ORDER NO. PIONEER ELECTRONIC CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER ELECTRONIC (EUROPE) N.V. Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 501 Orchard Road, #10-00 Wheelock Place, Singapore 238880 � � � � � � � � � �PIONEER ELECTRONIC CORPORATION 1998 RRV2036 CONTENTS T – ZZK OCT. 1998 Printed in Japan 1. SAFETY INFORMATION ...................................... 2 2. EXPLODED VIEWS AND PARTS LIST ................ 3 3. SCHEMATIC DIAGRAM ..................................... 14 4. PCB CONNECTION DIAGRAM .......................... 34 5. PCB PARTS LIST ............................................... 49 6. ADJUSTMENT .................................................... 55 7. GENERAL INFORMATION ............................... 61 7.1 PARTS ......................................................... 61 7.1.1 IC ......................................................... 61 7.1.2 DISPLAY.............................................. 73 7.2 DISASSEMBLY ........................................... 75 7.3 BLOCK DIAGRAM ....................................... 78 8. PANEL FACILITIES AND SPECIFICATIONS .... 80 STEREO CD/VCD CASSETTE DECK RECEIVER XR-VS99 THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Type Model Power Requirement The Voltage can be converted by XR-VS99 the following method. DBDXJ AC110-127V/220-230V/240V With the voltage selector DLXJ/NC AC110-127V/220-230V/240V With the voltage selector PREV NEXT RETURN SELECT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 XR-VS99 Printed on the Rear Panel LABEL CHECK (For DLXJ/NC type) Additional Laser Caution 1. Laser Interlock Mechanism The position of the switch (S8501) for detecting loading state is detected by the system microprocessor, and the design prevents laser diode oscillation when the switch (S8501) is pressed physically. Thus, the interlock will no longer function if the switch (S8501) is released physically and deliberatery. The interlock also does not function in the test mode ∗. Laser diode oscillation will continue, if pin 62 of LA9240ML (IC8101) on the CD ASSY mounted on the $M Loading Mechanism assembly is connected to GND, or else the terminals of Q8101 are shorted to each other (fault condition). 2. When the cover is opened, close viewing of the objective lens with the naked eye will cause exposure to a Class 1 laser beam. ∗ : Refer to page 60. 1. SAFETY INFORMATION This service manual is intended for qualified service technicians ; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. IMPORTANT THIS PIONEER APPARATUS CONTAINS LASER OF CLASS 1. SERVICING OPERATION OF THE APPARATUS SHOULD BE DONE BY A SPECIALLY INSTRUCTED PERSON. LASER DIODE CHARACTERISTICS MAXIMUM OUTPUT POWER: 1.3 mW WAVELENGTH: 790 nm ± 25 nm www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 XR-VS99 2.1 PACKING 1 FM Antenna ADH7004 2 Operating Instructions XRE3019 (English/Chinese) 3 AM Loop Antenna XTB3001 4 Remote Control Unit XZN3010 (CU-XR052) 5 Battery Cover AZA7204 NSP 6 Dry Cell Battery (R6P, AA) VEM-013 7 Polyethylene Bag Z21-038 (0.03 × 230 × 340) 8 Front Pad XHA3005 (1) PACKING PARTS LIST Mark No. Description Part No. 2. EXPLODED VIEWS AND PARTS LIST NOTES: • Parts marked by "NSP" and can not be supplied. • The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. • Screws adjacent to mark on the product are used for disassembly. 9 Rear Pad XHA3006 10 Packing Case See Contrast table (2) 11 Packing Sheet AHG7049 12 • • • • • 13 Power Cord See Contrast table (2) NSP 14 Polyethylene Bag AHG7033 15 Operating Instructions XRE3018 16 Video Cord VDE1034 NSP 17 Caution Card XAX3130 NSP 18 Door Spacer XHG3002 Mark No. Description Part No. (2) CONTRAST TABLE XR-VS99/DBDXJ and DLXJ/NC are constructed the same except for the following : Mark No. Symbol and Description Part No. Remarks XR-VS99 XR-VS99 /DBDXJ /DLXJ/NC 10 Packing Case XHD3055 XHD3038 13 Power Cord ADG1158 ADG1154 VOL KARAOKE SFC DISC DISC DISC CLEAR STATION REMOTE CONTROL UNIT CU-XR025 MONO BAND PGM REPEAT RANDOM AUX P.BASS DISPLAY SLEEP POWER 6 16 1 3 7 9(1/2) 8(1/2) 8(2/2) 9(2/2) 10 2 13 14 11 15 4 5 18 17 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 XR-VS99 2.2 EXTERIOR (1/2) 2 12 12 Note : Attatch on the same numbers × three. Refer to "2.5 $M MECHANISM VCD". Note : Hook Tray cap on top of loading tray and then insert the bottom three hooks. 9 9 11 15 11 15 11 1 6 10 4 5 7 14 13 3 9 8 17 16 18 9 19 19 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 XR-VS99 (1) EXTERIOR (1/2) PARTS LIST Mark No. Description Part No. 1 16P F.F.C/30V XDD3006 NSP 2 $M Mechanism VCD XXA3007 3 Volume Knob XAA3005 4 FL Cover A XAK3026 5 FL Cover B XAK3036 6 Tray Cap XZN3047 7 Display Panel XAK3047 8 Bonnet Case XZN3040 9 Screw BPZ30P100FZK 10 Pioneer Badge XZN3049 11 Screw VBT30P080FZK 12 Disc Label XAX3127 13 Jog Knob Assy XXG3024 14 Bass Knob XAB3005 15 Screw BCZ30P080FZK 16 Cord Stopper DNF1128 17 Push Rivet AEC7138 18 Mic Knob XAB3004 19 Cushion Rubber XEB3002 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 XR-VS99 2.3 EXTERIOR (2/2) b b d a a a a a a a b b b b b b c c c c a a b a c d 19 Refer to "2.4 FRONT PANEL SECTION". 8 17 19 19 19 29 22 7 11 33 19 19 13 27 35 27 16 34 30 38 28 28 2 3 6 5 4 9 10 14 15 25 36 21 19 31 32 37 41 42 18 1 19 24 24 24 19 26 24 19 24 11 22 39 40 A A 43 DLXJ/NC Type only www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 XR-VS99 (1) EXTERIOR (2/2) PARTS LIST Mark No. Description Part No. 1 AF Assy XWZ3136 2 SECONDARY Assy XWZ3137 3 PRIMARY Assy XWZ3111 4 FM/AM TUNER MODULE AXQ7065 5 Power Transformer (T1) XTS3018 6 Fuse (FU2, FU3 : T3.15A) AEK1059 7 Fuse (FU1 : 6.3A) REK1030 NSP 8 Chassis XNA3001 9 DC Fan Motor AXM7003 10 Fan Plate ANG7153 11 PCB Bracket XNG3006 12 • • • • • 13 Heat Sink XNH3004 14 Wire Clip A XEC3003 15 Rear Panel XNC3007 16 Cord Stopper DNF1128 NSP 17 SUPPORT Assy XNP3009 18 Screw BBZ30P140FMC 19 Screw VBZ30P080FZK 20 • • • • • 21 Screw ASZ40P060FMC 22 Binder ZCA-SKB90BK 23 • • • • • 24 Screw BPZ30P100FZK 25 Screw BBZ30P300FMC NSP 26 Name Label See Contrast table (2) 27 Screw BBZ30P060FMC 28 Screw IBZ30P135FMC 29 SUB TRANS Assy XWZ3113 30 REAR AMP Assy XWZ3160 31 TRADE Assy XWZ3140 32 PRO LOGIC Assy XWZ3133 33 H.S.Bracket XNG3007 34 FET Bracket XNG3009 35 H.S.Support XNG3014 36 Wire Clip B XEC3004 37 PCB Spacer B XEC3005 38 Mica Sheet XEE3002 39 Locking Spacer XEC3009 40 Card Spacer XEC3008 41 Push Rivet AEC7069 42 Shield Plate XNK3004 43 Caution Label See Contrast table (2) Mark No. Description Part No. (2) CONTRAST TABLE XR-VS99/DBDXJ and DLXJ/NC are constructed the same except for the following : Mark No. Symbol and Description Part No. Remarks XR-VS99 XR-VS99 /DBDXJ /DLXJ/NC NSP 26 Name Label XAL3015 Not used 43 Caution Label Not used PRW1018 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8 XR-VS99 2.4 FRONT PANEL SECTION 17 17 26 32 23 15 18 19 21 21 33 30 31 27 13 14 16 25 24 35 2 1 6 7 17 8 36 34(2/2) 34(1/2) 37 20 28 44 43 45 17 6 38 Refer to "2.7 MECHANISM UNIT". 40 12 17 17 10 46 9 17 3 5 42 41 39 A A B 11 17 17 B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9 XR-VS99 (1) FRONT PANEL SECTION PARTS LIST Mark No. Description Part No. Mark No. Description Part No. 1 DISPLAY Assy XWZ3138 2 CD SW LED Assy XWZ3131 3 SUB DISPLAY Assy XXG3014 4 • • • • • 5 Cord With Plug DE007VE0 6 Flexible Cable 14P XDD3011 7 Flexible Cable 19P XDD3009 8 Flexible Cable 40P XDD3005 9 Connector Assy 3P XDE3013 10 Connector Assy 5P XDE3014 11 GND Plate A XNG3004 12 Mechanism Unit XYM3003 13 Door Spring L XBH3001 14 Door Spring R XBH3002 15 Latch Spring L ABH7130 16 Latch Spring R ABH7131 17 Screw BPZ30P100FZK 18 Latch Mold L XMR3001 19 Latch Mold R XMR3002 NSP 20 Jog Lens XAK3025 21 Damper Assy AXA7052 22 • • • • • NSP 23 Front Panel Assy XXG3015 24 Function Button XZN3020 25 CD Button XZN3018 26 CD Lens XZN3037 27 Deck Lens L XZN3035 28 Deck Lens R XZN3036 29 • • • • • 30 Door Pocket L XZN3013 31 Door Pocket R XZN3015 32 Front Panel A XZN3011 33 Sub Panel A XZN3032 34 Power Button XZN3022 35 Play Button XZN3024 36 S.C. Button XZN3026 37 TIMER Button XZN3029 38 Sub Buttun XAD3012 39 Dolby Lens XAK3034 40 Diffusion Sheet XAK3035 41 Dolby Panel XAK3042 42 Button Lens XAK3044 NSP 43 Front Panel Assy B XXG3028 44 Sub Panel B XZN3054 45 Front Panel B XZN3051 46 Binder ZCA-SKB90BK www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10 XR-VS99 2.5 $M MECHANISM VCD 8 7 14 13 12 26 15 21 25 22 24 23 11 5 2 1 10 16 18 29 29 6 17 19 9 27 28 29 29 29 Refer to "2.6 SERVO MECHANISM ASSY". 29 29 29 29 4 3 30 20 B B A A 31 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 XR-VS99 1 Servo Mechanism AXA7039 2 SPINDLE MOTOR Assy AEA7009 3 SLEAD MOTOR Assy AEA7010 4 Gear A AEA7013 5 Gear B AEA7014 6 Screw AEA7015 7 Screw AEA7016 8 Screw AEA7017 9 Screw AEA7018 10 Leaf Switch AEA7011 Mark No. Description Part No. • SERVO MECHANISM ASSY PARTS LIST 2.6 SERVO MECHANISM ASSY 1 9 9 9 7 4 5 8 6 3 2 10 9 • $M MECHANISM VCD PARTS LIST Mark No. Description Part No. 1 MOTOR Assy XWZ3080 NSP 2 SW Assy XWZ3081 3 VCD SURVO Assy XWX3003 4 TRADE Assy XWZ3082 5 Servo Spring ABH7126 6 Belt AEB7072 7 Clamp Magnet AMF7001 8 Yoke ANB7067 9 Mecha Base XNW3001 10 Loading Tray XNW3002 11 Servo Base XNW3003 12 Rotary Tray ANW7113 13 Clamper ANW7091 14 Clamper Holder XNW3004 15 Main Cam ANW7093 16 Gear Pully ANW7094 17 Lock Lever ANW7095 18 Planet Gear ANW7096 19 Actuater ANW7097 20 13P F.F.C/30V XDD3008 21 15P F.F.C/30V XDD3007 22 Connector Assy (6P) ADE7010 23 Float Rubber A AEB7063 24 Float Rubber B AEB7066 25 Servo Mechanism Assy AXA7039 26 Screw IPZ30P080FMC 27 Carriage Motor VXM1033 28 Motor Pulley PNW1634 29 Ha Narl GEM1016 30 Card Spacer AEC7143 31 Cushion Rubber XEB3004 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 XR-VS99 2.7 MECHANISM UNIT 1 10 13 12 Mech. Ι Mech. ΙΙ Mech. ΙΙ Mech. Ι Mech. ΙΙ Only Mech. Ι Only Mech. ΙΙ Only 1 9 4 2 7 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 XR-VS99 5 11 8 6 Mark No. Description Part No. • MECHANISM UNIT PARTS LIST 1 Plate HD BLK (Mech. ΙΙ) F513-811 1 Plate HD BLK (Mech. Ι) F513-819 2 Motor Main BLK (Mech. ΙΙ only) F525-324 3 • • • • • 4 PCB Control BLK F567-621 5 Clutch Assy BLK F522-037 6 Main Belt FF17G-31 7 Joint Belt 113 (Mech. ΙΙ only) FF19D-21 8 Clutch Assy BLK F522-045 9 Roller Pinch BLK R F514-129 10 Roller Pinch BLK L F514-130 11 F/R Belt FF18W-12 12 Plate Base BLK F512-127 13 Plate Base BLK F512-128 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 14 A B C D 1 2 3 4 1 2 3 4 3. SCHEMATIC DIAGRAM 3.1 OVERALL WIRING DIAGRAM 1/3 AF ASSY (XWZ3136) DISPLAY ASSY (XWZ3138) SERVO MECHANISM ASSY (AXA7039) E VCD SURVO ASSY (XWX3003) CN1053 CN1001 CN9001 CN9002 CN1002 DECK MECHA B I SUB DISPLAY ASSY (XWZ3132) K FM/AM TUNER MODULE (AXQ7065) A E 3/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 15 A B C D 5 6 7 8 5 6 7 8 Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". CN9501 REAR AMP ASSY (XWZ3160) L SECONDARY ASSY (XWZ3137) F CD SW LED ASSY (XWZ3131) J PRIMARY ASSY (XWZ3111) G SUB TRANS ASSY (XWZ3113) H MOTOR ASSY (XWZ3080) C SW ASSY (XWZ3081) TRADE ASSY (XWZ3140) M PRO LOGIC ASSY (XWZ3133) N DA DB TRADE ASSY (XWZ3082) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 16 A B C D 1 2 3 4 1 2 3 4 3.2 FM/AM TUNER MODULE RF AMP 1T378A 1T378A MIX AMP BUFFER IF AMP FM +B SW MW RF TUNING BLOCK AKX7041 OSC FM/AM TUNER MODULE (AXQ7065) A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 17 A B C D 5 6 7 8 5 6 7 8 AF AMP REGULATOR PLL