ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2008 DEH-P310UB/XS/UC CRT4247 CD RECEIVER DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES This service manual should be used together with the following manual(s): Model No. Order No. Mech.Module Remarks CX-3240 CRT4050 S10.5COMP2-iPod/USB CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly For details, refer to "Important Check Points for Good Servicing". K-ZZZ. NOV. 2008 Printed in Japan www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 2 1 2 3 4 1 2 3 4 C D F A B E SAFETY INFORMATION CAUTION WARNING Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used: This product contains certain electrical parts contain chemicals which are known to the State of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do so and refer the repair to a qualified service technician. CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited) Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam. - Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. CAUTION CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS 2. During repair or tests, do not view laser beam for 10 seconds or longer. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 3 5 6 7 8 5 6 7 8 C D F A B E CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 4 1 2 3 4 1 2 3 4 C D F A B E [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. a Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 5 5 6 7 8 5 6 7 8 C D F A B E CONTENTS SAFETY INFORMATION .....................................................................................................................................2 1. SERVICE PRECAUTIONS................................................................................................................................6 1.1 SERVICE PRECAUTIONS.........................................................................................................................6 1.2 NOTES ON SOLDERING...........................................................................................................................6 2. SPECIFICATIONS.............................................................................................................................................7 2.1 SPECIFICATIONS......................................................................................................................................7 2.2 DISC/CONTENT FORMAT.......................................................................................................................12 2.3 PANEL FACILITIES ..................................................................................................................................13 2.4 CONNECTION DIAGRAM........................................................................................................................22 3. BASIC ITEMS FOR SERVICE ........................................................................................................................27 3.1 CHECK POINTS AFTER SERVICING .....................................................................................................27 3.2 PCB LOCATIONS.....................................................................................................................................28 3.3 JIGS LIST .................................................................................................................................................29 3.4 CLEANING ...............................................................................................................................................29 4. BLOCK DIAGRAM ..........................................................................................................................................30 5. DIAGNOSIS ....................................................................................................................................................33 5.1 OPERATIONAL FLOWCHART.................................................................................................................33 5.2 ERROR CODE LIST.................................................................................................................................34 5.3 CONNECTOR FUNCTION DESCRIPTION .............................................................................................36 6. SERVICE MODE.............................................................................................................................................37 6.1 DISPLAY TEST MODE.............................................................................................................................37 6.2 CD TEST MODE.......................................................................................................................................38 7. DISASSEMBLY...............................................................................................................................................40 8. EACH SETTING AND ADJUSTMENT............................................................................................................43 8.1 CD ADJUSTMENT ...................................................................................................................................43 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT ....................................................44 8.3 PCL OUTPUT CONFIRMATION ..............................................................................................................46 9. EXPLODED VIEWS AND PARTS LIST ..........................................................................................................48 9.1 PACKING..................................................................................................................................................48 9.2 EXTERIOR (1)..........................................................................................................................................50 9.3 EXTERIOR (2)..........................................................................................................................................52 9.4 CD MECHANISM MODULE .....................................................................................................................54 10. SCHEMATIC DIAGRAM................................................................................................................................56 10.1 TUNER AMP ASSY(GUIDE PAGE) .......................................................................................................56 10.2 KEYBOARD UNIT ..................................................................................................................................62 10.3 CD MECHANISM MODULE(GUIDE PAGE)...........................................................................................64 10.4 WAVEFORMS.........................................................................................................................................70 11. PCB CONNECTION DIAGRAM ....................................................................................................................74 11.1 TUNER AMP ASSY ................................................................................................................................74 11.2 KEYBOARD UNIT...................................................................................................................................78 11.3 CD CORE UNIT(S10.5iPod-C3-CLASS1) ..............................................................................................80 12. ELECTRICAL PARTS LIST...........................................................................................................................82 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 6 1 2 3 4 1 2 3 4 C D F A B E 1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS 1.2 NOTES ON SOLDERING 1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. 5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 7 5 6 7 8 5 6 7 8 C D F A B E 2. SPECIFICATIONS 2.1 SPECIFICATIONS General Power source..........................14.4 V DC (10.8 V to 15.1 V allowable) Grounding system.................Negative type Max. current consumption ...............................................10.0 A Dimensions (W × H × D): DIN Chassis................. 178 mm × 50 mm × 162 mm (7 in. × 2 in. × 6-3/8 in.) Nose....................... 188 mm × 58 mm × 24 mm (7-3/8 in.× 2-1/4 in.× 1 in.) D Chassis................. 178 mm × 50 mm × 162 mm (7 in.× 2 in.× 6-3/8 in.) Nose....................... 170 mm × 46 mm × 24 mm (6-3/4 in.× 1-3/4 in.× 1 in.) Weight ..................................... 1.3 kg(2.9 lbs) Audio Maximum power output ...... 50 W × 4 50 W × 2/4 + 70 W × 1/2 (for subwoofer) Continuous power output .. 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 load, both channels driven) Load impedance................... 4 to 8 × 4 4 to 8 × 2 + 2 × 1 Preout max output level ...... 4 V Equalizer (3-Band Parametric Equalizer): Low Frequency.............. 40/80/100/160 Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB Mid Frequency.............. 200/500/1k/2k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB High Frequency.............. 3.15k/8k/10k/12.5k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB HPF: Frequency.......................50/63/80/100/125 Hz Slope................................–12 dB/oct Subwoofer (mono): Frequency...................... 50/63/80/100/125 Hz Slope............................... –18 dB/oct Gain................................. +6 dB to – 24 dB Phase ............................. Normal/Reverse Bass boost: Gain................................. +12 dB to 0 dB CD player System.....................................Compact disc audio system Usable discs .......................... Compact disc Signal-to-noise ratio............. 94 dB (1kHz) (IHF-A net- work) Number of channels ............ 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) USB USB standard specification .............................................. USB 2.0full speed Maximum current supply ... 500 mA Maximum memory capacity .............................................. 250 GB Minimum memory capacity .............................................. 256 MB File system............................. FAT16, FAT32 MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) FM tuner Frequency range....................87.9 MHz to 107.9 MHz Usable sensitivity.................. 9 dBf (0.7 μV/75 , mono, S/N: 30 dB) Signal-to-noise ratio............. 72 dB (IHF-A network) AM tuner Frequency range................... 530 kHz to 1 710 kHz (10 kHz) Usable sensitivity.................. 25 μV(S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IHF-A network) Bakeup current ....................... 2.8 mA to 3.1 mA DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 8 1 2 3 4 1 2 3 4 C D F A B E CEA2006 Specifications Power output ......................... 14 W RMS × 4 Channels (4 and 1 % THD+N) S/N ratio .................................. 91 dBA (reference: 1 W into 4 ) Note Specifications and the design are subject to mod- ifications without notice due to improvements. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 9 5 6 7 8 5 6 7 8 C D F A B E Bakeup current ....................... 1.2 mA to 1.6 mA DEH-P3100UB/XS/EW5 General Power source..........................14.4 V DC (10.8 V to 15.1 V allowable) Grounding system.................Negative type Max. current consumption ...............................................10.0 A Dimensions (W × H × D): DIN Chassis.................. 180 mm × 50 mm × 162 mm Nose....................... 188 mm × 58 mm × 24 mm D Chassis................. 178 mm × 50 mm × 162 mm Nose....................... 170 mm × 46 mm × 24 mm Weight .................................... 1.3 kg Audio Maximum power output ...... 50 W × 4 50 W × 2/4 + 70 W × 1/2 (for subwoofer) Continuous power output .. 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 load, both channels driven) Load impedance................... 4 to 8 × 4 4 to 8 × 2 + 2 × 1 Preout max output level ...... 2.2 V Equalizer (3-Band Parametric Equalizer): Low Frequency.............. 40/80/100/160 Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB Mid Frequency.............. 200/500/1k/2k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB High Frequency.............. 3.15k/8k/10k/12.5k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB HPF: Frequency.......................50/63/80/100/125 Hz Slope................................–12 dB/oct Subwoofer (mono): Frequency.......................50/63/80/100/125 Hz Slope................................–18 dB/oct Gain.................................. +6 dB to –24 dB Phase ..............................Normal/Reverse Bass boost: Gain................................. +12 dB to 0 dB CD player System.....................................Compact disc audio system Usable discs .......................... Compact disc Signal-to-noise ratio............ 94 dB (1 kHz) (IEC-A net- work) Number of channels ............ 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) USB USB standard specification .............................................. USB 2.0full speed Maximum current supply ... 500 mA Maximum memory capacity .............................................. 250 GB Minimum memory capacity .............................................. 256 MB File system............................. FAT16, FAT32 MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 10 1 2 3 4 1 2 3 4 C D F A B E FM tuner Frequency range................... 87.5 MHz to 108.0 MHz Usable sensitivity................... 9 dBf(0.7 μV/75 , mono, S/N: 30 dB) Signal-to-noise ratio............. 72 dB (IEC-A network) MW tuner Frequency range.................. 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity................. 25 μV (S/N: 20 dB) Signal-to-noise ratio............ 62 dB (IEC-A network) LW tuner Frequency range................... 153 kHz to 281 kHz Usable sensitivity.................. 28 μV(S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IEC-A network) Notes Specifications and the design are subject to modifications without notice due to im- provements. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 11 5 6 7 8 5 6 7 8 C D F A B E DEH-3100UB/XS/ES Bakeup current ....................... 2.8 mA to 3.1 mA General Rated power source..............14.4 V DC (allowable voltage range: 12.0 V to 14.4 V DC) Grounding system.................Negative type Max. current consumption ...............................................10.0 A Dimensions (W × H × D): DIN Chassis.................. 178 mm × 50 mm × 162 mm Nose....................... 188 mm × 58 mm × 24 mm D Chassis.................. 178 mm × 50 mm × 162 mm Nose....................... 170 mm × 46 mm × 24 mm Weight .................................... 1.3 kg Audio Maximum power output ...... 50 W × 4 50 W × 2/4 + 70 W × 1/2 (for subwoofer) Continuous power output .. 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 load, both channels driven) Load impedance................... 4 to 8 × 4 4 to 8 × 2 + 2 × 1 Preout max output level ...... 2.2 V Equalizer (3-Band Parametric Equalizer): Low Frequency.............. 40/80/100/160 Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB Mid Frequency.............. 