PIONEER CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A. PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936 C PIONEER CORPORATION 2004 K-ZZB. SEPT. 2004 Printed in Japan ORDER NO. CRT3326 CLASS D MONO AMPLIFIER PRS-D5000SPL /X1H/EW Service Manual PRS-D5000SPL/X1H/EW For details, refer to "Important check points for good servicing". PRS-D5000SPL /X1H/UC www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 2 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW SAFETY INFORMATION - Service Precaution You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 3 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. 0 Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW CONTENTS SAFETY INFORMATION............................................2 1. SPECIFICATIONS.......................................................5 2. EXPLODED VIEWS AND PARTS LIST ......................6 2.1 PACKING..............................................................6 2.2 EXTERIOR............................................................8 3. SCHEMATIC DIAGRAM...........................................10 3.1 SCHEMATIC DIAGRAM (GUIDE PAGE) ...........10 4. PCB CONNECTION DIAGRAM................................16 4.1 AMP UNIT..........................................................16 5. ELECTRICAL PARTS LIST........................................20 6. ADJUSTMENT.........................................................24 7. GENERAL INFORMATION.......................................25 7.1 DIAGNOSIS .......................................................25 7.1.1 DISASSEMBLY.........................................25 7.1.2 CONNECTOR FUNCTION DESCRIPTION ......26 8. OPERATIONS...........................................................27 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 5 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW 1. SPECIFICATIONS Power source...................................................................................... 14.4 V DC (10.8 — 15.1 V allowable) Grounding system .................................................................................................................... Negative type Backup current ............................................................................................................................ 3 mA or less Current consumption .................................................................................. 70 A (at continuous power, 4 Ω) Average current drawn* .................................................................................. 10.6 A (4 Ω for one channel) 15.6 A (2 Ω for one channel) Fuse ...................................................................................................................................................... 150 A Dimensions ................................................................................................ 300 (W) × 64 (H) × 330 (D) mm Weight ................................................................................................ 7.3 kg (Leads for wiring not included) Maximum power output .................................................................. 1,500 W × 1 (4 Ω) / 3,000 W × 1 (2 Ω) Continuous power output (EW) .............. 1,100 W × 1 (4 Ω) / 1,950 W × 1 (2 Ω) (DIN45324, +B=14.4 V) Continuous power output (UC)........................................................ 