SERVICE MANUAL COMPACT DISC DECK RECEIVER AEP Model UK Model HCD-GPX9 Ver. 1.1 2005.05 SPECIFICATIONS 9-879-468-02 2005E05-1 © 2005.05 Sony Corporation Personal Audio Group Published by Sony Engineering Corporation – Continued on next page – HCD-GPX9 is the amplifier, CD player, tape deck and tuner section in CMT-GPX9DAB. Model Name Using Similar Mechanism HCD-GPX5 CD CD Mechanism Type CDM80B-K6BD80A Section Base Unit Name BU-K6BD80A Optical Pick-up Block Name KSM-213DCP Tape deck Model Name Using Similar Mechanism HCD-GPX5 Section Tape Transport Mechanism Type CMAL1Z234A AUDIO POWER SPECIFICATIONS Main unit Amplifier section DIN power output (rated): 30 + 30 W (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 35 + 35 W (6 ohms at 1 kHz, 10% THD) Music power output (reference): 60 + 60 W Inputs AUDIO IN: Sensitivity 250 mV, impedance 47 kilohms Outputs PHONES: Accepts headphones with an impedance of 8 ohms or more SPEAKER: Accepts impedance of 6 to 16 ohms. CD player section Laser Diode Properties Emission Duration: Continuous Laser Output*: Less than 44.6 µW µ * This output is the value measurement at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block with 7 mm operture. Frequency response 20 Hz – 20 kHz Wavelength 780 – 790 nm Aerial terminal 75 Ω, F female FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range 87.5 – 108.0 MHz Aerial FM lead aerial Aerial terminals 75 ohms unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range 531 – 1,602 kHz (with the tuning interval set at 9 kHz) Aerial AM loop aerial, external aerial terminal Intermediate frequency 450 kHz Tape deck section Recording system 4-track 2-channel, stereo Frequency response 50 – 13,000 Hz (±3 dB), using Sony TYPE I cassettes Tuner section DAB tuner section Frequency range Band-III: 174.928 (5A) – 239.200 (13F) MHz L-Band: 1452.960 MHz (L1) – 1490.624 MHz (L23) (L-Band is not available for the UK model.) * For details, see “DAB frequency table” below. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 HCD-GPX9 Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat.r may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ∞C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. L-Band Notes • L-Band is not available for the UK model. • Frequencies are displayed to two places of decimals on this system. Frequency Label 1452.960 MHz L1 1454.672 MHz L2 1456.384 MHz L3 1458.096 MHz L4 1459.808 MHz L5 1461.520 MHz L6 1463.232 MHz L7 1464.944 MHz L8 1466.656 MHz L9 1468.368 MHz L10 1470.080 MHz L11 1471.792 MHz L12 1473.504 MHz L13 1475.216 MHz L14 1476.928 MHz L15 1478.640 MHz L16 1480.352 MHz L17 1482.064 MHz L18 1483.776 MHz L19 1485.488 MHz L20 1487.200 MHz L21 1488.912 MHz L22 1490.624 MHz L23 Power consumption 85 W 0.25 W (in Power Saving Mode) Dimensions (w/h/d) Approx. 181.5 × 261.5 × 357.5 mm incl. projecting parts and controls Mass Approx. 5.8 kg General Power requirements 230 V AC, 50/60 Hz Design and specifications are subject to change without notice. DAB frequency table Band-III Note Frequencies are displayed to two places of decimals on this system. Frequency Label Frequency Label 174.928 MHz 5A 209.936 MHz 10A 176.640 MHz 5B 211.648 MHz 10B 178.352 MHz 5C 213.360 MHz 10C 180.064 MHz 5D 215.072 MHz 10D 181.936 MHz 6A 216.928 MHz 11A 183.648 MHz 6B 218.640 MHz 11B 185.360 MHz 6C 220.352 MHz 11C 187.072 MHz 6D 222.064 MHz 11D 188.928 MHz 7A 223.936 MHz 12A 190.640 MHz 7B 225.648 MHz 12B 192.352 MHz 7C 227.360 MHz 12C 194.064 MHz 7D 229.072 MHz 12D 195.936 MHz 8A 230.784 MHz 13A 197.648 MHz 8B 232.496 MHz 13B 199.360 MHz 8C 234.208 MHz 13C 201.072 MHz 8D 235.776 MHz 13D 202.928 MHz 9A 237.488 MHz 13E 204.640 MHz 9B 239.200 MHz 13F 206.352 MHz 9C 208.064 MHz 9D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 HCD-GPX9 TABLE OF CONTENTS 1. SERVICING NOTES ............................................... 4 2. GENERAL Location of Controls........................................................ 6 3. DISASSEMBLY 3-1. Disassembly Flow ........................................................... 8 3-2. Side Plate (L)/(R) ............................................................ 9 3-3. Top Block Assy ............................................................... 9 3-4. Tape Mechanism Deck (CMAL1Z234A)........................ 10 3-5. Front Panel Section ......................................................... 10 3-6. MAIN Board.................................................................... 11 3-7. DAB Board ...................................................................... 11 3-8. CD Mechanism Deck Block ............................................ 12 3-9. Base Unit (BU-K6BD80A) ............................................. 12 3-10. BD Board ......................................................................... 13 3-11. Driver Board .................................................................... 13 3-12. Chassis (Top) ................................................................... 14 3-13. Lever (Loading-L/R) ....................................................... 15 3-14. Lever (Disc Sensor)/(Disc Stop) ..................................... 16 3-15. Holder (BU215) Assy ...................................................... 16 3-16. Lever (BU Lock) ............................................................. 17 3-17. Close Lever ...................................................................... 17 3-18. Lever (Dir), Gear (IDL-B) ............................................... 18 3-19. Gear (IDL-C) ................................................................... 18 4. TEST MODE .............................................................. 19 5. ELECTRICAL ADJUSTMENTS Deck Section.................................................................... 21 CD Section ...................................................................... 22 6. DIAGRAMS 6-1. Block Diagram – CD SERVO Section – ........................ 23 6-2. Block Diagram – AUDIO Section – ............................... 24 6-3. Block Diagram – PANEL/POWER SUPPLY Section – ........................... 25 6-4. Printed Wiring Board – DRIVER Board – ..................... 27 6-5. Schematic Diagram – DRIVER Board – ........................ 27 6-6. Printed Wiring Board – BD Board – .............................. 28 6-7. Schematic Diagram – BD Board – ................................. 29 6-8. Printed Wiring Board – DAB Board –............................ 30 6-9. Schematic Diagram – DAB Board – .............................. 31 6-10. Printed Wiring Board – MAIN Board – ......................... 32 6-11. Schematic Diagram – MAIN Board (1/3) – ................... 33 6-12. Schematic Diagram – MAIN Board (2/3) – ................... 34 6-13. Schematic Diagram – MAIN Board (3/3) – ................... 35 6-14. Printed Wiring Board – AMP Board – ........................... 36 6-15. Schematic Diagram – AMP Board – .............................. 37 6-16. Printed Wiring Board – PANEL (1) Board –.................. 38 6-17. Schematic Diagram – PANEL (1) Board – .................... 39 6-18. Printed Wiring Board – PANEL (2) Board –.................. 40 6-19. Schematic Diagram – PANEL (2) Board – .................... 41 6-20. Printed Wiring Board – POWER Board – ...................... 42 6-21. Schematic Diagram – POWER Board – ......................... 43 7. EXPLODED VIEWS 7-1. Side Plates Section .......................................................... 52 7-2. Front Panel Section ......................................................... 53 7-3. Top Block Section ........................................................... 54 7-4. MAIN Section ................................................................. 55 7-5. Chassis Section-2 ............................................................ 56 7-6. CD Mechanism Deck Section-1 (CDM80B-K6BD80A) .................................................... 57 7-7. CD Mechanism Deck Section-2 (CDM80B-K6BD80A) .................................................... 58 7-8. CD Mechanism Deck Section-3 (CDM80B-K6BD80A) .................................................... 59 7-9. CD Mechanism Deck Section-4 (CDM80B-K6BD80A) .................................................... 60 7-10. Base Unit Section (BU-K6BD80A) ................................ 61 8. ELECTRICAL PARTS LIST ................................ 62 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 HCD-GPX9 The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick- up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. LASER DIODE AND FOCUS SEARCH OPERATION CHECK Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveforms is output three times. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT SERVICE POSITION – Tape Mechanism Deck – SECTION 1 SERVICING NOTES tape mechanism deck UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the lead- free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size) : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40 °C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350 °C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscou-s (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 HCD-GPX9 – CD Mechanism deck – – AMP Board – 2 Remove the AMP board from heat sink. AMP board 1 two screws (BVTP3 × 16) heat sink heat sink CD mechanism deck www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 HCD-GPX9 SECTION 2 GENERAL This section is extracted from instruction manual. Main unit BASS +/– wk Cassette compartment 4 CD SYNCHRO 7 DAB qf DIRECTION 6 Disc slot wf DISPLAY ea Display window 3 DSGX qs FM MODE wh FUNCTION e; PHONES jack wd PLAY MODE ws Remote sensor 2 REPEAT wa TREBLE +/– qd TUNER/BAND qg TUNING MODE wj TUNING +/– wg VOLUME qa ?/1 (power) 1 ./> (CD skip back/skip forward) w; m/M (CD rewind/fast forward) ql m/M (tape rewind/fast forward) wl x (CD stop) qj x (tape stop) 9 z REC PAUSE/START 8 CD/NX (play/pause) qk TAPE/nN (play) 0 A (CD eject) qh A PUSH EJECT (tape open/close) 5 List of button locations and reference pages ALPHABETICAL ORDER A – O P – Z BUTTON DESCRIPTIONS ?/1 m M Y x m M . > NX x Z 12 3 56 7 8 9 w; ql wdwswa qk 0 qs qd qf qg wf wg wh wj wk wl e; ea qh qj qa 4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 HCD-GPX9 Remote control CD qh CLEAR qd CLOCK/TIMER SELECT 2 PLAY MODE qk REPEAT 4 SLEEP w; TAPE qg TUNER BAND 5 TUNER MEMORY qj TUNING MODE qk VOLUME +/– qa ?/1 (power) 1 m/M (rewind/fast forward) 7 ./> (skip back/skip forward) qf x (stop) 8 X (pause) 8 N (play) 8 +/– (tuning) qf ALPHABETICAL ORDER A – O P – Z BUTTON DESCRIPTIONS 4 5 6 7 8 9 w; 1 qd qs ql qk qj qh qg qf qa 0 3 2 CLOCK/TIMER SET 3 DAB 6 DISPLAY ql ENTER 9 EQ qs FM MODE 4 FUNCTION q; Use buttons on the remote for the operation. 1 Press ?/1 to turn on the unit. 2 Press CLOCK/TIMER SET. 3 Press . or > repeatedly to set the hour. 4 Press ENTER. 5 Press . or > repeatedly to set the minute. 6 Press ENTER. The clock starts working. To adjust the clock 1 Press CLOCK/TIMER SET. 2 Press . or > repeatedly to select “CLOCK SET”, then press ENTER. 3 Do the same procedures as step 3 to 6 above. Note The clock is not displayed in Power Saving Mode. Setting the clock www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 8 • This set can be disassembled in the order shown below. 3-1. DISASSEMBLY FLOW SECTION 3 DISASSEMBLY SET 3-2. SIDE PLATE (L)/(R) (Page 9) 3-8. CD MECHANISM DECK BLOCK (Page 11) 3-15. HOLDER (BU215) ASSY (Page 15) 3-16. LEVER (BU LOCK) (Page 16) 3-17. CLOSE LEVER (Page 16) 3-18. LEVER (DIR), GEAR (IDL-B) (Page 17) 3-10. BD BOARD (Page 12) 3-9. BASE UNIT (BU-K6BD80A) (Page 12) 3-12. CHASSIS (TOP) (Page 13) 3-11. DRIVER BOARD (Page 13) 3-13. LEVER (LOADING-L/R) (Page 14) 3-14. LEVER (DISC SENSOR)/ (DISC STOP ) (Page 15) 3-19. GEAR (IDL-C) (Page 17) 3-4. TAPE MECHANISM DECK (CMAL1Z234A) (Page 10) 3-7. DAB BOARD (Page 10) 3-5. FRONT PANEL SECTION (Page 10) 3-6. MAIN BOARD (Page 11) 3-3. TOP BLOCK ASSY (Page 9) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 9 3-3. TOP BLOCK ASSY Note: Follow the disassembly procedure in the numerical order given. 3-2. SIDE PLATE (L) / (R) q; side plate (R) 7 two screws (BVTT3 × 6) 4 two screws (BVTT3 × 8) 5 side plate (L) 1 screw (BVTP3 × 10) 2 two screws (BVTT3 × 6) 3 screw (BVTP3 × 10) 6 screw (BVTP3 × 10) 8 screw (BVTP3 × 10) 9 two screws (BVTT3 × 8) 5 8 top block assy 7 connector (CN301) 2 screw (BVTT3 × 6) 6 wire (flat type) (7 core) (CN302) 4 Open the plate. 3 harness 4 Open the plate. 1 screw (BVTT3 × 6) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 10 3-4. TAPE MECHANISM DECK (CMAL1Z234A) 3-5. FRONT PANEL SECTION 2 harness 1 four screws (BVTP3 × 8) 3 tape mechanism deck (CMAL1Z234A) 5 front panel section 4 Open the plate. 3 two screws (BVTT3 × 6) 1 wire (flat type) (21 core) (CN310) 2 connector (CN604) 4 Open the plate. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 11 3-6. MAIN BOARD 3-7. DAB BOARD qs wire (flat type) (17 core) (CN304) 1 wire (flat type) (9 core) (CN306) 8 screw (BVTT3 × 6) qd MAIN board 9 4 heat sink cover 7 three screws (BVTP3 × 8) 3 two screws (BVTT3 × 8) 2 three connectors (CN603, 605, 901) 5 connector (CN201) 6 connector (CN701) 0 wire (flat type) (15 core) (CN305) qa wire (flat type) (11 core) (CN315) 2 wire (flat type) (11 core) (CN715) 1 connector 5 connector (CN700) 7 module (DAB tuner) 6 two holders DAB 3 four screws (BVTT3 × 6) 8 DAB board 4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 12 3-9. BASE UNIT (BU-K6BD80A) 3-8. CD MECHANISM DECK BLOCK qa CD mechanism deck block 5 screw (BVTT3 × 6) 8 screw (BVTT3 × 6) 9 two screws (BVTT3 × 6) 0 cover (CDM) 3 screw (BVTT3 × 6) 7 1 connector 4 DAB block 6 three screws (BVTT3 × 6) 2 two screws (KTP3 × 8) qs base unit (BU-K6BD80A) 3 two screws (BVTP3 × 10) 1 two screws (BVTT3 × 10) 4 CD mecha bracket (R) block 2 CD mecha bracket (L) 7 two coil springs (insulator) 8 two insulators 6 two stoppers (BU) 5 two screws (BVTP M2.6) 9 two floating screws (PTPWH M2.6) 0 two coil springs (insulator) qa two insulators www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 13 3-10. BD BOARD 3-11. DRIVER BOARD 1 Remove four solders. 4 BD board 2 wire (flat type) (16 core) (CN101) 3 screw (2.6) 3 Remove two solders. 