— 1 — SERVICE MANUAL COMPACT DISC DECK RECEIVER HCD-G101 is the tuner, deck, CD and amplifier section in MHC-G101. Model Name Using Similar Mechanism NEW CD Mechanism Type CX3 Base Unit Type KSM-213BCM Optical Pick-up Type KSS-213B/S-N Model Name Using Similar Mechanism HCD-H100 TK20FX-SW943-800 TK20FX-SW943-800 CD SECTION US Model Canadian Model HCD-G101 DECK-A DECK-B SPECIFICATIONS TAPE DECK SECTION Tape Transport Mechanism Type Ver 1.1 2002.03 With CORRECTION-1 (9-960-869-91) 9-960-869-12 2002C0200-1 © 2002.03 Sony Corporation Home Audio Company Pubulished by Sony Engineering Corporation www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 2 — CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous ra- diation exposure. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PROD- UCT MARKING is located on the rear exterior. This caution label is located inside the unit. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY. SAFETY-RELATED COMPONENT WARNING !! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. SERVICING NOTE NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick- up block. Therefore, when checking the laser diode emission, ob- serve from more than 30 cm away from the objective lens. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 3 — TABLE OF CONTENTS 1. GENERAL .......................................................................... 4 2. DISASSEMBLY 2-1. CD Door ............................................................................... 5 2-2. CD Mechanism Deck ............................................................ 5 2-3. Front Panel and Main Board ................................................. 6 2-4. Main Board and H/P Board................................................... 6 2-5. CD Tray ............................................................................... 7 2-6. CD Decoder Board................................................................ 7 2-7. Base Unit ............................................................................. 8 3. MECHANICAL ADJUSTMENTS ................................ 9 4. ELECTRICAL ADJUSTMENTS ................................. 9 5. DIAGRAMS 5-1. Circuit Boards Location ...................................................... 14 5-2. Brock Diagrams • Tuner Section ................................................................... 15 • CD Section ....................................................................... 17 • Deck Section .................................................................... 19 • Main Section .................................................................... 21 • Power Section .................................................................. 23 5-3. IC Brock Diagrams ............................................................. 25 5-4. Printed Wiring Board —Main Section —........................... 30 5-5. Schematic Diagram — Main Section — ............................ 35 5-6. Schematic Diagram —Panel Section — ............................. 39 5-7. Printed Wiring Board —Panel Section — .......................... 43 5-8. Printed Wiring Board — CD Section —............................. 47 5-9. Schematic Diagram —CD Section — ................................ 51 5-10. IC Pin Function ................................................................ 54 6. EXPLODED VIEWS 6-1. Top and Bottom Cabinet Section ........................................ 56 6-2. Front Panel Section ............................................................. 57 6-3. Cassette Mechanism Deck Section 1 .................................. 58 6-4. Cassette Mechanism Deck Section 2 .................................. 59 6-5. CD Mechanism Deck Section 1 .......................................... 60 6-6. CD Mechanism Deck Section 2 .......................................... 61 6-7. Base Unit Section (KSM-213BCM) ................................... 62 7. ELECTRICAL PARTS LIST ........................................ 63 To Exposed Metal Parts on Set 0.15µF 1.5kΩ AC voltmeter (0.75V) Earth Ground SAFETY CHECK-OUT After correcting the original service problem, perform the follow- ing safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE The AC leakage from any exposed metal part to earth Ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leak- age current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a pas- sive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) Fig. A. Using an AC voltmeter to check AC leakage. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 4 — SECTION 1 GENERAL Location of Parts and Controls 6 5 4 2 1 @º p(stop) button @¡ CD button @™ TAPE button @£ TUNER/BAND button @¢ PRESET – button @∞ PRESET + button @§ MEMORY button @¶ – TUNING +/≠ 0/ ) ± buttons @• PRESET EQ button @ª Deck B #º Tape operating buttons r (recording) (for deck A only) · (play) 0 (fast rewind) ) (fast forward) p6 (stop/eject) P (pause) #¡ Deck A 1 Disc tray 2 DISC 1 button 3 DISC 2 button 4 DISC 3 button 5 DISC SKIP button 6 § OPEN/CLOSE button 7 DBFB button 8 VOLUME knob 9 Display window !º TIMER SET, CLOCK LIGHT button !¡ TIMER MODE button !™ Remote sensor !£ CLOCK SET button !¢ POWER button !∞ PHONES jack !§ P (play/pause) button !¶ SHUFFLE button !• PROGRAM button !ª REPEAT button ¢ 3 !™ !£ !¡ !¢ !º 9 8 7 !∞ !§ !¶ !• !ª@º@¡ @™ @• @§ @∞ @¢ @£ @¶ @ª #º #¡ www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 5 — SECTION 2 DISASSEMBLY Note: Follow the disassembly procedure in the numerical order given. 2-1. CD DOOR 2-2. CD MECHANISM DECK CD door 1 Two screws (B3x8) 2 Screw (BVTP3x10) 3 Screw (BVTP3x10) 4 Two screws (BVTP3x10) 5 Flat type wire (21 core) (CN09) 6 Harness (Main board: CN302) 7 CD mechanism deck 1 Pull out the CD tray and remove the CD door with releasing claws into the direction of arrow. craws www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 6 — 2-3. FRONT PANEL AND MAIN BOARD 2-4. MAIN BOARD AND H/P BOARD 1 Harness (CN204) 2 Connector (CN203) 3 Connector (CN206) 4 Connector (CN201) 5 Screw (BVTP3x8) 6 Screw (BVTT3x6) 7 Screw (BVTT3x6) 8 Screw (PTPWH3x10) 9 Main board 0 H/P board 2 Connector (CN401) 6 Screw (BVTP3x10) 4 Two screws (BVTP3x10) 5 Two screws (BVTP3x10) 3 Screw (BVTP3x8) 7 Screw (BVTP3x10) 9 Front panel and Main board 1 Three screws (BVTP3x10) 8 Screw (BVTP3x10) POWER CORD HOW TO SET THE POWER CORD www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 7 — 2-5. CD TRAY 1 Screw (BVTP3x10) 2 Bracket 3 Screw (BVTP3x10) 4 Bracket 5 CD tray 2-6. CD DECODER BOARD 1 Two screws (BVTP3x6) 2 Two screws (BVTP3x10) 3 Two claws 4 Flat type wire (CN06) 5 Connector (CN05) 6 Flat type wire (CN01) 7 CD decoder board www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 8 — 2-7. BASE UNIT 1 Screw (PTPWH2.6x8) 2 UD-cam 4 Base unit Note: When installing, set to the groove of UD-cam. 3 Two screws www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 9 — Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagne- tizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power sup- ply voltage unless otherwise noted. Torque Measurement SECTION 3 MECHANICAL ADJUSTMENTS SECTION 4 ELECTRICAL ADJUSTMENTS DECK SECTION 0 dB=0.775V 1. Demagnetize the record/playback head with a head damagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjusted. 4. The adjustments should be performed with the rated power sup- ply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R- CH. Used for 10 kHz, –10 dB 3 kHz, 0 dB Azimuth Adjustment Tape Speed Adjustment Tape P-4-A100 WS-48B Signal Record/Playback Head Azimuth Adjustment (Deck A, Deck B) Note: Perform this adjustments for both decks. Procedure: 1. Mode : Playback test tape P-4-A100 (10kHz, –10dB) set SPEAKER terminal (JK302) level meter + – FWD FWD back tension 1 to 5 g • cm (0.01 - 0.07 oz • inch) FF/REW 40 to 70 g • cm (0.56 - 0.97 oz • inch) Torque Torque meter Meter reading CQ-102C CQ-102C CQ-201B 55 to 140 g • cm (0.76 - 1.94 oz • inch) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 10 — 2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 2 dB of peak. 3. Mode: Playback good R L-CH peak R-CH peak output level screw position within 2dB L-CH peak R-CH peak screw position test tape P-4-A100 (10kHz, –10dB) SPEKER terminal (JK302) (L-CH) set L oscilloscope SPEKER terminal (JK302) (R-CH) Waveform of oscilloscope wrong in phase 45˚ 90˚ 135˚ 180˚ within 2dB 4. After the adjustments, apply suitable locking compound to the parts adjusted. Adjustment Location: Adjustment screws REC/PB head (deck A) or PB head (deck B) test tape WS-48B (3kHz, 0dB) set SPEAKER terminal (JK302) frequency counter + Tape Speed Adjustment (Deck A) Procedure: 1. Mode: Playback – 2. Adjust the SFR201 so that the frequency counter reads 3,000 Hz ± 90Hz. Adjustment Location: MAIN board Sample Value of Wow and flutter W. RMS (JIS) within 0.3% (test tape: WS-48B) [MAIN BOARD] — Component side — SFR201 Tape Speed CN204 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 11 — TUNER SECTION 0 dB=1µV AM Tuning Voltage Adjustment Procedure: 1. Set the reception frequency of the unit to 530 kHz. 2. Adjust L105 for 1.2 ± 0.05 V reading on the DC voltmeter. 