索尼SONY DVP-FX850音响电路原理图

分类：电子电工日期：2023-04-04 点击：0

SERVICE MANUAL AEP Model UK Model Russian Model PORTABLE CD/DVD PLAYER DVP-FX850 RMT-D183 SPECIFICATIONS System Laser: Semiconductor laser Signal format system: PAL (NTSC) Audio characteristics Frequency response: DVD VIDEO (PCM 48 kHz): 20 Hz to 22 kHz/ CD: 20 Hz to 20 kHz Harmonic distortion: 0.01 % Dynamic range: DVD VIDEO: 90 dB/ CD: 90 dB Wow and flutter: Less than detected value (±0.001% W PEAK) Inputs/Outputs VIDEO (video input/output): Minijack (1) Output 1.0 Vp-p/75 ohms AUDIO (audio input/output)/OPTICAL OUT (optical output): Stereo minijack/optical minijack combined (1) Output 2.0 Vrms/47 kilohms Recommended load impedance over 47 kilohms PHONES (headphones) A/B: Stereo minijack (2) Liquid Crystal Display Panel size: 8 inches wide (diagonal) Driving system: TFT active matrix Resolution: 800 × 480 (effective pixel rate: more than 99.99%) General Power requirements: DC 9.5 V (AC Adaptor/Car battery adaptor) DC 7.4 V (Battery pack) Power consumption (DVD VIDEO Playback): 23 W (when used with a battery pack) 8.5 W (when used without a battery pack, with a headphone) Dimensions (approx.): 226.2 × 32.3 × 165.3 mm (width/height/ depth) incl. projecting parts Mass (approx.): 1.045 kg Operating temperature: 5 °C to 35 °C Operating humidity: 25 % to 80 % AC Adaptor: 100-240 V AC, 50/60 Hz Car Battery Adaptor: 12 V DC Supplied accessories • Audio/video cord (mini plug × 2 y phono plug × 3) (1) • Mains lead (1) • AC adaptor (AC-FX150) (1) • Car battery adaptor (DCC-FX150) (1) • Battery pack (NP-FX110) (1) • Remote (with battery) (1) • Carry case (1) Desing and specifications are subject to change without notice. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com – 2 – WARNING!! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 25 cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous ra- diation exposure. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. 1. Check the area of your repair for unsoldered or poorly-sol- dered connections. Check the entire board surface for solder splashes and bridges. 2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors. 3. Look for unauthorized replacement parts, particularly transis- tors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: CAUTION: The use of optical instrument with this product will increase eye hazard. Unleaded solder Boards requiring use of unleaded solder are printed with the lead- free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.) : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder. 4. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recom- mend their replacement. 5. Check the B+ voltage to see it is at the values specified. �� www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com – 3 – TABLE OF CONTENTS Section Title Page Section Title Page 1. GENERAL Precautions ................................................................... 1-1 About This Manual ........................................................ 1-1 This Player Can Play the Following Discs .................... 1-1 Preparations .................................................................. 1-2 Playing Discs ................................................................. 1-3 Enjoying DivX Videos .................................................... 1-7 Settings and Adjustments ............................................. 1-8 Hookups ........................................................................ 1-9 Additional Information ................................................... 1-10 2. DISASSEMBLY 2-1. MAIN Board, USB Board............................................... 2-1 2-2. Traverse ......................................................................... 2-2 2-3. Upper Block ................................................................... 2-3 2-4. LCD Panel Assy/DRIVER Board ................................... 2-4 3. BLOCK DIAGRAMS 3-1. Oveall Block Diagram .................................................... 3-1 4. SCHEMATIC DIAGRAMS 4-1. Frame (1/2) .................................................................... 4-1 Frame (2/2) .................................................................... 4-3 4-2. MCU & DC-DC POWER................................................ 4-5 4-3. DVD SERVO & DSP MT1389HD .................................. 4-7 4-4. SDRAM & FLASH ROM ................................................ 4-9 4-5. VIDEO OUT & PANEL CONNECT ................................ 4-11 4-6. AUDIO OUT ................................................................... 4-13 4-7. IR-KB ............................................................................. 4-15 4-8. T-CON ............................................................................ 4-17 4-9. USB ............................................................................... 4-19 5. PRINTED WIRING BOARDS 5-1. Circuit Boards Location ................................................. 5-1 5-2. MAIN Board ................................................................... 5-3 5-3. DRIVER Board .............................................................. 5-7 5-4. USB Board..................................................................... 5-9 6. WAVEFORMS AND CIRCUIT VOLTAGE 6-1. Waveforms ..................................................................... 6-1 6-2. Circuit Voltage Chart ..................................................... 6-5 7. IC PIN FUNCTION DESCRIPTION 7-1. MPEG/DSP/RF Pin Function (MAIN Board U7: MT1389HD) ...................................... 7-1 7-2. FRONT MICOM Pin Function (MAIN Board U3: Z8F0822) .......................................... 7-7 8. ELECTRICAL ADJUSTMENT 8-1. Standard Video Level .................................................... 8-1 8-2. VCOM DC Level ............................................................ 8-1 9. TROUBLESHOOTING 9-1. Electrical Trouble Shooting Guide ................................. 9-1 1. Power (DC-DC Converter) Circuit ................................. 9-1 2. MPEG Circuit ................................................................. 9-3 3. Front Circuit (Dogotrpm & Key) ..................................... 9-4 4. RF/Servo Circuit ............................................................ 9-5 9-2. LCD Trouble Shooting Guide ........................................ 9-6 10. REPAIR PARTS LIST 10-1. Exploded Views ............................................................. 10-1 10-1-1. Main Block ................................................................ 10-1 10-1-2. Upper Block .............................................................. 10-2 10-1-3. LCD Block................................................................. 10-3 10-2. Electrical Parts List ....................................................... 10-4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com – 4 – MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-1 SECTION 1 GENERAL This section is extracted from instruc- tion manual (3-100-247-11). DVP-FX850 3 Precautions Road safety Do not use the monitor unit and headphones while driving, cycling, or operating any motorized vehicle. Doing so may create a traffic hazard and is illegal in some areas. It can also be potentially dangerous to play your headsets at high volume while walking, especially at pedestrian crossings. You should exercise extreme caution or discontinue use in potentially hazardous situations. On safety Should any solid object or liquid fall into the cabinet, unplug the player and have it checked by qualified personnel before operating it any further. On power sources • The player is not disconnected from the AC power source (mains) as long as it is connected to the wall outlet, even if the player itself has been turned off. • If you are not going to use the player for a long time, be sure to disconnect the player from the wall outlet. To disconnect the AC power cord (mains lead), grasp the plug itself; never pull the cord. • Do not touch the mains lead or the AC adaptor with wet hands. Doing so may cause shock hazard. On temperature increases Heat may build up inside the player during charging or if it is being used for a long time. This is not a malfunction. On placement • Place the player in a location with adequate ventilation to prevent heat build-up in the player. • Do not place the player on a soft surface such as a rug that might block the ventilation holes. • Do not place the player in a confined space such as a bookshelf or similar unit. • To reduce the risk of fire, do not cover the ventilation of the apparatus with newspapers, tablecloths, curtains, etc. • Do not place the player in a location near heat sources, or in a place subject to direct sunlight, excessive dust, sand, moisture, rain, or mechanical shock, or in a car with its windows closed. On operation • If the player is brought directly from a cold to a warm location, or is placed in a very damp room, moisture may condense on the lenses inside the player. Should this occur, the player may not operate properly. In this case, remove the disc and leave the player turned on for about half an hour until the moisture evaporates. • When you move the player, take out any discs. If you don’t, the disc may be damaged. • Keep the lens on the player clean and do not touch it. Touching the lens may damage the lens and cause the player to malfunction. Leave the disc lid closed except when you insert or remove discs. On Liquid Crystal Display • Although manufactured with high precision technology, the LCD may occasionally display dots of various colours. That is not a malfunction. • Do not wipe the LCD surface with wet cloth. If water enters, a malfunction may result. • Do not place or drop any object onto the LCD surface. Also, do not apply pressure from hands or elbows. • If the player is brought directly from a cold to a warm location, moisture may condense over the LCD surface. In which case, wipe out the moisture with tissue paper, etc., before use. However, moisture condensation will continue if the LCD surface is cold. Wait until the surface warms to room temperature. On AC adaptor • Use the supplied AC adaptor for this player, as other adaptors may cause a malfunction. Install this system so that the mains lead can be unplugged from the wall socket immediately in the event of trouble. ,continued 4 • Do not confine the AC adaptor in a closed place such as a bookshelf or an AV cabinet. • Do not connect the AC adaptor to a traveler’s electric transformer, which may generate heat and cause a malfunction. On battery pack • Certain countries may regulate disposal of the battery used to power this product. Please consult with your local authority. • Because of the battery’s limited life, its capacity gradually deteriorates over time and repeated use. Purchase a new one when the battery holds about only half the normal period. • The battery may not be charged to its fullest capacity when charged for the first time, or when it has not been used for a long time. The capacity recovers after being charged and discharged several times. • Do not leave the battery pack in a car or direct sunlight, where temperature goes up above 60 ºC. • Do not expose to water. • Avoid short-circuiting the battery connecting jacks (A) located on the bottom of the player and the connecting jacks (C) on the battery pack with metal objects such as a necklace. • Make sure dust or sand does not enter the battery connecting jacks (A) and the guide holes (B) located on the bottom of the player, and the connecting jacks (C) and the guide holes (D) on the battery pack. On car adapter • Use the supplied car adaptor for this player, as other adaptors may cause a malfunction. • Do not dissemble or reverse-engineer. • Do not drop or apply shock. • Do not touch the metal parts, as it may cause a short and damage the car adaptor, especially if touched by other metal objects. • Do not place the car adaptor in a location near heat sources, or in a place subject to direct sunlight or mechanical shock, or in a car with its windows closed. On adjusting volume Do not turn up the volume while listening to a section with very low level inputs or no audio signals. If you do, the speakers may be damaged when a peak level section is played. On headphones • Preventing hearing damage Avoid using headphones at high volumes. Hearing experts advice against continuous, loud, and extended play. If you experience a ringing in your ears, reduce the volume or discontinue use. • Showing consideration for others Keep the volume at a moderate level. This will allow you to hear outside sounds and still be considerate to the people around you. On cleaning Clean the cabinet, panel, and controls with a soft cloth slightly moistened with a mild detergent solution. Do not use any type of abrasive pad, scouring powder or solvent such as alcohol or benzine. On cleaning discs, disc/lens cleaners Do not use cleaning discs or disc/lens cleaners (including wet or spray types). These may cause the apparatus to malfunction. If you have any questions or problems concerning your player, please consult your nearest Sony dealer. B A Bottom of the player D C Battery pack IMPORTANT NOTICE Caution: This player is capable of holding a still video image or on-screen display image on your television screen indefinitely. If you leave the still video image or on-screen display image displayed on your TV for an extended period of time you risk permanent damage to your television screen. Plasma display panel televisions and projection televisions are susceptible to this. 6 About This Manual • Instructions in this manual describe the controls on the remote. You can also use the controls on the player if they have the same or similar names as those on the remote. • “DVD” may be used as a general term for DVD VIDEOs, DVD+RWs/DVD+Rs (+VR mode) and DVD-RWs/DVD-Rs (VR mode, video mode). • The meaning of the icons used in this manual is described below: Icons Meaning Functions available for DVD VIDEOs and DVD+RWs/DVD+Rs in +VR mode or DVD-RWs/DVD-Rs in video mode Functions available for DVD-RWs/DVD-Rs in VR (Video Recording) mode Functions available for VIDEO CDs (including Super VCDs or CD-Rs/CD- RWs in video CD format or Super VCD format) Functions available for music CDs or CD-Rs/CD-RWs in music CD format Functions available for DATA CDs (CD-ROMs/CD-Rs/CD-RWs containing MP3*1 audio tracks, JPEG image files, and DivX*2*3 video files) Functions available for DATA DVDs (DVD-ROMs/DVD+RWs/DVD+Rs/ DVD-RWs/DVD-Rs containing MP3*1 audio tracks, JPEG image files, and DivX*2*3 video files) Functions available for USB devices containing MP3*1 audio tracks, and JPEG image files *1 MP3 (MPEG-1 Audio Layer III) is a standard format defined by ISO (International Organization for Standardization)/IEC (International Electrotechnical Commission) MPEG which compresses audio data. *2 DivX® is a video file compression technology, developed by DivXNetworks, Inc. *3 DivX, DivX Certified, and associated logos are trademarks of DivXNetworks, Inc. and are used under licence. 7 This Player Can Play the Following Discs “DVD+RW,” “DVD-RW,” “DVD+R,” “DVD-R,” “DVD VIDEO,” and “CD” logos are trademarks. Note about CDs/DVDs The player can play CD-ROMs/CD-Rs/CD- RWs recorded in the following formats: – music CD format – video CD format – MP3 audio tracks, JPEG image files, and DivX video files of format conforming to ISO 9660* Level 1, or its extended format, Joliet – KODAK Picture CD format * A logical format of files and folders on CD- ROMs, defined by ISO (International Organization for Standardization). The player can play DVD-ROMs/ DVD+RWs/DVD-RWs/DVD+Rs/DVD-Rs recorded in the following format: – MP3 audio tracks, JPEG image files, and DivX video files of format conforming to UDF (Universal Disk Format). Example of discs that the player cannot play The player cannot play the following discs: • Blu-ray discs. • Discs recorded in AVCHD format. • HD DVDs. • DVD-RAMs. • CD-ROMs/CD-Rs/CD-RWs other than those recorded in the formats listed on this page. • CD-ROMs recorded in PHOTO CD format. • Data part of CD-Extras. • DVD Audio discs. • DATA DVDs that do not contain MP3 audio tracks, JPEG image files, or DivX video files. • HD layer on Super Audio CDs. Also, the player cannot play the following discs: • A DVD VIDEO with a different region code. • A disc that has a non-standard shape (e.g., card, heart). • A disc with paper or stickers on it. • A disc that has the adhesive of cellophane tape or a sticker still left on it. Notes • Notes about DVD+RWs/DVD+Rs, DVD-RWs/ DVD-Rs or CD-Rs/CD-RWs Some DVD+RWs/DVD+Rs, DVD-RWs/DVD- Rs, or CD-Rs/CD-RWs cannot be played on this player due to the recording quality or physical condition of the disc, or the characteristics of the recording device and authoring software. The disc will not play if it has not been correctly finalized. For more information, refer to the operating instructions for the recording device. Note that some playback functions may not work with some DVD+RWs/DVD+Rs, even if they have been correctly finalized. In this case, view the disc by normal playback. Also some DATA CDs/DATA DVDs created in Packet Write format or multiple sessions cannot be played. • Notes about DVD+R DLs/DVD-R DLs MP3 and JPEG files recorded on the second layer of a DVD+R DL/-R DL (double layered) cannot be played. DVD-R DL discs recorded in VR mode cannot be played. Format of discs DVD VIDEO DVD-RW/-R (finalized disc) DVD+RW/+R (finalized disc) VIDEO CD/ Music CD CD-RW/-R ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-2 8 • Music discs encoded with copyright protection technologies This product is designed to playback discs that conform to the Compact Disc (CD) standard. Recently, various music discs encoded with copyright protection technologies are marketed by some record companies. Please be aware that among those discs, there are some that do not conform to the CD standard and may not be playable by this product. • Note on DualDiscs A DualDisc is a two sided disc product which mates DVD recorded material on one side with digital audio material on the other side. However, since the audio material side does not conform to the Compact Disc (CD) standard, playback on this product is not guaranteed. Region code It is the system that is used to protect copyrights. The region code is shown on the DVD VIDEO packages according to the region of sale. DVD VIDEOs labelled “ALL” or “2” will play on this player. Note on playback operations of DVDs and VIDEO CDs Some playback operations of DVDs and VIDEO CDs may be intentionally set by software producers. Since this player plays DVDs and VIDEO CDs according to the disc contents the software producers designed, some playback features may not be available. Also, refer to the instructions supplied with the DVDs or VIDEO CDs. Copyrights This product incorporates copyright protection technology that is protected by U.S. patents and other intellectual property rights. Use of this copyright protection technology must be authorized by Macrovision, and is intended for home and other limited viewing uses only unless otherwise authorized by Macrovision. Reverse engineering or disassembly is prohibited. Trademarks • Manufactured under license from Dolby Laboratories. “Dolby,” “Pro Logic,” and the double-D symbol are trademarks of Dolby Laboratories. • “DTS” and “DTS Digital Out” are registered trademarks of DTS, Inc. ALL 9 Preparations Preparations Checking the Accessories Check that you have the following items: • Audio/video cord (mini plug × 2 y phono plug × 3) (1) • Mains lead (1) • AC adaptor (AC-FX150) (1) • Car battery adaptor (DCC-FX150) (1) • Battery pack (NP-FX110) (1) • Remote (with battery) (1) • Carry case (1) Using the Remote When operating, point it at the remote sensor on the player. To replace the remote control battery Insert a lithium battery CR2025 matching the 3 and # ends of the battery. 1 Pull out the battery holder (2) while pressing the lock lever (1). 2 Remove the old battery. 3 Insert the new battery in the battery holder with the 3 side up and then push the holder fully. Notes • Do not expose the remote sensor to direct sunlight or a lighting apparatus. Doing so may cause a malfunction. • No button operation can be made, when the battery drains. If the remote does not work at all, change the battery and check the status. • When disposing the used batteries, follow the battery maker’s instructions. 10 Using the LCD Panel The LCD panel of the player can rotate a maximum of 180 degrees clockwise and still be used. After rotation of the LCD panel, it can be folded down on the main body of the player and still function. Rotating the LCD panel 1 Place the player on a table or other flat stable surface. 2 Push the LCD panel up with your thumbs until it is open to the vertical position. 3 Slowly rotate the LCD panel 180 degrees in the direction indicated by the arrow (clockwise). Rotating and folding down the LCD panel After rotating the LCD panel 180 degrees clockwise push the LCD panel down onto the main body of the player. In this position the panel is facing up. To return the LCD panel to its original position Open the LCD panel to the vertical position and rotate the LCD panel counter-clockwise slowly. Notes • Do not rotate the LCD panel over 180 degrees. In addition, do not rotate in the opposite direction. Doing so will break the LCD panel. • If the LCD panel does not fully open, do not further rotate it. The LCD panel may become damaged. • Return the LCD panel to its original positions after use. The LCD screen can be damaged by sudden shocks or similar treatment. 11 Preparations Connecting the AC Adapter Connect the AC adaptor (supplied) in the order of 1 to 3 below. To disconnect, follow the steps in reverse order. See also “On AC adaptor” in “Precautions” (page 3). Note Stop playback before disconnecting the mains lead. Failure to do so, may cause a malfunction. DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT DC plug 2 To DC IN 9.5 V jack AC Adaptor (supplied) 1 Mains lead (supplied) To mains 3 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-3 12 Using with Battery Pack When a mains connection is not available, the player can be enjoyed with the battery pack (supplied) installed. Please charge the battery pack before using it. See also “On battery pack” in “Precautions” (page 4). Installing the battery pack 1 Aligning the battery pack with the lines on the player’s bottom, engage the hooks of the battery pack in the holes on the bottom of the player. 2 Slide the battery pack in the direction of the arrow until it clicks into place. To remove the battery pack Push the release knob and slide the battery pack in the direction of the arrow. Notes • Turn the player off before installing the battery pack. • Do not remove the battery pack during playback. • Do not touch the connecting points of the player and the battery pack. Doing so may cause a malfunction. • Be careful not to drop the battery pack when installing and removing it. Bottom of the player Battery pack Release knob 13 Preparations Charging the battery pack 1 Attach the battery pack to the player (page 12). 2 Connect the AC adaptor to the player, and then connect the mains lead into a mains (page 11). When charging begins, the CHARGE indicator LED illuminates. When charging ends, the CHARGE indicator LED extinguishes. 