SERVICE MANUAL US Model SPECIFICATIONS FEATURES TV standard American TV standard Channel coverage VHF channels 2-13 UHF channels 14-69 Radio frequency range FM 87.6-l 08 MHz AM 530-l ,710 kHz A n t e n n a VHF/UHF/FM: telescopic antenna AM: Built-in ferrite bar antenna Picture tube 4.5-inch picture measured diagonally Input EXT ANT: minijack, 75 ohms output EAR: minijack, impedance 8-300 ohms Speaker Full range 05 cm (02 inches) Power requirements 12 V DC Battery life See page 4 for “Power sources.” Power consumption 10.8 W Dimensions Approx. 176.2 x 177x 175.5 mm (w/h/d) (7 x 7 x 7 inches) incl. projecting pans and controls Mass Approx. 2.8 kg (6 lb 3 oz) incl. batteries Supplied accessory AC power adaptor (1) � 4.5inch black and white 90” deflection picture tube. � The voltage synthesizer tuning system allows easy tuning. � AM/FM tuner is combined. � Built-in e-inch dia. speaker with powerful output and good sound suitable for garden and kitchen use. � Carrying handle for easy carrying. Design and specifications are subject to change without notice. Note Use only recommended AC power adaptor. Do not use any other AC power adaptor. Polarity of the plug SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK A OR DOTTED LINE WITH MARK A ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN :lN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY. BLACK AND WHITE TV-AM/FM TUNER SONY@ www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com NOTEONTHEANODECAPREMOVAL Even when the power switch is off, the voltage at the anode cap is still high. Remove the anode cap as follows. 1. Discharge the anode pin to the ground. 2. Pinch and remove the anode pin with a pair of tweezers. At this time, be careful not to scratch the anode button. Caution on Reinstallation : Confirm that the anode button is inserted into the anode cap securely. TABLEOFCONTENTS Section 1. GENERAL 0 Location of Controls. ................. � Power Sources ...................... � Watching the TV .................... � Listening to the Radio ................ � External Antenna Connection ........ 2. DISASSEMBLY 2-1. Cabinet (rear) .................... ....... 2-2. A Board ........................ ....... 2-3. Cathode-ray Tube ................ ....... 2-4. R Board ........................ ....... 2-5. Pointer Setting .................. ....... . . . . . . . . . . . . . . ....... 4 ....... 4 ....... 4 ....... 5 ....... 5 ....... 6 ....... 6 ....... 6 ....... 6 ....... 6 Section 3. ELECTRICAL ADJUSTMENTS 3-1. Tuner Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2. TV Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4. DIAGRAMS 4.1. Semiconductor Lead Layouts ............... . ..lO 4-2. Block Diagram ............................. . . . 11 4-3. Printed Wiring Boards ..................... . . . 13 4.4. Schematic Diagram......................... . . . 15 5. EXPLODED VIEWS 5-1. Rear Cabinet Section . . . . . . . . . . . . . . . . . . . . . . . 5-2. Front Cabinet Section . . . . . . . . . . . . . . . . . . . . . 6 . ELECTRICAL PARTS LIST . . . . . . . . . . . . . . . . . . ..21 . . . . 7 . . . . 8 . ..19 . . . 20 -2- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: 1. 2. 3. 4. 5. 6. I. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder splashes and bridges. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors. Check that all control knobs, shields, covers, ground straps, and mounting hardware have been replaced. Be absolutely certain that you have replaced all the insulators. Look for unauthorized replacement parts, par- ticularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replace- ment. Check the line cord for cracks and abrasion. Recommend the replacement of any such line cord to the customer. Check the condition of the monopole antenna (if any). Make sure the end is not broken off, and has the plastic cap on it. Point out the danger of impalement on a broken antenna to the customer, and recommend the antenna’s replacement. Check the B+ and HV to see they are at the values specified. Make sure your instruments are accurate; be suspicious of your HV meter if sets always have low HV. Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-S40A. Follow the manufacturers’ instructions to use these instru- ments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC volt- meter. The “limit” indication is 0.75V, so analog meters must have an accurate low- voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) HOW TO FIND A GOOD EARTH GROUND A cold-water pipe is guaranteed earth ground; the cover-plate retaining screw on most AC outlet boxes is also at earth ground. If the retaining screw is to be used as your earth-ground, verify that it is at ground by measuring the resistance between it and a cold- water pipe with an ohmmeter. The reading should be zero ohms. If a cold-water pipe is not accessible, connect a 60-100 watts trouble light (not a neon lamp) between the hot side of the receptacle and the retaining screw. Try both slots, if necessary, to locate the hot side of the line, the lamp should light at normal brilliance if the screw is at ground potential. (See Fig. B) Fig. A. Using an AC voltmeter to check AC leakage. Fig. B. Checking for earth ground. To Exposed Metal Parts on Set 0.15rF A C voltmeter 10.75 V) * Earth Ground Trouble Light . Ohmmeter Cold-water Pipe -3- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com sueen Handle POWER swkch CHANNEL +/- buttons VOLUME control TV BAND selector (VHFAIHF) EAR (earphone) jack RADIO TUNING ~~trcl CH CALL button MODE eelector Dial scale aattery comparment (bottom) Telescopic antenna BRT (brightness) mntrcl CONTR (contrast) ccntml DC IN t2V (external power input) jack IEXT ANT (external antenna) j a c k Usin on House Current II 2d AC) 1 Batteries Using the supplied AC power adaptor I Size D (R20) x 8 4 to DC IN 12V When to replace batteries When the picture became.5 small, replace all the batteries wim new ones. U s e o n l y r e c o m m e n d e d A C p o w e r a d a p t o r . Do not use any other AC power adaptor. Battery life Balmtea N RAM0 A M P M 3 Polarity o f t h e p l u g I I Sony SUM-l PW 1 . 5 25 25 Sony alkaline AM1 (N) 5 I 70 70 N o t e When me unit is not to be u s e d f o r a l o n g p e r i o d o f t i m e . remove the bettedes to avoid unit damage caused by ba”ery 1eakaga and ccrrcslon. r---3,6 1 110 L i s t e n U s i n g t h e E a r p h o n e 1 5 i CHC 2 :ALL button 1 Press the POWER switch 2 Se, the MODE selector to TV. The unit starts tunina autOmaticallY. M O D E t D :6 El . AM 3 Pull cut the antenna fully 4 Select the band. VHF or UHF. 5 Tune in the desired channel. CHANNEL I - > 6 Adiust the antenna length and its direction 7 Adiust the volume. To turn off the TV press me POWER switch ad i0id me antenna. It the channel changes If the power is momentarily lost because of a mechanical shock. or if the unit has passed t h r o u g h a t u n n e l . t h e channel may change. If this happens, tune in the desired channel again with CHANNEL +I-. To indicate the current channel P r e s s t h e C H C A L L b u t t o n . The line appears et the position