AF AMP 2/3 E CN3051 A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 18 A B C D 1 2 3 4 1 2 3 4 DA SW ASSY (XWZ3081) DB TRADE ASSY (XWZ3082) 1 2 3.3 VCD SURVO, MOTOR, SW and TRADE ASSEMBLIES 1/2 B DA DB www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 19 A B C D 5 6 7 8 5 6 7 8 VCD SURVO ASSY (1/2) (XWX3003) B 1/2 2/2 B 2/2 B 2/2 B SIGNAL ROUTE :CD AUDIO SIGNAL ROUTE : FOCUS SERVO LOOP LINE : TRACKING SERVO LOOP LINE : SPINDLE MOTOR ROUTE : CARRIAGE MOTOR ROUTE : LOADING MOTOR ROUTE (CD) (FS) (TS) (SM) (CM) (LM) C MOTOR ASSY (XWZ3080) CN1003- Pin 3 : PLAY MODE (RF) VREF:CN1003- Pin1 VREF 2.0Vp-p CN1003- Pin 2 : TEST MODE, Tracking Open(TRER) 1.0Vp-p H : 500nsec/div H : 5msec/div VREF 1 2 Note: The encircled numbers denote measuring point in the schematic diagram. C 1/2 B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 20 A B C D 1 2 3 4 1 2 3 4 2/2 B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 21 A B C D 5 6 7 8 5 6 7 8 VCD SURVO ASSY (2/2) (XWX3003) B 2/2 1/2 B 2/3 E 1/2 B CN1053 SIGNAL ROUTE :CD AUDIO SIGNAL ROUTE (CD) (CD) (CD) 2/2 B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 22 A B C D 1 2 3 4 1 2 3 4 3.4 AF ASSY (1/3) 1/3 AF ASSY (XWZ3136) : DECK PB SIGNAL ROUTE E (PB) : DECK REC SIGNAL ROUTE (REC) (PB) (PB) (PB) (PB) (PB) (REC) (REC) (REC) (REC) (REC) (REC) (REC) (PB) 22k 22k 0.022 C2323 0.022 33k 33k 220k 220k 0.01 1/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 23 A B C D 5 6 7 8 5 6 7 8 2/3 E 2/3 E 2/3 E (REC) (REC) (REC) (REC) (REC) (PB) (PB) (PB) (PB) (PB) (PB) (PB) 22k 22k IC2101(2/2) BA4558F–HT IC2101(1/2) BA4558F–HT 1/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 24 A B C D 1 2 3 4 1 2 3 4 3.5 AF ASSY (2/3) XR-A770:XKB3002 XR-A880:VKB1060 R3019,R3020 : 1.8k BA4558F-HT BA4558F-HT BA4558F-HT 22p 1 100k 180k 3/3 E CN83 H CN3702 M CN5501 I CN1004 B (TA) (TA) (TA) (TA) (CD) (CD) (CD) (CD) (CD) (PB) (PB) (PB) (PB) (PB) (PB) (PB) (C) (C) (B) (B) (B) (B) (B) (C) (C) (C) (C) (C) (C) (B) (B) (B) (B) (F/W) (F/W) (B) (B) (F/W) (F/W) (F/W) (B) (C) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) (PRO) (PRO) (C) 2/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 25 A B C D 5 6 7 8 5 6 7 8 BA4558F-HT 1SS133 1SS133 BA4558F-HT 1SS355 BA4558F-HT BA4558F-HT 2/3 AF ASSY (XWZ3136) 3/3 : AUDIO SIGNAL ROUTE E 3/3 E 3/3 E 3/3 E E : CD AUDIO SIGNAL ROUTE (CD) : CENTER SIGNAL ROUTE (C) : SURROUND/TWEETER SIGNAL ROUTE (S/T) : FRONT/WOOFER SIGNAL ROUTE (F/W) : PRO LOGIC SIGNAL ROUTE (PRO) : PRO LOGIC SIGNAL ROUTE (B) : TUNER AUDIO SIGNAL ROUTE (TA) : DECK PB SIGNAL ROUTE (PB) : DECK REC SIGNAL ROUTE (REC) 3/3 E 1/3 E CN6201 A (TA) (TA) (PB) (PB) (REC) (REC) (PB) (B) (B) (B) (B) (B) (B) (B) (B) (B) (B) (B) (F/W) (F/W) (F/W) (F/W) (B) (B) (B) (B) (C) (C) (C) (S/T) (S/T) (S/T) 2/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 26 A B C D 1 2 3 4 1 2 3 4 3.6 AF (3/3) and SECONDARY ASSEMBLIES 2/3 E 2/3 E 2/3 E J3401 L BA4558F-HT BA4558F-HT BA4558F-HT BA4558F-HT 2.2/50 2.2/50 2.2/50 2.2/50 4.7k 8.2k 8.2k 4.7k 2.2/50 D7674 U1GC44 D7673 2.2/50 1/2 2/2 1/2 2/2 100k 1.8k 1.8k 3.3k 3.3k 100k 2/3 E 2/3 E 120k 120k 120k 120k 1/2 2/2 BA4558F-HT 2SC5200(P) BA4558F-HT 820p 820p : CENTER SIGNAL ROUTE (C) : SURROUND/TWEETER SIGNAL ROUTE (S/T) : FRONT/WOOFER SIGNAL ROUTE (F/W) (C) (C) (C) (S/T) (S/T) (S/T) (C) (C) (S/T) (S/T) (S/T) (S/T) (C) (C) (C) (S/T) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) 3/3 E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 27 A B C D 5 6 7 8 5 6 7 8 3/3 AF ASSY (XWZ3136) E XKN3001 2SA1037K F SECONDARY ASSY(XWZ3137) POWER TRANSFORMER 10 FL 470/10 470/10 1000/10 1000/10 (C) (C) (C) (C) (C) (S/T) (S/T) (S/T) (S/T) (S) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) (F/W) CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491010F MFD, BY LITTELFUSE INK. FOR IC11, 12 (AEK7068). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491.400 MFD, BY LITTELFUSE INK. FOR IC23 (AEK7004). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 4911.25 MFD, BY LITTELFUSE INK. FOR IC3331 (AEK7010). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491002 MFD, BY LITTELFUSE INK. FOR IC33 (AEK7013). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491.630 MFD, BY LITTELFUSE INK. FOR IC71 (AEK7006). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491005 MFD, BY LITTELFUSE INK. FOR IC41 (AEK7019). CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491007 MFD, BY LITTELFUSE INK. FOR IC21, 22, 31 (AEK7021). 3/3 E F www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 28 A B C D 1 2 3 4 1 2 3 4 3.7 PRIMARY and SUB TRANS ASSEMBLIES H SUB TRANS ASSY (AWZ3113) J81 G PRIMARY ASSY (XWZ3111) 2/3 E 10000p/250 AEK1059 (T3.15A) AEK1059 (T3.15A) POWER TRANSFORMER G H www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 29 A B C D 5 6 7 8 5 6 7 8 AN1 LIVE NEUTRAL REK1030 (6.3A) • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS ONLY. CAUTION - H www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 30 A B C D 1 2 3 4 1 2 3 4 3.8 DISPLAY and CD SW LED ASSEMBLIES DISPLAY ASSY (XWZ3138) I I www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 31 A B C D 5 6 7 8 5 6 7 8 CD SW LED ASSY (XWZ3131) CN5401 CN5102 2/3 J K E D5557–D5560 1SS181 D5563–D5568 1SS181 R5514: 470 CN5502 52045–1445 CN5501 52045–3845 CN2901 52045–1945 DECK MECHA CD SW LED ASSY S5937 : OPEN/CLOSE ( ) S5938 : DISC CHANGE S5939 : DISC-3 S5940 : DISC-2 S5941 : DISC-1 DISPLAY ASSY S5911 : DISPLAY S5912 : TIMER/CLOCK ADJ S5913 : ENTER S5914 : P.BASS S5915 : ZOOM SURROUND S5916 : BASS BLASTER S5917 : EQUALIZER S5918 : PRESET S5919 : STANDBY/ON S5920 : TUNING – S5921 : TUNING + S5922 : STOP ( ) S5923 : PLAY/PAUSE S5924 : REC/STOP S5925 : FREQ/STATION S5926 : Dolby NR ON/OFF S5927 : ASES/COPY S5928 : AUX S5929 : TAPE Ι / ΙΙ S5930 : TUNER/BAND S5931 : CD S5951 : VOLUME S5952 : SOUND MORPHING JOG Function I J www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 32 A B C D 1 2 3 4 1 2 3 4 3.9 SUB DISPLAY and REAR AMP ASSEMBLIES D5411,D5412 D5414,D5416 (RED) (RED) L REAR AMP ASSY (XWZ3160) K SUB DISPLAY ASSY (XWZ3132) CN3401 3/3 E CN5502 I : CENTER SIGNAL ROUTE (C) (C) (C) (C) (C) (C) (C) (S/T) (S/T) (C) (C) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) (S/T) : SURROUND/TWEETER SIGNAL ROUTE (S/T) SUB DISPLAY ASSY S5401 : CENTER Volume S5402 : REAR Volume S5404 : PRO LOGIC MODE K L www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 33 A B C D 1 2 3 4 1 2 3 4 M N 3.10 TRADE and PRO LOGIC ASSEMBLIES (XR-A880 ONLY) KP200TA13L N PRO LOGIC ASSY (XWZ3133) M TRADE ASSY (XWZ3140) CN3701 3/3 E : CENTER SIGNAL ROUTE (C) : PRO LOGIC SIGNAL ROUTE (PRO) (PRO) (PRO) (PRO) (PRO) (PRO) : SURROUND SIGNAL ROUTE : AUDIO SIGNAL ROUTE (S) (C) (C) (C) (C) (S) (S) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 34 NOTE FOR PCB DIAGRAMS : 1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below. 3. The parts mounted on this PCB include all necessary parts for several destinations. For further information for respective destinations, be sure to check with the schematic diagram. 4. View point of PCB diagrams. Symbol In PCB Diagrams Symbol In Schematic Diagrams Part Name B C E D D G G S S B C E B C E D G S B C E B C E B C E Transistor Transistor with resistor Field effect transistor Resistor array 3-terminal regulator Capacitor Connector P.C.Board Chip Part SIDE A SIDE B 4. PCB CONNECTION DIAGRAM www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 35 A B C D 1 2 3 4 1 2 3 4 4.1 FM/AM TUNER MODULE VR6201 Q6203 Q6204 Q6304 Q6306 Q6401 Q6303 Q6302 Q6301 Q6214 Q6402 Q6403 Q6404 Q6202 Q6201 IC6202 IC6201 Q6205 CN3051 E FM/AM TUNER MODULE A FM/AM TUNER MODULE A (ANP7159-B) SIDE A SIDE B A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 36 A B C D 1 2 3 4 1 2 3 4 DA DB TRADE ASSY SW ASSY MOTOR ASSY C VCD SURVO ASSY B CN1053 E PICKUP ASSY LOADING MOTOR SERVO MECHANISM ASSY (XNP3010-A) (XNP3011-A) Q1353 Q1351 Q1101 Q1352 Q1354 IC1001 IC1401 IC1301 IC1201 IC1501 IC1752 IC1701 M SIDE A 4.2 VCD SURVO, MOTOR, SW and TRADE ASSEMBLIES C B DA DB www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 37 A B C D 1 2 3 4 1 2 3 4 VCD SURVO ASSY B (XNP3010-A) IC1754 IC1755 IC1101 IC1751 B SIDE B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 38 A B C D 1 2 3 4 1 2 3 4 4.3 AF ASSY CN3702 M CN83 H FAN MOTOR J11 J11 F VR280 Q3081 Q3081 Q54 IC32 Q51 Q52 Q57 IC23 Q21 Q22 Q34 Q31 IC42 IC51 IC AF ASSY E E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 39 A B C D 5 6 7 8 5 6 7 8 CN5501 I CN6201 A J3401 L MECHANISM UNIT CN1004 B (XNP3009-B) VR2301-VR2306 VR2802 VR2801 IC2301 Q51 Q52 Q57 Q2801 Q2804 IC3301 Q2802 IC51 IC3331 E SIDE A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 40 A B C D 1 2 3 4 1 2 3 4 E SIDE B IC5892 Q2802 Q2306 Q3607 Q2805-Q2807 Q2105 Q2104 IC2201 Q5751 IC3 Q2203 Q2204 Q3311-Q3314 Q5752 IC2101 Q2301 Q3622 Q3611 Q3606 Q3605 Q3353 Q3354 Q2103 IC5751 IC5751 IC3 IC5891 AF ASSY E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 41 A B C D 5 6 7 8 5 6 7 8E (XNP3009-B) 5751 Q3101 Q3102 IC3001 IC3101-IC3103 Q2203 Q2204 Q56 Q53 Q55 3311-Q3314 Q5752 5751 IC5751 IC3381 IC34 Q33 Q3401-Q3403 IC3201-IC3203 Q3202 Q3201 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 42 A B C D 1 2 3 4 1 2 3 4 4.4 SECONDARY ASSY (XNP3009-B) IC41 IC71 IC21 IC22 IC31 Q71 J11 E T1 POWER TRANSFORMER SECONDARY ASSY F SECONDARY ASSY F F SIDE A SIDE B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 43 A B C D 1 2 3 4 1 2 3 4H G 4.5 PRIMARY and SUB TRANS ASSEMBLIES (XNP3013-B) J81 E AC IN T1 POWER TRANSFORMER PRIMARY ASSY G SUB TRANS ASSY H LIVE NEUTRAL SIDE A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 44 A B C D 1 2 3 4 1 2 3 4 4.6 DISPLAY and CD SW LED ASSEMBLIES (XNP3013-B) CN5102 E MECHANISM UNIT DISPLAY ASSY I CD SW LED ASSY J CN5401 K SIDE A I J www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 45 A B C D 1 2 3 4 1 2 3 4 I J Q2901 Q2903 Q2906 Q2908 IC5601 IC5501 IC5631 IC3901 IC3931 Q2904 Q5502 Q5501 Q5601 Q5604 Q2910 Q5821 Q5606 Q5605 (XNP3013-B) DISPLAY ASSY I CD SW LED ASSY J SIDE B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 46 A B C D 1 2 3 4 1 2 3 4 4.7 REAR AMP, TRADE and PRO LOGIC ASSEMBLIES (XNP3013-B) (XNP3009-B) (XNP3009-B) CN3701 E CN3401 E PRO LOGIC ASSY N TRADE ASSY M REAR AMP ASSY L L M N SIDE A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 47 A B C D 1 2 3 4 1 2 3 4 L N SIDE B REAR AMP ASSY L PRO LOGIC ASSY N (XNP3009-B) (XNP3013-B) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com XR-VS99 48 A B C D 1 2 3 4 1 2 3 4 4.8 SUB DISPLAY ASSY IC5411 Q5411 Q5415 (XNP3013-B) CN5502 I SUB DISPLAY ASSY K SIDE A SIDE B K www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 49 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. FM/AM TUNER MODULE SEMICONDUCTORS IC6201 LA1832ML IC6202 LC72131MD Q6402 2SC2223 Q6203 2SC2705 Q6201,Q6202 2SC2712 Q6214,Q6403 2SC2714 Q6404 2SK302 Q6401 3SK194 Q6204 DTA124ES Q6205 DTC124EK D6202 1SS254 D6401,D6402 1T378A COILS AND FILTERS L6404 FM COIL ATC1003 L6401 FM RF COIL ATC1020 L6402 FM RF COIL ATC1021 F6204 FM CERAMIC FILTER ATF-107 F6203 FM CERAMIC FILTER ATF-119 FM/AM TUNER MODULE AXQ7065 VCD SURBO ASSY XWX3003 NSP $M MECHA PCB ASSY XWX3004 MOTOR ASSY XWZ3080 SW ASSY XWZ3081 NSP TRADE ASSY XWZ3082 NSP MAIN ASSY XWM3071 REAR AMP ASSY XWZ3160 AF ASSY XWZ3136 SECONDARY ASSY XWZ3137 TRADE ASSY XWZ3140 NSP COMPLEX ASSY XWM3072 PRIMARY ASSY XWZ3111 SUB TRANS ASSY XWZ3113 DISPLAY ASSY XWZ3138 CD SW LED ASSY XWZ3131 SUB DISPLAY ASSY XWZ3132 PRO LOGIC ASSY XWZ3133 LIST OF PCB ASSEMBLIES Mark No. Description Part No. Mark No. Description Part No. 5. PCB PARTS LIST NOTES: •Parts marked by "NSP" and can not be supplied. •The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. •When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). 