SERVICE MANUAL Model Name Using Similar Mechanism New CD Mechanism Type CDM-3325ER Optical Pick-up Type DAX-25E US Model AEP Model UK Model Australian Model Chinese Model D-FJ200 E Model D-FJ200/FJ201 System Compact disc digital audio system Laser diode properties Material: GaAlAs Wavelength: λ = 780 nm Emission duration: Continuous Laser output: Less than 44.6 µW (This output is the value measured at a distance of 200 mm from the objective lens surface on the optical pick-up block with 7 mm aperture.) Frequency range (AEP, UK, CH, E13 models) FM: 87.5 - 108.0 MHz AM: 531 - 1 602 kHz Frequency range (10k/9k) • D-FJ200:US/FJ201 9 kHz step: TV: 2 - 13 ch (US) WB (Weather band): 1 - 7 ch (US) FM: 87.5 - 108.0 MHz AM: 531 - 1 710 kHz 10 kHz step: TV: 2 - 13 ch (US) WB (Weather band): 1 - 7 ch (US) FM: 87.5 - 108.0 MHz AM: 530 - 1 710 kHz D-FJ200/FJ201 Ver 1.0 2004. 01 Sony Corporation Parsonal Audio Company Published by Sony Engineering Corporation 9-961-978-01 2004A02-1 © 2004.01 FM/AM PORTABLE CD PLAYER Photo : D-FJ200 • Australian model 9 kHz step: FM: 87.5 - 108.0 MHz AM: 531 - 1 602 kHz 10 kHz step: FM: 87.5 - 108.0 MHz AM: 530 - 1 710 kHz Power requirements • Two Sony NH-7WMAA rechargeable batteries: 1.2 V DC x 2 • Two LR6 (size AA) batteries: 1.5 V DC x 2 • AC power adaptor (DC IN 4.5 V jack): 220 V, 50 Hz (Chinese) 120 V, 60 Hz (D-FJ201) 220-230V, 50/60 Hz (AEP, UK, E13) 240 V, 50Hz (Australian) Dimensions (w/h/d) (without projecting parts and controls) Approx. 135.8 x 24.3 x 135.8 mm (5 3⁄8 x 31⁄32 x 5 3⁄8 in.) Mass (excluding accessories) Approx. 191 g (6.8 oz.) Operating temperature 5°C - 35°C (41°F - 95°F) Design and specifications are subject to change without notice. SPECIFICATIONS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 Specifications ............................................................................ 1 1. SERVICING NOTES ........................................... 3 2. GENERAL Locating the Controls ...................................................... 3 3. DISASSEMBLY 3-1. Upper Lid ASSY, Cabinet (Upper) Sub ASSY, Cabinet (Lower) ASSY ................................................... 4 3-2. MD ASSY (CDM-3325ER), Main Board ....................... 5 3-3. Motor ASSY (Sled) (M902), Optical Pick-up (DAX-25E), Turn Table Motor ASSY(Spindle) (M901) ..................... 6 4. ELECTRICAL ADJUSTMENS .......................... 7 5. DIAGRAMS 5-1. Block Diagram –CD Section– ......................................... 8 5-2. Block Diagram –Tuner Section– ..................................... 9 5-3. Printed Wiring Boards –MAIN Section (Side A)– .......... 10 Printed Wiring Boards –MAIN Section (Side B)– .......... 11 5-4. Schematic Diagram –MAIN SECTION (1/5)– .............. 12 5-5. Schematic Diagram –MAIN SECTION (2/5)– .............. 13 5-6. Schematic Diagram –MAIN SECTION (3/5)– .............. 14 5-7. Schematic Diagram –MAIN SECTION (4/5)– .............. 15 5-8. Schematic Diagram –MAIN SECTION (5/5)– .............. 16 5-9. IC Pin Function Description ............................................ 20 6. EXPLODED VIEWS 6-1. Upper Lid Section ........................................................... 24 6-2. Cabinet Section................................................................ 25 6-3. Optical pick-up Section (CDM-3325ER) ........................ 26 7. ELECTRICAL PARTS LIST ............................... 27 Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270°C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. TABLE OF CONTENTS CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. DANGER Invisible laser radiation when open and interlock failed or defeated. Avoid direct exposure to beam. D-FJ200/FJ201 UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the lead- free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.) : LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. Supplied Accessories AC power adaptor (1)*1 Headphones/earphones (1) Headphones/earphones with remote control (1)*2 Rechargeable batteries (2)*3 Battery carrying case (1)*3 *1Not supplied with US model *2Supplied with Australian, E13, Chinese models *3Supplied with E13, Chinese models For the area code of the model you purchased, check the upper left side of the bar code on the package. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 D-FJ200/FJ201 The laser diode in the optical pick-up block may suffer electrostatic break- down because of the potential difference generated by the charged elec- trostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, observe from more than 30cm away from the objective lens. Before Replacing the Optical pick-up Block Please be sure to check thoroughly the parameters as per the “Optical pick-up Block Checking Procedure” (Part No. : 9-960-027-11) issued separately before replacing the optical Pick-up block. Note and specifications required to check are given below. • FOK output : IC601 yg pin When checking FOK, remove the lead wire to disc motor. • RF signal P-to-P value : 0.4 to 0.8Vp-p SECTION 1 SERVICING NOTES Laser Diode Checking Methods During normal operation of the equipment, emission of the laser diode is prohibited unless the upper panel is closed while turning ON the S809(push switch type). The following two checking methods for the laser diode are operable. Method : Emission of the laser diode is visually checked. 1. Open the upper lid. 2. Push the S809 as shown in Fig. 1 . 3. Check the object lens for confirming normal emission of the laser diode. If not emitting, there is a trouble in the automatic power control circuit or the optical pick-up. During normal operation, the laser diode is turned ON about 2.5 seconds for focus searching. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT Fig.1 Method to push S809 SECTION 2 GENERAL LOCATING THE CONTROLS S809 CD player (front) *The button has a tactile dot. A Display 5 u* 2 3 4 RADIO ON/BAND• MEMORY OPEN 1 ./>•TUNE –/+ • PRESET –/+ i (headphones) jack 9 SOUND 8 P MODE/ 7 DISPLAY/MENU q; qa x/CHG ADIO OFF 6 HOLD (rear) Strap hole DC IN 4.5 V (external power input) jack qs VOL +*/– CD player (inside) Insert the # end first (for both batteries). B Open the battery compartment lid. This section is extracted from instruction manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 D-FJ200/FJ201 SECTION 3 DISASSEMBLY Note : Follow the disassembly procedure in the numerical order given. 3-1. UPPER LID ASSY, CABINET (UPPER) ASSY, CABINET (LOWER) ASSY z The equipment can be removed using the following procedure. Upper lid ASSY, Cabinet (upper) ASSY Cabinet (lower) ASSY MD ASSY Motor ASSY (Sled) (M902), Optical pick-up (DAX-25E), Turn table motor ASSY (spindle) (M901) Main board Set 3 five screws 5 claw 5 claw 5 two claws upper lid assy cabinet (upper) assy cabinet (lower) assy 7 CN802 5 claw 4 two screws 1 6 2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 D-FJ200/FJ201 3-2. MD ASSY (CDM-3325ER), MAIN BOARD 1 CN601 2 CN402 3 CN402 7 MAIN board 4 6 5 MD assy (CDM-3325ER) HOW TO SET THE HARNESS IN ASSEMBLING CN401 CN402 harness www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 D-FJ200/FJ201 3-3. MOTOR ASSY (SLED) (M902), OPTICAL PICK-UP (DAX-25E), TURN TABLE MOTOR ASSY (SPINDLE) (M901) 6 2 4 9 5 motor assy (sled) (M902) 1 three screws (B1.7x4) chassis 8 three screws (B1.7x4) q;turn table motor assy (spindle) (M901) 7 optical pick-up (DAX-25E) 3 gear cover www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 7 D-FJ200/FJ201 Procedure: 1. Connect the oscilloscope to the test point TP601(RF) on the MAIN board. 2. Set a disc. (YEDS-18) 3. Press the u button. 4. Check the oscilloscope waveform is as shown below. A good eye pattern means that the diamond shape (◊) in the cen- ter of the waveform can be clearly distinguished. RF Signal reference Waveform (Eye Pattern) To watch the eye pattern, set the oscilloscope to AC range and increase the vertical sensitivity of the oscilloscope for easy watch-ing. 5. Stop revolving of the disc motor by pressing the x button. SECTION 4 ELECTRICAL ADJUSTMENTS TUNER SECTION AM section BAND : AM FM section BAND :FM AM FREQUENCY COVERAGE ADJUSTMENT Adjust parts Frequency Reading on digtal voltmeter Confirmation 530kHz <531kHz> Standard value : 0.8–1.8V Confirmation 1,710kHz <1,602kHz> Standard value : 8.5–10.0V <6.9–8.4V> AM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L5 620kHz <621kHz> CT1 1,400kHz <1,404kHz> TV/WB/FM FREQUENCY COVERAGE ADJUSTMENT Frequency Reading on digtal voltmeter Confirmation 87.5MHz Standard value : 4.3–5.7V L2 108MHz Adjustment value : 9.5V Standard value : 9.0–10.0V Confirmation TV : 2ch Standard value : 0.1–0.55V (US model) FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L4 87.5MHz Confirmation 108MHz US model TV/WB TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L3 197.75MHz [TV : 10ch] 0 dB = 1µV • Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. AM RF signal generator 30% amplitude modulation by 400Hz signal. Output level : as low as possible Put the lead-wire antenna close to the set. set 16 Ω phones jack (J301) level meter ECB ECB C16 C8 C33 C22 C17 R13 C10 C23 R1 C5 C44 BP1 TP1(VT) TP3(FM RF IN) TP6(TU GND) C12 Q4 R2 1 D3 CF2 R4 D2 D4 C9 C21 C34 Q8 C27 R16 C43 FL1 1 2 3 FL1 FL2 C37 L4 L3 L2 FJ200:US FJ200:US FJ201 FM RF signal generator 33.75kHz frequency deviation by 1kHz signal. Output level : as low as possible TP3 (FM RF IN) 0.01µF [MAIN BOARD] (Side A) < > : 9kHz step Adjustment Location : Adjustment Location : Main board Frequency Coverage Adjustment Setting : ECB ECB C16 C8 C33 C22 C17 R13 C10 C23 R1 C5 C44 BP1 TP1(VT) TP3(FM RF IN) TP6(TU GND) C12 Q4 R2 1 D3 CF2 R4 D2 D4 C9 C21 C34 Q8 C27 R16 C43 FL1 1 2 3 FL1 FL2 C37 L4 L3 L2 FJ200:US FJ200:US FJ201 [MAIN BOARD] (Side A) TP1 (VT) TP6 (TU GND) digital voltmeter (DC range) [MAIN BOARD] (SIDE B) L4 : FM Traking Adjustment L3 : TV/WB Traking Adjustment L2 : TV/WB/FM Frequency Coverage Adjustment L5 : AM Tracking Adjustment CT1 : AM Tracking Adjustment The CD section adjustments are done automatically in this set. Precautions for Check 1. Perform check in the order given. 