1 CD player section Signal-to-noise ratio 92 dB Frequency response 10 – 20,000 Hz Wow and flutter Below measurable limit Laser Diode Properties Material GaAlAs Wavelength 780 nm Emission Duration Continuous Laser output power Less than 44.6 µW* * This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up Block. Cassette player section Tape track 4-track 2-channel stereo Wow and flutter 0.08 % (WRMS) Frequency response 30 – 18,000 Hz Signal-to-noise ratio Cassette type Dolby B NR Dolby NR off TYPE II, IV 67 dB 58 dB TYPE I 64 dB 55 dB SERVICE MANUAL US Model WX-4500X CHANGER CONTROL AUDIO MASTER SPECIFICATIONS – Continued on next page – Dolby noise reduction manufactured under license from Dolby Labo- ratories Licensing Corporation. “DOLBY” and the double-D symbol ; are trademarks of Dolby Laboratories Licensing Corporation. AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION 23 watts per channel minimum continuous average power into 4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than 5% total harmonic distortion. Tuner section FM Tuning range FM tuning interval: 50 kHz/200 kHz switchable 87.5 – 108.0 MHz (at 50 kHz step) 87.5 – 107.9 MHz (at 200 kHz step) Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Usable sensitivity 8 dBf Selectivity 75 dB at 400 kHz Signal-to-noise ratio 65 dB (stereo), 70 dB (mono) Harmonic distortion at 1 kHz 0.7% (stereo), 0.4% (mono) Separation 35 dB at 1 kHz Frequency response 30 – 15,000 Hz Ver 1.1 2002. 10 Sony Corporation e Vehicle Company Published by Sony Engineering Corporation 9-873-326-02 2002J0400-1 © 2002. 10 Model Name Using Similar Mechanism NEW CD Drive Mechanism Type MG-318RW/ A-153 Optical Pick-up Name RAF0143A Model Name Using Similar Mechanism WX-C55 Tape Transport Mechanism Type MG-25E-136 CD Section TC Section www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 SERVICE NOTE CAUTION Use of controls or adjustments or performance of proce- dures other than those specified herein may result in haz- ardous radiation exposure. Notes on Chip Component Replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be dam- aged by heat. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick- up block. Therefore, when checking the laser diode emission, ob- serve from more than 30 cm away from the objective lens. NOTES ON PICK-UP FLEXIBLE BOARD The pick-up flexible board in this set is secured to the optical pick- up with an adhesive tape. Once the tape is removed, an adhering force becomes weak, and it cannot be reused. Therefore, if the optical pick-up is replaced, replace also the pick- up flexible board with a new one. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. AM Tuning range AM tuning interval: 9 kHz/10 kHz switchable 531 - 1,602 kHz (at 9 kHz step) 530 – 1,710 kHz (at 10 kHz step) Antenna terminal External antenna connector Intermediate frequency 10.7 MHz/450 kHz Sensitivity 30 µV Power amplifier section Outputs Speaker outputs (sure seal connectors) Speaker impedance 4 – 8 ohms Maximum power output 50 W × 4 (at 4 ohms) General Outputs Audio output Subwoofer outout (mono) Power antenna relay control lead Power amplifier control lead Inputs Telephone ATT control lead Illumination control lead BUS control input connector BUS audio input connector Remote controller input connector Antenna input connector Tone controls Bass ±10 dB at 62 Hz Treble ±10 dB at 16 kHz Loudness +8 dB at 100 Hz +2 dB at 10 kHz Power requirements 12 V DC car battery (negative ground) Dimensions Approx. 178 × 100 × 186 mm (7 1/8 × 4 × 7 3/8 in.) (w/h/d) Mounting dimension Approx. 178 × 100 × 165 mm (7 1/8 × 4 × 6 1/2 in.) (w/h/d) Mass Approx. 2.1 kg (4 lb. 10 oz.) Supplied accessories Parts for installation and connections (1 set) NOTE This unit cannot be connected to a digital preamplifier or an equalizer. Design and specifications are subject to change without notice. WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 TABLE OF CONTENTS 1. GENERAL Location of Controls............................................................... 4 Getting Started ........................................................................ 5 CD Player ............................................................................... 5 Cassette Player ....................................................................... 6 Radio ...................................................................................... 6 Other Functions ...................................................................... 7 Connections ............................................................................ 9 2. DISASSEMBLY 2-1. Front Panel Assy .............................................................. 11 2-2. CD Mechanism Block ...................................................... 12 2-3. CD Main Board ................................................................ 12 2-4. Tension Spring (FL) ......................................................... 13 2-5. Floating Block Assy ......................................................... 13 2-6. Roller Arm Assy ............................................................... 14 2-7. Optical Pick-up Assy ........................................................ 14 2-8. Chassis (Top) Assy ........................................................... 15 2-9. Main Board ...................................................................... 15 2-10. Heat Sink .......................................................................... 16 2-11. Tape Mechanism Block .................................................... 16 3. ASSEMBLY OF MECHANISM DECK 3-1. Housing ............................................................................ 17 3-2. Arm (Suction) ................................................................... 17 3-3. Lever (LDG-A)/(LDG-B) ................................................ 18 3-4. Gear (Loading FT) ........................................................... 18 3-5. Guide (U) ......................................................................... 19 3-6. Main Motor Assy ............................................................. 19 4. MECHANICAL ADJUSTMENTS .............................. 20 5. ELECTRICAL ADJUSTMENTS Tape Section ......................................................................... 20 6. DIAGRAMS 6-1. IC Pin Descriptions .......................................................... 22 6-2. Block Diagram –CD Section–.......................................... 26 6-3. Block Diagram –Tuner Section– ...................................... 27 6-4. Block Diagram –Tape Section– ....................................... 28 6-5. Circuit Boards Location ................................................... 29 6-6. Printed Wiring Boards –CD Mechanism Section–........... 30 6-7. Schematic Diagram –CD Mechanism Section – .............. 31 6-8. Printed Wiring Board –Main Section– ............................. 32 6-9. Schematic Diagram –Main Section (1/3)– ....................... 34 6-10. Schematic Diagram –Main Section (2/3)– ....................... 35 6-11. Schematic Diagram –Main Section (3/3)– ....................... 36 6-12. Printed Wiring Board –Jog Section– ................................ 37 6-13. Printed Wiring Board –Display Section– ......................... 38 6-14. Schematic Diagram –Display, Jog Section– .................... 40 7. EXPLODED VIEWS 7-1. Cover Section ................................................................... 46 7-2. Front Panel Section .......................................................... 47 7-3. Main Board Section ......................................................... 48 7-4. CD Mechanism Section (1) .............................................. 49 7-5. CD Mechanism Section (2) .............................................. 50 7-6. Tape Mechanism Section ................................................. 51 8. ELECTRICAL PARTS LIST ................................... 52 WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 WX-4500X SECTION 1 GENERAL This section extracted from instruction manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8 WX-4500X www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9 9 WX-4500X Connections w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10 10 WX-4500X w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 WX-4500X SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence. Note : Follow the disassembly procedure in the numerical order given. 2-1. FRONT PANEL ASSY Set Front Panel Assy CD Mechanism Block Main Board Heat Sink Floating Block Assy Roller Arm Assy Optical Pick-up Assy Tape Mechanism Block CD Main Board Tension Spring (FL) Chassis (Top) Assy 1 PTT 2.6x6 2 PTT 2.6x6 3 claw 4 claw 5 CN901 6 panel assy, front www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 WX-4500X 6 CD MAIN board 4 M 2x3.0 5 M 2x3.0 1 CNP102 2 CNJ102 claw 3 CNJ103 1 PTT 2.6x6 2 PTT 2.6x6 6 PTT 2.6x6 7 bracket (MD) 3 PTT 2.6x6 4 CD mechanism block 5 CNJ101 2-2. CD MECHANISM BLOCK 2-3. CD MAIN BOARD www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 WX-4500X 1 washer (M) 3 lever (LE.L) 4 spring (SPM), tension 5 spring (angle), tension 6 Fit lever in the direction of the arrow. 0 floating block assy 7 shaft 8 shaft 9 shaft 2 1 spring (FL), tension 2 spring (FL), tension 2-4. TENSION SPRING (FL) 2-5. FLOATING BLOCK ASSY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 14 WX-4500X 6 pick-up assy, optical 1 gear (woam wheel) 2 shaft (sled guide) 3 cover (P) 4 PTP 1.7x4 5 rack (feed) 3 Fit lever in the direction of the arrow. 1 spring (roller) 6 arm assy, roller 4 shaft 5 shaft 2 spring (roller) 2-6. ROLLER ARM ASSY 2-7. OPTICAL PICK-UP ASSY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 15 WX-4500X 1 PTT 2.6x10 2 PTT 2.6x6, ground point 3 MAIN board 4 CN450 1 PTT 2.6x6 2 PTT 2.6x6 3 CN400 4 connector 5 chassis (TOP) assy projection projection 2-8. CHASSIS (TOP) ASSY 2-9. MAIN BOARD www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 16 WX-4500X 2 PTT 2.6x5 3 tape mechaniam block 1 PTT 2.6x5 1 PTT 2.6x10 2 PTT 2.6x10 3 PTT 2.6x10 5 PTT 2.6x10 6 heat sink 4 BTP 2.6x8 2-10. HEAT SINK 2-11. TAPE MECHANISM BLOCK www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 17 WX-4500X 2 Move the arm (suction) in the arrow Direction and fit on projection. 1 Fit the arm (suction) on the shaft. projection SECTION 3 ASSEMBLY OF MECHANISM DECK Note : Follow the assembly procedure in the numerical order given. 3-1. HOUSING 3-2. ARM (SUCTION) 7 Holder the hanger by bending the claw. 1Install the catcher to the hanger. 2 Install the hanger onto two claws of the housing. 3 Put the housing under A part. 6 Fit projection on D part. 4 Fit claw on B part. 5 Fit projection on C part. 8 Hold the hanger by bending the claw. hanger housing D part head C part B part A part Head, Housing Arm (Suction) Guide (U) Main Motor Assy Lever (LDG-A) / (LDG-B) Gear (Loading FT) Note : This set can be assemble according to the following sequence. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 18 WX-4500X 3-3. LEVER (LDG-A) / (LDG-B) 3-4. GEAR (LOADING FT) 1 Fit the lever (LDG-A) on shafts A to C and install it. 2 Fit the lever (LDG-B) on shafts A and B and install it. 3 type-E stop ring 2.0 shaft A shaft C shaft A shaft B shaft B 5 Align hole in the gear (LDG-D) with hole the lever (LDG-A). 4 Move the lever (LDG-B) in the arrow direction. 