3 After charging is finished, disconnect the mains lead from the mains and remove the AC adaptor. To check the battery level When the player is stopped, a battery indicator is displayed on the screen. Recharge the battery, when is displayed or the CHARGE indicator flashes. The battery indicator is not displayed when a DVD, VIDEO CD or JPEG file are being played. Stop the player and check the battery level. Charging time and maximum playing time * This is the indication of the longest continuous playback on the following conditions. – normal temperature (20°C) – Headphone Use – Set Backlight Adjustment to the Minimum – Set “Digital Output” to “Off” in “Audio Setup.” Battery condition may reduce operating time. Notes • The battery indicator does not appear on the screen when the AC adaptor is used or when inputting from external sources. • Charging times may differ from that indicated above due to conditions of use, environment, and other factors. The recommended charge up surrounding temperature is in the 10-30°C range. Charging time (with the player turned off) Playing time (with the display turned on) Approx. 6 hours Approx. 6 hours* DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT VOLUME A B IN OUT HOLD CHARGE CHARGE indicator DC IN 9.5 V jack Player Battery pack Full Exhausted 14 Using With the Car Battery Adaptor Use the car battery adaptor (supplied) to supply power from the cigarette lighter socket to the player. The adaptor is for a 12V car battery. Do not use it with a 24V car battery. The adaptor is also for use with negatively grounded cars. Do not use it with cars grounded positively. z Hint If the car adaptor interferes with car operation, use a commercial cigarette lighter extension cord. Notes • Do not use the car adaptor if it has been dropped or damaged. • Arrange the cord so as not to interfere with the driver. Also, do not place the LCD panel where the driver can watch. • If the picture is not clear, keep the player away from the car battery adaptor. • Use the car battery adaptor with the car engine running. If it is used with the car engine off, the car battery may become unusable. • If the cigarette lighter socket is dirty with ash, etc, a bad connection may cause the plug to heat up. Always clean well before use. • The car battery adaptor may heat up while charging or after a long period of use. That is not a malfunction. After using the car battery adaptor After turning the player off, disconnect the car battery adaptor from the cigarette lighter socket. Notes • Do not turn off the car engine while the player is turned on. Doing so stops the power supply and may cause damage to the player. • Disconnect the car battery adaptor after use. Since some cars supply power to the cigarette lighter socket even when the engine is turned off, the vehicles battery may discharge over time. • When disconnecting the car battery adaptor, hold the plug to pull it out. • When listening to the car radio, disconnect the car battery adaptor from the cigarette lighter socket to avoid noise. DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT To cigarette lighter socket To DC IN 9.5V jack Car battery adaptor (supplied) 15 Playing Discs Playing Discs Playing Discs Depending on the DVD or VIDEO CD, some operations may be different or restricted. Refer to the operating instructions supplied with the disc. Connect the AC adaptor or install the battery pack. 1 Open the player’s LCD panel. Set the LINE SELECT switch on the player’s right side to “OUT” and set the CD/DVD USB switch on the player’s left side to “CD/DVD.” 2 Press [/1 on the remote or slide the [/1/HOLD switch of the player to the right. The player turns on and the power indicator lights up in green. 3 Slide the OPEN knob to the left and open the disc lid. 4 Insert the disc to be played. Push with the playback side down until it clicks. 5 Push the PUSH CLOSE on the player to shut the disc lid. 6 Press H. Playback starts. • Some discs may start playing automatically after the disc lid is shut. • Depending on the disc, a menu may appear on the screen. For DVD VIDEOs, see page 17. For VIDEO CDs, see page 20. • After all titles have been played, the player will stop itself and the display will return to the menu screen. Notes • If the disc is inserted with playback side up, a “No Disc” message appears. • Discs created on DVD recorders must be correctly finalized to play on this player. For more information about finalizing, refer to the operating instructions supplied with the DVD recorder. RETURN OPTIONS MENU DISPLAY OPEN HOLD CHARGE x H OPEN knob \/1/HOLD 1 2 3 4 5 6 7 8 0 9 \/1 H x Playback side facing down ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-4 16 • The disc may be still spinning when the disc lid is opened. Wait until the spinning stops before removing the disc. • During operation, “ ” may appear on the screen. This symbol indicates that a function explained in this operating instruction is not available on the current DVD VIDEO. • Some DVD-RWs/DVD-Rs (VR mode) may take time before starting playback because of the recorded content. To adjust the volume Adjust to the preferred level using the VOLUME button on the right side of the player. To stop playback Press x. Pressing H again will start playback from the point you stopped (Resume Play). To play from the beginning, press x twice, then press H. To turn off the power Press the remote’s \/1 button or slide the player’s \/1/HOLD switch to the right. To avoid accidental button operation on the player Set the player’s \/1/HOLD switch to “HOLD.” All the buttons on the player are locked, while the button on the remote remains operable. To play DTS sound tracks on a DVD VIDEO • The player’s speaker does not output DTS sound. When you play DTS sound tracks on a DVD VIDEO, connect the player to an AV amplifier (receiver) (page 40) and set up “DTS” in “Audio Setup” (page 36). • If you connect the player to audio equipment such as an AV amplifier (receiver) without a DTS decoder, do not set “DTS” to “On” in “Audio Setup” (page 36). A loud noise may come out from the speakers, which may affect your ears or cause speaker damage. Notes • A screen saver image appears when you leave the player in pause or stop without operation for more than 15 minutes. The image disappears when you press H. See page 35 for details. • The player turns off, 15 minutes after starting the screen saver function (Auto Power Off). Additional playback operations * DVD VIDEOs, DVD-RWs/DVD-Rs (VR mode) only. The above functions may not be used for some scenes. VOLUME Min Max To Operation Stop Press x Pause Press X Go to the next chapter, track, or scene in continuous play mode Press > Go back to the previous chapter, track, or scene in continuous play mode Press . Briefly fast forward the current scene* Press during playback. 1 2 3 4 5 6 7 8 0 9 . > X x 17 Playing Discs Resuming playback from the point where you stopped the disc (Resume Play) When you stop playback, the player remembers the stop point and displays a message on the screen. You can resume from the same point by pressing H again. Resume Play works even after the player is turned off, as long as the disc lid is kept closed. 1 While playing a disc, press x to stop playback. A message appears. 2 Press H. The player starts playback from the point you stopped in step 1. z Hints • To play from the beginning of the disc, press x twice, then press H. • When turning power on again after power off, resume play starts automatically. Notes • Depending on the stop point, Resume play may not start from exactly the same point. • The point where you stopped playing is cleared when: – you turn off the player while playing a DVD- RW/DVD-R (VR mode). – you open the disc lid. – you disconnect the battery pack and the AC adaptor. Using the DVD’s menu A DVD is divided into long sections of a picture or a music feature called “titles.” When you play a DVD containing several titles, you can select the title you want using the TOP MENU button. When you play DVDs that allow you to select items such as language for the sound and subtitles, select these items using the MENU button. 1 Press TOP MENU or MENU. The disc’s menu appears on the screen. The contents of the menu vary from disc to disc. 2 Press C/X/x/c or the number buttons to select the item you want to play or change. 3 Press ENTER. Note Depending on the disc, you may not be able to use C/c of the player for the disc menu. In this case, use C/c on the remote. 1 2 3 4 5 6 7 8 0 9 H x 1 2 3 4 5 6 7 8 0 9 TOP MENU C/X/x/c ENTER MENU Number buttons ,continued 18 Changing the sound When playing a DVD VIDEO recorded in multiple audio formats (PCM, Dolby Digital, or DTS), you can change the audio format. If the DVD VIDEO is recorded with multilingual tracks, you can also change the language. With CDs or VIDEO CDs, you can select the sound from either the right or left channel and listen to the sound of the selected channel through both the right and left speakers. For example, when playing a disc containing a song with the vocals on the right channel and the instruments on the left channel, you can hear the instruments from both speakers by selecting the left channel. 1 Press AUDIO repeatedly to select the desired audio signal. The default setting is underlined. ◆ When playing a DVD VIDEO Depending on the DVD VIDEO, the choice of language varies. When the same language is displayed two or more times, the DVD VIDEO is recorded in multiple audio formats. ◆ When playing a DVD-VR mode disc The types of sound tracks recorded on a disc are displayed. Example: • 1.Main (main sound) • 1.Sub (sub sound) • 1.Main+Sub (main and sub sound) ◆ When playing a CD/VIDEO CD • Stereo: the standard stereo sound • Left: the sound of the left channel (monaural) • Right: the sound of the right channel (monaural) ◆ When playing a Super VCD • Stereo: the stereo sound of the audio track 1 • Left: the sound of the left channel of the audio track 1 (monaural) • Right: the sound of the right channel of the audio track 1 (monaural) • Stereo 1: the stereo sound of the audio track 2 • Left 1: the sound of the left channel of the audio track 2 (monaural) • Right 1: the sound of the right channel of the audio track 2 (monaural) z Hints • You can check of the current audio format (Dolby Digital, DTS, PCM, etc.) by pressing AUDIO repeatedly while playing a DVD VIDEO. • You can switch the sound in the Playback Settings Display while playing a DVD (page 21). Notes • Depending on the disc, you may not be able to change the audio format, even if it is recorded in multiple audio formats. • When playing a Super VCD that does not contain audio track 2, no sound will come out if you select “Stereo 1,” “Left 1,” or “Right 1.” • When playing soundtracks on DVD-RW/DVD-R (VR mode) with audio equipment such as an AV amplifier (receiver) connected via the OPTICAL OUT jack, set “Dolby Digital” in “Audio Setup” to “Downmix PCM” (page 36). • If “DTS” in “Audio Setup” is set to “Off” (page 36), the player does not output the DTS signal from the OPTICAL OUT jack even when the disc contains a DTS track. • When playing DTS sound tracks on a CD, you cannot change the sound. 1 2 3 4 5 6 7 8 0 9 AUDIO 19 Playing Discs Displaying the subtitles If subtitles are recorded on the disc, you can change the subtitles or turn them on and off whenever you want while playing a DVD. 1 Press SUBTITLE repeatedly to select a setting. Depending on the disc, the choice of language varies. To turn off the subtitles Select “Subtitle Off” in step 1. z Hint You can switch the subtitles in the Playback Settings Display while playing a DVD (page 21). Notes • Depending on the DVD VIDEO, you may not be able to change the subtitles even if multilingual subtitles are recorded on it. You also may not be able to turn them off. • While you play a disc with subtitles, the subtitle may disappear when you press . Changing the angles If various angles (multi-angles) for a scene are recorded on the DVD VIDEO, “ ” appears on the screen. This means that you can change the viewing angle. 1 Press ANGLE repeatedly to select an angle number. The scene changes to the selected angle. Notes • Some DVD VIDEOs prohibit changing angles even when multi-angles are recorded. • You cannot change angles during Slow Play or Scan Play. • “ ” (angle mark) does not appear when “Angle Mark” in “General Setup” is set to “Off” (page 35). 1 2 3 4 5 6 7 8 0 9 SUBTITLE 1 2 3 4 5 6 7 8 0 9 ANGLE ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-5 20 Selecting “Original” or “Play List” on a DVD-RW/DVD-R Some DVD-RWs/DVD-Rs in VR (Video Recording) mode have two types of title for playback: originally recorded titles (Original), and titles that can be created on recordable DVD players for editing (Play List). You can select the type of title to be played. 1 Press TOP MENU when the player is in stop mode. The current mode appears. The TOP MENU button does not work when Resume Play is activated. Cancel the Resume Play status first by pressing x twice, and then press TOP MENU. 2 Switch the mode by pressing TOP MENU repeatedly. z Hint You can check the current mode by pressing DISPLAY during playback. On the Playback Settings Display (page 21), “PL” or “ORG” will be displayed next to the title number. Notes • When a disc containing a Playlist title is inserted, the player automatically starts playing the Playlist title. • When no Playlist title is recorded, “ORG” appears in step 1. When you press TOP MENU once more, “ ” appears. Playing VIDEO CDs With PBC Functions (PBC Playback) Some VIDEO CDs have Playback Control (PBC) functions allowing for interactive search or playback options. 1 Start playing a VIDEO CD with PBC functions. The menu appears for your selection. 2 Press the number buttons to select the item number you want and press ENTER. 3 Follow the instructions on screen for interactive operations. Refer to the instructions supplied with the disc, as the operating procedure may differ depending on the VIDEO CD. z Hint To cancel the PBC function, set “PBC” to “Off” in “General Setup” (page 35) and then, open and close the disc lid. Note Depending on the VIDEO CD, “Press ENTER” in step 2 may appear as “Press SELECT.” In this case, press H. 1 2 3 4 5 6 7 8 0 9 TOP MENU ENTER H Number buttons 1 2 3 4 5 6 7 8 0 9 21 Playing Discs Using the Playback Settings Display While playing a DVD, you can check the current playback settings on the screen. The Playback Settings Display also allows you to change sound, subtitle, and angle or search for a title or track by inputting numbers. 1 Press DISPLAY while playing a DVD. The Playback Settings Display appears. Example: When playing a DVD VIDEO The corresponding icon for Play, Pause, Search, or Slow Play is displayed in the upper right corner of the screen. When a DVD-RW/DVD-R (VR mode) is played, “PL” or “ORG” is displayed next to the title number. 2 Press X/x to select the desired item and press ENTER. • Title • Chapter • Audio • Subtitle • Angle • T.Time • C.Time • Repeat • Time Disp. 3 Press X/x to select the setting, and press ENTER. To enter numbers, use the number buttons or X/x. Note Depending on the disc, you may not be able to set some options. To turn off the display Press DISPLAY or O RETURN. Searching for a title/chapter, etc. By entering the number or the time code, you can search a DVD by title or chapter. 1 Press X/x to select the search method on the Playback Settings Display, and press ENTER. • Title • Chapter • T.Time* • C.Time* * You can search the title or chapter of a DVD VIDEO by entering the time code. 2 Press the number buttons or X/x to select the title or chapter number, and press ENTER. The player starts playback from the selected number. When you select “T.Time” or “C.Time” in step 1, “00:00:00” will appear on the screen. Enter the desired time code using the number buttons, and press ENTER. Playback starts from the entered time code. Elapsed or remaining time appears on the footer of the Playback Settings Display. z Hints • You can use direct search without displaying the control menu. See page 23 for details. 1 2 3 4 5 6 7 8 0 9 Number buttons DISPLAY C/X/x/c ENTER O Menu Title Chapter Audio Subtitle 02/07 03/20 02 2CH DOLBY DIGITAL English 01 English Title Elapsed 00:12:01 Current playback settings Items Elapsed or remaining time Battery status ,continued 22 • See page 23 for details about using direct search for a CD or VIDEO CD. Notes • The displayed title/chapter number is the same as the number recorded on the disc. • Chapter times are not displayed when a DVD- RW/DVD-R (VR mode) is played. Chapter time will be displayed as “--:--:--.” • Depending on the disc, you may not be able to use the time code. Playing a DVD VIDEO repeatedly (Repeat Play) You can play all of the titles on a DVD VIDEO, or a single title or chapter repeatedly. 1 Select “Repeat” on the Playback Settings Display, and press ENTER. 2 Press X/x to select the setting, and press ENTER. • Chapter: repeats the current chapter. • Title: repeats the current title. • All: repeats all of the titles. To return to normal play Select “Off” in step 2. z Hint When playing a VCD or CD repeatedly, use OPTIONS (page 24). Note Depending on the disc, the Repeat function may not be available. Checking the playing time and remaining time You can check the playing time and remaining time of the current title or chapter. 1 Select “Time Disp.” on the Playback Settings Display, and press ENTER. 2 Press X/x to select the time information setting, and press ENTER. • Title Elapsed • Title Remain • Chapter Elapsed • Chapter Remain z Hint See page 25 for details about displaying the elapsed time of a CD or VIDEO CD. Notes • In the case of DVD-RWs/DVD-Rs (VR mode), the playing time and remaining time of the chapter is not displayed. • The default setting for “Time Disp.” is “Title Elapsed.” After selecting an other option of “Time Disp.” and exiting from the Playback Settings Display, the “Title Elapsed” appears when the Playback Settings Display is re-entered. Time Disp. Title Elapsed Title Remain Chapter Elapsed Chapter Remain Title Elapsed 00:12:48 23 Playing Discs Searching for a Particular Point on a Disc (Search, Scan, Slow Play, Repeat Play, Random Play) You can quickly locate a particular point on a disc by monitoring the picture or playing back slowly. Notes • Depending on the disc, you may not be able to perform some of the operations described. • For DATA CDs/DATA DVDs, you can search for a particular point only on an MP3 audio track. Locating a point quickly using the ./> PREV (previous)/ NEXT buttons (Search) During playback, press > or . once briefly to go to the next or previous chapter/ track/scene. z Hints When you know the title or chapter number, you can search directly by entering these numbers using the number buttons. • While playing a DVD VIDEO, you can search for a title or chapter using the number buttons and ENTER. Press C/c to switch between title and chapter. • While playing CDs/VIDEO CDs, you can search for a track using the number buttons and ENTER. Locating a point quickly by playing a disc in fast forward or fast reverse (Scan) Press m or M to fast reverse or fast forward during playback. To return to normal play, press H. Each time you press m or M during scan, the scan speed changes. With each press the indication changes as shown below. ◆ Playback direction ◆ Opposite direction The “3M”/“3m” playback speed is faster than “2M”/“2m” and the “2M”/“2m” playback speed is faster than “1M”/“1m.” z Hint C/c on the player works the same as m/M on the remote, and ENTER on the player works the same as H on the remote. This function is effective when you play back a DVD. 1 2 3 4 5 6 7 8 0 9 M m > OPTIONS H . DISPLAY H t 1M t 2M t 3M H t 1m t 2m t 3m ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-6 24 Notes • No sound is output during Scan play for a DVD or VIDEO CD. • Scan speed differs depending on the disc type. Watching frame by frame (Slow Play) Press m or M when the player is in pause mode. To return to normal speed, press H. Each time you press m or M during Slow Play, the playback speed changes. With each press the indication changes as follows: ◆ Playback direction ◆ Opposite direction (DVD only) The “3 ”/“3 ” playback speed is slower than “2 ”/“2 ” and the “2 ”/“2 ” playback speed is slower than “1 ”/“1 .” Note Slow speed differs depending on the disc type. Playing CD/VIDEO CD repeatedly or in random order (Repeat Play, Random Play) You can play all of the tracks on a disc, or a single track repeatedly (Repeat Play). Also, you can play the tracks in random order, too (Random Play). 1 Press OPTIONS repeatedly during playback to select the playback mode. • Track: repeats the current track. • All: repeats all tracks on the disc. • Random: plays all tracks on the disc randomly. To return to normal play Select “ Off” in step 1. z Hint During Random Play, you can start playing other randomly selected track by pressing > twice. Notes • You cannot use Repeat Play and Random Play with VIDEO CDs or Super VCDs with PBC playback. • Depending on the disc, Random Play may not be available. • The same track may be repeated several times in Random Play. H t 1 t 2 t 3 H t 1 t 2 t 3 25 Playing Discs Checking the play information of the disc When playing a DVD Press DISPLAY while playing a DVD, and then use the Playback Settings Display (page 21). When playing a CD Press DISPLAY. The playing track number/the total number of tracks and the elapsed time of the current track appear. Press DISPLAY repeatedly to switch the time information as below. • Track Elapsed • Track Remain • Disc Elapsed • Disc Remain When playing a VIDEO CD Press DISPLAY. The player displays “PBC On” (when you set “PBC” to “Off,” the player displays the playing track number/the total number of tracks), the elapsed time, and the audio mode on the screen. Playing MP3 Audio Tracks or JPEG Image Files You can play MP3 audio tracks and JPEG image files on DATA CDs (CD-ROMs/CD- Rs/CD-RWs) or DATA DVDs (DVD-ROMs/ DVD+RWs/DVD+Rs/DVD-RWs/DVD-Rs) or USB devices. For playable MP3 audio files and JPEG image files, refer to page 44. When you insert DATA CDs and DATA DVDs, the list of albums appears. To play back data on a USB device 1 Set the CD/DVD USB switch on the player’s left side to “USB.” 2 Connect the USB device to the USB jack on the player’s left side. To disconnect a USB device 1 Set the CD/DVD USB switch to “DVD/ CD.” 2 Disconnect a USB device. 1 2 3 4 5 6 7 8 0 9 MENU x . C/X/x/c ENTER X H > USB device CD/DVD USB switch ,continued 26 Compatible Sony USB devices JPEG and MP3 file playback via USB port is confirmed with Sony’s USB Memory Stick Reader/Writer and USB Flash drive “Pocket Bit.” (Confirmed device: MSAC-US40, USM-EX series, USM-J series, USM-JX series, USM-H series) Notes • Do not disconnect the USB device while its access indicator is flashing. Doing so may cause data corruption or loss of data. • The access indicator on some USB devices may keep flashing even after the data is transferred. • USB devices which can connect to the player are flash memory and multiple card reader. Other devices (digital still camera, USB hub, etc.) cannot be connected. When an incompatible device is connected, “Cannot recognise the connected device.” appears indicating that the device is unrecognizable. • DATA CDs recorded in KODAK Picture CD format automatically start playing when inserted. Playing an MP3 audio track 1 Press X/x to select an album on the list, and press ENTER. The list of tracks in the album appears. • To go to the next or previous page, press > or .. • To return to the list of albums, press X/ x to select and press ENTER. 