SERVICE MANUAL PORTABLE CD PLAYER SPECIFICATIONS D-NE240/NE241/NE241CK Photo: D-NE240 Ver. 1.0 2006.10 Model Name Using Similar Mechanism D-NE005 CD Mechanism Type CDM-3525A 9-887-425-01 2006J05-1 © 2006.10 Sony Corporation Personal Audio Division Published by Sony Techno Create Corporation AEP Model D-NE240/NE241 E Model D-NE241/NE241CK System Compact disc digital audio system Laser diode properties Emission duration: Continuous Laser output: Less than 44.6 µW (This output is the value measured at a distance of 200 mm from the objective lens surface on the optical pick-up block with 7 mm aperture.) Power requirements • AC power adaptor (DC IN 4.5 V jack): • Two LR6 (size AA) batteries: 1.5 V DC × 2 100 - 240 V, 50/60 Hz Dimensions (w/h/d) (without projecting parts and controls) Mass (excluding accessories) Approx. 210 g Approx. 140.0 × 32.7 × 140.0 mm Operating temperature 5°C - 35°C MPEG Layer-3 audio coding technology and patents licensed from Fraunhofer IIS and Thomson. Design and specifications are subject to change without notice. Supplied accessories AC power adaptor (1) (except NE240) Magic tape (1) (NE241CK) Headphones (1) Car battery cord (1) (NE241CK) Connection Cord (1) (NE241CK) Battery life* (approx. hours) (When the CD player is used on a flat and stable place.) Playing time varies depending on how the CD player is used. When using two Sony alkaline batteries LR6 (SG) (produced in Japan) G-PROTECTION G-on G-off Audio CD 16 11 MP3 CD (Recorded at 128 kbps) 23 23 * Measured value by the standard of JEITA (Japan Electronics and Information Technology Industries Association). • The indicator sections of roughly show the remaining battery power. One section does not always indicate one-fourth of the battery power. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 D-NE240/NE241/NE241CK TABLE OF CONTENTS 1. SERVICING NOTES ............................................... 3 2. GENERAL ................................................................... 4 3. DISASSEMBLY 3-1. Disassembly Flow ........................................................... 5 3-2. Cabinet (Lower) Assy ...................................................... 5 3-3. MAIN Board, CD Mechanism (CDM-3525A) ............... 6 3-4. Cabinet (Inner) Assy, SWITCH Board ............................ 6 4. TEST MODE .............................................................. 7 5. ELECTRICAL CHECK........................................... 7 6. DIAGRAMS 6-1. Printed Wiring Board – SWITCH Board – ..................... 9 6-2. Printed Wiring Board – MAIN Board (Component Side) – ............................... 10 6-3. Printed Wiring Board – MAIN Board (Conductor Side) – ................................. 11 6-4. Schematic Diagram – MAIN Section (1/2) – .................. 12 6-5. Schematic Diagram – MAIN Section (2/2) – .................. 13 7. EXPLODED VIEWS 7-1. Upper Lid and Cabinet (Inner) Section ........................... 17 7-2. Cabinet Lower Section .................................................... 18 8. ELECTRICAL PARTS LIST ................................ 19 Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270 ˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. On the AC power adaptor • Use only the AC power adaptor supplied. If your player is not supplied with an AC power adaptor, use an AC-E45HG AC power adaptor*. Do not use any other AC power adaptor. It may cause a malfunction. * Not available in Australia and some other regions. Ask your dealer for detailed information. Polarity of the plug • Do not touch the AC power adaptor with wet hands. • Connect the AC power adaptor to an easily accessible AC outlet. Should you notice an abnormality in the AC power adaptor, disconnect it from the AC outlet immediately. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 D-NE240/NE241/NE241CK LASER DIODE AND FOCUS SEARCH OPERATION CHECK During normal operation of the equipment, emission of the laser diode is prohibited unless the upper lid is closed while turning ON the S811. (push switch type) The following checking method for the laser diode is operable. • Method: Emission of the laser diode is visually checked. 1. Open the upper lid. 2. With a disc not set, turn on the S811 with a screwdriver having a thin tip as shown in Fig.1. 3. Push the u button. 4. Observing the objective lens, check that the laser diode emits light. When the laser diode does not emit light, automatic power control circuit or optical pickup is faulty. In this operation, the objective lens will move up and down 4 times along with inward motion for the focus search. SECTION 1 SERVICING NOTES Fig. 1 Method to push the S811 S811 S811 MAIN board OPERATION CHECK WHEN THE LID IS OPEN In performing the repair with the power supplied to the set, removing the MAIN board causes the set to be disabled. In such a case, make a solder bridge to short SL801 (OPEN/CLOSE) on the MAIN board in advance. – MAIN Board (Component Side) – SL801 (OPEN/CLOSE) • Abbreviation E92 : 120V AC area in E model MX : Mexican model COLOR VARIATION Model Destination COLOR BLACK SILVER D-NE240 AEP z z AEP z z D-NE241 E92 z MX z D-NE241CK MX z The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emis- sion, observe from more than 30 cm away from the objective lens. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 D-NE240/NE241/NE241CK SECTION 2 GENERAL This section is extracted from instruction manual. Playing time Temps de lecture Play mode Mode de lecture Remaining battery power Autonomie des piles * The button has a tactile dot. / Ce bouton possède un point tactile. Display / Fenêtre d’affichage Headphones Casque / • (group) (groupe) –/+ HOLD (rear) (arrière) (stop) (arrêt)•STOP SOUND/AVLS to an AC outlet vers une prise secteur AC power adaptor Adaptateur secteur *(play/pause) (lecture/pause)•ENTER (headphones) jack Prise (casque d’écoute) P MODE/ VOL +*/– DC IN 4.5 V OPEN GROUP Track number Numéro de plage Sound mode Mode audio Bookmark Signet Group indicator Témoin du groupe MP3 indicator Témoin MP3 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 5 Note: Follow the disassembly procedure in the numerical order given. 3-2. CABINET (LOWER) ASSY • This set can be disassembled in the order shown below. 3-1. DISASSEMBLY FLOW SECTION 3 DISASSEMBLY 3-2. CABINET (LOWER) ASSY (Page 5) 3-4. CABINET (INNER) ASSY, SWITCH BOARD (Page 6) 3-3. MAIN BOARD, CD MECHANISM (CDM-3525A) (Page 6) SET 2 two screws 3 four screws 5 screw 1 Open the upper lid. 4 Open the battery case lid. Note: On installation of MAIN board, adjust the position of slide switch (S812) and knob (hold). 9 cabinet (lower) assy 8 MAIN board block 6 Lift up the CD mechanism. knob (hold) knob (hold) S812 S812 7 flexible flat cable (CN801) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 6 3-3. MAIN BOARD, CD MECHANISM (CDM-3525A) 3-4. CABINET (INNER) ASSY, SWITCH BOARD 3 insulator 3 insulator 3 insulator 4 CD mechanism (CDM-3525A) 1 Remove four solders. orange red gray black 2 flexible board (CN501) 5 MAIN board 7 eight screws 1 two bosses 4 two bosses 2 spring (L) 3 spring (R) 5 battery case lid 6 cabinet (inner) assy 8 cover (upper lid) 9 SWITCH board 0 upper lid www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 7 7 D-NE240/NE241/NE241CK Focus Bias Check Condition: • Hold the set in horizonal state. Connection: Procedure: 1. Connect the oscilloscope to the test point TP604 (RF) on the MAIN board. 2. Set a disc. (YEDS-18) 3. Push the u button. 4. Check the oscilloscope waveform is as shown below. A good eye pattern means that the diamond shape (◊) in the center of the waveform can be clearly distinguished. RF Signal reference Waveform (Eye Pattern) VOLT/DIV: 500 mV (With the 10:1 probe in use) TIME/DIV: 500 ns To watch the eye pattem, set the oscilloscope to AC range and increase the vertical sensitivity of the oscilloscope for easy watching. 5. Stop revolving of the disc motor by pressing the x button. SECTION 4 TEST MODE SECTION 5 ELECTRICAL ADJUSTMENTS The CD section adjustments are done automatically in this set. In case of operation check, confirm that focus bias. Precautions for Cheack 1. Perform check in the order given. 2. Use YEDS-18 disc (Part No.: 3-702-101-01) unless otherwise indicated. 3. Power supply voltage requirement: DC4.5 C in DC IN jack. (J401) HOLD switch: OFF Connecting and Checking Location: In the test mode, this set can check the microcomputer version and liquid crystal display. 1) Short SL803 (TEST) on the MAIN board with a solder bridge. Then, turn on the power. 2) Microcomputer version is displayed on the liquid crystal display, and the liquid crystal display is all lighted. 3) Tuen off the power and open the solder bridge on SL803 (TEST) on the MAIN board. Note: Remove the solders completely. Remaining could be shorted with the chassis, etc. SL803 (TEST) – MAIN Board (Conductor Side) – TP604 (RF) – MAIN Board (Conductor Side) – oscilloscope (AC range) + – MAIN board TP604 (RF) RF level 1.1 to 1.5 Vp-p w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 8 8 D-NE240/NE241/NE241CK • Note for Printed Wiring Boards and Schematic Diagrams Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • f : internal component. • C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • A : B+ Line. • Power voltage is dc 3 V and fed with regulated dc power supply from battery terminal. • Voltages and waveforms are dc with respect to ground in no-signal conditions. no mark : CD PLAY • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal produc- tion tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal produc- tion tolerances. • Circled numbers refer to waveforms. • Signal path. J : CD PLAY Note on Printed Wiring Board: • X : parts extracted from the component side. • Y : parts extracted from the conductor side. • f : internal component. • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: Parts on the pattern face side seen from (Conductor Side) the pattern face are indicated. Parts face side: Parts on the parts face side seen from (Component Side) the parts face are indicated. • Waveforms – MAIN Board – 3 IC601 ya (XO) 500 mV/DIV, 20 ns/DIV 59.4 ns 1.6Vp-p 11.3 µs 3.1 Vp-p 2 IC601 th (CLK88) 1 V/DIV, 5 µs/DIV 237 ns 2.2 Vp-p 1 IC601 tg (CLK) 1 V/DIV, 100 ns/DIV SECTION 6 DIAGRAMS w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 9 9 D-NE240/NE241/NE241CK 6-1. PRINTED WIRING BOARD – SWITCH Board – : Uses unleaded solder. SWITCH BOARD S804 S807 S801 R849 R852 R850 C820 C819 S803 S802 S805 S808 S809 S806 R853 CN802 R854 R851 1-871-511- (11) 11 VOL + STOP x u ENTER VOL – GROUP MAIN BOARD CN801 A S801 – S809 – . + > 1 30 LCD801 LIQUID CRYSTAL DISPLAY 1 24 P-MODE F SOUND AVLS A B C D 1 2 3 4 5 6 7 8 9 (Page 10) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 10 10 D-NE240/NE241/NE241CK D403 H-6 IC301 E-2 IC401 G-6 IC601 C-3 IC603 A-3 IC802 F-6 Q320 E-2 Q321 D-2 Q323 D-2 Q401 H-7 Q602 C-2 6-2. PRINTED WIRING BOARD – MAIN Board (Component Side) – : Uses unleaded solder. CD MECHANISM BLOCK CDM-3525A (1/2) C632 C633 C620 C631 C618 C629 R626 RB602 RB601 R615 C615 C604 C609 FB602 CN801 R617 R613 R606 C611 C606 R614 R621 RB304 C105 R103 R203 C108 C301 RB301 C206 C106 VDR101 R202 R102 VDR201 C208 C303 R305 R304 RB305 C205 C324 RB331 RB330 C624 C101 C201 RB303 RB620 C625 R624 C619 C642 C634 IC603 FB605 R811 R618 R622 C637 IC601 Q602 Q321 Q323 Q320 R804 RB803 C871 C805 VDR801 CB414 R416 R417 R418 R407 R406 C413 R405 R401 R404 C405 C407 C406 L407 L406 CN403 CN408 CN407 CN404 SL801 C401 C421 L405 L404 F402 R402 R419 FB401 FB801 Q401 D403 IC401 IC802 1-871-510- (11) 11 IC301 MAIN BOARD (COMPONENT SIDE) E C B E C B E C B SWITCH BOARD CN802 A 1 3 5 4 1C 2B 2C 1B 1E 2E 2C 1B 1C 2B 2E 1E 1 30 (OPEN/CLOSE) A B C D E F G H 1 2 3 4 5 6 7 8 (Page 9) • Semiconductor Location Ref. No. Location w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 11 11 D-NE240/NE241/NE241CK D401 H-4 D402 H-3 D404 H-2 D406 H-2 D803 G-4 IC602 C-6 IC801 F-4 Q322 E-8 Q324 D-8 Q402 H-4 Q403 H-5 Q404 H-5 Q601 F-7 6-3. PRINTED WIRING BOARD – MAIN Board (Conductor Side) – : Uses unleaded solder. • Semiconductor Location Ref. No. Location C431 R415 R414 C417 R856 RB801 RB810 RB811 RB812 RB813 RB814 RB815 C627 C640 X601 C612 C402 C605 C603 Q324 R327 R326 C323 C102 C320 C321 C202 R329 R323 R321 R320 Q322 Q601 R603 R602 R201 R211 R111 L101 FB301 L201 C110 R101 C210 R410 R835 C809 C626 C806 R817 R818 C814 C813 SL803 C812 R847 C808 C802 RB806 R848 IC801 R821 R823 C818 C811 R829 R827 Q404 Q403 C416 D803 R828 R810 R422 C428 R403 Q402 D401 C403 C411 C410 C412 C807 F401 D406 D404 D402 VDR418 R812 VDR802 R604 R322 C322 R328 R619 IC602 C404 C419 L403 C420 J301 S811 S812 C409 C408 L401 J401 L402 C305 C304 C104 C204 C602 C601 C610 C623 C607 CN501 C810 C628 C630 MAIN BOARD (CONDUCTOR SIDE) 1-871-510- (11) 11 CN402 CN401 E C B E C B DC IN 4.5V – + + + + + + + + + + + + + B C E DRY BATTERY SAZE "AA" (IEC DESIGNATION LR6) 2PCS. 3V 1E 2E 2B 1C 1B 2C 1E 2E 2B 1C 1B 2C S811 OPEN/CLOSE DETECT i ON T OFF HOLD 1C 2B 2C 1B 1E 2E (TEST) 15 16 1 2 A B C D E F G H 1 2 3 4 5 6 7 8 9 TP604 (RF) CD MECHANISM BLOCK CDM-3525A (2/2) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 12 12 D-NE240/NE241/NE241CK 6-4. SCHEMATIC DIAGRAM – MAIN Board (1/2) – • See page 8 for Waveforms. • See page 14 for IC Block Diagrams. IC601 Z623 R615 C615 C609 C606 R606 C605 C607 R614 C610 C611 R604 C618 C402 RB601 RB602 R626 C629 C620 C623 C604 R617 C633 C642 R624 C619 FB602 R811 C637 X601 R618 R622 Z601 C624 C630 RB620 Z632 C627 C640 IC603 R602 C602 C101 C201 C102 RB330 C324 R327 R326 R329 R328 RB331 R320 R321 R322 C320 C321 C322 C323 Q320 C105 C205 R103 R203 C625 R619 Q602 C303 R305 C301 C305 IC301 RB305 C210 C204 R101 RB301 R410 RB303 RB304 C208 C108 C202 C110 C104 Z405 C106 R102 C206 R202 CN501 CD MECHANISM BLOCK CDM-3525A (1/2) R323 C626 Z407 Z403 Z402 Q324 Q323 Q322 Q321 R621 C631 C628 C304 R304 R111 L101 L201 R211 IC602 C634 C632 FB605 C612 R613 C603 Q601 C601 R603 R201 FB301 J301 VDR201 VDR101 TP604 BU9541JKV 68k 2200p 2200p 0.1 220k 0.1 47 6.3V 470 4.7 50V 0.22 100k 470p 0.01 10k 10k 220 2.2 0.1 470 6.3V 0.1 100 0.1 1 100k 0.1 100k 0.1 16.9344MHz 1M 220 0.1 10 16V 10k 4.7 4.7 BH15FB1WG-TR 2.2 47 6.3V 2200p 2200p 1000p 47k 0.47 2.2k 2.2k 1M 1M 1k 220 220 1M 0.047 0.047 0.047 0.047 2SA2018TL 2.2 2.2 22k 22k 2.2 100k RT1N140M-TP-1 1 220k 0.1 47 6.3V BH3544 22k 1000p 220 6.3V 10 1k 1 470 470 470p 470p 1000p 1000p 220 6.3V 0.22 2.2 0.22 2.2 16P 1M 0.01 UMH8N UMH8N UMH8N UMB2N-TN 0.1 10 16V 100 6.3V 1M 10 10 M12L16161A-7T(J) 1 10 0.1 68k 0.01 2SA1602TP-1EF 47 6.3V 4.7 10 A1 A2 A3 A6 A7 A8 FDOUT TDOUT SDOUT CLVOUT CLK CKE A13 A00 A01 A02 A03 A04 A05 A06 A07 A08 A09 A10 A11 RAS CAS WE LDQM UDQM DQ07 DQ00 DQ01 DQ02 DQ03 DQ04 