2 tension spring (LD-2) 1 3 tension spring (LD-1) 7 polyethylene washer 6 gear (loading FT) gear (LDG-D) gear (LDG-FB) lever (LDG-A) hole hole www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 WX-4500X 3-5. GUIDE (U) 3-6. MAIN MOTOR ASSY 1 claws 2 guide (C) 3 belt (25) 2 precision screws P 2x2 1 main motor assy (CAPSTAN/REEL) (M904) 30° www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 20 WX-4500X set frequency counter test tape WS-48A (3 kHz, 0 dB) SP OUT 4Ω PRECAUTION 1. Wipe the following components with an absorbent cotton cloth moistened with alcohol before adjustment : PB head Pinch roller Idler Rubber belt Capstan 2. Demagnetize the PB head using a head demagnetizer. 3. Be careful not to use a magnetized screwdriver. 4. After the adjustment is completed, lock the adjustment parts using screws. 5. Unless otherwise specified, make adjustments at the specified voltage (14.4 V). Torque Measurement Mode Torque Meter Meter Reading 2.95 – 6.37 mN • m FWD (30 – 65 g • cm) CQ-102C (0.42 – 0.90 oz • inch) FWD 0.05 – 0.44 mN • m Back Tension (0.5 – 4.5 g • cm) (0.01 – 0.06 oz • inch) 2.95 – 6.37 mN • m REV (30 – 65 g • cm) CQ-102RC (0.42 – 0.90 oz • inch) REV 0.05 – 0.44 mN • m (0.5 – 4.5 g • cm) Back Tension (0.01 – 0.06 oz • inch) 5.88 – 19.61 mN • m FF, REW CQ-201B (60 – 200 g • cm) (0.83 – 2.78 oz • inch) Tape Tension Measurement Mode Tension Meter Meter Reading FWD CQ-403A more than 90 g REV CQ-403R (more than 3.17 oz) SECTION 5 ELECTRICAL ADJUSTMENTS SECTION 4 MECHANICAL ADJUSTMENTS TAPE SECTION Tape Speed Adjustment Mode : FWD play 0 dB = 0.775 V Tape Speed Adjustment -Tape Mechanism Block upper side- • Adjustments of the tuner and CD sections have auto adjustments in this set. Test tape Type Signal Use WS-48A 3 kHz, 0 dB Tape speed adjustment P-4-D400 400 Hz, 0 dB Dolby level adjustment Procedure: 1. Playback the test tape in the FWD play mode. 2. Verify that the reading on the digital frequency counter is in the range between 3,010 and 3,300 Hz at the top of tape. 3. If the specified value is not met, adjust the variable resistor on the capstan motor so that the reading is 3,000 Hz at the FWD top of tape. Adjustment Location : www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 WX-4500X -MAIN BOARD- (SIDE B) TP-R TP-L Dolby level adjustment -MAIN BOARD- (SIDE A) Dolby level adjustment (R-CH) Dolby level adjustment (L-CH) DOLBY Level Adjustment Setting : Light down mark ; (DOLBY OFF) Procedure : 1. Set the FWD play mode. 2. Push the MENU button and rotate the jog roller to display “NR”. Then press “ — ” on the SEEK/AMS button to select “NR off”. (Dolby off) 3. Adjust RV400 for L-ch and RV401 for R-ch so that the level meter reads –6 ±0.5 dB (0.37 to 0.41 V). Adjustment Location : main board TP-L TP-R test tape P-4-D400 (400 Hz, 0 dB) level meter set www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 WX-4500X • IC103 µPD780058GC-259-8BT (CD MECHANISM CONTROLLER) Pin No. Pin Name I/O Pin Description 1 RST O Reset signal output to the MN6627481RPMFA (IC101) “L” : Reset 2, 3 — O Not used in this set (open) 4 AVSS — Ground pin (for A/D converter) 5 — O Not used in this set (open) 6 J/E, CE I Destination initial setting pin Fixed at “H” in this set 7 A VREF1 I Reference voltage (+5 V) input (for D/A converter) 8 SUBQ I Sub code Q data input from the MN6627481RPMFA (IC101) 9 — O Not used in this set (open) 10 SQCK O Clock signal output for sub code Q data write to the MN6627481RPMFA (IC101) 11 STAT I Internal status signal input from the MN6627481RPMFA (IC101) 12 FL-M- > F O Data write signal to external flash memory Not used in this set (open) 13 MCLK/FL-CLK O Clock signal output for command data from the MN6627481RPMFA (IC101) 14, 15 — O Not used in this set (open) 16 BUS SI I Serial data input from SONY bus interface (IC750) 17 BUS SO O Serial data output to SONY bus interface (IC750) 18 BUS CLK I/O Serial clock signal input/output for bus interface to the master controller (IC700) and the display controller (IC900), or serial clock signal output to the SONY bus interface (IC750) 19 — I Through pin of serial clock signal for the bus interface Connect to the BUS CLK (pin qk) 20 TLOCK I Tracking servo pull-in signal input from the MN6627481RPMFA (IC101) “L” : Active 21 FLOCK I Focus servo pull-in signal input from the MN6627481RPMFA (IC101) “L” : Active 22 SENCE I Internal status (SENSE) input from the MN6627481RPMFA (IC101) 23 — I Through pin of serial clock signal for the bus interface Connect to the BUS CLK (pin qk) 24 — O Through pin of bus serial data out Connect to the BUS SO (pin qj) 25, 26 — I Through pin of bus serial data in Connect to the BUS SI (pin qh) 27 MLD O Command road signal output from the MN6627481RPMFA (IC101) 28 MDATA O Command data signal output from the MN6627481RPMFA (IC101) 29 LINK OFF O Link on/off control signal output for SONY bus interface “L” : Link off, “H” : Link on Not used in this set 30 A MUTE O Audio line mute control signal output “H” : mute on 31 MECHA ON O Power on/off control signal output of CD mechanism deck block “H” : Power on 32 — I Through pin of power supply Connect to the VDD (pins yk, uf) 33 VSS — Ground pin 34 — I Through pin of battery down voltage detection signal 35 CD ON O Power on/off control signal output of CD mechanism deck block 36 – 38 — O Not used in this set (open) 39 — I Through pin of bus on/off control signal 40 — O Not used in this set (open) 41 — I Test signal input of auto adjustment 42 SER OK O Effect discrimination out of auto adjustment “H” : OK 43 SER NG O Effect discrimination out of auto adjustment “H” : NG 44 – 51 — O Not used in this set (open) 52 TEXT I Initial setting input used to with/without the CD text decording function “L” : without, “H” : with 53 SERCHK O Not used in this set (open) 54 P TEST O Not used in this set (open) 55 LIMSW I CD sled limit in detection switch input “L” signal is input when the optical pick-up comes on the innermost perimeter 56, 57 — O Not used in this set (open) SECTION 6 DIAGRAMS 6-1. IC PIN DESCRIPTIONS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 WX-4500X *1 CD loading motor (M903) control Operation STOP LOADING EJECT BRAKE Pin FOUT (Pin uj) “L” “H” “L” “H” ROUT (Pin uh) “L” “L” “H” “H” Pin No. Pin Name I/O Pin Description 58 SW3 I CD loading detection switch input “L” signal is input during CD disc loading and ejecting operations 59 SW4 I CD disc detection switch input “L” signal is input when CD disc catching is completed 60 SYS RESET I System reset signal input from the master controller (IC700) and the reset signal oscillator (IC701) “L” : Reset “L” signal is input for several hundreds of microseconds after the power is turned on, the signal then turns “H”. 61 — O Not used in this set (open) 62 BUS ON I BUS on/off control signal input from the master controller (IC700) “L” : Bus on 63 SW2 I CD disc detection switch input “L” signal is input when a disc is present at the CD disc inlet 64 B/U CHECK I Down voltage detection input from the SONY bus interface (IC750) and the battery detection circuit “L” signal is input when the voltage is reduced 65 BLKCK I Clock signal input for sub code interrupt from the MN6627481RPMFA (IC101) 66 — O Not used in this set (open) 67 VSS0 — Ground pin 68 VDD — Power supply pin (+5 V) 69 X2 — Main system clock connect pin (5 MHz) 70 X1 — Main system clock connect pin (5 MHz) 71 VPP — Fixed at “L” in this set 72 — — Sub System clock connect pin Not used in this set (open) 73 XT1 — Sub System clock connect pin Not used in this set (Fixed at “H”) 74 VDD — Power supply pin (+5 V) 75 A VREF0 I Reference voltage input (for A/D converter) Fixed at “L” in this set 76 ROUT O CD loading motor (M903) control signal (direction of eject) output to the BA5984FP (IC201) of CD mechanism deck block “H” : Active *1 77 FOUT O CD loading motor (M903) control signal (direction of loading) output to the BA5984FP (IC201) of CD mechanism deck block “H” : Active *1 78, 79 — — Not used in this set (open) 80 GCTL O FE, TE gain control signal output www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 24 WX-4500X • IC700 MB90574CPMT-G-356-BNDDE1 (MAIN SYSTEM CONTROL) Pin No. Pin Name I/O Pin Description 1 TU ON O Tuner on signal output 2 DOLON I/O Dolby control signal output (“H” : dolby on)/dolby function corresponding detection signal input (“L” : dolby function corresponding) 3 – 6 N. C. O O Not used in this set (open) 7 BUS ON O Bus on control signal output 8 VCC — Power supply pin (+5 V) 9 FLASH WR I Flash write mode detection signal input “L” : Flash write mode 10 EEDATA I/O EEPROM data signal input/output 11 EECLK O EEPROM clock signal output 12 RXD I Flash write data signal input 13 TXD O Flash write data signal output 14 N. C. O O Not used in this set (open) 15 BEEP O BEEP signal output 16 DPBOOT O Display microcomputer write control signal output 17 – 19 N. C. O O Not used in this set (open) 20 UNI SI I SONY bus data input 21 UNI SO O SONY bus data output 22 UNI CLK O SONY bus clock output 23 N. C. O O Not used in this set (open) 24 SIRCS I Remote control data signal input 25 – 28 POS0 – 3 I Position signal detection input 29 REEL1 I Reel stand rotation detection signal input 30 LM EJ O Tape mechanism loading motor control signal output (eject direction) 31 LM LOD O Tape mechanism loading motor control signal output (loading direction) 32 TP ON O Tape power control signal output 33 VSS — Ground pin 34 C — Capacitance pin of power stabilized 35 AD ON O Power control signal output of A/D conversion 36 N. C. O O Not used in this set (open) 37 CM-ON O Capstan motor control signal output 38 DVCC — D/A converter VREF input 39 DVSS — D/A converter ground pin 40, 41 N. C. O O Not used in this set (open) 42 AVCC — Analog power supply pin 43 A VRH — A/D converter VREF+ input 44 A VRL — A/D converter VREF– input 45 AVSS — Analog ground pin 46 KEY IN0 I Key 0 signal input 47 KEY IN1 I Key 1 signal input 48 DESTSEL0 I Destination initial setting pin (Fixed at “H” in this set) 49 RC IN0 I Rotary commander signal input 50 QUALITY I Tuner noise detection signal input Not used in this set (open) 51 FM AGC I FM AGC detection signal input 52 MPT I Tuner multi pass signal input Not used in this set (open) 53 VSM I S meter voltage signal input 54 VCC — Power supply pin (+5 V) 55, 56 N. C. O — Not used in this set (open) 57 E VOL MUTE O Electronic volume mute signal output “L” : mute on 58 AMP MUTE O Amplifier mute signal output 59 MUTE O System mute control signal output 60 AMP ON O Amplifier on signal output “L” : off/ “H” : on 61 SA LAT O Serial data lutch pulse output for spectrum analyzer www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 25 25 WX-4500X Pin No. Pin Name I/O Pin Description 62 FL ON I FL ON control signal input 63 VSS — Ground pin 64 RE IN1 I Rotary encoder signal input 65 FSW IN I Frequency signal input for D/D converter oscillation 66 RE IN0 I Rotary encoder signal input 67 – 69 N. C. O O Not used in this set (open) 70 II DATA O Data signal output for tuner volume communication 71 II CLK O Clock signal output for tuner volume communication 72 RC IN1 I Rotary commander signal input 73 X1A — Low speed oscillation input (32.768 kHz) 74 X0A — Low speed oscillation input (32.768 kHz) 75 W UP O Wake up signal output 76 KEYACK I Key acknowledge detection signal input 77 BU CHK I Back up power detection signal input 78 DAVN I RDS data block synchronization detection signal input 79 TEL ATT I TEL mute detection signal input 80 TEST IN I Test mode setting detection signal input 81 ACC IN I ACC power detection signal input “L” : ACC on 82 FSW SFT O D/D converter control signal output 83 SYS RST O System reset signal output 84 RAM RST I RAM reset detection signal input 85 NS MASK O Noise mask output Not used in this set (open) 86 HTMX I Hardware standby signal input 87 MODE2 I