ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2009 DEH-4250SD/XNES CRT4505 CD RECEIVER DEH-4250SD/XNES DEH-4250SD/XNES1 DEH-4290SD/XNID DEH-3200UB/XNUC This service manual should be used together with the following manual(s): Model No. Order No. Mech. Module Remarks CX-3269 CRT4488 S11STD-DOUT CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly For details, refer to "Important Check Points for Good Servicing". K-ZZZ NOV. 2009 Printed in Japan www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 2 1 2 3 4 1 2 3 4 C D F A B E SAFETY INFORMATION CAUTION Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used: This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. - Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. CAUTION CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS 2. During repair or tests, do not view laser beam for 10 seconds or longer. WARNING This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited) Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 3 5 6 7 8 5 6 7 8 C D F A B E [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. a Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 4 1 2 3 4 1 2 3 4 C D F A B E CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 SERVICE PRECAUTIONS......................................................................................................................... 5 1.2 NOTES ON SOLDERING .......................................................................................................................... 6 2. SPECIFICATIONS ............................................................................................................................................ 7 2.1 SPECIFICATIONS...................................................................................................................................... 7 2.2 DISC/CONTENT FORMAT ........................................................................................................................ 9 2.3 PANEL FACILITIES.................................................................................................................................. 10 2.4 CONNECTION DIAGRAM ....................................................................................................................... 12 3. BASIC ITEMS FOR SERVICE........................................................................................................................ 17 3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 17 3.2 PCB LOCATIONS .................................................................................................................................... 18 3.3 JIGS LIST ................................................................................................................................................ 19 3.4 CLEANING............................................................................................................................................... 19 4. BLOCK DIAGRAM.......................................................................................................................................... 20 5. DIAGNOSIS.................................................................................................................................................... 23 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 23 5.2 ERROR CODE LIST ................................................................................................................................ 24 5.3 CONNECTOR FUNCTION DESCRIPTION............................................................................................. 25 6. SERVICE MODE ............................................................................................................................................ 26 6.1 DISPLAY TEST MODE ............................................................................................................................ 26 6.2 CD TEST MODE...................................................................................................................................... 27 7. DISASSEMBLY............................................................................................................................................... 28 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 35 8.1 CD ADJUSTMENT................................................................................................................................... 35 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 36 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 38 9.1 PACKING ................................................................................................................................................. 38 9.2 EXTERIOR(1) .......................................................................................................................................... 40 9.3 EXTERIOR(2) .......................................................................................................................................... 42 9.4 CD MECHANISM MODULE..................................................................................................................... 44 10. SCHEMATIC DIAGRAM ............................................................................................................................... 46 10.1 TUNER AMP UNIT 1/2 [MAIN] (GUIDE PAGE) ..................................................................................... 46 10.2 TUNER AMP UNIT 2/2 [MEDIA Ucom] (GUIDE PAGE) ........................................................................ 52 10.3 KEYBOARD UNIT.................................................................................................................................. 58 10.4 CD CORE UNIT(S11STD-DOUT).......................................................................................................... 60 10.5 SD UNIT................................................................................................................................................. 62 10.6 WAVEFORMS........................................................................................................................................ 63 11. PCB CONNECTION DIAGRAM ................................................................................................................... 66 11.1 TUNER AMP UNIT................................................................................................................................. 66 11.2 KEYBOARD UNIT.................................................................................................................................. 70 11.3 CD CORE UNIT(S11STD-DOUT).......................................................................................................... 72 11.4 SD UNIT................................................................................................................................................. 74 12. ELECTRICAL PARTS LIST .......................................................................................................................... 75 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 5 5 6 7 8 5 6 7 8 C D F A B E 1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS 1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. 5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 6. On CD Core Unit, actual cable colors and silk print are different. 7. When a CD-DA (regular music CD) is played in the CD test mode, its sound quality will be temporarily deteriorated. The CD will then repeat normal, deteriorated, normal… playback. This is due to the difference in the playback modes between the normal operation mode and the CD test mode, and the interval of generating deteriorated mode and the time taken to return to the normal mode depend on the error of each clock. The time taken to turn to the deteriorated mode is at a minimum around 20 seconds while the time to return to the normal mode is maximum 40 seconds approximately. Make sure to check the sound quality in the normal operation mode. Green Red White Black 8. area and a heat sink becomes hot areas. Be careful not to burn yourself. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 6 1 2 3 4 1 2 3 4 C D F A B E 1.2 NOTES ON SOLDERING For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 7 5 6 7 8 5 6 7 8 C D F A B E 2. SPECIFICATIONS 2.1 SPECIFICATIONS Continuous power output .. 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 ohmload, both channels driven) Load impedance................... 4 ohm to 8 ohm × 4 4 ohm to 8 ohm × 2 + 2 ohm × 1 Preout maximum output level ............................................... 2.2 V Equalizer (5-Band Graphic Equalizer): Frequency.......................100/315/1.25k/3.15k/8k Hz Gain.................................. ±6 dB HPF: Frequency...................... 50/63/80/100/125 Hz Slope............................... –12 dB/oct Subwoofer (mono): Frequency...................... 50/63/80/100/125 Hz Slope............................... –18 dB/oct Gain.................................. +6 dB to –24 dB Phase ..............................Normal/Reverse Bass boost: Gain................................. +6 dB to 0 dB CD player System.....................................Compact disc audio system Usable discs .......................... Compact disc Signal-to-noise ratio.............. 94 dB (1 kHz) (IEC-A net- work) Number of channels ............ 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) SD Compatible physical format .............................................. Version 2.00 Maximum memory capacity ............................................. 32 GB (for SD and SDHC) File system.............................. FAT12, FAT16, FAT32 MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) FM tuner Frequency range................... 87.5 MHz to 108.0 MHz Usable sensitivity................... 9 dBf(0.8 μV/75 ohm, mono, S/N: 30 dB) Signal-to-noise ratio............. 72 dB (IEC-A network) AM tuner Frequency range................... 531 kHz to 1 602 kHz (9 kHz) 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity.................. 25 μV(S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IEC-A network) Infrared remote control Wavelength............................. 940 nm ± 50 nm Output ......................................typ; 12 mw/sr per Infrared LED Note Specifications and the design are subject to mod- ifications without notice. General Rated power source..............14.4 V DC (allowable voltage range: 10.8 V to 15.1 V DC) Grounding system.................Negative type Maximum current consumption ...............................................10.0 A Dimensions (W × H × D): DIN Chassis.................. 178 mm × 50 mm × 162 mm Nose....................... 188 mm × 58 mm × 24 mm D Chassis.................. 178 mm × 50 mm × 162 mm Nose........................ 170 mm × 46 mm × 24 mm Weight ...................................... 1.3 kg Audio Maximum power output ...... 50 W × 4 50 W × 2/4 ohm + 70 W × 1/2 ohm (for subwoofer) Backup current .....................5.0 mA or less USB USB standard specification .............................................. USB 2.0full speed Maximum current supply ... 500 mA USB Class.............................. MSC (Mass Storage Class) File system............................. FAT12, FAT16, FAT32 MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) ES, ES1 DEH-4250SD/XNES, DEH-4250SD/XNES1, DEH-4290SD/XNID www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 8 1 2 3 4 1 2 3 4 C D F A B E Signal-to-noise ratio............. 72 dB (IHF-A network) AM tuner Frequency range................... 530 kHz to 1 710 kHz Usable sensitivity.................. 25 μV(S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IHF-A network) CEA2006 Specifications Power output ......................... 14 W RMS × 4 Channels (4 ohm and 1 % THD+N) S/N ratio .................................. 91 dBA (reference: 1 W into 4 ohm) Note Specifications and the design are subject to mod- ifications without notice. General Power source..........................14.4 V DC (10.8 V to 15.1 V DC allowable) Grounding system.................Negative type Maximum current consumption ...............................................10.0 A Dimensions (W × H × D): DIN Chassis.................. 178 mm × 50 mm × 162 mm (7 in. × 2 in. × 6-1/2 in.) Nose....................... 188 mm × 58 mm × 24 mm (7-3/8 in.× 2-1/4 in.× 1 in.) D Chassis.................. 178 mm × 50 mm × 162 mm (7 in.× 2 in.× 6-1/2 in.) Nose....................... 170 mm × 46 mm × 24 mm (6-3/4 in.× 1-7/8 in.× 1 in.) Weight ..................................... 1.3 kg(2.9 lbs) Audio Maximum power output ....... 50 W × 4 50 W × 2/4 ohm + 70 W × 1/2 ohm (for subwoofer) Continuous power output ... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 ohm load, both channels driven) Load impedance................... 4 ohm to 8 ohm × 4 4 ohm to 8 ohm × 2 + 2 ohm × 1 Preout maximum output level ............................................... 2.2 V Equalizer (5-Band Graphic Equalizer): Frequency.......................100/315/1.25k/3.15k/8k Hz Gain................................. ±12 dB HPF: Frequency...................... 50/63/80/100/125 Hz Slope................................–12 dB/oct Subwoofer (mono): Frequency.......................50/63/80/100/125 Hz Slope................................–18 dB/oct Gain................................. +6 dB to –24 dB Phase ..............................Normal/Reverse Bass boost: Gain................................. +12 dB to 0 dB CD player System.....................................Compact disc audio system Usable discs ...........................Compact disc Signal-to-noise ratio............. 94 dB (1 kHz) (IHF-A net- work) Number of channels ............ 2 (stereo) MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and earlier) WAV signal format............... Linear PCM & MS ADPCM (Non-compressed) USB USB standard specification ............................................... USB 2.0 full speed Maximum current supply .... 500 mA USB Class............................... MSC(Mass Storage Class) File system.............................. FAT12, FAT16, FAT32 MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes en- coded only) (.m4a) (Ver. 8.2 and earlier) WAV signal format................Linear PCM & MS ADPCM (Non-compressed) FM tuner Frequency range................... 87.9 MHz to 107.9 MHz Usable sensitivity.................. 9 dBf (0.8 μV/75 ohm, mono, S/N: 30 dB) Backup current ...................... 5.0 mA or less DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 9 5 6 7 8 5 6 7 8 C D F A B E 2.2 DISC/CONTENT FORMAT DEH-4200SD www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 10 1 2 3 4 1 2 3 4 C D F A B E 2.3 PANEL FACILITIES Head unit 1 7 2 3 4 5 6 d e c a b f g h 9 8 i tr a P tr a P 1 SRC/ OFF a 6/ PAUSE 2 S.Rtrv b 1 to 6 3 (list) c 3 / 4 MULTI-CONTROL (M.C.) d 2 / 5 Disc loading slot e 1/iPod 6 (eject) f / DISP/SCRL. 7 USB port g CLK / DISP OFF 8 AUX input jack (3.5 mm stereo jack) h BAND / ESC 9 Detach button i SD memory card slot You can see the SD memory card slot if you remove the front panel. CAUTION Use an optional Pioneer USB cable (CD-U51E) to connect the USB audio player/USB memory to the USB port. Since the USB audio player/USB memory is projected forward from the unit, it is dangerous to connect directly. Do not use the unauthorized product. Remote control Part Operation j VOLUME Press to increase or decrease vo- lume. k MUTE Press to mute. Press again to un- mute. l / / / Press to perform manual seek tuning, fast forward, reverse and track search controls. Also used for controlling functions. m AUDIO Press to select an audio function. n DISP/SCRL Press to select different displays. Press and hold to scroll through the text information. o Press to pause or resume. p FUNCTION Press to select functions. Press and hold to recall the initial setting menu when the sources are off. q LIST/ ENTER Press to display the list depending on the source. While in the operating menu, press to control functions. Only for ES, ES1, ID . www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 11 5 6 7 8 5 6 7 8 C D F A B E Display indication 1 2 57 9 bc e f 4 6 8 a d 3 Indicator State 1 Main dis- play sec- tion Tuner: band and frequency Built-in CD, external storage de- vice (USB, SD) and iPod: elapsed playback time and text informa- tion 2 (artist) The disc (track) artist name is dis- played. Artist search refinement on the iPod browsing function is in use. 3 (disc) The disc (album) name is dis- played. Album search refinement on the iPod browsing function is in use. 4 (song) The track (song) name is dis- played. A playable audio file has been se- lected while operating the list. Song search refinement on the iPod browsing function is in use. 5 An upper tier of folder or menu exists. 6 (list) The list function is operated. 