TL-HA80 SERVICE MANUAL HANDS FREE ADAPTOR SPECIFICATIONS US Model 9-873-108-11 2001E0200-1 © 2001.5 Photo : TL-HA80 Photo : TL-DR0140 Sony Corporation Personal Audio Company Shinagawa Tec Service Manual Production Group Ver 1.0 2001.05 Headset (TL-DR0140) Dimension (Cord) Approx. 7 ft. (2m) Dimension (Plug) 3.5 mm dia. Mass Approx. 0.88 oz (25 g) (without cord) Type Open air dynamic Driver units 30 mm dia. (CCAW Voice coil) Sensitivity 104 dB/mW Impedance 24 Maximum input power 1000 mW (IEC) Type Close-talking pipe microphone Unit Back electret condenser Output impedance Under 2.2 k Closed circuit voltage level -47 dB (0 dB = 1 V/Pa) Design and specifications are subject to change without notice. Power source DC 9V from AC power adaptor Dimensions Approx. 3 5⁄8 x 3 7⁄8 x 6 5⁄8 inches (w/h/d) (92 x 96 x 165.5 mm) Mass Approx. 10.58 oz (300 g) Supplied accessories AC power adaptor (AC-T127) Telephone cord: approx. 1 ft. (30cm) Stereo audio cable (stereo mini-plug): approx. 3.5 ft. (1m) Headset TL-DR0140 Headset hanger www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 TL-HA80 Specifications ........................................................................... 1 1. GENERAL ...................................................................... 2 2. DISASSEMBLY 2-1. Cabinet (Upper) ASSY ............................................... 4 2-2. Main noard, Volume board, Jack Bords...................... 4 3. DIAGRAMS 3-1. Block Diagram............................................................ 5 3-2. Schematic Diagram..................................................... 6 3-3. Printed Wiring Boards ................................................ 7 4. EXPLODED VIEWS .................................................... 8 5. ELECTRICAL PARTS LIST ..................................... 9 TABLE OF CONTENTS SECTION 1 GENERAL This section is extracted from instruction manual. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be dam- aged by heat. Setting up the unit Connect the unit 1 Connect the AC power adaptor to the DC IN jack and to an AC outlet. 2 Disconnect the handset cord from the handset jack on the phone and connect the handset cord to the HANDSET jack of the unit. 3 Open the cover on the bottom of this unit and remove the switch securing cover. 4 Turn ON the TEST switch and make sure that you can hear a long confirmation beep from the speaker side on the handset. If no long confirmation beep is heard from the speaker side on the handset, see "If no long confirmation beep is heard" to select the setting of the A and B switches. 5 Turn OFF the TEST switch and put a switch securing cover. 6 Close the cover on the bottom. 7 Connect the telephone cord (supplied) to the phone and to the TEL jack of the unit. Notes • Use only the supplied AC-T127 AC power adaptor. Do not use any other AC power adaptor. • Use only the supplied telephone cord. Do not use any other telephone cord. • Do not close the AC power adaptor. It may cause noises. • During a power interruption, you cannot use this unit. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 TL-HA80 Tip When an external equipment is connected to the AUDIO IN jack and the handset is not placed on the TALK lever, the sound from the external equipment is connected to the headset in either case that the handset is in the on-hook or off-hook status on the main body of the phone. Notes • If your phone's handset does not stay on the TALK lever and easily drops from it, pull up the holder and place the handset as shown in the figure. • Howling noise might occur depending on the connected phone. In this case, lower the receiver HEADSET VOLUME (TEL) control to a suitable position before use. Additional tasks Do this Turn the HEADSET VOLUME (TEL) up to increase the receiver volume or down to decrease it. Put a coin, etc. in the slot of the MIC VOLUME control, and turn right or left to adjust. Adjust the microphone volume control to the suitable position by asking another party on the line to check. Press to disable the microphone. The button lights up. Press again to cancel. To Adjust the receiver volume Adjust the microphone volume Mute your voice If no long confirmation beep is heard 1 Turn ON the TEST switch. 2 Set the A switch to the position (1 to 4) where a long confirmation beep is heard. If this doesn't work and no long confirmation beep is heard yet, turn the B switch to 2 and then set the A switch to the position where a long confirmation beep is heard. Notes • Depending on the handset, a long confirmation beep is heard from the microphone side. Be sure to set the A and B switches to the position where a long confirmation beep is heard from the speaker side. • If you have connected this unit to another phone, follow the instructions described in “Connect the unit”. Listening to music, etc. from an external equipment If you want to listen to music, etc. from the external equipment, you can do it using the headset during handset on-hook status. Notes • When you are listening to music, etc. with the external equipment connected to AUDIO IN jack, HEADSET VOLUME (TEL) is not available. Volume control is available with the connected equipment. Also, turning off the sound from the connected equipment can be done either by shutting down the power for the external equipment or by pulling out the stereo audio cable from AUDIO IN jack on this unit. • The sound of this unit is a monaural type. Connect the headset 1 Connect the headset plug to the HEADSET jack. 2 Place the earpiece support unit behind the top of your ear. 3 Adjust the length of the headband so that the headset fits on your ear. 4 The earpiece can be rotated so it fits comfortably over either ear. 5 Position the headset microphone so that it is placed near the mouth. Notes • Listening with headset at high volume may affect your hearing. • The earpad may deteriorate due to long-term storage or use. If you need to replacing the earpad, it can be purchase separately (EP-Q1). Tip You can use the headset on either your right or left ear. Using the headset hunger The headset can be hung on the hook (supplied) by mounting the headset hanger (supplied) on the headset. Switching handset/headset conversation The handset/headset conversation can be switched by placing the handset on the TALK lever. When the handset is placed on the TALK lever: Headset conversation mode When the handset is not placed on the TALK lever: Handset conversation mode 1 Attach the headset hanger to the headset from the slit as illustration . Be sure to insert the protrusion of the headset hanger to the projection of the headset. 2 Hang the headset hanger on the hook. Note Do not hang the headset on as illustration . www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 TL-HA80 SECTION 2 DISASSEMBLY 2-1. CASE (UPPER) Note : Follow the disassembly procedure in the numerical order given. 