2. Use YEDS-18 disc (Part No.: 3-702-101-01) unless otherwise indicated. 3. Power supply voltage requirement :DC4.5 V in DC IN jack. (J401) VOLUME button : Minimum HOLD switch : OFF CD SECTION RF Level Check Condition: • Hold the set in horizontal state. Connection: RF level 0.4 to 0.8 Vp-p VOLT/DIV : 100 mV (With the 10 : 1 probe in use) TIME/DIV : 500ns C 4C606 C630 5 C613 C612 C615 CL410 (A GND) TP601(RF) C309 22 23 12 11 C30 R300 C304 R605 Q601 R608 L601 R614 C310 C312 C321 C308 TP601(RF) CL410(A GND) oscilloscope (AC range) [MAIN BOARD] (Side A) 0 dB = 0.765V w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8 8 D-FJ200/FJ201 5-1. BLOCK DIAGRAM –CD SECTION– SECTION 5 DIAGRAMS 13 16 17 32 36 31 7 44 17 4 5 6 29 34 5 9 8 6 7 4 75 74 77 76 79 78 72 73 71 50 49 47 53 37 38 12 22 6 71 80 7 11 77 2 79 78 65 70 52 43 45 14 16 17 18 66 39 40 38 37 8 35 36 34 72 70 57 58 55 56 59 60 44 CH3 H BRIDGE 42 48 46 LEVEL SHIFTER LEVEL SHIFTER I/F CH2 H BRIDGE 52 50 CH1 H BRIDGE 6 2 53 49 45 41 1 CH4 H BRIDGE EFM DEMODULATOR SERVO RF AMP A/D OP IC PWM FDOP PD LD-SW FDON TDOP TDON SDOP SDON CLVON CLVOP CLKDRV FIN+ FIN- TIN+ TIN- SIN+ SIN- SLVOP CPOL SYNC FIN+ FIN- TIN+ TIN- SIN- SIN+ CPOL CLVOP SYNC X_O X_I CLK4M SCLK_I SDTO_I SDTI_O P-OFF_I SCOR XBUSY_O GFS_O FOK_O CLOCK OSC DAC SIO DEFFERENTIAL Q407 WAKE-UP DETECT Q801,802 27 67 19 17 18 20 22 16 23 68 12 69 64 8 25 SWITCH Q402, 403 26 5 23 4 2,3,24,25 9-12,15-19,21,8 87,88,84,85 97-100,96-91,82 SUB CODE PROCESSOR 25 23 28 40 +VBAT L403 31 KEY MATRIX X_I POWER-OFF_O 15 48 SRW_I SRW_O SCOR_I XBUSY_I DEFECT_I 68 67 4 TEST PGM_SDTO_O PGM_SDTI_I 73 69 PGM_SCK_O PGM_SC_SEL TEST TEST CONNECTOR PGM_SDTO CLK4M_2 RESET2 PGM_SDTI PGM_SCK PGM_SC_SEL HPSW_O WP/AD_RMKEY GFS_I FOK_I XPOWER_LT_O 72 FG_I 33 WP/KEY2_RM_I SDTI_I SDTO_O SCK_O XWAKEUP_O XREST_I 76 XRST_O VCPU_2.0V WP/AD_KEY1 AD_KEY_2 WP/XOPEN_I HOLD_I AVCPU AD_DCINMNT 24 AD_BATTMNT 34 TUNER_ON_I +V BAT BATT_MNT TU_ON RM_KEY PGM_SC_SEL OPEN_DTS HOLD AD_KYE2 AD_KYE1 SDTO SCK AD_CHGMNT VCC1_2.2V VCC2_2.0V VCPU_2.0V OP_G-SW_O XOPSTBY_O D802 ADVREF 20 VCPU_2.0V IC801(1/2) SYSTEM CONTROL MICON L404 Q405 Q404 Q408 D408 Q406 D405 D402 L401 L402 VCC2_2.0V VCC1_2.2V VCPU_1.5V VCC2 VMMNT VCC SEO SEM VCPU_1.5V VCC0 STNG LG VIN BATM1 BATM2 DCIN_S +VBAT VCC1 VCPU 2.0V CHGMNT 61 DCIN 62 REGB X601 16.934MHz DVDDIO VCHK AVDD2 (2.25V) DVDDV (1.5V) RDACO LDACO POWER-L_O IN SEL VCC1 VCC2 POWER-R_O CENTER-AMP 25 BASS-H/L-SW TU_BASS2 +VBAT VCC2_2.0V XTU_BASS1 PWM BEEP AMUTE 26 BASS-SW 14 VOL-CTL_I 3 BEEP_I 1 MUTE-SW_I CD_L-I CD_I_R STB_HPSW_I IC301 PRE EQ AMP/EVR/ HADPHONE AMP IC403 (2/2) POWER CONTROL VCPU_2.0V FJ200:AUS,CH,US/FJ201 RFI A VCC1_2.2V B E FO3 RO3 FO2 RO2 FO1 RO1 W_O V_O U_O V COM COM VM1 VM12 VM23 VM3 SP_VCC1 F V-MON FIN3 RIN3 FIN1 RIN1 FIN2 RIN2 BBK PWM POWER_LT_I XSDTO XCSK XWAKEUP_I H_RESET XRST_I SYNC 74 FG_O IC403 (1/2) FOCUS/TRACKING COIL DRIVE SLED/SPINDLE MOTOR DRIVE IC602 D-RAM(16M) XRAS XCAS XWE XRAS A0-A10 D0-D3 DETI RFGO XCAS XWE D0-3 A0-10 90 83 89 IC601 RF AMP,SERVO DIGITAL SIGNAL PROCESSOR D-RAM CONTROLLER D/A CONVERTER J401 DC IN 4.5V ! DRY BATTERY SIZE "AA" (IEC DESIGNATION LR6) 2PCS, 3V J301 i M M902 SLED MOTOR FOCUS COIL M901 SPINDLE MOTOR M TRACKING COIL F+ F- T+ T- S+ S- W U OPTICAL PICK-UP BLOCK (DAX-25E) VCC RF A B E F LD PD OP_G-SW OP_STB LD DRIVER Q601 VCC1_2.2V S809 (OPEN) S810 HOLD OFF ON 4 80 40 51 36 80 86 APC 2 3 (Page 9) (Page 9) TO TUNER SECTION A (Page 9) TO TUNER SECTION B (Page 9) TO TUNER SECTION D TO TUNER SECTION C ANT TU_L TU_R 66 33 35 NC FJ200:US,CH,AUS/FJ201 VCC2_ 2.0V S901, S902, S906 S903- S905, S907, S908 38 VOL- 19 S802 VOL+ 35 VOL+ S803 VOL- VOL- VOL+ TUDC_MNT Q301 5 SPVCC2 • Signal path. F : FM E : CD PLAY w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9 9 D-FJ200/FJ201 5-2. BLOCK DIAGRAM –TUNER SECTION– TV/WB TRACKING L3 FM TRACKING FM/WB/TV FREQUENCY COVERAGE L4 AM TRACKING L5, CT1 L2 1 FM/TV MIX TV-RF FM-MIX_O CF2 FM-IF_I DET_O MPX_I LPF1 MODE1 MODE2 LPF2B LPF2A R_O L_O TU_L TU_R Q7 FM-IF IF BUFF TU-VCC TV-RF_O Q4 L3 (TV RF) L4 (FM RF) L2 (FM/TV OSC) L1 AM FERRITE-ROD ANTENNA L5 (AM OSC) D2 D3 D4 CT1 TU-VCC (VT) D6 T1 +VBAT FM-RF ANT FM-RF_O FM/TV-OSC AM-MIX_O BUFF BUFF AM_BP AM-RF_I AM-OSC CS X_O EO(D01)_O AM-STEP_I NC LCD-REQ_O X9K/10K CD_ON_O RESET-TU_O SDTI_I_TU ACK_CD_I LCD-REQ_I CD-ON_I RESET_I SDU-SDO_O ACK-CD_O RM-KEY_I TV/FM/AM_I IF_I IF-REQ_O BAND-CTL2_O BAND-CTL1_O AM-ON_O X3 75KHz X_I EEP-CS_O FJ200:AUS,CH,US/FJ201 EEP-SK_O EEP DO/DI_IO COM1-4 S1-17 SK D1 D0 IC1 TV/FM/AM FRONTEND, FM MPX IC4 EEPROM IC3 TUNER CONTROL IC801(2/2) SYSTEM CONTROL MICON IC5,6 LEVEL COMPARATOR IC2 +1.6V REG. 2 30 29 24 TV OSC FM OSC AM MIX 1/2 28 27 LPF Q12,13 LCD801 LIQUID CRYSTAL DISPLAY B+ SWITCH Q10,11 DC-DC CONVERTOR Q14 3 2 1 7 4 5 6 3 1 25 1 32 75 74 65 21 35 42 71 64 61 52 59 55 31 30 2 3 4 AM OSC 1/8 or 1/16 8 12 13 TU-VCC CF3 AM-IF_I AM-IF 5 10 23 26 41 AM DEF FM DET FM MPX FM/TV/AM PW SW 4 16 15 17 18 14 SW RF-VCC TU-VCC AD-DC_REF OSC_O IF-COUNT_O REQ-SW 20 19 21 22 (Page 8) TO CD SECTION D IC5 IC6 WAVE SHAPER Q15 RM_KEY B+ SWITCH Q5,9 VOUT VIN VCPU_2.0V +VBATT 1 3 (Page 8) TO CD SECTION C 39 36 70 75 10 9 TUNER_POWER_O AMUTE_O TU_MUTE_O TU-HOLD_I XLID-OPEN_I CDU-SCK_I CDU-SDI_I BATT_I VOL- AD-KEY2_I AD-KEY1_I TU-ON_O SC-SEL_I TU-BASS_O XTU-BASS_O VOL_PWM_O HOLD OPEN_DTS SCK SDTO BATT_MNT AD-KEY1 AD-KEY2 TU_ON PGM_SC_SEL TU-BASS2 XTU-BASS1 PWM BEEP AMUTE TU_BEEP_O BEEP_O D302 D301 29 74 62 49 50 58 56 43 46 48 29 51 38 28 39 73 47 54 36 37 38 27 36 (Page 8) TO CD SECTION B (Page 8) TO CD SECTION A BUFF 1-4 5-20,25 Q8 BPF BPF FL1 FL2 EXCEPT US D-FJ200: US/FJ201 US FJ200:US D1 33 44 VOL+ HIDC_I TUDC_MNT VOL- VOL+ 45 MONO/LOCAL-CTL_O • Signal path. F : FM E : CD PLAY f : AM w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10 10 D-FJ200/FJ201 5-3. PRINTED WIRING BOARDS – MAIN SECTION (SIDE A) – : Uses unleaded solder. BCE ECB ECB ECB ECB ECB BCE BCE BCE X3 VDR404 IC3 R94 R88 R91 R85 R82 R81 C75 L11 C629 C626 R606 C20 C14 C13 R8 C11 C632 C618 R7 C619 C624 R627 R619 R618 R620 L605 R31 R631 C604C606 C630 L5 C613 C612 C615 CL410 (A GND) TP601(RF) C309 22 34 44 33 1 23 12 11 IC301 C301 FB201 FB301 FB101 L302 C325 C302 R302 VDR101 VDR201 D306 VDR306 C323 FB303 FB302 R872 C105 FB406 C437 D410 C434 R438 C448 C447 R459 IC403 C428 R419 C403 C418 D400 C419 C406 C426 D402 C436 C432 R300 C304 R605 Q601 R604 R603 R611 R608 C609 R613 C614 C607 C608 C622 C7 C2 R612 C605 R32 R40 C625 C621 C87 C88 R53 C82 R58 R80 R79 R99 C92 C93 R84 R87 R90 R93 R96 R97 R47 R822 R827 C809 R833 R836 R804 R845 C806 R310 C36 C16 C8 C33 C22 C17 C68 R13 C10 C23 R1 C5 R11 Q10 Q11 C49 C44 R201 R814 R816 R54 C89 R55 R56 C300 R447 C631 L601 R614 C310 C315 C316 TP202 TP2102 C318 C319 R305 C808 R871 R874 C440 C450 C424 C420 C421 C422 C423 R420 Q403 R449 D405 C405 R448 C411 Q407 C433 C425 C317 C312 C321 C308 C600 R610 R601 C610 R600 R301 C313 R101 R17 R812 SL6 BP8 D802 R37 C67 L9 CF3 BP1 TP1(VT) TP3(FM RF IN) TP6(TU GND) C12 Q4 C55 2 1 3 R2 R22 R20 EXCEPT US,FJ201 R801 R427 R434 C427 D409 C445 C441 CN801 R803 R832 C78 R48 C73 R49 C71 R33 Q15 C85 40 21 61 41 60 20 50 51 75 1 25 26 76 100 1 80 IC801 40 21 61 41 60 20 1 80 TP72 TP74 TP75 TP76 TP77 TP78 TP79 TP80 TP81 TP83 TP82 TP73 TP71 TP84 TP85 TP86 TP87 CN802 26 TP89 TP88 1 TP90 R83 R86 C96 C95 R95 R98 R92 R89 C94 IC601 C435 C45 FB409 D3 IC2 R52 CF2 Q6 C53 C50 R4 D2 D4 C9 C21 C34 Q8 C27 R16 C43 FL1 1 2 3 4 5 1 2 3 FL1 FL2 FL2 C37 C438 R446 C633 X601 R616 R615 C627 40 41 60 61 80 1 20 21 J301(1/2) i (SIDE A) BOARD MAIN 11 (11) 1-860-874- DRY BATTERY SIZE "AA" (IEC DESIGNATION LR6) 2PCS, 3V DC IN 4.5V J401 S810 LCD801/ SWITCH UNIT L4 L3 L2 L1 AM FERRITE-BAR ANTENNA HOLD ON OFF t . S803 S802 VOL– VOL+ EXCEPT E FJ200:AUS,CH, E,US FJ200:AEP, CH,UK FJ200:AUS,E FJ200:AEP,AUS, CH,E,UK FJ200:AEP, CH,UK,E ,AUS FJ200:AUS,CH,US,FJ201 FJ200:US FJ200:US FJ200:US/ FJ201 FJ200:US EXCEPT FJ200:US FJ200:AEP,AUS, E,UK,US,FJ201 FJ200:AEP,AUS, E,UK,US,FJ201 FJ200:AUS,CH, E,US,FJ201 FJ200:CH,US,FJ201 FJ200:AUS,CH, US,FJ201 FJ200:US 2 3 4 5 6 7 8 9 A 1 B C D E F G Ref. No. Location D2 E-2 D3 F-2 D4 E-3 D306 C-8 D400 E-7 D402 F-7 D405 F-7 D409 E-6 D410 D-8 D802 E-6 IC2 E-4 IC3 C-3 IC301 C-7 IC403 E-7 IC601 B-4 IC801 D-5 Q4 F-3 Q6 E-4 Q8 E-3 Q10 E-4 Q11 E-4 Q15 C-4 Q403 F-7 Q407 F-6 Q601 C-5 • Semiconductor Location w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 11 D-FJ200/FJ201 PRINTED WIRING BOARDS – MAIN SECTION (SIDE B) – : Uses unleaded solder. ECB ECB ECB ECB ECB BCE BCE BCE ECB BCE DGS SDG ECB