2 Press X/x to select the track you want to play, and press ENTER. Playback starts from the selected track. To go to the next or previous MP3 audio track Press > or .. To stop playback Press x. Notes • The total albums and files the player can recognize is approximately 648. • The number of albums in a disc the player can recognize is approximately 299. . . MY BEST 001/003 03 Wing 02 Fire 01 Stardust 27 Playing Discs Playing a JPEG image file 1 Press X/x to select an album on the list, and press ENTER. The list of files in the album appears. • To go to the next or previous page, press > or .. • To return to the list of albums, press X/ x to select and press ENTER. 2 Press X/x to select the image you want to view, and press ENTER. The selected image appears. Example: To display the list of thumbnails Press MENU when a file is displayed on the screen. The image files in the album appear in 12 subscreens with the displayed file in the lead. • To move to the previous or next page of the thumbnail list display, select “bPrev” or “NextB” under the screen. • To exit the list of thumbnails, press MENU. To go to the next or previous JPEG image file Press > or .. To rotate a JPEG image Press C/X/x/c while viewing the image. X: Reverses the image vertically (up and down). x: Reverses the image horizontally (left and right). c: Rotates the image 90 degrees clockwise. C: Rotates the image 90 degrees counter clockwise. Note that the view also returns to normal if you press ./> to go to the next or previous image. Example: when C is pressed once. To stop viewing the JPEG image Press x. The display returns to the list of files. Notes • Images may take time to appear due to the number of recorded files or the size of the folders. If no image appears after a few minutes, some of the files included may be too large. • Some JPEG files, especially progressive JPEG files or JPEG files of 3,000,000 pixels or more, may take longer to display than others. • The player cannot play the JPEG image file that is larger than 3078 (width) x 2048 (height) in normal mode, or more than 3,300,000 pixels in progressive JPEG. (Some progressive JPEG files cannot be displayed even if the size is within this specified capacity.) • The total albums and files the player can recognize is approximately 648. • The number of albums in a disc the player can recognize is approximately 299. DSC00005 DSC00004 DSC00003 DSC00002 DSC00001 . . HAWAII 001/028 1 2 3 4 5 6 7 8 9 10 11 12 ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-7 28 Enjoying JPEG Images as a Slide Show You can play JPEG image files on a DATA CD or DATA DVD successively as a slide show. 1 While displaying the file you want to start a slideshow, press MENU. The list of thumbnails appears. 2 Press C/X/x/c to select “Slide Show” at the bottom of the screen, and press ENTER. A slideshow starts from the displayed file. To pause slideshow Press X. By pressing X again or H, you can return to slideshow. To stop slideshow Press x or MENU. Adjusting the Picture Size and Quality You can adjust the picture displayed on the LCD screen. See “General Setup” (page 34), when outputting the video signal to TV, etc. 1 Press OPTIONS. The Option Menu appears. 2 Press X/x to select “LCD Mode” and press ENTER. The items for “LCD Mode” appear. 3 Press X/x to select items and press ENTER. • LCD Aspect: Change the picture size. Select Normal or Full by pressing X/x*. • Backlight: Adjust the brightness of the LCD screen by pressing C/c. • Contrast: Adjust the difference between light and dark areas by pressing C/c. • Hue: Adjust the red and green colour balance by pressing C/c. • Color: Adjust the richness of colours by pressing C/c. • Default: Returns all settings to the factory defaults. * In “Normal,” the pictures are displayed in the original configuration, retaining the aspect ratio. For example, a 4:3 picture will have black bands on both sides, and the letterbox pictures recorded either in 16:9 or 4:3 will have black bands on all 1 2 3 4 5 6 7 8 9 10 11 12 1 2 3 4 5 6 7 8 0 9 C/X/x/c ENTER OPTIONS 29 Playing Discs sides. In “Full,” a 16:9 picture will be adjusted to fill the entire screen. z Hints • The screen turns off automatically when the LCD panel is closed. • You can see the settings for the display in “General Setup” (page 34). Notes • The screen size you can select differs depending on the DVD. • You cannot select “Normal” for a DVD recorded in “16:9.” • You cannot adjust the picture size and quality when playing a VIDEO CD with “PBC” set to “Off.” 30 Enjoying DivX® Videos Playing DivX Video Files You can play DivX video files on DATA CDs (CD-ROMs/CD-Rs/CD-RWs) and DATA DVDs (DVD-ROMs/DVD+RWs/DVD+Rs/ DVD-RWs/DVD-Rs). When you insert DATA CDs and DATA DVDs, the list of albums appears. Notes • When the selected file is not supported, “Data Error (DivX)” displays on the screen and the file will not be played. • Depending on the DivX video file, the picture may pause or be unclear. In which case, it is recommended that you create the file at a lower bit rate. If the sound is still noisy, MP3 is the recommended audio format. Note, however, this player does not conform to WMA (Windows Media Audio) format. • Because of the compression technology used for DivX video files, it may take some time after you press H (play) for the picture to appear. • Depending on the DivX video file, the sound may not match the pictures on the screen. • The player’s speaker does not output DTS sound. When you play DTS sound tracks on a DivX, connect the player to an AV amplifier (receiver) (page 40) and set up “DTS” in “Audio Setup” (page 36). • Depending on the DivX video file, you may not be able to perform some operations. Playing a DivX video file 1 Press X/x to select an album on the list, and press ENTER. A list of files in the album appears. • To go to the next or previous page, press > or .. • To return to the list of albums, press X/ x to select and press ENTER. 2 Press X/x to select the file you want to play, and press ENTER. Playback starts from the selected file. To go to the next or previous DivX video file Press > or .. To locate a point quickly by playing DivX video files in fast forward or fast reverse (Scan) Press M/m repeatedly to select the required speed for the search mode during playback. To watch frame by frame (Slow Play) Press M repeatedly in pause mode to select the required slow motion speed. To display the playback information Press DISPLAY repeatedly. The playback information changes as follow order, “Title Elapsed,” “Title Remain,” “Display Off,” and “Subtitle.” To change the sound Press AUDIO repeatedly during playback to select the desired audio signal. If “No Audio” appears, the player does not support the audio signal format contained in the disc. 1 2 3 4 5 6 7 8 0 9 C/X/x/c ENTER DISPLAY > . M AUDIO SUBTITLE x m . . MY FAVORITE 001/002 02 VENUS 01 HAWAII 31 Enjoying DivX® Videos To change the subtitles Press SUBTITLE during playback. Press X/x, and ENTER during displaying the subtitle information. To stop playback Press x. z Hint If the number of viewing times is preset, you can play the DivX video files as many times as the preset number. The following occurrences are counted: – when the player is turned off. This includes when the player is automatically turned off by the Auto Power Off function. Press X instead of x to stop viewing. – when the disc lid is opened. – when another file is played. Note The slow reverse function is prohibited. About DivX Video Files DivX® is a video file compression technology, developed by DivX, Inc. This product is an official DivX® Certified product. You can play DATA CDs and DATA DVDs that contain DivX video files. DATA CDs and DATA DVDs that the player can play This player only plays DATA CDs whose logical format is ISO 9660 Level 1 or Joliet, and DATA DVDs of Universal Disk Format (UDF). Refer to the instructions supplied with the disc drives and the recording software (not supplied) for details on the recording format. Note The player may not be able to play some DATA CDs/DATA DVDs created in the Packet Write format or multiple sessions. DivX video files that the player can play The player can play data that is recorded in DivX format, and which has the extension “.AVI,” or “.DIVX.” The player will not play files with the extension “.AVI” or “.DIVX” if they do not contain a DivX video. Notes • The player may not play a DivX video file when the file consists of two or more DivX video files combined. • The player cannot play a DivX video file of size more than 720 (width) u 576 (height)/2 GB. • Depending on the DivX video file, the picture may be unclear or the sound may skip. • The player cannot play some DivX video files that are longer than 3 hours. • The player can display a file name up to 14 characters. Any characters after the 14th character do not appear on the screen. • Characters that are not displayable appear as “*.” • Depending on the disc, a file name that is not displayable appears as “*.” • You cannot display correctly the CD-R/CD-RW file names written in the UDF file system. ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-8 32 About playback order of DivX video files Note that the playback order may not be applicable, depending on the software used for creating the DivX video file, or if there are more than 299 albums and 648 DivX video files in each album. See “About playback order of albums, tracks, and files” (page 45). 33 Settings and Adjustments Settings and Adjustments Using the Setup Display By using the Setup Display, you can make various adjustments to items such as picture and sound. You can also set a language for the subtitles and the Setup Display, among other things. For details on each Setup Display item, see pages from 34 to 38. Note Playback settings stored in the disc take priority over the Setup Display settings, and not all of the functions described may work. 1 Press OPTIONS when the player is in stop mode. The Option Menu appears. The Setup Display does not appear if Resume Play is activated. Cancel the Resume Play status first by pressing x twice, and the press OPTIONS. 2 Press X/x to select “Setup,” then press ENTER. The items for “Setup” appear. 3 Press X/x to select the desired Setup item from: “General Setup,” “Audio Setup,” “Language Setup,” or “Parental Control,” then press ENTER. The Setup item is selected. Example: “General Setup” 4 Press X/x to select an item, then press ENTER. The settings for the selected item appear. Example: “TV Display” 5 Press X/x to select a setting, then press ENTER. The setting is selected and setup is complete. Example: “4:3 Pan Scan” 1 2 3 4 5 6 7 8 0 9 C/X/x/c ENTER OPTIONS O x ENTER RETURN General Setup TV Display Angle Mark 16 : 9 On On On Screen Saver PBC Select: Cancel: DivX Default ENTER RETURN General Setup TV Display Angle Mark 16 : 9 On On On Screen Saver PBC Select: Cancel: DivX Default Selected item Setup items ENTER RETURN General Setup TV Display Angle Mark 4 : 3 Pan Scan 4 : 3 Letter Box 16 : 9 On Screen Saver PBC Select: Cancel: DivX Default Settings Selected setting ENTER RETURN General Setup TV Display Angle Mark 4 : 3 Pan Scan On On On Screen Saver PBC Select: Cancel: DivX Default ,continued 34 To turn off the Setup Display Press OPTIONS or O RETURN twice. Settings for the Display (General Setup) Choose playback display options and settings according to the TV to be connected. Select “General Setup” in the Setup Display. To use the display, see “Using the Setup Display” (page 33). The default settings are underlined. ◆ TV Display (DVD only) Selects the aspect ratio of the connected TV (4:3 standard or wide). 4:3 Pan Scan Select this when you connect a 4:3 screen TV. Automatically displays a wide picture on the entire screen and cuts off the portions that do not fit. 4:3 Letter Box Select this when you connect a 4:3 screen TV. Displays a wide picture with bands on the upper and lower portions of the screen. 16:9 Select this when you connect a wide-screen TV or a TV with a wide mode function. ENTER RETURN General Setup TV Display Angle Mark 16 : 9 On On On Screen Saver PBC DivX Default Select: Cancel: 16:9 4:3 Letter Box 4:3 Pan Scan 35 Settings and Adjustments Note Depending on the DVD, “4:3 Letter Box” may be selected automatically instead of “4:3 Pan Scan” or vice versa. ◆ Angle Mark Displays the angle mark when you can change the viewing angles during playback of DVDs recorded with multi-angles. ◆ Screen Saver The screen saver image appears when you leave the player in pause or stop mode for 15 minutes. The screen saver will help prevent your display device from becoming damaged (ghosting). Press H to turn off the screen saver. ◆ PBC By using the PBC (Playback Control) function, you can enjoy playing interactive programmes and programmes with search functions (page 20). This set up is effective when you play back VIDEO CDs with the PBC function. Set up becomes available by opening and closing the disc lid after setting. ◆ DivX Displays the registration code for this player. For more information, go to http://www.divx.com on the Internet. ◆ Default Each function returns to its original factory settings. Note that all of your settings will be lost. Settings for the Sound (Audio Setup) “Audio Setup” allows you to set the sound according to the playback and connection conditions. Select “Audio Setup” in the Setup Display. To use the display, see “Using the Setup Display” (page 33). The default settings are underlined. ◆ Audio DRC (Dynamic Range Control) (DVD only) Makes the sound clear when the volume is turned down when playing a DVD that conforms to “Audio DRC.” This function affects the output from the following jacks: – AUDIO jack – OPTICAL OUT jack only when “Dolby Digital” is set to “Downmix PCM” (page 36). ◆ Digital Output Selects if audio signals are output via the OPTICAL OUT jack. On Display the angle mark. Off Hide the angle mark. On Activates the screen saver function. Off Deactivates the screen saver function. On By the PBC function, you can play back VIDEO CDs via the menu screen. Off Turn off the PBC function. On Makes low sounds clear even if you turn the volume down. Off Normally select this position. On Normally select this position. When you select “On,” see “Setting the digital output signal” for further settings. Off The influence of the digital circuit upon the analog circuit is minimal. ENTER RETURN Audio Setup Audio DRC Digital Output Off On Select: Cancel: ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-9 36 Setting the digital output signal Switches the method of outputting audio signals when you connect an audio equipment such as an AV amplifier (receiver) with the OPTICAL OUT jack. For connection details, see page 39. After setting “Digital Output” to “On,” select “Dolby Digital” and “DTS.” If you connect a component that is incompatible with the selected audio signal, a loud noise (or no sound) may be heard from the speakers, damaging your ears or speakers. ◆ Dolby Digital (DVD only) Selects the type of Dolby Digital signal. ◆ MPEG (DVD only) Selects the type of MPEG audio signal. ◆ DTS Selects whether or not to output DTS signals. Setting the Display or Sound Track Language (Language Setup) “Language Setup” allows you to set various languages for the on-screen display or sound track. Select “Language Setup” in the Setup Display. To use the display, see “Using the Setup Display” (page 33). ◆ OSD (On-Screen Display) Switches the display language on the screen. ◆ Disc Menu (DVD VIDEO only) Switches the language for the disc’s menu. When you select “Original,” the language given priority in the disc is selected. ◆ Subtitle (DVD VIDEO only) Switches the subtitle language. When you select “Off,” no subtitle is displayed. ◆ Audio (DVD VIDEO only) Switches the language of the sound track. When you select “Original,” the language given priority in the disc is selected. Note If you select a language in “Disc Menu,” “Subtitle,” or “Audio” that is not recorded on the DVD VIDEO, one of the recorded languages will be automatically selected. Downmix PCM Select this when the player is connected to an audio component without a built-in Dolby Digital decoder. Dolby Digital Select this when the player is connected to an audio component with a built-in Dolby Digital decoder. PCM Select this when the player is connected to an audio component without a built-in MPEG decoder. If you play multi-channel MPEG audio sound tracks, only the Front (L) and Front (R) signals will be output from your two front speakers. MPEG Select this when the player is connected to an audio component with a built-in MPEG decoder. On Select this when the player is connected to an audio component with a built-in DTS decoder. Off Select this when the player is connected to an audio component without a built-in DTS decoder. ENTER RETURN Language Setup OSD Disc Menu English English English English Subtitle Audio Select: Cancel: 37 Settings and Adjustments Parental Control Settings (Parental Control) Playback of some DVD VIDEOs can be limited, by the parental control function. Select “Parental Control” in the Setup Display. To use the display, see “Using the Setup Display” (page 33). ◆ Password Enter or change a password. By setting a password, you can limit playback of a DVD that has the parental control function. When the Password option is first accessed, enter a new password (you do not need to enter the old password.). ◆ Parental Control The lower the setting value, the stricter the limitation. To set the parental control, you need the selected password in “Password,” therefore first set the password in the set up. Changing the password 1 Press X/x to select “Password” in the Parental Control setting display, and press ENTER. 2 Select “Change,” and press ENTER. The display for entering the password appears. 3 Enter your current 6-digit password in the “Old Password” box. 4 Enter your new 6-digit password in the “New Password” box. 5 Enter your new 6-digit password once again in the “Verify Password” box, then press ENTER to confirm. If you make a mistake entering your password Press CLEAR, or press C to return one by one before pressing ENTER in step 5, and then re- enter the password. Setting the parental control (limited playback) 1 Press X/x to select “Parental Control” in the Parental Control setting display, and press ENTER. The display for setting the playback limitation level appears. 2 Press X/x to select the limitation level (1-8), and press ENTER. The lower the value, the stricter the limitation. The display for entering the password appears. ENTER RETURN Parental Control Password Parental Control Select: Cancel: 1 2 3 4 5 6 7 8 Adult ENTER RETURN Parental Control Password Parental Control Select: Cancel: ,continued 38 3 Enter or re-enter your 6-digit password using the number buttons, then press ENTER. Parental Control setting is complete. To play a disc for which Parental Control is set 1 Insert the disc and press H. The display for entering your password appears. 2 Enter your 6-digit password using the number buttons, then press ENTER. The player starts playback. If you forget your password Remove the disc and repeat the steps outlined in “Changing the password” (page 37). Enter “136900” in the “Old Password” box, and then enter your new 6-digit password in the “New Password” box and “Verify Password” box. Notes • When you play discs which do not have the Parental Control function, playback cannot be limited on this player. • Depending on the disc, you may be asked to change the parental control level while playing the disc. In this case, enter your password, then change the level. If the Resume Play mode is cancelled, the level returns to the previous level. OK Password Enter password, then press . Enter Parental Control 39 Hookups Hookups Connecting to another device To switch LINE SELECT (IN/OUT) switch LINE SELECT IN: Input images or audio from an exterior device. The “Line in” message will be displayed on the LCD screen until the signal from the exterior device is received. LINE SELECT OUT:Sends the playback signal from this player to a TV. Notes • Plug cords securely to prevent noise. • Refer to the instructions supplied with the components to be connected. • You cannot connect this player to a TV that does not have a video input jack. • Be sure to disconnect the mains lead of each component before connecting. • Connect the player to the TV directly. Image quality may suffer when the video output from the player is passed through a video deck on to a TV. Connecting to TV monitor To send the playback signal to a TV or a monitor 1 Set the LINE SELECT switch on the player’s right side to “OUT.” DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT TV or monitor with audio/ video intput jacks To AUDIO/VIDEO Audio/video cord (supplied) ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-10 40 Connecting to an AV amplifier (receiver) Example 1 To send the playback signal to an AV amplifier (receiver) 1 Set the LINE SELECT switch on the player’s right side to “OUT.” * The yellow plug is used for video signals (page 39). Example 2 To send the playback signal to an AV amplifier (receiver) 1 Set the LINE SELECT switch on the player’s right side to “OUT.” 2 Set “Digital Output” to “On” in “Audio Setup” (page 35). DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT Stereo amplifier To AUDIO Audio/video cord (supplied) To AUDIO input DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT Amplifier with Dolby Digital or DTS decoder To OPTICAL OUT Optical digital cord (not supplied) To AUDIO input 41 Hookups Connecting to Video Player or Camcorder To recieve the playback signal from a Video Player or Camcorder 1 Set the LINE SELECT switch on the player’s right side to “IN.” Note Set the LINE SELECT switch to “OUT” after use. You cannot play back on the player if the switch is set to “IN.” DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT Video player or camcorder To AUDIO/VIDEO Audio/video cord (supplied) To AUDIO/VIDEO output 42 Additional Information Troubleshooting If you experience any of the following difficulties while using the player, use this troubleshooting guide to help remedy the problem before requesting repairs. Should any problem persist, consult your nearest Sony dealer (For customers in the USA only). Power The power is not turned on. , Check that the mains lead is connected securely. , When using with the battery pack, check that the battery pack is sufficiently charged. Picture There is no picture/picture noise appears. , The disc is dirty or flawed. , The brightness is set at minimum. Set the brightness in “LCD Mode” (page 28). , When you play discs, set the LINE SELECT switch to “OUT.” When you send the playback signal to other device, set the LINE SELECT switch to “OUT.” When you receive the playback signal from other device, set the LINE SELECT switch to “IN” (page 39). , Re-connect the connecting cord securely. , The connecting cords are damaged. , Check the connection to your TV (page 39) and switch the input selector on your TV so that the signal from the player appears on the TV screen. , The player is connected to the COMPONENT VIDEO IN (Y, PB, PR) jacks of high-vision TV. , If the picture output from your player goes through your video deck to get to your TV or if you are connected to a combination TV/VIDEO player, the copy-protection signal applied to some DVD programmes could affect picture quality. The picture does not fill the screen, even though the aspect ratio is set in “TV Display” under “General Setup.” , The aspect ratio of the disc is fixed on your DVD. The black points appear and the red, blue, green points remain on the LCD. , This is a structural property of the LCD and not mulfunction. Sound There is no sound. , The player is in pause mode or in Slow Play mode. , The player is in fast forward or fast reverse mode. , While playing a Super VCD on which the audio track 2 is not recorded, no sound will come out when you select “Stereo 1,” “Left 1,” or “Right 1.” , Re-connect the connecting cord securely. , The connecting cord is damaged. , The player is connected to the wrong input jack on the amplifier (receiver) (page 40). , The amplifier (receiver) input is not correctly set. , If the audio signal does not come through the OPTICAL OUT jack, check the audio settings (page 36). The sound volume is low. , The sound volume is low on some DVDs. The sound volume may improve if you set “Audio DRC” in “Audio Setup” to “On” (page 35). Operation The remote does not function. , The batteries in the remote are weak. , There are obstacles between the remote and the player. , The distance between the remote and the player is too far. , The remote is not pointed at the remote sensor on the player. , Direct sunlight or strong illumination is striking the remote sensor. 