7 A lower tier of folder or menu ex- ists. It flashes when a song/album re- lated to the song currently playing is selected from iPod. 8 LOC The local seek tuning is on. 9 (stereo) The selected frequency is being broadcasted in stereo. a (folder re- peat) Folder repeat is on. When repeat function is on, only is displayed. b (folder ran- dom) Folder random is on. When random function is on, only is displayed. c (shuf- fle) Shuffle or shuffle all function is on while the iPod source is being selected. d (sound re- triever) The sound retriever function is on. e iPod CTRL(control mode) is set to iPod. f (SD memory card) Only for ES, ES1, ID SD/SDHC memory card is in- serted. Fastening the front panel If you do not plan to detach the front panel, the front panel can be fastened with supplied screw. UC Screw BPZ20P060FTC ES, ES1, ID Service Screw CXX2204 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 12 1 2 3 4 1 2 3 4 C D F A B E 2.4 CONNECTION DIAGRAM 1. This product 3. Front output 5. Fuse (10 A) 2. Rear output or subwoofer output 4. Wired remote input Hard-wired remote control adaptor can be connected (sold separately). 6. Antenna jack 7. Yellow Connect to the constant 12 V supply terminal. 8. Red Connect to terminal controlled by ignition switch (12 V DC). 9. Black (chassis ground) Connect to a clean, paint-free metal location. t h g i R . 6 1 tf e L . 5 1 22. With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. 14. Front speaker 21. Rear speaker 10. White 12. Gray 13. Gray/black 11. White/black 17. Green 19. Violet 18. Green/black 20. Violet/black 14. Front speaker 21. Rear speaker 23. To rear output or subwoofer output 26. Power amp (sold separately) 25. Connect with RCA cables (sold separately) 24. To front output 26. Power amp (sold separately) 29. Perform these connections when using the optional amplifier. 28. System remote control 27. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). r e k a e p s t n o rF . 4 1 r e k a e p s t n o rF . 4 1 30. Rear speaker or subwoofer 30. Rear speaker or subwoofer DEH-4250SD/XNES, DEH-4250SD/XNES1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 13 5 6 7 8 5 6 7 8 C D F A B E ) 31. Note Change the initial setting of this unit. The subwoofer output of this unit is monaural. 7. Yellow Connect to the constant 12 V supply terminal. 8. Red Connect to terminal controlled by ignition switch (12 V DC). 9. Black (chassis ground) Connect to a clean, paint-free metal location. 1. This product 3. Front output 5. Fuse (10 A) 2. Rear output or subwoofer output 4. Wired remote input Hard-wired remote control adaptor can be connected (sold separately). 6. Antenna jack 32. Subwoofer (4 ) 33. When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything with Green and Green/black leads. 35. Subwoofer (4 ) 2 34. Not used. 15. Left 16. Right 14. Front speaker 10. White 12. Gray 13. Gray/black 11. White/black 17. Green 19. Violet 18. Green/black 20. Violet/black 14. Front speaker 27. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). 32. Subwoofer (4 17. Green 19. Violet 18. Green/black 20. Violet/black www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 14 1 2 3 4 1 2 3 4 C D F A B E Connect with RCA cables (sold separately) Rear output or subwoofer output This product Antenna jack Fuse (10 A) Blue/white Connect to system control terminal of the power amp or aut o-antenna relay control terminal (max. 300 mA 12 V DC). Yellow Connect to the constant 12 V supply terminal. Red Connect to terminal controlled by ignition switch (12 V DC). Black (chassis ground) Connect to a clean, paint-free metal location. System remote control Left Right Perform these connections when using the optional amplifier. White/black Violet/black Violet With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. Front speaker White Gray/black Gray Green/black Green Rear speaker Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Front output Power amp (sold separately) Power amp (sold separately) Front speaker Rear speaker Front speaker Rear speaker Front speaker Rear speaker DEH-4290SD/XNID www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 15 5 6 7 8 5 6 7 8 C D F A B E When not connecting a rear speaker lead to a subwoofer Yellow Connect to the constant 12 V supply terminal. Red Connect to terminal controlled by ignition switch (12 V DC). Black (chassis ground) Connect to a clean, paint-free metal location. This product Front output Right Left With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. Front speaker Rear speaker White Gray Gray/black White/black Green Violet Green/black Violet/black Rear output or subwoofer output Antenna jack Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Fuse (10 A) Front speaker Rear speaker Connect with RCA cables (sold separately) Perform these connections when using the optional amplifier. System remote control Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). Power amp (sold separately) Front speaker Power amp (sold separately) To rear output or subwoofer output To front output Front speaker Rear speaker or subwoofer Rear speaker or subwoofer DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 16 1 2 3 4 1 2 3 4 C D F A B E When using a subwoofer without using the optional amplifier Note Change the initial setting of this unit. The subwoofer output of this unit is monaural. Yellow Connect to the constant 12 V supply terminal. Red Connect to terminal controlled by ignition switch (12 V DC). Black (chassis ground) Connect to a clean, paint-free metal location. This product Front output Rear output or subwoofer output Antenna jack Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Fuse (10 A) Left Right Front speaker Front speaker White Gray Gray/black White/black Green Violet Green/black Violet/black Green Violet Green/black Violet/black Subwoofer (4 4 ( Subwoofer ) ) When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything with Green and Green/black leads. Subwoofer (4 ) x 2 Not used. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 17 5 6 7 8 5 6 7 8 C D F A B E 3. BASIC ITEMS FOR SERVICE 3.1 CHECK POINTS AFTER SERVICING To keep the product quality after servicing, please confirm following check points. d e m rif n o c e b o t m e tI s e r u d e c o r P . o N 1 Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. The customer complain must not be reappeared. Display, audio and operations must be normal. 2 CD Play back a CD. (Track search) No malfunction on display, audio and operation. 3 FM/AM tuner Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Display, audio and operations must be normal. 4 Check whether no disc is inside the product. The media used for the operating check must be ejected. r e tf a e c n a r a e p p a sti n o trid r o s e h ct a r c s o N k c e h c e c n a r a e p p A 5 receiving it for service. See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 18 1 2 3 4 1 2 3 4 C D F A B E 3.2 PCB LOCATIONS A B Keyboard Unit D SD Unit CD Core Unit (S11 STD-DOUT) C Tuner Amp Unit (DEH-4250SD/XNES) (DEH-4250SD/XNES1) (DEH-4290SD/XNID) A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC Unit Number : CWN4805(A,B,C) Unit Number : CWN5219(D) Unit Name : Tuner Amp Unit Unit Number : CWN4813(A,B,C) Unit Name : Keyboard Unit Unit Number : CWN5220(D) Unit Name : Keyboard Unit Unit Number : CWX3774 Unit Name : CD Core Unit(S11STD-DOUT) Unit Number : CWN4816(A,B,C) Unit Name : SD Unit www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 19 5 6 7 8 5 6 7 8 C D F A B E 3.3 JIGS LIST 3.4 CLEANING - Jigs List Name Test Disc L.P.F. Jig No. TCD-782 Remarks Checking the grating Checking the grating (Two pieces) Name Jig No. Remarks - Grease List Name Grease Grease Grease No. GEM1024 GEM1045 Remarks CD Mechanism Module CD Mechanism Module Name Grease No. Remarks Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 20 1 2 3 4 1 2 3 4 C D F A B E 4. BLOCK DIAGRAM JA401 JA661 ANTENNA SL FM/AM TUNER UNIT VCC FMANT AMANT 1 3 5 CE2 6 CE1 8 CK 9 DI 10 DO 14 4 SYS8V TUNER AMP UNIT A ROM_VDD 13 VDD3.3 VDD_3.3 17 Lch TUNL 23 SYS8V 3 1 NJM2885DL1-33 IC431 TUNER3V REG. USB5V DD5V 5 4 R5523N001B IC151 USB5V REG. VOUT VIN 1 EN 3 FLG DD5V BUP 2 1 BD9781HFP IC161 DD5V REG. SW VIN 7 EN VDD3.3 32 92 KEYAD 34 MED_RX 33 MED_TX 43 MEDMUTE 41 MEDSTBY KEYD 63 95 SL 10 RESET 64 TUNPCE1 TUNPCE2 65 TUNPCK 66 TUNPDI 67 TUNPDO 36 USBCTL 23 USBFLG 24 80 SDCTL SYNC 1 2 S-80827CNNB-B8M IC651 RESET VDD3.3 S651 R5S7262ZD144FPU IC501 CN701 MEDIA uCOM 114 SD_CD 113 CDRST RESET 16 15 8 9 VDD 63 SYS_TXD 61 59 58 BRST MEDIAMUTE SYS_RXD 71 70 DM DP WIRED REMOTE 2,3 1 KEYAD KEYD 2 3 1 GND VDD3.3 VDD5 1 5 S-1132B33-U5 IC901 VDD3.3V REG. VOUT VIN 4 SW SD_DATA0 - SD_DATA3, SD_CLK, SD_CMD CN781 SW33V SD_CD 4 9 DAT0 - DAT3, CLK, CMD CN1203 CN1202 VDD CD VDD CD 4 12 7 2 MED3.3V Q781 Q783 Q782 SD UNIT D SD3.3V REG. C PICKUP UNIT (P10.5)(SERVICE) CD CORE UNIT(S11STD-DOUT) LD MD LD- MD HOLOGRAM UNIT LD+ FOCUS ACT. TRACKING ACT. FOP TOP VREF FOM TOM VCC VCC 15 5 14 15 5 2 1 2 1 14 8 8 3 3 4 4 12 12 RF AMP, CD DECODER, MP3&WMA DECODER DIGITAL SERVO/DATA•PROCESSOR CPU, USB HOST CONTROLLER PE5706A IC201 Q101 IC301 BA5839FP ACTUATOR/ MOTOR DRIVER CN101 TD,FD AC,BD,E,F 1 2 VDD TOP FOP REFO 93 FOM TOM PD REFO V+3A LD+ GND SPINDLE MOTOR LOADING/CARRIAGE MOTOR 21 9 SD,MD 40 39 22 41 15 VO3+ 16 VO3- 17 VO4+ 18 VO4- 11 VO1- 14 VO2+ 12 VO1+ 13 VO2- SOM SOP LCOM LCOP CNT MUTE LOIN S903 S901 S905 DSCSNS HOME 8SNS 35 37 38 LD PD CONT CLCONT HOME 8SNS DSCSNS RESET REFOUT LOEJ PUEN CN701 2 VD 1 Q102 54 V+3A VDD CD DATA (CDSRQ,CDSTBY,SKIP, 29 RESET SCL,SDA,DATA,BCLK,LRCK,WAIT) 9 8 VDD CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT) M M MEDRST 21 CWW1967 IC571 FLASH ROM 16Mbit 12 RESET 43 RESET IC60 COMPU PEG640 SYSTEM M 138 DACLRCK 137 DACDATA 139 105 136 DACCLK DACDATA1 DACSCK WM876 IC18 DAC 1 LRCIN 2 DIN 3 BCKIN 12 DEEMPH 14 MCLK Q591 148 CP_SDA 149 CP_SCL 112 CPRST 111 CPPWR MED3.3V A B :DEH-4250SD/XNES :DEH-4250SD/XNES1 A :DEH-4290SD/XNID :DEH-3200UB/XNUC C B VD VD 85 VDSENS BUP Q751 Q752 MECHA VD 19 VDCONT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 21 5 6 7 8 5 6 7 8 C D F A B E 17 DSENS DSENS CN801 SOURCE SW3.3V KYDT DPDT ROT1 ROT0 3 8 11 16 19 4 6 10 12 14 D+ D- 15 13 VBUS USB5V AUXL OEL+B SYS8V BUP 2 1 NJM2388F84 IC911 SYS8V REG. VOUT VIN 4 CONTROL BUP PM9012A IC201 E.VOL 25 OUTFL 26 FL RL OUTRL 36 TUNL 35 CDL S5B+L 27 SWL OUTPL 39 AUXL S1Q+L S4B-L 21 22 CLK STB 23 DATA PA2030A IC351 AMP 9 OUT1(+) 7 FL2 OUT1(-) 12 RL 11 FL IN1 FL 5 RL1 OUT2(+) 3 RL2 OUT2(-) 25 BRE1 H-SW/VDS-DET IN2 22 MUTE 4 STBY 48 MUTE 46 SYSPW 32 92 KEYAD 16 18 40 TELIN 34 MED_RX 33 MED_TX 43 MEDMUTE 41 MEDSTBY KEYD 63 95 SL ASENS 10 RESET BSENS 64 TUNPCE1 TUNPCE2 65 TUNPCK 66 TUNPDI 67 TUNPDO 55 VST 54 VCK 53 VDT 36 USBCTL 23 USBFLG 24 80 SDCTL SYNC JA301 JA981 FL1 1 3 5 7 18 14 ACC1 13 TEL1 9 6 FL 5 SWL SWL Q303 Q301 Q361 Q381 Q382 VDD5 BUP BUP Q363 RCA OUT MED3.3V DD5V 1 6 S-1172B33-E6 IC581 MED3.3V REG. VOUT VIN 3 ON/OFF MED1.2V 4 3 BH12PB3WHFV IC583 MED1.2V REG. VOUT VIN 1 STBY MEDRST 21 IC601 COMPUTER PEG640A8 SYSTEM MICRO BUP Q831 Q832 BUP VDD5 Q901 Q902 45 DALMON 50 OELPW VDD5V REG. OEL+B OEL+B 90 SOURCE 30 KYDT SSENS 29 VDD3.3 Q841 Q842 BUP Q821 Q822 47 SWVDD 49 ILMPW DPDT 1 ROT1 2 ROT0 ILM+B SWVDD ILM+B 5 1 NJM2872F05 IC182 DAC5V REG. SYS8V WM8761GED IC181 DAC 9 VOUTL CDL 1 LRCIN 2 DIN 3 BCKIN 12 DEEMPH 14 MCLK 8 VDD VIN 3 CONT VOUT Q591 341S2162 IC591 iPod CP 13 I2C_SDA/SPI_SOMI 12 I2C_SCL/SPI_SIMO 4 nRESET 5 VCC 2 MODE1/SPI_nSS MED3.3V Q921 BSENS ASENS SOURCE CONNECTOR C TELMUTE Q951 3 16 KEYBOARD UNIT B CN1801 JA1801 19 AUXL 4 SOURCE SW3.3V CN1802 4 D+ 3 D- 2 US5V SW3.3V 6 KYDT 10 DPDT ROT0 14 15 D+ 13 D- S1801 ILLUMI 13 KYDT 12 DPDT MCLK R-ILM 14 19 XREST 11 XCMD 20 DCLK 1 DOUT 2 ADKEY1 17 REM 10 ADKEY2 15 CN1921 10 XI 7 XCS 6 XRES 5 XCMD 4 SCL 3 SI_RX KEY MATRIX 1 3 GP1UXC14RK IC1891 S1811 ROTARY COMMANDER ROT1 12 Phase_A Phase_B 18 ADKEY0 ILM+B IC1901 COMPUTER PEG642A8 MICRO CONTROL SENSOR REMOTE FRONT AUX AUXL AUXR AUXG 3 2 1 USB OEL MODULE 8 11 OEL+B VBUS(US5V) SW3.3V 12 VAH 13 8 VDD VKH 19 VDCONT 20 20 DSEN DSENS B.UP FUSE 10 A 15 17 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 22 1 2 3 4 1 2 3 4 C D F A B E FM/AM TUNER UNIT FMRF ANT adj RF adj FM ANT T51 CF52 RFGND OSCGND DGND AUDIOGND NC VCC VDD_3.3 3.3V 2.5V IC4 2.5V IC2 NC CE2 ROM_VDD SL DI CK CE1 NC DO NC NC NC NC 7 6 13 5 10 9 8 11 14 18 19 20 21 1 3 2 12 15 22 16 4 17 IC1 3.3V AM ANT FMRF ATT LPF OSC IC3 EEPROM 5.0V IC5 ATT MIXER, IF AMP DET, FM MPX 23 Lch A A A A 3.3V→2.5V 5V→3.3V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 23 5 6 7 8 5 6 7 8 C D F A B E 5. DIAGNOSIS 5.1 OPERATIONAL FLOWCHART VCC1 = 3.3 V Pin 14 BSENS Pin 16 ASENS Pin 18 BSENS = L Starts communication with Grille microcomputer. SWVDD <- H Pin 47 Source keys operative Source ON SYSPW <- H Pin 46 500 ms 500 ms Completes power-on operation. (After that, proceed to each source operation) In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 500 msec, the oscillator may be defective. Power ON ASENS = L DSENS Pin 17 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 24 1 2 3 4 1 2 3 4 C D F A B E 5.2 ERROR CODE LIST 8-digit display 6-digit display 4-digit display ERROR-xx ERR-xx E-xx (2) LIST OF CD ERROR CODES (Error Mode: 0xFD) Code Classification Error code to be displayed Details and possible causes 10 Servo Carriage Home NG The CRG cannot move toward the inner track. The CRG cannot move from the inner track. --> Defective HOME SW; Failure in CRG movement. 7 Servo TOC reading NG TOC information cannot be read. --> The partial disk or TOC content is illegal. 11 Servo Focus Search NG Focusing not available --> Disc placed upside-down; Stains on the disc; excessive vibration. 17 Servo Setup NG AGC protection does not work. Focus can be easily lost. --> Scratches or stains on the disc; excessive vibration. 15 Servo Failure in RF data RF not read --> A CD-R disc that does not contain data loaded --> A CD-RW disc that does not contain data loaded 12 Servo Spindle Lock NG Subcode NG RF-amp NG Spindle not locked. Subcode not readable. Proper RF AMP gain not obtained. --> Defective spindle; Scratches or stains on the disc; excessive vibration. --> A CD-R disc that does not contain data loaded, or in a rare case, disc placed upside-down. --> CD signal error. 30 Servo Search Time Out Failed to reach a target address --> CRG tracking error; Scratches on the disc; Stains on the disc 50 Mechanism Failure in ejection Load NG Disc ejection not completed Disc loading not completed --> A foreign object inserted in the mechanism; Disc jammed. 51 Mechanism Failure in retried turning for ejection Disc could not be ejected even after disc turning had been retried. --> A foreign object inserted in the mechanism; Disc jammed. NOTES • Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is generated. • If the TOC cannot be read, this is not processed as an error, and operation continues accordingly. • If you design a new head unit, be sure to use one of the display formats indicated in “Display example of the main unit.” ERROR CODES (1) DISPLAY METHOD If “0xFD” error mode is displayed in CD MODE (CD MODE area for display), an error code will be displayed in the MIN (minute display) and SEC (second display) areas. The same code is displayed in the MIN and SEC areas. The TNO area is blank (#0FFH), as it conventionally was. • Display example of the main unit Depending on the display capability of LCDs, the display format varies, as shown below. XX denotes an error number. Note: In a case of an OEM product, the error display format is subject to the specifications used by the equipment manufacturer. If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from customers and facilitate failure analysis and repair work in servicing. • The 2 high-order digits of an error code denote the main classification, shown below. 0x: Servo-related errors 1x: Servo-related errors 3x: Servo-related errors 5x: Mechanism-related errors • How to restore from each error is shown below. 