ORDER NO. PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2006 PRS-D1000M/XU/UC CRT3663 CLASS D MONO AMPLIFIER PRS-D1000M/XU/UC PRS-D1000M/XU/EW5 PRS-D1000M/XU/ES For details, refer to "Important Check Points for Good Servicing". K-ZZA. MAY 2006 Printed in Japan www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 2 1 2 3 4 1 2 3 4 C D F A B E SAFETY INFORMATION CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 - Service Precaution • You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. • Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. • The area where the temperature gets high as a completely assembled product is the heat sink. As a unit, on the other hand, sub-heat sink and the periphery of the sub-heat sink are the areas where the temperature gets high. • There is a danger for electrical shock in the periphery of an area where “High Voltage Attention” is indicated on the printed circuit board due to a high voltage being generated during operation. Therefore, be careful when working around such areas. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 3 5 6 7 8 5 6 7 8 C D F A B E [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. 0 Safe environment should be secured during servicing. When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 4 1 2 3 4 1 2 3 4 C D F A B E CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SPECIFICATIONS ............................................................................................................................................ 5 2. EXPLODED VIEWS AND PARTS LIST ............................................................................................................ 6 2.1 PACKING ................................................................................................................................................... 6 2.2 EXTERIOR................................................................................................................................................. 8 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM.......................................................................................... 10 3.1 SCHEMATIC DIAGRAM(GUIDE PAGE) .................................................................................................. 10 3.2 REMOTE CONTROL UNIT...................................................................................................................... 16 4. PCB CONNECTION DIAGRAM ..................................................................................................................... 18 4.1 AMP PCB................................................................................................................................................. 18 4.2 CONTROL PCB ....................................................................................................................................... 22 4.3 LED PCB.................................................................................................................................................. 24 4.4 REMOTE CONTROL UNIT...................................................................................................................... 25 5. ELECTRICAL PARTS LIST ............................................................................................................................ 26 6. ADJUSTMENT ............................................................................................................................................... 32 6.1 OFFSET VOLTAGE ADJUSTMENT......................................................................................................... 32 7. GENERAL INFORMATION............................................................................................................................. 33 7.1 DIAGNOSIS ............................................................................................................................................. 33 7.1.1 DISASSEMBLY ..................................................................................................................................... 33 7.1.2 CONNECTOR FUNCTION DESCRIPTION.......................................................................................... 34 8. OPERATIONS ................................................................................................................................................ 