43 Additional Information Nothing happens when buttons are pressed. , The player’s \/1/HOLD switch is set on “HOLD” (page 16). The disc does not play. , The disc is turned over. Insert the disc with the playback side facing down. , The disc is not set correctly. , The player cannot play certain discs (page 7). , The region code on the DVD does not match the player (page 8). , Moisture has condensed inside the player (page 3). , The player cannot play a recorded disc that is not correctly finalized (page 7). , Parental Control has been set. Change the setting. , The CD/DVD USB switch on the player’s left side is set to “USB.” , The LINE SELECT switch on the player’s right side is set to “IN.” The player starts playing the disc automatically. , The disc features an auto playback function. Playback stops automatically. , While playing discs with an auto pause signal, the player stops playback at the auto pause signal. Some functions such as Stop, Search, Scan, Slow Play, Repeat Play, or Random Play cannot be performed. , Depending on the disc, you may not be able to do some of the operations above. Refer to the operating instructions supplied with the disc. The language for the sound track cannot be changed. , Try using the DVD’s menu instead of the direct selection button on the remote (page 17). , Multilingual tracks are not recorded on the DVD being played. , The DVD prohibits the changing of the language for the sound track. The subtitle language cannot be changed or turned off. , Try using the DVD’s menu instead of the direct selection button on the remote (page 17). , Multilingual subtitles are not recorded on the DVD being played. , The DVD prohibits the changing of subtitles. The angles cannot be changed. , Try using the DVD’s menu instead of the direct selection button on the remote (page 17). , Multi-angles are not recorded on the DVD being played. , The angle can only be changed when the “ ” indicator lights up on the screen (page 19). , The DVD prohibits changing of the angles. The MP3 audio track cannot be played (page 44). , The DATA CD is not recorded in an MP3 format that conforms to ISO 9660 Level 1 or Joliet. , The DATA DVD is not recorded in MP3 format that conforms to UDF (Universal Disk Format). , The MP3 audio track does not have the extension “.MP3.” , The data is not formatted in MP3 even though it has the extension “.MP3.” , The data is not MPEG-1 Audio Layer III data. , The player cannot play audio tracks in mp3PRO format. , The MP3 audio track is damaged. ,continued www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-11 44 The JPEG image file cannot be played (page 44). , The DATA CD is not recorded in a JPEG format that conforms to ISO 9660 Level 1 or Joliet. , The DATA DVD is not recorded in JPEG format that conforms to UDF (Universal Disk Format). , The JPEG image file does not have the extension “.JPEG.” , The data is not formatted in JPEG even though it has the extension “.JPEG.” , The JPEG image file format does not conform to DCF (page 44). , The image is larger than 3078 (width) u 2048 (height) in normal mode, or more than 3,300,000 pixels in progressive JPEG. (Some progressive JPEG files cannot be displayed even if the file size is within this specified capacity.) , The JPEG image file is damaged. The DivX video file cannot be played. , The file is not created in DivX format. , The file has an extension other than “.AVI” or “.DIVX.” , The DATA CD (DivX video)/DATA DVD (DivX video) is not created in a DivX format that conforms to ISO 9660 Level 1 or Joliet/UDF. , The DivX video file is larger than 720 (width) × 576 (height). The album/track/file names are not displayed correctly. , The player can only display numbers and alphabet. Other characters are displayed as “*.” The disc does not start playing from the beginning. , Repeat Play or Random Play is selected (pages 22 and 24). , Resume play has taken effect (page 17). The player does not operate properly. , When static electricity, etc., causes the player to operate abnormally, unplug the player. About MP3 Audio Tracks and JPEG Image Files MP3 is audio compression technology that satisfies the ISO/IEC MPEG regulations. JPEG is image compression technology. You can play DATA CDs/DATA DVDs that contain MP3 audio tracks or JPEG image files. DATA CDs/DATA DVDs that the player can play You can play back DATA CDs (CD-ROMs/ CD-Rs/CD-RWs) or DATA DVDs (DVD- ROMs/DVD+RWs/DVD+Rs/DVD-RWs/ DVD-Rs) recorded in MP3 (MPEG-1 Audio Layer III) and JPEG format. However, this player only plays DATA CDs whose logical format is ISO 9660 Level 1 or Joliet, and DATA DVDs of Universal Disk Format (UDF). Refer to the instructions supplied with the disc drives and the recording software (not supplied) for details on the recording format. Note The player may not be able to play some DATA CDs/DATA DVDs created in the Packet Write format or multiple sessions. MP3 audio track or JPEG image file that the player can play The player can play the following tracks and files: • MP3 audio tracks with the extension “.MP3.” • JPEG image files with the extension “.JPEG” or “.JPG.” • JPEG image files that conform to the DCF* image file format. * “Design rule for Camera File system”: Image standards for digital cameras regulated by JEITA (Japan Electronics and Information Technology Industries Association). 45 Additional Information Notes • Change the extension to “.jpg,” for files with “.jpe” or “.jpeg” extension. • The player will play any data with the extension “.MP3,” “.JPG,” or “.JPEG,” even if they are not in MP3 or JPEG format. Playing this data may generate a loud noise which could damage your speaker system. • The player does not conform to audio tracks in mp3PRO format. • Some JPEG files cannot be played. • The player can display a file or track name up to 14 characters. Any characters after the 14th character do not appear on the screen. • Characters that are not displayable appear as “*.” • Depending on the disc, a file or track name that is not displayable appears as “*.” • You cannot display correctly the CD-R/CD-RW file names written in the UDF file system. • When playing an MP3 audio track recorded in VBR mode, you cannot display the bit rate correctly. About playback order of albums, tracks, and files Tracks and files within an album play in the order of the recorded media (CD-R etc.). z Hint Since a disc with many trees takes longer to start playback, it is recommended that you create albums with no more than two trees. Notes • The player can recognize up to 299 albums (including albums that do not contain MP3 audio tracks and JPEG image files). The player will not play any albums beyond the 299th album. • The player can recognize a combined total of up to 648 files, tracks, and albums. The player will not play beyond the 648th file, track or album. • Depending on the writing condition of the disc, the total number of files, tracks, and albums recognizable may be fewer than 648. • The Album List displays only the currently playing album name. Any album located on the upper layer is displayed as “\..\.” 47 Additional Information Index to Parts and Controls For more information, see the pages indicated in parentheses. Upper view t A ./> (previous/next) buttons (16) B x (stop) button (16) C X (pause) button (16) D H (play) button (15) E Speaker (18) F LCD panel (10) G DISPLAY button (21) H MENU button (17) I RETURN button (21) J (remote sensor) (9) K OPTIONS button (20) L C/X/x/c buttons, ENTER button (17) M Disc lid (15) N PUSH CLOSE (15) ,continued 48 Front view A OPEN knob (15) B (remote sensor) (9) C CHARGE indicator (13) D \/1 (on/standby)/HOLD switch (15) E Power indicator (15) Left view A CD/DVD USB switch (15) B USB jack (25) Right view A VOLUME +/– (sound volume) button (16) B PHONES (headphone) jack A, B C AUDIO (input/output) jack/OPTICAL OUT (optical output) jack (39, 40) D VIDEO (input/output) jack (39) E LINE SELECT (IN/OUT) switch (15) F DC IN 9.5V (AC adaptor input) jack (11) OPEN HOLD CHARGE CD/DVD USB DC IN 9.5V LINE SELECT AUDIO VIDEO PHONES OPTICAL OUT A B IN OUT VOLUME www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1-12 E 49 Additional Information Remote A DISPLAY button (21) B Number buttons (17)* C TOP MENU button (17) D C/X/x/c buttons, ENTER button (17) E O RETURN button (21) F ./> PREV (previous)/NEXT buttons (16) G m/M (scan/slow) buttons (23) H ADVANCE button (16) I X PAUSE button (16) J \/1 (on/standby) button (15) K Volume +/– buttons (16) L CLEAR button (37) M AUDIO button (18)* N MENU button (17) O SUBTITLE button (19) P ANGLE button (19) Q OPTIONS button (20) R H PLAY button (15)* S x STOP button (16) * Use the tactile dot as a reference when operating the player. The number 5 button has a tactile dot. 1 2 3 4 5 6 7 8 0 9 50 Index Numerics 16:9 34 4:3 Letter Box 34 4:3 Pan Scan 34 A Album 45 Angle 19 Audio 18, 36 Audio DRC 35 Audio Setup 35 B Batteries 9 C CD 7, 15 Connecting 39 D DATA CD 6, 31, 44 DATA DVD 6, 31, 44 Digital output 35 Disc Menu 36 Display Playback Settings Display 21 Setup Display 33 DivX® 30, 31 Dolby Digital 18, 36 DTS 18, 36 DVD 6, 15 DVD+RW 6 DVD’s menu 17 DVD-RW 6, 20 F Fast forward 23 Fast reverse 23 G General Setup 34 H Handling discs 2 J JPEG 6, 44 L Language Setup 36 M MP3 6, 44 O OPTICAL OUT 35 Original 20 OSD (On-Screen Display) 36 P PBC Playback 20 Play List 20 R Remote 9, 49 Repeat CD/VIDEO CD 24 DVD 22 Repeat Play 22, 24 Resume Play 17 S Scan 23 Screen Saver 35 Search 23 Setup 33 Setup Display 33 Slide Show 28 Slow Play 24 Subtitle 36 T Top Menu 17 Troubleshooting 42 TV Display 34 U Usable discs 7 V VIDEO CD 6, 8, 15 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2-1 Note: Follow the disassembly procedure in the numerical order given. 2-1. MAIN BOARD, USB BOARD SECTION 2 DISASSEMBLY DVP-FX850 8 four screws (M2.5 × 11) 3 two foot rubbers 1 two foot rubbers 4 two screws (TS2 × 8.5) 2 two screws (TS2 × 8.5) 9 bottom assy qg six screws (TS2 × 4.5) qh MAIN board 0 connector qa connector qf screw (TS2 × 4.5) 6 six screws (TS2 × 8.5) 5 two screws (TS2 × 8.5) 7 open preve sheet qh screw (TS2 × 4.5) qj USB board qs connector qd connector www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2-2 2-2. TRAVERSE 1 traverse 2 hinge cosmetic www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2-3 2-3. UPPER BLOCK 9 disc lid assy 3 damping support 2 two screws (TS2 × 4.5) 8 disc open supp. 5 disc lid open spr bracket 7 two screws (TS2 × 4.5) 4 three screws (TS2 × 4.5) 1 two screws (TS2 × 4.5) qa upper block 0 spring 6 spring www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2-4 E 2-4. LCD PANEL ASSY/DRIVER BOARD 6 four screws (M2.5 × 7.5) qf three screws (TS1.7 × 5) qd DRIVER board 8 connector 3 two screw pads 4 two screws (TS1.7 × 4) 4 two screws (TS1.7 × 4) 2 two screws (TS1.7 × 4) 5 two screws (TS1.7 × 2) 1 two screw pads 3 two screw pads qa hinge assy qg panel brace qh panel assy qk hinge brace 8 housing assy 0 connector 7 two connectors 9 connector qs three screws (TS1.7 × 5) qs three screws (TS1.7 × 5) qf two screws (TS1.7 × 5) qj two screws (TS1.7 × 2.5) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 SECTION 3 BLOCK DIAGRAMS 3-1 3-2 3-1. OVEALL BLOCK DIAGRAM TFT+5V Power Unit 16Mbit FLASH MEMORY Memory Data Bus Memory Addess Bus 4MX16 SDRAM 6.5V~9.5V +1.9V +3.3V +5VCC VIDEO PROCESSING 8.2"PANEL TFT-LCD DIGITAL LED DRIVER DC-IN POWER MANAGEMENT Panel Driver PCB RF Amp Signal MT1389HD EEPROM REMOTE CONTROL AT24CXX I2C Bus KEYPAD Serial Data Audio DAC PCM1742KE Command Bus 4558 Audio Audio In Out/In Audio AMP CVBS Out CVBS Out/In DIGITAL VOLUME CONTROL CVBS In I2C Y,C Out Head Phone SPEAKER Motor Driver Traverse SPINDLE MOTOR SLEDGE MOTOR OPU MST7915MA Servo Signal Servo Driver Signal Audio-R Audio-L APA2068 TV Set TV Set TV Set R G Signal B Timing Control Main Board PCB Servo & DSP & MPEG IC L-CH R-CH OPA MCU Z8F0822 RS232 MCU UPDATE IR POWER SW CHIP_Q1 CHIP_FB2_DPWM CHIP_FB1_DPWM Back Light Vcc w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 3-4E DVP-FX850 MEMO w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-1 4-1. FRAME (1/2) 4-2 SECTION 4 SCHEMATIC DIAGRAMS FRAME (1/2) DRIVER BOARD MECHA DECK OPTICAL PICK-UP UNIT MD UNIT MAIN BOARD USB BOARD J5 J7 J16 J10 UJ1 J9 NC 24 D 23 C 22 B 21 A 20 IOA 19 RF0 18 E 17 F 16 PUH5V 15 V20 14 RF GND 13 VR-CD 12 VR-DVD 11 MD1 10 LD-CD 9 RF GND 8 LD-DVD 7 NC 6 NC 5 F- 4 T+ 3 T- 2 F+ 1 KEY3 KEY1 P_SW KEY2 4 3 2 1 KEY4 5 KEY5 6 KEY6 7 KEY7 8 KEY8 9 KEY9 10 KEY10 11 KEY11 12 KEY12 13 P_3V3 14 IR_IN 15 GND 16 SP1 17 SP2 SP3 SP4 18 19 20 NC 1 USB_SW 2 DVD_SW 3 USB_GND 4 6 7 8 9 USBP D+ USBM D- USB_GND USB_GND USB_VCC 5 LGND LGND 2 1 DC_IN1 3 DC_IN1 4 LGND 5 LGND 6 5V_TFT 7 5V_TFT 8 5V_TFT 9 LGND 10 TFT_C 11 LGND 12 TFT_Y 13 LGND 14 CVBS_IN 15 LGND TFT_SCL TFT_IRQ LGND TFT_SDA 16 17 19 20 18 H- 1 HW- 2 HW+ 3 HV- 4 HV+ 5 HU- 6 HU+ 7 H+ 8 U 9 V 10 W 11 SL+ 12 SL- 13 USB_VCC 1 USB_N 2 USB_P 3 USB_GND 4 DVD_SW 5 USB_SW 6 TV_SW 7 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-3 4-4 FRAME (2/2) FRAME (2/2) MAIN BOARD DRIVER BOARD SPEAKER L SPEAKER R LCD PANEL CN1 CN7 CN6 CN2 CN3 CN5 KEYSCAN_R4 KEYSCAN_R3 KEYSCAN_R2 KEYSCAN_R1 PANEL_SW 5 4 3 2 1 KEYSCAN_C1 6 7 KEYSCAN_C3 KEYSCAN_C2 8 KEYSCAN_C4 9 KEYSCAN_C5 10 KEYSCAN_C6 11 KEYSCAN_C7 12 KEYSCAN_C8 13 IR_P 14 IR_IN 15 GND 16 SP1 17 SP2 18 SP3 SP4 20 19 DC_IN1 LGND LGND 3 2 1 DC_IN1 4 LGND 5 LGND 6 5V_TFT 7 5V_TFT 8 5V_TFT 9 LGND 10 TFT_C 11 LGND 12 STFT_Y 13 LGND 14 CVBS_IN 15 LGND 16 TFT_SDA TFT_SCL TFT_IRQ LGND 17 18 19 20 VCOM 1 DGND 2 PNL_AVDD 3 V13 4 V12 5 V10 6 V7 7 V4 8 V1 9 PNL_RL 10 PNL_B0 11 PNL_B1 12 PNL_B2 13 PNL_B3 14 PNL_B4 15 PNL_B5 16 PNL_LD 17 PNL_STHR 18 PNL_DVDD 19 PNL_CLK 20 DGND 21 DGND 22 PNL_STHL 23 PNL_G0 24 PNL_G1 25 PNL_G2 26 PNL_G3 27 PNL_G4 28 DGND 30 PNL_G5 29 DGND 1 PNL_R0 2 PNL_R1 3 PNL_R2 4 PNL_R3 5 PNL_R4 6 PNL_R5 7 DGND 8 V3 9 V5 10 V8 11 V11 12 V14 13 PNL_AVDD 14 DGND 15 VCOM 16 PNL_UD 17 V6 18 VGH 19 V2 20 VGL 21 V9 22 PNL_DVDD 23 DGND 24 DGND 25 PNL_STVU 26 PNL_CKV 27 PNL_OEV 28 PNL_POL 30 PNL_STVD 29 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-5 4-6 MCU & DC-DC POWER MAIN (1/5) 4-2. MCU & DC-DC POWER • See page 5-3 for printed wiring board. MCU_XOUT ZRR ZRL ZRL HOLD POWER_KEY IR_IN TxD RxD BAT_STAT MUTE AUDIO_DTC TFT_POWER_EN IR_IN AV_IN_SW MUTE P_3V3 CB_CHARGE_EN ZRR P_3V3 BAT_STAT TFT_POWER_EN SYSTEM_POWER_EN SYSTEM_POWER_EN HOLD POWER_KEY LED2 ADAPTER_DET CHARGE_EN AV_IN_SW LED1 BATTERY_IN TxD IR_IN MCU_XIN MCU_XOUT VOL_PWM DBG MCU_RESET RxD CHARGE_EN BATTERY_IN MCU_XIN TU_EN VOL_PWM CB_CHARGE_EN SYSTEM_POWER_EN AUDIO_DTC GND SMUTE SMUTE MCU_R_OUT MCU_RESET DBG SYSTEM_POWER_EN SYS_POW_EN MCU_DBG_EN MCU_R_OUT SYS_POW_EN MCU_DBG_EN USB_SW USB_SW TU_EN ADAPTER_DET TXD TU_EN SE SE MCU_RESET DBG MCU_RESET BTVCC P_3V3 RFV33 DV33 DC_IN MO_VCC DC_IN DC_IN DV33 AVCC P_3V3 BTVCC DC_IN +5V V18 USB_VCC P_3V3 P_3V3 P_3V3 P_3V3 P_3V3 DC_IN AUDIO_VCC ADVCC 5V_TFT_POWER V+5V P_3V3 P_3V3 RFGND VGND MGND AGND AGND AGND AGND DV33 AGND DV33 DV33 DV33 AGND DV33 DV33 AGND 3.3V TUN_VCC 3.3V TUN_V33 ADVCC IR_IN 3,5 RxD 3 TxD 3 AV_IN_SW 5 MUTE 6 P_3V3 5,6 ZRL 6 CB_CHARGE_EN 6 ZRR 6 TFT_POWER_EN 3,5 TU_EN 3 VOL_PWM 6 SMUTE 6 MCU_R_OUT 3 SYS_POW_EN 3 MCU_DBG_EN 3 USB_SW 3 SE 6 OFF ON Vb=>8.2V L Battery in/out H L AV_IN_OUT_CTRL 1:AV OUT 0:AV IN POWER ON Infrared Receiver POWER Switch OFF ADAPTER_DET 3V : ADAPTER IN 0V : NO ADAPTER POWER OFF BATTERY_IN ADAPTER_DET OFF H OFF Vb=>8.2V L Adapter Power Supply : 9.5V/2A Battery Power Supply : 7.4V/3600mAh 6.0V HOLD/ / . 1 – + DC IN 9.5V POWER CHARGE C A D 3 4 8 7 2 B 5 1 E G H I F K L M J 6 9 13 12 10 11 17 16 14 15 21 20 18 19 MAIN BOARD (1/5) 05 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-7 4-8 DVD SERVO & DSP MT1389 MAIN (2/5) 4-3. DVD SERVO & DSP MT1389 • See page 5-3 for printed wiring board. XO AD[0..7] FG ADIN ENDM STBY IR_IN V1P4 E Y2 A[0..20] KEYSCAN_C5 VR-DVD ADAC_MD Y3 PANEL_SW DEBUG1 TFT_SDA TFT_SCL FOO TRO DMO FMO H- KEYSCAN_C6 KEYSCAN_C4 KEYSCAN_R4 KEYSCAN_R2 KEYSCAN_C1 KEYSCAN_C2 KEYSCAN_C3 KEYSCAN_R3 KEYSCAN_R1 LD_SW U T+ F- F+ T- V20 MDI1 RFO C F E D VR-CD B A IOA URST# VR-DVD ADAC_MC KEYSCAN_C7 TFT_POWER_EN LD-CD V1P4 ENDM DMSO SL+ W U V SL- ADAT H- HV- HU- HV+ HW+ HW- HU+ TRIN BA[0..1] DQM[0..1] STBY IOA ACLK KEYSCAN_C8 PUH5V SDA ALRCK ABCK SCL DCKE DCLK ADAC_ML LD-DVD LDO2 V V1P4 FOSO XI TRSO SL+ FMSO SL- MA[0..11] F+ F- T- T+ PUH5V DQ[0..15] LDO1 V1P4 CS# CAS# RAS# WE# RFGND PWR# PCE# PRD# LD_SW F W MDI1 TxD RxD HV- HW+ HV+ HU- HU+ HW- VR-CD V1P4 Y1 RFVDD3 RFV18 A8 A1 JITFO A2 IO_19 DQ2 AD1 AD6 PLLVDD3 V1P4 TEO DQ0 RFVDD3 UP1_2 DQ15 VOL- TRO A3 JITFN A18 FG ADIN A17 DQ7 AD0 SCL A16 V2P8 A12 AD2 DACVDD3 TFT_SCL PWR# TXD2 RFVDD3 ADAC_MC DQ6 PLLVDD3 ADAC_ML RFV33 V2P8 DQ5 DACVDD3 ADACVDD ADAT RFON F E LDO1 RFOP MDI1 MDI2 V20 FOO FMO TCK DEBUG1 DMO ASPDIF A6 A4 A7 SUBA V1P4 RFV18 SUBB ALRCK MA0 KEYSCAN_C5 BA0 DQM1 MA11 KEYSCAN_R2 KEYSCAN_C2 DQ11 DCLK CS# SUBC DQ8 MA9 KEYSCAN_R3 KEYSCAN_C8 CHKS KEYSCAN_C4 KEYSCAN_R1 DQ10 MA7 MA1 MA8 MA5 DQ13 KEYSCAN_C6 DACVDD3 MA3 BA1 MA6 KEYSCAN_C1 RAS# MA2 MA10 WE# MA4 KEYSCAN_C7 DCKE CAS# KEYSCAN_C3 KEYSCAN_R4 DQ12 A10 DQ14 A9 AD3 DQ1 AD7 A14 A13 A20 SUBD UWR# PCE# TMS V18 USBVDD ADIN DQ4 RFVDD3 DQ3 A0 RXD1 TXD1 JITFO JITFN DACVDD3 APLLVDD3 DACVDD3 V18 ADACVDD ICE D V1P4 XI XTALI XO C URST# APLLVDD3 STBY ENDM TCK TRIN TMS B A IR_IN ALE V1P4 VREF FS Y1 A11 DQM0 PRD# A5 AD4 MDI1 SDA Y2 LDO2 IOA IO_19 TFT_SDA AD5 TEZISLV FEO Y3 V20 A19 A15 INT0# A D USBP DQ9 URD# USBM C B RFO VREF FS YUV0 ASPDIF ABCK ACLK ADAC_MD LD-DVD TRSO LD-CD DMSO FMSO FOSO FG TU_EN TFT_IRQ VOL- VOL+ AL AR TU_EN TU_DTC GND V20 MDI1 MCU_R_OUT SYS_POW_EN MCU_DBG_EN MCU_R_OUT SYS_POW_EN MCU_DBG_EN USBM USBP H+ F- T+ T- F+ RXD2 USB_SW DVD_SW IOA DVD_SW USB_SW TV_SW TV_SW TFT_IRQ USB_SW RXD1 RXD2 TXD1 TXD2 RXD TXD TV_V TV_L TV_R TV_L TV_R MPEG_AUDIO_EN TU_RESET TFT_POWER_EN RxD1 TxD1 VOL+ TU_AUDIO_EN TV_V CHKS TXD2 TU_VIDEOIN_SW TU_VIDEOIN_SW TU_AUDIO_EN TV_L DVD_SW CHKS TU_RESET TXD2 RXD2 TV_V TV_R USB_SW USBP USBM TV_SW MPEG_AUDIO_EN RFVDD3 TU_RESET RXD2 USBM USBP DVD_SW USB_SW TV_SW PANEL_SW RFGND MGND RFGND RFGND MGND AVCC RFV33 AVCC DV33 MGND MGND RFGND DV33 MGND MO_VCC MO_VCC RFV33 MGND DV33 MGND MO_VCC RFGND MGND MO_VCC MO_VCC MGND V18 DV33 MGND RFGND AVCC RFGND AVCC MGND DV33 DV33 DV33 DV33 DV33 V18 RFV33 V18 V18 V18 DV33 V18 DV33 RFGND VGND AGND MGND TUN_V33 DV33 USB_VCC USB_GND TUN_GND DV33 TUN_VCC USB_GND TUN_GND USB_GND DV33 USB_GND USB_VCC DV33 KEYSCAN_C2 5 KEYSCAN_C5 5 ADAC_MD 6 KEYSCAN_C1 5 TFT_SDA 5 TFT_SCL 5 KEYSCAN_C6 5 KEYSCAN_R4 5 IR_IN 2,5 KEYSCAN_C7 5 TFT_POWER_EN 2,5 ADAC_MC 6 KEYSCAN_R3 5 Y1 5 SCL 4 KEYSCAN_C8 5 PANEL_SW 5 KEYSCAN_R2 5 ADAC_ML 6 Y2 5 KEYSCAN_R1 5 SDA 4 DQ[0..15] 4 ALRCK 6 ABCK 6 PCE# 4 ADAT 6 MA[0..11] 4 PRD# 4 ACLK 6 PWR# 4 RAS# 4 CS# 4 WE# 4 CAS# 4 DCLK 4 A[0..20] 4 DCKE 4 AD[0..7] 4 BA[0..1] 4 DQM[0..1] 4 Y3 5 KEYSCAN_C4 5 RxD 2 TxD 2 KEYSCAN_C3 5 ASPDIF 6 TU_EN 2 TFT_IRQ 5 VOL- 6 VOL+ 6 MCU_R_OUT 2 SYS_POW_EN 2 MCU_DBG_EN 2 USB_SW 2 TV_L 6 TV_R 6 TV_V 5 TU_AUDIO_EN 6 TU_VIDEOIN_SW 5 MPEG_AUDIO_EN 6 3 E NC 9 MD 19 13 11 FLASH LD-CD TopRay TOP1100S F+ 24 VR-DVD RS-232 2SB1132 T- 3 D/d F- 15 SW-CD/DVD B/b 5 T+ C 6 VCC-PD A/a F 14 NC RF 12 AUDIO INTERFACE 2 GND-LD Crystal TopRay TOP1100S 20 LD-DVD 22 18 2 VC-PD 21 VR-CD 4 C/c NC 23 VIDEO DAC OUTPUT 10 MEMORY GND-PD 7 E 1 17 8 1 C B 16 Disc Cover Switch MCU KEY INTERFACE 1389 RESET TFT-IIC TUNER INTERFACE MCU UPDATE D+ D- EC25 1000uF/10V SAMPLE RUN L15 150uH SAMPLE RUN L16 47uH SAMPLE RUN USB TUNER Q18 READ DISC VOLTAGE DVD 1:3.33V 2:0.13V 3:3.35V VCD 1:2.37V 2:1.87V 3:3.04V Q16 READ DISC VOLTAGE DVD 1:2.43V 2:2.40V 3:3.10V VCD 1:3.32V 2:0.04V 3:3.35V EMI SOLUTION wafer 20 pin p=1.0mm white 21mA 4.6mA D+ D- R93 Countermeasure IR don't power on. + EC63 100uF/6.3V/NC 6.3X5.4 + EC63 100uF/6.3V/NC 6.3X5.4 R66 6.8R R66 6.8R EC29 47uF/10V 5.0X5.4 EC29 47uF/10V 5.0X5.4 C162 0.1uF C162 0.1uF RFO RFO EC31 10uF/6.3V 4.0X5.0 EC31 10uF/6.3V 4.0X5.0 TP35 TP35 C104 120pF/NC C104 120pF/NC C161 0.1uF C161 0.1uF R99 1R/0805 R99 1R/0805 C129 0.1uF C129 0.1uF R79 0R/0603 R79 0R/0603 TP150 TP150 FB58 FB-100R-3A FB58 FB-100R-3A C120 1000pF C120 1000pF C144 1000pF C144 1000pF L15 10uH-100mA L15 10uH-100mA R100 47R/0603 R100 47R/0603 R61 100k R61 100k R232 0R/0805 R232 0R/0805 R110 47R/0603 R110 47R/0603 C76 0.1uF C76 0.1uF TOP J7 FFC13P1.0mm BOT TOP J7 FFC13P1.0mm BOT 1 2 3 4 5 6 7 8 9 10 11 12 13 VY1 VY1 TP152 TP152 TP187 TP187 C69 0.1uF C69 0.1uF C126 1000pF C126 1000pF U9 BA6849 HSOP28 U9 BA6849 HSOP28 A3 2 A2 4 A1 7 RNF 28 H1+ 9 H1- 10 H2+ 11 H2- 12 H3+ 13 H3- 14 VH 15 FG 24 PS 23 EC 22 ECR 21 GND 8 CNF 17 VCC 25 VM1 27 FR 20 SB 18 BR 16 VM2 26 G1 29 G2 30 HU- HU- C269 22pF/NC C269 22pF/NC C75 0.1uF C75 0.1uF MDI1 MDI1 TP126 TP126 C127 0.1uF C127 0.1uF YUV0 YUV0 RFG RFG Q17 2N3904 Q17 2N3904 1 2 3 C268 22pF/NC C268 22pF/NC VRDVD VRDVD C116 1000pF C116 1000pF C146 1000pF C146 1000pF TP149 TP149 C103 1uF C103 1uF C109 0.1uF C109 0.1uF TP169 TP169 TP154 TP154 SC SC FMO FMO TP172 TP172 C258 100pF C258 100pF C134 1000pF C134 1000pF R114 NC R114 NC C81 1000pF C81 1000pF J16 CCHD1407RE-00012 J16 CCHD1407RE-00012 USB_SW 6 DVD_SW 5 USB_GND 4 USB_P 3 USB_N 2 USB_VCC 1 TV_SW 7 C102 1uF C102 1uF C114 0.1uF C114 0.1uF FEO FEO C77 0.1uF C77 0.1uF BOTTOM J5 FFC24P0.5mm TOP BOTTOM J5 FFC24P0.5mm TOP 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 Pin Assignment v1.5 MT1389HD U7 MT1389HD Pin Assignment v1.5 MT1389HD U7 MT1389HD DVDA 2 CRTPLP 