Input for operation mode (Connect to VSS) 88 MODE1 I Input for operation mode (Connect to VSS) 89 MODE0 I Input for operation mode (Connect to VSS) 90 RST I Microcomputer reset signal input 91 VSS — Ground pin 92 X0 — High speed oscillation input (3.58 MHz) 93 X1 — High speed oscillation input (3.58 MHz) 94 VCC — Power supply pin (+5 V) 95 DSTSEL1 I Destination initial setting pin 96, 97 N. C. O O Not used in this set (open) 98 DIM ON O Dimer control signal output 99 ILL ON O Illumination power control signal output 100 ILL IN I Illumination line detection signal input 101 – 103 N. C. O O Not used in this set (open) 104 POWER ON O System power control signal output 105 – 110 N. C. O O Not used in this set (open) 111 PLAY/AMS O AMS music interval detection function control signal output 112 F/R O FWR/REV control signal output “H” : FWD/ “L” : REV 113 MTL I/O Metal control signal output (“H” : metal on)/Metal function corresponding detection signal input 114 – 116 N. C. O O Not used in this set (open) 117 AMS IN I AMS music interval detection signal input “L” : Audio signal detection, “H” : Audio signal no detection 118 TAPE MUTE O During FF/REW period, audio signal select control signal output When the FF/REW mode is selected with ATA ON : “H” 119 VSS — Ground pin 120 N. C. O O Not used in this set (open) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 26 26 WX-4500X 6-2. BLOCK DIAGRAM — CD SECTION — M902 SLED 32 30 5 RF AMP 6 8 DETECTOR & I/V AMP RF AMP ENVELOPE LPD AMP AGC RF DET BDO DET OFER DET DSL. PLL VCO EFM/SUBCODE DEMODULATOR, CD-TEXT BUFFER INPUT PORT MICRO COMPUTER INTERFACE SERVO CPU A/O CONVERTER SUBCODE BUFFER I-V AMP FOCUS ERROR AMP FOCUS COIL DRIVE TRACKING COIL DRIVE SERVO TIMING GENERATOR SERVO TIMING GENERATOR TRACKING ERROR AMP 28 27 AUTOMATIC POWER CONTROL Q101 2 1 17 18 15 16 23 26 SLED MOTOR DRIVE LOADING MOTOR DRIVE 6 28 1 SPINDLE MOTOR DRIVE 3 27 21 28 26 25 M M901 SPINDLE M M903 LOADING M 12 11 22 24 CLV SERVO 8 12 7 9 20 28 13 27 11 18 1 11 21 10 22 13 65 30 17 18 16 62 64 60 73 75 14 10 15 8 17 70 69 77 76 63 58 59 55 10 15 44 68 53 38 14 36 12 23 20 19 18 26 25 24 39 35 31 30 40 32 34 33 CIRC ERROR CORRECTION, 16K S-RAM SOFT MUTING, ATTENUATOR TIMING GENERATOR 1BIT D/A CONVERTER, PWM LOGIC DIGITAL DEEMPHASIS DIGITAL FILTER 59 58 35 31 SYS RST BUS CHECK BUS ON BUS SI BUS SO BUS CLK A-MUTE BUS CLK BUS SO BUS ON B/U CHECK SYS RESET BUS SI B.P.F NA LD F+ F– T+ T– F E NB A PDF PDE LD PD PD B 2-AXIS DEVICE (FOCUS) (TRACKING) RFO RFI ARF ENV OFTR BDO FEO TEO TEBPF LDON FIN– F+ F– T+ T– SLED+ SLED– SPDL+ SPDL– VOL+ VOL– TIN– FIN RIN SLIN– SPIN– FBAL TBAL LDON FOD TRD KICK TVD TRV ECM ECS FBAL TBAL DSLB ARF RFDET OFT BDO RFENV FE TE VDET VDET NRFDET 10 9 14 13 FOCUS/TRACKING COIL DRIVE, SLED/SPINDLE/LOADING MOTOR DRIVE IC201 SENSE FLOCK TLOCK MDATA MCLK MLD STAT RST 16M X2 OUTL OUTR SQCK SUBQ BLKCK R-CH X101 16.93MHz CD L CD ON A-MUTE MECHA ON SENSE FLOCK TLOCK MDATA MCLK MLD STAT RST X1 X2 FOUT SW2 SW3 SW4 LIMSW ROUT SQCK SUBQ MECHA ON CD-ON BLKCK CD MECHANISM CONTROLLER IC103 X301 5MHz DIGITAL SIGNAL PROCESSOR, DIGITAL SIGNAL SERVO, CLV SERVO, D/A CONVERTER,CD-TEXT IC101 RF AMP, FOCUS/TRACKING ERROR AMP IC102 OPTICAL PICK-UP BLOCK LASER DIODE SW2 (DISC DETECT) SW3 (LOADING DETECT) SW4 (CHUCKING DETECT) SW5 (LIMIT) 2 TUNER SECTION 6 TAPE SECTION 3 TUNER SECTION 7 TAPE SECTION • Signal path : CD + + + – – – • R-ch is omitted due to same as L-ch. (Page 27) (Page 28) (Page 27) (Page 28) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 27 27 WX-4500X 6-3. BLOCK DIAGRAM — TUNER SECTION — ANT-AM CDC L TAPE L CD L AM MPXI MP IN AM DET CD L TAPE L MPX ANT-FM 1 1 2 8 40 10 SDA 12 SCL 13 S-METER 14 FM AGC 4 SDA 17 SCL 18 VSM SDA SCL S MUTE II DATA II CLK E-VOL MUTE MUTE 53 19 70 59 AMP ON 60 STBY 4 AC GND 16 AMP MUTE 58 BEEP RESET 15 TEST IN 80 FM AGC 51 EE DATA 10 EE CLK 11 X1A 73 XOA X700 32.768kHz X451 3.58MHz 74 3 1 3 33 38 MUTE 22 15 11 27 XO 92 XI 93 28 24 23 21 44 4 12 14 9 LPF IC451 VOL TONE BAL/ FAD ACC IN 81 ILL IN 100 TEL ATT 79 TU ON 1 POWER ON TU8.5V BATT BATT COM8V TU5V AUDIO 10V BATT 104 1 4 2 MUTE Q303 9 7 17 19 MUTE Q303 ACC CHECK Q903 ILLUM CHECK Q904 TEL ATT Q906 ANT REMOTE SW Q900(1/2) ANT/AMP REMOTE SW Q902 MUTE DRIVE Q300,301 AMP REMOTE SW Q900(2/2) MUTE Q303 1 4 2 +5V REG Q1 REG IC1 J1 (ANTENNA) 20 71 17 57 TU1 TUNER UNIT ELECTRONIC VOLUME IC300 ADSO(L-CH) IC100 SA OUT SA CLK SA AUDIO SA CLK SW FL RL MUTE Q302 CN300 CN900 -1 -2 -3 -4 L R L R SUB WOOFER OUT(MONO) BUS AUDIO IN R-CH FL+ FL– RL+ RL– FR+ FR– RR+ RR– TEST ACC ILL 2 1 10 9 3 7 ANT REM 5 6 4 11 12 13 15 ATT 14 BATT AMP REM 16 R-CH BATT F901 +8V REG IC301 POWER AMP IC170 MAIN SYSTEM CONTROL IC700(1/2) 4� TAPE SECTION 1� TAPE SECTION 2 CD SECTION 3 CD SECTION 5� TAPE SECTION A-MUTE • Signal path : FM : AM : CD : TAPE(PB) IN1 IN3 OUT1+ OUT1– OUT3+ OUT3– • R-ch is omitted due to same as L-ch. (Page 26) (Page 28) (Page 26) (Page 28) (Page 28) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 28 28 WX-4500X 6-4. BLOCK DIAGRAM — TAPE SECTION — (Page 26) (Page 27) (Page 27) 37 18 19 16 7 17 14 20 113 112 2 118 117 111 25 2 4 39 EQ DOLBY NR DOLBY LEVEL (L-CH) AUTO MUSIC SENSOR BUS ON CONT C-MOTOR DRIVE Q653,654 26 27 28 29 24 72 49 46 66 64 84 1 2 1 2 90 86 16 12 81 1 57 65 82 75 62 30 31 37 32 76 4 3 35 7 9 RV400 TAPE +8.5V REG Q650,651 +5V REG Q450,451 KEY ACK SW Q905 22 21 20 D/D CONV ON/OFF SW Q800 33 28 46 16 17 44 40 39 FL ON/OFF SW IC801,Q803 FREQ OSC ON/OFF SW Q801 CD+8V REG Q809 AMP IC803,Q810 Q812-814 BACK-UP +5V REG Q804 +10V REG Q808 DIMMER ON/OFF SW Q907 ILLUM ON/OFF SW Q901 FL ON/OFF SW Q810 ILLUM ON/OFF SW Q908 WAKE-UP SW Q807 POWER CONTROL Q805,806 2 27 34 82 38 51 97 98 101 62 50 112 52 85 11 BUS ON/OFF SW Q750 6 5 4 7 8 3 2 1 9 10 8 7 12 1 86 75 74 64 60 8 9 11 12 OVER VOLTAGE CHECK Q751 BATT CHECK 10 RESET 13 2 6 3 4 1 99 98 61 16 83 77 22 7 20 21 REMOTE CONTROL RECEIVER PH960 CD8V MECHA ON CD ON +8.5V CD5V BATT BATT R-CH TAPE EQ/DOLBY/METAL/AMS IC400 FWD/REV MTL/NORMAL NR ON L OUT MUTE/TAPE AMS OUT AMS/PLAY TAPE L F/R UNI SI UNI SO BUS ON UNI CLK BU CHK SYS RST DP BOOT SA LAT DIM ON ILL ON W UP FSW SFT F SW IN RESET FL ON MTL DOL ON TAPE MUTE AMS IN POS0 POS1 POS2 POS3 REEL1 LM EJ LM LOD CM ON SIRCS TP ON KEY ACK AD ON RC IN1 RC IN0 KEY IN0 RE IN0 RE IN1 RAM RST RST HTMX RXD AMS ON L L R R R-CH R-CH FWD REV HP901 PLAYBACK HEAD TAPE MECHANISM BLOCK LM+ LM– LOADING MOTOR DRIVE IC650 RAM RESET IC702 RESET IC701 BU5V BU5V EN960 KEY J900 (REMOTE IN) SW960 (RESET) MAIN SYSTEM CONTROL IC700(2/2) BUS CLK BUS SI BUS SO BUS ON BUS CHECK SYS RST BUS CONTROL IC750 DATA CLK LINK OFF RES SA CLK SA AUDIO IC901 DISPLAY SYSTEM CONTROL IC900 BOOT SA LAT BU IN NMI BUS ON FL ON UNI SO UNI SI UNI CK FL SI SA CLK SA DATA ILL ON XTAL BU5V AUDIO 10V AUDIO 10V EXTAL FL LAT FL BK FL SCK FL SO CN750 (BUS CONTROL IN) BATT RESET BATT BATT BATT BATT BATT OUT1 RT AUDIO 10V CD8V BU5V CTL1 CTL2 CTL3 DTC4 DTC3 OUT2 OUT3 OUT4 POWER CONTROL IC800 T800 VDD LAT BK CLK SI VH F2 F2 F1 F1 FL700 X901 18.432MHz 1 TUNER SECTION 6 CD SECTION 5 TUNER SECTION 4 TUNER SECTION • Signal path : TAPE 7 CD SECTION M904 (CAPSTAN/REEL) M M905 (LOADING) M 1 2 D903,905 908,911 D902,904,906 • R-ch is omitted due to same as L-ch. DST SEL1 FM 200k AM 10k FM 50k AM 9k S700 95 (FREQUENCY SELECT) BU5V (Page 26) (Page 27) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 29 29 WX-4500X 6-5. CIRCUIT BOARDS LOCATION Note on Printed Wiring Boards: • X : parts extracted from the component side. • Y : parts extracted from the conductor side. • a : Through hole. • f : internal component. • : Pattern from the side which enables seeing. (The other layer’s patterns are not indicated.) THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • % : indicates tolerance. • f : internal component. • C : panel designation. Caution: Pattern face side: Parts on the pattern face side seen from the (Side B) pattern face are indicated. Parts face side: Parts on the parts face side seen from the (Side A) parts face are indicated. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • A : B+ Line. • Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. • Voltage and waveforms are dc with respect to ground under no-signal conditions. • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal produc- tion tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal produc- tion tolerances. • Circled numbers refer to waveforms. • Signal path. F : FM f : AM E : TAPE J : CD MAIN board MOTOR board CD MAIN board SW board DISPLAY board JOG board • Waveforms — MAIN SECTION (2/3) — 1 2 32.768kHz IC700 uf (X0A) 2.1Vp-p 3.9Vp-p 3.58MHz IC700 os (X0) • Waveforms — CD MECHANISM SECTION — (MODE : CD PLAY) 3 1 2 IC102 8 (ARF) 1.2Vp-p Approx. 390mVp-p IC102 w; (TEO) IC101 td (PCK/DSLB) 16.9344MHz IC101 tk (16M) 5MHz IC103 u; (X1) 4 5.4Vp-p 5 3.6Vp-p 6 4.1Vp-p 0V Approx. 180mVp-p IC102 wd (FEO) 0V 1.9µsec w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 30 30 WX-4500X 6-6. PRINTED WIRING BOARD — CD MECHANISM SECTION — • Refer to page 29 for Circuit Boards Location. Ref. No. Location IC101 D-5 IC102 B-7 IC103 F-4 IC201 F-9 Q101 C-9 • Semiconductor Location CNJ102 IC201 CNJ103 X301 C138 C101 BP1 BP2 BP3 BP4 BP5 CNP102 TP311 TP306 TP309 TP308 TP307 TP310 TP304 TP305 JC306 JC305 JC307 JC311 JC312 JC309 JC310 JC114 JC110 JC112 JC123 JC313 JC121 JC103 JC102 JC212 JC213 JC139 JC106 JC107 JC104 JC101 JC105 JC138 JC137 JC301 JC303 JC308 JC208 JC209 JC203 JC210 JC211 JC202 JC201 R206 C201 JC205 JC133 JC134 Q101 JC108 C135 JC135 R133 R126 JC136 CNJ101 C116 IC101 R129 IC102 X101 JC119 TP104 TP101 R123 C124 R122 C127 R137 R117 R106 C128 C121 R113 R301 R209 C132 R102 C105 C118 C102 R101 C110 R203 C106 R207 R202 R119 R208 R115 R112 R148 C302 C137 R135 C120 R124 C136 R204 C111 C119 R108 C113 R110 R109 R107 R105 R104 R103 R111 R130 C141 C108 R205 C115 C125 C123 R116 C103 C122 C126 C139 R134 R114 R132 C117 C112 C130 R128 C140 R125 R120 R305 C114 C129 C206 R302 C301 R121 R127 R304 R149 R150 R143 R144 R141 R142 C145 C146 C147 R145 R146 R147 JC111 JC109 JC115 JC116 JC124 JC125 JC126 JC127 JC128 JC129 JC130 JC131 JC140 C104 IC103 C303 C207 R307 JC141 R152 JC142 C131 C133 JC122 R151 TP103 TP105 TP302 TP301 TP303 SW3 (LOADING DETECT) M903 (LOADING) SW2 (DISC DETECT) M902 (SLED) M901 (SPINDLE) SW4 CHUCKING DETECT ( ) 1 4 – + – + 2 5 1 6 ORG BLU SW5 (LIMIT) (Page 33) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 31 31 WX-4500X 6-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 29 for Waveforms. Refer to page 41 for IC Block Diagrams. Note: • Voltage and waveforms are dc with respect to ground under no-signal conditions. no mark : CD PLAY ∗ : Impossible to measure CNJ101 JC102 JC103 JC101 JC305 JC306 C302 JC307 JC114 JC110 JC112 JC105 JC104 JC213 JC212 C102 C101 TP105 TP104 TP103 R121 C118 JC138 JC139 C133 C138 JC106 C115 R119 R134 R135 TP101 C117 R117 C103 BP4 JC310 JC309 BP3 JC313 TP303 TP302 TP301 TP304 TP305 TP306 TP307 TP308 TP309 TP310 R307 R302 JC121 C136 R106 IC101 C112 C113 R116 C111 R112 R113 BP1 BP2 C120 R152 C108 R109 R103 C105 JC123 X301 BP5 TP311 JC308 JC303 JC301 R304 R305 R301 JC205 R137 C128 R125 R124 C127 R122 C123 C121 R143 C125 C132 C130 C129 R147 IC102 C147 R205 R204 R203 R202 JC201 IC201 JC211 JC210 C201 JC209 JC208 C207 R126 R133 C137 C135 C119 R128 R127 JC108 CNJ102 R129 R132 JC107 R101 R110 R108 R107 R105 R104 R102 R111 C106 R115 R114 C145 JC137 C116 C141 R145 R146 JC135 R209 C206 R207 R208 R206 R141 R142 C139 C140 JC312 JC311 C126 C301 JC202 JC203 CNJ103 CNP102 SW5 M902 M901 SW2 SW3 SW4 M903 JC136 JC131 R150 JC111 R149 JC119 JC127 JC130 JC128 R148 C104 C303 IC103 JC129 JC142 JC116 