SERVICE MANUAL Sony Corporation Home Audio Division Published by Sony Techno Create Corporation E Model HCD-DZ520K Russian Model HCD-DZ520K/DZ620K DVD RECEIVER 9-887-197-01 2006D1678-1 © 2006.04 Ver. 1.0 2006.04 HCD-DZ520K/DZ620K • HCD-DZ520K is the amplifier, DVD/CD and tuner section in DAV-DZ520K. • HCD-DZ620K is the amplifier, DVD/CD and tuner section in DAV-DZ620K. SPECIFICATIONS Model Name Using Similar Mechanism HCD-DZ110 Mechanism Type CDM85-DVBU102 Optical Pick-up Name KHM-310CAA This system incorporates with Dolby*1 Digital and Dolby Pro Logic (II) adaptive matrix surround decoder and the DTS*2 Digital Surround System. *1 Manufactured under license from Dolby Laboratories. “Dolby,” “Pro Logic,” and the double-D symbol are trademarks of Dolby Laboratories. *2 Manufactured under license from Digital Theater Systems, Inc. “DTS” and “DTS Digital Surround” are trademarks of Digital Theater Systems, Inc. * Depending on the sound field settings and the source, there may be no sound output. Inputs (Analog) TV/VCR (AUDIO IN/VIDEO IN) Sensitivity: 450/250 mV AUDIO IN/MIC 1/MIC Sensitivity: AUDIO IN 250/125 mV/MIC 1 1 mv MIC 2 Sensitivity: 1 mV DVD system Laser Semiconductor laser (DVD: λ = 650 nm) (CD: λ = 790 nm) Emission duration: continuous Signal format system Russian models: PAL Other models: NTSC/PAL Tuner section System PLL quartz-locked digital synthesizer system FM tuner section Tuning range 87.5-108.0 MHz (50 kHz step) Antenna (aerial) FM wire antenna (aerial) Antenna (aerial) terminals 75 ohms, unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range Middle Eastern and Russian models: 531-1,602 kHz (with the interval set at 9 kHz) Asian models: 531-1,602 kHz (with the interval set at 9 kHz) 530-1,710 kHz (with the interval set at 10 kHz) Antenna (aerial) AM loop antenna (aerial) Intermediate frequency 450 kHz Amp DZ520K lifier section Stereo mode (rated) 108 W + 108 W (3 ohms at 1 kHz, 1 % THD) Surround mode (reference)RMS output power, 10 % THD Front: 142 W + 142 W (with SS-TS53) Center*: 142 W (with SS-CT51) Surround*: 142 W + 142 W (with SS-TS51) Subwoofer*: 140 W (with SS-WS52) DZ620K Stereo mode (rated) 108 W + 108 W (3 ohms at 1 kHz, 1 % THD) Surround mode (reference)RMS output power, 10 % THD Front: 143 W + 143 W (with SS-TS53) Center*: 143 W (with SS-CT51) Surround*: 143 W + 143 W (with SS-TS53) Subwoofer*: 285 W (with SS-WS52B) — Continued on next page — Photo : HCD-DZ520K www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 HCD-DZ520K/DZ620K SECTION 4 TEST MODE Note 1: Regarding the notification symbol “R” Because the number of the operating buttons of this product are limited, some operations require use of the operating buttons of the remote commander, When a specific operation requires use of the operating buttons of the remote commander, “R” is added to the specific operating procedure in this manual. Example MENU/NO “R” The MENU/NO button of remote commander. Note 2: Incorrect operations may be performed if the test mode is not entered properly. In this case, press the ?/1 button to turn the power off, and retry to enter the test mode. 3. Disc Tray Lock The disc tray lock function for the antitheft of an demonstration disc in the store is equipped. Setting Procedure : 1. Press the ?/1 button to turn the set on. 2. Press the FUNCTION button to set DVD function. 3. Insert a disc. 4. Press the x button and the A button simultaneously for five seconds. 5. The message “LOCKED” is displayed and the tray is locked. Releasing Procedure : 1. Press the x button and the A button simultaneously for five seconds. again. 2. The message “UNLOCKED” is displayed and the tray is unlocked. Note: When “LOCKED” is displayed, the slot lock is not released by turning power on/off with the ?/1 button. 4. DVD Ship Mode • Use this mode when returning the set to the customer after repair. Procedure: 1. Press the ?/1 button to turn the set on. 2. Press the FUNCTION button to set the function “DVD”. 3. Remove all discs, press two buttons x , and . simulta- neously. 4. After a message “MECHA LOCK” is displayed on the fluorescent indicator tube, pull out the AC plug. 5. To exit from this mode, press the ?/1 button to turn the set on. 5. AM Step Change • A step of AM channels can be changed over between 9 kHz and 10 kHz. Procedure: 1. Press the ?/1 button to turn the set ON. 2. Select the function “TUNER”, and press FUNCTION button to select the BAND “AM”. 3. Press the ?/1 button to turn the set OFF. 4. Press two buttons > and ?/1 simultaneously, and the display of fluorescent indicator tube changes to “AM 9 k STEP” or “AM 10 k STEP”, and thus the channel step is changed over. 6. Volume Test Mode Procedure: 1. Press the ?/1 button to turn the power on. 2. Press three buttons . , H and > simultaneously. 3. The message “VOLUME MAX” is displayed, when the VOLUME control is turned in the dirction of (+). The message “VOLUME MIN” is displayed, when the VOLUME control is turned in the dirction of (–). 4. To exit from this mode, press the ?/1 button to turn the set off. 7. Product Out This mode moves the optical pick-up to the position durable to vibration and clears all data including preset data stored in the RAM to initial conditions. Use this mode when returning the set to the customer after repair. Procedure: 1. Press the ?/1 button to turn the power on. 2. Press the FUNCTION button to set the function “DVD”. 3. Remove all discs, and then press three buttons > , A and ?/1 simultaneously. 4. After the “STANDBY” blinking display finishes, the message “MECHA LOCK” is displayed on the fluorescent indicator tube disconnect the AC power plug, then the ship mode is set. 1. Cold Reset • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customers. Procedure: 1. Press the ?/1 button to turn the power on. 2. Press three buttons x , A and ?/1 simultaneously. 3. When this button is operated, display as “COLD RESET” for a while and all of the settings are reset. 2. Panel Test Mode • This mode is used to check the software version, FL, LED and KEY. 2-1. Display Test Mode Procedure: 1. Press the ?/1 button to turn the power on. 2. Press three buttons X , . and A simultaneously. 3. When the display test mode is activated, all segments and LEDs are turned on. 4. To exit from this mode, press three buttons X , . and A simultaneously. 2-2. Version Test Mode Procedure: 1. When the panal test mode is activated, press the . button and the message “DSX2KF” (DZ520K), “DSX2KF+” (DZ620K) are displayed, the version test mode is activated. 2. Whenever press the . button, the version is displayed in order of CE2, MC, SYS, UI, DVD, ST, TA, DSP and TM. 3. Press the > button and the date of the software production is displayed. 4. Press the > button again and the version is displayed. 5. To exit from this mode, press three buttons X , . and A simultaneously. 2-3. Key Test Mode Procedure: 1. When the panel test mode is activated, press the H button, to select the key test mode. 2. To enter the KEY test mode, the fluorecent indicator displays “K0 V0”. Each time a button is pressed, “KEY” value increases. However, once a button is pressed, it is no longer taken into account. When all keys are pressed correctly, “K8 V0” is displayed. 3. When the VOLUME control is turned in the direction of (+), “V0” is changed to “V1”, then ... “V9”. When the VOLUME control is turned in the direction of (–), “V0” is changed to “V9”, then ... “V1”. 4. To exit from this mode, press three buttons X , . and A simultaneously. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 20 HCD-DZ520K/DZ620K DVD SECTION [TEST DISC LIST] Be sure to use the DVD disc that matches the signal standards of your region. • CD YEDS-18 (Part No.: 3-702-101-01) PATD-012 (Part No.: 4-225-203-01) • DVD SL (Single Layer) NTSC : HLX-503 (Part No.: J-6090-069-A) HLX-504 (Part No.: J-6090-088-A) PAL : HLX-506 (Part No.: J-6090-077-A) • DVD DL (Dual Layer) NTSC : HLX-501 (Part No.: J-6090-071-A) HLX-505 (Part No.: J-6090-089-A) PAL : HLX-507 (Part No.: J-6090-078-A) 8-1. GENERAL DESCRIPTION The Mirror Time and IOP measurement allows you to make diagnosis and adjustment simply by using the remote commander and monitor TV. The instructions, diagnosis results, etc. are given on the on-screen display (OSD). Be sure to execute the Mirror Time and IOP measurement when a BU (Base Unit) is replaced. 8-2. HOW TO ENTER TEST MODE While pressing the x and A buttons simultaneously, turn VOLUME + with the DVD player in power on. The Test Mode starts, then the menu shown below will be displayed on the TV screen. * During the TEST mode is running, the model name “DSX2KF” is displayed for DZ520K in the “Remocon Diagnosis Menu”. The model name “DSX2KF+” is displayed for DZ620K. The menu above is the Remocon Diagnosis Menu screen which consists of six main function. At the bottom of the menu screen, the model name and IF-con version. To enter Mirror Time Adjustment menu, press button 2 “R” on the remote commander to enter Drive Manual Operation menu. To exit from the Test Mode, press the power button on the remote commander. 8-3. DRIVE MANUAL OPERATION The Drive Manual Operation menu consists of five main function. By pressing 2 “R” button on the remote commander in the Remocon Diagnosis Menu, the screen will appear as below. Remocon Diagnosis Menu 0. External Chip Check 1. Servo Parameter Check 2. Drive Manual Operation 3. Emergency History Check 4. Version Information Model Name : DSX2KF_XX IF-con : V Syscon : Ver. er. XX.XX (XXXX) X.XXX Drive Manual Operation 1. Servo Control 2. Track/Layer Jump 3. Manual Adjustment 4. Tray Aging Mode 5. MIRR time Adjust 0. Return to Top Menu 8-4. MIRROR TIME ADJUSTMENT To enter Mirror Time Adjustment, press 5 “R” button on the remote commander. The screen will appear as below. There are five main commands in the Mirr time Adjust menu as shown in the figure above. The functions of each command are described in the following page. 1. CD MIRR time Check This command checks the Mirror time value for CD disc. 2. DVD MIRR time Check This command checks the Mirror time value for DVD disc. 3. Threshold This command displays the threshold value between CD and DVD mirror time. 4. Save to EEPROM This command saves an adjusted mirror time value to the EEPROM. 5. Default set MIRR time This command will set CD and DVD mirror time to firmware default value. [Open] / [Close] Pressing the A button controls the tray for disc change during mirror time adjustment. [0] Return to previous menu Press the 0 “R” button to return to previous menu. 8-4-1. EXECUTING MIRROR TIME ADJUSTMENT In order to execute mirror time adjustment, the following standard procedures must be followed. (1) In power on, while pressing the x and A buttons simultaneously, turn VOLUME + . (2) Select “2. Drive Manual Operation”. MIRR time Adjust Menu 1. CD MIRR time Check: 2. DVD MIRR time Check: 3. Threshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [Close] Tray close [0] Return to previous menu Remocon Diagnosis Menu 0. External Chip Check 1. Servo Parameter Check 2. Drive Manual Operation 3. Emergency History Check 4. Version information Model Name : DSX2KF_XX IF-con : Ver. XX.XX (XXXX) Syscon : Ver. X.XXX www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 HCD-DZ520K/DZ620K (3) Select “5. MIRR time Adjust”. (4) Select “5. Default set MIRR time”. (5) Select “3. Threshold”. (6) Confirm the number. If it is 7D, go to next step. If it is any other value, return to step 4. (7) Push the A button to eject tray. (8) Insert Test Disc HLX-504 into tray. (9) Push the A button to close tray. (10) Push “2. DVD MIRR time Check”. (11) Wait for HEX number to display. (12) Confirm the number, if XX is 28 – 70, proceed with next step. If no, return to 8. (13) Push “4. Save to EEPROM”. Drive Manual Operation 1. Servo Control 2. Track/Layer Jump 3. Manual Adjustment 4. Mecha test mode 5. MIRR time Adjust 0. Return to Top Menu MIRR time Adjust Menu 1. CD MIRR time Check: 2. DVD MIRR time Check: 3. Threshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [Close] Tray close [0] Return to previous menu MIRR time Adjust Menu 1. CD MIRR time Check: 2. DVD MIRR time Check: 3. Threshold: 7D 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [Close] Tray close [0] Return to previous menu MIRR time Adjust Menu 1. CD MIRR time Check: 2. DVD MIRR time Check: XX XX 3. Thereshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] tray open [close] Tray close [0] Return to previous menu (14) Confirm the same values are displayed. If it is not same, return to step 7. (15) Push the A button to eject tray. (16) Take out HLX-504 and insert Test Disc YEDS-18 into tray. (17) Push the A button to close tray. (18) Push “1. CD MIRR time check”. (19) Wait for HEX number to display. (20) Confirm the number, if YY is 5A – E8, proceed with next step. If no, return to 15. (21) Push “4. Save to EEPROM”. (22) Confirm the same values are displayed. If it is not the same, return to step 15. (23) Push the A button to eject tray. (24) Remove Test Disc YEDS-18 from tray. (25) Push the A button to close tray. (26) Press the 0 “R” button to the Drive Manual Operation menu. (27) Press the 0 “R” button to return to the Remocon Diagnosis Menu. (28) Press the ?/1 button to switch OFF set. MIRR time Adjust Menu 1. CD MIRR time Check: 2. DVD MIRR time Check: XX XX 3. Threshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [close] Tray close [0] Return to previous menu MIRR time Adjust Menu 1. CD MIRR time Check: YY YY 2. DVD MIRR time Check: XX XX 3. Threshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [close] Tray close [0] Return to previous menu MIRR time Adjust Menu 1. CD MIRR time check: YY YY 2. DVD MIRR time check: XX XX 3. Threshold: 4. Save to EEPROM: 5. Default set MIRR time: [Open] Tray open [close] Tray close [0] Return to previous menu www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 HCD-DZ520K/DZ620K 8-5. EXECUTING IOP MEASUREMENT In order to execute mirror time adjustment, the following standard procedures must be followed. (1) In standby mode, while pressing the x and A buttons simultaneously, turn VOLUME + . (2) Select “2. Drive Manual Operation” by pressing the 2 “R” button on the remote commander. The screen will appear as below. (3) Select “3. Manual Adjustment” by pressing the 3 “R” button on the remote commander. The screen will appear as below. (4) Select Iop by pressing the 6 “R” button on the remote commander. Remocon Diagnosis Menu 0. External Chip Check 1. Servo Parameter Check 2. Drive Manual Operation 3. Emergency History Check 4. Version information Model Name : DSX2KF_XX IF-con : Ver. XX.XX (XXXX) Syscon : Ver. X.XXX Drive Manual Operation 1. Servo Control 2. Track/Layer Jump 3. Manual Adjustment 4. Tray Aging Mode 5. MIRR time adjust 0. Return to top Menu Manual Adjust 1. Track Balance Adjust: 2. Track Gain Adjust: 3. Focus Balance Adjust: 4. Focus Gain Adjust: 5. Eq boost Adjust: 6. Iop: 7. TRV. Level: 8. S curve(FE) Level: 9. RFL(PI) Level: 0. MIRR Time: o O Change Value [RETURN] Return to previous menu (5) Wait until a hexadecimal number appear. (6) Convert each data from hexadecimal to decimal using conversion table. (7) Substract between these two values. (8) If the remainder is smaller than 93 (decimal), then it is OK. However if the value is higher than 93, then the BU is defective and need to be change. (9) Press the RETURN “R” button to return back to previous menu. (10) Press the 0 “R” button to return to Top Menu and power OFF the DVD Player. Manual Adjust 1. Track Balance Adjust: 2. Track Gain Adjust: 3. Focus Balance Adjust: 4. Focus Gain Adjust: 5. Eq Boost Adjust: 6. Iop. 5B: 7. TRV. Level: 8. S curve(FE) Level: 9. RFL(PI) Level: 0. MIRR Time: Change Value [0] Return to previous menu www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 HCD-DZ520K/DZ620K SECTION 5 ELECTRICAL ADJUSTMENT DVD SECTION When the base unit is replaced, perform the adjustment and the measurement as shown below in this order. 