2 two screws (BVTP 2.6) 5 DRIVER board 4 motor (pully) assy (loading) 1 belt (MOT) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 14 3-12. CHASSIS (TOP) 1 screw (BVTP 2.6) 4 three screws (BVTP 2.6) 3 two screws (P 2 × 10) 5 chassis (top) 2 lever (CL UP2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 15 3-13. LEVER (LOADING-L/R) lever (loading-R) Align the horizontal position. lever (loading-L) Install the both levers so that they move symmetrically. — Bottom view — 2 two hooks 4 two hooks 3 lever (loading-L) 5 lever (loading-R) SPT-T (loading-R) SPT-T (loading-L) 1 1 PRECAUTION DURING LEVER (LOADING R / L) INSTALLATION www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 16 3-15. HOLDER (BU215) ASSY 3-14. LEVER (DISC SENSOR)/(DISC STOP) chassis (top) hole Install the lever (disc stop) so that the both holes are aligned. hole 1 gear (cap) 3 two claws 5 two hooks 6 lever (disc stop) lever (disc stop) 4 lever (disc sensor) PRECAUTION DURING DISC STOP LEVER INSTALLATION 2 gear (IDL L) 5 213 down holder SPR-E 1 screw (BVTP 2.6 × 8) 2 lever (CL UP2) 6 holder (BU215) assy 3 floating screw (PTPWHM2.6) 4 floating screw (PTPWHM2.6) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 17 3-16. LEVER (BU LOCK) 3-17. CLOSE LEVER 4 three hooks 1 floating screw (PTPWH M2.6) 5 lever (BU lock) 2 gear (cap) 3 gear (BU lock) 1 washer (3-1-0.4) 2 SPR-E lever close 4 shaft disc stop 5 close lever 3 claw www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 18 3-18. LEVER (DIR), GEAR (IDL-B) 3-19. GEAR (IDL-C) 4 pulley (gear) 3 nylon washer 1.7 2 claw washer 0 lever (DIR) 6 gear (IDL-A) qa gear (IDL-B) 1 DIR SPR-E 9 stoper 7 Loosen the screw. 8 Hold the release lever and change the direction. 5 gear (cap) 6 claw 1 gear (IDL-F) 5 gear loading lever 2 two claws 4 three hooks 3 gear (IDL-D) 7 gear (IDL-C) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 HCD-GPX9 SECTION 4 TEST MODE [MC COLD RESET] The cold reset clears all data including preset data stored in the memory to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. In the standby status, press the I/1 button to turn the power on. 2. Press three buttons of I/1 , x (CD), and [DSGX] simultaneously. 3. The set is reset, and become standby status. [COMMON TEST MODE] Enter The Common Test Mode Procedure: 1. In the standby status, press the I/1 button to turn the power on. 2. Press three buttons of [REPEAT], x (TAPE), and [DSGX] simultaneously. 3. When the common test mode is activated, “SLEEP” and “PLAY” icons are blink on the fluorescent indicator tube. AMP Test Procedure: 1. In the common test mode, if turn the [VOLUME] knob clockwise, it displays “VOL MAX”, and if turn the knob counterclockwise, it displays “VOL MIN”. 2. If the [TREBLE] knobs are turned clockwise or counterclockwise, it displays “TONE FLAT”. 3. If the [BASS] knobs are turned clockwise, it displays “TONE MAX”, and if turn the knob counterclockwise, it displays “TONE MIN”. 4. To release from this mode, disconnect the AC plug to turn the power off. Tape Test Procedure: 1. In the common test mode, insert a tape. 2. Input any audio signal from the [VIDEO/MD] jack (J301) on the MAIN board. 3. Press the [ REC] button, and press the [ TAPE] button to select the tape direction. 4. Press the [ REC] button again to start recording. 5. If press the m (TAPE) or M (TAPE) button, the tape is returned to recording start point by cue or review operation, and starts playback. 6. To release from this mode, disconnect the AC plug to turn the power off. [PANEL TEST MODE] Enter The Panel Test Mode Procedure: 1. In the standby status, press the I/1 button to turn the power on. 2. Press three buttons of [PLAY MODE], x (TAPE), and [DSGX] simultaneously. 3. When the panel test mode is activated, LEDs and segments of fluorescent indicator tube are all turned on. Version Check Procedure: 1. In the panel test mode (all LEDs and segments of fluorescent indicator tube are turned on), press the [TUNING MODE] button. 2. Destination indication and model type indication are displayed on the fluorescent indicator tube alternately. 3. From this status, each time the [TUNING MODE] button is pressed, it changes the version display of each module cyclically as follows. Display Module MC Main controller GC Display CD CD system CDD CD device master CDMA CDM upper module CDMB CDM lower module BDA BD upper module BDB BD lower module ST Tuner TA Amplifier TM Timer TC Tape 4. To date of any module, press the [DSGX] button. 5. To release from this mode, press three buttons of [PLAY MODE], x (TAPE), and [DSGX] simultaneously. Key Check Procedure: 1. In the panel test mode (all LEDs and segments of fluorescent indicator tube are turned on), press the [PLAY MODE] button. 2. It displays “K 0 J0 V0” on the fluorescent indicator tube. 3. Each time a button is pressed, “K” value increases. However, once a button is pressed, it is no longer taken into account. All keys are pressed, display becomes “K26”. 4. “V” value increases like 0, 2, 4... or 1, 3, 5... if turn the [VOLUME] knob clockwise, or it decreases like 0, 8, 6... or 1, 9, 7... if turn the knob counterclockwise. “J” value increases like 1, 2, 3... if turn the [BASS] or [TREBLE] knob clockwise, or it decreases like 0, 9, 8 ... if turn the knob counterclockwise. 5. To release from this mode, press three buttons of [PLAY MODE], x (TAPE), and [DSGX] simultaneously. z nN z www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 20 HCD-GPX9 [CD REPEAT 5 LIMIT CANCEL MODE] Number of repeat for CD playback is 5 times when the repeat mode is “REPEAT”. This mode enables CD to repeat playback for limitless times. Procedure: 1. Press the I/1 button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Press three buttons of m (CD), x (TAPE), and [DSGX] simultaneously. 4. It enters the CD repeat 5 limit cancel mode and display “LIMIT OFF” 5. To release this mode, press the I/1 button to turn the power off. [CD SHIP MODE] This mode can run the CD sled motor optionally. Use this mode, for instance, when cleaning the optical pick-up. Procedure: 1. Press the I/1 button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Press three buttons of [TUNING MODE], x (CD), and I/1 simultaneously. *1 4. Set to the CD ship mode. (chucking on) 5. After blink “STANDBY”, “LOCK” is displayed, disconnect the AC plug. *1) If press three buttons of [DIRECTION], u (CD), and [DSGX] simultaneously, Activate the CD ship mode and MC cold reset. [CD SLOT LOCK] This mode is for the antitheft of CD disc in shop. (not for transport) Procedure: 1. Press the I/1 button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Insert a disc. 4. While pressing the x (CD) button, press the A (CD) button for more 5 seconds. 5. The message “LOCKED” is displayed and the disc slot is locked. (Even if exiting from this mode, the disc slot is still locked) 6. If press the A (CD) button to eject the disc, the message “LOCKED” is displayed and can not eject the disc. 7. To release this lock, while pressing the x (CD) button, press the A (CD) button for 5 seconds again. 8. The message “UNLOCKED” is displayed and the disc slot is unlocked. [CD POWER MANAGE] This mode is for switch the CD power supply on/off. Even if this state pulls out AC plug, it is held. Procedure: 1. Press the I/1 button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Press the I/1 button again to turn the power off (standby). 4. While pressing the x (CD) button, press the I/1 button. 5. It turns power on and display “CD POWER”, then display “ON” or “OFF”. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 HCD-GPX9 DECK SECTION 1. Demagnetize the record/playback head with a head demagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjust. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed for both L-CH and R- CH. 6. Switches and controls should be set as follows unless otherwise specified. REC BAIS ADJUSTMENT Setting: Procedure: 1. Connect a digital voltmeter (AC range) to TP101 (L), TP201 (R) and TP (GND) on the MAIN board. 2. Insert a tape. 3. Press the I/1 button to turn the power on, and press the [FUNCTION] button to select TAPE function. 4. Press the [ REC] button twice to start recording. 5. Adjust RV101 (L-ch), RV201 (R-ch) on the MAIN board so that the digital voltmeter reads AC 6.15 V. 6. Connect an oscilloscope or frequency counter to TP101 (L), TP201 (R) and TP (GND) on the MAIN board. 7. Confirm that the frequency is 82 kHz ±3 kHz. Adjustment Location: SECTION 5 ELECTRICAL ADJUSTMENTS MAIN board digital voltmeter (AC range) TP101 (L), TP201 (R) TP (GND) z – MAIN BOARD (Conductor Side) – RV201 RV101 TP (GND) REC BIAS ADJUSTMENT (R-CH) (L-CH) TP201 (R) TP101 (L) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 HCD-GPX9 CD SECTION Note: 1. CD Block is basically constructed to operate without adjustment. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10 MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. 5. Check the focus bias check when optical block is replaced. FOCUS BIAS CHECK Procedure : 1. Connect the oscilloscope to TP012 (RFACO) and TP013 (VC) on the BD board. 2. Insert the disc (YEDS-18). (Part No. : 3-702-101-01) 3. Press the [ CD] button. 4. Confirm that the oscilloscope waveform is as shown in the figure below. (eye pattern) A good eye pattern means that the diamond shape (◊) in the center of the waveform can be clearly distinguished. • RF signal reference waveform (eye pattern) Checking Location: + – BD board TP012 (RFACO) TP013 (VC) oscilloscope (DC range) VOLT/DIV: 0.2 V (with the 10: 1 probe in use.) TIME/DIV: 500 ns 0.7 When observing the eye pattern, set the oscilloscope for AC range and raise vertical sensitivity. 0.3 Vp-p – BD BOARD (Conductor Side) – TP012 (RFACO) TP013 (VC) u www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 23 23 HCD-GPX9 SECTION 6 DIAGRAMS 6-1. BLOCK DIAGRAM – CD SERVO Section – 9 RIN 4 OUT1 2 OUT2 M701 (LOADING) S701 (OUT) S702 (CHUCK) S703 (TRIGGER) M LOADING MOTOR DRIVE IC701 7 FIN A/D CONVERTER CH2OUTF CH2OUTR 23 24 21 4 5 5 7 17 18 16 15 RFACI ASYO ASYI FILTER FILO PCO CLTV FILI DIGITAL PLL ASYMMETRY CORRECTOR EFM DEMODULATOR CD DSP IC101 (1/2) MDP DIGITAL CLV PROCESSOR 32K RAM ERROR CORRECTOR INTERNAL BUS SQCK SQSO EXCK AOUT1 C4M XTSL XTAO XTAI AOUT2 R-CH D/A DIGITAL INTERFACE D/A CONVERTER SELECTOR CLOCK GENERATOR SUBCODE PROCESSOR SCOR WFCK XUGF GFS EMPH SENS DATA CLOCK XLAT SBSO CD SENS CD DATA CD XLT TEI FEI FOCUS/ TRACKING/SLED SERVO DSP FOCUS/TRACKING/SLED PWM GENERATOR SFDR CH3FIN CH4IN CH3RIN CH3OUTF CH3OUTR CH1FIN CH1RIN CH2FIN CH2RIN 20 MUTE SRDR TFDR TRDR FFDR FRDR SSTP COUT MIRR, DFCT, FOK DETECTOR SERVO AUTO SEQUENCER SERVO INTERFACE CPU INTERFACE SCLK TO CPU INTERFACE FOK MIRR DFCT 2 OPIN+ CH4OUTF CH4OUTF 27 OPOUT M101 (SPINDLE) MOTOR DRIVE MOTOR DRIVE COIL DRIVE CH1OUTF CH1OUTR COIL DRIVE M M M102 (SLED) MOTOR/COIL DRIVE IC251 2-AXIS DEVICE (TRACKING) (FOCUS) CD DSP IC101 (2/2) • SIGNAL PATH : CD PLAY 14 13 11 12 CD SCOR A CD 13 11 12 9 10 14 112 101 20 22 3 1 2 7 TO SERVO AUTO SEQUENCER 39 48 50 XPCK 105 47 49 42 43 6 XRST 93 CD XRST 22 89 90 76 73 110 86 72 81 91 92 108 100 95 98 97 103104106 64 38 CD CLK 34 23 LRCK BCK PCMD 59 62 61 LRCKI BCKI PCMDI 58 56 57 24 19 25 26 27 28 23 21 19 18 35 34 E B A CD +3V F DETECTOR A B C D RF SUMMING AMP FOCUS ERROR AMP TRACKING ERROR AMP RFACO FEO TEO E F AUTOMATIC POWER CONTROL Q10 APC LD AMP LD LD PD LASER DIODE OPTICAL PICK-UP BLOCK (KSM-213DCP) PD I-V AMP D C EQ_ IN 38 33 32 EQ AC_ SUM RFAC VCA X171 16.9344MHz SYSTEM CONTROLLER IC306 (1/3) S101 (LIMIT) XTCN 55 CD AMUTE 39 R-CH MUTING Q102 CD MUTING CONTROL Q317, 318 • R-ch is omitted due to same as L-ch. XTACN 88 65 (CHUCK SW) CDM80 SW2 61 (TRIGGER SW) CDM80 SW3 63 (OUT SW) CDM80 SW1 59 CDM80 LOAD-OUT 60 CDM80 LOAD-IN (Page 24) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 24 24 HCD-GPX9 6-2. BLOCK DIAGRAM – AUDIO Section – 1 INPUT SELECT, TONE CONTROL, ELECTRICAL VOLUME IC302 POWER AMP IC601 MD IN L 61 J301 CD IN L 36 VOL IN L R-CH R-CH R-CH CD L-CH HRP350 (REC/PB/ERASE) R-CH ERASE R/P BIAS 63 TU IN L 11 TAPE IN L 7 PB OUT L 3 TAPE L 15 REC OUT L A 37 TONE OUT 33 VOL OUT L EQ 7 9 REC/PB SWITCH IC301 8 M+10V BIAS OSC T301 4 CONT LEVEL SHIFT Q301, 302 BIAS OSC Q303, 304 BIAS TRAP T101 REC BIAS (L) RIPPLE FILTER Q305 REC BIAS SWITCH Q306, 307 RV101 M CAPSTAN/REEL MOTOR DRIVE Q310, 311 TRGM+ PACK F REC R REC END SW PLAY SW TC CONT TC TRG HALF END SW PLAY SW PLUNGER DRIVE Q308, 309 LOW-PASS FILTER IC702, 703 TUNER SELECT SWITCH IC201 CAPSTAN/ REEL TAPE MECHANISM DECK BLOCK TUNED STEREO MUTE RDS DATA RDS INT DI DO CLK CE TUNED STEREO ST MUTE RDS DATA RDS INT ST DIN ST DOUT ST CLK ST CE ROUT R-CH S1_DIN S1_DOUT LOUT AM FM 75Ω ANTENNA FM/AM TUNER PACK AUDIO_RIGHT_OUT R-CH AUDIO_LEFT_OUT ANTENNA DAB DAB TUNER MODULE 76 TC TRG 77 TC CAPM CONT 95 TC HALF/REC SW 75 TC PLAY 94 TC END SW 78 BIAS ON 79 TC R/P 71 ST DATA OUT 72 ST DATA IN 73 ST CLK 70 ST CE 69 ST TUNED 68 ST STEREO 67 ST MUTE 58 RDS DATA ST DIN ST DOUT ST CLK ST CE TUNED STEREO ST MUTE RSD DATA RDS INT TC TRG TC CONT HALF PLAY SW END SW BIAS R/P 87 EQ DATA 88 EQ CLK LINE MUTE 86 AMP POWER 83 AC DET C 84 PROTECT 85 SP RELAY 18 RDS CLK 49 DAB SELECT 19 SI 18 SC R-CH R-CH VP CT OUT OCP R-CH R-CH MUTING Q501 D609 D611 D608 THP801 OVER LOAD DETECT Q502 POWER ON MUTING Q601 PROTECT SWICTH Q608 STANDBY SWITCH Q604 MUTING CONTROL Q602, 603 TEMPERATURE DETECT Q607 PROTECT CONTROL IC602 2 4 3 1 RELAY OFF SWITCH Q609 RELAY DRIVE Q610, 611 SPEAKER IMPEDANCE USE 6 – 16Ω TM301 RY301 + + RELAY B+ SWITCH Q605, 606 +POWER PHONES L R J321 HP SW B L R AUDIO IN • SIGNAL PATH : CD PLAY : FM : AUX IN : TAPE PLAY : TAPE REC • R-ch is omitted due to same as L-ch. SYSTEM CONTROLLER IC306 (2/3) + + – – 15 X IN 31 DAB DATA OUT 32 DAB DATA IN 13 X302 16MHz X OUT 11 XC OUT 10 X301 32.768kHz XC IN : DAB TUNER SELECT Q201 (Page 25) (Page 25) (Page 23) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 25 25 HCD-GPX9 6-3. BLOCK DIAGRAM – PANEL/POWER SUPPLY Section – 4 42 BASS A 43 BASS B REMOTE CONTROL RECEIVER IC802 S701 – 708, S709 – 717, S718 –725, 726 HP SW B ROTARY ENCODER BASS S801 40 TRE A 41 TRE B ROTARY ENCODER TREBLE S802 5 VOL A 6 VOL B 3 STBY LED 47 DAB POWER 5 48 DAB POWER 3.3 ROTARY ENCODER VOLUME S803 21 FL CLK FL DATA 7 FL STB 57 CD BD POWER 80 RY ON 7 DIN 8 CLK 9 STB 1 LED1 FL701 FLUORESCENT INDICATOR TUBE LED DRIVE Q801 n N TAPE D803 u CD D801 2 LED2 LED DRIVE Q802 BAND TUNER D802 3 LED3 LED DRIVE Q803 LED DRIVE Q804 I/1 D804 FL/LED DRIVER IC801 SYSTEM CONTROLLER IC306 (3/3) 100 SIRCS IN/ WAKE 74 KEY WAKE UP F902 D911 RECT D910 RY901 F901 T901 POWER TRANSFORMER RECT D901 RECT D902 – 905 +9V REGULATOR IC304 +10V REGULATOR IC901 +POWER –POWER UNREG A+9V M+10V +5V REGULATOR IC907 +3.3V REGULATOR IC911 DAB +5V DAB +3.3V D912 RECT D906 – 909 RELAY DRIVE Q319, 320 +7V REGULATOR IC902 +4V REGULATOR IC903 CD M+7V, M+7V D+4V FL AC FL AC D327 FL –30V –30V REGULATOR Q805 – 807 CURRENT LIMIT Q808 (AC IN) AC DET C B+ SWITCH Q312, 313 D311 D312 AVDD DVDD 30 – 42 GR1 – GR12 14 – 29 SG1 – SG16 89 – 91 KEY1 – KEY3 12 RESET 20 AC-CUT VOLTAGE DETECT IC305 53 SW-POWER RESET SWITCH Q316 D306 D308 A+9V U-COM B+ D317, 318 B+ SWITCH Q322, 323 SWITCH Q321 SUB POWER BLOCK U COM +B AC SW SW 9V (Page 24) (Page 24) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 26 26 HCD-GPX9 • Note for Printed Wiring Boards and Schematic Diagrams • Indication of transistor • Circuit Boards Location Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • f : internal component. • 2 : nonflammable resistor. • 5 : fusible resistor. • C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note on Printed Wiring Board: • X : parts extracted from the component side. • Y : parts extracted from the conductor side. • W : indicates side identified with part number. • f : internal component. • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: Parts on the pattern face side seen from (Conductor Side) the pattern face are indicated. Parts face side: Parts on the parts face side seen from (Component Side) the parts face are indicated. C B These are omitted. E Q B These are omitted. C E Q • A : B+ Line. • B : B– Line. • Voltages and waveforms are dc with respect to ground under no-signal conditions. – BD Board – no mark : CD PLAY – Other Boards – no mark : FM ( ) : CD PLAY [ ] : TAPE PLAY 〈〈 〉〉 : TAPE REC { } : DAB ∗ : Impossible to measure • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal produc- tion tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal produc- tion tolerances. • Circled numbers refer to waveforms. • Signal path. F : TUNER (FM/AM) E : TAPE PLAY a : TAPE REC J : CD PLAY L : AUX IN f : DAB • Abbreviation EE : East European model BD board PANEL (1) board module (DAB TUNER) DAB board MAIN board POWER board AMP board DRIVER board TUNER SWITCHING REGULATOR PANEL (2) board Ver. 1.1 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 27 27 HCD-GPX9 : Uses unleaded solder. 