JC115 JC122 JC109 Q101 JC124 JC141 JC134 JC126 JC125 JC133 C114 JC140 R120 C110 R123 C124 R130 C146 R144 C131 X101 C122 R151 IC B/D IC B/D IC B/D (Page 35) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 32 32 WX-4500X 6-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 29 for Circuit Boards Location. C20 C108 C111 C208 C211 C307 C314 C315 C321 C653 D650 D651 L300 Q650 Q651 Q653 Q654 Q907 Q908 R119 R219 R312 R316 R317 R650 R651 R652 R653 R654 R656 RB700 RB701 IC700 R118 R218 X451 IC701 R722 R205 R204 R104 R715 IC702 R720 C323 IC800 Q900 Q902 Q904 Q800 D803 R751 R753 C903 D757 Q751 R752 Q750 D756 D750 D755 D754 Q450 Q451 C463 D452 L452 C462 D908 R861 C834 T800 R850 R849 Q810 C837 C838 R862 R863 R455 L804 C842 Q803 R822 Q801 IC801 R860 R868 R807 C807 C900 R902 Q903 D809 Q809 L805 C830 R834 R836 R830 D808 Q808 L803 C827 C825 R831 R832 C841 L802 D807 Q804 C823 L801 R828 R827 D806 Q805 C821 Q806 R825 D805 D804 Q807 Q813 IC803 R839 R838 R837 R842 R840 R841 R833 R846 D801 R895 D453 R921 R922 R920 R413 C407 R404 D800 R408 L806 C721 TP701 G1 Q906 R912 R913 C317 Q905 C718 D903 C112 C109 C212 C209 R3 D900 D901 TH900 R340 TH901 R341 D812 D752 D753 D751 C1 Q1 D1 R318 C304 R110 R111 C107 C16 C301 C311 Q300 R539 C712 R900 Q303 L901 C820 C833 C902 Q812 R456 C418 C425 C416 R411 R410 R409 R400 R402 R401 C412 C404 C405 C401 R403 R405 C408 C409 C2 R1 R2 C5 C10 R4 R5 R6 R7 R8 C19 C18 C14 R9 R10 R303 R305 R302 C303 C308 C302 R114 R217 R214 R117 C322 C651 C654 C750 R896 C720 R721 R806 C806 R812 R704 R712 R714 R716 C710 C711 R733 R727 R729 R723 C652 R726 R713 R909 C464 C905 IC300 IC100 IC200 IC650 IC400 IC750 D701 D909 R864 C417 C419 R414 R415 C420 C421 R412 C423 R417 C426 C422 R416 C424 R804 R805 R212 D300 R215 R115 R105 R211 R210 C207 R906 R901 R810 R811 R818 R813 R814 R815 R816 R819 R823 R829 R824 R904 R905 C901 R803 R801 R802 R800 R711 R719 C828 C410 R730 C312 D302 R308 C325 C865 C101 C201 C103 C203 C104 C204 D304 C470 C471 C480 C481 R470 R471 R472 R480 R481 R482 C400 C414 C465 C808 C813 C809 C655 C305 C817 C818 C819 C660 C661 C662 C663 C824 C831 C815 C802 C804 C811 C703 C803 C805 R735 R750 R655 R903 R313 R908 R923 R907 R315 R206 R207 R230 R407 R314 R847 R893 R848 R858 R859 R113 R116 R213 R216 R319 R406 R734 R707 R701 C836 R852 R853 R854 RV401 RV400 D630 D811 D810 Q814 R894 C13 C839 R808 D813 L1 L2 R399 R418 C427 C428 R200 R700 R702 C709 R718 R717 C708 Q301 R321 C832 R756 R755 R309 R306 C15 R911 C810 C21 C413 C701 R710 D700 C705 R11 IC301 C713 D305 C205 C472 C482 R725 R307 R345 C310 R320 C309 C327 C106 C206 R222 D306 C328 C403 C415 C402 R419 R421 R100 R221 R122 R121 C116 C216 R910 IC451 C217 C117 C450 R112 Q302 Q304 R107 R106 C105 R130 R724 C707 IC1 TP3 TP4 L900 R708 X700 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 33 33 WX-4500X D1 G-4 D300 D-7 D302 C-8 D304 F-7 D305 F-7 D306 D-7 D452 G-12 D453 G-14 D630 G-6 D650 F-3 D651 F-4 D700 H-6 D701 K-6 D750 C-13 D751 B-12 D752 B-13 D753 B-12 D754 D-14 D755 D-14 D756 C-11 D757 B-13 D800 G-9 D801 I-10 D803 H-11 D804 E-9 D805 D-9 D806 E-8 D807 F-9 D808 F-10 D809 F-11 D810 E-14 D811 E-13 D812 F-14 D813 I-9 D900 B-10 D901 B-10 D903 B-10 (D907) C-12 D908 C-9 D909 K-8 IC1 H-4 IC100 E-5 (IC170) A-7 IC200 D-5 IC300 E-6 IC301 G-6 IC400 K-13 IC451 J-10 IC650 F-4 IC700 I-6 IC701 K-4 IC702 G-7 IC750 B-14 IC800 H-10 IC801 I-11 IC803 F-12 Q1 H-3 Q300 E-7 Q301 E-7 Q302 C-7 Q303 C-5 Q304 C-6 Q450 G-13 Q451 G-13 Q650 G-5 Q651 G-5 Q653 F-5 Q654 F-4 Q750 B-14 Q751 B-14 Q800 H-10 Q801 I-11 Q803 G-11 Q804 F-10 Q805 E-9 Q806 D-9 Q807 E-9 Q808 F-10 Q809 F-11 Q810 G-12 Q812 F-12 Q813 F-11 Q814 E-12 Q900 C-10 Q902 C-10 Q903 C-10 Q904 D-9 Q905 K-7 Q906 J-8 Q907 K-8 Q908 K-8 Ref. No. Location • Semiconductor Location Ref. No. Location ( ): SIDE B CN300 TU1 J900 CN900 CN750 D907 CN450 TH750 IC170 C719 CN901 C866 J1 S700 (Page 30) (Page 39) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 34 34 WX-4500X 6-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 43 for IC Block Diagrams. Note: • Voltage is dc with respect to ground under no-signal condition. no mark : FM ( ) : AM < > : CD PLAY [ ] : TAPE PLAY ∗ : Impossible to measure IC B/D IC B/D C1 C2 R2 R8 C13 C10 Q1 R11 C16 C15 C14 C21 C18 C19 C20 L2 L1 IC1 R3 C312 R539 C307 R305 C308 R306 R302 C305 R303 C304 C303 C104 C204 C201 C107 R110 R111 R107 R106 R130 C105 C315 R211 R210 C207 IC300 C310 C311 R907 R908 R903 C900 R902 R905 R901 C327 C317 R308 Q301 C328 Q300 R309 C208 R212 R213 R216 Q304 R215 C211 C111 R115 R116 R345 R205 R204 R105 R104 C108 R112 R113 Q303 C314 C205 R207 R206 R230 R315 R319 R318 C109 R114 C112 R117 C212 R217 C209 R214 C321 R314 R312 Q902 Q900(2/2) R900 R341 R340 Q900(1/2) G1 C323 R313 C322 C325 R316 R317 R219 R218 R118 R119 TH900 TH901 C901 C902 C903 D907 R904 R906 C203 C103 C101 R307 R320 R321 R7 R6 R5 R4 R9 CN300 J1 D903 D901 D900 IC170 Q903 D908 C905 Q904 D302 D305 D300 Q302 D304 D1 D306 CN900 F901 R1 C5 IC100 IC200 C106 C206 L900 TU1 R10 C309 (Page 35) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 35 35 WX-4500X Note: • Voltage is dc with respect to ground under no-signal condition. no mark : FM ( ) : AM < > : CD PLAY [ ] : TAPE PLAY ∗ : Impossible to measure 6-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 29 for Waveforms. Refer to page 44 for IC Block Diagrams. IC B/D IC B/D / / C417 C418 C419 R412 C424 R413 R400 C425 C426 CN450 R402 C400 L452 R456 CN650 C650 C651 C652 C654 C660 C661 C662 C663 C465 C450 C464 R455 Q450 Q451 R404 C401 RV400 C407 C408 R405 R403 R421 C427 R399 C403 R401 IC400 R419 C412 R408 C428 R418 C413 RV401 R410 R411 R409 C414 R100 R200 C472 R471 C471 R470 C410 R480 R481 C480 R482 C482 C409 R406 C217 C216 R222 R221 R472 C470 R122 C116 R121 R707 C701 R727 R730 R733 R726 C705 C703 R708 R712 R711 R714 TP700 R723 R724 R725 X451 C713 D701 R735 R913 R717 C708 C709 R718 R716 R756 R755 R722 C707 C710 X700 R720 C711 R719 R710 R704 R701 R702 R713 R700 RB700 RB701 R655 Q651 R656 Q653 R650 C655 IC650 R912 C415 C462 TP TP C402 R407 C463 R651 R652 R653 R654 D650 C653 C712 R414 C420 R415 C421 R417 C423 R416 C422 C416 C405 C404 CN400 C481 R729 C117 D452 D453 D630 D651 Q650 Q654 D700 Q906 IC451 IC700 R721 S700 (Page 31) (Page 34) (Page 36) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 36 36 WX-4500X 6-11. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 44 for IC Block Diagrams. Note: • Voltage is dc with respect to ground under no-signal condition. no mark : FM ( ) : AM < > : CD PLAY [ ] : TAPE PLAY ∗ : Impossible to measure IC B/D IC B/D IC B/D IC B/D Q751 Q800 R806 D801 R807 C807 C808 R715 Q801 R868 IC801 R810 R811 C809 C836 C813 C815 R819 R818 R815 R814 R813 C811 R812 Q803 R816 IC800 C803 C802 R800 R801 R802 R803 D800 R911 D909 R909 Q804 L801 R827 R828 C821 Q805 R829 C824 R830 C823 R824 Q808 L803 C828 C825 R832 Q809 R833 C831 R834 R836 C830 R854 R853 R852 R850 R849 R847 R862 C833 C834 C837 C865 R863 R893 R895 R861 R860 C832 R858 R859 R848 Q750 IC750 D755 R920 J900 Q908 G2 L804 C839 Q807 C820 R825 R808 D813 C301 C302 L300 R910 Q905 L805 R864 C838 R846 C810 R823 C818 C817 R822 D807 R894 R896 Q810 C842 R841 R840 R837 R838 R839 R842 C827 C819 R923 L901 Q907 TH750 CN750 R752 R750 D750 R751 R753 C719 C721 C720 C718 IC702 R734 TP701 L806 IC301 IC701 R921 R922 R831 L802 C866 C841 C805 R804 R805 C804 CN901 C806 D757 D753 D752 D751 D756 D754 D810 D811 Q812 Q813 IC803 Q814 D809 D808 D805 Q806 D806 D803 T800 D812 D804 C750 (Page 35) (Page 40) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 37 37 WX-4500X 6-12. PRINTED WIRING BOARD — JOG SECTION — • Refer to page 29 for Circuit Boards Location. D904 D902 D906 CN904 R937 R944 TB900 EN960 (Page 38) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 38 38 WX-4500X 6-13. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 29 for Circuit Boards Location. Ref. No. Location D903 C-12 D905 C-1 D907 A-7 D908 C-1 D909 A-7 D911 C-13 PH960 D-13 • Semiconductor Location LSW975 PH960 R938 R931 R930 LSW968 LSW961 LSW962 LSW963 SW960 CN903 R932 R935 R940 R922 R957 R959 R960 R961 R952 R923 R958 R964 R953 R954 R956 R951 R965 R943 R991 D908 D905 D903 D911 SW971 SW973 D907 D909 LSW970 LSW967 LSW969 LSW974 LSW966 LSW965 LSW972 LSW964 (Page 37) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 39 39 WX-4500X Ref. No. Location D900 B-9 D901 C-7 D960 D-13 IC900 C-10 IC901 C-8 Q901 C-7 • Semiconductor Location IC900 RB900 FB900 RB901 RB902 R918 C913 IC901 D900 Q901 D901 R942 D960 R929 R948 R949 R939 C903 C904 C910 C919 R980 R902 R911 R905 R903 R901 R904 R912 R910 C902 C920 R962 R921 R955 R963 CN902 C911 R967 TP901 C909 C907 R920 X901 C905 C906 R936 R913 R907 R906 R917 FL700 (Page 33) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 40 40 WX-4500X 6-14. SCHEMATIC DIAGRAM — DISPLAY, JOG SECTION — • Refer to page 45 for IC Block Diagrams. Note: • Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM IC B/D D908 R930 R932 D911 D905 D903 R940 R938 R957 R956 R955 R954 R953 R958 R959 R960 R961 R962 EN960(2/2) R937 R944 D906 D902 D904 TB900 CN904 CN903 R991 R943 C919 D960 R963 R964 R965 R952 R951 D907 D909 R939 R935 R931 R942 R903 R967 R929 R921 RB901 R904 R901 R980 RB900 R920 C910 C909 Q901 D901 RB902 C920 X901 R913 R936 C906 R912 D900 R911 R910 C903 C902 R907 IC901 R906 FB900 R917 R918 CN902 FL700 EN960(1/2) IC900 R905 R949 R948 R902 C913 C911 C907 C904 C905 R923 R922 LSW974(2/2) LSW974(1/2) LSW975(2/2) LSW975(1/2) LSW970(2/2) LSW970(1/2) LSW966(2/2) LSW966(1/2) LSW965(2/2) LSW965(1/2) LSW972(2/2) LSW972(1/2) LSW967(2/2) LSW967(1/2) LSW968(2/2) LSW968(1/2) LSW969(2/2) LSW969(1/2) LSW961(2/2) LSW961(1/2) LSW962(2/2) LSW962(1/2) LSW964(2/2) LSW964(1/2) LSW963(2/2) LSW963(1/2) SW960 SW973 SW971 PH960 (Page 36) • Waveforms — DISPLAY SECTION — 1 18.432MHz IC900 ig (XTAL) 3.2Vp-p w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 41 WX-4500X • IC Block Diagrams IC101 MN6627481RPMFA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 INTERPOLATION, SOFT MUTING, DIGITAL ATTENUATOR MICRO COMPUTER INTERFACE SERVO TIMING GENERATOR 8 TIMES OVER SAMPLING, DIGITAL FILTER OUTPUT PORT CLV SERVO SERVO CPU INPUT PORT DIGITAL AUDIO INTERFACE DIGITAL DEEMPHASIS 1BIT D/A CONVERTER, PWM LOGIC PWM (R) VDD VDD PWM (L) DSL, PLL VCO SUBCODE BUFFER A/D CONVERTER D/A CONVERTER 16K S-RAM CIRC ERROR CORRECTION, DEINTERLEAVE VCO TIMING GENERATOR, PITCH CONTROL EFM DEMODULATION, SYNC INTERPOLATION, SUBCODE DEMODULATION CD-TEXT BUFFER + – + – BCLK LRCK DATA DVDD DVSS TX MCLK MDATA MLD SENSE FLOCK TLOCK BLKCK SQCK/GIO0 SUBQ DMUTE STAT RST SMCK PMCK /PLAY TRV TVD PC ECM ECS KICK TRD FOD VREF FBAL TBAL FE TE RFENV VDET OFT TRCRS RFDET BDO LDON VDD X2 16M VSS SBCK SUBC VCOF2 PCK /DSLB EFM /CK384 AVSS2 AVDD2 VCOF PLLF DSLF DRF IREF ARF WVEL TOFS PLLF2 SSEL MSEL PSEL CSEL RSEL/GIO3 OUTR AVSS1 OUTL AVDD1 TEST IOSEL RESY/FLAG6 DEMPH CRC CLVS FLAG IPFLAG GIO2 /FCLK GIO1 /CLDCK BYTCK /TRVSTP www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 42 WX-4500X IC102 AN22000A-EA 17 VREF 18 VDET 19 TEBPF 26 TBAL 25 FBAL 24 LDON 27 PDE 28 PDF 29 D 30 B 31 C 32 A VDET BCA GCA AMP BCA GCA AMP SUBT BCA GCA AMP BCA GCA AMP SUBT 23 FEO 22 FEN 21 13 TEN 20 TEO OFTR 14 15 16 11 BDO 12 9 3TENV 10 4 RF EQ 5 2 3 1 7 AGC 8 6 NRFDET VCC VCC GND BDO ENV CEA ARF CAGC RFI RFO VCC LD PD RFN CBDO NRFDET OFTR COFTR + – + – + – REV FWD OUT B OUT A + – + – + – + – + – + – MUTE + – + – + – + – + – + – + – LEVEL SHIFT LEVEL SHIFT – + LEVEL SHIFT – + LEVEL SHIFT – + – + VCC LOADING DRIVER 24 23 22 21 20 19 18 17 16 15 4 5 6 7 8 9 10 11 12 13 14 2 1 3 27 28 26 25 FIN TIN+ TIN– TOUT FIN+ FIN– FOUT MUTE BIAS GND F– F+ T– T+ RIN SPIN+ SPIN– SPOUT SLIN+ SLIN– SLOUT VCC VOL– VOL+ SLED– SLED+ SPDL– SPDL+ IC201 