3. Set the reception frequency of the unit to 1,710 kHz. 4. Confirm that the voltage reading on the DC voltmeter is within 8.0 ± 0.5 V. Adjustment Location: MAIN board AM Tracking Adjustment Procedure: 1. Tune the set to 600 kHz. 2. Set the output of AM RF SSG so that the input level of the set will become 60 dB (µV/m). 3. Adjust L104 so that when the waveform on the oscilloscope is maximum, no noise appears. 4. Tune the set to 1,400 kHz. 5. Adjust TC102 so that when the waveform on the oscilloscope is maximum, no noise appears. • Repeat the procedures in each adjustment several times, and the tracking adjustment should be finally done by the trimmer capacitors. Adjustment Location: MAIN board FM Tuning Voltage Adjustment DC voltmeter + – Procedure : 1. Set the reception frequency of the unit to 87.5 MHz. 2. Adjust L103 for 1.2 ± 0.05V reading on the DC voltmeter. 3. Set the reception frequency of the unit to 108 MHz. 4. Confirm that the voltage reading on the DC voltmeter is within 7.8 ± 0.5V. Adjustment Location: MAIN board + – DC voltmeter TP1 Main board IF G VT set loop antenna AM RF SSG 60cm Field strength dB (µV/m) = SSG output level dB (µV/m) –26dB. 30% amplitude modulation by 400Hz signal Center of Bar antenna (L104) TP1 Main board IF G VT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 12 — FM Tuned Level Adjustment Carrier frequency : 98 MHz Modulation : AUDIO 1 kHz, 75 kHz deviation (100%) Output level : 28 dB (at 75 Ω open) FM RF SSG set 75 Ω coaxial FM ANTENNA terminal (JK101) Procedure: 1. Supply a 28 dB 98 MHz signal from the ANTENNA terminal. 2. Tune the set to 98 MHz. 3. Adjust SFR101 to the point (moment) when the TUNED indica- tor will change from going off to going on. Adjustment Location: MAIN board FM RF SSG oscilloscope FM ANTENNA terminal (JK101) SPEAKER terminal (JK302) set Carrier frequency : 90 MHz, 106 MHz Modulation : AUDIO 1kHz, 75kHz deviation (100%) Output level : 20 dB (at 75 Ω open) + – FM Tracking Adjustment Procedure: 1. Tune the set to 90 MHz. 2. Adjust L102 so that when the waveform on the oscilloscope is maximum, no noise appears. 3. Tune the set to 106 MHz. 4. Adjust TC101 so that when the waveform on the oscilloscope is maximum, no noise appears. • Repeat the procedures in each adjustment several times, and the tracking adjustment should be finally done by the trimmer capacitors. Adjustment Location: MAIN board Adjustment Location [MAIN BOARD] — Component side — FM Tuning Voltage JK101 FM Tracking AM Tuning Voltage SFR101 FM Tuned Level AM Tracking TC101 TC102 L105 L104 L103 L102 IC103 JK302 IC102 TP1 IF GND VT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 13 — CD SECTION Note: 1. CD Block is basically constructed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the fol- lowing checks. 5. Adjust the focus bias adjustment when optical block is replaced. Focus Bias Adjustment RF Level Check Procedure : 1. Connect oscilloscope to test point TP (RF) on CD DECODER board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in and playback. 4. Confirm that oscilloscope waveform is clear and check RF sig- nal level is correct or not. Note: Clear RF signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform. TP (RF) CN12 (VC) CD DECODER board oscilloscope level: 1.0 Vp-p VOLT/DIV: 200 mV TIME/DIV: 500 nS +0.3 –0.2 Adjustment Location: CD DECODER board FEO VC – + Procedure: 1. Connect DC voltmeter to test point CN12 (FEO), (VC) on CD DECODER board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in and stop. 4. Adjust VR01 so that the DC voitmeter reading is 0 ± 20 mV. Adjustment Location: CD DECODER board CD DECODER board CN12 DC voltmeter R07 VR01 Focus Bias Focus Gain VR02 Focus Gain Adjustment (VR02) This gain has a margin, so even if it is slightly off. There is no problem. Therfore, do not perform this adjusment. Please note that it should be fixed to mechanical center position when you moved and do not know original position. Adjustment Location [CD DECODER BOARD] — Component side — CN12 IC03 RF Level IC01 FEO VC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 14 — SECTION 5 DIAGRAMS 5-1. CIRCUIT BOARDS LOCATION MAIN Board DISC board PANEL board H/P board SENSOR board POWER TRANSFORMER board SW (B) board SW (C) board MOTOR board SW (D) board SW (A) board CD DECODER board MOTOR (6P) (S) board R/P SW board www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 15 — — 16 — 5-2. BLOCK DIAGRAMS — TUNER SECTION — HCD-G101 FM 75 OHM JK101 FM ANTENNA L101 1 6 3 8 RF IN IF FRONT END IC101 MIX IN OSC T101 TC101,L102 TC101 L102 FM TRACKING D103 D101 D104 FM OSC AMP Q102 L103 FM TUNING VOLTAGE TP1 (1/2) VT G AM TUNING VOLTAGE FM TUNING VOLTAGE TP1 (1/2) TC102 L104 MW BAR ANTENNA L.P.F Q105,106 21 1 24 X101 7.2MHz 17 Q103 B+ B+ 19 L103 FM IF AMP Q101 1 FM IF CF102 10.7MHz CF101 10.7MHz AM TUNING VOLTAGE L105 L105 23 24 21 22 18 FM TUNED LEVEL SFR101 6 10 7 15 16 12 13 20 11 12 13 14 2 3 4 8 CF104 10.7MHz 17 CF105 19kHz 16 18 IF G TP1 (2/2) 7 2 T102 4 DI CLK CE TU MUTE TUNED DO 1 ST/IN 14 15 AM IF L OUT R OUT TU L REC OUT R CH FM DET MPX VCO MPX IN AF DET ST IND AM MIX PL DET PH DET PH DET SMET AM/FM TU LED OSC AFC AM RF OSC/FMSD A MAIN SECTION CE DI CLK DO FM ST AM/FM SD SPEED L CTR H CTR SD/IN AM IN FM IN FM B+ X OUT X IN PD 1 09 FM/AM MPX IC102 • R CH is omitted • Signal path : FM : AM 5 PLL IC103 (Page 21) TC102, L104 AM TRACKING TUNED SWITCH Q107 REC MUTE Q108,109 CF103 www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 17 — — 18 — — CD SECTION — HCD-G101 B+ 4 1 2 5 6 10 DETECTOR LASER DIODE PD LD APC Q01 LD ON Q02 33 34 39 38 35 36 PD1 PD2 31 RF 0 FOCUS/TRACKING SERVO, RF AMP IC01 (1/2) 19 20 21 23 24 25 22 40 EI VR02 VC 42 TEO CN2 6 7 13 12 48 45 1 37 VC 2 1 CN12 FOCUS TRACKING RF LEVEL VR01 TRACKING COIL DRIVE VO3(+) 25 VO3(-) 18 17 FOCUS COIL DRIVE 15 16 27 VIN4 VIN3 VO4(+) VO4(-) TRACKING COIL FOCUS COIL 2-AXIS DEVICE FOCUS/TRACKING COIL DRIVE, SPINDLE/SLED MOTOR DRIVE IC03 SLED MOTOR DRIVE 6 12 11 • SPINDLE MOTOR DRIVE 13 14 • M M M102 SLED MOTOR M101 SPINDLE MOTOR 4 16 15 14 SLED SERVO IC01 (2/2) SL O SL M SL P 24 OP OUT 23 IN - 9 MUTE 22 8 23 14 13 15 16 17 36 RF DIGITAL PLL EFM DEMODULATOR DIGITAL FILTER + 1BIT DAC NLPWM LPWM RPWM NRPWM DATA SQCK CLOK SCOR SQSO SENS 70 69 78 77 R CH D/A INTERFACE SERVO AUTO SEQUENCER 9 5 11 4 1 7 10 SUB CODE PROCESSOR CPU INTERFACE DIGITAL CLV CLOCK GENERATOR 6 18 25 74 73 XLT01 33.8688MHz S05 LIMIT SWITCH SPOA 2 6 7 4 TURN TABLE MOTOR DRIVE Q10,11,14,15 11 TURN TABLE MOTOR DRIVE CONTROL 8 9 TRAY MOTOR DRIVER Q06 - Q09 5 13 14 15 3 10 CONTROL MUTE E POWER SECTION S01 OPTICAL PICK-UP UP/DOWN DET UP DOWN TRAY/TABLE MOTOR DRIVER, REG CONTROL IC02 + - CD L DATA SQCK SQSO SCOR SENS XLAT COUNT FOK DI CLK STB B. BOOST UP DOWN C MAIN SECTION MIX AMP IC05 DIGITAL SIGNAL PROCESSOR, D/A CONVERTER, DIGITAL FILTER IC04 CLKO XLTO DATO SEIN CNIN FOK XLON XRST MDP XTA0 XTA1 MUTE M M M103 TURN TABLE MOTOR M104 TRAY MOTOR T.T+ T.T- DOWN TRAY + TRAY - XRST MUTE B.BOOST DATA I CLOK STB CONTROL UP E F LD PD VC ATSC FEO FEBIAS TA M TA O FE M FE O XRST FOK C. OUT SENS DATA XLT CLK OPTICAL PICK-UP BLOCK A C B D E F 7 VO2(+) VO2(-) VO1(+) VO1(-) VIN2 VIN1 • • Q13 • R CH is omitted • Signal path : CD 09 FOCUS TRACKING FOCUS GAIN XLAT (Page 21) (Page 23) www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 19 — — 20 — — DECK SECTION — HCD-G101 R CH R CH CH1/A CH1/B NF - + PRE OUT BIAS OSC COIL L201 R CH R CH BIAS OSC Q218 REC/PB CONTROL Q203,205 REC/PB CONTROL DRIVE Q207 REC/PB CONTROL Q201 Q211 A/B PREOUT R CH TAPE A/TAPE B + - REC IN NF REC OUT REC/PB EQ AMP IC201 REC SWITCH DRIVE Q217 MUTE SWITCH Q216 MUTE Q209 D205 + Q220 D204 TAPE A SWITCH Q214 SW201 REC/PLAY SWITCH PLAY REC TAPE A/B SWITCH Q213 D201 D203 D202 D210 D211 B + D207 D206 M SFR201 TAPE SPEED M901 REEL/CAPSTAN MOTOR S203 PLAY SWITCH (DECK B) S202 PLAY SWITCH (DECK A) S201 REC SWITCH (DECK A) GROUND SWITCH Q219 B + REC L CD SYNC PB L D208 09 D209 B MAIN SECTION DECK B HP901 PB HEAD DECK A HRP901 REC/PB HEAD HE901 ERASE HEAD • R CH is omitted • Signal path : PB (DECK A) : PB (DECK B) : REC (DECK A) 3 1 2 5 20 9 11 10 19 (Page 21) www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-G101 — 21 — — 22 — — MAIN SECTION — 11 9 12 10 3 CONTROL ELECTRICAL VOLUME 1 2 LT IN LVR OUT SELECTOR IC301 LT OUT L2 L4 L1 L3 15 14 16 CLK DI CE CL DI CE Q301 18 19 16 BASS BOOST SWITCH Q307 BASS BOOST DRIVE SWITCH Q308 LED DRIVER Q605 DBFB LED601 MUTE Q309 MUTE Q604 MUTE Q311 RELAY DRIVE Q401 MUTE SWITCH Q603 PWR P. ON/OFF D POWER SECTION POWER DOWN DET Q601 B+ RESET SWITCH Q602 B+ 68 55 53 52 RESET POWER DOWN IN POWER OUT SYSTEM MUTE OUT DI CLK CE 64 65 66 D105,108 DI CLK B. BOOST MUTE CD L CD SYNC SQSO SCOR SENS XLAT COUNT FOK STB UP DOWN SQCK DATA 39 40 45 62 67 37 38 60 44 43 41 SQSO SCOR SENS XLAT COUNT FOK STB DI2 GFS SQCK/MODE SW IN DATA PB L REC L C CD SECTION B DECK SECTION DO 1 ST/IN TU MUTE