of the current channel For your safety, do not warch the N nor operate the controls while drivina. N o t e Be sure to turn off me N after use. especially when listening with earphone. This prevents unnecessary batter/ wear. ( Picture Adjustment V.HOLD control Turn the control when the picture rolls vertically BRT Mntrcl Turn the control counterclockwise for more brightness end clcdtwise lcr less brightness. CONTR ccntrcl The picture mntrast bewmes s t r o n g e r b y t u r n i n g t h e COntrCl counterclockwise. and is reduced by turning it ClCckWisB. www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 395 1 6 4 1 Press the POWER switch. 2 Set the MODE selector to FM or AM. MODE 3 Pull ail the antenna fully ior FM reception 4 Tune in the desired station RADIO TUNING 5 For FM reception. adjust the length and direction of ti?& Ct”W”M. For AM reception, rotate the unit. 6 Adjust the volume. al’ VOLUME To turn off the radto Press the POWER switch and told the antenna. To listen using the earphone See ‘Watching the TV”. N o t e Se sure to turn oft the radio after we, especially when listening with earphone. This prevents unnecessary battery wear. Outdoor antenna Monitoring the video camera recorder After connecting as illustrated, turn on the power d the equipment and tune in the channel 3 or 4. VHF antenna 75ohm maxtal cable F-type COtl”RCtO, 1 CM) Antenna cable EAC-110 (no, Slpplii) www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 TE L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com SECTION 2 DISASSEMBLY Note : Follow the disassembly procedure in the numerical order given. 2-1. CABINET (REAR) P battery case lid Q cabinet (rear) 2-2. A BOARD board board 0 power button 2-3. CATHODE-RAY TUBE ~BvTP3XlO \ C board CRT retainer spring 2-4. R BOARD 0 PTP3XB OR 2-5. POINTER SETTING 4) Set the pointer bracket. / pointer to the ditch of left edge. 0 Turn fully PTP3Xb -6. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com SECTION 3 ELECTRICAL ADJUSTMENTS 3-1. TUNER SECTION � FM Section Setting : MODE switch : FM FM rf signal generator deviation by 400Hz signal output level : as low as possible � AM Section Setting : MODE switch : AM AM rf signal antenna 30% amplitude modulation by 400Hz signal VTVM (range : 0.5-5V ac) , 4 EAR j a c k � Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. � Remove telescopic antenna in FM section adjustments. FM FREQUENCY COVERAGE A D J U S T M E N T I I Adjust for a maximum reading on VTVM. 1 L 3 CT3 86.5MHz 109.5MHz I Adjust for a maximum reading on VTVM. 11 AM FREQUENCY COVERAGE A D J U S T M E N T Adjust for a maximum reading on VTVM. L 4 CT4 I 520kHz 1,750kHz AM TRACKING ADJUSTMENT Adjust for a maximum reading on VTVM. Ll CT1 620kHz 1,400kHz AM IF ADJUSTMENT Adjust for a maximum reading on VTVM. Tl 4 5 0 k H z Adjustment Location : R board (component side) :: I . 3 CTJ, ,CTZ L2-1 L2-2, AL-L FREQFUMENCY CoYiYGE TR$$ NO -7- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Adjustment Location : A board (component side) 3-2. TV SECTION Setting : MODE switch : TV TV BAND switch : VHF or UHF Centering Adjustment Procedures : , 1. Tune in off-the-air signal. 2. Adjust the centering magnet so that the picture is in the center. 3. After the adjustment, look the magnets with suitable locking compound. Adjustment Location : centering magnet adjustment screw CRT B+(8.8V) Adjustment Procedure : Adjust RV601 for 8.8V reading on collector voltage of Q601. Horizontal Frequency (H-HOLD) Adjustment Procedures : 1. Connect between IC201 pin @ and pin @ with lkfi resis- tor. 2. Connect the frequency counter to IC201 pin 0. 