750 W × 1 (at 14.4 V, 4 Ω, 20 —240 Hz 1.0% THD) ................................................................................................1,500 W × 1 (at 14.4 V, 2 Ω, 20 —240 Hz 2.0% THD) Load impedance .............................................................. 4 Ω (2 — 8 Ω allowable), (Ex. Bridge 4 — 16 Ω) Frequency response ........................................................................................ 10 — 240 Hz (+0 dB, –1 dB) S/N ratio .................................................................................................................... 90 dB (IEC-A network) Distortion .................................................................................................................. 0.05 % (50 W, 100 Hz) Low pass filter ............................................................................................ Cut off frequency: 40 — 240 Hz Cut off slope: –18, –24 dB/oct Subsonic filter (HPF) ........................................................................................................ Frequency: 20 Hz Slope: –18 dB Bass boost .......................................................................................................................... Level: 0 — 12 dB Frequency: 40 — 120 Hz Phase control .................................................................................................................. SYNC, SYNC INV Gain control ........................................................................................................................ 200 mV — 6.5 V Maximum input level / impedance ................................................................................ RCA: 6.5 V / 22 kΩ (UC model) Power output ........................................................................................ 750 W RMS × 1 channel (4 Ω and 1 % THD+N) 1500 W RMS × 1 channel (2 Ω and 1 % THD+N, 240 Hz) S/N ratio .............................................................................. 60 dBA (Reference: 1 W into 4 Ω) Note: • Specifications and the design are subject to possible modification without notice due to improvements. *Average current drawn • The average current drawn is nearly the maximum current drawn by this unit when an audio signal is input. Use this value when working out total current drawn by multiple power amplifiers. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 6 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW 2. EXPLODED VIEWS AND PARTS LIST 2.1 PACKING 1 5 6 6 4 9 3 2 7 8 3 12 10 11(1/2) 11(2/2) 13 13 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 7 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW - PACKING SECTION PARTS LIST - Owner's Manual Part No. Language HRD0240 English, French HRD0241 English, Spanish, German, French, Italian, Dutch 1 Polyethylene Bag HEG0011 2 Polyethylene Bag HEG0022 3 Protector HHP0268 4 Screw Assy HEA0072 5 Screw BYC40P180FZK 6 Lock Tie HNV0071 7 Carton(EW) HHG0452 Carton(UC) HHG0448 8 Contain Box HHL0448 * 9-1 Warranty Card(EW) HRY1157 * 9-2 Card(UC) ARY1048 9-3 Owner’s Manual(EW) HRD0241 Owner’s Manual(UC) HRD0240 > 10 Fuse (150A) HEK1291 11(1/2) Fuse Holder (Base) HKR1026 11(2/2) Fuse Holder (Cover) HKR1026 12 Install Card (EW) HRP1298 Install Card (UC) HRP1297 13 Polyethylene Bag HEG0031 Mark No. Description Part No. NOTE: - Parts marked by “*” are generally unavailable because they are not in our Master Spare Parts List. - The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. - Screws adjacent to ∇ mark on the product are used for disassembly. - For the applying amount of lubricants or glue, follow the instructions in this manual. ( In the case of no amount instructions, apply as you think it appropriate.) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 1 2 21 48 4 22 22 15 22 12 12 12 12 26 25 47 44 28 30 45 27 33 22 22 22 22 22 22 22 5 5 13 46 46 4 15 5 5 5 15 5 5 5 56 56 56 57 19 18 2 2 2 2 7 2 2 3 3 3 8 14 52 3 9 3 3 3 1 1 1 1 1 10 10 10 10 10 10 31 34 35 36 37 38 39 40 41 42 32 1 1 6 1 11 16 24 24 24 24 24 24 24 24 24 23 29 43 43 25 55 55 55 20 24 24 49 17 24 1 1 1 3 3 55 55 55 A 8 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW 2.2 EXTERIOR www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 9 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW 1 Screw BBZ30P120FTC 2 Screw BMZ30P050FTC 3 Screw BSZ30P050FZK 4 Screw HBA0028 5 Stud HLA0022 6 Panel HNB0248 7 Panel HNB0249 8 Case HNB0250 9 Cover HNB0272 10 Clip HNC0189 11 Holder HNC0207 12 Spacer HNM0006 13 Insulator HNM0205 14 Insulator HNM0206 15 Insulator HNM0207 16 Insulator HNM0209 17 Insulator HNM0215 18 Heat Sink HNR0277 19 Plate HNS0122 20 Cover HNS0134 21 Cover HNS0135 22 Spacer HNV0016 23 Amp Unit(EW) HWH0218 Amp Unit(UC) HWH0219 24 Screw BBZ30P060FTC 25 Screw BBZ30P060SAD 26 Cushion(CN303) CNM6825 27 Cushion(CN304) CNM6825 28 Cord Assy HDE0065 29 Pin Jack(CN801) HKB0004 30 Terminal(CN903) HKE1050 31 Terminal(CN601) HKF0001 32 Terminal(CN602) HKF0001 33 Terminal(CN603) HKF0001 34 Terminal(CN604) HKF0001 35 Terminal(CN605) HKF0001 36 Terminal(CN606) HKF0001 37 Terminal(CN607) HKF0001 38 Terminal(CN608) HKF0001 39 Terminal(CN609) HKF0001 40 Terminal(CN610) HKF0001 41 Terminal(CN611) HKF0001 42 Terminal(CN612) HKF0001 43 Clip HNC0054 44 Buss Bar HNC0200 45 Buss Bar HNC0201 46 Insulator HNM0208 47 Screw PPZ30P100SAD 48 Light Pipe HXA0426 49 Terminal Unit (CN301,302) HXA0448 50 ••••• 51 ••••• 52 Terminal Unit (CN901,902) HXA0449 53 ••••• 54 ••••• 55 Screw PPZ30P120FZK 56 Screw SMZ20H060FNN * 57 Badge (EW) HAM0039 * Badge (UC) HAM0034 Mark No. Description Part No. Mark No. Description Part No. - EXTERIOR SECTION PARTS LIST www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com A-a A-a A-b A-b A-a A-a A-b A-b A-b A-b A-a A-a Large size SCH diagram Guide page Detailed page Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". A-a A The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. > > > > > > > > > > > > > > > SLOPE SELECT SWITCH SUBSONIC SELECT SWITCH 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A 10 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW 3. SCHEMATIC DIAGRAM 3.1 SCHEMATIC DIAGRAM (GUIDE PAGE) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 11 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW A-b A Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022 ← ← Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. A AMP UNIT MODE SELECT SWITCH BFC SWITCH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 12 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW A-a A-b A-a A-a A-b 1 2 3 4 5 > > SLOPE