0x, 1x and 3x: ACC-OFF then ON, CD-OFF then ON, Disc ejection 5X: ACC-OFF then ON, Disc ejection, Disc reloading www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 25 5 6 7 8 5 6 7 8 C D F A B E 5.3 CONNECTOR FUNCTION DESCRIPTION R/SW, F OUTPUT ANTENNA 1 FL+ 2 FR+ 3 FL- 4 FR- 5 RL+ 6 RR+ 7 RL- 8 RR- 9 NC 10 NC 11 NC 12 NC 13 ACC 14 B.REM 15 B.UP 16 GND 16 14 12 10 8 6 4 2 15 13 11 9 7 5 3 1 WIRED REMOTE CONTROL www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 26 1 2 3 4 1 2 3 4 C D F A B E 6. SERVICE MODE 6.1 DISPLAY TEST MODE The information such as the system version is checked and the lighting of every segment on the display is checked. [Operation key] [Test item] Test mode is started System Version information is displayed S $ $ $ $ # # # $ PEG number For PEG123A, "123A" is displayed # System microcomputer version For Ver.7.01, "701" is displayed Unit number information is displayed U % % % % % % % % System unit number For CWW1234, "CWW1234" is displayed Display Version information is displayed (Both of Sys. and Disp.) Ver. 2.01 or later D $ $ $ $ # # # $ PEG number For PEG123A, "123A" is displayed # Display microcomputer version For Ver.7.01, "701" is displayed (Both of Sys. and Disp.) less than Ver. 2.01 D I S P $ $ $ $ # # # $ PEG number For PEG123A, "123A" is displayed # Display microcomputer version For Ver.7.01, "701" is displayed Media microcomputer Version information is displayed M V $ $ # # $ Major version # Minor version Manufacture_ID information is displayed M I D $ $ $ $ $ $ $ $ $ Manufacture ID Display is normally updated Usual product operation is implemented to outward appearances. Display update is stopped The screen gets still when entering this item. Every segment lights up Every segment including icons lights up. Every segment goes out Every segment including icons goes out. Only /UC model (excluding DEH-3200UB/XNUC) Corresponding key Processing Remarks CLK/DISP OFF + LIST Switching to next test display Also used as an entry key www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 27 5 6 7 8 5 6 7 8 C D F A B E 6.2 CD TEST MODE [Key] Contents Display [BAND] Power On (T.Offset is adjusted) TRK MIN SEC 00 00 00 [2] RF AMP Gain switching GG GG GG *1 [3] Focus Close S curve check TRK MIN SEC 91 91 91 [6] Focus Mode switching 0X 0X 0X *2 [1] Tracking Servo Close 00 00 00 or 99 99 99 [<] CRG + [2] Self-adjusting switching TRK MIN SEC ?? ?? ?? *3 *8 [>] CRG - *8 [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [BAND] Power Off TRK MIN SEC [1] T.Close & AGC Applicable servomechanism TRK MIN SEC ?tr ?min ?sec [3] RF AGC / RF AGC coefficient display [<] CRG + 8X 8X 8X or 9X 9X 9X [2] T.Balance adjustment / T.BAL coefficient display TRK MIN SEC ?? ?? ?? [>] CRG - ?? ?? ?? [1] F,T,RF AGC F.Bias display switching TRK MIN SEC TRK MIN SEC TRK MIN SEC [3] [<] CRG/TR Jump + [2] Tracking Open [>] CRG/TR Jump - ?tr ?min ?sec TRK MIN SEC TRK MIN SEC 00 00 00 or 99 99 99 TRK MIN SEC ?tr ?min ?sec 8X 8X 8X or 9X 9X 9X 8X 8X 8X or 9X 9X 9X 00 00 00 or 99 99 99 TRK MIN SEC ?tr ?min ?sec ?? ?? ?? *7 F,T AGC / F.Bias RF AGC 8X 8X 8X or 9X 9X 9X [2] Tracking Open *6 *4 *4 Operation [Key] Test Mode [BAND] Power On/Off [<] CRG + / TR Jump + (Direction of the external surface) [>] CRG - / TR Jump - (Direction of the internal surface) [1] T. CLS & AGC & Applicable servomechanism / AGC,AGC display setting [2] RF Gain switching / Offset adjustment display / T.Balance adjustment / T. Open [3] F. Close,S. Curve / Rough Servo and RF AGC / F,T,RF AGC [6] F. Mode switching / Tracking Close After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete. When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks to Wall, causing the actuator to be damaged). 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released. When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows) - Flow Chart [CD] or [SOURCE] Source ON TRK MIN [3] + [DISP] -> Reset Test Mode IN NOTE When a CD-DA (regular music CD) is played in the CD test mode, its sound quality will be temporarily deteriorated. The CD will then repeat normal, deteriorated, normal… playback. This is due to the difference in the playback modes between the normal operation mode and the CD test mode, and the interval of generating deteriorated mode and the time taken to return to the normal mode depend on the error of each clock. The time taken to turn to the deteriorated mode is at a minimum around 20 seconds while the time to return to the normal mode is maximum 40 seconds approximately. Make sure to check the sound quality in the normal operation mode. *1) TYP t + 6 dB t + 12 dB TRK MIN SEC TRK06MIN06SEC06 TRK12MIN12SEC12 *2) Focus Close t S. Curve t F EQ measurement setting TRK00MIN00SEC00 TRK01MIN01SEC01 TRK02MIN02SEC02 (TRK99MIN99SEC99) *3) F.Offset Display t T.Offset Display t Switch to the order of the original display *4) 100TR Jump *7) TRK/MIN/SEC t F.AGC t T.AGC Gain t F.Bias t RF AGC *8) CRG motor voltage = 2 [V] *9) TYP (1X) t 2X t 1X TRK MIN SEC TRK22MIN22SEC22 TRK11MIN11SEC11 *10) OFF(TYP) t FORCUS t TRACKING TRK MIN SEC TRK70MIN70SEC70 TRK71MIN71SEC71 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 28 1 2 3 4 1 2 3 4 C D F A B E 7. DISASSEMBLY 2 1 2 3 4 5 Fig.1 Fig.2 - Removing the CD Mechanism Module (Fig.1) CD Mechanism Module - Removing the Tuner Amp Unit and SD Unit (Fig.2) 1. Remove the Case. Remove the two screws. Disconnect the connector. Remove the screw. Straighten the tabs at five locations indicated and then remove the Tuner Amp Unit. Straighten the tabs at three locations indicated and then remove the SD Unit (DEH-4250SD/XNES, DEH-4250SD/XNES1 DEH-4290SD/XNID). 1 1 2 1 4 4 4 4 2 2 2 3 4 5 2 5 5 Disconnect the connector and then remove the CD Mechanism Module. Tuner Amp Unit SD Unit 1 Release the two latches and then remove the Panel Assy. Remove the four screws. - Removing the Case (not shown) Panel Assy 1 While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 29 5 6 7 8 5 6 7 8 C D F A B E 1. The seesaw button has ten hooks as shown in the figure below. Front view Oblique perspective figure 2. Disconnect eight hools shown in the figure below and pull the seesaw button. 3. Pull the seesaw button forward. Note: When you want to assemble the seesaw button in the grille by contraries, take care not to break the hook. 4.The seesaw button is disconnected from the grille. - Removing the Grille Unit www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 30 1 2 3 4 1 2 3 4 C D F A B E 1. Hold the Upper and Lower Frames at the specified parts (circled with broken blue lines in the photo below). 2. You can hold the tabs of the Lower Frame (circled with broken green lines in the photo below) if you do so only while lifting the Mechanism Unit from the table. Keeping the Mechanism Unit lifted by holding these tabs with your fingers may result in deformation. 3. Be careful NOT to hold the front part of the Upper Frame or the CRG Mechanism and NOT to insert foreign objects into these mechanisms. Doing so may result in deformation. Proper handling Improper handling How to Hold the Mechanism Unit www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 31 5 6 7 8 5 6 7 8 C D F A B E 1. Remove the solder from the CRG-motor lead wire (Fig. 1). 2. Push in the Disc Detection Arm while applying 4-V power to the CRG Motor (Fig. 2). (Apply 4-V power to the green lead wire. The white lead wire is for grounding.) The Mechanism Module is set to the clamped state, and the PU will move toward the outer track. Note: NEVER apply power to the CRG-motor lead wire without removing the solder from the wire. Doing so may result in damage to the ICs and the PU. 3. Stop the motor when the PU reaches around the middle track. Note: Jumpiness will occur when the PU reaches the outermost track. Although jumpiness does not constitute a problem, it is recommended that it occur as least frequently as possible. Fig. 1 Note: Be aware that the colors of the lead wires do not match the indications on the Core Board Pattern (green wire to O and white wire to P). Fig. 2 Disc Detection Arm Mechanism Module: How to Set to the Quasi-Clamp State (Driven by the Motor) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 32 1 2 3 4 1 2 3 4 C D F A B E How to Remove the PU Unit How to Move the PU toward the Outer Track 1. Set the unit to the quasi-clamp state, following the procedures described in “Mechanism Module: How to Set to the Quasi- Clamp State (Driven by the Motor).” 2. Temporarily change the engagement position of the bias spring of the feed screw (Fig. 2b). Be careful not to cut yourself on the tip of the spring. 3. Hold the PU unit by parts A in Fig. 1 then slide it toward the inner track. 4. Remove the backend of the feed screw from the outer holder, by first sliding it, as shown in Fig. 3, then lifting it. 5. Remove the PU unit, by lifting it. Lifting the PU unit will disengage the PU unit from the part B of the chassis. Note: When reassembling the PU unit, be sure to securely engage the PU unit with the part B of the chassis, as shown in Fig. 4. Also, be sure to change the engagement position of the bias spring of the feed screw to its original position (Fig. 2a). After reassembling, perform the PU adjustment, following the description in the service manual. 1. Set the unit to the quasi-clamp state, following the procedures described in “Mechanism Module: How to Set to the Quasi- Clamp State (Driven by the Motor).” 2. Move the PU unit toward the outer track, by applying 1.5-V power to the CRG motor. Note: After moving the PU toward the outer track and taking the necessary measures, be sure to solder the lead wires. Fig. 4 Fig. 3 Fig. 1 Fig. 2a Original engagement position Fig. 2b Temporary engagement position Slide toward the inner track. One end of the spring is engaged beneath the resin flange and plate bend. Outer holder Backend of the feed screw Properly assembled state [Improper assembly] The chassis is not properly pinched by the PU case and PU rack. A B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 33 5 6 7 8 5 6 7 8 C D F A B E How to Remove the PU Rack 1. Remove the PU Unit, following the procedures described in “How to Remove the PU Unit.” 2. Remove the PU Rack fixing screw (Fig. 1). 3. Remove the PU Rack, by applying force in the direction of the arrow in Fig. 2. Notes: While handling the PU Unit, be careful NOT to touch the actuator block shown in Fig. 6 or bang the actuator block against your workbench. Handle the PU and PU Unit with care, according to the description in “How to Hold the PU.” When reattaching the PU Rack to the PU, first reassemble parts a and b shown in Fig. 3 into the PU case then attach the boss shown in Fig. 4 to the PU case. After reassembling the PU Rack, insert the feed screw from side c in Fig. 5 (insertion depth: Approx. 18 mm for the part indicated in the photo). Fig. 1 Fig. 2 Fig. 3 Fig. 4 Fig. 5 Fig. 6 PU Rack PU Rack fixing screw Actuator block 18 mm b c a www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 34 1 2 3 4 1 2 3 4 C D F A B E How to Hold the PU 1. Be sure to hold the PU at the positions shown in “Proper handling.” NEVER hold it as shown in “Improper handling.” Do not touch the object lens and ACT. Do not touch the VR. Do not touch the Hologram. Do not pull the FPC. Proper handling Improper handling www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 35 5 6 7 8 5 6 7 8 C D F A B E 8. EACH SETTING AND ADJUSTMENT 8.1 CD ADJUSTMENT 1) Cautions on adjustments In this product the single voltage (3.3 V) is used for the regulator. The reference voltage is the REFO1 (1.65 V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo’s misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately. Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on. In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFAGC and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. 2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. [3] + [DISP] -> Reset To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the (→) key or (←) key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0 dB, and the auto-adjustment values are reset to the default settings. When a CD-DA (regular music CD) is played in the CD test mode, its sound quality will be temporarily deteriorated. The CD will then repeat normal, deteriorated, normal… playback. This is due to the difference in the playback modes between the normal operation mode and the CD test mode, and the interval of generating deteriorated mode and the time taken to return to the normal mode depend on the error of each clock. The time taken to turn to the deteriorated mode is at a minimum around 20 seconds while the time to return to the normal mode is maximum 40 seconds approximately. Make sure to check the sound quality in the normal operation mode. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 36 1 2 3 4 1 2 3 4 C D F A B E 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT F E REFO1 CD CORE UNIT Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed. Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Oscilloscope, Two L.P.F. E, F, REFO1 Disc TCD-782 Mode TEST MODE Checking Procedure 1. In test mode, load the disc and switch the 3 V regulator on. 2. Using the right and left buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble". 100 kohm 390 pF 100 kohm 390 pF E VREF F VREF Xch Ych L.P.F. L.P.F. Oscilloscope www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 37 5 6 7 8 5 6 7 8 C D F A B E Grating waveform 45 degrees 0 degrees 75 degrees 60 degrees 30 degrees 90 degrees Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 38 1 2 3 4 1 2 3 4 C D F A B E 9. EXPLODED VIEWS AND PARTS LIST 9.1 PACKING NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) " DEH-4250SD/XNES1 DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 39 5 6 7 8 5 6 7 8 C D F A B E PACKING SECTION PARTS LIST (2) CONTRAST TABLE DEH-4250SD/XNES, DEH-4250SD/XNES1, DEH-4290SD/XNID and DEH-3200UB/XNUC are constructed the same except for the following: Owner's Manual,Installation Manual Mark No. Description Part No. 1 Unit Box See Contrast table (2) 2 Contain Box See Contrast table (2) 3 Protector See Contrast table (2) 4 Protector See Contrast table (2) 5 Polyethylene Bag See Contrast table (2) 6 Cord Assy YDP5039 7 Accessory Assy See Contrast table (2) 8 Polyethylene Bag CEG1160 9 Handle CND3707 10 Screw See Contrast table (2) 11 Screw Assy See Contrast table (2) * 12 Polyethylene Bag CEG-127 13 Screw TRZ50P080FTC 14 Screw See Contrast table (2) 15 Case Assy See Contrast table (2) 16 Remote Control Unit CXE2758 17-1 Owner's Manual See Contrast table (2) 17-2 Installation Manual See Contrast table (2) * 17-3 Warranty Card See Contrast table (2) * 17-4 Service Network See Contrast table (2) * 18 Service Network See Contrast table (2) Mark No. Description Part No. Mark No. Description DEH-4250SD/XNES DEH-4250SD/XNES1 DEH-4290SD/XNID DEH-3200UB/XNUC 1 Unit Box CHG7062 CHG7063 CHG7064 CHG7118 2 Contain Box CHL7062 CHL7063 CHL7064 CHL7118 3 Protector CHP3931 CHP3931 CHP3931 CHP3941 4 Protector CHP3932 CHP3932 CHP3932 CHP3942 5 Polyethylene Bag QEG3001 QEG3001 QEG3001 CEG1173 7 Accessory Assy YEA5084 YEA5084 YEA5084 *YEA5071 10 Screw Not Used Not Used Not Used BPZ20P060FTC 11 Screw Assy YEA5082 YEA5082 YEA5082 YEA5072 14 Screw Not Used Not Used Not Used CRZ50P090FTC 15 Case Assy YXB5009 YXB5009 YXB5009 Not Used 17-1 Owner's Manual CRD4434 CRD4434 CRB3094 CRD4457 17-2 Installation Manual CRD4437 CRD4437 Not Used CRD4458 * 17-3 Warranty Card Not Used CRY1250 CRY1304 CRY1276 * 17-4 Service Network Not Used Not Used CRY1305 Not Used * 18 Service Network Not Used CRY1251 Not Used Not Used Part No. Language CRD4434 English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic CRD4437 English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic CRB3094 English CRD4457 English, French, Spanish(Espanol) CRD4458 English, French, Spanish(Espanol) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 40 1 2 3 4 1 2 3 4 C D F A B E 9.2 EXTERIOR(1) B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 41 5 6 7 8 5 6 7 8 C D F A B E EXTERIOR(1) SECTION PARTS LIST (2) CONTRAST TABLE DEH-4250SD/XNES, DEH-4250SD/XNES1, DEH-4290SD/XNID and DEH-3200UB/XNUC are constructed the same except for the following: Mark No. Description Part No. 1 Holder CND3598 2 Panel CNU1016 3 Detach Grille Assy See Contrast table (2) 4 Screw BPZ20P100FTC 5 Button(DETACH) CAI2688 6 Button(EJECT) CAI2689 7 Button(1-6) CAI2690 8 Button See Contrast table (2) (SRC, BAND, S.Rtrv, CLK, LIST, BACK) 9 Spring CBH2210 10 Cover CNU1012 11 Lighting Conductor CNW1752 12 Lighting Conductor CNW1753 13 Holder CND5407 14 Double Side Tape CNN1878 15 Holder CNW1754 16 OEL Module See Contrast table (2) 17 Grille Unit See Contrast table (2) 18 Door(USB) CAT2911 19 Knob Unit CXE2417 20 Spring XBL7005 21 Cord Assy YDP5039 22 Case YNB5063 23 Remote Control Unit CXE2758 24 Cover CNS7068 Mark No. Description Part No. Mark No. Description DEH-4250SD/XNES DEH-4250SD/XNES1 DEH-4290SD/XNID DEH-3200UB/XNUC 3 Detach Grille Assy CXE2428 CXE2428 CXE2429 CXE3006 8 Button(SRC, BAND, S.Rtrv, CLK, LIST, DISP) CAI2692 CAI2692 CAI2692 CAI2713 16 OEL Module MXS4012 MXS4012 MXS4012 MXS4013 17 Grille Unit CXE2410 CXE2410 CXE2412 CXE2413 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 42 1 2 3 4 1 2 3 4 C D F A B E 9.3 EXTERIOR(2) DEH-4250SD/XNES DEH-4250SD/XNES1 DEH-4290SD/XNID A B B A A D C C www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 43 5 6 7 8 5 6 7 8 C D F A B E EXTERIOR(2) SECTION PARTS LIST (2) CONTRAST TABLE DEH-4250SD/XNES, DEH-4250SD/XNES1, DEH-4290SD/XNID and DEH-3200UB/XNUC are constructed the same except for the following: Mark No. Description Part No. 1 Screw ASZ26P050FTC 2 Screw BSZ26P060FTC 3 Screw BSZ26P100FTC 4 Cable CDE9106 5 Cable See Contrast table (2) 6 Chassis CNA3151 7 Earth Plate CNC8915 8 Cushion CNM8890 9 Insulator CNN3145 10 Tuner Amp Unit See Contrast table (2) 11 Screw BPZ26P080FTC 12 Screw BSZ26P060FTC 13 Screw BSZ26P160FTC 14 Holder CND5411 15 Holder CND5423 16 FM/AM Tuner Unit CWE2098 17 Holder CND4324 > 18 Fuse(10 A) YEK5001 19 Heat Sink YNR5139 20 SD Unit See Contrast table (2) 21 Holder See Contrast table (2) 22 Button CAC4836 23 Spring(Thin) CBH2961 24 Spring(Thick) CBH2962 25 Panel See Contrast table (2) 26 Arm CNV9312 27 Arm CNW1439 28 Spring YBH5012 29 Cover YNN5030 30 CD Mechanism Module(S11) CXK5800 31 Holder YND5048 Mark No. Description Part No. Mark No. Description DEH-4250SD/XNES DEH-4250SD/XNES1 DEH-4290SD/XNID DEH-3200UB/XNUC 5 Cable CDE9107 CDE9107 CDE9107 Not Used 10 Tuner Amp Unit CWN4805 CWN4805 CWN4805 CWN5219 20 SD Unit CWN4816 CWN4816 CWN4816 Not Used 21 Holder CND5417 CND5417 CND5417 Not Used 25 Panel CNU1015 CNU1015 CNU1015 CNU1017 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 44 1 2 3 4 1 2 3 4 C D F A B E 9.4 CD MECHANISM MODULE A C D C A B B C D (A) : GEM1045 (B) : GEM1038 (C) : GEM1024 (D) : GEM1043 (C) (C) (A) (A) (D) (D) (A) (A) (D) (A) (A) (A) (A) (A) (C) (C) (C) (C) (B) (C) (C) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 45 5 6 7 8 5 6 7 8 C D F A B E CD MECHANISM MODULE SECTION PARTS LIST Mark No. Description Part No. 1 Screw BMZ20P020FTC 2 Screw BSZ20P040FTC 3 Screw(M2 x 4) CBA1835 4 Washer CBF1038 5 Spring CBH3010 6 Spring CBH2855 7 Spring CBH2856 8 Spring CBH2860 9 ••••• 10 Spring CBH3011 11 Spring CBH3012 12 Spring CBH3014 13 Spring CBH3015 14 Spring CBH3016 15 Spring CBH3017 16 Spring CBH3018 17 Spring CBH3019 18 Spring CBH3020 19 Spring CBL1797 20 Pickup Unit(S10.5)(Service) CXX1942 21 Bracket CND4553 22 Arm CND4555 23 Frame CND4557 24 Frame CND5217 25 Lever CND5398 26 Sheet CNN2280 27 Rack CNV8342 28 Guide CNW1171 29 Roller CNW1172 30 Arm CNW1173 31 Arm CNW1174 32 Roller CNW1175 33 Lever CNW1176 34 Arm CNW1177 35 Arm CNW1178 36 Gear CNW1180 37 Gear CNW1181 38 Gear CNW1182 39 Gear CNW1183 40 Rack CNW1184 41 Gear CNW1185 42 Gear CNW1186 43 Gear CNW1187 44 Gear CNW1188 45 Clamper CNW1190 46 Arm CNW1192 47 Holder CNW1193 48 Holder CNW1194 49 Damper CNW1197 50 Damper CNW1198 51 Arm CNW1726 52 Motor Unit(M2)(LOAD/CRG) CXC4026 53 Screw Unit CXC8894 54 Arm Assy CXC8896 55 Washer CBF1037 56 Washer CBF1038 57 Arm CND4554 58 Collar CNV6906 59 Roller CNW1196 60 Gear Unit CXC8893 61 Washer YE15FTC 62 Chassis Unit CXE1946 63 Motor Unit(M1)(SPDL) CXE2273 64 Screw JFZ20P025FTC 65 Screw JGZ17P022FTC 66 Screw IMS20P030FTC 67 CD Core Unit (S11STD-DOUT) CWX3774 Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 46 1 2 3 4 1 2 3 4 C D F A B E 10. SCHEMATIC DIAGRAM 10.1 TUNER AMP UNIT 1/2 [MAIN] (GUIDE PAGE) A-a A-b A-a A-b A-b A-a Large size SCH diagram Guide page Detailed page Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". 