6-4. PRINTED WIRING BOARD – DRIVER Board – 6-5. SCHEMATIC DIAGRAM – DRIVER Board – • See page 26 for Circuit Boards Location. • See page 44 for IC Block Diagrams. R702 R701 IC701 CN701 D701 C711 S702 S701 M701 C705 100 680 BA6956AN 7P MTZJ-4.7C 10 50V 0.01 RNF MGND SW2(CHUCK SW) SW1(OUT SW) SW3(TRIGGER SW) FIN(POS) RIN(NEG) VCC OUT2 GND VREF OUT1 VM FIN RIN (CHUCK) (OUT) M+7V LOADING MOTOR DRIVE (LOADING) (Page 32) (Page 34) C711 IC701 S701 R702 R701 D701 C705 CN701 S702 DRIVER BOARD 1-688-337- 12 (12) M701 (LOADING) M MAIN BOARD CN303 B (CHUCK) (OUT) 1 9 A B C 1 2 3 4 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 28 28 HCD-GPX9 6-6. PRINTED WIRING BOARD – BD Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. JW104 JW105 JW106 JW107 JW108 JW109 JW110 JW111 JW112 JW116 JW117 JW118 JW120 JW123 JW124 JW125 JW132 JW133 JW134 JW102 JW126 JW128 JW131 JW119 JW101 JW114 JW115 C151 C183 CN201 C203 X101 C184 C201 C17 S101 CN101 C170 JW113 C116 JW103 JW127 IC251 JR109 JR104 C14 R114 JR108 JR101 R112 C202 R252 C161 R172 C181 C258 C163 C18 C131 R111 IC101 C182 C111 JR102 R10 JR110 R11 C141 C164 R141 JR103 C16 C15 C112 C251 C257 C113 JR106 Q10 C194 R251 C114 C259 C133 JR105 C115 C160 C252 C122 C124 C123 C162 R113 R142 R171 R406 R132 R151 R12 R121 R131 C125 C195 C117 C143 C172 C171 C174 R133 R407 C132 C142 R143 JR107 R13 R181 R182 C185 C186 JR111 R162 R161 R173 C10 C11 R202 C213 R408 R409 R410 R411 C212 C211 C210 R204 R412 R201 E 28 15 22 21 1 14 7 8 1 29 28 84 85 112 56 57 BD BOARD 1-860-501- 12 (12) M101 (SPINDLE) M M102 (SLED) M (LIMIT) TP013 (VC) TP012 (RFACO) OPTICAL PICK-UP BLOCK (KSM-213DCP) A MAIN BOARD CN304 A B C D 1 2 3 4 (Page 32) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 29 29 HCD-GPX9 6-7. SCHEMATIC DIAGRAM – BD Board – • See page 44 for IC Block Diagrams. • See page 44 for Waveforms. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. (Page 34) C161 C15 TP29 TP31 TP33 TP30 TP34 TP35 TP36 TP37 TP38 TP40 TP39 TP41 TP42 TP43 TP44 R411 R410 R409 R408 R407 R406 C163 C202 C203 C162 C201 C182 C181 C186 C185 C184 C183 R182 R181 C174 R173 X101 R172 R171 C172 C171 R161 R412 R162 C194 C213 C211 C212 JR110 C164 JR102 C160 R252 C251 C258 R251 JR107 C170 C252 R151 C111 C114 R114 R112 C112 C113 R111 R113 JR106 TP28 TP21 TP015 TP22 TP23 TP24 TP25 TP26 JR108 TP27 TP014 TP17 TP18 TP19 TP20 TP013 C16 R11 C18 C17 R12 C117 C125 C124 TP012 R133 C133 C132 R132 C142 R143 C141 R142 R141 C151 R202 C143 IC101 JR103 C122 R121 C123 C10 C14 CN201 CN101 C195 TP016 JR101 C257 C210 C116 R204 R201 C115 C259 JR104 IC251 JR105 Q10 TP32 JR111 C11 TP46 R13 TP45 R10 JPO004 JPO003 JPO001 S101 JR109 JPO002 R131 C131 0.1 0.1 XTACN DOUT LOUT AGND ROUT DGND DVDD XRST DATA CLK XLT SENS SCOR MGND(7V) M+7V 100 100 100 100 100 100 0.1 0.1 220 10V 0.1 220 10V 0.1 0.1 470p 470p 220 10V 220 10V 100 100 0.1 0 16.9344MHz 1M 470 27p 22p 100 100 47k 0.1 22p 220p 22p 0 0.1 0 0.1 22k 6800p 0.1 10k 0 220 16V 0.1 0 3300p 470p 15k 15k 470p 3300p 1k 1k 0 LD AGND F PD F+ T+ T- F- 0 TOP1 E D A B C (VC) 1 0 1000p 220 10V 100k 0.1 0.1 330p (RFACO) 180k 0.01 0.47 10k 1500p 3.3k 0.1 1k 4.7k 220 10V 0 0.1 CXD3058AR 0 0.1 15k 0.1 10 0.1 17P 16P 0.1 SSTP 0 0.1 0.1 220 10V 0.1 0.1 0 BA5947FM 0 2SB1690K AVDD 0 10 IOP1 1 IOP2 3.3 0 1M 100p SFDR SFDR SRDR SRDR TFDR TFDR TRDR TRDR FFDR FFDR FRDR FRDR E E D D A A B B C C F F PD PD F+ F+ T+ T+ T- T- F- F- VC VCC PD LD T- F- T+ F+ LMUT XTSL IOVSS0 XTACN SQSO SQCK SBSO EXCK XRST SYSM DATA VSS XLAT CLOK VDD SENS SCLK ATSK WFCK XUGF XPCK GFS C2PO SCOR VDD C4M WDCK MIRR DFCT FOK VSS LOCK MDP SSTP IOVSS1 SFDR SRDR TFDR TRDR FFDR FRDR IOVDD1 AVDD0 AVSS0 E F TEO FEO VC A B C D AVDD4 RFDCO PDSENS AC_SUM EQ_IN LD PD RFC AVSS4 RFACO RFACI AVDD3 BIAS ASYI ASYO VPCO VCTL AVSS3 CLTV FILO FILI PCO AVDD5 DDVROUT DDVRSEN AVSS5 DDCR LRCK LRCKI PCMD PCMDI VSS BCK BCKI VDD EMPH EMPHI IOVDD2 DOUT TEST TES1 IOVSS2 XVSS XTAO XTAI XVDD AVDD1 AOUT1 VREFL AVSS1 AVSS2 VREFR AOUT2 AVDD2 RMUT COUT IOVDD0 VR AGND F C B A E D TEI FEI SCOR SENS CLK XLT DATA DOUT DVDD DGND AVDD LOUT AGND ROUT XRST MGND(7V) M+7V AGND XTACN CD DSP MOTOR/COIL (LIMIT) AUTOMATIC POWER CONTROL DRIVE M102 M101 (SPINDLE) (SLED) MAIN BOARD (2/3) CN304 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 30 30 HCD-GPX9 6-8. PRINTED WIRING BOARD – DAB Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. CN715 C732 G702 C924 C922 C751 C713 C701 C731 G701 C791 C734 C792 C945 CN700 JW701 JW702 JW703 JW704 JW706 JW708 JW710 JW711 JW712 JW713 JW714 JW715 JW716 JW720 JW721 JW722 JW723 JW719 JW717 JW718 JW724 JW705 JW709 JW707 C702 R903 R764 R759 R758 R756 R755 R754 R753 R752 R714 R709 R708 R706 R705 R704 R703 R702 R716 R710 R711 IC907 FB793 FB792 C940 C939 C923 C921 C737 C761 C758 C755 C754 C753 C752 C711 C708 C705 C704 C703 C730 C735 C712 C700 R904 IC911 IC703 IC702 DAB BOARD 1-866-372- 13 (13) MAIN BOARD CN315 M DAB TUNER MODULE ANTENNA DAB 1 5 1 5 A B C D 1 2 3 4 5 6 (CHASSIS) (CHASSIS) C753 C716 C736 (AEP, EE) (AEP, EE) (Page 32) Ver. 1.1 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 31 31 HCD-GPX9 6-9. SCHEMATIC DIAGRAM – DAB Board – • See page 44 for IC Block Diagrams. R706 R755 C758 CN715 R711 C712 C734 C735 C731 R710 C751 C791 C792 C922 C939 R708 R709 R759 R705 C708 R704 R754 R758 R756 C711 C761 C752 C755 C705 R752 C703 R703 C754 C704 R702 C753 R753 C713 R714 R764 R716 R904 R903 C921 C924 C923 IC703(1/2) C945 C940 C700 C701 FB792 FB793 CN700 C730 IC911 IC907 IC702(1/2) C737 C732 IC703(2/2) IC702(2/2) C702 22k 12k 220p 11P 100 0.1 4.7 50V 0.1 4700 6.3V 100 10 50V 10 50V 10 50V 100 16V 0.1 1k 22k 22k 12k 220p 1.5k 1.5k 1k 22k 0.1 0.1 0.1 0.1 0.1 1k 0.0047 1.5k 0.001 0.001 1k 0.0047 1.5k 100 16V 1k 1k 10 10k 10k 0.1 100 16V 0.1 NJM4565M(TE2) 2200 16V 0.1 0.1 10 50V 44P 0.1 BA33BC0WFP BA50BC0WFP NJM4565M(TE2) 0.1 4700 6.3V NJM4565M(TE2) NJM4565M(TE2) 100 10V 1 2 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 34 36 38 40 42 44 LCH RCH +9V AGND DAB-OUT DAB-IN CD MGND CD+7V DAB+3.3V_ON DAB+5V_ON LOW-PASS FILTER LOW-PASS FILTER +3.3V REGULATOR +5V REGULATOR NC CTL VCC GND OUT CTL VCC GND OUT NC 4 4 8 8 DAB TUNER MODULE ANTENNA DAB 7 5 6 5 6 7 3 2 1 1 3 2 C736 (AEP, EE) (AEP, EE) G702 G701 0.01 C716 TP701 0.01 (CHASSIS) (CHASSIS) (Page 33) Ver. 1.1 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 32 32 HCD-GPX9 D320 D321 JW249 JW101 JW102 JW103 JW104 JW105 JW106 JW108 JW109 JW110 JW113 JW115 JW117 JW118 JW119 JW120 JW121 JW122 JW123 JW124 JW125 JW126 JW127 JW128 JW129 JW130 JW131 JW132 JW134 JW135 JW136 JW137 JW138 JW139 JW140 JW142 JW143 JW144 JW145 JW146 JW147 JW148 JW149 JW150 JW151 JW152 JW153 JW154 JW155 JW156 JW157 JW158 JW159 JW160 JW161 JW162 JW163 JW164 JW166 JW167 JW168 JW169 JW171 JW175 JW176 JW177 JW178 JW179 JW180 JW189 JW191 JW192 JW194 JW198 JW199 JW200 JW201 JW202 JW203 JW209 JW210 JW211 JW212 JW213 JW214 JW215 JW216 JW217 JW218 JW219 JW220 JW221 JW222 JW223 JW224 JW225 JW226 JW227 JW228 JW231 JW232 JW114 JW107 JW236 JW237 JW238 Q322 Q319 R361 C322 C102 C333 C326 C235 R222 C233 C234 R122 Q310 Q308 R302 D308 R418 C325 D304 R226 R126 D314 C134 D311 D302 R362 C367 C237 C137 C219 C119 C343 C133 D325 CN316 CN302 C329 C331 R350 C330 X301 R372 R373 C217 C215 C115 D319 RV101 C135 T201 Q312 R325 C122 C124 C202 CN315 C225 C125 R318 C110 C210 C109 C107 Q306 C306 Q307 C305 C304 C241 Q302 C218 D306 C141 C117 C118 Q304 C310 C309 C308 C307 Q303 Q305 C373 C207 C209 C128 RV201 IC301 C228 C319 C317 T101 T301 C327 R368 R494 R495 CN308 C223 R335 D316 CN303 CN309 CN307 C114 L202 L102 C214 C224 CN306 C302 C303 CN305 C337 Q301 C320 C395 C328 L302 CN313 D301 Q201 CN304 CN301 X302 RY301 D312 C242 D331 FB301 D303 C142 D305 C318 D326 R303 J301 CN310 R419 Q321 D307 D327 D317 Q314 D309 D318 C222 C123 IC304 C394 D332 D333 JW206 D334 D335 JW207 C354 JW205 D366 JW208 JW133 JW116 JW112 JW111 JW141 JW239 JW172 JW173 JW174 JW170 JW184 JW185 JW187 JW186 JW230 JW195 JW193 JW190 JW188 JW183 JW197 JW196 JW204 JW229 C336 R448 R375 Q313 D329 R374 Q323 Q320 R382 R381 C321 R396 C201 C101 R202 R201 R102 R101 R455 Q202 R342 R341 R340 R339 R413 Q102 C335 Q317 Q318 R227 D330 R358 R359 R360 FB307 C368 C238 C138 R124 R224 R223 R123 C342 FB306 FB305 R331 R474 R379 R326 C397 C334 R330 R332 R333 R334 R213 C216 R212 R211 C116 R113 R112 R111 R311 R314 R312 Q311 C314 R315 R319 R323 R320 R458 R363 R114 R214 R324 R321 R369 R322 R218 R118 C131 R107 R108 C112 C111 R109 C113 C231 R208 R207 C212 C211 R209 R210 C213 R106 R105 C206 R104 R103 R206 C106 R205 R204 R203 R310 R309 R308 R370 R307 R306 C203 R395 IC305 R305 R304 R110 C105 C205 Q309 R301 C103 R337 R417 R336 R429 R438 R434 R432 R367 R424 R423 R422 R484 R472 R469 R468 R420 IC306 R412 R411 C338 C339 IC302 R409 R465 R463 R461 C340 R460 R459 R443 R442 R441 R440 R406 R405 R404 R491 R489 R430 C372 R490 FB302 C371 C362 R219 R217 R119 IC201 R127 C396 R228 R128 FB309 C232 C221 R431 R394 R393 FB308 C132 R475 R447 JR233 JR234 JR235 R131 R231 R132 R232 JR200 R130 R230 R133 R233 C136 C236 R450 C393 3 1 4 5 1-866-371- 12 (13) MAIN BOARD + + – – L R SPEAKER IMPEDANCE USE 6-16Ω TM301 SUB POWER BLOCK (1/2) AMP BOARD CN306 E (CHASSIS) 1 7 4 1 6 1 DRIVER BOARD CN701 B DAB BOARD CN715 M BD BOARD CN201 A E E E E E E E E E E E E M301 (FAN) M AUDIO IN L R AMP BOARD CN605 F POWER BOARD CN901 G FM/AM TUNER UNIT SUPPLIED WITH THE ASSEMBLED BLOCK 1 3 1 3 1 3 1 12 E E E E 1 8 9 1 E E E E E TP101 (L) TP (GND) TAPE MECHANISM DECK BLOCK SUPPLIED WITH THE ASSEMBLED BLOCK HRP350 REC/PB/ ERASE HEAD PANEL (1) BOARD CN801 H AMP BOARD CN601 D TP201 (R) E E E A B C D E F G 1 2 3 4 5 6 7 8 9 10 11 C341 6-10. PRINTED WIRING BOARD – MAIN Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. (Page 27) (Page 36) (Page 36) (Page 36) (Page 38) (Page 42) (Page 28) • Semiconductor Location Ref. No. Location D301 B-4 D302 E-6 D303 E-6 D304 E-6 D305 E-6 D306 E-6 D307 D-5 D308 E-6 D309 D-5 D311 E-6 D312 E-6 D314 E-9 D316 B-9 D317 C-7 D318 C-7 D319 B-6 D320 E-6 D321 E-6 D325 C-9 D326 C-9 D327 D-9 D329 B-6 D330 B-6 D331 E-2 D332 F-10 D333 F-10 D334 E-6 D335 E-6 D366 E-6 IC301 C-3 IC302 D-3 IC304 B-8 IC305 D-6 IC306 D-7 Q102 E-5 Q201 F-8 Q202 F-5 Q301 C-4 Q302 C-4 Q303 B-2 Q304 B-2 Q305 B-1 Q306 B-1 Q307 C-1 Q308 B-5 Q309 B-5 Q310 B-4 Q311 B-5 Q312 E-5 Q313 E-5 Q314 D-6 Q317 F-5 Q318 F-5 Q319 C-9 Q320 C-9 Q321 D-9 Q322 C-9 Q323 C-9 (Page 30) Ver. 1.1 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 33 33 HCD-GPX9 6-11. SCHEMATIC DIAGRAM – MAIN Section (1/3) – • See page 44 for Waveforms. • See page 44 for IC Block Diagram. C225 C125 R101 R202 R102 C101 C201 C397 R201 R307 C306 R310 Q307 R309 R308 R306 Q306 C304 C305 C307 R304 C308 R305 C309 C310 C302 C303 R104 C107 R103 R105 R106 R205 R206 C207 R204 R203 C205 C103 C203 Q301 R301 IC301 C131 C231 CN306 Q305 J301 IC302 T301 C102 C202 C117 C114 C115 C214 R111 R127 R227 R213 C216 R212 R211 C215 C210 R208 C211 C212 R209 R207 R107 R108 R109 C110 C111 C112 C113 C317 C319 C320 C371 D331 C372 R326 C318 C228 C128 R114 C124 C218 C118 C219 C119 C321 C322 C141 C241 R118 R218 HRP350 C105 Q302 FB309 RV101 C206 C106 C213 Q303 Q304 CN301 R303 R302 C217 C116 R113 R112 TP201 TP R214 C224 CN305 T201 T101 RV201 TP101 JR200 JW249 C209 C109 R210 R110 C123 C223 C222 C122 CN315 R448 R447 R431 R432 Q201 C142 C242 R119 C132 C221 R217 R131 R230 R130 R231 IC201 C232 R219 R228 R128 R133 R232 R132 R233 22 50V 22 50V 1k 47k 47k 220p 220p 0.1 1k 6.8k 10 50V 10k KRC102M-AT 2.2k 22k 2.2k KTA1266-GR-AT 10 50V 47 16V 0.015 18k 0.0068 18k 0.0068 0.018 0.01 100V 2.2 50V 10k 4700p 5.6k 2.2k 47k 2.2k 47k 4700p 10k 5.6k 330p 680p 680p KRA103M-AT 4.7k BA3126N 470p 470p 9P 2SD1387-34 -TP 2P BD3402KS2 10 50V 10 50V 10 50V 1 50V 10 50V 1 50V 180 1k 1k 150k 0.022 5.6k 180 10 50V 10 50V 4.7k 330p 330p 330k 100k 100k 4.7k 330k 10 50V 330p 330p 0.0082 22 50V 470 10V 220 10V 0.1 10EDB40 0.1 100k 470 10V 10 50V 10 50V 3.3k 47 50V 10 50V 10 50V 10 50V 10 50V 0.01 220 10V 10 50V 10 50V 4.7k 4.7k 330p KRC102M-AT 220k 27p 27p 0.0082 2SC2001TP -LK 2SC2001TP -LK 8P 5.6 5.6 10 50V 0.022 150k 5.6k (R) (GND) 3.3k 47 50V 15P 220k (L) 0 10 50V 10 50V 470k 470k 0.12 0.12 1800p 1800p 11P 100 100 100 100 KRC102M-AT 10 50V 10 50V 4.7k 470p 0.1 10k 100k 100k 100k 100k TC4053BF 470p 4.7k 4.7k 4.7k 22k 22k 22k 22k A1 A2 A3 A4 A5 B3 B4 B5 B1 B2 83 84 85 86 78 79 MD R MD L TAPE R TAPE L REC R REC L REC L REC R TAPE L MD L MD R TAPE R 88 87 73 72 71 70 69 68 67 18 58 31 32 47 48 49 TAPE L TAPE R PB NF R PB NF L PB OUT L PB OUT R NC NC TAPE IN L TAPE IN R REC NF R REC OUT R REC OUT L REC NF L ALC SC SI VDD GND VCC NC FILTER NC NC NC NC NC NC NC VOL OUT L NC NC VOL IN L TONE OUT L VOL IN R TONE OUT R NC BASS NF R BASS OUTR R BASS OUTR L BASS NF L NC TREBLE NF R TREBLE NF L NC NC LINE OUT R LINE OUT L NC NC MD IN R MD IN L TU IN L CD IN L ST CLK ST DOUT ST DIN ST CE TUNED STEREO L OUT AGND R OUT ST MUTE RDS+3.3V NC RDS INT RDS DATA SIGNAL R SIGNAL GND LINE MUTE SPEAKER RELAY PROTECT AMP POWER +9V CD IN R WAT IN R WAT IN L D 4V SIGNAL L SAOUT1 SAOUT2 AC DET(SWTCHING) L-PB L-REC R-PB E-HOT R-REC GND GND VOL OUT R NC NC NC TU IN R (1/3) INPUT SEELCT, TONE CONTROL, ELECTRICAL VOLUME Q306,307 REC BIAS SWITCH RIPPLE FILTER BIAS OSC BIAS OSC Q303,304 LEVEL SHIFT Q301,302 REC/PB SWITCH R L AM FM 75Ω ANTENNA THE ASSEMBLED BLOCK SUPPLIED WITH FM/AM TUNER PACK (REC/PB/ERASE) GND LCH AGND RCH +9V DAB+3.3V DAB+5V DAB-OUT DAB-IN CD_MGND CD+7V TUNER SELECT SWITCH 1Y 0Y 1Z Z_COM 0Z INH VEE GND VCC Y_COM X_COM 1X 0X A B C TUNER SELECT AUDIO IN (Page 34) (Page 35) (Page 31) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. (Page 37) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 34 34 HCD-GPX9 6-12. SCHEMATIC DIAGRAM – MAIN Section (2/3) – • See page 44 for Waveforms. • See page 49 for IC Pin Function Description. 