ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2008 2008 Printed in Japan STANDBY/ON S-W601 RRV3862 POWERED SUBWOOFER S-W601 S-W501 S-W301 THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model Type Power Requirement Remarks S-W601 KUCXJ AC 120 V S-W501 KUCXJ AC 120 V S-W301 KUCXJ AC 120 V For details, refer to "Important Check Points for good servicing". T-ZZR SEPT. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 S-W601 1 2 3 4 A B C D E F 1 2 3 4 SAFETY INFORMATION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product contains certain electrical parts contain chemicals which are known to the State of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 NOTICE (FOR CANADIAN MODEL ONLY) Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must be of identical designation. REMARQUE (POUR MODÈLE CANADIEN SEULEMENT) Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que les pièces de remplacement doivent avoir la même désignation. ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURN- ING THE APPLIANCE TO THE CUSTOMER. 2. PRODUCT SAFETY NOTICE Many electrical and mechanical parts in the appliance have special safety related characteristics. These are often not evident from visual inspection nor the protection afforded by them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service Manual. Electrical components having such features are identified by marking with a on the schematics and on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in the parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. For the latest information, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PIONEER Service Manual may be obtained at a nominal charge from PIONEER. (FOR USA MODEL ONLY) 1. SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Measure leakage current to a known earth ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the earth ground and all exposed metal parts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120V AC 60 Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5 mA. Device under test Leakage current tester Earth ground Reading should not be above 0.5 mA Also test with plug reversed (Using AC adapter plug as required) Test all exposed metal surfaces AC Leakage Test www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 S-W601 5 6 7 8 5 6 7 8 A B C D E F [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. a Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 S-W601 1 2 3 4 A B C D E F 1 2 3 4 CONTENTS 1. SERVICE PRECAUTIONS ....................................................................................................................................................5 1.1 NOTES ON SOLDERING ...............................................................................................................................................5 2. SPECIFICATIONS .................................................................................................................................................................6 2.1 SPECIFICATIONS...........................................................................................................................................................6 2.2 PANEL FACILITIES.........................................................................................................................................................7 3. BASIC ITEMS FOR SERVICE...............................................................................................................................................8 3.1 PCB LOCATIONS ...........................................................................................................................................................8 4. BLOCK DIAGRAM...............................................................................................................................................................10 4.1 OVERALL WIRING DIAGRAM......................................................................................................................................10 4.2 BLOCK DIAGRAM ........................................................................................................................................................12 5. DIAGNOSIS.........................................................................................................................................................................13 6. SERVICE MODE .................................................................................................................................................................13 7. DISASSEMBLY....................................................................................................................................................................13 7.1 DISASSEMBLY .............................................................................................................................................................13 8. EACH SETTING AND ADJUSTMENT ................................................................................................................................15 9. EXPLODED VIEWS AND PARTS LIST...............................................................................................................................16 9.1 PACKING SECTION .....................................................................................................................................................16 9.2 EXTERIOR SECTION...................................................................................................................................................18 9.3 AMP SECTION .............................................................................................................................................................20 10. SCHEMATIC DIAGRAM ....................................................................................................................................................22 10.1 AMP, JACK AND REGULATOR ASSYS......................................................................................................................22 10.2 TRANS AND LED ASSYS ..........................................................................................................................................24 10.3 FAN AND SUB TRANS ASSYS..................................................................................................................................25 