250 DVDB 3 DVDC 4 DVDD 5 AGND 1 OSP 252 OSN 253 DVDRFIP 6 DVDRFIN 7 MA 8 MB 9 MC 10 MD 11 SA 12 SB 13 SC 14 SD 15 CDFON 16 CDFOP 17 TNI 18 TPI 19 MDI1 20 MDI2 21 LDO2 22 LDO1 23 AVDD3 256 V2REFO 28 SGND 27 VREFO 30 V20 29 TEO 32 FEO 31 VPLLVSS 43 RFLVL/RFON 26 CSO/RFOP 25 TEZISLV 33 OP_OUT 34 OP_INN 35 OP_INP 36 FOO 42 TRO 41 VPLLVDD3 45 TROPENPWM 39 PWMOUT1/V_ADIN9 40 USB_VSS 46 FMO 38 DMO 37 IOA5 59 IOA20 75 HIGHA1 74 HIGHA3 72 HIGHA4 71 HIGHA5 70 HIGHA6 69 HIGHA7 68 TMS/V_ADIN5 52 A17 91 HIGHA0 62 IOA18 63 IOA21 87 AD6 86 IOA19 64 DVDD3 65 AD4 84 AD3 83 AD2 82 DVSS 81 HIGHA2 73 DVDD18 93 TCK/V_ADIN6 53 TDO/V_ADIN7 54 DVDD18 55 IOA2 56 AD1 80 IOA3 57 IOA4 58 A16 67 IOA0 92 AD5 85 IOA6 60 IOA7 61 IOCS# 76 IOCE# 78 DVSS 90 AD0 79 IOWR# 66 IOA1 77 UWR# 94 URD# 95 DVDD3 96 UP1_2 97 UP1_3 98 UP1_4 99 UP1_5 100 UP1_6 101 UP1_7 102 UP3_0 103 UP3_1 104 UP3_4 105 RD4 116 UP3_5 106 ICE 107 ADCVDD3 244 ADCVSS 245 PRST# 108 IR 109 INT0# 110 DQM0 111 IO_19 112 RD15 122 RD7 113 RD6 114 RD5 115 RD3 117 DVDD3 118 RD1 120 RD2 119 RD0 121 RD14 123 RD13 124 RD12 125 RD11 126 RD9 128 RD10 127 RD8 129 DACVSSC 192 YUV1/Y 191 DACVDDB 190 YUV2/C 189 DACVSSB 188 YUV3/CVBS 187 DACVDDA 186 YUV4/G 185 DACVSSA 184 YUV5/B 183 YUV6/R 182 VSYNC/V_ADIN1 181 YUV7 180 HSYNC/V_ADIN2 179 DVSS 178 IO_17 177 C0/IO_0 176 C1/IO_1 175 DVDD18 174 C2/IO_2 173 C3/IO_3 172 C4/IO_4 171 DVDD3 170 C5/IO_5 169 C7/IO_7 167 C6/IO_6 168 YUVCLK/IO_8 166 Y0/IO_9 165 Y1/IO_10 164 Y2/IO_11 163 Y3/IO_12 162 Y4/IO_13 161 DVDD18 160 Y5/IO_14 159 Y6/IO_15 158 DVDD3 156 Y7/IO_16 157 RA4 155 RA5 154 RA6 153 RA7 152 RA8 151 RA9 150 DVSS 148 RA11 149 CKE 147 RCLK 146 DVDD3 145 RA3 144 RA2 143 RA1 141 DVDD18 142 RA0 140 RA10 139 BA1 138 BA0 137 RCS# 136 CAS# 134 RAS# 135 RWE# 133 DQM1 132 DVDD3 131 IO_18 130 HRFZC 249 IREF 255 SVDD3 24 RFGC 254 RFGND18 231 ADACVDD2 230 IDACEXLP 238 PLLVSS 237 RFRPAC 248 RFRPDC 247 JITFN 236 RFGND 251 RFVDD3 246 LPFOP 243 LPFIP 241 LPFIN 242 LPFON 240 PLLVDD3 239 XTALI 234 JITFO 235 RFVDD18 232 AR/SDATA1 224 AVCM 225 ARF(SW) 222 ADACVSS1 221 ADACVSS2 220 APLLVSS 219 AL/SDATA2 226 APLLCAP 218 APLLVDD3 217 MC_DATA 215 DVDD18 213 ASDATA4 214 SPMCLK 204 ACLK 211 ABCK 210 ALRCK 209 DVDD3 208 ASDATA3 212 SPBCK 207 SPLRCK 206 SPDATA 205 ASDATA2/GPO_0 203 ASDATA1/GPO_1 202 GPIO_3 201 GPIO_4 200 RCLKB/GPIO_5 199 RVREF/GPIO_6 198 ASDATA0/GPO_2 197 DACVDDC 196 VREF 195 FS 194 YUV0/CIN 193 XTALO 233 CAPPAD 44 USBP 47 USBM 48 USB_VDD3 49 FG/V_ADIN8 50 TDI/V_ADIN4 51 ALE 88 AD7 89 SPDIF 216 ARS/SDATA3 223 ALF/(CTR) 228 ADACVDD1 229 ALS/SDATA0 227 R94 1R/0805 R94 1R/0805 C123 0.1uF C123 0.1uF R84 10K R84 10K SA SA R107 0R/0805 R107 0R/0805 T+ T+ TP165 TP165 TP185 TP185 R75 100K R75 100K J6 SMD PAD 4P J6 SMD PAD 4P 1 2 3 4 TP83 TP83 R92 0R R92 0R R105 0R/0805 R105 0R/0805 C145 0.1uF C145 0.1uF TP52 TP52 SDA SDA C95 0.1uF C95 0.1uF R101 20K R101 20K C107 0.1uF C107 0.1uF C99 1uF C99 1uF ASPD ASPD FB59 FB-100R-3A FB59 FB-100R-3A U8 BA5954 U8 BA5954 VINFC 1 PVCC1 9 PGND 10 VOSL+ 12 CF2 3 CF1 2 VOTK+ 15 VNFFC 7 VOFC+ 14 VOFC- 13 PVCC2 21 PGND 19 VNFTK 20 CTK2 24 BIAS 27 VOSL 6 VINSL+ 4 VINSL- 5 STBY 28 VCC 8 VOSL- 11 VOLD+ 17 VOLD- 18 VOTK- 16 VINLD 23 PREGND 22 CTK1 25 VINTK 26 G1 29 G2 30 ABCK ABCK C72 27pF C72 27pF R290 10K R290 10K TXD TXD R60 100K R60 100K C159 0.1uF C159 0.1uF TP21 TP21 TP22 TP22 V TP111 TP111 R233 0R/0805 R233 0R/0805 C137 0.1uF C137 0.1uF C108 0.1uF C108 0.1uF C94 0.1uF C94 0.1uF R235 0R/0805 R235 0R/0805 R89 100K R89 100K TEZI TEZI TP162 TP162 C139 0.1uF C139 0.1uF TP179 TP179 + EC26 100uF/6.3V 6.3X5.4 + EC26 100uF/6.3V 6.3X5.4 R98 1R/0805 R98 1R/0805 TP158 TP158 C112 5600pF C112 5600pF C117 0.1uF C117 0.1uF R266 10K R266 10K TP59 TP59 C118 1000pF C118 1000pF Q14 2SK3018 Q14 2SK3018 2 1 3 TP146 TP146 HU+ HU+ C254 0.1uF C254 0.1uF C71 10uF/10V/1206 C71 10uF/10V/1206 R70 560R R70 560R TP114 TP114 R59 750k R59 750k R113 20K R113 20K R96 1R/0805 R96 1R/0805 TP160 TP160 C141 0.1uF C141 0.1uF C151 0.1uF C151 0.1uF FB56 FB-100R-3A FB56 FB-100R-3A R269 10K R269 10K TP148 TP148 C149 0.1uF C149 0.1uF E ML ML TP157 TP157 + EC23 10uF/25V 5.0X5.3 + EC23 10uF/25V 5.0X5.3 C65 390pF C65 390pF EC33 47uF/10V 5.0X5.4 EC33 47uF/10V 5.0X5.4 R234 0R/0805 R234 0R/0805 TP164 TP164 R230 0R/NC R230 0R/NC F+ F+ C68 2200pF C68 2200pF C152 0.1uF C152 0.1uF D12 MM4148 D12 MM4148 2 1 C257 100pF C257 100pF + TC2 100uF/10V C + TC2 100uF/10V C Q16 2SB1132 Q16 2SB1132 1 3 2 C84 0.1uF C84 0.1uF EC28 47uF/10V 5.0X5.4 EC28 47uF/10V 5.0X5.4 R267 10K/NC R267 10K/NC L22 10uH-100mA L22 10uH-100mA R65 15k R65 15k SW2 ESE11MH1T SW2 ESE11MH1T 1 2 R97 1R/0805 R97 1R/0805 C277 22pF C277 22pF V2P8 V2P8 LRCK LRCK TP124 TP124 C148 0.1uF C148 0.1uF C143 0.1uF C143 0.1uF C97 1uF C97 1uF R102 18K R102 18K TP102 TP102 FB57 FB-100R-3A FB57 FB-100R-3A MC MC R95 1R/0805 R95 1R/0805 R67 1K R67 1K C82 4.7uF/10V/0805 C82 4.7uF/10V/0805 VOL- VOL- Y2 27MHz Y2 27MHz VY3 VY3 L20 10uH-100mA L20 10uH-100mA V20 V20 R265 10K R265 10K TEN TEN TP142 TP142 LDO1 LDO1 H+ H+ R76 10K R76 10K C259 100pF C259 100pF C70 0.1uF C70 0.1uF C278 22pF C278 22pF C92 0.1uF C92 0.1uF LDO2 LDO2 R276 10K R276 10K TP53 TP53 R112 20K R112 20K RXD RXD C113 0.1uF C113 0.1uF FOO FOO MD MD C155 330pF C155 330pF C100 15pF C100 15pF TDTC TDTC ACLK ACLK TP173 TP173 H- H- TEO TEO EC32 47uF/10V 5.0X5.4 EC32 47uF/10V 5.0X5.4 D SCL SCL HW- HW- C89 0.047uF C89 0.047uF C150 0.1uF C150 0.1uF C98 1uF C98 1uF C270 100pF C270 100pF F- F- HV+ HV+ + EC24 100uF/6.3V 6.3X5.4 + EC24 100uF/6.3V 6.3X5.4 TP168 TP168 C87 0.033uF C87 0.033uF TP186 TP186 FB60 FB-100R-3A FB60 FB-100R-3A TP180 TP180 C105 15pF C105 15pF TP101 TP101 ADAT ADAT F D10 RLZ4.7B D10 RLZ4.7B 2 1 HV- HV- SW1 ESE11MH2T SW1 ESE11MH2T 1 2 R111 20K R111 20K TP153 TP153 C Q19 2N3904 Q19 2N3904 1 2 3 R268 10K R268 10K C281 1000pF C281 1000pF C86 0.1uF C86 0.1uF V1P4 V1P4 C157 150pF C157 150pF C88 0.047uF C88 0.047uF C272 100pF C272 100pF R87 4.7R/0805 R87 4.7R/0805 C85 0.1uF C85 0.1uF U R103 15K R103 15K C93 NC C93 NC C73 20pF C73 20pF D11 RLZ4.7B D11 RLZ4.7B 2 1 URST URST C160 0.1uF C160 0.1uF C91 0.1uF C91 0.1uF TP151 TP151 EC30 100uF/10V 6.3X5.4 EC30 100uF/10V 6.3X5.4 C153 330pF C153 330pF LDDVD LDDVD TP82 TP82 L16 10uH-100mA L16 10uH-100mA SL- SL- C80 0.1uF C80 0.1uF C136 1000pF C136 1000pF USBM USBM C66 0.1uF C66 0.1uF TP104 TP104 C67 0.01uF C67 0.01uF C106 15pF C106 15pF DMO DMO FB55 FB-100R-3A FB55 FB-100R-3A W D13 ZENER 3.3V/NC D13 ZENER 3.3V/NC 2 1 C111 0.1uF C111 0.1uF R104 10K R104 10K C273 100pF C273 100pF SD SD R78 100K R78 100K R81 NC R81 NC Q15 2SK3018 Q15 2SK3018 2 1 3 C79 0.47uF/NC C79 0.47uF/NC TP171 TP171 C275 0.1uF C275 0.1uF TP178 TP178 TP163 TP163 USBP USBP 10K R115 10K AL AL TP84 TP84 C128 1000pF C128 1000pF C121 0.1uF C121 0.1uF C78 0.1uF C78 0.1uF Q13 2N3904 Q13 2N3904 1 2 3 LDCD LDCD RFON RFON C135 0.1uF C135 0.1uF TP117 TP117 Q18 2SB1132 Q18 2SB1132 1 3 2 C96 0.1uF C96 0.1uF EC27 47uF/10V 5.0X5.4 EC27 47uF/10V 5.0X5.4 C133 0.1uF C133 0.1uF SB SB IOA IOA C181 0.1uF C181 0.1uF C138 1000pF C138 1000pF C124 0.1uF/NC C124 0.1uF/NC C154 0.015uF C154 0.015uF R77 10K R77 10K C158 150pF C158 150pF TRO TRO SL+ SL+ R88 100K R88 100K A VY2 VY2 R284 10K/NC R284 10K/NC C115 0.1uF C115 0.1uF J15 A1002H00-20PW/NC J15 A1002H00-20PW/NC TV_V 1 GND 2 TV_L 3 TV_R 4 GND 5 CHKS 6 TXD 7 RXD 8 RESET 9 TV_SW 10 USB_SW 11 DVD_SW 12 USB_GND 13 USB_P 14 USB_N 15 USB_VCC 16 TUN_5V 17 TUN_GND 18 TUN_3.3V 19 TUN_GND 20 TP156 TP156 C101 15pF C101 15pF R90 10K R90 10K C271 100pF C271 100pF VRCD VRCD TP159 TP159 R228 0R/NC R228 0R/NC R106 0R/0805 R106 0R/0805 C119 0.1uF C119 0.1uF TP103 TP103 TP139 TP139 EC35 22uF/6.3V 4.0X5.0 EC35 22uF/6.3V 4.0X5.0 R93 1K R93 1K C83 10uF/10V/1206 C83 10uF/10V/1206 C140 1000pF C140 1000pF TP105 TP105 C147 0.1uF C147 0.1uF VOL+ VOL+ Q20 2N3904 Q20 2N3904 1 2 3 + EC22 10uF/16V 4.0X5.0 + EC22 10uF/16V 4.0X5.0 TP155 TP155 + EC25 100uF/10V 6.3X5.4 + EC25 100uF/10V 6.3X5.4 C156 0.01uF C156 0.01uF C260 100pF C260 100pF RFOP RFOP TP144 TP144 C130 1000pF C130 1000pF TP161 TP161 EC34 47uF/10V 5.0X5.4 EC34 47uF/10V 5.0X5.4 C267 22pF/NC C267 22pF/NC PUH5 PUH5 R80 0R/0603 R80 0R/0603 C110 NC C110 NC HW+ HW+ C274 0.1uF C274 0.1uF R108 10K R108 10K C131 0.1uF C131 0.1uF T- T- TP147 TP147 TP34 TP34 C74 27pF C74 27pF C276 0.1uF C276 0.1uF + TC1 47uF/10V B + TC1 47uF/10V B C122 1000pF C122 1000pF C266 0.1uF C266 0.1uF C142 1000pF C142 1000pF B C125 0.1uF/NC C125 0.1uF/NC IR IR R285 10K R285 10K C90 0.1uF C90 0.1uF TP140 TP140 R86 4.7R/0805 R86 4.7R/0805 C132 1000pF C132 1000pF AR AR TP145 TP145 R85 100K R85 100K TP45 TP45 TO USB BOARD SPINDLE/ SLED MOTOR OPTICAL PICK-UP UNIT MECHA DECK M C A D 3 4 8 7 2 B 5 1 E G H I F K L M J 6 9 13 12 10 11 17 16 14 15 18 MAIN BOARD (2/5) 05w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-9 4-10 4-4. SDRAM & FLASH ROM • See page 5-3 for printed wiring board. SDRAM & FLASH ROM MAIN (3/5) WE# RAS# MA2 DQ[0..15] MA11 DWE# SDCKE SDA MA7 PCE# MA1 SDCLK MA0 DQM0 CS# MA8 SCL DQM[0..1] RAS# DCLK DBA0 CAS# A[0..20] BA1 DCAS# DQM1 CAS# BA[0..1] DCLK DCAS# MA10 DCKE SDCKE DCS# DCKE MA3 DRAS# BA0 DBA1 WE# MA[0..11] MA5 SDA MA9 MA6 DCS# SCL PWR# PRD# DRAS# DBA0 DWE# A20 AA20 AD[0..7] CS# SCL MA4 DBA1 A4 A15 AD4 A12 AA20 PCE# AD5 AD3 A8 PWR# AD2 A19 A2 A17 A9 A14 A0 A5 A13 A10 AD1 A6 A3 A16 A7 A11 AD7 PRD# A18 AD6 AD0 A1 SD33 SDA SDCLK GND DQ0 DQ7 DQ2 DQ5 DQ8 DQ9 DQ13 DQ12 DQ10 DQ14 DQ15 DQ11 DQ1 DQ6 DQ4 DQ3 DV33 SD33 DV33 DV33 DV33 DV33 DV33 SD33 DV33 SD33 RFGND VGND AGND MGND AD[0..7] 3 SDA 3 SCL 3 A[0..20] 3 PRD# 3 BA[0..1] 3 RAS# 3 WE# 3 DCKE 3 CAS# 3 DQ[0..15] 3 PWR# 3 DQM[0..1] 3 CS# 3 MA[0..11] 3 PCE# 3 DCLK 3 FLASH DRAM IIC FOR EMI SOLUTION RN8 33R 0402 RN8 33R 0402 1 2 3 4 5 6 7 8 EC37 47uF/10V 5.0X5.4 EC37 47uF/10V 5.0X5.4 FB61 FB-100R-3A FB61 FB-100R-3A R120 33R R120 33R R124 100R R124 100R C169 100pF C169 100pF RN7 33R 0402 RN7 33R 0402 1 2 3 4 5 6 7 8 C283 68pF C283 68pF RN5 33R 0402 RN5 33R 0402 1 2 3 4 5 6 7 8 C173 0.1uF C173 0.1uF U11 ESMT M12L64164A U11 ESMT M12L64164A VCC 1 DQ0 2 DQ1 4 VSSQ 12 DQ2 5 DQ3 7 VCCQ 9 DQ4 8 DQ5 10 VSSQ 46 DQ6 11 DQ7 13 DQML 15 WE 16 CAS 17 RAS 18 CS 19 A11 35 A10/AP 22 A0 23 A1 24 A2 25 A3 26 VCC 14 VSS 41 A4 29 A5 30 A6 31 A7 32 A8 33 A9 34 NC 36 CKE 37 CLK 38 DQMH 39 NC 40 VCCQ 43 DQ8 42 DQ9 44 VSSQ 52 DQ10 45 DQ11 47 VCCQ 49 DQ12 48 DQ13 50 DQ14 51 DQ15 53 VSS 54 BA0/A13 20 BA1/A12 21 VCCQ 3 VSSQ 6 VCC 27 VSS 28 R129 NC R129 NC C174 15pF C174 15pF C163 100pF C163 100pF RN6 33R 0402 RN6 33R 0402 1 2 3 4 5 6 7 8 C175 15pF/NC C175 15pF/NC U12 MX29LV160 U12 MX29LV160 A0 25 A1 24 A2 23 A3 22 A4 21 A5 20 A6 19 A7 18 A8 8 A20 10 OE 28 BYTE 47 A18 16 D0 29 D1 31 D2 33 D3 35 A9 7 CE 26 D4 38 D5 40 D6 42 D7 44 D8 30 D9 32 WP/ACC 14 D11 36 D12 39 D13 41 D14 43 D15 45 VCC 37 GND1 27 WE 11 A19 9 D10 34 GND2 46 A10 6 A12 4 A11 5 A13 3 A14 2 A15 1 A16 48 A17 17 RESET 12 C282 68pF C282 68pF C164 1000pF C164 1000pF U10 EEPROM 24C16 U10 EEPROM 24C16 NC 1 NC 2 NC 3 GND 4 SDA 5 SCL 6 WP 7 VCC 8 RN1 33R RN1 33R 1 2 3 4 5 6 7 8 C167 100pF C167 100pF C176 0.1uF C176 0.1uF C172 1000pF C172 1000pF C166 1000pF C166 1000pF R123 1K R123 1K C168 1000pF C168 1000pF C171 100pF C171 100pF R130 10K R130 10K R122 33R R122 33R C170 1000pF C170 1000pF R121 1K R121 1K EC36 47uF/10V 5.0X5.4 EC36 47uF/10V 5.0X5.4 R119 33R R119 33R C165 100pF C165 100pF C A D 3 4 8 7 2 B 5 1 E F 6 9 MAIN BOARD (3/5) 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-11 4-12 4-5. VIDEO OUT & PANEL CONNECT • See page 5-3 for printed wiring board. VIDEO OUT & PANEL CONNECT MAIN (4/5) SP1 T_SDA SP2 SP1 SP3 SP2 SP4 SP4 SP3 T_SCL T_IRQ Y3 TFT_SDA Y2 TFT_SCL Y3 Y1 SPL1 SPL2 SPR1 SPR2 T_SDA KEYSCAN_R2 KEYSCAN_R4 KEYSCAN_R1 KEYSCAN_R3 KEYSCAN_R2 KEYSCAN_R4 KEYSCAN_R1 KEYSCAN_C4 KEYSCAN_R3 KEYSCAN_C3 KEYSCAN_C2 KEYSCAN_C1 KEYSCAN_C4 KEYSCAN_C3 KEYSCAN_C1 P_3V3 IR_IN KEYSCAN_C5 KEYSCAN_C6 KEYSCAN_C7 KEYSCAN_C8 KEYSCAN_C2 KEYSCAN_C5 KEYSCAN_C6 KEYSCAN_C7 KEYSCAN_C8 key1 key2 key3 key4 key5 key6 key7 key8 key9 key10 key11 key12 CVBS TFT-C TFT-Y DC_IN1 TFT_POWER_EN TFT_POWER_EN Y2 Y1 AV_IN_SW key1 key2 key3 key4 key5 key6 key7 key8 key9 key10 key12 key11 IR_IN P_3V3 PANEL_SW p_sw p_sw PANEL_SW AV_IN_SW 5V_TFT TU_VIDEOIN_SW TU_VIDEOIN_SW VIDEO_I_O VIDEO_I_O TFT_IRQ T_SCL T_IRQ T_C T_Y T_CVBS T_C DC_IN1 T_Y 5V_TFT T_CVBS GND GND GND SP1 SPL2 SPR1 SPL1 SPR2 SP3 SP4 SP2 TFT_SDA T_SCL T_SDA TFT_SCL TFT_IRQ T_IRQ T_Y TFT-Y T_CVBS T_C TFT-C CVBS-IN P_3V3 IR_IN p_sw key1 key3 key2 key4 key5 key7 key6 key8 key9 key11 key10 key12 TV_V TV_V CVBS IR_IN P_3V3 CVBS-IN VGND VGND VGND VGND VGND VGND VGND DV33 DV33 VGND VGND VGND VGND DC_IN DC_IN V+5V VGND VGND VGND DV33 5V_TFT_POWER VGND DC_IN1 RFGND VGND AGND MGND LGND LGND LGNDLGND LGND LGND Y2 3 Y3 3 TFT_SDA 3 Y1 3 TFT_SCL 3 AO+ 6 AO- 6 BO+ 6 BO- 6 KEYSCAN_C4 3 KEYSCAN_C3 3 KEYSCAN_C2 3 KEYSCAN_C1 3 KEYSCAN_R4 3 KEYSCAN_R3 3 KEYSCAN_R2 3 KEYSCAN_R1 3 P_3V3 2,6 IR_IN 2,3 KEYSCAN_C5 3 KEYSCAN_C6 3 KEYSCAN_C7 3 KEYSCAN_C8 3 TFT_POWER_EN 2,3 AV_IN_SW 2 PANEL_SW 3 TU_VIDEOIN_SW 3 TFT_IRQ 3 TV_V 3 TFT IIC INTERFACE VIDEO DAC OUT Built-in SPEAKER KEY IR /EN IN ON SW 0 0 S1 AV_IN 0 1 S2 AV_OUT 1 X OFF TS5V330DBQR OR PT2328-X(L) YELLOW wafer 20 pin p=1.0mm black wafer 20 pin p=1.0mm white 10mA 238mA AV IN SWITCH 1,4->2,5 ON AV_IN 2,5->3,6 ON AV_OUT Q22 AP2309GN Q22 AP2309GN 2 3 1 C197 0.1uF C197 0.1uF R286 0R/NC R286 0R/NC C186 NC FB31 FB-100R-400mA/0603 FB31 FB-100R-400mA/0603 C196 0.1uF C196 0.1uF C184 NC C184 NC C255 0.1uF/NC C255 0.1uF/NC C206 0.1uF C206 0.1uF FB41 FB-100R-400mA/0603 FB41 FB-100R-400mA/0603 R214 0R/0805 R214 0R/0805 C195 0.1uF C195 0.1uF C178 1000pF C178 1000pF C200 0.1uF C200 0.1uF Q21 2N3904 Q21 2N3904 3 2 1 FB27 FB-1500R-300mA/0603 FB27 FB-1500R-300mA/0603 C177 1000pF C177 1000pF FB32 FB-100R-400mA/0603 FB32 FB-100R-400mA/0603 C194 0.1uF C194 0.1uF FB45 FB-1500R-300mA/0603 FB45 FB-1500R-300mA/0603 C193 0.1uF C193 0.1uF C192 0.1uF C192 0.1uF C210 330pF C210 330pF R215 0R/0805 R215 0R/0805 D15 PESD5V0S1BB D15 PESD5V0S1BB 1 1 2 2 TC TC L25 1.8uH-50mA L25 1.8uH-50mA J10 A1002H00-20PB J10 A1002H00-20PB 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 FB24 FB-1500R-300mA/0603 FB24 FB-1500R-300mA/0603 C191 0.1uF C191 0.1uF 5VT 5VT C205 0.1uF C205 0.1uF C179 1000pF C179 1000pF FB23 FB-1500R-300mA/0603 FB23 FB-1500R-300mA/0603 VIDE VIDE SR1 SR1 TIRQ TIRQ L26 1.8uH-50mA L26 1.8uH-50mA C201 0.1uF C201 0.1uF DCIN1 DCIN1 R131 100K R131 100K FB22 FB-1500R-300mA/0603 FB22 FB-1500R-300mA/0603 C204 0.1uF C204 0.1uF TY TY FB42 FB-100R-400mA/0603 FB42 FB-100R-400mA/0603 FB17 FB-100R-400mA/0603 FB17 FB-100R-400mA/0603 C212 47pF C212 47pF FB29 FB-1500R-300mA/0603 FB29 FB-1500R-300mA/0603 R134 75R 1% R134 75R 1% FB46 FB-1500R-300mA/0603 FB46 FB-1500R-300mA/0603 R133 1K R133 1K FB26 FB-1500R-300mA/0603 FB26 FB-1500R-300mA/0603 CVBS CVBS C180 1000pf SL1 SL1 C211 47pF C211 47pF FB18 FB-100R-400mA/0603 FB18 FB-100R-400mA/0603 FB21 FB-1500R-300mA/0603 FB21 FB-1500R-300mA/0603 C213 0.1uF C213 0.1uF KC7 KC7 GND1 GND1 C190 0.1uF C190 0.1uF C209 470pF/NC C209 470pF/NC R132 1K R132 1K R139 75R 1% R139 75R 1% RN2 1K RN2 1K 1 2 3 4 5 6 7 8 C208 180pF C208 180pF C185 NC C185 NC C189 0.1uF C189 0.1uF KC4 KC4 FB12 FB-100R-400mA/0603 FB12 FB-100R-400mA/0603 KC3 KC3 C188 0.1uF C188 0.1uF L27 1.8uH-50mA L27 1.8uH-50mA KC5 KC5 KR4 KR4 EC39 220uF/10V 8X6.2 EC39 220uF/10V 8X6.2 C203 1000pF C203 1000pF FB14 FB-100R-400mA/0603 FB14 FB-100R-400mA/0603 U13 PT2328-X(L) U13 PT2328-X(L) S1A 2 S2A 3 S1B 5 S2B 6 S2C 10 S1C 11 EN 15 DA 4 DB 7 DC 9 VCC 16 GND 8 IN 1 DD 12 S2D 13 S1D 14 FB43 FB-100R-400mA/0603 FB43 FB-100R-400mA/0603 KR3 KR3 KC6 KC6 KC1 KC1 TSDA TSDA C215 47pF C215 47pF J11 SCJ315P00ZS0B00 J11 SCJ315P00ZS0B00 1 2 FB28 FB-1500R-300mA/0603 FB28 FB-1500R-300mA/0603 R138 1K R138 1K IRP IRP RN3 1K RN3 1K 1 2 3 4 5 6 7 8 FB20 FB-1500R-300mA/0603 FB20 FB-1500R-300mA/0603 FB47 FB-1500R-300mA/0603 FB47 FB-1500R-300mA/0603 FB25 FB-1500R-300mA/0603 FB25 FB-1500R-300mA/0603 PSW PSW FB15 FB-100R-400mA/0603 FB15 FB-100R-400mA/0603 SL2 SL2 KC2 KC2 FB19 FB-100R-400mA/0603 FB19 FB-100R-400mA/0603 KC8 KC8 IRIN1 IRIN1 SR2 SR2 TSCL TSCL C214 47pF C214 47pF EC40 220uF/10V 8X6.2 EC40 220uF/10V 8X6.2 + TC3 100uF/10V C + TC3 100uF/10V C KR1 KR1 C202 1000pF C202 1000pF R136 75R 1% R136 75R 1% C183 NC C183 NC SW3 SST-2214 SW3 SST-2214 1 2 3 4 5 6 D14 PESD5V0S1BB D14 PESD5V0S1BB 1 1 2 2 KR2 KR2 J9 A1002H00-20PW J9 A1002H00-20PW 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 C199 0.1uF C199 0.1uF GND2 GND2 C182 NC C182 NC C198 0.1uF C198 0.1uF C207 180pF C207 180pF C187 NC C187 NC FB62 FB-100R-3A FB62 FB-100R-3A R135 10K R135 10K C256 100pF/NC C256 100pF/NC FB44 FB-100R-400mA/0603 FB44 FB-100R-400mA/0603 VIDEO LINE SELECT OUT IN r DRIVER BOARD (1/2) DRIVER BOARD (2/2) C A D 3 4 8 7 2 B 5 1 E G H F 6 9 13 12 10 11 MAIN BOARD (4/5) 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-13 4-14 AUDIO OUT MAIN (5/5) 4-6. AUDIO OUT • See page 5-3 for printed wiring board. ADAC_MD ADAC_ML ADAC_MC MUTE BI- AI- L_MUTE A_MUTE R_MUTE A_MUTE BO+ AO+ MUTE ADAT PCMSD3 ACLK ACLK ABCK PCMCLK ALRCK PCMWS BO- AO- BO+ AO+ R_CH_OUT BO+ AO+ ADAC_MD ADAC_MC ADAC_ML PCMWS PCMSD3 ACLK PCMCLK SE HP2 A_MUTE HP1 A_MUTE HP3 A_MUTE HP4 A_MUTE REF CB_CHARGE_EN RLINE LLINE R_MUTE L_MUTE HP2 HP1 HP3 HP4 RLINE LLINE RLINE 4066_EN 4066_EN MPEG_AUDIO_EN A_MUTE CB_CHARGE_EN HSHUTDOWN ZRL ZRR ZRL ZRR L_CH_OUT OPTICAL-OUT ASPDIF ASPDIF AO+ AO- BO+ BO- AI- BI- SE VOL_C VOL_PWM VOL_C VOL_PWM VOL- VOL+ VOL- DE1 REF VOL+ MPEG_AUDIO_EN LLINE HSHUTDOWN SMUTE GND DE2 TV_L TV_R TV_L TV_R MUTE_AMP DE1 DE2 RLINE LLINE 4066_EN_TV 4066_EN_TV TU_AUDIO_EN TU_AUDIO_EN SE MUTE_AMP SMUTE MUTE_AMP P_3V3 +5VOP AUDIO_VCC AGND AGND AGND AGND AGND -AVCC_OP DV33 -AVCC_OP AGND +5VOP +5V AGND AGND AUDIO_VCC AGND AGND AGND AGND AUDIO_VCC -AVCC AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND P_3V3 AGND +5V AGND AGND AGND AGND AGND AGND AGND AGND P_3V3 AGND AUDIO_VCC -AVCC AUDIO_VCC -AVCC AGND +5VOP AUDIO_VCC -AVCC -AVCC_OP AUDIO_VCC AGND AGND AGND AGND AGND AGND DV33 AGND AGND AGND AGND AGND RFGND VGND MGND AGND AGND AGND AUDIO_VCC -AVCC +5VOP AGND AGND AGND -AVCC_OP -AVCC_OP AGND +5VOP AUDIO_VCC AGNDAGND AUDIO_VCC -AVCC AGND AGND DV33 P_3V3 AGND DC_IN AGND AGND AGND AGND AGND AGND AGND AGND ALRCK 3 ACLK 3 ABCK 3 MUTE 2 ADAT 3 BO- 5 AO- 5 AO+ 5 BO+ 5 ADAC_MD 3 ADAC_MC 3 ADAC_ML 3 MPEG_AUDIO_EN 3 CB_CHARGE_EN 2 ZRL 2 ZRR 2 ASPDIF 3 VOL_PWM 2 VOL- 3 VOL+ 3 SMUTE 2 TV_L 3 TV_R 3 TU_AUDIO_EN 3 SE 2 P_3V3 2,5 AUDIO INTERFACE LINE OUT&OPTICAL OUT PWM VOLUME CONTROL PLUG DE1/2 NON L IN H R_CH L_CH R_CH L_CH WHITE GREEN GREEN 680pF FOR S2A SOLUTION R150 R150 510R R291 1M R291 1M FB64 FB-100R-3A FB64 FB-100R-3A C226 100pF C226 100pF D27 PESD5V0S1BB D27 PESD5V0S1BB 1 1 2 2 R171 1K R171 1K C233 18pF C233 18pF Q23 2N3904 Q23 2N3904 1 3 2 R153 47R/0805 R153 47R/0805 R167 68R R167 68R EC44 10uF/16V 4.0X5.4 EC44 10uF/16V 4.0X5.4 HR2 HR2 C225 1000pF C225 1000pF R142 20K R142 20K Q50 2N3906/NC Q50 2N3906/NC 1 2 3 D21 MM4148 D21 MM4148 2 1 C240 680pF C240 680pF + - U22B 4558/NC + - U22B 4558/NC 5 6 7 8 4 Q33 2N3904 Q33 2N3904 1 2 3 EC43 47uF/10V 5.0X5.4 EC43 47uF/10V 5.0X5.4 C250 C250 22pF U19 74HC4066 U19 74HC4066 VCC 14 Z4 10 Z3 9 Z2 3 Z1 2 Y1 1 Y2 4 Y3 8 Y4 11 E1 13 E2 5 E3 6 E4 12 GND 7 R176 68K R176 68K Q47 2N3906/NC Q47 2N3906/NC 1 2 3 EC54 100uF/10V 6.3X5.4 EC54 100uF/10V 6.3X5.4 C236 18pF C236 18pF D23 MM4148 D23 MM4148 2 1 C284 C284 4.7uF/10V/0805 C242 0.1uF C242 0.1uF R288 0R R288 0R R189 3.3K R189 3.3K EC47 100uF/10V 6.3X5.4 EC47 100uF/10V 6.3X5.4 R259 NC FB37 FB37 FB-100R-400mA/0603 Q27 2N3904 Q27 2N3904 3 2 1 J12 DLT13M1 J12 DLT13M1 1 SW1 3 R 2 L 5 SW2 4 GND 7 VCC 8 VIN 6 GND C263 18pF/NC C263 18pF/NC C249 22pF C249 22pF C227 100pF C227 100pF C289 100pF/NC C289 100pF/NC R160 39R R160 39R R170 68K R170 68K R193 10K R193 10K R203 1K R203 1K C237 39pF C237 39pF 100pF/NC C290 100pF/NC R185 1K R185 1K R181 1K R181 1K EC45 100uF/10V 6.3X5.3 EC45 100uF/10V 6.3X5.3 R180 1M R180 1M S1 VOL- S1 VOL- 1 2 3 4 Q29 2N3906 Q29 2N3906 1 2 3 R149 R149 510R R163 39R R163 39R R206 100K R206 100K R263 1M/NC R263 1M/NC C264 18pF/NC C264 18pF/NC EC48 100uF/10V 6.3X5.4 EC48 100uF/10V 6.3X5.4 D18 MM4148 D18 MM4148 2 1 R158 7.5K 1% R158 7.5K 1% C241 0.1uF C241 0.1uF Q35 2N3904 Q35 2N3904 1 2 3 R164 68R R164 68R HL2 HL2 R182 3.3K R182 3.3K C228 0.1uF C228 0.1uF C221 1uF/0805 C221 1uF/0805 D24 PESD5V0S1BB D24 PESD5V0S1BB 1 1 2 2 C238 680pF C238 680pF R199 3.3K R199 3.3K C265 39pF/NC C265 39pF/NC Q30 2N3904 Q30 2N3904 1 2 3 C229 0.1uF C229 0.1uF Q25 2N3904/NC Q25 2N3904/NC 1 2 3 C216 1uF/0805 C216 1uF/0805 R178 7.5K 1% R178 7.5K 1% R140 22R R140 22R R148 20K R148 20K R146 220K R146 220K EC50 100uF/10V 6.3X5.4 EC50 100uF/10V 6.3X5.4 EC57 220uF/10V 8.0X10.2 EC57 220uF/10V 8.0X10.2 C217 1uF/0805 C217 1uF/0805 D16 MM4148 D16 MM4148 2 1 D25 PESD5V0S1BB D25 PESD5V0S1BB 1 1 2 2 C220 100pF C220 100pF R260 NC R260 NC C219 150pF C219 150pF R197 10K R197 10K R169 68R R169 68R R255 R255 7.5K1%/NC Q31 2N3904 Q31 2N3904 1 2 3 EC51 10uF/10V 4.0X5.4 EC51 10uF/10V 4.0X5.4 Q49 2N3904 Q49 2N3904 3 2 1 R174 15K 1% R174 15K 1% R253 1M/NC R253 1M/NC R207 1K R207 1K R183 39R R183 39R R257 10K/NC R257 10K/NC FB38 FB38 FB-100R-400mA/0603 U18 PCM1742 KE U18 PCM1742 KE ZRL_NA 12 VDDD 5 BCKIN 1 DIN 2 LRCIN 3 VCOM 10 VADD 6 AGND 9 VOUTL 7 DGND 4 SCKIN 16 ML 15 MC 14 MD 13 ZRR_ZRA 11 VOUTR 8 D22 PESD5V0S1BB/NC D22 PESD5V0S1BB/NC 1 1 2 2 R152 47R/0805 R152 47R/0805 EC42 10uF/16V 4.0X5.4 EC42 10uF/16V 4.0X5.4 R166 39R R166 39R R238 0R/NC R238 0R/NC Q26 Q26 2N3904/NC 1 2 3 R200 4.7K R200 4.7K R195 1K R195 1K R261 7.5K1%/NC R261 7.5K1%/NC FB33 FB-100R-400mA/0603 FB33 FB-100R-400mA/0603 C285 1uF/0805 C285 1uF/0805 Q34 2N3904 Q34 2N3904 1 2 3 R277 10K/NC R277 10K/NC R186 1K/NC R186 1K/NC R281 100K/NC R281 100K/NC C287 100pF/NC C287 100pF/NC J14 SCJ315P00WS0B00 J14 SCJ315P00WS0B00 1 GND 2 R 3 SW1 5 L 4 SW2 R172 68R R172 68R + - U17A 4558 + - U17A 4558 3 2 1 8 4 R254 3.3K/NC R254 3.3K/NC RN4 10K RN4 10K 1 2 3 4 5 6 7 8 R156 1M R156 1M R264 15K1%//NC R264 15K1%//NC C234 680pF C234 680pF R210 10K R210 10K R278 1K R278 1K C246 0.1uF C246 0.1uF R192 1K R192 1K OPT OPT C248 22pF C248 22pF R209 1K R209 1K Q24 2N3906 Q24 2N3906 1 2 3 EC58 100uF/10V 6.3X5.4 EC58 100uF/10V 6.3X5.4 EC56 4.0X5.4 EC56 10uF/16V/NC 4.0X5.4 EC53 10uF/10V 4.0X5.4 EC53 10uF/10V 4.0X5.4 R179 3.3K 1% R179 3.3K 1% R154 47R/0805 R154 47R/0805 EC46 220uF/10V/NC 8X6.2 EC46 220uF/10V/NC 8X6.2 R262 3.3K1%/NC R262 3.3K1%/NC R201 1K R201 1K Q48 Q48 2N3904/NC 3 2 1 Q36 2N3906 Q36 2N3906 1 2 3 C224 1uF C224 1uF FB39 FB39 FB-100R-400mA/0603 100pF/NC C288 100pF/NC FB34 FB-300R-400mA/0603 FB34 FB-300R-400mA/0603 S2 VOL+ S2 VOL+ 1 2 3 4 U14 APA2068KA U14 APA2068KA VOLUME 7 GND 5 LOUT- 9 RIN- 3 LOUT+ 11 VOLMAX 8 SE/BTL 13 BYPASS 4 GND 12 ROUT+ 14 LIN- 6 ROUT- 16 SHUTDOWN 2 MUTE 1 VDD 10 VDD 15 HOT_PAD 17 U15 NPC1729 U15 NPC1729 GND 4 VIN 2 CE 5 VOUT 1 C1- 3 C1+ 6 R155 15K 1% R155 15K 1% R184 39R R184 39R R157 1K R157 1K Q28 2N3904 Q28 2N3904 1 3 2 R202 1K R202 1K C245 0.1uF C245 0.1uF R162 68K R162 68K R252 3.3K/NC R252 3.3K/NC R237 0R/NC R237 0R/NC R247 100K R247 100K U16 XC6351A/NC U16 XC6351A/NC GND 1 VIN 5 CE 2 VOUT 4 C1- 6 C1+ 3 EC52 10uF/10V 4.0X5.4 EC52 10uF/10V 4.0X5.4 + - U22A 4558/NC + - U22A 4558/NC 3 2 1 8 4 R208 1K R208 1K R194 1K/NC R194 1K/NC C222 100pF C222 100pF C230 39pF C230 39pF R205 4.7K R205 4.7K C218 1uF/0805 C218 1uF/0805 C239 10uF/10V/1206 C239 10uF/10V/1206 R141 20K R141 20K R187 39R R187 39R C286 1uF/0805 C286 1uF/0805 R159 39R R159 39R R188 39R R188 39R D17 