BA5984FP-E2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 43 WX-4500X 33 34 35 36 37 38 39 40 41 42 43 44 1 2 3 4 5 6 7 8 9 10 11 28 27 30 29 32 31 SOFT STEP FADER SOFT STEP FADER SOFT STEP FADER SUB WOOFER FILTER MONO FADER MIXER OUTPUT SELECTOR HIGH PASS SOFT STEP VOLUME 7BAND EQUALIZER SOFT MUTE BEEP PAUSE PLL PIL, DET LOUDNESS SPECTRUM ANALIZER IN GAIN + AUTO ZERO MAIN SOURCE SELECTOR MIXING SELECTOR IIC-BUS DIGITAL CONTROL DEMODULATOR +STEREO ADJUST +STEREO BLEND PILOT CANCELLATION MULTI PATH DETECTOR AM/FM NOISE BLANKER PULSE FORMER SUPPLY 25kHz LP 86kHz LP STD IN GAIN S & H HIGH OUT QUAL. A/D 12 13 14 15 16 18 19 22 21 20 INPUT MULTIPLEXER TAPE R FDR+ FDL– FDL+ PAUSE PHONE TIM NAVI AM/MPX2 AMIF CMPX TAPEL MDL MDR CDL CDR CREF AC OUTL SWACOUT ACOUTR ACINR SWIN ACINL MIXINFL MIXINRL MIXINRR MIXINFR OUTFL OUTRL OUTFR OUTRR OUTSW SAOUT 26 25 24 23 AUX1 LEVEL MP IN MP OUT QUAL 17 ATT GND SDA SCL SACLK VDD CREF IC300 TDA7406T 2 1 3 4 5 REFERENCE VOLTAGE CTL VCC OUT C GND VCC IC1 BA00ASFP-E2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 44 WX-4500X IC400 CXA2510AQ-T4 IC800 MB3785APFV-G-BND-ER + – + – + – + – + – 1 2 3 4 5 6 7 8 9 10 20 19 18 17 16 15 14 13 12 11 21 22 23 26 27 28 29 30 31 32 33 34 37 38 39 40 24 25 NF2(MTL) REVL VREFL FWDL 35 36 GND VCT FWDR VREF REVR NF1(MTL) EQOUT EQOUT VCC TAPE IN(L) AUXIN1 AMSLPF LCH OUT TCH1 TCL1 G1FB G2FB AMSTC AMS GND AMS OUT B/C NRON MUTE/TAPE MTL/NORMAL AMS/PLY FWD/REV AMS SW TCL2 TCH2 RCH OUT DIREF AUXIN2 TAPE IN(R) EQ OUT EQ OUT GND F2 120µ/ 70µ X1 X1 VCT + F1 120µ/ 70µ NR OFF/B F3 LPF VCC DETECT MS ON/ OFF NR MODE FWD/RVS TAPE EQ TAPE/AUX NR BIAS NR MS MODE OFF/B T2 T1 CB 4 VE 4 OUT 3 VE 3 VE 2 OUT 2 OUT 1 VE 1 GND VCC 2 OUT 4 CB 1 40 42 43 44 48 3 37 38 39 41 RE D RE C 45 46 47 RE B RE A 36 35 34 33 32 31 30 29 28 27 26 25 CA 4 CB 3 CA 3 DTC 4 FB 4 –IN 4 (E) +IN 4 (E) –IN 3 (E) +IN 3 (E) DTC 3 FB 3 –IN 4 (C) D C 24 23 4 5 2 1 SAW OSC CT RT XTAL XTAL –IN 2 (C) VCC 1 VOLTAGE REFERENCE +2.5V 22 21 20 –IN 3 (C) SCP CTL 3 CTL 2 CTL 1 VREF CT RT OSCO OSCI 19 18 17 16 15 14 13 B A 6 7 8 9 10 11 12 –IN 1 (C) CA 2 DTC 1 FB 1 DTC 2 FB 2 –IN 2 (E) +IN 2 (E) –IN 1 (E) +IN 1 (E) CB 2 CA 1 A B C D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 45 WX-4500X IC650 LB1930M-TLM IC301 BA08SFP-E2 IC750 BA8270F-E2 IC702, 901 RN5VD33AA-TL 1 2 3 4 5 6 7 8 9 10 VCC IN2 S-GND IN1 NC NC OUT2 NC P-GND OUT1 CONTROL CIRCUIT MOTOR DRIVE CIRCUIT BUFFER BUFFER 1 2 3 4 5 6 7 8 9 10 14 13 12 11 BUS ON SWITCH RESET SWITCH BATTERY SWITCH BUS ON RST BATT CLK VREF DATA GND VCC RST BUS ON CLK IN B/U–C DATA IN DATA OUT 2 1 3 4 5 REFERENCE VOLTAGE CTL VCC OUT NC GND VCC 1 2 3 4 5 CD NC OUT VDD GND RESET www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 46 WX-4500X 1 4 4 5 2 3 F901 MG-25E-136 #1 #1 #1 #1 A A B B SECTION 7 EXPLODED VIEWS NOTE: • The mechanical parts with no reference number in the exploded views are not supplied. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) Parts Color Cabinet’s Color • Accessories and hardware (# mark) list are given in the last of this parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ref. No. Part No. Description Remark 7-1. COVER SECTION R Ref. No. Part No. Description Remark R 1 X-3381-331-1 CHASSIS (B) ASSY * 2 3-048-048-01 COVER 3 1-790-926-21 CORD (WITH CONNECTOR) (POWER) 4 3-015-314-01 SCREW (2.6X5) (CZN) (C TITE), +PTT 5 3-016-299-01 CUSHION (MINIATURE) F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 47 WX-4500X 7-2. FRONT PANEL SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark FL700 #2 #2 #2 #2 51 52 53 54 55 56 58 66 59 60 61 62 63 65 64 57 51 X-3381-282-1 PANEL ASSY, FRONT 52 3-228-995-01 BUTTON (SOURCE) 53 3-228-980-11 BUTTON (SEEK +) 54 3-228-991-11 BUTTON (DSPL) 55 3-228-978-01 BUTTON (EQ) 56 3-228-992-01 BUTTON (EJECT) 57 A-3283-221-A DISPLAY BOARD, COMPLETE 58 1-680-656-11 JOG BOARD 59 3-228-993-01 BUTTON (SCRL) 60 3-228-981-01 BUTTON (SEEK –) 61 3-228-994-01 BUTTON (SOUND) 62 3-228-977-01 BUTTON (DSO) 63 1-757-576-11 CABLE, FLEXIBLE FLAT 5P 64 3-231-947-01 CUSHION (SCRL), INTERCEPTION 65 3-327-119-01 SPACER (A) 66 3-231-961-01 CUSHION (FL), INTERCEPTION FL700 1-518-760-11 INDICATOR TUBE, FLUORESCENT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 48 WX-4500X 101 102 103 104 105 108 109 106 106 107 #1 #1 MG-318RW/A-153 #1 TU1 #4 #4 #4 #4 #3 #4 #1 7-3. MAIN BOARD SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 A-3283-220-A MAIN BOARD, COMPLETE 102 3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT 103 1-792-838-12 CABLE, FLEXIBLE FLAT (21 CORE) * 104 3-022-317-01 BRACKET (AMP) * 105 3-048-049-01 HEAT SINK * 106 3-048-642-01 SHEET (FLEXIBLE) * 107 3-038-536-11 BRACKET (MD) 108 3-048-046-11 CHASSIS (TOP) 109 3-360-123-01 PLATE (C), GROUND TU1 A-3220-812-A TUNER UNIT (TUX-020) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 49 WX-4500X 7-4. CD MECHANISM SECTION (1) (MG-318RW/A-153) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark B 162 164 163 152 153 153 153 154 154 154 158 156 159 159 160 163 155 164 151 165 157 166 167 B D D A C C A #5 M903 #6 161 151 X-3378-794-1 ARM ASSY, ROLLER * 152 3-032-327-02 LEVER (LE.L) 153 3-037-492-01 DAMPER (P) 154 3-033-808-01 SCREW (M2X4.0) 155 3-042-644-01 SPRING (LEVER DLR) 156 3-032-373-01 SPRING (SPM), TENSION 157 3-933-152-02 ROLLER (S) 158 3-042-642-01 SPRING (LEVER D) 159 3-032-351-01 SPRING (FL), TENSION 160 3-032-352-01 SPRING (ANGLE), TENSION 161 X-3378-762-2 CHASSIS (M) COMPLETE ASSY * 162 1-670-827-11 SW BOARD 163 3-033-807-01 SCREW (M2X3.0) 164 3-032-359-01 SPRING (ROLLER) 165 3-039-600-02 ROLLER (SS) 166 A-3340-039-A CD MAIN BOARD, COMPLETE 167 3-033-806-01 SCREW (M2X2.5) M903 X-3378-888-1 MOTOR ASSY, LO (LOADING) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 50 WX-4500X 7-5. CD MECHANISM SECTION (2) (MG-318RW/A-153) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark M901 M902 201 202 223 203 224 222 204 205 206 207 208 221 209 210 211 212 213 214 215 216 217 218 not supplied not supplied 220 219 201 A-3301-898-A ARM ASSY, CHUCKING 202 3-033-805-01 SCREW (M2X2.0) * 203 3-027-473-01 CUSHION (EJ2) 204 3-032-353-01 SPRING (CH), TENSION 205 3-033-803-01 SCREW (M1.7X2.5) * 206 X-3376-720-4 CHASSIS (OP) ASSY 207 3-032-373-01 SPRING (SPM), TENSION * 208 X-3376-724-2 LEVER (WORM WHEEL) ASSY 209 3-042-642-01 SPRING (LEVER D), TENSION * 210 1-670-828-11 MOTOR BOARD 211 3-033-807-01 SCREW (M2X3.0) 212 3-032-341-01 BRACKET (SL MOTOR) 0213 X-3380-858-2 PICK-UP ASSY, OPTICAL 214 3-032-345-02 RACK (FEED) 215 3-033-804-01 SCREW (+PTP 1.7X4) 216 3-032-358-02 SHAFT (SLED GUIDE) 217 3-032-344-02 GEAR (WORM WHEEL) 218 1-673-761-11 MOTOR FLEXIBLE BOARD 219 3-366-892-01 SCREW (M1.4X1.1) * 220 3-037-490-01 CUSHION (DH) 221 3-042-739-01 COVER (P) * 222 3-027-767-01 RETAINER (DISC) 223 3-931-894-01 BRACKET (CP) 224 X-3380-922-1 ARM (CH) ASSY M901 X-3379-269-1 MOTOR ASSY, SPINDLE (SPINDLE) M902 X-3377-704-1 MOTOR ASSY, SLED (SLED) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Ver 1.1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 51 WX-4500X 260 259 258 255 254 253 252 256 269 257 263 261 262 264 265 266 267 251 268 268 HP901 M904 #8 #7 not supplied 7-6. TAPE MECHANISM SECTION (MG-25E-136) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 251 A-3291-667-A CLUTCH (FR) ASSY * 252 3-019-130-01 LEVER (LDG-A) 253 3-019-131-05 LEVER (LDG-B) 254 3-228-690-01 SPRING (LD-1), TENSION 255 3-020-540-01 SPRING (LD-2), TENSION 256 3-020-542-01 GEAR (LOADING FT) 257 3-341-753-11 WASHER (FT), POLYETHYLENE 258 3-020-533-01 HOUSING * 259 3-020-532-01 ARM (SUCTION) 260 3-020-534-01 HANGER 261 3-933-346-01 CATCHER 262 3-933-344-22 GUIDE (C) 263 3-927-100-21 SCREW (+PS 2X10), SPECIAL 264 3-364-151-01 WASHER 265 A-3220-607-A MECHANISM DECK ASSY, TAPE 266 3-017-302-01 BELT (25) 267 3-026-636-01 FLYWHEEL (F) 268 3-701-437-21 WASHER 269 3-020-538-02 GEAR (LDG-FB) HP901 1-500-157-21 HEAD, MAGNETIC (PLAYBACK) M904 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 52 WX-4500X SECTION 8 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. • CAPACITORS uF : µF • COILS uH : µH Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. CD MAIN A-3340-039-A CD MAIN BOARD, COMPLETE ************************ < CAPACITOR > C101 1-110-449-11 ELECT CHIP 47uF 20% 6.3V C102 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C103 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C104 1-110-449-11 ELECT CHIP 47uF 20% 6.3V C105 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C106 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C108 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C110 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C111 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C112 1-115-412-11 CERAMIC CHIP 680PF 5% 25V C113 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C114 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C115 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V C116 1-110-444-11 ELECT CHIP 47uF 20% 4V C117 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V C118 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C119 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C120 1-128-934-11 CERAMIC CHIP 0.33uF 20% 10V C121 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C122 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C123 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C124 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C125 1-164-172-11 CERAMIC CHIP 0.0056uF 10% 25V C126 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C127 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C128 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C129 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C130 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C131 1-162-963-11 CERAMIC CHIP 680PF 10% 50V C132 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C133 1-128-934-11 CERAMIC CHIP 0.33uF 20% 10V C135 1-110-569-11 TANTAL. CHIP 47uF 20% 6.3V C136 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C137 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C138 1-110-449-11 ELECT CHIP 47uF 20% 6.3V C139 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C140 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C141 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V C145 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C146 1-162-925-11 CERAMIC CHIP 68PF 5% 50V C147 1-162-925-11 CERAMIC CHIP 68PF 5% 50V C201 1-115-565-11 CERAMIC CHIP 2.2uF 10% 10V C206 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C207 1-104-919-11 TANTAL. CHIP 10uF 20% 25V C301 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C302 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C303 1-110-451-11 ELECT CHIP 22uF 20% 10V < CONNECTOR > CNJ101 1-569-479-21 CONNECTOR, FPC 21P * CNJ102 1-750-249-21 CONNECTOR, FPC 16P CNJ103 1-764-436-21 CONNECTOR, FPC 6P * CNP102 1-580-756-21 PIN, CONNECTOR (SMD) 7P < IC > IC101 8-759-574-26 IC MN6627481RPMFA IC102 6-700-101-01 IC AN22000A-EA IC103 6-700-100-01 IC uPD780058GC-259-8BT IC201 8-759-574-24 IC BA5984FP-E2 < JUMPER RESISTOR > JC101 1-216-296-11 SHORT 0 JC102 1-216-296-11 SHORT 0 JC103 1-216-296-11 SHORT 0 JC104 1-216-296-11 SHORT 0 JC105 1-216-296-11 SHORT 0 JC106 1-216-296-11 SHORT 0 JC107 1-216-296-11 SHORT 0 JC108 1-216-296-11 SHORT 0 JC109 1-216-296-11 SHORT 0 JC110 1-216-296-11 SHORT 0 JC111 1-216-864-11 METAL CHIP 0 5% 1/16W JC112 1-216-296-11 SHORT 0 JC114 1-216-296-11 SHORT 0 JC115 1-216-296-11 SHORT 0 JC116 1-216-296-11 SHORT 0 JC119 1-216-296-11 SHORT 0 JC121 1-216-296-11 SHORT 0 JC122 1-216-296-11 SHORT 0 JC123 1-216-296-11 SHORT 0 JC124 1-216-296-11 SHORT 