560 Ω → 56 × 10 1 → 561 ........................................................ RD1/4PU 5 6 1 J 47k Ω → 47 × 10 3 → 473 ........................................................ RD1/4PU 4 7 3 J 0.5 Ω → R50 ..................................................................................... RN2H R 5 0 K 1 Ω → 1R0 ..................................................................................... RS1P 1 R 0 K Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k Ω → 562 × 10 1 → 5621 ...................................................... RN1/4PC 5 6 2 1 F A F6401 FM BAND PASS FILTER ATF-155 F6206 FM CERAMIC DISCRIMINATOR ATF7008 F6202 AM CERAMIC FILTER ATF7011 L6206,L6208,L6403 LAU2R2J TRANSFORMERS T6201 AM IF TRANS. ATB7008 T6401 FM CONNECT TRANS. ATE7002 CAPACITORS C6208 CCSQCH100D50 C6212,C6274,C6275,C6408 CCSQCH101J50 C6412 CCSQCH102J50 C6221,C6222,C6416 CCSQCH150J50 C6271 CCSQCH200J50 C6415 CCSQCH330J50 C6406 CCSQCH331J50 C6401,C6419 CCSQCH5R0C50 C6407 CCSQCK1R0C50 C6410 CCSQCK2R0C50 C6413 CCSQRH180J50 C6414 CCSQRH8R0D50 C6405 CCSQTH150J50 C6234,C6235 CEAL1R0M50 C6245 CEAL470M16 C6224 CEAT100M50 C6243 CEAT101M16 C6231 CEAT1R0M50 C6227 CEAT220M25 C6214,C6236 CEAT2R2M50 C6262 CEAT3R3M50 C6219 CEAT470M10 C6244 CEAT470M16 C6249,C6250,C6265,C6266 CEAT4R7M50 C6258 CEJA470M16 C6215 CFTLA103J50 C6211,C6254,C6403,C6417 CKSQYB102K50 C6201,C6205,C6210,C6237,C6276 CKSQYB103K50 C6278,C6280,C6281,C6402,C6409 CKSQYB103K50 C6418 CKSQYB103K50 C6251,C6252 CKSQYB153K50 C6203,C6259 CKSQYB223K50 C6228 CKSQYB472K50 C6209 CKSQYB473K50 C6230 CKSQYB821K50 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 50 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. C1130 CCSQCH3R0C50 C1715, C1717 CCSQCH470J50 C1138 CEAT100M50 C1003, C1108, C1144, C1207, C1214 CEAT101M10 C1301, C1351, C1501 CEAT101M10 C1127 CEAT1R0M50 C1005, C1007, C1126, C1141, C1409 CEAT470M16 C1411 CEAT470M16 C1718 CEAT471M6R3 C1136 CEAT4R7M50 C1109 CEATR22M50 C1124 CEATR47M50 C1101 CEJA3R3M50 C1105 CEJA470M10 C1106, C1119, C1134 CKSQYB102K50 C1102, C1122, C1123, C1139, C1140 CKSQYB103K50 C1209, C1215, C1218, C1231, C1302 CKSQYB103K50 C1354, C1502–C1506, C1703, C9002 CKSQYB103K50 C9005, C9013, C9015 CKSQYB103K50 C1001, C1002, C1004, C1008, C1135 CKSQYB104K25 C1151, C1202, C1203, C1511 CKSQYB104K25 C1701, C1702, C1704, C1710–C1714 CKSQYB104K25 C1716, C1751–C1754, C1757, C9004 CKSQYB104K25 C9006, C9008, C9017, C9019 CKSQYB104K25 C1405, C1406 CKSQYB152K50 C1111 CKSQYB153K25 C1114, C1117, C1120, C1121 CKSQYB154K16 C1125 CKSQYB221K50 C1131 CKSQYB222K50 C1107 CKSQYB223K50 C1110, C1403, C1404, C1407, C1408 CKSQYB331K50 C1115, C1128 CKSQYB332K50 C1113 CKSQYB333K25 C1112, C1143 CKSQYB334K16 C1212 CKSQYB471K50 C1507 CKSQYB472K50 C1116, C1142 CKSQYB473K50 C1401, C1402 CKSQYB561K50 C1118, C1201, C1204, C1206 CKSQYF104Z25 RESISTORS R1704 RS1/10S2001F Other Resistors RS1/10S J OTHERS CN1004 16P FFC CONNECTOR 52044–1645 CN1003 3P SIDE POST B3P–SHF–1AA CN1002 13P FFC CONNECTOR SLW13R–1C7 CN1001 15P FFC CONNECTOR SLW15R–1C7 JA1701 1P PIN JACK VKB1063 X1201 CRYSTAL RESONATOR PSS1008 (16.9344MHz) X1501 CERAMIC RESONATOR RSS1050 (6MHz) X1751 CRYSTAL RESONATOR VSS1086 (27MHz) C6218,C6223,C6255 CKSQYF103Z50 C6220,C6226,C6242,C6256 CKSQYF223Z50 C6225 CKSQYF473Z50 RESISTORS R6280 RD1/4PU101J R6413,R6416,R6418,R6906,R6909 RS1/8S0R0J R6401 RS1/8S470J VR6201 (10kΩ) PCP1029 Other Resistors RS1/10S J OTHERS BN6202 4P ANTENNA TERMINAL AKE7025 X6202 CERAMIC RESONATOR ASS1066 (456kHz) X6201 CRYSTAL RESONATOR ASS1093 (7.2000MHz) CN6201 14P SOCKET KP200IA14L MW RF TUNING BLOCK AXX7041 VCD SURVO ASSY SEMICONDUCTORS IC1001 BA033FP IC1401 BA4558F–HT IC1301 BA5923FP IC1701 CL680T–D1 IC1101 LA9240ML IC1201 LC78632RE IC1752 MB814260–70PJ IC1501 PDC051A IC1751 PDK032A IC1754 TC7W14F IC1753 TC7WU04F Q1101 2SA1048 Q1351, Q1352 2SB1237X Q1353, Q1354 2SD1858X D1351–D1354 1SS355 COILS AND FILTERS F1501 DTF1064 F1201 DTF1066 F1202 DTF1067 F1705, F1706 DTF1069 L1702 LCTB1R8K2125 L1701 LCTB2R7K2125 L1201 LFA100J L1001 LFA220J CAPACITORS C1129, C1205, C1208, C1213, C1353 CCSQCH101J50 C1706, C1722 CCSQCH101J50 C1133, C1755, C1756 CCSQCH120J50 C1720 CCSQCH121J50 C1216 CCSQCH150J50 C1708 CCSQCH151J50 C1217 CCSQCH180J50 C1705 CCSQCH271J50 C1132 CCSQCH300J50 C1707 CCSQCH331J50 B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 51 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. D3301, D3302 1SR139-100 D2301–D2306, D3101, D3102, D32 1SS133 D3351–D3354, D3361, D3362, D34 1SS133 D3403, D3603, D3621, D3622 1SS133 D3625–D3627, D51 1SS133 D3402 1SS184 D2102, D2103, D2191, D2201, D2202 1SS355 D3051, D3601, D3604, D3623, D3624 1SS355 D5891 1SS355 D3355, D3356 20E2-FC D31 GBU4D D3357, D3358 MTZJ10C D3083 MTZJ11C D33 MTZJ20A D52 MTZJ22D D3363, D3364 MTZJ39C D3401 MTZJ4.7B D2001 MTZJ6.2A D48, D53 MTZJ6.8C D3673, D3674 U1GC44 OILS AND FILTERS L3331, L3332 ATH-133 L2801 ATX7002 L3001 LAU1R0J L3991 LAU4R7J L2301, L2302 LTA822J F2201, F2202 RTF1209 SWITCHES AND RELAYS RY3601 ASR7008 CAPACITORS C2303, C2304 ACG7024 C2301, C2302 CCSQCH100D50 C2192 CCSQCH220J50 C38 CCSQCH331J50 C3319, C3320 CCSQCH3R0C50 C3321, C3322 CCSQCH470J50 C33 CEAL100M50 C3621 CEAL2R2M50 C3317, C3318 CEANP100M35 C3313, C3314 CEANP2R2M50 C2207, C2803, C2810, C3041, C3042 CEAT100M50 C3047, C3048, C3081, C3091–C3093 CEAT100M50 C3450, C36, C3602, C3953 CEAT100M50 C51, C52 CEAT100M50 C2002, C2316 CEAT101M16 C3651 CEAT101M35 C3303, C3304, C3622, C54 CEAT101M50 C3432, C3434 CEAT102M10 C2312, C2313, C3035, C3036 CEAT1R0M50 C3107, C3108 CEAT1R0M50 C1990, C2106, C2214, C2215 CEAT220M50 C2321, C2322, C53 CEAT220M50 C2001 CEAT221M16 C40 CEAT222M25 C2201, C2202, C2205, C2206 CEAT2R2M50 C2212, C2213, C2319, C2320 CEAT2R2M50 C3005–C3010, C3015–C3018 CEAT2R2M50 C3037–C3040, C3043–C3046 CEAT2R2M50 C3049, C3050, C3104, C3311, C3312 CEAT2R2M50 C3421, C3422 CEAT2R2M50 MOTOR ASSY SWITCHES AND RELAYS S9503 ASG7009 OTHERS J9502 JUMPER WIRE 4P D20PWW0405E MOTOR PULLEY PNW1634 CARRIAGE MOTOR VXM1033 SW ASSY SWITCHES AND RELAYS S9502 ASG7009 S9501 DSG1017 OTHERS J9501 JUMPER WIRE 6P D20PWY0610E TRADE ASSY OTHERS CN9501 52147–0610 CN9001 S6B–PH–K–S CN9002 SLW13R–1C7 AF ASSY SEMICONDUCTORS IC23 AEK7004 IC3331 AEK7010 IC33 AEK7013 IC2101,IC3101-IC3103,IC3381,IC34 BA4558F-HT IC3421,IC3951,IC5691 BA4558F-HT IC5891,IC5892 BU4094BCF IC2201 HA12136AF IC2301 HA12211NT IC3001 LC75396NE IC42, IC51 NJM7805FA IC32 NJM7812FA IC3301 STK407-090B Q3354, Q3601, Q3621, Q55 2SA1037K Q51, Q52, Q57 2SB1237X Q22 2SB1375 Q2803, Q2804 2SC1815 Q2801 2SC2240 Q2102, Q2201, Q2202, Q3101, Q3102 2SC2412K Q33, Q3353, Q3401, Q3603 2SC2412K Q3605–Q3608, Q56 2SC2412K Q21 2SC5200(P) Q3081 2SD1858X Q34, Q54 2SD1858X Q31 2SD2012 Q2203, Q2204, Q2805, Q3311, Q3312 2SD2114K Q53 2SD2114K Q2301, Q2302 2SK368 Q3313, Q3403 DTA124EK Q2104, Q2105, Q3314, Q3402, Q3641 DTC124EK Q2103, Q2306, Q2802 DTC143EK C E DA DB www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 52 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. C2804, C2805, C3105 CEAT330M16 C3406 CEAT330M25 C11, C12 CEAT332M35 C3431, C3433 CEAT471M10 C3106, C3109 CEAT4R7M50 C3021, C3022 CEATR10M50 C2203, C2204, C3101, C3102 CEATR22M50 C3325 CEATR47M50 C35, C43 CEHAQ100M50 C32, C42 CEHAQ1R0M50 C3601 CEHAQ221M16 C3027, C3028 CFTLA334J50 C3023, C3024 CFTLA474J50 C2812 CKCYB103K50 C2802 CKCYB681K2H C1996, C3308, C5693, C5892 CKSQYB102K50 C1922, C1993–C1995, C1998, C1999 CKSQYB103K50 C2315, C2317, C2318, C3053, C3103 CKSQYB103K50 C1997, C2191, C2193, C3097, C3099 CKSQYB104K25 C3652 CKSQYB104K25 C2194 CKSQYB105K10 C3033, C3034 CKSQYB122K50 C2208, C2209 CKSQYB152K50 C2323, C2326 CKSQYB223K25 C3029, C3030 CKSQYB273K25 C2808, C2809 CKSQYB332K50 C2333, C2334 CKSQYB392K50 C2807 CKSQYB472K50 C3111, C3112, C5891 CKSQYB473K25 C2307, C2308, C2331, C2332 CKSQYB681K50 C3013, C3014 CKSQYB681K50 C3019, C3020, C3031, C3032 CKSQYB682K50 C3323, C3324 CKSQYB682K50 C3025, C3026 CKSQYB683K25 C3315, C3316 CKSQYB821K50 C3954 CKSQYF103Z50 C3331–C3333 CKSQYF104Z50 C37 CKSQYF105Z16 C2801 CQHA822J2A C2210, C2211 CQMBA103J50 C2806 CQMBA223J50 C31 XCH3003 RESISTORS R2809 RD1/2LMF4R7J R52, R64 RD1/2PM181J R54 RD1/2PM221J R2812 RD1/2PM270J R3333, R3334 RD1/4LMF100J R3116 RD1/4PU105J R3317, R3318 RD1/4PU124J R3081 RD1/4PU221J R33 RD1/4PU222J R3009, R3953 RD1/4PU472J R2334 RD1/4PU562J R41 RN1/10SE1002D R40 RN1/10SE2002D R39 RS1/10S3300F R3991, R3992 RS2LMF331J R30 RS3LMF470J R3601, R3602 RS3LMFR22J VR2303-VR2306 VCP1156 VR2301,VR2302 VCP1162 VR2801,VR2802 VCP1164 Other Resistors RS1/10S J OTHERS 4P CABLE HOLDER 51048-0400 CN1053 16P FFC CONNECTOR 52045-1645 CN5101 40P FFC CONNECTOR 52045-4045 CN3401 17P JUMPER CONNECTOR 52147-1710 CN3331 4P SPEAKER TERMINAL AKE7001 CN2302 KR CONNECTOR B2B-PH-K-S CN2303 KR CONNECTOR B3B-PH-K-R CN2301 KR CONNECTOR 3P B3B-PH-K-S J81 JUMPER WIRE D20PYY0440E CN3051 14P PLUG KM200IB14 CN3701 13P PLUG KM200TA13 JA3431 JACK RKB1044 PCB BINDER VEF1040 JA3001 2P PIN JACK VKB1060 J3051 CONNECTOR ASSEMBLY XDX3002 CN3991 HEADPHONE JACK XKN3001 SECONDARY ASSY SEMICONDUCTORS IC71 (630mA) AEK7006 IC41 (5A) AEK7019 IC21,IC22,IC31 (7A) AEK7021 IC11,IC12 (10A) AEK7068 Q71 2SA965 D73 1SS133 D21 GBU4DL-5303 D11 GBU6DL-5302 D74 MTZJ36A D75 MTZJ8.2B D41-D44,D71,D72 S5688G CAPACITORS C72 CEAT220M50 C71 CEAT221M63 C41 CEAT222M25 C13 CQMA103K2E C21,C22 (4700µF/80V) XCH3001 RESISTORS R72 RD1/4PU222J Other Resistors RS1/10S J OTHERS J11 JUMPER WIRE 17P D20PYY1740E F www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 53 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. PRIMARY ASSY CAPACITOR C3 (10000pF/AC250V) ACG7020 SWITCH S1 AKX7006 OTHERS H3-H6 FUSE CLIP AKR7001 SUB TRANS ASSY SEMICONDUCTORS IC81 NJM7805FA Q81 2SD1859X D85,D88-D90 1SS133 D81-D84 S5688G SWITCH AND RELAY S2 AKX7004 RY81 ASR7018 COIL L1 LINE FILTER ATF1136 TRANSFORMER T2 ATT7027 CAPACITORS C83 CEAT100M50 C82 CEAT102M25 RESISTORS R83 RS1/10S102J Other Resistors RD1/4PU J OTHERS CN83 4P JUMPER CONNECTOR 52147-0410 H1,H2 FUSE CLIP AKR7001 AN1 1P AC INLET BKP1046 DISPLAY ASSY SEMICONDUCTORS IC5631 BA3835F IC3901 BA4558F-HT IC5601 BU2092F IC3931 BU9253FS IC5501 PDC050B Q5501 2SA1037K Q2903, Q2906, Q2908 2SB1132 Q5604, Q5801 2SC2412K Q2910, Q2911 DTA124EK Q5606 DTC124EK Q2901, Q2904, Q2907, Q5502, Q5603 DTC143EK Q5821 DTC143EK D5591–D5593, D5811 1SS133 D5557–D5560, D5563–D5568 1SS181 D2901–D2903, D5569, D5570, D5626 1SS355 D5901 1SS355 D5612 BR5064X D5613–D5616 MAA5064X D5608–D5611 MBG5064X D3931 MTZJ5.1B D5617–D5620 SLP6118C51H D5603–D5607, D5621 SLP9118C51H COILS AND FILTERS F3903, F3904 DTF1069 L5811 LAU220J L3931 LCTB100K2125 SWITCHES AND RELAYS S5951 ASX7004 S5952 ASX7017 S5911–S5931 XSG3001 CAPACITORS C5812 ACH1246 C3941 CCSQCH101J50 C5601 CCSQSL151J50 C3903 CCSQSL331J50 C5821 CEJA100M16 C3943 CEJA101M16 C5803 CEJA1R0M50 C3933 CEJA220M16 C3901, C3902, C3904, C3906 CEJA2R2M50 C3905, C5510, C5811, C5814 CEJA470M16 C3936, C3937 CEJA4R7M50 C3932 CEJAR47M50 C5804 CKSQYB102K50 C3911, C3931, C3934, C3940 CKSQYB103K50 C3910, C5816, C5997–C5999 CKSQYB104K25 C3939 CKSQYB123K50 C5505, C5509, C5951–C5954 CKSQYB471K50 C3907, C3938, C5506–C5508 CKSQYB472K50 C3935 CKSQYB473K50 C3942, C5602, C5631–C5634, C5901 CKSQYF104Z50 C5503, C5504, C5813, C5822 CKSQYF473Z50 RESISTORS R5529 ACN7056 