11. PCB CONNECTION DIAGRAM ........................................................................................................................................26 11.1 LED AND FAN ASSYS................................................................................................................................................26 11.2 SUB TRANS ASSY.....................................................................................................................................................27 11.3 AMP ASSY..................................................................................................................................................................28 11.4 JACK, REGULATOR AND TRANS ASSYS ................................................................................................................30 12. PCB PARTS LIST ..............................................................................................................................................................34 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 S-W601 5 6 7 8 5 6 7 8 A B C D E F 1. SERVICE PRECAUTIONS 1.1 NOTES ON SOLDERING • For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. • Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 ºC. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 ºC in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Do NOT use a soldering iron whose tip temperature cannot be controlled. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: • Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 S-W601 1 2 3 4 A B C D E F 1 2 3 4 2. SPECIFICATIONS 2.1 SPECIFICATIONS Cabinet ............................... Bass-reflex, floor-standing type Speaker S-W301....................................................... 20 cm cone type S-W501....................................................... 25 cm cone type S-W601....................................................... 30 cm cone type Power Amplifier Continuous Power Output (RMS) S-W301................................................. 150 W/6 Ω (100 Hz) S-W501................................................. 170 W/6 Ω (100 Hz) S-W601................................................. 180 W/6 Ω (100 Hz) Input (sensitivity at 100 Hz) LINE LEVEL (RCA jack) ...........................................200 mV Output (Level at 100 Hz) LINE LEVEL (RCA jack) .......................................... 200 mV Selectable CROSSOVER Frequencies .................................................................... 50 Hz to 200 Hz Outline Dimension S-W301 .......................... 360 mm (W) x 360 mm (H) x 398.5 mm (D) 14.2 in. (W) x 14.2 in. (H) x 15.7 in. (D) S-W501 .......................... 360 mm (W) x 380 mm (H) x 418.5 mm (D) 14.2 in. (W) x 15.0 in. (H) x 16.5 in. (D) S-W601 .......................... 360 mm (W) x 430 mm (H) x 438.5 mm (D) 14.2 in. (W) x 16.9 in. (H) x 17.3 in. (D) Weight (without package) S-W301................................................. 14.6 kg / 32 lb. 4 oz. S-W501................................................. 15.6 kg / 34 lb. 7 oz. S-W601............................................... 17.2 kg / 37 lb. 15 oz. Power Requirements........................................ 120 V, 60 Hz Power Consumption................................................... 144 W Power Consumption in standby ................................. 0.5 W Accessories............................................... RCA plug cord x1 Operating instructions Specifications and design subject to possible modification without notice, due to improvements. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 S-W601 5 6 7 8 5 6 7 8 A B C D E F 2.2 PANEL FACILITIES 1 STANDBY/ON POWER VOLUME MAX MIN ON OFF 200 Hz 50 Hz CROSSOVER BYPASS ON OFF AUTO STANDBY PHASE LINE LEVEL INPUT OUTPUT 3 5 7 4 6 8 9 10 2 FRONT PANEL REAR PANEL 2 Power switch (POWER) Switches the subwoofer between ON and OFF. 1 Power Indicator (STANDBY/ON) Lights blue when the power has been switched ON. When AUTO STANDBY switch is set to ON, lights blue whenever the speaker receive an audio signal. If the power is switched OFF only briefly, the indicator lights blue when power is restored. If no signal is present for more than12 minutes, the subwoofer automatically reverts to standby mode and the power indicator lights red. If, subsequently, a signal is received, power automatically comes back on and the power indicator lights blue. NOTE: • If you are planning on switching the unit OFF for a long period of time, make sure to check that the indicator light has gone out after switching OFF. 3 Volume knob (VOLUME) Sets the subwoofer volume. • Turn the knob slowly from the MIN position. • With this unit, the bass level can be independently set, so do not turn up the bass on the AV amplifier. 4 Crossover knob (CROSSOVER) When using the subwoofer, set the upper frequency limit for the subwoofer (50 Hz to 200 Hz) so that it complements the output from your other speakers. When using the bass management features of an AV receiver, set to BYPASS ON in order to use the low-pass filter of the AV receiver for high quality sound. 5 Bypass switch (BYPASS) When set to ON, the audio signal is routed to the woofer unit, bypassing the amplifier’s crossover circuit. 6 Phase switch (PHASE 0º /180º) When set to 180º, the output phase becomes the reverse of the input signal, and when set to 0º, it is in the same phase as the input signal. • Normally, the switch is set to 0º. But when the sound connection between the subwoofer and the left and right speakers sound unnatural, try switching to 180º and set the switch in the position where the sound is natural. • When using two or more subwoofers together, make sure that the phase switch of all of them are set to the same position. 7 Auto Standby switch (AUTO STANDBY) Switches the Auto Standby feature on/off. When switched ON (the default setting is OFF), the Auto Standby feature becomes active. In this mode, if there is no input signal for 12 minutes the system automatically switches to standby. The power is automatically switched on again if an input signal is detected. NOTE: There may be cases where a connected component outputs noise or some other non-audio signal which causes this system to automatically power on when in Auto Standby mode. If this happens, switch off the Auto Standby mode and switch the system on/off manually. 