DQ05 DQ06 RESTB CLK88 CLK SUBSYQ BUSY MCK DIN/DOUT R/W DQ00 DQ01 DQ02 DQ03 DQ04 DQ05 DQ06 DQ07 DQ00 DQ01 DQ02 DQ03 DQ04 DQ05 DQ06 DQ07 LDQM WE CAS RAS A10 A11 A00 A01 A02 A03 UDQM CLK CKE A04 A05 A06 A07 A08 A09 LPF_SW2 XHP_MUTE LPF_SW3 LPF_SW1 F+ T+ T- F- OUT1 XMUTE IN1 GND VCC OUT2 BIAS IN2 SD-RAM VCC DQ0 DQ1 VSSQ DQ2 DQ3 VCCQ DQ4 DQ5 VSSQ DQ6 DQ7 VCCQ LDQM XWE CAS RAS XCS A11 A10 A0 A1 A2 A3 VCC VSS DQ15 DQ14 VSSQ DQ13 DQ12 VCCQ DQ11 DQ10 VSSQ DQ9 DQ8 VCCQ NC UDQM CLK CKE NC A9 A8 A7 A6 A5 A4 VSS VOUT NC VIN VSS CE AVDD1 AC BD VBIAS AGND1 E F PD LD ASY PCO FCO FDOUT TDOUT SDOUT CLVOUT RCLK RCKE A13 A12 A11 A10 A09 A08 A07 A06 A05 A04 A03 A02 A01 A00 VDD_CORE1 RASX CASX WEX LDQM UDQM DQ07 DGND1 RFI ANA_MONI1 ANA_MONI0 AD_MONI1 AD_MONI0 VDD_RD HPRDACO VSS_RD VSS_LD HPLDAC0 VDD_LD AVDD2 RDACO VCDAC LDACO AGND2 FLAG0 DVDD2 XO XI DGND2 TESET RESTB CLK88 SUBSYQ BUSY MCK DIN/DOUT R/W VDD_CORE2 DQ00 DQ01 DQ02 DQ03 DQ04 DQ05 DQ06 DVDD1 C E A B F VCC VC GND GND PD LD NC F+ T+ T- F- (1/2) FILTER SWITCH FILTER SWITCH LOW-PASS FILTER FILTER LOW-PASS FILTER LOW-PASS BUFFER RF AMP,SERVO,DIGITAL SIGNAL PROCESSOR, ,SD-RAM CONTROLLER,D/A CONVERTER HEADPHONE AMP +1.5V REGULATOR CLK EQO AUTOMATIC POWER CONTROL -1-2 -1-2 -1-2 -1-2 2200p 2200p (RF) (Page 13) (Page 13) (Page 13) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 13 13 D-NE240/NE241/NE241CK 6-5. SCHEMATIC DIAGRAM – MAIN Board (2/2) – IC802 S811 RB803 FB801 RB806 RB801 CN801 L406 L407 47µH 47µH Z401 L401 330µH Q401 L403 10µH L402 165µH VDR418 D406 D404 R804 C805 C871 R828 R812 C809 C808 R818 R817 C814 C806 SL803 C813 C812 C802 R847 R848 RB810 RB811 RB812 RB813 RB814 RB815 R827 R821 R810 C807 R422 C428 FB401 R419 CB414 C406 C407 C412 C410 C411 C413 R406 R405 C409 Q402 C403 C404 C408 R403 D403 C419 C431 R415 R414 C416 C417 C405 R404 Q403 D402 C421 IC801 CN802 C820 C819 S807 S808 R852 R853 R854 R849 R850 R851 R835 R856 D803 S812 VDR801 VDR802 C810 C818 R823 R829 C811 C420 R416 R417 R418 R407 R401 C401 R402 L404 L405 D401 IC401 F401 F402 J401 CN404 CN403 CN407 CN408 CN401 CN402 S801 S804 S805 S806 S809 S802 S803 SL801 Z801 Q404 BR24L02 10k 47k 10k 30P 2SB1132-T100-Q UDZS-TE17-12B UDZS-TE17-12B 0 0.1 0.1 2.2k 100k 0.1 1 100k 10k 470p 0.1 470p 470p 0.01 2.2k 2.2k 10k 10k 10k 10k 10k 10k 470k 100k 1M 1 47k 0.022 0 22k 0.022 0.1 10 1 0.1 470p 0.022 10k 12k 10 16V UMH8N 0.1 10 16V 220 6.3V 1k MA2YD2300LS0 220 6.3V 1 1k 10 47p 0.1 1000p 100 2SD2652T106 MA2YD2300LS0 0.22 BU18704-S1 30P 470 470 2.2k 4.7k 22k 2.2k 4.7k 22k 470 MA111-TX 22 6.3V 0.1 1k 100k 0.1 470 6.3V 22k 100k 47k 27k 100k 1 22k MAZ8062-TX BH6575FV 2A 32V 2A 32V 1P 1P 2SD2652T106 A2 A1 A3 A6 A7 A8 SUBSYQ LPF_SW1 LPF_SW2 LPF_SW3 KEY1 KEY2 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 KEY1 KEY2 COM1 COM2 COM3 COM4 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 OFF MUTE1 MUTE34 COM1 COM2 COM3 COM4 WP WP OFF CLK88 MUTE34 MUTE1 RESET RESET CLVOUT SDOUT TDOUT FDOUT F- F+ T+ T- DIN/DOUT MCK R/W BUSY A13 RESTB XHP_MUTE CLK COM1 COM2 COM3 COM4 COM1 COM2 COM3 COM4 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 VCC WP SCL SDA A0 A1 A2 GND GND GND SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 COM4 COM3 COM2 COM1 S_GND KEY2 KEY1 GND XIN4M XOUT4M VDD DC_IN BATT+ KEY1 KEY2 WREM SEL_OPTION SEL_DRAM TEST1 XP.OFF MMUTE1 MMUTE2 COM1 COM2 COM3 COM4 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 XLINEOUT_MUTE EE_SDA/REM_SDA EE_SCL PLL_CE PLL_CKE PLL_DATA NC SEL_CEX NC NC NC GND NC LPF_SW1 LPF_SW2 LPF_SW3 XLINE_DET SUBSYQ HOLD TEST MODE XIN75 TEST0 XRESET XHP_MUTE TU_CTL CD_CTL XXRESET VDD FIFO BUSY R.W MCK NC BEEP K_TUNER K_PLAY INNER OPEN/CLOSE DIN OUT TRK+ TRK- FO+ FO- DPG1 FIL4 FIL3 FIL2 FIL1 VREF FOCUS TRK SLED CLV RESET MUTE1 MUTE34 CLK OFF WP PVCC SLED- SLED+ SPIND- SPIND+ DPG2 SPRT SOFT CT DCIN REGB REGO PRGND PGND LG VG SW VSYS EI EO (2/2) GND GND SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 COM4 COM3 COM2 COM1 S_GND KEY2 KEY1 SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 COM4 COM3 COM2 COM1 K_PLAY ON OFF HOLD EEPROM (TEST) XOUT75 SYSTEM CONTROLLER SWITCHING SWITCHING SPINDLE MOTOR DRIVE,DC/DC CONVERTER FOCUS/TRANCKING COIL DRIVE,SLED/ -1 -2 DETECT DC IN +B SWITCH DC IN 4.5V DRY BATTERY SIZE"AA" (IEC DESIGNATION LR6) 2PCS. 3V K_PLAY LIQUID DISPLAY CRYSTAL ENTER VOL + VOL - GROUP P-MODE + - STOP SOUND AVSL LCD801 (OPEN/CLOSE) OPEN/CLOSE DETECT 1 24 CD MECHANISM BLOCK CDM-3525A (2/2) (Page 12) (Page 12) (Page 12) • See page 14 for IC Block Diagrams. • See page 15 for IC Pin Function Description. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-NE240/NE241/NE241CK 14 14 D-NE240/NE241/NE241CK • IC Block Diagrams – MAIN Board – IC301 BH3544F-FE2 1 20 19 18 17 OUT1 2 MUTE 3 IN1 4 GND VCC OUT2 BIAS IN2 + + BIAS MUTE IC401 BH6575FV 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 START OFF CLK MUTE34 MUTE1 RESET IN1 IN2 IN3 IN4 VREF FIL1 FIL2 FIL3 FIL4 PGND1 OUT4− OUT4+ OUT3− OUT3+ 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 EO EI VSYS SW VG LG PGND3 GND REGO REGB DC IN CT SOFT SPRT PGND2 OUT1+ OUT1− OUT2+ OUT2− PVCC VSYS DC/DC CONVERTER SYSTEM OFF SYSTEM ON OSC MUTE34 MUTE1 RESET PRE-DRIVER PRE-DRIVER PRE-DRIVER PRE-DRIVER VG CONVERTER REGULATOR VSYS DETECT IC601 BU9541JKV MP3 & ADPCM CORE X8 OVER SAMPLING DIGITAL FILTER DIGITAL SIGNAL PROCESSOR DIGITAL SERVO SIGNAL PROCESSOR 16K SRAM SERVE SIGNAL GENERATOR RF SIGNAL GENERATOR APC D CLASS HP AMPLIFIER PLL LINE AMPLIFIER 1 BIT DAC AVDD1 AC BD VBIAS AGND1 E F PD LD ASY PCO FCO FDOUT TDOUT SDOUT CLVOUT RCLK RCKE A13 A12 A11 A10 A09 A08 A07 A06 A05 A04 A03 A02 A01 A00 VDD_CORE1 DGND RASX CASX WEX LDQM UDQM DQ07 SUBSYQ BUSY MCK DIN/DOUT VDD_CORE2 DQ00 DQ01 DQ02 DQ03 DQ04 DQ05 DQ06 DVDD1 R/W XI DGND2 TEST RESETB CLK CLK88 EQO RFI ANA_MONI1 ANA_MONI0 AD_MONI1 AD_MONI0 VDD_RD HPRDACO VSS_RD VSS_LD HPLDACO VDD_LD AVDD2 RDACO VCDAC LDACO AGND2 FLAG0 DVDD2 XO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 80 79 78 77 76 75 74 73 72 71 70 69 54 53 52 51 49 46 45 44 68 67 66 65 64 63 62 61 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 43 42 41 47 48 50 60 59 58 57 55 56 IC603 BH15FB1WG THERMAL PROTECTION VOLTAGE REFERENCE CONTROL BLOCK OVER CURRENT PROTECTION VIN + − 1 GND 2 STBY 3 NC 4 VOUT 5 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 15 D-NE240/NE241/NE241CK • IC Pin Function Description MAIN BOARD IC801 BU18704-S1 (SYSTEM CONTROLLER) Pin No. Pin Name I/O Description 1 SEG0 O Segment drive signal output terminal Not used 2 to 21 SEG1 to SEG20 O Segment drive signal output to the liquid crystal display 22 XLINEOUT_ MUTE - Not used 23 EE_SDA/ REM_SDA O Two way data bus with the power control and EEPROM 24 EE_SCL O Serial clock signal output to the power control and EEPROM 25 PLL_CE - Not used 26 PLL_CKE - Not used 27 PLL_DATA - Not used 28 NC - Not used 29 SEL_CEX I Model setting terminal 30 to 32 NC - Not used 33 GND - Ground terminal 34 NC - Not used 35 to 37 LPF_SW1 to LPF_SW3 O Low-pass filter on/off control signal output terminal 38 XLINE_DET - Not used 39 SUBSYSQ I Sub-code sync (S0+S1) detection signal input from the RF amplifier 40 HOLD I HOLD switch input terminal "L": hold on, "H": hold off 41 OPEN/CLOSE I CD lid open/close detection switch input terminal 42 NC - Not used 43 K_PLAY I Play key input terminal 44 K_TUNER - Not used 45 BEEP - Not used 46 NC - Not used 47 DIN OUT I/O Commande output/DSP status input terminal 48 MCK O Serial interface clock signal output to the RF amplifier 49 R.W O Data read/write selection signal output to the RF amplifier 50 BUSY I Busy signal input from the RF amplifier 51 FIFO O SD-RAM initialize signal output to the RF amplifier 52 VDD - Power supply terminal (+3V) 53 XXRESET O System reset signal output to the RF amplifier "L": reset 54 CD_CTL - Not used 55 TU_CTL - Not used 56 XHP_MUTE O Headphone muting on/off control signal output to the headphone amplifier 57 XRESET I System reset signal input from the DC/DC converter "L": reset 58 TEST0 - Not used 59 XIN75 - Not used 60 XOUT75 - Not used 61 GND - Ground terminal 62 XIN4M I Clock signal input (4MHz) from the RF amplifier 63 XOUT4M - Not used 64 VDD - Power supply terminal (+3V) 65 DC_IN I DC input voltage monitor input terminal 66 BATT+ I Battery voltage monitor input terminal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 16 D-NE240/NE241/NE241CK Pin No. Pin Name I/O Description 67, 68 KEY1, KEY2 I Top panel key input terminal (A/D input) 69 TEST MODE I Setting terminal for the CD test mode Normally: fixed at "H" ("L": test mode) 70 WREM - Not used 71 SEL_OPTION I Option setting terminal Fixed at "L" in this set 72 SEL_DRAM I Internal D-RAM setting terminal Fixed at "L" in this set 73 TEST1 - Not used 74 XP.OFF O Power off controlsignal output terminal 75 MMUTE1 O Spindle motor drive on/off control signal output terminal 76 MMUTE2 O Sled motor drive on/off control signal output terminal 77 to 80 COM1 to COM4 O Common drive signal output to the liquid crystal display www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 17 D-NE240/NE241/NE241CK 3 4 5 5 SWITCH board cabinet lower section 2 1 15 10 7 9 14 13 12 11 6 8 SECTION 7 EXPLODED VIEWS Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 2-699-871-01 SPRING (L) 2 2-699-872-01 SPRING (R) 3 X-2159-378-1 LID SUB ASSY, UPPER (for SILVER) (NE240) 3 X-2159-381-1 LID SUB ASSY, UPPER (for BLACK) (NE240) 3 X-2159-385-1 LID SUB ASSY (S), UPPER (for SILVER) (NE241) 3 X-2159-386-1 LID SUB ASSY (B), UPPER (for BLACK) (NE241: AEP) 3 X-2176-011-1 LID SUB ASSY (B), UPPER (for BLACK) (NE241CK) 4 2-699-864-01 LID, BATTERY CASE (SILVER) 4 2-699-864-11 LID, BATTERY CASE (BLACK) 5 3-254-070-11 SCREW 6 A-1209-616-A SWITCH BOARD, COMPLETE 7 1-833-573-11 CABLE, FLEXIBLE FLAT 8 2-699-865-01 COVER (LID, UPPER) (SILVER) 8 2-699-865-11 COVER (LID, UPPER) (BLACK) 9 3-254-014-11 SCREW 