TUNED CE CLK DI TU L REC OUT A TUNER SECTION 13 - 15 1 - 3 15 10• 7 A - C Y0 Y5 • Y7 5 G2 SELECTOR IC602 KEY MATRIX 29 - 32 • 34 69 - 80 • 1 - 12 21 - 24 LCD DISPLAY LCD601 59 58 X601 4.19MHz X2 X1 COM 0 COM 3 S00 S23 KI 0 KI 4 KO A KO C 42 2 REMOTE CONTROL RECEIVER RM601 49 48 S02 OPEN/CLOSE DET 46 47 S03 TURN TABLE POSITION DET S04 TURN TABLE OPERATION DET TRAY CLOSE SW TRAY OPEN SW DISC COUNT SW TURN TABLE SW 36 63 61 SYC.REC IN TAPE REC OUT DI1 FM ST IN TU MUTE OUT TUNED DO CLK CE SYSTEM CONTROLLER, LCD DRIVER IC601 REM. IN JK302 SPEAKER R-CH JK303 PHONES • R CH is omitted. • Signal path : FM : PB : REC : CD (Page 16) (Page 20) (Page 18) (Page 23) CD SYNCHRO SWITCH Q208 LINE AMP Q305 D413,414 15 11 POWER AMP IC303 09 www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 23 — — POWER SECTION — HCD-G101 +7.6V REG Q406 +11.5V REG Q405 RECT Q407-Q410 +5.6V REG Q407 +7.6V +5V +5.6V PT302 POWER TRANSFORMER AC IN 5 2 1 6 4 3 +5V REG Q05 REG CONTROL Q04 +10.4V REG Q408 +11.4V REG Q404 S401 RELAY POWER ON/OFF SWITCH Q402 +10.4V RECT D411 +43.5V 09 P.ON/OFF PWR CONTROL MUTE D MAIN SECTION (Page 22) E CD SECTION (Page 18) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 24 — www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 26 — — 25 — 5-3. IC BLOCK DIAGRAMS — CD SECTION — IC01 CXA1782BQ IC03 BA5941FP + – LEVEL SHIFT + – + – 1 2 3 4 5 6 7 8 9 10 11 12 13 14 28 27 LEVEL SHIFT + – + – MUTE + – + – LEVEL SHIFT + – + – LEVEL SHIFT + – + – + – 15 16 17 18 19 21 20 22 26 25 24 23 + – NC Vcc Vcc Vcc VCC BIAS IN IN1B IN1A IN2B IN2A GND GND MUTE VCC OUT2A OUT2B OUT1A OUT1B IN4B IN4A IN3B IN3A OP OUT OP IN (–) OP IN (+) GND NC VCC OUT3A OUT3B OUT4A OUT4B DRIVER DRIVER GND MUTE CONTROL XRST T.T(M) POSI.1 POSI.2 T.T.SW VDD STB CLOK DATA I DATA 0 LOADING M- LOADING M+ SENSOR 1 8 2 3 4 5 6 7 16 9 15 T C 14 13 12 11 10 SERIAL I/O CONTROL LATCH LATCH LATCH IC02 TC9173P 36 PHD2 PHD1 PHD 33 LD 32 RF M 31 RF O 30 RF I 29 CP 28 CB 27 CC1 26 CC2 25 FOK 24 SENS 23 C. OUT 22 XRST 21 DATA 20 XLT 19 CLK 18 VCC 17 ISET 16 SL 0 15 SL M 14 SL P 13 12 TA O TA M 11 FSET 10 TG2 9 TGU 8 SRCH 7 FE M 6 FE O 5 FLB 4 FGD 3 FDFCT 2 FEI 1 FEO 48 VC 47 TDFCT 46 TZC 45 ATSC 44 TEI 43 LPFI 42 TEO 41 VEE 40 EI 39 E 38 F 37 FE BIAS + + – + + – + – + – + – + – + – + + + – + – + – + – + – + – + – + – – + + – – + + – + – + – + – + – APC – – – – LEVELS FOK MIRR DFCT RF IV AMP2 RF IV AMP1 FE AMP F IV AMP E IV AMP TE AMP FZC COMP BAL1 BAL2 BAL3 TOG1 TOG2 TOG3 TTL IIL IIL TTL TTL IIL • IIL DATA RESISTOR • INPUT SHIFT RESISTOR • ADDRESS DECODER • OUTPUT DECODER HPF COMP LPF COMP TZC COMP DFCT DFCT TM1 FS4 ATSC • WINDOW COMP • FCS PHASE COMPENSATION • TRACKING • PHASE COMPENSATION • ISET FS1 FS2 TM4 TM5 TM6 TM3 TM7 TG2 • F SET TG1 TM2 + – TOG1-3 FS1-4 TG1-2 TM1-7 PS1-4 BAL1-3 35 34 www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com IC04 CXD2508Q DTS3 DTS2 RPWM NRPWM AVSS2 AVSS3 XTA0 XTA1 AVDD3 AVDD2 NLPWM LPWM VDD DTS1 ZEROR ZEROL SCOR SBSO EXCK SQSO XRST DATA XLAT CLOK VSS SEIN DATO XLTO CLKO SPOA (PIC SW) SPOB (OPEN SW) SPOC (CLOSE SW) XTSL XLON (LD ON) FOK MON WFCK EMPHI EMPH DOUT C4M FSTT MNT0 MNT1 MNT3 XPOF C2PO VSS RFCK GFS XPCK XUGF GTOP BCK1 BCK PCMD1 PCMD LRCK1 LRCK WDCK MDP MDS LOCK TEST FIL0 FIL1 PCO VDD AVSS1 CLTV AVDD1 RF BIAS ASY1 ASY0 ASYE 1 24 EFM DEMODULATOR DIGITAL OUT 1 10 3 4 3 13 11 DIGITAL FILTER + 1BIT DAC DIGITAL CLV D / A INTERFACE ERROR CORRECTOR SQCK MUTE SENS CNIN 23 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 SERVO AUTO SEQUENCER 16K RAM 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 22 21 64 41 42 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 CPU INTERFACE SUB CODE PROCESSOR CLOCK GENERATOR DIGITAL PLL ASYMMETRY CORRECTOR — 28 — — 27 — IC102 LA1831 XIN CE DI CL DO SYC IN0 IN1 OUT0 OUT1 OUT2 OUT3 SHIFT REGISTER LATCH 12 BIT PROGRAMMABLE DIVIDER SWALLOW COUNTER 1/16 . 1/17 BIT REFERENCE DIVIDER PHASE DETECTOR CHARGE PUMP 1 / 2 X OUT VSS PD2 PD1 VDD FM IN AM IN OUT 6 HCTR LCTR OUT 5 OUT 4 UNIVERSAL COUNTER 7 10 11 12 9 8 6 5 4 3 2 1 13 14 24 23 22 21 20 19 18 17 16 15 IC103 LC7218 IC201 TA8189N FM IF REG GND VCC FM DET S-CURVE TUNING DRIVE LEVEL DET AM/FM IF BUFE ALC BUFFER AM OSC AM MIX AM RF AMP AGC AM DET AM IF COMP FM AM MUTE DECORDER STEREO DRIVE FF TRIG PHASE DET VCO AM/FM SW PILOT DET STEREO SW 3 6 9 12 2 5 8 11 1 4 7 10 22 19 16 13 23 20 17 14 24 21 18 15 OSC/FMSD OSC AFC AM RF SMET AM HPF AF DET MPX VCO MPX IN R OUT L OUT PL DET FM IF AM MIX REG AM IF GND TU LED ST IND FM DET VCC AM/FM PH DET PH DET CH2/A CH2/B NF VCC CG NF ALC METAL OUT PRE OUT TAPE A /TAPE B REC OUT REC IN CH1/A CH1/B NF GND1 M/H NF CH2 CH2 ALC M/N CH1 GND GND CH1 + – + – + – + – A/B GND METAL OUT PRE OUT MIX OUT REC OUT REC IN IREF VREF2 VREF1 24 23 22 21 20 19 18 17 16 15 14 13 1 2 3 4 5 6 7 8 9 10 11 12 IC101 LA1186N RF IN 1 2 3 4 5 6 7 8 9 BYPAS GND GND MIX IN IF OSC VCC AFC RF VREF MIX REG OSC BUF — MAIN SECTION — www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 29 — + – 3 6 9 12 15 2 5 8 11 14 1 4 7 10 13 28 25 22 19 16 29 26 23 20 17 30 27 24 21 18 + – + – + – LATCH DECODER CONTROL SHIFT REGISTER – + LVROUT LVRIN LTOUT LTCOM LT4 LT3 LT2 LT1 L4 L3 L2 L1 VDD CL DI RVROUT RVRIN RTOUT RTCOM RT4 RT3 RT2 RT1 R4 R3 R2 R1 VREF VSS CE IC301 LC75392 HCD-G101 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 55 — — 54 — 57 58 59 60 61 62 63 64 65 66 67 68 69 to 80 VDD X1 X2 XLAT FM ST IN DI 2 DI 1 DO CLK CE STB RESET S00 to S11 — — — O I I I O O O O I O I/O Pin Name Function Pin No. +5V power supply System clock (4.19 MHz) Latch signal output to CXD2508 FM stereo detection signal input Optical pick-up up detection signal input Serial data input Serial data output Serial clock output Chip enable output STB signal output Reset input “L” : reset Segment output to LCD 5-10. IC PIN FUNCTION • IC601 System Controller, LCD driver (µPD753017AGC) 1 to 12 13 14 15 16 17 18 19 20 21 to 24 25 26 to 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 Segment output to LCD. Key control signal output A “H” : active Key control signal output B “H” : active Key control signal output C “H” : active Turned detection signal from tuner Latch output to LED driver “H” : active (Not used) REC/PB select signal output to tape selector Tuner mute control signal output Not used LCD drive signal output Not used Key input 0 “ H” : active Key input 1 “ H” : active Key input 2 “ H” : active Key input 3 “ H” : active Ground Key input 4 “ H”: active Key input 5 “ H” : active (Not used) CD SYNCHRO REC signal input “L” : active FOK signal input from CXD2508 COUNT signal input from CXD2508 SQCK/CLOK/MODE SW signal input/output Serial data output Serial data input from CXD2508 Remote control signal input “L” : active SCOR signal input from CXD2508 SENS signal input from CXD2508 Optical pick-up down detection signal input “L” : down Detection signal input of turn table position Detection signal input of turn table operation Disc tray open detection signal input Disc tray close detection signal input Volume encoder signal input and volume motor control signal output (Not used) System mute control signal output “H” : ON Power ON/OFF control signal output “H” : OFF, “L” : ON +5V power supply Power down detect input “L” : active Not used I/O Function Pin No. Pin Name S12 to S23 KO A KO B KO C TUNED LATCH OUT TAPE REC OUT TU MUTE OUT — COM 1 to COM 3 BIAS VLC 0 to VLC 2 KI 0 KI 1 KI 2 KI 3 VSS KI 4 KI 5 SYC. REC IN FOK COUNT SQCK/MODE SW IN DATA SQSO REM. IN SCOR SENS GFS DISC COUNT SW TURN TABLE SW TRAY OPEN SW TRAY CLOSE SW VR UP VR DOWN SYSTEM MUTE OUT POWER OUT VDD POWER DOWN IN OPEN O O O O I O O O — O O O I I I I — I I I I I I/O O I I I I I I I I I I/O I/O O O — I — • Abbreviation LCD: Liquid Crystal Display www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 56 — SECTION 6 EXPLODED VIEWS NOTE: • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and pack- ing materials are given in the last of this parts list. 6-1. TOP AND BOTTOM CABINET SECTION 1 2 3 4 5 8 9 7 6 not supplied #14 #11 #2 #4 #11 #4 #4 #14 #1 PT302 #1 #1 #1 #1 #1 #4 CD mechanism deck #11 #11 #1 #1 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 4-992-791-01 DOOR, CD 2 4-992-802-01 RUBBER, FOOT 3 4-992-798-01 CABINET, TOP * 4 1-666-622-11 POWER TRANSFORMER BOARD * 5 4-992-800-01 WASHER, AC CORD * 6 4-992-799-01 CABINET, BOTTOM 7 4-992-801-01 FOOT (B) * 8 A-4403-093-A MAIN BOARD, COMPLETE !9 1-559-583-11 CORD, POWER !PT302 1-431-463-11 TRANSFORMER, POWER not supplied #3 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 57 — 6-2. FRONT PANEL SECTION 64 65 61 79 76 80 67 66 60 62 58 53 52 51 59 57 56 54 55 57 68 69 71 72 73 74 62 63 78 81 77 70 84 75 85 83 82 not supplied #5 #1 #1 #1 #1 #1 #1 #1 #1 #1 #1 Cassette mechanism deck #10 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 70 4-992-149-01 KNOB, FUNCTION * 71 4-992-818-01 LENS, LED 72 4-992-814-01 BUTTON, BASS BOOST 73 4-992-816-01 BUTTON, PRESET (EQ) 74 4-992-819-01 NUT, PC BOARD FIXED * 75 1-666-623-11 R/P SW BOARD * 76 1-666-626-11 DISC BOARD * 77 A-4403-097-A PANEL BOARD, COMPLETE 78 1-773-152-11 WIRE (FLAT TYPE) (21 CORE) * 79 4-992-820-01 BRACKET (B), HEAT SINK * 80 4-992-824-01 BRACKET, TOP CABINET * 81 1-666-440-11 SENSOR BOARD * 82 4-992-826-01 PLATE, DISPLAY * 83 4-992-827-01 HOLDER, DISPLAY * 84 4-992-828-01 HOLDER (LED3-10), LED * 85 4-980-832-01 COVER, LED * 86 4-992-825-01 WASHER, FIBER LCD601 1-801-841-11 DISPLAY PANEL, LIQUID CRYSTAL 51 4-992-794-01 WINDOW (L), CASSETTE 52 4-992-792-01 DOOR (L), CASSETTE 53 4-992-808-01 HOLDER (L), DOOR 54 4-992-795-01 WINDOW (R), CASSETTE 55 4-992-793-01 DOOR (R), CASSETTE 56 4-992-809-01 HOLDER (R), DOOR 57 4-992-821-01 SPRING, DOOR 58 4-992-815-01 KNOB, VOLUME 59 4-992-822-01 SPRING, VOLUME 60 4-992-797-01 WINDOW, TUNING 61 4-992-796-01 WINDOW, TOP 62 4-992-131-01 DAMPER (GRY), GEAR 63 4-992-807-01 PANEL, FRONT * 64 1-666-624-11 H/P BOARD 65 4-992-813-01 BUTTON, CLOCK 66 4-992-812-01 BUTTON, POWER 67 4-992-817-01 KNOB, DISC 68 4-992-810-01 BUTTON, DISC SKIP 69 4-992-811-01 BUTTON, TAPE 86 86 LCD601 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 58 — 6-3. CASSETTE MECHANISM DECK SECTION 1 101 102 103 104 105 106 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 4-992-133-01 BUTTON, REC 102 4-992-134-01 BUTTON (A), PLAY 103 4-992-135-01 BUTTON (A), REW 104 4-992-136-01 BUTTON (A), F.F 105 4-992-137-01 BUTTON (A), STOP/EJECT 106 4-992-489-11 BUTTON (A), PAUSE 107 4-992-139-01 BUTTON (B), PLAY 108 4-992-140-01 BUTTON (B), REW 109 4-992-141-01 BUTTON (B), F.F 110 4-992-142-01 BUTTON (B), STOP/EJECT 111 4-992-138-01 BUTTON (B), PAUSE 111 107 108 109 110 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 59 — 6-4. CASSETTE MECHANISM DECK SECTION 2 161 SW202 not supplied M901 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark HE901 9-980-280-01 E HEAD (ERASE) HP901 9-980-287-01 HEAD (PLAY) HRP901 9-980-279-01 HEAD (REC/PLAY) M901 9-980-281-01 MOTOR (CAPSTAN/REEL) SW202 9-980-270-01 LEAF SWITCH (A DECK) SW203 9-980-270-01 LEAF SWITCH (B DECK) SW204 9-980-271-01 LEAF SWITCH (PLAY) 151 9-980-282-01 E HEAD SCREW 152 9-980-284-01 AZIMUTH SCREW 153 9-980-283-01 HEAD SCREW ISO 154 9-980-272-01 PINCH ROLLER ARM ASSY 157 9-980-275-01 MOTOR COLLAR SCREW 158 9-980-274-01 MOTOR RUBBER 160 9-980-273-01 RF BELT 161 9-980-277-01 MAIN BELT * 163 1-759-417-11 DECK, MECHANICAL 151 152 153 154 152 153 154 163 HE901 not supplied not supplied not supplied SW204 HRP901 SW203 not supplied 160 not supplied not supplied not supplied HP901 158 157 not supplied 160 161 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 60 — 6-5. CD MECHANISM DECK SECTION 1 209 211 218 208 207 #7 #5 #7 221 222 #9 225 223 203 212 206 205 224 212 201 M103 204 #5 215 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 215 4-992-183-01 SCREW, RELAY GEAR (B) 216 4-992-174-01 GEAR, CHANGE 217 4-992-184-01 WASHER, CHANGE GEAR 218 4-992-176-01 SPRING, CHANGE GEAR 219 4-992-185-01 WASHER, CHANGE PLATE 220 4-992-172-01 GEAR (A), RELAY * 221 4-993-032-01 PLATE, CHANGE 222 4-993-033-01 WASHER, POLY ETHYLENE * 223 1-666-448-11 SW (B) BOARD * 224 1-666-447-11 SW (A) BOARD * 225 4-993-034-01 GUIDE, RAIL 226 4-993-140-01 TURN TABLE M103 X-4948-765-1 MOTOR ASSY (TURN TABLE) * 201 1-666-451-11 MOTOR BOARD 202 3-669-480-11 + PTPWH 2 203 4-992-168-01 TRAY, CHANGER BASE 204 4-992-180-01 PLATE, BLIND 205 4-992-181-01 LEVER, SENSOR (SW) 206 4-992-182-01 SPRING, SENSOR (SW) LEVER 207 4-992-170-01 BELT, LOADING 208 4-992-171-01 PULLEY, GEAR 209 4-992-179-01 GEAR, TR 210 4-992-177-01 GEAR, TR LOCK 211 4-992-178-01 GEAR (C), RELAY 212 4-992-187-01 CUSHION 213 4-992-186-01 CUSHION, SW LEVER 214 4-992-173-01 GEAR (B), RELAY 202 226 225 214 219 220 210 213 217 216 #5 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 61 — 6-6. CD MECHANISM DECK SECTION 2 263 257 256 264 266 252 253 259 #1 #1 #1 #1 251 268 #1 Base unit block 255 259 M104 258 267 not supplied #10 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 262 4-992-193-01 LEVER, SW * 263 1-666-450-11 SW (D) BOARD * 264 1-666-449-11 SW (C) BOARD 266 4-992-194-01 CLAMP 267 4-992-201-01 WASHER, POLYETHYLENE * 268 A-4398-909-A CD DECODER BOARD, COMPLETE M104 X-4948-766-1 MOTOR ASSY (A) (TRAY) 251 1-769-856-11 WIRE (FLAT TYPE) (5 CORE) 252 4-992-190-01 UD-CAM 253 4-992-191-01 UD-GEAR 254 4-992-195-01 MAGNET * 255 4-992-196-01 CHASSIS, MAIN 256 4-992-197-01 BELT, LOADING GEAR 257 4-992-198-01 PULLEY (B), GEAR 258 4-992-199-01 GEAR, SLIDE 259 4-992-200-01 ROLLER 261 4-992-192-01 SPRING, BRAKE CAM #7 261 254 262 #7 #7 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 62 — 6-7. BASE UNIT SECTION (KSM-213BCM) Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 301 4-992-164-01 BASE, KSM MECHANICAL 302 4-992-165-01 DAMPER (GREEN) 303 4-992-166-01 DAMPER (RED) 304 4-992-167-01 SPRING, MECHANICAL BASE 305 2-626-907-01 GEAR (A) (S) 306 2-626-908-01 SHAFT, SLED 307 2-627-003-02 GEAR (B) !308 8-848-379-31 OPTICAL PICK-UP KSS-213B/S-N * 309 1-639-678-12 MOTOR (6P)(S) BOARD M101 X-2625-877-1 MOTOR ASSY (SPINDLE) M102 X-2625-769-1 MOTOR ASSY (SLED) not supplied 302 302 #6 #6 #6 307 #8 308 305 #6 306 303 M102 M101 303 304 309 304 301 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 63 — • SEMICONDUCTORS In each case, u: µ , for example: uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., uPC...: µ PC..., uPD...: µ PD... • CAPACITORS uF : µ F • COILS uH : µ H • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable Note: SECTION 7 ELECTRICAL PARTS LIST CD DECODER The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. When indicating parts by reference number, please include the board name. Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * A-4398-909-A CD DECODER BOARD, COMPLETE ************************** < CAPACITOR > C02 1-126-963-11 ELECT 4.7uF 20% 50V C03 1-126-933-11 ELECT 100uF 20% 10V C04 1-162-306-11 CERAMIC 0.01uF 20% 16V C05 1-136-159-00 FILM 0.033uF 5% 50V C06 1-162-306-11 CERAMIC 0.01uF 20% 16V C07 1-136-159-00 FILM 0.033uF 5% 50V C07A 1-162-199-31 CERAMIC 10PF 5% 50V C08 1-161-494-00 CERAMIC 0.022uF 25V C09 1-126-959-11 ELECT 0.47uF 20% 50V C10 1-162-306-11 CERAMIC 0.01uF 20% 16V C11 1-126-933-11 ELECT 100uF 20% 10V C11A 1-164-159-11 CERAMIC 0.1uF 50V C12 1-162-306-11 CERAMIC 0.01uF 20% 16V C13 1-164-159-11 CERAMIC 0.1uF 50V C14 1-162-302-11 CERAMIC 0.0022uF 30% 16V C15 1-164-159-11 CERAMIC 0.1uF 50V C16 1-136-159-00 FILM 0.033uF 5% 50V C17 1-136-165-00 FILM 0.1uF 5% 50V C18 1-164-159-11 CERAMIC 0.1uF 50V C19 1-126-963-11 ELECT 4.7uF 20% 50V C20 1-162-306-11 CERAMIC 0.01uF 20% 16V C21 1-136-157-00 FILM 0.022uF 5% 50V C22 1-126-933-11 ELECT 100uF 20% 10V C23 1-164-159-11 CERAMIC 0.1uF 50V C24 1-126-965-11 ELECT 22uF 20% 50V C25 1-126-960-11 ELECT 1uF 20% 50V C26 1-161-494-00 CERAMIC 0.022uF 30% 25V C27 1-162-306-11 CERAMIC 0.01uF 20% 16V C28 1-164-159-11 CERAMIC 0.1uF 50V C29 1-126-935-11 ELECT 470uF 20% 16V C30 1-126-933-11 ELECT 100uF 20% 10V C31 1-162-600-11 CERAMIC 0.047uF 10% 16V C32 1-162-301-11 CERAMIC 0.0015uF 30% 16V C33 1-162-306-11 CERAMIC 0.01uF 20% 16V C34 1-162-286-31 CERAMIC 220PF 10% 50V C35 1-162-306-11 CERAMIC 0.01uF 20% 16V C36 1-126-963-11 ELECT 4.7uF 20% 50V C37 1-164-159-11 CERAMIC 0.1uF 50V C38 1-102-958-00 CERAMIC 20PF 5% 50V C39 1-102-958-00 CERAMIC 20PF 5% 50V C42 1-126-012-11 ELECT 470uF 20% 16V C43 1-126-933-11 ELECT 100uF 20% 10V C45 1-126-923-11 ELECT 220uF 20% 10V C46 1-126-933-11 ELECT 100uF 20% 10V C51 1-162-288-31 CERAMIC 330PF 10% 50V C51A 1-126-959-11 ELECT 0.47uF 20% 50V C52 1-162-288-31 CERAMIC 330PF 10% 50V C53 1-162-284-31 CERAMIC 150PF 10% 50V C54 1-162-284-31 CERAMIC 150PF 10% 50V C55 1-162-284-31 CERAMIC 150PF 10% 50V C56 1-162-284-31 CERAMIC 150PF 10% 50V C57 1-126-961-11 ELECT 2.2uF 20% 50V C58 1-126-961-11 ELECT 2.2uF 20% 50V C59 1-162-294-31 CERAMIC 0.001uF 10% 50V C60 1-162-294-31 CERAMIC 0.001uF 10% 50V C80 1-164-159-11 CERAMIC 0.1uF 50V C81 1-164-159-11 CERAMIC 0.1uF 50V C82 1-164-159-11 CERAMIC 0.1uF 50V C83 1-164-159-11 CERAMIC 0.1uF 50V C84 1-162-282-31 CERAMIC 100PF 10% 50V C85 1-162-292-31 CERAMIC 680PF 10% 50V C86 1-162-282-31 CERAMIC 100PF 10% 50V C86A 1-161-494-00 CERAMIC 0.022uF 25V C87 1-162-282-31 CERAMIC 100PF 10% 50V C88 1-162-282-31 CERAMIC 100PF 10% 50V C89 1-161-494-00 CERAMIC 0.022uF 25V C90 1-161-494-00 CERAMIC 0.022uF 25V C93 1-126-925-11 ELECT 470uF 20% 10V C94 1-126-933-11 ELECT 100uF 20% 10V C98 1-161-494-00 CERAMIC 0.022uF 25V < CONNECTOR > CN01 1-580-475-11 SOCKET, CONNECTOR 16P CN05 1-564-721-11 PIN, CONNECTOR (SMALL TYPE) 5P CN06 1-695-366-21 PIN, CONNECTOR (PC BOARD) 5P CN09 1-695-382-11 PIN, CONNECTOR (PC BOARD) 21P < DIODE > D01 8-719-987-63 DIODE 1N4148M D03 8-719-109-89 DIODE RD5.6ESB2 D09 8-719-109-93 DIODE RD6.2ESB2 D20 8-719-987-63 DIODE 1N4148M D21 8-719-987-63 DIODE 1N4148M D22 8-719-987-63 DIODE 1N4148M D23 8-719-987-63 DIODE 1N4148M D24 8-719-987-63 DIODE 1N4148M D25 8-719-987-63 DIODE 1N4148M D26 8-719-987-63 DIODE 1N4148M D27 8-719-987-63 DIODE 1N4148M D35 8-719-982-11 DIODE MTZJ-4.3B D36 8-719-031-85 DIODE 1N4002L