SELECT SWITCH SUBSONIC SELECT SWITCH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 13 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW A-a A-b A-a A-a A-b 5 6 7 8 > > > > > > > > > > > > > > 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A 30A www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 14 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW A-a A-b A-b 1 2 3 4 A AMP UNIT MODE SELECT SWITCH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 15 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW A-a A-b A-b 5 6 7 8 Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022 ← ← The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. BFC SWITCH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 4. PCB CONNECTION DIAGRAM 4.1 AMP UNIT Capacitor Connector P.C.Board Chip Part A A AMP UNIT SIDE B SIDE A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams BFC 16 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 17 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW A SIDE A MODE SELECT GAIN CONTROL BASS BOOST FREQ. BASS BOOST LEVEL SPEAKER OUTPUT LPF FREQ. SLOPE SELECT SUBSONIC SELECT 12 10 6 4 2 1 3 5 9 11 Rch INPUT Lch INPUT SYNC OUTPUT SYNC INPUT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 18 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW A A AMP UNIT 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 19 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW A SIDE B www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com Unit Number : HWH0218(EW) Unit Number : HWH0219(UC) Unit Name : Amp Unit MISCELLANEOUS IC 101 IC NJM2068D IC 102 IC NJM2068D IC 103 IC NJM2068D IC 104 IC NJM2068D IC 301 IC TDA7570 IC 600 IC PA2027A IC 601 IC UPC494C IC 602 IC UPC494C IC 603 IC NJM2903M IC 605 IC NJM2068MD IC 801 IC NJM2068D IC 802 IC NJM2068D IC 803 IC NJM2068D IC 804 IC NJM2068D Q 202 Transistor DTC114EK Q 203 Transistor DTC143EK Q 204 Transistor 2SA1037K Q 303 Transistor 2SA992 Q 304 Transistor 2SA992 Q 305 Transistor 2SC1845 Q 306 Transistor 2SC1845 Q 307 Transistor 2SC4730 Q 308 Transistor 2SA1826 Q 309 Transistor 2SC4730 Q 310 Transistor 2SA1826 Q 311 Transistor 2SC4730 Q 312 Transistor 2SA1826 Q 313 Transistor 2SA1826 Q 314 Transistor 2SC4730 Q 315 Transistor IRF9640 Q 316 Transistor IRF9640 Q 317 Transistor IRF9640 Q 318 Transistor IRF9640 Q 319 Transistor IRF9640 Q 320 Transistor IRF9640 Q 321 Transistor IRF640N Q 322 Transistor IRF640N Q 323 Transistor IRF640N Q 324 Transistor IRF640N Q 325 Transistor DTC124EK Q 326 Transistor DTA124EK Q 327 Transistor DTA124EK Q 328 Transistor DTC124EK Q 600 Transistor KSC1623 Q 601 Transistor 2SA1048 Q 602 Transistor 2SB1243 Q 603 Transistor 2SB1243 Q 608 Transistor 2SD1862 Q 609 Transistor 2SB1240 Q 610 Transistor 2SB1240 Q 611 Transistor 2SD1862 Q 612 Transistor 2SD1862 Q 613 Transistor 2SB1240 Q 614 Transistor 2SB1240 Q 615 Transistor 2SD1862 Q 616 FET IRF2807 Q 617 FET IRF2807 Q 618 FET IRF2807 Q 619 FET IRF2807 Q 620 FET IRF2807 Q 621 FET IRF2807 Q 622 FET IRF2807 Q 623 FET IRF2807 Q 624 FET IRF2807 Q 625 FET IRF2807 Q 626 FET IRF2807 Q 627 FET IRF2807 Q 628 Transistor KSC1623 Q 629 Transistor DTA114EK Q 630 Transistor DTC114TK Q 631 Transistor DTC114TK Q 632 Transistor KSC1623 Q 661 Transistor 2SA1048 Q 700 Transistor 2SC5511E Q 701 Transistor 2SA2005E Q 702 