ECB OPTICAL PICK-UP BLOCK DAX-25E FJ200:AUS, CH,US,FJ201 FJ200:AUS, CH,US,FJ201 R39 (FJ200:AEP,E,UK) C314 C324 C205 R204 C203 R311 C303 C307 C306 FB601 FB401 C330 C305 R205 L301 R202 C201 C101 R431 R441 R440 R436 R841 C805 C801 C802 C31 D7 D6 R10 C41 FB1 FB4 C47 C76 R59 C1 R61 R60 R14 R73 C107 R65 C38 R74 R70 C24 C54 R23 R24 R26 C19 R6 C6 C18 CT1 C28 R41 C58 C59 C623 R27 R30 C109 IC5 C81 C91 R43 FB6 C30 R45 C42 C77 R46 R38 R63 FB2 C116 R34 Q9 R36 L10 R35 Q14 C61 T1 R421 R444 R425 R415 R411 C415 Q401 R412 R453 R454 R413 R408 L403 L404 R862 R864 R861 R863 L402 L411 R451 C210 D301 D302 FB304 FB403 R452 SL5 C417 Q408 R430 Q404 Q405 FB405 R858 R859 R806 C800 C807 R439 L407 CN402 CN401 Q406 L409 D804 D805 R808 Q802 Q801 R813 R807 R846 R843 R830 R837 R802 Q5 R19 C65 R12 C66 C64 C69 R9 R50 R51 C32 R5 C29 FB3 C35 15 1 16 30 C40 Q7 C98 FB5 C80 CF4 C39 C99 L606 C84 IC6 C86 FJ200:US C83 R44 R76 R77 R75 C97 R64 R72 R69 R71 R67 R68 R66 C108 C63 R25 C60 C62 IC602 R3 D1 C4 R28 R29 Q13 Q12 IC1 IC4 L406 R403 R407 D403 C410 L401 Q402 FB402 R416 C400 R433 D408 R428 FB408 C103 R320 R103 C102 C202 R102 R203 R106 C104 R609 R602 R617 R42 R854 R849 R825 R817 CN601 13 1 14 28 C634 C204 R206 R105 R104 R314 C311 C110 (SIDE B) BOARD MAIN 11 (11) 1-860-874- 1 4 1 2 M901 SPINDLE MOTOR M902 SLED MOTOR M M S809 (OPEN) J301(2/2) R61 (FJ200:AEP,CH,UK,US,FJ201) R60 (FJ200:AUS,E,US,FJ201) R59 (FJ200:AEP,UK,FJ201) FJ200:AUS,CH,US, FJ201 FJ200:AEP,E,UK FJ200:AUS,CH,US,FJ201 FJ200:CH FJ200:AUS,CH,US, FJ201 FJ200:AUS,CH,US, FJ201 FJ200:US 2 3 4 5 6 7 8 A 1 B C D E F G Ref. No. Location D1 A-5 D6 E-6 D7 E-6 D301 C-3 D302 C-3 D403 G-3 D408 C-3 D804 E-5 D805 E-5 IC1 D-7 IC4 D-7 IC5 C-7 IC6 C-7 IC602 B-6 Q5 E-6 Q7 D-6 Q9 E-6 Q12 B-7 Q13 B-7 Q14 E-5 Q401 F-3 Q402 F-3 Q404 D-2 Q405 D-2 Q406 D-2 Q408 D-2 Q801 E-5 Q802 E-5 • Semiconductor Location w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 12 D-FJ200/FJ201 5-4. SCHEMATIC DIAGRAM – MAIN SECTION (1/5) – D1 D2 D3 D4 D6 D7 FL2 C64 C65 C66 C67 C68 C69 R35 R36 L10 10µH T1 R19 R9 L9 10µH R1 R2 R4 R5 C5 C10 C23 C12 L2 C21 C4 R6 R7 R8 C18 C19 C6 C28 C20 C13 C14 C2 C7 C11 CT1 FB1 FB3 FB5 FB6 C27 R10 R11 R12 R50 R51 C31 C32 C30 C47 C43 C37 C34 R13 R16 C35 C36 CF2 CF3 CF4 C39 C40 C41 C42 R101 R201 C53 R17 C45 R22 R20 C55 R14 C98 C58 C59 C54 C60 C62 R23 R24 R26 R27 R28 R29 R30 C1 C76 C9 L4 C17 L3 C16 C8 R3 L5 BP1 C33 R25 R34 C44 R52 C29 Q12 Q13 Q10 Q5 Q9 Q14 Q11 Q4 Q8 L606 C63 R37 C116 Q7 Q6 C49 C50 C22 FB2 C61 KV1610S MA2S357(E)-(TX) MA2S357(E)-(TX) MA2S357(E)-(TX) 1SS355TE-17 MA8130-TX 6p 0.01 2.2 22 6.3V 0.01 0.01 100k 220 4.7k 47 470k 470k 470k 4.7k 100p 100p 0.01 7p 0.01 1000p 470k 470k 10k 0.022 0.022 2200p 3p 0.1 10p 10p 100p 220p 47p 0 0 0 0 100p 0 2.2k 1k 47k 10k 0.01 0.1 1000p 0.1 0.01 0.01 0.01 4.7k 4.7k 0.022 4.7 470p 0.01 0.01 0.047 4.7k 4.7k 0.47 1k 220 4V 47k 4.7k 1 0 0.01 0.22 1000p 0.01 0.01 100p 22k 0 10k 4.7k 470 4.7k 0 47 4V 1000p 0.01 2p 5p 0.01 10k 1000p 100k 1k 4.7 0 0.01 2SK880GR-TE85L LPF 2SC4154TP-1F LPF DTC114TUA-T106 B+ SWITCH 2SA1602TP-1EF B+ SWITCH DTC114TUA-T106 B+ SWITCH 2SC4154TP-1F DC-DC CINVERTOR 2SA1602TP-1EF B+ SWITCH 2SC4154TP-1F SWITCH 2SC4154TP-1F SWITCH 0 1000p 0 1000p DTC114TUA-T106 SWITCH UN5210 MONO SWITCH 0.047 0.022 0.01 0 7p TV/FM/AM EO V OUT MODE2 MODE1 REQ IF COUNT AM ON D GND VCPU 2.0V TU R TU L TU POWER ON FM ANT MONO/LOCAL IC2 XC62RP1602MR IC1 TA2154FN(EL) TV RF I RF GND FM RF I AGC VCC FM IF I QUAD DET O MPX I LPF1 R O AM IF I GND L O LPF2A LPF2B IF COUNT O REQ SW OSC O RF VCC AM RF I AM BP FM RF O TV RF O FM/TV OSC VIN VOUT GND FL1 AM ANTENNA FERRITE-BAR L1 AM OSC MODE2 MODE1 AM MIX O FM MIX O 1.6V REG TRACKING L3 FM TRACKING L4 FREQUENCY COVERAGE L2 TRACKING AM TV/FM/AM FRONTEND, FM MPX FJ200:US FJ200:US FJ200:US/FJ201 FJ200:US FJ200:US FJ200 FJ200:US EXCEPT FJ200:US US/FJ201 EXCEPT L5,CT1 FJ200:US TV/WB FM/TV/WB w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 13 D-FJ200/FJ201 5-5. SCHEMATIC DIAGRAM – MAIN SECTION (2/5) – C808 R631 L605 C626 C629 R618 R619 R620 R615 X601 C618 L601 R608 R610 C610 R602 R603 R604 R605 C604 C606 C605 C612 C614 C607 C608 C609 R613 CN601 R614 R871 R616 C634 C613 Q601 R446 R447 R872 S810 S809 C631 R611 FB601 R874 R102 R103 C101 C102 C202 R203 C201 R202 R104 R105 R106 C103 C104 C203 R204 R205 R206 C204 R300 C304 C305 C306 C307 C324 C105 C205 R311 R320 L301 10µH C308 C309 C310 C312 C321 C315 C314 R314 C301 FB201 FB101 FB301 FB304 C325 C302 R302 VDR101 VDR201 FB302 C319 J301 C316 C317 C318 D306 C330 D301 R612 C630 C633 C627 R627 C624 C619 C625 C615 C600 R609 C303 C323 C622 C621 R606 C623 C632 L302 0µH FB303 R305 VDR306 D302 C311 R600 C110 C210 R617 R601 4700p 1k 0 0.1 22p 1k 1k 1k 0 16.934MHz 2.2 2.2 100k 4.7 100k 100k 100k 100k 0.1 10 6.3V 1000p 1000p 2200p 0.1 0.22 1 470 15P 47 220k 1M 1000p 0.01 2SB167900LSO LD DRIVER 0 0 10k (OPEN) 0.1 2.2k 0 10k 10k 1 470p 470p 1 10k 4.7k 2.2k 4.7k 470p 1 470p 4.7k 2.2k 4.7k 1 2.2k 0.047 1 22 6.3V 10 6.3V 0.01 2.2 2.2 100k 0 1 0.047 2.2 22 6.3V 22 6.3V 0.1 1000p 4.7 100p 0.01 10p 47 0 4700p 220 6.3V 0.01 0.22 MA147 0 1SS355TE-17 0 100 4V 0.1 0.01 10k 10p 10p 0.1 1 47 6.3V 100k 22 6.3V 0.01 22 6.3V 0.1 10 0.1 0.1 1K 10k 1SS355TE-17 22 6.3V 2.2 1M 0 BUS 3 A GND VCC2 VCC1 BUS 1 VCC4 AU GND BUS 2 SYNC S GND D GND TU L TU R XTU BASS1 TU BASS2 HP SW PWM VIN TU/CD FM ANT VCPU BEEP TU MUTE A MUTE VMMNT HOLD OPEN DTS RM KEY CDUTY SCK SRW SDTO SDTI SCOR POFF XRST CPOL FIN- FIN+ TIN+ TIN- SIN- SIN+ D0 D1 D2 D3 A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 XRAS XCAS XWE A10 OPGSW OPSTB F+ T- T+ F- CLK4M J XBUSY FOK GFS A0 A1 A2 A3 D0 D1 D2 D3 A4 A5 A6 A7 A8 A9 XRAS XCAS XWE A10 * * * * IC601 BU9354CKV AVSS2 RLINO RLINI RDACO VCDACO LDACO LLINI LLINO AVDD2(2.25V) MUTE DVDDIO(2.0V) DVSSIO DVDD(1.5V) SCOR XRST DVSSIO A3 A2 A1 A0 A4 A5 A6 A7 A8 A9 XRAS XWE D1 D2 XCAS DVSSIO2 SDOP SDON TDOP TDON D0 D3 FDOP FDON CLVOP CLVON CLKDRV GFS EXPCLK C2FX A10/CAS2B EFM/YFLG FOK O DEFECT O LRCKI DOUTAI LRCKO DOUTAO DOCKO TEST TDO TDI TMS TCK CLK4M XBUSY O DVDD(1.5V) AVDD(2.0V) PD E F B A BIAS NC RFI PKC BTC RFGO DETI ASYI ASYO MON1 MON2 ADPFO ADPFI FCO PCO SVSSI DOCKI DVSS1 TEST S DVDDIO(2.0V) DVDDIO2(2.4V) HEADPHONE AMP DIGITAL SIGNAL PROCESSOR RF AMP,SERVO D-RAM CONTROLLER D/A CONVERTER HOLD ON OFF RIPPLE BIAS O BIAS I BASS T BASS SW BASS H/L SW BASS O BASS CTL STB HPSW I CD-L I TU-L I VCC2 BEEP I MUTE T MUTE SW I AVLS O AVLS I C AMP SW POWER GND POWER L O CENTER AMP POWER R O BASS NF MIX O AGC SW NC NC VCC1 VOL BIAS VOL CTL I RIPPLE F VOL BIAS AVLS SW IC301 PRE GND TU-R I CD-R I VREF IN SEL LINE-L O LINE-R O VOL-L O VOL-R O AN17883A-VF IC602 VSS A4 A5 A6 A7 A8 A9 XOI XCAS D2 D3 VSS VCC D0 D1 XWE XRAS A10 A0 A1 A2 A3 VCC D-RAM(16M) GLT4160N04-100TC FJ200:US FJ200:AUS,CH,US/FJ201 FJ200:AUS,CH,E,US/FJ201 FJ200 FJ200:AUS,CH,US/FJ201 FJ200:AEP,UK FJ200:AUS,CH,E,US/FJ201 2.2k 4.7k *R103,203 FJ200:AUS,CH,US/FJ201 EXCEPT E FJ200:CH,US/FJ201 *R103,203 0.001 0.0022 FJ200 FJ201 FJ200:US,AUS,CH/FJ201 FJ200:AUS,CH,US/FJ201 FJ201 FJ200:AUS,CH,US/FJ201 LD SW V MON V CHK X I X O P OFF I SCLK I SRW I SDTO I SDTI O w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 14 14 D-FJ200/FJ201 5-6. SCHEMATIC DIAGRAM – MAIN SECTION (3/5) – D802 R854 R858 R859 CN801 C805 R836 R830 C807 S802 S803 Q801 Q802 D804 D805 R841 R837 C801 R813 R808 R846 R843 R807 R833 R827 C802 R817 R816 R806 C800 C806 R801 R822 R803 R862 R849 R863 R864 C809 R802 R861 R804 R832 R845 R825 R812 R814 MA2ZD14001S0 0 0 0 10P 0.01 0 0 0.22 DTC143TUA-T106 2SC4154-F MA111-TX MA2ZD14001S0 10k 1k 0.01 100k 1M 470k 2.2M 2.2M 1k 0 0.01 0 22k 100k 0.1 0.1 220k 10k 100k 22k 0 1k 1k 0 22k 1k 100k 0 0 220k BUS 1 VCPU D GND TU/CD BEEP A MUTE AD KEY2 TU POWER ON AD KEY1 HOLD RM KEY TU ON LCD REQ OPEN DTS CHG MNT DC MNT BATT MNT VOL+ VOL- SDTI TU HP SW ACK CD CD ON PGM SC SEL RESET TU STEP SCK SRW SDTO SDTI POWERLT SCOR RESET XWAKEUP XBUSY FOK CLK4M J GFS FG PGM SEL PGM SEL PGM SCK PGM SCK PGM SDTI PGM SDTI PGM SDTO PGM SDTO RESET2 RESET2 CLK4M J CLK4M J XRST POFF OPSTB OPGSW * * COM COM COM SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG SEG COM 0 1 2 3 0 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 ADVREF AVCPU SCK SDTO SDTI SRW HPSW SCOR HP RESET XBUSY FOK TEST XOUT XIN GND O O I O O O I L I I I I VCPU 2V TEST NC TU ON I VOL+ VOL- LCD REQ O HOLD I VDD EEPROM BEEP O AD DCINMNT WP/AD RMKEY WP/AD KEY 1 AD BATTMNT AD KEY 2 AD CHGMNT V3 V2 V1 C1 C0 RESET TU 0 XRESET O XOPSTBY O CD/TU XWAKEUP O PGM SCK O GFS I FG I /SC SEL O IC801 AMUTE 0 SYSTEM CONTROL MICOM TEST CONNECTOR T5AW5-04TU FJ200:AUS,CH,US/FJ201 FJ200:AEP,E,UK *C809 0.01 10K FJ200:US,AUS,CH/FJ201 FJ200:AEP,E,UK *R804 FJ200:AUS,CH,US/FJ201 Q801,802 DETECT ACK CD 53/54 XPOW LT ADSEL I WP/XOPEN I TUPWR POWER O WP/K2 RM I PGM SDTO O PGM SDTI I CD ON O POWER OFF O OP G SW O 47k 220k FJ200:AUS,E FJ200:US,AEP,UK,CH/FJ201 9k/10k FJ200:AEP,CH,UK,E,AUS WAKE-UP • See page 22 for IC Pin Function Description. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 15 15 D-FJ200/FJ201 5-7. SCHEMATIC DIAGRAM – MAIN SECTION (4/5) – D402 D403 D405 D407 D409 FB405 FB406 FB408 FB402 R416 C418 C419 C420 C421 C422 C423 R419 L403 47µH R428 R421 R439 R444 L404 220µH C428 C434 C436 C437 L406 47µH 47µH L409 C438 C435 L411 47µH R440 C427 C445 R436 C448 C440 R438 R434 C441 CN401 L401 4.7µH 4.7µH L402 C405 C410 C432 C450 C447 CN402 Q406 Q403 Q407 C426 L407 100µH J401 Q404 Q405 Q408 D408 R430 R431 R433 C424 C425 C403 C406 R453 R454 R415 R411 R412 C415 R413 R451 R452 C417 C411 FB409 VDR404 R420 R449 FB403 FB401 R441 C400 D400 D410 Q401 R408 R407 R403 R425 C433 R427 R459 R448 Q402 RB160M-30TR MA2YD2300LS0 RB160M-30TR 1SS355TE-17 MA111-TX 0 0 0 0 220 0.1 0.022 0.022 4700p 4700p 4700p 10k 100k 10k 47k 100k 4.7 16V 47 4V 47 4V 47 4V 1 22 10V 47k 0.01 1 0 0.047 2200p 10k 100k 0.22 2P 1 1 220 4V 1 1000p 4P 2SA1602TP-1F SWITCH 2SC4154TP-1F SWITCH 2SC4081T106R DEFFERENTIAL 220 6.3V 2SB167900LSO SWITCH MCH3309-TL-E SWITCH 2SC4081T106 SWITCH MA111-TX 2.2k 100k 100k 0.1 22 6.3V 1 2.2 47k 47k 220k 220k 47k 0.22 47k 100k 100k 0.1 1 100k 100k 0 0 0 4.7 1SS355TE-17 1SS355TE-17 2SD1781K-QR SWITCH 100 2.2 1 0 1 47k 10k 0 BUS 1 BUS 3 VIN VCC1 VCC2 VCPU D GND AU GND A GND VCC4 BUS 2 SYNC TU ON VMMNT TUDC MNT BATT MNT CHG MNT DC MNT S GND SDT O SCK CDUTY POWERLT RESET SDTO SCK XWAKEUP FG CPOL FIN- FIN+ TIN+ TIN- SIN- SIN+ F+ T- F- T+ * SWITCH IC403 BH6580KV DCIN REGB DET DCIN S VMMNT CHGMNT BATM1 BATM2 BBK PREGND PWM SOFTPWM CSL2 CSL1 COM SYNC PREGND SOFT SLOW VCC2NF VCPUNF PMG STNG SEP SEM SEO GSW FIN3 RIN3 FIN2 RIN2 FIN1 0GND VM1 FO1 PGND1 RO1 VM12 FO2 PGND2 RO2 VM23 FO3 PGND3 RO3 VM3 U OUT SPGND1 V OUT SPVCC2 W OUT SPGND2 LG VG SSW VCC3 VIN DSW POWERGND USW VCC VCC2 2.0V VCC1 2.25V VCC0 2.25V CHGB VCPU 2.0V RIN1 FOCUS/TRACKING COIL DRIVE SLED/SPINDLE MOTOR DRIVE POWER CONTROL DC IN 4.5V DRY BATTERY SIZE"AA" 2PCS,3V FJ200 FJ200:CH FJ200:AEP,AUS,E,UK,US/FJ201 *Q402 EXCPT CH 2SA1363-T111-1E FJ200:CH E O E I H RESET XRST I WAKEUP I XSCK XSDTO POWER LT I FG O W 1 V 1 U 1 SP VCC 2SB1132-T100-Q (IEC DESIGNATION LR6) w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 16 16 D-FJ200/FJ201 5-8. SCHEMATIC DIAGRAM – MAIN SECTION (5/5) – R33 SL2 C75 R31 R32 C71 R40 R48 R49 C73 R46 R47 R43 R60 R61 C85 C87 R44 R53 X3 C88 C89 C92 C93 C94 C95 C96 C81 R41 R70 R71 R72 R73 R66 R67 R68 R69 C24 C38 C107 R75 R76 C108 C109 R63 C99 C83 R310 R301 C300 C313 C82 R42 C78 C84 C91 C97 C80 CN802 R81 R82 R83 R84 R85 R86 R87 R88 R89 R90 R91 R92 R93 R94 R95 R96 R97 R98 R99 R80 R79 Q15 R45 R64 R65 R55 R56 R59 L11 10µH R74 R39 R38 R54 R77 C86 C77 FB4 R58 1k TU TEST 0.01 470 100k 0.01 100k 0 47k 0.1 0 0 470 10k 10k 22 6.3V 0.1 0 4.7k 75kHz 22p 5p 10p 0.47 0.1 0.1 0.47 0 10k 22k 22k 4.7k 22k 2.2k 10k 10k 4.7k 0.01 0.01 0.01 10k 10k 0.01 0.01 100k 1 0.01 22k 22k 4.7 4.7 0.01 10k 1 0.01 0.01 0.01 1000p 26P 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 10k 2SC3931-C-TX WAVE SHAPER 470 220k 220k 10k 10k 10k 4.7k 10k 470 10k 22k 0.01 0.01 0 EO RESET TU TU MUTE XTU BASS1 ACK CD HOLD BEEP SCK SDTI TU SDT O BATT MNT PWM TU BASS2 AM ON IF COUNT REQ MODE1 MODE2 V OUT STEP LCD REQ PGM SC SEL TU ON CD ON S GND VOL- VOL+ OPEN DTS TV/FM/AM D GND VCPU 2.0V TU POWER ON RM KEY TUDC MNT MONO/LOCAL AD KEY1 AD KEY2 DO SK CS CS SK DO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 * IC5 IC6 IC4 AK93C55AV-L TC75S57F(TE85R) TC75W58FK(TE85R) IC3 TC9327AF-04CD XTU BASS O XTU TEST I ACK CD O DCIN DET I BAND CTL2 O TU HOLD I TU BEEP O CDU SCK I CDU SDD O CDU SDI I AD DC REF HIDC I BATT I AM ON +B ON/OFF O MONO/LOCAL CTR O COM1 COM2 COM3 COM4 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 IF REQ O TU MUTE O TEST IF I EO(D01) O NC(D02) HOLD I GND NC(FM I) VDD(1.8-2.2V) RESET I X O X I VXT VLCD C1 C2 VEE TV/FM/AM I T AVLS O CD ON I TU ON I SC SEL I AD KEY2 I RM SUB AD KEY1 I VOL+ EEP CS O EEP SK O EEP DO/DI IO XLID OPEN I VOL- NC S17 AM STEP I DEST2 I DEST1 I DEST0 I VCC PE NC GND CS SK D1 D0 1 5 10 15 20 26 NC(OT1) BAND CTL1 0 TU BASS O VOL PWM O LCD REQ I LEVEL LEVEL EEPROM TUNER CONTROL FJ200:US FJ200:AUS,CH,US/FJ201 FJ200:AUS,CH,US/FJ201 FJ200:AEP,E,UK FJ200:AUS,CH,E,US FJ200:AEP,CH,UK FJ200:AUS,E FJ200:AEP,UK/FJ201 FJ200:AUS,E,US/FJ201 FJ200:AEP,CH,UK,US/FJ201 RM KEY I *R58 100k 200k AUS,E AEP,UK,CH FJ200:AEP,UK,CH,AUS,E COMPARATOR COMPARATOR • See page 20 for IC Pin Function Description. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 17 D-FJ200/FJ201 1.0 Vp-p 75 KHz For Schematic Diagrams. Note: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specifed. • f : internal component. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. • A : B+ Line. • Power voltage is dc 4.5 V and fed with regulated dc power supply from battery terminal. • Voltages are dc with respect to ground under no-signal conditions. no mark : PLAY • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production toler ances. • Circled numbers refer to waveforms. • Signal path. E : CD PLAY • Abbreviation AUS: Australian model E13 : AC 220-230V Area in E model CH :Chinese model For Printed Wiring Boards: Note: • X : parts extracted from the component side. • f : internal component. • a : Through hole. • : Pattern from the side which enables seeing. (The other layers’ patterns are not indicated.) Caution: Pattern face side :Parts on the pattern face side seen from the (Side B) pattern face are indicated. Parts face side : Parts on the parts face side seen from the (Side A) parts face are indicated. • WAVEFORMS IC3 uf X_O 4.0 Vp-p 0.29 µsec 0.4 to 0.8Vp-p 2.0 Vp-p 16.934MHz 2 Q14 C (FM/AM/TV/WB MODE) VOL/DIV : 2 V AC TIME/DIV : 0.1 µsec 3 IC601 qd RFI (CD PLAY MODE) VOL/DIV : 0.5 V AC TIME/DIV : 0.5 µsec 4 IC601 ek XOUT (CD PLAY MODE) VOL/DIV : 1 V AC TIME/DIV : 20 nsec 1 VOL/DIV : 0.5 V AC TIME/DIV : 5 µsec 5 IC601 td CLK4M 6 IC801 2 XIN VOL/DIV : 1 V AC TIME/DIV : 0.1 µsec VOL/DIV : 1 V AC TIME/DIV : 0.1 µsec 2.0Vp-p 235 µsec 1.8Vp-p 235 µsec • Abbreviation AUS: Australian model E13 : AC 220-230V Area in E model CH :Chinese model 3.0 Vp-p 5.7 µsec 7 IC403 qd DSW (CD PLAY MODE) VOL/DIV : 1 V AC TIME/DIV : 2 µsec 8 IC403 ef SYNC (CD PLAY MODE) VOL/DIV : 1 V AC TIME/DIV : 0.1 µsec 2.0Vp-p 235 µsec www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 18 D-FJ200/FJ201 • IC BLOCK DIAGRAM IC1 TA2154FN (EL) 12 13 14 19 15 FM/TV MIX 8 9 10 TV-RF_I VCC FM-IF_I AM-IF_I QUAD DET_O MPX_I LPF1 R_O GND 1 4 2 3 5 6 FM-FR_I RF-GND FM-MIX_O AM-MIX_O AGC 7 AM MIX SW FM/AM/TV PW SW 1/2 FM OSC TV OSC 1/8 OR 1/16 AM DET LEVEL DET FM MPX FM DET AM OSC AGC 18 17 16 20 FM/TV-OSC AM-RF_I OSC_O TV-RF_O FM-RF_O AM_BP AM-OSC MODE2 MODE1 REQ-SW IF-COUNT_O LPF2B LPF2A L_O RF-VCC 30 29 27 28 23 24 25 26 22 21 11 BUFF IF BUFF BUFF BUFF FM IF AM IF AF TV RF FM RF IC601 BU9354CKV 1 100 AVDD1_2.0V 2 LD-SW 3 PD 4 V_MON 5 V_CHK 6 E 7 F 8 B 9 A 10 AVSS1 11 BIAS 12 N.C. 13 RFI 14 PKC 15 BTC 16 RFGO 17 DETI 18 ASY_I 19 ASY_O 20 MON1 22 ADPF_O 23 ADPF_I 24 FCO 25 PCO 75 FDOP 74 FDON 73 CLVOP 72 CLVON 71 CLKDRV 70 GFS_O 69 EXPLCK 68 ESP_LT 67 EFM/YFLG 66 C2FX 65 FOK_O 64 63 62 61 60 59 58 DOCKO DOUTA_O LRCK_O DOUTA_I LRCK_I 57 TD_O TEST DEFECT_O 56 TD_I 55 TMS 54 TCK 53 CLK4M 52 BUSY_O 51 DVDD (1.5V) A3 99 A2 98 A1 97 A0 96 A4 95 A5 94 A6 93 A7 92 A8 91 A9 90 XRAS 88 D1 87 D0 86 DVDDIO2 (2.0V) 85 D3 84 D2 83 XCAS 82 A10 81 DVSSIO2 80 DVDDIO (2.0V) 79 SDOP 78 SDON 77 TDOP 76 TDON 28 RLINI 29 RDACO 26 AVSS2 27 RLINO 30 VCDACO 31 LDACO 32 LLINI 33 LLINO 34 AVDD2 (2.25V) 35 MUTE 36 DVDDIO (2.0V) 37 X_I 38 X_O 39 DVSSIO 40 DVDD (1.5V) 41 DOCKI 42 DVSS1 43 SCOR 44 XRST 45 P-OFF_I 46 DVSSIO 47 SCLK_I 48 SRW_I 49 SDTO_I 50 SDTI_O ESP SERVO CORE APC PWM FLAG 21 MON2 89 XWE A/D D/A PLL 1bit DAC WINDOW ECC CLOCK GEN SUB SIO RF AMP www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 D-FJ200/FJ201 IC403 BH6580KV 61 60 DCIN 59 58 57 56 55 54 53 51 50 49 47 46 45 48 52 36 35 34 32 31 30 33 23 22 29 27 26 25 24 28 21 9 1 2 3 4 7 8 5 6 10 11 12 13 14 15 16 62 REGB 63 DET 64 DCIN_S 65 CHGB 66 VMMNT 67 CHGMNT 68 BATM1 69 BATM2 70 BBK 71 PREGND 72 PWM 73 SOFTPWM 74 FG_O 75 CSL1 SP_VCC1 U_O SP_GND1 V_O SPVCC2 W_O LG SP_GND2 VG SSW VCC3_2.4V VIN DSW POWER_GND USW VCC0_2.25V 17 VCC1_2.25V 18 VCC2_2.0V 20 VCC FIN3 RIN3 FIN2 RIN2 FIN1 RIN1 VM1 0GND FO1 P_GND1 VM12 RO1 FO2 P_GND2 RO2 VM23 44 FO3 43 P_GND3 42 RO3 41 VM3 76 W_I PRE DRIVE LOGIC VG VCC VG SLOPE SIGNAL 77 V_I 78 U_I 79 COM 80 CSL2 XRST_I 37 WAKEUP_I 38 XSCK 39 XSDTO 40 POWER_LT_I H_RESET SYNC PRE_GND E_I SOFT SLOW E_O PMG VCP_UNF VCC2_NF STNG SEP SEM SEO GSW INPUT SELECT CHARGE CONTROLLER LEVEL SHIFTER HVPROT MONTOR AMP VM VCC VG VG VCC3 CH1 H BRIDGE CH2 H BRIDGE CH3 H BRIDGE INTERFACE RESET CLK SAW GEN VG VCC VCC2 19 VCPU_2.0V 10msec DELAY VCC4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 20 D-FJ200/FJ201 1 to 4 COM1 to 4 O LCD common output 5 to 20 S1 to 16 O LCD segment output 21 AM-STEP_I I Tuning frequency (9k/10k) step select signal input 22 DEST2_I I Destination input 23 DEST1_I I Destination input 24 DEST0_I I Destination input 25 S17 O LCD segment output 26 NC O Not used (OPEN) 27 VOL– I “VOL–” button detection input 28 LCD-REQ_I I LCD request signal input 29 XLID-OPEN_I O OPEN switch status detection input 30 EEP D0/DI_IO I/O Serial data input/output to EEPROM 31 EEP-SK_O O Serial clock output to EEPROM 32 EEP-CS_O O Chip select signal output to EEPROM 33 VOL+ I “VOL+” button detection input 34 AD-KEY1_I I Set’s button detection input 35 RM_SUB I Remocon’s button detection inout 36 AD-KEY2_I I Set’s button detection input 37 SC-SEL_I I PGM select signal input 38 TU_ON_O O Tuner ON signal output 39 CD_ON_I I CD ON signal input 40 T-AVLS_O O Not used (Connected to ground with capacitor) 41 AM-ON_O O AM/FM sound EQ switch signal