200/500/1k/2k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB High Frequency.............. 3.15k/8k/10k/12.5k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain......................... ±12 dB HPF: Frequency.......................50/63/80/100/125 Hz Slope................................–12 dB/oct Subwoofer (mono): Frequency.......................50/63/80/100/125 Hz Slope................................–18 dB/oct Gain................................. +6 dB to –24 dB Phase ..............................Normal/Reverse Bass boost: Gain................................. +12 dB to 0 dB CD player System.....................................Compact disc audio system Usable discs .......................... Compact disc Signal-to-noise ratio............ 94 dB (1 kHz) (IEC-A net- work) Number of channels ............ 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) USB USB standard specification .............................................. USB 2.0full speed Maximum current supply ... 500 mA Maximum memory capacity .............................................. 250 GB Minimum memory capacity .............................................. 256 MB File system............................. FAT16, FAT32 MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 7.7 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 12 1 2 3 4 1 2 3 4 C D F A B E 2.2 DISC/CONTENT FORMAT FM tuner Frequency range................... 87.5 MHz to 108.0 MHz Usable sensitivity.................. 9 dBf (0.7 μV/75 , mono, S/N: 30 dB) Signal-to-noise ratio............. 72 dB (IEC-A network) AM tuner Frequency range................... 531 kHz to 1 602 kHz (9 kHz) 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity.................. 25 μV(S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IEC-A network) Infrared remote control Wavelength............................ 940 nm ±50 nm Output ......................................typ; 12 mw/sr per Infrared LED Notes Specifications and the design are subject to modifications without notice due to im- provements. (DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 13 5 6 7 8 5 6 7 8 C D F A B E 2.3 PANEL FACILITIES DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC What ’s what Head unit 1 7 8 a 23 4 5 6 b c d e f 9 1 SRC/OFF button This unit is turned on by selecting a source. Press to cycle through all the available sources. 2 /LIST button Press to display the track title list, folder list, file list or preset channel list depending on the source. Press and hold to switch to link play mode while using an iPod. For details, refer toSelecting songs from lists related to the currently playing song. 3 S.Rtrv/SAT button Press to switch Sound Retriever settings. For details, refer to Using Sound Retriever. When XM tuner or SIRIUS tuner is selected as the source, press to change the channel select mode. When SIRIUS tuner is selected as the source, press and hold to perform the In- stant Replay mode. 4 MULTI-CONTROL Move to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. Turn to increase or decrease the volume. 5 SW/BASS button Press to switch to subwoofer setting menu. When operating subwoofer menu, press to switch menu. Press and hold to switch to bass boost menu. 6 Disc loading slot Insert a CD/CD-R/CD-RW to play. 7 (eject) button Press to eject a CD/CD-R/CD-RW. 8 USB port Use to connect a USB storage device. • When connecting, open up the USB con- nector lid. • Use a USB cable to connect the USB sto- rage device to the USB port. Since the USB storage device is projected forward from the unit, it is dangerous to connect directly. Pioneer CD-U50E USB cable is also avail- able. For details, consult your dealer. 9 (detach) button Press to remove the front panel from the head unit. a AUX input jack (3.5 mm stereo jack) Use to connect an auxiliary device. b CLOCK/DISP OFF button Press to change to the clock display. Press and hold to turn the display indication and button illumination off or on. c (repeat)/LOC button Press to switch the repeat play range while using CD, USB or iPod. Press to switch local settings while using tuner as the source. d (random)/iPod button Press to turn random function on or off while using CD or USB. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 14 1 2 3 4 1 2 3 4 C D F A B E While using an iPod, press to shuffle all tracks. Press and hold to switch the control mode while using an iPod. For details, refer to Operating this unit ’s iPod function from your iPod. e DISP/BACK/SCRL button Press to select different displays. Press and hold to scroll through the text in- formation. Press to return to the previous display when operating the menu. Press and hold to return to the main menu when operating the menu. f BAND/ESC button Press to select among three FM bands and one AM band. Press to return to the ordinary display when operating the menu. Remote control Operation is the same as when using the but- tons on the head unit. g VOLUME buttons Press to increase or decrease the volume. h MUTE button Press to turn off the sound. To turn on the sound, press again. i / / / buttons Press to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. j AUDIO button Press to select an audio function. k button Press to turn pause on or off. l FUNCTION button Press to select functions. m LIST/ENTER button Press to display the disc title list, track title list, folder list, file list or preset channel list depending on the source. While in the operating menu, press to con- trol functions. Display indication 1 2 4 6 8 a c efg 3 5 7 9 b d 1 Main display section Displays band, frequency, elapsed playback time and other settings. • Tuner Band and frequency are displayed. • Built-in CD player, USB storage device, iPod Elapsed playback time and literal infor- mation are displayed. 2 indicator Appears when an upper tier of folder or menu exists. 3 (list) indicator Appears when operating list function. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 15 5 6 7 8 5 6 7 8 C D F A B E 4 indicator Appears when a lower tier of folder or menu exists. 5 (artist) indicator Appears when the disc (track) artist name is displayed on the main display section. Appears when artist search refinement on the iPod browsing function is in use. 6 (disc) indicator Appears when the disc (album) name is dis- played on the main display section. Appears when album search refinement on the iPod browsing function is in use. 7 (song) indicator Appears when the track (song) name is dis- played on the main display section. Appears when song search refinement on the iPod browsing function is in use. 8 (subwoofer) indicator Appears when subwoofer is on. 9 LOC indicator Appears when local seek tuning is on. a (loudness) indicator Appears when loudness is on. b (stereo) indicator Appears when the selected frequency is being broadcast in stereo. c (folder repeat) indicator Appears when folder repeat is on. When repeat function is on, only is dis- played. d (folder random) indicator Appears when folder random is on. When random function is on, only is dis- played. e (shuffle) indicator Appears when shuffle function is on while iPod source is being selected. f S.Rtrv indicator Appears when Sound Retriever function is on. For details, refer to Using Sound Retriever. g indicator Appears whenCONTROL (control mode) is set to IPOD. For details about the control mode, refer to Operating this unit’s iPod function from your iPod. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 16 1 2 3 4 1 2 3 4 C D F A B E DEH-P3100UB/XS/EW5 What ’s what Head unit 1 7 8 a 23 4 5 6 b c d e f 9 1 SRC/OFF button This unit is turned on by selecting a source. Press to cycle through all the available sources. 2 /LIST button Press to display the disc title list, track title list, folder list, file list or preset channel list depending on the source. Press and hold to switch to link play mode while using an iPod. For details, refer toSelecting songs from lists related to the currently playing song. 3 S.Rtrv button Press to switch Sound Retriever settings. For details, refer to Using Sound Retriever. 4 MULTI-CONTROL Move to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. Turn to increase or decrease the volume. 5 MUTE button Press to turn off the sound. To turn on the sound, press again. 6 Disc loading slot Insert a CD/CD-R/CD-RW to play. 7 (eject) button Press to eject a CD/CD-R/CD-RW. 8 USB port Use to connect a USB storage device. • When connecting, open up the USB con- nector lid. • Use a USB cable to connect the USB sto- rage device to the USB port. Since the USB storage device is projected forward from the unit, it is dangerous to connect directly. Pioneer CD-U50E USB cable is also avail- able. For details, consult your dealer. 9 (detach) button Press to remove the front panel from the head unit. a AUX input jack (3.5 mm stereo jack) Use to connect an auxiliary device. b TA/NEWS button Press to turn TA function on or off. Press and hold to turn NEWS function on or off. c (repeat)/LOC button Press to switch the repeat play range while using CD, USB/SD or iPod. Press to switch local settings while using tuner as the source. d (random)/iPod button Press to turn random function on or off while using CD or USB/SD. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 17 5 6 7 8 5 6 7 8 C D F A B E While using an iPod, press to shuffle all tracks. Press and hold to switch the control mode while using an iPod. For details, refer to Operating this unit’s iPod function from your iPod. If using the iPod with an interface adapter (CD-IB100 ), press to switch the shuffle function. e DISP/BACK/SCRL button Press to select different displays. Press and hold to scroll through the text in- formation. Press to return to the previous display when operating the menu. Press and hold to return to the main menu when operating the menu. f BAND/ESC button Press to select among three FM bands and MW/LW bands. Press to return to the ordinary display when operating the menu. Optional remote control The remote control CD-R320 is sold separately. Operation is the same as when using the but- tons on the head unit. h VOLUME buttons Press to increase or decrease the volume. i / / / buttons Press to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. j AUDIO button Press to select an audio function. k button Press to turn pause on or off. l FUNCTION button Press to select functions. m LIST/ENTER button Press to display the disc title list, track title list, folder list, file list or preset channel list depending on the source. While in the operating menu, press to con- trol functions. Display indication 1 2 4 6 8 a c e g hij k 3 5 7 9 b d 1 Main display section Displays band, frequency, elapsed playback time and other settings. • Tuner Band and frequency are displayed. • RDS Program service name, PTY information and other literal information are dis- played. • Built-in CD player, external storage de- vice (USB), iPod Elapsed playback time and literal infor- mation are displayed. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 18 1 2 3 4 1 2 3 4 C D F A B E 2 indicator Appears when an upper tier of folder or menu exists. 3 (list) indicator Appears when operating list function. 4 indicator Appears when a lower tier of folder or menu exists. 5 (artist) indicator Appears when the disc (track) artist name is displayed on the main display section. Appears when artist search refinement on the iPod browsing function is in use. 6 (disc) indicator Appears when the disc (album) name is dis- played on the main display section. Appears when album search refinement on the iPod browsing function is in use. 7 (song) indicator Appears when the track (song) name is dis- played on the main display section. Appears when song search refinement on the iPod browsing function is in use. 8 (subwoofer) indicator Appears when subwoofer is on. 9 LOC indicator Appears when local seek tuning is on. a (loudness) indicator Appears when loudness is on. b (TA) indicator Appears when TA (traffic announcement standby) function is on. c (TP) indicator Appears when a TP station is tuned in. d (AF) indicator Appears when AF (alternative frequencies search) function is on. e (stereo) indicator Appears when the selected frequency is being broadcast in stereo. g (folder repeat) indicator Appears when folder repeat is on. When repeat function is on, only is dis- played. h (folder random) indicator Appears when folder random is on. When random function is on, only is dis- played. i (shuffle) indicator Appears when shuffle function is on while iPod source is being selected. j S.Rtrv indicator Appears when Sound Retriever function is on. For details, refer to Using Sound Retriever. k indicator Appears when CONTROL(control mode) is set to IPOD. For details about the control mode, refer to Operating this unit’s iPod function from your iPod. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 19 5 6 7 8 5 6 7 8 C D F A B E DEH-3100UB/XS/ES What ’s what Head unit 1 7 8 a 23 4 5 6 b c d e f 9 1 SRC/OFF button This unit is turned on by selecting a source. Press to cycle through all the available sources. 2 /LIST button Press to display the track title list, folder list, file list or preset channel list depending on the source. Press and hold to switch to link play mode while using an iPod. For details, refer toSelecting songs from lists related to the currently playing song. 3 S.Rtrv button Press to switch Sound Retriever settings. For details, refer to Using Sound Retriever. 4 MULTI-CONTROL Move to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. Turn to increase or decrease the volume. 5 SW/BASS button Press to switch to subwoofer setting menu. When operating subwoofer menu, press to switch menu. Press and hold to switch to bass boost menu. 6 Disc loading slot Insert a CD/CD-R/CD-RW to play. 7 (eject) button Press to eject a CD/CD-R/CD-RW. 8 USB port Use to connect a USB storage device. • When connecting, open up the USB con- nector lid. • Use a USB cable to connect the USB sto- rage device to the USB port. Since the USB storage device is projected forward from the unit, it is dangerous to connect directly. Pioneer CD-U50E USB cable is also avail- able. For details, consult your dealer. 9 (detach) button Press to remove the front panel from the head unit. a AUX input jack (3.5 mm stereo jack) Use to connect an auxiliary device. b CLOCK/DISP OFF button Press to change to the clock display. Press and hold to turn the display indication and button illumination off or on. c (repeat)/LOC button Press to switch the repeat play range while using CD, USB/SD or iPod. Press to switch local settings while using tuner as the source. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 20 1 2 3 4 1 2 3 4 C D F A B E d (random)/iPod button Press to turn random function on or off while using CD or USB/SD. While using an iPod, press to shuffle all tracks. Press and hold to switch the control mode while using an iPod. For details, refer to Operating this unit’s iPod function from your iPod. e DISP/BACK/SCRL button Press to select different displays. Press and hold to scroll through the text in- formation. Press to return to the previous display when operating the menu. Press and hold to return to the main menu when operating the menu. f BAND/ESC button Press to select among three FM bands and one AM band. Press to return to the ordinary display when operating the menu. Remote control Operation is the same as when using the but- tons on the head unit. h VOLUME buttons Press to increase or decrease the volume. i MUTE button Press to turn off the sound. To turn on the sound, press again. j / / / buttons Press to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. k AUDIO button Press to select an audio function. l button Press to turn pause on or off. m FUNCTION button Press to select functions. n LIST/ENTER button Press to display the disc title list, track title list, folder list, file list or preset channel list depending on the source. While in the operating menu, press to con- trol functions. Display indication 1 2 4 6 8 a e gh 3 5 7 9 b d f 1 Main display section Displays band, frequency, elapsed playback time and other settings. • Tuner Band and frequency are displayed. • Built-in CD player, external storage de- vice (USB), iPod Elapsed playback time and literal infor- mation are displayed. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 21 5 6 7 8 5 6 7 8 C D F A B E 2 indicator Appears when an upper tier of folder or menu exists. 3 (list) indicator Appears when operating list function. 4 indicator Appears when a lower tier of folder or menu exists. 5 (artist) indicator Appears when the disc (track) artist name is displayed on the main display section. Appears when artist search refinement on the iPod browsing function is in use. 6 (disc) indicator Appears when the disc (album) name is dis- played on the main display section. Appears when album search refinement on the iPod browsing function is in use. 7 (song) indicator Appears when the track (song) name is dis- played on the main display section. Appears when song search refinement on the iPod browsing function is in use. 8 (subwoofer) indicator Appears when subwoofer is on. 9 LOC indicator Appears when local seek tuning is on. a (loudness) indicator Appears when loudness is on. b (stereo) indicator Appears when the selected frequency is being broadcast in stereo. d (folder repeat) indicator Appears when folder repeat is on. When repeat function is on, only is dis- played. e (folder random) indicator Appears when folder random is on. When random function is on, only is dis- played. f (shuffle) indicator Appears when shuffle function is on while iPod source is being selected. g S.Rtrv indicator Appears when Sound Retriever function is on. For details, refer to Using Sound Retriever. h indicator Appears whenCONTROL(control mode) is set to IPOD. For details about the control mode, refer to Operating this unit’s iPod function from your iPod. Fastening the front panel If you do not plan to detach the front panel, the front panel can be fastened with supplied screw. Screw Screw Parts No. DEH-P310UB/XS/UC BPZ20P060FTC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 BPZ20P080FTC DEH-3100UB/XS/ES CXX2204 (Service) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 22 1 2 3 4 1 2 3 4 C D F A B E 2.4 CONNECTION DIAGRAM DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC When not connecting a rear speaker lead to a subwoofer This product Rear output or subwoofer output Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Front output Antenna jack Fuse (10 A) IP-BUS input (Blue) IP-BUS cable Multi-CD player (sold separately) Connect with RCA cables (sold separately) To front output To rear output or subwoofer output Power amp (sold separately) Power amp (sold separately) Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). System remote control Yellow Connect to the constant 12 V supply terminal. Red Connect to terminal controlled by ignition switch (12 V DC). Black (chassis ground) Connect to a clean, paint-free metal location. Perform these connections when using the optional amplifier. Left Front speaker Rear speaker Right Front speaker Rear speaker White Gray Gray/black White/black Green Violet Green/black Violet/black Rear speaker or subwoofer Rear speaker or subwoofer Front speaker Front speaker With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. DEH-P310UB/XS/UC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 23 5 6 7 8 5 6 7 8 C D F A B E When using a subwoofer without using the optional amplifier This product Front output Antenna jack Subwoofer output Fuse (10 A) IP-BUS input (Blue) IP-BUS cable Multi-CD player (sold separately) Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Note: Change the initial setting of this unit. The subwoofer output of this unit is monaural. Yellow Connect to the constant 12 V supply terminal. Red Connect to terminal controlled by ignition switch (12 V DC). Black (chassis ground) Connect to a clean, paint-free metal location. Left Right r e k a e p s t n o rF r e k a e p s t n o rF White Gray Gray/black White/black Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). Green Violet Green/black Violet/black Subwoofer (4 4 ( r e f o o w b u S ) ) When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything with Green and Green/black leads. Not used. Green Violet Green/black Violet/black Subwoofer (4 ) x 2 DEH-P310UB/XS/UC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 24 1 2 3 4 1 2 3 4 C D F A B E DEH-P3100UB/XS/EW5 1* 3* 2* 4* 5* 9. Note Depending on the kind of vehicle, the function of 3* and 5* may be different. In this case, be sure to connect 2* to 5* and 4* to 3*. 5. Wired remote input Hard-wired remote control adaptor can be connected (sold separately). 3. Fuse (10 A) 2. Antenna jack 6. This product 1. Rear output or subwoofer output 23.To Rear output or subwoofer output 4. IP-BUS input (Blue) 7. IP-BUS cable 8. Multi-CD player (sold separately) 25. Power amp (sold separately) 24. Connect with RCA cables (sold separately) 10. Connect leads of the same color to each other. 11. Cap (1*) Do not remove cap if this terminal is not in use. 12. Yellow (3*) Back-up (or accessory) 13. Yellow (2*) Connect to the constant 12 V supply terminal. 27. Left 28. Right 26. System remote control 14. Red (5*) Accessory (or back-up) 15. Red (4*) Connect to terminal controlled by ignition switch (12 V DC). 19. Blue/white Connect to system control terminal of the power amp (max. 300 mA 12 V DC). 20. Blue/white (7*) Connect to auto-antenna relay control terminal (max. 300 mA 12 V DC). 29.Rear speaker or subwoofer 29.Rear speaker or subwoofer 30. Perform these connections when using the optional amplifier. 31. Notes • Change the initial setting of this unit (refer to the operation manual). The subwoofer output of this unit is monaural. • When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything with Green and Green/black leads. The pin position of the ISO connector will differ depends on the type of vehicle. Connect 6* and 7* when Pin 5 is an antenna control type. In another type of vehicle, never connect 6* and 7*. 21. Blue/white (6*) 17. ISO connector Note In some vehicles, the ISO connector may be divided into two. In this case, be sure to connect to both connectors. 22. Speaker leads White: Front left White/black: Front left Gray: Front right Gray/black: Front right Green: Rear left or subwoofer Green/black:Rear left or subwoofer Violet: Rear right or subwoofer Violet/black: Rear right or subwoofer 18. Yellow/black If you use an equipment with Mute function, wire this lead to the Audio Mute lead on that equipment. If not, keep the Audio Mute lead free of any connections. 16. Black (chassis ground) Connect to a clean, paint-free metal location. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 25 5 6 7 8 5 6 7 8 C D F A B E DEH-3100UB/XS/ES 23. To rear output or subwoofer output 26. Power amp (sold separately) 1. This product 4. Front output 5. Fuse (10 A) 2. Rear output or subwoofer output 6. Wired remote input Hard-wired remote control adaptor can be connected (sold separately). 3. Antenna jack 25. Connect with RCA cables (sold separately) 24. To front output 26. Power amp (sold separately) 29. Perform these connections when using the optional amplifier. 28. System remote control 27. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). r e k a e p s t n o rF . 4 1 r e k a e p s t n o rF . 4 1 30. Rear speaker or subwoofer 30. Rear speaker or subwoofer 7. Yellow Connect to the constant 12 V supply terminal. 8. Red Connect to terminal controlled by ignition switch (12 V DC). 9. Black (chassis ground) Connect to a clean, paint-free metal location. t h g i R . 6 1 tf e L . 5 1 22. With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. 14. Front speaker 21. Rear speaker 10. White 12. Gray 13. Gray/black 11. White/black 17. Green 19. Violet 18. Green/black 20. Violet/black 14. Front speaker 21. Rear speaker www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 26 1 2 3 4 1 2 3 4 C D F A B E 1. This product 4. Front output 3. Antenna jack 5. Fuse (10 A) 31. Subwoofer output 33. Subwoofer (4 ) 34. When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything with Green and Green/black leads. 36. Subwoofer (4 ) x 2 35. Not used. 32. Note Change the initial setting of this unit. The subwoofer output of this unit is monaural. 7. Yellow Connect to the constant 12 V supply terminal. 8. Red Connect to terminal controlled by ignition switch (12 V DC). 9. Black (chassis ground) Connect to a clean, paint-free metal location. 15. Left 16. Right 14. Front speaker 10. White 12. Gray 13. Gray/black 11. White/black 17. Green 19. Violet 18. Green/black 20. Violet/black 14. Front speaker 27. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). 33. Subwoofer (4 ) 17. Green 19. Violet 18. Green/black 20. Violet/black 6. Wired remote input Hard-wired remote control adaptor can be connected (sold separately). www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 27 5 6 7 8 5 6 7 8 C D F A B E 3. BASIC ITEMS FOR SERVICE 3.1 CHECK POINTS AFTER SERVICING To keep the product quality after servicing, please confirm following check points. d e m rif n o c e b o t m e tI s e r u d e c o r P . o N 1 Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. The customer complain must not be reappeared. Display, audio and operations must be normal. 2 CD Play back a CD. (Track search) No malfunction on display, audio and operation. 3 FM/AM tuner Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Display, audio and operations must be normal. 4 Check whether no disc is inside the product. The media used for the operating check must be ejected. r e tf a e c n a r a e p p a sti n o trid r o s e h ct a r c s o N k c e h c e c n a r a e p p A 5 receiving it for service. See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 28 1 2 3 4 1 2 3 4 C D F A B E 3.2 PCB LOCATIONS A B Keyboard Unit CD Core Unit (S10.5iPod-C3-CLASS1) C Tuner Amp Assy A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES Unit Number : YWM5360(A) Unit Number : YWM5361(B) Unit Number : YWM5359(C) Unit Number : YWM5362(D) Unit Name : Tuner Amp Assy Unit Number : (A) Unit Number : (B) Unit Number : (C) Unit Number : (D) Unit Name : Keyboard Unit Unit Number : CWX3727 Unit Name : CD Core Unit(S10.5iPod-C3-CLASS1) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 29 5 6 7 8 5 6 7 8 C D F A B E 3.3 JIGS LIST 3.4 CLEANING - Jigs List Name Test Disc L.P.F. Jig No. TCD-782 Remarks Checking the grating Checking the grating (Two pieces) Name Jig No. Remarks - Grease List Name Grease Grease Grease No. GEM1024 GEM1045 Remarks CD Mechanism Module CD Mechanism Module Name Grease No. Remarks Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 30 1 2 3 4 1 2 3 4 C D F A B E 4. BLOCK DIAGRAM PICKUP UNIT (P10.5)(SERVICE) CD CORE UNIT(S10.5iPod-C3-CLASS1) C BRST,BRXEN,BSRQ CN701 Q101 M LD MD S903 DSCSNS SPINDLE MOTOR M LOADING/CARRIAGE MOTOR LD- MD 15 5 HOLOGRAM UNIT IC301 BA5839FP IC201 PE5661A RF AMP, CD DECODER, MP3&WMA DECODER DIGITAL SERVO/DATA•PROCESSOR CPU, USB HOST CONTROLLER ACTUATOR/ MOTOR DRIVER 2 VD VD 13 9 LOUT VDD CN101 16 SOP 15 SOM 18 LCOP 17 LCOM 21 CLCONT 55 LOUT 9 CONT TD,FD AC,BD,E,F SD,MD S901 HOME S904 12EJ S905 8EJ LD+ 14 141 LD 142 PD 12EJ CONT CLCONT HOME 8 9 20 41 VDD 1 VDD2 BDATA,BSCK 15 5 FOCUS ACT. TRACKING ACT. FOP TOP 2 1 TOP FOP 11 FOP 14 TOP 2 1 14 8EJ 7 DSCSNS 10 16 /RESET 8 /RESET 8 8 VREF REFO 133 REFOUT 3 3 FOM FOM 12 FOM 4 4 TOM TOM 13 TOM 22 LOEJ LOEJ 28 52 50 X201 XTAL /XTAL 16.93MHz VDSENS 11 VD 16 17 DP DM 4 5 DM DP 2 1 X205 48MHz USBXTAL /USBXTAL VDD2 Q102 39 /PUEN VCC VDD2 IC205 341S2159 iPod CP CPRDY,CPRST SDA,SCL ASENBO 41 MUTE 49 40 30 29 54 CN401 1 2,3 TX RX IPPW SWVDD TUNER AMP ASSY 3 ROT1 4 ROT0 51 ILMPW A B- B14 B+ IN1+ CN101 IN1- IP-BUS DRIVER IC101 HA12241FP 1 2 8 6 5 B.UP Q101 VDD ANTENNA USBCTL FLG VD CN701 VDD VDD3.3V CDL Q102 CD VD VD DP DM VDCONT B.UP Q702 Q701 BRST,BRXEN,BSRQ,BDATA,BSCK 11 7 18 12 CDRST 19 4 3 26 SYNC B.UP USB5V IC702 NJM2885DL1-33 CD3.3V 3 1 CDRST 23 21 VCC 5 1 8 EN/SYNC PVIN VIN SW 2 USB5V IC501 BD9007F CDVDD SYSPW 48 24 25 7 11 5 1 8 IP BUS BUS- BUS+ DIN1 ROUT STBY 27 RX2 TUNPDO LDET TUNPCK TUNPDI CE1 CE2 SL 93 JOYST 92 SSENS 32 KYDT 31 DPDT 19 DSENS A B C SYSTEM CONTROLLER IC 601(1/2) A C D B PEG516A8: PEG513A8: PEG517A: :DEH-P310UB/XS/UC :DEH-P3100UB/XS/UC :DEH-P3100UB/XS/EW5 :DEH-3100UB/XS/ES A B C D FMRF ANT adj RF adj FM ANT T51 CF52 RFGND OSCGND DGND AUDIOGND NC VCC VDD_3.3 3.3V 2.5V IC4 3.3V 2.5V IC2 2.5V NC CE2 ROM_VDD SL DI CK CE1 LDET DO RDS_CK RDS_DATA RDS_LOCK RDS_HSLK RDS_CK RDS_DATA RDS_LOCK RDS_HSLK 7 6 13 5 10 9 8 11 14 18 19 20 21 1 3 2 12 15 22 16 4 17 IC1 3.3V AM ANT FMRF ATT LPF OSC IC3 EEPROM 5.0V IC5 5V 3.3V ATT MIXER, IF AMP DET, FM MPX, RDS DECODER 23 Lch FM/AM TUNER UNIT → → www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 31 5 6 7 8 5 6 7 8 C D F A B E BSENS ASENS B.UP 20 18 O 10 Front_L 11 Rear_L 41 MUTE ILM+B SW5V VBUS D+ D- 21 23 5 3 FL+ FL- RL+ RL- ACC IN2_L 49 IN4+_L 3 IN4-_L 4 IN1_L 7 FLIN 14 RLIN VCC 12 6,20 22 AMP IC151 PML018A IC301 PAL007C VDD Q911 Q401 Q402 Q931 ELECTRONIC VOLUME/ SOURCE SELECTOR SWVDD STBY MUTE Q851 Q852 VST,VCK,VDT TUNL BUSL+ BUSL- CDL ROT1 3 ROT1 4 ROT0 ROT0 MUTE Q451 SWL Q351 Pre/SW_L 51 ILMPW MUTE Q453 SYSTEM CONTROLLER IC 601(2/2) 25 B.REM VDD BSENS ASENS CN901 B.UP CN351 DALMON 47 SWL TELIN 42 USBCTL FLG VDD CN803 US5V 5 TEL GND B.UP T FL1 FL2 RL1 RL2 BREM 14 6 8 7 5 16 11 15 9 1 IN5-_L 6 AUXL ILM SWVDD 12 PEE 22 BZ601 BUZZER XIN XOUT 15 X601 15MHz 13 IC401 NJM2885DL1-33 1 3 VCC VDD3.3V VDD3.3V Q353 6 MUTE RCFL FL IN5+_L 2 SYSPW 48 24 25 AUXG B. UP Q841 Q842 RCA OUT SL TUNPCE2 TUNPCE1 TUNPDI TUNPDO 97 65 66 68 69 TUNPCK 67 CE2 CE1 TUNPDO TUNPDI TUNPCK SL LDET 74 LDET RDSLK 76 RDS_LOCK RDSDT 77 RDS_DATA RDS57K 78 RDS_HSLK RCK 73 RDS_CK 12 1 VDD RESET IC961 S-80835CNMC-B8U RESET 2 Q912 TEL MUTE Q951 AUXL AUXG KEYD KEYAD CN621 3 2 1 KEY2 34 94 KEY1 WIRED REMOTE POWER CONNECTOR B.UP 7 17 3 16 JOYST 93 JOYST 92 SSENS SOURCE 4 8 KYDT 32 KYDT 31 DPDT DPDT 19 19 DSENS DSENS 20 18 6 15 14 12 13 5 1 3 4 US5V US5V IC251 BD6538G USB5V VIN EN OC VOUT A C D C C A B D C A C D B B C SYSTEM CONTROLLER IC 601(1/2) A C D B G516A8: G513A8: G517A: 1 2 4 B.UP VCC8.4V IC921 NJM2388F84 VCC VOUT CONTROL VIN PEG516A8: PEG513A8: PEG517A: 23 Lch FRONT AUX ILLUMI D5-D14 7 CN4 CN3 USB CN2 IC2 GP1UXC14RK LCD REMOTE CONTROL SENSOR 14 17 8 18 4 3 20 19 D+ 16 6 3 1 2 15 57 D+ D- 46 1 47 3 49 9 1 58 50 D3 D15 Q4 Q7 12 D- 13 KST1-3, KDT1-3 TXD RXD REM VCC V3 ROUT2 LCD DRIVER/ KEY CONTROLLER IC1 PD6538A ROTARY COMMANDER S28 AUXL AUXR AUXG 2 3 1 AUXL AUXG KYDT SOURCE JOYST ROT0 ROT1 DPDT SW5V DSEN VBUS(US5V) ILM+B KEYBOARD UNIT B SW5V US5V US5V X0 X1 54 X1 55 KEY MATRIX S2 DISP S8 S7 CLOCK/ DISP OFF : TA/NEWS : BAND S1 RDM S9 S6 RPT LIST S4 S10 EJECT S.Rtrv A C B D S5 SW/BASS : MUTE : A C B D S3 SRC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 32 1 2 3 4 1 2 3 4 C D F A B E SEGMENT COMMON LCD (YAW5101) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 33 5 6 7 8 5 6 7 8 C D F A B E 5. DIAGNOSIS 5.1 OPERATIONAL FLOWCHART Vcc = 5 V Pin 16 BSENS Pin 18 ASENS Pin 20 DSENS Pin 19 ASENBO <- H Pin 40 BSENS = L DSENS = L Starts communication with Grille microcomputer. SWVDD <- H Pin 49 Source keys operative Source ON SYSPW <- H Pin 48 300 m 300 m Completes power-on operation. (After that, proceed to each source operation) In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 300 msec, the oscillator may be defective. Power ON ASENS = L www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 34 1 2 3 4 1 2 3 4 C D F A B E 5.2 ERROR CODE LIST - Error Messages If a CD is not operative or stopped during operation due to an error, the error mode is turned on and cause(s) of the error is indicated with a corresponding number. This arrangement is intended at reducing nonsense calls from the users and also for facilitating trouble analysis and repair work in servicing. (1) Basic Indication Method 1) When SERRORM is selected for the CSMOD (CD mode area for the system), error codes are written to DMIN (minutes display area) and DSEC (seconds display area). The same data is written to DMIN and DSEC. DTNO remains in blank as before. 