MM4148 D17 MM4148 2 1 R258 1K/NC R258 1K/NC C231 680pF C231 680pF R251 15K1%/NC R251 15K1%/NC EC61 4.0X5.4 EC61 10uF/10V/NC 4.0X5.4 D26 PESD5V0S1BB D26 PESD5V0S1BB 1 1 2 2 C243 22pF C243 22pF R190 0R/NC R190 0R/NC R287 220K R287 220K C232 0.1uF C232 0.1uF R282 10K/NC R282 10K/NC FB35 FB-300R-400mA/0603 FB35 FB-300R-400mA/0603 Q32 2N3904 Q32 2N3904 1 2 3 R147 20K R147 20K EC55 100uF/10V 6.3X5.4 EC55 100uF/10V 6.3X5.4 LOR LOR R177 68K R177 68K + - U17B 4558 + - U17B 4558 5 6 7 8 4 HR1 HR1 R144 R144 510R LOL LOL C262 39pF/NC C262 39pF/NC FB36 FB36 FB-100R-400mA/0603 R198 10K R198 10K C223 1000pF C223 1000pF FB63 FB-100R-3A FB63 FB-100R-3A C244 22pF C244 22pF EC49 10uF/10V 4.0X5.4 EC49 10uF/10V 4.0X5.4 J13 SCJ315P00WS0B00 J13 SCJ315P00WS0B00 1 GND 2 R 3 SW1 5 L 4 SW2 C247 C247 22pF EC62 10uF/10V/NC 4.0X5.4 HL1 HL1 R196 10K R196 10K R289 100K R289 100K R280 4.7K/NC R280 4.7K/NC R161 3.3K 1% R161 3.3K 1% U23 74HC4066/NC U23 74HC4066/NC VCC 14 Z4 10 Z3 9 Z2 3 Z1 2 Y1 1 Y2 4 Y3 8 Y4 11 E1 13 E2 5 E3 6 E4 12 GND 7 R151 220K R151 220K R145 R145 510R R256 R256 3.3K1%/NC C235 0.1uF C235 0.1uF D19 MM4148 D19 MM4148 2 1 R191 470K/NC R191 470K/NC AUDIO PHONES VOLUME – S1 + S2 PHONES C A D 3 4 8 7 2 B 5 1 E G H I F K L J 6 9 13 12 10 11 17 16 14 15 20 18 19 MAIN BOARD (5/5) 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-15 4-16 IR-KB DRIVER (1/2) 4-7. IR-KB • See page 5-7 for printed wiring board. KEYSCAN_R3 PANEL_SW KEYSCAN_C7 KEYSCAN_R4 KEYSCAN_C8 KEYSCAN_C1 IR_P IR_IN KEYSCAN_C4 KEYSCAN_R4 IR_P KEYSCAN_C2 KEYSCAN_C5 KEYSCAN_C7 KEYSCAN_C8 KEYSCAN_C6 KEYSCAN_C2 IR_IN KEYSCAN_C3 PANEL_SW KEYSCAN_C4 KEYSCAN_R1 KEYSCAN_C5 KEYSCAN_R2 KEYSCAN_C6 KEYSCAN_R4 KEYSCAN_C5 KEYSCAN_C8 KEYSCAN_C6 GND SPR2 SPL2 SPR2 SPR1 SPL2 SPL1 KEYSCAN_C4 SPR1 SPL1 KEYSCAN_C4 KEYSCAN_C7 KEYSCAN_R3 KEYSCAN_R2 KEYSCAN_R1 KEYSCAN_C3 KEYSCAN_C1 VCC3.3V GND EVQPLHA15∗9 (SW1-SW9) 5 1 2 3 4 5 6 J1 PIN ARRAY 5 5 5 5 5 5 5 5 5 6 6 6 6 6 6 6 6 6 D12 D12 PESD5V0S1BB/NC 1 1 2 2 CN7 Wafer 1.25mm H2.0mm Black CN7 Wafer 1.25mm H2.0mm Black 22 21 12 13 14 15 8 6 3 10 4 5 2 7 1 11 9 16 17 18 19 20 KS_C5 KS_C5 SW7 LCDMODE PNL_SW PNL_SW KS_C4 KS_C4 SW5 SW5 D11 PESD5V0S1BB/NC D11 PESD5V0S1BB/NC 1 1 2 2 J1 5-direction key/EVQWHA50K J1 5-direction key/EVQWHA50K 1 1 2 2 3 3 4 4 5 5 6 6 7 7 KS_C6 KS_C6 D6 PESD5V0S1BB/NC D6 PESD5V0S1BB/NC 1 1 2 2 SPL1 SPL1 KS_R1 KS_R1 SW9 RETURN SPR1 SPR1 SW4 D7 PESD5V0S1BB/NC D7 PESD5V0S1BB/NC 1 1 2 2 C84 100p C84 100p C87 100p C87 100p R69 1.8R/1206 C73 0.1u C73 0.1u CN6 AO- 1 AO+ 2 KS_R4 KS_R4 KS_R2 KS_R2 KS_R3 KS_R3 KS_C3 KS_C3 C72 100P R70 10R IR1 IR_D3P IR1 IR_D3P 1 2 3 SW1 SW1 R73 1.8R/1206 D10 D10 PESD5V0S1BB 1 1 2 2 KS_C8 KS_C8 CN5 BO- 1 BO+ 2 SPR2 SPR2 D3 PESD5V0S1BB/NC PESD5V0S1BB/NC 1 1 2 2 SW10 ESE13H01B SW10 2 1 4 3 SW3 SW3 C85 100p C85 100p D5 PESD5V0S1BB/NC PESD5V0S1BB/NC 1 1 2 2 SW6 MENU KS_C1 KS_C1 D9 PESD5V0S1BB D9 PESD5V0S1BB 1 1 2 2 KS_C7 KS_C7 SW8 DISPLAY KS_C2 KS_C2 D13 D13 PESD5V0S1BB/NC 1 1 2 2 D8 PESD5V0S1BB D8 PESD5V0S1BB 1 1 2 2 IR_P IR_P IR_I IR_IN R72 10K R72 10K R71 33K/NC R71 33K/NC SPL2 SPL2 D2 PESD5V0S1BB PESD5V0S1BB 1 1 2 2 SW2 SW2 C86 100p C86 100p D4 PESD5V0S1BB/NC PESD5V0S1BB/NC 1 1 2 2 x X H . > LCD PANEL OPEN/CLOSE DETECT SPEAKER R SPEAKER L MAIN BOARD (4/5) C A D 3 4 8 7 2 B 5 1 E G F 6 DRIVER BOARD (1/2) 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-17 4-18 T-CON DRIVER (2/2) 4-8. T-CON • See page 5-7 for printed wiring board. CHIP_SDA CHIP_Q1 LED- CHIP_FB2_DPWM CHIP_P0.0 LED+ VCOM CHIP_SCL PGND CHIP_FB1_DPWM V4 V7 V10 CHIP_FZ CHIP_VIN CHIP_STHR CHIP_RL CHIP_LD CHIP_B5 CHIP_B4 CHIP_B3 CHIP_B2 CHIP_B1 PNL_STHR PNL_RL PNL_LD PNL_B5 PNL_B4 PNL_B3 PNL_B2 PNL_B1 PNL_B0 PNL_POL PNL_STHL PNL_G5 PNL_G4 PNL_G3 PNL_G2 PNL_G1 PNL_G0 PNL_OEV PNL_UD PNL_R5 PNL_R4 PNL_R3 PNL_R2 PNL_R1 PNL_R0 PNL_CKV PNL_STVU PNL_STVD CHIP_CKV CHIP_STVU CHIP_STVD CHIP_CLKO PNL_CLK CHIP_R0 CHIP_R1 CHIP_R2 CHIP_R3 CHIP_R4 CHIP_R5 CHIP_UD CHIP_OEV CHIP_G0 CHIP_G1 CHIP_G2 CHIP_G3 CHIP_G4 CHIP_G5 CHIP_STHL CHIP_POL CHIP_B0 CHIP_CSN CHIP_SDO CHIP_SDI CHIP_SCK CE SO SI SCLK VGL PNL_G5 PNL_G4 PNL_G3 PNL_G2 PNL_G1 PNL_G0 PNL_STHL PNL_CLK PNL_STHR PNL_LD PNL_B5 PNL_B4 PNL_B3 PNL_B2 PNL_B1 PNL_B0 PNL_RL V1 V1 V4 V7 V10 V12 V12 V13 V13 DC_IN1 TFT_SDA TFT_SCL TFT_IRQ CHIP_P0.1 TFT_IRQ AV_IN Y_IN C_IN 5V_TFT DC_IN1 VGH VGL VCC3.3V VCC2.5V PNL_AVDD PNL_DVDD VGH_VGL_SW C_IN Y_IN AGND AV_IN TFT_SDA TFT_SCL V2 PNL_CKV V6 PNL_R2 PNL_R0 V14 PNL_UD PNL_OEV V14 PNL_R3 PNL_R1 VGH V11 PNL_DVDD V8 PNL_DVDD V5 V3 V8 V11 PNL_STVD PNL_R4 PNL_R5 V6 V3 PNL_STVU PNL_AVDD V9 V5 PNL_POL V2 V9 5V_TFT TFT_SCL TFT_SDA CHIP_C+ CHIP_Y+ CHIP_AV+ CHIP_C- CHIP_Y- CHIP_AV- GND VCC2.5V FB2 PWMOUT2 VCC3.3V 5V_TFT PWMOUT1 FB1 VCOM TFT_IRQ LED+ LED- PGND GND GND PGND AGND PGND GND GND VCC3.3V LED Backlight Driver VGL VCOM DC Panel Power Control AVDD Boost1 VGH 9.52V 7.51V 5.37V 2.96V 1.86V 0.52V 9.46V 8.18V 7.06V 6.29V 4.66 3.73V 2.46V 0.48V +10V CDRH3D16/LD/460mA CDRH3D16/LD/210mA CDRH3D16/LD/510mA CDRH5D16/1.2A SPI FLASH Bottom 3.3V Buck2 CDRH3D16/LD/ 260mA CDRH5D18/650mA 2.5V Buck1 EMI Solutions EMI solutions R60 240R R60 240R H5 H2.7D2.7 H5 H2.7D2.7 R51 820R R51 820R C17 10u/16V C1206D C17 10u/16V C1206D R85 0R/0805/NC R85 0R/0805/NC R16 13R R16 13R C46 0.1u C46 0.1u R64 200R R0603D R64 200R R0603D C25 0.1u C25 0.1u C5 100p C5 100p 470p/NC C32 470p/NC H6 H2D2 H6 H2D2 R75 10K R75 10K C20 0.1u C20 0.1u R18 0R R18 0R TC6 47u/6.3V R33 39R R33 39R C30 0.1u C30 0.1u C7 33n C7 33n SD3 SK32A /20V/ 3.0A/Vf 0.55 1 2 C1 0.1u C1 0.1u LED+ LED+ R49 470R R49 470R R44 10R R44 10R R82 62R R82 62R R52 640R R52 640R C38 0.1u C38 0.1u TC5 47u/6.3V C41 0.1u C41 0.1u CN2 FFC CON30 CN2 FFC CON30 1.POL 30 2.STVD 29 3.OEV 28 4.CKV 27 5.STVU 26 6.GND1 25 7.EDGSL 24 8.VCC 23 9.(V9) 22 10.VGL 21 11.(V2) 20 12.VGH 19 13.(V6) 18 14.U/D 17 15.VCOM1 16 16.GND2 15 17.AVDD1 14 18.(V14) 13 19.(V11) 12 20.(V8) 11 21.(V5) 10 22.(V3) 9 23.GND3 8 24.R5 7 25.R4 6 26.R3 5 27.R2 4 28.R1 3 29.R0 2 30.GND4 1 DGND 31 DGND 32 RP7 33R RP7 33R 1 2 3 4 5 6 7 8 R84 0R/0805/NC R84 0R/0805/NC H7 H2.7D2.7 H7 H2.7D2.7 L7 33u L7 33u R58 39R R58 39R R39 1K5 R39 1K5 C57 0.1u C57 0.1u R2 1M R2 1M C71 1000P C71 1000P BD1 BD1 3 2 1 R8 10K R8 10K R21 4K7 R21 4K7 RP4 33R RP4 33R 1 2 3 4 5 6 7 8 R19 18R U3 PMC25LV512 U3 PMC25LV512 HOLD 7 SO 2 WP 3 GND 4 SI 5 SCLK 6 VCC 8 CE 1 R10 100K R10 100K R11 100K R11 100K 5V_TFT 5V_TFT DVDD DVDD LED- LED- H8 H3.5D3.5 H8 H3.5D3.5 U4A AP4501M U4A AP4501M 7 2 1 8 C11 0.1u C11 0.1u R50 5K1 1% R50 5K1 1% R65 4K7 R65 4K7 C61 0.1u C61 0.1u R78 0R/0805 R78 0R/0805 C53 0.1u C53 0.1u R35 649R R35 649R R76 240R R63 6K8 1% R63 6K8 1% 47u/6.3V TC3 47u/6.3V C58 0.1u C58 0.1u AVDD AVDD DC_IN1 DC_IN1 C26 0.1u C26 0.1u H9 H2.7D2.7 H9 H2.7D2.7 M1 AP2301 M1 AP2301 1 3 2 VCOM VCOM TC1 33u/16V TC1 33u/16V R47 51K R47 51K R45 22K R45 22K ZD1 UDZ15B ZD1 UDZ15B 1 2 C35 0.1u C35 0.1u R77 0R/0805 R77 0R/0805 CON4 CON4 1 2 C68 1000P L9 4.7uH/CDRH3D16 L9 4.7uH/CDRH3D16 PGND PGND H10 H2D2 H10 H2D2 L6 33u L6 33u R4 R4 0R R7 0R R7 0R C48 0.1u C48 0.1u C55 0.1u C55 0.1u R22 150R R22 150R R57 1K R57 1K C27 0.1u C27 0.1u H11 H2.7D2.7 H11 H2.7D2.7 C50 0.1u C50 0.1u R28 100K L4 8.2u L4 8.2u R67 10K R67 10K R53 3K6 R53 3K6 C13 0.1u C13 0.1u SD1 SGL34-02/ 20V/0.5A/Vf0.55V SD1 SGL34-02/ 20V/0.5A/Vf0.55V 1 2 TC9 33u/16V C16 10u/25V C1206D C16 10u/25V C1206D RP5 33R RP5 33R 1 2 3 4 5 6 7 8 C37 0.1u C37 0.1u CN3 FFC CON30 CN3 FFC CON30 31.GND5 30 32.G5 29 33.G4 28 34.G3 27 35.G2 26 36.G1 25 37.G0 24 38.STHL 23 39.INV 22 40.GND6 21 41.DCLK 20 42.VCC 19 43.STHR 18 44.LD 17 45.B5 16 46.B4 15 47.B3 14 48.B2 13 49.B1 12 50.B0 11 51.R/L 10 52.(V1) 9 53.(V4) 8 54.(V7) 7 55.(V10) 6 56.(V12) 5 57.(V13) 4 58.AVDD2 3 59.GND7 2 60.VCOM2 1 DGND 31 DGND 32 C76 C76 1000P H12 H2D2 H12 H2D2 C24 0.1u C24 0.1u R7 R/0805 9 0 SD4 SGL34-02 SD4 SGL34-02 1 2 C51 0.1u C51 0.1u R59 390R R59 390R C78 470p C78 470p 8.2u L3 8.2u C39 33p C39 33p R5 3.3K C31 0.1u C31 0.1u R81 62R R81 62R C28 0.1u C28 0.1u C2 0.1u C2 0.1u R43 820R R43 820R C49 3.3n C49 3.3n 91R R80 91R U4B AP4501M U4B AP4501M 5 3 6 4 VCC2_5V VCC2_5V R25 10K R25 10K BD2 BD2 3 2 1 C56 C56 3.3n L8 L8 4.7uH/CDRH3D16 RP3 33R RP3 33R 1 2 3 4 5 6 7 8 C14 0.1u C14 0.1u C63 0.1u C63 0.1u R13 13R R13 13R C40 0.1u C40 0.1u R61 4R7 R61 4R7 C74 1000P C74 1000P R27 39R R27 39R C82 560p C82 560p Y_IN Y_IN R56 1K R56 1K VCC3_3V VCC3_3V R55 4K7 1% R55 4K7 1% R42 1K6 R42 1K6 RP1 33R RP1 33R 1 2 3 4 5 6 7 8 R40 390R R40 390R R37 360R R37 360R Q1 3904 Q1 3904 1 3 2 H13 H2D2 H13 H2D2 D_PANEL w/TCON 1C1S+DPWM SAR*3 GPIO*2 PWM*2 MST7915MA U2 D_PANEL w/TCON 1C1S+DPWM SAR*3 GPIO*2 PWM*2 MST7915MA U2 DTCON4 75 DTCON5 74 GOUT5 73 GOUT4 72 GOUT3/LVA0M 71 GOUT2/LVA0P 70 GOUT1/LVA1M 69 GOUT0/LVA1P [76]VDDP [77]GND [78]INTOUT 68 DTCON6 67 DTCON7 66 ROUT5/LVA2M 65 ROUT4/LVA2P 64 ROUT3/LVACKM 63 ROUT2/LVACKP 62 ROUT1/LVA3M 61 ROUT0/LVA3P 60 VDDP 59 GND 58 [46]GPIO0/P0.0 DTCON8 57 [47]GPIO1/P0.1 DTCON9 56 DTCON10 55 CLKO 54 RESET [48]INT [49]SDA [50]SCL 53 TESTIN 52 PWR_ON_RSTN 51 100 100 99 99 98 98 VSYNCIN 97 XTALIN 96 XTALOUT 95 GND 94 AVDD_XTAL 93 VREXT_CDAC 92 AVDD_OPLL 91 GND 90 VDDC 89 ROM_EN 88 DTCON1 87 DTCON2 86 DTCON3 85 BOUT5 84 BOUT4 83 BOUT3 82 BOUT2 81 BOUT1 80 BOUT0 79 78 78 77 77 76 76 GND 1 VCLAMP 2 VRM 3 VRP 4 AVDD_ADC 5 C1INP 6 C1INM 7 YS1INP [98]HSYNCIN [99]GND [100]AVDD_MPLL 8 YS1INM 9 CVBS1P 10 CVBS1M 11 AVDD_GMC 12 VIN 13 FAULTZ 14 FB2_DPWM 15 FB1_DPWM 16 AVDD_SAR 17 GND 18 GND 19 AVDD_DPWM [27]FB2 20 Q2 [26]PWMOUT2 [28]SENSE2 21 Q1 22 VDDC 23 GND 24 AVDD_PWM 25 26 26 27 27 28 28 PWMOUT1 29 FB1 30 SENSE1 31 CP1_FB 32 CP1_N 33 CP1_P 34 REF_PWM 35 PGOOD 36 SAR0 37 SAR1 38 SAR2 39 SCK 40 SDI 41 SDO 42 CSN 43 PWM1D 44 PWM2D 45 46 46 47 47 48 48 49 49 50 50 C3 0.1u C3 0.1u C45 0.1u C45 0.1u C29 0.1u C29 0.1u U1AIC1896PG/FP6736 FB 3 SS 5 LX 1 GND 2 SD 4 IN 6 AV_IN AV_IN R41 10K R41 10K R26 100K R26 100K BD3 3 2 1 TC7 47u/6.3V TC7 47u/6.3V C15 0.1u C15 0.1u C64 0.1u C64 0.1u R30 4K7 R30 4K7 C88 3.3n C88 3.3n L2 47u L2 47u C52 0.1u C52 0.1u C62 0.1u C62 0.1u L5 33u L5 33u TC8 33u/16V TC8 33u/16V ZD2 UDZ10B ZD2 UDZ10B 1 2 C79 470p C79 470p RP8 33R RP8 33R 1 2 3 4 5 6 7 8 C34 470p/NC C34 470p/NC TC13 47u/6.3V/BSize C75 C75 1000P C23 1u C23 1u C67 1000P TC12 47u/6.3V C18 1u C18 1u C89 1000P R23 39R R23 39R C_IN C_IN C66 1000P RP2 33R RP2 33R 1 2 3 4 5 6 7 8 C59 0.1u C59 0.1u C12 0.1u H2 H2D2 H2 H2D2 C19 0.1u C19 0.1u R34 270R R34 270R TC4 33u/16V TC4 33u/16V C65 0.1u C65 0.1u R32 4K7 R32 4K7 C10 20p C10 20p VGH VGH R1206 R36 5R R1206 C4 0.1u R83 0R/0805/NC R48 1K8 R48 1K8 C70 1000P R68 39R R68 39R H3 H2D2 H3 H2D2 C81 470p C81 470p R74 39R R74 39R C22 1u C22 1u VGL L1 10u L1 10u C8 0.1u C8 0.1u C80 560p C80 560p R46 1K R46 1K R24 39R R24 39R C47 0.1u C47 0.1u C44 1000p Y1 12MHz Y1 12MHz R54 10R R0805D R54 10R R0805D C36 0.1u C36 0.1u R38 560R R38 560R RP6 33R RP6 33R 1 2 3 4 5 6 7 8 SD2 SK32A /20V/3.0A/Vf 0.55 SD2 SK32A /20V/3.0A/Vf 0.55 1 2 0 TC10 33u/16V C9 20p C9 20p R1 100K/1% R1 100K/1% TC11 47u/6.3V TC11 47u/6.3V C83 560p C83 560p VR1 50K VR1 50K 1 3 2 C54 0.1u C54 0.1u IRQ IRQ J2 4x1 W/HOUSING/NC J2 4x1 W/HOUSING/NC 1 2 3 4 R6 15K R6 15K 10u/NC C1206D C90 10u/NC C1206D D1 4148 D1 4148 1 2 C60 0.1u C60 0.1u R12 0R R12 0R SD5 SGL34-02 SD5 SGL34-02 1 2 Q2 3904 Q2 3904 1 3 2 C69 1000P M3 AP2301 M3 AP2301 1 3 2 C6 0.1u C6 0.1u C42 0.1u C42 0.1u C33 470p/NC C33 470p/NC H4 H4D3.5X4 H4 H4D3.5X4 C21 1u C21 1u R31 39R R31 39R R3 14K/1% R3 14K/1% R15 0R R15 0R R62 4K7 R62 4K7 C77 1000P CN1 Wafer 1.25mm H2.0mm White 22 21 12 13 14 15 8 6 3 10 4 5 2 7 1 11 9 16 17 18 19 20 C43 0.1u C43 0.1u M2 AP2301 M2 AP2301 1 3 2 H1 H2D2 H1 H2D2 TC2 33u/16V TC2 33u/16V K99 1% R66 R9 10K R9 10K 8.2inch TFT LCD PANEL COLOR LCD MAIN BOARD (4/5) C A D 3 4 8 7 2 B 5 1 E G H I F J 6 9 13 12 10 11 14 DRIVER BOARD (2/2) 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 4-19 4-20E USB 4-9. USB DVD_SW USB_SW USBM USBP DVD_SW USB_SW USB_VCC USBM USBP USB_GND DVD_SW USB_SW USBD- USBD+ USB_VCC USB_VCC USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND USB_GND D- D+ D- D+ 8&9PIN is ground pad 1,4->2,5 ON CD/DVD 2,5->3,6 ON USB GND GND UD1 PESD5V0S1BB/NC UD1 PESD5V0S1BB/NC 1 1 2 2 UD2 PESD5V0S1BB/NC UD2 PESD5V0S1BB/NC 1 1 2 2 BP BP UC1 0.1uF UC1 0.1uF UD4 PESD5V0S1BB/NC UD4 PESD5V0S1BB/NC 1 1 2 2 BM BM UC6 NC UC6 NC UC5 NC UC5 NC UFB2 FB-100R/0603 UFB2 FB-100R/0603 UR5 15K D+ D+ UJ2 UB1112C-C1608-FR 4 2 3 1 UJ2 UB1112C-C1608-FR 3 2 1 4 5 6 UC4 10uF/ 16V USBS USBS UR6 15K UR6 15K VCC VCC D- D- USW USW UR3 33R UR3 33R UT1 ACM2012-900-2P/NC UT1 ACM2012-900-2P/NC 2 1 3 4 UJ1 CCHD1407RE-00012 UJ1 CCHD1407RE-00012 1 2 3 4 5 6 7 8 9 UC2 0.1uF UC2 0.1uF UR4 0R UR4 0R UR2 33R UR2 33R UC3 0.1uF UC3 0.1uF USW1 SST-2214 1 2 3 4 5 6 UR1 0R UR1 0R DSW DSW DVDS DVDS UFB1 FB-100R/0603 UFB1 FB-100R/0603 UD3 PESD5V0S1BB/NC UD3 PESD5V0S1BB/NC 1 1 2 2 MAIN BOARD (2/5) CD/DVD Y USB (USB) C A D 3 4 7 2 B 5 1 6 USB BOARD 05 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-1 5-2 SECTION 5 PRINTED WIRING BOARDS 5-1. CIRCUIT BOARDS LOCATION DRIVER BOARD MAIN BOARD USB BOARD w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-3 5-4 5-2. MAIN BOARD MAIN MAIN BOARD (SIDE A) D10 C-1 D11 B-1 D12 E-5 D16 E-7 D17 E-7 D18 G-5 D19 G-6 D21 F-7 Q3 G-5 Q7 F-5 Q8 F-6 Q13 B-2 Q14 C-2 Q15 B-2 Q16 B-1 Q17 B-1 Q18 B-1 Q19 B-1 Q20 B-2 Q21 B-3 Q23 H-8 Q24 G-6 Q27 G-5 Q28 H-8 Q29 H-6 Q30 G-7 Q31 F-8 Q32 E-8 Q33 F-8 Q34 E-8 Q35 D-8 Q36 E-7 Q49 H-7 U3 H-5 U7 E-3 U10 F-5 U12 E-3 U13 B-5 U14 G-7 U17 G-6 U18 E-6 U19 H-6 U22 H-5 U23 H-6 : Uses unleaded solder. • See page 5-1 for circuit boards location. There are a few cases that the part isn't mounted in this model is printed on this diagram. C D E F G H A 1 2 3 4 5 6 7 8 05 B MAIN BOARD (SIDE A) DISC COVER SWITCH SW1 POWER CHARGE > HOLD/ /1 . w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-5 5-6 MAIN MAIN BOARD (SIDE B) J3 C-6 J5 C-1 J7 E-3 J9 B-4 J10 B-3 J16 G-2 D1 A-8 D2 A-7 D3 C-6 D5 A-7 D6 B-7 D9 C-8 D13 G-5 D14 C-8 D15 D-7 D23 H-6 Q1 A-8 Q4 A-8 Q6 A-8 Q9 G-5 Q10 G-5 Q11 G-5 Q12 A-7 Q22 C-3 Q26 H-6 Q39 G-3 Q40 G-3 Q44 H-3 Q45 G-4 Q46 G-4 Q47 H-6 Q48 H-5 U1 B-7 U2 B-7 U4 D-7 U5 C-7 U6 A-7 U8 G-3 U9 G-4 U11 E-5 C D E F G H A 1 2 3 4 5 6 7 8 05 B MAIN BOARD (SIDE B) DC IN 9V – + LINE SELECT OUT IN r VIDEO AUDIO PHONES PHONES + – VOLUME TO RECHARGEABLE BATTERY PACK w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-7 5-8 DRIVER 5-3. DRIVER BOARD : Uses unleaded solder. • See page 5-1 for circuit boards location. There are a few cases that the part isn't mounted in this model is printed on this diagram. C A 1 2 3 4 5 6 7 8 9 10 11 12 05 B DRIVER BOARD (SIDE A) LCD PANEL OPEN/CLOSE DETECT C A 1 2 3 4 5 6 7 8 9 10 11 12 05 B DRIVER BOARD (SIDE B) LCDMODE RETURN MENU DISPLAY x X H . > SW1 SW2 SW3 SW4 SW5 SW7 SW7 SW9 SW6 1 2 1 2 2 1 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 (T/R/r/t/ENTER) 1 2 1 2 1 2 1 2 1 2 1 2 1 2 1 2 DRIVER BOARD (SIDE A) CN1 A-11 CN2 B-5 CN3 B-6 CN5 A-11 CN6 A-1 CN7 A-3 D1 A-2 BD1 A-3 BD2 A-3 BD3 A-3 SD2 B-1 SD3 B-1 SD4 B-10 SD5 B-11 Q1 B-2 Q2 A-2 U2 A-8 U4 B-2 DRIVER BOARD (SIDE B) D2 B-11 D8 B-1 D9 B-12 D10 B-10 U3 A-7 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-4. USB BOARD 5-9 5-10 USB MAIN BOARD (SIDE B) UJ1 F-2 UD1 A-1 UD2 B-1 UD3 D-2 UD4 D-2 : Uses unleaded solder. • See page 5-1 for circuit boards location. There are a few cases that the part isn't mounted in this model is printed on this diagram. C D E F G A 1 2 1 2 1 2 05 B USB BOARD (SIDE A) 1 2 1 2 C D E F G A 1 2 05 B USB BOARD (SIDE B) CD/DVD Y USB (USB) 1 4 3 3 2 6 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 5-12E DVP-FX850 MEMO w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 6-1 6-2 SECTION 6 WAVEFORMS AND CIRCUIT VOLTAGE 6-1. WAVEFORMS 1. Spindle control waveform (No disc condition) DMSO/ECR (U9 PIN9) TEO (U7 PIN32) TRSO (U8 PIN26) U (U9 PIN7) V (U9 PIN4) W (U9 PIN2) Fig 6-1 Fig 6-2 Fig 6-3 Fig 6-4 TEO (U10 PIN32) AUDIO OUT (J12 PIN2) TRSO (U8 PIN26) 2. Tracking control related signal (system checking-cd) 4. Audio output from IC (L/R) 3. Tracking control related signal (system checking-dvd) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 6-3 6-4 5. Audio related signal DIN (U18 PIN2) DIN (13 PIN10) SCKIN (U18 PIN16) DIN (U18 PIN3) Fig 6-5 Fig 6-6 Fig 6-7 Fig 6-8 Y FB19 C FB44 DVDRFIP (U7 PIN6) 6. Video output waveform (CVBS) 8. RF waveform 7. Video output waveform (Y/C) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 6-5 6-6 6-2. CIRCUIT VOLTAGE CHART PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY 1 0 0 51 0 0 101 3.266 3.269 151 0.041 0.026 201 3.256 3.267 251 0 0 2 0.236 0 52 3.262 0 102 3.266 3.263 152 1.114 1.143 202 0.036 0.039 252 1.68 1.661 3 0.17 0.028 53 0 0 103 3.302 3.282 153 1.591 1.601 203 0.036 0.039 253 1.684 1.673 4 0.157 0.029 54 0.002 3.223 104 3.026 3.027 154 1.597 1.611 204 2.641 5.027 254 0.983 1.43 5 0.159 0.034 55 1.923 1.905 105 2.723 2.707 155 1.038 1.051 205 3.26 3.27 255 0.896 0.899 6 1.75 1.695 56 2.045 2.022 106 3.262 3.269 156 3.263 3.255 206 3.26 3.27 256 3.262 3.265 7 1.749 1.696 57 1.801 1.848 107 0.014 0.053 157 1.992 1.993 207 0.036 0.039 8 2.192 2.037 58 2.553 1.963 108 3.263 3.268 158 0 0 208 3.262 3.272 9 2.003 2.039 59 2.533 2.172 109 2.772 2.978 159 0 0 209 1.535 1.524 10 2.005 2.035 60 1.558 2.141 110 2.772 2.726 160 1.912 1.928 210 1.585 1.649 11 2.193 2.047 61 0.825 1.963 111 3.263 2.892 161 0 0 211 1.586 1.608 12 0.807 1.03 62 0.023 1.542 112 3.254 0.047 162 2.614 2.907 212 1.909 0.039 13 0.81 1.027 63 0.037 0.822 113 1.635 1.321 163 2.502 3.285 213 1.909 1.927 14 0.775 1.031 64 0.042 0.04 114 0.13 0.633 164 3.238 0 214 0.036 0.039 15 0.687 1.033 65 3.263 3.269 115 1.2 0.866 165 3.238 3.271 215 2.955 2.965 16 0.642 1.047 66 3.262 3.268 116 0.804 1.15 166 3.238 0 216 1.643 1.651 17 0.616 1.038 67 0.089 0.107 117 1.048 1.261 167 3.263 3.271 217 3.26 3.27 18 2.013 2.023 68 0.216 0.561 118 3.262 3.271 168 3.263 3.271 218 1.277 1.84 19 2.009 2.006 69 0.108 0.897 119 0.883 1.18 169 3.262 3.273 219 0 0 20 0.003 0.177 70 3.262 2.853 120 0.94 1.083 170 3.262 3.272 220 0 0 21 0.005 0.177 71 0 3.052 121 0.97 1.207 171 3.263 3.273 221 0 0 22 3.246 2.409 72 3.262 2.876 122 0.123 1.166 172 3.263 3.273 222 3.004 3.022 23 3.246 3.237 73 0.029 0 123 1.604 1.457 173 1.912 3.273 223 1.621 1.622 24 3.267 3.255 74 0.027 1.638 124 1.095 1.177 174 3.263 0 224 1.622 1.625 25 2.809 2.747 75 0.026 0.026 125 1.29 0.955 175 3.263 3.273 225 1.591 1.591 26 2.073 1.763 76 0.025 0.022 126 1.064 1.146 176 3.263 3.273 226 2.101 1.591 27 0 0 77 0.008 2.01 127 0.805 0.804 177 0 3.273 227 1.823 1.601 28 2.779 2.705 78 0.008 0.024 128 0.852 1.004 178 0 0 228 1.739 1.607 29 2.03 2 79 3.268 1.451 129 0.961 1.264 179 0.052 0.056 229 3.249 3.259 30 1.395 1.378 80 3.257 1.605 130 2.554 3.053 180 3.258 3.269 230 3.249 3.259 31 1.435 1.187 81 0 0 131 3.262 3.272 181 3.258 3.269 231 0 0 32 1.549 1.308 82 3.267 1.153 132 2.955 2.963 182 0.556 1.001 232 1.906 1.923 33 1.551 1.311 83 3.267 1.051 133 3.242 3.251 183 0.558 0.933 233 0.697 0.701 34 0.348 1.036 84 3.268 1.532 134 3.116 3.125 184 0 0 234 0.703 0.621 35 0.347 0.971 85 3.267 1.816 135 3.211 3.201 185 0.554 0.936 235 0.53 0.971 36 1.399 0.971 86 3.267 1.993 136 3.067 3.076 186 3.257 3.268 236 1.122 0.965 37 1.399 1.378 87 2.921 2.993 137 0.928 0.893 187 0.96 0.937 237 0 0 38 1.399 1.372 88 0 1.2 138 0.933 0.896 188 0 0 238 0.029 0.038 39 1.399 1.377 89 3.267 0.962 139 0.035 0.046 189 1.348 0.667 239 3.204 3.201 40 1.397 1.377 90 0 0 140 0.167 0.177 190 3.256 3.266 240 3.059 1.671 41 1.394 1.372 91 0 0.076 141 0.97 1.043 191 0.96 0.473 241 0.008 1.581 42 1.394 1.372 92 1.553 1.922 142 1.912 1.809 192 0 0 242 1.598 0 43 0 0 93 1.929 1.922 143 0.987 2.428 193 1.959 1.99 243 1.041 1.578 44 1.806 0 94 1.927 2.816 144 1.013 1.52 194 1.302 1.315 244 3.262 3.265 45 3.263 1.827 95 3.19 3.245 145 3.262 3.272 195 1.298 1.315 245 0 0 46 0 0 96 3.266 0 146 1.584 1.605 196 3.256 3.267 246 3.262 3.265 47 0.866 0.795 97 0 2.263 147 3.262 3.27 197 0.035 0.039 247 0.255 2.305 48 0.451 0.69 98 3.262 5.028 148 0 0 198 0.035 0.039 248 1.358 1.345 49 3.265 3.26 99 0 5.029 149 0.015 0.042 199 3.258 3.269 249 3.244 1.544 50 3.746 1.783 100 0 2.706 150 0.041 0.069 200 3.257 3.267 250 1.397 1.866 U7 (MT1389 MPEG) U7 (MT1389 MPEG) U7 (MT1389 MPEG) U7 (MT1389 MPEG) U7 (MT1389 MPEG) U7 (MT1389 MPEG) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DVP-FX850 6-7 6-8E PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY 1 3.266 3.263 51 0.078 1.449 1 0.107 0.118 1 3.268 3.228 1 0 0 1 0 0 1 0 0 2 1.017 1.612 52 0 0 2 2.25 2.241 2 3.301 3.261 2 0 0 2 2.924 2.891 2 0 0 3 3.266 3.266 53 0.056 0.591 3 2.41 2.401 3 3.301 3.261 3 0 0 3 2.561 2.533 3 0 0 4 1.032 0.579 54 0 0 4 1.51 1.735 4 3.297 3.257 4 0 0 4 2.531 2.509 4 -4.785 -4.722 5 0.079 1.133 5 1.97 2.061 5 0 0 5 5.155 5.094 5 0 0 5 0 0 6 0 0 6 1.497 1.503 6 1.588 1.584 6 5.155 5.094 6 2.561 2.533 6 0 0 7 0.05 1.249 7 1.167 0.889 7 1.834 1.733 7 -4.984 -4.924 7 1.089 0 7 0 0 8 0.052 1.109 8 1.64 2.495 8 3.304 3.262 8 0 0 8 0 0 8 4.987 4.936 9 3.267 3.265 9 0.026 0.026 9 3.303 3.262 9 0 0 9 2.588 2.557 10 0.079 1.156 10 0 0 10 3.274 3.233 10 0 0 10 2.192 5.134 11 0.076 1.121 11 3.266 3.258 11 3.27 3.264 11 0 0 11 2.583 2.556 PIN STOP PLAY 12 0 0 12 3.266 0 12 3.032 3.016 12 5.154 5.094 12 0 1.332 1 0 0 13 0.053 1.078 13 0 0 13 2.376 2.379 13 5.154 5.094 13 0.605 1.329 2 0 0 14 3.267 3.265 14 0 0 14 2.175 1.637 14 5.193 5.134 14 2.582 2.558 3 1.084 1.504 15 3.259 2.945 15 1.02 0 15 3.3 3.26 15 5.192 5.134 4 0 0 16 3.264 3.242 16 0.04 0.041 16 2.773 2.729 16 2.583 2.56 5 3.266 3.26 17 3.261 3.117 17 0.83 0.822 17 3.026 3.02 6 3.266 3.26 18 3.26 3.208 18 2.47 1.979 18 3.3 0.038 7 0 0 19 3.256 3.062 19 2.18 1.998 19 0.982 2.618 8 3.266 3.26 20 0.062 1.109 20 2.27 2.141 20 3.3 3.26 21 0.07 0.906 21 3.26 2.172 21 3.3 3.262 22 0.043 0.067 22 3.26 1.963 22 0 0 PIN STOP PLAY PIN STOP PLAY PIN STOP PLAY 23 0.042 0.174 23 0.84 1.849 23 3.3 3.263 1 0 0 1 1.281 1.387 1 1.653 1.645 24 0.259 0.944 24 3.26 2.024 24 3 2.993 2 0 3.762 2 1.107 2.522 2 0.052 0.044 25 0.27 1.418 25 2.179 1.982 25 3.3 3.262 3 0 0 3 0.204 2.52 3 1.544 1.539 26 0.271 1.526 26 0.025 0 26 2.932 2.744 4 0 3.765 4 1.373 1.369 4 0 0 27 3.267 3.264 27 0 0 27 0.073 3.261 5 0 0 5 0.241 1.37 5 3.266 3.261 28 0 0 28 0.023 0 28 0.134 1.388 6 0 0 6 0.241 1.369 6 4.881 4.828 29 0.27 1.002 29 1.881 1.564 7 0 3.767 7 0.102 2.512 7 2.447 2.435 30 0.337 1.029 30 0.307 0.393 8 0 0 8 0.688 0 8 2.412 2.401 31 0.197 1.685 31 0.287 1.739 9 1.142 3.121 9 0.688 5.074 9 0 0 32 0.334 1.101 32 1.056 0.39 10 1.132 3.123 10 0 0 10 2.411 2.416 33 0.023 0.038 33 0.294 1.751 11 1.132 3.101 11 0.228 2.525 11 3.266 3.259 34 0.021 0.029 34 0.378 0.43 12 1.136 3.1 12 0.23 2.521 12 3.266 3.259 35 0.019 0.019 35 0.296 0 13 1.161 3.147 13 1.105 2.519 13 0.051 0.044 36 0.003 0 36 1.375 0 14 1.184 3.154 14 0.24 2.543 14 3.262 3.255 37 3.266 3.265 37 0.031 0 15 1.106 1.184 15 0.197 2.529 15 3.262 3.255 38 1.583 1.555 38 3.266 0 16 0 0 16 1.111 2.529 16 1.62 1.595 39 3.26 2.961 39 0.021 0 17 0 0.581 17 1.1 2.579 40 0.003 0 40 2.001 2.133 18 0 0 18 1.101 2.57 41 0 0 41 0.247 0 19 0 0 19 0 0 PIN STOP PLAY 42 0.6 0.963 42 1.607 0 20 5.3 0.021 20 1.138 2.513 1 3.262 3.257 43 3.267 3.266 43 0.267 0 21 1.399 1.463 21 0.727 5.064 2 1.596 1.481 44 0.077 0.609 44 2.434 1.75 22 1.395 1.369 22 0 0 3 1.748 1.413 45 0.08 1.007 45 0.233 0 23 0.041 3.228 23 1.305 1.375 4 1.96 1.412 46 0 0 46 0 0 24 3.687 1.756 24 0.19 2.519 5 1.746 1.487 47 0.05 1.065 47 0 0 25 5.312 5.064 25 1.106 2.521 6 1.615 1.423 48 0.05 1.203 48 0 0.8 26 5.323 5.063 26 1.283 1.366 7 1.95 1.456 49 3.267 3.266 27 5.306 5.064 27 1.379 1.369 8 0 0 50 0.079 0.734 28 5.27 5.051 28 0.041 3.228 9 0.943 1.468 10 0.943 1.467 11 3.35 1.294 12 3.3 1.234 13 3.3 1.214 14 3.3 1.244 15 0 0 16 5.2 5.136 U18 (PT2328-X(L)) U9 (BA6849) U14 (APA2068KA) U17 (4558) U8 (BA5954) U18 (PCM1742 KE) U10 (EEPROM 24C16) U12 (FLASH) U3 (MCU Z8F0822) U19 (74HC4066) U11(SDRAM) U11 (SDRAM) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-1 Pin Name I/O Description number 1 AGND - Analog ground 2 DVDA I AC coupled input path A 3 DVDB I AC coupled input path B 4 DVDC I AC coupled input path C 5 DVDD I AC coupled input path D 6 DVDRFIP I AC coupled DVD RF signal 7 DVDRFIN I TP45 8 MA I DC coupled main-beam RF signal input A 9 MB I DC coupled main-beam RF signal input B 10 MC I DC coupled main-beam RF signal input C 11 MD I DC coupled main-beam RF signal input D 12 SA I DC coupled sub-beam RF signal input A 13 SB I DC coupled sub-beam RF signal input B 14 SC I DC coupled sub-beam RF signal input C 15 SD I DC coupled sub-beam RF signal input D 16 CDFON I TP52 17 CDFOP I TP53 18 TNI I 3 beam satellite PD signal negative input 19 TPI I 3 beam satellite PD signal positive input 20 MDI1 I Laser power monitor input 21 MDI2 I Laser power monitor 22 LDO2 O Laser driver output 23 LDO1 O Laser driver output 24 SVDD3 - Analog power 3.3V 25 CSO O Positive main beam summing output 26 RFLVL O Negative main beam summing output 27 SGND - Analog ground 28 V2REFO O Reference voltage 2.8V 29 V20 O Reference voltage 2.0V 30 VREFO O Reference voltage 1.4V 31 FEO O Focus error monitor output 32 TEO O Tracking error monitor output 33 TEZISLV O TE Slicing Level 34 OP_OUT O TP162 35 OP_INN I TP163 36 OP_INP I TP164 37 DMO O Disk motor control output. PWM output. 