1SS133T C342 C343 CN303 C367 C368 FB306 C137 R123 R350 R224 C238 C237 R223 R124 R318 R319 R320 R321 R322 R323 R324 R325 Q308 Q310 R311 C314 Q309 R312 R314 C396 C395 D311 D312 Q311 R126 R226 Q318 R342 R341 R340 R339 R443 R442 R441 R440 R438 R434 R455 R458 R459 R460 R461 R463 R465 R469 R468 R472 R475 R330 R332 R331 C333 R489 R490 R491 R368 R369 R370 R495 R494 R333 C335 C334 R334 Q314 C336 C337 C340 R372 R373 X301 R411 R409 R417 R418 R419 R420 R422 R423 R424 R406 R405 R404 IC305 R412 R335 D317 D318 CN302 X302 C138 R315 FB301 FB305 FB307 R358 R359 R362 R361 R360 R474 R413 Q317 Q202 Q102 C362 R484 R363 R379 FB308 R367 IC306 R429 R430 D309 D307 D308 D306 D305 D304 D303 D302 D301 JR233 R337 R336 CN304 JR234 JR235 C338 C339 R450 D334 D335 D320 D321 C354 D366 FB302 C393 0.1 2200 10V 7P 1000 10V 0.1 0 22 50V 1k 4.7k 100k 220p 22 50V 1k 100k 10k 22k 47k 4.7k 4.7k 4.7k 10k 10k KTA1271Y-AT KTA1271Y-AT 47k 0.0047 KRC402-RTK 1k 47k 0.1 2200 6.3V 10EDB40 10EDB40 KRC402-RTK 10k 10k KRC102S-RTK 47k 47k 47k 47k 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 220 4.7k 10k 10 50V 0 0 0 3.3k 3.3k 3.3k 100 100 22k 0.1 0.1 47k KTC3199GR-RTK 0.22F 5.5V C341 100 25V 0.1 0.1 47k 47k 32.768KHz 1k 10k 10k 100 100 47k 100 100 100 100 100 10k BD4729G-TR 1k 10k 1SS133T 1SS133T 8P 16MHz 220p 1k 0 47k 47k 10k 10k 47k 1M 0 KRA102S-RTK 2SC3624T1L1718 2SC3624T1L1718 0.1 100 10k 10k 0 M30622MEP -A27FPU0 4.7k 4.7k 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 0 100 100 17P 0 0 22p 27p 47k 1SS133T 1SS133T 1SS133T 100p MTZJ-T-77-3.9 0 0.1 A1 A2 A3 A4 A5 C1 C2 C3 C4 C5 C6 C8 C10 C11 C12 C13 C14 C15 65 63 61 60 59 77 76 75 78 88 79 6 5 4 3 100 7 84 85 86 87 83 57 80 89 94 90 95 91 21 39 58 67 68 69 70 71 72 73 94 53 55 95 60 59 61 63 65 55 19 24 34 23 38 22 39 22 23 24 34 38 43 42 41 40 76 77 18 19 47 48 49 31 32 RESET NMI AC-CUT IICDATA IICCLK AVSS VREF AVCC VCC XIN VSS XOUT XCOUT XCIN SIRCS IN/WAKE RDS-CLK CD SCOR CD BD POWER CD XRST CD XLT CD SENS CD MP3REQ CD MILP CD MP3STB CD MICS CD MP3RST CD MICK CD CLK CD DATA CDM80 LOAD-OUT CDM80 LOAD-IN VCC VSS (CHUCK SW)CDM80 SW2 (OUT SW)CDM80 SW1 (TRIGGER SW)CDM80 SW3 FAN DRIVE ST MUTE ST STEREO ST TUNDE ST CE ST DATA OUT ST DATA IN ST CLK KEY WAKE UP TC PLAY TC TRG TC CAPM CONT BIAS ON CNVSS BYTE FLSTB VOL B VOL A STBY LED RDS DATA FL CLK RY ON WATPOW LINE MUTE PROTECT SP RELAY AMP POWER EQ DATA EQ CLK TC END SW TC HALF/REC SW MODEL DEST KEY3 KEY2 KEY1 TC R/P MGND SW2(CHUCK SW) SW1(OUT SW) SW3(TRIGGER SW) FIN(POS) RIN(NEG) END SW MGND TRGM+ PACK F REC R REC PLAY SW CD MIDIN CD MIDIO CD AMUTE CD DISCSEN1 CD DISCSEN2 NC M+10V SW4(8CM) SW3(PUSH-CLOSE) LOD NEG LOD POS SW-POWER TC DOOR SW XTCN DATA FL (2/3) THE ASSEMBLED BLOCK SUPPLIED WITH TAPE MECHANISM DECK BLOCK Q308,309 PLUNGER DRIVE Q310,311 CAPSTAN/REEL MOTOR DRIVE Q317,318 CD MUTING CONTROL Q102,202 MUTING VOLTAGE DETECT SWITCH RESET SYSTEM CONTROLLER SCOR SENS CLK XLT DATA DOUT DVDD DGND AVDD LOUT AGND ROUT XRST MGND(7V) M+7V AGND XTACN BASS B BASS A TRE B TRE A DAB DATA IN DAB DATA OUT SW2-1(CLOSE) UK LOCAL DAB SELECT DAB POWER 3.3 DAB POWER 5 M+7V (Page 29) (Page 27) (Page 33) (Page 35) Ver. 1.1 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 35 35 HCD-GPX9 Q320 R381 R396 CN308 CN310 CN307 CN316 Q322 R393 Q323 R395 C373 R394 Q321 C330 Q312 R375 Q319 R382 R374 Q313 C327 C326 C325 L302 IC304 D330 D329 C394 L102 L202 C134 C133 C233 C234 R222 R122 RY301 C235 C135 C331 C328 C329 CN309 TM301 D314 D316 D319 D325 D326 D327 C236 C136 D333 D332 KRC102S-RTK 47k 33k 4P 21P 12P 3P KTA1271Y-AT 47k KRC102S-RTK 1k 47 16V 1k KRC102M-AT 470 10V KTA1273Y-AT 1k KTA1273Y-AT 1k 47k KRC102S-RTK 0.01 0.01 470 10V TA7809S 1SS355 1SS355 0.1 0.1 0.1 0.1 0.1 10 1/2W 10 1/2W 0.01 0.01 470 10V 2200 10V 10 50V 6P 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1000p 1000p 1SS133T 1SS133T C1 C2 C3 C4 C5 C6 C8 C10 C11 C12 C13 C14 C15 B3 B4 B5 B1 B2 80 89 90 91 100 3 4 5 6 7 21 41 42 43 53 57 40 VOL-A VOL-B FL-CLK FL-STB FL-DATA STBY-LED SIRCS 3.3V KEY1 KEY2 KEY3 TRE-A TRE-B BASS-A BASS-B FL -3OV U COM +B U-COM GND UNREG HIGH UNREG GND TC MGND CD M7V CD MGND D 4V D GND RELAY ON FL AC FL AC FL -30V RELAY - RELAY + GND LCH GND RCH SP OUT RCH SP OUT LCH DGND TC M10V SW SW 9V GND (CD DIGITAL) GND (REF) GND (REF) R CH L CH L GND R GND +9V REGULATOR (CHASSIS) (3/3) BLOCK SUB POWER (1/2) L R IMPEDANCE USE 6 – 16Ω SPEAKER FL-AC FL-AC DRIVEGND FLDRIVE+B Q322,323 B+ SWITCH SWITCH RELAY DRIVE Q319,320 Q312,313 B+ SWITCH O G I (Page 39) (Page 33) (Page 43) (Page 37) (Page 37) (Page 34) 6-13. SCHEMATIC DIAGRAM – MAIN Section (3/3) – w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 36 36 HCD-GPX9 6-14. PRINTED WIRING BOARD – AMP Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. JW624 C617 C503 C603 C553 Q608 Q609 Q610 Q611 CN605 D609 R562 D610 D612 C606 C604 C605 C607 C608 C609 CN603 C506 R512 Q551 R564 R514 C611 D611 CN601 Q606 Q605 C557 C507 D551 C610 Q502 C556 D603 D501 C501 C551 Q501 Q604 R607 R608 CN604 Q552 C613 CN602 R606 R615 IC601 C615 C614 R560 R510 C612 JW619 JW614 JW602 JW618 JW613 JW616 JW620 JW643 JW608 JW640 JW607 JW604 JW606 JW603 JW609 JW610 JW612 JW644 JW615 JW641 JW642 JW611 JW621 JW617 JW632 JW622 JW623 JW626 JW627 JW628 JW629 JW630 JW631 JW633 JW634 JW625 C505 C555 C502 R565 C552 R515 R555 R505 IC602 R509 R605 R553 R503 R551 R609 R513 R563 R624 R626 R622 R625 R620 R552 R621 R619 R558 R601 R511 R559 C616 R508 Q603 R507 R502 R612 R614 R611 R602 Q602 R603 R604 R501 C554 R557 R561 R613 C504 Q601 R610 R628 R506 R556 3 1 AMP BOARD 1-526-594- 11 (13) MAIN BOARD CN306 D MAIN BOARD CN316 F POWER BOARD CN902 J MAIN BOARD CN309 E PANEL (2) BOARD CN311 K 1 3 6 4 E E E E E E E E E E E E E E 1 3 1 6 1 7 A B C D E F 1 2 3 4 5 (Page 32) (Page 32) (Page 32) (Page 40) (Page 42) • Semiconductor Location Ref. No. Location D501 F-5 D551 F-5 D603 C-3 D609 B-3 D610 B-2 D611 B-4 D612 B-2 IC601 E-5 IC602 B-2 Q501 C-4 Q502 F-4 Q551 C-4 Q552 F-4 Q601 B-4 Q602 C-4 Q603 C-3 Q604 C-3 Q605 C-2 Q606 C-3 Q608 B-2 Q609 C-2 Q610 C-2 Q611 C-2 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 37 37 HCD-GPX9 6-15. SCHEMATIC DIAGRAM – AMP Board – • See page 44 for IC Block Diagram. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Q501 Q551 R507 C505 C502 R502 C501 R508 R509 D501 Q502 R511 D551 R559 Q552 R558 C503 R552 C553 C555 R557 C551 D611 R503 R553 R501 R602 R515 R565 R551 C610 C611 R601 R603 R605 C613 R610 R609 D603 R608 R561 R562 R512 C507 C506 C557 Q604 C612 R613 R612 R611 Q606 Q605 R614 C556 D609 C616 R628 Q608 C604 R619 R621 C605 R622 D612 R620 D610 Q611 R625 R563 R626 C606 C607 R624 C609 R564 R514 CN605 CN604 CN602 Q609 Q610 C552 CN601 Q601 R604 Q602 Q603 C617 R505 R556 R555 C603 C615 C614 CN603 R513 R510 IC602 R560 R615 R506 C504 R607 R606 IC601 C554 C608 2SC3623ATP-LK 2SC3623ATP-LK 56k 15p 220p 56k 10 50V 1k 15k 1SS133T-72 KTA1266-GR-AT 100k 1SS133T-72 15k KTA1266-GR-AT 1k 47 50V 56k 47 50V 15p 56k 10 50V 1SS133T -72 1k 1k 2.2k 220k 100k 100k 2.2k 22 50V 22 50V 10k 2.2k 4.7k 10 50V 33k 10k 1SS133T -72 100 100k 10 1/2W 10 1/2W 0.1 0.22 50V 0.1 KTC3199GR-RTK 220 50V 10k 100k 10k KTC3199GR-RTK KTA1266-GR-AT 10k 0.22 50V 1SS133T -72 0.1 470k KTC3199GR-RTK 10 50V 1k 100k 100 10V 22k 1SS133T -72 4.7k 1SS133T-72 KTC3199GR -RTK 100 56k 100 0.001 10 50V 1k 2.2 50V 470 2W 470 2W 3P 3P 7P KTC3199GR -RTK KTC3199GR -RTK 22Op 9P KRA102S-RTK 2.2k KRA102S-RTK KRC102S-RTK 0.001 0 0 0.001 6P 47k 0.22 2W RT8H015C-T112-1 0.22 2W 470p 1 1 470p 100 10V 1.8k 1.8k UNREG HI +POWER -POWER POWER GND SIGNAL L SIGNAL R SIGNAL GND LINE MUTE SPEAKER RELAY PROTECT AMP POWER RELAY - RELAY + GND LCH GND RCH SP OUT RCH SP OUT LCH D 4V AC DETECT HP LCH HP GND HP RCH AC DET(SWTCHING) GND HIGH GND (CD DIGITAL) GND (REF) GND (REF) GND LOW (CHASSIS) POWER AMP MUTING MUTING MUTING POWER ON Q602,603 MUTING CONTROL PROTECT SWITCH OVER LOAD DETECT OVER LOAD DETECT SWITCH RELAY OFF Q610,611 RELAY DRIVE CT GND VCC OCP VP OUT RELAY Q605,606 B+ SWITCH 470 2W SWITCH STANDBY 2200 50V 2200 50V STK433-040 PROTECT CONTROL (Page 33) (Page 35) (Page 43) (Page 41) (Page 35) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 38 38 HCD-GPX9 6-16. PRINTED WIRING BOARD – PANEL (1) Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. JW1 JW2 JW3 JW4 JW5 JW6 JW7 JW9 JW10 JW11 JW20 JW25 JW26 JW27 JW28 JW29 JW30 JW31 JW32 JW33 JW34 JW35 JW39 JW40 JW41 JW18 JW44 JW45 JW46 JW47 JW24 JW21 JW16 JW53 JW38 JW13 JW12 JW54 JW55 JW36 JW37 JW19 JW15 JW22 JW8 D810 D804 C805 CN801 Q805 Q806 Q807 IC802 R856 C841 FL701 C840 D802 D805 D803 D806 S703 S702 S716 S715 S705 S704 S709 S710 S802 S801 S803 S706 S707 S708 S701 S717 S712 S711 S714 S713 C832 Q808 CN802 JW48 B11 C842 Q802 R832 R831 R842 Q801 R835 R841 C804 R861 R862 R845 R848 R830 Q804 Q803 R852 R853 R854 R855 C839 R857 R858 R859 R860 C837 R851 R850 R849 C836 C835 C834 R847 R846 R819 R818 R817 R816 R815 R814 R813 R812 R811 R807 R806 R805 R804 R803 R802 R801 C811 C810 C809 C808 C807 C806 C838 C833 C831 C830 C829 C828 C827 C826 C825 C823 C822 C821 C820 IC801 C824 E E E E E 1 44 22 23 34 33 11 12 E E E PANEL (1) BOARD 1-576-593- 11 (12) DIRECTION CD SYNCHRO DSGX (TAPE) REC PAUSE/START MAIN BOARD CN310 H TAPE BAND TUNER DAB TUNING MODE D802, S715 D803, S704 DISPLAY FUNCTION 1 3 D804, S701 BASS ROTARY ENCODER 1 3 VOLUME ROTARY ENCODER 1 3 TREBLE ROTARY ENCODER 1 3 TUNING FM MODE + – PANEL (2) BOARD CN803 L S701 – 717 FL701 FLUORESCENT INDICATOR TUBE A B C D E F G 1 2 3 4 5 6 7 8 (TAPE) (TAPE) (Page 32) (Page 40) • Semiconductor Location Ref. No. Location D802 G-3 D803 C-3 D804 B-7 D805 A-5 D806 A-6 D810 C-3 IC801 B-5 IC802 B-7 Q801 B-3 Q802 F-3 Q803 C-3 Q804 B-7 Q805 A-5 Q806 A-5 Q807 A-5 Q808 A-5 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 39 39 HCD-GPX9 6-17. SCHEMATIC DIAGRAM – PANEL (1) Board – • See page 44 for IC Block Diagram. (Page 35) R842 R803 R802 R801 R804 R805 R806 R807 R819 R818 R817 R816 R815 R814 R813 R812 R811 S701 S702 S703 S704 S705 S706 S707 S708 S717 S716 S715 S714 S713 S712 S711 S710 S709 R831 R832 R830 C804 C805 C806 C807 C808 C809 C810 C811 R841 Q804 R845 C838 C821 C820 C823 C824 C822 C825 C826 C827 C828 C829 C830 C837 C834 C835 C836 R846 R847 R848 C833 C831 C832 R849 R850 R851 R859 R860 R858 D806 R835 R852 R853 R854 R855 C840 C839 D805 Q807 Q806 Q805 R856 C841 R857 CN801 CN802 FL701 D810 IC801 Q808 D804 S801 S802 S803 D802 D803 Q803 Q802 Q801 C842 R861 R862 IC802 150 470 330 220 680 1k 1.5k 2.2k 10k 4.7k 2.2k 1.5k 1k 680 470 330 220 150 100 56 0.01 10 50V 0.01 0.01 0.01 0.01 0.01 0.01 100 KRC102S-RTK 0 220p 220p 220p 220p 220p 220p 220p 220p 220p 220p 220p 220p 0.1 0.001 100p 0.001 100k 100k 82k 0.1 220p 10 50V 100 100 100 100 100 10k MTZJ-T-73 -5.1B 100 4.7k 4.7k 4.7k 4.7k 100 10V 0.01 MTZJ-T-73-33B KTA1266-GR -AT KTA1266-GR -AT KTA1266-GR -AT 10 22 50V 100k 21P 5P 10EDB40 -TB3 PT6315 KTA1266-GR -AT SLR325VC-N-T32 SLR325DC-P -T32 SLR325DC-P -T32 KRC102S-RTK KRC102S-RTK KRC102S-RTK 4700p 0 0 RPM7240 23 24 25 26 27 28 29 32 33 VOLA VOLB TREBLEB TREBLEA BASSA BASSB 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 42 41 40 39 38 37 36 35 34 33 32 31 31 BASSB BASSA VOLA VOLB TREBLEA TREBLEB 14 15 16 17 18 19 20 21 22 34 35 36 37 38 39 40 41 42 FL-AC FL-AC F1 F1 P16 P15 P14 P13 P12 P11 P10 P9 P8 P7 P6 P5 P4 P3 P2 P1 12G 11G 10G 9G 8G 7G 6G 5G 4G 3G 2G 1G F2 F2 SG10 SG11 SG12 SG13 SG14 SG15 SG16 VEE GR1 GR2 GR3 GR4 GR5 GR6 GR7 GR8 GR9 GR10 GR11 GR12 VDD VSS LED1 LED2 LED3 LED4 DSC DOUT DIN CLK K1 K2 STB VSS VDD SG1 SG2 SG3 SG4 SG5 SG6 SG7 SG8 SG9 FL-CLK FL-STB FL-DATA DRIVEGND 3.3V STBY-LED KEY1 KEY2 KEY3 VOLA VOLB SIRCS FLVDRIVE+B DGND KEY3 GND KEY2 LED-CD+ LED-CD- FLUORESCENT INDICATOR TUBE FL -30V TRE-A TRE-B BASS-A BASS-B Q805-807 -30V REGULATOR CURRENT LIMIT LED DRIVE REMOTE CONTROL RECEIVER VOLUME BASS TREBLE ROTARY ENCODER ROTARY ENCODER ROTARY ENCODER FL/LED DRIVER BAND TUNER TAPE Q801-803 LED DRIVE TAPE REC PAUSE/START CD SYNCHRO DIRECTION DSGX TUNING MODE BAND DAB TUNER + − TUNING FM MODE FUNCTION DISPLAY (TAPE) (Page 41) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 40 40 HCD-GPX9 6-18. PRINTED WIRING BOARD – PANEL (2) Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. JW43 JW52 JW51 JW56 JW50 JW42 D801 CN311 CN803 J321 S718 S722 S719 S726 S721 S725 S723 S724 S720 C236 C136 FB121 FB221 R826 R828 R825 R822 R821 R824 R823 R827 l L 1 5 PANEL (2) BOARD 1-526-597- 11 (12) AMP BOARD CN604 K D801, S724 REPEAT PLAY MODE PHONES CD (CD) S718 – 726 PANEL (1) BOARD CN802 L A B C 1 2 3 4 5 6 7 8 (Page 36) (Page 38) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 41 41 HCD-GPX9 6-19. SCHEMATIC DIAGRAM – PANEL (2) Board – C236 C136 CN311 R821 R822 R823 R824 R825 R826 R827 R828 S725 S724 S723 S722 S721 S720 S719 S718 CN803 S726 FB221 FB121 J321 D801 0.001 0.001 3P 220 330 470 680 1k 1.5k 2.2k 4.7k 5P 0 0 SLR325DC-P-T32 L_CH(HP) R_CH(HP) GND(HP) KEY3 GND KEY2 LED-CD+ LED-CD- PHONES (CD) CD REPEAT PLAY MODE CD l L (Page 37) (Page 39) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 42 42 HCD-GPX9 6-20. PRINTED WIRING BOARD – POWER Board – • See page 26 for Circuit Boards Location. : Uses unleaded solder. • Semiconductor Location Ref. No. Location D901 C-7 D902 B-6 D903 B-6 D904 B-6 D905 B-6 D906 C-6 D907 C-6 D908 C-6 D909 C-6 D910 C-3 D911 B-5 D912 B-5 D913 C-3 IC901 C-3 IC902 C-3 IC903 C-4 JW913 JW918 JW921 JW919 JW925 JW931 JW932 JW935 JW936 JW911 JW916 JW915 JW934 JW917 JW933 JW912 JW937 JW922 JW914 JW929 JW939 JW904 CN904 F902 JW907 C907 JW902 F901 JW906 T901 CN902 R901 D909 CN903 IC903 D908 D902 D903 D904 D905 D906 D907 C912 C909 C905 D913 RY901 C902 IC901 C904 C901 C903 CN901 C915 R909 D912 R902 D911 D901 R903 C914 C913 R905 R904 D910 JW938 JW930 JW927 JW928 JW924 JW923 IC902 JW920 POWER BOARD 1-526-598- 11 (12) AMP BOARTD CN602 J MAIN BOARD CN307 G NOT REPLACEABLE: BUILT IN TRANSFORMER MAIN POWER TRANSFORMER 1 2 (AC IN) 2 1 SUB POWER BLOCK (2/2) 1 3 1 3 1 3 A B C D E F G G 1 2 3 4 5 6 7 1 7 (Page 32) (Page 36) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 43 43 HCD-GPX9 6-21. SCHEMATIC DIAGRAM – POWER Board – The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. C903 IC902 C905 C904 R909 C915 C902 C901 D911 D912 R902 R901 C913 C914 R904 R903 C907 D903 D905 D904 D902 D906 D907 D909 D908 R905 JW906 D913 CN904 CN903 IC901 CN901 C912 T901 C909 D910 D901 JW902 JW904 JW939 F902 F901 CN902 RY901 JW907 470 10V TA7807S IC903 µPC3504AHF 3300 25V 470 10V 2.2k 10 50V 3300 25V 470 10V 1SS133T-72 1SS133T-72 1k 1k 0.1 0.1 0.22 0.22 0.1 1N4002 1N4002 1N4002 1N4002 1N4002 1N4002 1N4002 1N4002 3.3 1SS133T-72 2P 2P TA7810S 12P 220 50V 0.1 10EDB40 ∗ ∗ UNREG HIGH UNREG GND TC MGND CD M7V CD MGND D 4V D GND RELAY ON FL AC FL AC FL -30V UNREG HI +POWER -POWER POWER GND AC DETECT TC M10V GND HIGH GND LOW O G I +10V REGULATOR O G I G I O +4V REGULATOR +7V REGULATOR MAIN POWER TRANSFORMER BUILT IN TRANSFORMER NOT REPLACEABLE: ∗ (AC IN) BLOCK SUB POWER (2/2) ∗ F901,902 T3.15A 250V D3SBA20 220V 1 7 (Page 35) (Page 37) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-GPX9 44 44 HCD-GPX9 • Waveforms Approx. 