www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 64 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < IC > IC01 8-752-069-56 IC CXA1782BQ IC02 8-759-388-27 IC TC9173P IC03 8-759-429-31 IC BA5941FP IC04 8-752-369-28 IC CXD2508Q IC05 8-759-505-55 IC NJM4558L < COIL > L01 1-410-509-11 INDUCTOR 10uH < TRANSISTOR > Q01 8-729-195-23 TRANSISTOR 2SA952 Q02 8-729-195-23 TRANSISTOR 2SA952 Q04 8-729-194-57 TRANSISTOR 2SC945-P Q05 8-729-142-46 TRANSISTOR 2SC2001-LK Q06 8-729-195-23 TRANSISTOR 2SA952 Q07 8-729-195-23 TRANSISTOR 2SA952 Q08 8-729-142-46 TRANSISTOR 2SC2001-LK Q09 8-729-142-46 TRANSISTOR 2SC2001-LK Q10 8-729-195-23 TRANSISTOR 2SA952 Q11 8-729-195-23 TRANSISTOR 2SA952 Q12 8-729-142-46 TRANSISTOR 2SC2001-LK Q13 8-729-142-46 TRANSISTOR 2SC2001-LK Q14 8-729-142-46 TRANSISTOR 2SC2001-LK Q15 8-729-142-46 TRANSISTOR 2SC2001-LK < RESISTOR > R01 1-249-459-11 CARBON 12K 5% 1/4W R02 1-249-430-11 CARBON 12K 5% 1/4W R03 1-249-397-11 CARBON 22 5% 1/4W F R05 1-247-863-11 CARBON 22K 5% 1/4W R06 1-247-847-11 CARBON 4.7K 5% 1/4W R07 1-249-430-11 CARBON 12K 5% 1/4W R07A 1-249-430-11 CARBON 12K 5% 1/4W R07B 1-249-430-11 CARBON 12K 5% 1/4W R08 1-249-460-11 CARBON 15K 5% 1/4W R09 1-249-460-11 CARBON 15K 5% 1/4W R10 1-247-718-11 CARBON 2.7K 5% 1/4W F R11 1-249-438-11 CARBON 56K 5% 1/4W F R12 1-247-879-11 CARBON 100K 5% 1/4W R13 1-247-896-11 CARBON 510K 5% 1/4W R14 1-247-879-11 CARBON 100K 5% 1/4W R15 1-247-881-00 CARBON 120K 5% 1/4W R16 1-247-887-00 CARBON 220K 5% 1/4W R17 1-247-879-11 CARBON 100K 5% 1/4W R18 1-249-428-11 CARBON 8.2K 5% 1/4W F R19 1-249-431-11 CARBON 15K 5% 1/4W R21 1-247-863-11 CARBON 22K 5% 1/4W R22 1-247-879-11 CARBON 100K 5% 1/4W R23 1-249-430-11 CARBON 12K 5% 1/4W R24 1-247-883-00 CARBON 150K 5% 1/4W R25 1-247-879-11 CARBON 100K 5% 1/4W R26 1-249-855-11 CARBON 10K 5% 1/4W R27 1-249-430-11 CARBON 12K 5% 1/4W R28 1-249-855-11 CARBON 10K 5% 1/4W R29 1-249-843-11 CARBON 3.3K 5% 1/4W R30 1-249-843-11 CARBON 3.3K 5% 1/4W R31 1-249-855-11 CARBON 10K 5% 1/4W R32 1-247-903-00 CARBON 1M 5% 1/4W R33 1-249-855-11 CARBON 10K 5% 1/4W R34 1-247-879-11 CARBON 100K 5% 1/4W R35 1-249-847-11 CARBON 4.7K 5% 1/4W R36 1-249-847-11 CARBON 4.7K 5% 1/4W R37 1-247-807-11 CARBON 100 5% 1/4W R38 1-247-807-11 CARBON 100 5% 1/4W R39 1-249-847-11 CARBON 4.7K 5% 1/4W R40 1-249-847-11 CARBON 4.7K 5% 1/4W R41 1-247-807-11 CARBON 100 5% 1/4W R42 1-247-807-11 CARBON 100 5% 1/4W R44 1-247-807-11 CARBON 100 5% 1/4W R44A 1-249-847-11 CARBON 4.7K 5% 1/4W R46 1-249-855-11 CARBON 10K 5% 1/4W R46A 1-249-409-11 CARBON 220 5% 1/4W F R50 1-249-847-11 CARBON 4.7K 5% 1/4W R50A 1-247-721-11 CARBON 4.7K 5% 1/4W F R52 1-247-721-11 CARBON 4.7K 5% 1/4W F R53 1-249-411-11 CARBON 330 5% 1/4W R55 1-249-847-11 CARBON 4.7K 5% 1/4W R56 1-249-847-11 CARBON 4.7K 5% 1/4W R57 1-249-427-11 CARBON 6.8K 5% 1/4W F R58 1-249-442-11 CARBON 510 5% 1/4W R59 1-247-903-00 CARBON 1M 5% 1/4W R61 1-249-855-11 CARBON 10K 5% 1/4W R62 1-249-855-11 CARBON 10K 5% 1/4W R63 1-249-855-11 CARBON 10K 5% 1/4W R64 1-249-855-11 CARBON 10K 5% 1/4W R65 1-247-864-11 CARBON 24K 5% 1/4W R66 1-247-864-11 CARBON 24K 5% 1/4W R67 1-247-864-11 CARBON 24K 5% 1/4W R68 1-247-864-11 CARBON 24K 5% 1/4W R69 1-249-430-11 CARBON 12K 5% 1/4W R70 1-249-430-11 CARBON 12K 5% 1/4W R71 1-249-430-11 CARBON 12K 5% 1/4W R72 1-249-430-11 CARBON 12K 5% 1/4W R73 1-249-839-11 CARBON 2.2K 5% 1/4W R74 1-249-839-11 CARBON 2.2K 5% 1/4W R75 1-249-847-11 CARBON 4.7K 5% 1/4W R76 1-249-847-11 CARBON 4.7K 5% 1/4W R78 1-249-847-11 CARBON 4.7K 5% 1/4W R79 1-249-405-11 CARBON 100 5% 1/4W F R80 1-247-883-00 CARBON 150K 5% 1/4W R81 1-247-807-11 CARBON 100 5% 1/4W R82 1-247-807-11 CARBON 100 5% 1/4W R83 1-249-469-11 CARBON 100K 5% 1/4W R83A 1-247-863-11 CARBON 22K 5% 1/4W R84 1-249-465-11 CARBON 47K 5% 1/4W R85 1-249-465-11 CARBON 47K 5% 1/4W R86 1-249-465-11 CARBON 47K 5% 1/4W R87 1-249-465-11 CARBON 47K 5% 1/4W R88 1-249-469-11 CARBON 100K 5% 1/4W R89 1-249-839-11 CARBON 2.2K 5% 1/4W R90 1-249-839-11 CARBON 2.2K 5% 1/4W CD DECODER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 65 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R91 1-249-839-11 CARBON 2.2K 5% 1/4W R92 1-249-839-11 CARBON 2.2K 5% 1/4W R93 1-249-420-11 CARBON 1.8K 5% 1/4W F R93A 1-249-420-11 CARBON 1.8K 5% 1/4W F R94 1-249-420-11 CARBON 1.8K 5% 1/4W F R94A 1-249-420-11 CARBON 1.8K 5% 1/4W F R99 1-247-704-11 CARBON 220 5% 1/4W F < VARIABLE RESISTOR > VR01 1-228-996-00 RES, ADJ, METAL 47K VR02 1-228-998-00 RES, ADJ, METAL 220K < VIBRATOR > XTL01 1-760-123-11 VIBRATOR, CRYSTAL (33.8688MHz) ************************************************************** * 1-666-626-11 DISC BOARD ********** < SWITCH > S623 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(6 OPEN/CLOSE) S624 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(DISC 1) S625 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(DISC 2) S626 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(DISC 3) S627 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(DISC SKIP) ************************************************************** * 1-666-624-11 H/P BOARD ********* < JACK > JK303 1-779-715-11 JACK (LARGE TYPE)(PHONES) < RESISTOR > R373 1-247-695-11 CARBON 39 5% 1/4W F R374 1-247-695-11 CARBON 39 5% 1/4W F ************************************************************** * A-4403-093-A MAIN BOARD, COMPLETE ********************* 7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-871-01 SCREW +BVTT 3X6 (S) < CAPACITOR > C101 1-162-294-31 CERAMIC 0.001uF 10% 50V C102 1-162-294-31 CERAMIC 0.001uF 10% 50V C103 1-162-193-31 CERAMIC 3.3PF 10% 50V C104 1-161-494-00 CERAMIC 0.022uF 25V C105 1-162-206-31 CERAMIC 20PF 5% 50V C106 1-161-494-00 CERAMIC 0.022uF 25V C107 1-161-494-00 CERAMIC 0.022uF 25V C108 1-104-665-11 ELECT 100uF 20% 16V C109 1-162-191-31 CERAMIC 2.2PF 10% 50V C110 1-162-191-31 CERAMIC 2.2PF 10% 50V C111 1-162-217-31 CERAMIC 56PF 5% 50V C112 1-162-282-31 CERAMIC 100PF 10% 50V C114 1-164-159-11 CERAMIC 0.1uF 50V C115 1-162-294-31 CERAMIC 0.001uF 10% 50V C116 1-130-014-00 FILM 470PF 5% 50V C117 1-162-206-31 CERAMIC 20PF 5% 50V C118 1-104-665-11 ELECT 100uF 20% 16V C119 1-161-494-00 CERAMIC 0.022uF 25V C120 1-161-494-00 CERAMIC 0.022uF 25V C121 1-162-203-31 CERAMIC 15PF 5% 50V C122 1-126-961-11 ELECT 2.2uF 20% 50V C123 1-124-903-11 ELECT 1uF 20% 50V C124 1-162-206-31 CERAMIC 20PF 5% 50V C125 1-124-903-11 ELECT 1uF 20% 50V C126 1-110-671-31 CERAMIC 47000PF 50V C127 1-124-907-11 ELECT 10uF 20% 50V C128 1-161-494-00 CERAMIC 0.022uF 25V C129 1-109-889-11 ELECT 1uF 20% 50V C130 1-161-054-00 CERAMIC 0.018uF 10% 25V C131 1-161-054-00 CERAMIC 0.018uF 10% 25V C132 1-161-047-00 CERAMIC 0.0047uF 10% 50V C133 1-161-047-00 CERAMIC 0.0047uF 10% 50V C134 1-162-294-31 CERAMIC 0.001uF 10% 50V C135 1-126-962-11 ELECT 3.3uF 20% 50V C137 1-126-959-11 ELECT 0.47uF 20% 50V C138 1-161-494-00 CERAMIC 0.022uF 25V C139 1-161-494-00 CERAMIC 0.022uF 25V C140 1-104-665-11 ELECT 100uF 20% 16V C141 1-161-494-00 CERAMIC 0.022uF 25V C142 1-104-665-11 ELECT 100uF 20% 16V C143 1-126-959-11 ELECT 0.47uF 20% 50V C144 1-161-494-00 CERAMIC 0.022uF 25V C145 1-162-217-31 CERAMIC 56PF 5% 50V C146 1-162-294-31 CERAMIC 0.001uF 10% 50V C148 1-161-494-00 CERAMIC 0.022uF 25V C149 1-162-294-31 CERAMIC 0.001uF 10% 50V C150 1-164-159-11 CERAMIC 0.1uF 50V C151 1-126-233-11 ELECT 22uF 20% 50V C152 1-162-282-31 CERAMIC 100PF 10% 50V C154 1-162-282-31 CERAMIC 100PF 10% 50V C155 1-162-282-31 CERAMIC 100PF 10% 50V C156 1-102-516-11 CERAMIC 27PF 5% 50V C157 1-102-516-11 CERAMIC 27PF 5% 50V C158 1-104-664-11 ELECT 47uF 20% 16V C159 1-161-379-00 CERAMIC 0.01uF 20% 25V C160 1-126-963-11 ELECT 4.7uF 20% 50V C161 1-126-963-11 ELECT 4.7uF 20% 50V C162 1-161-494-00 CERAMIC 0.022uF 25V C201 1-162-286-31 CERAMIC 220PF 10% 50V C202 1-162-286-31 CERAMIC 220PF 10% 50V C203 1-162-294-31 CERAMIC 0.001uF 10% 50V C204 1-162-294-31 CERAMIC 0.001uF 10% 50V C205 1-162-286-31 CERAMIC 220PF 10% 50V C206 1-162-286-31 CERAMIC 220PF 10% 50V C207 1-104-664-11 ELECT 47uF 20% 16V C208 1-104-664-11 ELECT 47uF 20% 16V C209 1-161-052-00 CERAMIC 0.012uF 10% 25V C210 1-161-052-00 CERAMIC 0.012uF 10% 25V MAIN DISC H/P CD DECODER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 66 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C211 1-124-903-11 ELECT 1uF 20% 50V C212 1-124-903-11 ELECT 1uF 20% 50V C213 1-162-294-31 CERAMIC 0.001uF 10% 50V C214 1-162-294-31 CERAMIC 0.001uF 10% 50V C215 1-162-301-11 CERAMIC 0.0015uF 30% 16V C216 1-162-301-11 CERAMIC 0.0015uF 30% 16V C217 1-162-286-31 CERAMIC 220PF 10% 50V C218 1-162-286-31 CERAMIC 220PF 10% 50V C219 1-126-962-11 ELECT 3.3uF 20% 50V C220 1-126-962-11 ELECT 3.3uF 20% 50V C221 1-104-664-11 ELECT 47uF 20% 16V C222 1-104-664-11 ELECT 47uF 20% 16V C223 1-162-294-31 CERAMIC 0.001uF 10% 50V C224 1-162-294-31 CERAMIC 0.001uF 10% 50V C225 1-126-962-11 ELECT 3.3uF 20% 50V C226 1-126-962-11 ELECT 3.3uF 20% 50V C228 1-126-233-11 ELECT 22uF 20% 50V C230 1-130-485-00 MYLAR 0.015uF 5% 50V C231 1-130-483-00 MYLAR 0.01uF 5% 50V C232 1-162-600-11 CERAMIC 0.0047uF 30% 16V C233 1-130-992-11 