1/2 A A-a 1/2 DI ROT0 ROT1 PEE PEE SSENS DSENS ASENS BSENS MEDRST DSENS SYStoSH TELIN SL SSENS KEYAD SYNC FLG uCOM_BUS VDCONT FLG USBCTL DPDT DPDT KYDT KYDT RWCLK MEDSTBY SYNC KEYD KEYAD POWER_BUS DD5V KEYD KEYD TUNR TUNL TUNL CDL TUNR CDR USB5V ROT0 ROT1 DM DP AUXL AUXR RDSLK RDS57K RCK RDT SHtoSYS USBCTL CE2 CE1 CK DO LDET SYS8V SYS8V SL BUP RESET RESET RWCNVSS VDD5V VDD33 AUXR AUXG AUXL AUXG NM BZ601 1 1 2 2 JA661 CKS4124 2 3 1 CKS6188-A CN801 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 220u C161 CCH1804-A C166 C610 0.1u/10 C606 0.1u/10 C151 0.1u/10 C152 0.1u/10 C607 NM 1u/10 C211 1u/10 C212 2.2u/10 C203 1u/10 C202 1u/10 C201 C403 NM C401 0.01u/10 C405 0.01u/10 C164 NM C163 0.1u/16 C167 220p/50 C162 1u/16 C402 CCG1192-A C406 NM C431 4.7u/6.3 C404 NM C432 0.01u/50 C210 0.22u/16 C209 0.22u/16 D432 NM D431 NM D161 CRG03 D601 RB551V-30 D602 RB751S-40 D163 CMS02 GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND NJM2885DL1-33 IC431 1 IN 2 GND 3 OUT BD9781HFP IC161 1 VIN 2 SW 3 RT 4 GND 5 FB 6 INV 7 EN IC151 R5523N001B EN 1 GND 2 FLG 3 VIN 4 5 VOUT IC601 1 2 3 4 5 BYTE 6 CNVSS 7 8 9 RESET 10 XOUT 11 VSS1 12 XIN 13 VCC1 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 84 85 86 87 88 89 90 91 92 93 94 95 VREF 96 AVCC 97 98 99 100 M2R6TP_GND KN401 L602 L151 NM L161 CTH1253-A L401 BTH1100-A L402 BTH1100-A Q402 NM 1 E1 2 B1 3 C2 4 E2 5 B2 6 C1 Q401 NM 1 E1 2 B1 3 C2 4 E2 5 B2 6 C1 R409 NM 2 1 4 3 6 5 8 7 R616 100k R 1 R809 100k R811 8.2 R810 8.2 R808 2.2k R408 1.5k R406 680 R403 680 R402 NM R407 680 R401 680 R405 680 R404 680 R804 2.2k R801 2.2k R805 2.2k R802 2.2k R165 100k R613 100k R168 470 R167 33k R162 NM R161 100k R615 100k R607 100k R662 1k R661 1k R608 100k R605 100k R606 2.2k R610 100k R609 100k R151 100k R624 47k R164 NM R163 68k R614 100k R617 R604 100 R603 1M R626 10k R601 NM KEYD KEYAD DSENS PCL1 DP VBUS AUXL OELG SSENS ROT0 DPDT DM ILMG DGND CNVSS RESET DPDT2 KYDT2 RWCLK KEYD2 EPM AUXG AUXR SWVDD KYDT USB5V VA661 VR105C5R0AAA VA662 VR105C5R0AAA USB5V DD5V ZNR401 IMSA-6802-01Y900-T uCOM_BUS POWER_BUS D162 CRG03 D164 NM R166 24k C165 0.01u/10 C433 4.7u/10 R803 2.2k C604 10p/50 C605 12p/50 IC201 S1Q+R 1 S2A-R 2 S3A+R 3 S4B-R 4 5 S5B+R 6 S6R 7 MNR 8 MPR 9 SOR 10 INFR 11 INRR 12 INPR 13 OUTPR 14 OUTRR 27 OUTPL 28 INPL 29 INRL 30 INFL 31 SOL 32 MPL 33 MNL 34 S6L 35 S5B+L 36 S4B-L 37 S3A+L 38 S2A-L 39 S1Q+L 40 QCOM R205 NM R206 NM GND C219 1u/10 C221 NM C220 1u/10 C222 NM USBG ROT1 ILM+B GND OEL+B R207 22k R208 22k R814 100 R816 100 L801 CTF1713-A 1 2 3 4 GND GND DDIN R627 100k R628 100k U401 1 AMANT 2 RFGND 3 FMANT 4 VCC 5 SL 6 CE2 7 NC1 8 CE1 9 CK 10 DI 11 LDET 12 OSCGND 13 ROM_VDD 14 DO 15 DGND 16 NC2 17 VDD_3.3 18 RDS_CK 19 RDS_DATA 20 RDS_LOCK 21 RDS_HSLK 22 AGND 23 Lch 24 Rch L404 BTH1104-A L403 NM C407 0.01u/10 C408 CCG1192-A R169 120 TUN3V X601 CSS1795-A X1 1 GND1 2 GND2 4 X2 3 R602 4.7k GND VA807 VR105C5R0AAA VA808 VR105C5R0AAA VA806 VR105C5R0AAA VA801 VR105C5R0AAA VA802 VR105C5R0AAA VA803 VR105C5R0AAA GND D801 DZ2S068C D802 DZ2S068C D803 DZ2S068C D804 DZ2S068C D805 DZ2S068C R202 330 VA811 NM 1 1 2 2 3 3 4 4 5 5 6 6 JA401 CKX1070-A 1 2 3 C801 0.1u/16 R631 100k R632 100k C802 1u/16 TUNG FM/AM TUNER UNIT RF TUNER ILM CWE2098- X-2026 ILM GRILL TUNER3V REG E.VOL NM D A D A VDD5 BUP KEYD NC NC MED_RX MEDSTBY NC NC MODEL1 SL BSENS USBCTL NC PEE NC ASENS TELIN ROT0 SYNC ROT1 NC MED_TX USBFLG PCL NC NC AANT VDCONT DPDT NC KYDT NC SYS.MICRO SSENS 20.000MHz ASENBO AVSS NC NC MEDRST DSENS KEYAD VDD3.3 SYS8V VDD BUP SYS VDD3.3 BUP SYS8V NC DDCON NC D- ROT1 KYDT ILMG DPDT OELG D+ USBG USBG ROT0 AUX R DGND AUX G AUX L VBUS SOURCE SW3.3V OEL+B ILM+B DSENS USB ILM 1608 (Black) WIRED REMOTE NC NC NC NC NC MODEL2 1608 1608 1608 TUNL AUXG CDL CDR TUNR AUXR AUXL 10U/10 10U/10 1608 1R0u 1R0u BLM15AG102SN1 D F (15uH) (150u) 1608 VDD VDD5 VDD5 BUP VDD3.3 SYS8V SYS8V A OEL 1608 VDD3.3 D IC601 * CWW1965-/PEG640A8 1608 * R6 100k R627 5.13V 5.13V 3.29V 2/2 A B CN1801 A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC FM(30%):-24.00 dBs AM(30%):-24.00 dBs FM:-24.00 dBs AM:-24.00 dBs AUX: +2.20 dBs CD/USB/SD: +3.04 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 47 5 6 7 8 5 6 7 8 C D F A B E 1/2 A A-b 1/2 RR2 RL2 RR1 RL1 FR2 FR1 FL1 FL2 RR2 RR1 FR2 FR1 FL1 FL2 RL1 RL2 TELIN RESET FR FL RR RL SWR SWL DALMON CE1 CE2 LDET DO RDSLK FR RR RL FL BSENS ASENS ISENS SSENS DI SWVDD MUTE VCK DSENS SYStoSH TELIN SL SSENS ISENS KEYAD VCK VDT VST DPDT RWCNVSS RESET KYDT DALMON KEYD RWCLK KYDT RWCLK MEDSTBY MEDMUTE MUTE SYSPW SYSPW SYSPW KEYD KEYD VST VDT DALMON DALMON KYDT SWVDD ILMPW OELPW FL RL SWL FR RR SWR ROT0 ROT1 DM DP OELPW RCK SYSPW ILMPW DPDT SHtoSYS SDCTL USBCTL RDS57K RDT SYS8V SG001528 CK JA981 CKM1586-A 1 2 3 4 5 6 7 8 9 10 11 12 14 15 16 17 18 13 CCH1486-A C361 22u/16 C381 220u/10 C911 100u/16 C913 1000u/16 C901 C609 NM C608 0.1u/10 C602 NM C358 0.47u/16 C355 0.47u/16 C641 NM C362 0.1u/16 C941 0.047u/16 C931 NM C903 NM C356 0.47u/16 C363 2.2u/10 C364 2.2u/10 C366 NM C902 0.01u/10 C357 0.47u/16 C353 0.47u/10 C601 CCG1192-A C302 CCG1192-A C303 NM C301 CCG1192-A C304 NM C306 CCG1192-A C305 CCG1192-A C651 1u/10 C352 0.47u/10 C367 CCG1192-A C904 CCG1192-A C351 0.47u/10 C311 NM C214 CCG1192-A C365 10u/35 C218 CCG1192-A C213 CCG1203-A C841 NM C842 NM C215 0.1u/10 C912 NM C951 NM C312 NM C307 NM C309 NM C308 NM C310 NM C906 NM C354 0.47u/10 D931 NM D901 CRG03 D941 CRG03 D981 CRG03 D942 CRG03 D982 CRG03 D651 1SS352-TRB D383 1SS352 D602 RB751S-40 D382 DAN202U D951 NM D922 HZU7L(A1) D381 UDZS8R2(B) D921 HZU7L(C3) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND IC651 S-80827CNNB-B8M OUT 1 VDD 2 NC 3 VSS 4 IC641 CS 1 SK 2 DI 3 DO 4 5 GND 6 TEST 7 NC 8 VCC IC601 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 VREF 96 NJM2388F84 IC911 1 VIN 2 VOUT 3 GND 4 CONTROL JA301 1 2 3 4 5 6 7 8 9 10 L603 L601 BTH1103-A L841 NM L201 NM L951 miniSMDC075F/24 P301 1 2 LTC114EUB Q361 NM Q931 RT3T22M Q902 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 RT3T22M Q382 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q381 2SC4081(RS) Q901 2SD2396(K) NM Q951 R201 1k 2 1 4 3 6 5 8 7 R616 100k R813 100k R812 100k R809 100k R811 8.2 R810 8.2 R808 2.2k R642 NM R641 NM R643 100k R619 4.7k R804 2.2k R801 2.2k R805 2.2k R802 2.2k R384 47k R383 47k R381 47k R382 100k R361 10k R362 10k R363 330 R911 1k R912 47k R313 NM R314 NM R316 0 R385 1k R304 NM R823 10k R951 NM R922 10k R921 100k R925 4.7k R923 47k R924 47k R931 NM R306 820 R608 100k R651 100k R652 1.5k R844 10k R843 1k R842 4.7k R301 820 R365 10k R622 NM R303 NM R308 22k R629 NM R624 47k R309 NM R305 820 R311 22k R312 22k R307 22k R310 NM R621 NM R617 100k R618 100k R620 100k R623 100k R821 1 R626 10k R315 0 R302 820 R364 NM R901 3.3k R902 22k R841 NM CSG1020-A S651 1 2 RESET2 VDD2 8VCNT BUP1 GND2 BUP2 GND1 RR RL SWL SWR FL FR MUTE1 VDD33V RCAG BSEN1 VDD5V PCL1 BSEN2 TEL1 ASENS MUTE3 SYS+B RL2 RR2 ILL1 FL1 RWCLK KEYD2 EPM MEDMUTE CE ACC1 RR1 FR2 FL2 RL1 FR1 BRE1 TEST1 VDD33 SYS8V BUP VDD5V R926 1k R932 NM C921 0.1u/16 C932 NM R954 NM D902 UDZS5R6(B) RT3CLLM(EF) Q921 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 C905 4.7u/6.3 C907 4.7u/6.3 C603 CCG1201-A GND NM Q362 R803 2.2k R952 NM NM CN601 1 2 3 4 5 6 7 8 9 10 DALMON GND Q831 2SD1664(R) R833 1.2k C831 0.047u/16 RT3T22M Q832 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R831 10k R832 1 D831 HZU10(B1) LTC114EUB Q842 LSA1576UB Q841 LTC114EUB Q822 R822 4.7k 2SA1036K(QR) Q821 BD3733FV S S3A+R 3 S4B-R 4 5 S5B+R 6 S6R 7 MNR 8 MPR 9 SOR 10 INFR 11 INRR 12 INPR 13 OUTPR 14 OUTRR 15 OUTFR 16 GND 17 VREF 18 VCCL 19 FILH 20 VCCH 21 STB 22 CLK 23 DATA 24 DGND 25 OUTFL 26 OUTRL 27 OUTPL 28 INPL 29 INRL 30 INFL 31 SOL 32 MPL 33 MNL 34 S6L 35 S5B+L 36 S4B-L 37 S3A+L 38 S2A-L S1Q+L R203 NM C217 0.1u/10 C216 CCG1203-A C219 1u/10 C221 NM C220 1u/10 C222 NM RT3T22M Q363 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R366 10k L801 CTF1713-A 2 3 ND VDD1 R834 NM L981 D903 NM IC901 S-1132B33 VOUT 1 VSS 2 NC 3 SW 4 5 VIN C368 NM C369 NM IC351 PA2030A TAB 1 PW-GND2 2 OUT2(-) 3 STBY 4 5 OUT2(+) 6 VCC2 7 OUT1(-) 8 PW-GND1 9 OUT1(+) 10 RIPPLE 11 IN1 12 IN2 15 IN3 16 AC-GND 17 OUT3(+) 18 PW-GND3 19 OUT3(-) 20 VCC1 21 OUT4(+) 22 MUTE 23 OUT4(-) 24 PW-GND4 25 H-SW/VOS-DET 13 PRE-GND 14 IN4 TP70 TP69 R630 100k C832 1000p/50 NM Q302 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH3N Q301 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH3N Q303 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 REFERENCE AREA MAP sheet1 SWVDD ROM COLECTION TEL IN VDD5 & VDD3.3 MECHA VD SYS+B ISENS ILM+B B.REM SYSTEM MICRO SOURCE CONNECTOR MECHA RESET ASENS&BSENS GRILL TUNER 3V REG AUTO ANTENNA A ILM NM TUNER IN3(FR) IN1(FL) IN4(RR) IN2(RL) RCA AMP MED3.3V & MED1.2V USB H.SW MUTE IP-BUS 3300/16 105 10U/10 D FR FL SWVDD ILM+B TELMUTE SYS+B VDD5.0 MUTE B.REM AMP ROM CORRECTION OL RCA OUT A RR RL CONNECTOR SOURCE (2125) BSENS&ASENS RESET BUP KEYD NC LDET TUNPDI VDT MED_RX MEDSTBY SYSPW MEDMUTE NC ROMCS MODEL1 DALMON ILMPW SL VCK USBCTL ROMCK VST VCC SWVDD ROMDATA TESTIN TELIN NC NC MED_TX TUNPDO PCL NC NC TUNPCK RDSLK TUNPCE1 IPPW KYDT RCK RDSDT SYS.MICRO SSENS ASENBO AVSS NC VSS NC NC OELPW NC NC KEYAD ISENS VDD3.3 BUP SYS8V VDD3.3 SYS8V BUP VDD5 SYS8V VDD3.3 SYS8V VDD3.3 VDD3.3 BUP SYS8V MUTE RDS57K R632 R631 No MOUNT 100K 1K 0.1u E.VOL MEDIA uCOM FLASH ROM DAC & LPF SD CONNECT NC TUNPCE2 NM 10U/10 1608 -- 1608 NC NC NC NC ISENS NC NC NC NC NC NC A -- SWR FR SWL FL GND GND GND GND BUP VDD3.3 SVR S-GND SWITCH OUT 10U/10 10U/10 10U/10 1608 10uH NM 10U/10 10U/10 10U/10 10U/10 10u/10 ipod CP BUP BUP VDD3.3 VDD5 VDD3.3 VDD5 D VDD5 REFERENCE AREA MAP sheet2 WIRED REMOTE ILM BUP OEL+B 10U/10 1608 DC-DC CONVERTOR OEL+B NC SDCTL CCG1236-A 1608 1608 1608 IC601 * 100k - CWW1965-/PEG640A8 1608 NM NM NM CTH1445 YKB5011- R628 100k R627 - FUSE 10 A 600 uH YEK5001 5.10V 3.30V 8.36V 9.17V 14.18V 3.24V 3.28V > TUNER AMP UNIT (MAIN) 1/2 A The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. NM : No Mount > FM:+20.00 dBs AM:+20.00 dBs AUX:+36.20 dBs CD/USB/SD:+36.04 dBs FM: -6.00 dBs AM: -6.00 dBs AUX:+10.20 dBs CD/USB/SD:+10.04 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 48 1 2 3 4 1 2 3 4 C D F A B E A-a A-b A-b 1/2 RR2 RR1 FR2 FR1 FL1 FL2 RL1 RL2 FR FL RR RL SWR SWL CE1 CE2 LDET DO RDSLK FR RR RL FL DI VCK SSENS ISENS MUTE VST VDT FL RL SWL FR RR SWR RCK SYSPW SDCTL RDS57K RDT SG001528 CK CCH1486-A C361 22u/16 C381 C609 NM C608 0.1u/10 C602 NM C358 0.47u/16 C355 0.47u/16 641 NM C362 0.1u/16 C356 0.47u/16 C363 2.2u/10 C364 2.2u/10 C366 NM C357 0.47u/16 C353 0.47u/10 C601 CCG1192-A C302 CCG1192-A C303 NM C301 CCG1192-A C304 NM C306 CCG1192-A C305 CCG1192-A C352 0.47u/10 C367 CCG1192-A C351 0.47u/10 C311 NM C214 CCG1192-A C365 10u/35 C218 CCG1192-A C213 CCG1203-A C215 0.1u/10 C312 NM C307 NM C309 NM C308 NM C310 NM C354 0.47u/10 D383 1SS352 D602 RB751S-40 D382 DAN202U D381 GND GND GND GND GND GND GND GND IC641 CS 1 SK 2 7 NC 8 VCC IC601 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 JA301 1 2 3 4 5 6 7 8 9 10 L603 L601 BTH1103-A L201 NM miniSMDC075F/24 P301 1 2 LTC114EUB Q361 RT3T22M Q382 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R201 1k 2 1 4 3 6 5 8 7 R643 100k R384 47k R383 47k R382 R361 10k R362 10k R363 330 R313 NM R314 NM R316 0 R385 1k R304 NM R306 820 R301 820 R365 10k R622 NM R303 NM R308 22k R629 NM R624 47k R309 NM R305 820 R311 22k R312 22k R307 22k R310 NM R623 100k R626 10k R315 0 R302 820 R364 NM RR RL SWL SWR FL FR MUTE1 RCAG MUTE3 TEST1 C603 CCG1201-A GND BD3733FV MNR 8 MPR 9 SOR 10 INFR 11 INRR 12 INPR 13 OUTPR 14 OUTRR 15 OUTFR 16 GND 17 VREF 18 VCCL 19 FILH 20 VCCH 21 STB 22 CLK 23 DATA 24 DGND 25 OUTFL 26 OUTRL 27 OUTPL 28 INPL 29 INRL 30 INFL 31 SOL 32 MPL 33 MNL S6L R203 NM C217 0.1u/10 C216 CCG1203-A C219 1u/10 C221 NM C220 1u/10 C222 NM RT3T22M Q363 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R366 10k C368 NM C369 NM IC351 PA2030A TAB 1 PW-GND2 2 OUT2(-) 3 STBY 4 5 OUT2(+) 6 VCC2 7 OUT1(-) 8 PW-GND1 9 OUT1(+) 10 RIPPLE 11 IN1 12 IN2 15 IN3 16 AC-GND 17 OUT3(+) 18 PW-GND3 19 OUT3(-) 20 VCC1 21 OUT4(+) 22 MUTE 23 OUT4(-) 24 PW-GND4 25 H-SW/VOS-DET 13 PRE-GND 14 IN4 TP70 TP69 R630 100k NM Q302 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH3N Q301 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 UMH3N Q303 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 REFERENCE AREA MAP sheet1 SWVDD ROM COLECTION TEL IN VDD5 & VDD3.3 MECHA VD SYS+B ISENS ILM+B B.REM SYSTEM MICRO SOURCE CONNECTOR MECHA RESET ASENS&BSENS GRILL TUNER 3V REG AUTO ANTENNA TUNER IN3(FR) IN1(FL) IN4(RR) IN2(RL) RCA AMP MED3.3V & MED1.2V USB H.SW MUTE IP-BUS 3300/16 105 10U/10 FR FL MUTE AMP RCA OUT A RR RL (2125) NC LDET TUNPDI ROMCS ROMCK VCC TESTIN NC TUNPDO NC TUNPCK RDSLK TUNPCE1 RCK RDSDT SYS.MICRO SSENS VSS NC NC NC VDD3.3 SYS8V VDD3.3 RDS57K R632 R631 u E.VOL MEDIA uCOM FLASH ROM DAC & LPF SD CONNECT TUNPCE2 -- 1608 NC NC NC NC ISENS NC NC NC NC NC NC A -- SWR FR SWL FL GND GND GND GND BUP SVR S-GND SWITCH OUT 10U/10 10U/10 10U/10 10uH NM 10U/10 10U/10 10U/10 10U/10 10u/10 ipod CP REFERENCE AREA MAP sheet2 WIRED REMOTE 10U/10 DC-DC CONVERTOR OEL+B NC SDCTL CCG1236-A 1 * 100k - EG640A8 NM YKB5011- R628 100k R627 - 3.28V > TUNER AMP UNIT (MAIN) 1/2 A The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. FM: -6.00 dBs AM: -6.00 dBs AUX:+10.20 dBs CD/USB/SD:+10.04 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 49 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-b 1/2 RR2 RL2 RR1 RL1 FR2 FR1 FL1 FL2 RR2 RR1 FR2 TELIN RESET DALMON CE1 CE2 BSENS ASENS ISENS SSENS DI SWVDD MUTE DSENS TELIN VCK VDT VST DPDT RWCNVSS RESET KYDT DALMON KEYD RWCLK MEDSTBY MEDMUTE MUTE SYSPW SYSPW SYSPW KEYD DALMON DALMON KYDT SWVDD ILMPW OELPW ROT0 ROT1 DM DP OELPW ILMPW DPDT USBCTL SYS8V CK JA981 CKM1586-A 1 2 3 4 5 6 7 8 9 10 11 12 14 15 16 17 18 13 CCH1486-A C361 220u/10 C911 100u/16 C913 1000u/16 C901 C608 0.1u/10 C641 NM C362 0.1u/16 C941 0.047u/16 C931 NM C903 NM C902 0.01u/10 C651 1u/10 C367 CCG1192-A C904 CCG1192-A C841 NM C842 NM C912 NM C951 NM C906 NM D931 NM D901 CRG03 D941 CRG03 D981 CRG03 D942 CRG03 D982 CRG03 D651 1SS352-TRB D382 DAN202U D951 NM D922 HZU7L(A1) D381 UDZS8R2(B) D921 HZU7L(C3) GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND GND IC651 S-80827CNNB-B8M OUT 1 VDD 2 NC 3 VSS 4 IC641 CS 1 SK 2 DI 3 DO 4 5 GND 6 TEST 7 NC 8 VCC IC601 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 NJM2388F84 IC911 1 VIN 2 VOUT 3 GND 4 CONTROL L603 L841 NM L951 LTC114EUB Q361 NM Q931 RT3T22M Q902 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q381 2SC4081(RS) Q901 2SD2396(K) NM Q951 R616 100k R813 100k R812 100k R809 100k 1 2 0 2 R642 NM R641 NM R643 100k R619 4.7k R384 47k R383 47k R381 47k R382 100k R361 10k R362 10k R363 330 R911 1k R912 47k R823 10k R951 NM R922 10k R921 100k R925 4.7k R923 47k R924 47k R931 NM R608 100k R651 100k R652 1.5k R844 10k R843 1k R842 4.7k R622 NM R621 NM R617 100k R618 100k R620 100k R623 100k R821 1 R364 NM R901 3.3k R902 22k R841 NM CSG1020-A S651 1 2 RESET2 VDD2 8VCNT BUP1 GND2 BUP2 GND1 MUTE1 VDD33V BSEN1 VDD5V PCL1 BSEN2 TEL1 ASENS MUTE3 