2-2. MAIN BOARD, VOLUME BOARD, JACK BOARD Case (upper) Main board, Volume board, Jack board Set 1 Screw (+BVTP3X10) 1 Screws (+BVTP3X10) Case (upper) Case (lower) 2 7 Screws (+BVTP2.6X8) 5 Screw (+BTP2.6X8) 6 Audio board 9 MJ102 Case (lower) 2 Knob (MIC) 1 Knob (VOL) 7 Screws (+BVTP2.6X8) 3 Screws (+BTP2.6X8) qaMJ101 Spred 0claws and put qaMJ101 off from the case (lower) 4 Volume board 0 Claws Main board Case (upper) 8 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 5 TL-HA80 3-1. BLOCK DIAGRAMS • Signal path. H : RX O : TX SECTION 3 DIAGRAMS J301 MJ102 MJ101 F101 F102 F103 T102 D201 D202 S201 J103 T101 CDS1 RY101 J105 RV202 RV201 S105 D104 JW103 JW203 S101 D106 RY102 RY103 250V 500mA 250V 500mA 250V 500mA DC IN 9V Q CK PR CLR Q D + HEADSET HANDSET TEL OFF ON S104 S102 B 2 1 S103 1 2 3 4 A TEST MODE ON OFF AMP HEADPHONE MUTING (TEL) HANDSET VOLUME MUTING (LINE) MIC VOLUME +5V REG LED DRIVER MUTING HOLD ANALOG SWITCH RELAY DRIVER LED DRIVER TALK (HANDSET) (HEADSET) RELAY DRIVER Q106 Q109 Q108 /BUFFER DELAY D109 DELAY IC101 MIC AMP Q101,102 +5V IC102 +5V ANALOG SWITCH IC105 Q112 MUTE Q110,111 LEVEL DETECT IC103 AUDIO IN +5V IC104 +5V +5V DELAY SIGNAL TEST GENERATOR Q104,105 +5V +5V D107 RY101-2 RY101-1 RY102-1 RY103-1 Q107 VDD VDD OR Q103 S103-A S103-B S103-C S103-D TEST MODE S104-D S104-C S104-B S104-A +5V D108 VDD VDD w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 6 TL-HA80 3-2. SCHEMATIC DIAGRAM z Refer to page 8 for Notes. z Refer to page 8 for Waveforms. z Refer to page 8 for IC Block Diagrams. R111 MJ101 JW203 JW103 F101 F102 F103 RY101 RY102 D101 RY103 D102 D107 D108 D109 C101 C102 C103 C104 C105 C108 C110 C111 C112 C113 R101 R104 R105 R106 R108 R109 R112 R113 R114 R115 C148 C149 R116 R118 R158 CDS1 C116 C117 C118 T101 C119 C120 T102 C122 C123 C124 C125 C126 C128 C129 C130 C136 C138 C139 C140 R122 R123 R124 R125 R126 R127 R128 R129 R130 R131 R132 R134 R135 R136 R137 R138 R139 R140 R142 R141 R143 R144 R145 R147 R148 R149 R151 R150 R153 R154 R155 R152 C143 C144 C145 R160 C151 C152 R161 Q101 Q102 Q103 Q104 Q105 Q109 R120 S201 D201 D202 S105 R103 C153 R156 R157 R102 ZD104 ZD105 C107 R110 R107 C903 R159 R119 J301 VR201 VR202 CN101 CN201 J103 D106 Q107 Q106 C135 C134 R133 C131 R163 R164 C154 C155 R167 C901 C902 C156 C157 R165 Q110 Q111 Q112 R162 J104 C137 R121 Q108 C142 R146 C150 MJ102 S101 D104 C109 C106 22k 250V 500mA 250V 500mA 250V 500mA DAN202A DAN202A DAN202A DAN202A DAN202A 4.7 4.7 0.1 0.1 0.1 0.1 390p 1000p 0.1 0.47 10k 100 560 100k 100k 47k 100k 100k 100k 22k 1 0.47 1k 330 100k 4.7 4.7 0.01 4.7 4.7 0.1 0.022 0.022 0.022 0.01 0.1 0.015 2.2 0.1 10 0.1 0.1 3.9k 5.6k 220k 1k 1k 270k 330k 150k 100 6.8k 2.2k 47 10 22k 5.6k 330 330 10k 100 100 68 100 100k 1M 22k 22k 12k 2.2k 560 10k 10k 100k 0.047 0.1 1 4.7k 0.1 0.01 2.2M 2SC2412K 2SC2412K 2SC2412K 2SC2412K 2SC2412K 2SC2412K 470 100k 1000p 10k 100k 47k UDZ27 UDZ27 6800p 0 22k 0.01 100 2.2k 10K 10K 1SR139-400 2SC2412K 2SC2412K 220 6.3V 82p 390k 10 1M 1M 0.01 0.01 27 2.2 2.2 2.2 2.2 100k 2SA1576A 2SA1576A 2SC2412K MUTE 12k 100 10V 180 2SC2412K 22 25V 2.2k 0.1 TLRE180AP 100 10V 10 AS1 AS2 BS1 BS2 BCT CCT GND CS1 CS2 DS1 DS2 DCT ACT VCC VCC Q CK GND PR CLR Q D CD +VREF -VIN VOUT2 VOUT1 +VIN GND V+ AS1 AS2 BS1 BS2 BCT CCT GND CS1 CS2 DS1 DS2 DCT ACT VCC DC IN 9V IC102 ANALOG SWITCH ANALOG SWITCH IC104 NJM78M05 IC103 IC105 IC101 TC7W74F MUTING TEL S102 S102 B 2 1 S103 1 2 3 4 A MUTING HOLD TALK (HANDSET) (HEADSET) OFF ON S104 MIC AMP MIC AMP OR HEADSET (TEL) HANDSET VOLUME MUTING (LINE) MIC VOLUME +5V REG RELAY DRIVER DRIVER LED AMP HEADPHONE NJM2113M Q110,111 LEVEL DETECT AUDIO IN SIGNAL TEST GENERATOR Q104,105 TEST MODE ON OFF RELAY DRIVER BUFFER LED DRIVER TC74HC4066AF HANDSET TC74HC0466AF TEST MODE S104-A S104-B S104-C S104-D S103-A S103-B S103-C S103-D w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 7 TL-HA80 D101 C-4 D102 D-4 D104 D-3 D106 D-5 D107 D-4 D108 D-4 D109 D-3 D201 A-1 D202 E-1 IC101 A-4 IC102 B-5 IC103 B-3 IC104 D-4 IC105 E-3 Q101 A-5 Q102 B-5 Q103 B-5 Q104 B-4 Q105 C-4 Q106 D-3 Q107 D-3 Q108 C-3 Q109 C-3 Q110 C-3 Q111 C-3 Q112 C-2 ZD104 C-3 ZD105 C-3 11 (12) 1-681-414- 12 (12) 1-681-412- 11 (12) 1-681-413- 12 (12) 1-681-412- VOLUME BOARD MAIN BOARD (SIDE B) MAIN BOARD (SIDE A) AUDIO BOARD C106 C109 C102 MJ101 MJ101 TEL C101 C138 C120 C119 B A D C B A D C C135 C137 C131 MJ102 MJ102 HANDSET CN101 CN201 C117 C113 C116 C142 1 10 RY102 RY103 S102 B 2 1 F101 RY101 RY101 F103 F102 DC IN 9V J103 IC104 D106 1 10 S103 A 4 3 2 1 S104,105 TEST OFF ON 1 4 5 8 IC103 1 4 5 8 IC101 C108 C112 C122 C125 JW203 JW103 C151 C139 C140 C118 R118 R105 R113 R112 R104 R101 R114 R107 R127 R121 C130 R124 R129 R131 R158 R156 R111 S104 S105 R115 R161 R152 R148 R147 R146 R137 R136 R154 R155 R153 R150 R120 R149 R119 R140 R144 R143 R142 R133 R163 R102 C103 R103 R106 R110 R159 R128 R122 R123 R130 R126 R125 R134 R155 R132 R157 R116 R160 R145 R138 R139 R141 R151 R165 R162 R166 ZD104 A K K A ZD105 C154 C156 C157 R135 C104 C105 C152 C107 R108 C110 C148 R109 C111 3 1 J301 3 1 W301 C124 C123 C126 C128 C129 C149 C903 C143 C153 C150 C145 C134 C144 C902 C901 C132 CDS1 T102 C136 Q104 BCE D107 Q107 BCE Q106 BCE Q108 BCE Q111 BCE Q112 ECB Q110 BCE D103 Q101 S102 ECB Q102 ECB Q103 ECB Q105 ECB T101 D102 D101 D108 1 3 D104 D109 Q109 ECB IC105 1 5 8 14 10 7 IC102 1 5 8 14 10 7 J104 AUDIO IN S101 TALK HANDSET HEADSET J301 HEADSET VR202 MIC VOLUME VR201 HANDSET VOLUME (TEL) S201 MUTING D202 MUTING D201 (LINE) S103 k A C B D 1 4 C A A A A C A A C A A C 1 4 2 3 4 5 6 7 8 9 A 1 B C D E F 3-3. PRINTED WIRING BOARDS – MAIN SECTION – Note : • X : parts extracted from the component side. • z : Through hole. • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: Parts on the pattern face side seen from the (Side B) pattern face are indicated. Parts face side: Parts on the parts face side seen from the (Side A) parts face are indicated. Ref. No. Location z Semiconductor Location w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8 8 TL-HA80 z Waveforms 1 Q105 C VOLT/DIV : 0.5 V AC TIME/DIV : 0.5msec Note on Schematic Diagram • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • f : internal component. • C : panel designation. • A : B+ Line. • Power voltage is dc 12V and fed with regulated dc power supply from MJ101. • Voltages and waveforms are dc with respect to ground under no-signal conditions. no mark : TALK OFF (HANDSET) ( ) : TALK ON (HEADSET) < > : TEST MODE at TALK ON • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal produc- tion tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal produc- tion tolerances. • Circled numbers refer to waveforms. • Signal path. N : RX O : TX 1.7Vp-p 1.4msec TEST MODE • IC BLOCK DIAGRAMS IC101 TC7W74F-TE12L IC102, 105 TC74HC4066AF IC103 NJM2113M-TE2 6 CLR 7 PR 8 VCC 5 Q R S Q 3 Q 2 D 4 GND 1 CK Q D C 7 6 5 2 1 4 3 8 9 10 11 13 14 12 GND CCT BCT ACT BS2 DS2 VCC DCT AS1 CS1 BS1 AS2 CS2 DS1 5 VOUT1 V+ GND VOUT2 –VIN +VIN VREF CD – + – + 1 2 3 4 6 7 8 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com TL-HA80 9 SECTION 4 EXPLODED VIEWS Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark NOTE : • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. 