8 Line Level Input terminal (LINE LEVEL INPUT) Connect to the SUBWOOFER PREOUT terminal of an amplifier or receiver, with the specially provided RCA plug cord. 9 Line Level Output terminal (LINE LEVEL OUTPUT) Used for connecting other equipment through the amplifier. The signal output from this jack is not affected in any way by the settings of the various controls on the unit. 10 AC CORD Connect the AC cord to a AC socket (in the room). www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 8 S-W601 1 2 3 4 A B C D E F 1 2 3 4 3. BASIC ITEMS FOR SERVICE 3.1 PCB LOCATIONS SUB TRANS ASSY G Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. NOTES: Mark No. Description Part No. LIST OF ASSEMBLIES Mark No. Description Part No. 1..AMP ASSY XWZ4352 1..JACK ASSY (for S-W601) XWZ4372 (for S-W501) XWZ4371 (for S-W301) XWZ4356 1..REGULATOR ASSY XWZ4416 > 1..TRANS ASSY XWM3443 1..LED ASSY XWM3439 A TRANS ASSY Chassis PSW H/Sink PSW PSW Trans D LED ASSY F FAN ASSY E JACK ASSY B DC FAN Motor R/Cover PSW REGULATOR ASSY AMP ASSY C 1..FAN ASSY XWZ4359 1..SUB TRANS ASSY XWZ4353 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9 S-W601 5 6 7 8 5 6 7 8 A B C D E F www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 10 S-W601 1 2 3 4 A B C D E F 1 2 3 4 4. BLOCK DIAGRAM 4.1 OVERALL WIRING DIAGRAM C F D POWER TRANSFORMER FUSE AC POWER CORD TRANS ASSY REGULATOR ASSY FAN ASSY 52147-0310 51048-0300 B3B-EH 52151-0510 51048-0500 B2P3-VH 1 1 1 2 2 3 3 2 3 3 4 5 1 2 5 4 3 2 1 1 2 J801 CN902 CN901 CN803 CN601 D20PYY0310E FAN STOP FAN STOP FAN+ FAN- FAN STOP FAN- FAN+ FAN+ FAN- FAN ON/OFF V+24V V+ V- GNDF FAN DRIVE RELAY CNTL V-12V D20PYY0510E V+12V J9 GNDA T1 MAIN TRANS SWITCH SWITCH (XWZ4416) (XWZ4359) KU TO SUB TRANS ASSY BASE TO TRANS1 ASSY SWITCH SWITCH (XDX3079 KUC ONLY) CN7 2 1 B2P3-VH RELAY RELAY NEUTRAL (XDX3081 KUC ONLY) LIVE (XWZ4353) SUB TRANS ASSY POW ON- GNDD POW ON+ STBY GNDA LEVEL IN AUTO ON INPUT GNDA KUCONLY ALWAYS ON CN6 CN101 CN103 4 1 3 2 6 5 2 3 4 3 2 4 1 1 52147-0410 B4P7-VH 52147-0610 NEUTRAL LIVE KUC ONLY RKP1751 RELAY RELAY NEUTRAL LIVE KUC ONLY CN4 4 3 2 1 B4P7-VH XXM3013 FAN KUC (XWM3443) KUC XTS3116 REK1067(Buss) 5A 125V ADG7024 G J501 D20PYY0625E GNDA LEVEL IN AUTO ON INPUT GNDA ALWAYS ON 6 2 5 4 3 1 51048-0600 CN1 2 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 S-W601 5 6 7 8 5 6 7 8 A B C D E F A B E �When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". � The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. � : The power supply is shown with the marked box. AMP ASSY LED ASSY JACK ASSY J4 51048-0500 52147-0510 CKS-555 CKS-556 52147-0510 51048-0500 AKB7008- + - 5 4 3 2 1 5 3 4 1 2 3 2 1 1 2 3 4 5 2 1 4 3 5 CN802 CN301 CN8 CN302 JA501 D20PYY0510E V- V+24V GNDF V+ FAN ON/OFF J5 V+12V V-12V GNDA FAN DRIVE RELAY CNTL SPK+ SPK- WHITE BLACK BOARD IN TO AMP ASSY V- GNDP XDX3080 YELLOW V+ V- GNDP GNDA SW_IN V+12V V-12V GNDP V+ GNDA SW_IN V+12V V-12V D20PYY0525E GNDP J502 SWIN SWOUT 2 1 (S-W601 : XWZ4372) (S-W501 : XWZ4371) (S-W301 : XWZ4356) POW ON- GNDD CN702 POW ON+ STBY TO SUB TRANS ASSY (KUC ONLY) 4 3 2 1 52147-0410 KU TO SUB TRANS ASSY BASE TO TRANS1 ASSY (XWZ4352) N N ON (XWM3439) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 S-W601 1 2 3 4 A B C D E F 1 2 3 4 4.2 BLOCK DIAGRAM STK404-140SC Power Amp Bypass ON OFF Vol ADJ Protection Circuit Overload BLOCK DIAGRAM OF POWER SUBWOOFER KUCXJ Model Only Phase 0 Deg 180 Deg CROSSOVER (50-200Hz) Main Transformer Sub Transformer Buffer Line Level input Line Level Outout Auto Power ON OFF V+ V- ±12V +5V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 S-W601 5 6 7 8 5 6 7 8 A B C D E F 5. DIAGNOSIS 6. SERVICE MODE 7. DISASSEMBLY 7.1 DISASSEMBLY • There is no information to be shown in this chapter. • There is no information to be shown in this chapter. 1 2 3 3 1 1 1 2 [1] AMP SECTION Remove the 8 screws. Remove the 8 screws and then remove R/Cover. -Cut the 2 binder on TRANS Assy and 1 on REGULATOR Assy. -Release wires from wire saddles. Remove the 3 screws. R/Cover PSW www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 14 S-W601 1 2 3 4 A B C D E F 1 2 3 4 3 4 8 8 9 9 9 9 5 6 6 7 7 6 5 4 7 Remove the 2 screws and then disconnect FAN connector. -Remove the 4 screws, then REGULATOR Assy from heatsink. -Remove the 2 screws on POWER PACK. Remove the 4 screws from AMP Assy. Remove the 2 screws from SUB TRANS Assy. Remove the connector. Remove the AC connector. Remove the 8 screws from Chassis PSW. Exchange TRANS ASSY Chassis PSW H/Sink PSW PSW Trans JACK ASSY DC FAN Motor R/Cover PSW REGULATOR ASSY AMP ASSY F FAN ASSY A D B C SUB TRANS ASSY G www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 15 S-W601 5 6 7 8 5 6 7 8 A B C D E F 8. EACH SETTING AND ADJUSTMENT 1 1 1 2 4 1 2 3 5 3 4 5 POWER ON Remove the 8 screws and then remove the Speaker. Remove the acoustic absorbent. Speaker Speaker LED ASSY E Remove the 4 screws. Remove the LED ASSY. Remove the 2 screws. [2] SPEAKER ASSY • There is no information to be shown in this chapter. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 16 S-W601 1 2 3 4 A B C D E F 1 2 3 4 9. EXPLODED VIEWS AND PARTS LIST 9.1 PACKING SECTION NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List. - The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. - Screws adjacent to b mark on product are used for disassembly. - For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) FRONT POWER ON Set www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 17 S-W601 5 6 7 8 5 6 7 8 A B C D E F (1) PACKING SECTION PARTS LIST (2) CONTRAST TABLE S-W601/KUCXJ, S-W501/KUCXJ and S-W301/KUCXJ are constructed the same except for the following: Mark No. Description Part No. > 1 • • • • • 2 Setup Guide PSW 12KU XRE3208 (English) 3 • • • • • 4 Black RCA Cable XDE3075 NSP 5 Polyethylene Bag Z21-038 6 Top Pad IW XHA3186 7 Protection Sheet XHG3019 8 Bottom Pad IW XHA3187 9 PSW PACK. CASE See Contrast table (2) 10 • • • • • 11 Warranty Card XRY3006 12 Packing Case Board XHB3062 Mark No. Symbol and Description S-W601/KUCXJ S-W501/KUCXJ S-W301/KUCXJ 9 PSW PACK. CASE XHD3843 XHD3842 XHD3841 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 18 S-W601 1 2 3 4 A B C D E F 1 2 3 4 9.2 EXTERIOR SECTION Refer to “9.3 AMP SECTION”. PSW Cabinet back board F POWER ON POWER