2) Head unit display examples Depending on display capability of LCD used, display will vary as shown below. xx contains the error number. 8-digit display 6-digit display 4-digit display ERROR-xx ERR-xx E-xx (2) Error Code List Code Class Displayed error code Description of the code and potential cause(s) 10 Electricity Carriage Home NG CRG can't be moved to inner diameter. SERVO LSI Com- CRG can't be moved from inner diameter. munication Error -> Failure on home switch or CRG move mechanism. Communication error between microcomputer and SERVO LSI. 11 Electricity Focus Servo NG Focusing not available. -> Stains on rear side of disc or excessive vibrations on REWRITABLE. 12 Electricity Spindle Lock NG Spindle not locked. Sub-code is strange (not readable). Subcode NG -> Failure on spindle, stains or damages on disc, or excessive vibrations. A disc not containing CD-R data is found. Turned over disc are found, though rarely. CD signal error. 17 Electricity Setup NG AGC protection doesn't work. Focus can be easily lost. -> Damages or stains on disc, or excessive vibrations on REWRITABLE. 30 Electricity Search Time Out Failed to reach target address. -> CRG tracking error or damages on disc. 44 Electricity ALL Skip Skip setting for all track. (CD-R/RW) 50 Mechanism CD On Mech Error Mechanical error during CD ON. -> Defective loading motor, mechanical lock and mechanical sensor. A0 System Power Supply NG Power (VD) is ground faulted. -> Failure on SW transistor or power supply (failure on connector). Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 35 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 36 1 2 3 4 1 2 3 4 C D F A B E 5.3 CONNECTOR FUNCTION DESCRIPTION 1. BUS1 2. GND 3. GND 4. NC 5. BUS2 6. GND 7. BUSL1 8. ASENB1 9. BUSR1 10. BUSR2 11. BUSL2 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 1. FR+ 2. RR+ 3. FR- 4. RR- 5. FL+ 6. RL+ 7. FL- 8. RL- 9. TEL 10. NC 11. BREM 12. NC 13. A.ANT 14. ACC 15. GND 16. BUP IP-BUS INPUT (DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5) SUBWOOFER OUTPUT FRONT OUTPUT (DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-3100UB/XS/ES) WIRED REMOTE CONTROL (DEH-P310UB/XS/UC, DEH-P3100UB/XS/EW5, DEH-3100UB/XS/ES) ANTENNA www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 37 5 6 7 8 5 6 7 8 C D F A B E 6. SERVICE MODE 6.1 DISPLAY TEST MODE To enter the test mode During pressing the "DISP" and "SW(MUTE)" keys simultaneously, perform the reset-start, then turn ON the Source to enter the Display test mode. Operation method *1) System version display: When System version display, the PD number, the system microcomputer version and the CWW number is displayed. Example) For PEG123A, VER1.02, CWW1111 *2) ROM Correction version display: Normally read: Caution: H123 : ROM Correction Ver.Info CH1 - CH4 : Usage condition of ROM Correction CH (using:X / Not used:0) When ROM Correction itself didn't exist: When check sum is a disagreement: *3) LCD check mode 1 *4) LCD check mode 2 *5) LCD check mode 3 Display test mode System version display (*1) ROM Correction version display (*2) Normal display Display stop All lighting of display All lights out of display LCD check mode 1 (*3) LCD check mode 2 (*4) LCD check mode 3 (*5) Return to top DISP + SW(MUTE) Key DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) DISP + SW(MUTE) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 38 1 2 3 4 1 2 3 4 C D F A B E 6.2 CD TEST MODE During pressing the "BAND" and "S.Rtrv" keys simultaneously, perform the reset-start, then turn ON the CD to enter the CDS test mode. How to issue the 1 - 6 keys in the slave test: The specification of the model does not include the 1 - 6 keys issuance function for H/U and the remote control unit. Therefore, in order to issue commands in a slave test, use the direct FUNCTION keys alternatively to enable the equal key command sending function to the existing models. Outline) Use the direct FUNCTION keys to display, select, or issue the KEY 1 - 6. *) For convenience, a name of each direct FUNCTION key is shown as "A", "B", and "C". How to issue the 1 - 6 keys for the CDS source: (The areas below are overwritten and displayed on character strings for the normal mode display.) 1 During the slave test mode, the key name "K1" is shown at the left by default. In this condition, press the A key to toggle K1 - K6, and select a command to be sent to the slave. SECOND MINUTE K R T R E D L O F A key 2 During the K1 - K6 key names are displayed, press the B key and issue the selected command. Send a key command selected K 1 T by pressing the KEY 1. B key 3 Press the C key to change display/non-display of key names. When the non-display mode is selected for the K1 - K6 key names, "A key" and "B key" are invalid. C key *) Pressing the A key or B key does not work. Normal mode Issuing a key command S.Rtrv/FUNC1 B RDM/SHFL/FUNC2 Slave test mode A BAND + S.Rtrv Switching a screen Direct FUNCTION key S.Rtrv/SAT Key RPT/LOCAL RDM/SHFL C LOCAL/RPT/FUNC3 Issuing a key command www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 39 5 6 7 8 5 6 7 8 C D F A B E [Key] Contents Display [BAND] + [S.Rtrv] + Reset or [BAND] + [S.Rtrv] + BU + ACC Test Mode In [CD] or [SOURCE] Source On TRK MIN SEC [BAND] Power On (T.Offset is adjusted) TRK MIN SEC 00 00 00 [3] Power On (T.Offset is not adjusted) 99 99 99 [2] RF AMP Gain switching GG GG GG *1 [4] SPINDLE Speed switching SP SP SP *9 [3] Focus Close S curve check TRK MIN SEC 91 91 91 [6] Focus Mode switching 0X 0X 0X *2 [1] Tracking Servo Close 00 00 00 or 99 99 99 [>] CRG + [2] Self-adjusting switching TRK MIN SEC ?? ?? ?? *3 *8 [<] CRG - *8 [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [1] T.Close & AGC Applicable servomechanism TRK MIN SEC ?tr ?min ?sec [6] [3] RF AGC / RF AGC coefficient display [>] CRG + 8X 8X 8X or 9X 9X 9X [2] T.Balance adjustment / T.BAL coefficient display TRK MIN SEC ?? ?? ?? [<] CRG - T.Close Applicable servomechanism ?? ?? ?? [1] F,T,RF AGC F.Bias display switching TRK MIN SEC TRK MIN SEC TRK MIN SEC TRK MIN SEC ?tr ?min ?sec TRK MIN SEC [3] [6] CRG/TR jump value switching [>] CRG/TR Jump + [2] Tracking Open [<] CRG/TR Jump - ?tr ?min ?sec TRK MIN SEC TRK MIN SEC TRK MIN SEC ?tr ?min ?sec 00 00 00 or 99 99 99 TRK MIN SEC TRK MIN SEC ?tr ?min ?sec 8X 8X 8X or 9X 9X 9X 8X 8X 8X or 9X 9X 9X 00 00 00 or 99 99 99 TRK MIN SEC ?tr ?min ?sec ?? ?? ?? *7 F,T AGC / F.Bias RF AGC 8X 8X 8X or 9X 9X 9X [2] Tracking Open *6 *5 *4 *4 Operation [Key] Test Mode [BAND] Power On/Off [>] CRG + / TR Jump + (Direction of the external surface) [<] CRG - / TR Jump - (Direction of the internal surface) [1] T. CLS & AGC & Applicable servomechanism / AGC,AGC display setting [2] RF Gain switching / Offset adjustment display / T.Balance adjustment / T. Open [3] F. Close,S Curve / Rough Servo and RF AGC / F,T,RF AGC [4] SPDL 1X/2X switching As for the double speed(2x), audio output cannot be supported. [5] Error Rate measurement ON : ERR 30 Counts Start BER display data[%] [6] F. Mode switching / Tracking Close / CRG•TR Jump Switching • As for the double speed (2x), audio output cannot be supported • After the [Eject] key is pressed keys other than the [Eject] key should not be pressed, until disc ejection is complete. • When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks to Wall, causing the actuator to be damaged). • In the case of TR jump other than to 100TR, the function shall continue to be processed even if the TR jump key is released. As for the CRG Move and 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released. • When the power is turned on/off the jump mode is reset to the Single TR (91) while the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. *10 TRK MIN SEC [5] Gop Mode Gop Mode switching OL OL OL - Flow Chart *1) TYP -> + 6 dB -> + 12 dB TRK MIN SEC TRK06MIN06SEC06 TRK12MIN12SEC12 *2) Focus Close -> S.Curve -> F EQ measurement setting TRK00MIN00SEC00 TRK01MIN01SEC01 TRK02MIN02SEC02 (TRK99MIN99SEC99) *3) F.Offset Display -> RF.Offset -> T.Offset Display -> Switch to the order of the original display *4) 1TR/4TR/10TR/32TR/100TR *5) Single -> 4TR -> 10TR -> 32TR -> 100TR -> CRG Move 9x(8x):91(81) 92(82) 93(83) 94(84) 95(85) 96(86) *6) Only at the time of CRG move, 100TR jump *7) TRK/MIN/SEC -> F.AGC -> T.AGC Gain -> F Bias -> RF AGC *8) CRG motor voltage = 2 [V] *9) TYP (1X) -> 2X -> 1X TRK MIN SEC TRK22MIN22SEC22 TRK11MIN11SEC11 *10) OFF(TYP) -> FORCUS -> TRACKING TRK MIN SEC TRK70MIN70SEC70 TRK71MIN71SEC71 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 40 1 2 3 4 1 2 3 4 C D F A B E 7. DISASSEMBLY 2 1 2 3 Fig.1 Fig.2 - Removing the CD Mechanism Module (Fig.1) CD Mechanism Module - Removing the Tuner Amp Unit (Fig.2) 1. Remove the Case. Remove the three screws. Remove the screw. Straighten the tabs at four locations indicated and then remove the Tuner Amp Unit. 1 2 1 1 2 2 Disconnect the connector and then remove the CD Mechanism Module. Tuner Amp Unit 1 Release the three latches and then remove the Panel Assy. Remove the four screws. - Removing the Case (not shown) Panel Assy 1 3 3 2 2 3 3 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 41 5 6 7 8 5 6 7 8 C D F A B E A A B B B B B a B Upper Frame Lower Frame Damper Carriage Mechanism Damper Do not squeeze this area. - How to hold the Mechanism Unit - Removing the Upper and Lower Frames 1. With a disc inserted and clamped in the mechanism, remove the two Springs (A), the six Springs (B), and the four Screws. 2. Turn the Upper Frame using the part "a" as a pivot, and remove the Upper Frame. 3. While lifting the Carriage Mechanism, remove it from the three Dampers. Caution: When assembling, be sure to apply some alcohol to the Dampers and assemble the mechanism in a clamped state. 1. Hold the Upper and Lower Frames. 2. Do not hold the front portion of the Upper Frame, because it is not very solid. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 42 1 2 3 4 1 2 3 4 C D F A B E Screw Shorting Solder CD Core Unit Solder - How to remove the CD Core Unit 1. Apply Shorting Solder to the flexible cable of the Pickup, and disconnect it from the connector. 2. Unsolder the four leads, and loosen the Screw. 3. Remove the CD Core Unit. Caution: When assembling the CD Core Unit, assemble it with the SW in a clamped state so as not to damage it. Chassis Pickup Rack Pickup Poly Washer Change Arm Pickup Lock Arm Feed Screw Inner Holder Planet Gear - How to remove the Pickup Unit 1. Make the system in the carriage mechanism mode, and have it clamped. 2. Remove the CD Core Unit and remove the leads from the Inner Holder. 3. Remove the Poly Washer, Change Arm, and Pickup Lock Arm. 4. While releasing from the hook of the Inner Holder, lift the end of the Feed Screw. Caution: When assembling, move the Planet Gear to the load/eject position before setting the Feed Screw in the Inner Holder. Assemble the sub unit side of the Pickup, taking the plate (Chassis) in-between. When treating the leads of the Load Carriage Motor Assy, do not make them loose over the Feed Screw. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 43 5 6 7 8 5 6 7 8 C D F A B E 8. EACH SETTING AND ADJUSTMENT 8.1 CD ADJUSTMENT 1) Cautions on adjustments In this product the single voltage (3.3 V) is used for the regulator. The reference voltage is the REFO1 (1.65 V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo’s misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately. Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on. In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFI and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. 2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. While pressing the 4 and 6 keys at the same time, reset. To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the (->) key or (<-) key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0 dB, and the auto-adjustment values are reset to the default settings. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 44 1 2 3 4 1 2 3 4 C D F A B E 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT CD CORE UNIT Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed. Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Oscilloscope, Two L.P.F. E, F, REFO1 Disc TCD-782 Mode TEST MODE Checking Procedure 1. In test mode, load the disc and switch the 3 V regulator on. 2. Using the -> and <- buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 degrees. Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 degrees try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 degrees then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble". 100 kohm 390 pF 100 kohm 390 pF E VREF F VREF Xch Ych L.P.F. L.P.F. Oscilloscope F E REFO1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 45 5 6 7 8 5 6 7 8 C D F A B E Grating waveform 45 degrees 0 degrees 75 degrees 60 degrees 30 degrees 90 degrees Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 46 1 2 3 4 1 2 3 4 C D F A B E 8.3 PCL OUTPUT CONFIRMATION - PCL output In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode cancelled), shift the STEST IC601(Pin 63) terminal to H. The clock signal is output from the PCL1 terminal IC601(Pin 39). The frequency of the clock signal is 468.750 Hz that is one 32th of the fundamental frequency. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 47 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 48 1 2 3 4 1 2 3 4 C D F A B E 9. EXPLODED VIEWS AND PARTS LIST 9.1 PACKING NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) " DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-3100UB/XS/ES DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 49 5 6 7 8 5 6 7 8 C D F A B E (1) PACKING SECTION PARTS LIST (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: Owner's Manual,Installation Manual Mark No. Description Part No. 1 Polyethylene Bag See Contrast table (2) * 2 Battery See Contrast table (2) 3 Remote Control Assy See Contrast table (2) 4 Cord Assy See Contrast table (2) 5 Cord Assy See Contrast table (2) 6 Accessory Assy See Contrast table (2) 7 Screw See Contrast table (2) 8 Polyethylene Bag CEG1160 9 Handle CND3707 10 Screw Assy See Contrast table (2) * 11 Polyethylene Bag CEG-127 12 Screw CRZ50P090FTC 13 Screw TRZ50P080FTC 14 Unit Box See Contrast table (2) 15 Contain Box See Contrast table (2) 16 Protector See Contrast table (2) 17 Protector See Contrast table (2) 18 Screw See Contrast table (2) 19 Bush See Contrast table (2) 20 Case Assy See Contrast table (2) 21-1 Caution Card See Contrast table (2) 21-2 Caution Card See Contrast table (2) * 21-3 Warranty Card See Contrast table (2) 21-4 Installation Manual See Contrast table (2) 21-5 Owner's Manual See Contrast table (2) 21-6 Owner's Manual See Contrast table (2) Mark No. Description Part No. Mark No. Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES 1 Polyethylene Bag CEG1173 CEG1173 CEG-162 CEG-162 * 2 Battery CEX1065 CEX1065 Not used CEX1065 3 Remote Control Assy CXC8885 CXC8885 Not used CXC8885 4 Cord Assy YDP5022 YDP5022 CDP1015 CDP1017 5 Cord Assy YDP5026 Not used Not used Not used 6 Accessory Assy *YEA5071 *YEA5071 *CEA6707 CEA9954 7 Screw BPZ20P060FTC BPZ20P060FTC BPZ20P080FTC Not used 10 Screw Assy YEA5072 YEA5072 CEA3849 CEA3849 14 Unit Box YHG5486 YHG5478 YHG5475 YHG5477 15 Contain Box YHL5486 YHL5478 YHL5475 YHL5477 16 Protector YHP5052 YHP5052 YHP5050 YHP5050 17 Protector YHP5053 YHP5053 YHP5051 YHP5051 18 Screw Not used Not used CBA1650 CBA1650 19 Bush Not used Not used CNV3930 CNV3930 20 Case Assy Not used Not used YXB5009 YXB5009 21-1 Caution Card CRP1387 CRP1387 Not used CRP1387 21-2 Caution Card Not used CRP1386 Not used Not used * 21-3 Warranty Card CRY1280 CRY1276 CRY1279 Not used 21-4 Installation Manual YRD5273 YRD5275 YRD5276 YRD5271 21-5 Owner's Manual YRD5272 YRD5274 YRD5277 YRD5269 21-6 Owner's Manual Not used Not used YRD5278 YRD5270 Part No. Language YRD5273 English, French,Spanish(Espanol) YRD5275 English, French,Spanish(Espanol) YRD5276 English, Spanish(Espanol), German, French, Italian, Dutch, Russian YRD5271 English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic YRD5272 English, French, Spanish(Espanol) YRD5274 English, French, Spanish(Espanol) YRD5277 English, Spanish(Espanol) YRD5278 German, French, Italian, Dutch. Russian YRD5269 English, Spanish(Espanol), Arabic YRD5270 Portuguese(B), Traditional Chinese www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 50 1 2 3 4 1 2 3 4 C D F A B E 9.2 EXTERIOR (1) A A A DEH-P3100UB/XS/EW5 DEH-P3100UB/XS/EW5 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 51 5 6 7 8 5 6 7 8 C D F A B E (1) EXTERIOR (1) SECTION PARTS LIST (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: Mark No. Description Part No. 1 Screw BSZ26P060FTC 2 Screw BSZ30P060FTC 3 Screw BSZ30P200FTC 4 Earth Plate CNC8915 5 Cushion CNM8890 6 CD Mechanism Module(S10.5) CXK5777 7 Cable YDE5030 8 Tuner Amp Assy See Contrast table (2) 9 Screw BPZ26P080FTC 10 Screw BSZ26P060FTC 11 Screw BSZ26P200FTC 12 Pin Jack(CN351) See Contrast table (2) 13 Plug(CN901) CKM1376 14 Connector(CN101) See Contrast table (2) 15 Connector(CN701) CKS3833 16 Connector(CN803) CKS6050 17 Antenna Jack(CN401) CKX1070 18 FM/AM Tuner Unit See Contrast table (2) 19 Holder CND4324 20 Holder XNC7030 > 21 Fuse(10 A) YEK5001 22 Jack(CN621) See Contrast table (2) 23 Holder See Contrast table (2) 24 Heat Sink YNR5128 25 Chassis Unit See Contrast table (2) 26 Button CAC4836 27 Spring CBH2367 28 Spring(Silver) CBH2961 29 Spring(Black) CBH2962 30 Arm CNV9312 31 Arm CNW1439 32 Cover YNN5016 33 Panel YNS5468 34 Screw See Contrast table (2) 35 Holder See Contrast table (2) 36 IC(IC301) PAL007C 37 IC(IC921) NJM2388F84 38 Transistor(Q702, Q911) 2SD2396 39 Screw See Contrast table (2) Mark No. Description Part No. Mark No. Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES 8 Tuner Amp Assy YWM5360 YWM5361 YWM5359 YWM5362 12 Pin Jack(CN351) CKB1054 CKB1054 CKB1056 CKB1054 14 Connector(CN101) CKS3408 CKS3408 CKS3408 Not used 18 FM/AM Tuner Unit CWE2098 CWE2098 CWE2097 CWE2098 22 Jack(CN621) YKS5002 Not used YKS5002 YKS5002 23 Holder YNC5041 YNC5079 YNC5042 YNC5055 25 Chassis Unit YXA5524 YXA5524 YXA5573 YXA5524 34 Screw Not used BMZ40P140FTC Not used Not used 35 Holder Not used CNV7619 Not used Not used 39 Screw BPZ26P080FTC Not used BPZ26P080FTC BPZ26P080FTC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 52 1 2 3 4 1 2 3 4 C D F A B E 9.3 EXTERIOR (2) B DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-3100UB/XS/ES DEH-P3100UB/XS/EW5 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 53 5 6 7 8 5 6 7 8 C D F A B E (1) EXTERIOR (2) SECTION PARTS LIST (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: Mark No. Description Part No. 1 Holder CND3598 2 Remote Control Assy See Contrast table (2) 3 Cover See Contrast table (2) 4 Cord Assy See Contrast table (2) 5 Case YNB5014 6 Panel YNS5517 7 Detachable Assy See Contrast table (2) 8 Screw BPZ20P100FTB 9 Spring CBH2210 10 Button(LIST, DISP) YAC5360 11 Button(DETACH) YAC5366 12 Button(EJECT) YAC5367 13 Button(UC:CLOCK, EW5/ES:TA)YAC5368 14 Cover YNS5429 15 Holder YNV5180 16 Connector(CN4) CKS6049 17 LCD(LCD1) YAW5101 18 Jack(CN3) YKN5006 19 Connector(CN2) YKS5032 20 Holder YNC5062 21 Sheet YNM5143 22 Cushion YNM5148 23 Connector YNV5140 24 Lighting Conductor YNV5173 25 Button Unit See Contrast table (2) 26 Knob Unit See Contrast table (2) 27 Spring YBL5013 28 Button Unit(SRC, BAND) YXA5567 29 Grille Unit See Contrast table (2) 30 ..... 31 ..... 32 Terminal Cover See Contrast table (2) 33 Remote IC(IC2) GP1UXC14RK Mark No. Description Part No. Mark No. Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES 2 Remote Control Assy CXC8885 CXC8885 Not used CXC8885 3 Cover CNS7068 CNS7068 Not used CNS7068 4 Cord Assy YDP5022 YDP5022 CDP1015 CDP1017 7 Detachable Assy YXA5534 YXA5528 YXA5533 YXA5536 25 Button Unit YXA5521 YXA5521 YXA5587 YXA5570 (S.Rtrv, SW, iPod, LOC) (S.Rtrv, SW, iPod, LOC) (S.Rtrv, MUTE, iPod, LOC) (S.Rtrv, SW, iPod, LOC) 26 Knob Unit YXA5522 YXA5523 YXA5522 YXA5522 29 Grille Unit YXA5592 YXA5591 YXA5593 YXA5594 32 Terminal Cover Not used Not used CKX-003 Not used www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 54 1 2 3 4 1 2 3 4 C D F A B E 9.4 CD MECHANISM MODULE B C A B C D E 5 19 A 19 5 5 5 19 19 27 48 29 13 13 66 44 44 72 8 15 60 46 33 62 38 39 40 28 4 47 17 37 14 12 35 6 45 52 53 65 64 18 32 41 5 61 49 8 51 55 51 56 59 43 10 20 57 16 25 58 31 23 69 71 70 70 63 73 21 7 19 24 19 24 67 4 36 68 50 (1) (1) (1) (1) (1) (1) (1) E 30 34 22 42 11 26 (1) (1) (1) (1) (1) (1) (1) (1) (1) (1) (1) (2) (2) (2) (1) (1) (2) (1) (2) (1) (1): GEM1024 : GEM1045 (2) (2) 1 2 3 74 D C 54 9 9 (1) (2) (2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 55 5 6 7 8 5 6 7 8 C D F A B E CD MECHANISM MODULE SECTION PARTS LIST Mark No. Description Part No. 1 CD Core Unit(S10.5iPod-C3-CLASS1) CWX3727 2 Connector(CN101) CKS4808 3 Connector(CN701) CKS5854 4 Screw BMZ20P025FTC 5 Screw BSZ20P040FTC 6 Screw(M2 x 3) CBA1511 7 Screw(M2 x 4) CBA1835 8 Washer CBF1038 9 Roller CNV9499 10 Spring CBH2609 11 Spring CBH2612 12 Spring CBH2614 13 Spring CBH2616 14 Spring CBH2617 15 Spring CBH2620 16 Spring CBH2855 17 Spring CBH2937 18 Spring CBH2735 19 Spring CBH2854 20 Spring CBH2642 21 Spring CBH2856 22 Spring CBH2857 23 Spring CBH2860 24 Spring CBH2861 25 Spring CBL1686 26 Arm CND1909 27 Frame CND2582 28 Bracket CND2583 29 Arm CND3831 30 Lever CND2585 31 Arm CND2586 32 Bracket CND2587 33 Arm CND2588 34 Lever CND2589 35 Holder CNV9522 36 Gear CNV7207 37 Gear CNV9513 38 Gear CNV7209 39 Gear CNV9514 40 Gear CNV9515 41 Gear CNV9516 42 Rack CNV9517 43 Arm CNV7216 44 Roller CNV8189 45 Gear CNV9518 46 Guide CNV9519 47 Gear CNV7595 48 Guide CNV9520 49 Arm CNV7805 50 Rack CNV8342 51 Roller CNV8343 52 Holder CNV8344 53 Arm CNV8345 54 Guide CNV9498 55 Arm CNV8348 56 Arm CNV8349 57 Arm CNV8350 58 Clamper CNV8365 59 Arm CNV8386 60 Guide CNV8396 61 Arm CNV9521 62 Collar CNV8447 63 Motor Unit(M2) CXC4026 64 Arm Unit CXC4027 65 Chassis Unit CXC4028 66 Gear Unit CXC4029 67 Frame Unit CXC4031 68 Motor Unit(M1) CXC7134 69 Screw Unit CXC6359 70 Screw JFZ20P025FTC 71 Screw JGZ17P022FTC 72 Washer YE20FTC 73 Pickup Unit(P10.5)(Service) CXX1942 74 Screw IMS26P030FTC Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 56 1 2 3 4 1 2 3 4 C D F A B E 10. SCHEMATIC DIAGRAM 10.1 TUNER AMP ASSY(GUIDE PAGE) A A-a A-a A-b A-a A-b A-b A-a Large size SCH diagram Guide page Detailed page Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". RDS-HSLK RDS-CK RDS-LOCK RDS-DATA TUNPDO VDCONT /BSRQ /BRST BRXEN BDATA CDRST BUSL+ BUSR+ BUSR- TUNR AUXR AUXL ROT1 ROT0 TX ASENBO SYSPW DALMON RX RX RST CE1 CE2 VST VCK IPPW ASENBO BUSL+ RX BUSR+ TX BUSR- BUSL- /BSENS FLG CDRST MUTE TELIN /BRST BRXEN /BSRQ SWVDD ILMPW VDT TUNPCK TUNPDO SD_CD RDS-LOCK RDS-DATA LDET USBCTL RDS-HSLK RDS-CK KEY2 KEY1 /DSENS TUNR TUNL USBCTL SW5V SOURCE ILM+B SL CE2 CE1 TUNPCK LDET SYNC BSCK FLG ILMPW USDM USDP VDCONT /ASENS SYNC BDATA BSCK DSENS KEY1 AUXG DPDT KYDT IPPW TUNPDI TUNPDI CN401 1 2 3 BZ601 1 1 2 2 CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 CN803 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 220u/16 C502 22u/10 C708 100u/10 C703 100u/10 C405 47u/6.3 C401 22u/10 C408 CCH1804-A C501 C101 0.1u/25 C103 NM C102 NM C503 33p/50 C609 47p/50 C604 C602 18p/50 C601 18p/50 C104 0.01u/50 C715 NM C716 NM C159 1u/10 C156 1u/10 C154 1u/10 1 /10 C157 1u/10 C152 1u/10 C151 1u/10 C701 0.047u/25 C702 NM C504 2.2u/16 C711 NM C710 0.47u/10 C252 1u/10 C709 1u/10 C707 NM C706 NM C705 1u/10 C704 1u/10 C410 0.47u/10 C505 NM C251 1u/10 C506 0.015u/50 C802 0.1u/10 C412 1u/10 C720 1u/10 C153 0.22u/10 C404 4.7u/10 C407 0.01u/50 C411 47p/50 C406 0.1u/25 C403 0.01u/50 C402 0.01u/50 C513 68p/50 C841 NM C603 1u/10 C621 D501 RB060L-40 D502 S5688G D701 HZS7L(C3) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND NJM2885DL1-33 IC702 1 IN 2 GND 3 OUT NJM2885DL1-33 IC401 1 IN 2 GND 3 OUT IC251 BD6538G VIN 1 GND 2 EN 3 /OC 4 5 VOUT BD9007F IC501 PVIN 1 SW 2 FB 3 INV 4 5 EN/SYNC 6 RT 7 GND 8 VIN HA12241FP IC101 DIN1 1 ROUT 2 DIN2 3 GND 4 5 BUS- 6 BUS+ 7 VCC 8 STBY IC151 IN5-_L 1 IN5+_L 2 IN4+_L 3 26 IN4- R 27 IN4+_R 28 IN5+_R IC601 1 2 ROT1 3 ROT0 4 5 6 7 BYTE 8 CNVss 9 10 11 RESET 12 Xout 13 14 15 16 17 NMI 18 BSENS 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 KEYD 35 36 37 38 PCL 39 ASENBO 40 MUTE 41 42 BRST 43 BRXEN 44 BSRQ 45 46 DALMON 47 SYSPW 48 49 SWVDD 50 51 ILMPW 52 53 IPPW 54 VST 55 VCK 56 VDT 57 ROMDATA 58 ROMCK 59 ROMCS 60 61 62 TESTIN 63 64 TUNPCE2 65 TUNPCE1 66 TUNPCK 67 TUNPDI 68 TUNPDO 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 KEYAD 94 MODEL 95 Avss 96 SL 97 98 99 100 CN621 2 1 3 CN101 1 2 3 4 5 6 7 8 9 10 11 L720 DTH1197-A 1 2 3 4 L501 YTF5003-A L101 2.2u L401 1u L251 CTF1394-A L403 1u L721 NM L402 22u L601 10u Q701 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C LTC114EUB Q102 LTC114EUB Q842 UMH1N Q401 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH1N Q402 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q702 2SD2396(JK) LSA1576UB Q101 2SA1036K Q841 R414 4.7 R811 47k R803 47k R813 100k R804 2.2k R106 22k R809 2.2k R808 100k R505 10k R611 1k R504 6.8k R603 10k R607 680 R604 680 R812 0 R112 1k R810 0 R503 47k R967 1k R602 10k R616 47k R618 1k R622 1k R629 100k R707 100k R714 100k R706 100k R705 4.7k R704 100k R711 220 R107 22k R716 12 R715 12 R104 100 R703 4.7k R701 270 R713 220 R110 3.3k R116 47 R712 220 R814 1k R710 220 R708 220 R102 2.2k R816 1 R841 10k R842 4.7k R709 1k R117 15 R113 4.7k R109 1k R502 0 R255 47k R254 680 R610 47k R605 680 R621 1k R101 180 R628 100k R111 5.6k R627 1k R509 3.9k R501 470 R257 100k R506 39k R108 1k R512 0 R412 NM R407 R421 0 R406 680 R405 680 R404 680 R619 0 R403 680 R402 680 R507 2.2k R415 220 R408 22k R620 0 R807 2.2k R413 220 R411 22k R806 2.2k R805 2.2k R410 22k R409 22k R401 680 R601 NM R513 0 R105 100 R118 0 R103 180 R114 4.7k R510 47k R815 1k BSRQ BRST BRXEN BDATA CDRST CDVDD UG CDR AG CDL PG DP DM USGND WREM1 WREM2 RFG WREMG RST PCL TEST FM T8V SL LCD_CLR BUSY VDD CE2 CE1 CK DI LDET OSCG T5V DO TUNG T3V RCK RDAT RLK RHSLK BEG SCLK LCH USB5V RCH SW DG ILM+B D+ SSENS D- DSEN DPDT AUXR USBG KYDT SW5V AUXG ILMG CNVSS AUXL ROT0 ROT1 VBUS SYNC BSCK JOYST AM IN1- IN2- IN2+ B14 STBY RX TX IN1+ IPG B- B+ FLG USBCTL VD D812 EZJZ1V270RM D807 EZJZ1V270RM D804 EZJZ1V270RM D808 EZJZ1V270RM D806 EZJZ1V270RM D813 EZJZ1V270RM D805 EZJZ1V270RM D810 EZJZ1V800AM D811 EZJZ1V800AM D802 EZJZ1V270RM D801 EZJZ1V270RM D809 EZJZ1V270RM D803 EZJZ1V270RM VDD VCC VCC US5V USB5V B.UP USB5V B.UP B.UP VDD B.UP VDD VDD VDD X601 YSS5002-A Y401 1 AM_ANT 2 RF_GND 3 FM_ANT 4 VCC 5 SL 6 CE2 7 WC 8 CE1 9 CK 10 DI 11 LDET 12 OSCGND 13 ROM_VDD 14 DO 15 DGND 16 COMP 17 VDD_3.3 18 RDS_CK 19 RDS_DATA 20 RDS_LOCK 21 RDS_HSLK 22 BEGND 23 Lch 24 Rch ZNR401 IMSA-6801-01Y901 (1/4W) VD VD BSRQ BRST BSCK BRXEN BDATA CDRST CDVDD CDGND CDR AGND CDL CDGND PGND DP DM USBGND USBGND IP BUS RDS USB5V BUZZER 15 MHz A,B,D:0 C:1k VBUS USBG USBG ILMG DGND AUX L AUX R D+ AUX G JOYST D- ILM P D JUMPER USB C:CWE2097 A,B,D:CWE2098 NC NC NC NC DSENS VSS XIN VCC NC ASENS RX2 VDCONT CDRST USBCTL FLG SYNC RX TX BSO BSI BSCK DPDT KYDT NC NC TELIN NC NC NC NC VCC NC NC NC RCK LDET RDSLK RDSDT RDS57K NC NC SD_nRESET SD_EN FLG_SD SEL1 SEL2 NC SSENS NC NC NC RDS AUX IN W.REM IP-BUS A.ANT TEL IN SD Unit RCA /P/UC /UC FRONT /ES /EW5 FRONT FRONT FRONT x x x x RT3T22M IPBUS FOR FM(10%):/EW -29.5 dBs, OTHERS -33.5 dBs AM(15%):/EW -26.0 dBs, OTHERS -30.0 dBs CD/USB: +0.6 dBs IP-BUS: +2.2 dBs 14.1V IP-BUS 101-120 EVOL 151-170 USB 251-260 AMP 301-350 RCA 351-400 TUNER 401-450 MUTE 451-500 USB5V 501-520 A.ANT 551-560 UCOM 601-620 CD MECHA 701-750 GRILL 801-860 B.UP 901-910 POWER 911-929 ASENS BSENS 931-940 TELMUTE 951-960 RST 961-970 P3100UB DEH- CDMECHA IPOD USB FRONT LCD_CLR x x x 2P/O 2P/O 2P/O P/O SD UNIT 650-670 SD_VDD 670-700 NC A,B:PEG516A8 D:PEG517A PEE NC SD_CD JOYST ROT1 ROT0 DPDT KYDT NC LCD_CLR x 1/4W AVCC VREF VSS NC NC NC C:PEG513A8 47p FM/AM TUNER UNIT 3100UB P310UB P3100UB C CN701 B CN4 C C A,B,D C A,B,D A,C,D B A,B,C A,B,C C C A,C,D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 57 5 6 7 8 5 6 7 8 C D F A B E A A-b FR1 FR2 FL1 FL2 RL2 RL1 RR2 RR1 VDT VCK VST BUSL- BUSL+ BUSR+ BUSR- TUNR TUNL AUXR AUXL RST ROT1 ROT0 KEY2 /ASENS RDS-LOCK RDS-DATA SWVDD RDS-HSLK SSENS TELIN SYSPW RL2 FL2 RL1 FL1 RR2 FR2 RR1 FR1 SSENS KYDT DPDT AUXR AUXL USDP AUXG FLG_SD SD_nRESET JOYST SD_EN SEL1 SEL2 /BSENS DALMON MUTE LCD_CLR USDM LCD_CLR ROT1 ROT0 SL JOYST /DSENS FLG_SD SD_EN SD_CD SEL1 SEL2 USDP USDM SD/USB_D- SD/USB_D+ AUXG 100u/16 C923 220u/10 C922 1000u/16 C913 47u/10 C911 2.2u/50 C352 10u/16 C160 10u/16 C165 3300u/16 C313 47u/10 C162 2.2u/50 C355 10u/16 C311 33u/10 C451 10u/16 C962 10u/16 C605 10u/16 C607 2.2u/50 C351 2.2u/50 C356 C608 0.1u/25 C316 0.47u/10 C606 0.1u/25 C317 0.47u/10 C604 1u/10 C318 0.47u/10 C961 0.047u/25 