10 2-699-855-01 CABINET (MIDDLE) (SILVER) 10 2-699-855-11 CABINET (MIDDLE) (BLACK) 11 2-699-862-01 KNOB (OPEN) (SILVER) 11 2-699-862-11 KNOB (OPEN) (BLACK) 12 2-187-914-01 SPRING (OPEN) 13 2-187-913-01 LEVER (OPEN) 14 3-034-792-11 SCREW, TAPPING (B2.0) 15 2-895-894-01 CUSHION (CDM) 7-1. UPPER LID AND CABINET (INNER) SECTION • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories are given in the last of the electrical parts list. • Refer to “COLOR VARIATION” in the “SERVICING NOTES” (page 3) about color variation of model and destination. NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 18 D-NE240/NE241/NE241CK 7-2. CABINET LOWER SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 2-699-869-01 TERMINAL (RELAY), BATTERY 52 3-245-331-02 INSULATOR 053 A-1112-193-A CDM-3525A (CD MECHANISM) 54 2-699-867-01 TERMINAL (+), BATTERY 55 A-1209-048-A MAIN PC BOARD ASSY 56 2-699-868-01 TERMINAL (-), BATTERY 57 2-699-856-01 CABINET (LOWER) (SILVER) 57 2-699-856-11 CABINET (LOWER) (BLACK) 58 2-699-863-01 KNOB (HOLD) (SILVER) 58 2-699-863-11 KNOB (HOLD) (BLACK) 57 58 MAIN board not supplied not supplied 51 56 55 54 52 52 52 53 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 D-NE240/NE241/NE241CK SECTION 8 ELECTRICAL PARTS LIST Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1209-048-A MAIN BOARD, COMPLETE ********************* 2-699-867-01 TERMINAL (+), BATTERY 2-699-868-01 TERMINAL (–), BATTERY < CAPACITOR > C101 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C102 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C104 1-124-635-00 ELECT 220uF 20% 6.3V C105 1-135-834-11 CERAMIC CHIP 2.2uF 6.3V C106 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C108 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C110 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C201 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C202 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C204 1-124-635-00 ELECT 220uF 20% 6.3V C205 1-135-834-11 CERAMIC CHIP 2.2uF 6.3V C206 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C208 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C210 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C301 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C303 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V C304 1-126-382-11 ELECT 100uF 20% 16V C305 1-126-513-11 ELECT 47uF 20% 6.3V C320 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C321 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C322 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C323 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C324 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V C401 1-100-352-11 CERAMIC CHIP 1uF 20% 16V C402 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C403 1-164-156-11 CERAMIC CHIP 0.1uF 25V C404 1-126-791-11 ELECT 10uF 20% 35V C405 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C406 1-164-156-11 CERAMIC CHIP 0.1uF 25V C407 1-112-342-91 CERAMIC CHIP 10uF 20% 10V C408 1-124-635-00 ELECT 220uF 20% 6.3V C409 1-126-791-11 ELECT 10uF 20% 35V C410 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C411 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C412 1-115-156-11 CERAMIC CHIP 1uF 10V C413 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C416 1-162-923-11 CERAMIC CHIP 47PF 5% 50V NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u: µ, for example: uA... : µA... uPA... : µPA... uPB... : µPB... uPC... : µPC... uPD... : µPD... • CAPACITORS uF: µF • COILS uH: µH • Abbreviation E92 : 120 V AC area in E model MX : Mexican model The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. MAIN C417 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C419 1-124-635-00 ELECT 220uF 20% 6.3V C420 1-119-941-41 ELECT 470uF 20% 6.3V C421 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C428 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C431 1-100-352-11 CERAMIC CHIP 1uF 20% 16V C601 1-126-513-11 ELECT 47uF 20% 6.3V C602 1-126-513-11 ELECT 47uF 20% 6.3V C603 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C604 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C605 1-164-156-11 CERAMIC CHIP 0.1uF 25V C606 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C607 1-126-513-11 ELECT 47uF 20% 6.3V C609 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C610 1-126-794-11 ELECT 4.7uF 20% 50V C611 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C612 1-164-156-11 CERAMIC CHIP 0.1uF 25V C615 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C618 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C619 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C620 1-164-156-11 CERAMIC CHIP 0.1uF 25V C623 1-119-941-41 ELECT 470uF 20% 6.3V C624 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C625 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3V C626 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C627 1-100-507-91 CERAMIC