VOLUME MAX MIN AC IN ON OFF 200 Hz 50 Hz CROSSOVER BYPASS PHASE LINE LEVEL INPUT OUTPUT ON OFF AUTO STANDBY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 S-W601 5 6 7 8 5 6 7 8 A B C D E F (1) EXTERIOR SECTION PARTS LIST (2) CONTRAST TABLE S-W601/KUCXJ, S-W501/KUCXJ and S-W301/KUCXJ are constructed the same except for the following: Mark No. Description Part No. NSP 1 SBOX PSW See Contrast table (2) 2 LED ASSY XWM3439 3 R/Cover PSW XMC3004 4 MIC Knob (PLS) XAA3029 > 5 PSW KU Trans XTS3116 6 Rubber Leg AEB7353 > 7 DC FAN Motor XXM3013 8 Cord Clamper (Steel) RNH1005 9 FAN Holder PSW XMR3122 10 Cable Tie AEC2078 NSP 11 Label VRW1629 NSP 12 Energy Star Label XAX3745 NSP 13 FAN Cushion (Rub) XEB3139 14 Screw BPZ30P080FTB 15 Screw M4 XBA3020 16 Screw (3x11.6) ABA7146 17 Screw M3 XBA3019 Mark No. Symbol and Description S-W601/KUCXJ S-W501/KUCXJ S-W301/KUCXJ NSP 1 SBOX PSW XXG3389 XXG3390 XXG3391 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 20 S-W601 1 2 3 4 A B C D E F 1 2 3 4 9.3 AMP SECTION B D E G A C A A To SP To AMP Assy www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 S-W601 5 6 7 8 5 6 7 8 A B C D E F (1) AMP SECTION PARTS LIST (2) CONTRAST TABLE S-W601/KUCXJ, S-W501/KUCXJ and S-W301/KUCXJ are constructed the same except for the following: Mark No. Description Part No. 1 AMP Assy XWZ4352 2 JACK Assy See Contrast table (2) 3 REGULATOR Assy XWZ4416 > 4 TRANS Assy XWM3443 5 FAN Assy XWZ4359 > 6 PSW KU Trans XTS3116 > 7 Fuse REK1067 > 8 AC Power Cord ADG7024 > 9 Cable Assy XDX3079 > 10 DC FAN Motor XXM3013 NSP 11 Chassis PSW (MTL) XNA3066 12 Cord Bracket XNG3186 13 H/S Bracket L XNG3188 14 H/S Bracket R XNG3189 15 REG Bracket XNG3190 NSP 16 H/Sink PSW (MTL) XNH3051 > 17 Cable Assy XDX3081 18 Wire Saddle (PLS) AEC7586 19 Washer Cushion XEB3074 > 20 SUB TRANS Assy XWZ4353 21 PSW Encoder GND XNK3026 NSP 22 Binder (BK-1) ZCA-BK1 23 MIC Knob (PLS) XAA3029 24 R/Cover PSW XMC3004 NSP 25 SBOX PSW See Contrast table (2) NSP 26 Fuse Card AAX7097 27 Screw BBZ40P080FNI 28 Screw BPZ30P080FTB 29 Screw (M3) XBA3019 30 Screw BBZ30P060FTC 31 Screw BBZ30P080FNI 32 Screw BBZ30P140FTC NSP 33 Rear Cover Cush (Rub) XEB3129 NSP 34 Fan Cushion (Rub) XEB3139 NSP 35 Trans Cushion XEB3134 NSP 36 AMP Assy Cush (Rub) XEB3138 37 Cord Stopper (Plastic) CM-22C 38 PCB Holder PNW2562 39 Cord Bracket Cush XEB3143 40 Cable Cushion XEB3144 41 Cable Cushion XEB3145 42 SubTrans Barrier-KU XEB3138 43 PSW Jack Shield XNK3024 44 Push Rivet (Brown) AEC7205 Mark No. Description Part No. Mark No. Symbol and Description S-W601/KUCXJ S-W501/KUCXJ S-W301/KUCXJ 2 JACK Assy XWZ4372 XWZ4371 XWZ4356 NSP 25 SBOX PSW XXG3389 XXG3390 XXG3391 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 S-W601 1 2 3 4 A B C D E F 1 2 3 4 10. SCHEMATIC DIAGRAM 10.1 AMP, JACK AND REGULATOR ASSYS A A B B CN103 G CN7 G + - - + - + - + 6 5 1 5 3 2 6 4 3 1 4 2 6 5 8 4 7 8 4 2 3 1 1 2 3 3 2 1 1 2 2 4 1 8 3 6 8 7 5 4 R214 C203 R215 C202 R216 C204 R205 Q207 D203 R207 R206 R209 Q201 D201 R202 R227 C207 Q212 D211 R225 R226 Q211 D210 R201 R224 C206 R237 R218 Q209 R221 R219 Q205 Q204 R208 Q210 Q206 R220 D206 Q203 D205 R212 C208 D204 R203 D212 D202 R204 C205 R222 D208 R239 R238 D209 R223 D207 Q23 R411 IC401 RY201 Q202 C402 C C4 R406 IC401 KN503 KN502 KN501 R515 C510 C511 C528 S501 C536 R503 C535 C542 C501 C540 R517 R516 C541 R501 C502 JA501 CN601 C601 R537 S601 L501 C503 C512 R519 R522 R518 R502 IC502 C504 C513 R520 C505 R504 R523 R521 R505 R506 S502 IC502 C514 C529 C523 C516 C506 R540 R507 VR501 C515 W25 R513 VR501 R531 C539 R509 R508 R510 100K STBY 220/25 220/16 (1W) 10 2.7K 1K 2SA1576A(RS) 1SS355 2SC4081(QR) 33K 16K 10K GNDD V-12V V+12V RT1N241M RT1P241M 47K -TS 22/25 560 UDZS2R7(B) UDZS2R7(B) 1.2K 2.2K 2SD2114K 100K 4.7/50 51048-0600 GNDC 1K 2SC4081(QR) V-12V RT1P241M GNDD 2SA1576A(RS) 10K 22K 10K RT1N241M 2SC4081(QR) 1SS355 1SS355 22K 1SS355 2.2/50 1SS355 47K 820 NP 1SS355 1SS355 ASR7001 2.2K 5.6K 1SS355 2.2/50 STBY 1K 100K 1K 1SS355 1SS355 V+12V 1K 10K NJM4558MD V+12V 2SC2240(GR) GNDA 10K STBY 47 47/ NJM4558MD V+ VNE1948 STBY VNE1948 STBY STBY STBY AL-TS 10/50 ASH7002 STBY *1 STBY 100p 100p STBY 220K 220K 220 AL-TS STBY 10/50 AKB7008- B2P3-VH ACG7034-A 0.01u 820 XSM7001 10/50 AL-TS V-12V STBY STBY 220K 39K 15K STBY 220 10/50 AL-TS NJM4558MD STBY STBY 22K 18K ASH7002 STBY STBY 220 NJM4558MD V+12V 0.01 STBY 0.022 0.022 0.022 AL-TS 10/50 1K 15K STBY 10K-B ACT7005 15K 10K-B ACT7005 50K 50K STBY STB 0 47K DISCHARGE POWER OFF MUTE OVERLOAD D20PYY0625E TO SUB TRANS ASSY GNDA (SW) DC DETECT AC DETECT (1/2) (SW) (SW) AMP ASSY (2/2) LEVEL IN ON AUTO ALWAYS INPUT ON J501 SW SW IN (SW) OUT BUFFER PWR ON PWR OFF (1/2) (2/2) (SW OUT) PHASE SW JACK ASSY -3dB C522 C521 R525 R530 C518 C517 R507 C802 R503 *1 *1 (XWZ4352) (S-W601 : XWZ4372)(S-W501 : XWZ43 KUC TO SUB TRANS ASSY BASE TO TRANS ASSY KUCONLY STBY <-- <-- 2.2/50 0.47 0.47 120 <-- <-- 0 KUC S-W301 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 S-W601 5 6 7 8 5 6 7 8 A B C D E F C B A C TO SPEAKER J4 D CN902 F + - + - - + - + 2 1 4 3 5 1 2 3 5 3 4 1 4 3 1 2 2 1 3 4 5 4 7 8 6 8 4 7 3 2 8 4 8 1 2 1 3 2 5 4 1 1 2 3 13 11 12 5 3 4 10 9 8 7 1 2 5 6 4 3 2 1 4 5 3 2 1 8 2 1 3 4 5 4 6 5 7 4 8 2 3 1 + - + - D11 C11 D10 D12 C17 R11 D9 C10 R14 R19 C6 R17 R7 Q803 R803 R806 R805 C802 R808 Q4 R12 Q3 R20 R13 R21 IC8 W811 R15 R16 R18 D13 C18 D8 D7 Q5 C9 W251 IC5 C16 R222 R239 R238 R232 R233 R235 R234 R236 R223 Q231 R416 R415 R412 C8 CN232 R24 R10 Q6 Q2 R5 C7 R9 C15 IC4 R22 R25 R23 W250 D6 IC402 C408 R414 R312 Q301 C404 C403 C405 R413 R407 C406 R408 C409 C410 IC402 Q402 R409 C407 Q401 R417 R313 R314 C401 R401 R410 C411 R405 R402 R403 R404 R300 C412 R801 W810 D801 Q804 IC7 R809 R810 Q806 Q805 CN803 KN1 C14 CN8 R311 C310 L301 R310 R309 R308 C309 C308 R307 C306 C307 D301 R306 CN802 C305 C303 R304 C304 R303 R305 C313 CN301 R302 C302 R301 C301 IC301 CN302 C529 C523 C516 C531 C530 R528 R542 VR501 C515 W253 R513 VR501 R531 C539 C507 R541 IC503 R510 R514 R551 R529 R530 R552 C519 C522 R532 R538 S503 R524 C538 C543 C521 C517 C546 C518 C520 R546 R512 R525 C508 R526 Q501 R543 C532 R534 C533 R533 C526 R535 C534 R536 C524 C525 VR502 C527 R527 C509 UDZS6.2B UDZS6.2B 51048-0500 GNDA STBY UDZS6.2B UDZS6.2B STBY 47/35 TS 10 1 47/35 (1W) 12k TS V+12V (1W) 10 1 12K GNDF RT1N241M V-12V 4.7K 22K 10K 51048-0300 68K *1 1SS355 6.8K (QR) 2SC4081 V+24V GNDF 52151-0510 2SB1375 V-12V V- (3W) (3W) STBY 1.2K 1.2K