SYS+B RL2 RR2 ILL1 FL1 EPM MEDMUTE CE ACC1 RR1 FR2 FL2 RL1 FR1 BRE1 TEST1 VDD33 SYS8V BUP VDD5V R926 1k R932 NM C921 0.1u/16 C932 NM R954 NM D902 UDZS5R6(B) RT3CLLM(EF) Q921 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 C905 4.7u/6.3 C907 4.7u/6.3 NM Q362 R952 NM NM CN601 1 2 3 4 5 6 7 8 9 10 DALMON GND Q831 2SD1664(R) R833 1.2k C831 0.047u/16 RT3T22M Q832 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 R831 10k R832 1 D831 HZU10(B1) LTC114EUB Q842 LSA1576UB Q841 LTC114EUB Q822 R822 4.7k 2SA1036K(QR) Q821 VDD1 R834 NM L981 D903 NM IC901 S-1132B33 VOUT 1 VSS 2 NC 3 SW 4 5 VIN C368 NM C369 NM OUT3(+) 18 PW-GND3 19 OUT3(-) 20 VCC1 21 OUT4(+) 22 MUTE 23 OUT4(-) 24 PW-GND4 25 H-SW/VOS-DET C832 1000p/50 A ILM NM 3300/16 105 10U/10 D SWVDD ILM+B TELMUTE SYS+B VDD5.0 MUTE B.REM ROM CORRECTION A CONNECTOR SOURCE BSENS&ASENS RESET BUP TUNPDI VDT MEDSTBY SYSPW MEDMUTE NC ROMCS DALMON ILMPW VCK USBCTL ROMCK VST VCC SWVDD ROMDATA TESTIN TELIN PCL NC TUNPCK TUNPCE1 IPPW ASENBO NC VSS NC OELPW NC ISENS VDD3.3 BUP SYS8V VDD3.3 SYS8V BUP VDD5 SYS8V VDD3.3 BUP SYS8V MUTE R632 R631 No MOUNT 100K 1K 0.1u NC TUNPCE2 NM 10U/10 VDD3.3 SWITCH OUT 08 NM BUP BUP VDD3.3 VDD5 VDD3.3 VDD5 D VDD5 ILM BUP OEL+B 1608 1608 1608 1 * 100k - EG640A8 608 NM NM CTH1445 R628 100k R627 - FUSE 10 A 600 uH YEK5001 5.10V 3.30V 8.36V 9.17V 14.18V 3.24V Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. NM : No Mount > FM:+20.00 dBs AM:+20.00 dBs AUX:+36.20 dBs CD/USB/SD:+36.04 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 50 1 2 3 4 1 2 3 4 C D F A B E A-b A-a A-a 1/2 A-b 1/2 ROT0 ROT1 PEE DSENS ASENS BSENS SL SSENS KEYAD uCOM_BUS VDCONT SYNC KEYD KEYAD POWER_BUS DD5V TUNL CDL TUNR CDR USB5V AUXL AUXR SYS8V BUP RESET RESET RWCNVSS VDD5V VDD33 AUXG NM BZ601 1 1 2 2 JA661 CKS4124 2 3 1 220u C161 804-A 66 C610 0.1u/10 C606 0.1u/10 1u/10 C211 1u/10 C212 2.2u/10 C203 1u/10 C202 1u/10 C201 C164 NM C163 u/16 167 p/50 C162 1u/16 C210 0.22u/16 C209 0.22u/16 D161 CRG03 D602 RB751S-40 63 S02 GND GND GND BD9781HFP IC161 1 VIN 2 SW 3 RT 4 GND 5 FB 6 INV 7 EN IC601 1 2 3 4 5 BYTE 6 CNVSS 7 8 9 RESET 10 XOUT 11 VSS1 12 XIN 13 VCC1 14 15 16 17 18 19 83 84 85 86 87 88 89 90 91 92 93 94 95 VREF 96 AVCC 97 98 99 100 L602 L161 CTH1253-A R161 100k R662 1k R661 1k R605 100k R6 R624 47k R164 NM R604 100 R603 1M R626 10k R601 NM KEYD KEYAD CNVSS RESET USB5V VA661 VR105C5R0AAA VA662 VR105C5R0AAA DD5V uCOM_BUS POWER_BUS D162 CRG03 64 M C165 u/10 C604 10p/50 C605 12p/50 IC201 S1Q+R 1 S2A-R 2 S3A+R 3 S4B-R 4 5 S5B+R 6 S6R 7 MNR 8 MPR 9 SOR 10 INFR 11 INRR 12 INPR 13 OUTPR 14 OUTRR 15 OUTFR 16 25 26 OUTRL 27 OUTPL 28 INPL 29 INRL 30 INFL 31 SOL 32 MPL 33 MNL 34 S6L 35 S5B+L 36 S4B-L 37 S3A+L 38 S2A-L 39 S1Q+L 40 QCOM R205 NM R206 NM GND C219 1u/10 C221 NM C220 1u/10 C222 NM R207 22k R208 22k GND DDIN R627 100k R628 100k X601 CSS1795-A X1 1 GND1 2 GND2 4 X2 3 R602 4.7k GND GND R202 330 R631 100k R632 100k ILM E.VOL VDD5 BUP NC MODEL1 SL BSENS NC NC ASENS ROT0 ROT1 NC AANT VDCONT SYS.MICRO SSENS 20.000MHz AVSS NC DSENS KEYAD NC DDCON NC (Black) WIRED REMOTE NC NC NC NC NC NC NC MODEL2 A 1608 1608 1608 TUNL AUXG CDL CDR TUNR AUXR AUXL BLM15AG102SN1 D F (15uH) u) 1608 VDD3.3 SYS8V A IC601 * CWW1965-/PEG640A8 * R628 100k R627 - 5.13V 2/2 A A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC FM:-24.00 dBs AM:-24.00 dBs AUX: +2.20 dBs CD/USB/SD: +3.04 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 51 5 6 7 8 5 6 7 8 C D F A B E A-b A-a A-a 1/2 A-b 1/2 DI PEE SSENS DSENS ASENS BSENS MEDRST DSENS SYStoSH TELIN SYNC FLG VDCONT FLG USBCTL DPDT DPDT KYDT KYDT RWCLK MEDSTBY MEDMUTE SYNC KEYD KEYD TUNR TUNL USB5V ROT0 ROT1 DM DP RDSLK RDS57K RCK RDT SHtoSYS USBCTL CE2 CE1 CK DO LDET SYS8V SYS8V SL VDD33 AUXR AUXG AUXL CKS6188-A CN801 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 220u C16 CCH1804-A C166 C606 0.1u/10 C151 0.1u/10 C152 0.1u/10 C607 NM C403 NM C401 0.01u/10 C405 0.01u/10 C164 NM C163 0.1u/16 C167 220p/50 C16 1u/16 C402 CCG1192-A C406 NM C431 4.7u/6.3 C404 NM C432 0.01u/50 D432 NM D431 NM D601 RB551V-30 D163 CMS02 GND GND GND GND GND GND GND GND GND GND GND GND GND GND NJM2885DL1-33 IC431 1 IN 2 GND 3 OUT 1 VIN 2 SW 3 RT 4 GND 5 FB 6 INV 7 EN IC151 R5523N001B EN 1 GND 2 FLG 3 VIN 4 5 VOUT IC601 RESET 10 XOUT 11 VSS1 12 XIN 13 VCC1 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 M2R6TP_GND KN401 L602 L151 NM L161 CTH1253-A L401 BTH1100-A L402 BTH1100-A Q402 NM 1 E1 2 B1 3 C2 4 E2 5 B2 6 C1 Q401 NM 1 E1 2 B1 3 C2 4 E2 5 B2 6 C1 R409 NM 2 1 4 3 6 5 8 7 R616 100k R813 100k R812 100k R809 100k R811 8.2 R810 8.2 R808 2.2k R408 1.5k R406 680 R403 680 R402 NM R407 680 R401 680 R405 680 R404 680 R804 2.2k R801 2.2k R805 2.2k R802 2.2k R165 100k R613 100k R168 470 R167 33k R162 NM R161 100k R615 100k R607 100k R608 100k R605 100k R606 2.2k R610 100k R609 100k R151 100k R164 NM R163 68k R614 100k R617 100k R604 100 R60 1M DSENS PCL1 DP VBUS AUXL OELG SSENS ROT0 DPDT DM ILMG DGND DPDT2 KYDT2 RWCLK KEYD2 EPM AUXG AUXR SWVDD KYDT USB5V USB5V DD5V ZNR401 IMSA-6802-01Y900-T D162 CRG03 D164 NM R166 24k C165 0.01u/10 C433 4.7u/10 R803 2.2k C605 12p/50 USBG ROT1 ILM+B GND OEL+B R814 100 R816 100 L801 CTF1713-A 1 2 3 4 GND U401 1 AMANT 2 RFGND 3 FMANT 4 VCC 5 SL 6 CE2 7 NC1 8 CE1 9 CK 10 DI 11 LDET 12 OSCGND 13 ROM_VDD 14 DO 15 DGND 16 NC2 17 VDD_3.3 18 RDS_CK 19 RDS_DATA 20 RDS_LOCK 21 RDS_HSLK 22 AGND 23 Lch 24 Rch L404 BTH1104-A L403 NM C407 0.01u/10 C408 CCG1192-A R169 120 TUN3V X601 CSS1795 X1 1 GND2 4 GND VA807 VR105C5R0AAA VA808 VR105C5R0AAA VA806 VR105C5R0AAA VA801 VR105C5R0AAA VA802 VR105C5R0AAA VA803 VR105C5R0AAA D801 DZ2S068C D802 DZ2S068C D803 DZ2S068C D804 DZ2S068C D805 DZ2S068C VA811 NM 1 1 2 2 3 3 4 4 5 5 6 6 JA401 CKX1070-A 1 2 3 C801 0.1u/16 C802 1u/16 TUNG FM/AM TUNER UNIT RF TUNER ILM CWE2098- X-2026 GRILL TUNER3V REG NM D A D A VDD5 BUP KEYD NC MED_RX MEDSTBY MEDMUTE NC NC BSENS USBCTL PEE ASENS TELIN SYNC NC MED_TX USBFLG PCL NC NC VDCONT DPDT NC KYDT NC 20.000M ASENBO NC MEDRST DSENS VDD3.3 SYS8V VDD3.3 BUP SYS8V VDD3.3 BUP SYS8V DDCON D- ROT1 KYDT ILMG DPDT OELG D+ USBG USBG ROT0 AUX R DGND AUX G AUX L VBUS SOURCE SW3.3V OEL+B ILM+B DSENS USB ILM 1608 1608 10U/10 10U/10 1608 1R0u 1R0u BLM15AG102SN1 D F (15uH) (150u) 1608 VDD5 VDD5 VDD5 BUP VDD3.3 SYS8V SYS8V OEL 1608 VDD3.3 D IC601 * CWW1965-/PEG640A8 1608 R628 100k R627 - 5.13V 5.13V 3.29V B CN1801 FM(30%):-24.00 dBs AM(30%):-24.00 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 52 1 2 3 4 1 2 3 4 C D F A B E 10.2 TUNER AMP UNIT 2/2 [MEDIA Ucom] (GUIDE PAGE) 2/2 A A-a 2/2 CP_SDA CP_SCL A7 A6 A5 A4 A3 A1 A9 A10 A11 A12 A13 A14 A15 A16 A17 A8 CD_SCL CDWAIT CDSKIP CD_SDA CDSRQ CDSTBY CDRST CPPWR DACDATA DEEMPH FORMAT RD FLCS PD13 PD5 PD7 WE0/DQML VDSENS A9 A8 A6 A19 WE0/DQML A15 A7 A4 A5 A2 A14 A12 A3 A13 A10 A16 A18 A20 A11 CPPWR CPRST SD_CD SD_WP SD_DATA1 SD_DATA0 SD_CLK SD_CMD SD_DATA2 SD_DATA3 CP_SDA CP_SCL CD_SDA CDRST A2 CPRST VDCONT CDWAIT CD_SCL CDSTBY CDSRQ VDD33 CDSKIP DACCLK PD14 PD12 PD11 PD10 PD9 PD8 PD15 PD6 PD4 PD3 PD2 PD1 PD0 BUP CDDATAIN CDLRCKIN CDSCKIN MEDRST2 DACMUTE CDDATAIN CDSCKIN CDLRCKIN SD_DATA2 SD_DATA3 SD_CMD SD_DATA1 SD_CD SD_WP SD_DATA0 DACLRCK DACSCK SDCTL SD_CLK NM C752 C533 0.1u/10 C534 0.1u/10 C592 0.1u/10 C508 0.1u/10 C507 0.1u/10 C510 0.1u/10 C509 0.1u/10 C512 0.1u/10 C542 0.1u/10 C541 0.1u/10 C543 0.1u/10 C544 0.1u/10 C540 0.1u/10 C539 0.1u/10 C535 0.1u/16 C574 0.01u/10 C536 0.1u/16 C537 0.1u/10 C704 10p/50 C703 22p/50 C705 22p/50 C511 0.1u/10 C751 CCG1192-A C754 0.047u/10 C538 0.1u/10 C591 0.1u/10 C753 NM C702 NM C701 NM D751 HZU8R2(B1) GND GND GND GND GND GND GND GND 341S2162 IC591 NC1 1 MODE1/SPI_nSS 2 NC2 3 nRESET 4 VCC 5 NC3 6 NC4 7 NC5 8 NC6 9 NC7 10 VSS 11 I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI 13 MODE0/SPI_CLK 14 NC8 15 NC9 16 NC10 17 NC11 18 NC12 19 NC13 20 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 R5S7262ZD144FPU IC501 RD/WR 1 WE0 2 DQMU 3 RAS 4 CAS 5 Vcc1 6 CKE 7 Vss1 8 CS_SDRAM 9 PVcc1 10 A1 11 A2 12 A3 13 A4 14 A5 15 A6 16 A7 17 Vcc2 18 A8 19 Vss2 20 A9 21 PVcc2 22 A10 23 A11 24 A12 25 A13 26 A14 27 A15 28 29 A16 30 Vss4 31 CKIO 32 33 A17 34 RAM TEST1 99 RAM_TEST2 100 NC2 101 (TX) 102 (RX) 103 DACCLK 104 DACDATA1 105 PVcc7 106 DACCS 107 Vss10 108 (EJSW) 109 Vcc6 110 CPPWR 111 CPRST 112 113 SD_CD 114 SD_WP 115 SD_DATA1 116 SD_DATA0 117 PVcc8 118 SD_CLK 119 Vss11 120 SD_CMD 121 Vcc7 122 SD_DATA3 123 SD_DATA2 124 AUDIO_XIN 125 AUDIO_XOUT 126 127 PVcc9 128 129 Vss12 130 131 Vcc8 132 133 CDSRQ 134 CDSTBY 135 136 137 138 139 140 PVcc10 141 142 Vss13 143 144 145 Vcc9 146 CD_SDA 147 CD_SCL 148 CP_SDA 149 CP_SCL 150 CDWAIT 151 CDSKIP 152 PVcc11 153 Vss14 154 PD15 155 PD14 156 PD13 157 PD12 158 PD11 159 PD10 160 Vss15 161 PVcc12 162 PD9 163 PD8 164 PD7 165 PD6 166 PD5 167 PD4 168 PD3 169 Vcc10 170 PD2 171 Vss16 172 PD1 173 PVcc13 174 PD0 175 CS_FLASH 176 RD L591 LCTC4R7K1608-T L701 NM L781 NM RT3T22M Q752 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q751 2SD2396(K) LSA1576UB Q591 R754 10k R529 3.3k R530 NM R522 47k R753 47k R524 NM R525 NM R527 NM R526 220 R535 100 R534 100 R533 100 R532 220 R591 4.7k R752 NM R751 820 R702 47k R704 4.7k R703 4.7k R716 100k R715 100k R713 150 R711 150 R712 150 R709 100 R707 100 R706 220 R705 220 R544 4.7k R600 4.7k R547 0 R594 100 R592 100 R595 10k R593 10k R599 2.7k R596 47k CPSDA CPSCL PGND LRCK CPPWR RAM_MON VD2 VD1 CDSRQ CDSTBY SCL SKIP SDA VDCONT RST2 VDD4 DGND1 DATA BCLK WAIT BUP SD33V VDD33 R597 NM R598 NM R792 47k 2 1 4 3 6 5 8 7 R793 47k 2 1 4 3 6 5 8 7 R701 4.7k R708 220 R714 220 R710 1k R717 100k C706 0.01u/10 R531 47k C547 22p/50 C785 NM GND C786 NM VKN1192-A CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 VKN1186-A CN781 1 2 3 4 5 6 7 8 9 10 R788 220 R787 220 R786 220 R785 220 R784 220 R783 220 R781 220 SDDT1 SDDT0 SDCLK SD33V SDCMD SDDT3 SDDT2 SDCD TP1 2SB1689 Q781 LTC114EUB Q782 R789 680 R790 10k C781 NM X503 CSS1794-A X1 1 GND1 2 GND2 4 X2 3 C549 12p/50 C548 12p/50 CPRST R560 47k R794 1k R795 0 C552 NM C553 NM C554 NM C555 NM C556 NM C557 NM C558 NM C559 NM C560 NM C561 NM C562 NM C563 NM C564 NM C565 NM C567 NM C568 NM C551 NM C550 22p/50 R796 NM C787 NM GND C788 1000p/50 GND DTA123EU Q783 P 1608 D DATA LRCK PGND SCL GND CDSRQ VDD SKIP GND VD VD CDSTBY SDA RESET BCLK MECHA VD MECHA BUP 3.3V 1.2V 1.2V 3.3V MEDIA uCOM ipod CP 10U/10 VCC PVCC WAIT CDRST SD_CD SW33V SD_DATA2 SD_CLK SD_CMD GND SD_DATA3 SD_DATA0 SD_DATA1 SD_WP D DACCLK DACDATA DACLRCK DACSCK USB SEL NC1 16.93MHz MISO0 MOSI0 SSL00 RSPCK0 FLA SPAN 1608 MED3.3V NM CDDATAIN CDLRCKIN CDSCKIN *A,B,C *D 7.63V 3.26V C CN701 D CN1202 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 53 5 6 7 8 5 6 7 8 C D F A B E 2/2 A A-b 2/2 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20 DEEMPH FORMAT A9 A8 A6 A19 WE0/DQML A15 A7 A4 A5 A2 A14 A12 A3 A13 FLCS A10 A16 A17 A18 A20 RD A11 VDSENS SYS8V POWER_BUS DD5V A1 MEDRST2 USB5V VDD5V SYSPW MEDMUTE DP PD6 PD14 PD7 PD15 PD13 PD5 PD12 PD4 PD11 PD3 PD10 PD2 PD9 PD1 PD8 PD0 SHtoSYS SYStoSH MEDSTBY DM MEDRST MEDRST2 DACLRCK DACDATA DACSCK DACCLK DEEMPH FORMAT DACMUTE DACMUTE CDR CDL C572 0.1u/10 C522 0.1u/10 C504 CCG1192-A C586 NM C587 NM C521 0.1u/10 C515 0.01u/10 C584 NM C582 NM C583 CCG1192-A C581 CCG1203-A C532 0.1u/10 C531 0.1u/10 C533 0.1u/10 C189 NM C523 10p/50 C524 10p/50 C192 1800p/50 C534 0.1u/10 C191 1800p/50 C194 NM 0.1u/10 C512 0.1u/10 C513 0.1u/10 C514 0.1u/10 C182 CCG1192-A C519 0.1u/10 C525 0.1u/10 C527 0.1u/10 C528 0.1u/10 C526 0.1u/10 C530 0.1u/10 C529 0.1u/10 C184 CCG1192-A C574 0.01u/10 C571 CCG1192-A C501 CCG1192-A C503 CCG1192-A C506 CCG1192-A C585 CCG1192-A C193 NM C183 0.01u/16 C181 NM C188 0.1u/10 C511 0.1u/10 C545 1u/6.3 C516 0.1u/10 C186 1u/10 C502 NM C505 NM C187 0.1u/10 C185 NM D581 1SS352 D582 CRG03 GND GND GND GND GND GND GND GND GND IC182 NJM2872F05 VIN 1 GND 2 CONT 3 NB 4 5 VOUT IC571 CWW1967 A15 1 A14 2 A13 3 A12 4 5 A11 6 A10 7 A9 8 A8 9 A19 10 NC1 11 /WE 12 /RESET 13 NC2 14 NC3 15 RY_/BY 16 A18 17 A17 18 A7 19 A6 20 A5 21 A4 22 A3 23 A2 24 A1 25 A0 26 /CE 27 Vss1 28 /OE 29 DQ0 30 DQ8 31 DQ1 32 DQ9 33 DQ2 34 DQ10 35 DQ3 36 DQ11 37 Vcc 38 DQ4 39 DQ12 40 DQ5 41 DQ13 42 DQ6 43 DQ14 44 DQ7 45 DQ15_A-1 46 Vss2 47 /BYTE 48 A16 144FPU 1 A10 23 A11 24 A12 25 A13 26 A14 27 A15 28 29 A16 30 Vss4 31 CKIO 32 33 A17 34 A18 35 A19 36 A20 37 38 39 Vcc3 40 Vss5 41 PVcc3 42 RESET 43 44 PLLVcc 45 MD_CLK0 46 PLLVss 47 MD_CLK1 48 XIN 49 XOUT 50 MD_BOOT0 51 MD_BOOT1 52 Vss6 53 PVcc4 54 RTC_XIN 55 RTC_XOUT 56 Vss7 57 BRST 58 59 Vcc4 60 61 Vss8 62 63 PVcc5 64 USBX1 65 USBX2 66 ASEMD 67 USBDPVCC 68 USBDVSS 69 DM 70 DP 71 VBUS 72 USBDVcc 73 USBDVss 74 REFRIN 75 USBAPVCC 76 USBAPVSS 77 USBAVCC 78 USBAVSS 79 USBUVCC 80 USBUVSS 81 82 83 84 85 AVSS 86 AVREF 87 AVCC 88 TRST 89 ASEBRKAK/ASEBRK 90 TDO 91 TDI 92 TMS 93 TCK 94 PVcc6 95 Vss9 96 Vcc5 97 RAM_TEST0 98 RAM_TEST1 99 RAM_TEST2 100 NC2 101 (TX) 102 (RX) 103 DACCLK 104 DACDATA1 105 PVcc7 106 DACCS 107 Vss10 108 (EJSW) 109 Vcc6 110 L502 CTF1410-A R521 47k R522 47k R518 100 R509 47k R510 47k R192 820 R191 820 R512 NM R505 47k R504 47k R524 NM R525 NM R527 NM R572 4.7k R526 220 R573 NM R574 4.7k R513 1k R581 NM R182 NM R181 0 R184 NM R183 NM R519 5.6k RAM_MON VDSENS VBUS2 DAC5V MED33IN MED33 MED12 RESET3 MED33 DD5V VDD5V USB5V SYS8V MED12 uCOM_BUS POWER_BUS IC581 S-1172B33-E6 VOUT 1 VSS1 2 ON/OFF 3 NC 4 5 VSS2 6 VIN GND C588 CCG1192-A R511 NM WR_SW C546 1000p/10 TCK TDO TMS ASEBRK TDI TRST ASEMD R515 NM R514 NM R501 47k C520 0.1u/10 R557 NM R558 NM NM Q181 NM Q182 NM C195 R559 NM WR_END R551 NM 2 1 4 3 6 5 8 7 R575 220 2 1 4 3 6 5 8 7 R576 220 2 1 4 3 6 5 8 7 R577 220 2 1 4 3 6 5 8 7 R578 220 2 1 4 3 6 5 8 7 R553 NM R552 NM R554 47k TP1 TP2 SYSTX SYSRX BRST X501 CSS1760-A X1 1 GND1 2 GND2 4 X2 3 TP3 D583 NM NM IC582 1 VSS 2 VIN 3 VOUT IC583 BH12PB3WHFV STBY 1 GND 2 VIN3 VOUT 4 5 SEL L571 NM L181 DTL1107-A L501 VTL1145-A R502 100 IC181 WM8761GED LRCIN 1 DIN 2 BCKIN 3 NC1 4 5 CAP 6 VOUTR 7 GND 8 VDD 9 VOUTL 10 MUTE 11 NC2 12 DEEMPH 13 FORMAT 14 MCLK R185 NM C190 1000p/10 GND GND R561 10k C196 680p/50 GND GND 1.2V 3.3V 3.3V 3.3V 1.2V SYS8V COM DAC LPF VCC PVCC NC WR_END 1.2V USB USBA A ROM USB_SEL NC1 VDSENS SYS_RXD SYS_TXD WR_SW MEDIAMUTE FLASH ROM SPANSION 16Mbit 10u/10 10u/10 10u/10 10u/10 10u/10 10u/10 5.1V DAC5V 10u/10 10u/10 10u/10 3.3V 1.2V 10u/10 1608 1608 ROM COLECTION ISENS GRILL AUTO ANTENNA ipod CP REFERENCE AREA MAP sheet2 E.VOL OEL+B SOURCE CONNECTOR SD CONNECT TUNER 3V REG TUNER DAC & LPF WIRED REMOTE B.REM ASENS&BSENS MED3.3V & MED1.2V RCA SWVDD MEDIA uCOM FLASH ROM MUTE REFERENCE AREA MAP sheet1 RESET TEL IN ILM+B MECHA VD SYS+B IP-BUS DC-DC CONVERTOR VDD5 & VDD3.3 SYSTEM MICRO AMP USB H.SW MECHA 3.28V 1.19V 1.20V 3.30V 5.01V TUNER AMP UNIT (MEDIA uCOM) 2/2 A 1/2 A A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 54 1 2 3 4 1 2 3 4 C D F A B E A-a A-b A-b 2/2 DEEMPH FORMAT VDSENS CPPWR SYS8V POWER_BUS DD5V USB5V VDD5V SYSPW MEDMUTE DP SHtoSYS SYStoSH MEDSTBY DM DACLRCK DACDATA DACSCK DACCLK DEEMPH FORMAT DACMUTE DACMUTE CDR CDL C522 0.1u/10 C521 0.1u/10 C584 NM C582 NM C583 CCG1192-A C581 CCG1203-A C532 0.1u/10 C531 0.1u/10 C533 0.1u/10 C189 NM C523 10p/50 C524 10p/50 C192 1800p/50 C534 0.1u/10 C191 1800p/50 C194 NM C182 CCG1192-A C519 0.1u/10 C525 0.1u/10 C527 0.1u/10 C528 0.1u/10 C526 0.1u/10 C530 0.1u/10 C529 0.1u/10 C184 CCG1192-A C501 CCG1192-A C503 CCG1192-A C193 NM C183 0.01u/16 C181 NM C188 0.1u/10 C545 1u/6.3 C186 1u/10 C502 NM C187 0.1u/10 C185 NM D581 1SS352 D582 CRG03 GND GND GND IC182 NJM2872F05 VIN 1 GND 2 CONT 3 NB 4 5 VOUT D144FPU 501 XOUT 50 MD_BOOT0 51 MD_BOOT1 52 Vss6 53 PVcc4 54 RTC_XIN 55 RTC_XOUT 56 Vss7 57 BRST 58 59 Vcc4 60 61 Vss8 62 63 PVcc5 64 USBX1 65 USBX2 66 ASEMD 67 USBDPVCC 68 USBDVSS 69 DM 70 DP 71 VBUS 72 USBDVcc 73 USBDVss 74 REFRIN 75 USBAPVCC 76 USBAPVSS 77 USBAVCC 78 USBAVSS 79 USBUVCC 80 USBUVSS 81 82 83 84 85 AVSS 86 AVREF 87 AVCC 88 TRST 89 ASEBRKAK/ASEBRK 90 TDO 91 TDI 92 TMS 93 TCK 94 PVcc6 95 Vss9 96 Vcc5 97 RAM_TEST0 98 RAM_TEST1 99 RAM_TEST2 100 NC2 101 (TX) 102 (RX) 103 DACCLK 104 DACDATA1 105 PVcc7 106 DACCS 107 Vss10 108 (EJSW) 109 Vcc6 110 CPPWR 111 R521 47k R522 47k R518 100 R509 47k R510 47k R192 820 R191 820 R512 NM R524 NM R525 NM R527 NM R526 220 R513 1k R581 NM R182 NM R181 0 R184 NM R183 NM R519 5.6k CPPWR RAM_MON VDSENS VBUS2 DAC5V MED33IN MED33 MED12 MED33 DD5V VDD5V USB5V SYS8V MED12 uCOM_BUS POWER_BUS IC581 S-1172B33-E6 VOUT 1 VSS1 2 ON/OFF 3 NC 4 5 VSS2 6 VIN R511 NM C546 1000p/10 TCK TDO TMS ASEBRK TDI TRST ASEMD R515 NM R514 NM C520 0.1u/10 R557 NM R558 NM NM Q181 NM Q182 NM C195 R559 NM R551 NM 2 1 4 3 6 5 8 7 R553 NM R552 NM R554 47k TP1 CPRST SYSTX SYSRX BRST X501 CSS1760-A X1 1 GND1 2 GND2 4 X2 3 TP3 D583 NM NM IC582 1 VSS 2 VIN 3 VOUT L181 DTL1107-A L501 VTL1145-A IC181 WM8761GED LRCIN 1 DIN 2 BCKIN 3 NC1 4 5 CAP 6 VOUTR 7 GND 8 VDD 9 VOUTL 10 MUTE 11 NC2 12 DEEMPH 13 FORMAT 14 MCLK R185 NM C190 1000p/10 GND GND R561 10k C196 680p/50 GND GND 1.2V 3.3V 3.3V SYS8V uCOM DAC LPF 1.2V ROM USB_SEL NC1 VDSENS SYS_RXD SYS_TXD MEDIAMUTE 10u/10 10u/10 10u/10 10u/10 5.1V DAC5V 10u/10 10u/10 3.3V 1 2V 1608 1608 3.28V 1.20V 3.30V 5.01V TUNER AMP UNIT (MEDIA uCOM) 2/2 A 1/2 A A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 55 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-b 2/2 