12 11 10 14 13 15 28 28 28 28 28 9 8 7 6 5 2 4 3 1 16 28 28 23 19 19 22 21 20 27 17 26 25 24 27 18 MJ102 a a MJ101 1 4-921-277-71 SCREW (B2.6) 2 3-231-587-01 COVER (SPRING) 3 3-231-585-01 HOLDER (SPRING B) 4 3-231-584-01 HOLDER (SPRING) 5 3-229-164-01 SPRING (LEVER) 6 3-229-152-01 HOLDER (LEVER) 7 3-229-154-01 RUBBER, H/S 8 3-229-151-01 LEVER (HOOK) 9 3-232-620-01 RUBBER (HOOK) 10 3-229-155-01 KNOB (MUTE) 11 3-229-149-01 CASE (UPPER) 12 3-229-163-01 LENS (LED) 13 3-229-162-01 KNOB (MIC) 14 3-229-146-01 KNOB (VOL) * 15 1-681-414-11 VOLUME BOARD * 16 A-3062-418-A MAIN BOARD, COMPLETE 17 3-230-680-01 CUSHION (LEVER) 18 3-229-150-01 CASE (LOWER) 19 3-230-678-01 FOOT, RUBBER 20 3-229-165-01 SHEET (SW) 21 3-229-153-01 LID (EXPLANATION) 22 3-230-679-01 CUSHION (SHEET) 23 1-681-413-11 AUDIO BOARD 24 3-229-159-01 KNOB (EXPLANATION B) 25 3-229-158-01 KNOB (EXPLANATION A) 26 3-229-157-01 KNOB (TEST) 27 7-685-547-19 SCREW +BTP 3X10 TYPE2 N-S 28 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S MJ101 1-695-256-51 JACK, MODULAR (H.S) (TEL) MJ102 1-695-256-51 ACK, MODULAR (H.S) (HANDSET) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10 TL-HA80 SECTION 5 ELECTRICAL PARTS LIST Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark AUDIO NOTE : • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms METAL : Metal-film resistor METAL OXIDE :Metal oxide-film resistor F : nonflammable • Items marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u : µ , for example : uA.... : µ A.... , uPA.... : µ PA.... uPB.... : µ PB.... , uPC.... : µ PC.... uPD.... : µ PD.... • CAPACITORS uF : µ F • COILS uH : µ H When indicating parts by reference num- ber, please include the board. * 1-681-413-11 AUDIO BOARD *********** J301 1-695-211-21 JACK (SMALL TYPE) (HEAD SET) ***************************************************** * A-3062-418-A MAIN BOARD, COMPLETE ******************* 3-231-611-01 CASE (COUPLER UPPER) 3-231-612-01 CASE (COUPLER LOWER) C101 1-126-963-11 ELECT 4.7uF 20% 50V C102 1-126-963-11 ELECT 4.7uF 20% 50V C103 1-164-156-11 CERAMIC CHIP 0.1uF 25V C104 1-164-156-11 CERAMIC CHIP 0.1uF 25V C105 1-164-156-11 CERAMIC CHIP 0.1uF 25V C106 1-126-964-11 ELECT 10uF 20% 50V C107 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V C108 1-164-156-11 CERAMIC CHIP 0.1uF 25V C109 1-124-584-00 ELECT 100uF 20% 10V C110 1-164-392-11 CERAMIC CHIP 390PF 10% 50V C111 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C112 1-164-156-11 CERAMIC CHIP 0.1uF 25V C113 1-126-959-11 ELECT 0.47uF 20% 50V C116 1-126-963-11 ELECT 4.7uF 20% 50V C117 1-126-963-11 ELECT 4.7uF 20% 50V C118 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C119 1-126-963-11 ELECT 4.7uF 20% 50V C120 1-126-963-11 ELECT 4.7uF 20% 50V C122 1-164-156-11 CERAMIC CHIP 0.1uF 25V C123 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C124 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C125 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C126 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C128 1-164-156-11 CERAMIC CHIP 0.1uF 25V C129 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25V C130 1-126-961-11 ELECT 2.2uF 20% 50V C131 1-126-964-11 ELECT 10uF 20% 50V C134 1-162-926-11 CERAMIC CHIP 82PF 5% 50V C135 1-124-635-00 ELECT 220uF 20% 6.3V C136 1-164-156-11 CERAMIC CHIP 