0 JC125 1-216-296-11 SHORT 0 JC126 1-216-296-11 SHORT 0 JC127 1-216-296-11 SHORT 0 JC128 1-216-864-11 METAL CHIP 0 5% 1/16W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 53 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark JC129 1-216-296-11 SHORT 0 JC130 1-216-296-11 SHORT 0 JC131 1-216-296-11 SHORT 0 JC133 1-216-296-11 SHORT 0 JC134 1-216-296-11 SHORT 0 JC135 1-216-296-11 SHORT 0 JC136 1-216-296-11 SHORT 0 JC137 1-216-296-11 SHORT 0 JC138 1-216-296-11 SHORT 0 JC139 1-216-296-11 SHORT 0 JC140 1-216-296-11 SHORT 0 JC141 1-216-296-11 SHORT 0 JC142 1-216-296-11 SHORT 0 JC201 1-216-296-11 SHORT 0 JC202 1-216-296-11 SHORT 0 JC203 1-216-296-11 SHORT 0 JC205 1-216-296-11 SHORT 0 JC208 1-216-296-11 SHORT 0 JC209 1-216-296-11 SHORT 0 JC210 1-216-296-11 SHORT 0 JC211 1-216-296-11 SHORT 0 JC212 1-216-296-11 SHORT 0 JC213 1-216-296-11 SHORT 0 JC301 1-216-296-11 SHORT 0 JC303 1-216-296-11 SHORT 0 JC305 1-216-296-11 SHORT 0 JC306 1-216-296-11 SHORT 0 JC307 1-216-296-11 SHORT 0 JC308 1-216-296-11 SHORT 0 JC309 1-216-296-11 SHORT 0 JC310 1-216-296-11 SHORT 0 JC311 1-216-296-11 SHORT 0 JC312 1-216-296-11 SHORT 0 JC313 1-216-296-11 SHORT 0 < TRANSISTOR > Q101 8-729-141-48 TRANSISTOR 2SB624-BV345 < RESISTOR > R101 1-216-809-11 METAL CHIP 100 5% 1/16W R102 1-216-843-11 METAL CHIP 68K 5% 1/16W R103 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R104 1-216-833-11 METAL CHIP 10K 5% 1/16W R105 1-216-841-11 METAL CHIP 47K 5% 1/16W R106 1-216-821-11 METAL CHIP 1K 5% 1/16W R107 1-216-833-11 METAL CHIP 10K 5% 1/16W R108 1-216-845-11 METAL CHIP 100K 5% 1/16W R109 1-216-833-11 METAL CHIP 10K 5% 1/16W R110 1-216-833-11 METAL CHIP 10K 5% 1/16W R111 1-216-833-11 METAL CHIP 10K 5% 1/16W R112 1-216-833-11 METAL CHIP 10K 5% 1/16W R113 1-216-833-11 METAL CHIP 10K 5% 1/16W R114 1-216-821-11 METAL CHIP 1K 5% 1/16W R115 1-216-821-11 METAL CHIP 1K 5% 1/16W R116 1-216-847-11 METAL CHIP 150K 5% 1/16W R117 1-216-839-11 METAL CHIP 33K 5% 1/16W R119 1-216-817-11 METAL CHIP 470 5% 1/16W R120 1-218-736-11 METAL CHIP 68K 0.5% 1/16W R121 1-216-809-11 METAL CHIP 100 5% 1/16W R122 1-216-836-11 METAL CHIP 18K 5% 1/16W R123 1-216-837-11 METAL CHIP 22K 5% 1/16W R124 1-216-848-11 METAL CHIP 180K 5% 1/16W R125 1-216-849-11 METAL CHIP 220K 5% 1/16W R126 1-216-150-11 RES-CHIP 10 5% 1/8W R127 1-216-797-11 METAL CHIP 10 5% 1/16W R128 1-216-793-11 RES-CHIP 4.7 5% 1/16W R129 1-216-013-00 METAL CHIP 33 5% 1/10W R130 1-218-742-11 METAL CHIP 120K 0.5% 1/16W R132 1-216-793-11 RES-CHIP 4.7 5% 1/16W R133 1-216-150-11 RES-CHIP 10 5% 1/8W R134 1-216-826-11 METAL CHIP 2.7K 5% 1/16W R135 1-216-849-11 METAL CHIP 220K 5% 1/16W R137 1-216-803-11 METAL CHIP 33 5% 1/16W R141 1-218-715-11 METAL CHIP 9.1K 0.5% 1/16W R142 1-218-715-11 METAL CHIP 9.1K 0.5% 1/16W R143 1-218-732-11 METAL CHIP 47K 0.5% 1/16W R144 1-218-732-11 METAL CHIP 47K 0.5% 1/16W R145 1-218-700-11 METAL CHIP 2.2K 0.5% 1/16W R146 1-218-710-11 METAL CHIP 5.6K 0.5% 1/16W R147 1-218-704-11 METAL CHIP 3.3K 0.5% 1/16W R148 1-216-841-11 METAL CHIP 47K 5% 1/16W R149 1-216-864-11 METAL CHIP 0 5% 1/16W R150 1-216-864-11 METAL CHIP 0 5% 1/16W R151 1-216-849-11 METAL CHIP 220K 5% 1/16W R152 1-216-849-11 METAL CHIP 220K 5% 1/16W R202 1-216-833-11 METAL CHIP 10K 5% 1/16W R203 1-216-833-11 METAL CHIP 10K 5% 1/16W R204 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R205 1-216-833-11 METAL CHIP 10K 5% 1/16W R206 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R207 1-216-833-11 METAL CHIP 10K 5% 1/16W R208 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R209 1-216-833-11 METAL CHIP 10K 5% 1/16W R301 1-216-821-11 METAL CHIP 1K 5% 1/16W R302 1-216-845-11 METAL CHIP 100K 5% 1/16W R304 1-216-845-11 METAL CHIP 100K 5% 1/16W R305 1-216-833-11 METAL CHIP 10K 5% 1/16W R307 1-216-864-11 METAL CHIP 0 5% 1/16W < VIBRATOR > X101 1-767-621-22 VIBRATOR, CERAMIC (16.93MHz) X301 1-781-383-22 VIBRATOR, CERAMIC (5MHz) ************************************************************* CD MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 54 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark DISPLAY A-3283-221-A DISPLAY BOARD, COMPLETE ************************ * 3-048-063-01 SHEET (FL), ADHESIVE * 3-230-714-01 SHEET (PHOTO) < CAPACITOR > C902 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C903 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C904 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C905 1-164-850-11 CERAMIC CHIP 10PF 0.5PF 16V C906 1-164-850-11 CERAMIC CHIP 10PF 0.5PF 16V C907 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C909 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C910 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C911 1-165-467-21 ELECT CHIP 47uF 20% 63V C913 1-119-669-11 CERAMIC CHIP 0.01uF 10% 250V C919 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C920 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V < CONNECTOR > CN902 1-779-823-21 CONNECTOR, BOARD TO BOARD 30P * CN903 1-785-242-21 CONNECTOR 5P (FFC/FPC) 1mm PITCH < DIODE > D900 8-719-404-50 DIODE MA111-TX D901 8-719-404-50 DIODE MA111-TX D903 8-719-064-68 LED LBT676-J2/K1/K2 (EQ) D905 8-719-064-68 LED LBT676-J2/K1/K2 (DSO) D907 8-719-078-39 LED CL-170SR-CD-T (CD WINDOW) D908 8-719-064-68 LED LBT676-J2/K1/K2 (DSO) D909 8-719-078-39 LED CL-170SR-CD-T (CD WINDOW) D911 8-719-064-68 LED LBT676-J2/K1/K2 (EQ) D960 8-719-422-43 DIODE MA8051-H < FERRITE BEAD > FB900 1-414-598-11 INDUCTOR, FERRITE BEAD < FLUORESCENT INDICATOR TUBE > FL700 1-518-760-11 INDICATOR TUBE, FLUORESCENT < IC > IC900 6-701-631-01 IC HD6432355A43F IC901 8-759-495-76 IC RN5VD33AA-TL PH960 8-749-012-25 IC RS-170-TU < SWITCH > LSW961 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SOURCE) LSW962 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (TAPE A) LSW963 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (TI) LSW964 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (CD A) LSW965 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (9 MODE) LSW966 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF) LSW967 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MENU) LSW968 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEEK/AMS + L J) LSW969 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEEK/AMS – l j) LSW970 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SOUND) LSW972 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL) LSW974 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SCRL) LSW975 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SA) < TRANSISTOR > Q901 8-729-020-67 TRANSISTOR XN1A312-TX < RESISTOR > R901 1-216-845-11 METAL CHIP 100K 5% 1/16W R902 1-216-845-11 METAL CHIP 100K 5% 1/16W R903 1-216-809-11 METAL CHIP 100 5% 1/16W R904 1-216-809-11 METAL CHIP 100 5% 1/16W R905 1-216-813-11 METAL CHIP 220 5% 1/16W R906 1-216-813-11 METAL CHIP 220 5% 1/16W R907 1-216-813-11 METAL CHIP 220 5% 1/16W R910 1-216-845-11 METAL CHIP 100K 5% 1/16W R911 1-216-853-11 METAL CHIP 470K 5% 1/16W R912 1-216-845-11 METAL CHIP 100K 5% 1/16W R913 1-218-990-11 SHORT 0 R917 1-216-845-11 METAL CHIP 100K 5% 1/16W R918 1-216-158-00 RES-CHIP 22 5% 1/8W R920 1-216-864-11 METAL CHIP 0 5% 1/16W R921 1-216-864-11 METAL CHIP 0 5% 1/16W R922 1-216-809-11 METAL CHIP 100 5% 1/16W R923 1-216-809-11 METAL CHIP 100 5% 1/16W R929 1-218-990-11 SHORT 0 R930 1-216-029-00 METAL CHIP 150 5% 1/10W R931 1-216-035-00 METAL CHIP 270 5% 1/10W R932 1-216-029-00 METAL CHIP 150 5% 1/10W R935 1-202-923-11 METAL CHIP 130 5% 1/16W R936 1-218-965-11 RES-CHIP 10K 5% 1/16W R938 1-216-035-00 METAL CHIP 270 5% 1/10W R939 1-216-190-00 RES-CHIP 470 5% 1/8W R940 1-216-035-00 METAL CHIP 270 5% 1/10W R942 1-216-182-00 RES-CHIP 220 5% 1/8W R943 1-216-809-11 METAL CHIP 100 5% 1/16W R948 1-218-977-11 RES-CHIP 100K 5% 1/16W R949 1-218-977-11 RES-CHIP 100K 5% 1/16W R951 1-216-819-11 METAL CHIP 680 5% 1/16W R952 1-216-819-11 METAL CHIP 680 5% 1/16W R953 1-216-819-11 METAL CHIP 680 5% 1/16W R954 1-216-821-11 METAL CHIP 1K 5% 1/16W R955 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R956 1-216-823-11 METAL CHIP 1.5K 5% 1/16W R957 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R958 1-216-827-11 METAL CHIP 3.3K 5% 1/16W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 55 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN JOG R959 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R960 1-216-831-11 METAL CHIP 6.8K 5% 1/16W R961 1-216-833-11 METAL CHIP 10K 5% 1/16W R962 1-216-835-11 METAL CHIP 15K 5% 1/16W R963 1-216-837-11 METAL CHIP 22K 5% 1/16W R964 1-216-841-11 METAL CHIP 47K 5% 1/16W R965 1-216-845-11 METAL CHIP 100K 5% 1/16W R967 1-216-845-11 METAL CHIP 100K 5% 1/16W R980 1-216-845-11 METAL CHIP 100K 5% 1/16W R991 1-216-295-11 SHORT 0 < NETWORK RESISTOR > RB900 1-233-576-11 RES, CHIP NETWORK 100X4 RB901 1-233-810-21 RES, CHIP NETWORK 100KX4 (3216) RB902 1-233-576-11 RES, CHIP NETWORK 100X4 < SWITCH > SW960 1-771-884-11 SWITCH, TACTILE (WITH LED) (RESET) SW971 1-771-884-11 SWITCH, TACTILE (WITH LED) (EQ) SW973 1-771-884-11 SWITCH, TACTILE (WITH LED) (DSO) < VIBRATOR > X901 1-795-350-11 VIBRATOR, CERAMIC (18.432MHz) ************************************************************* 1-680-656-11 JOG BOARD ********** < CONNECTOR > * CN904 1-785-242-21 CONNECTOR 5P (FFC/FPC) 1mm PITCH < DIODE > D902 8-719-078-39 LED CL-170SR-CD-T (JOG ILLUMINATION) D904 8-719-078-39 LED CL-170SR-CD-T (TAPE WINDOW) D906 8-719-078-39 LED CL-170SR-CD-T (JOG ILLUMINATION) < JOG ENCODER > EN960 1-418-503-13 ENCODER, JOG < RESISTOR > R937 1-216-041-00 METAL CHIP 470 5% 1/10W R944 1-216-194-00 METAL CHIP 680 5% 1/8W ************************************************************* A-3283-220-A MAIN BOARD, COMPLETE ********************* * 3-022-317-01 BRACKET (AMP) * 3-048-049-01 HEAT SINK 3-237-009-01 SPACER (SW) 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S 7-685-794-09 SCREW +PTT 2.6X10 (S) < CAPACITOR > C1 1-163-233-11 CERAMIC CHIP 18PF 5% 50V C2 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C5 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C10 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C13 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C14 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C15 1-128-994-21 ELECT CHIP 47uF 20% 10V C16 1-128-994-21 ELECT CHIP 47uF 20% 10V C18 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C19 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C20 1-126-206-11 ELECT CHIP 100uF 20% 6.3V C21 1-126-204-11 ELECT CHIP 47uF 20% 16V C101 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C103 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C104 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C105 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C106 1-163-022-00 CERAMIC CHIP 0.012uF 10% 50V C107 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V C108 1-126-601-11 ELECT CHIP 2.2uF 20% 50V C109 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C111 1-126-601-11 ELECT CHIP 2.2uF 20% 50V C112 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C116 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C117 1-124-779-00 ELECT CHIP 10uF 20% 16V C201 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C203 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C204 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C205 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C206 1-163-022-00 CERAMIC CHIP 0.012uF 10% 50V C207 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V C208 1-126-601-11 ELECT CHIP 2.2uF 20% 50V C209 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C211 1-126-601-11 ELECT CHIP 2.2uF 20% 50V C212 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C216 