STBY 2SD2012 (3W) 1.2K 1.2K (3W) STBY V+12V UDZS8.2B GNDA V- 47/25 UDZS8.2B UDZS8.2B RT1N241C 5600/71 XCH3027 STBY 5600/71 XCH3027 STBY 1K 100K 2SC4081(QR) 2.7K(1/10W) 2.7K(1/10W) 2.7K(1/10W) 2.7K(1/10W) 2.7K(1/10W) V+12V 1K D 100K 100K STBY 52147-0310 TS 47/25 (1W) 12k RT1P241M 10 TS 2SD2012 1 STBY V+24V 470 (3W) (3W) (3W) 470 470 D5SBA20(B) V+ NJM4558MD STBY 470 220 (QR) 2SC4081 47/25 47/25 0.01 68K 680 STBY 680 10/50 58MD V+12V V-12V 10/50 NJM4558MD RT1P241M (YGR) 2SK246 1/50 1M 470 100K 180K (1/10W) (1/10W) 180K V+12V 68K 0.01 680K 470 39K 470K 2.2/50 1/50 0 2SC4081 (QR) STBY V+ 10K RT1N241C 10K VNF1084- GNDD CKS-556 CQMA STBY 0.01 STBY GNDD 51048-0500 STBY GNDA V+ 4.7 0.1 (1W) CQMA V- 2.2u 4.7 (1W) V+24V V-12V 10/100 10/100 ACN7094 0.22(5W) ACN7094 0.22(5W) 52147-0510 8.2K 100/16 47/50 100/100 STBY 8.2K 100 (1W) GNDA CKS-555 10/50 56K 1.8K 56K 2.2/50 3p STBY 2 GNDD 1 52147-0510 470p 1K V+12V STK404-140S GNDA V-12V V+12V STBY 0.022 0.022 0.022 0.022 0.01 STBY STBY STBY 10K-B CT7005 15K 10K-B ACT7005 50K 50K STBY STBY STBY NJM4558MD 47K STBY STBY STBY STBY 47K 3.3K 220 STBY ASH7002 STBY 0 0 AL-TS *1 10/35 *1 0.47 STBY STBY 1000p 220 2SC4081(QR) V+12V 3900p 47/25 4.7K 100K 47p 33K CH AL-TS 10/50 V-12V 0 51048-0500 4.7/50 10K-B 10/50 ACT7002 STBY 220 NJM4558MD IC503 10/50 AL-TS V+12V D20PYY0510E J9 TO AMP ASSY GNDA FAN V-12V RELAY DRIVE CNTL -12V V+12V VEF1040- BINDER D20PYY0310E FAN STOP FAN+ FAN- J801 V- TO AMP ASSY V+24V TO FAN ASSY +12V GND V+12V TO LED ASSY NC GODZILLA AMP +24V +62V (2/2) 2/2) (1/2) WD, LF & KUC ONLY WD, LF ONLY (SW) REGULATOR ASSY GNDF OFF FAN ON/ V+ -62V TO TRANS ASSY V- D20PYY0510E TO REG ASSY V+24V GNDD OFF FAN ON/ V+ J5 V-12V V+12V TO REG ASSY RELAY CNTL FAN DRIVE (SW) (SW) (SW) SPK+ SPK- POWER AMP GNDP TO JACK ASSY V-12V V+12V SW_IN SW GNDA VEF1040- (1/2) LPF HPF +18dB TO AMP ASSY GNDC V-12V BINDER D20PYY0525E (2/2) V+12V (SW) SW_IN GNDA J502 (XWZ4416) (SW) C522 C521 R525 R530 C518 C517 R507 C802 R503 *1 *1 *1 *1 *1 -W501 : XWZ4371)(S-W301 : XWZ4356) <-- <-- <-- <-- 1 0.22 2.2/50 0.47 0.47 120 <-- <-- 0 <-- <-- <-- <-- <-- 330 470 <-- <-- <-- <-- <-- <-- 68k KUC S-W301 KUC S-W501 KUC S-W601 :SW SIGNAL ROUTE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 24 S-W601 1 2 3 4 A B C D E F 1 2 3 4 10.2 TRANS AND LED ASSYS D E D E D TRANS ASSY (XWM3443) D CN8 E LED ASSY (XWM3439) 1 2 2 1 4 3 2 1 C13 H1 H2 CN3 CN1*3 CN4 R701 D702 D701 RED AC CORD YELLOW BOARD IN WHITE J4 TO AMP ASSY XDX3080 *3 CN1 *2 T1 *1 FU1 0V NEUTRAL BLACK MAIN TRANS T1 230V/120V W903 W904 *2 ASSY JACK TO W905 W906 FU1 *1 LIVE TO SUB TRANS ASSY TO SUB TRANS ASSY CN702 4 GNDD 52151-0410 1 2 3 POW ON+ STBY POW ON- BLUE 0.022 ACE7022 AKR7001 B2P3-VH B4P7-VH GNDD STBY SLR343BC4T(JKLM) SLI-343U8RC(HJKL) XTS3116- 5A 125V REK1067 RKP1751 KUC G CN6 G CN101 KUC ONLY KUC ONLY • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS OF FUSE. CAUTION - KUC ONLY KUC ONLY KUC ONLY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 25 S-W601 5 6 7 8 5 6 7 8 A B C D E F 10.3 FAN AND SUB TRANS ASSYS F TO FAN J501 B J801 C 1 1 3 2 3 2 CN902 CN901 52147-0310 B3B-EH TO REG ASSY STOP FAN VEF1040- BINDER FAN+ FAN- (XWZ4359) FAN ASSY ALL RESISTOR ARE IN OHM (1/10W) RS1/16S***J RS1/10***J + + + UNLESS OTHERWISE SPECIFIED CEAT**M** JQ:CEJQ**M** AL:CEAL**M** CKSRYB**K50 +5V ALL CAPACITOR ARE IN uF (2/2) (1/2) SUB TRANS TO TRANS ASSY RELAY RELAY NEUTRAL LIVE TO JACK ASSY SWITCH SWITCH GNDA GND AMPO TO JACK ASSY GNDA LEVEL IN AUTO ON INPUT IN CON LEVEL DETECT ALWAYS ON CAP OUT1 OUT2 POW_ON- VCC (XWZ4353) SUB TRANS ASSY POW_ON+ KUCONLY TO LED ASSY GNDD STBY -TS 10/50 STBY 390 0.047 KIA7805API VE+5 1000p 1SS355 STBY STBY 1SS355 33 1000/25 ASR7027 ATT7079 2SD1859X (QR) 1.8K 1/50 1SS355 ASR7027 -TS 1SS355 STBY STBY S1WB(A)60SD 0.022 ACE7022 100 GNDA STBY 4.7K STBY 2SC4081(QR) B4P7-VH B2P3-VH 52147-0610 2SC4081(QR) STBY 1K 2.2/50 1M 0.1 10K 1000p 470p -TS 8.2K 10K 1000/6.3 NJM2072M 220/6.3 2200/10 STBY 4.7K 5.6K 82 (1/10W) 5.6K 82 (1/10W) 0.01 1K 10K 2SC4081(QR) STBY 1K (1/10W) 52147-0410 C2 C3 D2 R112 C106 IC1 D5 R2 R3 R4 C5 RY1 D4 Q1 R1 D14 RY1 D1 W254 C4 IC2 D3 C12 T2 R118 R114 R116 C111 Q103 CN6 CN7 R103 Q101 R102 R113 C107 C104 C105 C101 R104 C103 R101 R105 CN103 C108 C109 IC101 C110 R117 R115 R119 R109 R106 C102 R107 R108 Q102 R110 R111 CN101 OUT IN + - 5 4 1 3 4 2 6 7 3 8 9 2 1 2 1 3 4 1 2 6 3 4 5 3 4 2 2 1 1 5 6 8 7 4 3 1 2 G F G CN702 E CN4 D CN601 B F G www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 26 S-W601 1 2 3 4 A B C D E F 1 2 3 4 11. PCB CONNECTION DIAGRAM 11.1 LED AND FAN ASSYS 0 10 20 30 40 50 20 30 40 X Y 220 230 240 250 0 10 20 30 40 50 X Y 0 10 20 30 40 50 20 30 40 X Y 220 230 240 250 0 10 20 30 40 50 X Y 1 3 1 4 D702 CN701 CN702 D701 XWM3438 ASSY XWM3439 LED 4 4.GND 2.STBY 1.POW ON+ 1 3.POW ON- B A C7 [[ G ]] 1 3 1 3 CN901 CN902 D4 1.FAN STOP 2.FAN- 3.FAN+ 2.FAN- BLACK YELLOW 1 3 RED 3.FAN+ 1.FAN STOP XWZ4359 FAN ASSY C7 [[ G ]] 1 3 R701 4 1 XWM3439 XWM3438 4.GND 2.STBY 1.POW ON+ 3.POW ON- LED ASSY LF FAN ASSY 3.FAN+ 2.FAN- 1.FAN STOP 3.FAN+ 2.FAN- 3 1.FAN STOP 1 1 XWZ4359 LF SIDE A SIDE B F E F E F FAN ASSY J801 C CN902 TO FAN CN901 CN901 CN902 (XNP3140-B) F FAN ASSY (XNP3140-B) SIDE A SIDE B E LED ASSY CN101 G CN702 (XNP3138-B) (XNP3138-B) E LED ASSY CN702 NOTE FOR PCB DIAGRAMS : 1. The parts mounted on this PCB include all necessary parts for several destinations. For further information for respective destinations, be sure to check with the schematic diagram. Capacitor Connector P.C.Board Chip Part SIDE A SIDE B 2. View point of PCB diagrams. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 27 S-W601 5 6 7 8 5 6 7 8 A B C D E F 11.2 SUB TRANS ASSY 100 110 120 130 140 150 160 170 180 190 200 210 220 230 240 250 120 130 140 150 160 170 180 190 200 X Y 100 110 120 130 140 150 160 170 180 190 200 210 220 230 240 250 120 130 140 150 160 170 180 190 200 X Y 1 4 5 9 1 6 1 3 1 1 4 C4 C5 Q1 C3 C2 RY1 IC1 C111 C110 C109 C108 C101 T2 IC2 CN103 CN6 CN7 CN101 C12 W104 W101 W103 W254 KIA7805API SIDE PRINTED D5 PRIMARY B A CAUTION XWZ4353 SUB TRANS ASSY 2.INPUT 1.ALWAYS ON 3.AUTO ON 5.GNDA 4.LEVEL IN 1.POW ON+ 2.STBY 4.GNDD VE+5 LINE KNIFE 1 3.POW ON- 6 IC101 MFD. BY LITTLEFUSE INC. REPLACE IC LINKS AS MARKED. TYPE NO. ATTENTION 1 4 REMPLACER LE IC COMME INDIQUE N'UTILISER QUE LA REFERENCE DE CHEZ LITTELFUSE INC. 6.GNDA BOND 4 1 1 2 C7 [[ G ]] R4 R3 R2 D5 D3 R1 D4 D2 D1 Q103 R116 R114 R118 R113 R112 Q102 R117 R108 R115 C107 Q101 R103 R102 C106 R111 R110 R109 R106 C102 IC101 C104 C105 R105 C103 R101 R104 R107 R119 D14 LITTLEFUSE INC. 1 PRIMARY REPLACE IC LINKS AS MARKED. TYPE NO. MFD BY 5 6.GNDA 6 3.AUTO ON 2.INPUT 1.ALWAYS ON 4.LEVEL IN 5.GNDA 1.POW ON+ 2.STBY 4.GNDD NO PATTERN KNIFE LINE 8 4 1 DE CHEZ LITTELFUSE INC. QUE LAREFERENCE INDIQUE N'UTILISER REMPLACER LE IC COMME ATTENTION 1 4 CAUTION PRIMARY 3.POW ON- XWZ4353 SUB TRANS ASSY - + ?