3. Adjust RV501 for a 15.734kHz+60Hz reading on frequen- cy counter. 4. After the adjustment, remove the resistor in item 1. Vertical Amplitude (V-SIZE) Adjustment Procedures : 1. Tune in an off-the-air signal. 2. Adjust RV551 for the best vertical amplitude. RF AGC Adjustment Procedures : 1. Tune in an off-the-air signal. 2. Adjust RV201 so that snow noise disappears from the picture. WI01 6+%!v’ ID El WI01 %b”J’” RV551 V-S I ZE ADJ Tuning Adjustment Procedures : 1. Short S104 (CH CALL). (State where the display bar is shown on the screen.) 2. Set S151 (TV BAND) to the VHF side. 3. Receive the broadcast of 2CH by pushing S102 (CHAN- NEL-) or S103 (CHANNEL+). 4. Adjust RV103 so that the display bar is corresponded to the position of 2CH. 5. Receive the broadcast of 13CH, and adjust RVlOl so that the display bar is corresponded to the 13CH. Note : Since the items 4 and 5 will interfere each other, the adjustment is necessary for 2 to 3 times. 6. Receive the broadcasts of 2 to 13CH, and check if the display bar is corresponded to each channel. 7. Set S151 (TV BAND) to the UHF side. 8. Receive the broadcast of 14CH, and adjust RV104 so that the display bar is corresponded to the position of 14CH. 9. Receive the broadcast of 69CH, and adjust RV102 so that the display bar is corresponded to the position of 69CH. Note : Since the items of 8 and 9 will interfere each other, the adjustment is necessary for 2 to 3 times. 10. Receive the broadcasts of 14CH to 69CH, and check if the display bar is corresponded to the position of each chan- nel. 11. Disconnect the S104 shorted in the above item 1. -8- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Adjustment Location : B board (conductor side) TUNING AOJ * 1 3 C H G9CH 2CH 14CH’ RVlOl WI02 RV103 R V 1 0 4 n -9- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com SECTION 4 DIAGRAMS 4-1. SEMICONDUCTOR LEAD LAYOUTS AN5151N NJM3868S (Top vrnvl AN5707NS RC78L05A ITOP VIEW) CX2011 l-T6 (TOP VIEW) L5630 DTC114YS 2SC2785-FEK x cathode NJM3404AD a 7 6 5 crl 1 2 3 4 (Top view) DTC144ES letter ride 2iA952 2SA1175.FEK 2SC2001TP-KlK2 2sc2909 2SB1094mLK 2SD1159 D B e d: 2SC2786-K GPlOG5020 RL202-Ml1 lOE2 5 CATHJOE AWE RD6.2ES.82 RD7.5ES-B2 lSS119 lSS168 il cathode " anode RU-3AM cathode anode -lO- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com SECTION 6 ELECTRICAL PARTS L1S-i mlslm NOTE : � Due to standardization, replacements in � Items marked ‘I*” are not stocked since the parts list may be different from the they are seldom required for routine service. parts specified in the diagrams or the Some delay should be anticipated components used on the set. when ordering these items. � -XX and -X mean standardized parts, so � SEMICONDUCTORS they may have some difference from the In each case, u:~, for example: original one. uA..: ,uA.. uPA..: ,uPA.. � RESISTORS uPB.. : DPB.. UPC.. : L~PC.. uPD..: ,uPD.. All resistors are in ohms. � CAPACITORS METAL:Metal-film resistor. uF: /JF METAL OXIDE: Metal oxide-film resistor. 0 COILS F:nonflammable uH: UH Ref. No. Part No. Description C211 l-101-361-00 CERAMIC C212 l-136-161-00 MYLAR C213 l-124-907-11 ELECT C214 l-136-157-00 MYLAR C215 l-136-157-00 MYLAR Ref. No. Part No. Description Remark * A-3016-359-A A BOARD, COMPLETE (INCLUDING B, C BOARD) ****+************ 150PF 0.047uF 1OuF 0.022uF 0.022uF * l-526-736-00 SOCKET, CRT 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > C216 l-102-947-00 CERAMIC 1OPF 5 % 5ov C401 l-124-443-00 ELECT 1OOuF 20% 1ov C402 l-102-116-00 CERAMIC 680PF 10% 5ov C403 l-102-116-00 CERAMIC 680PF 10% 5ov C404 l-136-165-00 MYLAR 0. 