1) MIRROR TIME ADJUSTMENT (See page 20) 2) EXECUTING IOP MEASUREMENT (See page 22) [TEST DISC LIST] Be sure to use the DVD disc that matches the signal standards of your region. • CD YEDS-18 (Part No.: 3-702-101-01) PATD-012 (Part No.: 4-225-203-01) • DVD SL (Single Layer) NTSC : HLX-503 (Part No.: J-6090-069-A) HLX-504 (Part No.: J-6090-088-A) PAL : HLX-506 (Part No.: J-6090-077-A) • DVD DL (Dual Layer) NTSC : HLX-501 (Part No.: J-6090-071-A) HLX-505 (Part No.: J-6090-089-A) PAL : HLX-507 (Part No.: J-6090-078-A) [RF Level Check] Connection: Procedure: 1. Connect an oscilloscope to CN1105 pin 6 (RFMON) and CN1105 pin 3 (GND) on the MAIN board. 2. Turn the power on. 3. Insert the CD test disc (refer to the TEST DISC LIST), and press the H button to play the disc back. 4. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not. Note: A clear RF signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform. 5. Eject the CD disc, and insert the DVD SL test disc (refer to the TEST DISC LIST), and press the H button to play the disc back. Checking Location: MAIN board (Side A) + – CN1105 pin 6 (RFMON) CN1105 pin 3 (GND) oscilloscope MAIN board RF signal waveform VOLT/DIV: 200 mV TIME/DIV: 500 ns level: 0.57 to 1.1 Vp-p (CD) 0.58 to 1.23 Vp-p (DVD) IC501 IC1103 3 6 CN1105 Pin 3 (GND) CN1105 Pin 6 (RFMON) CN1105 MAIN BOARD (SIDE A) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 24 HCD-DZ520K/DZ620K SECTION 6 DIAGRAMS For Schematic Diagrams. Note: • All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • f : internal component. • C : panel designation. THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) • A : B+ Line. • Voltages and waveforms are dc with respect to ground un- der no-signal (detuned) conditions. • Voltages and waveforms are dc with respect to ground in service mode. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. no mark : DVD STOP * : Impossible to measure • Voltages are taken with VOM (Input impedance 10 MΩ). • Circled numbers refer to waveforms. • Signal path. F : AUDIO J : CD PLAY c : DVD PLAY I : SACD PLAY d : TUNER L : VIDEO E : Y a : CHROMA r : COMPONENT VIDEO f : AUDIO IN • Abbreviation E3 : 240V AC area in E model RU : Russian model SP : Singapore model For Printed Wiring Boards. Note: • X : parts extracted from the component side. • a : Through hole. • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) • Indication of transistor. Caution: Parts face side: Parts on the parts face side seen from (SIDE A) the parts face are indicated. Pattern face side: Parts on the pattern face side seen from (SIDE B) the pattern face are indicated. ✩ New part of EEP ROM (IC1103) on the MAIN board cannot be used. Therefore, if the mounted MAIN board (A-1144-746-A, etc.) is replaced, exchange new EEP ROM (IC1103) with that used before the replacement. C B These are omitted. E Q C E B These are omitted Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 25 25 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K • Circuit Boards Location FL board JACK board DDCON board SW board IO-S TERMINAL board SPEAKER board MAIN board HEATSINK A board HEATSINK B board POWER board TUNER UNIT MS-203 board • Waveforms – MAIN Board – 200 ns 2.7 Vp-p 5.5 Vp-p 20.3 ns 5 IC3010 rk (XFSOIN) 1 V/DIV, 10 ns/DIV 4 IC501 qg (XIN) 1 V/DIV, 100 ns/DIV 2 IC1101 FUNCTION AUDIO IN/ MIC 1/ A.CAL MIC MIC 2 VOLUME – + IO-S TERMINAL BOARD CN302 (Page 44) L I/1 6 1 3 1 2 4 5 1 5 E E E E E E E E E 13 13 13 13 13 13 13 13 MAIN BOARD CN509 (Page 31) A 1 • Semiconductor Location Ref. No. Location D431 H-7 D432 H-7 D433 D-6 D470 C-7 D496 D-3 D497 D-4 D801 J-13 D802 J-12 D803 K-12 D804 J-12 Ref. No. Location D805 J-12 IC401 C-5 IC402 C-3 IC801 G-9 IC802 H-13 Q470 D-7 Q471 D-7 Q472 C-7 Ref. No. Location Q473 C-7 Q474 C-6 Q475 C-6 Q476 C-7 Q477 D-4 Q478 D-4 Q801 K-13 Q802 H-11 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 47 47 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K 6-22. SCHEMATIC DIAGRAM – PANEL SECTION – • See page 54 for IC Block Diagram. IO-S TERMINAL BOARD CN302 (Page 45) AUDIO IN/ MIC 1/ A.CAL MIC MIC 2 R857 R819 R802 C808 C807 C806 R812 R813 L801 C803 C805 R854 TP831 TP832 L802 Q802 R817 R853 R851 R855 R856 TP801 TP802 C802 IC801 R800 TP841 TP842 TP803 TP804 TP805 TP806 TP807 TP808 TP809 TP810 TP811 TP812 TP813 TP814 TP815 TP816 TP817 TP818 TP819 TP820 TP821 TP822 TP823 TP851 TP852 TP853 TP854 TP855 TP856 TP857 TP858 TP859 TP860 TP861 TP862 TP863 TP871 TP872 TP873 TP876 TP877 CNP806 CNP807 R852 R823 CN801 T801 R437 S800 FB806 FL801 C436 C829 R479 R411 R421 R414 R471 R492 R490 C490 FB470 FB471 R470 R480 CNP401 CNP402 JR814 Q471 R488 R413 R423 R424 R415 C422 R401 R402 R422 R412 R433 R431 R435 R432 C433 C413 R416 R478 R477 C405 C431 JR811 JR817 R403 J401 J402 C434 C823 C822 C821 C818 C817 C816 C815 C813 C812 C832 R816 R815 R814 R811 C471 Q473 D470 IC401 Q477 R496 R404 R405 C406 C444 R446 IC402 R443 C441 R441 R440 C440 R494 FB476 D496 D497 Q801 R801 D803 D432 D431 C826 C825 C810 C809 C824 R820 R804 C801 C800 D801 D804 D805 D802 C804 TP882 TP883 TP880 TP881 TP879 TP878 TP874 TP875 S802 S803 S808 S807 S804 S805 S806 R436 C814 C811 C435 C493 C473 C819 C820 C442 TP416 Q478 C403 D433 TP414 C421 R434 FB420 C404 C412 R482 TP415 R481 TP413 FB474 JR812 Q472 Q476 R487 Q470 C411 TP402 TP409 TP400 TP410 TP418 TP412 R445 R472 Q474 FB472 R420 C420 C410 R410 JR813 FB475 R442 CN402 JR816 CNP801 CN804 CN810 CN811 R805 C423 C401 FB410 CNP802 CN805 C443 R444 C432 S801 R822 R821 Q475 IC802 2.2k 2.2k 47 100 100p 50V 100p 50V 100p 50V 100k 100k 100 10V 0.1 16V 2SC3052EF-T1-LEF 1k 2.2k 1k 1k 2.2k 47 35V NJL23H400A 1k CHASSIS GND CHASSIS GND 2.2k 0 23P FFC_1.0 L DC-DC CONVERTER 15k VOLUME KNOB 0UH 52P 1 35V 0 470 470 15k 2.2k 0 0 1000p 0UH 0UH 2.2k 39 CHASSIS GND CHASSIS GND 0 RT1P141C 100k 1k 1k 1k 1k 47p 3.3k 4.7k 22k 22k 3.3k 0 1M 22k 68p 220p 22 220 4.7k 0.1 0.47 0 0 1k NEW 0.047 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 220p 50V 100 100 100 82k 6.3V RT1P141C -TP-1 1SS355 TE-17 NJM4558M -TE2 RT1P141C-TP-1 10k 4.7k 4.7k 4.7 10 100 NJM4558M -TE2 1k 10 470 100k 100p 0 1SS355WTE-17 1SS355WTE-17 CPH5504-TL-E 33k UDZSTE-17-6.2B 1SS355 TE-17 1SS355 TE-17 220p 50V 220p 50V 0.1 16V 10 16V 0.01 50V 100k 3.9k 0.022 50V 0.0047 50V 1SS355 TE-17 1SS355 TE-17 1SS355 TE-17 1SS355 TE-17 0.01 50V 12k 10 16V 0.01 25V 0.47 1000p 0.022 0.01 25V 0.01 25V 47p 2SC3052EF -T1-LEF 100 10V 1SS355 TE-17 10 0 0UH 0.1 47p 10k 100k 0UH 0 2SK3018 -T106 RT1N140C -TP-1 0 RT1N441C -TP-1 10 0 680 RT1P140C -TP-1 0UH 100k 100p 100p 100k 0 0UH 22k 0 2P 2P 5P 5P 0 220p 47 16V 0UH 13P 13P 220p 47p 0 0 RT1N441C -TP-1 15k w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 48 48 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K 6-23. PRINTED WIRING BOARD – SPEAKER BOARD – • See page 25 for Circuit Boards Location. :Uses unleaded solder. 6-24. SCHEMATIC DIAGRAM – SPEAKER BOARD – SUR R SUR L FRONT R SPEAKER FRONT L CENTER WOOFER SPEAKER BOARD 1 2 13 13 (CHASSIS) (CHASSIS) J MAIN BOARD CN3200 (Page 32) K MAIN BOARD CN3300 (Page 32) I MAIN BOARD CN3100 (Page 32) EP301 EP302 C301 C302 C303 C304 C305 C306 C307 C308 CN302 TB301 CN301 CN303 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C323 C324 TB302 EARTH PLATE EARTH PLATE 1000p 1000p 1000p 1000p 1000p 1000p 1000p 1000p VH-L 2P DICS 4P EH-4P EH-6P 1000p 1000p 1000p 1000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p 10000p DICS 2P (CHASSIS) (CHASSIS) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 49 49 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K 6-25. PRINTED WIRING BOARD – MS-203 BOARD – • See page 25 for Circuit Boards Location. :Uses unleaded solder. 6-26. SCHEMATIC DIAGRAM – MS-203 BOARD – M 4 2 5 1 CN001 1-861-327- 12 S001 (CHUCK/TRAY DETECT) M203 (LOADING) D MAIN BOARD CN1202 (Page 32) MS-203 BOARD + - 1 2 A B 3 4 CN001 S001 5P 42 MAIN BOARD (10/10) CN1202 D w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 50 50 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K 6-27. PRINTED WIRING BOARD – POWER BOARD – • See page 25 for Circuit Boards Location. :Uses unleaded solder. IC941 IC942 IC943 IC901 IC951 IC931 PC903 PC901 IC921 PC902 F MAIN BOARD CN515 (Page 32) G MAIN BOARD CN3002 (Page 32) AC IN 8 1 3 6 5 1 5 1 5 1 1 3 1 12 E E E E E 12 12 MAIN POWER TRANSFORMER SUB POWER TRANSFORMER E K C A A K A K A 1 2 4 5 C E A K C E A K EB905 (CHASSIS) (CHASSIS) (CHASSIS) (CHASSIS) (CHASSIS) A A K • Semiconductor Location Ref. No. Location D901 B-11 D905 B-5 D906 A-6 D907 A-7 D908 B-5 D909 C-8 D910 A-5 D913 B-5 D914 C-8 D915 B-7 D921 B-3 D922 B-2 D923 B-1 D924 C-1 D925 A-1 D926 B-2 D931 F-6 D932 E-8 D941 D-2 D942 E-2 D943 D-3 D944 D-2 D945 F-2 IC901 B-6 IC921 B-3 IC931 E-9 IC941 G-2 IC942 G-3 IC943 G-4 IC951 D-1 PC901 D-9 PC902 C-1 PC903 D-8 Q901 B-5 Q921 B-1 Q943 E-8 Q945 F-3 Q947 E-8 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 51 51 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K 6-28. SCHEMATIC DIAGRAM – POWER BOARD – IC901 IC921 PC902 PC903 PC901 IC943 IC942 IC941 IC931 IC951 C951 R933 Q943 TP916 C955 C909 FH901 FH902 C929 D901 TP910 C934 TP914 C944 EB904 TP915 L951 L947 C947 C949 TP901 C936 TP907 C953 L941 EB903 TP909 TP911 C940 C911 C923 C937 TP912 TP903 R955 R956 R908 L942 L948 Q947 TP913 TP918 TP904 TP902 TP908 TP917 C954 C902 D913 C920 C918 C901 C913 IC921 IC941 IC942 IC943 VDR901 C922 C925 C948 C945 C942 C946 CN901 C958 C960 C967 C968 C969 C970 C941 L945 C971 C939 R966 R967 R968 R913 T902 C924 R965 C976 CN902 D941 C930 EB902 CN904 FR901 R971 R974 T901 D931 R929 L931 R901 LF901 C963 C965 C964 0.001 250V LF902 TH901 330 400V C903 C905 0.0033 400V R903 100k 100k R904 C938 680p 250V C906 1000 1.5kV IC901 R914 0.1 R912 0.33 R911 R907 C907 0.001 R906 D906 D908 D907 D909 R905 R910 R909 R919 R935 D914 D915 C910 22 PC901 PC903 R934 R927 1 D910 R925 R969 D923 R926 R923 R922 C928 470 250V PC902 D942 D943 Q945 D945 R958 R957 R954 R948 R946 IC931 R931 R940 R937 R938 D932 R949 R939 R932 R951 R952 R953 C943 R943 R941 D944 D921 D926 D925 D924 D905 D922 C908 C933 C935 C932 R936 Q901 C952 IC951 Q921 F901 0.1 25V 4.7k RT1N441C-TP-1 0.1 25V 220p 50V HOLDER FUSE HOLDER FUSE 0.1 50V D5SBA60F01 2200 35V 2200 16V 100 10V 100 10V 0.1 50V 0.001 2kV 3300 10V 0.0047 50V 0.0047 50V 0.047 50V 470 1k 1/10W 3.3k 1/2W RT1N441C-TP-1 0.1 25V 0.22 275V SARS03 0.01 250V 250V 0.01 0.22 275V 250V 100p STR-V153 SI-3120KM-TL SI-3050KM-TL SI-3033KM-TL VARISTOR TNR14SE471K490 22 100V 47p 2kV 470 10V 470 16V 470 25V 1000 16V 2P 0.1 0.1 0.1 0.1 0.1 0.1 1000 25V 0.1 0.1 50V 1k 1/10W 1k 1/10W 1k 1/10W SUB TRANS 2.2 50V 100 16V WIRE 3P EK19LF-F7 100p 250V WIRE 12P 0.1 1W 0 3.3k FCU20UC20 2.2 1/2W 220 10k 3.3k 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 1SS355WTE-17 10 2.2k 100k 18k 1k 1SS355WTE-17 UDZSTE-1710B TLP421F(D4-GR) TLP421F(D4-GR) 1k 1SS355WTE-17 10 1k UDZSTE-1710B 680k 4.7k 4.7 TLP421F(D4-GR) RK36LF-B3 RK36LF-B3 RSR025N03TL UDZSTE-1720B 1k 47k 22k 10k 150 TA76431AS (TPE6) 10k 10k 1k UDZSTE-175.1B 1k 3.3k 33k 220 2.2k 3.9k 100 16V 0 0 EK19LF-F7 ST02D-140 UDZSTE -1710B UDZSTE -175.1B UDZSTE -1724B D1NL20U-TR2 D1NL20U -TR2 47 35V 2200 35V 0.1 2200 35V 470k 2SB1116A TP-LK 0.047 50V TA76L431S (TPE6,Q) 2SD1616A -TP-LK 0.22 2W MAIN TRANS 5.6k 1M 0.001 0.001 3.3k STR-F6168-LF1352 THERMISTOR, NTC 6.0 (CHASSIS) (CHASSIS) (CHASSIS) (CHASSIS) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 52 52 HCD-DZ520K/DZ620K HCD-DZ520K/DZ620K • IC Block Diagrams – MAIN Board – IC2200 PCM1803DBR VINL 1 VINR 2 VERF1 3 VERF2 4 VCC 5 AGND 6 PDWN 7 BYPAS 8 FSYNC 9 LRCK 10 MODE1 20 MODE0 19 FMT1 18 FMT0 17 OSR 16 SCKI 15 VDD 14 DGCD 13 DOUT 12 BCK 11 Single-End /Differential Converter 5 th Order Delta-Sigma Modulator 5 th Order Delta-Sigma Modulator Reference Single-End /Differential Converter × 1/64 (× 1/128) Decimation Filter with DC Cut Filter Power Supply Clock and Timing Control Serial Interface Mode/ Format Control IC3010, IC3020, IC3030 CXD9788AR S P Sampling Rate Converter DF1 DF2 Gain Control Filter & LOW CUT Filter Serial Control Liner Interpolator ∆ ∑ Converter XVSS PWM INIT/MUTE Clock Generator Clock Generator (Secondary Clock System) 1 VSUBC 2 VSSR VSSL VSSL VSSR 3 OUTR2 OUTL2 OUTR1 OUTL1 4 VDDR DVDD DVSS VDDL 5 6 7 8 XOVSS XOVDD 9 XFSOOUT 10 11 NSPMUTE 12 SOFTMUTE 13 PGMUTE SCSHIFT 14 SCDT 15 SCLATCH OVF FLAGR OVF FLAGL 16 SFLAG INIT 17 MCKSEL 18 LRCK 19 BCK 20 DATA BFVDD BFVSS TEST DVDD XFSIIN 21 42 43 41 40 39 38 37 XFSOIN 36 XVDD 35 HPVDDL 34 HPOUTL2 33 HPVSSL 32 31 HPVDDR 30 HPOUTR1 HPOUTL1 29 28 HPVSSR 27 26 25 HPOUTR2 24 FSOI 23 FSOCKO 22 44 45 46 47 48 (Primary Clock System) IC3050 TK1118CSCL-G 1 2 3 5 4 VCONT GND NP VIN VOUT CONTROL CIRCUIT OVER HEAT & OVER CURRENT PROTECTION BANDGAP REFERENCE IC3100, IC3150, IC3200, IC3250, IC3300, IC3400, IC3500 CXD9883M 1 10 9 8 11 12 13 14 7 6 15 16 17 18 3 4 5 20 19 2 AGND GND GND PGND PGND PGND PGND PGND PGND 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 Stuck Detect Stuck Detect Timing Control Timing Control Protection Logic Protection Logic Gate Drive Gate Drive Gate Drive Gate Drive Over Current Fault Over Current Fault Over Current Fault Over Current Fault Programmable Current sense OUT_B OUT_B OUT_B PVDD_B PVDD_B PVDD_B OUT_A OUT_A OUT_A PVDD_A PVDD_A PVDD_A REG BST_B GVDD_B VDD PWM_B M1 M2 M3 VREG OC_ADJ PWM_A /RESET /SD /OTW GVDD_A BST_A Protection and Reset Logic OLP OTP CB3C Temperature waming/error Power-Up Reset Under Voltage Protection /HIZ_HS_B /HIZ_HS_A /HIZ_LS_B /HIZ_LS_A /OCL_B /OCL_A /OCH_B /OCH_A /RESET_A /RESET_B VREG /HIZ_HS_X /HIZ_LS_X /OCH_X /OCL_X /RESET_X /PCR /UVP /UVP /UVP_VREG VREG GVDD_A GVDD_B VREG w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 53 HCD-DZ520K/DZ620K – IO-S TERMINAL Board – IC350 MC14052BDR2 IC371 M62429FP-TP VR 2 VR 1 VIN1 VOUT1 GND DATA VIN2 VOUT2 VCC CLOCK 7 2 3 4 8 1 REF AMP VOL AMP 2 VOL AMP 1 6 LOGIC CONTROL 5 VREF 1 VCC1 2 C IN 3 MUTE 1 4 CVBS IN 28 VCC2 23 CVBS OUT 25 S1 150kΩ BIAS 12 CB IN 150kΩ BIAS CLAMP 6dB 6dB 6 Y IN 7 GND1 8 BIAS CLAMP BIAS 6dB 9 I/P 10 CY IN 11 CLP 13 MUTE2 5 YC MIX + 6dB –6dB 6dB 27 S-DC OUT 24 S2 LOW-PASS FILTER 21 Y OUT 22 GND2 6.75MHz 75Ω DRIVER LOW-PASS FILTER 