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20 A9 A8 A6 A19 WE0/DQML A15 A7 A4 A5 A2 A14 A12 A3 A13 FLCS A10 A16 A17 A18 A20 RD A11 DD5V A1 MEDRST2 MEDMUTE PD6 PD14 PD7 PD15 PD13 PD5 PD12 PD4 PD11 PD3 PD10 PD2 PD9 PD1 PD8 PD0 MEDSTBY MEDRST MEDRST2 C572 0.1u/10 C504 CCG1192-A C586 NM C587 NM C515 0.01u/10 C584 NM C582 NM C583 CCG1192-A C581 CCG1203-A 0.1u/10 C512 0.1u/10 C513 0.1u/10 C514 0.1u/10 C519 0.1u/10 C574 0.01u/10 C571 CCG1192-A C506 CCG1192-A C585 CCG1192-A C511 0.1u/10 C516 0.1u/10 C505 NM D581 1SS352 D582 CRG03 GND GND GND GND GND GND IC571 CWW1967 A15 1 A14 2 A13 3 A12 4 5 A11 6 A10 7 A9 8 A8 9 A19 10 NC1 11 /WE 12 /RESET 13 NC2 14 NC3 15 RY_/BY 16 A18 17 A17 18 A7 19 A6 20 A5 21 A4 22 A3 23 A2 24 A1 25 A0 26 /CE 27 Vss1 28 /OE 29 DQ0 30 DQ8 31 DQ1 32 DQ9 33 DQ2 34 DQ10 35 DQ3 36 DQ11 37 Vcc 38 DQ4 39 DQ12 40 DQ5 41 DQ13 42 DQ6 43 DQ14 44 DQ7 45 DQ15_A-1 46 Vss2 47 /BYTE 48 A16 PVcc2 22 A10 23 A11 24 A12 25 A13 26 A14 27 A15 28 29 A16 30 Vss4 31 CKIO 32 33 A17 34 A18 35 A19 36 A20 37 38 39 Vcc3 40 Vss5 41 PVcc3 42 RESET 43 44 PLLVcc 45 MD_CLK0 46 PLLVss 47 MD_CLK1 48 XIN 49 XOUT 50 MD_BOOT0 51 MD_BOOT1 52 Vss6 53 PVcc4 54 RTC_XIN 55 RTC_XOUT 56 Vss7 57 BRST 58 59 L502 CTF1410-A R509 47k R510 47k R512 NM R505 47k R504 47k R572 4.7k R573 NM R574 4.7k R581 NM MED33IN MED33 MED12 RESET3 MED33 DD5V MED12 IC581 S-1172B33-E6 VOUT 1 VSS1 2 ON/OFF 3 NC 4 5 VSS2 6 VIN GND C588 CCG1192-A R511 NM WR_SW C546 1000p/10 R501 47k WR_END R575 220 2 1 4 3 6 5 8 7 R576 220 2 1 4 3 6 5 8 7 R577 220 2 1 4 3 6 5 8 7 R578 220 2 1 4 3 6 5 8 7 TP2 BRST D583 NM NM IC582 1 VSS 2 VIN 3 VOUT IC583 BH12PB3WHFV STBY 1 GND 2 VIN3 VOUT 4 5 SEL L571 NM R502 100 3.3V 1.2V VCC PVCC NC WR_END USB USBA A WR_SW MEDIAMUTE FLASH ROM SPANSION 16Mbit 10u/10 10u/10 10u/10 10u/10 10u/10 3.3V 1.2V 10u/10 ROM COLECTION ISENS GRILL AUTO ANTENNA ipod CP REFERENCE AREA MAP sheet2 E.VOL OEL+B SOURCE CONNECTOR SD CONNECT TUNER 3V REG TUNER DAC & LPF WIRED REMOTE B.REM ASENS&BSENS MED3.3V & MED1.2V RCA SWVDD MEDIA uCOM FLASH ROM MUTE REFERENCE AREA MAP sheet1 RESET TEL IN ILM+B MECHA VD SYS+B IP-BUS DC-DC CONVERTOR VDD5 & VDD3.3 SYSTEM MICRO AMP USB H.SW MECHA 1.19V 1.20V 3.30V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 56 1 2 3 4 1 2 3 4 C D F A B E A-b A-a A-a 2/2 A-b 2/2 CD_SCL CDWAIT CDSKIP CD_SDA CDSRQ CDSTBY CDRST DACDATA DEEMPH FORMAT PD13 VDSENS CPPWR CPRST SD_CD SD_WP SD_DATA1 SD_DATA0 SD_CLK SD_CMD SD_DATA2 SD_DATA3 CP_SDA CP_SCL CD_SDA CDRST VDCONT CDWAIT CD_SCL CDSTBY CDSRQ VDD33 CDSKIP DACCLK PD14 PD12 PD11 PD10 PD9 PD8 PD15 BUP CDDATAIN CDLRCKIN CDSCKIN DACMUTE CDDATAIN CDSCKIN CDLRCKIN SD_DATA2 SD_DATA3 SD_CMD SD_DATA1 SD_CD SD_WP SD_DATA0 DACLRCK DACSCK SDCTL SD_CLK NM C752 C533 0.1u/10 C534 0.1u/10 C542 0.1u/10 C541 0.1u/10 C543 0.1u/10 C540 0.1u/10 C539 0.1u/10 C535 0.1u/16 C536 0.1u/16 C537 0.1u/10 C704 10p/50 C703 22p/50 C705 22p/50 C751 CCG1192-A C754 0.047u/10 C538 0.1u/10 C753 NM C702 NM C701 NM D751 HZU8R2(B1) GND GND GND GND R5S7262ZD144FPU IC501 103 DACCLK 104 DACDATA1 105 PVcc7 106 DACCS 107 Vss10 108 (EJSW) 109 Vcc6 110 CPPWR 111 CPRST 112 113 SD_CD 114 SD_WP 115 SD_DATA1 116 SD_DATA0 117 PVcc8 118 SD_CLK 119 Vss11 120 SD_CMD 121 Vcc7 122 SD_DATA3 123 SD_DATA2 124 AUDIO_XIN 125 AUDIO_XOUT 126 127 PVcc9 128 129 Vss12 130 131 Vcc8 132 133 CDSRQ 134 CDSTBY 135 136 137 138 139 140 PVcc10 141 142 Vss13 143 144 145 Vcc9 146 CD_SDA 147 CD_SCL 148 CP_SDA 149 CP_SCL 150 CDWAIT 151 CDSKIP 152 PVcc11 153 Vss14 154 PD15 155 PD14 156 PD13 157 PD12 158 PD11 159 PD10 160 Vss15 161 PVcc12 162 PD9 163 PD8 164 PD7 165 PD6 166 PD5 167 PD4 168 PD3 169 Vcc10 170 PD2 171 Vss16 L701 NM L781 NM RT3T22M Q752 E1 1 B1 2 C2 3 E2 4 5 B2 6 C1 Q751 2SD2396(K) R754 10k R529 3.3k R530 NM R753 47k R524 R525 NM R527 NM R526 220 R535 100 R534 100 R533 100 R532 220 R752 NM R751 820 R702 47k R704 4.7k R703 4.7k R716 100k R715 100k R713 150 R711 150 R712 150 R709 100 R707 100 R706 220 R705 220 CPSDA CPSCL PGND LRCK CPPWR VD2 VD1 CDSRQ CDSTBY SCL SKIP SDA VDCONT RST2 VDD4 DGND1 DATA BCLK WAIT BUP SD33V VDD33 R792 47k 2 1 4 3 6 5 8 7 R793 47k 2 1 4 3 6 5 8 7 R701 4.7k R708 220 R714 220 R710 1k R717 100k C706 0.01u/10 R531 47k C547 22p/50 C785 NM C786 NM VKN1192-A CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 VKN1186-A CN781 1 2 3 4 5 6 7 8 9 10 R788 220 R787 220 R786 220 R785 220 R784 220 R783 220 R781 220 SDDT1 SDDT0 SDCLK SD33V SDCMD SDDT3 SDDT2 SDCD 2SB1689 Q781 LTC114EUB Q782 R789 680 R790 10k C781 NM X503 CSS1794-A X1 1 GND1 2 GND2 4 X2 3 C549 12p/50 C548 12p/50 CPRST R794 1k R795 0 C552 NM C553 NM C554 NM C555 NM C556 NM C557 NM C558 NM C559 NM C560 NM C561 NM C562 NM C563 NM C551 NM C550 22p/50 R796 NM C787 NM C788 DTA123EU Q783 P 1608 D DATA LRCK PGND SCL GND CDSRQ VDD SKIP GND VD VD CDSTBY SDA RESET BCLK MECHA VD MECHA BUP 3.3V 1.2V MEDIA uCOM 10U/10 WAIT CDRST SD_CD SW33V SD_DATA2 SD_CLK SD_CMD GND SD_DATA3 SD_DATA0 SD_DATA1 SD_WP DACCLK DACDATA DACLRCK DACSCK 16.93MHz MISO0 MOSI0 SSL00 RSPCK0 1608 CDDATAIN CDLRCKIN CDSCKIN *A,B,C *D 7.63V C CN701 D CN1202 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 57 5 6 7 8 5 6 7 8 C D F A B E A-b A-a A-a 2/2 A-b 2/2 CP_SDA CP_SCL A7 A6 A5 A4 A3 A1 A9 A10 A11 A12 A13 A14 A15 A16 A8 CPPWR RD FLCS PD5 PD7 WE0/DQML A9 A8 A6 A19 WE0/DQML A15 A7 A4 A5 A2 A14 A12 A3 A13 A10 A16 A18 A20 A11 A2 CPRST PD9 PD8 PD6 PD4 PD3 PD2 PD1 PD0 MEDRST2 SD_DATA2 SD_DATA3 SD_CMD SD_CD SD_WP C592 0.1u/10 C508 0.1u/10 C507 0.1u/10 C510 0.1u/10 C509 0.1u/10 0.1u/10 C543 0.1u/10 C544 0.1u/10 C574 0.01u/10 C511 0.1u/10 C591 0.1u/10 GND GND GND GND 341S2162 IC591 NC1 1 MODE1/SPI_nSS 2 NC2 3 nRESET 4 VCC 5 NC3 6 NC4 7 NC5 8 NC6 9 NC7 10 VSS 11 I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI 13 MODE0/SPI_CLK 14 NC8 15 NC9 16 NC10 17 NC11 18 NC12 19 NC13 20 RD/WR 1 WE0 2 DQMU 3 RAS 4 CAS 5 Vcc1 6 CKE 7 Vss1 8 CS_SDRAM 9 PVcc1 10 A1 11 A2 12 A3 13 A4 14 A5 15 A6 16 A7 17 Vcc2 18 A8 19 Vss2 20 A9 21 PVcc2 22 A10 23 A11 24 A12 25 A13 26 A14 27 A15 28 29 30 162 PD9 163 PD8 164 PD7 165 PD6 166 PD5 167 PD4 168 PD3 169 Vcc10 170 PD2 171 Vss16 172 PD1 173 PVcc13 174 PD0 175 CS_FLASH 176 RD L591 LCTC4R7K1608-T LSA1576UB Q591 R591 4.7k R544 4.7k R600 4.7k R547 0 R594 100 R592 100 R595 10k R593 10k R599 2.7k R596 47k R597 NM R598 NM C785 NM GND C786 NM 5 6 7 8 9 10 R785 220 R784 220 R783 220 R781 220 SDDT3 SDDT2 SDCD R560 47k C556 NM C557 NM C558 NM C559 NM C560 NM C561 NM C562 NM C563 NM C564 NM C565 NM C567 NM C568 NM C787 NM GND C788 1000p/50 GND ipod CP VCC SD_CD SD_DATA2 SD_CMD GND SD_DATA3 SD_WP D MED3.3V NM 3.26V D CN1202 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 58 1 2 3 4 1 2 3 4 C D F A B E 10.3 KEYBOARD UNIT B DCLK DOUT RESET XOUT VSS XIN VCC MODE REM XREST DPDT KYDT MCLK ADKEY2 VREF ADKEY1 ADKEY0 XCMD OEL R-ILM Grille MICRO G_ILM C1902 0.01u/50 C1891 10u/10 C1901 0.1u/16 C1921 1u/10 C1923 1u/16 C1922 1u/10 D1901 1SS355 ILMGND DGND DGND OELG DGND DGND DGND DGND DGND IC1901 PEG268-A-K 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 IC1891 GP1UXC14RK 1 REM 2 GND 3 VCC L1901 NM R1924 100 2 1 4 3 6 5 8 7 R1817 8.2k R1818 10k R1855 2.2k R1856 10k R1857 6.8k R1815 1.8k R1904 47k R1816 3.3k R1905 47k R1923 NM R1901 47k R1854 10k R1891 120 R1877 10k R1893 2.2 R1880 3.3k R1872 1.2k R1876 33k R1882 33k R1892 NM R1858 NM R1909 1k R1903 47k R1922 51k R1906 47k R1859 0 R1908 10k R1907 47k R1871 10k R1878 1.2k R1902 150k R1879 1.8k R1881 8.2k R1874 3.3k R1875 8.2k R1873 1.8k CSG1155-A S1873 1 2 3 4 CSG1155-A S1877 1 2 3 4 CSG1155-A S1878 1 2 3 4 CSG1155-A S1879 1 2 3 4 CSG1155-A S1880 1 2 3 4 CSG1155-A S1881 1 2 3 4 CSG1155-A S1882 1 2 3 4 CSG1155-A S1875 1 2 3 4 CSG1155-A S1874 1 2 3 4 CSG1155-A S1871 1 2 3 4 CSG1155-A S1876 1 2 3 4 CSG1155-A S1872 1 2 3 4 CSX1120-A S1811 1 2 3 4 5 6 GND 7 C 8 D 9 Push 10 Phase_B DPDT MODE VCC VSS RESET KYDT X1901 CSS1577-A 1 1 2 2 3 3 CKS6036-A CN1921 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 R1925 100 2 1 4 3 6 5 8 7 ILMGND Q1831 IMX9 E1 6 B1 5 C2 4 E2 3 2 B2 1 C1 LTC114EUB Q1832 R1867 5.6k R1910 47k L1921 NM L1922 NM R1894 NM 2 0.16 0.54 BAND over~under 0.00 016 ADKEY1 SW(V) DISP 1.00 1.59 0.54 1.00 CLK 1.59 2.31 2.31 3.16 3.16 3.30 S.Rtrv 1 6 10.000MHz (1.25MHz) YF106 LIST 3 4 5 EJECT VSSD2 SO_TX SI_RX SCL XCMD XRES XCS VDD VSSD1 XI VSSA VAH VKH IREF VSSK ADKEY2 RELEASE RELEASE BAND DISP CLK 1 2 6 S.Rtrv LIST 3 4 5 EJECT RED GREEN D1849-1 A,B,C A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC D o 3.29V 9.06V OEL MODULE B KEYBOARD UNIT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 59 5 6 7 8 5 6 7 8 C D F A B E B ROTARY COMMANDER CKS6049-A CN1801 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 C1846 C1845 C1844 C1843 C1842 C1841 C1840 C1839 C1838 C1837 C1836 C1847 C1834 C1833 C1832 C1848 NM C1804 100p/50 C1805 1000p/50 C1806 1u/6.3 C1803 4700p/50 C1802 4700p/50 C1835 C1801 0.1u/16 D1836 D1837 D1835 D1839 D1863 D1854 D1842 D1845 D1851 D1849 D1850 D1844 D1833 D1831 D1841 D1838 D1843 D1840 NM D1866 D1847 D1846 D1853 D1861 D1852 D1862 D1865 D1860 D1857 D1859 D1858 D1834 D1856 D1855 D1805 DAP202U D1804 DAN202U D1802 NM D1803 NM OELG DGND ILMGND DGND DGND ILMGND DGND JA1801 YKN5006-A 2 1 3 L1801 NM 11 2 2 3 3 4 4 NM Q1833 R1849 R1813 10k R1819 NM R1818 10k R1855 2.2k R1815 1.8k R1851 R1840 R1838 R1837 R1831 R1802 NM R1841 R1843 R1801 NM R1854 10k R1844 R1812 1k 1 R1811 1k R1861 NM R1814 1.2k R1860 NM R1842 R1804 2.2k R1805 2.2k R1858 NM R1803 NM R1839 CSG1155-A S1801 1 2 3 4 CSX1120-A S1811 Phase_A 1 Enc_Com 2 A 3 B 4 5 Com 6 GND 7 C 8 D 9 Push 10 Phase_B VA1802 NM VA1801 NM R1845 R1835 LMGND R1862 R1863 R1864 R1865 R1866 C1807 NM Q1831 IMX9 E1 6 B1 5 C2 4 E2 3 2 B2 1 C1 B DGND DGND CN1802 YKS5036-A 1 2 3 4 5 6 C1808 1u/6.3 R1941 R1949 R1948 R1947 R1942 R1943 R1944 R1945 R1946 SRC DGND ILMG ILM+B ROT1 DPDT VBUS(US5V) OEL+B GREEN AUXG RED D+ AUXR SW3.3V USBG SOURCE DSEN USBG AUXL KYDT D- OELG B(LEFT) A(UP) D RELEASE PUSH over~under JOYST(V) C(DOWN) D(RIGHT) PUSH C A B SW ROT0 1801 1810 1811 1820 1831 1870 1871 1890 1891 1900 1901 1910 1921 1940 AUX & USB ROTARY COMMANDER LED BUTTON to REM Grille MICRO OEL REFERENCE AREA MAP 0.16 0.54 1.59 2.31 2.31 3.16 3.16 3.30 1.00 1.59 0.54 1.00 0.00 0.16 RELEASE ED GREEN D1831-1846 : CL-195SR-CD D1849-1862,1865 : CL-195PG-CD 1/4W 1/4W 1/4W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/10W 1/4W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1941 1949 LED D only 270 560 NM NM NM NM NM NM NM NM NM NM NM NM NM NM NM NM NM NM 150 330 NM NM NM NM NM 330 330 330 220 470 150 150 150 470 470 470 470 180 270 390 470 3.29V 14.16V 14.16V CN801 1/2 A USB AUX AUX:+2.20 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 60 1 2 3 4 1 2 3 4 C D F A B E 10.4 CD CORE UNIT(S11STD-DOUT) C C101 C102 C110 C111 C204 C207 C235 C239 C301 C307 C308 C701 C702 C703 C705 C707 C708 D101 TH201 Q201 C240 C281 C282 C283 C284 C601 C602 R106 R297 R246 R603 R604 R710 R711 R281 R282 R283 R291 R292 R293 R299 R601 R602 R606 R225 R722 R242 R243 R707 R721 R723 C205 C206 CN702 FOP FOM TOM TOP TD FD SOM SOP LCOM LCOP LOEJ TOM FOM FOP TOP E BD SD CONT SOM SOP LCOM LCOP HOME 8SNS DSCSNS MD LD PD LD CLCONT BD F E AC AC PD F V+3A RESET REFO PUEN IC301 BA5839FP VR 1 OPIN2+ 2 OPIN2- 3 OPOUT2 4 5 OPIN1+ 6 OPIN1- 7 OPOUT1 29 FIN1 9 MUTE 10 PowVcc1 11 VO1- 12 VO1+ 13 VO2- 14 VO2+ 8 GND1 15 VO3+ 17 VO4+ 18 VO4- 19 PowVcc2 20 GND2 21 CNT 22 LDIN 23 OPOUTSL 24 OPINSL 25 OPOUT3 26 OPIN3- 27 OPIN3+ 28 PreVcc 16 VO3- 30 FIN2 SIN CIN TIN FIN CSN1067-A S901 1 2 3 4 CSN1068-A S905 1 2 3 4 HOME 8SNS DSCSNS BLK RED PL OG NM C301 MDY MDX LOEJ CONT D101 NM TOP FOP TOM FOM R101 2.4 R102 2.4 R103 2.7 LD LD1 C104 4.7u/6.3 (2125) ADCIN FE TE TEC RFO RFAGC ATEST V+3A PD CLCONT M2 LOAD/CRG MOTOR CXC4026 M1 SPDL MOTOR CXE2273 FOCUS ACT 1 TOP 2 FOP 3 FOM 4 TOM 5 MD 6 A+C 7 VR 8 VREF 9 P1+P6 10 GND 11 P5+P10 12 VCC 13 B+D 14 LD+ 15 LD- VCC TRK ACT C101 NM C102 NM C215 C221 0.1u/10 C220 0.1u/10 C219 0.1u/10 C222 0.1u/10 C225 0.01u/16 C217 56p/50 C223 68p/50 C224 47p/50 C216 1800p/50 C304 4700p/25 C305 0.022u/16 R108 1M R106 NM R305 18k R306 18k R307 18k R308 18k R218 4.7k R216 1.2k R217 5.6k 2SA1577(QR) Q101 E F BD AC RST INTQ ASY EFM CSN1068-A S903 1 2 3 4 REFO1 REFO2 C307 NM (1608) CN702 CKS5766-A 1 VDD 2 3 CVDD 4 5 ICECK 6 SO 7 SCK 8 SI C229 0.1u/10 C236 0.1u/10 C306 1u/10 (1608) C110 NM C218 4p/50 C111 NM V3R3 CKS4808-A CN101 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 R109 2.2k C239 NM NM C308 UNR511MG Q102 C214 0.047u/10 R215 39k R214 10k C213 3300p/50 LD 1 PD 2 /RST 3 INTQ(INT1) 4 5 71 AD.Vdd 72 EFM 73 ASY 74 ATEST 75 A.Vdd1 76 A.GND1 77 RFI 78 AGCO 79 C3T 80 AGCI 81 RFO 82 EQ2 83 EQ1 84 RF2- 85 RF- 86 A.GND2 87 A.Vdd2 88 A 89 B 90 F 91 E 92 REFOUT 93 FE- 94 FEO 95 ADCIN 96 TE- 97 TEO 98 TE2 99 TEC 100 C228 27p/50 R229 470 E:P5+P10 F:P1+P6 HOLOGRAM UNIT PICKUP UNIT(P10.5)(SERVICE) CXX1942 F.ACT: Applying positive voltage to FOP, the lens approaches DISC. T.ACT: Applying positive voltage to TOP, the lens moves outer circumference of DISC. CLCONT MOTOR DRIVER LOGIC TABLE LOEJ CONT LOAD EJ PLAY OFF H H L L - L - H L L H L VDD GND PGND VD REFO REFO REFO * (1/10SR,1608) * * * * * * * * * A D I P C209 C238 C240 C306 C307 R243 R246 R101 R102 R103 C104 1608:PARTS 2125:PARTS R606 Parts with Polarity IC201 IC301 D101 Q101 Q102 Q201 C205 C301 C308 * D A I P * CIRCUIT No. (1/10W) C708 Digital Out model only Analog Out model only IIC-BUS model only P-BUS model only HOME 8EJ DSCSNS SWITCHES: CD CORE UNIT S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH.....ON-OFF S905:8EJ SWITCH..............ON-OFF The underlined indicates the switch position. F T T F F T T F F T T F F T F T F T C C S S S C C S C S 1 2 3 9 a 7 8 4 5 f c d e www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 61 5 6 7 8 5 6 7 8 C D F A B E C P A A A D I P P A A P I D D D D D D P SCL MD SD LOEJ SKIP /CDSRQ ADENA CLCONT TEMP VDSENS CONT RESET ADENA TEMP /CDSTBY /WAIT VPP ICECK DSCSNS 8SNS SCK ICECK SCK FD HOME TD BCLK LRCK DATA SDA VPP PUEN CVDD CVDD SKIP /CDSRQ VDSENS /CDSTBY RESET /WAIT LRCK DATA SCL SDA DATA /WAIT BCLK LRCK BCLK RESET VDD VD PGND GND CDSRQ CDSTBY SCL SKIP SDA RESET LRCK BCLK DATA X201 CSS1603-A 1 2 3 PUEN ATEST TESTIN R246 NM (1608) VDSENS TEMP C203 0.1u/10 C207 NM C210 0.1u/10 C211 0.1u/10 C212 0.1u/10 C215 0.1u/10 C206 NM C235 NM C710 1000p/50 C232 1000p/50 C231 1000p/50 R264 1k R254 100k R253 100k R260 10k R235 10k R236 10k R263 4.7k R262 4.7k NM TH201 NM Q201 RST INTQ A0 STB SCK SO SI ICEMD VPP CVDD ICECK C16M MONI0 MONI1 MONI2 ASY EFM VD2 VD1 VDD1 GND1 GND2 GND3 R242 NM R245 100k C233 0.01u/16 R237 220 R240 47k C705 NM VDD2 CN702 CKS5766-A 1 VDD 2 3 CVDD 4 5 ICECK 6 SO 7 SCK 8 SI 9 VPP 10 GND R296 0 C204 NM C707 NM C702 NM C209 0.1u/16 (1608) C238 NM (1608) C240 NM (1608) C708 NM (1608) R283 0 C281 NM C282 NM NM C205 R294 470 C701 NM C703 NM WAIT NM C283 NM C284 NM R243 NM (1608) PGND1 PGND2 ADENA C299 NM R706 220 R702 100 R701 100 R297 NM C601 NM C602 NM R723 NM R721 NM R707 NM R606 NM (1608) R722 0 R709 0 R708 0 R299 0 C214 0.047u/10 R215 39k R214 10k C213 3300p/50 CKS6146-A CN701 1 VD 2 VD 3 /CDSRQ 4 /CDSTBY 5 SCL 6 SKIP 7 SDA 8 RESET 9 VDD 10 GND 11 DATA 12 BCLK 13 LRCK 14 GND 15 PGND 16 WAIT AAGND1 AAGND2 R225 0 R292 0 R293 0 R710 NM R711 NM IC201 PE5706A LD 1 PD 2 /RST 3 INTQ(INT1) 4 A0 5 /STB 6 /SCK 7 SO 8 SI 9 D.Vdd 10 D.GND 11 REG16 12 REGS 13 DA.Vdd1 14 ROUT 15 DA.GND1 16 REGC 17 DA.GND 18 LOUT 19 DA.Vdd 20 ICEMD 21 X.Vdd 22 /XTAL 23 X.GND 24 XTAL 25 Vpp 26 C.Vdd 27 C.GND 28 RESET 29 IO.GND1 30 IO.Vdd1 31 ICECK 32 /CDSTBY 33 34 HOME 35 12SNS 36 8SNS 37 DSCSNS 38 CONT 39 CLCONT 40 LOEJ 41 PA7 42 DOUT 43 SCKO 44 LRCK 45 TX/EMPH 46 /WAIT 47 SCL 48 SDA 49 PC3 50 /TESTIN 51 /CDSRQ 52 SKIP 53 54 /ADENA 55 56 57 TEMP 58 Monitor0 59 Monitor1 60 Monitor2 61 Monitor3 62 SD2 63 IO.GND2 64 IO.Vdd2 65 FD 66 TD 67 SD 68 MD 69 TEST 70 AD.GND 71 AD.Vdd 72 EFM 73 ASY 74 ATEST 75 A.Vdd1 76 A.GND1 77 RFI 78 AGCO 79 C3T 80 AGCI 81 RFO 82 EQ2 83 EQ1 84 RF2- 85 RF- 86 A.GND2 87 A.Vdd2 88 A 89 B 90 F 91 E 92 REFOUT 93 FE- 94 FEO 95 ADCIN 96 TE- 97 TEO 98 TE2 99 TEC 00 R232 0 BSCK0 LRCK0 EJSW R601 NM R602 NM R603 NM R604 NM R281 56 R282 56 R291 56 NO MOUNT PARTS (NM) * Land for manual soldering BLE OFF L - L GND GND GND 3.3V 7.5V 7.5V I/O VDD GND GND EJSW VDCONT VDSENS * * * * * * * * * * * * * * * * (ROUT) (LOUT) (AGND) * * * R294 Mask Flash 470 0 Mask R232 Flash 10k 0 PUEN * * * * * * Mask Flash R281 R282 R291 56 56 56 22 22 22 A CN701 C CD CORE UNIT(S11STD-DOUT) F SIGNAL LINE FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE T C S S T F C 6 i h g b www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 62 1 2 3 4 1 2 3 4 C D F A B E 10.5 SD UNIT D VKN1302-A CN1202 1 GND 2 3 4 5 6 7 8 9 10 CKS6180-A CN1203 1 CD/DAT3 3 VSS1 5 CLK 7 DAT0 9 DAT2 11 GND2 13 CD/WP 14 WP 12 CD 10 GND1 8 DAT1 6 VSS2 4 VDD 2 CMD 15 NC1 16 NC2 17 GND3 18 GND4 19 GND5 20 GND6 SD_CD SD_WP SD_DATA2 SD_CMD SD33V SD_CLK SD_DATA3 SD_DATA1 SD_DATA0 3.29V D SD UNIT (A,B,C only) CN781 2/2 A A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 63 5 6 7 8 5 6 7 8 C D F A B E 10.6 WAVEFORMS - Waveforms Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V) 500 ms/div 5 V/div 5 V/div 5 V/div 10 V/div 1DSCSNS 5CLCONT 4LOEJ 6VD 5 V/div 5 V/div 5 V/div 5 V/div 1DSCSNS 28SNS 4LOEJ 3HOME 