1uF 10% 5ov Cl01 1-124-464-11 ELECT 0.22uF 20% 5ov Cl02 1-162-851-11 CERAMIC 0. 1uF 16V Cl03 l-131-498-00 TANTALUM 1uF 10% 2 5 V Cl04 l-102-074-00 CERAMIC 0. OOluF 10% 5ov Cl05 l-102-525-11 CERAMIC 68PF 5 % 5ov C405 l-124-907-11 ELECT 1OuF 20% 5ov C406 l-101-361-00 CERAMIC 150PF 5 % 5ov C407 l-101-880-00 CERAMIC 47PF 5 % 5ov C408 l-102-121-00 CERAMIC 2200PF 10% 5ov C451 l-136-153-00 FILM 0. OluF 5 % 5ov Cl06 l-102-121-00 CERAMIC 2200PF 10% 5ov Cl07 1-101-004-00 CERAMIC 0. OluF 5ov Cl08 1-124-916-11 ELECT 22uF 20% 63V Cl09 1-101-004-00 CERAMIC 0. OluF 5ov Cl10 l-102-115-00 CERAMIC 560PF 10% 5ov C452 l-124-120-11 ELECT 220uF 20% 2 5 V C453 l-136-165-00 MYLAR 0. 1uF 10% 5ov C454 1-101-004-00 CERAMIC 0. OluF 5ov C455 l-124-360-00 ELECT 1OOOuF 20% 1 6 V C456 l-124-907-11 ELECT 1OuF 20% 5ov Cl11 1-124-927-11 ELECT 4.7uF 20% 1oov Cl14 l-124-902-00 ELECT 0.47uF 20% 5ov Cl17 1-101-006-00 CERAMIC 0.047uF 5ov Cl18 l-102-973-00 CERAMIC 1OOPF 5 % 5ov Cl20 1-101-005-00 CERAMIC 22000PF 5ov C457 1-124-477-11 ELECT 47uF 20% 2 5 V C501 l-136-153-00 FILM 0. OluF 5 % 5ov C502 l-130-485-00 MYLAR 0.015uF 5 % 5ov C504 1-124-893-11 ELECT 2200uF 20% 1ov C505 1-101-004-00 CERAMIC 0. OluF 5ov Cl21 1-124-477-11 ELECT 47uF 20% 2 5 V Cl24 l-124-902-00 ELECT 0.47uF 20% 5ov Cl51 l-102-074-00 CERAMIC 0. OOluF 10% 5ov Cl52 l-102-121-00 CERAMIC 2200PF 10% 5ov Cl53 l-124-907-11 ELECT 1OuF 20% 5ov C506 l-124-903-11 ELECT 1uF 20% 5ov C507 l-136-157-00 MYLAR 0.022uF 10% 5ov C508 l-130-479-00 MYLAR 0.0047uF 5 % 5ov C509 1-126-176-11 ELECT 220uF 20% 1ov C551 l-131-347-00 TANTALUM 1uF 10% 35v Cl54 1-101-005-00 CERAMIC 22000PF 5ov Cl58 l-124-443-00 ELECT 1OOuF 20% 1ov Cl59 l-102-074-00 CERAMIC 0. OOluF 10% 5ov Cl60 l-102-074-00 CERAMIC 0. OOluF 10% 5ov c201 1-101-004-00 CERAMIC 0. OluF 5ov C552 l-323-382-00 ELECT 3.3uF 20% 1oov C553 l-131-347-00 TANTALUM 1uF 10% 3 5 v C554 l-131-347-00 TANTALUM 1uF 10% 35v C555 l-102-074-00 CERAMIC 0. OOluF 10% 5ov C556 l-124-126-00 ELECT 47uF 20% 1ov c202 1-101-004-00 CERAMIC 0. OluF 5ov C203 1-101-004-00 CERAMIC 0. OluF 5ov C205 1-124-916-11 ELECT 22uF 20% 63V C206 l-124-902-00 ELECT 0.47uF 20% 5ov C207 1-101-004-00 CERAMIC 0. OluF 5ov C557 1-124-473-11 ELECT 1OOOuF 20% 1ov C558 l-124-360-00 ELECT 1OOOuF 20% 16V C559 l-124-126-00 ELECT 47uF 20% 1ov C560 1-124-473-11 ELECT 1OOOuF 20% 1ov C601 1-124-563-11 ELECT 2200uF 20% 2 5 V C208 l-101-880-00 CERAMIC 47PF 5 % 5ov c209 l-130-473-00 MYLAR 0.0015uF 5 % 5ov c210 l-123-382-00 ELECT 3.3uF 20% 1oov -21- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark C602 1-101-005-00 CERAMIC C603 1-101-004-00 CERAMIC C604 l-124-907-11 ELECT 0305 1-124-472-11 ELECT C606 l-124-126-00 ELECT 22000PF 0. OluF 1OuF 470uF 47uF 5ov 5ov 20% 5ov 20% 1ov 20% 1ov Ref. No. Part No. Description < FUSE > AF601 1;532-591-00 FUSE, GLASS TUBE (2A/125V) < IC > CEO1 l-101-005-00 CERAMIC 22000PF ’ 5ov IClOl 8-759-420-88 IC AN5707NS C802 l-loz-bwoo CERAMIC 0. OOluF 10% 5ov IC102 8-759-701-50 I C NJM3404AD C803 l-124-126-00 ELECT 47uF 20% 1ov IC103 8-759-982-21 IC RC78105A AC804 l-106-379-12 MYLAR 0.033uF 5% 2oov IC201 l-808-293-11 IC AN5151N AC805 l-106-379-12 MYLAR 0.033uF 5% 2oov IC451 8-759-702-01 IC NJM386BS C806 1-124-915-11 ELECT 1OuF 20% 63V C807 1-128-119-21 ELECT 3.3uF 20% 3 5 0 v C808 l-102-050-00 CERAMIC 0. OluF 99% 5oov C809 l-136-161-00 MYLAR 0.047uF 10% 5ov C810 1-101-004-00 CERAMIC 0. OluF 5ov C811 1-126-515-11 ELECT C813 l-106-347-00 MYLAR C814 l-136-159-00 MYLAR 4.7uF 10% 1500PF 5% 