Transistor 2SC5511E Q 703 Transistor 2SA2005E Q 902 Transistor KSA812 Q 903 Transistor KSC1623 Q 904 Transistor KSC1623 Q 905 Transistor KSC1623 Q 910 Transistor KSA812 D 201 Diode 1SS133 D 202 Diode 1SS133 D 203 Diode 1SS133 D 204 Diode RD3R9E(B1) D 301 Diode 1SS133 D 302 Diode 1SS133 D 303 Diode FML22S D 304 Diode FML22S D 305 Diode FML22S D 306 Diode RD39EB D 307 Diode RD9R1E(B2) D 308 Diode RD9R1E(B2) D 309 Diode RD39EB =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- A 20 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW 5. ELECTRICAL PARTS LIST NOTE: - Parts whose parts numbers are omitted are subject to being not supplied. - The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... - The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 21 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW D 310 Diode RD30E(B2) D 311 Diode RD39EB D 312 Diode RD27E(B4) D 600 Diode RM4Z-LFJ4 D 601 Diode RM4Z-LFJ4 D 602 Diode RM4Z-LFJ4 D 603 Diode RM4Z-LFJ4 D 605 Diode HZS7L(B2) D 606 Diode ERA15-02VH D 607 Diode ERA15-02VH D 608 LED DB1112H D 610 Diode 1SS133 D 612 Diode 1SS133 D 613 Diode 1SS133 D 620 Diode MTZJ18(B) D 621 Diode 1SS133 D 622 Diode 1SS133 D 623 Diode 1SS133 D 624 Diode 1SS355 D 625 Diode 1SS355 D 626 Diode 1SS355 D 627 Diode 1SS355 D 658 Diode 1SS133 D 701 Diode MUR1620CT D 702 Diode MUR1620CTR D 703 Diode MUR1620CT D 704 Diode MUR1620CTR D 712 Diode HZS16L(1) D 713 Diode HZS16L(1) D 714 Diode RD22EB2 D 715 Diode RD22EB2 D 901 Diode 1SS133 L 301 Coil HTH0016 L 601 Choke Coil 7µH HTH0014 L 700 Choke Coil 100µH HTH0015 L 701 Choke Coil 100µH HTH0015 L 801 Ferri-Inductor CTF1007 L 802 Ferri-Inductor CTF1007 L 803 Ferri-Inductor CTF1007 T 700 Transformer HTT0031 T 701 Transformer HTT0031 TH 601 Thermistor HCX0002 TH 602 Thermistor HCX0002 TH 603 Thermistor HCX0001 TH 604 Thermistor HCX0001 TH 605 Thermistor HCX0001 TH 606 Thermistor HCX0004 S 101 Switch (SLOPE SELECT) HSH0004 S 102 Switch (MODE SELECT) HSH0005 S 103 Switch (SUBSONIC SELECT) HSH0004 S 601 Switch (BFC)(EW) HSH-156 VR 101 Variable Resistor 20kΩ(E) CCS1266 (LPF FREQ.) VR 105 Variable Resistor 10kΩ(A) CCS1265 (BASS BOOST LEVEL) VR 106 Variable Resistor 50kΩ(C) CCS1263 (BASS BOOST FREQ.) VR 107 Variable Resistor 10kΩ(A) CCS1265 (GAIN CONTROL) VR 301 Semi-fixedr 2.2kΩ HCP0003 VR 600 Semi-fixed 100kΩ(B) RH063MC15R VR 601 Semi-fixed 100kΩ(B) RH063MC15R FU 601 Fuse 30A HEK0041 FU 602 Fuse 30A HEK0041 FU 603 Fuse 30A HEK0041 FU 604 Fuse 30A HEK0041 FU 605 Fuse 30A HEK0041 FU 606 Fuse 30A HEK0041 FU 607 Fuse 30A HEK0041 FU 608 Fuse 30A HEK0041 FU 609 Fuse 30A HEK0041 FU 610 Fuse 30A HEK0041 FU 611 Fuse 30A HEK0041 FU 612 Fuse 30A HEK0041 FU 701 Fuse 0.375A HEK0042 FU 702 Fuse 0.375A HEK0042 FU 801 Fuse 3A HEK0043 RESISTORS R 101 RS1/16S432J R 102 RS1/16S432J R 103 RS1/16S432J R 105 RS1/16S432J R 107 RS1/16S432J R 108 RS1/16S222J R 110 RS1/16S182J R 111 RS1/16S822J R 112 RS1/16S221J R 113 RS1/16S222J R 114 RS1/16S560J R 115 RS1/16S822J R 116 RS1/16S222J R 117 RS1/16S202J R 118 RS1/16S103J R 119 RS1/16S123J R 120 RS1/16S392J R 121 RS1/16S393J R 122 RS1/16S473J R 124 RS1/16S331J R 204 RD1/4PU101J R 205 RD1/4PU472J R 209 RD1/4PU102J R 210 RD1/4PU202J R 211 RD1/4PU223J R 212 RD1/4PU222J R 213 RD1/4PU333J R 301 RS1/16S101J R 302 RS1/16S103J R 303 RD1/4PU561J R 304 RD1/4PU102J R 305 