6.75MHz 75Ω DRIVER 20 CY OUT 75Ω DRIVER S-DC OUT S1/S2 26 C OUT LOW-PASS FILTER 6.75MHz 75Ω DRIVER CLAMP 150kΩ BIAS LOW-PASS FILTER 6.75MHz LOW-PASS FILTER 13.5MHz 18 CB OUT 19 GND2 17 GND2 15 GND2 75Ω DRIVER LOW-PASS FILTER 6.75MHz LOW-PASS FILTER 13.5MHz 14 CR IN 150kΩ BIAS 16 CR OUT 75Ω DRIVER LOW-PASS FILTER 6.75MHz LOW-PASS FILTER 13.5MHz 6dB 6dB IC201 MM1623BFBE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 54 HCD-DZ520K/DZ620K – FL Board – IC802 uPD16315GB-3BS 1 2 3 4 5 4-bit latch 24-bit output latch 12-bit shift register Data selector 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 Serial interface OSC Timing generator key scan Display memory 24 bits x 12 words Key data memory (2 x 16 bits) Command decoder segment driver Grid driver Multiplexed driver 39 40 41 42 43 44 LED1 LED2 LED3 LED4 OSC DOUT DIN CLK STB KEY1 KEY2 VSS VDD SEG1/KS1 SEG2/KS2 SEG3/KS3 SEG4/KS4 SEG5/KS5 SEG6/KS6 SEG7/KS7 SEG8/KS8 SEG9/KS9 SEG10/KS10 SEG20/GRID9 SEG21/GRID8 SEG22/GRID7 SEG23/GRID6 SEG24/GRID5 GRID4 GRID3 GRID2 GRID1 VDD VSS SEG11/KS11 SEG12/KS12 SEG13/KS13 SEG14/KS14 SEG15/KS15 SEG16/KS16 VEE SEG17/GRID12 SEG18/GRID11 SEG19/GRID10 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 55 HCD-DZ520K/DZ620K • IC Pin Function Description MAIN BOARD IC501 M30622MEP-A49FPU0 (SYSTEM CONTROLLER) Pin No. Pin Name I/O Description 1 DAMP_SCDT/ O DAMP processor and Diat data output DIAT_SDATA 2 DAMP_SHIFT/ O DAMP processor and Diat clock output DIAT_SCLK 3 DSP_INTR I DSP interrupt (not used) 4 SIRCS_IN I Sircs input 5 DSP_MOSI/DIR_DIN O DSP and DIR data output (not used) 6 DSP_MOSI I DSP data input (not used) 7 DSP_SPICLK/DIR_CLK O DSP/DIR clock output (not used) 8 BYTE I External data bus (Ground terminal) 9 CNVSS I Change processor mode (Pull down) 10 EN_A I Volume control for ENCODER (Pull up) 11 EN_B/FL_RESET I Volume control for ENCODER (Pull up) 12 RESET I System reset signal input 13 XOUT O Crystal output for main clock (5MHz) 14 VSS — Ground terminal 15 XIN I Crystal input for main clock (5MHz) 16 VCC — Power supply (BUP+3.3V) 17 NMI I BUP 3.3V 18 DIR_ZERO I DIR zero data detect (not used) 19 DIR_CSFLAG I Out level detect for auto calibration 20 AC_CUT I Detect AC-CUT 21 FL_CLK/LED_CLK O FL and LED driver clock output 22 LED_LAT O LED driver latch (not used) 23 DIAT_CSOD I DIAT CSOD signal input (not used) 24 FL_D_OUT/LED_DATA O FL and LED driver data output 25 FL_CS/STB O FL driver chip select 26 MIC_GAIN O MIC gain control 27 CDM_OPEN_SW I CDM open switch input 28 DC_CONT O A.CAL MIC DC control output 29 I2C_CLK I/O I2C clock input 30 I2C_DATA I/O I2C data input 31 DVD_SID O Media Tek data out/Flash white TXD1 32 DVD_SOD I Media Tek data in/Flash white RXD1 33 DVD_SCO I Media Tek clock in/Flash white CLK1 34 DVD_XIFBUSY O Media Tek busy request/Flash white RTS1 35 XM_SC_TX_OUT/ MIC_DET_OUT O MIC detect status out to Media Tek 36 XM_SC_RX_IN/ KARAOKE MODE I KARAOKE mode information from Media Tek 37 DVD XIFCS I Media Tek chip select 38 MTK RST O Media Tek reset 39 P_CONT1 O Control for power supply 1 40 P_CONT2 O Control for power supply 2 41 P_CONT3 O Control for power supply 3 42 DRIVE_RST (EN) O DAMP driver reset 43 DRIVE_OCP (DIAG) I DAMP driver shut down www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 56 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 44 OVERFLOW1 I DAMP processor F/C/S over flow detect 45 OVERFLOW2 I DAMP processor SW over flow detect 46 WRITE CE I Flash write CE (not used) 47 DAMP LATCH1 O DAMP processor latch1 48 DAMP LATCH2 O DAMP processor latch2 49 DAMP LATCH3 O DAMP processor latch3 50 DAMP INIT O DAMP processor reset 51 DAMP SOFT MUTE O DAMP processor soft muting 52 MIC2_SW I MIC2 insert switch 53 HP_MUTE O Headphone muting (not used) 54 SRC_MUTE O Sampling rate converter mute control (not used) 55 DSP_RESET O DSP reset (not used) 56 DSP_SPIDS O DSP device select (not used) 57 SEL_SA-CD O DSP input data select (not used) 58 DSP_RST O DIR reset (not used) 59 DSP_HCE O DIR chip enable (not used) 60 DAMP OUT2DLY/ DIR_ERR I Not used 61 DAMP FSDLY/ DIR_XSTATE I Not used 62 VCC — Power supply (BUP 3.3V) 63 DIR_HDOUT I DIR data in (not used) 64 VSS — Ground terminal 65 DIAT_XRST O DIAT reset (not used) 66 DIAT_XSCEN O DIAT chip enable (not used) 67 SRC_MODEO O Sampling rate convertor MODEO control (not used) 68 M_ST O LINK (Multi STEREO) control 69 TUNED I TUNER tuned input 70 ST_CLK O TUNER clock output 71 ST_DC I TUNER data input 72 ST_CE O TUNER chip enable 73 ST_DI O TUNER data output 74 KEY INT I Wakeup from ECO mode by key input 75 RDS_CLK/MIC_CLK/ XM_ERR_IRQ O RDS clock input 76 RDS-DATA/MIC-DAT/ XM_COM_SEL O RDS data input 77 XM_RESET O XM reset (not used) 78 DABSEL/XMSEL O XM clock select (not used) 79 V_SEL0 O VIDEO selector 0 80 V_SEL1 O VIDEO selector 1 81 TVSEL/V_SEL3 O TV control/VIDEO selector 3 (not used) 82 A_SEL0 O Audio selector 0 83 A_SEL1 O Audio selector 1 84 V_SEL2 O VIDEO selector 2 85 IO_CE O I/O expander IC chip enable (not used) 86 IO_RESET O I/O expander IC reset (not used) 87 IO_DI O I/O expander IC data output (not used) 88 IO_DO I I/O expander IC data input (not used) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 57 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 89 IO_CLK O I/O expander IC clock output (not used) 90 MONO/ST_DET I Front jack MONO or STEREO detect 91 A.CAL MIC LEVEL I MIC level detect for auto calibration 92 DESTINATION I Destination select input 93 MODEL I Model select input 94 KEY2 I Key input 2 input 95 KEY1 I Key input 1 input 96 VSS — Ground terminal 97 KEY0 I Key input 0 input 98 VREF I Reference voltage (E3.3V) 99 VCC I Power supply (BUP3.3V) 100 MIC/A.CAL SW I MIC insert switch www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 58 HCD-DZ520K/DZ620K MAIN BOARD IC1101 CXD9849R (CD/DVD RF AMP, FOCUS/TRACKING ERR AMP, DVD SYSTEM PROCESSOR, DIGITAL SERVO PROCESSOR) Pin No. Pin Name I/O Description 1 AGND — Ground terminal 2 DVDA I AC coupled input path A 3 DVDB I AC coupled input path B 4 DVDC I AC coupled input path C 5 DVDD I AC coupled input path D 6 DVDRFIP I AC coupled DVD RF signal input RFIP 7 DVDRFIN I AC coupled DVD RF signal input RFIN (not used) 8 NA I DC coupled main-beam RF signal input A 9 NB I DC coupled main-beam RF signal input B 10 MC I DC coupled main-beam RF signal input C 11 MD I DC coupled main-beam RF signal input D 12 SA I DC coupled sub-beam RF signal input A (not used) 13 SB I DC coupled sub-beam RF signal input B (not used) 14 SC I DC coupled sub-beam RF signal input C (not used) 15 SD I DC coupled sub-beam RF signal input D (not used) 16 CDFON I CD focusing error negative input (not used) 17 CDFOP I CD focusing error positive input (not used) 18 TNI I 3 beam satellite PD signal negative input 19 TPI I 3 beam satellite PD signal positive input 20 MDI1 I Laser power PD monitor input 21 MDI2 I Laser power PD monitor input 22 LDO2 O Laser drive output 23 LDO1 O Laser drive output 24 SVDD3 — Power supply (RF+3.3V) 25 CSD O Central servo, positive main beam summing output (not used) 26 RFLVL O RFRP low pass, or Positive main beam summing output (not used) 27 SGND — Ground terminal 28 V2REFO O Reference voltage 2.8V 29 V2O O Reference voltage 2.0V 30 VREFO O Reference voltage 1.4V 31 FED O Focus error monitor output (not used) 32 TEO O Tracking error monitor output (not used) 33 TEZISLV O TE slicing level (not used) 34 OPOUT O Op amp output (not used) 35 OPIN I Op amp negative input (not used) 36 OPIN I Op amp positive input (not used) 37 DMO O Disk motor control output. PWM output 38 FMO O Feed motor control. PWM output 39 TROPENPWM O Tray PWM output/tray open output. 40 IOPMON O General PWM output 41 TRO O Tracking servo output 42 FOO O Focus servo output 43 DVSS — Ground terminal 44 NC — USB port DPLUS analog pin (not used) 45 NC — USB port DMINUS analog pin (not used) 46 DVDD3 — Power supply (SW+3.3V) 47 SPFG I Motor hall sensor input www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 59 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 48 DSEL — Not used 49 WIDE I Wide switch signal input terminal 50 MSW I Mute signal control input 51 MAMUTE O MAMUTE signal output to system controller (IC501) (not used) 52 DVDD18 — Power supply (+1.8V from IC1109) 53 to 58 IOA 2 to 7 O Address bus 2 to 7 output to PROM (IC1102) 59 HIGHA0 O Address bus 8 output to PROM (IC1102) 60, 61 IOA18, 19 O Address bus 18, 19 output to PROM (IC1102) 62 DVSS — Ground terminal 63 APLLCAP I APLL external capacitance connection 64 APLLVSS — Ground terminal 65 VDD3 — Power supply (+3.3V from IC1105) 66 I OWR O WE signal output to PROM (IC1102) 67 A16 O Address bus 16 output to PROM (IC1102) 68 to 72 HIGHA 7 to 3 O Address bus 15 to 11 output to PROM (IC1102) 73 DVDD3 — Power supply (SW+3.3V) 74, 75 HIGHA 2, 1 O Address bus 10, 9 output to PROM (IC1102) 76 IOA20 O Address bus 20 output to PROM (IC1102) 77 IOCS O CE signal output to PROM (IC1102) 78 IOA1 O Address bus 1 output to PROM (IC1102) 79 IOOE O OE signal output to PROM (IC1102) 80 DVDD3 — Power supply (SW+3.3V) 81 to 84 AD 0 to 3 I Data bus 0 to 3 input from PROM (IC1102) 85 DVSS — Ground terminal 86 to 88 AD 4 to 6 I Data bus 4 to 6 input from PROM (IC1102) 89 IOA21 O Address bus 21 output to PROM (IC1102) 90 ALE O Address latch enable (not used) 91 AD7 I Data bus 7 input from PROM (IC1102) 92 A17 O Address bus 17 output to PROM (IC1102) 93 IOA0 O Address bus 0 output to PROM (IC1102) 94 DVSS — Ground terminal 95 UWA I System controller write strobe (not used) 96 URD I System controller read strobe (not used) 97 DVDD18 — Power supply (+1.8V from IC1109) 98 IFSDO I DVD SOD signal input from system controller (IC501) 99 IFCK O DVD SCO signal output to system controller (IC501) 100 XIFCS I DVD XIFCS signal input from system controller (IC501) 101 IFSDI I VIFBUSY signal input from system controller (IC501) 102 SCL O SCL signal output to EEPROM (IC1103) 103 SDA O SDA signal output to EEPROM (IC1103) 104 TRG-SW O RS232 RXD signal output (not used) 105 IFBSY I RS232 TXD signal input from system controller (IC501) 106 RXD I RD232 RXD clock 107 TXD I RD232 TXD data 108 DVDD3 — Power supply (SW+3.3V) 109 ICE I ICE mode enable (not used) 110 PRST I MTRST signal input from system controller (IC501) 111 IR I IR control signal input (not used) 112 INT0 I External interrupt0 (not used) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 60 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 113 DQMO O DQM0 signal output to SD-RAM (IC1104) 114 MREQ I DQM signal input (not used) 115 RD7 I Data bus 7 from SD-RAM (IC1104) 116 DVSS — Ground terminal 117, 118 RD 6, 5 I Data bus 6, 5 from SD-RAM (IC1104) 119 DVSS — Ground terminal 120, 121 RD 4, 3 I Data bus 4, 3 from SD-RAM (IC1104) 122 DVDD18 — Power supply (+1.8V from IC1109) 123 to 125 RD 2 to 0 I Data bus 2 to 0 from SD-RAM (IC1104) 126 RD15 I Data bus 15 from SD-RAM (IC1104) 127 DVDD3 — Power supply (SW+3.3V) 128 RD 14 I Data bus 14 from SD-RAM (IC1104) 129 to 133 RD 13 to 9 I Data bus 13 to 9 from SD-RAM (IC1104) 134 DVSS — Ground terminal 135 RD8 I Data bus 8 from SD-RAM (IC1104) 136 GPI0 — Not used 137 DQM1 O DQM1 signal output to SD-RAM (IC1104) 138 RWE O WE signal output to SD-RAM (IC1104) 139 CAS O CAS signal output to SD-RAM (IC1104) 140 RAS O RAS signal output to SD-RAM (IC1104) 141 DVDD3 — Power supply (SW+3.3V) 142 RCS O RCS signal output to SD-RAM (IC1104) 143 BA0 O BAO signal output to SD-RAM (IC1104) 144 DVSS — Ground terminal 145 BA1 O BA1 signal output to SD-RAM (IC1104) 146 RA10 O Address bus 10 output to SD-RAM (IC1104) 147 RA0 O Address bus 0 output to SD-RAM (IC1104) 148 DVSS — Ground terminal 149 to 151 RA 1 to 3 O Address bus 1 to 3 output to SD-RAM (IC1104) 152 DVDD18 — Power supply (+1.8V from IC1109) 153 NC — Reference voltage 154 NC — Dram clock 155 DVDD3 — Power supply (SW+3.3V) 156 RCLK O CLK signal output to SD-RAM (IC1104) 157 CKE O CKE signal output to SD-RAM (IC1104) 158 to 160 RA 11 to 8 O Address bus 11 to 8 output to SD-RAM (IC1104) 161 DVSS — Ground terminal 162 RA7 O Address bus 7 output to SD-RAM (IC1104) 163 DVSS — Ground terminal 164 to 166 RA 6 to 4 O Address bus 6 to 4 output to SD-RAM (IC1104) 167 DVDD3 — Power supply (SW+3.3V) 168 DISC/X — Not used 169 RGB O RGB control signal output 170 TSD_M O TSD signal output to IC1201 171 NC — Not used 172 NC — Not used 173 DVDD18 — Power supply (+1.8V) 174 FWD O FWD signal output to IC1201 175 NC — Not used www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 61 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 176 LIMSW O LIMSW signal output to optical pick-up 177 OCSW I SEN signal input from system controller (IC501)/OCSW signal input 178 REW — REW signal output to IC1201 179 CKSW I CKSW signal input 180 NC — Not used 181 NC — Not used 182 DVDD3 — Power supply (SW+3.3V) 183 NC — Not used 184 NC — Not used 185 NC — Not used 186 NC — Not used 187 NC — Not used 188 NC — Not used 189 DAVCC — Power supply (+3.3V from IC1105) 190 VREF I Bandgap reference voltage (not used) 191 FS O Full scale adjustment (pull down) 192 YUV0 — Not used 193 DAVSS — Ground terminal 194 YUV1 O Y signal output to VIDEO AMP (IC201) 195 DAVDD — Power supply (+3.3V from IC1105) 196 YUV2 O CHROMA signal output to VIDEO AMP (IC201) 197 DAVSS — Ground terminal 198 YUV3 O VIDEO signal output to VIDEO AMP (IC201) 199 DAVDD — Power supply (+3.3V from IC1105) 200 YUV4 O G signal output to VIDEO AMP (IC201) 201 DAVSS — Ground terminal 202 YUV5 O B signal output to VIDEO AMP (IC201) 203 YUV6 O R signal output to VIDEO AMP (IC201) 204 DVDD3 — Power supply (SW+3.3V) 205 MIC/VSYNC I MIC_DET signal to IC501 206 VOICE/YUV7 — Not used 207 KRMOD/HSYNC O KARAOKE MODE signal to IC501 208 SMSCK — Not used 209 SPDATA/SMSDI I Audio data of SPDIF input 210 MUTE O MUTE signal to IC1201 211 MUTE123 O MUTE123 signal to IC1201 212 DVDD3 — Power supply (SW+3.3V) 213 ALRCK I Audio left/right channel clock 214 ABCK O Audio bit clock 215 ACLK I Audio DAC master clock 216 DVSS — Ground terminal 217 ASDATA0 O Audio serial data 0 218 ASDATA1 O Audio serial data 1 219 ASDATA2 O Audio serial data 2 220 XRST — Not used 221 DVDD18 — Power supply (+1.8V) 222 ASDATA4 O Audio serial data (not used) 223 DVSS — Ground terminal 224 DWIDE — To pin 209 of IC1101 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 62 HCD-DZ520K/DZ620K Pin No. Pin Name I/O Description 225 SDPIF — SPDIF output (not used) 226 RFGND18 — Ground terminal 227 RFVDD18 — Power supply (RF+1.8V) 228 XTALO O Oscillator output signal (27MHz) 229 XTALI I Oscillator input signal (27MHz) 230 JITFO O RF jitter meter output 231 JITFN I Negative input of operation amplifier for RF jigger meter 232 PLLVSS — Ground terminal 233 IDAC — Not used 234 PLLVDD3 — Power supply (RF+3.3V) 235 LPFON O Negative output of loop filter amplifier 236 LPFIP I Positive input of loop filter amplifier 237 LPFIN I Negative input of loop filter amplifier 238 LPFOP O Positive output of loop filter amplifier 239 VDD3 I Power supply (RF+3.3V) 240 NC I Not used 241 VSS — Ground terminal 242 NC — Not used 243 NC — Not used 244 RFVDD3 — Power supply (RF+3.3V) 245 RFRPDC I RFRP signal input 246 RFRPAC I RFRP signal input 247 HRFZC I High frequency RF ripple zero crossing 248 CRTPLP O Defect level filter capacitor connecting 249 RFGND — Ground terminal 250 NC — Not used 251 NC — Not used 252 OSP O RF offset cancellation capacitor connecting 253 OSN I RF offset cancellation capacitor connecting 254 RFGC O RF offset loop capacitor connecting for DVD-ROM 255 IREF I Current reference input (not used) 256 AVDD3 — Power supply (RF+3.3V) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 63 HCD-DZ520K/DZ620K SECTION 7 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Abbreviation E3 : 240V AC area in E model RU : Russian model SP : Singapore model Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 7-1. OVERALL SECTION 1 2-652-972-01 PANEL, LOADING 2 4-232-478-41 FOOT 3 1-693-701-11 TUNER (FM/AM) (TM10SKR) (RU) 3 1-693-702-11 TUNER (FM/AM) (TM10SE) (E3, SP) 4 A-1146-023-A IO-S TERMINAL BOARD, COMPLETE 5 3-077-331-21 +BV3 (3-CR) 6 3-363-099-51 SCREW (CASE 3 TP2) 7 2-653-932-01 CASE 8 1-828-953-11 WIRE (FLAT TYPE)(9 CORE) #1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 #3 7-685-871-01 SCREW +BVTT 3X6 (S) not supplied not supplied #1 #1 #3 front panel section b b a a 6 7 6 1 3 2 5 #1 5 4 chassis section 8 2 not supplied Note: If the wire (flat type) was replaced, fold it some as the wire (flat type) before replacement. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 64 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 2-652-983-01 KNOB (VOL) 52 2-652-982-01 RING (VOL) 53 2-652-981-01 ORNAMENT (RIGHT) 54 2-652-980-01 ORNAMENT (PLAY) 55 2-652-984-01 WINDOW, INDICATION 56 2-652-979-01 ORNAMENT (POWER) 57 2-661-952-01 SHEET (WINDOW), ADHESIVE 58 3-943-995-31 EMBLEM (NO.5), SONY 59 2-652-977-01 BUTTON BASE (POWER) 60 2-652-971-72 PANEL, FRONT (DZ520K) 60 2-661-871-21 PANEL, FRONT (SB)(DZ620K) 61 3-087-053-01 +BVTP2.6 (3CR) 62 2-652-978-01 BUTTON BASE (PLAY) 63 A-1144-961-A JACK BOARD, COMPLETE 64 A-1144-960-A FL BOARD, COMPLETE 65 1-828-384-11 WIRE (FLAT TYPE)(23 CORE) 66 1-828-325-11 WIRE (FLAT TYPE)(13 CORE) 67 2-652-973-01 CAP (POWER) 68 2-652-974-01 CAP (PLAY) 69 2-652-975-01 CAP (FUNC) 70 2-652-976-01 CAP (AMS) 71 3-531-576-01 RIVET 7-2. FRONT PANEL SECTION 61 61 61 64 61 63 51 54 55 52 53 60 not supplied not supplied including S800 56 57 59 67 58 not supplied 61 61 66 65 not supplied 71 68 69 70 62 Note: If the wire (flat type) was replaced, fold it some as the wire (flat type) before replacement. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 65 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 3-077-331-21 +BV3 (3-CR) ✩ 102 A-1144-746-A MAIN BOARD, COMPLETE (DZ520K:SP) ✩ 102 A-1144-759-A MAIN BOARD, COMPLETE (DZ520K:RU) ✩ 102 A-1159-377-A MAIN BOARD, COMPLETE (DZ520K:E3) ✩ 102 A-1183-326-A MAIN BOARD, COMPLETE (DZ620K) 103 3-077-331-01 +BV3 (3-CR) 104 1-787-331-11 FAN, D.C. 0106 1-777-071-22 CORD, POWER (E3) 0106 1-830-188-11 CORD, POWER (RU, SP) 107 3-703-244-00 BUSHING (2104), CORD 108 3-077-331-11 +BV3 (3-CR) 109 A-1144-950-A POWER BOARD, COMPLETE (RU) 109 A-1178-430-A POWER BOARD, COMPLETE (E3, SP) 110 1-828-292-11 WIRE (FLAT TYPE)(5 CORE) 111 1-828-332-11 WIRE (FLAT TYPE)(13 CORE) 112 1-828-300-11 WIRE (FLAT TYPE)(7 CORE) 113 1-828-330-11 WIRE (FLAT TYPE)(13 CORE) 114 2-597-972-01 SHEET, RADITION (DZ620K) 114 2-597-972-21 SHEET, RADITION (DZ520K) 115 2-597-972-11 SHEET, RADITION 0F901 1-532-325-00 FUSE, TIME-LAG (T6.3AL/250V) #1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3 #2 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3 #4 7-685-881-09 SCREW +BVTT 4X8 (S) 7-3. CHASSIS SECTION 101 114 115 102 104 103 109 101 101 101 107 106 101 101 101 not supplied not supplied not supplied not supplied not supplied not supplied F901 not supplied not supplied not supplied not supplied #1 #1 #1 #4 not supplied DVD mechanism deck section (CDM85-DVBU102) #2 101 not supplied 111 108 112 113 110 ✩ New part of EEP ROM (IC1103) on the MAIN board cannot be used. Therefore, if the mounted MAIN board (A-1144-746-A, etc.) is replaced, exchange new EEP ROM (IC1103) with that used before the replacement. Note: If the wire (flat type) was replaced, fold it some as the wire (flat type) before replacement. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 66 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 7-4. DVD MECHANISM DECK SECTION (CDM85-DVBU102) not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied 501 504 502 503 505 505 505 505 506 507 508 506 506 506 Note: If the wire (flat type) was replaced, fold it some as the wire (flat type) before replacement. 501 A-6071-669-A LOADING ASSY (J) 502 3-088-371-01 BELT 503 4-974-725-11 SCREW (M1.7X2.5), P 504 4-674-137-11 SCREW (PTP2X5) 505 2-634-618-01 INSULATOR 506 3-087-599-01 INSULATOR SCREW 0507 8-820-290-02 OPTICAL PICK-UP KHM-310CAA/C2RP 508 1-828-773-51 WIRE (FLAT TYPE)(24 CORE) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 67 HCD-DZ520K/DZ620K SECTION 8 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS uF: µF • COILS uH: µH • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. ., uPA. . : µPA. ., uPB. . : µPB. ., uPC. . : µPC. ., uPD. . : µPD. . Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark When indicating parts by reference number, please include the board name. DDCON BOARD *********** < CAPACITOR > C800 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C801 1-163-037-11 CERAMIC CHIP 0.022uF 10% 50V C802 1-119-772-91 ELECT 47uF 20% 35V C803 1-124-584-00 ELECT 100uF 20% 10V C804 1-162-974-11 CERAMIC CHIP 0.01uF 50V C805 1-164-360-11 CERAMIC CHIP 0.1uF 16V < DIODE > D801 8-719-988-61 DIODE 1SS355TE-17 D802 8-719-988-61 DIODE 1SS355TE-17 D803 8-719-069-56 DIODE UDZSTE-176.2B D804 8-719-988-61 DIODE 1SS355TE-17 D805 8-719-988-61 DIODE 1SS355TE-17 < COIL > L801 1-410-671-31 INDUCTOR 47uH L802 1-410-671-31 INDUCTOR 47uH < TRANSISTOR > Q801 6-550-065-01 TRANSISTOR CPH5504-TL-E < RESISTOR > R801 1-216-839-11 METAL CHIP 33K 5% 1/10W R802 1-216-809-11 METAL CHIP 100 5% 1/10W R804 1-216-828-11 METAL CHIP 3.9K 5% 1/10W R805 1-216-295-91 SHORT CHIP 0 < TRANSFORMER > T801 1-443-645-11 TRANSFORMER, DC CONVERTER ************************************************************* A-1144-960-A FL BOARD, COMPLETE ****************** < CAPACITOR > C435 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C436 1-115-156-11 CERAMIC CHIP 1uF 10V C806 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C807 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C808 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C809 1-126-157-11 ELECT 10uF 20% 16V C810 1-164-360-11 CERAMIC CHIP 0.1uF 16V C811 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C812 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C813 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C814 1-126-157-11 ELECT 10uF 20% 16V C815 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C816 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C817 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C818 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C821 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C822 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C823 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C824 1-162-974-11 CERAMIC CHIP 0.01uF 50V C825 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C826 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C829 1-124-259-11 ELECT 4.7uF 20% 35V C832 1-162-960-11 CERAMIC CHIP 220PF 10% 50V < CONNECTOR > CN801 1-779-560-21 CONNECTOR, FFC (LIF (NON-ZIF)) 23P CN805 1-794-506-51 CONNECTOR, FFC/FPC 13P CN811 1-785-331-11 PIN, CONNECTOR (LIGHT ANGLE) 5P < DIODE > D431 8-719-988-61 DIODE 1SS355TE-17 D432 8-719-988-61 DIODE 1SS355TE-17 < FERRITE BEAD > FB806 1-414-813-11 FERRITE, EMI (SMD) (2012) < FLUORESCENT INDICATOR > FL801 1-519-852-11 FLUORESCENT INDICATOR < IC > IC801 6-600-349-21 IC NJL23H400A IC802 8-759-643-83 IC PT6315 < TRANSISTOR > Q802 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF < RESISTOR > R436 1-216-834-11 METAL CHIP 12K 5% 1/10W R437 1-216-835-11 METAL CHIP 15K 5% 1/10W R800 1-216-821-11 METAL CHIP 1K 5% 1/10W DDCON FL The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • Abbreviation E3 : 240V AC area in E model RU : Russian model SP : Singapore model www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 68 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R811 1-216-844-11 METAL CHIP 82K 5% 1/10W R812 1-216-845-11 METAL CHIP 100K 5% 1/10W R813 1-216-845-11 METAL CHIP 100K 5% 1/10W R814 1-216-809-11 METAL CHIP 100 5% 1/10W R815 1-216-809-11 METAL CHIP 100 5% 1/10W R816 1-216-809-11 METAL CHIP 100 5% 1/10W R817 1-216-821-11 METAL CHIP 1K 5% 1/10W R819 1-216-805-11 METAL CHIP 47 5% 1/10W R820 1-216-845-11 METAL CHIP 100K 5% 1/10W R823 1-216-864-11 SHORT CHIP 0 ************************************************************* A-1146-023-A IO-S TERMINAL BOARD ******************* < CAPACITOR > C201 1-164-156-11 CERAMIC CHIP 0.1uF 25V C202 1-126-925-91 ELECT 470uF 20% 10V C203 1-126-933-11 ELECT 100uF 20% 16V C204 1-164-156-11 CERAMIC CHIP 0.1uF 25V C205 1-164-156-11 CERAMIC CHIP 0.1uF 25V C206 1-126-964-11 ELECT 10uF 20% 50V C207 1-126-964-11 ELECT 10uF 20% 50V C208 1-115-156-11 CERAMIC CHIP 1uF 10V C209 1-115-156-11 CERAMIC CHIP 1uF 10V C210 1-115-156-11 CERAMIC CHIP 1uF 10V C211 1-126-964-11 ELECT 10uF 20% 50V C212 1-164-156-11 CERAMIC CHIP 0.1uF 25V C213 1-126-916-11 ELECT 1000uF 20% 6.3V C214 1-126-916-11 ELECT 1000uF 20% 6.3V C215 1-126-933-11 ELECT 100uF 20% 16V C216 1-126-933-11 ELECT 100uF 20% 16V C221 1-164-156-11 CERAMIC CHIP 0.1uF 25V C222 1-126-933-11 ELECT 100uF 20% 16V C224 1-126-964-11 ELECT 10uF 20% 50V C225 1-126-916-11 ELECT 1000uF 20% 6.3V C292 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C302 1-127-573-11 CERAMIC CHIP 1uF 10% 16V C303 1-126-947-11 ELECT 47uF 20% 16V C304 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C305 1-126-933-11 ELECT 100uF 20% 16V C306 1-164-156-11 CERAMIC CHIP 0.1uF 25V C310 1-104-662-91 ELECT 22uF 20% 25V C311 1-104-662-91 ELECT 22uF 20% 25V C320 1-104-662-91 ELECT 22uF 20% 25V C321 1-104-662-91 ELECT 22uF 20% 25V C331 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C332 1-104-662-91 ELECT 22uF 20% 25V C341 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C342 1-104-662-91 ELECT 22uF 20% 25V C351 1-104-662-91 ELECT 22uF 20% 25V C352 1-104-662-91 ELECT 22uF 20% 25V C354 1-126-960-11 ELECT 1uF 20% 50V C355 1-126-933-11 ELECT 100uF 20% 16V C356 1-164-156-11 CERAMIC CHIP 0.1uF 25V C358 1-126-933-11 ELECT 100uF 20% 16V C359 1-164-156-11 CERAMIC CHIP 0.1uF 25V C361 1-104-662-91 ELECT 22uF 20% 25V C362 1-104-662-91 ELECT 22uF 20% 25V C364 1-126-960-11 ELECT 1uF 20% 50V C365 1-104-662-91 ELECT 22uF 20% 25V C366 1-164-156-11 CERAMIC CHIP 0.1uF 25V C371 1-126-957-11 ELECT 0.22uF 20% 50V C372 1-126-960-11 ELECT 1uF 20% 50V C374 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C375 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C376 1-104-662-91 ELECT 22uF 20% 25V C377 1-126-933-11 ELECT 100uF 20% 16V C378 1-164-156-11 CERAMIC CHIP 0.1uF 25V C379 1-126-933-11 ELECT 100uF 20% 16V C380 1-164-156-11 CERAMIC CHIP 0.1uF 25V C381 1-126-957-11 ELECT 0.22uF 20% 50V C382 1-126-960-11 ELECT 1uF 20% 50V C387 1-164-156-11 CERAMIC CHIP 0.1uF 25V C388 1-126-933-11 ELECT 100uF 20% 16V C389 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C390 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C391 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C394 1-162-927-11 CERAMIC CHIP 100PF 5% 50V < CONNECTOR > CN201 1-779-550-21 CONNECTOR, FFC (LIF (NON-ZIF)) 13P CN302 1-785-318-11 PIN, CONNECTOR (STRAIGHT) 6P CN303 1-568-828-11 CONNECTOR, FFC 9P CN304 1-779-544-21 CONNECTOR, FFC (LIF (NON-ZIF)) 7P < DIODE > D280 8-719-988-61 DIODE 1SS355TE-17 D300 8-719-058-24 DIODE RB501V-40TE-17 D310 8-719-069-54 DIODE UDZSTE-175.1B < IC > IC201 6-705-602-01 IC MM1623BFBE IC202 6-703-622-01 IC MM1508XNRE IC300 6-703-550-01 IC TA7809LS IC350 8-759-385-76 IC MC14052 BDR2 IC360 8-759-100-96 IC NJM4558M-TE2 IC371 6-706-078-01 IC M62429FP-TP IC372 8-759-100-96 IC NJM4558M-TE2 < JACK > J201 1-780-211-11 TERMINAL BOARD (S TERMINAL+1P)(VIDEO) (S VIDEO (DVD ONLY))(MONITOR OUT) J203 1-819-063-11 JACK, PIN (6P)(Y, PB/CR, PR/CR)(TV/VCR) (R, L, VIDEO IN)(COMPONENT VIDEO OUT) < COIL > L201 1-469-525-91 INDUCTOR 10uH L221 1-469-525-91 INDUCTOR 10uH L300 1-469-525-91 INDUCTOR 10uH L350 1-469-525-91 INDUCTOR 10uH L371 1-469-525-91 INDUCTOR 10uH < TRANSISTOR > Q300 8-729-027-23 TRANSISTOR RT1P141C-TP-1 Q310 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF IO-S TERMINAL FL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 69 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q320 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF Q391 8-729-027-52 TRANSISTOR RT1N241C-TP-1 Q393 8-729-027-52 TRANSISTOR RT1N241C-TP-1 Q395 8-729-027-52 TRANSISTOR RT1N241C-TP-1 Q396 8-729-027-52 TRANSISTOR RT1N241C-TP-1 < RESISTOR > R210 1-218-285-11 METAL CHIP 75 5% 1/10W R211 1-218-285-11 METAL CHIP 75 5% 1/10W R212 1-218-285-11 METAL CHIP 75 5% 1/10W R213 1-218-285-11 METAL CHIP 75 5% 1/10W R214 1-218-285-11 METAL CHIP 75 5% 1/10W R215 1-218-285-11 METAL CHIP 75 5% 1/10W R216 1-218-285-11 METAL CHIP 75 5% 1/10W R217 1-216-833-11 METAL CHIP 10K 5% 1/10W R224 1-218-285-11 METAL CHIP 75 5% 1/10W R225 1-218-285-11 METAL CHIP 75 5% 1/10W R227 1-218-827-11 METAL CHIP 150 0.5% 1/10W R228 1-218-827-11 METAL CHIP 150 0.5% 1/10W R229 1-218-827-11 METAL CHIP 150 0.5% 1/10W R230 1-218-827-11 METAL CHIP 150 0.5% 1/10W R231 1-218-827-11 METAL CHIP 150 0.5% 1/10W R232 1-218-827-11 METAL CHIP 150 0.5% 1/10W R286 1-216-821-11 METAL CHIP 1K 5% 1/10W R301 1-216-821-11 METAL CHIP 1K 5% 1/10W R302 1-216-821-11 METAL CHIP 1K 5% 1/10W R310 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R311 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R312 1-216-833-11 METAL CHIP 10K 5% 1/10W R313 1-216-841-11 METAL CHIP 47K 5% 1/10W R314 1-216-841-11 METAL CHIP 47K 5% 1/10W R320 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R321 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R322 1-216-833-11 METAL CHIP 10K 5% 1/10W R323 1-216-841-11 METAL CHIP 47K 5% 1/10W R324 1-216-841-11 METAL CHIP 47K 5% 1/10W R331 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R332 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R335 1-216-841-11 METAL CHIP 47K 5% 1/10W R336 1-216-841-11 METAL CHIP 47K 5% 1/10W R341 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R342 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R345 1-216-841-11 METAL CHIP 47K 5% 1/10W R346 1-216-841-11 METAL CHIP 47K 5% 1/10W R351 1-216-845-11 METAL CHIP 100K 5% 1/10W R352 1-216-845-11 METAL CHIP 100K 5% 1/10W R353 1-216-841-11 METAL CHIP 47K 5% 1/10W R355 1-216-817-11 METAL CHIP 470 5% 1/10W R356 1-216-833-11 METAL CHIP 10K 5% 1/10W R357 1-216-821-11 METAL CHIP 1K 5% 1/10W R358 1-216-833-11 METAL CHIP 10K 5% 1/10W R359 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R360 