R5556, R5561, R5562 ACN7062 R5563, R5564 ACN7077 R5508 RA11T104J R5506 RA7T104J R2907, R2909, R2910, R5611, R5919 RD1/4PU102J R5915 RD1/4PU181J R5925 RD1/4PU331J R3940 RD1/4PU471J R5605, R5606, R5612, R5613, R5926 RD1/4PU561J R2902, R5604, R5607–R5610 RD1/4PU681J R5927 RD1/4PU821J R2911–R2913, R5567 RS1/8S0R0J R5702 RS1/8S223J R5614 RS1/8S331J R2905 RS1/8S681J VR3901,VR3931 XCS3002 Other Resistors RS1/10S J G H I www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 54 XR-VS99 Mark No. Description Part No. Mark No. Description Part No. D3663 1SS355 D3359,D3360 MTZJ18B D3661 MTZJ2.7A D3671 MTZJ20A D3371,D3372 U1GC44 TH3661 AEX7002 CAPACITORS C3411 CEAT101M35 C3401,C3402 CEATR47M50 RESISTORS R3353,R3354 RD1/4PU101J Other Resistors RS1/10S J OTHERS J3401 JUMPER WIRE 17P D20PYY1720E TRADE ASSY OTHERS CN3703 13P PLUG KM200TA13 CN3702 13P SOCKET KP200TA13L PRO LOGIC ASSY SEMICONDUCTORS IC3701 LV1035M D3701,D3702 1SS133 CAPACITORS C3727 CCSQCH681J50 C3741,C3744 CEANL3R3M50 C3737,C3739,C3746,C3748 CEANL4R7M50 C3703-C3706,C3709,C3715 CEAT100M50 C3718-C3720,C3732,C3733 CEAT100M50 C3707,C3708,C3713,C3716 CEAT221M10 C3726 CEAT221M6R3 C3717 CEAT2R2M50 C3731 CEAT470M10 C3721 CEATR33M50 C3722,C3736,C3738,C3747,C3749 CEATR47M50 C3701,C3702 CFTLA104J50 C3740,C3742,C3743,C3745 CFTLA154J50 C3730 CFTLA474J50 C3750,C3753 CKSQYB103K50 C3714 CKSQYB182K50 C3734,C3735 CQMBA104J50 C3729 CQMBA223J50 C3724 CQMBA332J50 C3728 CQMBA473J50 C3723,C3725 CQMBA823J50 RESISTORS R3701 RD1/4PU183J R3704 RS1/10S3902F Other Resistors RS1/10S J OTHERS X3701 CERAMIC RESONATOR DSS1053 (8MHz) CN3704 13P SOCKET KP200TA13L OTHERS CN5502 14P FFC CONNECTOR 52045-1445 CN2901 19P FFC CONNECTOR 52045-1945 CN5501 40P FFC CONNECTOR 52045-4045 JA3901,JA3902 AKN7004 5901 REMOTE RECEIVER UNIT GP1U28X V5621 FL TUBE XAV3004 2902 FL HOLDER XNG3008 X5501 CERAMIC RESONATOR RSS1050 (6MHz) CD SW LED ASSY SEMICONDUCTORS D5623 SLP3118C51H D5624 SLP7118C51H D5622 SLP9118C51H SWITCHES S5937-S5941 XSG3001 RESISTORS All Resistors RS1/10S J OTHERS J5501 JUMPER WIRE D20PWW0615E SUB DISPLAY ASSY SEMICONDUCTORS IC5411 BU4094BCF Q5411-Q5415 DTC143EK D5411,D5412 SLP7118C51H D5414,D5416,D5418,D5420 SLP9118C51H SWITCHES S5404 XSG3001 S5401,S5402 XSX3002 CAPACITORS C5411-C5413 CCSQCH101J50 C5414 CKSQYB103K50 RESISTORS R5416 RD1/4PU221J R5430 RD1/4PU561J R5432,R5434 RD1/4PU681J Other Resistors RS1/10S J OTHERS CN5401 14P FFC CONNECTOR 52045-1445 REAR AMP ASSY SEMICONDUCTORS IC3401 TDA8560Q Q3661 2SA1037K Q3352 IRF540A Q3351 IRF9540A D3662 1SS133 J K M N L www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 55 XR-VS99 6. ADJUSTMENT 6.1 TUNER SECTION FM Tuner Section • Set the mode selector to FM BAND. • Connect the wiring as shown in Fig. 1. AM Tuner Section • Set the mode selector to AM BAND. • Connect the wiring as shown in Fig. 1. p e t S . o N t n e m t s u j d A e lti T ,z H k 1 ( G S M F ± ). v e d z H k 5 7 n o it p e c e R y c n e u q e r F y a l p s i D t n e m t s u j d A n o it a c o L s n o it a c ifi c e p S y c n e u q e r F ) z H M ( l e v e L B d ( µ ) V 1 d n E t n o r F ytivitis n e S 8 9 0 3 - 0 z H M 8 9 2 0 4 6 L 1 0 4 6 T - 1 0 2 6 C I e h t n e e w t e b e g a tlo v C D e h t t a h t o s ts ujd A .le v el m u m ix a m t a s e m o c e b D N G d n a 0 2 nip 2 . D N I D E N U T le v e L g nit h giL 8 9 8 1 ± 2 z H M 8 9 1 0 2 6 R V str a ts . D N I D E N U T f o r o t a cid ni e h t t a h t o s ts ujd A . p u t h gil o t :eto N d n a ,tsrif re hto h c a e hti w tc atn o c otni m e ht g nir b , m e ht n e e w te b p a g a si ere ht fI .2 0 4 6 L d n a 1 0 4 6 L n e e w te b p a g o n si ere ht er u s e k a m ,g nits ujd a er o fe B .stn e m ts ujd a e k a m n e ht p e t S . o N t n e m t s u j d A e lti T ). d o M % 0 3 ,z H 0 0 4 ( G S M A n o it p e c e R y c n e u q e r F y a l p s i D t n e m t s u j d A n o it a c o L s n o it a c ifi c e p S y c n e u q e r F ) z H k ( l e v e L B d ( µ ) m / V 1 d n E t n o r F ytivitis n e S ( 9 9 9 * ) 1 5 4 - 5 3 ( z H k 9 9 9 * ) 1 1 0 2 6 T - 1 0 2 6 C I e h t n e e w t e b e g a tlo v C D e h t t a h t o s ts ujd A .le v el m u m ix a m t a s e m o c e b D N G d n a 0 2 nip ( eto N * .z H k 0 0 0 1 e b dlu o h s s eic n e u q erf ,p ets z H k 0 1 g nis u a era e ht r o F :) 1 AM SG MPX SG FM SG PRODUCT DC Voltmeter FM75Ω antenna terminal AM antenna terminal 60cm Center Center Loop antenna Fig. 1 AM and FM Adjustment Wiring Diagram FM/AM TUNER MODULE AXX7041 L6402 L6401 T6401 T6201 IC6201 Pin 20 VR6201 AM antenna terminal FM antenna terminal YELLOW BLACK Fig. 2 Adjustment Point SIDE A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 56 XR-VS99 Electrical Adjustment Check the following before starting. (1) Confirm that the tape speed adjustment has been completed. (2) Clean the heads and demagnetize them using a head eraser. (3) Set the measurement level to 0 dBV = 1 Vrms. (4) Use the specified tape for adjustment. Use the labeled (A) side of the test tape. STD-331E : For playback check STD-632 : Normal blank tape (5) Provide yourself with the following measuring devides: • AC millivoltmeter • Low-frequency oscillator • Attenuator • Oscilloscope (6) Adjust both right and left channels unless otherwise specified. (7) Turn the DOLBY NR switch off unless otherwize specified. (8) Warm up the unit for several minutes before adjustment. In particular, be sure to warm up the unit in the REC/PLAY mode for 3 to 5 minutes before starting recording/playback frequency characteristics adjustment. (9) Always follow the indicated adjustment order. Otherwise, a complete adjustment may not be achieved. Playback Adjustment (Decks I and II) (1) Head Azimuth Adjustment (2) Playback Level Adjustment Recording Adjustment (Deck I) (1) Bias Oscillation Frequency Adjustment (2) Recording Bias Adjustment (3) Recording Level Adjustment. (4) ALC Operation Check * As the reference recording level is 250nwb/m for STD-331E, the recording level will be higher by 4 dB for STD-331B (160nwb/m). When adjusting, pay carefull attention to the type of tape used. 6.2 CASSETTE DECK SECTION • Adjustment points and test points are shown in Fig.3, Fig.5 and Fig.7. Mechanical Adjustment • Test tape: NCT-111 (3kHz, 30min). 1. Tape Speed Adjustment Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. “DOLBY” and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation. . o N e d o M e p a T t s e T g n it s u j d A s t n i o P t n e m e r u s a e M s t n i o P e r u d e c o r P t n e m t s u j d A s k r a m e R 1 k c e D I Y A L P 1 1 1 - T C N ) z H k 3 : k c a b y al P ( n o R V .J D A E T T E S S A C ) 3 . gi F ( A H C E M T S E T E P A T ) h c R ( T N I O P ) y s s A F A ( g nid a e r e h t t a h t o s ts ujd a d n a W S Y A L P e h t s s e r P z H 0 0 0 3 s e m o c e b ± r e tt ulf & w o w t a h t m rif n o C .z H 0 2 m rif n o c , n oitc e rid e s r e v e r e h t ni( % 3 . 0 w ole b sile v el z H 0 0 0 3 nih ti w si g nid a e r e h t t a h t ± .) z H 0 6 Front Side AF Assy Fig.3 Tape Speed ADJ. Point Cassette Mechanism Section (Side View) Tape Speed ADJ. VR www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 57 XR-VS99 Playback Adjustment (1) Head Azimuth Adjustment • Do not switch between forward and reverse operation with the screwdriver inserted. Fig. 5 Head Azimuth Adjustment Screw REV Azimuth Adjustment Screw FWD Azimuth Adjustment Screw 250 3dB 10k 12.5k 3dB 4dB PLAY BACK 250 3dB 10k 12.5k 3dB 5dB RECORDING Fig. 6 Frequency Characteristics (2) Playback Level Adjustment • Since this adjustment determines playback Dolby NR level, perform it carefully. p e t S e d o M /l a n g i S t u p n I e p a T t s e T s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P t n e m t s u j d A e u l a V s k r a m e R 1 Y A L P e p a t ts e t E 1 3 3 - D T S ,z H k 0 1 :k c a b y al P ( ) B d 0 2 - k c e D I h t u m iz a d a e H t n e m ts ujd a ) 5 . gi F ( w e r c s T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( k c a b y alp .x a M le v ella n gis o t d n o b n o cilis ylp p a ,t n e m ts ujd a r e tf A . w e r c s t n e m ts ujd a h t u m iz a d a e h e h t k c e D II p e t S e d o M /l a n g i S t u p n I e p a T t s e T s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P t n e m t s u j d A e u l a V s k r a m e R 1 Y A L P E 1 3 3 - D T S e p a t ts e t ) B d 0 ,z H 5 1 3 :k c a b y al P ( k c e D I ) h c L ( 3 0 3 2 R V ) h c R ( 4 0 3 2 R V T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( V B d 7 . 3 – k c e D II ) h c L ( 5 0 3 2 R V ) h c R ( 6 0 3 2 R V 0 dB –20 dB 30s 0 dB: 315 Hz, 250 nwb/m 315Hz 6.3kHz 10kHz 315Hz 14kHz 12.5 kHz 6.3 kHz 500 Hz 250 Hz 125 Hz 10kHz 8kHz 4kHz 2kHz 63Hz 40Hz 1kHz 30s 30s 30s 10s 10s ......................................................................................................... 10s Fig. 4 STD-331E Test Tape www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 58 XR-VS99 p e t S e d o M /l a n g i S t u p n I e p a T t s e T s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P t n e m t s u j d A e u l a V s k r a m e R 1 C E R 2 3 6 - D T S e h t d a o L e h t t e s d n a e p a t ts e t . e d o m g nid r o c e r k c e D II                       n oit allic s O o t y c n e u q e rf z H k 0 . 5 0 1 e b ± .z H k 2 r u o f r o f n o tt u b P O T S / C E R e h t fI D N A T S ni si r e w o p e h t elih w s d n o c e s e s a e r c e d lli w y c n e u q e rf e h t , e d o m Y B .z H k 3 o t 2 K C E D I 1 0 8 2 L ) y s s A F A ( n e e w t e B 7 . gi F ni t nio p . D N G d n a Recording Adjustment (1) Bias Oscillation Frequency Adjustment (2) Recording Bias Adjustment • Since this adjustment affects recording bias, prevent distortion from increasing due to underbias. A Note : Set the 10kHz input signal level to the same value as the 315Hz input signal level of step 1. (4) ALC Operation Check (3) Recording Level Adjustment p e t S e d o M e p a T t s e T /l a n g i S t u p n I s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P e u l a V t n e m t s u j d A s k r a m e R 1 C E R e h t o tla n gis z H 5 1 3 a t u p n I t u p ni e h t t e s d n a la ni m r e t X U A . X U A o t r o tc ele s k c e D II                T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( V B d 7 . 3 2 – K C E D I le v ella n gis t u p n I 2 C E R → Y A L P d n a e p a t ts e t 2 3 6 - D T S e h t d a o L d n a z H 5 1 3 e h t k c a b y alp / d r o c e r .sla n gis z H k 0 1 ) w ole b e t o N e h t e e s ( k c e D II                T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( le v el k c a b y alp lit n u t n e m ts ujd a t a e p e R 0 nih ti w sila n gis z H k 0 1 e h t f o ± B d 5 . 0 .la n gis z H 5 1 3 e h t f o t a h t m o rf K C E D I ) h c L ( 1 0 8 2 R V ) h c R ( 2 0 8 2 R V p e t S e d o M e p a T t s e T /l a n g i S t u p n I s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P e u l a V t n e m t s u j d A s k r a m e R 1 C E R e h t o tla n gis z H 5 1 3 a t u p n I t u p ni e h t t e s d n a la ni m r e t X U A . X U A o t r o tc ele s k c e D II le v ella n gis t u p n I T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( V B d 7 . 7 – K C E D I 2 C E R → Y A L P d n a e p a t ts e t 2 3 6 - D T S e h t d a o L z H 5 1 3 e h t k c a b y alp / d r o c e r .la n gis k c e D II                T S E T E P A T ) h c R , L ( T N I O P ) y s s A F A ( d n a k c a b y alp , g nid r o c e r t a e p e R e h t f o le v el k c a b y alp lit n u t n e m ts ujd a . V B d 7 . 