200 mVp-p Approx. 400 mVp-p 0.7 Vp-p 59 µs 3.4 Vp-p 21.2 µs 12.4 Vp-p 21.2 µs 2.6 Vp-p 30.4 µs 3.2 Vp-p 62.6 ns 2 Vp-p 6.3Vp-p 2 s – BD Board – – MAIN Board – 1 IC101 w; (TEI) (CD Play Mode) 0.1 V/DIV, 2 ms/DIV 1 Q303, 304 (Collector) (REC Mode) 5 V/DIV, 20 µs/DIV 2 IC101 ws (FEI) (CD Play Mode) 0.1 V/DIV, 2 ms/DIV 2 Q303, 304 (Base) (REC Mode) 1 V/DIV, 10 µs/DIV 3 IC101 ek (RFACO) (CD Play Mode) 0.2 V/DIV, 0.5 µs/DIV 3 IC306 qa (XCOUT) 1 V/DIV, 10 µs/DIV 4 IC101 us (XTAO) 1 V/DIV, 0.1 µs/DIV 4 IC306 qd (XOUT) 500 mV/DIV, 20 ns/DIV 5 IC306 of (TC END SW) (Tape Play Mode) 2 V/DIV, 1 s/DIV IC701 BA6956AN 1 2 3 4 5 6 7 8 9 CONTROL LOGIC TSD VREF OUT2 OUT1 RNF VM VCC FIN GND RIN • IC Block Diagrams – DRIVER Board – w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 45 HCD-GPX9 – BD Board – IC101 CXD3058AR XRST SERVO INTERFACE 30 RFDCO 32 AC_SUM 33 EQ_IN 31 PDSENS 29 AVDD4 85 LMUT 86 XTSL 87 IOVSS0 88 XTACN 89 SQSO 90 SQCK 91 97 98 SBSO 92 93 94 95 96 99 EXCK 1 MIRR 2 DFCT 3 FOK 9 SFDR 10 SRDR 11 TFDR 12 TRDR 13 FFDR 14 FRDR 18 E 19 F 25 A 26 B 27 C 28 D 20 TEI 22 FEI 21 TEO 23 FEO 24 VC 5 LOCK 6 MDP 7 SSTP 4 VSS 8 IOVSS1 15 IOVDD1 16 AVDD0 17 AVSS0 64 EMPH 62 BCK 63 VDD 67 DOUT 65 EMPHI 66 IOVDD2 60 VSS 59 LRCK 61 PCMD 69 TES1 70 IOVSS2 73 XTAI 71 XVSS 74 XVDD 75 AVDD1 72 XTAO 68 TEST MIRR DFCT FOK TE FE SUM PWM GENERATOR SERVO DSP A/D CONVERTER DC/DC CONVERTER ASYNMMETRY CORRECTOR SUB CODE PROCESSOR ERROR CORRECTOR 32k RAM D/A INTERFACE D/A COVERTER SELECTOR DIGITAL OUT CPU INTERFACE CLOCK GENERATOR SERVO AUTO SEQUENCER LPF LPF DIGITAL CLV VC ATT 36 RFC EQ 38 RFACO AMP 34 LD 35 PD 39 RFACI 40 AVDD3 41 BIAS 53 DDVRSEN 54 AVSS5 51 AVDD5 55 DDCR 56 BCKI 52 DDVROUT 42 ASYI 44 VPCO 45 VCTL 46 AVSS3 43 ASYO DIGITAL PLL EFM DEMODULATOR 48 FILO 47 CLTV 49 FILI 50 PCO 37 AVSS4 APC 105 XPCK 104 XUGF 103 WFCK 102 ATCK SYSM VSS DATA XLAT VDD 100 SENS CLOK 101 SCLK 106 GFS 109 VDD 108 SCOR 107 C2PO 110 C4M 112 COUT 111 WDCK 77 VREFL 78 AVSS1 79 AVSS2 76 AOUT1 81 AOUT2 82 AVDD2 83 IOVDD0 84 RMUT 80 VREFR 57 PCMDI 58 LRCKI www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 46 HCD-GPX9 – DAB Board – IC907 BA50BC0WFP-E2 IC911 BA33BC0WFP-E2 THERMAL SHUT DOWN OVER CURRENT PROTECT VDD VCC 2 GND 3 NC 5 OUT 4 CTL 1 – + VREF DRIVER 1 LEVEL SHIFT MUTING D 15 16 + – + – D D 17 18 D 19 20 VREF 21 22 23 24 25 26 27 28 PREVCC OPOUT OUTVREF CH4CAPA CH4IN CH3FIN CH3RIN GND MUTE POWVCC CH3OUTF CH3OUTR CH4OUTF CH4OUTR OPIN– 2 OPIN+ INTERFACE 14 13 D 12 11 D 10 9 8 7 6 CH2FIN CH2RIN GND 5 4 CH1FIN CH1RIN VREFIN POWVCC CH2OUTR CH2OUTF CH1OUTR CH1OUTF INTERFACE D D 3 SW INTERFACE IC251 BA5947FM-E2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 47 HCD-GPX9 – MAIN Board – 1 2 3 4 5 6 7 8 B1 B0 C.COM CO INH VEE VSS VDD B.COM A.COM A1 A0 A B C C1 9 10 11 12 13 14 15 16 OPEN OPEN OPEN IC201 HD14053BFP 1 D1 2 D2 3 E1 9 NC 10 NC 11 TAPE 1 12 TAPE 2 13 RECNF2 14 RECOUT2 5 PBNF2 6 PBOUT2 7 PBOUT1 4 E2 8 PBNF1 15 RECOUT1 16 RECNF1 33 VOLOUT1 34 NC 35 NC 36 VIN1 DIGITAL CONTROL 64 C2 + − + − + − ALC ATT ALC 17 ALC 18 SC 19 SI 27 NC 28 NC 29 NC 30 NC 20 VDD 21 GND 22 VCC 23 NC 24 FILTER 32 VOLOUT2 25 NC 26 NC + − BUFFER MIX 31 NC 38 VIN2 37 TONE OUT1 48 NC + − + − + − + − + − + − + − + − 63 C1 62 B2 61 B1 60 A2 59 A1 45 NC 44 BNF1 42 BOUT2 41 BNF2 39 TONE OUT2 40 NC 47 NC 46 NC 43 BOUT1 58 NC 56 NC 55 NC 57 NC + − INPUT SELECT + − + − 54 LINEOUT1 53 LINEOUT2 52 NC 51 NC 49 TNF2 50 TNF1 TONE CONTROL TONE CONTROL ATT IC302 BD3402KS2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 48 HCD-GPX9 – AMP Board – IC602 RT8H015C-T112-1 1 2 3 OCP VP OUT OVER LOAD DETECT DC DETECT 4 CT 5 GND 6 VCC – PANEL (1) Board – IC801 µPD16315GB-3BS 5 OSC OSC DATA SELECTOR 6 DOUT 7 DIN 8 CLK 9 STB 10 KEY1 11 KEY2 SERIAL INTERFACE DISPLAY MEMORY 24 BITS x 12 WORDS 24-BIT OUTPUT LATCH 12-BIT SHIFT REGISTER SEGMENT DRIVER TIMING GENERATOR KEY SCAN COMMAND DECODER DIMMING CIRCUIT KEY DATA MEMORY (2 x 16 BITS) 4-BIT LATCH 1 LED1 2 LED2 3 LED3 4 LED4 24 16 16 12 4 8 8 4 8 27 SEG14/KS14 29 SEG16/KS16 30 VEE 28 SEG15/KS15 8 31 SEG17/GRID12 33 SEG19/GRID10 32 SEG18/GRID11 23 SEG10/KS10 24 SEG11/KS11 25 SEG12/KS12 26 SEG13/KS13 22 SEG9/KS9 21 SEG8/KS8 20 SEG7/KS7 19 SEG6/KS6 18 SEG5/KS5 17 SEG4/KS4 16 SEG3/KS3 15 SEG2/KS2 14 SEG1/KS1 MULTIPLEXED DRIVER 34 SEG20/GRID9 35 SEG21/GRID8 36 SEG22/GRID7 37 SEG23/GRID6 39 GRID4 40 GRID3 41 GRID2 42 GRID1 43 VDD 44 VSS 13 VDD 12 VSS 38 SEG24/GRID5 GRID DRIVER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 49 HCD-GPX9 • IC Pin Function Description MAIN BOARD IC306 M30622MEP-A27FPU0 (SYSTEM CONTROLLER) Pin No. Pin Name I/O Description 1 CD DISCSENS 2 I Not used 2 CD DISCSENS 1 I Not used 3 STBY LED O LED drive signal output terminal (power) 4 SIRCS IN/WAKE I SIRCS signal input terminal 5, 6 VOL A, VOL B I Jog dial pulse input terminal (volume) 7 FLSTB O Serial data read strobe signal output to the FL/LED driver 8 BYTE I External data bus width select signal input terminal 9 CNVSS - Ground terminal 10 XCIN I Sub system clock input terminal (32.768 kHz) 11 XCOUT O Sub system clock output terminal (32.768 kHz) 12 RESET I System reset signal input terminal "L": reset For several hundreds msec. after the power supply rises, "L" is input, then it changes to "H" 13 XOUT O Main system clock output terminal (16 MHz) 14 VSS - Ground terminal 15 XIN I Main system clock input terminal (16 MHz) 16 VCC - Power supply terminal (+3.3V) 17 NMI I Non-maskable interrupt signal input terminal Not used 18 RDS-CLK I RDS serial data transfer clock signal input terminal 19 CD SCOR I Subcode Q data request signal input terminal 20 AC-CUT I Power down detection signal input terminal "L": power down 21 FL CLK O Serial data transfer clock signal output to the FL/LED driver 22 CD XRST O System reset signal output to the CD servo block 23 CD XLT O Latch pulse signal output to the CD servo block 24 CD SENS I Internal status (SENSE) input from the CD DSP 25 CD MILP O Serial data latch pulse output to the MP3 decoder Not used 26 CD MICS O Chip select signal output to the MP3 decoder Not used 27 CD MP3REQ I Data transfer request signal input from the MP3 decoder Not used 28 CD MP3STB O Standby signal output to the MP3 decoder Not used 29 IICCLK I/O IIC data transfer clock signal input and output Not used 30 IICDATA I/O IIC two-way data bus Not used 31 DAB DATA IN I Serial data input from the DAB module 32 DAB DATA OUT O Serial data output to the DAB module 33 CD MP3RST O Reset signal output to the MP3 decoder Not used 34 CD CLK O Serial data transfer clock signal output to the CD DSP 35 CD MIDIO O Serial data output to the MP3 decoder Not used 36 CD MIDIN I Serial data input from the MP3 decoder Not used 37 CD MICK O Serial data transfer clock signal output to the MP3 decoder Not used 38 CD DATA O Serial data output to the CD DSP 39 CD AMUTE O CD muting on/off control signal output terminal 40 TRE A I Jog dial pulse input from the rotary encoder (treble) 41 TRE B I Jog dial pulse input from the rotary encoder (treble) 42 BASS A I Jog dial pulse input from the rotary encoder (bass) 43 BASS B I Jog dial pulse input from the rotary encoder (bass) 44 SW4 (8CM) I CD disc size detection (8cm/12cm) signal input terminal Not used 45 SW3 (PUSH- CLOSE) I CD push-close switch input terminal Not used Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 50 HCD-GPX9 Pin No. Pin Name I/O Description 46 SW2-1 (CLOSE) I CD close switch input terminal Not used 47 DAB POWER 5 O Power on/off control signal output for the DAB 48 DAB POWER 3.3 O Power on/off control signal output for the DAB 49 DAB SELECT O DAB/analog tuner (FM/AM) input selection signal output termianl 50 UK LOCAL I Destination setting terminal 51 LOD NEG O Loading motor control signal output Not used 52 LOD POS O Loading motor control signal output Not used 53 SW-POWER O Sub power block on/off control signal output terminal 54 - O Not used 55 XTCN O Oscillator control signal output to the CD DSP 56 - O Not used 57 CD BD POWER O Power on/off control signal output for CD block 58 RDS DATA I RDS serial data input terminal 59 CDM80 LOAD-OUT O Loading motor control signal output (loading out direction) 60 CDM80 LOAD-IN O Loading motor control signal output (loading in direction) 61 (TRIGGER SW) CDM80 SW3 I Trigger switch input terminal "L": switch on 62 VCC - Power supply terminal (+3.3V) 63 (OUT SW) CDM80 SW1 I Out switch input terminal "L": switch on 64 VSS - Ground terminal 65 (CHUCK SW) CDM80 SW2 I Chuck switch input terminal "L": switch on 66 FAN DRIVE O Fan motor drive signal output terminal Not used 67 ST MUTE O Tuner muting on/off control signal output terminal 68 ST STEREO I FM stereo detection signal input from the tuner unit "L": stereo 69 ST TUNED I Tuning detection signal input from the tuner unit "L": tuned 70 ST CE O Chip enable signal output to the FM/AM tuner unit 71 ST DATA OUT O Serial data output to the FM/AM tuner unit 72 ST DATA IN I Serial data input from the FM/AM tuner unit 73 ST CLK O Serial data transfer clock signal output to the FM/AM tuner unit 74 KEY WAKE UP I System wake up signal input terminal in the standby status 75 TC PLAY I Tape play switch input terminal 76 TC TRG O Plunger driver signal output terminal "L": plunger on 77 TC CAPM CONT O Capstan/reel motor drive signal output terminal "L": forward, "H": reverse 78 BIAS ON O REC bias on/off control signal output terminal "H": REC bias on 79 TC R/P O PB/REC switching control signal output terminal "L": PB 80 RY ON O Relay drive signal output for main power supply "H": power on 81 WATPOW O Not used 82 TC DOOR SW I Tape deck lid open/close detection signal input terminal Not used 83 LINE MUTE O Line muting on/off control signal output terminal "H": muting on 84 PROTECT I Protect signal input from the amplifier circuit "L": protect 85 SP RELAY O Speaker on/off relay drive signal output terminal "L": speaker off 86 AMP POWER O AMP muting on/off control signal output terminal "H": AMP on 87 EQ DATA O Serial data output to the electrical volume www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 51 HCD-GPX9 Pin No. Pin Name I/O Description 88 EQ CLK O Serial data transfer clock signal output to the electrical volume 89 to 91 KEY3 to KEY1 I Front panel key or headphone detection input terminal (A/D input) 92 MODEL I Setting terminal for the model type 93 DEST I Setting terminal for the destination 94 TC END SW I End switch detection from tape deck block 95 TC HALF/ REC SW I Half/REC switch detection from tape deck block 96 AVSS - Ground terminal 97 NC O Not used 98 VREF I Reference voltage (+3.3V) input terminal 99 AVCC - Power supply terminal (+3.3V) 100 FL DATA O Serial data output to the FL/LED driver www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 52 HCD-GPX9 SECTION 7 EXPLODED VIEWS Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 4-251-905-01 PLATE (L), SIDE 2 2-630-669-01 SHEET (TOP) 3 4-251-906-01 PLATE (R), SIDE 4 4-247-752-01 FOOT, RUBBER 5 4-251-908-42 COVER, HEAT SINK #1 7-685-871-01 SCREW +BVTT 3X6 (S) #2 7-685-647-11 SCREW +BVTP 3X10 TYPE2 IT-3 #3 7-685-872-01 SCREW +BVTT 3X8 (S) 7-1. SIDE PLATES SECTION • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories are given in the last of the electrical parts list. NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 1 2 5 3 4 not supplied not supplied not supplied front panel section top block section main section #1 #1 #1 #1 #2 #2 #2 #2 #3 #3 #3 #3 Ver. 1.1 • Abbreviation EE : East European model www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 53 HCD-GPX9 7-2. FRONT PANEL SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 4-251-909-01 KNOB, VOLUME 52 4-251-910-01 KNOB, B/T 53 X-2050-884-1 FRONT PANEL ASSY 54 A-1105-497-A PANEL (1) BOARD, COMPLETE 55 4-951-620-01 SCREW (2.6X8), +BVTP 56 A-4750-229-A PANEL (2) BOARD, COMPLETE 57 4-247-752-01 FOOT, RUBBER 58 4-249-984-01 FILTER (FL TUBE) 59 4-249-151-01 HOLDER, FL TUBE 60 4-251-887-01 INDICATOR, POWER 61 4-251-888-01 INDICATOR, RING 62 4-251-889-01 BUTTON, REC 63 4-251-889-11 BUTTON, REC 64 4-251-891-01 BUTTON, POWER 65 4-251-892-01 BUTTON, TUN 66 4-251-893-01 BUTTON, CD FL701 1-519-816-11 INDICATOR TUBE, FLUORESCENT 51 52 53 54 55 55 55 58 59 56 57 not supplied FL701 not supplied panel (1) board not supplied 64 61 60 65 65 62 63 66 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 54 HCD-GPX9 7-3. TOP BLOCK SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 X-4956-091-1 HOLDER ASSY, CASSETTE 102 4-251-899-02 SPRING, CASSETTE 103 4-251-898-03 CABINET, TOP 104 4-231-836-01 SPRING (HEART CAM-A) 105 4-231-824-01 CAM (A), HEART 106 4-224-104-41 DAMPER 107 3-701-748-00 CLAMP 108 1-796-351-41 MECHANISM, SIGNAL CASSETTE (CML1Z234A) #4 7-685-862-01 SCREW +BVTT 2.6X6 (S) #5 7-685-646-11 SCREW +BVTP 3X8 TYPE2 IT-3 101 102 103 104 105 106 107 108 not supplied not supplied not supplied #4 #4 #5 #5 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 55 HCD-GPX9 7-4. MAIN SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 151 A-1105-482-A MAIN BOARD, COMPLETE (UK) 151 A-1105-483-A MAIN BOARD, COMPLETE (AEP) 151 A-1105-484-A MAIN BOARD, COMPLETE (EE) 152 2-590-157-01 HOLDER DAB 153 A-1105-495-A DAB BOARD, COMPLETE (UK) 153 A-1126-082-A DAB BOARD, COMPLETE (AEP, EE) 154 1-478-669-11 MODULE (DAB TUNER) (UK) 154 1-479-310-11 MODULE (DAB TUNER) (AEP, EE) 155 4-247-752-01 FOOT, RUBBER 156 1-830-386-12 CORD (WITH CONNECTOR) (UK) 156 1-830-493-11 CORD (WITH CONNECTOR) (AEP, EE) 158 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P (UK) #1 7-685-871-01 SCREW +BVTT 3X6 (S) #2 7-685-647-11 SCREW +BVTP 3X10 TYPE2 IT-3 #5 7-685-646-11 