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 4LOEJ 3HOME 500 mV/div 500 mV/div 200 ms/div cTE dFE 200 mV/div 2 V/div 2 V/div 500 ms/div aFIN bRFOK(MONI_3) 7SIN 1 V/div 500 mV/div 500 mV/div 2 s/div 500 ms/div 7SIN 8CIN 9TIN 2 V/div 500 mV/div 5 μs/div eMDX 7SIN 2 V/div 500 mV/div 50 ms/div eMDX 7SIN 500 mV/div 500 mV/div 500 mV/div 500 mV/div 20 ms/div dFE aFIN cTE 9TIN 1 V/div 500 mV/div 500 mV/div 500 μs/div fRFAGC cTE 9TIN 500 mV/div 500 mV/div 2 ms/div cTE fRFAGC 500 mV/div 500 mV/div 200 ms/div aFIN dFE Source On setup operation 12 cm CD-DA Source On setup operation CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation (Wider) Focus Search waveform Track Open waveform 100 Track Jump waveform (32 Track Jump x 3) 12 cm CD-DA setup operation after loading 12 cm CD Loading operation 12 cm CD Loading operation 8 cm CD Loading operation Ref.: GND Mode: Normal Ref.: GND Mode: Normal Ref.: GND Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: REFO Mode: TEST Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 64 1 2 3 4 1 2 3 4 C D F A B E 2 V/div 2 V/div 2 V/div 10 μs/div gLRCK hBCLK iDATA 1 V/div 1 V/div 500 mV/div 2 V/div 200 ms/div fRFAGC cTE 8CIN 7SIN 1 V/div 500 mV/div 500 mV/div 2 ms/div fRFAGC cTE 9TIN 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 4LOEJ 3HOME 5 V/div 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 28SNS 4LOEJ 3HOME 5 V/div 5 V/div 5 V/div 500 ms/div 1DSCSNS 5CLCONT 4LOEJ 1 V/div 1 V/div 1 V/div 1 V/div 500 μs/div fRFAGC 9TIN cTE aFIN 12 cm CD Eject operation 8 cm CD Eject operation Black Dot (800 μm) during play 12 cm CD Eject operation 32 Tracks Jump waveform (Zoom of 100 Track Jump waveform) Search operation(Outter to Inner) Digital Out waveform Ref.: REFO Mode: TEST Ref.: GND Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: REFO Mode: Normal Ref.: GND Mode: Normal Ref.: AGND Mode: Normal www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 65 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 66 1 2 3 4 1 2 3 4 C D F A B E 11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP UNIT A A TUNER AMP UNIT Capacitor Connector P.C.Board Chip Part SIDE B SIDE A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams 1 1 5 1 5 10 15 20 25 30 35 40 1 E E 1 1 1 1 5 1 E E 1 1 E E 5 1 1 1 5 10 1 1 1 IC151 D751 IC161 D383 D581 D583 C201 IC1 C202 C203 P301 IC581 VA661 IC582 VA662 IC583 R661 R662 JA661 Q301 Q302 Q303 IC201 Q901 Q902 L151 Q361 R301 Q362 R302 Q363 R303 R304 R305 R306 R307 R308 L161 Q751 R309 Q752 R310 R311R312 R313 R314 R315 R316 JA301 Q382 R901 R902 R911 R912 Q781 Q782 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 R161 R162 R163 R361 C901 R362 C902 R363 C903 R364 C904 R365 R366 R751 R752 R753 R754 C911 C912 C913 C151 C152 R385 R581 C352 C161 C162 C356 C163 C164 C165 C166 R789 C365 C367 C368 C369 C751 C752 C753 R790 C754 R794 C188 C381 D902 C582 C583 C584 C585 C586 C587 C588 C781 D161 IC911 D162 D163 D164 R201 R2 R205 10 20 30 40 50 60 70 8 X 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y D CN FRO RCA WIRED REMOTE C C www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 67 5 6 7 8 5 6 7 8 C D F A B E A SIDE A 1 1 10 1 5 10 15 20 25 30 35 40 45 1 5 10 15 20 1 5 10 15 20 25 30 35 40 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 1 E 1 E 1 5 E 1 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 105 110 115 120 125 130 135 140 145 150 155 160 165 170 175 E E 1 E E 1 5 1 1 1 1 1 E E 10 1 5 10 15 E E 15 5 1 10 1 5 10 15 20 1 5 1 5 0 2 0 1 1 1 1 10 1 5 1 5 10 5 2 5 1 5 1 20 10 1 1 D941 R401 D942 R402 R403 R404 VA811 R405 R406 R407 R408 R409 R600 IC351 L841 R601 R603 R604 D951 R605 R606 R607 R608 R609 R801 R802 R803 R610 R804 R805 R613 R614 R808 R615 JA401 R616 R617 R618 R619 R810 R811 CN601 R812 R813 R814 R620 R621 R816 R622 R623 R624 IC181 C201 IC182 R626 C202 R627 C203 R628 R629 CN801 R821 C209 IC571 R822 R823 R630 R631 C401 R632 C402 C403 C210 C404 D981 C405 D982 C406 C407 C408 C214 C215 C217 C218 R831 C601 R832 C602 R833 C603 R834 C604 R641 C605 R642 C606 R643 C607 C608 C609 C610 X601 IC591 R841 R842 R843 R844 R651 R652 C831 C832 C641 C841 C842 C651 BZ601 D601 D602 IC201 D801 L501 D802 L502 D803 D804 D805 S651 L701 IC601 Q921 D831 Q931 2 Q363 D651 R501 R502 R504 R505 Q181 Q951 IC641 R509 Q182 R701 R702 R703 R510 R704 R511 R705 R512 R706 R513 R707 R708 R709 R518 IC651 R519 R710 L181 L951 R711 R712 R713 R714 U401 R521 R715 R522 R716 R717 R524 L571 CN701 R529 Q781 Q782 Q783 R530 Q591 R151 R921 R922 R923 R924 R925 C501 KN401 R926 C502 C503 C504 L781 C505 C506 C507 R544 C508 L591 C509 R547 R931 C701 R932 C702 C703 C510 C704 L981 X501 C511 C705 C706 C512 X503 C513 C514 R551 C515 R552 C516 R553 R554 C519 R557 R558 R559 R365 R366 C520 C521 C522 C523 C524 R561 C525 C526 C527 C528 C529 R181 R951 R182 R952 R183 R184 R954 C530 R185 C531 C532 C533 C534 R572 R573 C537 R574 C538 R575 C539 C921 R576 R577 R383 R578 R191 R192 C540 C541 C542 C543 C544 C351 C545 C546 C352 C353 C548 C354 C549 C355 C931 C356 C932 C357 C358 R781 C552 C553 R783 C554 R784 C555 R591 R785 C361 C556 R592 R786 C557 R593 R787 C363 C558 R594 R788 C364 C559 R789 R595 C365 C941 Q401 R596 Q402 R597 C368 R598 C369 R599 C560 R790 C561 L201 C562 R792 C563 R793 C564 R794 C565 R795 R796 C567 C568 C181 C951 C182 C183 C184 CN781 C185 L401 C186 L402 L403 C187 C188 C189 C571 C572 C574 C190 C191 L601 C192 L602 C193 L603 C194 JA981 C195 C196 IC501 L801 C781 C785 C591 Q821 C786 Q822 C592 C787 D921 D922 Q832 D931 R201 VA801 R202 VA802 R203 VA803 R205 Q841 Q842 R206 VA806 R207 VA807 R208 VA808 70 80 90 100 110 120 130 140 150 160 170 FUSE D CN1202 FRONT FM/AM TUNER UNIT ANTENNA CORD ASSY B CN1801 RESET C CN701 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 68 1 2 3 4 1 2 3 4 C D F A B E A A TUNER AMP UNIT 170 160 150 140 130 120 110 100 90 1 E R602 R809 C801 C802 C431 C432 C433 ZNR401 D431 IC431 R514 R515 R525 R526 R527 R531 R532 R533 R534 R535 R560 C535 C536 C547 C550 C551 C362 C366 L404 C788 Q831 D432 1 10 1 1 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 69 5 6 7 8 5 6 7 8 C D F A B E A SIDE B 100 90 80 70 60 50 40 30 X 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y 20 10 E E 1 D381 D382 D582 C211 C212 C213 C216 C219 C220 C221 C222 Q381 R164 R166 R167 R168 R169 C905 C906 C907 R381 R382 R384 C167 C362 D901 D903 C581 C788 IC901 Q831 R165 10 1 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 70 1 2 3 4 1 2 3 4 C D F A B E 11.2 KEYBOARD UNIT B SIDE A B KEYBOARD UNIT E 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 5 10 1 5 10 15 1 5 1 CN1921 C1921 C1922 R1906 R1907 R1922 R1924 CN1802 C1832 C1833 C1834 C1835 JA1801 C1836 C1837 Q1833 C1838 C1839 C1840 C1841 C1842 C1843 C1844 C1845 C1846 C1847 C1848 S1801 D1831 D1833 D1834 D1835 7 3 8 1 D 6 3 8 1 D D1838 D1839 S1811 D1840 D1841 D1842 D1843 D1844 D1845 D1846 D1847 D1849 L1922 D1850 D1851 D1852 D1853 D1854 D1855 D1856 D1857 D1858 D1859 D1860 D1861 D1862 D1863 R1860 D1865 R1861 R1871 R1872 R1873 R1874 R1875 R1876 R1877 R1878 R1879 R1880 R1881 R1882 R1894 S1871 S1872 S1873 S1874 IC1891 S1875 S1876 S1877 S1878 S1879 S1880 S1881 S1882 D1866 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 X 40 30 20 10 0 Y 160 USB AUX EJECT 6 5 4 3 2 1 CLK DISP LIST ROTARY COMMANDER S.Rtrv BAND SRC CEL MODULE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 71 5 6 7 8 5 6 7 8 C D F A B E B SIDE B B KEYBOARD UNIT 160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 X 40 30 20 10 0 Y 10 5 1 E 1 5 10 15 20 1 1 5 1 5 1 20 10 C1901 C1902 C1923 D1901 R1901 R1902 R1903 R1904 R1905 R1908 R1909 IC1901 R1910 L1801 R1923 R1925 R1941 R1942 R1943 R1944 R1945 R1946 R1947 R1948 R1949 VA1801 VA1802 CN1801 C1801 C1802 C1803 C1804 C1805 C1806 C1807 C1808 X1901 D1802 D1803 D1804 D1805 R1801 R1802 R1803 R1804 R1805 Q1831 Q1832 R1811 R1812 R1813 R1814 R1815 R1816 R1817 R1818 R1819 L1901 R1831 R1835 R1837 R1838 R1839 R1840 R1841 R1842 R1843 R1844 R1845 L1921 R1849 R1851 R1854 R1855 R1856 R1857 R1858 R1859 R1862 R1863 R1864 R1865 R1866 R1867 C1891 R1891 R1892 R1893 A CN801 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 72 1 2 3 4 1 2 3 4 C D F A B E 11.3 CD CORE UNIT(S11STD-DOUT) C SIDE A C CD CORE UNIT (S11STD-DOUT) 1 5 10 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 1 5 10 15 1 5 10 15 1 5 10 1 0 1 5 1 15 20 25 29 30 1 R214 R215 R216 R217 R218 R225 R229 R232 R235 R236 C203 C204 TH201 C207 C209 R246 C210 X201 C211 C212 C213 C214 C215 C216 C217 C218 C219 C221 C222 C223 C224 C225 R262 R263 C228 R264 C235 C238 C240 R281 R282 R294 IC201 C299 R305 R306 R307 R308 CN101 R707 R708 R709 R710 C102 CN701 CN702 C304 C305 C306 C307 C701 C702 S901 D101 IC301 10 20 30 40 50 60 70 X 60 50 40 30 20 10 0 Y A CN701 PICKUP UNIT(P10.5)(SERVICE) F E REFO1 M1 SPINDLE MOTOR M2 LOADING/CARRIAGE MOTOR HOME www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 73 5 6 7 8 5 6 7 8 C D F A B E C SIDE B C CD CORE UNIT (S11STD-DOUT) 70 60 50 40 30 20 10 X 60 50 40 30 20 10 0 Y E E 1 1 E R601 R602 R603 R604 R606 R237 R240 C205 C206 R242 R243 R245 R253 R254 C601 C602 C220 R260 C229 C231 C232 C233 C236 C239 R283 R291 R292 R293 Q101 Q102 R296 R297 R299 C281 C282 C283 C284 R101 R102 R103 R106 R108 R109 R701 R702 R706 R711 C101 C104 R721 R722 R723 C301 C110 C111 C308 C703 C705 C707 C708 C710 S903 S905 Q201 8EJ DSCSNS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 74 1 2 3 4 1 2 3 4 C D F A B E 11.4 SD UNIT D SIDE A D SD UNIT SIDE B D SD UNIT 1 5 10 1 0 1 5 15 20 CN1202 CN1203 10 20 30 40 X 40 30 20 10 0 Y 10 20 30 40 X 10 20 30 40 0 Y A CN781 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 75 5 6 7 8 5 6 7 8 C D F A B E 12. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No. Part No. A:DEH-4250SD/XNES B:DEH-4250SD/XNES1 C:DEH-4290SD/XNID D:DEH-3200UB/XNUC Unit Number: CWN4805(A,B,C) Unit Number: CWN5219(D) Unit Name : Tuner Amp Unit Unit Number: CWN4813(A,B,C) Unit Name : Keyboard Unit Unit Number: CWN5220(D) Unit Name : Keyboard Unit Unit Number: CWX3774 Unit Name : CD Core Unit(S11STD-DOUT) Unit Number: CWN4816(A,B,C) Unit Name : SD Unit A Unit Number: CWN4805(A,B,C) Unit Number: CWN5219(D) Unit Name : Tuner Amp Unit MISCELLANEOUS IC 151 (A,62,91) IC R5523N001B IC 161 (A,50,102) Regulator IC BD9781HFP IC 181 (A,108,75) IC WM8761GED IC 182 (A,80,99) IC NJM2872F05 IC 201 (A,75,118) IC PM9012A IC 351 (A,83,142) IC PA2030A IC 431 (B,152,131) IC NJM2885DL1-33 IC 501 (A,121,50) IC R5S7262ZD144FPU IC 571 (A,148,51) Software Unit CWW1967 IC 581 (A,24,80) IC S-1172B33-E6 IC 583 (A,24,89) IC BH12PB3WHFV IC 591 (A,102,23) IC 341S2162 IC 601 (A,128,96) IC PEG640A8 IC 651 (A,119,108) IC S-80827CNNB-B8M IC 901 (B,24,70) Regulator IC S-1132B33-U5 IC 911 (A,7,122) IC NJM2388F84 Q 301 (A,14,126) Transistor UMH3N Q 303 (A,29,126) Transistor UMH3N Q 361 (A,57,131) Transistor LTC114EUB Q 363 (A,70,128) Transistor RT3T22M Q 381 (B,55,131) Transistor 2SC4081 Q 382 (A,45,129) Transistor RT3T22M Q 591 (A,108,25) Transistor LSA1576UB Q 751 (A,7,94) Transistor 2SD2396 Q 752 (A,16,104) Transistor RT3T22M Q 781 (A,72,92) Chip Transistor(A,B,C) 2SB1689 Q 782 (A,70,92) Transistor(A,B,C) LTC114EUB Q 783 (A,106,95) Transistor(A,B,C) DTA123EU Q 821 (A,95,126) Transistor 2SA1036K Q 822 (A,96,121) Transistor LTC114EUB Q 831 (B,93,118) Transistor 2SD1664 Q 832 (A,91,122) Transistor RT3T22M Q 841 (A,94,16) Transistor LSA1576UB Q 842 (A,93,11) Transistor LTC114EUB Q 901 (A,7,71) Transistor 2SD2396 Q 902 (A,14,77) Transistor RT3T22M Q 921 (A,136,108) Transistor RT3CLLM D 161 (A,28,96) Diode CRG03 D 162 (A,28,94) Diode CRG03 D 163 (A,36,94) Diode CMS02 D 381 (B,61,131) Diode UDZS8R2(B) D 382 (B,47,126) Diode DAN202U D 383 (A,54,128) Diode 1SS352 D 581 (A,19,79) Diode 1SS352 D 582 (B,23,80) Diode CRG03 D 601 (A,122,85) Diode RB551V-30 D 602 (A,128,107) Diode RB751S-40 D 651 (A,118,105) Diode 1SS352 D 751 (A,12,104) Diode HZU8R2(B1) Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 76 1 2 3 4 1 2 3 4 C D F A B E D 801 (A,116,14) Diode DZ2S068C D 802 (A,119,14) Diode DZ2S068C D 803 (A,122,13) Diode DZ2S068C D 804 (A,123,13) Diode DZ2S068C D 805 (A,124,13) Diode DZ2S068C D 831 (A,91,119) Diode HZU10(B1) D 901 (B,14,97) Diode CRG03 D 902 (A,12,77) Diode UDZS5R6(B) D 921 (A,141,122) Diode HZU7L(C3) D 922 (A,139,122) Diode HZU7L(A1) D 941 (A,100,129) Diode CRG03 D 942 (A,105,125) Diode CRG03 D 981 (A,139,130) Diode CRG03 D 982 (A,139,128) Diode CRG03 ZNR401 (B,164,117) Surge Protector IMSA-6802-01Y900 L 161 (A,44,92) Inductor CTH1253 L 181 (A,102,80) Chip Ferrite Bead DTL1107 L 401 (A,153,103) Chip Coil BTH1100 L 402 (A,155,73) Chip Coil BTH1100 L 404 (B,167,103) Chip Coil BTH1104 L 501 (A,98,74) Inductor VTL1145 L 502 (A,98,79) Inductor CTF1410 L 601 (A,109,89) Chip Coil BTH1103 L 801 (A,117,17) Inductor CTF1713 L 981 (A,116,141) Choke Coil 600 uH CTH1445 X 501 (A,124,69) Oscillator 48.000 MHz CSS1760 X 503 (A,103,43) Oscillator 16.93 MHz CSS1794 X 601 (A,114,97) Oscillator 20.000 MHz CSS1795 S 651 (A,134,10) Switch CSG1020 P 301 (A,40,118) Poly Switch MINISMDC075F/24 VA661 (A,53,135) Varistor VR105C5R0AAA VA662 (A,53,133) Varistor VR105C5R0AAA VA801 (A,106,15) Varistor VR105C5R0AAA VA802 (A,115,16) Varistor VR105C5R0AAA VA803 (A,120,14) Varistor VR105C5R0AAA VA806 (A,110,15) Varistor VR105C5R0AAA VA807 (A,111,15) Varistor VR105C5R0AAA VA808 (A,127,14) Varistor VR105C5R0AAA CN701 (A,96,39) Connector VKN1192 CN781 (A,96,61) Connector(A,B,C) VKN1186 CN801 (A,114,4) Connector CKS6188 JA301 (A,25,138) Pin Jack YKB5011 JA401 (A,169,129) Antenna Jack CKX1070 JA661 (A,47,139) Connector CKS4124 JA981 (A,118,141) Plug CKM1586 FM/AM Tuner Unit CWE2098 > Fuse(10 A) YEK5001 RESISTORS R 151 (A,96,90) RS1/16SS104J R 161 (A,42,103) RS1/16SS1003F R 163 (A,42,98) RS1/16SS683J R 165 (B,48,97) RS1/10SR1003D R 166 (B,47,99) RS1/10SR2402D R 167 (B,45,96) RS1/10SR333J R 168 (B,52,99) RS1/10SR471J R 169 (B,47,101) RS1/10SR121J R 181 (A,102,95) RS1/10SR0R0J R 191 (A,92,103) RS1/16SS821J Circuit Symbol and No. Part No. R 192 (A,92,104) RS1/16SS821J R 201 (A,69,124) RAB4CQ102J R 202 (A,80,105) RS1/16SS331J R 207 (A,81,105) RS1/16SS223J R 208 (A,81,106) RS1/16SS223J R 301 (A,12,128) RS1/16SS821J R 302 (A,18,126) RS1/16SS821J R 305 (A,27,128) RS1/16SS821J R 306 (A,32,128) RS1/16SS821J R 307 (A,12,129) RS1/16SS223J R 308 (A,17,129) RS1/16SS223J R 311 (A,28,129) RS1/16SS223J R 312 (A,32,129) RS1/16SS223J R 315 (A,23,130) RS1/16SS0R0J R 316 (A,26,130) RS1/16SS0R0J R 361 (A,59,132) RS1/16SS103J R 362 (A,57,129) RS1/16SS103J R 363 (A,60,132) RS1/16SS331J R 365 (A,69,131) RS1/16SS103J R 366 (A,70,131) RS1/16SS103J R 381 (B,59,132) RS1/10SR473J R 382 (B,63,133) RS1/10SR104J R 383 (A,134,84) RS1/16SS473J R 384 (B,50,129) RS1/10SR473J R 385 (A,45,131) RS1/16SS102J R 401 (A,156,92) RS1/16SS681J R 403 (A,156,94) RS1/16SS681J R 404 (A,156,95) RS1/16SS681J R 405 (A,156,96) RS1/16SS681J R 406 (A,156,97) RS1/16SS681J R 407 (A,156,98) RS1/16SS681J R 408 (A,156,99) RS1/16SS152J R 501 (A,134,65) RS1/16SS473J R 502 (A,140,66) RS1/16SS101J R 504 (A,132,65) RS1/16SS473J R 505 (A,131,65) RS1/16SS473J R 509 (A,130,65) RS1/16SS473J R 510 (A,129,65) RS1/16SS473J R 513 (A,122,65) RS1/16SS102J R 518 (A,96,71) RS1/16SS101J R 519 (A,118,65) RS1/16SS5601F R 521 (A,106,55) RS1/16SS473J R 522 (A,106,54) RS1/16SS473J R 526 (B,114,63) RS1/10SR221J R 529 (A,106,43) RS1/16SS332J R 530 (A,106,41) RS1/16SS473J R 531 (B,109,38) RS1/10SR473J R 532 (B,120,51) RS1/10SR221J R 533 (B,120,49) RS1/10SR101J R 534 (B,120,46) RS1/10SR101J R 535 (B,120,42) RS1/10SR101J R 544 (A,137,40) RS1/16SS472J R 547 (A,136,40) RS1/16SS0R0J R 554 (A,112,67) RS1/16SS473J R 560 (B,135,43) RS1/10SR473J R 561 (A,101,71) RS1/16SS103J R 572 (A,141,38) RS1/16SS472J R 574 (A,143,38) RS1/16SS472J R 575 (A,142,29) RAB4CQ221J R 576 (A,139,31) RAB4CQ221J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 77 5 6 7 8 5 6 7 8 C D F A B E R 577 (A,142,33) RAB4CQ221J R 578 (A,138,35) RAB4CQ221J R 591 (A,111,24) RS1/16SS472J R 592 (A,108,28) RS1/16SS101J R 593 (A,102,28) RS1/16SS103J R 594 (A,108,27) RS1/16SS101J R 595 (A,101,28) RS1/16SS103J R 596 (A,108,23) RS1/16SS473J R 599 (A,103,18) RS1/16SS272J R 600 (A,101,17) RS1/16SS472J R 602 (B,121,98) RS1/10SR472J R 603 (A,116,97) RS1/16SS105J R 604 (A,117,98) RS1/16SS101J R 605 (A,116,92) RS1/16SS104J R 606 (A,117,91) RS1/16SS222J R 607 (A,129,83) RS1/16SS104J R 608 (A,118,86) RS1/16SS104J R 609 (A,134,109) RS1/16SS104J R 610 (A,134,107) RS1/16SS104J R 613 (A,125,84) RS1/16SS104J R 614 (A,126,84) RS1/16SS104J R 615 (A,124,84) RS1/16SS104J R 616 (A,127,84) RS1/16SS104J R 617 (A,129,84) RS1/16SS104J R 618 (A,130,84) RS1/16SS104J R 619 (A,132,83) RS1/16SS472J R 620 (A,131,83) RS1/16SS104J R 623 (A,138,96) RS1/16SS104J R 624 (A,130,107) RS1/16SS473J R 626 (A,128,108) RS1/16SS103J R 627 (A,125,109) RS1/16SS104J R 630 (A,142,105) RS1/16SS104J R 631 (A,122,107) (A,B,C) RS1/16SS104J R 632 (A,121,107) (D) RS1/16SS104J R 643 (A,147,93) RS1/16SS104J R 651 (A,117,104) RS1/16SS104J R 652 (A,117,103) RS1/16SS152J R 661 (A,56,135) RS1/10SR102J R 662 (A,56,133) RS1/10SR102J R 701 (A,100,49) RS1/16SS472J R 702 (A,100,46) RS1/16SS473J R 703 (A,106,29) RS1/16SS472J R 704 (A,106,30) RS1/16SS472J R 705 (A,101,47) RS1/16SS221J R 706 (A,103,39) RS1/16SS221J R 707 (A,110,35) RS1/16SS101J R 708 (A,102,37) RS1/16SS221J R 709 (A,110,34) RS1/16SS101J