0.033uF 10% 5ov 2oov 5ov < FILTER > CF201 l-567-115-00 FILTER, CERAMIC CF202 l-577-066-11 FILTER, CERAMIC (DISCRIMINATOR) < CONNECTOR > * CN151 1-568-454-11 PIN. CONNECTOR (PC BOARD) 9P CN153 1-564-777-11 PLUG, CONNECTOR (2.5MM) 2P CN451 1-564-777-11 PLUG, CONNECTOR (2.5htM) 2P CN601 1-564-777-11 PLUG, CONNECTOR (2.5MM) 2P * CN801 1-564-778-11 PLUG, CONNECTOR (2.5MM) 4P < DIODE > Dl 8-719-903-27 DIODE lSS168 D 2 8-719-903-27 DIODE lSS168 DlOl 8-719-911-19 DIODE lSS119 D102 8-719-911-19 DIODE lSS119 D103 8-719-911-19 DIODE lSS119 D151 8-719-903-27 DIODE lSS168 D152 8-719-911-19 DIODE lSS119 D201 8-719-110-03 DIODE RD7. 5ES-B2 D551 8-719-911-19 DIODE lSS119 D552 8-719-911-19 DIODE lSS119 D553 8-719-911-19 DIODE lSS119 D601 8-719-979-32 DIODE RL202-Ml1 D602 8-719-109-93 DIODE RD6.2ES-B2 D801 8-719-911-19 DIODE lSS119 D802 8-719-300-33 DIODE RU-3AM D803 l-808-394-11 DIODE GPlOG5020 D804 8-719-300-33 DIODE RU-3AM D805 8-719-200-02 DIODE lOE2 -22- Remark IC801 8-759-802-17 IC 15630 < JACK > 5151 l-507-667-00 JACK, MIC (EXT ANT) 5 4 5 1 1-695-473-11 JACK (EAR) J601 l-580-288-11 JACK, POWER (DC IN 12V) < COIL > 1201 l-410-312-11 INDUCTOR 0.22uH 1202 l-404-785-11 COIL, VIF DETECTOR 1203 l-404-785-11 COIL, VIF DETECTOR 1204 l-410-972-11 INDUCTOR 15uH 1402 l-414-030-41 INDUCTOR 27uH 1451 l-408-421-00 INDUCTOR 1OOuH 1501 l-408-421-00 INDUCTOR 1OOuH 1502 l-408-418-00 INDUCTOR 56uH < TRANSISTOR > QlOl 8-729-904-36 TRANSISTOR DTCll4YS QlO2 8-729-119-79 TRANSISTOR 2SC2785-FEK 8151 8-729-119-77 TRANSISTOR 2SA1175-FEK 4152 8-729-119-77 TRANSISTOR 2SA1175-FEK 8153 8-729-900-89 TRANSISTOR DTC144ES 8201 8-729-178-63 TRANSISTOR 2SC2786-K 8401 8-729-821-01 TRANSISTOR 2SC2909 Q403 8-729-119-79 TRANSISTOR 2SC2785-FEK 8451 8-729-904-36 TRANSISTOR DTC114YS 8551 8-729-119-79 TRANSISTOR 2SC2785-FEK 8552 8-729-011-92 TRANSISTOR 2SC2001TP-KlK2 8553 8-729-195-23 TRANSISTOR 2SA952 AQSOl 8-729-141-83 TRANSISTOR 2SB1094-LK Q602 8-729-119-79 TRANSISTOR 2SC2785-FEK Q801 8-729-011-92 TRANSISTOR 2SC2001TP-KlK2 Q802 8-729-017-78 TRANSISTOR 2SD1159 < RESISTOR > R106 l-249-440-11 CARBON 82K 5% l/4! R108 1-249-429-11 CARBON 10K 5% 1/4w www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com MO9 1-249-428-11 CARBON Ml0 1-249-435-11 CARBON lull l-215-459-00 METAL R112 1-249-437-11 CARBON R113 1-249-429-11 CARBON Ref. No. Part No. Description Remark R115 R116 R117 R118 R120 R121 R122 R123 R124 R125 R126 R130 R131 R132 R136 R137 R151 R152 R153 R154 R155 R156 R157 R158 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R213 R214 R216 R217 R218 R219 R220 R221 1-249-426-11 CARBON 1-249-425-11 CARBON 1-249-441-11 CARBON 1-249-437-11 CARBON l-215-463-00 METAL 1-249-417-11 CARBON l-249-440-11 CARBON 1-249-441-11 CARBON 1-247-899-11 CARBON 1-249-439-11 CARBON l-249-409-11 CARBON 1-249-417-11 CARBON l-247-887-00 CARBON l-247-895-00 CARBON 1-249-437-11 CARBON 1-249-425-11 CARBON 1-249-435-11 CARBON 1-249-429-11 CARBON 1-249-429-11 CARBON 1-249-437-11 CARBON 1-249-425-11 CARBON 1-249-437-11 CARBON 1-249-425-11 CARBON 1-249-432-11 CARBON 1-249-429-11 CARBON 1-249-427-11 CARBON 1-249-426-11 CARBON 1-249-413-11 CARBON l-249-407-11 CARBON l-249-405-11 CARBON 1-249-416-11 CARBON 1-249-429-11 CARBON 1-249-415-11 CARBON l-249-420-11 CARBON l-249-409-11 CARBON l-249-440-11 CARBON 1-249-415-11 CARBON 1-249-421-11 CARBON 1-249-429-11 CARBON 1-249-393-11 CARBON 1-249-423-11 CARBON l-249-440-11 CARBON l-249-440-11 CARBON 1-249-429-11 CARBON 8.2K 5% 1/4w 33K 5% 1/4w 39K 1% 1/6W 47K 5% 1/4w 10K 5% 1/4w 5. 