SCREW +BVTP 3X8 TYPE2 IT-3 151 156 155 154 not supplied not supplied CD mechanism deck section-1 (CDM80B-K6BD80A) not supplied not supplied not supplied not supplied not supplied chassis section #2 not supplied #1 #1 #5 #1 #1 #5 #2 #1 #1 #1 #1 not supplied (included 156) (UK) 153 152 152 158 156 (AEP, EE) (AEP, EE) Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 56 HCD-GPX9 7-5. CHASSIS SECTION-2 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 201 4-251-907-01 HEAT SINK (NE7) 202 4-900-386-01 SCREW 203 A-1113-708-A POWER BOARD, COMPLETE 204 1-500-386-11 FILTER, CLAMP (FERRITE CORE) 205 3-703-244-00 BUSHING (2104), CORD 0206 1-751-520-31 CORD, POWER (UK) 0206 1-830-188-11 CORD, POWER (AEP, EE) 207 A-4753-293-A AMP BOARD, COMPLETE 208 1-468-738-11 REGULATOR, SWITCHING 209 1-693-626-11 TUNER (FM/AM) 210 3-701-748-00 CLAMP 211 4-812-134-31 RIVET (DIA. 3.5), NYLON 0F901 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15A/250V) 0F902 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15A/250V) 0T901 1-443-198-11 TRANSFORMER, POWER #1 7-685-871-01 SCREW +BVTT 3X6 (S) #6 7-685-650-71 SCREW +BVTP 3X16 TYPE2 IT-3 #7 7-685-874-01 SCREW +BVTT 3X12 (S) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 202 203 210 211 204 205 206 207 201 208 209 not supplied not supplied not supplied not supplied power board #6 #1 #1 #1 #1 #7 T901 F901 F902 Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 57 HCD-GPX9 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 351 2-515-538-01 SPRING (HOLDER DOWN B), COIL 352 X-4956-146-1 HOLDER (BU215) ASSY 353 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 354 4-227-549-11 INSULATOR 355 4-227-045-31 SPRING (INSULATOR), COIL 356 4-231-151-01 STOPPER (BU) 357 4-218-253-31 +SCREW (M2.6), +BTTP 359 3-087-053-01 +BVTP2.6 (3CR) 360 4-245-639-01 LEVER (CL UP2) 7-6. CD MECHANISM DECK SECTION-1 (CDM80B-K6BD80A) 353 353 352 351 354 354 355 355 356 357 353 BU-K6BD80A CD mechanism deck section-2 (CDM80B-K6BD80A) 359 360 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 58 HCD-GPX9 7-7. CD MECHANISM DECK SECTION-2 (CDM80B-K6BD80A) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 401 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 403 4-245-653-01 BELT (MOT) 404 4-245-662-02 PULLEY (GEAR) 405 4-245-646-01 GEAR (IDL-F) 406 4-245-644-01 GEAR (IDL-D) 407 4-245-645-01 GEAR (IDL-E) 408 4-246-203-01 LEVER (RELEASE) 409 4-245-630-01 LEVER (SW) 410 3-087-053-01 BVTP2.6 (3CR) 412 1-688-337-11 DRIVER BOARD M701 X-4955-496-1 MOTOR (PULLEY) ASSY (LOADING) #9 7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT #10 7-623-921-01 WASHER 1.7, NYLON CD mechanism section-3 (CDM80B-K6BD80A) 410 410 410 412 409 408 401 407 406 405 404 403 CD mechanism section-4 (CDM80B-K6BD80A) #10 M701 #9 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 59 HCD-GPX9 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 451 4-245-627-01 WASHER (6-2.7-0.4) 452 4-245-637-01 ROLLER, RUBBER 453 4-245-649-01 GEAR (IDL-I) 454 4-245-657-11 LEVER (LOADING-R) 455 4-245-647-01 GEAR (IDL-G) 456 4-245-648-01 GEAR (IDL-H) 457 4-245-655-01 CHASSIS (TOP) 458 4-245-631-11 SPT-T (LOADING-R) 459 4-245-650-01 GEAR (IDL-J) 460 4-245-651-11 GEAR (IDL-L) 461 4-245-640-01 GEAR (CAP) 462 1-452-925-21 MAGNET ASSY 463 4-245-638-01 LEVER (CL UP1) 464 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 465 4-245-636-01 SPR-T CL DOWN 466 4-245-658-11 LEVER (DISC STOP) 467 4-245-659-11 LEVER (DISC SENSOR) 468 4-245-632-11 SPR-T (LOADING-L) 469 X-2021-532-1 CLAMPER 213 ASSY 470 4-245-656-11 LEVER (LOADING-L) 7-8. CD MECHANISM DECK SECTION-3 (CDM80B-K6BD80A) 451 451 452 452 453 454 457 458 459 460 461 462 453 470 464 467 469 466 463 455 465 455 456 456 468 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 60 HCD-GPX9 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 501 4-245-643-01 GEAR (IDL-C) 502 X-2021-531-1 CHASSIS (BOTTOM) ASSY 503 2-515-536-01 SPRING (DIR), TENSION COIL 504 4-245-642-01 GEAR (IDL-B) 505 4-245-814-01 LEVER (DIR FIRST) 506 2-515-534-01 SPRING (DIR BACK), TENSION COIL 507 4-245-660-11 LEVER (DIR) 508 4-245-641-01 GEAR (IDL-A) 509 4-245-640-01 GEAR (CAP) 510 4-245-628-01 LEVER (BU LOCK) 511 4-248-206-01 WASHER (3-1-0.4) 512 4-245-624-01 LEVER, CLOSE 513 4-245-635-01 SPR-E LEVER CLOSE 514 4-245-629-01 GEAR (BU LOCK) 515 4-245-644-01 GEAR (IDL-D) 516 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 7-9. CD MECHANISM DECK SECTION-4 (CDM80B-K6BD80A) not supplied not supplied 501 502 515 505 503 507 508 509 504 506 511 512 513 514 509 510 516 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 61 HCD-GPX9 651 660 not supplied M102 (sled) not supplied M101 (spindle) S101 657 (including M101 (spindle), M102 (sled)) 658 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 651 A-4750-181-A BD BOARD, COMPLETE 0657 A-4735-357-A BASE ASSY, OP (KSM-213DCP) 658 1-827-991-11 WIRE (FLAT TYPE) (16 CORE) 660 3-087-053-01 +BVTP2.6 (3CR) S101 1-771-853-11 SWITCH, DETECTION (LIMIT) 7-10. BASE UNIT SECTION (BU-K6BD80A) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 62 HCD-GPX9 SECTION 8 ELECTRICAL PARTS LIST Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u: µ, for example: uA... : µA... uPA... : µPA... uPB... : µPB... uPC... : µPC... uPD... : µPD... • CAPACITORS uF: µF • COILS uH: µH AMP The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. A-4753-293-A AMP BOARD, COMPLETE ******************** < CAPACITOR > C501 1-126-964-11 ELECT 10uF 20% 50V C502 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C503 1-126-967-11 ELECT 47uF 20% 50V C504 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C505 1-162-917-11 CERAMIC CHIP 15PF 5% 50V C506 1-126-957-11 ELECT 0.22uF 20% 50V C507 1-130-495-00 MYLAR 0.1uF 5% 50V C551 1-126-964-11 ELECT 10uF 20% 50V C552 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C553 1-126-967-11 ELECT 47uF 20% 50V C554 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C555 1-162-917-11 CERAMIC CHIP 15PF 5% 50V C556 1-126-957-11 ELECT 0.22uF 20% 50V C557 1-130-495-00 MYLAR 0.1uF 5% 50V C603 1-162-294-31 CERAMIC 0.001uF 10% 50V C604 1-126-964-11 ELECT 10uF 20% 50V C605 1-104-665-11 ELECT 100uF 20% 25V C606 1-162-294-31 CERAMIC 0.001uF 10% 50V C607 1-126-964-11 ELECT 10uF 20% 50V C608 1-104-665-11 ELECT 100uF 20% 25V C609 1-126-961-11 ELECT 2.2uF 20% 50V C610 1-126-965-11 ELECT 22uF 20% 50V C611 1-126-965-11 ELECT 22uF 20% 50V C612 1-126-969-11 ELECT 220uF 20% 50V C613 1-126-964-11 ELECT 10uF 20% 50V C614 1-128-550-11 ELECT 2200uF 20% 50V C615 1-128-550-11 ELECT 2200uF 20% 50V C616 1-100-597-91 CERAMIC CHIP 0.1uF 10% 25V C617 1-130-471-00 MYLAR 0.001uF 5% 50V < CONNECTOR > CN601 1-568-828-11 CONNECTOR, FFC 9P * CN602 1-564-510-11 PLUG, CONNECTOR 7P CN603 1-564-509-11 PLUG, CONNECTOR 6P CN604 1-564-506-11 PLUG, CONNECTOR 3P CN605 1-815-444-11 PIN, CONNECTOR (PWB) 3P < DIODE > D501 8-719-991-33 DIODE 1SS133T-77 D551 8-719-991-33 DIODE 1SS133T-77 D603 8-719-991-33 DIODE 1SS133T-77 D609 8-719-991-33 DIODE 1SS133T-77 D610 8-719-991-33 DIODE 1SS133T-77 D611 8-719-991-33 DIODE 1SS133T-77 D612 8-719-991-33 DIODE 1SS133T-77 < IC > IC601 6-705-625-01 IC STK433-040 IC602 6-703-610-01 IC RT8H015C-T112-1 < TRANSISTOR > Q501 8-729-141-30 TRANSISTOR 2SC3623A-LK Q502 8-729-037-03 TRANSISTOR KTA1266GR-AT Q551 8-729-141-30 TRANSISTOR 2SC3623A-LK Q552 8-729-037-03 TRANSISTOR KTA1266GR-AT Q601 8-729-038-54 TRANSISTOR KRA102S Q602 8-729-038-54 TRANSISTOR KRA102S Q603 8-729-038-67 TRANSISTOR KRC102S Q604 8-729-016-42 TRANSISTOR KTC3199GR-TP Q605 8-729-037-03 TRANSISTOR KTA1266GR-AT Q606 8-729-016-42 TRANSISTOR KTC3199GR-TP Q608 8-729-016-42 TRANSISTOR KTC3199GR-TP Q609 8-729-016-42 TRANSISTOR KTC3199GR-TP Q610 8-729-016-42 TRANSISTOR KTC3199GR-TP Q611 8-729-016-42 TRANSISTOR KTC3199GR-TP < RESISTOR > R501 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R502 1-216-842-11 METAL CHIP 56K 5% 1/10W R503 1-216-821-11 METAL CHIP 1K 5% 1/10W R505 1-216-864-11 SHORT CHIP 0 R506 1-216-824-11 METAL CHIP 1.8K 5% 1/10W R507 1-216-842-11 METAL CHIP 56K 5% 1/10W R508 1-216-821-11 METAL CHIP 1K 5% 1/10W R509 1-216-835-11 METAL CHIP 15K 5% 1/10W 0R510 1-220-755-11 METAL 0.22 10% 2W F R511 1-216-845-11 METAL CHIP 100K 5% 1/10W R512 1-260-076-11 CARBON 10 5% 1/2W R513 1-216-841-11 METAL CHIP 47K 5% 1/10W 0R514 1-215-890-11 METAL OXIDE 470 5% 2W F R515 1-216-845-11 METAL CHIP 100K 5% 1/10W R551 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R552 1-216-842-11 METAL CHIP 56K 5% 1/10W Ver. 1.1 • Abbreviation EE : East European model www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 63 HCD-GPX9 BD AMP The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. R553 1-216-821-11 METAL CHIP 1K 5% 1/10W R555 1-216-864-11 SHORT CHIP 0 R556 1-216-824-11 METAL CHIP 1.8K 5% 1/10W R557 1-216-842-11 METAL CHIP 56K 5% 1/10W R558 1-216-821-11 METAL CHIP 1K 5% 1/10W R559 1-216-835-11 METAL CHIP 15K 5% 1/10W 0R560 1-220-755-11 METAL 0.22 10% 2W F R561 1-216-845-11 METAL CHIP 100K 5% 1/10W R562 1-260-076-11 CARBON 10 5% 1/2W R563 1-216-842-11 METAL CHIP 56K 5% 1/10W 0R564 1-215-890-11 METAL OXIDE 470 5% 2W F R565 1-216-845-11 METAL CHIP 100K 5% 1/10W R601 1-216-833-11 METAL CHIP 10K 5% 1/10W R602 1-216-849-11 METAL CHIP 220K 5% 1/10W R603 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R604 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R605 1-216-829-11 METAL CHIP 4.7K 5% 1/10W 0R606 1-202-972-61 FUSIBLE 1 5% 1/4W F 0R607 1-202-972-61 FUSIBLE 1 5% 1/4W F 0R608 1-212-881-11 FUSIBLE 100 5% 1/4W F R609 1-216-833-11 METAL CHIP 10K 5% 1/10W R610 1-216-839-11 METAL CHIP 33K 5% 1/10W R611 1-216-833-11 METAL CHIP 10K 5% 1/10W R612 1-216-845-11 METAL CHIP 100K 5% 1/10W R613 1-216-833-11 METAL CHIP 10K 5% 1/10W R614 1-216-833-11 METAL CHIP 10K 5% 1/10W 0R615 1-215-890-11 METAL OXIDE 470 5% 2W F R619 1-216-821-11 METAL CHIP 1K 5% 1/10W R620 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R621 1-216-845-11 METAL CHIP 100K 5% 1/10W R622 1-216-837-11 METAL CHIP 22K 5% 1/10W R624 1-216-821-11 METAL CHIP 1K 5% 1/10W R625 1-216-809-11 METAL CHIP 100 5% 1/10W R626 1-216-809-11 METAL CHIP 100 5% 1/10W R628 1-216-853-11 METAL CHIP 470K 5% 1/10W ************************************************************ A-4750-181-A BD BOARD, COMPLETE ******************* < CAPACITOR > C10 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3V C11 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3V C14 1-164-360-11 CERAMIC CHIP 0.1uF 16V C15 1-164-360-11 CERAMIC CHIP 0.1uF 16V C16 1-115-156-11 CERAMIC CHIP 1uF 10V C17 1-126-934-11 ELECT 220uF 20% 16V C18 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C111 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V C112 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C113 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V C114 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C115 1-164-360-11 CERAMIC CHIP 0.1uF 16V C116 1-126-934-11 ELECT 220uF 20% 16V C117 1-164-360-11 CERAMIC CHIP 0.1uF 16V C122 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C123 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C124 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C125 1-164-360-11 CERAMIC CHIP 0.1uF 16V C131 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C132 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V C133 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C141 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C142 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V C143 1-164-360-11 CERAMIC CHIP 0.1uF 16V C151 1-126-934-11 ELECT 220uF 20% 16V C160 1-164-360-11 CERAMIC CHIP 0.1uF 16V C161 1-164-360-11 CERAMIC CHIP 0.1uF 16V C162 1-164-360-11 CERAMIC CHIP 0.1uF 16V C163 1-164-360-11 CERAMIC CHIP 0.1uF 16V C164 1-164-360-11 CERAMIC CHIP 0.1uF 16V C170 1-126-934-11 ELECT 220uF 20% 16V C171 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C172 1-162-920-11 CERAMIC CHIP 27PF 5% 50V C174 1-164-360-11 CERAMIC CHIP 0.1uF 16V C181 1-164-360-11 CERAMIC CHIP 0.1uF 16V C182 1-164-360-11 CERAMIC CHIP 0.1uF 16V C183 1-126-934-11 ELECT 220uF 20% 16V C184 1-126-934-11 ELECT 220uF 20% 16V C185 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C186 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C194 1-164-360-11 CERAMIC CHIP 0.1uF 16V C195 1-164-360-11 CERAMIC CHIP 0.1uF 16V C201 1-126-934-11 ELECT 220uF 20% 16V C202 1-164-360-11 CERAMIC CHIP 0.1uF 16V C203 1-126-934-11 ELECT 220uF 20% 16V C210 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C211 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C212 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C213 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C251 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V C252 1-164-360-11 CERAMIC CHIP 0.1uF 16V C257 1-164-360-11 CERAMIC CHIP 0.1uF 16V C258 1-164-360-11 CERAMIC CHIP 0.1uF 16V C259 1-164-360-11 CERAMIC CHIP 0.1uF 16V < CONNECTOR > CN101 1-793-907-11 CONNECTOR, FFC/FPC 16P CN201 1-568-860-11 SOCKET, CONNECTOR 17P < IC > IC101 8-752-425-11 IC CXD3058AR IC251 6-705-808-01 IC BA5947FM-E2 < JUMPER RESISTOR > JR101 1-216-296-11 SHORT CHIP 0 JR102 1-216-296-11 SHORT CHIP 0 JR103 1-216-296-11 SHORT CHIP 0 JR104 1-216-296-11 SHORT CHIP 0 JR105 1-216-296-11 SHORT CHIP 0 JR106 1-216-296-11 SHORT CHIP 0 JR107 1-216-296-11 SHORT CHIP 0 JR108 1-216-864-11 SHORT CHIP 0 JR109 1-216-296-11 SHORT CHIP 0 JR110 1-216-296-11 SHORT CHIP 0 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 64 HCD-GPX9 BD DAB JR111 1-216-296-11 SHORT CHIP 0 < TRANSISTOR > Q10 6-551-120-01 TRANSISTOR 2SA2119K < RESISTOR/FERRITE BEAD > R10 1-216-791-11 METAL CHIP 3.3 5% 1/10W R11 1-216-864-11 SHORT CHIP 0 R12 1-216-845-11 METAL CHIP 100K 5% 1/10W R13 1-218-446-11 METAL CHIP 1 5% 1/10W R111 1-216-821-11 METAL CHIP 1K 5% 1/10W R112 1-216-835-11 METAL CHIP 15K 5% 1/10W R113 1-216-821-11 METAL CHIP 1K 5% 1/10W R114 1-216-835-11 METAL CHIP 15K 5% 1/10W R121 1-216-835-11 METAL CHIP 15K 5% 1/10W R131 1-216-857-11 METAL CHIP 1M 5% 1/10W R132 1-216-833-11 METAL CHIP 10K 5% 1/10W R133 1-216-848-11 METAL CHIP 180K 5% 1/10W R141 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R142 1-216-821-11 METAL CHIP 1K 5% 1/10W R143 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R151 1-216-864-11 SHORT CHIP 0 R161 1-216-809-11 METAL CHIP 100 5% 1/10W R162 1-216-841-11 METAL CHIP 47K 5% 1/10W R171 1-216-817-11 METAL CHIP 470 5% 1/10W R172 1-216-857-11 METAL CHIP 1M 5% 1/10W R173 1-216-295-00 SHORT CHIP 0 R181 1-216-809-11 METAL CHIP 100 5% 1/10W R182 1-216-809-11 METAL CHIP 100 5% 1/10W R201 1-500-445-21 FERRITE, EMI (SMD) (2012) R202 1-216-864-11 SHORT CHIP 0 R204 1-500-445-21 FERRITE, EMI (SMD) (2012) R251 1-216-833-11 METAL CHIP 10K 5% 1/10W R252 1-216-837-11 