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C217 1-124-779-00 ELECT CHIP 10uF 20% 16V C301 1-128-994-21 ELECT CHIP 47uF 20% 10V C302 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C303 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C304 1-104-760-11 CERAMIC CHIP 0.047uF 10% 50V C305 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C307 1-107-682-11 CERAMIC CHIP 1uF 10% 16V C308 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C309 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C310 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V C311 1-128-994-21 ELECT CHIP 47uF 20% 10V C312 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C314 1-126-603-11 ELECT CHIP 4.7uF 20% 35V C315 1-124-779-00 ELECT CHIP 10uF 20% 16V C317 1-126-204-11 ELECT CHIP 47uF 20% 16V C321 1-124-779-00 ELECT CHIP 10uF 20% 16V C322 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C323 1-124-779-00 ELECT CHIP 10uF 20% 16V C325 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V DISPLAY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 56 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN C327 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C328 1-127-573-11 CERAMIC CHIP 1uF 10% 16V C400 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V C401 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C402 1-117-681-11 ELECT CHIP 100uF 20% 16V C403 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C404 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C405 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C407 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C408 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C409 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C410 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C412 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C413 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V C414 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V C415 1-124-779-00 ELECT CHIP 10uF 20% 16V C416 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C417 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C418 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C419 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C420 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C421 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C422 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C423 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C424 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C425 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C426 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C427 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C428 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C450 1-126-603-11 ELECT CHIP 4.7uF 20% 35V C462 1-124-779-00 ELECT CHIP 10uF 20% 16V C463 1-126-206-11 ELECT CHIP 100uF 20% 6.3V C464 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C465 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V C470 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C471 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C472 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C480 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C481 1-162-960-11 CERAMIC CHIP 220PF 10% 50V C482 1-109-982-11 CERAMIC CHIP 1uF 10% 10V C650 1-126-941-11 ELECT 470uF 20% 25V C651 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C652 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C653 1-124-779-00 ELECT CHIP 10uF 20% 16V C654 1-165-128-11 CERAMIC CHIP 0.22uF 16V C655 1-124-779-00 ELECT CHIP 10uF 20% 16V C660 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C661 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C662 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C663 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C701 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C703 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C705 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C707 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C708 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C709 1-164-935-11 CERAMIC CHIP 470PF 10% 16V C710 1-162-918-11 CERAMIC CHIP 18PF 5% 50V C711 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C712 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C713 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C718 1-126-206-11 ELECT CHIP 100uF 20% 6.3V C719 1-125-710-11 DOUBLE LAYERS 0.1F 5.5V C720 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C721 1-164-505-11 CERAMIC CHIP 2.2uF 16V C750 1-164-943-11 CERAMIC CHIP 0.01uF 10% 16V C802 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C803 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C804 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C805 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C806 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C807 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C808 1-107-682-11 CERAMIC CHIP 1uF 10% 16V C809 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C810 1-164-949-11 CERAMIC CHIP 0.047uF 16V C811 1-162-959-11 CERAMIC CHIP 330PF 5% 50V C813 1-107-682-11 CERAMIC CHIP 1uF 10% 16V C815 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C817 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C818 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C819 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C820 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C821 1-126-206-11 ELECT CHIP 100uF 20% 6.3V C823 1-117-681-11 ELECT CHIP 100uF 20% 16V C824 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C825 1-164-505-11 CERAMIC CHIP 2.2uF 16V C827 1-117-681-11 ELECT CHIP 100uF 20% 16V C828 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C830 1-117-681-11 ELECT CHIP 100uF 20% 16V C831 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C832 1-163-251-11 CERAMIC CHIP 100PF 5% 50V C833 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C834 1-164-505-11 CERAMIC CHIP 2.2uF 16V C836 1-107-820-11 CERAMIC CHIP 0.1uF 16V C837 1-117-681-11 ELECT CHIP 100uF 20% 16V C838 1-107-682-11 CERAMIC CHIP 1uF 10% 16V C839 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V C841 1-117-681-11 ELECT CHIP 100uF 20% 16V C842 1-117-681-11 ELECT CHIP 100uF 20% 16V C865 1-126-206-11 ELECT CHIP 100uF 20% 6.3V C866 1-128-551-71 ELECT 22uF 20% 63V C900 1-126-193-11 ELECT 1uF 20% 50V C901 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C902 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C903 1-137-944-11 ELECT 2200uF 20% 16V C905 1-126-603-11 ELECT CHIP 4.7uF 20% 35V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 57 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN < JACK > CN300 1-794-497-11 JACK, PIN 4P (BUS AUDIO IN, SUBWOOFER OUT (MONO)) < CONNECTOR > CN400 1-766-260-11 CONNECTOR, FFC/FPC (ZIF) 7P CN450 1-815-149-11 CONNECTOR, FPC/FFC (1mm PITCH) 21P * CN650 1-506-995-11 PIN, CONNECTOR (PC BOARD) 13P CN750 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN) CN900 1-793-277-11 PLUG, CONNECTOR 16P CN901 1-779-821-11 CONNECTOR, BOARD TO BOARD 30P < DIODE > D1 8-719-047-99 DIODE HZU5.6B3TRF D300 8-719-404-50 DIODE MA111-TX D302 8-719-404-50 DIODE MA111-TX D304 8-719-404-50 DIODE MA111-TX D305 8-719-404-50 DIODE MA111-TX D306 8-719-404-50 DIODE MA111-TX D452 8-719-404-50 DIODE MA111-TX D453 8-719-047-99 DIODE HZU5.6B3TRF D630 8-719-404-50 DIODE MA111-TX D650 8-719-053-18 DIODE 1SR154-400TE-25 D651 8-719-042-30 DIODE HZU9.1B2TRF D700 8-719-404-50 DIODE MA111-TX D701 8-719-820-05 DIODE 1SS181 D750 8-719-422-64 DIODE MA8062-M D751 8-719-057-80 DIODE MA8180-M-TX D752 8-719-033-43 DIODE RB751H D753 8-719-057-80 DIODE MA8180-M-TX D754 8-719-404-50 DIODE MA111-TX D755 8-719-801-78 DIODE 1SS184 D756 8-719-404-50 DIODE MA111-TX D757 8-719-057-80 DIODE MA8180-M-TX D800 8-719-404-50 DIODE MA111-TX D801 8-719-801-78 DIODE 1SS184 D803 8-719-404-50 DIODE MA111-TX D804 8-719-047-98 DIODE HZU5.6B2TRF D805 8-719-105-99 DIODE RD6.2M-B1 D806 8-719-053-18 DIODE 1SR154-400TE-25 D807 8-719-080-69 DIODE M1FS4-4063 D808 8-719-080-69 DIODE M1FS4-4063 D809 8-719-080-69 DIODE M1FS4-4063 D810 8-719-080-75 DIODE M1FL20U-4063 D811 8-719-080-69 DIODE M1FS4-4063 D812 8-719-070-29 DIODE PTZ-TE25-5.1B D813 8-719-404-50 DIODE MA111-TX D900 8-719-053-18 DIODE 1SR154-400TE-25 D901 8-719-053-18 DIODE 1SR154-400TE-25 D903 8-719-053-18 DIODE 1SR154-400TE-25 D907 8-719-049-38 DIODE 1N5404TU D908 8-719-053-18 DIODE 1SR154-400TE-25 D909 8-719-820-05 DIODE 1SS181 < IC > IC1 8-759-643-48 IC BA00ASFP-E2 IC100 8-759-278-58 IC NJM4558V-TE2 IC170 8-759-827-14 IC TA8268AH IC200 8-759-278-58 IC NJM4558V-TE2 IC300 8-759-827-13 IC TDA7406T IC301 8-759-476-23 IC BA08SFP-E2 IC400 8-752-079-79 IC CXA2510AQ-T4 IC451 8-759-278-58 IC NJM4558V-TE2 IC650 8-759-527-33 IC LB1930M-TLM IC700 6-801-063-01 IC MB90574CPMT-G-356-BNDE1 IC701 8-759-571-49 IC XC61AN4102PR IC702 8-759-495-76 IC RN5VD33AA-TL IC750 8-759-449-89 IC BA8270F-E2 IC800 8-759-060-94 IC MB3785APFV-G-BND-ER IC801 8-759-031-84 IC SC7S04F IC803 8-759-075-70 IC TA75S393F < JACK > J1 1-785-503-11 JACK (ANTENNA) J900 1-566-822-41 JACK (REMOTE IN) < COIL > L1 1-412-058-11 INDUCTOR CHIP 10uH L2 1-412-058-11 INDUCTOR CHIP 10uH L300 1-412-058-11 INDUCTOR CHIP 10uH L452 1-412-058-11 INDUCTOR CHIP 10uH L801 1-469-389-21 COIL, CHOKE 47uH L802 1-414-408-11 INDUCTOR 1uH L803 1-403-584-11 COIL, CHOKE 33uH L804 1-414-408-11 INDUCTOR 1uH L805 1-469-388-21 COIL, CHOKE 100uH L806 1-412-058-11 INDUCTOR CHIP 10uH L900 1-419-476-11 COIL, CHOKE 250uH L901 1-412-060-11 INDUCTOR 22uH < TRANSISTOR > Q1 8-729-920-85 TRANSISTOR 2SD1664-QR Q300 8-729-424-08 TRANSISTOR UN2111 Q301 8-729-421-22 TRANSISTOR UN2211 Q302 8-729-920-21 TRANSISTOR DTC314TKH04 Q303 8-729-047-71 TRANSISTOR FMG12-T-148 Q304 8-729-047-71 TRANSISTOR FMG12-T-148 Q450 8-729-020-67 TRANSISTOR XN1A312-TX Q451 8-729-807-12 TRANSISTOR 2SD1802-S Q650 8-729-807-12 TRANSISTOR 2SD1802-S Q651 8-729-020-67 TRANSISTOR XN1A312-TX Q653 8-729-106-60 TRANSISTOR 2SB1115A Q654 8-729-421-22 TRANSISTOR UN2211 Q750 8-729-424-08 TRANSISTOR UN2111 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 58 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN Q751 8-729-421-22 TRANSISTOR UN2211 Q800 8-729-421-22 TRANSISTOR UN2211 Q801 8-729-020-67 TRANSISTOR XN1A312-TX Q803 8-729-421-22 TRANSISTOR UN2211 Q804 8-729-822-84 TRANSISTOR 2SB1202FAST Q805 8-729-807-12 TRANSISTOR 2SD1802-S Q806 8-729-230-49 TRANSISTOR 2SC2712-YG Q807 8-729-421-22 TRANSISTOR UN2211 Q808 8-729-822-84 TRANSISTOR 2SB1202FAST Q809 8-729-822-84 TRANSISTOR 2SB1202FAST Q810 8-729-025-48 TRANSISTOR XN4381 Q812 8-729-216-22 TRANSISTOR 2SA1162-G Q813 8-729-230-49 TRANSISTOR 2SC2712-YG Q814 8-729-049-23 FET 2SK3150STL Q900 8-729-055-53 FET UPA1853GR-9JG-E2 Q902 8-729-429-92 TRANSISTOR XN1211 Q903 8-729-230-49 TRANSISTOR 2SC2712-YG Q904 8-729-230-49 TRANSISTOR 2SC2712-YG Q905 8-729-424-08 TRANSISTOR UN2111 Q906 8-729-230-49 TRANSISTOR 2SC2712-YG Q907 8-729-025-48 TRANSISTOR XN4381 Q908 8-729-025-48 TRANSISTOR XN4381 < RESISTOR > R1 1-216-001-00 METAL CHIP 10 5% 1/10W R2 1-216-864-11 METAL CHIP 0 5% 1/16W R3 1-216-041-00 METAL CHIP 470 5% 1/10W R4 1-216-864-11 METAL CHIP 0 5% 1/16W R5 1-216-864-11 METAL CHIP 0 5% 1/16W R6 1-216-809-11 METAL CHIP 100 5% 1/16W R7 1-216-809-11 METAL CHIP 100 5% 1/16W R8 1-218-969-11 RES-CHIP 22K 5% 1/16W R9 1-218-728-11 METAL CHIP 33K 0.5% 1/16W R10 1-218-710-11 METAL CHIP 5.6K 0.5% 1/16W R11 1-216-049-11 RES-CHIP 1K 5% 1/10W R100 1-216-864-11 METAL CHIP 0 5% 1/16W R104 1-216-809-11 METAL CHIP 100 5% 1/16W R105 1-216-809-11 METAL CHIP 100 5% 1/16W