7 – s e m o c e b la n gis z H 5 1 3 K C E D I ) h c L ( 1 0 3 2 R V ) h c R ( 2 0 3 2 R V p e t S e d o M e p a T t s e T /l a n g i S t u p n I s t n i o P g n it s u j d A t n e m e r u s a e M s t n i o P e u l a V t n e m t s u j d A s k r a m e R 1 / C E R E S U A P e h t o t la n gis z H 5 1 3 a t u p n I t u p ni e h t t e s d n a la ni m r e t X U A . X U A o t r o tc ele s le v ella n gis t u p n I T S E T E P A T T N I O P ) h c R , L ( ) y s s A F A ( V B d 2 . 8 – 2 e h t e v o d a B d 0 1 + le v el a o t t e S . 1 p e ts t a le v el t u p ni si g nid a e r e h t t a h t m rif n o C 2 . 2 – ± . V B d 5 . 2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 59 XR-VS99 A VR2302 VR2802 VR2303 VR2305 VR2304 TAPE TEST POINT Fig.7 Adjustment and Measurement Points FRONT L ch R ch VR2306 VR2801 L2801 VR2301 SIDE A AF ASSY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 60 XR-VS99 REC/ STOP PLAY/ PAUSE CD STANDBY/ON Function CD TEST DISC: YEDS-7 "TEST 4" Laser diode: LIGHTS UP Focus servo: CLOSE Spindle motor: START Spindle servo: CLOSE CLOSE OPEN Tracking servo: STOP all operations. TEST DISC: YEDS-7 STANDBY/ON CD TEST Short Point CD TEST Short Point inwards outwards Pickup Move TEST MODE : ON TEST MODE : PLAY TEST MODE : STOP CANCEL How to Start/Cancel Test Mode Test Point 6.3 TEST MODE NOTE: There is no information to be shown in this CD adjustment. DISPLAY ASSY CD TEST Bottom Side SIDE B REC/ STOP PLAY/ PAUSE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 61 XR-VS99 7. GENERAL INFORMATION • The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams. HA12136AF (AF ASSY : IC2201) • Dolby B Type NR System IC •Pin Function 7.1 PARTS 7.1.1 IC . o N e m a N n i P n o it c n u F . o N e m a N n i P n o it c n u F 1 N I C E R t u p ni ) e d o c n E ( g nid r o c e R 9 T U O C E R t u p t u o ) e d o c n E ( g nid r o c e R 2 V C C ylp p u s r e w o P 0 1 T E D r o tc e t e d le v el e h t r o f nip t n a ts n o c e m i T 3 N I B P t u p ni ) e d o c e D ( k c a b y al P 1 1 T U O B P t u p t u o ) e d o c e D ( k c a b y al P 4 f e r V e g a tlo v e c n e r e f e R 2 1 B P / C E R ) e d o c e D / e d o c n E ( B P / C E R r o f nip lo rt n o c e d o M ) e d o c e D ( B P : " L " ,) e d o c n E ( C E R : " H " 5 F F O / N O R N F F O / N O R N r o f nip lo rt n o c e d o M F F O R N : " L " , N O R N : " H " 3 1 S A I B s r e tlif e vitc a e h t r o f nip t u p ni t n e rr u c e c n e r e f e R 6 T U O B P t u p t u o ) e d o c e D ( k c a b y al P 4 1 N I B P t u p ni ) e d o c e D ( k c a b y al P 7 T E D r o tc e t e d le v el e h t r o f nip t n a ts n o c e m i T 5 1 D N G d n u o r G 8 T U O C E R t u p t u o ) e d o c n E ( g nid r o c e R 6 1 N I C E R t u p ni ) e d o c n E ( g nid r o c e R HA12211NT (AF ASSY : IC2301) • REC Equalizer and PB Equalizer System IC 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 REC–EQ GND TAPE(L) REC–OUT(L) REC–OUT(R) PB–IN PB–IN PB–CAL PB–CAL PB–EQ PB–EQ PB–NF PB–NF PB–IN PB–IN TAPE(R) AUX(L) AUX(R) IREF REC–SEL BCr ACr HSP A/B PB–OUT(L) PB–OUT(R) PB–CAL PB–CAL REC IN from logic B(L) B(R) to Dolby REC–RETURN Vcc (R) (R) (L) (L) A(R) A(R) A(L) A(L) VREF B(R) B(L) R–ch L–ch R–ch L–ch 12dB 139k 5k 2.7k 2.26k 1.12k 10k B A B A •Block Diagram www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 62 XR-VS99 •Pin Function . o N e m a N n i P n o it c n u F . o N e m a N n i P n o it c n u F 1 V C C V C C nip 6 1 ) R ( B la C - B P t n e m ts ujd a nia g r o f t u p ni k c a b d e e F 2 ) L ( T U O C E R t u p t u o Q E - C E R 7 1 ) L ( B la C - B P 3 ) R ( T U O C E R 8 1 ) R ( T U O B P t u p t u o B P 4 N R U T E R - C E R n r u t e r C E R 9 1 ) L ( T U O B P 5 ) L ( B N I- B P t u p ni k c e d B B P 0 2 B / A t u p nilo rt n o c e d o M 6 ) R ( B N I- B P 1 2 P S H 7 F E R V e g a tlo v e c n e r e f e R 2 2 r c A 8 ) L ( A N I- B P t u p ni k c e d A B P 3 2 r c B 9 ) R ( A N I- B P 4 2 L E S - C E R t u p nilo rt n o c e d o M 0 1 ) L ( F N - B P k c a b d e e f Q E B P 5 2 F E R I t u p ni t n e rr u c e c n e r e f e r r e zila u q E 1 1 ) R ( F N - B P 6 2 ) R ( X U A t u p ni Q E - C E R 2 1 ) L ( Q E - B P t u p t u o B A N 7 2 ) L ( X U A 3 1 ) R ( Q E - B P 8 2 ) R ( E P A T 4 1 ) L ( A la C - B P t n e m ts ujd a nia g r o f t u p ni k c a b d e e F 9 2 ) L ( E P A T 5 1 ) R ( A la C - B P 0 3 D N G nip D N G LC75396NE (AF ASSY : IC3001) • Electrical Volume IC •Block Diagram 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LSELO LINVIN1 L5 L4 L3 L2 L1 VDD R1 R2 R3 R4 R5 RINVIN1 RSELO RTIN RFOUT RRIN RRCOM RROUT RVref RVref Vref CL DI CE VSS LVref LVref LROUT LRCOM LRIN LFOUT LFCOM LTIN LF1C1 LF1C2 LF1C3 LF2C1 LF2C2 LF2C3 LF3C1 LF3C2 LF3C3 LF4C1 LF4C2 LF4C3 LF5 LTOUT LFIN RF1C1 RF1C2 RF1C3 RF2C1 RF2C2 RF2C3 RF3C1 RF3C2 RF3C3 RF4C1 RF4C2 RF4C3 RF5 RTOUT RFIN RFCOM CONTROL CIRCUIT LOGIC CIRCUIT CCB INTERFACE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 63 XR-VS99 PDC049A (DISPLAY ASSY : IC5501) • System Control Microcomputer •Pin Function . o N e m a N n i P O /I n o it c n u F . o N e m a N n i P O /I n o it c n u F 1 T E S E R D C V O I S L D C V r o f t u p t u o t e s e R 1 5 P D F V – 2 C N O d e s u t o N 2 5 3 9 5 5 D /* S * e d o n a lo rt n o c y alp sid L F 3 C N I d e s u t o N 3 5 2 9 5 5 D /* S * 4 D E L / D E L S S A B 2 E C O ) S S A B D E L ( r o t a cid ni S S A B . P r o f lo rt n o c D E L 4 5 1 9 5 5 D /* S * 5 K L C P X E O C I D E L ,) 4 9 0 4 U B ( C I P X E r o f t u p t u o k c ol C ) 5 3 0 1 V L ( C I cig olo r P d n a ) 2 9 0 2 U B ( 5 5 2 C G O J B /* S O /I 6 A T A D P X E O C I D E L ,) 4 9 0 4 U B ( C I P X E r o f t u p t u o a t a D ) 5 3 0 1 V L ( C I cig olo r P d n a ) 2 9 0 2 U B ( 6 5 1 C G O J B /* S O /I 7 E C P X E O e b o rts ) 2 9 0 2 U B ( C I D E L ,) 4 9 0 4 U B ( C I P X E t u p t u o 7 5 2 B G O J B /* S O /I 8 A E P S / 1 D E L O / lo rt n o c D E L lo rt n o c t u p t u o ) 3 2 9 1 U B ( C I r e z yla n a m u rtc e p S 8 5 1 B G O J B /* S O /I 9 B E P S / 2 D E L O 9 5 2 A G O J B /* S O /I 0 1 C E P S / 3 D E L O 0 6 1 A G O J B /* S O /I 1 1 C A I t u p ni e slu p C A )r o tin o m ylp p u s r e w o p , k c olc r o f( 1 6 * S O /I 2 1 T E S E R X I t u p ni t e s e r U P C 2 6 * S O /I 3 1 1 L E E R I le e r 2 k c e d r o f t u p ni e slu P 3 6 * S O /I 4 1 2 L E E R I le e r 1 k c e d r o f t u p ni e slu P 4 6 * S O /I 5 1 S S V – d n u o r G 5 6 * S O /I 6 1 1 F C I 6 6 * S O /I 7 1 2 F C O 7 6 R R A /* S O /I 8 1 D D V – ylp p u s r e w o P 8 6 F R A /* S O /I 9 1 1 Y E K I t u p ni y e k t n o r F 9 6 1 E D O M /* S O /I 0 2 S M I t u p nila n gis S M k c e D 0 7 2 E D O M /* S O /I 1 2 E N U T / T S I n oitc e t e d ) O E R E T S ( d e n u t r e n u T 1 7 1 F L A H /* S O /I 2 2 H T I n oitc e t e d tiu c ric n oitc e t o r p d n a e r u t a r e p m e T 2 7 D D V – 3 2 D E L R E M I T O )r e m it r o f( lo rt n o c D E L 3 7 2 F L A H /* S O /I e d o n a lo rt n o c y alp sid L F 4 2 2 Y E K I t u p ni y e k t n o r F 4 7 1 _ 2 O r C /* S O /I 5 2 N I- E P S I t u p nila n gis r e z yla n a m u rtc e p S 5 7 2 _ 2 O r C /* S O /I 6 2 3 Y E K I t u p ni y e k t n o r F 6 7 N O N A C S O lo rt n o c t u p ni n a c s y e K 7 2 S C V I I S L D C V m o rf t u p ni e b o rt S 7 7 2 L O S O lo rt n o c dio n elo s 1 k c e D 8 2 C N I d e s u t o N 8 7 1 L O S O lo rt n o c dio n elo s 2 k c e D 9 2 N O C O M E R I t u p nila n gis lo rt n o c e t o m e R 9 7 R O T O M O lo rt n o c r o t o m k c e D 0 3 * G O e d o n a lo rt n o c y alp sid L F 0 8 A T A D S D R I S D R r o f t u p ni a t a D 1 3 * G 1 8 1 G O J L O V I g oj e m ulo v r o f t u p ni e slu P 2 3 * G 2 8 2 G O J L O V 3 3 * G 3 8 E C L L P O t u p t u o e b o rts C I L L P r e n u T 4 3 * G 4 8 E C O R P / W S P H O /I C I cig olo r P / t u p ni tc e t e d W S e n o h p d a e H t u p t u o e b o rts ) 5 3 0 1 V L ( 5 3 * G 5 8 E C L O V E O e b o rts ) 4 9 3 5 7 C L ( C I lo rt n o c e m ulo v nia M t u p t u o 6 3 * G 6 8 R E W O P O lo rt n o c r e w o p nia M 7 3 * G 7 8 E T U M E N I L O lo rt n o c e t u m e niL 8 3 * G 8 8 E C D E L O t u p t u o e b o rts ) 2 9 0 2 U B ( C I lo rt n o c D E L 9 3 * G 9 8 S S V – d n u o r G 0 4 * G 0 9 D D V – ylp p u s r e w o P 1 4 * G 1 9 C N I n oitc e n n o c o N 2 4 * G 2 9 C N 3 4 * G 3 9 1 G O J P R O M I g oj g nih p r o m d n u o s r o f t u p ni e slu P 4 4 * G 4 9 2 G O J P R O M 5 4 * G 5 9 A T A D S Y S O t u p t u o a t a d lair e S 6 4 D D V – ylp p u s r e w o P 6 9 A T A D X T I t u p ni a t a d lair e S 7 4 7 9 5 5 D /* S O e d o n a lo rt n o c y alp sid L F 7 9 K L C S O t u p t u o k c olc lair e S 8 4 6 9 5 5 D /* S O 8 9 S D V O I S L D C V r o f t u p t u o a t a d lair e S 9 4 5 9 5 5 D /* S * 9 9 V D V I I S L D C V r o f t u p ni a t a d lair e S 0 5 4 9 5 5 D /* S * 0 0 1 K L C V O I S L D C V r o f t u p t u o k c ol C www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 64 XR-VS99 LC78622NE (CD ASSY : IC8301) • CD DSP IC • Block Diagram • Pin Function Slice level control RAM address generator Interpolation mute Digital output Digital attenuator L. P. F Crystal oscillation system generator General purpose port Sync detection EFM demosulation C1, C2 error detection & correcting Flag Processing CLV Digital servo Sub core separation QCRC Microcomputer Interface Servo commander VCO clock oscillator clock control 2k × 8-bits RAM 8 × oversampling digital-filter 1-bit DAC 1 10 22 9 3 5 59 15 16 17 19 20 45 60 61 46 52 44 43 39 41 35 40 37 42 38 36 48 34 24 18 29 7 20 64 11 32 33 62 23 8 31 21 51 63 30 56 54 12 13 49 47 50 53 55 57 14 25 26 27 28 DEFI EFMIN FSEQ CLV+ CLV– V/*P PW SBCK SBSY SFSY *CS WRQ SQOUT *CQCK COIN RWC HFL TES TOFF JP– JP+ 58 *RES TGL PCCL CONT1 CONT2 CONT3 CONT4 CONT5 EMPH/CONT6 EFLG 16M 4.2M XVSS FSX XIN XOUT XVDD RVSS RVDD MUTER/CONT7 RCHO LCHO MUTEL/CONT8 LVSS LVDD C2F DOUT VSS VDD TEST4 TEST5 TEST3 TEST2 TEST1 TST11 TAI PCK FR ISET PDO EFMO 6 VVDD 4 VVSS . o N e m a N n i P O /I n o it c n u F 1 I F E D I .) d e s u n u n e h w V 0 o t d e tc e n n o c e b ts u M ( nip t u p ni ) F E D ( la n gis n oitc e t e d tc e f e D 2 I A T I s nip L L P . V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A nip t u p ni ts e T 3 O D P O nip t u p t u o r o t a r a p m o c e s a h p lo rt n o c O C V la n r e tx E 4 S S V V − . V 0 o t d e tc e n n o c e b ts u M nip d n u o r g O C V la n r e t n I 5 T E S I I A nip n oitc e n n o c r o tsis e r t n e m ts ujd a t n e rr u c t u p t u o O D P 6 D D V V − nip ylp p u s r e w o p O C V la n r e t n I 7 R F I A t n e m ts ujd a e g n a r y c n e u q e rf O C V 8 S S V − . V 0 o t d e tc e n n o c e b ts u M nip d n u o r g m e ts y s la tigi D 9 O M F E O lo rt n o c le v el e cil S nip t u p t u o la n gis M F E 0 1 N I M F E I nip t u p nila n gis M F E 1 1 2 T S E T I . V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A nip t u p ni ts e T 2 1 + V L C O t u p t u o lo rt n o c r o t o m c si D . d n a m m o c r o s s e c o r p o r ci m y b t u p t u o e ula v - e e r h t o t t e s e b n a C 3 1 – V L C O 4 1 P */ V O nip t u p t u o r o tin o m g nih cti w s cit a m o t u a lo rt n o c e s a h p / o v r e s h g u o R .le v el w ol a o v r e s h g u o r g nir u d le v el h gih a st u p t u O 5 1 L F H I .t u p ni tti m h c S a si sih T nip t u p nila n gis n oitc e t e d k c a r T 6 1 S E T I .t u p ni tti m h c S a si sih T nip t u p nila n gis r o rr e g nik c a r T 7 1 F F O T O nip t u p t u o ff o g nik c a r T 8 1 L G T O . w ol n e h w nia g e h t e s a e r c n I nip t u p t u o g nih cti w s nia g g nik c a r T 9 1 + P J O t u p t u o p m uj k c a r T . d n a m m o c r o s s e c o r p o r ci m y b d eific e p s n e h w elbis s o p o sla si t u p t u o e ula v - e e r h T 0 2 – P J O www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 65 XR-VS99 . o N e m a N n i P O /I n o it c n u F 1 2 K C P O . d e k c ol si e s a h p e h t n e h w z H M 8 1 2 3 . 