FILM 0.022uF 5% 50V C234 1-104-664-11 ELECT 47uF 20% 16V C235 1-161-494-00 CERAMIC 0.022uF 25V C237 1-124-119-00 ELECT 330uF 20% 16V C238 1-126-962-11 ELECT 3.3uF 20% 50V C239 1-162-292-31 CERAMIC 680PF 10% 50V C240 1-162-292-31 CERAMIC 680PF 10% 50V C241 1-104-664-11 ELECT 47uF 20% 16V C242 1-126-959-11 ELECT 0.47uF 20% 50V C243 1-126-961-11 ELECT 2.2uF 20% 50V C303 1-126-959-11 ELECT 0.47uF 20% 50V C304 1-126-959-11 ELECT 0.47uF 20% 50V C305 1-126-959-11 ELECT 0.47uF 20% 50V C306 1-126-959-11 ELECT 0.47uF 20% 50V C307 1-126-959-11 ELECT 0.47uF 20% 50V C308 1-126-959-11 ELECT 0.47uF 20% 50V C309 1-162-199-31 CERAMIC 10PF 5% 50V C310 1-162-199-31 CERAMIC 10PF 5% 50V C313 1-162-290-31 CERAMIC 470PF 10% 50V C314 1-162-290-31 CERAMIC 470PF 10% 50V C315 1-130-485-00 MYLAR 0.015uF 5% 50V C316 1-130-485-00 MYLAR 0.015uF 5% 50V C317 1-130-471-00 MYLAR 0.001uF 5% 50V C318 1-130-471-00 MYLAR 0.001uF 5% 50V C319 1-162-301-11 CERAMIC 0.0015uF 30% 16V C320 1-162-301-11 CERAMIC 0.0015uF 30% 16V C321 1-130-485-00 MYLAR 0.015uF 5% 50V C322 1-130-485-00 MYLAR 0.015uF 5% 50V C323 1-162-284-31 CERAMIC 150PF 10% 50V C324 1-162-284-31 CERAMIC 150PF 10% 50V C325 1-130-481-00 MYLAR 0.0068uF 5% 50V C326 1-130-481-00 MYLAR 0.0068uF 5% 50V C327 1-104-666-11 ELECT 220uF 20% 16V C328 1-104-666-11 ELECT 220uF 20% 16V C329 1-162-199-31 CERAMIC 10PF 5% 50V C330 1-162-199-31 CERAMIC 10PF 5% 50V C331 1-104-664-11 ELECT 47uF 20% 25V C332 1-124-572-11 ELECT 100uF 20% 63V C333 1-104-665-11 ELECT 100uF 20% 16V C334 1-124-903-11 ELECT 1uF 20% 50V C335 1-124-903-11 ELECT 1uF 20% 50V C336 1-130-471-00 MYLAR 0.001uF 5% 50V C337 1-126-959-11 ELECT 0.47uF 20% 50V C338 1-126-959-11 ELECT 0.47uF 20% 50V C339 1-124-907-11 ELECT 10uF 20% 50V C340 1-124-907-11 ELECT 10uF 20% 50V C341 1-162-215-31 CERAMIC 47PF 5% 50V C342 1-162-215-31 CERAMIC 47PF 5% 50V C343 1-130-495-00 MYLAR 0.1uF 5% 50V C344 1-130-495-00 MYLAR 0.1uF 5% 50V C345 1-124-907-11 ELECT 10uF 20% 50V C346 1-124-903-11 ELECT 1uF 20% 50V C347 1-126-301-11 ELECT 1uF 20% 50V C348 1-162-294-31 CERAMIC 0.001uF 10% 50V C349 1-162-294-31 CERAMIC 0.001uF 10% 50V C350 1-162-290-31 CERAMIC 470PF 10% 50V C351 1-162-290-31 CERAMIC 470PF 10% 50V C352 1-104-666-11 ELECT 220uF 20% 16V C353 1-104-666-11 ELECT 220uF 20% 16V C354 1-124-557-11 ELECT 1000uF 20% 25V C355 1-124-557-11 ELECT 1000uF 20% 25V C356 1-130-495-00 MYLAR 0.1uF 5% 50V C357 1-130-495-00 MYLAR 0.1uF 5% 50V C358 1-104-664-11 ELECT 47uF 20% 25V C359 1-104-664-11 ELECT 47uF 20% 25V C360 1-124-572-11 ELECT 100uF 20% 63V C361 1-124-907-11 ELECT 10uF 20% 50V C362 1-126-959-11 ELECT 0.47uF 20% 50V C363 1-126-959-11 ELECT 0.47uF 20% 50V C364 1-126-941-11 ELECT 470uF 20% 16V C366 1-162-294-31 CERAMIC 0.001uF 10% 50V C367 1-162-294-31 CERAMIC 0.001uF 10% 50V C371 1-124-903-11 ELECT 1uF 20% 50V C372 1-124-903-11 ELECT 1uF 20% 50V C401 1-117-750-11 ELECT 3300uF 20% 63V C402 1-104-666-11 ELECT 220uF 20% 16V C403 1-126-961-11 ELECT 2.2uF 20% 50V C404 1-161-494-00 CERAMIC 0.022uF 25V C405 1-104-665-11 ELECT 100uF 20% 16V C406 1-104-666-11 ELECT 220uF 20% 16V C407 1-126-941-11 ELECT 470uF 20% 16V C408 1-161-494-00 CERAMIC 0.022uF 25V C409 1-124-563-11 ELECT 2200uF 20% 25V C410 1-104-665-11 ELECT 100uF 20% 16V C411 1-104-666-11 ELECT 220uF 20% 16V C412 1-161-494-00 CERAMIC 0.022uF 25V C413 1-126-941-11 ELECT 470uF 20% 16V C414 1-104-666-11 ELECT 220uF 20% 16V C415 1-161-494-00 CERAMIC 0.022uF 25V C416 1-126-941-11 ELECT 470uF 20% 16V C417 1-161-494-00 CERAMIC 0.022uF 25V C418 1-161-494-00 CERAMIC 0.022uF 25V C419 1-161-494-00 CERAMIC 0.022uF 25V MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 67 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C420 1-161-494-00 CERAMIC 0.022uF 25V C421 1-104-665-11 ELECT 100uF 20% 16V C422 1-161-494-00 CERAMIC 0.022uF 25V C423 1-104-665-11 ELECT 100uF 20% 16V C424 1-161-494-00 CERAMIC 0.022uF 25V C425 1-137-416-11 MYLAR 0.01uF 10% 100V C426 1-137-416-11 MYLAR 0.01uF 10% 100V < FILTER > CF101 1-579-568-11 FILTER, CERAMIC (10.7MHz) CF102 1-567-390-11 FILTER,CERAMIC (10.7MHz) CF103 1-527-996-11 FILTER, CERAMIC (450kHz) CF104 1-579-856-31 DISCRIMINATOR, CERAMIC (10.7MHz) CF105 1-577-075-11 OSCILLATOR, CERAMIC (19kHz) < CONNECTOR > * CN201 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P CN202 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P * CN203 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P * CN204 1-568-274-11 SOCKET, CONNECTOR 8P CN301 1-770-334-11 PIN, CONNECTOR 17P * CN302 1-568-272-11 SOCKET, CONNECTOR 6P * CN303 1-565-386-11 HOLDER, CABLE 5P * CN401 1-564-508-11 PLUG, CONNECTOR 5P < DIODE > D101 8-719-059-68 DIODE KV1340A-2 D102 8-719-987-63 DIODE 1N4148M D103 8-719-059-68 DIODE KV1340A-2 D104 8-719-800-72 DIODE 1SV149-B D105 8-719-987-63 DIODE 1N4148M D106 8-719-987-63 DIODE 1N4148M D107 8-719-109-89 DIODE RD5.6ESB2 D108 8-719-987-63 DIODE 1N4148M D201 8-719-911-19 DIODE 1SS119 D202 8-719-987-63 DIODE 1N4148M D203 8-719-987-63 DIODE 1N4148M D204 8-719-987-63 DIODE 1N4148M D205 8-719-987-63 DIODE 1N4148M D208 8-719-987-63 DIODE 1N4148M D209 8-719-987-63 DIODE 1N4148M D210 8-719-987-63 DIODE 1N4148M D211 8-719-987-63 DIODE 1N4148M D301 8-719-911-19 DIODE 1SS119 D401 8-719-110-31 DIODE RD12ES-B2 D402 8-719-110-31 DIODE RD12ES-B2 D403 8-719-110-08 DIODE RD8.2ES-B2 D404 8-719-987-63 DIODE 1N4148M D405 8-719-987-63 DIODE 1N4148M D406 8-719-150-30 DIODE RD6.2EB3T D407 8-719-904-02 DIODE 1N4002T D408 8-719-904-02 DIODE 1N4002T D409 8-719-904-02 DIODE 1N4002T D410 8-719-904-02 DIODE 1N4002T D411 8-719-312-09 DIODE RBA402 D412 8-719-911-19 DIODE 1SS119 D413 8-719-987-63 DIODE 1N4148M D414 8-719-911-19 DIODE 1SS119 < FUSE, FUSE HOLDER > !F401 1-576-107-12 FUSE (3.15A/250V) * F401H 1-533-293-11 FUSE HOLDER !F402 1-576-104-11 FUSE (2A/250V) * F402H 1-533-293-11 FUSE HOLDER < IC > IC101 8-759-801-96 IC LA1186 IC102 8-759-090-40 IC LA1831 IC103 8-759-175-87 IC LC7218-ST IC201 8-759-242-58 IC TA8189N IC301 8-759-473-59 IC LC75392 IC303 8-749-943-92 IC STK4392 < TERMINAL > JK101 1-694-090-11 TERMINAL BOARD, ANTENNA (FM ANTENNA) JK302 1-694-092-11 TERMINAL BOARD (SPEAKER)(SPEAKER) < COIL > L101 1-429-550-11 TRANSFORMER, FM ANT L102 1-429-551-11 TRANSFORMER, FM RF L103 1-411-798-11 COIL, FM OSC L104 1-501-837-11 ANTENNA, AM FERRITE-ROD L105 1-429-555-11 TRANSFORMER, MW OSC L106 1-408-417-00 INDUCTOR 47uH L201 1-429-552-11 TRANSFORMER, BIAS OSCILLATION < TRANSISTOR > Q101 8-729-672-42 TRANSISTOR 2SC2724-C Q102 8-729-178-63 TRANSISTOR 2SC2786-K Q103 8-729-119-76 TRANSISTOR 2SA1175-HFE Q105 8-729-194-57 TRANSISTOR 2SC945-P Q106 8-729-194-57 TRANSISTOR 2SC945-P Q107 8-729-194-57 TRANSISTOR 2SC945-P Q108 8-729-194-57 TRANSISTOR 2SC945-P Q109 8-729-194-57 TRANSISTOR 2SC945-P Q201 8-729-194-57 TRANSISTOR 2SC945-P Q202 8-729-194-57 TRANSISTOR 2SC945-P Q203 8-729-194-57 TRANSISTOR 2SC945-P Q204 8-729-194-57 TRANSISTOR 2SC945-P Q205 8-729-194-57 TRANSISTOR 2SC945-P Q206 8-729-194-57 TRANSISTOR 2SC945-P Q207 8-729-119-76 TRANSISTOR 2SA1175-HFE Q208 8-729-194-57 TRANSISTOR 2SC945-P Q209 8-729-194-57 TRANSISTOR 2SC945-P Q210 8-729-194-57 TRANSISTOR 2SC945-P Q211 8-729-194-57 TRANSISTOR 2SC945-P Q212 8-729-194-57 TRANSISTOR 2SC945-P Q213 8-729-119-76 TRANSISTOR 2SA1175-HFE Q214 8-729-194-57 TRANSISTOR 2SC945-P Q216 8-729-119-76 TRANSISTOR 2SA1175-HFE Q217 8-729-194-57 TRANSISTOR 2SC945-P Q218 8-729-142-46 TRANSISTOR 2SC2001-LK Q219 8-729-142-46 TRANSISTOR 2SC2001-LK Q220 8-729-194-57 TRANSISTOR 2SC945-P Q301 8-729-194-57 TRANSISTOR 2SC945-P MAIN Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 68 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q302 8-729-194-57 TRANSISTOR 2SC945-P Q304 8-729-194-57 TRANSISTOR 2SC945-P Q305 8-729-194-57 TRANSISTOR 2SC945-P Q306 8-729-194-57 TRANSISTOR 2SC945-P Q307 8-729-194-57 TRANSISTOR 2SC945-P Q308 8-729-194-57 TRANSISTOR 2SC945-P Q309 8-729-231-55 TRANSISTOR 2SC2878-AB Q310 8-729-231-55 TRANSISTOR 2SC2878-AB Q311 8-729-194-57 TRANSISTOR 2SC945-P Q312 8-729-194-57 TRANSISTOR 2SC945-P Q401 8-729-194-57 TRANSISTOR 2SC945-P Q402 8-729-194-57 TRANSISTOR 2SC945-P Q404 8-729-188-23 TRANSISTOR 2SD882-P Q405 8-729-188-23 TRANSISTOR 2SD882-P Q406 8-729-188-23 TRANSISTOR 2SD882-P Q407 8-729-142-46 TRANSISTOR 2SC2001-LK Q408 8-729-142-46 TRANSISTOR 2SC2001-LK < RESISTOR > R101 1-247-879-11 CARBON 100K 5% 1/4W R102 1-249-417-11 CARBON 1K 5% 1/4W F R103 1-249-398-11 CARBON 27 5% 1/4W F R104 1-247-807-11 CARBON 100 5% 1/4W R105 1-249-411-11 CARBON 330 5% 1/4W R106 1-247-807-11 CARBON 100 5% 1/4W R107 1-247-879-11 CARBON 100K 5% 1/4W R108 1-247-871-11 CARBON 47K 5% 1/4W R109 1-247-879-11 CARBON 100K 5% 1/4W R110 1-247-867-11 CARBON 33K 5% 1/4W R111 1-249-417-11 CARBON 1K 5% 1/4W F R112 1-247-807-11 CARBON 100 5% 1/4W R113 1-247-879-11 CARBON 100K 5% 1/4W R114 1-247-879-11 CARBON 100K 5% 1/4W R115 1-249-417-11 CARBON 1K 5% 1/4W F R116 1-247-692-11 CARBON 22 5% 1/4W F R117 1-249-431-11 CARBON 15K 5% 1/4W R118 1-247-807-11 CARBON 100 5% 1/4W R119 1-249-413-11 CARBON 470 5% 1/4W F R120 1-247-843-11 CARBON 3.3K 5% 1/4W R121 1-247-843-11 