6K 5% 1/4w 4.7K 5% 1/4w 1OOK 5% 1/4w 47K 5% 1/4w 56K 1% 1/6W 1K 5% 1/4w 82K 5% 1/4w 1OOK 5% 1/4w 680K 5% 1/4w 68K 5% 1/4w 2 2 0 5 % 1/4w 1K 5% 1/4w 220K 5% 1/4w 470K 5% 1/4w 47K 5% 1/4w 4.7K 5% 1/4w 33K 5% 1/4w 10K 5% 1/4w IOK 5% 1/4w 47K 5% 1/4w 4.7K 5% 1/4w 47K 5% 1/4w 4.7K 5% 1/4w 18K 5% 1/4w 10K 5% 1/4w 6.8K 5% 1/4w 5.6K 5% 1/4w 4 7 0 5 % 1/4w 1 5 0 5 % 1/4w 1 0 0 5 % 1/4w 8 2 0 5 % 1/4w 10K 5% 1/4w 6 8 0 5 % 1/4w 1.8K 5% 1/4w 2 2 0 5 % 1/4w 82K 5% 1/4w 6 8 0 5 % 1/4w 2.2K 5% 1/4w 10K 5% 1/4w 1 0 5 % 1/4w 3.3K 5% 1/4w 82K 5% 1/4w 82K 5% 1/4w 10K 5% 1/4w Ref.No. Part No. Description R401 l-249-409-11 CARBON R402 1-249-393-11 CARBON R403 1-249-412-11 CARBON R404 1-249-417-11 CARBON R405 1-249-417-11 CARBON R406 1-249-429-11 CARBON R407 1-249-429-11 CARBON R408 1-249-427-11 CARBON R409 1-249-413-11 CARBON R410 l-249-409-11 CARBON R411 1-249-433-11 CARBON R451 1-249-414-11 CARBON R452 l-249-401-11 CARBON R453 l-249-401-11 CARBON R454 1-249-393-11 CARBON R501 l-249-434-11 CARBON R502 1-249-433-11 CARBON R503 1-249-418-11 CARBON R504 1-249-431-11 CARBON R505 l-249-405-11 CARBON R506 1-249-393-11 CARBON R551 1-249-422-11 CARBON R552 1-249-418-11 CARBON R553 1-249-412-11 CARBON R554 1-249-415-11 CARBON R555 l-247-889-00 CARBON R556 1-249-433-11 CARBON R557 1-249-436-11 CARBON R558 1-249-426-11 CARBON R559 l-249-440-11 CARBON R560 1-249-415-11 CARBON R561 1-249-416-11 CARBON R562 1-249-411-11 CARBON R563 1-249-385-11 CARBON R565 1-249-381-11 CARBON R567 1-249-411-11 CARBON R568 1-249-433-11 CARBON R569 1-249-441-11 CARBON R570 1-249-389-11 CARBON R601 1-249-416-11 CARBON R602 1-249-416-11 CARBON R603 1-249-416-11 CARBON R604 1-249-416-11 CARBON R605 i-249-411-11 CARBON R606 i-249-405-11 CARBON Remark 2 2 0 5 % 1/4w 1 0 5 % 1/4w 3 9 0 5 % 1/4w 1K 5% 1/4w 1K 5% 1/4w 10K 5% 1/4w 10K 5% 1/4w 6.8K 5% 1/4w 4 7 0 5 % 1/4w 2 2 0 5 % 1/4w 22K 5% 1/4w 5 6 0 5 % 1/4w 4 7 5 % 1/4w 4 7 5 % 1/4w 1 0 5 % 1/4w 27K 5% 1/4w 22K 5% 1/4w 1.2K 5% 1/4w 15K 5% 1/4w 1 0 0 5 % 1/4w 1 0 5 % 1/4w 2.7K 5% 1/4w 1.2K 5% 1/4w 3 9 0 5 % 1/4w 6 8 0 5 % 1/4w 270K 5% 1/4w 22K 5% 1/4w 39K 5% 1/4w 5.6K 5% 1/4w 82K 5% 1/4w 6 8 0 5 % 1/4w 8 2 0 5 % 1/4w 3 3 0 5 % 1/4w 2.2 5 % 1/6W 1 5 % 1/4w 3 3 0 5 % 1/4w 22K 5% 1/4w 1OOK 5% 1/4w 4.7 5 % 1/4w 8 2 0 5 % 1/4w 8 2 0 5 % 1/4w 8 2 0 5 % 1/4w 820 ’ 5% 1/4w 3 3 0 5 % 1/4w 1 0 0 5 % 1/4w AR607 1-249-423-11 CARBON Ap608 1-249-419-11 CARBON R801 1-249-417-11 CARBON R802 l-249-405-11 CARBON 3.3K 5% 1/4w 1.5K 5% 1/4w 5 % 1/4w 100 5% 1/4w -23- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark - - R803 l-249-405-11 CARBON 100 5% 1/4w R804 1-249-429-11 CARBON 10K 5% 1/4w R805 1-247-897-11 CARBON 560K 5% 1/4w R806 1-247-897-11 CARBON 560K 5% 1/4w R807 1-249-433-11 CARBON 22K 5% 1/4w R808 1-259-882-11 CARBON 3.3M 5% &4w R809 1-259-88611 CARBON 2.2M 5% 1/4w R810 1-249-385-11 CARBON 2.2 5% 1/6W R811 l-247-889-00 CARBON 270K 5% 1/4w R812 l-249-436:11 CARBON 39K 5% 1/4w R813 1-249-429-11 CARBON 10K 5% 1/4w < VARIABLE RESISTOR > RVlOl l-238-020-11 RES, ADJ, CARBON 1OOK RV102 l-238-020-11 RES, ADJ, CARBON 1OOK RV103 l-238-019-11 RES. ADJ, CARBON 47K RV104 l-238-019-11 RES, ADJ. CARBON 47K RV201 1-241-629-11 RES, ADJ, CARBON 4.7K RV401 l-238-049-21 RES, VAR, CARBON 2K (CONTR) RV451 1-223-365-21 RES, VAR, CARBON 10K (VOLHME) RV501 l-241-630-11 RES, ADJ, CARBON 10K RV551 1-241-628-11 RES, ADJ, CARBON 2.2K RV552 l-238-050-21 RES, VAIL CARBON 1OOK (Y-HOLD) ARV601 1-241-627-11 RES. ADJ. CARBON 1K RV801 l-238-051-21 RES. VAR. CARBON 1M (BRT) < SWITCH > SlOl l-554-088-41 SWITCH, KEY BOARD (CH CALL) S102 l-554-088-41 SWITCH, KEY BOARD (CHANNEL -1 S103 l-554-088-41 SWITCH, KEY