CHIP 4.7uF 20% 6.3V C628 1-126-791-11 ELECT 10uF 20% 35V C629 1-135-834-11 CERAMIC CHIP 2.2uF 6.3V C630 1-126-791-11 ELECT 10uF 20% 35V C631 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C632 1-100-966-91 CERAMIC CHIP 10uF 20% 10V C633 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C634 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V C637 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C640 1-100-507-91 CERAMIC CHIP 4.7uF 20% 6.3V C642 1-100-352-11 CERAMIC CHIP 1uF 20% 16V C802 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C805 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C806 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C807 1-115-156-11 CERAMIC CHIP 1uF 10V C808 1-115-156-11 CERAMIC CHIP 1uF 10V C809 1-164-156-11 CERAMIC CHIP 0.1uF 25V C810 1-126-514-11 ELECT 22uF 20% 16V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 20 D-NE240/NE241/NE241CK MAIN C811 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C812 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C813 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C814 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C818 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C871 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V < COMPOSITION CIRCUIT BLOCK > CB414 1-112-557-11 CERAMIC CHIP 0.022uF 20% 16V < CONNECTOR > CN501 1-774-975-51 CONNECTOR, FFC/FPC 16P CN801 1-573-370-51 CONNECTOR, FFC/FPC (ZIF) 30P < DIODE > D401 8-719-422-58 DIODE MA8062 D402 8-719-085-43 DIODE MA2YD2300LS0 D403 8-719-085-43 DIODE MA2YD2300LS0 D404 8-719-083-82 DIODE UDZS-TE17-12B D406 8-719-083-82 DIODE UDZS-TE17-12B D803 8-719-404-50 DIODE MA111-TX < FUSE > 0F401 1-576-415-21 FUSE (2A/32V) 0F402 1-576-415-21 FUSE (2A/32V) < FERRITE BEAD/JUMPER RESISTOR > FB301 1-414-813-11 FERRITE, EMI (SMD) (2012) FB401 1-216-864-11 SHORT CHIP 0 FB602 1-414-760-21 FERRITE, EMI (SMD) (1608) FB605 1-414-760-21 FERRITE, EMI (SMD) (1608) FB801 1-414-760-21 FERRITE, EMI (SMD) (1608) < IC > IC301 8-759-588-61 IC BH3544F-FE2 IC401 6-704-047-01 IC BH6575FV-E2 IC601 6-709-383-01 IC BU9541JKV IC602 6-709-459-01 IC M12L16161A-7T (J) IC603 6-705-807-01 IC BH15FB1WG IC801 6-805-927-02 IC BU18704-S1 IC802 6-704-001-01 IC BR24L02F-WE2 < JACK > J301 1-819-363-11 JACK, HEADPHONE (i) J401 1-819-364-11 JACK, DC (POLARITY UNIFIED TYPE) (DC IN 4.5V) < COIL > L101 1-469-152-11 FERRITE, EMI (SMD) (2012) L201 1-469-152-11 FERRITE, EMI (SMD) (2012) L401 1-457-095-11 INDUCTOR 330uH L402 1-457-096-11 INDUCTOR 165uH L403 1-400-945-11 INDUCTOR 10uH L404 1-469-670-21 FERRITE, EMI (SMD) (2012) L405 1-469-670-21 FERRITE, EMI (SMD) (2012) L406 1-400-145-21 INDUCTOR 47uH L407 1-400-145-21 INDUCTOR 47uH < TRANSISTOR > Q320 8-729-051-23 TRANSISTOR 2SA2018TL Q321 6-551-375-01 TRANSISTOR UMB2N-TN Q322 6-551-395-01 TRANSISTOR UMH8N-TR Q323 6-551-395-01 TRANSISTOR UMH8N-TR Q324 6-551-395-01 TRANSISTOR UMH8N-TR Q401 8-729-106-60 TRANSISTOR 2SB1115A-YQ Q402 6-551-395-01 TRANSISTOR UMH8N-TR Q403 6-550-364-01 TRANSISTOR 2SD2652T106 Q404 6-550-364-01 TRANSISTOR 2SD2652T106 Q601 8-729-602-36 TRANSISTOR 2SA1602-F Q602 8-729-028-97 TRANSISTOR DTC114TUA-T106 < RESISTOR/FERRITE BEAD > R101 1-216-797-11 METAL CHIP 10 5% 1/10W R102 1-216-789-11 METAL CHIP 2.2 5% 1/10W R103 1-216-837-11 METAL CHIP 22K 5% 1/10W R111 1-216-797-11 METAL CHIP 10 5% 1/10W R201 1-216-797-11 METAL CHIP 10 5% 1/10W R202 1-216-789-11 METAL CHIP 2.2 5% 1/10W R203 1-216-837-11 METAL CHIP 22K 5% 1/10W R211 1-216-797-11 METAL CHIP 10 5% 1/10W R304 1-216-857-11 METAL CHIP 1M 5% 1/10W R305 1-216-849-11 METAL CHIP 220K 5% 1/10W R320 1-216-813-11 METAL CHIP 220 5% 1/10W R321 1-216-813-11 METAL CHIP 220 5% 1/10W R322 1-216-857-11 METAL CHIP 1M 5% 1/10W R323 1-216-857-11 METAL CHIP 1M 5% 1/10W R326 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R327 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R328 1-216-857-11 METAL CHIP 1M 5% 1/10W R329 1-216-857-11 METAL CHIP 1M 5% 1/10W R401 1-216-845-11 METAL CHIP 100K 5% 1/10W R402 1-216-837-11 METAL CHIP 22K 5% 1/10W R403 1-216-821-11 METAL CHIP 1K 5% 1/10W R404 1-216-809-11 METAL CHIP 100 5% 1/10W R405 1-218-873-11 METAL CHIP 12K 0.5% 1/10W R406 1-216-833-11 METAL CHIP 10K 5% 1/10W R407 1-218-881-11 METAL CHIP 27K 0.5% 1/10W R410 1-218-446-11 METAL CHIP 1 5% 1/10W R414 1-216-797-11 METAL CHIP 10 5% 1/10W R415 1-216-821-11 METAL CHIP 1K 5% 1/10W R416 1-216-837-11 METAL CHIP 22K 5% 1/10W R417 1-216-845-11 METAL CHIP 100K 5% 1/10W R418 1-216-841-11 METAL CHIP 47K 5% 1/10W R419 1-216-837-11 METAL CHIP 22K 5% 1/10W R422 1-216-841-11 METAL CHIP 47K 5% 1/10W R602 1-216-789-11 METAL CHIP 2.2 5% 1/10W R603 1-216-793-11 METAL CHIP 4.7 5% 1/10W R604 1-216-845-11 METAL CHIP 100K 5% 1/10W R606 1-216-849-11 METAL CHIP 220K 5% 1/10W R613 1-216-843-11 METAL CHIP 68K 5% 1/10W R614 1-216-817-11 METAL CHIP 470 5% 1/10W R615 1-216-843-11 METAL CHIP 68K 5% 1/10W R617 1-216-809-11 METAL CHIP 100 