0.1uF 25V C137 1-104-665-11 ELECT 100uF 20% 10V C138 1-126-964-11 ELECT 10uF 20% 50V C139 1-164-156-11 CERAMIC CHIP 0.1uF 25V C140 1-164-156-11 CERAMIC CHIP 0.1uF 25V C142 1-128-551-11 ELECT 22uF 20% 25V C143 1-164-361-11 CERAMIC CHIP 0.047uF 16V C144 1-164-156-11 CERAMIC CHIP 0.1uF 25V C145 1-115-156-11 CERAMIC CHIP 1uF 10V C148 1-115-156-11 CERAMIC CHIP 1uF 10V C149 1-113-619-11 CERAMIC CHIP 0.47uF 10V C150 1-164-156-11 CERAMIC CHIP 0.1uF 25V C151 1-164-156-11 CERAMIC CHIP 0.1uF 25V C152 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C153 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C154 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C155 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C156 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C157 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C901 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C902 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C903 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V CDS1 1-804-399-11 SENSOR, CDS LIGHT D101 8-719-914-43 DIODE DAN202K D102 8-719-914-43 DIODE DAN202K D104 8-719-084-62 DIODE TLRE180AP D106 8-719-970-02 DIODE 1SR139-400 D107 8-719-914-43 DIODE DAN202K D108 8-719-914-43 DIODE DAN202K D109 8-719-914-43 DIODE DAN202K IC101 8-759-180-84 IC TC7W74F-TE12L IC102 8-759-239-25 IC TC74HC4066AF IC103 8-759-291-01 IC NJM2113M-TE2 IC104 8-759-701-56 IC NJM78M05FA IC105 8-759-239-25 IC TC74HC4066AF MAIN The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 TL-HA80 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MAIN J103 1-779-207-11 JACK,DC(POLARITY UNIFIED TYPE) (DC IN 9V) J104 1-566-822-21 JACK (AUDIO IN) JW103 1-216-864-11 METAL CHIP 0 5% 1/16W JW203 1-216-864-11 METAL CHIP 0 5% 1/16W MJ101 1-695-256-51 JACK, MODULAR (H.S) (TEL) MJ102 1-695-256-51 JACK, MODULAR (H.S) (HANDSET) Q101 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q102 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q103 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q104 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q105 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q106 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q107 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q108 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q109 8-729-120-28 TRANSISTOR 2SC1623-L5L6 Q110 8-729-026-53 TRANSISTOR 2SA1576A-T106-QR Q111 8-729-026-53 TRANSISTOR 2SA1576A-T106-QR Q112 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R101 1-216-833-11 METAL CHIP 10K 5% 1/16W R102 1-216-841-11 METAL CHIP 47K 5% 1/16W R103 1-216-845-11 METAL CHIP 100K 5% 1/16W R104 1-216-809-11 METAL CHIP 100 5% 1/16W R105 1-216-818-11 METAL CHIP 560 5% 1/16W R106 1-216-845-11 METAL CHIP 100K 5% 1/16W R107 1-216-837-11 METAL CHIP 22K 5% 1/16W R108 1-216-845-11 METAL CHIP 100K 5% 1/16W R109 1-216-841-11 METAL CHIP 47K 5% 1/16W R110 1-216-864-11 SHORT 0 R111 1-216-837-11 METAL CHIP 22K 5% 1/16W R112 1-216-845-11 METAL CHIP 100K 5% 1/16W R113 1-216-845-11 METAL CHIP 100K 5% 1/16W R114 1-216-845-11 METAL CHIP 100K 5% 1/16W R115 1-216-837-11 METAL CHIP 22K 5% 1/16W R116 1-216-821-11 METAL CHIP 1K 5% 1/16W R118 1-216-815-11 METAL CHIP 330 5% 1/16W R119 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R120 1-216-817-11 METAL CHIP 470 5% 1/16W R121 1-216-812-11 METAL CHIP 180 5% 1/16W R122 1-216-828-11 METAL CHIP 3.9K 5% 1/16W R123 1-216-830-11 METAL CHIP 5.6K 5% 1/16W R124 1-216-849-11 METAL CHIP 