BOARD (CHANNEL +) S151 l-554-222-00 SWITCH, SLIDE (TV BAND) S601 1-570-690-U SWITCH, PUSH (POWER) < FILTER > SWF201 1-577-244-11 FILTER CERAMIC < TRANSFORMER > AT801 1-439-487-21 TRANSFORMER ASSY, FLYBACK < TUNER > TH151 1-693-196-11 TUNER UNIT ******t*t*******t********~~****~***********~****~~*~******** Ref. No. Part No. Description - - * A-3016-362-A R BOARD, COMPLETE **********St***** Remark 3-714-118-01 SCREW (1.7X4) 4-039-681-01 GEAR, TUNING 4-039-691-01 KNOB, RADIO TUNING (BLACK) 4-039-691-11 KNOB, RADIO TUNING (WHITE) 4-039-693-01 POINTER 4-039-694-01 DRHM, TUNING CAPACITOR 4-039-701-01 BRACKET, POINTER 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > Cl l-102-074-00 CERAMIC c3 l-102-960-00 CERAMIC c4 l-102-960-00 CERAMIC c5 l-102-943-00 CERAMIC C6 l-102-973-00 CERAMIC c7 C8 c9 Cl0 Cl1 Cl2 Cl3 Cl4 Cl5 Cl6 Cl7 CF2 CF3 0. OOluF 24PF 24PF 6. OPF 1OOPF l-124-907-11 ELECT 1OuF l-102-074-00 CERAMIC 0. OOluF l-101-004-00 CERAMIC 0. OluF l-124-907-11 ELECT 1OuF l-124-927-11 ELECT 4.7uF l-124-903-11 ELECT 1uF l-124-907-11 ELECT 1OuF l-124-907-11 ELECT 1OuF 1-101-004-00 CERAMIC 0. OluF l-124-907-11 ELECT 1OuF l-124-907-11 ELECT 1OuF < FILTER > 1-567-097-61 FILTER, CERAMIC (10.7MHz) l-567-097-61 FILTER, CERAMIC (10.7MHz) 10% 5ov 5 % 5ov 5 % 5ov 0.5PF 50V 5 % 5ov 20% 5ov 10% 5ov 5ov 20% 5ov 20% 1oov 20% 5ov 20% 5ov 20% 5ov 5ov 20% 5ov 20% 5ov < CONNECTOR > * CN152 l-565-980-11 HOUSING,CONNECTOR(PC BOARD) 9P < VARIABLE CAPACITOR > ;;;:;) l-141-458-11 CAP, VAR (RADIO TUNING) < DIODE > D 3 8-719-109-93 DIODE RD6.2ES-B2 < FILTER > FL1 l-236-022-11 FILTER BAND PASS 1 The components identified by mark A or dotted line with mark A are critical for safety. Replace only with part number specified. -24- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description < IC > ICl Ll LZ-1 * 12-z 13 L 4 Ii1 1-249-429-11 CARBON 10K 5% Il.2 1-249-421-11 CARBON 2.2K 5% R3 l-249-405-11 CARBON 100 5% R4 1-249-423-11 CARBON 3.3K 5% R7 l-249-409-11 CARBON 220 5% R8 1-249-417-11 CARBON 1K 5% Sl Tl 8-752-061-79 I C CX20111-T6 < COIL > l-402-523-11 ANTENNA, FERRITE-ROD (AM) l-406-042-00 COIL, FM OSC l-426-074-00 COIL, FM RF (A) l-422-131-00 COIL, FM OSCILLATION l-406-087-11 COIL, OSC (AM) < RESISTOR > < SWITCH > l-554-061-00 SWITCH, SLIDE (MODE) < ENCAPSULATED COMPONENT > 1-236-385-11 ENCAPSULATED COMPONENT Remark 1/4w 1/4w 1/4w L/4W 1/4w 1/4w **************t*****+*tt2rr*r*******r* MISCELLANEOUS ************* A68 l-546-075-11 CATHODE-RAY TUBE, B/W (E2282) A69 1-451-365-21 DEFLECTION YOKE ANT1 l-501-596-11 ANTENNA, TELESCOPIC (BLACK)...(BLACK) ANT1 l-501-596-21 ANTENNA, TELESCOPIC (WHITE)...(WHITE) SPl l-504-247-11 SPEAKER (5CM) ***********************+t*********************************~** ACCESSORIES & PACKING MATERIALS ******************************* A l-467-048-11 ADAPTOR, AC (AC-E5251 3-756-602-21 MANUAL, INSTRUCTION (ENGLISH) * 4-039-803-01 CUSHION (L) * 4-039-804-01 CUSHION (R) * 4-039-805-01 INDIVIDUAL CARTON I R Ref. No. Part No. Description - - **t*********************** HARDWARE L 1 ST *********************LL***** Remark #l #2 #3 #4 #5 7-685-648-79 SCREW +BVTP 3X12 TYPE2 N-S 7-626-323-31 SPRING PIN 4X14 7-682-548-04 SCREW +B 3X8 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT 7-685-647-79 SCREW, TAPPING, M3XlO #6 7-685-105-11 SCREW +PTP 2X8 -25- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com FD-525 9-957-689-l 1 Sony Corporation General Audio Group -26- English 93co44121 Plinted in Japan 0 1993. 3 Published by Audio Corporate Planning Group www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com