METAL CHIP 22K 5% 1/10W R406 1-216-809-11 METAL CHIP 100 5% 1/10W R407 1-216-809-11 METAL CHIP 100 5% 1/10W R408 1-216-809-11 METAL CHIP 100 5% 1/10W R409 1-216-809-11 METAL CHIP 100 5% 1/10W R410 1-216-809-11 METAL CHIP 100 5% 1/10W R411 1-216-809-11 METAL CHIP 100 5% 1/10W R412 1-216-809-11 METAL CHIP 100 5% 1/10W < VIBRATOR > X101 1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz) ************************************************************ A-1105-495-A DAB BOARD, COMPLETE (UK) A-1126-082-A DAB BOARD, COMPLETE (AEP, EE) ******************** < CAPACITOR > C700 1-164-156-11 CERAMIC CHIP 0.1uF 25V C701 1-126-964-11 ELECT 10uF 20% 50V C702 1-124-584-00 ELECT 100uF 20% 10V C703 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C704 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C705 1-164-156-11 CERAMIC CHIP 0.1uF 25V C708 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C711 1-164-156-11 CERAMIC CHIP 0.1uF 25V C712 1-164-156-11 CERAMIC CHIP 0.1uF 25V C713 1-126-933-11 ELECT 100uF 20% 16V C716 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (AEP, EE) C730 1-164-156-11 CERAMIC CHIP 0.1uF 25V C731 1-126-918-11 ELECT 4700uF 20% 6.3V C732 1-126-918-11 ELECT 4700uF 20% 6.3V C734 1-126-963-11 ELECT 4.7uF 20% 50V C735 1-164-156-11 CERAMIC CHIP 0.1uF 25V C736 1-162-306-11 CERAMIC 0.01uF 20% 16V (AEP, EE) C737 1-164-156-11 CERAMIC CHIP 0.1uF 25V C751 1-126-964-11 ELECT 10uF 20% 50V C752 1-164-156-11 CERAMIC CHIP 0.1uF 25V C753 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C754 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C755 1-164-156-11 CERAMIC CHIP 0.1uF 25V C758 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C761 1-164-156-11 CERAMIC CHIP 0.1uF 25V C791 1-126-964-11 ELECT 10uF 20% 50V C792 1-126-964-11 ELECT 10uF 20% 50V C921 1-164-156-11 CERAMIC CHIP 0.1uF 25V C922 1-126-933-11 ELECT 100uF 20% 16V C923 1-164-156-11 CERAMIC CHIP 0.1uF 25V C924 1-126-933-11 ELECT 100uF 20% 16V C939 1-164-156-11 CERAMIC CHIP 0.1uF 25V C940 1-164-156-11 CERAMIC CHIP 0.1uF 25V C945 1-126-768-11 ELECT 2200uF 20% 16V < CONNECTOR > CN700 1-818-488-11 PIN, CONNECTOR (PC BOARD) 44P CN715 1-568-854-11 CONNECTOR, FFC 11P < FERRITE BEAD > FB792 1-469-450-21 INDUCTOR, FERRITE BEAD (3225) FB793 1-469-450-21 INDUCTOR, FERRITE BEAD (3225) < EARTH TERMINAL > * G701 1-537-738-21 TERMINAL, EARTH * G702 1-537-738-21 TERMINAL, EARTH < IC > IC702 8-759-710-97 IC NJM4565M-D IC703 8-759-710-97 IC NJM4565M-D IC907 6-706-468-01 IC BA50BC0WFP-E2 IC911 6-705-756-01 IC BA33BC0WFP-E2 < RESISTOR > R702 1-216-821-11 METAL CHIP 1K 5% 1/10W R703 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R704 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R705 1-216-834-11 METAL CHIP 12K 5% 1/10W R706 1-216-837-11 METAL CHIP 22K 5% 1/10W R708 1-216-821-11 METAL CHIP 1K 5% 1/10W R709 1-216-837-11 METAL CHIP 22K 5% 1/10W R710 1-216-809-11 METAL CHIP 100 5% 1/10W R711 1-216-809-11 METAL CHIP 100 5% 1/10W Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 65 HCD-GPX9 DAB MAIN DRIVER R714 1-216-821-11 METAL CHIP 1K 5% 1/10W R716 1-216-797-11 METAL CHIP 10 5% 1/10W R752 1-216-821-11 METAL CHIP 1K 5% 1/10W R753 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R754 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R755 1-216-834-11 METAL CHIP 12K 5% 1/10W R756 1-216-837-11 METAL CHIP 22K 5% 1/10W R758 1-216-821-11 METAL CHIP 1K 5% 1/10W R759 1-216-837-11 METAL CHIP 22K 5% 1/10W R764 1-216-821-11 METAL CHIP 1K 5% 1/10W R903 1-216-833-11 METAL CHIP 10K 5% 1/10W R904 1-216-833-11 METAL CHIP 10K 5% 1/10W ************************************************************ 1-688-337-11 DRIVER BOARD ************* < CAPACITOR > C705 1-162-306-11 CERAMIC 0.01uF 20% 16V C711 1-126-964-11 ELECT 10uF 20% 50V < CONNECTOR > CN701 1-785-333-11 PIN, CONNECTOR (LIGHT ANGLE) 7P < DIODE > D701 8-719-921-40 DIODE MTZJ-4.7C < IC > IC701 8-759-598-69 IC BA6956AN < RESISTOR > R701 1-249-415-11 CARBON 680 5% 1/4W R702 1-247-807-31 CARBON 100 5% 1/4W < SWITCH > S701 1-762-951-21 SWITCH, PUSH (OUT) S702 1-762-951-21 SWITCH, PUSH (CHUCK) ************************************************************ A-1105-482-A MAIN BOARD, COMPLETE (UK) A-1105-483-A MAIN BOARD, COMPLETE (AEP) A-1105-484-A MAIN BOARD, COMPLETE (EE) ********************* < CAPACITOR > C101 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C102 1-126-964-11 ELECT 10uF 20% 50V C103 1-162-963-11 CERAMIC CHIP 680PF 10% 50V C105 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C106 1-162-946-11 CERAMIC CHIP 27PF 5% 50V C107 1-130-479-00 MYLAR 0.0047uF 5% 50V C109 1-126-964-11 ELECT 10uF 20% 50V C110 1-126-964-11 ELECT 10uF 20% 50V C111 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C112 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C113 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V C114 1-126-160-11 ELECT 1uF 20% 50V C115 1-126-964-11 ELECT 10uF 20% 50V C116 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C117 1-126-964-11 ELECT 10uF 20% 50V C118 1-126-964-11 ELECT 10uF 20% 50V C119 1-126-964-11 ELECT 10uF 20% 50V C122 1-130-474-00 MYLAR 0.0018uF 5% 50V C123 1-130-496-00 MYLAR 0.12uF 5% 50V C124 1-126-967-11 ELECT 47uF 20% 50V C125 1-126-965-11 ELECT 22uF 20% 50V C128 1-126-964-11 ELECT 10uF 20% 50V C131 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C132 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C133 1-130-495-00 MYLAR 0.1uF 5% 50V C134 1-130-495-00 MYLAR 0.1uF 5% 50V C135 1-162-306-11 CERAMIC 0.01uF 20% 16V C136 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C137 1-126-965-11 ELECT 22uF 20% 50V C138 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C141 1-126-964-11 ELECT 10uF 20% 50V C142 1-126-964-11 ELECT 10uF 20% 50V C201 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C202 1-126-964-11 ELECT 10uF 20% 50V C203 1-162-963-11 CERAMIC CHIP 680PF 10% 50V C205 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C206 1-162-946-11 CERAMIC CHIP 27PF 5% 50V C207 1-130-479-00 MYLAR 0.0047uF 5% 50V C209 1-126-964-11 ELECT 10uF 20% 50V C210 1-126-964-11 ELECT 10uF 20% 50V C211 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C212 1-162-961-11 CERAMIC CHIP 330PF 10% 50V C213 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V C214 1-126-160-11 ELECT 1uF 20% 50V C215 1-126-964-11 ELECT 10uF 20% 50V C216 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C217 1-126-964-11 ELECT 10uF 20% 50V C218 1-126-964-11 ELECT 10uF 20% 50V C219 1-126-964-11 ELECT 10uF 20% 50V C221 1-164-156-11 CERAMIC CHIP 0.1uF 25V C222 1-130-474-00 MYLAR 0.0018uF 5% 50V C223 1-130-496-00 MYLAR 0.12uF 5% 50V C224 1-126-967-11 ELECT 47uF 20% 50V C225 1-126-965-11 ELECT 22uF 20% 50V C228 1-126-964-11 ELECT 10uF 20% 50V C231 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C232 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C233 1-130-495-00 MYLAR 0.1uF 5% 50V C234 1-130-495-00 MYLAR 0.1uF 5% 50V C235 1-162-306-11 CERAMIC 0.01uF 20% 16V C236 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C237 1-126-965-11 ELECT 22uF 20% 50V C238 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C241 1-126-964-11 ELECT 10uF 20% 50V C242 1-126-964-11 ELECT 10uF 20% 50V C302 1-137-150-11 FILM 0.01uF 5% 100V C303 1-124-257-00 ELECT 2.2uF 20% 50V C304 1-126-964-11 ELECT 10uF 20% 50V C305 1-126-947-11 ELECT 47uF 20% 35V C306 1-126-964-11 ELECT 10uF 20% 50V Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 66 HCD-GPX9 MAIN C307 1-130-485-00 MYLAR 0.015uF 5% 50V C308 1-130-481-00 MYLAR 0.0068uF 5% 50V C309 1-130-481-00 MYLAR 0.0068uF 5% 50V C310 1-130-486-00 MYLAR 0.018uF 5% 50V C314 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C317 1-126-965-11 ELECT 22uF 20% 50V C318 1-126-935-11 ELECT 470uF 20% 16V C319 1-126-935-11 ELECT 470uF 20% 16V C320 1-126-934-11 ELECT 220uF 20% 16V C321 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C322 1-126-934-11 ELECT 220uF 20% 16V C325 1-126-935-11 ELECT 470uF 20% 16V C326 1-130-483-00 MYLAR 0.01uF 5% 50V C327 1-130-483-00 MYLAR 0.01uF 5% 50V C328 1-126-927-11 ELECT 2200uF 20% 10V C329 1-126-964-11 ELECT 10uF 20% 50V C330 1-126-935-11 ELECT 470uF 20% 16V C331 1-126-935-11 ELECT 470uF 20% 16V C333 1-126-964-11 ELECT 10uF 20% 50V C334 1-164-156-11 CERAMIC CHIP 0.1uF 25V C335 1-164-156-11 CERAMIC CHIP 0.1uF 25V C336 1-115-456-21 DOUBLE LAYER 0.22F 5.5V C337 1-127-888-21 CERAMIC 0.1uF 10% 50V C338 1-162-945-11 CERAMIC CHIP 22PF 5% 50V C339 1-162-946-11 CERAMIC CHIP 27PF 5% 50V C340 1-164-156-11 CERAMIC CHIP 0.1uF 25V C341 1-104-665-11 ELECT 100uF 20% 25V C342 1-164-156-11 CERAMIC CHIP 0.1uF 25V C343 1-126-927-11 ELECT 2200uF 20% 10V C354 1-128-809-11 CERAMIC 100PF 5% 50V C362 1-164-156-11 CERAMIC CHIP 0.1uF 25V C367 1-126-926-11 ELECT 1000uF 20% 10V C368 1-164-156-11 CERAMIC CHIP 0.1uF 25V C371 1-164-156-11 CERAMIC CHIP 0.1uF 25V C372 1-164-156-11 CERAMIC CHIP 0.1uF 25V C373 1-126-947-11 ELECT 47uF 20% 35V C393 1-164-156-11 CERAMIC CHIP 0.1uF 25V C394 1-127-888-21 CERAMIC 0.1uF 10% 50V C395 1-104-656-11 ELECT 2200uF 20% 6.3V C396 1-164-156-11 CERAMIC CHIP 0.1uF 25V C397 1-164-156-11 CERAMIC CHIP 0.1uF 25V < CONNECTOR > * CN301 1-564-511-11 PLUG, CONNECTOR 8P CN302 1-770-516-31 FFC/CONNECTOR, FPC (LIF (NON-ZIF)) 8P CN304 1-784-739-11 CONNECTOR, FFC 17P CN305 1-784-776-11 CONNECTOR, FFC 15P CN306 1-568-828-11 CONNECTOR, FFC 9P CN310 1-568-838-11 CONNECTOR, FFC 21P CN315 1-568-830-11 CONNECTOR, FFC 11P < DIODE > D301 8-719-991-33 DIODE 1SS133T-77 D302 8-719-991-33 DIODE 1SS133T-77 D303 8-719-991-33 DIODE 1SS133T-77 D304 8-719-991-33 DIODE 1SS133T-77 D305 8-719-991-33 DIODE 1SS133T-77 D306 8-719-991-33 DIODE 1SS133T-77 D307 8-719-991-33 DIODE 1SS133T-77 D308 8-719-991-33 DIODE 1SS133T-77 D309 8-719-991-33 DIODE 1SS133T-77 D311 6-500-522-01 DIODE 10EDB40-TA1B2 D312 6-500-522-01 DIODE 10EDB40-TA1B2 D314 8-719-991-33 DIODE 1SS133T-77 D316 8-719-991-33 DIODE 1SS133T-77 D317 8-719-991-33 DIODE 1SS133T-77 D318 8-719-991-33 DIODE 1SS133T-77 D319 8-719-991-33 DIODE 1SS133T-77 D320 8-719-991-33 DIODE 1SS133T-77 D321 8-719-991-33 DIODE 1SS133T-77 D325 8-719-991-33 DIODE 1SS133T-77 D326 8-719-991-33 DIODE 1SS133T-77 D327 8-719-991-33 DIODE 1SS133T-77 D329 8-719-988-61 DIODE 1SS355TE-17 D330 8-719-988-61 DIODE 1SS355TE-17 D331 6-500-522-01 DIODE 10EDB40-TA1B2 D332 8-719-991-33 DIODE 1SS133T-77 D333 8-719-991-33 DIODE 1SS133T-77 D334 8-719-991-33 DIODE 1SS133T-77 D335 8-719-991-33 DIODE 1SS133T-77 D366 8-719-109-72 DIODE RD3.9ESB2 < FERRITE BEAD/JUMPER RESISTOR > FB301 1-412-473-21 INDUCTOR (SMALL TYPE) FB302 1-216-864-11 SHORT CHIP 0 FB305 1-216-864-11 SHORT CHIP 0 FB306 1-216-864-11 SHORT CHIP 0 FB307 1-500-445-21 FERRITE, EMI (SMD) (2012) FB308 1-500-445-21 FERRITE, EMI (SMD) (2012) FB309 1-500-445-21 FERRITE, EMI (SMD) (2012) < IC > IC201 8-759-300-71 IC HD14053BFP IC301 8-759-508-69 IC BA3126N IC302 6-705-622-01 IC BD3402KS2 IC304 8-759-701-59 IC NJM78M09FA IC305 6-801-402-01 IC BD4729GTR IC306 6-805-338-01 IC M30622MEP-A27FPU0 < JACK > J301 1-764-593-21 JACK 2P (AUDIO IN) < JUMPER RESISTOR > JR200 1-216-864-11 SHORT CHIP 0 JR233 1-216-864-11 SHORT CHIP 0 JR234 1-216-864-11 SHORT CHIP 0 JR235 1-216-864-11 SHORT CHIP 0 < COIL > L102 1-422-009-13 COIL, AIR-CORE L202 1-422-009-13 COIL, AIR-CORE L302 1-414-857-11 INDUCTOR 100uH Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 67 HCD-GPX9 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. MAIN < TRANSISTOR > Q102 8-729-107-43 TRANSISTOR 2SC3624-L18 Q201 8-729-036-58 TRANSISTOR KRC102M-AT Q202 8-729-107-43 TRANSISTOR 2SC3624-L18 Q301 8-729-037-16 TRANSISTOR KRA103M-AT Q302 8-729-036-58 TRANSISTOR KRC102M-AT Q303 8-729-142-46 TRANSISTOR 2SC2001-LK Q304 8-729-142-46 TRANSISTOR 2SC2001-LK Q305 8-729-801-93 TRANSISTOR 2SD1387-3 Q306 8-729-037-03 TRANSISTOR KTA1266GR-AT Q307 8-729-036-58 TRANSISTOR KRC102M-AT Q308 8-729-037-13 TRANSISTOR KTA1271Y Q309 8-729-054-16 TRANSISTOR KRC402-RTK Q310 8-729-037-13 TRANSISTOR KTA1271Y Q311 8-729-054-16 TRANSISTOR KRC402-RTK Q312 8-729-040-76 TRANSISTOR KTA1273-Y-AT Q313 8-729-038-67 TRANSISTOR KRC102S Q314 8-729-016-42 TRANSISTOR KTC3199GR-TP Q317 8-729-038-54 TRANSISTOR KRA102S Q318 8-729-038-67 TRANSISTOR KRC102S Q319 8-729-040-76 TRANSISTOR KTA1273-Y-AT Q320 8-729-038-67 TRANSISTOR KRC102S Q321 8-729-036-58 TRANSISTOR KRC102M-AT Q322 8-729-037-13 TRANSISTOR KTA1271Y Q323 8-729-038-67 TRANSISTOR KRC102S < RESISTOR > R101 1-216-821-11 METAL CHIP 1K 5% 1/10W R102 1-216-841-11 METAL CHIP 47K 5% 1/10W R103 1-216-830-11 METAL CHIP 5.6K 5% 1/10W R104 1-216-833-11 METAL CHIP 10K 5% 1/10W R105 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R106 1-216-841-11 METAL CHIP 47K 5% 1/10W R107 1-216-845-11 METAL CHIP 100K 5% 1/10W R108 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R109 1-216-851-11 METAL CHIP 330K 5% 1/10W R110 1-216-853-11 METAL CHIP 470K 5% 1/10W R111 1-216-812-11 METAL CHIP 180 5% 1/10W R112 1-216-830-11 METAL CHIP 5.6K 5% 1/10W R113 1-216-847-11 METAL CHIP 150K 5% 1/10W R114 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R118 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R119 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R122 1-260-076-11 CARBON 10 5% 1/2W R123 1-216-821-11 METAL CHIP 1K 5% 1/10W R124 1-216-845-11 METAL CHIP 100K 5% 1/10W R126 1-249-429-11 CARBON 10K 5% 1/4W R127 1-216-821-11 METAL CHIP 1K 5% 1/10W R128 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R130 1-216-845-11 METAL CHIP 100K 5% 1/10W R131 1-216-845-11 METAL CHIP 100K 5% 1/10W R132 1-216-837-11 METAL CHIP 22K 5% 1/10W R133 1-216-837-11 METAL CHIP 22K 5% 1/10W R201 1-216-821-11 METAL CHIP 1K 5% 1/10W R202 1-216-841-11 METAL CHIP 47K 5% 1/10W R203 1-216-830-11 METAL CHIP 5.6K 5% 1/10W R204 1-216-833-11 METAL CHIP 10K 5% 1/10W R205 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R206 1-216-841-11 METAL CHIP 47K 5% 1/10W R207 1-216-845-11 METAL CHIP 100K 5% 1/10W R208 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R209 1-216-851-11 METAL CHIP 330K 5% 1/10W R210 1-216-853-11 METAL CHIP 470K 5% 1/10W R211 1-216-812-11 METAL CHIP 180 5% 1/10W R212 1-216-830-11 METAL CHIP 5.6K 5% 1/10W R213 1-216-847-11 METAL CHIP 150K 5% 1/10W R214 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R217 1-216-833-11 METAL CHIP 10K 5% 1/10W R218 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R219 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R222 1-260-076-11 CARBON 10 5% 1/2W R223 1-216-821-11 METAL CHIP 1K 5% 1/10W R224 1-216-845-11 METAL CHIP 100K 5% 1/10W R226 1-249-429-11 CARBON 10K 5% 1/4W R227 1-216-821-11 METAL CHIP 1K 5% 1/10W R228 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R230 1-216-845-11 METAL CHIP 100K 5% 1/10W R231 1-216-845-11 METAL CHIP 100K 5% 1/10W R232 1-216-837-11 METAL CHIP 22K 