` ?` 1 4 1 2 1 4 LF SIDE B SIDE B G G SIDE A SIDE A CN4 D CN6 J501 B CN103 CN601 B CN7 CN702 E CN101 G SUB TRANS ASSY (XNP3140-B) CN6 CN103 CN7 CN101 G SUB TRANS ASSY (XNP3140-B) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 28 S-W601 1 2 3 4 A B C D E F 1 2 3 4 11.3 AMP ASSY 0 10 20 30 40 50 60 70 80 90 100 110 120 130 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 210 X Y 1 2 3 4 1 2 1 13 1 3 1 3 1 5 1 5 1 5 C9 C7 C303 D6 C404 C403 C204 C203 R215 C202 C305 Q202 W241 C14 C302 C310 R308 C307 C309 C407 R309 R311 R310 R305 C306 L301 C8 IC4 IC5 RY201 C205 C207 C206 C208 Q2 CN301 C412 C411 C308 IC301 CN8 CN232 CN302 Q401 C410 W233 W225 W234 C16 C409 W223 C15 W210 W229 W214 W213 W215 W201 W222 W232 W221 W228 W211 W216 W238 W220 W224 W212 W299 W209 W226 W235 W218 W217 W203 W207 W205 W240 W227 W208 R22 R23 R24 5 CN802 W231 W251 W250 W202 W219 KN1 C313 W230 W236 R25 W204 W239 W206 W244 C18 GNDA 1.GNDA 4.V-12V 3.V+12V 2.SW_IN 5.GNDP <15MM <15MM 470 10 4.7 100 XWZ4360 12K 470 3.GNDF 4.7 GNDD GNDD BOND GNDD BOND AMP ASSY XWZ4352 1.SPK- 2.SPK+ D C 4.V+24V 2.FAN ON/OFF B BOND LITTELFUSE INC. GNDD MFD. BY TYPE NO. IC402 IC401 1.GNDA AS MARKED. 4.V-12V 1.V+12V SIDE PRINTED J 2SD2012 5.V- GNDD V-12V 1 3.RELAY CNTL 5.V+12V 2.FAN DRIVE 3.GNDD 2.NC BOND BOND BOND REFERCE OF CHEZ BOND 1.V+ A V+ LITTLEFUSE INC. A A N'UTILISER QUE LA REMPLACER LE IC ATTENTION 470 V+12V GNDD GNDA V+12V V+12V V+12V V-12V V-12V V-12V V+12V V+12V GNDA V+ GNDD 5 REPLACE IC LINKS CAUTION 5 3 1 1 COMME INDIQUE BOND BOND NP 1 2 1 13 1 3 C7 [[ G ]] DI P 1 5 SIDE A A A AMP ASSY TO SPEAKER CN301 CN803 C J5 J9 C CN802 (XNP3140-B) CN8 CN302 J502 B J4 D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 29 S-W601 5 6 7 8 5 6 7 8 A B C D E F 0 10 20 30 40 50 60 70 80 90 100 110 120 130 40 50 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 210 X Y D8 R5 D7 C408 R415 R416 R412 IC402 R407 R413 C405 C406 R408 R401 C401 R223 R222 R221 Q209 R204 R219 R218 R216 R214 C304 D209 D208 D207 R220 D206 D204 R212 D201 Q205 Q204 R209 R207 D203 Q207 R205 D205 Q203 R202 R203 Q201 R206 R301 R201 R417 R306 R302 R307 C301 R405 R403 R410 R409 R402 Q402 R414 R404 R303 D13 D301 R314 R313 R312 R304 D202 IC401 C402 R406 R411 R227 R225 D210 D211 R226 Q211 R224 R300 R232 R233 R234 R235 R236 Q206 Q210 Q212 R9 R10 R237 Q231 R239 D212 R238 R208 Q5 Q6 Q301 3.V+12V 1.GNDA 2.SW_IN 3 XWZ4360 1.SPK- 2.SPK+ 3.GNDD NO PATTERN MFD. BY 4.V-12V 2.FAN ON/OFF 4.V-12V 5.V+12V 5.GNDP 2.NC 1.V+12V 3.RELAY CNTL 2.FAN DRIVE 1.GNDA AS MARKED REPLACE IC LINKS CAUTION TYPE NO. LITTLEFUSE INC. ATTENTION REMPLACER LE IC COMME INDIQUE 1.V+ 5.V- 4.V+24V 3.GNDD N'UTILISER QUE LA REFERCE DE CHEZ LITTELFUSE INC. 1 XWZ4352 AMP ASSY 1 4 5 8 1 4 5 8 2 1 1 13 1 LF 1 5 A SIDE B A AMP ASSY (XNP3140-B) CN301 J5 CN802 CN8 CN302 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 30 S-W601 1 2 3 4 A B C D E F 1 2 3 4 11.4 JACK, REGULATOR AND TRANS ASSYS 0 10 20 30 40 50 60 70 80 90 100 110 120 1 0 10 20 30 40 50 60 X Y 100 110 120 130 140 150 160 170 180 190 40 50 60 70 80 90 100 110 X Y 1 6 S501 C528 C506 C513 C505 C504 C503 C502 C534 C532 C527 C525 C524 C509 501 S502 S503 JA501 W253 C546 KN501 C543 C539 C538 W507 W511 W510 W508 W506 W505 W501 W502 BYPASS LPF PHASE ON AUTO D1 IC502 PRODUCTION CODE XWZ4371 XWZ4372 JACK ASSY 2.INPUT 1.ALWAYS ON 3.AUTO ON 4.LEVEL IN 5.GNDA J V-12V GNDA GNDA 6 1 IC503 GNDA JUMPER ONLY 6.GNDA 0 deg D2 XWZ4356 ON XWZ4351 C7 [[ G ]] 1 5 1 5 1 3 C6 C10 C17 C11 W809 W810 W811 R18 R13 W807 W804 W805 W806 Q3 Q4 R15 R16 R17 R19 R20 R21 CN803 9 801 W803 W808 C802 IC7 IC8 W802 SIDE OPEN REPLACE IC LINKS DRIVE CNTL 2.FAN PRINTED SIDE 3.FAN+ 2.FAN- 1.FAN STOP LITTLEFUSE INC. 5.V- 2SB1375 2SD2012 5.V+12V 4.V-12V D3 J AS MARKED. CAUTION XWZ4416 REGULATOR 3.GNDF 1.GNDA 2.FAN ON/OFF 1.V+ 3.RELAY PRINTED DE CHEZ LITTELFUSE INC. REFERCE N'UTILISER QUE LA INDIQUE REMPLACER LE IC COMME ATTENTION MFD. BY 1.2K 1.2K 12K 1.2K 1.2K 5 12K V- 1 V+12V V+12V V-12V GNDA 1 J TYPE NO. 4.V+24V ASSY 1 5 C7 [[ G ]] SIDE A B C D B JACK ASSY C REGULATOR ASSY CN802 A J9 J5 A CN803 CN902 F J801 CN103 G J501 (XNP3140-B) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 31 S-W601 5 6 7 8 5 6 7 8 A B C D E F 0 10 20 30 40 50 60 70 80 90 100 110 120 0 10 20 30 40 50 60 70 80 90 100 X Y 110 120 130 140 150 160 170 180 190 200 210 220 230 240 11 1 3 W901 W904 W902 W907 W908 W906 H2 W905 H1 CN1 CN3 W903 C13 TRANS ASSY REPLACE FUSE AS MARKED KU ONLY XWM3442 L WD/LF ONLY WD/LF ONLY YELLOW KU ONLY PRIMARY TYPE AND RATINGS XWM3443 J4 CAUTION REPLACE WITH SAME FU1 PRODUCTION CODE OF FUSE BLACK WHITE 2 1 N 2 1 CN4 SECONDARY RISK OF FIRE C7 [[ G ]] 1 4 1 1 5 1 1 VR502 VR501 C532 C527 C524 S601 C601 502 W253 KN501 KN502 KN503 C539 W509 W503 W504 CN601 LPF VOLUME <6MM 1.GNDA 2.SW_IN 3.V+12V 4.V-12V 5.GNDC V+12V J <9MM GNDC 1 5 1 2 B C D SIDE A (XNP3140-B) (XNP3139-B) D TRANS ASSY CN6 G CN4 CN8 A J4 AC CORD CN1 CN302 A J502 CN7 G CN601 FU1 T1.6AL250V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 32 S-W601 1 2 3 4 A B C D E F 1 2 3 4 0 10 20 30 40 50 60 70 80 90 100 110 120 0 10 20 30 40 50 60 70 80 90 100 X Y 110 120 130 140 150 160 170 180 190 200 210 220 230 240 XWM3443 FU1 REPLACE FUSE AS MARKED 1 BLACK WHITE YELLOW TRANS ASSY 4 ATTENTION EN INTENSITE NO PATTERN PAR UN MODELE IDENTIQUE REMPLACER PAR LE FUSIBLE 1 RISK OF FIRE CAUTION XWM3442 3 TYPE AND RATINGS OF FUSE REPLACE WITH SAME N L SECONDARY PRIMARY 1 2 LF 1 2 1 0 1 2 3 4 5 6 7 8 9 0 1 2 3 0 0 1 C B A 1 4 C529 R510 R527 R525 R52 R531 1.GNDA 2.SW_IN 3.V+12V 4.V-12V 5.GNDC KNIFE LINE 1 5 1 2 SIDE B B C D B JACK ASSY (XNP3140-B) D TRANS ASSY (XNP3139-B) CN4 J4 CN1 J502 CN601 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 33 S-W601 5 6 7 8 5 6 7 8 A B C D E F 0 10 20 30 40 50 60 70 80 90 100 110 120 0 0 10 20 30 40 50 60 X Y 100 110 120 130 140 150 160 170 180 190 40 50 60 70 80 90 100 110 X Y C531 R528 C530 C516 R522 R519 C512 