output 42 RM-KEY_I I Remocon’s button detection input 43 BATT_I I Battery voltage monitor input 44 HIDC_I I Battery voltage monitor input 45 AD-DC_REF I Analog reference voltage to A/D, D/A converter 46 CDU-SDI_I I Serial data input from IC801 47 CDU-SDO_O O Serial data output to IC801 48 CDU-SCK_I I Serial clock input from IC801 49 TU-BEEP_O O BEEP signal output 50 VOL-PWM_O O Electronic volume control signal output 51 TU-HOLD_I I HOLD switch status detection input 52 BAND-CTL2_O O Tuner band select signal output to IC1 53 DCIN-DET_I I Not used (OPEN) 54 ACK-CD_O O ACK signal output 55 MONO/LOCAL-CTR_O O MONO-Stereo/Local select signal output 56 TU-BASS_O O BASS H/L switch signal output to IC301 57 XTU-TEST_I I Not used (Pull down) 58 XTU-BAND_O O BASS switch signal output to IC301 59 BAND-CTL1_0 O Tuner band select signal output to IC301 60 +B ON/OFF_O O Tuner IF Amp power ON/OFF signal output 61 IF-REQ_O O Tuner IF signal request signal output to IC1 62 TU-MUTE_O O Mute signal output 63 TEST I Not used 64 IF_I I Tuner IF signal input 65 EO (D01)_O O Tuning voltage pulse output 66 NC (D02) O Not used (OPEN) 5-9. IC PIN FUNCTION DESCRINTION Pin No. Pin name I/O Description IC3 (DIGITAL TUNING, LCD DRIVER CONTROL TC9327AF-04CD) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 D-FJ200/FJ201 67 HOLD_I I Not used (Fixed to L) 68 NC (OT1) O Not used (OPEN) 69 GND – Ground 70 NC (FM_I) I Not used (OPEN) 71 TV/FM/AM_I I Tuner OSC frequency input 72 VDD (1.8-2.2V) – Power supply 73 RESET_I I Reset signal input 74 X_O O Crystal oscillator output (75kHz) 75 X_I I Crystal oscillator input (75kHz) 76 VXT – Power supply terminal 77 VLCD – Charge pump terminal 78 C1 – Charge pump terminal 79 C2 – Charge pump terminal 80 VEE – LCD drive power supply (Connected to ground with capacitor) Pin No. Pin name I/O Description www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 D-FJ200/FJ201 Pin No. Pin name I/O Description IC801 (SYSTEM CONTROL) T5AW5-04CD 1 GND – Ground terminal 2 X_I I System clock input 3 X_O O Not used (OPEN) 4 TEST I Test mode terminal 5 VCPU_2.0V – Power supply 6 FOK_I I Focus OK signal input 7 XBUSY_I I Auto sequencer status signal input from IC601 8 RESET_I I Micon reset input 9 ACK_CD_I I ACK signal input from IC3 10 SDTI_I_TU I Signal data input from IC3 11 SCOR_I I SCOR pulse input 12 HPSW_O O Power ON signal output to AN17883A 13 53/54 I DEFECT signal input (Pull down) 14 XPOW_LT_O O Data latch signal output to BH6580KV 15 SRW_O O Serial interface Read/Write signal output to IC601 16 SDTI_I I Serial data input from IC601 17 SDTO_O O Serial data output to IC601 18 SCK_O O Serial clock output to IC601 19 AVCPU – Power supply for CPU and I/O 20 ADVREF I Analog reference voltage for A/D converter 21 ADSEL_I I A/D converter select signal input 22 AD_CHGMNT I Charging monitor input 23 AD_KEY2 I Set’s button detection input 24 AD_BATTMNT I Battery voltage monitor input 25 WP/AD_KEY1 I Set’s button detection input 26 WP/AD_RMKEY I Remocon’s button detection input 27 AD_DCINMNT I DC-IN voltage monitoring input 28 WP/XOPEN_I I OPEN switch status detection input 29 TUPWR_POWER_O O Power supply for tuner 30 BEEP_O O BEEP sound output 31 NC O Not used (OPEN) 32 – Power supply for EEPROM (Not used) 33 WP/K2_RM_I I Wake-up signal input 34 TUNER_ON_I I Tuner ON signal input 35 VOL+ I “VOL+” button detection input 36 X9K/10K_O O Tuning frequency (9k/10k) step select signal output 37 TEST I TEST terminal 38 VOL– I “VOL–” button detection input 39 LCD_REQ_O O LCD request signal output to IC3 40 HOLD_I I HOLD switch status detection input 41 to 56 SEG0 to 15 O Not used (OPEN) 57 to 60 COM0 to 3 O Not used (OPEN) 61 to 63 V1 to 3 – Not used (OPEN) 64 C1 – Not used (OPEN) 65 C0 – Not used (OPEN) 66 XWAKEUP_O O Wake-up signal output to IC403 67 PGM_SDTO_O O PGM serial data output www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 D-FJ200/FJ201 Pin No. Pin name I/O Description 68 PGM_SDTI_I I PGM serial data input 69 PGM_SCK_O O PGM clock output 70 CD_ON_O O CD ON signal output to IC3 71 GFS_I I Guard Frame Synchronous signal input from IC601 72 FG_I I FG signal input from IC403 73 PGM/SC_SEL_O O PGM select signal output 74 AMUTE_O O Mute ON/OFF signal output 75 RESET_TU_O O Reset signal output to IC3 76 XREST_O O System reset output 77 POWER-OFF_O O Power off output to IC601 78 XOPSTBY_O O Pick-up’s power supply ON/OFF control 79 OP_G-SW_O O RF IC’s gain control 80 (CD/TU) O CD/TU audio select signal output to IC301 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 24 D-FJ200/FJ201 SECTION 6 EXPLODED VIEWS NOTE : • -XX, -X mean standardized parts, so they may have some difference from the original one. • Color indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ••• (RED) ↑ ↑ Parts color Cabinet's color • Items marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. • Abbreviation AUS : Australian model E13 : AC 220-230V Area in E model CH : Chinese model 6-1. UPPER LID SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 2 3 7 8 10 11 4 5 LCD801 not supplied not supplied cabinet section not supplied The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 1 3-254-014-11 SCREW * 2 3-261-257-01 COVER (UPPER LID) 3 3-261-259-01 SHEET (COVER), ADHESIVE 4 1-478-413-11 SWITCH UNIT 5 3-261-234-01 CONNECTOR, RUBBER 7 3-261-231-01 BUTTON (SOUND) 8 3-261-229-21 BUTTON (STOP) 10 X-3384-772-1 WINDOW (S) SUB ASSY, LCD (FJ200:AEP,AUS,E13,UK) 10 X-3384-773-1 WINDOW (S) SUB ASSY, LCD (FJ200:US) 10 X-3384-774-1 WINDOW (S) SUB ASSY, LCD (FJ200:CH) 10 X-3384-775-1 WINDOW (S) SUB ASSY, LCD (FJ201) 11 3-261-230-21 BUTTON (PLAY) LCD801 1-805-462-11 DISPLAY PANEL, LIQUID CRYSTAL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 25 D-FJ200/FJ201 6-2. CABINET SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 52 53 54 55 56 58 60 60 61 62 63 64 65 66 67 67 59 57 CDM-3325ER 68 51 3-261-238-01 KNOB (HOLD) 52 3-261-305-01 CABINET (LOWER) * 53 A-4541-837-A MAIN BOARD, COMPLETE (FJ200:US) * 53 A-4542-741-A MAIN BOARD, COMPLETE (FJ200:AEP,UK) * 53 A-4542-745-A MAIN BOARD, COMPLETE (FJ201) * 53 A-4542-749-A MAIN BOARD, COMPLETE (FJ200:E) * 53 A-4542-753-A MAIN BOARD, COMPLETE (FJ200:AUS) * 53 A-4542-772-A MAIN BOARD, COMPLETE (FJ200:CH) 54 3-261-254-01 TERMINAL, BATTERY LINK 55 3-261-253-01 TERMINAL, BATTERY (-) 56 3-261-252-01 TERMINAL, BATTERY (+) 57 3-245-331-02 INSULATOR 58 3-261-240-01 LEVER (DETECTION) 59 3-261-239-01 KNOB (OPEN) 60 3-254-070-11 SCREW 61 3-261-255-01 SPRING (L) 62 3-261-256-01 SPRING (R) 63 X-3384-382-1 CABINET (UPPER) SUB ASSY 64 3-261-258-01 LID, BATTERY CASE 65 3-261-250-01 LOCK, OPEN 66 3-261-251-01 SPRING (OPEN) 67 3-034-792-11 SCREW, TAPPING (B2.0) 68 3-831-441-99 SPACER, KNOB www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 26 D-FJ200/FJ201 6-3. OPTICAL PICK-UP SECTION (CDM-3325ER) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark M901 M902 101 101 102 103 104 105 106 107 108 109 110 111 101 3-318-203-61 SCREW (B1.7X4), TAPPING 102 3-221-474-01 SPRING, SLED 103 3-221-472-02 CHASSIS 104 A-3180-967-A FEED ASSY, SCREW 105 3-221-473-01 COVER, GEAR 106 3-221-268-01 GEAR (B) 0107 X-3380-950-1 OPTICAL PICK-UP (DAX-25E RP ASSY) 108 3-221-475-01 SHAFT, STANDARD 109 3-222-298-01 RACK 110 3-222-299-01 SPRING, RACK RETAINER 111 3-348-998-31 SCREW (M1.4X2.5), TAPPING, PAN M901 A-3180-965-A MOTOR ASSY, TURN TABLE (SPINDLE) M902 A-3180-966-A MOTOR ASSY, SLED The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 27 D-FJ200/FJ201 SECTION 7 ELECTRICAL PARTS LIST Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF • RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable • COILS uH: µH • SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... When indicating parts by reference number, please include the board. MAIN • Abbreviation AUS : Australian model E13 : AC 220-230V Area in E model CH : Chinese model * A-4541-837-A MAIN BOARD, COMPLETE (FJ200:US) * A-4542-741-A MAIN BOARD, COMPLETE (FJ200:AEP,UK) * A-4542-745-A MAIN BOARD, COMPLETE (FJ201) * A-4542-749-A MAIN BOARD, COMPLETE (FJ200:E) * A-4542-753-A MAIN BOARD, COMPLETE (FJ200:AUS) * A-4542-772-A MAIN BOARD, COMPLETE (FJ200:CH) ******************* 3-261-252-01 TERMINAL,BATTERY(+) 3-261-253-01 TERMINAL,BATTERY(-) 3-261-254-01 TERMINAL,BATTERY LINK < CAPACITOR > C1 1-131-862-91 TANTAL. CHIP 47uF 20% 4V C2 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C4 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C5 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C6 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C7 1-164-230-11 CERAMIC CHIP 220PF 5% 50V C8 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C9 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C10 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C11 1-162-923-11 CERAMIC CHIP 47PF 5% 50V C12 1-162-912-11 CERAMIC CHIP 7PF 0.5PF 50V C13 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C14 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C16 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V (FJ200:US) C17 1-162-907-11 CERAMIC CHIP 2PF 0.25PF 50V C18 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C19 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C20 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C21 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C22 