R106 1-218-965-11 RES-CHIP 10K 5% 1/16W R107 1-218-965-11 RES-CHIP 10K 5% 1/16W R110 1-216-833-11 METAL CHIP 10K 5% 1/16W R111 1-216-833-11 METAL CHIP 10K 5% 1/16W R112 1-216-809-11 METAL CHIP 100 5% 1/16W R113 1-218-973-11 RES-CHIP 47K 5% 1/16W R114 1-216-864-11 METAL CHIP 0 5% 1/16W R115 1-216-809-11 METAL CHIP 100 5% 1/16W R116 1-218-973-11 RES-CHIP 47K 5% 1/16W R117 1-216-864-11 METAL CHIP 0 5% 1/16W R118 1-216-089-11 RES-CHIP 47K 5% 1/10W R119 1-216-025-11 RES-CHIP 100 5% 1/10W R121 1-216-833-11 METAL CHIP 10K 5% 1/16W R122 1-216-833-11 METAL CHIP 10K 5% 1/16W R130 1-218-965-11 RES-CHIP 10K 5% 1/16W R200 1-216-864-11 METAL CHIP 0 5% 1/16W R204 1-216-809-11 METAL CHIP 100 5% 1/16W R205 1-216-809-11 METAL CHIP 100 5% 1/16W R206 1-218-965-11 RES-CHIP 10K 5% 1/16W R207 1-218-965-11 RES-CHIP 10K 5% 1/16W R210 1-216-833-11 METAL CHIP 10K 5% 1/16W R211 1-216-833-11 METAL CHIP 10K 5% 1/16W R212 1-216-809-11 METAL CHIP 100 5% 1/16W R213 1-218-973-11 RES-CHIP 47K 5% 1/16W R214 1-216-864-11 METAL CHIP 0 5% 1/16W R215 1-216-809-11 METAL CHIP 100 5% 1/16W R216 1-218-973-11 RES-CHIP 47K 5% 1/16W R217 1-216-864-11 METAL CHIP 0 5% 1/16W R218 1-216-089-11 RES-CHIP 47K 5% 1/10W R219 1-216-025-11 RES-CHIP 100 5% 1/10W R221 1-216-833-11 METAL CHIP 10K 5% 1/16W R222 1-216-833-11 METAL CHIP 10K 5% 1/16W R230 1-218-965-11 RES-CHIP 10K 5% 1/16W R302 1-216-845-11 METAL CHIP 100K 5% 1/16W R303 1-216-831-11 METAL CHIP 6.8K 5% 1/16W R305 1-216-864-11 METAL CHIP 0 5% 1/16W R306 1-218-973-11 RES-CHIP 47K 5% 1/16W R307 1-216-809-11 METAL CHIP 100 5% 1/16W R308 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R309 1-216-017-11 RES-CHIP 47 5% 1/10W R312 1-216-089-11 RES-CHIP 47K 5% 1/10W R313 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R314 1-216-073-00 RES-CHIP 10K 5% 1/10W R315 1-216-025-11 RES-CHIP 100 5% 1/10W R316 1-216-295-11 SHORT 0 R317 1-216-295-11 SHORT 0 R318 1-216-049-11 RES-CHIP 1K 5% 1/10W R319 1-218-973-11 RES-CHIP 47K 5% 1/16W R320 1-216-809-11 METAL CHIP 100 5% 1/16W R321 1-216-809-11 METAL CHIP 100 5% 1/16W R340 1-216-073-00 RES-CHIP 10K 5% 1/10W R341 1-216-073-00 RES-CHIP 10K 5% 1/10W R345 1-216-809-11 METAL CHIP 100 5% 1/16W R399 1-216-821-11 METAL CHIP 1K 5% 1/16W R400 1-216-836-11 METAL CHIP 18K 5% 1/16W R401 1-216-834-11 METAL CHIP 12K 5% 1/16W R402 1-216-851-11 METAL CHIP 330K 5% 1/16W R403 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R404 1-216-001-00 METAL CHIP 10 5% 1/10W R405 1-216-827-11 METAL CHIP 3.3K 5% 1/16W R406 1-218-985-11 RES-CHIP 470K 5% 1/16W R407 1-218-965-11 RES-CHIP 10K 5% 1/16W R408 1-216-079-00 METAL CHIP 18K 5% 1/10W R409 1-216-836-11 METAL CHIP 18K 5% 1/16W R410 1-216-834-11 METAL CHIP 12K 5% 1/16W R411 1-216-851-11 METAL CHIP 330K 5% 1/16W R412 1-216-033-00 METAL CHIP 220 5% 1/10W R413 1-216-033-00 METAL CHIP 220 5% 1/10W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 59 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN R414 1-216-845-11 METAL CHIP 100K 5% 1/16W R415 1-216-845-11 METAL CHIP 100K 5% 1/16W R416 1-216-845-11 METAL CHIP 100K 5% 1/16W R417 1-216-845-11 METAL CHIP 100K 5% 1/16W R418 1-216-821-11 METAL CHIP 1K 5% 1/16W R419 1-216-864-11 METAL CHIP 0 5% 1/16W R421 1-216-864-11 METAL CHIP 0 5% 1/16W R455 1-216-049-11 RES-CHIP 1K 5% 1/10W R456 1-216-845-11 METAL CHIP 100K 5% 1/16W R470 1-216-841-11 METAL CHIP 47K 5% 1/16W R471 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R472 1-216-833-11 METAL CHIP 10K 5% 1/16W R480 1-216-841-11 METAL CHIP 47K 5% 1/16W R481 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R482 1-216-833-11 METAL CHIP 10K 5% 1/16W R539 1-216-089-11 RES-CHIP 47K 5% 1/10W R650 1-216-049-11 RES-CHIP 1K 5% 1/10W R651 1-216-150-11 RES-CHIP 10 5% 1/8W R652 1-216-150-11 RES-CHIP 10 5% 1/8W R653 1-216-150-11 RES-CHIP 10 5% 1/8W R654 1-216-150-11 RES-CHIP 10 5% 1/8W R655 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R656 1-216-073-00 RES-CHIP 10K 5% 1/10W R700 1-218-941-11 RES-CHIP 100 5% 1/16W R701 1-216-845-11 METAL CHIP 100K 5% 1/16W R702 1-218-977-11 RES-CHIP 100K 5% 1/16W R704 1-218-941-11 RES-CHIP 100 5% 1/16W R707 1-216-845-11 METAL CHIP 100K 5% 1/16W R708 1-216-097-11 RES-CHIP 100K 5% 1/10W R710 1-218-965-11 RES-CHIP 10K 5% 1/16W R711 1-218-941-11 RES-CHIP 100 5% 1/16W R712 1-218-977-11 RES-CHIP 100K 5% 1/16W R713 1-218-977-11 RES-CHIP 100K 5% 1/16W R714 1-218-965-11 RES-CHIP 10K 5% 1/16W R715 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R716 1-218-965-11 RES-CHIP 10K 5% 1/16W R717 1-218-965-11 RES-CHIP 10K 5% 1/16W R718 1-218-965-11 RES-CHIP 10K 5% 1/16W R719 1-218-965-11 RES-CHIP 10K 5% 1/16W R720 1-216-855-11 METAL CHIP 680K 5% 1/16W R721 1-216-845-11 METAL CHIP 100K 5% 1/16W R722 1-216-845-11 METAL CHIP 100K 5% 1/16W R723 1-218-977-11 RES-CHIP 100K 5% 1/16W R724 1-216-845-11 METAL CHIP 100K 5% 1/16W R725 1-216-864-11 METAL CHIP 0 5% 1/16W R726 1-218-977-11 RES-CHIP 100K 5% 1/16W R727 1-218-990-11 SHORT 0 R729 1-218-990-11 SHORT 0 R730 1-216-845-11 METAL CHIP 100K 5% 1/16W R733 1-218-977-11 RES-CHIP 100K 5% 1/16W R734 1-218-985-11 RES-CHIP 470K 5% 1/16W R735 1-216-809-11 METAL CHIP 100 5% 1/16W R750 1-216-809-11 METAL CHIP 100 5% 1/16W R751 1-216-077-11 RES-CHIP 15K 5% 1/10W R752 1-216-809-11 METAL CHIP 100 5% 1/16W R753 1-216-049-11 RES-CHIP 1K 5% 1/10W R755 1-216-809-11 METAL CHIP 100 5% 1/16W R756 1-216-809-11 METAL CHIP 100 5% 1/16W R800 1-218-967-11 RES-CHIP 15K 5% 1/16W R801 1-218-973-11 RES-CHIP 47K 5% 1/16W R802 1-218-973-11 RES-CHIP 47K 5% 1/16W R803 1-218-967-11 RES-CHIP 15K 5% 1/16W R804 1-218-973-11 RES-CHIP 47K 5% 1/16W R805 1-218-973-11 RES-CHIP 47K 5% 1/16W R806 1-219-336-21 RES-CHIP 82K 2% 1/16W R807 1-218-716-11 METAL CHIP 10K 0.5% 1/16W R808 1-216-065-11 RES-CHIP 4.7K 5% 1/10W R810 1-218-973-11 RES-CHIP 47K 5% 1/16W R811 1-218-973-11 RES-CHIP 47K 5% 1/16W R812 1-218-967-11 RES-CHIP 15K 5% 1/16W R813 1-218-973-11 RES-CHIP 47K 5% 1/16W R814 1-218-973-11 RES-CHIP 47K 5% 1/16W R815 1-218-973-11 RES-CHIP 47K 5% 1/16W R816 1-218-979-11 RES-CHIP 150K 5% 1/16W R818 1-218-965-11 RES-CHIP 10K 5% 1/16W R819 1-218-969-11 RES-CHIP 22K 5% 1/16W R822 1-216-037-00 METAL CHIP 330 5% 1/10W R823 1-216-037-00 METAL CHIP 330 5% 1/10W R824 1-216-037-00 METAL CHIP 330 5% 1/10W R825 1-216-085-11 RES-CHIP 33K 5% 1/10W R827 1-219-316-11 RES-CHIP 12K 2% 1/16W R828 1-218-859-11 RES-CHIP 3.3K 2% 1/16W R829 1-216-033-00 METAL CHIP 220 5% 1/10W R830 1-216-033-00 METAL CHIP 220 5% 1/10W R831 1-219-326-11 RES-CHIP 33K 2% 1/16W R832 1-218-863-11 RES-CHIP 4.7K 2% 1/16W R833 1-216-033-00 METAL CHIP 220 5% 1/10W R834 1-219-320-11 RES-CHIP 18K 2% 1/16W R836 1-218-859-11 RES-CHIP 3.3K 2% 1/16W R837 1-216-049-11 RES-CHIP 1K 5% 1/10W R838 1-216-049-11 RES-CHIP 1K 5% 1/10W R839 1-216-049-11 RES-CHIP 1K 5% 1/10W R840 1-216-049-11 RES-CHIP 1K 5% 1/10W R841 1-216-049-11 RES-CHIP 1K 5% 1/10W R842 1-216-049-11 RES-CHIP 1K 5% 1/10W R846 1-216-845-11 METAL CHIP 100K 5% 1/16W R847 1-216-073-00 RES-CHIP 10K 5% 1/10W R848 1-216-077-11 RES-CHIP 15K 5% 1/10W R849 1-216-065-11 RES-CHIP 4.7K 5% 1/10W R850 1-216-065-11 RES-CHIP 4.7K 5% 1/10W R852 1-216-198-11 RES-CHIP 1K 5% 1/8W R853 1-216-198-11 RES-CHIP 1K 5% 1/8W R854 1-216-198-11 RES-CHIP 1K 5% 1/8W R858 1-216-085-11 RES-CHIP 33K 5% 1/10W R859 1-216-085-11 RES-CHIP 33K 5% 1/10W R860 1-216-845-11 METAL CHIP 100K 5% 1/16W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 60 WX-4500X Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN R861 1-216-017-11 RES-CHIP 47 5% 1/10W R862 1-216-089-11 RES-CHIP 47K 5% 1/10W R863 1-216-089-11 RES-CHIP 47K 5% 1/10W R864 1-216-049-11 RES-CHIP 1K 5% 1/10W R868 1-216-845-11 METAL CHIP 100K 5% 1/16W R893 1-216-085-11 RES-CHIP 33K 5% 1/10W R894 1-216-049-11 RES-CHIP 1K 5% 1/10W R895 1-219-351-21 RES-CHIP 360K 2% 1/16W R896 1-218-871-11 RES-CHIP 10K 2% 1/16W R900 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R901 1-216-089-11 RES-CHIP 47K 5% 1/10W R902 1-216-089-11 RES-CHIP 47K 5% 1/10W R903 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R904 1-216-049-11 RES-CHIP 1K 5% 1/10W R905 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R906 1-216-049-11 RES-CHIP 1K 5% 1/10W R907 1-216-845-11 METAL CHIP 100K 5% 1/16W R908 1-218-969-11 RES-CHIP 22K 5% 1/16W R909 1-218-973-11 RES-CHIP 47K 5% 1/16W R910 1-218-941-11 RES-CHIP 100 5% 1/16W R911 1-218-716-11 METAL CHIP 10K 0.5% 1/16W R912 1-216-073-00 RES-CHIP 10K 5% 1/10W R913 1-216-073-00 RES-CHIP 10K 5% 1/10W R920 1-218-716-11 METAL CHIP 10K 0.5% 1/16W R921 1-216-809-11 METAL CHIP 100 5% 1/16W R922 1-216-809-11 METAL CHIP 100 5% 1/16W R923 1-216-821-11 METAL CHIP 1K 5% 1/16W < NETWORK RESISTOR > RB700 1-233-576-11 RES, CHIP NETWORK 100X4 RB701 1-233-810-21 RES, CHIP NETWORK 100KX4 (3216) < CERMET RESISTOR > RV400 1-225-205-11 RES, ADJ, CERMET 10K RV401 1-225-205-11 RES, ADJ, CERMET 10K < SWITCH > S700 1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT) < TRANSFORMER > T800 1-435-598-11 TRANSFORMER, DC-DC CONVERTER < THERMISTOR (POSITIVE) > TH750 1-801-792-21 THERMISTOR, POSITIVE TH900 1-803-615-21 THERMISTOR, POSITIVE TH901 1-803-615-21 THERMISTOR, POSITIVE < TUNER > TU1 A-3220-812-A TUNER UNIT (TUX-020) < VIBRATOR > X451 1-781-660-11 VIBRATOR, CERAMIC (3.58MHz) X700 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************* * 1-670-828-11 MOTOR BOARD ************* < SWITCH > SW5 1-762-946-12 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************* * 1-670-827-11 SW BOARD ********** < SWITCH > SW2 1-762-946-12 SWITCH, PUSH (1 KEY) (DISC DETECT) SW3 1-762-946-12 SWITCH, PUSH (1 KEY) (LOADING DETECT) SW4 1-762-946-12 SWITCH, PUSH (1 KEY) (CHUCKING DETECT) ************************************************************* MISCELLANEOUS *************** 3 1-790-926-21 CORD (WITH CONNECTOR) (POWER) 63 1-757-576-11 CABLE, FLEXIBLE FLAT 5P 103 1-792-838-12 CABLE, FLEXIBLE FLAT (21 CORE) 0213 X-3380-858-2 PICK-UP ASSY, OPTICAL 218 1-673-761-11 MOTOR FLEXIBLE BOARD F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A HP901 1-500-157-21 HEAD, MAGNETIC (PLAYBACK) M901 X-3379-269-1 MOTOR ASSY, SPINDLE (SPINDLE) M902 X-3377-704-1 MOTOR ASSY, SLED (SLED) M903 X-3378-888-1 MOTOR ASSY, LO (LOADING) M904 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL) ************************************************************* ACCESSORIES ************ 3-229-005-11 MANUAL, INSTRUCTION (ENGLISH, TRADITIONAL CHINESE,KOREAN) 3-229-007-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, TRADITIONAL CHINESE,KOREAN) ************************************************************* ************** HARDWARE LIST ************** #1 7-685-792-09 SCREW +PTT 2.6X6 (S) #2 7-685-105-19 TPG +P 2X8, TYPE2, NON-SLIT #3 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S #4 7-685-794-09 SCREW +PTT 2.6X10 (S) #5 7-624-101-04 STOP RING 1.2 (E TYPE) #6 7-685-780-01 SCREW +PTT 2X3 (S) #7 7-624-104-04 STOP RING 2.0, TYPE -E #8 7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3 ************************************************************* MOTOR SW Ver 1.1 The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 61 WX-4500X Ref. No. Part No. Description Remark PARTS FOR INSTALLATION AND CONNECTIONS ************************************** 301 X-3375-549-1 SCREW ASSY (6) 302 3-023-953-11 SCREW, +T (5X8) TAPPING 303 3-038-767-02 FRAME (N), ORNAMENT 304 1-790-926-21 CORD (WITH CONNECTOR) (POWER) 1-543-653-21 CORE ASSY, BEAD (DIVISION TYPE) (for POWER CORD) 302 301 303 304 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 62 WX-4500X REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2001. 09 New 1.1 2002. 10 Part number correction of optical pick-up assy (SPM-02009) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com