R515 C507 IC503 C515 R540 R508 R507 R506 R523 IC502 R521 R505 R520 R504 R502 R518 R517 R501 R516 C501 C511 C510 R509 L501 R534 R533 R532 R530 R527 R536 C533 R535 C526 C542 R525 C522 R529 C519 R514 R526 Q501 C508 R512 C521 C520 C517 C518 R524 C514 R503 C536 C535 R537 C523 C540 C541 R513 R541 R542 R552 R546 R538 R543 31 R551 XWZ4351 XWZ4356 XWZ4372 1.ALWAYS ON 2.INPUT 3.AUTO ON 4.LEVEL IN 5.GNDA KNIFE LINE 6.GNDA XWZ4371 1 6 JACK ASSY 1 4 5 8 1 4 5 8 6 1 1 0 1 2 3 4 5 6 7 8 9 0 1 2 3 0 0 1 C B A LF D801 R7 D12 D11 R11 D10 D9 Q804 Q805 Q806 R808 R809 R810 Q803 R12 R14 R801 R805 R806 R803 CNTL 3.RELAY DRIVE 1 3 3.FAN+ 2.FAN- 1.FAN STOP 5.V+12V 1.GNDA 2.FAN 4.V-12V LITTELFUSE INC. REFERCE DE CHEZ N'UTILISER QUE LA REMPLACER LE IC ATTENTION LITTLEFUSE INC. MFD. BY TYPE NO. AS MARKED REPLACE IC LINKS CAUTION 1 5.V- 4.V+24V 2.FAN ON/OFF 3.GNDF 1.V+ COMME INDIQUE 5 XWZ4416 REGULATOR ASSY 5 1 3 1 LF B C D SIDE B C REGULATOR ASSY (XNP3140-B) J9 CN803 J801 J501 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 34 S-W601 1 2 3 4 A B C D E F 1 2 3 4 12. PCB PARTS LIST - Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V 5 6 2 1 1 R 0 R 5 0 5 6 1 4 7 3 NOTES: - Parts marked by “NSP” are generally unavailable because they are not in our Master Spare Parts List. - The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. - When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47 k ohm (tolerance is shown by J = 5%, and K = 10%). 560 Ω → 56 × 101 → 561 ...................................................................RD1/4PU J 47 kΩ → 47 × 103 → 473 ...................................................................RD1/4PU J 0.5 Ω → R50 .................................................................................................RN2H K 1 Ω → 1R0 .................................................................................................RS1P K Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62 kΩ → 562 × 101 → 5621 .................................................................RN1/4PC F Mark No. Description Part No. LIST OF ASSEMBLIES 1..POWER AMP KUC L ASSY (for S-W601) XWK3374 1..POWER AMP KUC M ASSY (for S-W501) XWK3373 1..POWER AMP KUC S ASSY (for S-W301) XWK3372 2..AMP ASSY XWZ4352 2..JACK ASSY (for S-W601) XWZ4372 (for S-W501) XWZ4371 (for S-W301) XWZ4356 2..REGULATOR ASSY XWZ4416 2..FAN ASSY XWZ4359 > 2..SUB TRANS ASSY XWZ4353 > 1..TRANS ASSY XWM3443 1..LED ASSY XWM3439 Mark No. Description Part No. A AMP ASSY MISCELLANEOUS > IC 301 (A,110,128) AUDIO POWER IC STK404-140SC > Q 2 (A,86,188) TRANSISTOR 2SD2012 Q 5 (B,91,175) TRANSISTOR RT1N241C-12 Q 6 (B,86,176) DIGITAL TR(SC-70) RT1P241M Q 201 (B,19,123) TRANSISTOR RT1N241M Q 202 (A,61,132) TRANSISTOR 2SC2240 Q 203 (B,17,141) TRANSISTOR 2SC4081 Q 204 (B,8,115) TRANSISTOR 2SC4081 Q 205 (B,14,102) TRANSISTOR 2SC4081 Q 206 (B,15,134) TRANSISTOR RT1N241M Q 207 (B,12,117) TRANSISTOR 2SA1576A Q 209 (B,9,146) TRANSISTOR 2SA1576A Q 210 (B,12,138) DIGITAL TR(SC-70) RT1P241M Q 211 (B,10,89) TRANSISTOR 2SD2114K Q 212 (B,14,99) DIGITAL TR(SC-70) RT1P241M Q 301 (B,104,141) TRANSISTOR 2SC4081 > D 6 (A,26,187) DIODE D5SBA20(B) D 7 (B,77,177) DIODE UDZS8R2(B) D 8 (B,84,173) DIODE UDZS8R2(B) D 13 (B,90,169) DIODE UDZS8R2(B) D 201 (B,62,129) DIODE 1SS355 D 202 (B,74,66) DIODE 1SS355 D 203 (B,15,114) DIODE 1SS355 D 204 (B,56,135) DIODE 1SS355 D 205 (B,18,138) DIODE 1SS355 D 206 (B,17,147) DIODE 1SS355 D 207 (B,18,152) DIODE 1SS355 D 208 (B,18,154) DIODE 1SS355 D 209 (B,12,154) DIODE 1SS355 D 210 (B,8,98) DIODE UDZS2R7(B) D 211 (B,8,100) DIODE UDZS2R7(B) D 212 (B,77,64) DIODE 1SS355 L 301 (A,86,79) COIL ATH1004 J 5 JUMPER WIRE D20PYY0510E KN 1 (A,99,180) WRAPPING TERMINAL VNF1084 RY 201 (A,80,60) RELAY ASR7001 CN 8 (A,11,168) PLUG CKS-556 CN 301 (A,52,65) PLUG CKS-555 CN 302 (A,9,82) 5P JUMPER CONNECTOR 52147-0510 CN 802 (A,40,74) 5P JUMPER CONNECTOR 52147-0510 5 (A,89,165) 5P CABLE HOLDER 51048-0500 RESISTORS R 5 (B,79,186) RS1/16S1R0J R 10 (B,77,180) RS1/16S100J R 22 (A,62,183) METAL OXIDE RESISTOR RS3LMF471J R 23 (A,61,189) METAL OXIDE RESISTOR RS3LMF471J R 24 (A,86,170) METAL OXIDE RESISTOR RS1LMF123J R 25 (A,82,177) METAL OXIDE RESISTOR RS3LMF471J R 201 (B,64,122) RS1/16S122J R 202 (B,57,129) RS1/16S473J R 203 (B,57,123) RS1/16S821J R 204 (B,17,144) RS1/16S472J R 205 (B,12,119) RS1/16S102J R 206 (B,19,119) RS1/16S103J R 207 (B,19,117) RS1/16S333J R 208 (B,21,112) RS1/16S103J R 209 (B,9,112) RS1/16S163J R 212 (B,61,135) RS1/16S223J R 214 (B,9,126) RS1/16S104J Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 35 S-W601 5 6 7 8 5 6 7 8 A B C D E F R 215 (A,17,127) METAL OXIDE RESISTOR RS1LMF100J R 216 (B,9,109) RS1/16S272J R 218 (B,11,141) RS1/16S103J R 219 (B,11,143) RS1/16S223J R 220 (B,16,149) RS1/16S102J R 221 (B,10,149) RS1/16S562J R 222 (B,16,157) RS1/16S102J R 223 (B,12,157) RS1/16S102J R 224 (B,8,96) RS1/16S104J R 225 (B,14,96) RS1/16S561J R 226 (B,14,93) RS1/16S222J R 227 (B,19,97) RS1/16S473J R 237 (B,8,93) RS1/16S102J R 300 (B,71,105) RS1/16S0R0J R 301 (B,71,110) RS1/16S102J R 302 (B,104,131) RS1/16S563J R 303 (B,74,126) RS1/16S182J R 304 (B,65,125) RS1/16S563J R 305 (A,99,147) METAL OXIDE RESISTOR RS1LMF101J R 306 (B,99,103) RS1/16S822J R 307 (B,103,102) RS1/16S822J R 308 (A,81,102) RESISTOR (0.22, 5 W) ACN7094 R 309 (A,81,94) RESISTOR (0.22, 5 W) ACN7094 R 310 (A,99,84) METAL OXIDE RESISTOR RS1LMF4R7J R 311 (A,61,63) METAL OXIDE RESISTOR RS1LMF4R7J R 312 (B,109,138) RS1/16S221J R 313 (B,109,143) RS1/10S184J R 314 (B,109,141) RS1/10S184J CAPACITORS C 7 (A,51,178) E-CAP 5600/71 XCH3027 C 8 (A,92,183) ELECT. CAPACITOR CEAT470M25 C 9 (A,68,157) E-CAP 5600/71 XCH3027 C 14 (A,20,176) MYLAR FILM CAPACITOR CQMA103K2E C 18 (A,96,173) ELECT. CAPACITOR CEAT470M25 C 203 (A,13,131) CEAT221M25 C 204 (A,13,106) CEAT221M16 C 205 (A,12,151) CEAT2R2M50 C 206 (A,21,86) CEAT4R7M50 C 207 (A,18,94) ELECT. CAPACITOR CEAT220M25 C 208 (A,56,126) CEANP2R2M50 C 301 (B,70,137) CKSRYB471K50 C 302 (A,68,129) CEAT2R2M50 C 303 (A,74,123) CEAT100M50 C 304 (B,70,126) CCSRCJ3R0C50 C 305 (A,90,155) ELECT. CAPACITOR CEAT101M2A C 306 (A,94,127) CEAT101M16 C 307 (A,86,110) CEAT470M50 C 308 (A,85,138) ELECT. CAPACITOR CEAT100M2A C 309 (A,87,127) ELECT. CAPACITOR CEAT100M2A C 310 (A,61,82) CQMA104J50 B JACK ASSY MISCELLANEOUS IC 502 (B,56,19) IC NJM4558MD IC 503 (B,85,25) IC NJM4558MD Q 501 (B,98,32) TRANSISTOR 2SC4081 J 501 PARALLEL WIRE