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R361 1-216-845-11 METAL CHIP 100K 5% 1/10W R362 1-216-845-11 METAL CHIP 100K 5% 1/10W R363 1-216-841-11 METAL CHIP 47K 5% 1/10W R365 1-216-817-11 METAL CHIP 470 5% 1/10W R370 1-215-865-11 METAL OXIDE 220 5% 1W R372 1-216-837-11 METAL CHIP 22K 5% 1/10W R374 1-216-849-11 METAL CHIP 220K 5% 1/10W R375 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R376 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R377 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R382 1-216-837-11 METAL CHIP 22K 5% 1/10W R387 1-216-832-11 METAL CHIP 8.2K 5% 1/10W R388 1-216-833-11 METAL CHIP 10K 5% 1/10W R389 1-216-833-11 METAL CHIP 10K 5% 1/10W R390 1-216-833-11 METAL CHIP 10K 5% 1/10W R391 1-216-833-11 METAL CHIP 10K 5% 1/10W R393 1-216-809-11 METAL CHIP 100 5% 1/10W R394 1-216-833-11 METAL CHIP 10K 5% 1/10W R396 1-216-809-11 METAL CHIP 100 5% 1/10W R399 1-216-821-11 METAL CHIP 1K 5% 1/10W ************************************************************* A-1144-961-A JACK BOARD, COMPLETE ********************* < CAPACITOR > C401 1-124-589-11 ELECT 47uF 20% 16V C403 1-124-584-00 ELECT 100uF 20% 10V C404 1-164-156-11 CERAMIC CHIP 0.1uF 25V C405 1-164-156-11 CERAMIC CHIP 0.1uF 25V C406 1-127-760-11 CERAMIC CHIP 4.7uF 10% 6.3V C410 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C411 1-126-157-11 ELECT 10uF 20% 16V C412 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C413 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C420 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C421 1-126-157-11 ELECT 10uF 20% 16V C422 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C423 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C431 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C432 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C433 1-162-925-11 CERAMIC CHIP 68PF 5% 50V C434 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C440 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C441 1-126-157-11 ELECT 10uF 20% 16V C442 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C443 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C444 1-126-157-11 ELECT 10uF 20% 16V C471 1-124-222-91 ELECT 22uF 20% 6.3V C473 1-162-995-11 CERAMIC CHIP 0.022uF 50V C490 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V C493 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V C819 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C820 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V < CONNECTOR > CNP802 1-779-550-21 CONNECTOR, FFC (LIF (NON-ZIF)) 13P < DIODE > D433 8-719-988-61 DIODE 1SS355TE-17 D470 8-719-988-61 DIODE 1SS355TE-17 D496 6-501-193-01 DIODE 1SS355WTE-17 JACK IO-S TERMINAL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 70 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D497 6-501-193-01 DIODE 1SS355WTE-17 < FERRITE BEAD > FB410 1-469-144-21 FERRITE, EMI (SMD) (2012) FB420 1-469-144-21 FERRITE, EMI (SMD) (2012) FB470 1-469-144-21 FERRITE, EMI (SMD) (2012) FB471 1-469-144-21 FERRITE, EMI (SMD) (2012) FB472 1-469-144-21 FERRITE, EMI (SMD) (2012) FB474 1-469-144-21 FERRITE, EMI (SMD) (2012) FB475 1-469-144-21 FERRITE, EMI (SMD) (2012) FB476 1-469-144-21 FERRITE, EMI (SMD) (2012) < IC > IC401 8-759-100-96 IC NJM4558M-TE2 IC402 8-759-100-96 IC NJM4558M-TE2 < JACK > J401 1-819-878-11 JACK (AUDIO IN/MIC 1/A.CAL MIC) J402 1-819-878-11 JACK (MIC 2) < SHORT > JR811 1-216-864-11 SHORT CHIP 0 JR813 1-216-864-11 SHORT CHIP 0 JR814 1-216-864-11 SHORT CHIP 0 JR815 1-216-864-11 SHORT CHIP 0 JR816 1-216-864-11 SHORT CHIP 0 JR817 1-216-864-11 SHORT CHIP 0 JR901 1-216-864-11 SHORT CHIP 0 JR902 1-216-864-11 SHORT CHIP 0 JR903 1-216-864-11 SHORT CHIP 0 JR904 1-216-864-11 SHORT CHIP 0 JR905 1-216-864-11 SHORT CHIP 0 JR907 1-216-864-11 SHORT CHIP 0 JR908 1-216-864-11 SHORT CHIP 0 < TRANSISTOR > Q470 1-801-806-11 TRANSISTOR RT1N441C-TP-1 Q471 8-729-027-23 TRANSISTOR RT1P141C-TP-1 Q472 8-729-048-50 TRANSISTOR 2SK3018-T106 Q473 8-729-027-23 TRANSISTOR RT1P141C-TP-1 Q474 8-729-027-24 TRANSISTOR RT1P140C-TP-1 Q475 1-801-806-11 TRANSISTOR RT1N441C-TP-1 Q476 8-729-027-44 TRANSISTOR RT1N140C-TP-1 Q477 8-729-027-23 TRANSISTOR RT1P141C-TP-1 Q478 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF < RESISTOR > R401 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R402 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R403 1-216-821-11 METAL CHIP 1K 5% 1/10W R404 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R405 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R410 1-216-845-11 METAL CHIP 100K 5% 1/10W R411 1-216-817-11 METAL CHIP 470 5% 1/10W R412 1-216-837-11 METAL CHIP 22K 5% 1/10W R413 1-216-821-11 METAL CHIP 1K 5% 1/10W R414 1-216-835-11 METAL CHIP 15K 5% 1/10W R415 1-216-821-11 METAL CHIP 1K 5% 1/10W R416 1-216-801-11 METAL CHIP 22 5% 1/10W R420 1-216-845-11 METAL CHIP 100K 5% 1/10W R421 1-216-817-11 METAL CHIP 470 5% 1/10W R422 1-216-837-11 METAL CHIP 22K 5% 1/10W R423 1-216-821-11 METAL CHIP 1K 5% 1/10W R424 1-216-821-11 METAL CHIP 1K 5% 1/10W R431 1-216-864-11 SHORT CHIP 0 R432 1-216-837-11 METAL CHIP 22K 5% 1/10W R433 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R434 1-216-864-11 SHORT CHIP 0 R435 1-216-857-11 METAL CHIP 1M 5% 1/10W R440 1-216-845-11 METAL CHIP 100K 5% 1/10W R441 1-216-817-11 METAL CHIP 470 5% 1/10W R442 1-216-837-11 METAL CHIP 22K 5% 1/10W R443 1-216-821-11 METAL CHIP 1K 5% 1/10W R444 1-216-835-11 METAL CHIP 15K 5% 1/10W R446 1-216-809-11 METAL CHIP 100 5% 1/10W R470 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R471 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R472 1-216-819-11 METAL CHIP 680 5% 1/10W R477 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R478 1-216-813-11 METAL CHIP 220 5% 1/10W R479 1-216-864-11 SHORT CHIP 0 R480 1-216-804-11 METAL CHIP 39 5% 1/10W R481 1-216-845-11 METAL CHIP 100K 5% 1/10W R482 1-216-833-11 METAL CHIP 10K 5% 1/10W R487 1-216-864-11 SHORT CHIP 0 R488 1-216-845-11 METAL CHIP 100K 5% 1/10W R490 1-216-864-11 SHORT CHIP 0 R492 1-216-864-11 SHORT CHIP 0 R494 1-216-864-11 SHORT CHIP 0 R496 1-216-833-11 METAL CHIP 10K 5% 1/10W R821 1-216-864-11 SHORT CHIP 0 R822 1-216-864-11 SHORT CHIP 0 R851 1-216-821-11 METAL CHIP 1K 5% 1/10W R852 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R853 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R854 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R855 1-216-821-11 METAL CHIP 1K 5% 1/10W R856 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R857 1-216-825-11 METAL CHIP 2.2K 5% 1/10W < SWITCH > S800 1-418-725-51 ENCODER, ROTARY (12 TYPE) (VOLUME – +) S802 1-762-875-21 SWITCH, KEYBOARD (FUNCTION) S803 1-762-875-21 SWITCH, KEYBOARD (.) S804 1-762-875-21 SWITCH, KEYBOARD (X) S805 1-762-875-21 SWITCH, KEYBOARD (x) S806 1-762-875-21 SWITCH, KEYBOARD (>) S807 1-762-875-21 SWITCH, KEYBOARD (A) S808 1-762-875-21 SWITCH, KEYBOARD (H) ************************************************************ JACK www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 71 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark ✩ A-1144-746-A MAIN BOARD, COMPLETE (DZ520K:SP) ✩ A-1144-759-A MAIN BOARD, COMPLETE (DZ520K:RU) ✩ A-1159-377-A MAIN BOARD, COMPLETE (DZ520K:E3) ✩ A-1183-326-A MAIN BOARD, COMPLETE (DZ620K) ********************* < CAPACITOR > C501 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C503 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C504 1-126-947-11 ELECT 47uF 20% 16V C505 1-126-947-11 ELECT 47uF 20% 16V C506 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C507 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C508 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C509 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C510 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C511 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C512 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C513 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C517 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C525 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C570 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C571 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C572 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C580 1-104-656-11 ELECT 2200uF 20% 6.3V C582 1-104-658-91 ELECT 100uF 20% 10V C583 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V C587 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V C589 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C598 1-127-573-11 CERAMIC CHIP 1uF 10% 16V C601 1-126-947-11 ELECT 47uF 20% 16V C602 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C603 1-104-658-91 ELECT 100uF 20% 10V C712 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C716 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C762 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C798 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C799 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C855 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C856 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C875 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1102 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1105 1-126-947-11 ELECT 47uF 20% 16V C1106 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1109 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C1110 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1112 1-126-947-11 ELECT 47uF 20% 16V C1113 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1114 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1115 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1116 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1117 1-126-795-11 ELECT 10uF 20% 50V C1118 1-126-795-11 ELECT 10uF 20% 50V C1119 1-126-795-11 ELECT 10uF 20% 50V C1120 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1121 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1122 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1123 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1124 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C1125 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1126 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1127 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1128 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V C1130 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1131 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3V C1132 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1133 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1135 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V C1136 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1137 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1138 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C1139 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C1140 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1144 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1146 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1147 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C1148 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C1149 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1150 1-126-795-11 ELECT 10uF 20% 50V C1151 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V C1152 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C1153 1-162-917-11 CERAMIC CHIP 15PF 5% 50V C1154 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1155 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1156 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1158 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1159 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1160 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1161 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1162 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1163 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1164 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1167 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1170 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1171 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1172 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1173 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1174 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1175 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1176 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1177 1-126-947-11 ELECT 47uF 20% 16V C1178 1-126-786-11 ELECT 47uF 20% 16V C1179 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1180 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1181 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1182 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V C1184 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1186 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V C1187 1-126-786-11 ELECT 47uF 20% 16V C1188 1-128-934-91 CERAMIC CHIP 0.33uF 20% 10V C1190 1-126-947-11 ELECT 47uF 20% 16V C1191 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1192 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1193 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V C1195 1-127-715-91 CERAMIC CHIP 0.22uF 10% 16V MAIN ✩ New part of EEP ROM (IC1103) on the MAIN board cannot be used. Therefore, if the mounted MAIN board (A-1144-746-A, etc.) is replaced, exchange new EEP ROM (IC1103) with that used before the replacement. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 72 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1197 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1199 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C1203 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1205 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C1206 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C1208 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1209 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V C1210 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1211 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16V C1212 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1213 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1214 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C1215 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1217 1-126-947-11 ELECT 47uF 20% 16V C1218 1-126-964-11 ELECT 10uF 20% 50V C1219 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1220 1-126-964-11 ELECT 10uF 20% 50V C1221 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1222 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1223 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C1224 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C1225 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C1226 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C1228 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C2200 1-126-795-11 ELECT 10uF 20% 50V C2201 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C2202 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C2204 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C2205 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C2206 1-216-864-11 SHORT CHIP 0 C2207 1-126-786-11 ELECT 47uF 20% 16V C2208 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C2209 1-126-795-11 ELECT 10uF 20% 50V C2210 1-126-795-11 ELECT 10uF 20% 50V C2211 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C2212 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C2213 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3000 1-125-972-91 ELECT 100uF 20% 16V C3001 1-126-947-11 ELECT 47uF 20% 16V C3002 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V C3011 1-126-947-11 ELECT 47uF 20% 16V C3012 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3013 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3014 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3015 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3016 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3017 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3018 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3019 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3020 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3021 1-126-947-11 ELECT 47uF 20% 16V C3022 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3023 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3024 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3025 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3026 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3027 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3028 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3029 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3030 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3031 1-126-947-11 ELECT 47uF 20% 16V C3032 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3033 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3034 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3035 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3036 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3037 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3038 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3039 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3040 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3051 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V C3052 1-165-908-11 CERAMIC CHIP 1uF 10% 10V C3053 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3054 1-126-933-11 ELECT 100uF 20% 16V C3055 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C3056 1-126-923-91 ELECT 220uF 20% 10V C3057 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C3058 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V C3059 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3060 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C3067 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C3068 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C3069 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C3070 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3071 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3072 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C3073 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C3075 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C3091 1-126-934-11 ELECT 220uF 20% 16V C3100 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3103 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3104 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3105 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3106 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3107 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3108 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3109 1-112-246-11 ELECT 100uF 20% 35V C3112 1-112-246-11 ELECT 100uF 20% 35V C3113 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3114 1-136-177-00 FILM 1uF 5% 50V C3115 1-136-177-00 FILM 1uF 5% 50V C3116 1-112-831-11 ELECT 2200uF 20% 35V C3117 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3118 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3119 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3120 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3121 1-164-505-11 CERAMIC CHIP 2.2uF 16V C3122 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3123 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3150 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3153 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3154 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3155 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3156 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3157 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 73 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3158 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3159 1-112-246-11 ELECT 100uF 20% 35V C3162 1-112-246-11 ELECT 100uF 20% 35V C3163 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3164 1-136-177-00 FILM 1uF 5% 50V C3165 1-136-177-00 FILM 1uF 5% 50V C3166 1-112-831-11 ELECT 2200uF 20% 35V C3167 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3168 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3169 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3170 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3171 1-164-505-11 CERAMIC CHIP 2.2uF 16V C3172 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3173 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3200 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3203 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3204 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3205 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3206 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3207 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3208 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3209 1-112-246-11 ELECT 100uF 20% 35V C3212 1-112-246-11 ELECT 100uF 20% 35V C3213 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3214 1-136-177-00 FILM 1uF 5% 50V C3215 1-136-177-00 FILM 1uF 5% 50V C3216 1-112-831-11 ELECT 2200uF 20% 35V C3217 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3218 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3219 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3220 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3221 1-164-505-11 CERAMIC CHIP 2.2uF 16V C3222 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3223 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3250 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3253 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3254 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3255 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3256 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3257 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3258 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3259 1-112-246-11 ELECT 100uF 20% 35V C3262 1-112-246-11 ELECT 100uF 20% 35V C3263 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3264 1-136-177-00 FILM 1uF 5% 50V C3265 1-136-177-00 FILM 1uF 5% 50V C3266 1-112-831-11 ELECT 2200uF 20% 35V C3267 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3268 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3269 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3270 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3271 1-164-505-11 CERAMIC CHIP 2.2uF 16V C3272 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3273 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3300 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3303 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3304 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3305 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3306 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3307 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3308 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3309 1-112-246-11 ELECT 100uF 20% 35V C3312 1-112-246-11 ELECT 100uF 20% 35V C3313 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3314 1-136-177-00 FILM 1uF 5% 50V C3315 1-136-177-00 FILM 1uF 5% 50V C3316 1-112-831-11 ELECT 2200uF 20% 35V C3317 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3318 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3319 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3320 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3321 1-164-505-11 CERAMIC CHIP 2.2uF 16V C3322 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3323 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3400 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3403 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3404 1-164-156-11 CERAMIC CHIP 0.1uF 25V C3405 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V C3406 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3407 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V C3408 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3409 1-112-246-11 ELECT 100uF 20% 35V C3412 1-112-246-11 ELECT 100uF 20% 35V C3413 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V C3414 1-136-177-00 FILM 1uF 5% 50V C3415 1-136-177-00 FILM 1uF 5% 50V C3416 1-112-831-11 ELECT 2200uF 20% 35V C3417 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3418 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3419 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3420 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C3421 1-117-370-11 CERAMIC CHIP 10uF 10V C3422 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3423 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C3500 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V (DZ620K) C3503 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V (DZ620K) C3504 1-164-156-11 CERAMIC CHIP 0.1uF 25V (DZ620K) C3505 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16V (DZ620K) C3506 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V (DZ620K) C3507 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V (DZ620K) C3508 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V (DZ620K) C3509 1-112-246-11 ELECT 100uF 20% 35V (DZ620K) C3512 1-112-246-11 ELECT 100uF 20% 35V (DZ620K) C3513 1-104-329-11 CERAMIC CHIP 0.1uF 10% 50V (DZ620K) C3514 1-136-177-00 FILM 1uF 5% 50V (DZ620K) MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 74 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3515 1-136-177-00 FILM 1uF 5% 50V (DZ620K) C3516 1-112-831-11 ELECT 2200uF 20% 35V (DZ620K) C3517 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (DZ620K) C3518 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (DZ620K) C3519 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (DZ620K) C3520 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (DZ620K) C3551 1-126-960-11 ELECT 1uF 20% 50V C3552 1-126-964-11 ELECT 10uF 20% 50V C3555 1-163-038-91 CERAMIC CHIP 0.1uF 25V < CONNECTOR > CN501 1-506-469-11 PIN, CONNECTOR 4P CN507 1-779-281-11 CONNECTOR, FFC (LIF (NON-ZIF)) 13P CN509 1-784-380-51 CONNECTOR, FFC/FPC 23P (DZ620K) CN509 1-793-991-11 CONNECTOR, FFC/FPC 23P (DZ520K) CN510 1-784-368-11 CONNECTOR, FFC/FPC 9P * CN515 1-564-714-11 PIN, CONNECTOR (SMALL TYPE) 12P CN1101 1-815-763-32 CONNECTOR, FFC/FPC 24P * CN1105 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P * CN1201 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P CN1202 1-779-273-11 CONNECTOR, FFC (LIF (NON-ZIF)) 5P CN1301 1-779-281-11 CONNECTOR, FFC (LIF (NON-ZIF)) 13P CN1302 1-779-275-11 CONNECTOR, FFC (LIF (NON-ZIF)) 7P CN3000 1-564-704-41 PIN, CONNECTOR (SMALL TYPE) 2P CN3002 1-785-101-11 PIN, CONNECTOR (3.96mm PITCH) 3P < DIODE > D503 6-501-193-01 DIODE 1SS355WTE-17 D504 6-501-193-01 DIODE 1SS355WTE-17 D505 6-501-193-01 DIODE 1SS355WTE-17 D2001 8-719-058-24 DIODE RB501V-40TE-17 D3071 6-501-193-01 DIODE 1SS355WTE-17 D3072 6-501-193-01 DIODE 1SS355WTE-17 D3073 6-501-193-01 DIODE 1SS355WTE-17 D3111 6-500-885-01 DIODE P6SMBJ33A-5 D3112 6-500-885-01 DIODE P6SMBJ33A-5 D3151 6-500-885-01 DIODE P6SMBJ33A-5 D3152 6-500-885-01 DIODE P6SMBJ33A-5 D3201 6-500-885-01 DIODE P6SMBJ33A-5 D3202 6-500-885-01 DIODE P6SMBJ33A-5 D3251 6-500-885-01 DIODE P6SMBJ33A-5 D3252 6-500-885-01 DIODE P6SMBJ33A-5 D3301 6-500-885-01 DIODE P6SMBJ33A-5 D3302 6-500-885-01 DIODE P6SMBJ33A-5 D3401 6-500-885-01 DIODE P6SMBJ33A-5 D3402 6-500-885-01 DIODE P6SMBJ33A-5 D3501 6-500-885-01 DIODE P6SMBJ33A-5 (DZ620K) D3502 6-500-885-01 DIODE P6SMBJ33A-5 (DZ620K) D3551 6-501-193-01 DIODE 1SS355WTE-17 D3552 6-501-193-01 DIODE 1SS355WTE-17 < GROUND TERMINAL BOAR > EB903 1-537-770-21 TERMINAL BOARD, GROUND EB1001 1-537-770-21 TERMINAL BOARD, GROUND EB1002 1-537-770-21 TERMINAL BOARD, GROUND EB1003 1-537-770-21 TERMINAL BOARD, GROUND EB1004 1-537-770-21 TERMINAL BOARD, GROUND EB3001 1-537-770-21 TERMINAL BOARD, GROUND EB3002 1-537-770-21 TERMINAL BOARD, GROUND EB3003 1-537-770-21 TERMINAL BOARD, GROUND EB3004 1-537-770-21 TERMINAL BOARD, GROUND EB3005 1-537-770-21 TERMINAL BOARD, GROUND < FERRITE BEAD > FB500 1-469-324-21 FERRITE, EMI (SMD) (2012) FB501 1-469-324-21 FERRITE, EMI (SMD) (2012) FB502 1-469-324-21 FERRITE, EMI (SMD) (2012) FB503 1-469-324-21 FERRITE, EMI (SMD) (2012) FB504 1-469-324-21 FERRITE, EMI (SMD) (2012) FB505 1-469-324-21 FERRITE, EMI (SMD) (2012) FB506 1-469-324-21 FERRITE, EMI (SMD) (2012) FB507 1-469-324-21 FERRITE, EMI (SMD) (2012) FB508 1-469-324-21 FERRITE, EMI (SMD) (2012) FB509 1-469-324-21 FERRITE, EMI (SMD) (2012) FB1106 1-414-226-21 INDUCTOR, FERRITE BEAD FB1108 1-414-226-21 INDUCTOR, FERRITE BEAD FB1111 1-414-226-21 INDUCTOR, FERRITE BEAD FB3051 1-216-295-91 SHORT CHIP 0 < FLUORESCENT INDICATOR > FL501 1-234-177-21 FILTER, CHIP EMI FL502 1-234-177-21 FILTER, CHIP EMI FL503 1-233-893-21 FILTER, CHIP EMI FL1101 1-234-177-21 FILTER, CHIP EMI FL1104 1-234-177-21 FILTER, CHIP EMI FL1105 1-234-177-21 FILTER, CHIP EMI FL1106 1-234-177-21 FILTER, CHIP EMI FL1107 1-234-177-21 FILTER, CHIP EMI FL1108 1-234-177-21 FILTER, CHIP EMI < IC > IC501 6-806-589-01 IC M30622MEP-A76FPU0 IC502 6-702-302-01 IC TK11133CSCL-G IC511 6-708-922-01 IC PST3635NR IC516 6-703-547-01 IC TA7805LS IC1101 6-707-535-01 IC CXD9849R IC1102 6-806-328-01 IC MX29LV320CBTC70-OBA2-0601CE(RU, E3) IC1102 6-806-329-01 IC MX29LV320CBTC70-OBA2-0601GA (SP) ✩ IC1103 not supplied IC BR24L64F-WE2 IC1104 6-709-370-01 IC A2V64S40CTP-G75 IC1105 6-702-302-01 IC TK11133CSCL-G IC1107 6-702-302-01 IC TK11133CSCL-G IC1109 6-707-485-01 IC NJM2885DL1-18 (TE2) IC1201 6-704-524-01 IC FAN8036L IC2200 6-707-608-01 IC PCM1803DBR IC3003 8-759-680-48 IC TC7WH157FK (TE85R) IC3010 6-705-979-01 IC CXD9788AR IC3020 6-705-979-01 IC CXD9788AR IC3030 6-705-979-01 IC CXD9788AR MAIN ✩ New part of EEP ROM (IC1103) on the MAIN board cannot be used. Therefore, if the mounted MAIN board (A-1144-746-A, etc.) is replaced, exchange new EEP ROM (IC1103) with that used before the replacement. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 75 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC3050 6-702-300-01 IC TK11118CSCL-G IC3051 8-759-649-50 IC SN74AHC1GU04DCKR IC3100 6-708-921-01 IC CXD9883M IC3150 6-708-921-01 IC CXD9883M IC3200 6-708-921-01 IC CXD9883M IC3250 6-708-921-01 IC CXD9883M IC3300 6-708-921-01 IC CXD9883M IC3400 6-708-921-01 IC CXD9883M IC3500 6-708-921-01 IC CXD9883M (DZ620K) < SHORT > JC505 1-216-864-11 SHORT CHIP 0 (DZ520K) JC507 1-216-864-11 SHORT CHIP 0 (DZ620K) JC511 1-216-864-11 SHORT CHIP 0 (SP) JC512 1-216-864-11 SHORT CHIP 0 (E3) JC520 1-216-864-11 SHORT CHIP 0 (RU) < COIL > L2200 1-414-754-11 INDUCTOR 10uH L2201 1-216-295-91 SHORT CHIP 0 L3000 1-469-527-91 INDUCTOR 47uH L3051 1-414-754-11 INDUCTOR 10uH L3052 1-414-754-11 INDUCTOR 10uH L3053 1-414-754-11 INDUCTOR 10uH L3054 1-412-939-11 INDUCTOR 1uH L3111 1-456-680-11 INDUCTOR 10uH L3112 1-456-680-11 INDUCTOR 10uH L3151 1-456-680-11 INDUCTOR 10uH L3152 1-456-680-11 INDUCTOR 10uH L3201 1-456-680-11 INDUCTOR 10uH L3202 1-456-680-11 INDUCTOR 10uH L3251 1-456-680-11 INDUCTOR 10uH L3252 1-456-680-11 INDUCTOR 10uH L3301 1-456-680-11 INDUCTOR 10uH L3302 1-456-680-11 INDUCTOR 10uH L3401 1-456-680-11 INDUCTOR 10uH L3402 1-456-680-11 INDUCTOR 10uH L3501 1-456-680-11 INDUCTOR 10uH (DZ620K) L3502 1-456-680-11 INDUCTOR 10uH (DZ620K) < TRANSISTOR > Q502 6-550-718-01 TRANSISTOR RSR025N03TL Q506 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF Q1101 6-550-008-01 TRANSISTOR UM6K1N-TN Q1102 6-550-653-01 TRANSISTOR QST8TR Q1103 8-729-027-52 TRANSISTOR RT1N241C-TP-1 Q3000 8-729-142-48 TRANSISTOR 2SD1616-TP-LK Q3001 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF Q3002 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF Q3101 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3102 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3151 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3152 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3201 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3202 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3251 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3252 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3301 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3302 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3401 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3402 8-729-600-22 TRANSISTOR 2SA1235TP-1EF Q3551 8-729-120-28 TRANSISTOR 2SC3052EF-T1-LEF < RESISTOR > R506 1-216-821-11 METAL CHIP 1K 5% 1/10W R507 1-216-841-11 METAL CHIP 47K 5% 1/10W R513 1-216-821-11 METAL CHIP 1K 5% 1/10W R515 1-216-821-11 METAL CHIP 1K 5% 1/10W R519 1-216-809-11 METAL CHIP 100 5% 1/10W R524 1-216-833-11 METAL CHIP 10K 5% 1/10W R535 1-216-821-11 METAL CHIP 1K 5% 1/10W R536 1-216-821-11 METAL CHIP 1K 5% 1/10W R577 1-216-833-11 METAL CHIP 10K 5% 1/10W (DZ520K) R577 1-216-835-11 METAL CHIP 15K 5% 1/10W (DZ620K) R585 1-216-809-11 METAL CHIP 100 5% 1/10W R586 1-216-809-11 METAL CHIP 100 5% 1/10W R587 1-216-809-11 METAL CHIP 100 5% 1/10W R588 1-216-809-11 METAL CHIP 100 5% 1/10W R589 1-216-809-11 METAL CHIP 100 5% 1/10W R590 1-216-809-11 METAL CHIP 100 5% 1/10W R591 1-216-809-11 METAL CHIP 100 5% 1/10W R592 1-216-833-11 METAL CHIP 10K 5% 1/10W R593 1-216-833-11 METAL CHIP 10K 5% 1/10W R594 1-216-809-11 METAL CHIP 100 5% 1/10W R595 1-216-809-11 METAL CHIP 100 5% 1/10W R596 1-216-821-11 METAL CHIP 1K 5% 1/10W (SP) R596 1-216-833-11 METAL CHIP 10K 5% 1/10W (E3) R596 1-216-841-11 METAL CHIP 47K 5% 1/10W (RU) R597 1-216-809-11 METAL CHIP 100 5% 1/10W R598 1-216-809-11 METAL CHIP 100 5% 1/10W R601 1-216-809-11 METAL CHIP 100 5% 1/10W R608 1-216-809-11 METAL CHIP 100 5% 1/10W R612 1-216-833-11 METAL CHIP 10K 5% 1/10W R614 1-216-833-11 METAL CHIP 10K 5% 1/10W R616 1-216-833-11 METAL CHIP 10K 5% 1/10W R620 1-216-809-11 METAL CHIP 100 5% 1/10W R622 1-216-833-11 METAL CHIP 10K 5% 1/10W R624 1-216-833-11 METAL CHIP 10K 5% 1/10W R628 1-216-821-11 METAL CHIP 1K 5% 1/10W R656 1-216-864-11 SHORT CHIP 0 R657 1-216-841-11 METAL CHIP 47K 5% 1/10W R659 1-216-845-11 METAL CHIP 100K 5% 1/10W R662 1-216-841-11 METAL CHIP 47K 5% 1/10W R673 1-216-833-11 METAL CHIP 10K 5% 1/10W R692 1-216-809-11 METAL CHIP 100 5% 1/10W R693 1-216-809-11 METAL CHIP 100 5% 1/10W R702 1-216-833-11 METAL CHIP 10K 5% 1/10W R703 1-216-809-11 METAL CHIP 100 5% 1/10W R704 1-216-809-11 METAL CHIP 100 5% 1/10W R707 1-216-809-11 METAL CHIP 100 5% 1/10W MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 76 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R708 1-216-833-11 METAL CHIP 10K 5% 1/10W R709 1-216-833-11 METAL CHIP 10K 5% 1/10W R710 1-216-809-11 METAL CHIP 100 5% 1/10W R713 1-216-864-11 SHORT CHIP 0 R717 1-216-833-11 METAL CHIP 10K 5% 1/10W R719 1-216-833-11 METAL CHIP 10K 5% 1/10W R720 1-216-833-11 METAL CHIP 10K 5% 1/10W R725 1-216-833-11 METAL CHIP 10K 5% 1/10W R726 1-216-821-11 METAL CHIP 1K 5% 1/10W R727 1-216-833-11 METAL CHIP 10K 5% 1/10W R728 1-216-821-11 METAL CHIP 1K 5% 1/10W R729 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R730 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R733 1-216-833-11 METAL CHIP 10K 5% 1/10W R739 1-216-833-11 METAL CHIP 10K 5% 1/10W R741 1-216-833-11 METAL CHIP 10K 5% 1/10W R742 1-216-833-11 METAL CHIP 10K 5% 1/10W R744 1-216-833-11 METAL CHIP 10K 5% 1/10W R746 1-216-833-11 METAL CHIP 10K 5% 1/10W R755 1-216-821-11 METAL CHIP 1K 5% 1/10W R756 1-216-821-11 METAL CHIP 1K 5% 1/10W R760 1-216-809-11 METAL CHIP 100 5% 1/10W R761 1-216-809-11 METAL CHIP 100 5% 1/10W R762 1-216-809-11 METAL CHIP 100 5% 1/10W R763 1-216-809-11 METAL CHIP 100 5% 1/10W R764 1-216-809-11 METAL CHIP 100 5% 1/10W R765 1-216-809-11 METAL CHIP 100 5% 1/10W R774 1-216-821-11 METAL CHIP 1K 5% 1/10W R775 1-216-841-11 METAL CHIP 47K 5% 1/10W R789 1-216-809-11 METAL CHIP 100 5% 1/10W R790 1-216-809-11 METAL CHIP 100 5% 1/10W R791 1-216-809-11 METAL CHIP 100 5% 1/10W R792 1-216-823-11 METAL CHIP 1.5K 5% 1/10W (RU) R792 1-216-841-11 METAL CHIP 47K 5% 1/10W (E3) R793 1-216-841-11 METAL CHIP 47K 5% 1/10W R1101 1-216-809-11 METAL CHIP 100 5% 1/10W R1105 1-216-833-11 METAL CHIP 10K 5% 1/10W R1106 1-216-833-11 METAL CHIP 10K 5% 1/10W R1107 1-216-833-11 METAL CHIP 10K 5% 1/10W R1108 1-216-857-11 METAL CHIP 1M 5% 1/10W R1109 1-216-864-11 SHORT CHIP 0 R1110 1-216-841-11 METAL CHIP 47K 5% 1/10W R1111 1-216-809-11 METAL CHIP 100 5% 1/10W R1112 1-211-977-11 METAL CHIP 22 0.5% 1/10W R1113 1-211-977-11 METAL CHIP 22 0.5% 1/10W R1114 1-216-845-11 METAL CHIP 100K 5% 1/10W R1115 1-211-977-11 METAL CHIP 22 0.5% 1/10W R1116 1-216-821-11 METAL CHIP 1K 5% 1/10W R1117 1-216-841-11 METAL CHIP 47K 5% 1/10W R1118 1-216-801-11 METAL CHIP 22 5% 1/10W R1120 1-216-801-11 METAL CHIP 22 5% 1/10W R1121 1-216-801-11 METAL CHIP 22 5% 1/10W R1123 1-216-864-11 SHORT CHIP 0 R1124 1-216-841-11 METAL CHIP 47K 5% 1/10W R1126 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R1132 1-216-845-11 METAL CHIP 100K 5% 1/10W R1136 1-216-835-11 METAL CHIP 15K 5% 1/10W R1141 1-218-916-11 METAL CHIP 750K 5% 1/10W R1142 1-216-845-11 METAL CHIP 100K 5% 1/10W R1144 1-216-864-11 SHORT CHIP 0 R1145 1-216-864-11 SHORT CHIP 0 R1146 1-216-805-11 METAL CHIP 47 5% 1/10W R1147 1-216-864-11 SHORT CHIP 0 R1148 1-216-864-11 SHORT CHIP 0 R1151 1-216-833-11 METAL CHIP 10K 5% 1/10W R1152 1-216-864-11 SHORT CHIP 0 R1153 1-216-864-11 SHORT CHIP 0 R1154 1-216-809-11 METAL CHIP 100 5% 1/10W R1155 1-216-809-11 METAL CHIP 100 5% 1/10W R1156 1-216-809-11 METAL CHIP 100 5% 1/10W R1159 1-216-805-11 METAL CHIP 47 5% 1/10W R1160 1-216-864-11 SHORT CHIP 0 R1161 1-216-864-11 SHORT CHIP 0 R1164 1-216-864-11 SHORT CHIP 0 R1166 1-216-809-11 METAL CHIP 100 5% 1/10W R1168 1-216-833-11 METAL CHIP 10K 5% 1/10W R1169 1-216-809-11 METAL CHIP 100 5% 1/10W R1171 1-216-833-11 METAL CHIP 10K 5% 1/10W R1176 1-216-864-11 SHORT CHIP 0 R1180 1-216-805-11 METAL CHIP 47 5% 1/10W R1181 1-216-805-11 METAL CHIP 47 5% 1/10W R1182 1-216-805-11 METAL CHIP 47 5% 1/10W R1191 1-216-821-11 METAL CHIP 1K 5% 1/10W R1193 1-216-821-11 METAL CHIP 1K 5% 1/10W R1204 1-216-822-11 METAL CHIP 1.2K 5% 1/10W R1205 1-216-833-11 METAL CHIP 10K 5% 1/10W R1206 1-216-833-11 METAL CHIP 10K 5% 1/10W R1207 1-216-826-11 METAL CHIP 2.7K 5% 1/10W R1208 1-216-839-11 METAL CHIP 33K 5% 1/10W R1209 1-216-839-11 METAL CHIP 33K 5% 1/10W R1210 1-216-841-11 METAL CHIP 47K 5% 1/10W R1212 1-216-833-11 METAL CHIP 10K 5% 1/10W R1213 1-218-867-11 METAL CHIP 6.8K 5% 1/10W R1214 1-216-835-11 METAL CHIP 15K 5% 1/10W R1215 1-216-834-11 METAL CHIP 12K 5% 1/10W R1216 1-216-834-11 METAL CHIP 12K 5% 1/10W R1219 1-216-838-11 METAL CHIP 27K 5% 1/10W R1220 1-216-833-11 METAL CHIP 10K 5% 1/10W R1221 1-218-889-11 METAL CHIP 56K 0.5% 1/10W R1222 1-216-839-11 METAL CHIP 33K 5% 1/10W R1223 1-218-895-11 METAL CHIP 100K 0.5% 1/10W R1224 1-216-833-11 METAL CHIP 10K 5% 1/10W R1225 1-218-895-11 METAL CHIP 100K 0.5% 1/10W R1226 1-218-889-11 METAL CHIP 56K 0.5% 1/10W R1227 1-216-864-11 SHORT CHIP 0 R1228 1-216-864-11 SHORT CHIP 0 R1230 1-218-893-11 METAL CHIP 82K 0.5% 1/10W R1231 1-218-875-11 METAL CHIP 15K 0.5% 1/10W R1232 1-218-877-11 METAL CHIP 18K 0.5% 1/10W R1233 1-218-883-11 METAL CHIP 33K 0.5% 1/10W R1234 1-216-833-11 METAL CHIP 10K 5% 1/10W R1236 1-216-821-11 METAL CHIP 1K 5% 1/10W R1237 1-216-821-11 METAL CHIP 1K 5% 1/10W R1238 1-216-829-11 METAL CHIP 4.7K 5% 1/10W MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 77 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1239 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R1243 1-216-809-11 METAL CHIP 100 5% 1/10W R1246 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R1247 1-216-821-11 METAL CHIP 1K 5% 1/10W R1255 1-216-864-11 SHORT CHIP 0 R2101 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R2103 1-216-833-11 METAL CHIP 10K 5% 1/10W R2104 1-216-833-11 METAL CHIP 10K 5% 1/10W R2105 1-216-833-11 METAL CHIP 10K 5% 1/10W R2109 1-216-864-11 SHORT CHIP 0 R2110 1-216-826-11 METAL CHIP 2.7K 5% 1/10W R2114 1-216-809-11 METAL CHIP 100 5% 1/10W R2115 1-216-809-11 METAL CHIP 100 5% 1/10W R2120 1-216-864-11 SHORT CHIP 0 R2121 1-216-864-11 SHORT CHIP 0 R2122 1-216-864-11 SHORT CHIP 0 R2123 1-216-864-11 SHORT CHIP 0 R2124 1-216-864-11 SHORT CHIP 0 R2125 1-216-864-11 SHORT CHIP 0 R2126 1-216-833-11 METAL CHIP 10K 5% 1/10W R2129 1-216-845-11 METAL CHIP 100K 5% 1/10W R2133 1-216-864-11 SHORT CHIP 0 R2134 1-216-864-11 SHORT CHIP 0 R2150 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R2151 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R2152 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R2161 1-216-864-11 SHORT CHIP 0 R2168 1-216-815-11 METAL CHIP 330 5% 1/10W R2176 1-216-864-11 SHORT CHIP 0 R2200 1-216-809-11 METAL CHIP 100 5% 1/10W R2202 1-216-817-11 METAL CHIP 470 5% 1/10W R2203 1-216-817-11 METAL CHIP 470 5% 1/10W R2211 1-216-809-11 METAL CHIP 100 5% 1/10W R2212 1-216-809-11 METAL CHIP 100 5% 1/10W R2213 1-216-809-11 METAL CHIP 100 5% 1/10W R2214 1-216-809-11 METAL CHIP 100 5% 1/10W R2306 1-216-864-11 SHORT CHIP 0 R2307 1-216-864-11 SHORT CHIP 0 R2308 1-216-864-11 SHORT CHIP 0 R2309 1-216-864-11 SHORT CHIP 0 R2310 1-216-864-11 SHORT CHIP 0 R2311 1-216-864-11 SHORT CHIP 0 R2314 1-216-864-11 SHORT CHIP 0 R2315 1-216-864-11 SHORT CHIP 0 R2316 1-216-864-11 SHORT CHIP 0 R2317 1-216-864-11 SHORT CHIP 0 R2318 1-216-864-11 SHORT CHIP 0 R2319 1-216-864-11 SHORT CHIP 0 R2506 1-216-864-11 SHORT CHIP 0 R2546 1-216-827-11 METAL CHIP 3.3K 5% 1/10W R2547 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2548 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2549 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2550 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2551 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2553 1-216-864-11 SHORT CHIP 0 R2554 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R3001 1-216-833-11 METAL CHIP 10K 5% 1/10W R3002 1-216-833-11 METAL CHIP 10K 5% 1/10W R3003 1-216-823-11 METAL CHIP 1.5K 5% 1/10W R3004 1-216-822-11 METAL CHIP 1.2K 5% 1/10W R3006 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R3011 1-216-817-11 METAL CHIP 470 5% 1/10W R3012 1-216-817-11 METAL CHIP 470 5% 1/10W R3013 1-216-833-11 METAL CHIP 10K 5% 1/10W R3014 1-216-809-11 METAL CHIP 100 5% 1/10W R3015 1-216-809-11 METAL CHIP 100 5% 1/10W R3017 1-216-809-11 METAL CHIP 100 5% 1/10W R3021 1-216-817-11 METAL CHIP 470 5% 1/10W R3022 1-216-817-11 METAL CHIP 470 5% 1/10W R3023 1-216-809-11 METAL CHIP 100 5% 1/10W R3024 1-216-809-11 METAL CHIP 100 5% 1/10W R3026 1-216-809-11 METAL CHIP 100 5% 1/10W R3031 1-216-817-11 METAL CHIP 470 5% 1/10W R3032 1-216-817-11 METAL CHIP 470 5% 1/10W R3033 1-216-833-11 METAL CHIP 10K 5% 1/10W R3034 1-216-809-11 METAL CHIP 100 5% 1/10W R3035 1-216-809-11 METAL CHIP 100 5% 1/10W R3037 1-216-809-11 METAL CHIP 100 5% 1/10W R3052 1-216-857-11 METAL CHIP 1M 5% 1/10W R3053 1-216-809-11 METAL CHIP 100 5% 1/10W R3054 1-216-801-11 METAL CHIP 22 5% 1/10W R3055 1-216-809-11 METAL CHIP 100 5% 1/10W R3057 1-216-809-11 METAL CHIP 100 5% 1/10W R3059 1-216-833-11 METAL CHIP 10K 5% 1/10W R3060 1-216-833-11 METAL CHIP 10K 5% 1/10W R3061 1-216-864-11 SHORT CHIP 0 R3062 1-216-809-11 METAL CHIP 100 5% 1/10W R3063 1-216-821-11 METAL CHIP 1K 5% 1/10W R3064 1-216-821-11 METAL CHIP 1K 5% 1/10W R3065 1-216-821-11 METAL CHIP 1K 5% 1/10W R3066 1-216-809-11 METAL CHIP 100 5% 1/10W R3067 1-216-809-11 METAL CHIP 100 5% 1/10W R3068 1-216-809-11 METAL CHIP 100 5% 1/10W R3069 1-216-809-11 METAL CHIP 100 5% 1/10W R3070 1-216-809-11 METAL CHIP 100 5% 1/10W R3071 1-216-809-11 METAL CHIP 100 5% 1/10W R3072 1-216-809-11 METAL CHIP 100 5% 1/10W R3073 1-216-809-11 METAL CHIP 100 5% 1/10W R3075 1-216-809-11 METAL CHIP 100 5% 1/10W R3076 1-216-809-11 METAL CHIP 100 5% 1/10W R3077 1-216-809-11 METAL CHIP 100 5% 1/10W R3078 1-216-809-11 METAL CHIP 100 5% 1/10W R3079 1-216-809-11 METAL CHIP 100 5% 1/10W R3080 1-216-845-11 METAL CHIP 100K 5% 1/10W R3097 1-216-809-11 METAL CHIP 100 5% 1/10W R3101 1-216-809-11 METAL CHIP 100 5% 1/10W R3102 1-216-809-11 METAL CHIP 100 5% 1/10W R3103 1-216-797-11 METAL CHIP 10 5% 1/10W R3104 1-216-864-11 SHORT CHIP 0 R3107 1-216-834-11 METAL CHIP 12K 5% 1/10W R3115 1-216-797-11 METAL CHIP 10 5% 1/10W R3116 1-216-797-11 METAL CHIP 10 5% 1/10W R3119 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3120 1-216-136-00 RES-CHIP 2.7 5% 1/8W MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 78 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3121 1-216-833-11 METAL CHIP 10K 5% 1/10W R3122 1-216-833-11 METAL CHIP 10K 5% 1/10W R3123 1-216-833-11 METAL CHIP 10K 5% 1/10W R3124 1-216-833-11 METAL CHIP 10K 5% 1/10W R3125 1-216-845-11 METAL CHIP 100K 5% 1/10W R3126 1-216-845-11 METAL CHIP 100K 5% 1/10W R3127 1-216-845-11 METAL CHIP 100K 5% 1/10W R3151 1-216-809-11 METAL CHIP 100 5% 1/10W R3152 1-216-809-11 METAL CHIP 100 5% 1/10W R3153 1-216-797-11 METAL CHIP 10 5% 1/10W R3154 1-216-864-11 SHORT CHIP 0 R3157 1-216-834-11 METAL CHIP 12K 5% 1/10W R3165 1-216-797-11 METAL CHIP 10 5% 1/10W R3166 1-216-797-11 METAL CHIP 10 5% 1/10W R3169 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3170 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3171 1-216-833-11 METAL CHIP 10K 5% 1/10W R3172 1-216-833-11 METAL CHIP 10K 5% 1/10W R3173 1-216-833-11 METAL CHIP 10K 5% 1/10W R3174 1-216-833-11 