38 FMO O Feed motor control. PWM output. 39 TROPENPWM (-) N.C. 40 PWMOUT1 /V_ADIN9 O 1stGeneral PWM output, or Version AD input 9 41 TRO O Tracking servo output. PDM output of tracking servo compensator 42 FOO O Focus servo output. PDM output of focus servo compensator 43 VPLLVSS - Analog ground for VPLL 44 CAPPAD I Capacitance connection 45 VPLLVDD3 - Analog 3.3V Power for VPLL 46 USB_VSS - USB ground pin 47 USBP I USB port DPLUS analog pin 48 USBM I USB port DMINUS analog pinPin SECTION 7 IC PIN FUNCTION DESCRIPTION DVP-FX850 7-1. MPEG/DSP/RF PIN FUNCTION (MAIN BOARD U7: MT1389HD) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-2 Pin Name I/O Description number 49 USB_VDD3 - USB Power pin 3.3V 50 FG/V_ADIN8 I Motor Hall sensor input, or Version AD input 8 51 TDI/V_ADIN4 I/O Serial interface port 3 data-out Version AD input port 4 GPIO 52 TMS/V_ADIN5 I/O Serial interface port 3 data-in Version AD input port 5 GPIO 53 TCK/V_ADIN6 I/O Serial interface port 3 clock pin Version AD input port 6 GPIO 54 TDO/V_ADIN7 I/O Serial interface port 3 chip-select Version AD input port 7 GPO 55 DVDD18 - 1.8V power pin for internal 56 IOA2 I/O Microcontroller address 2 / IO 57 IOA3 I/O Microcontroller address 3 / IO 58 IOA4 I/O Microcontroller address 4 / IO 59 IOA5 I/O Microcontroller address 5 / IO 60 IOA6 I/O Microcontroller address 6 / IO 61 IOA7 I/O Microcontroller address 7 / IO 62 HIGHA0 I/O Microcontroller address 8 63 IOA18 I/O Flash address 18 / IO 64 IOA19 I/O Flash address 19 / IO 65 DVDD3 - 3.3V power pin for internal 66 IOWR I/O Flash write enable, active low / IO 67 A16 O Flash address 16 68 HIGHA7 I/O Microcontroller address 15 69 HIGHA6 I/O Microcontroller address 14 70 HIGHA5 I/O Microcontroller address 13 71 HIGHA4 I/O Microcontroller address 12 72 HIGHA3 I/O Microcontroller address 11 73 HIGHA2 I/O Microcontroller address 10 74 HIGHA1 I/O Microcontroller address 9 75 IOA20 I/O Flash address 20 / IO 76 IOCS I/O Flash chip select, active low / IO 77 IOA1 I/O Microcontroller address 1 / IO 78 IOOE I/O Flash output enable, active low / IO 79 AD0 I/O Microcontroller address/data 0 80 AD1 I/O Microcontroller address/data 1 81 DVSS - Ground pin for internal 82 AD2 I/O Microcontroller address/data 2 83 AD3 I/O Microcontroller address/data 3 84 AD4 I/O Microcontroller address/data 4 85 AD5 I/O Microcontroller address/data 5 86 AD6 I/O Microcontroller address/data 6 87 IOA21/V_ADIN0 I/O Flash address 21 / IO 88 ALE I/O Microcontroller address latch enable 89 AD7 I/O Microcontroller address/data 7 90 DVSS - Ground pin for internal digital circuitry 91 A17 I/O Flash address 17 92 IOA0 I/O Microcontroller address 0 / IO 93 DVDD18 - 1.8V power pin for internal 94 UWR I/O Microcontroller write strobe, active low 95 URD I/O Microcontroller read strobe, active low 96 DVDD3 - 3.3V power pin for internal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-3 Pin Name I/O Description number 97 UP1_2 I/O Microcontroller port 1-2 98 UP1_3 I/O Microcontroller port 1-3 99 UP1_4 I/O Microcontroller port 1-4 100 UP1_5 I/O TP168 101 UP1_6 I/O Microcontroller port 1-6 I2C clock pin 102 UP1_7 I/O Microcontroller port 1-7 I2C data pin 103 UP3_0 I/O Microcontroller port 3-0 8032 RS232 RXD 104 UP3_1 I/O Microcontroller port 3-1 8032 RS232 TXD 105 UP3_4 I/O Microcontroller port 3-4 Hardwired RD232 RXD I2C clock pin 106 UP3_5 I/O Microcontroller port 3-5 Hardwired RD232 TXD I2C data pin 107 ICE I Microcontroller ICE mode enable 108 PRST I Power on reset input, active low 109 IR I IR control signal 110 INT0 I/O Microcontroller external interrupt 0, active 111 DQM0 I/O Data mask 0 112 IO_19 I/O GPIO 113 RD7 I/O DRAM data 7 114 RD6 I/O DRAM data 6 115 RD5 I/O DRAM data 5 116 RD4 I/O DRAM data 4 117 RD3 I/O DRAM data 3 118 DVDD3 - 3.3V power pin for internal 119 RD2 I/O DRAM data 2 120 RD1 I/O DRAM data 1 121 RD0 I/O DRAM data 0 122 RD15 I/O DRAM data 15 123 RD14 I/O DRAM data 14 124 RD13 I/O DRAM data 13 125 RD12 I/O DRAM data 12 126 RD11 I/O DRAM data 11 127 RD10 I/O DRAM data 10 128 RD9 I/O DRAM data 9 129 RD8 I/O DRAM data 8 130 IO_18 I/O GPIO 131 DVDD3 - 3.3V power pin for internal 132 DQM1 I/O Data mask 1 133 RWE O DRAM Write enable, active low 134 CAS O DRAM column address strobe, active low 135 RAS O DRAM row address strobe, active low 136 RCS O DRAM chip select, active low 137 BA0 I/O DRAM bank address 0 138 BA1 I/O DRAM bank address 1 139 RA10 I/O DRAM address 10 140 RA0 I/O DRAM address 0 141 RA1 I/O DRAM address 1 142 DVDD18 - 1.8V power pin for internal 143 RA2 I/O DRAM address 2 144 RA3 I/O DRAM address 3 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-4 Pin Name I/O Description number 145 DVDD3 - 3.3V power pin for internal 146 RCLK I/O DRAM clock 147 CKE O DRAM clock enable 148 DVSS - Ground pin for internal digital circuitry 149 RA11 I/O DRAM address 11 150 RA9 I/O DRAM address 9 151 RA8 I/O DRAM address 8 152 RA7 I/O DRAM address 7 153 RA6 I/O DRAM address 6 154 RA5 I/O DRAM address 5 155 RA4 I/O DRAM address 4 156 DVDD3 - 3.3V power pin for internal 157 Y_7/IO_16 I/O Digital Video output Y bit 7 GPIO 158 Y_6/IO_15 I/O Digital Video output Y bit 6 GPIO 159 Y_5/IO_14 I/O Digital Video output Y bit 5 GPIO 160 DVDD18 - 1.8V power pin for internal 161 Y_4/IO_13 I/O Digital Video output Y bit 4 GPIO 162 Y_3/IO_12 I/O Digital Video output Y bit 3 GPIO 163 Y_2/IO_11 I/O Digital Video output Y bit 2 GPIO 164 Y_1/IO_10 I/O Digital Video output Y bit 1 GPIO 165 Y_0/IO_9 I/O Digital Video output Y bit 0 GPIO 166 YUVCLK/IO_8 I/O Digital Video output Clock GPIO 167 C_7/IO_7 I/O Digital Video output C bit 7 GPIO 168 C_6/IO_6 I/O Digital Video output C bit 6 GPIO 169 C_5/IO_5 I/O Digital Video output C bit 5 GPIO 170 DVDD3 - 3.3V power pin for internal 171 C_4/IO_4 I/O Digital Video output C bit 4 GPIO 172 C_3/IO_3 I/O Digital Video output C bit 3 GPIO 173 C_2/IO_2 I/O Digital Video output C bit 2 GPIO 174 DVDD18 - 1.8V power pin for internal 175 C_1/IO_1 I/O Digital Video output C bit 1 GPIO 176 C_0/IO_0 I/O Digital Video output C bit 0 GPIO 177 IO_17 I/O GPIO 178 DVSS - Ground pin for internal 179 HSYN/V_ADIN2 I/O Horizontal sync for video-input 180 YUV7 I/O Microcontroller external interrupt 181 VSYNC/V_ADIN1 I/O Vertical sync input/output While no External TV-encoder 182 YUV6/R O TP160 183 YUV5/B O TP159 184 DACVSSA - Ground pin for VIDEO DAC circuitry 185 YUV4/G O TP158 186 DACVDDA - 3.3V power pin for VIDEO DAC circuitry 187 YUV3/CVBS O Video data output bit 3 Analog composite output 188 DACVSSB - Ground pin for VIDEO DAC circuitry 189 YUV2/C O Video data output bit 2 Analog chroma output 190 DACVDDB - 3.3V power pin for VIDEO DAC circuitry 191 YUV1/Y O Video data output bit 1 Analog Y output 192 DACVSSC - Ground pin for VIDEO DAC circuitry www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-5 Pin Name I/O Description number 193 YUV0/CIN O Video data output bit 0 Compensation capacitor 194 FS O Full scale adjustment 195 VREF O Bandgap reference voltage 196 DACVDDC - 3.3V power pin for VIDEO DAC circuitry 197 ASDATA0/GPO_2 I/O Audio serial data 0 (Front-Left/Front-Right) DSD data left channel Trap value in power- on reset 198 RVREF/GPIO_6 I/O GPIO 199 RCLKB/GPIO_5 I/O GPIO 200 GPIO_4 I/O GPIO 201 GPIO_3 I/O GPIO 202 ASDATA1/GPO_1 I/O TP155 203 ASDATA2/GPO_2 I/O TP152 204 SPMCLK I/O KEYSCAN C6 205 SPDATA I/O KEYSCAN C7 206 SPLRCK I/O ADAC MC 207 SPBCK I/O TP165 208 DVDD3 - 3.3V power pin for internal 209 ALRCK I/O Audio left/right channel clock Trap value in power-on reset: I) 1 : use external 373 II) 0: use internal 373 210 ABCK O Audio bit clock Phase de-modulation 211 ACLK O Audio DAC master clock 212 ASDATA3 I/O TP152 213 DVDD18 - 1.8V power pin for internal 214 ASDATA4 I/O TP151 215 MC_DATA I/O Inout PD SMT 216 SPDIF O SPDIF output 217 APLLVDD3 - 3.3V Power pin for audio clock circuitry 218 APLLCAP O APLL External 219 APLLVSS - Ground pin for audio clock circuitry 220 ADACVSS2 - Ground pin for AUDIO DAC circuitry 221 ADACVSS1 - Ground pin for AUDIO DAC circuitry 222 ARF (SW) O AUDIO DAC Sub-woofer channel output While internal AUDIO DAC not used: GPIO 223 ARS/SDATA3 O TP149 224 AR/SDATA1 O AUDIO DAC Right channel output While internal AUDIO DAC not used: a. SDATA1 225 AVCM O AUDIO DAC reference voltage 226 AL/SDATA2 O AUDIO DAC Left Surround channel output While internal AUDIO DAC not used: a. SDATA2 227 ALS/SDATA 0 O TP148 228 ALF/(CTR) O TP147 229 ADACVDD1 - 3.3V power pin for AUDIO DAC circuitry 230 ADACVDD2 - 3.3V power pin for AUDIO DAC circuitry 231 RFGND18 - Analog ground 232 RFVDD18 - Analog power 1.8V 233 XTALO O 27M crystal out 234 XTALI I 27M crystal in 235 JITFO O The output terminal of RF jitter meter. 236 JITFN I The input terminal of RF jitter meter. 237 PLLVSS - Ground pin for data PLL and related analog circuitry. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-6 Pin Name I/O Description number 239 PLLVDD3 - 3.3V power pin for data PLL and related analog circuitry. 240 LPFON O The negative output of loop filter amplifier 241 LPFIP I The positive input terminal of loop filter amplifier. 242 LPFIN I The negative input terminal of loop filter amplifier. 243 LPFOP O The positive output of loop filter amplifier 244 ADCVDD3 - Analog 3.3V Power for ADC 245 ADCVSS - Analog ground for ADC 246 RFVDD3 - Analog Power 247 RFRPDC O RF ripple detect output 248 RFRPAC I RF ripple detect input(through AC-coupling) 249 HRFZC I High frequency RF ripple zero crossing 250 CRTPLP O Defect level filter capacitor connecting 251 RFGND - Analog Power 252 OSP O RF Offset cancellation capacitor connecting 253 OSN O RF Offset cancellation capacitor connecting 254 RFGC O RF AGC loop capacitor connecting for DVD-ROM 255 IREF I RF path. Connect an external 15K resistor to this pin and 256 AVDD3 - Analog power 3.3V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-7 7-2. FRONT MICOM PIN FUNCTION (MAIN BOARD U3: Z8F0822) Pin Name I/O Description number 1 PC0/T1IN O SYSTEM POWER EN 2 PA6/SCL I POWER KEY 3 PA7/SDA I HOLD 4 /RESET I MCU RESET 5 Vss - Ground pin 6 XIN I MCU XIN 7 XOUT O MCU XOUT 8 Vdd - 3.3V 9 PC5/MISO O MUTE 10 PC4/MOSI I Battery detect 11 PC3/SCK I AV IN SW 12 PC2/SS O CHARGE EN 13 PA0/T0IN I ADAPTER_DET 14 PA1/T0OUT O VOL_PWM 15 PA2/DE0 I LED2 (CHARGE) 16 PA3/CTS0 I IR_IN 17 PA4/RXD0 I/O TXD 18 PA5/TXD0 I/O RXD 19 PC1/T1OUT O SE 20 DBG I DBG 21 AVdd - 3.3V 22 AVss - Ground pin 23 VREF - 3.3V 24 PB4/ANA4 O cb charge enable 25 PB3/ANA3 O S MUTE 26 PB2/ANA2 I AUDIO_DTC 27 PB1/ANA1 I LED1 (POWER) 28 PB0/ANA0 I Battery IN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7-8E MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8-1 SECTION 8 ELECTRICAL ADJUSTMENT DVP-FX850 This section describes procedures and instructions necessary for adjusting electrical circuits in this set. Instruments required: 1) Color monitor TV 2) Oscilloscope 1 or 2 phenomena, band width over 100 MHz, with delay mode 3) Frequency counter (over 8 digits) 4) Digital voltmeter 5) Standard commander (RMT-D183) 6) DVD reference disc HLX-501 (J-6090-071-A) (dual layer) (NTSC) HLX-503 (J-6090-069-A) (single layer) (NTSC) HLX-504 (J-6090-088-A) (single layer) (NTSC) HLX-505 (J-6090-089-A) (dual layer) (NTSC) HLX-506 (J-6090-077-A) (single layer) (PAL) HLX-507 (J-6090-078-A) (dual layer) (PAL) 8-1. STANDARD VIDEO LEVEL 1. Checking Video Output Level This checks whether Video Output level satisfy the NTSC stan- dard. If it is not correct, the brightness will be too large or small. Mode Play Signal Check the Color-bar (100%) signal on DVD reference disc Measurement Point LINE OUT (VIDEO) connector (75 Ω terminated) Measuring Instrument Oscilloscope Specification 1.00 ± 0.05 Vp-p Checking method: 1) Confirm that the Video Output level is 1.00 ± 0.05 Vp-p. Figure 8-1 8-2. VCOM DC LEVEL 1. VCOM DC Level Adjustment When the Driver Board or LCD is replaced, the VCOM DC Level Adjustment is necessary. Mode Play Signal Arbitrary Measurement Point VCOM (Driver Board) Measuring Instrument Digital voltmeter Specification 4.0 V to 4.1 V Adjusting method: 1) Adjust the VR1 to attain 4.0 V to 4.1 V. Figure 8-2 1.00 ± 0.05 Vp-p DRIVER BOARD (SIDE A) VCOM VR1 + www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8-2E MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-1 SECTION 9 TROUBLESHOOTING DVP-FX850 9-1. ELECTRICAL TROUBLE SHOOTING GUIDE No power on by adaptor No power on by battery Is adaptor out 9.5V? YES NO Is P1 OK? Replace P1 Is D2 OK? NO. P_3V3 NO. +3.3V NO. +5V NO. +1.8V Is Q12 OK? Replace Q12 Is U5 OK? Replace U5 Is U2 OK? Is U1 OK? Is –AVCC OK? Replace U2 NO. LCD power Replace U15 Replace U1 Is U4 OK? Replace U4 Replace U6 Is U6 OK? Replace D2 Replace adaptor Is battery OK? Replace Q1 Is Q1 OK? Replace battery AUDIO OUT ABNORMAL SPEAKER ABNORMAL Is S1, S2 OK? Replace S1, S2 Replace U14 Replace U7 Replace speaker Is U14 OK? Is speaker OK? Check audio jack & mode Check U19 Check U17 Check U18 Check signals from U7 (MT1389) YES YES YES YES NO NO NO NO NO NO NO NO NO NO NO NO NO NO NO YES YES YES YES YES YES YES YES YES YES YES YES YES YES YES YES YES YES 1. A. Power (DC-DC Converter) circuit B. Audio out abnormal C. Speaker abnormal Is –USB VCC OK? Replace U21 NO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-2 VIDEO OUT ABNORMAL OPEN/CLOSE ABNORMAL NO CHARGING Is 9.5V OK? Check P1 Is Q12, U6 OK? Replace Q12, U6 Is U3 OK? Replace U3 Is Q4 OK? Replace Q4 Is J3 OK? Replace J3 Check SW1 & SW2 Check the connection of part Check traverse PICTURE ABNORMAL DISC ERROR Check video jack & mode Check the disc Check disc Check the traverse Check traverse Check the SDRAM Refer to servo part Refer to servo part Check LC filter Check video signals from U7 (MT1389) YES YES YES YES D. Video out abnormal G. Open/close abnormal H. Charging circuit E. Picture abnormal F. Disc error NO NO NO NO NO Refer to servo part www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-3 Power is on Does logo appear on the screen? Check power & clock Does the moving picture of the DVD disc play on the screen normally? Does the moving picture of the CD play on the screen normally? Is MPEG data signal normal? Is error signal normal? Check CD/DVD DSP output signal Check MPEG decoder input signal Is clock normal? Check clock signal Check clock signal Does the audio signal output from MPEG decoder? Does the audio sound output normally? 2. MPEG Circuit NO NO NO YES YES YES YES YES OK OK MT1389HD MT1389HD OK OK NO YES NO NO NO YES NO NO Check CD/DVD DSP output signal Check MPEG decoder input signal Check CD/DVD DSP output signal Check MPEG decoder input signal Is MPEG data signal normal? www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-4 START Power on Power green LED on Do all the buttons work normally? Does remote control work normally? Check P_3V3 Check IC MT1389 Does IR1 work by testing waveform normally? Is battery OK? Check J3 on the mainboard Check IC MT1389 Replace IC MT1389 Replace IC MT1389 Replace battery Replace IR1 Check the buttons Is P_3V3 OK? Do the U3 work normally? Check power Replace U3 3. Front Circuit (Dogotrpm & key) YES YES YES YES YES YES YES NO NO NO YES YES NO NO NO NO YES NO NO NO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-5 Put disc in? Disc ID is correct? Does spindle rotate? Focus on OK? Track on OK? DISC is play? Check RF signal waveform Proper signal on A, B, C, D of MT1389 Proper FO+ & FO signal on MT1389 Proper FOSO signal on MT1389? Check the related circuit on MT1389 Check the TRSO connection on MT1389 and motor driver Check the tracking control amp circuit on motor driver Proper TRSO signal on MT1389? TR+ & TR out properly? Check cable connection on pick up head Check the cable connection on pick up head Check the related circuit on MT1389 FO+ & FO signal Check connection between MT1389 and pick up head Check the RF connection between J5 and MT1389 Proper DMSO signal on MT1389 Check the cable connection between spindle and main PCBA Check the related circuit on MT1389 RFL signal Check DMSO related circuit on MT1389 No disc (laser off) 4. RF/Servo Circuit YES YES YES YES YES YES YES YES YES YES YES NO NO NO NO NO NO NO NO NO NO NO NO NO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9-6E Display condition Inverter abnormal Replace VCC5V normal PNL_DVDD normal VGH normal VGL normal Y1 operate Video_Y, Video_C Is M1, U3 OK? Is U2 OK? Is U1 OK? SDA, SCL signal R, G, B signal output TFT LCD normal Check CN1 Check M1 Check BD1 Check BD2, BD3 Replace Y1 Check R15, R16, C82, R12, R13, C80 Replace M1, U3 Replace U2 Replace U1 Check R30, R31, R32, R33 RP1, RP2 check Replace YES NO YES YES YES YES YES YES YES YES YES YES YES NO NO NO NO NO NO NO NO NO NO NO NO Appear shadow from interference in black background There is only bright (LCD B/D) abnormal 9-2. LCD TROUBLE SHOOTING GUIDE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10-1 DVP-FX850 NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories and packing materials are given in the last of the electrical parts list. SECTION 10 REPAIR PARTS LIST 10-1. EXPLODED VIEWS 10-1-1. MAIN BLOCK Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 9-885-103-46 FOOT RUBBER (091-0001-261) 02 9-885-110-96 TRAVERSE +MYLAR (413-0003-164) 3 9-885-113-63 BOTTOM PANEL WITH LABEL (AEP, UK) 3 9-885-113-64 BOTTOM PANEL WITH LABEL (RUS) 04 9-885-113-59 NP-FX110 (79-11000009-92) (Battery Pack) 5 A-1308-586-A MAIN BOARD, COMPLETE (02-01041061-00) (AEP, UK) upper block not supplied not supplied 5 1 1 1 2 3 not supplied not supplied not supplied not supplied not supplied not supplied 7 6 not supplied 4 8 5 A-1308-587-A MAIN BOARD, COMPLETE (02-01041062-00) (RUS) 6 9-885-110-68 REMOTE CONTROL (RMT-D183) (1-885-110-68) 7 A-1268-702-A USB BOARD, COMPLETE (02-06040446-00) 8 9-885-108-32 SHEET, OPEN PREVE (086-0001-041) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • Abbreviation RUS :Russian model www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10-2 10-1-2. UPPER BLOCK Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 A-1308-584-A DISC LID ASSY (030-0002-515) 52 A-1268-689-A UPPER ASSY (030-0001-479) LCD block 51 52 53 not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied 53 9-885-110-31 DISC SPRING S (023-0002-3702) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10-3 10-1-3. LCD BLOCK Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 9-885-112-42 SCREW PAD (091-0001-419) 102 A-1268-693-A BEZEL ASSY (030-0001-478) 103 9-885-112-34 LCD COSMETIC (013-0011-5758) 0104 9-885-112-45 LCD SCREEN (AA0800003151) 106 A-1268-696-A DRIVER BOARD, COMPLETE (02-06040445-00) 107 9-885-103-26 SLIDE BUTTON (013-0001-4093) not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied not supplied 109 108 106 104 101 103 102 101 112 110 108 107 111 not supplied not supplied 108 9-885-112-46 SPEAKER (GP-DSP-250150-03) 109 9-885-112-72 HINGE COVER (013-0021-4086) 110 A-1268-690-A HINGE ASSY (020-0001-760) 111 A-1268-694-A HOUSING ASSY (030-0001-480) 112 9-885-112-43 SCREW PAD (091-0001-420) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10-4E NOTE: • Due to standardization, replacements in the parts list may be different from the parts speci- fied in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • Not all of the parts are listed. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when order- ing these items. • SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . • CAPACITORS uF: µF • COILS uH: µH 10-2. ELECTRICAL PARTS LIST Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. • Abbreviation RUS :Russian model DRIVER MAIN USB A-1268-696-A DRIVER BOARD, COMPLETE (02-06040445-00) *********************** A-1308-586-A MAIN BOARD, COMPLETE (02-01041061-00) (AEP, UK) A-1308-587-A MAIN BOARD, COMPLETE (02-01041062-00) (RUS) ********************* < FUSE > 0P1 9-885-102-63 FUSE 1206, 3A/32V (CF12V3T3R00) 0P2 9-885-102-64 FUSE 1206, 1A/64V (CF12V6T1R0) < IC > U8 6-703-242-01 IC BA5954FP-E2 U9 9-885-101-97 IC MOTOR DRIVER (U-BA6849FM) < JACK > * J1 9-885-102-19 DC JACK, 3P (DC-051) (PHONES) A-1268-702-A USB BOARD, COMPLETE (02-06040446-00) ******************** MISCELLANEOUS ************** 02 9-885-110-96 TRAVERSE +MYLAR (413-0003-164) 104 9-885-112-45 LCD SCREEN (AA0800003151) 108 9-885-112-46 SPEAKER (GP-DSP-250150-03) ACCESSORIES & PACKING MATERIALS ******************************** 3-100-247-11 MANUAL, INST. (086-0001-7812) (ENGLISH) (AEP, UK) 3-100-247-21 MANUAL, INST. (086-0002-7812) (FRENCH) (AEP) 3-100-247-31 MANUAL, INST. (086-0003-7812) (GERMAN) (AEP) 3-100-247-41 MANUAL, INST. (086-0004-7812) (SPANISH) (AEP) 3-100-247-51 MANUAL, INST. (086-0005-7812) (ITALIAN) (AEP) 3-100-247-61 MANUAL, INST. (086-0006-7812) (DUTCH) (AEP) 3-100-247-71 MANUAL, INST. (086-0007-7812) (RUSSIAN) (RUS) 9-885-103-56 AV CABLE (010-0001-206) (RCA Audio/Video cable) 9-885-104-13 CARRYING CASE (086-0001-5560) 0 9-885-105-82 POWER CODE (073-0002-2029) (AEP, RUS) 0 9-885-105-83 POWER CODE (073-0004-2029) (UK) 9-885-110-68 REMOTE CONTROL (RMT-D183) (1-885-110-68) 0 9-885-113-59 NP-FX110 (79-11000009-92) (Battery Pack) 0 9-885-113-60 AC-FX150 (SYBR019H832LF) (AC Adaptor) 0 9-885-113-61 DCC-FX150 (G12PCL-513-0021) (Car Battery Adaptor) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com – 86 – DVP-FX850 Sony Corporation Home Electronics Network Company 9-883-954-11 2007E0500-1 © 2007.5 Published by Quality Assurance Dept. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com REVISION HISTORY Ver. Date Description of Revision 1.0 2007.05 New DVP-FX850 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com