RS1PMF163J R 306 RS1/16S101J R 307 RS1/16S101J R 308 RS1/16S103J R 309 RS1/16S393J R 310 RS1/16S393J R 311 RS1/16S103J R 314 RD1/4PU0R0J R 315 RD1/4PU0R0J R 316 RS1/2PMF223J R 317 RS1/2PMF223J R 318 RS1/2PMF241J R 319 RS1/2PMF221J R 320 RS1/2PMF221J R 321 RS1/2PMF241J R 322 RD1/4PU100J R 323 RD1/4PU100J R 324 RS1/16S510J R 325 RS1/16S470J R 326 RS2LMF301J R 327 RS2LMF301J R 328 RS2LMF221J R 329 RS2LMF221J R 330 RS1/2PMF4R7J =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- > > > > > > > > > > > > > > > www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 22 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- R 331 RS1/2PMF4R7J R 332 RD1/4PU104J R 333 RD1/4PU104J R 334 RD1/4PU272J R 335 RD1/4PU272J R 336 RS1/2PMF100J R 337 RS1/2PMF100J R 338 RS1/2PMF100J R 339 RS1/2PMF100J R 340 RS1/2PMF100J R 341 RS1/2PMF100J R 342 RS1/2PMF100J R 343 RS1/2PMF100J R 344 RS1/2PMF100J R 345 RS1/2PMF100J R 346 0.01Ω HCN0011 R 347 0.01Ω HCN0011 R 348 0.01Ω HCN0011 R 349 0.01Ω HCN0011 R 350 RS2PMF220J R 351 RS2LMF2R2J R 352 RD1/4PU473J R 353 RD1/4PU473J R 354 RD1/4PU393J R 355 RD1/4PU393J R 356 RS1/2PMF822J R 357 RS2LMF2R2J R 358 RS1/16S472J R 359 RS1/16S472J R 360 RS1/16S163J R 361 RS1/16S153J R 600 RD1/4PU102J R 601 RD1/4PU473J R 602 RD1/4PU103J R 603 RD1/4PU103J R 604 RD1/4PU222J R 605 RS1/16S621J R 606 RS1/16S621J R 607 RD1/4PU103J R 608 RD1/4PU472J R 609 RS1/16S472J R 610 RS1/16S223J R 611 RS1/16S223J R 612 RD1/4PU223J R 613 RD1/4PU331J R 614 RD1/4PU331J R 615 RD1/4PU152J R 616 RD1/4PU152J R 617 (EW) RS1/16S105J R 618 RS1/16S183J R 619 RS1/16S102J R 620 RS1/16S273J R 621 RD1/4PU0R0J R 622 RS1/16S242J R 623 RS1/16S472J R 624 RS1/16S472J R 625 RS1/16S272J R 626 RS1/16S272J R 627 RS1/16S272J R 632 RD1/4PU621J R 633 RD1/4PU621J R 634 RD1/4PU621J R 635 RD1/4PU621J R 636 RD1/4PU472J R 637 RD1/4PU472J R 638 RD1/4PU472J R 639 RD1/4PU472J R 640 RS1/2PMF470J R 641 RS1/2PMF470J R 642 RS1/2PMF470J R 643 RS1/2PMF470J R 644 RS1/2PMF470J R 645 RS1/2PMF470J R 646 RS1/2PMF470J R 647 RS1/2PMF470J R 648 RS1/2PMF470J R 649 RS1/2PMF470J R 650 RS1/2PMF470J R 651 RS1/2PMF470J R 652 RS1/2PMF220J R 653 RS1/2PMF220J R 654 RS1/2PMF220J R 655 RS1/2PMF220J R 656 RS1/16S122J R 657 RS1/16S101J R 658 RS1/16S223J R 659 RS1/16S103J R 660 RS1/16S472J R 661 RS1/16S472J R 662 RS1/16S472J R 664 RD1/4PU104J R 665 RD1/4PU512J R 667 RS1/16S563J R 668 RD1/4PU104J R 669 RD1/4PU472J R 670 RS1/16S222J R 671 RS1/16S272J R 672 RS1/16S242J R 673 RS1/16S563J R 674 RS1/16S103J R 675 RS1/16S563J R 676 RS1/16S563J R 677 RS1/16S103J R 679 RS1/16S333J R 678 RS1/16S103J R 680 RS1/16S1602D R 681 RS1/16S1602D R 682 RS1/16S1803D R 683 RS1/16S2203D R 684 RS1/16S1102D R 685 RS1/16S1501D R 686 RS1/16S2401D R 687 RS1/16S2401D R 688 RS1/16S433J R 689 RS1/16S433J R 690 RS1/16S103J R 691 RS1/16S163J R 692 RS1/16S104J R 698 RS1/16S272J R 699 RD1/4PU151J R 700 RS1/2PMF220J R 701 RS1/2PMF220J R 712 RD1/4PU153J R 713 RD1/4PU153J R 714 RD1/4PU333J R 715 RD1/4PU333J R 800 RS1/16S471J R 801 RS1/16S223J R 802 RN1/10SE1002D R 803 RN1/10SE1002D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 23 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- R 804 RN1/10SE1002D R 805 RN1/10SE1002D R 806 RS1/16S471J R 807 RS1/16S223J R 808 RN1/10SE1002D R 809 RN1/10SE1002D R 810 RN1/10SE1002D R 811 RN1/10SE1002D R 812 RS1/16S471J R 813 RS1/16S223J R 