220K 5% 1/16W R125 1-216-821-11 METAL CHIP 1K 5% 1/16W R126 1-216-821-11 METAL CHIP 1K 5% 1/16W R127 1-216-850-11 METAL CHIP 270K 5% 1/16W R128 1-216-851-11 METAL CHIP 330K 5% 1/16W R129 1-216-847-11 METAL CHIP 150K 5% 1/16W R130 1-216-809-11 METAL CHIP 100 5% 1/16W R131 1-216-831-11 METAL CHIP 6.8K 5% 1/16W R132 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R133 1-216-848-11 METAL CHIP 180K 5% 1/16W R134 1-216-805-11 METAL CHIP 47 5% 1/16W R135 1-216-797-11 METAL CHIP 10 5% 1/16W R136 1-216-837-11 METAL CHIP 22K 5% 1/16W R137 1-216-830-11 METAL CHIP 5.6K 5% 1/16W R138 1-216-815-11 METAL CHIP 330 5% 1/16W R139 1-216-815-11 METAL CHIP 330 5% 1/16W R140 1-216-833-11 METAL CHIP 10K 5% 1/16W R141 1-216-809-11 METAL CHIP 100 5% 1/16W R142 1-216-809-11 METAL CHIP 100 5% 1/16W R143 1-216-807-11 METAL CHIP 68 5% 1/16W R144 1-216-809-11 METAL CHIP 100 5% 1/16W R145 1-216-845-11 METAL CHIP 100K 5% 1/16W R146 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R147 1-216-857-11 METAL CHIP 1M 5% 1/16W R148 1-216-837-11 METAL CHIP 22K 5% 1/16W R149 1-216-837-11 METAL CHIP 22K 5% 1/16W R150 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R151 1-216-834-11 METAL CHIP 12K 5% 1/16W R152 1-216-845-11 METAL CHIP 100K 5% 1/16W R153 1-216-818-11 METAL CHIP 560 5% 1/16W R154 1-216-833-11 METAL CHIP 10K 5% 1/16W R155 1-216-833-11 METAL CHIP 10K 5% 1/16W R156 1-216-833-11 METAL CHIP 10K 5% 1/16W R157 1-216-845-11 METAL CHIP 100K 5% 1/16W R158 1-216-845-11 METAL CHIP 100K 5% 1/16W R159 1-216-809-11 METAL CHIP 100 5% 1/16W R160 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R161 1-216-861-11 METAL CHIP 2.2M 5% 1/16W R162 1-216-834-11 METAL CHIP 12K 5% 1/16W R163 1-216-857-11 METAL CHIP 1M 5% 1/16W R164 1-216-857-11 METAL CHIP 1M 5% 1/16W R165 1-216-845-11 METAL CHIP 100K 5% 1/16W R166 1-216-802-11 RES-CHIP 27 5% 1/16W RY101 1-755-378-11 RELAY RY102 1-755-441-11 RELAY RY103 1-755-441-11 RELAY S101 1-786-182-11 SWITCH, MICRO (HOOK) S102 1-572-624-11 SWITCH, SLIDE (B) S103 1-786-134-11 SWITCH, SLIDE (A) S104 1-762-823-11 SWITCH, SLIDE (TEST) S105 1-786-200-11 SWITCH, SLIDE (TEST) T101 1-437-371-11 TRANSFORMER, INPUT T102 1-437-371-11 TRANSFORMER, INPUT ZD104 8-719-056-97 DIODE UDZ-TE-17-27B ZD105 8-719-056-97 DIODE UDZ-TE-17-27B ***************************************************** www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 TL-HA80 Ref. No. Part No. Description Remark VOLUME * 1-681-414-11 VOLUME BOARD ************ 3-229-160-01 HOLDER (LED A) 3-229-161-01 HOLDER (LCD B) D201 8-719-027-79 DIODE BR3368S D202 8-719-084-63 DIODE BR3361X VR201 1-227-420-11 RES, VAR, CARBON 10K (HANDSET VOLUME (TEL)) VR202 1-227-420-11 RES, VAR, CARBON 10K (MIC VOLUME) S201 1-692-539-11 SWITCH, KEYBOARD (MUTUNG) ***************************************************** ACCESSORIES & PACKING MATERIALS **************************** 0 1-476-621-11 ADAPTOR, AC (AC-T127) 1-823-019-11 CORD, CONNECTION (STEREO MINI-PLUG) 1-823-020-11 CORD, CONNECTION (TELEPHONE CODE) 3-231-905-11 MANUAL,INSTRUCTION (ENGLISH,SPANISH) 3-232-330-01 HANGER (H/S) 3-232-331-01 HOOK (WALL HOOK) 3-232-357-01 SEAL (EXPLANATION) 3-232-411-01 TAPE 3-234-108-01 LABEL 8-954-004-90 HEAD SET TL-DR0140 X-3380-768-1 CLIP ASSY ***************************************************** The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 TL-HA80 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2001.05 New TL-HA80 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com