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C23 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C24 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:AUS,CH,US/FJ201) C27 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C28 1-162-908-11 CERAMIC CHIP 3PF 0.25PF 50V C29 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C30 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C31 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C32 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C33 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V C34 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C35 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C36 1-127-760-11 CERAMIC CHIP 4.7uF 10% 6.3V C37 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US/FJ201) C38 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C39 1-164-315-11 CERAMIC CHIP 470PF 5% 50V C40 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C41 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C42 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C43 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C44 1-127-760-11 CERAMIC CHIP 4.7uF 10% 6.3V C45 1-124-434-00 ELECT 220uF 20% 4V C47 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C49 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C50 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C53 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V C54 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C55 1-115-156-11 CERAMIC CHIP 1uF 10V C58 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C59 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C60 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C61 1-162-912-11 CERAMIC CHIP 7PF 0.5PF 50V C62 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C63 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C64 1-162-911-11 CERAMIC CHIP 6PF 0.50PF 50V C65 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C66 1-135-834-91 CERAMIC CHIP 2.2E+06PF 6.3V C67 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C67 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C68 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C69 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C71 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C73 1-164-156-11 CERAMIC CHIP 0.1uF 25V C75 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C76 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C77 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C78 1-115-156-11 CERAMIC CHIP 1uF 10V C80 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C81 1-216-864-11 METAL CHIP 0 5% 1/10W C82 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 28 D-FJ200/FJ201 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks MAIN C83 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C84 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C85 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C85 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C86 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C87 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C88 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C89 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50V C91 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C92 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C93 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V C94 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C95 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C96 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V C97 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C98 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:US) C99 1-115-156-11 CERAMIC CHIP 1uF 10V C101 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C102 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C103 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C104 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C105 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C107 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C108 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:AUS,CH,US/FJ201) C109 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:AUS,CH,US/FJ201) C110 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V (FJ201) C110 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (FJ200) C116 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V (FJ200:US) C201 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C202 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C203 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C204 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C205 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C210 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V (FJ201) C210 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V (FJ200) C300 1-127-760-11 CERAMIC CHIP 4.7uF 10% 6.3V C301 1-162-927-11 CERAMIC CHIP 100PF 5% 50V C302 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V (FJ200:US) C303 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C303 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C304 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C305 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C306 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C306 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C307 1-135-259-11 TANTAL. CHIP 10uF 20% 6.3V C308 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C309 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C310 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3V C311 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C311 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C312 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C312 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C313 1-127-760-11 CERAMIC CHIP 4.7uF 10% 6.3V C314 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C315 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C316 1-124-635-00 ELECT 220uF 20% 6.3V C317 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C318 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C319 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V (FJ200:AUS,CH,US/FJ201) C321 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C321 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C323 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:AUS,CH,E,US/FJ201) C324 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C325 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C330 1-216-864-11 METAL CHIP 0 5% 1/10W C400 1-117-720-11 CERAMIC CHIP 4.7uF 10V C403 1-115-156-11 CERAMIC CHIP 1uF 10V C405 1-115-156-11 CERAMIC CHIP 1uF 10V C406 1-135-834-91 CERAMIC CHIP 2.2E+06PF 6.3V C410 1-115-156-11 CERAMIC CHIP 1uF 10V C411 1-115-156-11 CERAMIC CHIP 1uF 10V C415 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C417 1-164-156-11 CERAMIC CHIP 0.1uF 25V C418 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C419 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C420 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C421 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C422 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C423 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C424 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C425 1-126-153-11 ELECT 22uF 20% 6.3V C426 1-124-635-00 ELECT 220uF 20% 6.3V C427 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C428 1-107-686-11 TANTAL. CHIP 4.7uF 20% 16V C432 1-124-434-00 ELECT 220uF 20% 4V C433 1-115-156-11 CERAMIC CHIP 1uF 10V C434 1-124-589-11 ELECT 47uF 20% 16V C435 1-126-153-11 ELECT 22uF 20% 6.3V C436 1-124-589-11 ELECT 47uF 20% 16V C437 1-124-589-11 ELECT 47uF 20% 16V C438 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C440 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C441 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C445 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C447 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 29 D-FJ200/FJ201 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks MAIN C448 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V C450 1-115-156-11 CERAMIC CHIP 1uF 10V C600 1-110-569-11 TANTAL. CHIP 47uF 20% 6.3V C604 1-164-156-11 CERAMIC CHIP 0.1uF 25V C605 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C606 1-135-259-11 TANTAL. CHIP 10uF 20% 6.3V C607 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C608 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C609 1-125-837-91 CERAMIC CHIP 1uF 10% 6.3V C610 1-117-720-11 CERAMIC CHIP 4.7uF 10V C612 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C613 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C614 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V C615 1-115-156-11 CERAMIC CHIP 1uF 10V C618 1-135-834-91 CERAMIC CHIP 2.2uF 6.3V C618 1-216-821-11 METAL CHIP 1K 5% 1/10W (FJ200:E) C619 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C619 1-216-821-11 METAL CHIP 1K 5% 1/10W (FJ200:E) C621 1-164-156-11 CERAMIC CHIP 0.1uF 25V C622 1-104-852-11 TANTAL. CHIP 22uF 20% 6.3V (FJ200) C622 1-119-750-11 TANTAL. CHIP 22uF 20% 6.3V (FJ201) C623 1-164-156-11 CERAMIC CHIP 0.1uF 25V C624 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V C625 1-164-156-11 CERAMIC CHIP 