5% 1/10W R233 1-216-837-11 METAL CHIP 22K 5% 1/10W R301 1-216-829-11 METAL CHIP 4.7K 5% 1/10W 0R302 1-212-851-00 FUSIBLE 5.6 5% 1/4W F 0R303 1-212-851-00 FUSIBLE 5.6 5% 1/4W F R304 1-216-836-11 METAL CHIP 18K 5% 1/10W R305 1-216-836-11 METAL CHIP 18K 5% 1/10W R306 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R307 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W R308 1-216-837-11 METAL CHIP 22K 5% 1/10W R309 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R310 1-216-833-11 METAL CHIP 10K 5% 1/10W R311 1-216-841-11 METAL CHIP 47K 5% 1/10W R312 1-216-821-11 METAL CHIP 1K 5% 1/10W R314 1-216-841-11 METAL CHIP 47K 5% 1/10W R315 1-216-821-11 METAL CHIP 1K 5% 1/10W R318 1-249-429-11 CARBON 10K 5% 1/4W R319 1-216-837-11 METAL CHIP 22K 5% 1/10W R320 1-216-841-11 METAL CHIP 47K 5% 1/10W R321 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R322 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R323 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R324 1-216-833-11 METAL CHIP 10K 5% 1/10W R325 1-249-429-11 CARBON 10K 5% 1/4W R326 1-216-845-11 METAL CHIP 100K 5% 1/10W R330 1-216-813-11 METAL CHIP 220 5% 1/10W R331 1-216-833-11 METAL CHIP 10K 5% 1/10W R332 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R333 1-216-837-11 METAL CHIP 22K 5% 1/10W R334 1-216-841-11 METAL CHIP 47K 5% 1/10W R335 1-249-429-11 CARBON 10K 5% 1/4W R336 1-216-809-11 METAL CHIP 100 5% 1/10W R337 1-216-809-11 METAL CHIP 100 5% 1/10W R339 1-216-841-11 METAL CHIP 47K 5% 1/10W R340 1-216-841-11 METAL CHIP 47K 5% 1/10W R341 1-216-841-11 METAL CHIP 47K 5% 1/10W R342 1-216-841-11 METAL CHIP 47K 5% 1/10W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 68 HCD-GPX9 MAIN PANEL (1) R350 1-249-425-11 CARBON 4.7K 5% 1/4W R358 1-216-841-11 METAL CHIP 47K 5% 1/10W R359 1-216-841-11 METAL CHIP 47K 5% 1/10W R360 1-216-841-11 METAL CHIP 47K 5% 1/10W R361 1-249-429-11 CARBON 10K 5% 1/4W R362 1-249-429-11 CARBON 10K 5% 1/4W R363 1-216-833-11 METAL CHIP 10K 5% 1/10W R367 1-216-864-11 SHORT CHIP 0 R368 1-247-843-11 CARBON 3.3K 5% 1/4W R369 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R370 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R372 1-249-437-11 CARBON 47K 5% 1/4W R373 1-249-437-11 CARBON 47K 5% 1/4W R374 1-216-841-11 METAL CHIP 47K 5% 1/10W R375 1-216-821-11 METAL CHIP 1K 5% 1/10W R379 1-216-833-11 METAL CHIP 10K 5% 1/10W R381 1-216-841-11 METAL CHIP 47K 5% 1/10W R382 1-216-821-11 METAL CHIP 1K 5% 1/10W R393 1-216-841-11 METAL CHIP 47K 5% 1/10W R394 1-216-821-11 METAL CHIP 1K 5% 1/10W R395 1-216-821-11 METAL CHIP 1K 5% 1/10W R396 1-216-839-11 METAL CHIP 33K 5% 1/10W R404 1-216-833-11 METAL CHIP 10K 5% 1/10W R405 1-216-809-11 METAL CHIP 100 5% 1/10W R406 1-216-809-11 METAL CHIP 100 5% 1/10W R409 1-216-833-11 METAL CHIP 10K 5% 1/10W R411 1-216-821-11 METAL CHIP 1K 5% 1/10W R412 1-216-821-11 METAL CHIP 1K 5% 1/10W R413 1-216-864-11 SHORT CHIP 0 R417 1-216-833-11 METAL CHIP 10K 5% 1/10W R418 1-247-807-31 CARBON 100 5% 1/4W R419 1-247-807-31 CARBON 100 5% 1/4W R420 1-216-841-11 METAL CHIP 47K 5% 1/10W R422 1-216-809-11 METAL CHIP 100 5% 1/10W R423 1-216-809-11 METAL CHIP 100 5% 1/10W R424 1-216-809-11 METAL CHIP 100 5% 1/10W R429 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R430 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R431 1-216-809-11 METAL CHIP 100 5% 1/10W R432 1-216-809-11 METAL CHIP 100 5% 1/10W R434 1-216-809-11 METAL CHIP 100 5% 1/10W R438 1-216-809-11 METAL CHIP 100 5% 1/10W R440 1-216-809-11 METAL CHIP 100 5% 1/10W R441 1-216-809-11 METAL CHIP 100 5% 1/10W R442 1-216-809-11 METAL CHIP 100 5% 1/10W R443 1-216-809-11 METAL CHIP 100 5% 1/10W R447 1-216-809-11 METAL CHIP 100 5% 1/10W R448 1-216-809-11 METAL CHIP 100 5% 1/10W R450 1-216-841-11 METAL CHIP 47K 5% 1/10W R455 1-216-809-11 METAL CHIP 100 5% 1/10W R458 1-216-809-11 METAL CHIP 100 5% 1/10W R459 1-216-809-11 METAL CHIP 100 5% 1/10W R460 1-216-809-11 METAL CHIP 100 5% 1/10W R461 1-216-809-11 METAL CHIP 100 5% 1/10W R463 1-216-809-11 METAL CHIP 100 5% 1/10W R465 1-216-809-11 METAL CHIP 100 5% 1/10W R468 1-216-809-11 METAL CHIP 100 5% 1/10W R469 1-216-809-11 METAL CHIP 100 5% 1/10W R472 1-216-809-11 METAL CHIP 100 5% 1/10W R474 1-216-857-11 METAL CHIP 1M 5% 1/10W R475 1-216-809-11 METAL CHIP 100 5% 1/10W R484 1-216-809-11 METAL CHIP 100 5% 1/10W R489 1-216-864-11 SHORT CHIP 0 R490 1-216-864-11 SHORT CHIP 0 R491 1-216-864-11 SHORT CHIP 0 R494 1-247-807-31 CARBON 100 5% 1/4W R495 1-247-807-31 CARBON 100 5% 1/4W < VARIABLE RESISTOR > RV101 1-241-768-11 RES, ADJ CERMET 220K RV201 1-241-768-11 RES, ADJ CERMET 220K < RELAY > RY301 1-515-920-11 RELAY (24V) < TRANSFORMER > T101 1-419-080-21 COIL T201 1-419-080-21 COIL T301 1-423-980-11 TRANSFORMER, BIAS OSCILLATION < TERMINAL > TM301 1-536-708-81 TERMINAL BOARD, PUSH (4P) (SPEAKER IMPEDANCE USE 6-16Ω) < VIBRATOR > X301 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz) X302 1-795-482-11 VIBRATOR, CERAMIC (16MHz) ************************************************************ A-1105-497-A PANEL (1) BOARD, COMPLETE ************************* 4-249-151-01 HOLDER, FL TUBE 4-249-984-01 FILTER (FL TUBE) < CAPACITOR > C804 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C805 1-126-964-11 ELECT 10uF 20% 50V C806 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C807 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C808 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C809 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C810 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C811 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C820 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C821 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C822 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C823 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C824 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C825 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C826 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C827 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C828 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C829 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C830 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C831 1-162-960-11 CERAMIC CHIP 220PF 10% 50V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 69 HCD-GPX9 C832 1-126-964-11 ELECT 10uF 20% 50V C833 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C834 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V C835 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C836 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V C837 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C838 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C839 1-162-974-11 CERAMIC CHIP 0.01uF 50V C840 1-126-382-11 ELECT 100uF 20% 16V C841 1-126-796-11 ELECT 22uF 20% 50V C842 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V < CONNECTOR > CN801 1-568-838-11 CONNECTOR, FFC 21P < DIODE > D802 8-719-063-91 LED SLR325DC-P-T32 (BAND, TUNER) D803 8-719-063-91 LED SLR325DC-P-T32 (n N TAPE) D804 8-719-063-93 LED SLR325VC-N-T32 (I/1) D805 8-719-982-26 DIODE MTZJ-33B D806 8-719-109-85 DIODE RD5.1ESB2 D810 6-500-522-01 DIODE 10EDB40-TA1B2 < FLUORESCENT INDICATOR > FL701 1-519-816-11 INDICATOR TUBE, FLUORESCENT < IC > IC801 8-759-643-83 IC uPD16315GB-3BS IC802 6-600-446-01 IC RPM7240-H18 < TRANSISTOR > Q801 8-729-038-67 TRANSISTOR KRC102S Q802 8-729-038-67 TRANSISTOR KRC102S Q803 8-729-038-67 TRANSISTOR KRC102S Q804 8-729-038-67 TRANSISTOR KRC102S Q805 8-729-037-03 TRANSISTOR KTA1266GR-AT Q806 8-729-037-03 TRANSISTOR KTA1266GR-AT Q807 8-729-037-03 TRANSISTOR KTA1266GR-AT Q808 8-729-037-03 TRANSISTOR KTA1266GR-AT < RESISTOR > R801 1-216-813-11 METAL CHIP 220 5% 1/10W R802 1-216-815-11 METAL CHIP 330 5% 1/10W R803 1-216-817-11 METAL CHIP 470 5% 1/10W R804 1-216-819-11 METAL CHIP 680 5% 1/10W R805 1-216-821-11 METAL CHIP 1K 5% 1/10W R806 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R807 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R811 1-216-813-11 METAL CHIP 220 5% 1/10W R812 1-216-815-11 METAL CHIP 330 5% 1/10W R813 1-216-817-11 METAL CHIP 470 5% 1/10W R814 1-216-819-11 METAL CHIP 680 5% 1/10W R815 1-216-821-11 METAL CHIP 1K 5% 1/10W R816 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R817 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R818 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R819 1-216-833-11 METAL CHIP 10K 5% 1/10W R830 1-216-806-11 METAL CHIP 56 5% 1/10W R831 1-216-811-11 METAL CHIP 150 5% 1/10W R832 1-216-809-11 METAL CHIP 100 5% 1/10W R835 1-216-809-11 METAL CHIP 100 5% 1/10W R841 1-216-809-11 METAL CHIP 100 5% 1/10W R842 1-216-811-11 METAL CHIP 150 5% 1/10W R845 1-216-864-11 SHORT CHIP 0 R846 1-216-845-11 METAL CHIP 100K 5% 1/10W R847 1-216-845-11 METAL CHIP 100K 5% 1/10W R848 1-216-844-11 METAL CHIP 82K 5% 1/10W R849 1-216-809-11 METAL CHIP 100 5% 1/10W R850 1-216-809-11 METAL CHIP 100 5% 1/10W R851 1-216-809-11 METAL CHIP 100 5% 1/10W R856 1-249-393-11 CARBON 10 5% 1/4W R861 1-216-864-11 SHORT CHIP 0 R862 1-216-864-11 SHORT CHIP 0 < SWITCH > S701 1-762-875-21 SWITCH, KEYBOARD (I/1) S702 1-762-875-21 SWITCH, KEYBOARD (m (TAPE)) S703 1-762-875-21 SWITCH, KEYBOARD (M (TAPE)) S704 1-762-875-21 SWITCH, KEYBOARD (n N TAPE) S705 1-762-875-21 SWITCH, KEYBOARD (x (TAPE)) S706 1-762-875-21 SWITCH, KEYBOARD (z REC, PAUSE/START) S707 1-762-875-21 SWITCH, KEYBOARD (CD SYNCHRO) S708 1-762-875-21 SWITCH, KEYBOARD (DIRECTION) S709 1-762-875-21 SWITCH, KEYBOARD (DISPLAY) S710 1-762-875-21 SWITCH, KEYBOARD (FUNCTION) S711 1-762-875-21 SWITCH, KEYBOARD (FM MODE) S712 1-762-875-21 SWITCH, KEYBOARD (TUNING MODE) S713 1-762-875-21 SWITCH, KEYBOARD (TUNING −) S714 1-762-875-21 SWITCH, KEYBOARD (TUNING +) S715 1-762-875-21 SWITCH, KEYBOARD (BAND, TUNER) S716 1-762-875-21 SWITCH, KEYBOARD (DAB) S717 1-762-875-21 SWITCH, KEYBOARD (DSGX) S801 1-418-859-21 ENCODER, ROTARY (BASS) S802 1-418-859-21 ENCODER, ROTARY (TREBLE) S803 1-476-730-11 ENCODER, ROTARY (VOLUME) ************************************************************ A-4750-229-A PANEL (2) BOARD, COMPLETE ************************* < CAPACITOR > C136 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V C236 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V < DIODE > D801 8-719-063-91 LED SLR325DC-P-T32 (u CD) < JUMPER RESISTOR > FB121 1-216-864-11 SHORT CHIP 0 FB221 1-216-864-11 SHORT CHIP 0 < JACK > J321 1-764-106-21 JACK (PHONES) PANEL (2) PANEL (1) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 70 HCD-GPX9 < RESISTOR > R821 1-216-813-11 METAL CHIP 220 5% 1/10W R822 1-216-815-11 METAL CHIP 330 5% 1/10W R823 1-216-817-11 METAL CHIP 470 5% 1/10W R824 1-216-819-11 METAL CHIP 680 5% 1/10W R825 1-216-821-11 METAL CHIP 1K 5% 1/10W R826 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R827 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R828 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R852 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R853 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R854 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R855 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R857 1-216-845-11 METAL CHIP 100K 5% 1/10W R858 1-216-833-11 METAL CHIP 10K 5% 1/10W R859 1-216-809-11 METAL CHIP 100 5% 1/10W R860 1-216-809-11 METAL CHIP 100 5% 1/10W < SWITCH > S718 1-762-875-21 SWITCH, KEYBOARD (PLAY MODE) S719 1-762-875-21 SWITCH, KEYBOARD (REPEAT) S720 1-762-875-21 SWITCH, KEYBOARD (L) S721 1-762-875-21 SWITCH, KEYBOARD (l) S722 1-762-875-21 SWITCH, KEYBOARD (m) S723 1-762-875-21 SWITCH, KEYBOARD (M) S724 1-762-875-21 SWITCH, KEYBOARD (u CD) S725 1-762-875-21 SWITCH, KEYBOARD (x (CD)) S726 1-762-875-21 SWITCH, KEYBOARD (A) ************************************************************ A-1113-708-A POWER BOARD, COMPLETE *********************** 1-533-233-31 FUSE HOLDER 3-701-748-00 CLAMP 4-812-134-31 RIVET (DIA. 3.5), NYLON 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > C901 1-126-935-11 ELECT 470uF 20% 16V C902 1-126-944-11 ELECT 3300uF 20% 25V C903 1-126-935-11 ELECT 470uF 20% 16V C904 1-126-935-11 ELECT 470uF 20% 16V C905 1-126-944-11 ELECT 3300uF 20% 25V C907 1-130-495-00 MYLAR 0.1uF 5% 50V C909 1-130-495-00 MYLAR 0.1uF 5% 50V C912 1-126-969-11 ELECT 220uF 20% 50V C913 1-130-495-00 MYLAR 0.1uF 5% 50V C914 1-130-495-00 MYLAR 0.1uF 5% 50V C915 1-126-964-11 ELECT 10uF 20% 50V < CONNECTOR > * CN901 1-564-527-11 PLUG, CONNECTOR 12P CN903 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P < DIODE > D901 8-719-500-56 DIODE D3SBA20 D902 8-719-063-79 DIODE 1N4002B D903 8-719-063-79 DIODE 1N4002B D904 8-719-063-79 DIODE 1N4002B D905 8-719-063-79 DIODE 1N4002B D906 8-719-063-79 DIODE 1N4002B D907 8-719-063-79 DIODE 1N4002B D908 8-719-063-79 DIODE 1N4002B D909 8-719-063-79 DIODE 1N4002B D910 6-500-522-01 DIODE 10EDB40-TA1B2 D911 8-719-991-33 DIODE 1SS133T-77 D912 8-719-991-33 DIODE 1SS133T-77 D913 8-719-991-33 DIODE 1SS133T-77 < IC > IC901 8-759-231-57 IC TA7810S IC902 8-759-071-48 IC TA7807S IC903 6-701-760-01 IC uPC3504AHF < RESISTOR > R901 1-249-417-11 CARBON 1K 5% 1/4W R902 1-249-417-11 CARBON 1K 5% 1/4W 0R903 1-219-121-11 FUSIBLE 0.22 5% 1/4W F 0R904 1-219-121-11 FUSIBLE 0.22 5% 1/4W F 0R905 1-212-946-11 FUSIBLE 3.3 5% 1/2W F R909 1-249-421-11 CARBON 2.2K 5% 1/4W < RELAY > 0RY901 1-755-324-11 RELAY ************************************************************ MISCELLANEOUS ************** 108 1-796-351-41 MECHANISM, SIGNAL CASSETTE (CML1Z234A) 154 1-478-669-11 MODULE (DAB TUNER) (UK) 154 1-479-310-11 MODULE (DAB TUNER) (AEP, EE) 156 1-830-386-12 CORD (WITH CONNECTOR) (UK) 156 1-830-493-11 CORD (WITH CONNECTOR) (AEP, EE) 158 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P 204 1-500-386-11 FILTER, CLAMP (FERRITE CORE) 0206 1-751-520-31 CORD, POWER (UK) 0206 1-830-188-11 CORD, POWER (AEP, EE) 208 1-468-738-11 REGULATOR, SWITCHING 209 1-693-626-11 TUNER (FM/AM) 462 1-452-925-21 MAGNET ASSY 0657 A-4735-357-A BASE ASSY, OP (KSM-213DCP) 658 1-827-991-11 WIRE (FLAT TYPE) (16 CORE) 0F901 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15A/250V) 0F902 1-533-470-12 FUSE, GLASS TUBE (DIA. 5) (T3.15A/250V) M701 X-4955-496-1 MOTOR (PULLEY) ASSY (LOADING) S101 1-771-853-11 SWITCH, DETECTION (LIMIT) 0T901 1-443-198-11 TRANSFORMER, POWER POWER PANEL (2) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ver. 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 71 HCD-GPX9 MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 HCD-GPX9 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2005.03 New 1.1 2005.05 Addition of East European model Change of parts on the DAB board and MAIN board www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com