CARBON 3.3K 5% 1/4W R123 1-249-428-11 CARBON 8.2K 5% 1/4W F R124 1-247-843-11 CARBON 3.3K 5% 1/4W R126 1-247-847-11 CARBON 4.7K 5% 1/4W R127 1-247-847-11 CARBON 4.7K 5% 1/4W R128 1-247-847-11 CARBON 4.7K 5% 1/4W R129 1-247-847-11 CARBON 4.7K 5% 1/4W R130 1-249-405-11 CARBON 100 5% 1/4W F R131 1-247-713-11 CARBON 1K 5% 1/4W F R132 1-247-855-11 CARBON 10K 5% 1/4W R133 1-247-843-11 CARBON 3.3K 5% 1/4W R134 1-249-427-11 CARBON 6.8K 5% 1/4W F R135 1-249-417-11 CARBON 1K 5% 1/4W F R136 1-247-847-11 CARBON 4.7K 5% 1/4W R137 1-247-725-11 CARBON 10K 5% 1/4W F R138 1-249-405-11 CARBON 100 5% 1/4W F R139 1-247-855-11 CARBON 10K 5% 1/4W R140 1-247-855-11 CARBON 10K 5% 1/4W R141 1-247-839-11 CARBON 2.2K 5% 1/4W R142 1-247-839-11 CARBON 2.2K 5% 1/4W R143 1-247-839-11 CARBON 2.2K 5% 1/4W R144 1-247-867-11 CARBON 33K 5% 1/4W R145 1-247-879-11 CARBON 100K 5% 1/4W R146 1-249-417-11 CARBON 1K 5% 1/4W F R148 1-247-855-11 CARBON 10K 5% 1/4W R149 1-247-855-11 CARBON 10K 5% 1/4W R201 1-249-393-11 CARBON 10 5% 1/4W F R202 1-249-393-11 CARBON 10 5% 1/4W F R203 1-247-889-00 CARBON 270K 5% 1/4W R204 1-247-889-00 CARBON 270K 5% 1/4W R205 1-249-407-11 CARBON 150 5% 1/4W F R206 1-249-407-11 CARBON 150 5% 1/4W F R207 1-249-430-11 CARBON 12K 5% 1/4W R208 1-249-430-11 CARBON 12K 5% 1/4W R209 1-247-863-11 CARBON 22K 5% 1/4W R210 1-247-855-11 CARBON 10K 5% 1/4W R211 1-247-891-00 CARBON 330K 5% 1/4W R212 1-247-891-00 CARBON 330K 5% 1/4W R213 1-247-847-11 CARBON 4.7K 5% 1/4W R214 1-247-847-11 CARBON 4.7K 5% 1/4W R215 1-247-855-11 CARBON 10K 5% 1/4W R216 1-249-431-11 CARBON 15K 5% 1/4W R217 1-247-871-11 CARBON 47K 5% 1/4W R218 1-247-704-11 CARBON 220 5% 1/4W F R219 1-247-841-11 CARBON 2.7K 5% 1/4W R220 1-249-434-11 CARBON 27K 5% 1/4W R221 1-247-879-11 CARBON 100K 5% 1/4W R222 1-247-879-11 CARBON 100K 5% 1/4W R223 1-247-855-11 CARBON 10K 5% 1/4W R224 1-247-855-11 CARBON 10K 5% 1/4W R225 1-249-434-11 CARBON 27K 5% 1/4W R226 1-249-434-11 CARBON 27K 5% 1/4W R227 1-247-885-00 CARBON 180K 5% 1/4W R228 1-247-885-00 CARBON 180K 5% 1/4W R229 1-247-881-00 CARBON 120K 5% 1/4W R230 1-247-881-00 CARBON 120K 5% 1/4W R231 1-249-420-11 CARBON 1.8K 5% 1/4W F R232 1-249-420-11 CARBON 1.8K 5% 1/4W F R233 1-247-839-11 CARBON 2.2K 5% 1/4W R234 1-247-839-11 CARBON 2.2K 5% 1/4W R235 1-247-855-11 CARBON 10K 5% 1/4W R236 1-247-855-11 CARBON 10K 5% 1/4W R237 1-247-839-11 CARBON 2.2K 5% 1/4W R238 1-247-843-11 CARBON 3.3K 5% 1/4W R240 1-249-393-11 CARBON 10 5% 1/4W F R241 1-249-434-11 CARBON 27K 5% 1/4W R242 1-247-708-11 CARBON 470 5% 1/4W F R243 1-247-855-11 CARBON 10K 5% 1/4W R244 1-247-855-11 CARBON 10K 5% 1/4W R245 1-249-393-11 CARBON 10 5% 1/4W F R246 1-249-393-11 CARBON 10 5% 1/4W F R247 1-247-855-11 CARBON 10K 5% 1/4W R248 1-249-434-11 CARBON 27K 5% 1/4W R249 1-249-381-11 CARBON 1 5% 1/4W F R250 1-247-847-11 CARBON 4.7K 5% 1/4W MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 69 — Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R251 1-247-847-11 CARBON 4.7K 5% 1/4W R252 1-247-871-11 CARBON 47K 5% 1/4W R253 1-247-871-11 CARBON 47K 5% 1/4W R256 1-249-417-11 CARBON 1K 5% 1/4W F R257 1-247-839-11 CARBON 2.2K 5% 1/4W R258 1-247-871-11 CARBON 47K 5% 1/4W R259 1-247-871-11 CARBON 47K 5% 1/4W R261 1-247-839-11 CARBON 2.2K 5% 1/4W R262 1-247-713-11 CARBON 1K 5% 1/4W F R263 1-247-855-11 CARBON 10K 5% 1/4W R264 1-247-871-11 CARBON 47K 5% 1/4W R265 1-247-887-00 CARBON 220K 5% 1/4W R266 1-247-839-11 CARBON 2.2K 5% 1/4W R267 1-247-871-11 CARBON 47K 5% 1/4W R268 1-247-871-11 CARBON 47K 5% 1/4W R269 1-247-891-00 CARBON 330K 5% 1/4W R270 1-247-891-00 CARBON 330K 5% 1/4W R271 1-247-839-11 CARBON 2.2K 5% 1/4W R301 1-247-855-11 CARBON 10K 5% 1/4W R302 1-247-855-11 CARBON 10K 5% 1/4W R305 1-247-871-11 CARBON 47K 5% 1/4W R306 1-247-871-11 CARBON 47K 5% 1/4W R307 1-247-863-11 CARBON 22K 5% 1/4W R308 1-247-863-11 CARBON 22K 5% 1/4W R309 1-249-440-11 CARBON 82K 5% 1/4W R310 1-249-440-11 CARBON 82K 5% 1/4W R311 1-247-871-11 CARBON 47K 5% 1/4W R312 1-247-871-11 CARBON 47K 5% 1/4W R313 1-247-863-11 CARBON 22K 5% 1/4W R314 1-247-863-11 CARBON 22K 5% 1/4W R315 1-249-434-11 CARBON 27K 5% 1/4W R316 1-249-434-11 CARBON 27K 5% 1/4W R317 1-247-887-00 CARBON 220K 5% 1/4W R318 1-247-887-00 CARBON 220K 5% 1/4W R319 1-247-855-11 CARBON 10K 5% 1/4W R320 1-247-855-11 CARBON 10K 5% 1/4W R321 1-249-434-11 CARBON 27K 5% 1/4W R322 1-249-434-11 CARBON 27K 5% 1/4W R323 1-247-867-11 CARBON 33K 5% 1/4W R324 1-247-867-11 CARBON 33K 5% 1/4W R325 1-247-843-11 CARBON 3.3K 5% 1/4W R326 1-247-843-11 CARBON 3.3K 5% 1/4W R327 1-249-430-11 CARBON 12K 5% 1/4W R328 1-249-430-11 CARBON 12K 5% 1/4W R329 1-247-867-11 CARBON 33K 5% 1/4W R330 1-247-867-11 CARBON 33K 5% 1/4W R331 1-247-717-11 CARBON 2.2K 5% 1/4W F R332 1-247-717-11 CARBON 2.2K 5% 1/4W F R333 1-247-717-11 CARBON 2.2K 5% 1/4W F R334 1-247-855-11 CARBON 10K 5% 1/4W R335 1-247-855-11 CARBON 10K 5% 1/4W R336 1-247-847-11 CARBON 4.7K 5% 1/4W R337 1-247-704-11 CARBON 220 5% 1/4W F R338 1-249-413-11 CARBON 470 5% 1/4W F R339 1-247-903-00 CARBON 1M 5% 1/4W R340 1-247-903-00 CARBON 1M 5% 1/4W R341 1-247-855-11 CARBON 10K 5% 1/4W R342 1-247-855-11 CARBON 10K 5% 1/4W R343 1-247-879-11 CARBON 100K 5% 1/4W R344 1-247-889-00 CARBON 270K 5% 1/4W R345 1-249-417-11 CARBON 1K 5% 1/4W F R347 1-247-883-00 CARBON 150K 5% 1/4W R348 1-247-883-00 CARBON 150K 5% 1/4W R349 1-247-839-11 CARBON 2.2K 5% 1/4W R350 1-247-839-11 CARBON 2.2K 5% 1/4W R351 1-247-827-11 CARBON 680 5% 1/4W R352 1-247-827-11 CARBON 680 5% 1/4W R353 1-249-409-11 CARBON 220 5% 1/4W F R354 1-247-855-11 CARBON 10K 5% 1/4W R355 1-247-855-11 CARBON 10K 5% 1/4W R356 1-247-849-11 CARBON 5.6K 5% 1/4W R357 1-247-849-11 CARBON 5.6K 5% 1/4W R358 1-247-879-11 CARBON 100K 5% 1/4W R359 1-247-879-11 CARBON 100K 5% 1/4W R360 1-247-855-11 CARBON 10K 5% 1/4W R361 1-247-855-11 CARBON 10K 5% 1/4W R362 1-247-871-11 CARBON 47K 5% 1/4W R363 1-247-879-11 CARBON 100K 5% 1/4W R364 1-247-855-11 CARBON 10K 5% 1/4W R365 1-247-721-11 CARBON 4.7K 5% 1/4W F R366 1-247-847-11 CARBON 4.7K 5% 1/4W R367 1-247-879-11 CARBON 100K 5% 1/4W R368 1-247-879-11 CARBON 100K 5% 1/4W R369 1-247-702-11 CARBON 150 5% 1/4W F R370 1-247-702-11 CARBON 150 5% 1/4W F R371 1-260-072-11 CARBON 4.7 5% 1/2W R372 1-260-072-11 CARBON 4.7 5% 1/2W R375 1-249-417-11 CARBON 1K 5% 1/4W F R376 1-249-417-11 CARBON 1K 5% 1/4W F R378 1-249-405-11 CARBON 100 5% 1/4W F R379 1-249-459-11 CARBON 12K 5% 1/4W R380 1-249-459-11 CARBON 12K 5% 1/4W R381 1-249-460-11 CARBON 15K 5% 1/4W R382 1-247-863-11 CARBON 22K 5% 1/4W R383 1-249-417-11 CARBON 1K 5% 1/4W F R384 1-249-469-11 CARBON 100K 5% 1/4W R385 1-247-879-11 CARBON 100K 5% 1/4W R386 1-249-469-11 CARBON 100K 5% 1/4W R387 1-247-879-11 CARBON 100K 5% 1/4W R389 1-247-879-11 CARBON 100K 5% 1/4W R390 1-249-469-11 CARBON 100K 5% 1/4W R391 1-247-879-11 CARBON 100K 5% 1/4W R392 1-247-879-11 CARBON 100K 5% 1/4W R401 1-249-430-11 CARBON 12K 5% 1/4W R402 1-247-847-11 CARBON 4.7K 5% 1/4W R403 1-247-719-11 CARBON 3.3K 5% 1/4W F R404 1-247-855-11 CARBON 10K 5% 1/4W R405 1-247-855-11 CARBON 10K 5% 1/4W R406 1-247-855-11 CARBON 10K 5% 1/4W R407 1-247-706-11 CARBON 330 5% 1/4W F R408 1-249-417-11 CARBON 1K 5% 1/4W F R409 1-247-706-11 CARBON 330 5% 1/4W F R410 1-247-704-11 CARBON 220 5% 1/4W F R411 1-247-708-11 CARBON 470 5% 1/4W F R412 1-249-408-11 CARBON 180 5% 1/4W F MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 70 — * A-4403-097-A PANEL MOUNTED BOARD, COMPLETE ****************************** * 4-980-832-01 COVER, LED 4-992-826-01 PLATE, DISPLAY 4-992-827-01 HOLDER, DISPLAY * 4-992-828-01 HOLDER (LED3-10), LED < CAPACITOR > C601 1-164-159-11 CERAMIC 0.1uF 50V C603 1-124-471-00 ELECT 1000uF 20% 6.3V C604 1-161-494-00 CERAMIC 0.022uF 25V C607 1-104-664-11 ELECT 47uF 20% 16V C608 1-164-159-11 CERAMIC 0.1uF 50V C609 1-126-961-11 ELECT 2.2uF 20% 50V C610 1-124-903-11 ELECT 1uF 20% 50V C611 1-164-159-11 CERAMIC 0.1uF 50V C612 1-124-907-11 ELECT 10uF 20% 50V C613 1-161-494-00 CERAMIC 0.022uF 25V C614 1-124-903-11 ELECT 1uF 20% 50V C615 1-162-282-31 CERAMIC 100PF 10% 50V C616 1-161-494-00 CERAMIC 0.022uF 25V C617 1-162-202-31 CERAMIC 13PF 5% 50V C618 1-162-202-31 CERAMIC 13PF 5% 50V C622 1-104-665-11 ELECT 100uF 20% 16V C623 1-104-665-11 ELECT 100uF 20% 16V C624 1-162-306-11 CERAMIC 0.01uF 20% 16V C625 1-162-286-31 CERAMIC 220PF 10% 50V < CONNECTOR > CN601 1-568-838-11 SOCKET, CONNECTOR 21P < DIODE > D601 8-719-987-63 DIODE 1N4148M D602 8-719-987-63 DIODE 1N4148M D603 8-719-987-63 DIODE 1N4148M D604 8-719-987-63 DIODE 1N4148M D608 8-719-911-19 DIODE 1SS119 D610 8-719-911-19 DIODE 1SS119 D611 8-719-911-19 DIODE 1SS119 D612 8-719-911-19 DIODE 1SS119 D613 8-719-911-19 DIODE 1SS119 D614 8-719-911-19 DIODE 1SS119 D615 8-719-911-19 DIODE 1SS119 D616 8-719-987-63 DIODE 1N4148M D620 8-719-911-19 DIODE 1SS119 D699 8-719-987-63 DIODE 1N4148M < IC > IC601 8-759-473-58 IC uPD753017AGC-E02-3B9 IC602 8-759-241-12 IC TC74HC237AP < COIL > L601 1-408-096-00 INDUCTOR 470uH L602 1-412-507-11 INDUCTOR 47uH < LIQUID CRYSTAL DISPLAY > LCD601 1-801-855-11 DISPLAY PANEL, LIQUID CRYSTAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R205A 1-247-827-11 CARBON 680 5% 1/4W R206A 1-247-827-11 CARBON 680 5% 1/4W < SWITCH > S401 1-515-921-11 RELAY (12V) < RES ADJ METAL > SFR101 1-228-995-00 RES, ADJ, METAL 22K SFR201 1-228-993-00 RES, ADJ, METAL 4.7K < TRANSFORMER > T101 1-429-553-11 TRANSFORMER, FM IFT T102 1-429-554-11 TRANSFORMER, AM IFT < TRIMMER > TC101 1-141-304-21 CAP, TRIMMER 10PF TC102 1-141-227-00 CAP, TRIMMER 20PF < VIBRATOR > X101 1-579-585-11 VIBRATOR, CRYSTAL (7.2MHz) ************************************************************** * 1-666-451-11 MOTOR BOARD ************ < CAPACITOR > C01 1-126-963-11 ELECT 4.7uF 20% 50V < MOTOR > M103 X-4948-765-1 MOTOR ASSY (TURN TABLE) ************************************************************** * 1-639-678-12 MOTOR (6P) (S) BOARD ******************** < CONNECTOR > CN1 1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P < MOTOR > M101 X-2625-877-1 MOTOR ASSY (SPINDLE) M102 X-2625-769-1 MOTOR ASSY (SLED) < SWITCH > S1 1-572-085-11 SWITCH, LEAF (LIMIT) ************************************************************** MAIN MOTOR MOTOR (6P) (S) PANEL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 71 — < DIODE > LED601 8-719-300-79 DIODE SEL1213C (DBFB) < BASE POST > LP601 1-518-527-51 LAMP, PILOT LP602 1-518-527-51 LAMP, PILOT LP603 1-518-527-51 LAMP, PILOT < TRANSISTOR > Q601 8-729-194-57 TRANSISTOR 2SC945-P Q602 8-729-194-57 TRANSISTOR 2SC945-P Q603 8-729-194-57 TRANSISTOR 2SC945-P Q604 8-729-119-76 TRANSISTOR 2SA1175-HFE Q605 8-729-194-57 TRANSISTOR 2SC945-P < RESISTOR > R601 1-247-871-11 CARBON 47K 5% 1/4W R602 1-249-417-11 CARBON 1K 5% 1/4W F R603 1-249-417-11 CARBON 1K 5% 1/4W F R604 1-247-871-11 CARBON 47K 5% 1/4W R605 1-247-871-11 CARBON 47K 5% 1/4W R606 1-249-417-11 CARBON 1K 5% 1/4W F R607 1-249-431-11 CARBON 15K 5% 1/4W R608 1-247-871-11 CARBON 47K 5% 1/4W R610 1-247-855-11 CARBON 10K 5% 1/4W R611 1-247-879-11 CARBON 100K 5% 1/4W R612 1-247-879-11 CARBON 100K 5% 1/4W R613 1-247-879-11 CARBON 100K 5% 1/4W R614 1-247-871-11 CARBON 47K 5% 1/4W R615 1-247-871-11 CARBON 47K 5% 1/4W R616 1-247-871-11 CARBON 47K 5% 1/4W R617 1-247-871-11 CARBON 47K 5% 1/4W R618 1-247-871-11 CARBON 47K 5% 1/4W R619 1-247-871-11 CARBON 47K 5% 1/4W R621 1-249-381-11 CARBON 1 5% 1/4W F R622 1-249-381-11 CARBON 1 5% 1/4W F R623 1-249-381-11 CARBON 1 5% 1/4W F R624 1-247-855-11 CARBON 10K 5% 1/4W R629 1-249-409-11 CARBON 220 5% 1/4W F R636 1-247-871-11 CARBON 47K 5% 1/4W R638 1-247-847-11 CARBON 4.7K 5% 1/4W R641 1-247-871-11 CARBON 47K 5% 1/4W R642 1-247-847-11 CARBON 4.7K 5% 1/4W R643 1-247-847-11 CARBON 4.7K 5% 1/4W R644 1-247-847-11 CARBON 4.7K 5% 1/4W R645 1-247-847-11 CARBON 4.7K 5% 1/4W R646 1-247-847-11 CARBON 4.7K 5% 1/4W R647 1-247-807-11 CARBON 100 5% 1/4W R648 1-247-807-11 CARBON 100 5% 1/4W R649 1-247-807-11 CARBON 100 5% 1/4W R650 1-247-807-11 CARBON 100 5% 1/4W < SWITCH > S601 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(POWER) S602 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(TUNER) S603 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(CD) S604 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(TAPE) S606 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(DBFB) S607 1-571-914-21 SWITCH, KEY BOARD (VOLUME +) S608 1-571-914-21 SWITCH, KEY BOARD (VOLUME –) S609 1-572-481-11 SWITCH, KEY BOARD (1 KEY) (TUNING +, ) ±) S610 1-572-481-11 SWITCH, KEY BOARD (1 KEY) (TUNING –, ≠ 0) S611 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(PRESET +) S612 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(PRESET –) S613 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(MEMORY) S614 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(p) S615 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(·P) S616 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(SHUFFLE) S617 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(REPEAT) S618 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(PROGRAM) S619 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(CLOCK SET) S620 1-572-481-11 SWITCH, KEY BOARD (1 KEY) (TIME SET, CLOCK LIGHT) S621 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(TIME MODE) S622 1-572-481-11 SWITCH, KEY BOARD (1 KEY)(PRESET EQ) < VIBRATOR > X601 1-760-096-11 VIBRATOR, CRYSTAL (4.1943MHz) ************************************************************** * 1-666-622-11 POWER TRANSFORMER BOARD *********************** < RESISTOR > !R001 1-219-238-11 SOLID 4.7M 20% 1/2W ************************************************************** * 1-666-623-11 R/P SW BOARD ************ < CAPACITOR > C236 1-104-666-11 ELECT 220uF 20% 16V C244 1-161-494-00 CERAMIC 0.022uF 25V < CONNECTOR > * CN204 1-573-288-11 HOLDER, CABLE 8P * CN205 1-565-385-11 HOLDER, CABLE 4P CN206 1-565-134-21 HOLDER, CABLE (6P) < DIODE > D206 8-719-904-02 DIODE 1N4002T D207 8-719-904-02 DIODE 1N4002T < COIL > L202 1-411-822-11 COIL, CHOKE < SWITCH > SW201 1-571-135-11 SWITCH, PUSH (1 KEY)(REC/PB SWITCH) ************************************************************** Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark PANEL POWER TRANSFORMER R/P SW Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com — 72 — Ref. No. Part No. Description Remark * 1-666-440-11 SENSOR BOARD ************ < IC > RM601 8-749-013-84 IC SPS-447-1 ************************************************************** * 1-666-447-11 SW (A) BOARD ************ < SWITCH > S04 1-572-143-11 SWITCH, PUSH (TURN TABLE OPERATION DET) ************************************************************** * 1-666-448-11 SW (B) BOARD ************ < SWITCH > S03 1-572-143-11 SWITCH, PUSH (TURN TABLE POSITION DET) ************************************************************** * 1-666-449-11 SW (C) BOARD ************ < SWITCH > S02 1-571-300-31 SWITCH, LEVER (OPEN/CLOSE DET) ************************************************************** * 1-666-450-11 SW (D) BOARD ************ < SWITCH > S01 1-571-300-31 SWITCH, LEVER (OPTICAL PICK-UP UP/DOWN DET) ************************************************************* MISCELLANEOUS ************* !9 1-559-583-11 CORD, POWER 78 1-773-152-11 WIRE (FLAT TYPE) (21 CORE) 251 1-769-856-11 WIRE (FLAT TYPE) (5 CORE) !308 8-848-379-31 OPTICAL PICK-UP KSS-213B/S-N HE901 9-980-280-01 E HEAD (ERASE) HP901 9-980-287-01 HEAD (PLAY) HRP901 9-980-279-01 HEAD (REC/PLAY) M101 X-2625-877-1 MOTOR ASSY (SPINDLE) M102 X-2625-769-1 MOTOR ASSY (SLED) M103 X-4948-765-1 MOTOR ASSY (TURN TABLE) M104 X-4948-766-1 MOTOR ASSY (A) (TRAY) M901 9-980-281-01 MOTOR (CAPSTAN/REEL) !PT302 1-431-463-11 TRANSFORMER, POWER SW202 9-980-270-01 LEAF SWITCH (A DECK) SW203 9-980-270-01 LEAF SWITCH (B DECK) SW204 9-980-271-01 LEAF SWITCH (PLAY) ************************************************************** ************* HARDWARE LIST ************* #1 7-685-647-79 SCREW +P 3X10 TYPE2 SLIT #2 7-685-660-79 SCREW +P 4X10 TYPE2 SLIT #3 7-682-548-09 SCREW +B 3X8 #4 7-685-871-01 SCREW +BVTT 3X6 (S) #5 7-685-131-19 SCREW +P 2.6X4 TYPE2 SLIT #6 7-685-139-29 SCREW, TAPPING, (M2.6X20) #7 7-685-134-19 SCREW (+ PTPWH) (2.6X8) #8 7-621-255-15 SCREW +P 2X3 #9 7-624-118-01 RING, RETAINING 2.5 #10 7-685-903-31 SCREW +PTPWH 3X10 (TYPE2) #11 7-685-646-79 SCREW +BVTP 3X8 TYPE2 SLIT #14 7-685-793-09 SCREW +PTT 2.6X8 (S) SW (A) SW (B) SW (C) SW (D) SENSOR Ref. No. Part No. Description Remark HCD-G101 Les composants identifiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-G101 1997.08 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-G101 – 2 – MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-G101 – 3 – Printing the page that exceeds A4-size two pages (or letter size) is possible by specifying the print range. (Acrobat Reader Version 4.0 or later) 1. The enlarged print is made, if a smaller range than A4 size is specified and the A4 size is selected as a print paper. 2. Almost real sized print is made, if the range is specified, meeting the print paper size. 3. The reduced print is made, if a larger range than the print paper size is specified. Printing by Specifying a Range In printing out the drawings such as a schematic diagram and a printed wiring board larger than the printed paper size, they can be printed by specifying the range. (Acrobat Reader Version 4.0 or later) 1. Display the page to be printed. 2. From the File menu, select [Page Setup] and set the paper size. 3. From the Command bar, select [Graphic Select Tool]. (Keep pressing T , select ) 4. Dragging the cursor, enclose the range on the page to be printed. 5. From the File menu, select [Print] and make sure that the [Selected Graphic] is already checked. Also, if [Fit to page] is checked, the selected range is enlarged or reduced (and rotated as necessary) meeting the paper size. 6. To cancel the printed range, click an arbitrary position on the screen. Printing Method for Large Sized Documents Such As Circuit Diagrams @ ! www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 1997. 03 New 1.1 2002. 03 PDF registration of CORRECTION-1. HCD-G101 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com