C315 0.47u/10 C305 0.47u/16 C310 2.2u/10 C309 2.2u/10 C306 0.47u/16 C304 NM C307 0.47u/16 C301 NM C163 0.1u/25 C308 0.47u/16 C159 1u/10 C156 1u/10 C154 1u/10 C158 1u/10 C157 1u/10 C152 1u/10 C151 1u/10 C901 0.1u/25 5 4 C851 0.1u/25 C912 0.01u/50 C924 0.01u/50 C921 0.01u/50 C931 NM C802 0.1u/10 C302 NM C153 0.22u/10 C155 0.22u/10 C303 NM C170 0.1u/10 D904 S5688G D911 S5688G D902 S5688G D903 S5688G D901 S5688G D454 1SS133 D951 DAN202U D931 HZS7L(C3) D912 HZS6L(B2) D932 HZS7L(A1) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND IC961 S-80835CNMC-B8U OUT 1 VDD 2 VSS 3 N.C1 4 5 N.C2 S-93C46ADFJ IC602 CS 1 SK 2 DI 3 DO 4 5 GND 6 TEST 7 NC 8 VCC IC151 PML018A IN5-_L 1 IN5+_L 2 IN4+_L 3 IN4-_L 4 5 IN3_L 6 IN2_L 7 IN1_L 8 Vref 9 Vcc 10 Front_L 11 Rear_L 12 Pre/SW_L 13 Vp 14 Pref 15 PGND 16 Pre/SW_R 17 Rear_R 18 Front_R 19 DATA 20 CLK 21 STB 22 GND 23 IN1_R 24 IN2_R 25 IN3_R 26 IN4-_R 27 IN4+_R 28 IN5+_R 1 2 ROT1 3 ROT0 4 5 6 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 KEYAD 94 MODEL 95 Avss 96 SL 97 98 99 100 NJM2388F84 IC921 1 VIN 2 VOUT 3 GND 4 CONTROL PAL007C IC301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 CN351 1 2 3 4 5 6 7 8 9 10 CN901 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 L951 2.2u L852 2.2u L602 2.2u L901 CTH1280 L161 2.2u FU353 RXEF075P 1 2 Q912 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C Q453 UMD2N 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C LTC124EUB Q451 LTC114EUB Q852 Q353 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q351 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q931 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q911 2SD2396(JK) 2SA1037K(QR) Q951 2SA1036K(QR) Q851 R309 15k R824 1k R811 47k R803 47k R912 1.5k R938 1k R813 100k R608 R454 1k R609 R973 100k R969 0 R972 0 R613 100k R825 1k R612 10k R606 10k R818 0 R962 8.2k R452 220 R453 15k R451 10k R153 1k R152 1k R151 1k R614 NM R617 0 R303 470 4 k R306 470 R852 4.7k R853 2.2k R615 2.2k R911 22k R922 47k R953 4.7k R952 1k R951 47k R937 4.7k R933 100k R653 100k R932 100k R931 100k R627 1k R819 10k R936 47k R935 47k R934 47k R393 0 R394 0 R381 0 R382 0 R358 820 R363 22k R364 22k R355 820 R968 0 R352 0 R356 820 R351 820 R359 22k R360 R954 NM R384 0 R955 15k R304 470 R301 470 R851 15k BUP3 BS1 BS2 AS2 AS1 SWR SWL RCFR RCFL RCG1 USBOUT- USB- USB+ SEL2 SEL1 FLG_SD CD SDGND SD_EN 13V VCC1 FR1 RR1 MUTE DALMON FR2 RR2 FL1 RL1 FL2 RL2 TEL RCRR RCRL BREM BSENS ACC GND2 GND1 BUP2 BUP1 USBOUT+ MODEL D811 EZJZ1V800AM VCC VDD US5V VDD VDD VCC B.UP VCC VDD VDD VDD VDD VDD B.UP VDD VDD TEL MUTE 8.4V VDD ASENS BSENS SWVDD RESET MUTE FOR 2P/O NM SWR SWL FR FL TAB PGND RL- STBY RL+ VCC RR- PGND RR+ SVR RRIN RLIN AGND FLIN FRIN ACGND FR+ PGND FR- VCC FL+ MUTE FL- PGND B.REM GND B.UP NC RDSLK RDSDT RDS57K NC NC SD_nRESET SD_EN FLG_SD SEL1 SEL2 NC SSENS NC NC NC RT3CLLM RT3N66M RT3N66M RT3T22M RT3T22M IPBUS FOR 5V FM(10%):/EW -12.0 dBs, -11.0 dBs AM(15%):/EW -7.5 dBs, -7.5 dBs CD/USB: -6.3 dBs IP-BUS/AUX1: -5.7 dBs CD/USB: +0.6 dBs 8.4V 5V FM(10%):/EW +13.98 dBs, OTHERS +9.98 dBs AM(15%):/EW +18.48 dBs, OTHERS +14.48 dBs CD/USB:+16.7 dBs IP-BUS/AUX1:+16.3 dBs R609 R608 100k 2-5V 100k D - C - OPEN A,B 0-1V - - JOYST NC LCD_CLR 1/4W 1/4W 1/4W 1/4W AVCC VREF NC NC NC 600 uH model 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. NM : No Mount A TUNER AMP ASSY A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES A,B,C A,C,D C,D C,D A,B,D A,B,D C YEK5001 10 A > www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 58 1 2 3 4 1 2 3 4 C D F A B E A-a A-b A-b FR1 FR2 FL1 FL2 RL2 RL1 RR2 RR1 VDT VCK VST BUSL- BUSL+ TUNL AUXL KEY2 SSENS FLG_SD SD_nRESET JOYST SD_EN SEL1 SEL2 MUTE LCD_CLR SL 100u/16 C923 220u/10 C922 2.2u/50 C352 10u/16 C160 10u/16 C165 3300u/16 C313 47u/10 C162 2.2u/50 C355 10u/16 C311 33u/10 C451 10u/16 C605 10u/16 C607 2.2u/50 C351 2.2u/50 C356 C316 0.47u/10 C606 0.1u/25 C317 0.47u/10 C604 1u/10 C318 0.47u/10 61 C315 0.47u/10 C305 0.47u/16 C310 2.2u/10 C309 2.2u/10 C306 0.47u/16 C304 NM C307 0.47u/16 C301 NM C163 0.1u/25 C308 0.47u/16 C156 1u/10 C158 1u/10 C157 1u/10 C901 0.1u/25 C924 0.01u/50 C921 0.01u/50 C302 NM C155 0.22u/10 C303 NM C170 0.1u/10 D904 S5688G D902 S5688G D903 S5688G D901 S5688G D454 1SS133 GND GND GND GND GND GND GND GND GND GND GND GND IC961 S-80835CNMC-B8U OUT 1 VDD 2 VSS 3 N.C1 4 5 N.C2 PML018A IN5+_L 2 IN4+_L 3 IN4-_L 4 5 IN3_L 6 IN2_L 7 IN1_L 8 Vref 9 Vcc 10 Front_L 11 Rear_L 12 Pre/SW_L 13 Vp 14 Pref 15 PGND 16 Pre/SW_R 17 Rear_R 18 Front_R 19 DATA 20 CLK 21 STB 22 GND 23 IN1_R 24 IN2_R 25 IN3_R 26 IN4-_R 27 IN4+_R NJM2388F84 IC921 1 VIN 2 VOUT 3 GND 4 CONTROL PAL007C IC301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 CN351 1 2 3 4 5 6 7 8 9 10 CN901 13 14 15 16 L602 2.2u L901 CTH1280 L161 2.2u FU353 RXEF075P 1 2 Q453 UMD2N 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C LTC124EUB Q451 Q353 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q351 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R309 15k R608 R454 1k R609 R606 10k 62 k R452 220 R453 15k R451 10k R153 1k R152 1k R151 1k R617 0 R303 470 R306 470 R615 2.2k R922 47k R393 0 R394 0 R381 0 R382 0 R358 820 R363 22k R364 22k R355 820 R352 0 R356 820 R351 820 R359 22k R360 R384 0 R304 470 R301 470 SWR SWL RCFR RCFL RCG1 VCC1 MUTE RCRR RCRL ACC GND2 GND1 BUP2 BUP1 MODEL VCC VCC B.UP VCC VDD VDD B.UP 8.4V MUTE FOR 2P/O SWR SWL FR FL TAB PGND RL- STBY RL+ VCC RR- PGND RR+ SVR RRIN RLIN AGND FLIN FRIN ACGND FR+ PGND FR- VCC FL+ MUTE FL- PGND B.REM GND B.UP RT3N66M RT3N66M RT3T22M FM(10%):/EW -12.0 dBs, -11.0 dBs AM(15%):/EW -7.5 dBs, -7.5 dBs CD/USB: -6.3 dBs IP-BUS/AUX1: -5.7 dBs 8.4V FM(10%):/EW +13.98 dBs, OTHERS +9.98 dBs AM(15%):/EW +18.48 dBs, OTHERS +14.48 dBs CD/USB:+16.7 dBs IP-BUS/AUX1:+16.3 dBs R609 R608 100k 2-5V 100k D - C - OPEN A,B 0-1V - - 1/4W 1/4W 600 uH model 13 14 15 16 A TUNER AMP ASSY A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES ,C A,C,D A,B,D A,B,D YEK5001 10 A > www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 59 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-b RST /ASENS SWVDD TELIN SYSPW RL2 FL2 RL1 FL1 RR2 FR2 RR1 FR1 SSENS KYDT DPDT AUXR AUXL USDP AUXG FLG_SD SD_nRESET SD_EN SEL1 SEL2 /BSENS DALMON USDM LCD_CLR ROT1 ROT0 JOYST /DSENS FLG_SD SD_EN SD_CD SEL1 SEL2 USDP USDM SD/USB_D- SD/USB_D+ 100u/16 C923 220u/10 C922 1000u/16 C913 47u/10 C911 33u C 10u/16 C962 C608 0.1u/25 C961 0.047u/25 C851 0.1u/25 C912 0.01u/50 C924 0.01u/50 C921 0.01u/50 C931 NM C802 0.1u/10 D904 D911 S5688G D902 S5688G D901 S5688G D951 DAN202U D931 HZS7L(C3) D912 HZS6L(B2) D932 HZS7L(A1) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND IC961 S-80835CNMC-B8U OUT 1 VDD 2 VSS 3 N.C1 4 5 N.C2 S-93C46ADFJ IC602 CS 1 SK 2 DI 3 DO 4 5 GND 6 TEST 7 NC 8 VCC NJM2388F84 IC921 1 VIN 2 VOUT 3 GND 4 CONTROL CN901 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 L951 2.2u L852 2.2u L901 CTH1280 Q912 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C LTC124EUB Q451 LTC114EUB Q852 Q931 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q911 2SD2396(JK) 2SA1037K(QR) Q951 2SA1036K(QR) Q851 R824 1k R912 1.5k R938 1k R973 100k R969 0 R972 0 R613 100k R825 1k R612 10k R818 0 R962 8.2k R 1 R614 NM R852 4.7k R853 2.2k R911 22k R922 47k R953 4.7k R952 1k R951 47k R937 4.7k R933 100k R653 100k R932 100k R931 100k R819 10k R936 47k R935 47k R934 47k R968 0 R954 NM R955 15k R851 15k BUP3 BS1 BS2 AS2 AS1 USBOUT- USB- USB+ SEL2 SEL1 FLG_SD CD SDGND SD_EN 13V FR1 RR1 MUTE DALMON FR2 RR2 FL1 RL1 FL2 RL2 TEL BREM BSENS ACC GND2 GND1 BUP2 BUP1 USBOUT+ VCC VDD US5V VDD VDD VDD VDD VDD VDD B.UP VDD VDD TEL MUTE 8.4V VDD ASENS BSENS SWVDD RESET NM GND B.UP RT3CLLM RT3T22M 5V 8.4V 5V 1/4W 1/4W 600 uH 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. NM : No Mount C,D C,D C YEK5001 10 A > www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 60 1 2 3 4 1 2 3 4 C D F A B E A-b A-a A-a A-b RDS-HSLK RDS-CK RDS-LOCK RDS-DATA TUNPDO VDCONT /BSRQ /BRST BRXEN BDATA CDRST BUSL- BUSL+ BUSR+ BUSR- TUNR TUNL AUXR AUXL ROT1 ROT0 TX ASENBO SYSPW DALMON RX RX RST IPPW ASENBO BUSL+ RX BUSR+ TX BUSR- BUSL- /BSENS FLG CDRST MUTE TELIN /BRST BRXEN /BSRQ SWVDD USBCTL KEY2 KEY1 /DSENS TUNR TUNL SL CE2 CE1 TUNPCK LDET BSCK USDM USDP VDCONT /ASENS SYNC BDATA BSCK KEY1 AUXG DPDT KYDT TUNPDI CN401 1 2 3 BZ601 1 1 2 2 CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 22u/10 C708 100u/10 C703 10u/16 C160 100u/10 C405 10u/16 C605 47u/6.3 C401 22u/10 C408 C101 0.1u/25 C103 NM C102 NM C604 1u/10 C602 18p/50 C601 18p/50 C104 0.01u/50 0.1u/25 C715 NM C716 NM C159 1u/10 C156 1u/10 C154 1u/10 C158 1u/10 C157 1u/10 C152 1u/10 C151 1u/10 C701 0.047u/25 C702 NM C711 NM C710 0.47u/10 C709 1u/10 C707 NM C706 NM C705 1u/10 C704 1u/10 C410 0.47u/10 C412 1u/10 C720 1u/10 C153 0.22u/10 C155 0.22u/10 C404 4.7u/10 C407 0.01u/50 C411 47p/50 C406 0.1u/25 C403 0.01u/50 C402 0.01u/50 C170 0.1u/10 C603 1u/10 D701 HZS7L(C3) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND NJM2885DL1-33 IC702 1 IN 2 GND 3 OUT NJM2885DL1-33 IC401 1 IN 2 GND 3 OUT IC251 VIN 1 5 VOUT HA12241FP IC101 DIN1 1 ROUT 2 DIN2 3 GND 4 5 BUS- 6 BUS+ 7 VCC 8 STBY IC151 IN5-_L 1 IN5+_L 2 IN4+_L 3 IN4-_L 4 5 IN3_L 6 IN2_L 7 IN1_L 8 Vref 9 Vcc 10 F t L 19 20 CLK 21 STB 22 GND 23 IN1_R 24 IN2_R 25 IN3_R 26 IN4-_R 27 IN4+_R 28 IN5+_R IC601 1 2 ROT1 3 ROT0 4 5 6 7 BYTE 8 CNVss 9 10 11 RESET 12 Xout 13 14 15 16 17 NMI 18 BSENS 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 KEYD 35 36 37 38 PCL 39 ASENBO 40 MUTE 41 42 BRST 43 BRXEN 44 BSRQ 45 46 DALMON 47 SYSPW 48 49 SWVDD 50 51 ILMPW 52 53 IPPW 54 VST 55 VCK 56 VDT 57 ROMDATA 58 ROMCK 59 ROMCS 60 61 62 TESTIN 63 64 TUNPCE2 65 TUNPCE1 66 TUNPCK 67 TUNPDI 68 TUNPDO 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 KEYAD 94 MODEL 95 Avss 96 SL 97 98 99 100 CN621 2 1 3 CN101 1 2 3 4 5 6 7 8 9 10 11 L720 DTH1197-A 1 2 3 4 L602 2.2u L101 2.2u L401 1u L251 CTF1394-A L403 1u L721 NM L402 22u L161 2.2u L601 10u Q701 2E 1 2B 2 1C 3 1E 4 5 1B 6 2C LTC114EUB Q102 UMH1N Q401 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH1N Q402 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q702 2SD2396(JK) LSA1576UB Q101 R414 4.7 R106 22k R611 1k R603 10k R112 1k R967 1k R602 10k R616 47k R618 1k R622 1k R629 100k R707 100k R714 100k R706 100k R705 4.7k R704 100k R711 220 R107 22k R716 12 R715 12 R104 100 R703 4.7k R701 270 R713 220 R110 3.3k R116 47 R712 220 R710 220 R708 220 R102 2.2k R709 1k R615 2.2k R117 15 R113 4.7k R109 1k R621 1k R101 180 R628 100k R111 5.6k R627 1k R108 1k R412 NM R407 R406 680 R405 680 R404 680 R403 680 R402 680 R415 220 R408 22k R413 220 R411 22k R410 22k R409 22k R401 680 R601 NM R105 100 R118 0 R103 180 R114 4.7k BSRQ BRST BRXEN BDATA CDRST CDVDD UG CDR AG CDL PG DP DM USGND WREM1 WREM2 RFG WREMG RST PCL FM T8V SL BUSY VDD VCC1 CE2 CE1 CK DI LDET OSCG T5V DO TUNG T3V RCK RDAT RLK RHSLK BEG SCLK LCH RCH CNVSS BSCK AM IN1- IN2- IN2+ B14 RX TX IN1+ IPG B- B+ VD VDD VCC VCC US5V USB5V B.UP VCC B.UP VDD VDD VDD X601 YSS5002-A Y401 1 AM_ANT 2 RF_GND 3 FM_ANT 4 VCC 5 SL 6 CE2 7 WC 8 CE1 9 CK 10 DI 11 LDET 12 OSCGND 13 ROM_VDD 14 DO 15 DGND 16 COMP 17 VDD_3.3 18 RDS_CK 19 RDS_DATA 20 RDS_LOCK 21 RDS_HSLK 22 BEGND 23 Lch 24 Rch ZNR401 IMSA-6801-01Y901 (1/4W) VD VD BSRQ BRST BSCK BRXEN BDATA CDRST CDVDD CDGND CDR AGND CDL CDGND PGND DP DM USBGND USBGND IP BUS RDS BUZZER 15 MHz A,B,D:0 C:1k P D JUMPER USB C:CWE2097 A,B,D:CWE2098 NC NC NC NC DSENS VSS XIN VCC NC ASENS RX2 VDCONT CDRST USBCTL FLG SYNC RX TX BSO BSI BSCK DPDT KYDT NC NC TELIN NC NC NC NC VCC NC NC NC RCK LDET RDSLK RDSDT RDS57K NC NC SD_nRESET SD_EN FLG_SD SEL1 SEL2 NC SSENS NC NC NC RT3T22M IPBUS FOR FM(10%):/EW -29.5 dBs, OTHERS -33.5 dBs AM(15%):/EW -26.0 dBs, OTHERS -30.0 dBs CD/USB: +0.6 dBs IP-BUS: +2.2 dBs NC 2-5V D C OPEN A,B 0-1V A,B:PEG516A8 D:PEG517A PEE NC SD_CD JOYST NC LCD_CLR 1/4W AVCC VREF VSS NC NC NC C:PEG513A8 FM/AM TUNER UNIT model C CN701 C C A,B,D C A,B,D A,C,D B A,B,C A,B,C C A,C,D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 61 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-b A-a SYSPW DALMON CE1 CE2 VST VCK /BSRQ SWVDD ILMPW VDT TUNPCK TUNPDO SD_CD RDS-LOCK RDS-DATA LDET RDS-HSLK RDS-CK USBCTL SW5V SOURCE ILM+B SYNC FLG ILMPW DSENS IPPW TUNPDI CN803 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 220u/16 C502 CCH1804-A C501 C503 33p/50 C609 47p/50 C504 2.2u/16 C252 1u/10 C505 NM C251 1u/10 C506 0.015u/50 C802 0.1u/10 C513 68p/50 C841 NM C621 D501 RB060L-40 D502 S5688G GND GND GND GND GND GND GND GND GND GND IC251 BD6538G VIN 1 GND 2 EN 3 /OC 4 5 VOUT BD9007F IC501 PVIN 1 SW 2 FB 3 INV 4 5 EN/SYNC 6 RT 7 GND 8 VIN 44 BSRQ 45 46 DALMON 47 SYSPW 48 49 SWVDD 50 51 ILMPW 52 53 IPPW 54 VST 55 VCK 56 VDT 57 ROMDATA 58 ROMCK 59 ROMCS 60 61 62 TESTIN 63 64 TUNPCE2 65 TUNPCE1 66 TUNPCK 67 TUNPDI 68 TUNPDO 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 L501 YTF5003-A L251 CTF1394-A LTC114EUB Q842 2SA1036K Q841 R811 47k R803 47k R813 100k R804 2.2k R809 2.2k R808 100k R505 10k R504 6.8k R607 680 R604 680 R812 0 R810 0 R503 47k R613 100k R612 10k R818 0 R614 NM R814 1k R816 1 R841 10k R842 4.7k R502 0 R255 47k R254 680 R610 47k R605 680 R509 3.9k R501 470 R257 100k R506 39k R512 0 R421 0 R619 0 R507 2.2k R620 0 R807 2.2k R806 2.2k R805 2.2k R513 0 R510 47k R815 1k TEST LCD_CLR USB5V SW DG ILM+B D+ SSENS D- DSEN DPDT AUXR USBG KYDT SW5V AUXG ILMG AUXL ROT0 ROT1 VBUS SYNC JOYST STBY FLG USBCTL D812 EZJZ1V270RM D807 EZJZ1V270RM D804 EZJZ1V270RM D808 EZJZ1V270RM D806 EZJZ1V270RM D813 EZJZ1V270RM D805 EZJZ1V270RM D810 EZJZ1V800AM D811 EZJZ1V800AM D802 EZJZ1V270RM D801 EZJZ1V270RM D809 EZJZ1V270RM D803 EZJZ1V270RM US5V USB5V USB5V B.UP VDD B.UP VDD SW USB5V VBUS USBG USBG ILMG DGND AUX L AUX R D+ AUX G JOYST D- ILM NC NC NC NC VCC NC NC NC RCK LDET RDSLK RDSDT RDS57K NC NC SD_nRESET SD_EN FLG_SD SEL1 SEL2 NC RDS AUX IN W.REM IP-BUS A.ANT TEL IN SD Unit RCA /P/UC /UC FRONT /ES /EW5 FRONT FRONT FRONT x x x x 5V 14.1V IP-BUS 101-120 EVOL 151-170 USB 251-260 AMP 301-350 RCA 351-400 TUNER 401-450 MUTE 451-500 USB5V 501-520 A.ANT 551-560 UCOM 601-620 CD MECHA 701-750 GRILL 801-860 B.UP 901-910 POWER 911-929 ASENS BSENS 931-940 TELMUTE 951-960 RST 961-970 P3100UB DEH- CDMECHA IPOD USB FRONT LCD_CLR x x x 2P/O 2P/O 2P/O P/O SD UNIT 650-670 SD_VDD 670-700 NC SD_CD ROT1 ROT0 DPDT KYDT x VSS 47p 3100UB P310UB P3100UB B CN4 , , C www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 62 1 2 3 4 1 2 3 4 C D F A B E 10.2 KEYBOARD UNIT B SEG38 SEG36 SEG33 SEG35 SEG34 SEG27 SEG30 SEG32 SEG28 SEG29 SEG31 SEG20 SEG15 SEG21 SEG24 SEG26 SEG22 SEG23 SEG17 SEG25 SEG16 SEG18 SEG19 SEG14 SEG13 SEG12 SEG11 SEG10 SEG8 SEG9 SEG3 SEG7 SEG5 SEG2 SEG6 SEG4 COM1 SEG1 COM3 COM0 SEG0 COM2 SEG53 SEG52 SEG51 SEG56 SEG55 SEG54 SEG50 SEG49 SEG62 SEG61 SEG60 SEG63 SEG59 SEG58 SEG57 KST3 KST2 KST1 KDT3 KDT2 KDT1 SEG37 SEG48 SEG44 SEG45 SEG39 SEG43 SEG47 SEG40 SEG42 SEG46 SEG41 KDT3 DPDT KYDT KDT2 KST3 KST1 KST2 KDT1 SEG33 SEG7 SEG62 SEG36 SEG10 SEG39 SEG13 SEG42 SEG16 SEG45 SEG19 SEG48 SEG22 COM0 SEG51 SEG25 COM3 SEG54 SEG28 SEG2 SEG57 SEG31 SEG5 SEG60 SEG34 SEG8 SEG37 SEG11 SEG40 SEG14 SEG43 SEG17 SEG46 SEG20 SEG49 SEG23 COM1 SEG52 SEG26 SEG0 SEG55 SEG29 SEG3 SEG58 SEG32 SEG6 SEG61 SEG35 SEG9 SEG38 SEG12 SEG41 SEG15 SEG44 SEG18 SEG47 SEG21 SEG50 SEG24 COM2 SEG53 SEG27 SEG1 SEG56 SEG30 SEG4 SEG59 SEG63 C1 10u/10 C4 0.1u/16 C3 0.1u/16 C2 0.1u/16 