METAL CHIP 10K 5% 1/10W R3175 1-216-845-11 METAL CHIP 100K 5% 1/10W R3176 1-216-845-11 METAL CHIP 100K 5% 1/10W R3177 1-216-845-11 METAL CHIP 100K 5% 1/10W R3201 1-216-809-11 METAL CHIP 100 5% 1/10W R3202 1-216-809-11 METAL CHIP 100 5% 1/10W R3203 1-216-797-11 METAL CHIP 10 5% 1/10W R3204 1-216-864-11 SHORT CHIP 0 R3207 1-216-834-11 METAL CHIP 12K 5% 1/10W R3215 1-216-797-11 METAL CHIP 10 5% 1/10W R3216 1-216-797-11 METAL CHIP 10 5% 1/10W R3219 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3220 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3221 1-216-833-11 METAL CHIP 10K 5% 1/10W R3222 1-216-833-11 METAL CHIP 10K 5% 1/10W R3223 1-216-833-11 METAL CHIP 10K 5% 1/10W R3224 1-216-833-11 METAL CHIP 10K 5% 1/10W R3225 1-216-845-11 METAL CHIP 100K 5% 1/10W R3226 1-216-845-11 METAL CHIP 100K 5% 1/10W R3227 1-216-845-11 METAL CHIP 100K 5% 1/10W R3251 1-216-809-11 METAL CHIP 100 5% 1/10W R3252 1-216-809-11 METAL CHIP 100 5% 1/10W R3253 1-216-797-11 METAL CHIP 10 5% 1/10W R3254 1-216-864-11 SHORT CHIP 0 R3257 1-216-834-11 METAL CHIP 12K 5% 1/10W R3265 1-216-797-11 METAL CHIP 10 5% 1/10W R3266 1-216-797-11 METAL CHIP 10 5% 1/10W R3269 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3270 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3271 1-216-833-11 METAL CHIP 10K 5% 1/10W R3272 1-216-833-11 METAL CHIP 10K 5% 1/10W R3273 1-216-833-11 METAL CHIP 10K 5% 1/10W R3274 1-216-833-11 METAL CHIP 10K 5% 1/10W R3275 1-216-845-11 METAL CHIP 100K 5% 1/10W R3276 1-216-845-11 METAL CHIP 100K 5% 1/10W R3277 1-216-845-11 METAL CHIP 100K 5% 1/10W R3301 1-216-809-11 METAL CHIP 100 5% 1/10W R3302 1-216-809-11 METAL CHIP 100 5% 1/10W R3303 1-216-797-11 METAL CHIP 10 5% 1/10W R3304 1-216-864-11 SHORT CHIP 0 R3307 1-216-834-11 METAL CHIP 12K 5% 1/10W R3315 1-216-797-11 METAL CHIP 10 5% 1/10W R3316 1-216-797-11 METAL CHIP 10 5% 1/10W R3319 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3320 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3321 1-216-833-11 METAL CHIP 10K 5% 1/10W R3322 1-216-833-11 METAL CHIP 10K 5% 1/10W R3323 1-216-833-11 METAL CHIP 10K 5% 1/10W R3324 1-216-833-11 METAL CHIP 10K 5% 1/10W R3325 1-216-845-11 METAL CHIP 100K 5% 1/10W R3326 1-216-845-11 METAL CHIP 100K 5% 1/10W R3327 1-216-845-11 METAL CHIP 100K 5% 1/10W R3401 1-216-809-11 METAL CHIP 100 5% 1/10W R3402 1-216-809-11 METAL CHIP 100 5% 1/10W R3403 1-216-797-11 METAL CHIP 10 5% 1/10W R3404 1-216-864-11 SHORT CHIP 0 R3407 1-216-834-11 METAL CHIP 12K 5% 1/10W R3415 1-216-797-11 METAL CHIP 10 5% 1/10W R3416 1-216-797-11 METAL CHIP 10 5% 1/10W R3419 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3420 1-216-136-00 RES-CHIP 2.7 5% 1/8W R3421 1-216-833-11 METAL CHIP 10K 5% 1/10W R3422 1-216-833-11 METAL CHIP 10K 5% 1/10W R3423 1-216-833-11 METAL CHIP 10K 5% 1/10W R3424 1-216-833-11 METAL CHIP 10K 5% 1/10W R3425 1-216-845-11 METAL CHIP 100K 5% 1/10W R3426 1-216-845-11 METAL CHIP 100K 5% 1/10W R3427 1-216-845-11 METAL CHIP 100K 5% 1/10W R3501 1-216-809-11 METAL CHIP 100 5% 1/10W (DZ620K) R3502 1-216-809-11 METAL CHIP 100 5% 1/10W (DZ620K) R3503 1-216-797-11 METAL CHIP 10 5% 1/10W (DZ620K) R3504 1-216-864-11 SHORT CHIP 0 (DZ620K) R3507 1-216-835-11 METAL CHIP 15K 5% 1/10W (DZ620K) R3515 1-216-797-11 METAL CHIP 10 5% 1/10W (DZ620K) R3516 1-216-797-11 METAL CHIP 10 5% 1/10W (DZ620K) R3519 1-216-136-00 RES-CHIP 2.7 5% 1/8W (DZ620K) R3520 1-216-136-00 RES-CHIP 2.7 5% 1/8W (DZ620K) R3551 1-216-845-11 METAL CHIP 100K 5% 1/10W R3553 1-216-833-11 METAL CHIP 10K 5% 1/10W R3554 1-216-845-11 METAL CHIP 100K 5% 1/10W R3555 1-216-864-11 SHORT CHIP 0 R4002 1-216-864-11 SHORT CHIP 0 < COMPOSITION CIRCUIT BLOCK > RB501 1-233-576-11 RES, CHIP NETWORK 100 (3216) RB1103 1-234-372-11 RES, NETWORK 100 (1005X4) RB1104 1-234-372-11 RES, NETWORK 100 (1005X4) RB1105 1-234-372-11 RES, NETWORK 100 (1005X4) RB1106 1-234-372-11 RES, NETWORK 100 (1005X4) MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 79 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark RB1107 1-234-372-11 RES, NETWORK 100 (1005X4) RB1108 1-234-372-11 RES, NETWORK 100 (1005X4) RB1111 1-234-372-11 RES, NETWORK 100 (1005X4) RB1112 1-234-371-21 RES, NETWORK 47 (1005X4) RB1113 1-234-371-21 RES, NETWORK 47 (1005X4) RB1114 1-234-372-11 RES, NETWORK 100 (1005X4) RB1115 1-234-372-11 RES, NETWORK 100 (1005X4) < VIBRATOR > X502 1-795-058-21 VIBRATOR, CERAMIC 5MHz X1102 1-813-539-11 QUARTZ CRYSTAL UNIT 27MHz X3051 1-795-660-21 QUARTZ CRYSTAL UNIT 49.152MHz ************************************************************* MS-203 BOARD ************* < CONNECTOR > CN001 1-815-412-11 CONNECTOR, FFC/FPC 5P < SWITCH > S001 1-786-693-11 SWITCH, DETECTION ************************************************************* A-1144-950-A POWER BOARD, COMPLETE (RU) A-1178-430-A POWER BOARD, COMPLETE (E3, SP) *********************** < CAPACITOR > 0C901 1-165-529-11 MYLAR 0.22uF 10 275V 0C902 1-165-529-11 MYLAR 0.22uF 10 275V 0C903 1-112-333-11 ELECT (BLOCK) 330uF 20% 450V 0C905 1-112-335-91 FILM 0.0033uF 5% 400V 0C906 1-117-815-11 FILM 1000PF 3% 1.5KV 0C907 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V 0C908 1-107-909-11 ELECT 47uF 20% 35V 0C909 1-162-960-11 CERAMIC CHIP 220PF 10% 50V 0C910 1-107-907-11 ELECT 22uF 20% 50V 0C911 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V 0C913 1-117-693-11 CERAMIC 100PF 10% 250V 0C918 1-113-925-11 CERAMIC 0.01uF 20% 250V 0C920 1-113-925-11 CERAMIC 0.01uF 20% 250V 0C922 1-128-560-11 ELECT 22uF 20% 100V 0C923 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V 0C924 1-126-961-11 ELECT 2.2uF 20% 50V 0C925 1-107-974-81 CERAMIC 47PF 5% 2KV 0C928 1-113-900-11 CERAMIC 470PF 10% 250V 0C929 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V 0C930 1-117-693-11 CERAMIC 100PF 10% 250V C932 1-100-924-21 ELECT 2200uF 20% 35V C933 1-100-924-21 ELECT 2200uF 20% 35V C934 1-112-831-11 ELECT 2200uF 20% 35V C935 1-165-319-11 CERAMIC CHIP 0.1uF 50V C936 1-165-319-11 CERAMIC CHIP 0.1uF 50V C937 1-100-756-91 CERAMIC CHIP 0.047uF 50V 0C938 1-117-698-51 CERAMIC 680PF 10% 250V C939 1-136-165-00 FILM 0.1uF 5% 50V C940 1-128-947-31 ELECT 3300uF 20% 10V C941 1-128-954-11 ELECT 1000uF 20% 25V C942 1-126-941-11 ELECT 470uF 20% 25V C943 1-126-933-11 ELECT 100uF 20% 16V C944 1-128-951-21 ELECT 2200uF 20% 16V C945 1-126-935-11 ELECT 470uF 20% 16V C946 1-128-950-21 ELECT 1000uF 20% 16V C947 1-104-658-91 ELECT 100uF 20% 10V C948 1-126-925-91 ELECT 470uF 20% 10V C949 1-165-722-11 ELECT 100uF 20% 10V C951 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C952 1-100-756-91 CERAMIC CHIP 0.047uF 50V C953 1-117-214-11 CERAMIC 0.001uF 10% 2KV C954 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C955 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C958 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C960 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V 0C963 1-117-699-11 CERAMIC 0.001uF 99% 250V 0C964 1-117-699-11 CERAMIC 0.001uF 99% 250V C965 1-117-699-11 CERAMIC 0.001uF 99% 250V C967 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C968 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C969 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C970 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C971 1-100-566-91 CERAMIC CHIP 0.1uF 10% 25V C976 1-126-933-11 ELECT 100uF 20% 16V < CONNECTOR > CN901 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P < DIODE > 0D901 8-719-082-57 DIODE D5SBA60F01 0D905 8-719-063-74 DIODE D1NL20U-TR2 0D906 6-501-193-01 DIODE 1SS355WTE-17 0D907 6-501-193-01 DIODE 1SS355WTE-17 0D908 6-501-193-01 DIODE 1SS355WTE-17 0D909 6-501-193-01 DIODE 1SS355WTE-17 0D910 6-501-193-01 DIODE 1SS355WTE-17 0D913 6-500-241-01 DIODE SARS03 0D914 6-501-193-01 DIODE 1SS355WTE-17 0D915 8-719-977-28 DIODE UDZSTE-1710B 0D921 6-501-424-01 DIODE STO2D-140 0D922 8-719-063-74 DIODE D1NL20U-TR2 0D923 8-719-977-28 DIODE UDZSTE-1710B 0D924 8-719-083-69 DIODE UDZSTE-1724B 0D925 8-719-069-54 DIODE UDZSTE-175.1B 0D926 8-719-977-28 DIODE UDZSTE-1710B D931 6-501-413-01 DIODE FCU20UC20 D932 8-719-069-54 DIODE UDZSTE-175.1B D941 6-500-288-11 DIODE EK19LF-F7 D942 8-719-080-53 DIODE RK36LF-B3 D943 8-719-080-53 DIODE RK36LF-B3 D944 6-500-288-11 DIODE EK19LF-F7 D945 8-719-083-67 DIODE UDZSTE-1720B < GROUND TERMINAL BOARD > EB901 1-537-770-21 TERMINAL BOARD, GROUND EB902 1-537-770-21 TERMINAL BOARD, GROUND MAIN MS-203 POWER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 80 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark EB903 1-537-770-21 TERMINAL BOARD, GROUND EB904 1-537-770-21 TERMINAL BOARD, GROUND < FUSE HOLDER > 0FH901 1-533-313-11 FUSE HOLDER 0A 0V 0FH902 1-533-313-11 FUSE HOLDER 0A 0V < FUSIBLE > 0FR901 1-220-886-11 FUSIBLE 0.1 10% 1W < IC > 0IC901 6-707-742-01 IC STR-F6168-LF1352 0IC921 6-707-740-01 IC STR-V153 IC931 8-759-648-34 IC TA76431AS (TPE6) IC941 6-707-746-01 IC SI-3120KM-TL IC942 6-707-745-10 IC SI-3050KM-TL IC943 6-707-744-01 IC SI-3033KM-TL IC951 6-707-743-01 IC TA76L431S (TPE6, Q) < COIL > L931 1-457-226-11 INDUCTOR 10uH L941 1-414-398-11 INDUCTOR 10uH L942 1-414-398-11 INDUCTOR 10uH L945 1-414-398-11 INDUCTOR 10uH L947 1-414-398-11 INDUCTOR 10uH L948 1-414-398-11 INDUCTOR 10uH L951 1-414-398-11 INDUCTOR 10uH < LINE FILTER > 0LF901 1-457-054-21 COIL, LINE FILTER (E3, SP) 0LF901 1-457-079-11 COIL, LINE FILTER (RU) 0LF902 1-457-054-21 COIL, LINE FILTER (E3, SP) 0LF902 1-457-079-11 COIL, LINE FILTER (RU) < IC > 0PC901 6-600-438-01 IC TLP421F (D4-GR) 0PC902 6-600-438-01 IC TLP421F (D4-GR) 0PC903 6-600-438-01 IC TLP421F (D4-GR) < TRANSISTOR > 0Q901 8-729-140-04 TRANSISTOR 2SB1116A-TP-LK 0Q921 8-729-142-51 TRANSISTOR 2SD1616A-TP-LK Q943 1-801-806-11 TRANSISTOR RT1N441C-TP-1 Q945 6-550-718-01 TRANSISTOR RSR025N03TL Q947 1-801-806-11 TRANSISTOR RT1N441C-TP-1 < RESISTOR > 0R901 1-219-759-11 METAL 1M 5% 1/2W 0R903 1-215-929-11 METAL OXIDE 100K 5% 3W 0R904 1-215-929-11 METAL OXIDE 100K 5% 3W 0R905 1-216-797-11 METAL CHIP 10 5% 1/10W 0R906 1-216-827-11 METAL CHIP 3.3K 5% 1/10W 0R907 1-216-833-11 METAL CHIP 10K 5% 1/10W 0R908 1-260-105-11 CARBON 3.3K 5% 1/2W 0R909 1-216-845-11 METAL CHIP 100K 5% 1/10W 0R910 1-216-825-11 METAL CHIP 2.2K 5% 1/10W 0R911 1-216-813-11 METAL CHIP 220 5% 1/10W 0R912 1-216-363-00 METAL OXIDE 0.33 5% 2W 0R914 1-219-718-11 METAL 0.1 10% 5W 0R919 1-216-836-11 METAL CHIP 18K 5% 1/10W 0R922 1-216-793-11 METAL CHIP 4.7 5% 1/10W 0R923 1-216-829-11 METAL CHIP 4.7K 5% 1/10W 0R925 1-216-797-11 METAL CHIP 10 5% 1/10W 0R926 1-216-855-11 METAL CHIP 680K 5% 1/10W 0R927 1-216-349-00 METAL OXIDE 1 5% 1W 0R929 1-249-478-11 CARBON 2.2 5% 1/2W R931 1-218-859-11 METAL CHIP 3.3K 0.5% 1/10W R932 1-218-883-11 METAL CHIP 33K 0.5% 1/10W R933 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R934 1-216-821-11 METAL CHIP 1K 5% 1/10W R935 1-216-821-11 METAL CHIP 1K 5% 1/10W R936 1-216-853-11 METAL CHIP 470K 5% 1/10W R937 1-216-833-11 METAL CHIP 10K 5% 1/10W R938 1-216-821-11 METAL CHIP 1K 5% 1/10W R939 1-218-859-11 METAL CHIP 3.3K 0.5% 1/10W R940 1-216-833-11 METAL CHIP 10K 5% 1/10W R941 1-216-864-11 SHORT CHIP 0 R943 1-216-864-11 SHORT CHIP 0 R946 1-216-811-11 METAL CHIP 150 5% 1/10W R948 1-216-833-11 METAL CHIP 10K 5% 1/10W R949 1-216-821-11 METAL CHIP 1K 5% 1/10W R951 1-218-831-11 METAL CHIP 220 0.5% 1/10W R952 1-218-855-11 METAL CHIP 2.2K 0.5% 1/10W R953 1-218-861-11 METAL CHIP 3.9K 0.5% 1/10W R954 1-216-837-11 METAL CHIP 22K 5% 1/10W R955 1-216-817-11 METAL CHIP 470 5% 1/10W R956 1-216-821-11 METAL CHIP 1K 5% 1/10W R957 1-216-841-11 METAL CHIP 47K 5% 1/10W R958 1-216-821-11 METAL CHIP 1K 5% 1/10W R965 1-218-865-11 METAL CHIP 5.6K 0.5% 1/10W R966 1-216-821-11 METAL CHIP 1K 5% 1/10W R967 1-216-821-11 METAL CHIP 1K 5% 1/10W 0R968 1-216-821-11 METAL CHIP 1K 5% 1/10W R969 1-216-821-11 METAL CHIP 1K 5% 1/10W R971 1-216-864-11 SHORT CHIP 0 R974 1-216-827-11 METAL CHIP 3.3K 5% 1/10W < TRANSFORMER > 0T901 1-443-874-11 TRANSFORMER, CONVERTER 0T902 1-443-650-11 TRANSFORMER, CONVERTER < THERMISTOR > 0TH901 1-805-842-21 THERMISTOR, NTC 6.0 < VARISTOR > 0VDR901 1-805-482-11 VARISTOR ************************************************************* SPEAKER BOARD ************** < CAPACITOR > C301 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C302 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C303 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V POWER SPEAKER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 81 HCD-DZ520K/DZ620K Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C304 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C305 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C306 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C307 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C308 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C309 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C310 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C311 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C312 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C313 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C314 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C315 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C316 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C317 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C318 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C319 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C320 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C321 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C322 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C323 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V C324 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V < CONNECTOR > * CN301 1-564-519-11 PLUG, CONNECTOR 4P CN302 1-818-651-11 PIN, CONNECTOR 2P * CN303 1-564-521-11 PLUG, CONNECTOR 6P < EARTH TERMINAL > EP301 1-537-770-21 TERMINAL BOARD, GROUND EP302 1-537-770-21 TERMINAL BOARD, GROUND < TERMINAL > TB301 1-780-344-11 TERMINAL BOARD (SPEAKER) 4P (FRONT R)(FRONT L)(CENTER)(WOOFER) TB302 1-780-343-11 TERMINAL BOARD (SPEAKER) 2P (SUR R)(SUR L) ************************************************************* SW BOARD ********* < SWITCH > S801 1-762-875-21 SWITCH, KEYBOARD (?/1) ************************************************************* MISCELLANEOUS ************** 3 1-693-701-11 TUNER (FM/AM) (TM10SKR) (RU) 3 1-693-702-11 TUNER (FM/AM) (TM10SE) (E3, SP) 8 1-828-953-11 WIRE (FLAT TYPE)(9 CORE) 65 1-828-384-11 WIRE (FLAT TYPE)(23 CORE) 66 1-828-325-11 WIRE (FLAT TYPE)(13 CORE) 104 1-787-331-11 FAN, D.C. 0106 1-777-071-22 CORD, POWER (E3) 0106 1-830-188-11 CORD, POWER (RU, SP) 110 1-828-292-11 WIRE (FLAT TYPE)(5 CORE) 111 1-828-332-11 WIRE (FLAT TYPE)(13 CORE) 112 1-828-300-11 WIRE (FLAT TYPE)(7 CORE) 113 1-828-330-11 WIRE (FLAT TYPE)(13 CORE) 0507 8-820-290-02 OPTICAL PICK-UP KHM-310CAA/C2RP 508 1-828-773-51 WIRE (FLAT TYPE)(24 CORE) 0F901 1-532-325-00 FUSE, TIME-LAG (T6.3AL/250V) SPEAKER SW www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com HCD-DZ520K/DZ620K REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2006.04 New www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com