5% 1/10W R618 1-216-857-11 METAL CHIP 1M 5% 1/10W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 21 D-NE240/NE241/NE241CK SWITCH MAIN R619 1-216-845-11 METAL CHIP 100K 5% 1/10W R621 1-414-760-21 FERRITE, EMI (SMD) (1608) R622 1-216-813-11 METAL CHIP 220 5% 1/10W R624 1-216-845-11 METAL CHIP 100K 5% 1/10W R626 1-216-813-11 METAL CHIP 220 5% 1/10W R804 1-216-864-11 SHORT CHIP 0 R810 1-216-857-11 METAL CHIP 1M 5% 1/10W R811 1-216-845-11 METAL CHIP 100K 5% 1/10W R812 1-216-845-11 METAL CHIP 100K 5% 1/10W R817 1-216-833-11 METAL CHIP 10K 5% 1/10W R818 1-216-845-11 METAL CHIP 100K 5% 1/10W R821 1-216-845-11 METAL CHIP 100K 5% 1/10W R823 1-216-821-11 METAL CHIP 1K 5% 1/10W R827 1-216-853-11 METAL CHIP 470K 5% 1/10W R828 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R829 1-216-845-11 METAL CHIP 100K 5% 1/10W R835 1-414-760-21 FERRITE, EMI (SMD) (1608) R847 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R848 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R856 1-216-817-11 METAL CHIP 470 5% 1/10W < COMPOSITION CIRCUIT BLOCK > RB301 1-233-787-11 RES, NETWORK 1K (1608) RB303 1-233-679-11 RES, NETWORK (1608) 470 RB304 1-233-679-11 RES, NETWORK (1608) 470 RB305 1-233-790-91 RES, NETWORK 22K (1608) RB330 1-233-791-91 RES, NETWORK 47K (1608) RB331 1-233-787-11 RES, NETWORK 1K (1608) RB601 1-233-789-11 RES, NETWORK 10K (1608) RB602 1-233-789-11 RES, NETWORK 10K (1608) RB620 1-233-789-11 RES, NETWORK 10K (1608) RB801 1-233-789-11 RES, NETWORK 10K (1608) RB803 1-233-789-11 RES, NETWORK 10K (1608) RB806 1-233-791-91 RES, NETWORK 47K (1608) RB810 1-236-908-11 RES, CHIP NETWORK 10K (3216) RB811 1-236-908-11 RES, CHIP NETWORK 10K (3216) RB812 1-236-908-11 RES, CHIP NETWORK 10K (3216) RB813 1-236-908-11 RES, CHIP NETWORK 10K (3216) RB814 1-236-908-11 RES, CHIP NETWORK 10K (3216) RB815 1-236-908-11 RES, CHIP NETWORK 10K (3216) < SWITCH > S811 1-570-953-11 SWITCH, PUSH (1 KEY) (OPEN/CLOSE DETECT) S812 1-786-864-11 SWITCH, SLIDE (HOLD) < CAPACITOR/VARISTOR > VDR101 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V VDR201 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V VDR418 1-801-864-21 VARISTOR, CHIP (1608) VDR801 1-801-923-11 VARISTOR, CHIP (1608) VDR802 1-801-923-11 VARISTOR, CHIP (1608) < VIBRATOR > X601 1-813-590-11 VIBRATOR, CERAMIC (16.9344MHz) ************************************************************ A-1209-616-A SWITCH BOARD, COMPLETE *********************** 1-833-573-11 CABLE, FLEXIBLE FLAT < CAPACITOR > C819 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C820 1-162-962-11 CERAMIC CHIP 470PF 10% 50V < CONNECTOR > CN802 1-573-939-51 CONNECTOR, FFC/FPC (ZIF) 30P < RESISTOR > R849 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R850 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R851 1-216-837-11 METAL CHIP 22K 5% 1/10W R852 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R853 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R854 1-216-837-11 METAL CHIP 22K 5% 1/10W < SWITCH > S801 1-786-650-21 SWITCH, TACTILE (u, ENTER) S802 1-786-650-21 SWITCH, TACTILE (>, FOLDER +) S803 1-786-650-21 SWITCH, TACTILE (., FOLDER –) S804 1-786-650-21 SWITCH, TACTILE (VOL +) S805 1-786-650-21 SWITCH, TACTILE (VOL –) S806 1-786-650-21 SWITCH, TACTILE (GROUP) S807 1-786-650-21 SWITCH, TACTILE (STOP, x) S808 1-786-650-21 SWITCH, TACTILE (SOUND, AVLS) S809 1-786-650-21 SWITCH, TACTILE (P MODE, F) ************************************************************ MISCELLANEOUS ************** 053 A-1112-193-A CDM-3525A (CD MECHANISM) ************************************************************ www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 22 D-NE240/NE241/NE241CK ACCESSORIES ************ 1-251-824-41 CONNECTING PACK, CAR (CPA-7) (NE241CK) 0 1-479-496-21 ADAPTOR, AC (AC-ES457K) (NE241: MX, E92/NE241CK) 0 1-479-497-21 ADAPTOR, AC (AC-ES457K) (NE241: AEP) 1-542-673-12 HEADPHONE (MDR-J0Z1LP/BC19) (NE241: MX, E92/NE241CK) 1-542-697-31 HEADPHONE (MDR-E706) (NE240/NE241: AEP) 1-792-970-41 CORD, CAR BATTERY (DCC-E2455) (NE241CK) 2-892-695-21 MANUAL, INSTRUCTION (ENGLISH, FRENCH, GERMAN, ITALIAN) (NE240/NE241: AEP) 2-892-695-31 MANUAL, INSTRUCTION (SPANISH, DUTCH, PORTUGUESE, SWEDISH, FINNISH) (NE240/NE241: AEP) 2-892-695-42 MANUAL, INSTRUCTION (HUNGARIAN, POLISH, CZECH, SLOVAKIAN, RUSSIAN) (NE240/NE241: AEP) 2-892-695-51 MANUAL, INSTRUCTION (ARABIC) (NE241: AEP) 2-892-695-61 MANUAL, INSTRUCTION (ENGLISH) (NE241: E92) 2-892-695-81 MANUAL, INSTRUCTION (SPANISH) (NE241: MX, E92) 2-892-695-91 MANUAL, INSTRUCTION (PORTUGUESE) (NE241: E92) 2-892-696-21 MANUAL, INSTRUCTION (SPANISH) (NE241CK) 3-234-573-01 TAPE, MAGIC (NE241CK) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 D-NE240/NE241/NE241CK MEMO www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 D-NE240/NE241/NE241CK REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2006.10 New www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com