814 RN1/10SE1002D R 815 RN1/10SE1002D R 816 RN1/10SE1002D R 817 RN1/10SE1002D R 819 RS1/16S471J R 821 RS1/16S472J R 823 RS1/16S472J R 824 RS1/16S472J R 890 RS1/16S222J R 891 RS1/16S152J R 892 RS1/16S472J R 893 RS1/16S562J R 901 RD1/4PU473J R 902 RD1/4PU104J R 903 RD1/4PU103J R 904 RD1/4PU472J R 905 RD1/4PU103J R 907 RD1/4PU563J R 908 RD1/4PU221J R 915 RD1/4PU472J CAPACITORS C 101 CFTNA154J50 C 102 CFTNA103J50 C 103 CFTNA473J50 C 105 CFTNA154J50 C 107 CFTNA474J50 C 110 CFTNA273J50 C 111 CFTNA224J50 C 112 CCSRCH271J50 C 113 CEAT4R7M50 C 114 CFTNA103J50 C 115 CFTNA103J50 C 116 CFTNA103J50 C 117 CFTNA103J50 C 118 CFTNA824J50 C 119 CFTNA824J50 C 120 CFTNA824J50 C 121 CFTNA824J50 C 122 CFTNA103J50 C 123 CFTNA103J50 C 124 CFTNA103J50 C 125 CFTNA103J50 C 201 CEAT100M16 C 202 CEATR47M50 C 203 CEAT471M16 C 204 CEAT100M50 C 301 CEAT100M50 C 302 CEAT100M50 C 303 CEAT100M50 C 304 CEAT100M50 C 305 CEAT1R0M50 C 306 CEAT1R0M50 C 307 CEATR22M50 C 308 CEAT1R0M50 C 309 CKSRYB223K25 C 310 CKSRYB103K50 C 311 CKSRYB103K50 C 312 CKSRYB104K25 C 313 CKSRYB473K50 C 314 CKSRYB224K16 C 315 CKSRYB473K50 C 321 CCSRCH101J50 C 322 CCSRCH101J50 C 325 CKSRYB224K16 C 326 CKSRYB224K16 C 327 CKSRYB682K50 C 328 0.1µF HCE0003 C 329 0.1µF HCE0003 C 330 CKSRYB103K50 C 341 1µF HCE0004 C 342 0.1µF HCE0003 C 343 100µF/100V HCH0026 C 344 0.1µF HCE0003 C 346 1µF HCE0004 C 347 560pF HCE0002 C 352 3300µF/100V HCH0029 C 353 CKSRYB332K50 C 354 CKSRYB332K50 C 355 CKSRYB332K50 C 360 4.7µF HCE0005 C 361 22µF/100V HCH0028 C 362 22µF/100V HCH0028 C 363 3300µF/100V HCH0029 C 364 CQMA472J50 C 365 CQMA472J50 C 366 CEAT220M50 C 370 CEAT101M25 C 371 CEAT101M25 C 600 CKSRYB104K25 C 601 CKSRYB223K50 C 602 CFTNA103J50 C 603 CFTNA103J50 C 604 CEAT100M50 C 605 CFTNA223J50 C 606 CEAT100M50 C 607 CFTNA223J50 C 609 CFTNA223J50 C 610 CFTNA105J50 C 611 CFTNA103J50 C 612 CEAT471M25 C 613 CEAT220M50 C 614 CFTNA103J50 C 615 CQMA102J50 C 616 CFTNA223J50 C 617 CEAT471M25 C 618 CKSRYB332K50 C 619 CKSRYB472K50 C 620 CQMA472J50 C 621 4700µF/25V HCH0022 C 622 4700µF/25V HCH0022 C 623 4700µF/25V HCH0022 C 624 CQMA472J50 C 625 CQMA472J50 C 626 4700µF/25V HCH0022 C 627 4700µF/25V HCH0022 C 628 4700µF/25V HCH0022 C 629 CQMA472J50 C 630 CFTNA103J50 C 631 220µF/10V HCH0012 C 632 CFTNA473J50 C 633 CFTNA223J50 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 24 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW C 634 CFTNA473J50 C 635 CEAT471M25 C 636 CFTNA564J50 C 637 CFTNA564J50 C 638 CEAT1R0M50 C 639 CEAT220M50 C 640 CKSRYB472K50 C 641 CFTNA103J50 C 642 CKSRYB103K50 C 643 CKSRYB103K50 C 644 CEAT100M50 C 664 CEAT100M50 C 698 CEAT220M50 C 699 CEAT220M50 C 700 CQMA102K2E C 701 CQMA102K2E C 702 3900µF/100V HCH0023 C 703 3900µF/100V HCH0023 C 704 3900µF/100V HCH0023 C 705 3900µF/100V HCH0023 C 706 3900µF/100V HCH0023 C 707 3900µF/100V HCH0023 C 708 3300p HCH0029 C 709 3300p HCH0029 C 724 CEAT100M50 C 725 CEAT100M50 C 726 CEAT470M25 C 727 CEAT470M25 C 728 0.1µF HCE0003 C 729 0.1µF HCE0003 C 730 CFTNA104J50 C 731 CFTNA104J50 C 732 CFTNA334J50 C 734 220µF/35V HCH0032 C 735 220µF/35V HCH0032 C 736 CEAT100M50 C 737 CEAT100M50 C 740 3300pF HCH0029 C 741 3300pF HCH0029 C 742 3300pF HCH0029 C 743 3300pF HCH0029 C 800 CKSRYB471K50 C 801 CEAT100M16 C 802 CQMA472J50 C 803 CCSRCH271J50 C 804 CCSRCH271J50 C 805 CFTNA103J50 C 806 CKSRYB471K50 C 807 