0.1uF 25V C626 1-164-156-11 CERAMIC CHIP 0.1uF 25V C627 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C629 1-162-919-11 CERAMIC CHIP 22PF 5% 50V C630 1-124-584-00 ELECT 100uF 20% 10V C631 1-164-156-11 CERAMIC CHIP 0.1uF 25V C632 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V C633 1-164-156-11 CERAMIC CHIP 0.1uF 25V C634 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C800 1-164-156-11 CERAMIC CHIP 0.1uF 25V C801 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C802 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C805 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C806 1-164-156-11 CERAMIC CHIP 0.1uF 25V C807 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C808 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C809 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V (FJ200:AUS,CH,US/FJ201) C809 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AEP,E,UK) < FILTER > CF2 1-813-163-21 FILTER, CERAMIC CF3 1-767-480-11 FILTER, CERAMIC (AM) CF4 1-795-410-21 FILTER, CERAMIC < CONNECTOR > CN401 1-784-342-21 HOUSING, CONNECTOR 2P * CN402 1-785-877-21 HOUSING, CONNECTOR 4P CN601 1-818-127-11 CONNECTOR, FFC/FPC (ZIF) 15P CN802 1-691-390-11 CONNECTOR, FFC/FPC 26P < TRIMMER > CT1 1-141-373-11 CAP, TRIMMER 10PF (AM TRACKING) < DIODE > D1 6-500-338-01 DIODE KV1610S D2 8-719-080-77 DIODE MA2S357(E)-(TX).SO (FJ200:US) D3 8-719-080-77 DIODE MA2S357(E)-(TX).SO D4 8-719-080-77 DIODE MA2S357(E)-(TX).SO D6 8-719-988-61 DIODE 1SS355TE-17 D7 8-719-420-87 DIODE MA8130 D301 8-719-988-61 DIODE 1SS355TE-17 D302 8-719-988-61 DIODE 1SS355TE-17 D306 8-719-421-33 DIODE MA147 D400 8-719-988-61 DIODE 1SS355TE-17 D402 8-719-081-34 DIODE RB160M-30TR D403 8-719-085-43 DIODE MA2YD2300LS0 D405 8-719-081-34 DIODE RB160M-30TR D408 8-719-988-61 DIODE 1SS355TE-17 D409 8-719-988-61 DIODE 1SS355TE-17 D410 8-719-988-61 DIODE 1SS355TE-17 D802 8-719-072-70 DIODE MA2ZD14001S0 D804 8-719-988-61 DIODE 1SS355TE-17 D805 8-719-072-70 DIODE MA2ZD14001S0 < FERRITE BEAD > FB1 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT US) FB1 1-414-760-21 FERRITE 0uH (FJ200:US) FB2 1-216-864-11 METAL CHIP 0 5% 1/10W FB3 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT US) FB3 1-414-760-21 FERRITE 0uH (FJ200:US) FB4 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT US) FB4 1-414-760-21 FERRITE 0uH (FJ200:US) FB5 1-216-864-11 METAL CHIP 0 5% 1/10W FB6 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT US) FB6 1-414-760-21 FERRITE 0uH (FJ200:US) FB101 1-414-760-21 FERRITE 0uH FB201 1-414-760-21 FERRITE 0uH FB301 1-414-813-11 FERRITE 0uH FB302 1-216-295-91 SHORT CHIP 0 (FJ200:AUS,CH/FJ201) FB302 1-414-813-11 FERRITE 0uH (FJ200:US) FB303 1-216-821-11 METAL CHIP 1K 5% 1/10W (FJ200:AUS,CH,US/FJ201) FB304 1-414-813-11 FERRITE 0uH (FJ200:AUS,CH,US/FJ201) FB401 1-216-295-91 SHORT CHIP 0 FB402 1-216-295-91 SHORT CHIP 0 FB403 1-414-813-11 FERRITE 0uH FB405 1-216-295-91 SHORT CHIP 0 FB406 1-216-295-91 SHORT CHIP 0 FB408 1-469-152-11 FERRITE 0uH FB409 1-216-864-11 METAL CHIP 0 5% 1/10W (EXCEPT US) FB409 1-414-760-21 FERRITE 0uH (FJ200:US) FB601 1-216-295-91 SHORT CHIP 0 (FJ200:US) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 30 D-FJ200/FJ201 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks FB601 1-414-813-11 FERRITE 0uH (EXCEPT US) < FILTER > FL1 1-781-765-11 FILTER, BAND PASS (FJ200:US) FL2 1-236-711-21 FILTER, BAND PASS (EXCEPT US) < IC > IC1 6-701-310-01 IC TA2154FN(EL) IC2 8-759-457-70 IC XC62RP1602MR IC3 6-803-924-01 IC TC9327AF-04CD IC4 8-759-449-23 IC AK93C55AV-L IC5 8-759-594-55 IC TC75S57F(TE85R) (FJ200:AUS,CH,US/FJ201) IC6 8-759-598-39 IC TC75W58FK(TE85R) (FJ200:AUS,CH,US/FJ201) IC301 6-704-626-01 IC AN17883A-VF IC403 6-703-034-01 IC BH6580KV IC601 6-803-922-01 IC BU9354CKV IC602 6-704-412-01 IC GLT4160N04-100TC IC801 6-804-057-01 IC T5AW5-04CD < JACK > J301 1-816-153-61 JACK (i) (FJ200:AUS,CH,US/FJ201) J301 1-818-051-11 JACK (i) (FJ200:AEP,E,UK) J401 1-778-153-51 JACK,DC (DC IN 4.5V) (POLARITY UNIFIED TYPE) < COIL > L1 1-424-851-31 COIL, FERRITE-ROD ANTENNA (MW) L2 1-419-542-11 COIL, AIR-CORE (TV/WB/FM FREQUENCY COVEREGE) L3 1-419-542-11 COIL, AIR-CORE (TV/WB TRACKING)(FJ200:US) L4 1-456-313-11 COIL, AIR-CORE (FM TRACKING) L5 1-424-883-11 COIL (AM OSC) (AM TRACKING) L9 1-400-389-21 INDUCTOR 10uH L10 1-400-389-21 INDUCTOR 10uH L11 1-412-006-31 INDUCTOR 10uH L301 1-400-389-21 INDUCTOR 10uH L302 1-400-681-21 INDUCTOR 0uH (FJ200:US) L401 1-400-373-21 INDUCTOR 4.7uH L402 1-400-373-21 INDUCTOR 4.7uH L403 1-400-387-21 INDUCTOR 47uH L404 1-400-388-21 INDUCTOR 220uH L406 1-400-145-21 INDUCTOR 47uH L407 1-419-387-21 INDUCTOR 100uH L409 1-400-145-21 INDUCTOR 47uH L411 1-400-387-21 INDUCTOR 47uH L601 1-400-389-21 INDUCTOR 10uH L605 1-216-295-91 SHORT CHIP 0 L606 1-216-295-91 SHORT CHIP 0 < TRANSISTOR > Q4 8-729-602-21 TRANSISTOR 2SC4154-F (FJ200 : US) Q5 8-729-602-36 TRANSISTOR 2SA1602-F Q6 8-729-420-44 TRANSISTOR UN5210 (EXCEPT US/FJ201) Q7 8-729-028-97 TRANSISTOR DTC114TUA-T106 Q8 8-729-602-21 TRANSISTOR 2SC4154-F (FJ200 :US/FJ201) Q9 8-729-028-97 TRANSISTOR DTC114TUA-T106 Q10 8-729-028-97 TRANSISTOR DTC114TUA-T106 Q11 8-729-602-36 TRANSISTOR 2SA1602-F Q12 8-729-053-44 TRANSISTOR 2SK880-Y-TE85R Q13 8-729-602-21 TRANSISTOR 2SC4154-F Q14 8-729-602-21 TRANSISTOR 2SC4154-F Q15 8-729-423-52 TRANSISTOR 2SC3931-C Q401 8-729-921-73 TRANSISTOR 2SD1781K-QR (FJ200:CH) Q402 6-550-760-01 TRANSISTOR 2SA1363-T111-1E (FJ200:CH) Q402 8-729-903-53 TRANSISTOR 2SB1132-T100-Q (EXCEPT CH) Q403 8-729-602-21 TRANSISTOR 2SC4154-F Q404 8-729-054-79 TRANSISTOR 2SB167900LSO Q405 8-729-055-99 TRANSISTOR MCH3309-TL-E Q406 8-729-602-36 TRANSISTOR 2SA1602-F Q407 8-729-905-40 TRANSISTOR 2SC4081T106 Q408 8-729-905-40 TRANSISTOR 2SC4081T106 Q601 8-729-054-79 TRANSISTOR 2SB167900LSO Q801 8-729-421-26 TRANSISTOR UN5216QRS (FJ200:US,CH,AUS/FJ201) Q802 8-729-602-21 TRANSISTOR 2SC4154-F < RESISTOR > R1 1-216-853-11 METAL CHIP 470K 5% 1/10W R2 1-216-853-11 METAL CHIP 470K 5% 1/10W R3 1-216-833-11 METAL CHIP 10K 5% 1/10W R4 1-216-853-11 METAL CHIP 470K 5% 1/10W (FJ200:US) R5 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R6 1-216-853-11 METAL CHIP 470K 5% 1/10W R7 1-216-853-11 METAL CHIP 470K 5% 1/10W R8 1-216-833-11 METAL CHIP 10K 5% 1/10W R9 1-216-805-11 METAL CHIP 47 5% 1/10W R10 1-216-864-11 METAL CHIP 0 5% 1/10W R11 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R12 1-216-821-11 METAL CHIP 1K 5% 1/10W R13 1-216-829-11 METAL CHIP 4.7K 5% 1/10W (FJ200:US/FJ201) R14 1-216-864-11 METAL CHIP 0 5% 1/10W R16 1-216-829-11 METAL CHIP 4.7K 5% 1/10W (FJ200:US) R17 1-216-821-11 METAL CHIP 1K 5% 1/10W R19 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R20 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R22 1-216-841-11 METAL CHIP 47K 5% 1/10W R23 1-216-837-11 METAL CHIP 22K 5% 1/10W R24 1-216-864-11 METAL CHIP 0 5% 1/10W R25 1-216-845-11 METAL CHIP 100K 5% 1/10W R26 1-216-833-11 METAL CHIP 10K 5% 1/10W R27 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R28 1-216-817-11 METAL CHIP 470 5% 1/10W R29 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R30 1-216-864-11 METAL CHIP 0 5% 1/10W R31 1-216-817-11 METAL CHIP 470 5% 1/10W R32 1-216-845-11 METAL CHIP 100K 5% 1/10W R33 1-216-821-11 METAL CHIP 1K 5% 1/10W R34 1-216-821-11 METAL CHIP 1K 5% 1/10W R35 1-216-845-11 METAL CHIP 100K 5% 1/10W R36 1-216-813-11 METAL CHIP 220 5% 1/10W R37 1-216-864-11 METAL CHIP 0 5% 1/10W R38 1-216-817-11 METAL CHIP 470 5% 1/10W (FJ200:AUS,CH,US/FJ201) MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 31 D-FJ200/FJ201 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R39 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AEP,E,UK) R40 1-216-845-11 METAL CHIP 100K 5% 1/10W R41 1-216-833-11 METAL CHIP 10K 5% 1/10W R42 1-216-833-11 METAL CHIP 10K 5% 1/10W R43 1-216-817-11 METAL CHIP 470 5% 1/10W R44 1-216-864-11 METAL CHIP 0 5% 1/10W R45 1-216-817-11 METAL CHIP 470 5% 1/10W R46 1-216-864-11 METAL CHIP 0 5% 1/10W R47 1-216-864-11 METAL CHIP 0 5% 1/10W R48 1-216-864-11 METAL CHIP 0 5% 1/10W R49 1-216-841-11 METAL CHIP 47K 5% 1/10W R50 1-216-841-11 METAL CHIP 47K 5% 1/10W R51 1-216-833-11 METAL CHIP 10K 5% 1/10W R52 1-216-864-11 METAL CHIP 0 5% 1/10W R53 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R54 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AUS,CH,E,US) R55 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AEP,CH,UK) R56 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AUS,E) R58 1-216-845-11 METAL CHIP 100K 5% 1/10W (FJ200:AEP,CH,UK) R58 1-216-849-11 METAL CHIP 220K 5% 1/10W (FJ200:AUS,E) R59 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AEP,UK/FJ201) R60 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AUS,E,US/FJ201) R61 1-216-833-11 METAL CHIP 10K 5% 1/10W (FJ200:AEP,CH,UK,US/FJ201) R63 1-216-845-11 METAL CHIP 100K 5% 1/10W R64 1-218-903-11 METAL CHIP 220K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R65 1-218-903-11 METAL CHIP 220K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R66 1-218-855-11 METAL CHIP 2.2K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R67 1-218-871-11 METAL CHIP 10K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R68 1-218-871-11 METAL CHIP 10K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R69 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R70 1-218-879-11 METAL CHIP 