D20PYY0625E Mark No. Description Part No. J 502 5P JUMPER WIRE D20PYY0525E JA 501 (A,18,51) 2P PIN JACK AKB7008 KN 501 (A,114,51) SCREW PLATE VNE1948 KN 503 (A,214,51) SCREW PLATE VNE1948 VR 501 (A,137,39) VARIABLE(50K-BX2) ACT7005 VR 502 (A,156,38) VARIABLE (10K-A5) ACT7002 S 501 (A,42,47) SLIDE SWITCH ASH7002 S 502 (A,62,47) SLIDE SWITCH ASH7002 S 503 (A,82,47) SLIDE SWITCH ASH7002 S 601 (A,194,50) POWER SWITCH XSM7001 CN 601 (A,183,8) CONNECTOR B2P3-VH 502 (A,146,10) 5P CABLE HOLDER 51048-0500 501 (A,36,32) 6P CABLE HOLDER 51048-0600 RESISTORS R 501 (B,43,18) RS1/16S221J R 502 (B,53,28) RS1/16S221J R 503 (B,33,37) RS1/16S121J R 504 (B,60,29) RS1/16S183J R 506 (B,69,18) RS1/16S221J R 507 (B,76,28) RS1/16S0R0J R 508 (B,76,35) RS1/16S0R0J R 513 (B,72,38) RS1/16S473J R 516 (B,43,16) RS1/16S224J R 517 (B,47,18) RS1/16S224J R 519 (B,33,40) RS1/16S224J R 520 (B,66,24) RS1/16S223J R 522 (B,61,26) RS1/16S393J R 523 (B,65,19) RS1/16S153J R 524 (B,76,19) RS1/16S221J R 525 (B,107,33) (for S-W301) RS1/16S273J R 525 (B,107,33) (for S-W601, S-W501) RS1/16S683J R 526 (B,103,33) RS1/16S221J R 527 (B,106,18) RS1/16S221J R 530 (B,93,33) (for S-W301) RS1/16S122J R 530 (B,93,33) (for S-W601) RS1/16S331J R 530 (B,93,33) (for S-W501) RS1/16S471J R 531 (B,129,33) RS1/16S153J R 532 (B,86,31) RS1/16S332J R 533 (B,93,24) RS1/16S104J R 534 (B,93,21) RS1/16S472J R 535 (B,89,17) RS1/16S333J R 536 (B,101,11) RS1/16S0R0J R 537 (B,20,46) RS1/16S821J R 538 (B,67,34) RS1/16S0R0J R 540 (B,76,32) RS1/16S153J R 543 (B,76,37) RS1/16S0R0J R 552 (B,102,43) RS1/16S473J CAPACITORS C 501 (B,43,13) CCSRCH101J50 C 502 (A,47,24) ELECTR. CAPACITOR CEAL100M50 C 503 (A,71,11) ELECTR. CAPACITOR CEAL100M50 C 504 (A,51,32) ELECTR. CAPACITOR CEAL100M50 C 506 (A,71,23) ELECTR. CAPACITOR CEAL100M50 C 508 (B,93,31) CKSRYB102K50 C 509 (A,85,13) CEAL100M50 C 514 (B,76,30) CKSRYB103K50 C 515 (B,82,32) CKSRYB223K50 C 516 (B,82,30) CKSRYB223K50 Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 36 S-W601 1 2 3 4 A B C D E F 1 2 3 4 C 517 (B,90,38) CKSRYB474K16 C 518 (B,94,38) CKSRYB474K16 C 520 (B,94,35) CKSRYB474K16 C 521 (B,98,38) (for S-W601, S-W501) CKSRYB105K16 C 521 (B,98,38) (for S-W301) CKSRYB474K16 C 522 (B,102,41) (for S-W601, S-W501) CKSRYB224K16 C 523 (B,81,34) CKSRYB223K50 C 524 (A,109,28) CEAT4R7M50 C 525 (A,99,20) CEAT100M50 C 526 (B,93,26) CCSRCH470J50 C 528 (A,62,8) CEAL100M50 C 530 (B,80,14) CKSRYB103K50 C 531 (B,80,17) CKSRYB223K50 C 532 (A,104,22) CEAT470M25 C 533 (B,89,19) CKSRYB392K50 C 534 (A,93,8) CEAL100M50 C 546 (A,93,41) ELECTR. CAPACITOR CEAL100M35 C 601 (A,194,18) CKA (10000P/AC250 V) ACG7034 C REGULATOR ASSY MISCELLANEOUS > Q 3 (A,167,97) TRANSISTOR 2SD2012 > Q 4 (A,135,97) TRANSISTOR 2SB1375 Q 803 (B,173,74) TRANSISTOR RT1N241M Q 804 (B,165,65) TRANSISTOR 2SC4081 Q 805 (B,168,79) TRANSISTOR 2SC4081 Q 806 (B,161,62) TRANSISTOR RT1N241C-12 D 9 (B,175,84) DIODE UDZS6R2(B) D 10 (B,177,89) DIODE UDZS6R2(B) D 11 (B,139,88) DIODE UDZS6R2(B) D 12 (B,139,91) DIODE UDZS6R2(B) D 801 (B,148,69) DIODE 1SS355 J 9 JUMPER WIRE D20PYY0510E J 801 JUMPER WIRE D20PYY0310E 801 (A,175,56) 3P CABLE HOLDER 51048-0300 9 (A,149,62) 5P CABLE HOLDER 51048-0500 3 PCB BINDER VEF1040 CN 803 5P JUMPER CONNECTOR 52151-0510 RESISTORS R 7 (B,172,91) RS1/16S1R0J R 11 (B,133,94) RS1/16S100J R 12 (B,140,94) RS1/16S1R0J R 14 (B,167,88) RS1/16S100J R 15 (A,160,69) METAL OXIDE RESISTOR RS3LMF122J R 16 (A,160,75) METAL OXIDE RESISTOR RS3LMF122J R 17 (A,168,91) METAL OXIDE RESISTOR RS1LMF123J R 19 (A,129,81) METAL OXIDE RESISTOR RS1LMF123J R 20 (A,134,75) METAL OXIDE RESISTOR RS3LMF122J R 21 (A,134,69) METAL OXIDE RESISTOR RS3LMF122J R 801 (B,146,66) RS1/16S682J R 803 (B,138,67) RS1/16S472J R 805 (B,173,77) RS1/16S223J R 806 (B,166,84) RS1/16S103J R 808 (B,173,64) RS1/16S683J R 809 (B,164,75) RS1/16S103J R 810 (B,164,69) RS1/16S103J Mark No. Description Part No. CAPACITORS C 10 (A,163,91) ELECT. CAPACITOR CEAT470M35 C 17 (A,144,92) ELECT. CAPACITOR CEAT470M35 C 802 (A,169,64) CEAT100M50 D TRANS ASSY MISCELLANEOUS H 1 (A,17,59) FUSE CLIP AKR7001 H 2 (A,17,39) FUSE CLIP AKR7001 J 4 CABLE ASSY XDX3080 > CN 1 (A,18,31) AC CORD SOCKET RKP1751 > CN 4 4P-VH CONNECTOR B4P7-VH CAPACITORS > C 13 (A,25,49) FILM CAPACITOR ACE7022 E LED ASSY MISCELLANEOUS D 701 (A,29,115) LED(RED) SLI-343U8RC(HJKL) D 702 (A,23,115) LED(BLUE) SLR-343BC4T(JKLM) CN 702 (A,25,133) 4P JUMPER CONNECTOR 52151-0410 F FAN ASSY MISCELLANEOUS CN 901 (A,239,18) 3P TOP POST B3B-EH CN 902 (A,239,35) 3P JUMPER CONNECTOR 52147-0310 4 PCB BINDER VEF1040 G SUB TRANS ASSY MISCELLANEOUS > IC 1 (A,218,180) REGULATOR IC KIA7805API IC 101 (B,221,151) LEVEL DETECT IC NJM2072M Q 1 (A,141,146) TRANSISTOR 2SD1859X Q 101 (B,173,148) TRANSISTOR 2SC4081 Q 102 (B,236,149) TRANSISTOR 2SC4081 Q 103 (B,237,155) TRANSISTOR 2SC4081 D 1 (B,155,155) DIODE 1SS355 > D 3 (B,208,165) BRIDGE DIODE S1WB(A)60SD D 4 (B,151,143) DIODE 1SS355 D 5 (B,146,142) DIODE 1SS355 D 14 (B,149,155) DIODE 1SS355 > RY 1 (A,159,159) RELAY ASR7027 > T 2 (A,173,166) POWER TRANSFORMER ATT7079 > CN 6 (A,134,165) 4P-VH CONNECTOR B4P7-VH CN 7 (A,157,151) CONNECTOR B2P3-VH CN 101 (A,231,142) 4P JUMPER CONNECTOR 52147-0410 CN 103 (A,187,141) 6P JUMPER CONNECTOR 52147-0610 RESISTORS R 1 (B,173,151) RS1/16S102J R 2 (B,137,145) RS1/16S330J R 101 (B,217,157) RS1/16S822J R 102 (B,199,145) RS1/16S102J R 104 (B,178,148) RS1/16S105J Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 37 S-W601 5 6 7 8 5 6 7 8 A B C D E F R 105 (B,191,147) RS1/16S103J R 106 (B,230,152) RS1/16S102J R 107 (B,223,164) RS1/16S103J R 108 (B,230,155) RS1/16S562J R 109 (B,238,147) RS1/10S820J R 110 (B,230,147) RS1/10S102J R 112 (B,172,145) RS1/16S391J R 113 (B,191,140) RS1/16S103J R 115 (B,234,162) RS1/16S472J R 116 (B,239,163) RS1/16S472J R 117 (B,236,152) RS1/16S562J R 118 (B,235,165) RS1/16S101J R 119 (B,240,150) RS1/10S820J CAPACITORS C 2 (A,226,177) CEAT100M50 C 3 (A,236,177) CEAT1R0M50 C 5 (A,226,186) ELECT. CAPACITOR CEAT102M25 > C 12 (A,145,175) FILM CAPACITOR ACE7022 C 101 (A,199,142) CEAT2R2M50 C 102 (B,221,141) CKSRYB103K50 C 103 (B,192,154) CKSRYB104K50 C 104 (B,217,146) CKSRYB102K50 C 105 (B,217,143) CKSRYB471K50 C 106 (B,176,145) CKSRYB473K50 C 107 (B,217,141) CKSRYB102K50 C 108 (A,226,160) ELECT. CAPACITOR CEAT471M6R3 C 109 (A,226,169) ELECT. CAPACITOR CEAT222M10 Mark No. Description Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com