D DAP ILMGND DGND ILMGND DGND DGND IC1 PD6538A SEG38 1 SEG37 2 SEG36 3 SEG35 4 SEG34 5 SEG33 6 SEG32 7 SEG31 8 SEG30 9 SEG29 10 SEG28 11 SEG27 12 SEG26 13 SEG25 14 SEG24 15 SEG23 16 SEG22 17 SEG21 18 SEG20 19 SEG19 20 SEG18 21 SEG17 22 SEG16 23 SEG15 24 SEG14 25 SEG13 26 SEG12 27 SEG11 28 SEG10 29 SEG9 30 SEG8 31 SEG7 32 SEG6 33 SEG5 34 SEG4 35 SEG3 36 SEG2 37 SEG1 38 SEG0 39 COM3 40 COM2 41 COM1 42 COM0 43 V1 44 V2 45 V3 46 VCC 47 POUT1 48 TXD 49 RXD 50 MOD0 51 MOD1 52 RESET 53 X0 54 X1 55 VSS 56 REM 57 ROUT2 58 ROUT3 59 KDT4 60 KDT3 61 KDT2 62 KDT1 63 KST6 64 KST5 65 KST4 66 KST3 67 KST2 68 KST1 69 SEG69 70 SEG68 71 SEG67 72 SEG66 73 SEG65 74 SEG64 75 SEG63 76 SEG62 77 SEG61 78 SEG60 79 SEG59 80 SEG58 81 SEG57 82 SEG56 83 SEG55 84 SEG54 85 SEG53 86 SEG52 87 SEG51 88 SEG50 89 SEG49 90 SEG48 91 SEG47 92 SEG46 93 SEG45 94 SEG44 95 SEG43 96 SEG42 97 SEG41 98 SEG40 99 SEG39 100 IC2 1 REM 2 GND 3 VCC R34 120 R32 2.2 R31 10k R39 NM R33 NM CSG1155-A S6 1 2 3 4 CSG1155-A S1 1 2 3 4 CSG1155-A S3 1 2 3 4 CSG1155-A S9 1 2 3 4 CSG1155-A S8 1 2 3 4 CSG1155-A S5 1 2 3 4 CSG1155-A S4 1 2 3 4 CSG1155-A S10 1 2 3 4 CSG1155-A S7 1 2 3 4 CSG1155-A S2 1 2 3 4 LCD1 YAW5101-A 1 NC 2 SEG63 3 SEG62 4 SEG61 5 SEG60 6 SEG59 7 SEG58 8 SEG57 9 SEG56 10 SEG55 11 SEG54 12 SEG53 13 SEG52 14 SEG51 15 SEG50 16 SEG49 17 SEG48 18 SEG47 19 SEG46 20 SEG45 21 SEG44 22 SEG43 23 SEG42 24 SEG41 25 SEG40 26 SEG39 27 SEG38 28 SEG37 29 SEG36 30 SEG35 31 SEG34 32 SEG33 33 SEG32 34 SEG31 35 SEG30 36 SEG29 37 SEG28 38 SEG27 39 SEG26 40 SEG25 41 SEG24 42 SEG23 43 SEG22 44 SEG21 45 SEG20 46 SEG19 47 SEG18 48 SEG17 49 SEG16 50 SEG15 51 SEG14 52 SEG13 53 SEG12 54 SEG11 55 SEG10 56 SEG09 57 SEG08 58 SEG07 59 SEG06 60 SEG05 61 SEG04 62 SEG03 63 SEG02 64 SEG01 65 SEG00 66 COM03 67 COM02 68 COM01 69 COM00 X1 CSS1547-A D5-D15 R4-R8 CL-197HB1-D(CDE) RS1/4SA392J CL-195PG-CD(GREEN) RS1/4SA681J A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC D:DEH-3100UB/XS/ES R10 *1 RS1/16S102J RS1/16S181J IMLCLR1 SW A(UP) B(LEFT) C(DOWN) D(RIGHT) PUSH RELEASE SW(V) OVER-UNDER 0.00-0.50 0.50-1.30 1.30-2.30 2.30-3.70 3.70-4.50 4.50-5.00 YF106 C:DEH-P3100UB/XS/EW CL-195SR-CD(RED) RS1/4SA122J RS1/16S331J BAND LIST REGION2 S.Rtrv RDM DISP EJECT RPT SRC REGION1 REGION1 REGION2 TA/NEWS MUTE CLOCK/ SW/BASS BUTTON C A,B,D DISP OFF GP1UXC14RK 5.00 MHz model B KEYBOARD UNIT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 63 5 6 7 8 5 6 7 8 C D F A B E B KDT3 DPDT KYDT ROT0 CN2 1 2 3 4 5 CN4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 C5 4700p/16 C6 4700p/16 C8 1000p/25 C9 0.01u/50 C7 100p/50 C10 0.1u/25 D10 D9 D15 D7 D6 D5 NESW505C-5273 D3 D8 D11 D14 D12 D13 D2 DAP202U D1 DAN202U D43 MALS068X D44 MALS068X D42 MALS068X ILMGND ILMGND ILMGND DGND ILMGND CN3 2 1 3 L1 NM 1 2 3 4 RT1N141M-11 Q4 Q7 2SD2114K R25 27k R22 2.2k R37 10k R6 R8 R38 10k R4 R10 R41 100 R40 100 R2 2.2k R1 2.2k R26 47k R5 R24 8.2k R7 R3 1.2k R23 3.3k 3 4 SG1155-A S5 2 3 4 SG1155-A S4 2 3 4 SG1155-A S10 1 2 3 4 S28 CSX1116-A 1 PB 2 D 3 A 4 COM1 5 PUSH 6 COM2 7 B 8 C 9 PA D23 EZJZ1V800AM D24 EZJZ1V800AM DGND ILMG SW5V SOURCE AUXR AUXG AUXL NC USBG USBG D+ D- VBUS(US5V) ILM+B KYDT DPDT DSEN *COLOR1 *1 ROT1 JOYST GION2 S.Rtrv EJECT 2 S CSX1144 AUX USB A CN803 A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 64 1 2 3 4 1 2 3 4 C D F A B E 10.3 CD MECHANISM MODULE(GUIDE PAGE) C-a C M1 CXC7134 SPINDLE MOTOR M2 CXC4026 SWITCHES: CD CORE UNIT(S10.5IPOD-C3-CLASS1) S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH....ON-OFF S904:12EJ SWITCH...........ON-OFF S905:8EJ SWITCH.............ON-OFF PICKUP UNIT(P10.5)(SERVICE) LOADING/CARRIAGE MOTOR F F F F T T F F T T T T F T C S S C T F F T T T T F F S S C C S S C C 1 2 3 4 5 8 7 a 9 c d e f F www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 65 5 6 7 8 5 6 7 8 C D F A B E C-b C 341S2159 A CN701 C CD CORE UNIT(S10.5iPod-C3-CLASS1) F SIGNAL LINE FOCUS LINE TRACKING LINE CARRIAGE LINE SPINDLE LINE T C S 6 b g h www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 66 1 2 3 4 1 2 3 4 C D F A B E C-a C-b C-b C CD CORE UNIT(S10.5iPod-C3-CLASS1) F SIGNAL LINE FOCUS LINE TRACKING LINE CARRIAGE LINE SPINDLE LINE T C S b www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 67 5 6 7 8 5 6 7 8 C D F A B E C-a C-b C-b 341S2159 A CN701 6 g h www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 68 1 2 3 4 1 2 3 4 C D F A B E C-b C-a C-a C-b PICKUP UNIT(P10.5)(SERVICE) F F F F T T F F T T T T F T C S T T F F c d f www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 69 5 6 7 8 5 6 7 8 C D F A B E C-a C-b C-b C-a M1 CXC7134 SPINDLE MOTOR M2 CXC4026 SWITCHES: CD CORE UNIT(S10.5IPOD-C3-CLASS1) S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH....ON-OFF S904:12EJ SWITCH...........ON-OFF S905:8EJ SWITCH.............ON-OFF LOADING/CARRIAGE MOTOR S C T F F T T S S C C S S C C 1 2 3 4 5 8 7 a 9 e F www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 70 1 2 3 4 1 2 3 4 C D F A B E 10.4 WAVEFORMS - CD CORE UNIT Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V) 500 ms/div 5 V/div 5 V/div 5 V/div 10 V/div 1DSCSNS 5CLCONT 4LOEJ 6VD 5 V/div 5 V/div 5 V/div 5 V/div 1DSCSNS 28SNS 312SNS 4LOEJ 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 312SNS 4LOEJ 500 mV/div 500 mV/div 200 ms/div @TE #FE 200 mV/div 2 V/div 2 V/div 500 ms/div 0FIN !RFOK(MONI_3) 7SIN 1 V/div 500 mV/div 1 V/div 1 s/div 500 ms/div 7SIN 8CIN 9TIN 2 V/div 500 mV/div 5 µs/div $MDX 7SIN 2 V/div 500 mV/div 200 ms/div $MDX 7SIN 500 mV/div 500 mV/div 500 mV/div 500 mV/div 20 ms/div #FE 0FIN @TE 9TIN 1 V/div 500 mV/div 500 mV/div 500 µs/div %RFAGC @TE 9TIN 500 mV/div 500 mV/div 2 ms/div @TE %RFAGC 500 mV/div 500 mV/div 200 ms/div 0FIN #FE Source On setup operation 12 cm CD-DA Source On setup operation CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation (Wider) Focus Search waveform Track Open waveform 1 Track Jump waveform 12 cm CD-DA setup operation after loading 12 cm CD Loading operation 12 cm CD Loading operation 8 cm CD Loading operation Ref.: GND Mode: Normal Ref.: GND Mode: Normal Ref.: GND Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 71 5 6 7 8 5 6 7 8 C D F A B E 1 V/div 500 mV/div 500 mV/div 2 ms/div %RFAGC @TE 9TIN 1 V/div 500 mV/div 500 mV/div 500 µs/div %RFAGC @TE 9TIN 1 V/div 500 mV/div 500 mV/div 500 µs/div %RFAGC @TE 9TIN 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 312SNS 4LOEJ 1 V/div 1 V/div 200 µs/div ^LOUT &ROUT 1 V/div 1 V/div 1 V/div 2 V/div 200 ms/div %RFAGC @TE 8CIN 7SIN 1 V/div 1 V/div 1 V/div 1 V/div 500 µs/div %RFAGC 9TIN @TE 0FIN 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 312SNS 4LOEJ 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 5CLCONT 4LOEJ 12 cm CD Eject operation Analog audio waveform 12 cm CD Eject operation 8 cm CD Eject operation Black dot(800 µm) during play Search operation(Outter to Inner) 4 Tracks Jump waveform 10 Tracks Jump waveform 32 Tracks Jump waveform Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: GND Mode: Normal Ref.: REFO Mode: Normal Ref.: GND Mode: Normal 2 V/div 2 V/div 50 ms/div *DP (DM 2 V/div 2 V/div 50 ms/div *DP (DM 1 V/div 1 V/div 50 ns/div *DP (DM USB Play USB device inserting to USB connector. CD Play with USB(iPod) device connecting. Ref.: REFO Mode: Normal Ref.: GND Mode: Normal Ref.: AGND Mode: Normal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 72 1 2 3 4 1 2 3 4 C D F A B E 2 V/div 2 V/div 2 V/div )CPRDY ⁄SDA ¤SCL 2 V/div 2 V/div 2 V/div 10 s/div )CPRDY ⁄SDA ¤SCL 2 V/div 2 V/div 50 ms/div *DP (DM ACC OFF with USB(iPod) device connecting. iPod Authentication Operation iPod Authentication Operation(zoom until 2 s) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 73 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 74 1 2 3 4 1 2 3 4 C D F A B E 11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP ASSY A A TUNER AMP ASSY Capacitor Connector P.C.Board Chip Part SIDE B SIDE A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams 1 1 5 1 5 0 2 0 1 1 E E 1 1 5 10 15 IC921 L852 CN803 CN621 C607 L101 BZ601 Q702 L501 Q911 L901 CN101 R701 L951 CN701 R912 CN901 C501 C502 C313 C703 C708 C911 C913 R955 C922 C923 D502 D701 D901 L601 L602 D90 D903 D904 D911 D912 D931 D932 D551 D552 10 20 30 40 50 60 70 X 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y 1 16 15 10 2 5 C CN701 CORD ASSY IP-BUS W.REM www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 75 5 6 7 8 5 6 7 8 C D F A B E A SIDE A 1 5 1 0 2 0 1 1 5 10 15 1 5 10 15 20 1 5 10 1 5 10 15 20 25 R414 CN401 CN803 C401 C405 C408 C605 C607 R454 X601 CN650 FU353 C451 L101 Y401 D454 R309 L161 L951 C311 CN351 R955 C351C352 C353 C354 C160 C355 C356 C162 C165 L401 L403 IC301 D901 L601 L602 C962 D902 51 70 80 90 100 110 120 130 140 150 160 170 1 2 5 FRONT SY RCA ANTENNA FM/AM TUNER UNIT B CN4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 76 1 2 3 4 1 2 3 4 C D F A B E A A TUNER AMP ASSY 170 160 150 140 130 120 110 100 90 1 5 10 15 20 25 1 1 5 10 15 20 25 35 40 45 50 55 60 65 70 75 80 85 90 95 100 1 5 1 1 1 1 E 1 1 E 1 E E R401 IC151 R402 R403 R404 R405 R406 R407 R408 R409 R603 R604 R410 R605 R411 D951 R606 R412 R607 R413 R608 R609 R415 R803 R804 R610 R611 R805 R612 R613 R614 R615 R421 R617 R619 R810 R811 R812 R813 R814 R620 R815 R816 R627 R82 R824 C402 C403 C404 C406 C407 C602 C604 C410 C411 C606 C412 C608 C609 R451 R452 R453 R841 R842 R651 R652 R653 R654 R655 C621 R666 R667 C841 ZNR401 IC401 D810 IC601 IC602 L720 Q351 Q352 Q353 R301 R303 R304 R306 Q951 R715 R716 C301 C302 C303 C304 C305 C306 C307 C308 C309 R151 R152 R153 C310 C315 R351 C316 R352 R353 C317 R354 C318 R355 R932 R356 C704 R358 C705 R359 R360 R361 R362 R363 R364 R951 R952 R953 R954 C151 R381 C152 R382 R383 C153 C154 R384 R385 C155 R386 C156 C157 C158 C159 R968 R391 R392 C357 C163 R393 C358 R394 C359 R972 R973 C360 C361 C362 C170 Q401 Q402 L402 Q451 Q453 Q841 Q842 1 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 77 5 6 7 8 5 6 7 8 C D F A B E A SIDE B 90 80 70 60 50 40 30 X 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y 20 10 E E 1 5 10 1 E E 1 1 5 10 15 20 25 30 35 40 45 50 100 1 1 1 1 1 5 1 5 1 Q851 Q852 R601 R602 R608 IC551 R804 R611 R805 R806 R807 R808 R809 R616 R618 R810 R811 R812 R813 R814 R815 R621 R622 R818 R819 R628 R629 R820 R825 IC961 R254R255 C601 C602 C603 R257 C604 C606 C802 R851 R852 R853 C251 C252 Q101 Q102 C851 Q701 D801 D802 D803 D804 D805 D806 D807 D808 D809 810 D811 D812 D813 IC601 Q912 L720 L721 R101 Q931 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R116 R117 R118 IC251 R501 R502 R503 R504 R505 R506 R507 R509 R703 R510 R704 R705 R512 R706 R513 R707 R708 R709 R710 R711 R712 R713 R714 C101 C102 C103 C104 R911 R922 C503 C504 C505 C506 C701 R931 C702 R933 R934 R935 C706 R936 C707 R937 C513 R938 C709 C901 C710 C711 C715 C716 C912 C720 C721 C921 C924 R962 R967 R968 R969 C931 R972 C551 C552 D501 IC101 C961 IC501 IC702 L251 1 1 1 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 78 1 2 3 4 1 2 3 4 C D F A B E 11.2 KEYBOARD UNIT B SIDE A B KEYBOARD UNIT 1 1 5 10 15 20 25 30 35 40 45 50 55 60 65 1 5 1 1 1 1 1 1 1 1 1 1 1 5 1 S10 LCD1 S28 D3 D5 D6 D7 D8 D9 D10 D11 D12 D13 D14 D15 D27 D28 D29 D30 D31 D32 D33 D34 D35 D36 D37 IC2 R10 R16 R26 S1 S2 S3 S6 S7 S8 S9 CN2 CN3 S5 S4 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 X 40 30 20 10 0 Y 160 USB AUX EJECT REGION1 LIST RPT REGION2 S.Rtrv DISP RDM BAND SRC REGION1 REGION2 TA/NEWS MUTE CLOCK/ SW/BASS BUTTON C A,B,D DISP OFF model A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES MULTI CONTROL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 79 5 6 7 8 5 6 7 8 C D F A B E B SIDE B B KEYBOARD UNIT 160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 X 40 30 20 10 0 Y 10 1 1 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 E 5 1 E E 5 1 5 1 20 10 C1 C2 C3 C4 C5 C6 C7 C8 C9 D1 D2 D23 D24 L1 D42 D43 D44 IC1 R12 R13 R14 R15 R22 R23 R24 R25 Q4 Q5 Q6 Q7 R31 R32 R33 R34 R1 R35 R2 R36 R37 R3 R4 R38 R5 R39 R6 R7 R8 R40 R41 CN4 X1 C10 A CN803 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 80 1 2 3 4 1 2 3 4 C D F A B E 11.3 CD CORE UNIT(S10.5iPod-C3-CLASS1) C SIDE A C CD CORE UNIT(S10.5iPod-C3-CLASS1) HOME M2 LOADING/CARRIAGE MOTOR M1 SPINDLE MOTOR REFO1 F E A CN701 PICKUP UNIT(P10.5) (SERVICE) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 81 5 6 7 8 5 6 7 8 C D F A B E C C SIDE B CD CORE UNIT(S10.5iPod-C3-CLASS1) 8EJ 12EJ DSCSNS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 82 1 2 3 4 1 2 3 4 C D F A B E 12. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V The expression of the unit in this manual is shown by u instead of µ. Please do not make a mistake. Circuit Symbol and No. Part No. A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES Unit Number : YWM5360(A) Unit Number : YWM5361(B) Unit Number : YWM5359(C) Unit Number : YWM5362(D) Unit Name : Tuner Amp Assy Unit Number : (A) Unit Number : (B) Unit Number : (C) Unit Number : (D) Unit Name : Keyboard Unit Unit Number : CWX3727 Unit Name : CD Core Unit(S10.5iPod-C3-CLASS1) model A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES A Unit Number : YWM5360(A) Unit Number : YWM5361(B) Unit Number : YWM5359(C) Unit Number : YWM5362(D) Unit Name : Tuner Amp Assy MISCELLANEOUS IC 101 (B,70,67) IC(A,B,C) HA12241FP IC 151 (B,135,85) IC PML018A IC 251 (B,46,65) IC BD6538G IC 301 (A,104,139) IC PAL007C IC 401 (B,165,30) IC NJM2885DL1-33 IC 501 (B,16,32) IC BD9007F IC 601 (B,96,73) IC(A,B) PEG516A8 (B,96,73) IC(C) PEG513A8 (B,96,73) IC(D) PEG517A IC 702 (B,57,28) IC NJM2885DL1-33 IC 921 (A,6,121) IC NJM2388F84 IC 961 (B,77,49) IC S-80835CNMC-B8U Q 101 (B,40,96) Transistor(A,B,C) LSA1576UB Q 102 (B,30,115) Transistor(A,B,C) LTC114EUB Q 351 (B,165,126) Transistor RT3N66M Q 353 (B,136,122) Transistor(A,B,D) RT3N66M Q 401 (B,156,46) Transistor(C) UMH1N Q 402 (B,156,51) Transistor(C) UMH1N Q 451 (B,117,120) Transistor LTC124EUB Q 453 (B,116,117) Transistor RT3T22M Q 701 (B,20,61) Transistor RT3T22M Q 702 (A,7,70) Transistor 2SD2396 Q 841 (B,112,15) Transistor 2SA1036K Q 842 (B,116,13) Transistor LTC114EUB Q 851 (B,32,16) Transistor 2SA1036K Q 852 (B,23,17) Transistor LTC114EUB Q 911 (A,7,105) Transistor 2SD2396 Q 912 (B,15,73) Transistor RT3T22M Q 931 (B,64,95) Transistor RT3CLLM Q 951 (B,111,107) Transistor(C) 2SA1037K D 454 (A,94,106) Diode 1SS133 D 501 (B,23,43) Diode RB060L-40 D 502 (A,15,58) Diode 1SR139-400 D 701 (A,26,66) Diode HZS7L(C3) D 801 (B,79,13) Varistor EZJZ1V270RM D 802 (B,81,9) Varistor EZJZ1V270RM D 803 (B,83,10) Varistor EZJZ1V270RM Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 83 5 6 7 8 5 6 7 8 C D F A B E D 804 (B,76,13) Varistor EZJZ1V270RM D 805 (B,46,9) Varistor EZJZ1V270RM D 806 (B,63,13) Varistor EZJZ1V270RM D 807 (B,51,9) Varistor EZJZ1V270RM D 808 (B,61,13) Varistor EZJZ1V270RM D 809 (B,80,13) Varistor EZJZ1V270RM D 810 (B,97,16) Varistor EZJZ1V800AM D 811 (B,68,13) Varistor EZJZ1V800AM D 812 (B,41,10) Varistor EZJZ1V270RM D 813 (B,66,13) Varistor EZJZ1V270RM D 901 (A,74,111) Diode 1SR139-400 D 902 (A,77,108) Diode 1SR139-400 D 903 (A,61,104) Diode 1SR139-400 D 904 (A,59,104) Diode 1SR139-400 D 911 (A,15,81) Diode 1SR139-400 D 912 (A,15,76) Diode HZS6L(B2) D 931 (A,55,97) Diode HZS7L(C3) D 932 (A,53,94) Diode HZS7L(A1) D 951 (B,108,109) Diode(C) MC2848-11 ZNR401 (B,164,113) Surge Protector IMSA-6801-01Y901 L 101 (A,72,71) Inductor(A,B,C) LAU2R2K L 161 (A,122,100) Inductor