22K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R71 1-218-879-11 METAL CHIP 22K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R72 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R73 1-218-879-11 METAL CHIP 22K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R74 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R75 1-218-871-11 METAL CHIP 10K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R76 1-218-871-11 METAL CHIP 10K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R77 1-218-879-11 METAL CHIP 22K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R79 1-216-833-11 METAL CHIP 10K 5% 1/10W R80 1-216-833-11 METAL CHIP 10K 5% 1/10W R81 1-216-833-11 METAL CHIP 10K 5% 1/10W R82 1-216-833-11 METAL CHIP 10K 5% 1/10W R83 1-216-833-11 METAL CHIP 10K 5% 1/10W R84 1-216-833-11 METAL CHIP 10K 5% 1/10W R85 1-216-833-11 METAL CHIP 10K 5% 1/10W R86 1-216-833-11 METAL CHIP 10K 5% 1/10W R87 1-216-833-11 METAL CHIP 10K 5% 1/10W R88 1-216-833-11 METAL CHIP 10K 5% 1/10W R89 1-216-833-11 METAL CHIP 10K 5% 1/10W R90 1-216-833-11 METAL CHIP 10K 5% 1/10W R91 1-216-833-11 METAL CHIP 10K 5% 1/10W R92 1-216-833-11 METAL CHIP 10K 5% 1/10W R93 1-216-833-11 METAL CHIP 10K 5% 1/10W R94 1-216-833-11 METAL CHIP 10K 5% 1/10W R95 1-216-833-11 METAL CHIP 10K 5% 1/10W R96 1-216-833-11 METAL CHIP 10K 5% 1/10W R97 1-216-833-11 METAL CHIP 10K 5% 1/10W R98 1-216-833-11 METAL CHIP 10K 5% 1/10W R99 1-216-833-11 METAL CHIP 10K 5% 1/10W R101 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R102 1-216-833-11 METAL CHIP 10K 5% 1/10W R103 1-216-825-11 METAL CHIP 2.2K 5% 1/10W (FJ200:AEP,UK) R103 1-216-829-11 METAL CHIP 4.7K 5% 1/10W (FJ200:AUS,CH,E,US/FJ201) R104 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R105 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R106 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R201 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R202 1-216-833-11 METAL CHIP 10K 5% 1/10W R203 1-216-825-11 METAL CHIP 2.2K 5% 1/10W (FJ200:AEP,UK) R203 1-216-829-11 METAL CHIP 4.7K 5% 1/10W (FJ200:AUS,CH,E,US/FJ201) R204 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R205 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R206 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R300 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R301 1-216-837-11 METAL CHIP 22K 5% 1/10W R302 1-216-805-11 METAL CHIP 47 5% 1/10W (FJ200:US) R305 1-218-871-11 METAL CHIP 10K 0.5% 1/10W (FJ200:AUS,CH,US/FJ201) R310 1-216-837-11 METAL CHIP 22K 5% 1/10W R311 1-216-845-11 METAL CHIP 100K 5% 1/10W R314 1-216-793-11 METAL CHIP 4.7 5% 1/10W R320 1-216-864-11 METAL CHIP 0 5% 1/10W R403 1-218-446-11 METAL CHIP 1 5% 1/10W (FJ200:CH) R407 1-216-789-11 METAL CHIP 2.2 5% 1/10W (FJ200:CH) R408 1-216-809-11 METAL CHIP 100 5% 1/10W (FJ200:CH) R411 1-218-903-11 METAL CHIP 220K 0.5% 1/10W R412 1-218-887-11 METAL CHIP 47K 0.5% 1/10W R413 1-216-841-11 METAL CHIP 47K 5% 1/10W R415 1-218-903-11 METAL CHIP 220K 0.5% 1/10W R416 1-216-813-11 METAL CHIP 220 5% 1/10W MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 32 D-FJ200/FJ201 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R419 1-216-833-11 METAL CHIP 10K 5% 1/10W R420 1-216-845-11 METAL CHIP 100K 5% 1/10W (FJ200:AEP,AUS,E,UK,US/FJ201) R421 1-216-833-11 METAL CHIP 10K 5% 1/10W R425 1-216-295-91 SHORT CHIP 0 R427 1-216-841-11 METAL CHIP 47K 5% 1/10W R428 1-216-845-11 METAL CHIP 100K 5% 1/10W R430 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R431 1-216-845-11 METAL CHIP 100K 5% 1/10W R433 1-216-845-11 METAL CHIP 100K 5% 1/10W R434 1-216-845-11 METAL CHIP 100K 5% 1/10W R436 1-216-864-11 METAL CHIP 0 5% 1/10W R438 1-216-833-11 METAL CHIP 10K 5% 1/10W R439 1-216-841-11 METAL CHIP 47K 5% 1/10W R440 1-216-841-11 METAL CHIP 47K 5% 1/10W R441 1-216-864-11 METAL CHIP 0 5% 1/10W R444 1-216-845-11 METAL CHIP 100K 5% 1/10W R446 1-216-864-11 METAL CHIP 0 5% 1/10W R447 1-216-864-11 METAL CHIP 0 5% 1/10W R448 1-216-864-11 METAL CHIP 0 5% 1/10W R449 1-216-845-11 METAL CHIP 100K 5% 1/10W (FJ200:AEP,AUS,E,UK,US/FJ201) R451 1-218-895-11 METAL CHIP 100K 0.5% 1/10W R452 1-218-895-11 METAL CHIP 100K 0.5% 1/10W R453 1-218-887-11 METAL CHIP 47K 0.5% 1/10W R454 1-218-887-11 METAL CHIP 47K 0.5% 1/10W R459 1-216-833-11 METAL CHIP 10K 5% 1/10W R600 1-216-789-11 METAL CHIP 2.2 5% 1/10W R601 1-216-864-11 METAL CHIP 0 5% 1/10W R602 1-216-845-11 METAL CHIP 100K 5% 1/10W R603 1-216-845-11 METAL CHIP 100K 5% 1/10W R604 1-216-845-11 METAL CHIP 100K 5% 1/10W R605 1-216-845-11 METAL CHIP 100K 5% 1/10W R606 1-216-797-11 METAL CHIP 10 5% 1/10W R608 1-216-789-11 METAL CHIP 2.2 5% 1/10W R609 1-216-845-11 METAL CHIP 100K 5% 1/10W R610 1-216-845-11 METAL CHIP 100K 5% 1/10W R611 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R612 1-216-864-11 METAL CHIP 0 5% 1/10W R613 1-216-817-11 METAL CHIP 470 5% 1/10W R614 1-216-805-11 METAL CHIP 47 5% 1/10W R615 1-216-864-11 METAL CHIP 0 5% 1/10W R616 1-216-857-11 METAL CHIP 1M 5% 1/10W R617 1-216-857-11 METAL CHIP 1M 5% 1/10W (FJ201) R618 1-216-821-11 METAL CHIP 1K 5% 1/10W (EXCEPT E) R619 1-216-821-11 METAL CHIP 1K 5% 1/10W (EXCEPT E) R620 1-216-821-11 METAL CHIP 1K 5% 1/10W (EXCEPT E) R627 1-216-833-11 METAL CHIP 10K 5% 1/10W R631 1-216-821-11 METAL CHIP 1K 5% 1/10W R801 1-216-849-11 METAL CHIP 220K 5% 1/10W R802 1-216-864-11 METAL CHIP 0 5% 1/10W (FJ200:AEP,E,UK) R803 1-216-845-11 METAL CHIP 100K 5% 1/10W R804 1-216-849-11 METAL CHIP 220K 5% 1/10W (FJ200:US,AEP,UK,CH/FJ201) R804 1-216-841-11 METAL CHIP 47K 5% 1/10W (FJ200:AUS,E) R806 1-216-845-11 METAL CHIP 100K 5% 1/10W R807 1-216-861-11 METAL CHIP 2.2M 5% 1/10W (FJ200:AUS,CH,US/FJ201) R808 1-216-857-11 METAL CHIP 1M 5% 1/10W (FJ200:AUS,CH,US/FJ201) R812 1-216-864-11 METAL CHIP 0 5% 1/10W R813 1-216-845-11 METAL CHIP 100K 5% 1/10W (FJ200:AUS,CH,US/FJ201) R814 1-216-849-11 METAL CHIP 220K 5% 1/10W R816 1-216-837-11 METAL CHIP 22K 5% 1/10W R817 1-216-864-11 METAL CHIP 0 5% 1/10W R822 1-216-833-11 METAL CHIP 10K 5% 1/10W R825 1-216-864-11 METAL CHIP 0 5% 1/10W R827 1-216-864-11 METAL CHIP 0 5% 1/10W R830 1-216-864-11 METAL CHIP 0 5% 1/10W R832 1-216-821-11 METAL CHIP 1K 5% 1/10W (FJ200:AUS,CH,US/FJ201) R833 1-216-821-11 METAL CHIP 1K 5% 1/10W R836 1-216-864-11 METAL CHIP 0 5% 1/10W R837 1-216-821-11 METAL CHIP 1K 5% 1/10W R841 1-216-833-11 METAL CHIP 10K 5% 1/10W R843 1-216-861-11 METAL CHIP 2.2M 5% 1/10W (FJ200:AUS,CH,US/FJ201) R845 1-216-845-11 METAL CHIP 100K 5% 1/10W (FJ200:AEP,CH,UK,E,AUS) R846 1-216-853-11 METAL CHIP 470K 5% 1/10W (FJ200:AUS,CH,US/FJ201) R849 1-216-864-11 METAL CHIP 0 5% 1/10W R854 1-216-864-11 METAL CHIP 0 5% 1/10W R858 1-216-864-11 METAL CHIP 0 5% 1/10W R859 1-216-864-11 METAL CHIP 0 5% 1/10W R861 1-216-837-11 METAL CHIP 22K 5% 1/10W R862 1-216-837-11 METAL CHIP 22K 5% 1/10W R863 1-216-821-11 METAL CHIP 1K 5% 1/10W R864 1-216-821-11 METAL CHIP 1K 5% 1/10W R871 1-216-849-11 METAL CHIP 220K 5% 1/10W R872 1-216-833-11 METAL CHIP 10K 5% 1/10W R874 1-216-833-11 METAL CHIP 10K 5% 1/10W < SWITCH > S802 1-572-499-21 SWITCH, TACTIL (VOL+) S803 1-572-499-21 SWITCH, TACTIL (VOL-) S809 1-786-717-21 SWITCH, PUSH (1 KEY) (OPEN) S810 1-762-078-11 SWITCH, SLIDE (HOLD.) < TRANSFORMER > T1 1-449-021-21 TRANSFORMER, DC/DC CONVERTER < VARISTOR > VDR101 1-801-862-11 VARISTOR, CHIP (1608) VDR201 1-801-862-11 VARISTOR, CHIP (1608) VDR306 1-801-862-11 VARISTOR, CHIP (1608) (FJ200:CH,US/FJ201) VDR404 1-801-862-11 VARISTOR, CHIP (1608) < VIBRATOR > X3 1-577-262-11 VIBRATOR, CRYSTAL (75kHz) X601 1-795-101-21 VIBRATOR, CERAMIC (16.934MHz) ****************************************************** MAIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 33 D-FJ200/FJ201 Ref. No. Part No. Description Remarks MISCELLANEOUS ************* 4 1-478-413-11 SWITCH UNIT 0107 X-3380-950-1 OPTICAL PICK-UP (DAX-25E RP ASSY) LCD801 1-805-462-11 DISPLAY PANEL, LIQUID CRYSTAL M901 A-3180-965-A MOTOR ASSY, TURN TABLE (SPINDLE) M902 A-3180-966-A MOTOR ASSY, SLED ****************************************************** ACCESSORIES *********** 1-477-627-13 REMOTE CONTROL UNIT (RM-MC22F) (FJ200:AUS,CH) 0 1-477-661-11 ADAPTOR, AC (AC-ET455K) (FJ201) 0 1-477-662-11 ADAPTOR, AC (AC-ET455K) (FJ200:AEP,E13) 0 1-477-663-12 ADAPTOR, AC (AC-ET455K) (FJ200:UK) 0 1-477-664-11 ADAPTOR, AC (AC-ET455K) (FJ200:AUS) 0 1-477-665-11 ADAPTOR, AC (AC-ET455K) (FJ200:CH) 1-478-404-11 REMOTE COMMANDER (RM-MC28F) (FJ200:US/FJ201) 1-756-307-22 BATTERY, NICKEL.HYDRIGEN (FJ200:CH) 3-262-448-11 MANUAL,INSTRUCTION (ENGLISH) (FJ200:US) 3-262-448-21 MANUAL,INSTRUCTION (ENGLISH, FRENCH) (FJ200:AEP,UK,AUS,E13/FJ201) 3-262-448-31 MANUAL,INSTRUCTION (SPANISH, PORTUGUESE) (FJ200:E13/FJ201) 3-262-448-41 MANUAL,INSTRUCTION (DUTCH, SWEDISH) (FJ200:AEP) 3-262-448-51 MANUAL,INSTRUCTION (GERMAN, ITALIAN) (FJ200:AEP) 3-262-448-61 MANUAL,INSTRUCTION (FINNISH) (FJ200:AEP) 3-262-448-71 MANUAL,INSTRUCTION (ENGLISH, SIMPLIFIED CHINESE) (FJ200:CH) 3-262-448-81 MANUAL,INSTRUCTION (ENGLISH, TRADITIONAL CHINESE) (FJ200:E13) 8-954-007-93 RECEVER, EAR (MDR-027LP) (FJ200:US) 8-954-008-90 RECEIVER, EAR MDR-E808SP (FJ200:AUS,CH) 8-954-008-93 RECEIVER,EAR MDR-E808LP (FJ200:AEP,E13,UK/FJ201) The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com D-FJ200/FJ201 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 1.0 2004.01 New www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com