R 710 (A,103,36) RS1/16SS102J R 711 (A,100,36) RS1/16SS151J R 712 (A,100,35) RS1/16SS151J R 713 (A,100,34) RS1/16SS151J R 714 (A,100,32) RS1/16SS221J R 715 (A,119,31) RS1/16SS104J R 716 (A,101,32) RS1/16SS104J R 717 (A,100,37) RS1/16SS104J R 751 (A,15,101) RS1/10SR821J R 753 (A,13,99) RS1/16SS473J R 754 (A,14,99) RS1/16SS103J R 781 (A,100,62) (A,B,C) RS1/16SS221J R 783 (A,100,61) (A,B,C) RS1/16SS221J Circuit Symbol and No. Part No. R 784 (A,100,60) (A,B,C) RS1/16SS221J R 785 (A,100,59) (A,B,C) RS1/16SS221J R 786 (A,100,58) (A,B,C) RS1/16SS221J R 787 (A,100,53) (A,B,C) RS1/16SS221J R 788 (A,100,54) (A,B,C) RS1/16SS221J R 789 (A,70,90) (A,B,C) RS1/10SR681J R 790 (A,72,90) (A,B,C) RS1/10SR103J R 792 (A,104,54) RAB4CQ473J R 793 (A,103,58) RAB4CQ473J R 794 (A,76,91) (A,B,C) RS1/10SR102J R 795 (A,104,56) (D) RS1/10SS0R0J R 801 (A,127,16) RS1/10SR222J R 802 (A,112,15) RS1/10SR222J R 803 (A,109,15) RS1/10SR222J R 804 (A,120,17) RS1/10SR222J R 805 (A,114,15) RS1/10SR222J R 808 (A,108,15) RS1/10SR222J R 809 (B,134,21) RS1/10SR104J R 810 (A,118,20) RS1/10SR8R2J R 811 (A,117,20) RS1/10SR8R2J R 812 (A,126,24) RS1/16SS104J R 813 (A,127,24) RS1/16SS104J R 814 (A,122,17) RS1/10SR101J R 816 (A,124,17) RS1/10SR101J R 821 (A,94,123) RS1/10SR1R0J R 822 (A,97,124) RS1/16SS472J R 823 (A,95,129) RS1/16SS103J R 831 (A,90,115) RS1/10SR103J R 832 (A,87,117) RS1/16SS1R0J R 833 (A,91,126) RS1/10SR122J R 842 (A,96,12) RS1/16SS472J R 843 (A,94,14) RS1/16SS102J R 844 (A,92,16) RS1/16SS103J R 901 (A,14,73) RS1/16SS332J R 902 (A,12,73) RS1/16SS223J R 911 (A,12,108) RS1/16SS102J R 912 (A,12,111) RS1/16SS473J R 921 (A,139,106) RS1/16SS104J R 922 (A,139,109) RS1/16SS103J R 923 (A,140,106) RS1/16SS473J R 924 (A,140,108) RS1/16SS473J R 925 (A,128,126) RS1/16SS472J R 926 (A,124,127) RS1/4SA102J CAPACITORS C 151 (A,60,92) CKSSYB104K10 C 152 (A,59,90) CKSSYB104K10 C 161 (A,35,104) Capacitor CEVW221M16 C 162 (A,42,107) CKSRYB105K16 C 163 (A,43,103) CKSSYB104K16 C 165 (A,42,100) CKSSYB103K10 C 166 (A,54,93) 150 uF/6.3 V CCH1804(P25) C 167 (B,48,95) CCSRCH221J50 C 182 (A,113,77) 10 uF CCG1192 C 183 (A,105,80) CKSSYB103K16 C 184 (A,104,81) 10 uF CCG1192 C 186 (A,99,81) CKSRYB105K10 C 187 (A,82,98) CKSSYB104K10 C 188 (A,77,99) CKSSYB104K10 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 78 1 2 3 4 1 2 3 4 C D F A B E C 190 (A,119,74) CKSSYB102K10 C 191 (A,89,103) CCSRCH182J50 C 192 (A,90,103) CCSRCH182J50 C 196 (A,99,83) CKSSYB681K50 C 201 (A,79,104) CKSRYB105K10 C 202 (A,79,107) CKSRYB105K10 C 203 (A,77,105) CKSQYB225K10 C 209 (A,88,109) CKSRYB224K16 C 210 (A,88,108) CKSRYB224K16 C 211 (B,70,113) CKSRYB105K10 C 212 (B,72,113) CKSRYB105K10 C 213 (B,83,119) 10 uF CCG1203 C 214 (A,84,121) 10 uF CCG1192 C 215 (A,84,119) CKSSYB104K10 C 216 (B,80,122) 10 uF CCG1203 C 217 (A,85,126) CKSSYB104K10 C 218 (A,84,124) 10 uF CCG1192 C 219 (B,72,118) CKSRYB105K10 C 220 (B,79,117) CKSRYB105K10 C 301 (A,28,119) 10 uF CCG1192 C 302 (A,29,121) 10 uF CCG1192 C 305 (A,35,125) 10 uF CCG1192 C 306 (A,39,127) 10 uF CCG1192 C 351 (A,82,129) CKSRYB474K10 C 352 (A,80,129) CKSRYB474K10 C 353 (A,84,129) CKSRYB474K10 C 354 (A,86,129) CKSRYB474K10 C 355 (A,82,132) CKSRYB474K16 C 356 (A,80,132) CKSRYB474K16 C 357 (A,84,132) CKSRYB474K16 C 358 (A,86,132) CKSRYB474K16 C 361 (A,136,122) 3 300 uF/16 V CCH1486 C 362 (B,98,143) CKSRYB104K16 C 363 (A,88,126) CKSQYB225K10 C 364 (A,88,130) CKSQYB225K10 C 365 (A,76,130) 10 uF CCG1236 C 367 (A,62,132) 10 uF CCG1192 C 381 (A,50,128) Capacitor CEVW220M16 C 401 (A,154,105) CKSSYB103K10 C 402 (A,156,104) 10 uF CCG1192 C 405 (A,156,69) CKSSYB103K10 C 406 (A,155,70) 10 uF CCG1192 C 407 (A,155,78) CKSSYB103K10 C 431 (B,159,125) CKSQYB475K6R3 C 432 (B,159,122) CKSRYB103K50 C 433 (B,159,136) CKSQYB475K10 C 501 (A,98,75) 10 uF CCG1192 C 503 (A,102,73) 10 uF CCG1192 C 504 (A,98,77) 10 uF CCG1192 C 506 (A,102,77) 10 uF CCG1192 C 507 (A,136,42) CKSSYB104K10 C 508 (A,137,43) CKSSYB104K10 C 509 (A,136,48) CKSSYB104K10 C 510 (A,137,49) CKSSYB104K10 C 511 (A,136,54) CKSSYB104K10 C 512 (A,137,55) CKSSYB104K10 C 513 (A,136,59) CKSSYB104K10 C 514 (A,137,59) CKSSYB104K10 C 515 (A,136,61) CKSSYB103K10 C 516 (A,133,65) CKSSYB104K10 Circuit Symbol and No. Part No. C 519 (A,127,65) CKSSYB104K10 C 520 (A,124,65) CKSSYB104K10 C 521 (A,124,66) CKSSYB104K10 C 522 (A,119,67) CKSSYB104K10 C 523 (A,122,71) CCSSCH100D50 C 524 (A,125,71) CCSSCH100D50 C 525 (A,119,66) CKSSYB104K10 C 526 (A,116,67) CKSSYB104K10 C 527 (A,116,66) CKSSYB104K10 C 528 (A,115,65) CKSSYB104K10 C 529 (A,111,65) CKSSYB104K10 C 530 (A,110,65) CKSSYB104K10 C 531 (A,106,57) CKSSYB104K10 C 532 (A,106,56) CKSSYB104K10 C 533 (A,106,52) CKSSYB104K10 C 534 (A,106,50) CKSSYB104K10 C 535 (B,109,45) CKSRYB104K16 C 536 (B,109,43) CKSRYB104K16 C 537 (A,106,40) CKSSYB104K10 C 538 (A,106,38) CKSSYB104K10 C 539 (A,115,34) CKSSYB104K10 C 540 (A,116,33) CKSSYB104K10 C 541 (A,120,34) CKSSYB104K10 C 542 (A,124,35) CKSSYB104K10 C 543 (A,129,34) CKSSYB104K10 C 544 (A,130,35) CKSSYB104K10 C 545 (A,100,71) CKSSYB105K6R3 C 546 (A,137,70) CKSSYB102K10 C 547 (B,120,53) CCSRCH220J50 C 548 (A,101,42) CCSSCH120J50 C 549 (A,101,44) CCSSCH120J50 C 550 (B,120,44) CCSRCH220J50 C 571 (A,139,40) 10 uF CCG1192 C 572 (A,140,39) CKSSYB104K10 C 574 (A,148,62) CKSSYB103K10 C 581 (B,22,77) 10 uF CCG1203 C 583 (A,30,81) 10 uF CCG1192 C 585 (A,23,86) 10 uF CCG1192 C 588 (A,34,85) 10 uF CCG1192 C 591 (A,108,22) CKSSYB104K10 C 592 (A,101,18) CKSSYB104K10 C 601 (A,106,90) 10 uF CCG1192 C 603 (A,113,90) 4.7 uF CCG1201 C 604 (A,111,98) CCSSCH100D50 C 605 (A,111,96) CCSSCH120J50 C 606 (A,117,95) CKSSYB104K10 C 608 (A,138,95) CKSSYB104K10 C 610 (A,118,101) CKSSYB104K10 C 651 (A,117,108) CKSRYB105K10 C 703 (A,103,33) CCSSCH220J50 C 704 (A,103,32) CCSSCH100D50 C 705 (A,103,31) CCSSCH220J50 C 706 (A,118,31) CKSSYB103K10 C 751 (A,14,96) 10 uF CCG1192 C 754 (A,13,104) CKSSYB473K10 C 788 (B,98,68) CKSRYB102K50 C 801 (B,104,17) CKSRYB104K16 C 802 (B,128,22) CKSRYB105K16 C 831 (A,91,118) CKSSYB473K16 C 832 (A,89,115) CKSSYB102K50 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 79 5 6 7 8 5 6 7 8 C D F A B E C 901 (A,15,63) CEAT102M16 C 902 (A,14,79) CKSSYB103K10 C 904 (A,16,72) 10 uF CCG1192 C 905 (B,24,66) CKSQYB475K6R3 C 907 (B,29,69) CKSQYB475K6R3 C 911 (A,25,108) Capacitor CEVW221M10 C 913 (A,16,114) CEVW101M16 C 921 (A,128,127) CKSSYB104K16 C 941 (A,103,128) CKSSYB473K16 B Unit Number: CWN4813(A,B,C) Unit Name : Keyboard Unit MISCELLANEOUS IC 1891 (A,144,18) Remote IC GP1UXC14RK IC 1901 (B,87,23) IC PEG642A8 D 1804 (B,87,14) Diode DAN202U D 1805 (B,91,15) Diode DAP202U D 1831 (A,152,39) LED CL-195SR-CD D 1833 (A,7,29) LED CL-195SR-CD D 1834 (A,18,28) LED CL-195SR-CD D 1835 (A,30,27) LED CL-195SR-CD D 1836 (A,8,12) LED CL-195SR-CD D 1837 (A,19,12) LED CL-195SR-CD D 1838 (A,30,13) LED CL-195SR-CD D 1839 (A,77,8) LED CL-195SR-CD D 1840 (A,87,8) LED CL-195SR-CD D 1841 (A,101,8) LED CL-195SR-CD D 1842 (A,111,8) LED CL-195SR-CD D 1843 (A,125,8) LED CL-195SR-CD D 1844 (A,135,8) LED CL-195SR-CD D 1845 (A,43,24) LED CL-195SR-CD D 1846 (A,64,28) LED CL-195SR-CD D 1901 (B,97,31) Diode 1SS355 X 1901 (B,87,29) Radiator 10.0 MHz CSS1577 S 1801 (A,5,36) Push Switch CSG1155 S 1811 (A,55,20) Switch CSX1120 S 1871 (A,11,6) Push Switch CSG1155 S 1872 (A,22,6) Push Switch CSG1155 S 1873 (A,34,7) Push Switch CSG1155 S 1874 (A,72,7) Push Switch CSG1155 S 1875 (A,91,7) Push Switch CSG1155 S 1876 (A,139,7) Push Switch CSG1155 S 1877 (A,21,34) Push Switch CSG1155 S 1878 (A,33,33) Push Switch CSG1155 S 1879 (A,95,7) Push Switch CSG1155 S 1880 (A,115,7) Push Switch CSG1155 S 1881 (A,120,7) Push Switch CSG1155 S 1882 (A,149,42) Push Switch CSG1155 CN1801 (B,108,10) Connector CKS6049 CN1802 (A,154,25) Connector YKS5036 CN1921 (A,97,21) Connector CKS6036 JA1801 (A,153,10) Jack YKN5006 OEL Module MXS4012 RESISTORS R 1804 (B,88,12) RS1/10SR222J R 1805 (B,90,17) RS1/10SR222J Circuit Symbol and No. Part No. R 1811 (B,68,16) RS1/10SR102J R 1812 (B,47,12) RS1/10SR102J R 1813 (B,49,13) RS1/10SR103J R 1814 (B,61,12) RS1/10SR122J R 1815 (B,59,25) RS1/10SR182J R 1816 (B,48,28) RS1/10SR332J R 1817 (B,48,26) RS1/10SR822J R 1818 (B,42,27) RS1/10SR103J R 1831 (B,150,37) RS1/4SA271J R 1835 (B,13,24) RS1/4SA331J R 1837 (B,15,10) RS1/4SA331J R 1838 (B,67,8) RS1/4SA331J R 1839 (B,120,23) RS1/4SA331J R 1840 (B,31,26) RS1/4SA471J R 1859 (B,43,8) RS1/10SR0R0J R 1871 (A,6,7) RS1/10SR103J R 1872 (A,15,7) RS1/10SR122J R 1873 (A,30,7) RS1/10SR182J R 1874 (A,39,8) RS1/10SR332J R 1875 (A,81,9) RS1/10SR822J R 1876 (A,119,22) RS1/10SR333J R 1877 (A,17,33) RS1/10SR103J R 1878 (A,26,32) RS1/10SR122J R 1879 (A,38,32) RS1/10SR182J R 1880 (A,118,27) RS1/10SR332J R 1881 (A,122,19) RS1/10SR822J R 1882 (A,125,18) RS1/10SR333J R 1891 (B,131,24) RS1/10SR121J R 1893 (B,140,17) RS1/10SR2R2J R 1901 (B,75,28) RS1/10SR473J R 1902 (B,94,32) RS1/10SR154J R 1903 (B,81,31) RS1/10SR473J R 1904 (B,98,19) RS1/10SR473J R 1905 (B,99,21) RS1/10SR473J R 1906 (A,109,28) RS1/10SR473J R 1907 (A,110,30) RS1/10SR473J R 1908 (B,86,16) RS1/10SR103J R 1909 (B,71,21) RS1/10SR102J R 1910 (B,75,24) RS1/10SR473J R 1922 (A,89,21) RS1/10SR5102D R 1924 (A,107,25) RAB4C101J R 1925 (B,95,22) RAB4C101J R 1941 (B,155,37) RS1/4SA561J R 1942 (B,15,23) RS1/10SR151J R 1943 (B,13,20) RS1/10SR151J R 1944 (B,70,8) RS1/10SR151J R 1945 (B,122,21) RS1/10SR151J R 1946 (B,31,30) RS1/10SR221J CAPACITORS C 1801 (B,146,32) CKSRYB104K16 C 1802 (B,157,17) CKSRYB472K50 C 1803 (B,145,13) CKSRYB472K50 C 1804 (B,145,27) CCSRCH101J50 C 1805 (B,143,27) CKSRYB102K50 C 1806 (B,108,19) CKSRYB105K6R3 C 1808 (B,135,7) CKSRYB105K6R3 C 1891 (B,138,20) CKSYF106Z10 C 1901 (B,99,29) CKSRYB104K16 C 1902 (B,82,24) CKSRYB103K50 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 80 1 2 3 4 1 2 3 4 C D F A B E C 1921 (A,89,25) CKSRYB105K10 C 1922 (A,89,23) CKSRYB105K10 C 1923 (B,99,22) CKSRYB105K10 B Unit Number : CWN5220(D) Unit Name : Keyboard Unit MISCELLANEOUS IC 1891 (A,144,18) Remote IC GP1UXC14RK IC 1901 (B,87,23) IC PEG642A8 Q 1831 (B,40,8) Transistor IMX9 Q 1832 (B,40,15) Transistor LTC114EUB D 1804 (B,87,14) Diode DAN202U D 1805 (B,91,15) Diode DAP202U D 1831 (A,152,39) LED CL-195SR-CD D 1833 (A,7,29) LED CL-195SR-CD D 1834 (A,18,28) LED CL-195SR-CD D 1835 (A,30,27) LED CL-195SR-CD D 1836 (A,8,12) LED CL-195SR-CD D 1837 (A,19,12) LED CL-195SR-CD D 1838 (A,30,13) LED CL-195SR-CD D 1839 (A,77,8) LED CL-195SR-CD D 1840 (A,87,8) LED CL-195SR-CD D 1841 (A,101,8) LED CL-195SR-CD D 1842 (A,111,8) LED CL-195SR-CD D 1843 (A,125,8) LED CL-195SR-CD D 1844 (A,135,8) LED CL-195SR-CD D 1845 (A,43,24) LED CL-195SR-CD D 1846 (A,64,28) LED CL-195SR-CD D 1849 (A,7,31) LED CL-195PG-CD D 1850 (A,18,30) LED CL-195PG-CD D 1851 (A,30,29) LED CL-195PG-CD D 1852 (A,8,11) LED CL-195PG-CD D 1853 (A,19,11) LED CL-195PG-CD D 1854 (A,30,11) LED CL-195PG-CD D 1855 (A,76,8) LED CL-195PG-CD D 1856 (A,88,8) LED CL-195PG-CD D 1857 (A,100,8) LED CL-195PG-CD D 1858 (A,112,8) LED CL-195PG-CD D 1859 (A,124,8) LED CL-195PG-CD D 1860 (A,136,8) LED CL-195PG-CD D 1861 (A,45,24) LED CL-195PG-CD D 1862 (A,62,28) LED CL-195PG-CD D 1865 (A,150,39) LED CL-195PG-CD D 1901 (B,97,31) Diode 1SS355 X 1901 (B,87,29) Radiator 10.0 MHz CSS1577 S 1801 (A,5,36) Push Switch CSG1155 S 1811 (A,55,20) Switch CSX1120 S 1871 (A,11,6) Push Switch CSG1155 S 1872 (A,22,6) Push Switch CSG1155 S 1873 (A,34,7) Push Switch CSG1155 S 1874 (A,72,7) Push Switch CSG1155 S 1875 (A,91,7) Push Switch CSG1155 S 1876 (A,139,7) Push Switch CSG1155 S 1877 (A,21,34) Push Switch CSG1155 S 1878 (A,33,33) Push Switch CSG1155 S 1879 (A,95,7) Push Switch CSG1155 Circuit Symbol and No. Part No. S 1880 (A,115,7) Push Switch CSG1155 S 1881 (A,120,7) Push Switch CSG1155 S 1882 (A,149,42) Push Switch CSG1155 CN1801 (B,108,10) Connector CKS6049 CN1802 (A,154,25) Connector YKS5036 CN1921 (A,97,21) Connector CKS6036 JA1801 (A,153,10) Jack YKN5006 OEL Module MXS4013 RESISTORS R 1804 (B,88,12) RS1/10SR222J R 1805 (B,90,17) RS1/10SR222J R 1811 (B,68,16) RS1/10SR102J R 1812 (B,47,12) RS1/10SR102J R 1813 (B,49,13) RS1/10SR103J R 1814 (B,61,12) RS1/10SR122J R 1815 (B,59,25) RS1/10SR182J R 1816 (B,48,28) RS1/10SR332J R 1817 (B,48,26) RS1/10SR822J R 1818 (B,42,27) RS1/10SR103J R 1831 (B,150,37) RS1/4SA271J R 1835 (B,13,24) RS1/4SA331J R 1837 (B,15,10) RS1/4SA331J R 1838 (B,67,8) RS1/4SA331J R 1839 (B,120,23) RS1/4SA331J R 1840 (B,31,26) RS1/4SA471J R 1841 (B,10,24) RS1/4SA471J R 1842 (B,12,10) RS1/4SA471J R 1843 (B,67,6) RS1/4SA471J R 1844 (B,117,23) RS1/4SA471J R 1845 (B,33,26) RS1/4SA391J R 1849 (B,149,35) RS1/4SA271J R 1854 (B,41,12) RS1/10SR103J R 1855 (B,43,12) RS1/10SR222J R 1856 (B,35,14) RS1/10SR103J R 1857 (B,35,16) RS1/10SR682J R 1867 (B,43,15) RS1/10SR562J R 1871 (A,6,7) RS1/10SR103J R 1872 (A,15,7) RS1/10SR122J R 1873 (A,30,7) RS1/10SR182J R 1874 (A,39,8) RS1/10SR332J R 1875 (A,81,9) RS1/10SR822J R 1876 (A,119,22) RS1/10SR333J R 1877 (A,17,33) RS1/10SR103J R 1878 (A,26,32) RS1/10SR122J R 1879 (A,38,32) RS1/10SR182J R 1880 (A,118,27) RS1/10SR332J R 1881 (A,122,19) RS1/10SR822J R 1882 (A,125,18) RS1/10SR333J R 1891 (B,131,24) RS1/10SR121J R 1893 (B,140,17) RS1/10SR2R2J R 1901 (B,75,28) RS1/10SR473J R 1902 (B,94,32) RS1/10SR154J R 1903 (B,81,31) RS1/10SR473J R 1904 (B,98,19) RS1/10SR473J R 1905 (B,99,21) RS1/10SR473J R 1906 (A,109,28) RS1/10SR473J R 1907 (A,110,30) RS1/10SR473J R 1908 (B,86,16) RS1/10SR103J R 1909 (B,71,21) RS1/10SR102J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 81 5 6 7 8 5 6 7 8 C D F A B E R 1910 (B,75,24) RS1/10SR473J R 1922 (A,89,21) RS1/10SR5102D R 1924 (A,107,25) RAB4C101J R 1925 (B,95,22) RAB4C101J R 1941 (B,155,37) RS1/4SA561J R 1942 (B,15,23) RS1/10SR151J R 1943 (B,13,20) RS1/10SR151J R 1944 (B,70,8) RS1/10SR151J R 1945 (B,122,21) RS1/10SR151J R 1946 (B,31,30) RS1/10SR221J R 1947 (B,34,30) RS1/10SR181J R 1948 (B,155,35) RS1/4SA471J CAPACITORS C 1801 (B,146,32) CKSRYB104K16 C 1802 (B,157,17) CKSRYB472K50 C 1803 (B,145,13) CKSRYB472K50 C 1804 (B,145,27) CCSRCH101J50 C 1805 (B,143,27) CKSRYB102K50 C 1806 (B,108,19) CKSRYB105K6R3 C 1808 (B,135,7) CKSRYB105K6R3 C 1891 (B,138,20) CKSYF106Z10 C 1901 (B,99,29) CKSRYB104K16 C 1902 (B,82,24) CKSRYB103K50 C 1921 (A,89,25) CKSRYB105K10 C 1922 (A,89,23) CKSRYB105K10 C 1923 (B,99,22) CKSRYB105K10 C Unit Number: CWX3774 Unit Name : CD Core Unit(S11STD-DOUT) MISCELLANEOUS IC 201 (A,28,33) IC PE5706A IC 301 (A,64,27) IC BA5839FP Q 101 (B,8,56) Transistor 2SA1577 Q 102 (B,21,51) Digital TR(PNP) UNR511MG X 201 (A,15,27) Ceramic Resonator 16.934 MHz CSS1603 S 901 (A,42,53) Switch CSN1067 S 903 (B,21,12) Switch CSN1068 S 905 (B,11,25) Switch CSN1068 CN101 (A,16,58) Connector CKS4808 CN701 (A,37,10) Connector CKS6146 RESISTORS R 101 (B,6,59) RS1/10SR2R4J R 102 (B,7,59) RS1/10SR2R4J R 103 (B,8,59) RS1/10SR2R7J R 108 (B,19,53) RS1/16SS105J R 109 (B,11,52) RS1/16SS222J R 214 (A,38,41) RS1/16SS103J R 215 (A,38,40) RS1/16SS393J R 216 (A,30,44) RS1/16SS122J R 217 (A,33,46) RS1/16SS562J R 218 (A,30,46) RS1/16SS472J R 225 (A,33,23) RS1/16SS0R0J R 229 (A,31,44) RS1/16SS471J Circuit Symbol and No. Part No. R 232 (A,19,21) RS1/16SS0R0J R 235 (A,45,32) RS1/16SS103J R 236 (A,46,32) RS1/16SS103J R 237 (B,24,25) RS1/16SS221J R 240 (B,26,30) RS1/16SS473J R 245 (B,28,30) RS1/16SS104J R 253 (B,27,30) RS1/16SS104J R 254 (B,29,30) RS1/16SS104J R 260 (B,41,21) RS1/16SS103J R 262 (A,44,32) RS1/16SS472J R 263 (A,47,32) RS1/16SS472J R 264 (A,44,25) RS1/16SS102J R 281 (A,31,22) RS1/16SS560J R 282 (A,30,22) RS1/16SS560J R 283 (B,32,18) RS1/16SS0R0J R 291 (B,31,17) RS1/16SS560J R 292 (B,32,16) RS1/16SS0R0J R 293 (B,32,11) RS1/16SS0R0J R 294 (A,18,28) RS1/16SS471J R 296 (B,32,30) RS1/16SS0R0J R 299 (B,31,13) RS1/16SS0R0J R 305 (A,60,34) RS1/16SS183J R 306 (A,61,37) RS1/16SS183J R 307 (A,58,34) RS1/16SS183J R 308 (A,58,36) RS1/16SS183J R 701 (B,37,21) RS1/16SS101J R 702 (B,38,20) RS1/16SS101J R 706 (B,43,11) RS1/16SS221J R 708 (A,40,22) RS1/16SS0R0J R 709 (A,40,21) RS1/16SS0R0J R 722 (B,37,22) RS1/16SS0R0J CAPACITORS C 104 (B,11,55) CKSQYB475K6R3 C 203 (A,18,35) CKSSYB104K10 C 209 (A,17,28) CKSRYB104K16 C 210 (A,21,21) CKSSYB104K10 C 211 (A,24,23) CKSSYB104K10 C 212 (A,38,33) CKSSYB104K10 C 213 (A,40,41) CKSSYB332K50 C 214 (A,40,40) CKSSYB473K10 C 215 (A,38,37) CKSSYB104K10 C 216 (A,36,46) CKSSYB182K50 C 217 (A,31,46) CCSSCH560J50 C 218 (A,29,46) CCSSCH4R0C50 C 219 (A,32,43) CKSSYB104K10 C 220 (B,32,41) CKSSYB104K10 C 221 (A,35,43) CKSSYB104K10 C 222 (A,29,43) CKSSYB104K10 C 223 (A,25,44) CCSSCH680J50 C 224 (A,23,44) CCSSCH470J50 C 225 (A,20,43) CKSSYB103K16 C 228 (A,32,46) CCSSCH270J50 C 229 (B,28,40) CKSSYB104K10 C 231 (B,44,28) CKSSYB102K50 C 232 (B,45,28) CKSSYB102K50 C 233 (B,25,25) CKSSYB103K16 C 236 (B,26,41) CKSSYB104K10 C 238 (A,15,35) CKSRYB104K16 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com DEH-4250SD/XNES 82 1 2 3 4 1 2 3 4 C D F A B E C 299 (A,17,33) CKSSYB104K10 C 304 (A,60,35) CKSSYB472K25 C 305 (A,58,35) CKSSYB223K16 C 306 (A,68,20) CKSRYB105K10 C 710 (B,43,10) CKSSYB102K50 D Unit Number : CWN4816(A,B,C) Unit Name : SD Unit MISCELLANEOUS CN1202 (A,33,43) VKN1302 CN1203 (A,23,19) Connector CKS6180 Miscellaneous Parts List Pickup Unit(S10.5)(Service) CXX1942 M 1 Motor Unit(SPINDLE) CXE2273 M 2 Motor Unit(LOADING/CARRIAGE) CXC4026 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com