4 nip t u p t u O nip r o tin o m k c olc k c a b y alp a t a d M F E 2 2 Q E S F O nip t u p t u o n oitc e t e d la n gis n oit a zin o r h c n y S d e t a r e n e g yla n r e t ni e h t d n a la n gis M F E e h t m o rf d e tc e t e d la n gis n oit a zin o r h c n y s e h t n e h w le v el h gih a t u p t u O . e g n a r la n gis n oit a zin o r h c n y s 3 2 D D V − nip ylp p u s r e w o p m e ts y s la tigi D 4 2 1 T N O C O /I 1 e s o p r u p -la r e n e G e r a t a h t e s e h t f o y n A .r o s s e c o r p o r ci m e h t m o rf s d n a m m o c a t a d lair e s y b d ello rt n o C t u p t u o s a p u t e s r o , V 0 o t d e tc e n n o c d n a str o p nip t u p ni s a p u t e s r e h tie e b ts u m d e s u n u . n e p o tf el d n a str o p nip 5 2 2 T N O C 2 e s o p r u p -la r e n e G 6 2 3 T N O C 3 e s o p r u p -la r e n e G 7 2 4 T N O C 4 e s o p r u p -la r e n e G 8 2 5 T N O C 5 e s o p r u p -la r e n e G 9 2 6 T N O C / H P M E O 6 e s o p r u p -la r e n e G / .k sid sis a h p m e - e d a f o k c a b y alp s e t a cid nile v el h gih A nip r o tin o m sis a h p m e - e D 0 3 F 2 C O nip t u p t u o g alf 2 C 1 3 T U O D O )t a m r o f A JI E ( nip t u p t u o la tigi D 2 3 3 T S E T I . V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A nip t u p ni ts e T 3 3 4 T S E T I 4 3 L C C P I nip g niyfit n e di d n a m m o c t u p t u o / t u p ni e s o p r u p -la r e n e G . E 2 2 6 8 7 C L f o e s o h t o t r ali m is s n oitc n u f h ti w d e s u n e h w V 0 o t d e tc e n n o c e b ts u M d n a m m o c tr o p t u p t u o / t u p ni e s o p r u p -la r e n e g e h t r o f yln o elbis s o p lo rt n o C : H s d n a m m o c lla r o f elbis s o p lo rt n o C : L 5 3 7 T N O C / L E T U M O tib - e n o le n n a h c tf e L r e tr e v n o c A / D nip t u p t u o e t u m le n n a h c tf e L 6 3 D D V L − nip ylp p u s r e w o p le n n a h c tf e L 7 3 O H C L O nip t u p t u o le n n a h c tf e L 8 3 S S V L − . V 0 o t d e tc e n n o c e b ts u M nip d n u o r g le n n a h c tf e L 9 3 S S V R − - e n o le n n a h c t h gi R r e tr e v n o c A / D tib . V 0 o t d e tc e n n o c e b ts u M nip d n u o r g le n n a h c t h gi R 0 4 O H C R O nip t u p t u o le n n a h c t h gi R 1 4 D D V R − nip ylp p u s r e w o p le n n a h c t h gi R 2 4 8 T N O C / R E T U M O nip t u p t u o e t u m le n n a h c t h gi R 3 4 D D V X − nip ylp p u s r e w o p r o t allic s o la ts y r C 4 4 T U O X O nip t n e m ele r o t allic s o la ts y r c z H M 4 4 3 9 . 6 1 a r o f s n oitc e n n o C 5 4 N I X I 6 4 S S V X − . V 0 o t d e tc e n n o c e b ts u M nip d n u o r g r o t allic s o la ts y r C 7 4 Y S B S O nip t u p t u o la n gis n oit a zin o r h c n y s k c olc e d o c b u S 8 4 G L F E O nip r o tin o m n oitc e rr o c r o rr e elb u o d d n a elg nis 2 C , 1 C 9 4 W P O nip t u p t u o W d n a U , T , S , R , Q , P e d o c b u S 0 5 Y S F S O . e t a ts y b d n a ts ni e r a e d o c b u s e h t n e h w slla f la n gis sih T nip t u p t u o la n gis n oit a zin o r h c n y s e m a rf e d o c b u S 1 5 K C B S I ). d e s u n u n e h w V 0 o t d e tc e n n o c e b ts u M ( .t u p ni tti m h c S a si sih T nip t u p ni k c olc t u o d a e r e d o c b u S 2 5 X S F O r o t allic s o la ts y r c e h t m o rf d e divid la n gis n oit a zin o r h c n y s z H k 5 3 . 7 e h t r o f nip t u p t u O 3 5 Q R W O nip t u p t u o y b d n a ts t u p t u o Q e d o c b u S 4 5 C W R I .t u p ni tti m h c S a si sih T nip t u p nilo rt n o c e tir w / d a e R 5 5 T U O Q S O nip t u p t u o Q e d o c b u S 6 5 N I O C I r o s s e c o r p o r ci m lo rt n o c m o rf nip t u p ni d n a m m o C 7 5 K C Q C * I . nip t u p ni k c olc t u o d a e r e d o c b u s nip T U O Q S e h t d n a k c olc n oitisiu q c a t u p ni d n a m m o c e h t h t o b r o f t u p n I .t u p ni tti m h c S a si sih T 8 5 S E R * I . d eilp p a ts rif si r e w o p r e tf a ylf eir b w ol t e s e b ts u m nip sih T nip t u p ni t e s e R 9 5 1 1 T S T O ).le v el w ol a t u p t u o ylla m r o N ( . n e p o e v a e L nip t u p t u o ts e T 0 6 M 6 1 O nip t u p t u o z H M 4 4 3 9 . 6 1 1 6 M 2 . 4 O nip t u p t u o z H M 6 3 3 2 . 4 2 6 5 T S E T I . V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A nip t u p ni ts e T 3 6 S C * I . d ello rt n o c t o n fi V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A nip t u p ni tc ele s pih C 4 6 1 T S E T I . V 0 o t d e tc e n n o c e b ts u M .r o tsis e r n w o d -llu p o N nip t u p ni ts e T . D D V X d n a D D V R , D D V L , D D V V , D D V ,. e .i ,s nip ylp p u s r e w o p lla o t d eilp p u s e b ts u m lait n e t o p e m a s e h T : e t o N www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 66 XR-VS99 LV1035M (PRO LOGIC ASSY : IC3701) • Dolby Pro Logic Decoder IC • Block Diagram 48 1 5 6 7 10 11 12 15 16 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 2 3 4 8 9 13 14 DCOUT3 R-RECT DCOUT4 L-RECT VLR-TH VLR-1 VLR-2 VCS-2 VCS-1 VCS-TH L+R-RECT DCOUT2 L-R-RECT DCOUT1 R-BPF3 OSC VDD VDD A/D NS D/A DC-OUT DC-OUT L-OUT R-OUT S-OUT GND IREF DET VCC DELAY-OUT OSC L-BPF1 RT-IN LT-IN DC-OUT C-MODE GND NS-BPF1 NS-BPF2 OSC CLK DATA ENABLE DATA VSS CLK L-BPF2 R-BPF1 S-DC-OUT C-DC-OUT R-DC-OUT L-DC-OUT S-IN C-OUT S-OUT R-OUT L-OUT AC-GND L-IN VCC VREF R-IN R-BPF2 L-BPF3 20kΩ 20kΩ BPF RECT RECT VOL B-NR ADM S-RAM DEV OSC VOL PG R L R S S S L R S L R R S C L L R L LOGDIFF BFL-CONT ADM-CONT OUT-FILTER DC-OUT STRIM VOL/MUTE IN-FILTER NOISE-FIL DATA-DEC NOISE-GEN CH-CONT LOGDIFF LR BPF RECT RECT VREF CIRIM S-MODE C-MODE 13PIN PG VCA VCA VCA VCA VCA VCA VCA VCA VCS SW2 A B SW2 A B SW7 A B SW7 SW7 A A B A B B SW7 SW7 A B A B SW7 A B A B SW7 SW6 A B SW5 A B SW3 A B SW4 A B SW7 SW7 A B SW4 D S C B 23PIN 15PIN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 67 XR-VS99 BU9253FS (DISPLAY ASSY : IC3931) • 1 Chip Karaoke Echo LSI •Pin Function 16 CR MlX IN MUTE VCC ADINT IN ADINT OUT ADLPF OUT ADLPF IN GND MIX OUT ECHO VR BIAS DAINT IN DAINT OUT DALPF IN DALPF OUT 15 14 13 12 11 10 9 1 OSC A/D SRAM COUNTER MIX D/A 2 3 4 5 6 7 8 . o N e m a N n i P O /I n o it c n u F . o N e m a N n i P O /I n o it c n u F l D N G - ni P d n u o r G 9 N I X l M I t u p ni P M A X I M 2 o h c E R V O H C E I lo rt n o c le v el o h c E 0 1 N I F P L D A I t u p ni F P L e dis D A 3 S A I B - s aib C D tr a p g ola n A 1 1 T U O F P L D A O t u p t u o F P L e dis D A 4 N I T N I A D I t u p ni r o t a r g e t nl e dis A D 2 1 T U O T N I D A O t u p t u o r o t a r g e t nl e dis D A 5 T U O T N I A D O t u p t u o r o t a r g e t nl e dis A D 3 1 N I T N I D A I t u p ni r o t a r g e t nl e dis D A 6 N I F P L A D I t u p ni F P L e dis A D 4 1 C C V - nip C C V 7 T U O F P L A D O t u p t u o F P L e dis A D 5 1 E T U M I lo rt n o c e t u M 8 T U O X I M O t u p t u o P M A X I M 6 1 R C - r o t allic s 0 r o f ni P R C •Block Diagram HostData Serial Bitstream CD Subcode Data Host lnterface RISC CPU Decompression Coprocessors Video Interface Video Data Audio Data lnternal Bus DRAM/ROM lnterface DRAM and ROM CD lnterace Audio Interface CL680T-D1 (VCD ASSY : IC1701) • MPEG Decoder •Block Diagram www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 68 XR-VS99 FIN2 1 FIN1 2 E 3 F 4 TB 5 TE- 6 TE 7 TESI 8 SCI 9 TH 10 TA 11 TD- 12 TD 13 JP 14 TO 15 FD 16 JP+ 33 TGL 34 TOFF 35 TES 36 HFL 37 SLOF 38 CV- 39 CV+ 40 RFSM 41 RFS- 43 SLC 43 SLI 44 DGND 45 FSC 46 TBC 47 NC 48 DEF 49 CLK 50 CL 51 DAT 52 CE 53 DRF 54 FSS 55 VCC2 56 REF1 57 VR 58 LF2 59 PH1 60 BH1 61 LDD 62 LDS 63 VCC1 64 FD- 17 FA 18 FA- 19 FE 20 FE- 21 AGND 22 NC 23 SP 24 SPG 25 SP- 26 SPD 27 SLEQ 28 APC REF RF DET VCA VCA BAL I/V TE T.SERVO & T.LOGIC F.SERVO & F.LOGIC SPINDLE SERVO SLED SERVO RFAmp SLC u-com INTER FACE SLD 29 SL- 30 SL+ 31 JP- 32 LA9241ML (VCD ASSY : IC1101) • CD RF/SERVO •Block Diagram www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 69 XR-VS99 PDK032A (VCD ASSY : IC1751) • 1M ROM •Block Diagram A16 2 MEMORY MATRIX (131,072 x 8bit) COLUMN SELECTOR CE BUFFER OE BUFFER TIMING GENERATOR SENSE AMP ADDRESS DECODER ADDRESS BUFFER OUTPUT BUFFER A15 3 A14 29 A13 28 A12 4 A11 25 A10 23 A9 26 A8 27 A7 5 A6 6 A5 7 A4 8 A3 9 A2 10 A1 11 A0 12 D7 21 D6 20 D5 19 D4 18 D3 17 D2 15 D1 14 D0 13 CE 22 OE 24 OE1/OE1 /D.C. 1 Vcc 32 GND 16 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 70 XR-VS99 LC78632 (VCD ASSY : IC1201) • Compact Disc Signal Processing and Servo control for Video Compact Disc player. •Pin Function . o N l o b m y s n i P O /I n o it p ir c s e D 1 O D P V O . nip t u p t u o ts e T 2 2 0 D P O . d e s u n u fi n e p o tf el e b ts ul M .t u p t u o p m u p e g r a h c L L P k c a b y alp e d o m d e e p s - d a u q d n a d e e p s - elb u o D 3 1 0 D P O . nip t u p t u o p m u p e g r a h c L L P k c a b y alp k c o 1 c tip d e e p s -la m o N 4 S S V A . V 0 o t d e tc e n n o c e b o t ylla m r o N . nip d n u o r g m e ts y s g ola n A 5 R F . e g n a r y c n e u q e rf O C V ni-tliu b e h t t e s o t nip n oitc e n n o c r o tsis e R 6 D D V A . nip d n u o r g m e ts y s g ola n A 7 T E S I .t n e rr u c t u p t u o 2 0 D P d n a 1 0 D P t e s o t nip n oitc e n n o c r o tsis e R 8 I A T I . S S V o t d e tc e n n o c e b ts ul M . ni-tliu b si r e tsis e r n w o d -llu p A . nip t u p ni ts e T 9 O M F E O . nip t u p t u o la n gis M F E 0 1 S S V . V 0 o t d e tc e n n o c e b la m r o N . nip d n u o r g m e ts y s la tigi D 1 1 N I M F E I . nip t u p nila n gis M F E 2 1 1 T S E T I . S S V o t d e tc e n n o c e b ts u M . ni-tliu b si r e tsis e r n w o d -llu p A . nip t u p ni ts e T 3 1 + V L C O r o f le v el h gih a st u p t u o - V L C d n a , n oit a r ele c c a r o f le v el- h gih a st u p t u o + V L C . nip t u p t u o lo rt n o c o v r e s eld nip S . n oit a r ele c e d 4 1 - V L C O 5 1 P / V O , o v r e s h g u o r s e t a cid ni t u p t u o le v el- h gih A . nip t u p t u o r o tin o m g nih cti w s cit a m o t u a lo rt n o c e s a h p / o v r e s h g u o R .lo rt n o c e s a h p s e t a cid ni t u p t u o le v el- w ol a d n a 6 1 2 T S E T I . S S V o t d e tc e n n o c e b ts u M . ni-tliu b si r e tsis e r n w o d -llu p A . nip t u p ni ts e T 7 1 3 T S E T I . S S V o t d e tc e n n o c e b ts u M . ni-tliu b si r e tsis e r n w o d -llu p A . nip t u p ni ts e T 8 1 4 P O /I S S V r o D O V o t d e tc e n n o c d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s h cih w ,tr o p 0 /I . d e s u t o n n e h w 9 1 L F H I .t u p ni tti m h c S a si sih T . nip t u p nila n gis n oitc e t e d k c a r T 0 2 S E T I .t u p ni tti m h c S a si sih T . nip t u p nila n gis r o rr e g nik c a r T 1 2 K C P O . d e k c ol si e s a h p e h t n e h w z H M 8 1 2 3 . 