立即购买

下载本素材需消耗 50 积分

无法下载？立即反馈

标签：

版权声明

1. 本站所有素材，仅限学习交流，仅展示部分内容，如需查看完整内容，请下载原文件。
2. 会员在本站下载的所有素材，只拥有使用权，著作权归原作者所有。
3. 所有素材，未经合法授权，请勿用于商业用途，会员不得以任何形式发布、传播、复制、转售该素材，否则一律封号处理。
4. 如果素材损害你的权益请联系客服QQ：77594475 处理。

索尼SONY DVP-FX850音响电路原理图

版权声明

相关素材

索尼XTL-W70汽车电视说明书

索尼SONY TC-K770ES电路图

索尼LMD-152172W232W121322W液晶监视器说明书

索尼KLV-46W300A液晶电视背光板电路图

索尼KLV-17HR2彩电说明书

索尼KDL-75W850C液晶电视说明书

索尼KDL-70W858B液晶电视说明书

索尼KDL-70W850B液晶电视说明书

随机推荐

TCL王牌L55E5300D-3D液晶彩电使用说明书

TCL王牌PWE4210SCH彩电电源原理图

建伍KENWOOD KRC-27YG CD影碟播放机维修手册

先锋PIONEER DEH-12X1M电路图

先锋PIONEER XW-HT1电路图

LG 42LM6200-CE液晶彩电使用说明书

奇声SVD-2069超级VCD电源板电路图

先锋PIONEER KEH-P4800R音响电路图

三星SP50L2HX彩电使用说明书

会员登录