LAU2R2K L 251 (B,49,59) Inductor CTF1394 L 401 (A,150,91) Inductor LAU1R0K L 402 (B,159,108) Inductor LCTAW220J2520 L 403 (A,151,38) Inductor LAU1R0K L 501 (A,28,41) Inductor YTF5003 L 601 (A,74,54) Ferri-Inductor LAU100K L 602 (A,73,52) Inductor LAU2R2K L 720 (B,94,39) Chip Cmmon Mode DTH1197 L 852 (A,37,16) Inductor LAU2R2K L 901 (A,38,103) Choke Coil 600 uH CTH1280 L 951 (A,69,104) Inductor(C) LAU2R2K X 601 (A,85,56) Oscillator 15 MHz YSS5002 FU353 (A,136,129) Poly Switch RXEF075P BZ601 (A,29,17) Buzzer(C) CPV1062 RESISTORS R 101 (B,31,123) (A,B,C) RS1/16S181J R 102 (B,34,115) (A,B,C) RS1/16S222J R 103 (B,23,125) (A,B,C) RS1/16S181J R 104 (B,35,135) (A,B,C) RS1/16S101J R 105 (B,33,136) (A,B,C) RS1/16S101J R 106 (B,29,122) (A,B,C) RS1/16S223J R 107 (B,25,125) (A,B,C) RS1/16S223J R 108 (B,26,125) (A,B,C) RS1/16S102J R 109 (B,28,122) (A,B,C) RS1/16S102J R 110 (B,36,96) (A,B,C) RS1/16S332J R 111 (B,32,112) (A,B,C) RS1/16S562J R 112 (B,70,75) (A,B,C) RS1/16S102J R 113 (B,77,71) (A,B,C) RS1/16S472J R 114 (B,78,71) (A,B,C) RS1/16S472J R 116 (B,31,136) (A,B,C) RS1/16S470J R 117 (B,30,136) (A,B,C) RS1/16S150J R 118 (B,66,74) (A,B,C) RS1/16S0R0J R 151 (B,145,89) RS1/16S102J R 152 (B,145,87) RS1/16S102J R 153 (B,145,86) RS1/16S102J R 254 (B,46,67) RS1/16S681J Circuit Symbol and No. Part No. R 255 (B,42,67) RS1/16S473J R 257 (B,40,69) RS1/16S104J R 301 (B,123,112) RS1/16S471J R 303 (B,124,109) RS1/16S471J R 304 (B,135,109) RS1/16S471J R 306 (B,130,110) RS1/16S471J R 309 (A,98,107) RD1/4PU153J R 351 (B,159,115) RS1/16S821J R 352 (B,156,120) RS1/16S0R0J R 355 (B,137,118) (A,B,D) RS1/16S821J R 356 (B,132,98) RS1/16S821J R 358 (B,132,125) (A,B,D) RS1/16S821J R 359 (B,163,134) RS1/16S223J R 360 (B,158,133) RS1/16S223J R 363 (B,135,125) (A,B,D) RS1/16S223J R 364 (B,140,126) (A,B,D) RS1/16S223J R 381 (B,136,125) (A,B,D) RS1/16S0R0J R 382 (B,140,122) (A,B,D) RS1/16S0R0J R 384 (B,148,118) RS1/16S0R0J R 393 (B,142,129) (A,B,D) RS1/16S0R0J R 394 (B,146,129) RS1/16S0R0J R 401 (B,150,56) RS1/16S681J R 402 (B,157,79) (C) RS1/16S681J R 403 (B,156,85) RS1/16S681J R 404 (B,156,89) RS1/16S681J R 405 (B,157,90) RS1/16S681J R 406 (B,156,92) RS1/16S681J R 407 (B,156,93) (A,B) RS1/16S0R0J (B,156,93) (C) RS1/16S102J R 408 (B,142,48) (C) RS1/16S223J R 409 (B,146,54) (C) RS1/16S223J R 410 (B,147,49) (C) RS1/16S223J R 411 (B,143,43) (C) RS1/16S223J R 413 (B,156,42) (C) RS1/16S221J R 414 (A,157,24) RD1/4PU4R7J R 415 (B,156,48) (C) RS1/16S221J R 421 (B,115,75) RS1/16S0R0J R 451 (B,121,118) RS1/16S103J R 452 (B,119,122) RS1/16S221J R 453 (B,121,126) RS1/16S153J R 454 (A,117,112) RD1/4PU102J R 501 (B,25,29) RS1/10SR471J R 502 (B,28,23) RS1/16S0R0J R 503 (B,25,24) RS1/16S4702D R 504 (B,23,24) RS1/16S6801F R 505 (B,25,34) RS1/16S1002F R 506 (B,25,31) RS1/16S393J R 507 (B,71,62) RS1/16S222J R 509 (B,10,33) RS1/16S392J R 510 (B,10,30) RS1/16S473J R 512 (B,49,22) RS1/16S0R0J R 513 (B,24,22) RS1/16S0R0J R 602 (B,82,63) RS1/16S103J R 603 (B,104,88) (A,C,D) RS1/16S103J R 604 (B,114,78) RS1/16S681J R 605 (B,112,76) RS1/16S681J R 606 (B,99,48) (A,C,D) RS1/16S103J R 607 (B,112,77) RS1/16S681J R 608 (B,98,52) (C) RS1/16S104J R 609 (B,101,54) (D) RS1/16S104J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 84 1 2 3 4 1 2 3 4 C D F A B E R 610 (B,110,81) RS1/16S473J R 611 (B,87,60) RS1/16S102J R 613 (B,106,88) RS1/16S104J R 615 (B,110,51) RS1/16S222J R 616 (B,35,28) RS1/16S473J R 617 (B,99,52) RS1/16S0R0J R 618 (B,71,60) (C) RS1/16S102J R 619 (B,112,74) (C) RS1/16S0R0J R 620 (B,115,83) RS1/16S0R0J R 621 (B,18,141) (A,C,D) RS1/16S102J R 622 (B,12,142) (A,C,D) RS1/16S102J R 627 (B,122,78) RS1/16S102J R 628 (B,13,139) (B) RS1/16S104J R 629 (B,15,140) (B) RS1/16S104J R 653 (B,132,37) (C,D) RS1/16S104J R 701 (A,15,63) RD1/4PU271J R 703 (B,49,44) RS1/16S472J R 704 (B,32,27) RS1/16S104J R 705 (B,49,47) RS1/16S472J R 706 (B,49,48) RS1/16S104J R 707 (B,36,29) RS1/16S104J R 708 (B,47,51) RS1/16S221J R 709 (B,35,25) RS1/16S102J R 710 (B,49,45) RS1/16S221J R 711 (B,37,41) RS1/16S221J R 712 (B,49,42) RS1/16S221J R 713 (B,35,26) RS1/16S221J R 714 (B,49,54) RS1/16S104J R 715 (B,110,41) RS1/16S12R0F R 716 (B,110,38) RS1/16S12R0F R 803 (B,107,48) RS1/16S473J R 804 (B,96,48) RS1/16S222J R 805 (B,94,48) RS1/16S222J R 806 (B,82,16) RS1/16S222J R 807 (B,74,76) RS1/16S222J R 808 (B,68,54) RS1/16S104J R 809 (B,61,17) RS1/16S222J R 810 (B,96,44) RS1/16S0R0J R 811 (B,96,52) RS1/16S473J R 812 (B,94,44) RS1/16S0R0J R 813 (B,92,48) RS1/16S104J R 814 (B,94,52) RS1/16S102J R 815 (B,93,52) RS1/16S102J R 816 (B,116,15) RS1/16S1R0J R 818 (B,50,11) RS1/16S0R0J R 819 (B,51,19) RS1/16S103J R 824 (B,108,51) RS1/16S102J R 825 (B,69,56) RS1/16S102J R 841 (B,108,15) RS1/16S103J R 842 (B,111,13) RS1/16S472J R 851 (B,33,20) RS1/16S153J R 852 (B,23,19) RS1/16S472J R 853 (B,39,15) RS1/16S222J R 911 (B,20,71) RS1/16S223J R 912 (A,15,78) RD1/4PU152J R 922 (B,10,110) RS1/16S473J R 931 (B,67,56) RS1/16S104J R 932 (B,100,100) RS1/16S104J R 933 (B,63,97) RS1/16S104J R 934 (B,63,98) RS1/16S473J Circuit Symbol and No. Part No. R 935 (B,59,92) RS1/16S473J R 936 (B,59,99) RS1/16S473J R 937 (B,62,118) RS1/16S472J R 938 (B,59,126) RS1/4SA102J R 951 (B,106,107) RS1/16S473J R 952 (B,106,105) (C) RS1/16S102J R 953 (B,115,108) (C) RS1/16S472J R 955 (A,71,104) (C) RD1/4PU153J R 962 (B,71,46) RS1/16S822J R 967 (B,73,46) RS1/16S102J R 968 (B,97,48) RS1/16S0R0J R 969 (B,34,74) RS1/4SA0R0J R 972 (B,87,13) RS1/16S0R0J R 973 (B,135,42) (C,D) RS1/16S104J CAPACITORS C 101 (B,28,136) (A,B,C) CKSRYB104K25 C 104 (B,70,73) (A,B,C) CKSRYB103K50 C 151 (B,111,96) (A,B,C) CKSRYB105K10 C 152 (B,117,96) (A,B,C) CKSRYB105K10 C 153 (B,159,75) CKSRYB224K10 C 154 (B,145,78) CKSRYB105K10 C 155 (B,163,72) CKSRYB224K10 C 156 (B,124,78) CKSRYB105K10 C 157 (B,112,96) (A,B,C) CKSRYB105K10 C 158 (B,115,96) (A,B,C) CKSRYB105K10 C 159 (B,124,81) CKSRYB105K10 C 160 (A,123,84) CEJQ100M16 C 162 (A,123,89) CEJQ470M10 C 163 (B,123,87) CKSRYB104K25 C 165 (A,135,98) CEJQ100M16 C 170 (B,145,76) CKSRYB104K25 C 251 (B,47,61) CKSRYB105K10 C 252 (B,42,64) CKSRYB105K10 C 305 (B,134,114) CKSQYB474K25 C 306 (B,127,114) CKSQYB474K25 C 307 (B,129,114) CKSQYB474K25 C 308 (B,132,114) CKSQYB474K25 C 309 (B,125,135) CKSQYB225K10 C 310 (B,128,132) CKSQYB225K10 C 311 (A,103,128) CEJQ100M16 C 313 (A,51,124) 3 300 uF/16 V CCH1494 C 315 (B,133,118) CKSRYB474K10 C 316 (B,124,115) CKSRYB474K10 C 317 (B,122,115) CKSRYB474K10 C 318 (B,131,118) CKSRYB474K10 C 351 (A,130,98) CEJQ2R2M50 C 352 (A,140,98) CEJQ2R2M50 C 355 (A,130,104) (A,B,D) CEJQ2R2M50 C 356 (A,146,104) (A,B,D) CEJQ2R2M50 C 401 (A,154,61) CEJQ470M6R3 C 402 (B,157,59) CKSRYB103K50 C 403 (B,157,43) CKSRYB103K50 C 404 (B,164,25) (C) CKSYB475K10 C 405 (A,154,103) CEJQ101M10 C 406 (B,167,95) CKSRYB104K25 C 407 (B,159,68) CKSRYB103K50 C 408 (A,157,31) CEJQ220M10 C 410 (B,154,27) (A,B,D) CKSRYB474K10 C 411 (B,167,93) (A,B,D) CCSRCH470J50 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 85 5 6 7 8 5 6 7 8 C D F A B E C 412 (B,128,135) CKSRYB105K10 C 451 (A,119,126) CEJQ330M10 C 501 (A,28,27) 150 uF/6.3 V CCH1804 C 502 (A,17,51) CEJQ221M16 C 503 (B,22,30) CCSRCH330J50 C 504 (B,14,37) CKSQYB225K16 C 506 (B,25,32) CKSRYB153K50 C 513 (B,63,64) CCSRCH680J50 C 601 (B,82,59) CCSRCH180J50 C 602 (B,86,58) CCSRCH180J50 C 603 (B,79,57) CKSRYB105K10 C 604 (B,91,48) CKSRYB105K10 C 605 (A,84,48) CEJQ100M16 C 606 (B,92,44) CKSRYB104K25 C 607 (A,77,44) CEJQ100M16 C 609 (B,115,81) CCSRCH470J50 C 621 (B,116,78) CCSRCH470J50 C 701 (B,21,58) CKSRYB473K25 C 703 (A,24,54) CEJQ101M10 C 704 (B,138,68) CKSRYB105K10 C 705 (B,126,78) CKSRYB105K10 C 708 (A,39,27) CEJQ220M10 C 709 (B,47,29) CKSRYB105K10 C 710 (B,45,28) CKSRYB474K10 C 720 (B,41,55) CKSRYB105K10 C 802 (B,46,10) CKSRYB104K25 C 851 (B,25,13) CKSRYB104K25 C 901 (B,54,118) CKSRYB104K25 C 911 (A,15,69) CEJQ470M10 C 912 (B,21,74) CKSRYB103K50 C 913 (A,24,74) CEAT102M16 C 921 (B,11,113) CKSRYB103K50 C 922 (A,17,99) CEJQ221M10 C 923 (A,15,117) CEJQ101M16 C 924 (B,14,115) CKSRYB103K50 C 961 (B,72,48) CKSRYB473K25 C 962 (A,86,44) CEJQ100M16 B Unit Number: (A) Unit Number: (B) Unit Number: (C) Unit Number: (D) Unit Name : Keyboard Unit MISCELLANEOUS IC 1 (B,94,18) IC PD6538A IC 2 (A,107,7) Remote IC GP1UXC14RK Q 4 (B,53,25) Transistor LTC114EUB Q 7 (B,46,32) Chip Transistor 2SD2114K D 1 (B,104,12) Diode MC2848-11 D 2 (B,107,11) Diode MC2846-11 D 3 (A,50,22) White LED NESW505C-5273 D 5 (A,42,10) LED(A,B) CL-195PG-CD (A,42,10) LED(C) CL-195SR-CD (A,42,10) LED(D) CL-197HB1-D(CDE) D 6 (A,147,40) LED(A,B) CL-195PG-CD (A,147,40) LED(C) CL-195SR-CD Circuit Symbol and No. Part No. (A,147,40) LED(D) CL-197HB1-D(CDE) D 7 (A,6,34) LED(A,B) CL-195PG-CD (A,6,34) LED(C) CL-195SR-CD (A,6,34) LED(D) CL-197HB1-D(CDE) D 8 (A,7,40) LED(A,B) CL-195PG-CD (A,7,40) LED(C) CL-195SR-CD (A,7,40) LED(D) CL-197HB1-D(CDE) D 9 (A,6,9) LED(A,B) CL-195PG-CD (A,6,9) LED(C) CL-195SR-CD (A,6,9) LED(D) CL-197HB1-D(CDE) D 10 (A,13,9) LED(A,B) CL-195PG-CD (A,13,9) LED(C) CL-195SR-CD (A,13,9) LED(D) CL-197HB1-D(CDE) D 11 (A,16,31) LED(A,B) CL-195PG-CD (A,16,31) LED(C) CL-195SR-CD (A,16,31) LED(D) CL-197HB1-D(CDE) D 12 (A,26,28) LED(A,B) CL-195PG-CD (A,26,28) LED(C) CL-195SR-CD (A,26,28) LED(D) CL-197HB1-D(CDE) D 13 (A,26,9) LED(A,B) CL-195PG-CD (A,26,9) LED(C) CL-195SR-CD (A,26,9) LED(D) CL-197HB1-D(CDE) D 14 (A,42,26) LED(A,B) CL-195PG-CD (A,42,26) LED(C) CL-195SR-CD (A,42,26) LED(D) CL-197HB1-D(CDE) D 15 (A,57,8) LED(A,B) CL-195PG-CD (A,57,8) LED(C) CL-195SR-CD (A,57,8) LED(D) CL-197HB1-D(CDE) D 23 (B,137,18) Varistor EZJZ1V800AM D 24 (B,135,18) Varistor EZJZ1V800AM D 42 (B,127,13) Diode MALS068X D 43 (B,129,9) Diode MALS068X D 44 (B,131,9) Diode MALS068X X 1 (B,102,7) Ceramic Resonator 5.00 MHz CSS1547 S 1 (A,16,33) Push Switch CSG1155 S 2 (A,6,7) Push Switch CSG1155 S 3 (A,6,37) Push Switch CSG1155 S 4 (A,23,29) Push Switch CSG1155 S 5 (A,44,29) Push Switch CSG1155 S 6 (A,44,8) Push Switch CSG1155 S 7 (A,53,7) Push Switch CSG1155 S 8 (A,16,6) Push Switch CSG1155 S 9 (A,23,8) Push Switch CSG1155 S 10 (A,146,37) Push Switch CSG1155 S 28 (A,33,18) Switch(MULTI-CONTROL) CSX1144 LCD1 (A,56,31) LCD YAW5101 RESISTORS R 1 (B,67,19) RS1/16S222J R 2 (B,96,5) RS1/16S222J R 3 (B,58,22) RS1/4SA122J R 4 (B,152,40) (A,B) RS1/4SA681J (B,152,40) (C) RS1/4SA122J (B,152,40) (D) RS1/4SA392J R 5 (B,11,23) (A,B) RS1/4SA681J (B,11,23) (C) RS1/4SA122J (B,11,23) (D) RS1/4SA392J R 6 (B,10,18) (A,B) RS1/4SA681J (B,10,18) (C) RS1/4SA122J (B,10,18) (D) RS1/4SA392J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 86 1 2 3 4 1 2 3 4 C D F A B E R 7 (B,16,26) (A,B) RS1/4SA681J (B,16,26) (C) RS1/4SA122J (B,16,26) (D) RS1/4SA392J R 8 (B,22,28) (A,B) RS1/4SA681J (B,22,28) (C) RS1/4SA122J (B,22,28) (D) RS1/4SA392J R 10 (A,63,9) (A,B) RS1/16S181J (A,63,9) (C) RS1/16S331J (A,63,9) (D) RS1/16S102J R 22 (B,20,10) RS1/16S222J R 23 (B,18,12) RS1/16S332J R 24 (B,19,7) RS1/16S822J R 25 (B,22,8) RS1/16S273J R 26 (A,79,7) RS1/16S473J R 31 (B,105,8) RS1/16S103J R 32 (B,102,4) RS1/16S2R2J R 34 (B,107,14) RS1/16S121J R 37 (B,44,27) RS1/16S103J R 38 (B,46,29) RS1/16S103J R 40 (B,133,15) RS1/16S101J R 41 (B,128,15) RS1/16S101J CAPACITORS C 1 (B,107,7) CKSYF106Z10 C 2 (B,112,16) CKSRYF104Z25 C 3 (B,114,16) CKSRYF104Z25 C 4 (B,117,17) CKSRYF104Z25 C 5 (B,129,13) CKSRYB472K50 C 6 (B,131,15) CKSRYB472K50 C 7 (B,152,37) CCSRCH101J50 C 8 (B,149,37) CCSRCH102J50 C 9 (B,151,37) CKSRYB103K50 C 10 (B,137,23) CKSRYF104Z25 C Unit Number : CWX3727 Unit Name : CD Core Unit(S10.5iPod-C3-CLASS1) MISCELLANEOUS IC 201 (A,35,46) IC PE5661A IC 205 (B,24,49) IC 341S2159 IC 301 (A,28,15) IC BA5839FP Q 101 (B,58,69) Transistor 2SA1577 Q 102 (B,48,58) Chip Transistor 2SB1689 Q 201 (B,27,54) Transistor 2SA1577 X 201 (A,22,37) Ceramic Resonator 16.934 MHz CSS1603 X 205 (B,33,63) Oscillator 48.000 MHz CSS1753 S 901 (A,55,37) Switch(HOME) CSN1067 S 903 (B,19,58) Switch(DSCSNS) CSN1067 S 904 (B,40,68) Switch(12EJ) CSN1068 S 905 (B,25,69) Switch(8EJ) CSN1068 RESISTORS R 101 (B,61,74) RS1/10SR2R4J R 102 (B,61,72) RS1/10SR2R4J R 103 (B,61,71) RS1/10SR2R7J R 104 (B,53,66) RS1/16SS222J R 105 (B,44,57) RS1/16SS102J R 107 (B,52,60) RS1/16SS105J Circuit Symbol and No. Part No. R 202 (A,27,32) RS1/16SS473J R 203 (A,51,44) RS1/16S473J R 204 (A,23,58) RS1/16SS221J R 206 (B,10,26) RS1/16SS104J R 209 (B,18,52) RS1/16SS103J R 210 (B,10,23) RS1/16SS102J R 214 (B,49,50) RS1/16SS472J R 216 (B,48,49) RS1/16SS472J R 221 (A,51,48) RS1/16SS103J R 222 (A,51,46) RS1/16SS103J R 223 (B,13,43) RS1/16SS473J R 225 (A,50,50) RS1/16SS103J R 226 (A,50,51) RS1/16SS393J R 227 (B,47,51) RS1/16SS562J R 228 (B,44,51) RS1/16SS122J R 229 (B,46,53) RS1/16SS472J R 230 (B,21,25) RS1/16SS0R0J R 232 (B,45,51) RS1/16SS122J R 233 (B,26,59) RS1/16SS103J R 234 (B,22,26) RS1/16SS473J R 235 (A,26,59) RS1/16SS473J R 237 (A,24,35) RS1/16SS151J R 240 (B,14,26) RS1/16S473J R 241 (B,13,25) RS1/16SS103J R 244 (B,22,55) RS1/16SS473J R 249 (B,14,50) RS1/16SS103J R 250 (B,19,50) RS1/16SS101J R 252 (B,18,47) RS1/16SS101J R 254 (A,25,64) RS1/16SS104J R 255 (A,26,63) RS1/16SS104J R 256 (A,25,62) RS1/16SS104J R 259 (A,27,66) RS1/16SS0R0J R 261 (A,26,65) RS1/16SS104J R 262 (A,29,59) RS1/16SS0R0J R 263 (A,27,63) RS1/16SS0R0J R 273 (B,18,48) RS1/16SS103J R 277 (B,18,50) RS1/16SS103J R 282 (A,30,61) RS1/16SS120J R 283 (A,29,61) RS1/16SS120J R 284 (B,29,63) RS1/16SS153J R 285 (B,28,63) RS1/16SS153J R 291 (B,42,62) RS1/16SS272J R 292 (B,24,43) RS1/16SS272J R 293 (B,27,52) RS1/16SS472J R 294 (A,31,62) RS1/16SS471J R 307 (A,35,19) RS1/16SS183J R 308 (A,37,19) RS1/16SS183J R 309 (A,35,21) RS1/16SS183J R 310 (A,37,22) RS1/16SS183J R 601 (B,30,31) RS1/16SS0R0J R 602 (B,27,31) RS1/16SS0R0J R 606 (B,28,23) RS1/16S0R0J R 701 (B,11,37) RS1/16SS221J R 702 (A,23,56) RS1/16SS221J R 708 (B,15,37) RS1/16S0R0J R 712 (B,14,54) RS1/16SS0R0J R 713 (B,14,53) RS1/16SS0R0J CAPACITORS Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-P310UB/XS/UC 87 5 6 7 8 5 6 7 8 C D F A B E C 106 (B,56,67) CKSQYB475K10 C 202 (A,28,57) CKSSYB104K10 C 204 (A,23,59) CKSSYB103K16 C 205 (B,27,41) CKSQYB475K10 C 206 (A,23,40) CKSSYB104K10 C 207 (A,24,37) CKSRYB104K16 C 209 (B,35,34) CEVW220M6R3 C 210 (B,29,37) CKSSYB104K10 C 211 (A,28,35) CKSSYB104K10 C 212 (A,28,30) CKSRYB104K16 C 213 (A,46,39) CKSSYB104K10 C 214 (A,29,33) CKSSYB104K10 C 216 (A,51,52) CKSSYB332K50 C 217 (A,48,51) CKSSYB104K10 C 218 (A,50,52) CKSSYB473K10 C 219 (A,47,53) CKSSYB104K10 C 220 (A,48,53) CKSSYB182K50 C 221 (A,46,54) CKSSYB104K10 C 222 (B,45,53) CCSSCH560J50 C 223 (B,47,53) CCSSCH4R0C50 C 224 (A,44,55) CKSSYB104K10 C 226 (A,42,59) CCSSCH680J50 C 227 (A,42,61) CCSSCH470J50 C 228 (B,41,61) CKSSYB103K16 C 229 (B,48,60) CKSSYB104K10 C 236 (A,49,58) CKSSYB104K10 C 239 (B,46,51) CCSSCH220J50 C 240 (A,38,61) CKSSYB104K10 C 243 (B,22,41) CKSQYB475K10 C 250 (A,52,48) CKSSYB102K50 C 251 (A,52,46) CKSSYB102K50 C 260 (A,28,61) CKSSYB104K10 C 261 (B,33,66) CCSSCH8R0D50 C 262 (B,31,66) CCSSCH8R0D50 C 290 (B,26,45) CKSSYB104K10 C 293 (B,43,61) CKSSYB102K50 C 294 (B,24,41) CKSSYB104K10 C 303 (A,36,19) CKSSYB472K25 C 304 (A,36,21) CKSSYB223K16 C 307 (A,22,11) CKSRYB104K16 C 308 (B,11,18) CKSRYB105K10 C 703 (B,14,35) CCSSCH101J50 C 704 (B,11,36) CKSSYB102K50 C 711 (A,31,25) CKSSYB104K10 Miscellaneous Parts List Pickup Unit(P10.5)(Service) CXX1942 M 1 Motor Unit(SPINDLE) CXC7134 M 2 Motor Unit(LOADING/CARRIAGE) CXC4026 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com