4 nip t u p t u 0 . nip r o tin o m k c olc tib k c a b ylp a t a d M F E 2 2 Q E S F O e h t h ti w s e e r g a la n gis M F E e h t m o rf d e tc e t e d la n gis c n y s e h t n e h w " H " . nip t u p t u o n oitc e t e d la n gis c n y S .la n gis c n y s d e t a r e n e g ylla n r e t ni 3 2 F F O T O . nip t u p t u o ff o g nik c a r T 4 2 L G T O . w ol n e h w nia g e h t e s a e r c n I . nip t u p t u o g nih cti w s nia g g nik c a r T 5 2 D L H T .t u p t u o dlo h g nik c a r T 6 2 4 T S E T I . S S V o t d e tc e n n o c e b ts u M . ni-tliu b si r e tsis e r n w o d -llu p A . nip t u p ni ts e T 7 2 D D V . nip ylp p u s r e w o p m e ts y s la tigi D 8 2 + P J O g n r u d n oit a r ele c e d r o f d n a s p m uj t u o g nir u d n oit a r ele c c a r o f h t o b le v el h gih a t u p t u o + P J . nip t u p t u o p m uj k c m T r o f d n a s p m uj n oitc e rid d r a w ni g nir u d n oit a r ele c c a r o f h t o b le v el h gih a st u p t u o - p J .s p m uj n oitc e rid d r a w ni .s p m uj d r a w t u o g nir u d n oit a r ele c e d 9 2 - P J O 0 3 + D L S O .r o s s e c o r p o r ci m lo rt n o c m e ts y s e h t m o rf t n e s s d n a m m o c y b sle v el 4 f o 1 o t t e s e b n a c nip sih T .t u p t u o d el S 1 3 - D L S O 2 3 H P M E O .k sid sis a h p m e - e D a f o k c a b y alp s e t a cid nile v el h gih A . nip r o tin o m sis a h p m e - e D 3 3 5 P O /I S S V r o D D V o t d e tc e n n o c d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s h cih w ,tr o p O /I . d e s u t o n n e h w 4 3 O K C R L O . nip t u p t u o k c olc R L : st u p t u o r e tlif la tigi D 5 3 O L O F D O . d n a m m o c F F O F D e h t h ti w d e n r u t e b n a c r e tlif la tigid e h T . nip t u p t u o a t a d R L : st u p t u o r e tlif la tigi D 6 3 O K C A D O . nip t u p t u o k c olc t u B : st u p t u o r e tlif la tigi D 7 3 1 T N O C O .tr o p t u p t u O 8 3 K C F D / 0 P O /I d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s h cih w , nip t u p ni k c olc tib F D r o tr o p 0 /I . d e s u t o n n e h w S S V r o D D V o t d e tc e n n o c 9 3 N I F D / 1 P O /I d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s h cih w , nip t u p ni a t a d F D r o tr o p O /I . d e s u t o n n e h w S S V r o D D V o t d e tc e n n o c 0 4 2 P O /I d n a e d o m k c o h s -it n a e h t ni r e tlif sis a h p m e - e d e h t f o r e v o e g n a h c ff O / n O r o f t u p ni n a s a stc a o sla h cih w ,tr o p O /I . d e s u t o n n e h w S S V r o D D V o t d e tc e n n o c d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 71 XR-VS99 . o N l o b m y s n i P O /I n o it p ir c s e D 1 4 R L F D / 3 P 0 /I d n a t u p ni e h t o t t e s r o d e n e p o d n a t u p t u o e h t o t t e s e b r e h tie dlu o h s h cih w , nip t u p ni k c olc F D r o t u p t u o tr o P . d e s u t o n n e h w S S V r o D D V o t d e tc e n n o c 2 4 Y S R L O . nip t u p t u o k c olc R L : A X M O R 3 4 2 K C O . d n a m m o c N O C 2 K C e h t h ti w d e tr e v ni e b n a c ytir alo p e h T . nip t u p t u o k c olc ti B : A X M O R 4 4 A X M 0 R O A X M O R e h t g niu s si y b t u p t u o e b n a c d e t alo p r e t ni n e e b t o n s a h t a h t a t a D . nip t u p t u o a t a d d e t alo p r e t n I : A X M O R . d n a m m o c 5 4 F 2 C O . nip t u p t u o g alf 2 C : A X M O R 6 4 L E T U M O . nip t u p t u o e t u m le n n a h c tf e L : C A D tib - 1 7 4 D D V L . nip ylp p u s r e w o p le n n a h c tf e L : C A D tib - 1 8 4 P H C L O . nip t u p t u o P le n n a h c tf e L : C A D tib - 1 9 4 N H C L O . nip t u p t u o N le n n a h c tf e L : C A D tib - 1 0 5 S S V L . V 0 o t d e tc e n n o c e b ts u M . nip d n u o r g le n n a h c tf e L : C A D tib - 1 1 5 S S V X . V 0 o t d e tc e n n o c e b ts u M . d n u o r g r o t allic s o la ts y r C 2 5 T U O X O - d a u q r o f r o t allic s o la ts y r c z H M 8 8 6 8 . 3 3 a e s U . nip t n e m ele r o t allic s o la ts y r c z H M 4 4 3 9 . 6 1 a r o f s n oitc e n n o C .k c a b y alp d e e p s 3 5 N I X I r o fle v el h gih a st u p t u o - V L C d n a , n oit a r ele c c a r o fle v el- h gih a st u p t u o + V L C . nip t u p t u o lo rt n o c o v r e s eld nip S . n oit a r ele c e d 4 5 D D V X . nip ylp p u s r e w o p r o t allic s o la ts y r C 5 5 S S V R . V 0 o t d e tc e n n o c e b ts u M . nip d n u o r g le n n a h c t h gi R : C A D tib - 1 6 5 N H C R O . nip t u p t u o N le n n a h c t h gi R : C A D tib - 1 7 5 P H C R O . nip t u p t u o P le n n a h c t h gi R : C A D tib - 1 8 5 D D V R . nip ylp p u s r e w o p le n n a h c t h gi R : C A D tib - 1 9 5 R E T U M O . nip t u p t u o e t u m le n n a h c t h gi R : C A D tib - 1 0 6 Y S B S O . nip t u p t u o la n gis n oit a zin o r h c n y s k c olc e d o c b u S 1 6 G L F E O .r o tin o m e t a ts n oitc e rr o c r o rr e 2 C d n a l C 2 6 W P O . nip t u p t u o W d n a U , T , S , R , Q , P e d o c b u S 3 6 Y S F S O . e s a ts y b d n a ts ni e r a e d o c b u s e h t n e h w slla fla n gis sih T . nip t u p t u o la n gis n oit a zin o r h c n y s e m a rf e d o c b u S 4 6 K C B S I . d e s u n u fi V 0 o t d e tc e n n o c e b ts u m nip sih T .t u p nitti m h c S a si sih T . nip t u p ni k c olc t u o d a e r e d o c b u S 5 6 T U O D O . nip t u p t u o la tigi D 6 6 X S F O .r o t allic s o la ts y r c e h t m o rf d e divid la n gis n oit a zin o r h c n y s z H k 5 3 . 7 e h t r o f nip t u p t u o 7 6 Q R W O . nip t u p t u o y b d n a ts t u p t u o Q e d o c b u S 8 6 C W R I . nip t u p nilo rt n o c e tir w / d a e R 9 6 T U O Q S O . nip t u p t u o Q e d o c b u S 0 7 N I O C I .r o s s e c o r p o r ci m lo rt n o c m o rf nip t u p ni d n a m m o C 1 7 K C Q C I si sih T . nip t u p ni k c olc t u o d a e r e d o c b u s nip T U O Q S e h t d n a k c olc n oitisiu q c a t u p ni d a m m o c e h t h t o b r o f t u p n I .t u p nitti m h c S 2 7 S E R I . d eilp p a ts rif si r e w o p r e tf a ylf eir b w olt e s e b ts u m nip sih T . nip t u p nit e s e r pih C 3 7 F T S E T O . nip t u p t u o ts e T 4 7 2 T N O C O .tr o p t u p t u O 5 7 M 6 1 O . nip t u p t u o z H M 4 4 3 9 . 6 1 6 7 M 2 . 4 O . nip t u p t u o z H M 6 3 3 2 . 4 7 7 5 T S E T I . V 0 o t d e tc e n n o c e b ts u M . ni-tliu b si r o tsis e r n w o d -llu p A . nip t u p nits e T 8 7 S C I t o n n e h w P S D tc ele s o t S S V o t tc e n n o c o t e r u s e B . ni-tliu b si r o tsis e r n w o d -llu p A . nip t u p nitc ele s pih C . d ello rt n o c 9 7 I F E D I . S S V o t nip e h t tc e n n o c .t o n fI . nip sih t e s u o t e r u s e B . nip t u p nila n gis n oitc e t e d tc e f e D 0 8 C O C V I . S S V o t d e tc e n n o c e b ts u M . nip t u p nits e T www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 72 XR-VS99 PDC051A (VCD ASSY : IC1501) • VCD Control Microcomputer •Pin Function . o N l o b m y S O /I e m a N n i P n o it c n u F . o N e m a N n i P O /I e m a N n i P n o it c n u F 1 Z Z U B / 6 1 P O — — ) C N ( d e s u t o N 1 5 P V — — D N G o t d e tc e n n o C 2 0 M W P / 7 1 P O — — ) C N ( d e s u t o N 2 5 | 5 5 4 C P / 0 2 S | 7 C P / 3 2 S O — — ) C N ( d e s u t o N 3 0 3 P O E C D C I S L D C r o f la ni m r e t lo rt n o c e tir W - d a e R ) e tir W : " H "( 4 1 3 P I F R D D C la ni m r e t n oitc e t e d le v el F R 6 5 | 3 6 0 D P / 4 2 S | 7 D P / 1 3 S O — — ) C N ( d e s u t o N 5 2 3 P O F C D C ) e vitc A : " L "( I S L D C r o f tc ele s pih C 6 3 3 P O T S R D C I S L D C V / D C r o f la ni m r e t t e s e R 4 6 | 1 7 0 E P / 2 3 S | 7 E P / 9 3 S O — — ) C N ( d e s u t o N 7 4 3 P O S C V r e t u p m o c o r ci m N I A M r o f tc ele s pih C ) e vitc A : " L "( 8 5 3 P I Y D R H I S L V D C r o f la n gis y ale d a t a D ) e vitc A : " L "( 2 7 4 D D V — — — V 5 + o t d e tc e n n o C 9 6 3 P O — — ) C N ( d e s u t o N 3 7 | 0 8 0 F P / 0 4 S | 7 F P / 7 4 S O — — ) C N ( d e s u t o N 0 1 7 3 P O — — ) C N ( d e s u t o N 1 1 0 T N I/ 0 7 P I T N I H ) e vitc A : " L "( I S L D C V r o f t u p ni t p u rr e t n I 1 8 0 G P / 8 4 S I C S I D n oitis o p c sid f o n oitc e t e d t u p n I ) m sin a h c e m D C ( 2 1 S E R I T S R V la ni m r e t t u p ni t e s e R 2 8 1 G P / 9 4 S I E D I S N I n oitis o p r e dils f o n oitc e t e d t u p n I ) m sin a h c e m D C ( 3 1 4 7 P I — — ) D D V o t d e tc e n n o C ( d e s u t o N 3 8 2 G P / 0 5 S I N E P O n oitis o p e s olc/ n e p o f o n oitc e t e d t u p n I ) m sin a h c e m D C ( 4 1 5 7 P O — — ) C N ( d e s u t o N 4 8 3 G P / 1 5 S I P M A L C p m alc c sid f o n oitc e t e d t u p n I ) m sin a h c e m D C ( 5 1 1 S S V — — — D N G o t d e tc e n n o C 5 8 | 8 8 0 0 P | 3 0 P O — — ) C N ( d e s u t o N 6 1 1 F C I — — r o t a n o s e r ci m a r e C z H M 6 o t d e tc e n n o C 7 1 2 F C O — — 9 8 2 S S V — — — D N G o t d e tc e n n o C 8 1 1 D D V — — — V 5 + o t d e tc e n n o C 0 9 2 D D V — — — V 5 + o t d e tc e n n o C 9 1 | 2 2 0 N A / 0 8 P | 3 N A / 3 8 P I — — ) D N G o t d e tc e n n o C ( d e s u t o N 1 9 4 0 P O + D A O L r e vir d r o t o m g nid a o L f o lo rt n o C 2 9 5 0 P O – D A O L 3 2 | 6 2 4 N A / 4 8 P | 7 N A / 7 8 P O — — ) C N ( d e s u t o N 3 9 6 0 P O E T U M D ) e vitc A : " L "( r e vir d o v r e s f o e t u M 4 9 7 0 P O L E S H D C V r o f t u p t u o tc e r e s a t a D /s s e r d d A ) s s e r d d A : " H "( I S L 7 2 1 T N I/ 1 7 P I Q R W D C la n gis y b d n a ts a t a d Q e d o c b u s D C ) K O : " L "( ) e vitc A : " L "( t p u rr e t n I t n u o c k c a r T 5 9 0 O S / 0 1 P O V D V A T A D D C / t u p t u o a t a d lair e S )I S L D C /r e t u p m o c o r ci m N I A M ( 8 2 2 T N I/ 2 7 P O — — ) C N ( d e s u t o N 6 9 0 B S / 0 I S / 1 1 P I T U O Q S / S D V t u p ni a t a d lair e S )I S L D C /r e t u p m o c o r ci m N I A M ( 9 2 3 T N I/ 3 7 P O — — ) C N ( d e s u t o N 7 9 0 K C S / 2 1 P O /I K L C D C / K L C V t u p t u o /t u p ni k c olc lair e S )I S L D C /r e t u p m o c o r ci m N I A M ( 0 3 | 5 4 0 T / 0 S | 5 1 T / 5 1 S O — — ) C N ( d e s u t o N 8 9 1 O S / 3 1 P O — — ) C N ( d e s u t o N 9 9 1 B S / 1 I S / 4 1 P O /I O I D H I S L D C V r o f t u p t u o /t u p ni a t a d lair e S 6 4 3 D D V — — — V 5 + o t d e tc e n n o C 0 0 1 1 K C S / 5 1 P O K C H I S L D C V r o f t u p t u o k c olc lair e S 7 4 | 0 5 0 C P / 6 1 S | 3 C P / 9 1 S — — — ) C N ( d e s u t o N www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 73 XR-VS99 53 1 7.1.2 DISPLAY 7 XAV3004 (DISPLAY ASSY : V5621) • FL Display • Pin Assignment • Grid Assignment 1G 2G 3G 4G 5G 6G 7G 8G 9G 16G (2G) (2G to 9G) (7G) (9G) (16G to 10G) (9G) s t u w d1 d2 S3 S2 S4 S5 S1 B26 B13 B20 B7 B14 B1 a1 a2 d1 d2 D1 D1 D2 a1 f b k h r p n e c j a2 S6 S7 g m 15G 14G 13G 12G 11G 10G www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 74 XR-VS99 • Anode Connection 1G 2G 3G to 6G P1 – a1 a1 P2 a2 a2 P3 h h P4 j j P5 k k P6 b b P7 (Left) f f P8 g g P9 (Right) m m P10 (Upper right) c c P11 e e P12 r r P13 p p P14 n n P15 (V-CD) d1 d1 P16 d2 d2 P17 s – P18 (Under) t – P19 (PBC) u – P20 w – P21 – – P22 – – P23 – – P24 – – P25 D1 D1 P26 – – – P27 – – – 7G a1 a2 h j k b f g m c e r p n d1 d2 – – – – – – – – D1 D2 S6 8G a1 a2 h j k b f g m c e r p n d1 d2 – – – – – – – – D1 – – 9G a1 a2 h j k b f g m c e r p n d1 d2 S7 S2 S3 S4 S5 – 10G to 16G B14 B15 B16 B17 B18 B19 B20 B21 B1 B2 B3 B4 B5 B6 B7 B8 B22 B23 B24 B25 B9 B10 B11 B12 B26 B13 S1 • Pin Connection Pin No. Connection F2 53 F2 52 F2 51 NP 50 NP 49 1G 48 2G 47 3G 46 4G 45 5G 44 6G 43 7G 42 8G 41 9G 40 10G 39 11G 38 12G 37 13G 36 14G 35 15G 34 16G 33 P1 32 P2 31 P3 30 P4 29 P5 28 P6 27 Pin No. Connection P7 26 P8 25 P9 24 P10 23 P11 22 P12 21 P13 20 P14 19 P15 18 P16 17 P17 16 P18 15 P19 14 P20 13 P21 12 P22 11 P23 10 P24 9 P25 8 P26 7 P27 6 NP 5 NP 4 F1 3 F1 2 F1 1 NOTE 1) F1, F2........... Filament 2) NP................ No pin 3) DL................. Datum Line 4) 1G to 16G..... Grid www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 75 XR-VS99 Fitting Main Cam Lock Lever Note: The loading tray can be pulled out when the main cam is in this position. (The Lock Lever should be in the notch of the Main Cam.) 7.2 DISASSEMBLY $M MECHANISM VCD 2 1 × 3 7 × 3 5 × 3 1 × 3 1 × 3 1 4 6 8 12 10 3 × 3 1 × 3 Bonnet Case Unhook Tray Cap $M Mechanism VCD Release the jumper wire from Cord Stopper. 11 9 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 76 XR-VS99 $M MECHANISM VCD ADDITIONAL TO JOB Mechanism Base (Bottom View) FRONT PANEL DISPLAY Assy Front Panel CD SW LED Assy AF Assy FM/AM TUNER MODULE SUB TRANS Assy TRADE Assy PRO LOGIC Assy PRIMARY Assy SECONDARY Assy 5 4 3 Unhook 1 Unhook 2 Mechanism Unit Release the jumper wire from Clip B. SUB DISPLAY Assy Front Side 3 2 1 2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 77 XR-VS99 FITTING THE PULLEY INTO THE CARRIAGE MOTOR Clamper Holder Actuater Servo Base Hook Clamper Holder $M Mechanism CD Actuater Hook Hook Servo Mechanism Assy Servo Base Hook Carriage Motor Motor Pulley Servicing pulley press-in station Loading Tray For replacement of the carriage motor, fit the motor pulley by using the servicing pulley press-in station located on the loading tray, as shown in the figure on the right. 1 2 1 2 1 1 2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 78 XR-VS99 + TAPE DECK TAPE DECK PB TAPE DECK FUNCTION TUNER MODULE PROLOGIC LV1035M CD $ MECH AUX (200mV) (-3.8dB) (-2dB) (-8dB) (-8dB) (+2dB) (-6dB) - + - + - + 5 + - + + HA12211NT HA12136AF DOLBY NR Vref Vref 19 14 11 4 + - Vref Vref BASS BLASTER REAR CENTER TRIM : -10dB To R ch From R ch IC3001 DUMMY LC75396 ZOOM SURROUND BASS BLASTER BASS TREBLE 53 55 52 54 50 49 45 46 48 47 35 45 24 22 VR2305 - + Vref E IC3701 N Q2301 E IC2301 E IC2201 E E A B 7 3 1 5 (+30dB) (+15dB) IC2501 MIC AMP IC2501 MIC AMP VR3901 JA3901 JA3902 MIC1 MIC2 I I I I 7.3 BLOCK DIAGRAM www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 79 XR-VS99 FRONT TOTAL GAIN +31dB POWER AMP 2 1 14 - + STK407-090 (+40dB) REAR CENTER TWEETER POWER AMP 3 1 1 4 7 - + TDA8560Q (+40dB) (+9dB) (+5dB) 34 33 30 31 28 TAPE DECK REC TAPE DECK REC IN + + + HA12136AF MPX DOLBY NR Vref Vref Vref Vref - + HA12211NT - + + 16 9 27 2 IC2201 E IC2301 E VR2301 E F2201 E IC3381 E IC3421 E IC3951 E DOLBY PROLOGIC ON IC3401 L IC3301 E RY3601 E CN3991 HEAD PHONE E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 80 XR-VS99 1 DISC-1 indicator 2 DISC-2 indicator 3 DISC-3 indicator 4 DISC-1 select button 5 DISC-2 select button 6 DISC-3 select button 7 DISC CHANGE button 8 OPEN/CLOSE button 9 Display 0 CD disc tray - CD Function button & indicator = TUNER/BAND Function button & indicator ~ TAPE I/II Function button & indicator ! AUX Function button & indicator @ STANDBY indicator # STANDBY/ON switch $ TUNING 1�4 – PREV button % TUNING + ¢�¡ NEXT button ^ STOP/RETURN (7) button & PLAY/PAUSE SELECT 2�3 , MEMORY button * REC/STOP button ( FREQ/STATION button ) ASES/COPY button _ TAPE I Eject button (0) + TAPE I cassette door ¡ Dolby* NR ON/OFF button ™ Volume control (VOLUME) £ DISPLAY button ¢ ENTER button ∞ SOUND MORPHING JOG dial § TIMER/CLOCK ADJ button ¶ PHONES jack (Headphones) • TAPE II Eject button (0) ª TAPE II cassette door º BASS BLASTER button & indicator – PRESET button & indicator ≠ EQUALIZER button & indicator Ÿ ZOOM SURROUND button & indicator ⁄ P.BASS (DEMO) button & indicator ¤ TIMER indicator Lights in Standby mode when the system has been set for timer operation. ‹ MIC MAIN SUB jack › MIC LEVEL knob fi ECHO LEVEL knob fl CENTER level control ‡ REAR level control ° PRO LOGIC MODE button & indicator · NORMAL indicator ‚ PRO LOGIC indicator — 3ch LOGIC indicator ± PHANTOM indicator 7 XR-VS99 PREV NEXT RETURN SELECT 4 5 6 7 8 ¤� 0 - = ~ ! @ # $ % _ + ^ & * ) ( fi� ¡� º� ⁄� ≠� –� ª� •� ¢� ¶� ∞� §� £� ™� 9 1 2 3 fl� ‡� ·� ‚� —� ±� °� ‹� ›� Ÿ� • PANEL FACILITIES 8. PANEL FACILITIES AND SPECIFICATIONS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 81 XR-VS99 7 For model XR-VS99 7 5 6 % = ~ 9 8 ^ 0 ! $ - @ # Display section 5 Displays timer function indications. 6 Indicates CD function status. 7 Lights during recording. 8 Lights during ASES operation. 9 Lights during Sleep Timer operation. 0 Indicates tuner operation status. - Displays a wide range of operation status indications. = Indicates Video CD function status. ~ Indicates Karaoke function status. ! Lights when BEAT CUT 2 is selected. @ Indicates tuner reception status. # Indicates SOUND MORPHING status. $ Indicates TAPE status. % Displays audio level, spectrum analyzer and other indications. ^ Indicates CD player operation status. * ÷ Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. ÷ “DOLBY” and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 82 XR-VS99 Function button section 1 CD function button 2 TUNER/BAND function button 3 TAPE I/II function button 4 AUX function button 5 TUNING 1,4 (–) PREV, (+) ¢,¡ NEXT buttons 6 STOP/RETURN button (7) 7 PLAY/PAUSE SELECT button (2 3) ÷ Roles of the common operation buttons (The rules of the buttons vary depending on the input functions as shown below.) During CD input PLAY/PAUSE/SELECT: Play/pause button/SELECT for VCD playback control STOP/RETURN: Stop button/RETURN for VCD playback control (+) ¢,¡/NEXT: Fast forward/track search button/NEXT for VCD playback control 1,4 (–)/PREV: Fast reverse/track search button/PREV for VCD playback control During cassette deck input PLAY/PAUSE: Play button/Tape transport direction STOP: Stop button (+) ¢,¡: Fast forward button/ Music search button 1,4 (–): Rewind button/ Music search button During tuner operation PLAY/PAUSE MEMORY: STATION MEMORY button (+) ¢,¡: Frequency & Station + (up) button 1,4 (–): Frequency & Station – (down) button 7 Function Auto Play If you press the CD function button when a CD is loaded, the CD automatically starts playing. If you press the TAPEI/II function button when a tape is loaded in the cassette deck, the tape automati- cally starts playing. NOTE: The function cannot be switched during recording and tape copying. 1 2 3 4 PREV NEXT RETURN SELECT 5 6 7 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 83 XR-VS99 1 OPEN/CLOSE button 2 DISC CHANGE button 3 KEYCON buttons 4 TAPE I/II function button 5 AUX function button 6 SHIFT button To operate an indicated function on the numerical key-pad, press the desired button while pressing the SHIFT button. Ex. Press -> 1 Press while pressing -> SLEEP 7 SOUND MORPHING mode button & SOUND MORPHING jog control buttons 8 STANDBY/ON button 9 DISC select buttons (1–3) 0 PGM button - RETURN button = SLOW , STEP E button ~ BAND button Use to switch between FM and AM bands. ! CD function button @ CD/TAPE/STATION (up,down) operation buttons ¶ CD operation buttons (Play/Pause 3/8, Track search 4�¢ , Stop 7, Fast 1�¡ ) (SELECT, NEXT ¢, PREV 4 for VCD playback control) ¶ TAPE operation buttons (Play 2�3 , Music Search 4�¢ , Stop 7, Fast 1�¡ ) The XR-VS55 does not feature the Music Search 4�¢ , function. ¶ TUNER buttons + Stations change in order in the upward direction. – Stations change in order in the downward direction. 1 Frequency down. ¡ Frequency up. # DISPLAY button $ VOLUME 5 (up), ∞ (down) buttons % Used both as Numerical key-pad and various functions. When using for radio station tuning: Pressing these buttons tunes the unit to the frequencies stored in memory. Examples: Station 5 Station 13 Station 20 When using for the CD player: Pressing these buttons lets you directly select the tracks you want from the program you entered. Examples: 3rd track 99th track ^ PRO LOGIC button, TEST TONE button Refer to Supplementary Operating Instructions. & LEVEL MODE button Refer to Supplementary Operating Instructions. Remote control unit KARAOKE 1 2 3 E 1 6 5 2 ! @ # $ - = ^ 3 4 7 8 9 0 ~ % & 3 FM AM 2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 84 XR-VS99 • SPECIFICATIONS STEREO CD/VCD CASSETTE DECK RECEIVER Amplifier section [FRONT] Continuous Power Output (RMS) ................................................ 120 W + 120 W (1 kHz, 10%, 6 Ω) [REAR] Continuous Power Output (RMS) .................................................... 30 W + 30 W (1 kHz, 10%, 4 Ω) [CENTER] Continuous Power Output (RMS) .................................................... 30 W + 30 W (1 kHz, 10%, 4 Ω) Peak Music Power Output ................................................. 3,000 W FM/AM Tuner section FM tuner section Frequency Range ......................................... 87.5 MHz to 108 MHz Antenna input ........................................................75 Ω unbalanced AM tuner section Frequency Range With 9 kHz step ........................................ 531 kHz to 1,602 kHz With 10 kHz step ...................................... 530 kHz to 1,700 kHz Antenna ...................................................................... Loop antenna Miscellaneous Power Requirements ... AC 110 – 127, 220 – 230, 240 V, 50/60 Hz Power Consumption XR-VS99/DBDXJ ..............................................................800 W DLXJ .................................................................230 W DAMXJ .............................................................720 W Power Consumption in Standby mode .......................................1 W NOTE: Specifications and design subject to possible modification without notice due to improvement. CD section Type ...........................................Compact disc digital audio system Wow and Flutter ............................................ Limit of measurement (±0.001 % W.PEAK) or less (EIAJ) Cassette deck section Systems ................................................... 4 track, 2-channel stereo Heads .................................................Recording/playback head x 1 Playback head x 1 Erasing head x 1 Motor ................................................................. DC servo motor x 1 Tape type ...................................................... TYPE I (Normal) tape Dimensions XR-VS99 ................................. 270 (W) x 380 (H) x 343 (D) mm Weight (without package) XR-VS99 ............................................................................ 10 kg Accessories Operating instructions .................................................................... 1 Remote control unit ........................................................................ 1 FM antenna .................................................................................... 1 AM loop antenna ............................................................................ 1 Size AA/R6P dry cell batteries ....................................................... 2 Video cord ...................................................................................... 1 Power cord ..................................................................................... 1 1 Remote control unit x 1 : XZN3010 (CUXR052) 2 FM antenna x 1 : ADH7004 3 AM loop antenna x 1 : XTB3001 4 Video cord x 1 : VDE1034 5 AA/R6P dry cell batteries x 2 6 Power Cord x 1 : ADG1158 (DBDXJ type) ADG1154 (DLXJ/NC type) 1 4 5 3 2 6 KARAOKE 1 2 3 E * Manufactured under license from Dolby Laboratories Licensing Corporation. DOLBY, the double-D symbol and “PRO LOGIC” are trademarks of Dolby Laboratories Licensing Corporation. (L=1.5m) Yellow www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com