CEAT100M16 C 808 CCSRCH271J50 C 809 CCSRCH271J50 C 810 CFTNA103J50 C 811 CFTNA103J50 C 812 CQMA472J50 C 813 CKSRYB471K50 C 814 CEAT100M16 C 815 CKSRYB272K50 C 816 CCSRCH271J50 C 817 CFTNA103J50 C 818 CFTNA103J50 C 819 CFTNA104J50 C 820 CKSRYB272K50 C 822 CEAT100M16 C 823 CKSRYB332K50 C 824 CKSRYB332K50 C 826 CFTNA103J50 C 830 CKSRYB332K50 C 831 CKSRYB272K50 C 890 CKSRYB272K50 C 891 CFTNA103J50 C 892 CFTNA103J50 C 901 220µF/10V HCH0012 6. ADJUSTMENT There is no information to be shown in this chapter. =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No. --- ------ ------------------------------------------ ------------------------- www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 25 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW 1 1 - Removing the Case (Fig.1) - Removing the Amp Unit (Fig.2) Remove the seven screws. Remove the two screws. Fig.1 Fig.2 Case 2 Remove the screw. 3 Remove the five screws and then remove the Panel. 2 Remove the screw. 2 1 1 1 3 3 3 3 3 3 4 Remove the two screws. 5 Remove the two screws and then remove the Panel. 6 Remove the seventeen screws. Panel Panel Amp Unit 1 1 1 1 3 Remove the six screws and then remove the Case. 1 1 2 3 3 3 3 3 4 4 5 5 6 6 7 7 7 7 7 7 7 7 7 7 7 7 7 7 7 7 Remove the fifteen screws and then remove the Amp Unit. 7. GENERAL INFORMATION 7.1 DIAGNOSIS 7.1.1 DISASSEMBLY www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 26 1 2 3 4 1 2 3 4 F E D C B A PRS-D5000SPL/X1H/EW 7.1.2 CONNECTOR FUNCTION DESCRIPTION www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com 27 5 6 7 8 F E D C B A 5 6 7 8 PRS-D5000SPL/X1H/EW 8. OPERATIONS Bass Boost Frequency Control You can select a bass boost frequency from 40 to 120 Hz with the bass boost control. Power Indicator The power indicator lights when the power is switched on. Bass Boost Level Control Bass boost level control can boost the level around the frequency selected by the bass boost frequency control from 0 to 12 dB. Cut Off Frequency Control for LPF You can select a cut off frequency from 40 to 240 Hz. Gain Control If the sound level is too low, even when the volume of the car stereo used along with this power amplifier is turned up, turn gain control on the front of the power amplifier clockwise. If the sound distorts when the volume is turned up, turn the gain control counter-clockwise. • When using with an RCA equipped car stereo (standard output of 500 mV), set to the NORMAL position. When using with an RCA equipped Pioneer car stereo with max. output of 4 V or more, adjust level to match the car stereo output level. • For synced amplifier’s gain control, see the “Setting the Gain for synced amplifier” section. BFC (Beat Frequency Control) Switch If you hear a beat while listening to an MW/LW broadcast with your car stereo, change the BFC switch using a small standard tip screwdriver. Slope Select Switch You can select a slope for the LPF from –18 and –24 dB. Subsonic Select Switch The subsonic filter cuts inaudible fre- quencies below 20 Hz to eliminate unwanted vibrations and minimize power loss. MODE SELECT Switch You can select amplifier’s sync mode from MASTER, SYNC and SYNC INV. For the position of the MODE SELECT switch, see the “Connecting the Speaker wires” section. (EW model) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com