35 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 5 5 6 7 8 5 6 7 8 C D F A B E 1. SPECIFICATIONS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 6 1 2 3 4 1 2 3 4 C D F A B E 2. EXPLODED VIEWS AND PARTS LIST 2.1 PACKING NOTES : • Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. • The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. • Screw adjacent to mark on the product are used for disassembly. • For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) " 17 6 16 11 7 14 4 5 2 10 1 4 3 15 8 9 12 13 18 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 7 5 6 7 8 5 6 7 8 C D F A B E (1) PACKING SECTION PARTS LIST (2) CONTRAST TABLE PRS-D1000M/XU/UC , PRS-D1000M/XU/EW5 and PRS-D1000M/XU/ES are constructed the same except for the following: Owner's Manual Mark No. Description Part No. 1 Cord Assy CDE7804 2 Screw Assy CEA5328 3 Screw BYC30P100FTB 4 Screw BYC40P180FTB * 5 Polyethylene Sheet CNM4338 6 Polyethylene Bag CEG1116 7-1 Owner's Manual See Contrast table(2) 7-2 Owner's Manual See Contrast table(2) 7-3 Caution Card YRP5001 * 7-4 Warranty Card See Contrast table(2) * 7-5 Warranty Card See Contrast table(2) 8 Remote Control Assy CXC4064 * 9 Polyethylene Bag CEG1171 10 Cord Assy YDE5010 11 Polyethylene Bag See Contrast table(2) 12 Carton See Contrast table(2) 13 Contain Box See Contrast table(2) 14 Protector YHP5006 15 Protector YHP5007 16 Protector YHP5012 17 Protector YHP5013 18 Shaft YLP5001 Mark No. Description Part No. Mark No. Description PRS-D1000M/XU/UC PRS-D1000M/XU/EW5 PRS-D1000M/XU/ES 7-1 Owner's Manual CRD4120 CRD4119 CRD4121 7-2 Owner's Manual Not used Not used CRD4122 * 7-4 Warranty Card CRY1157 CRY1157 Not used * 7-5 Warranty Card CRY1070 Not used Not used 11 Polyethylene Bag YEG5004 YEG5003 YEG5003 12 Carton CHG5908 CHG5907 CHG5909 13 Contain Box CHL5908 CHL5907 CHL5909 Part No. Language CRD4120 English, French, Spanish CRD4119 English, Spanish, German, French, Italian, Dutch, Russian CRD4121 English, Spanish CRD4122 Arabic, Portuguese(B) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 8 1 2 3 4 1 2 3 4 C D F A B E 2.2 EXTERIOR A A D A B C 53 47 47 6 56 5 42 40 43 41 55 44 8 9 8 8 33 32 8 34 8 11 10 27 28 8 53 1 54 3 3 4 4 4 4 4 4 4 4 4 49 4 2 2 12 16 7 12 50 51 52 2 2 9 9 9 18 58 21 17 22 23 25 24 13 57 36 36 46 45 45 46 46 48 46 9 26 35 15 14 38 29 30 31 8 37 37 39 19 20 : GYA-009 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 9 5 6 7 8 5 6 7 8 C D F A B E (1) EXTERIOR SECTION PARTS LIST (2) CONTRAST TABLE PRS-D1000M/XU/UC , PRS-D1000M/XU/EW5 and PRS-D1000M/XU/ES are constructed the same except for the following: Mark No. Description Part No. 1 Screw BBZ30P060FTB 2 Screw BBZ30P100FTB 3 Screw BSZ30P060FTC 4 Screw(M3 x 8) CBA2011 5 Heat Sink CNR1880 6 Cover See Contrast table(2) 7 Amp Unit CWH1327 8 Screw BBZ30P080FSN 9 Screw(M3 x 8) CBA2011 10 Pin Jack(CN201) CKB1079 11 Connector(CN241) CKS4962 12 Holder CND2466 13 Spacer CNM9570 14 Sub Heat Sink CNR1882 15 Sub Heat Sink YNR5010 16 Plate Unit CXC6603 17 Terminal(CN105) VNF1084 18 Terminal(CN202) VNF1084 19 Terminal(CN301) VNF1084 20 Terminal(CN302) VNF1084 21 Terminal(CN303) VNF1084 22 Terminal(CN304) VNF1084 23 Terminal(CN601) VNF1084 24 Terminal(CN901) VNF1084 25 Terminal(CN905) VNF1084 26 Cord Assy(CN801) YDE5017 27 Terminal(CN305) YKE5001 28 Terminal(CN306) YKE5001 29 Terminal(CN906) YKE5002 30 Fuse Holder(CN903) YKR5001 31 Fuse Holder(CN904) YKR5001 32 Connector(CN101) YKS5008 33 Connector(CN103) YKS5009 34 Connector(CN902) YKS5010 35 Holder YND5002 36 Insulator YNM5045 37 Cushion YNN5001 38 Sub Heat Sink CNR1883 39 Spacer YNS5118 40 Remote Control Assy CXC4064 41 Cover CNS8141 42 Remote Control Unit CWM9848 43 Connector(CN1351) CKS4962 44 Spring CBL1692 45 Screw PPZ20P060FTB 46 Screw PPZ30P100FTB 47 Screw(M6 X 10) YBA5001 48 Panel YNB5004 49 Case YNB5006 50 Badge Unit See Contrast table(2) 51 Lighting Conductor Unit YXA5176 52 Lighting Conductor Unit YXA5177 53 Screw BPZ20P100FTB 54 Grille CNS8140 55 Knob Unit CXC4335 > 56 Fuse(40 A)(FU901, FU902) CEK1332 57 Choke Coil(L601, L602) CTH1351 58 LED(D906) NSPB346BS-5859 Mark No. Description Part No. Mark No. Description PRS-D1000M/XU/UC PRS-D1000M/XU/EW5 PRS-D1000M/XU/ES 6 Cover CNR1885 CNR1881 CNR1881 50 Badge Unit YXA5136 YXA5135 YXA5135 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 10 1 2 3 4 1 2 3 4 C D F A B E 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM 3.1 SCHEMATIC DIAGRAM(GUIDE PAGE) A-a A-b A-a A-b A-b A-a Large size SCH diagram Guide page Detailed page Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". A-a A B > B CONTROL PCB D CN1351 220 µH 220 µH 20K(E) 10K(A) BB ON GAIN TYP -3.8 dBs RCA IN(50 Hz) 400 mVrms to 6.5 Vrms = -5.74 dBs to 18.5 dBs -3.8 dBs -4.0 dBs -4.1 dBs 4.1 dBs 7.9 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 11 5 6 7 8 5 6 7 8 C D F A B E A-b A C B LED PCB > > C A AMP PCB AMP UNIT Consists of AMP PCB CONTROL PCB LED PCB 18.25 µH 50 µH Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022 ← ← The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. 10K(B) 4.1 dBs 7.9 dBs 7.9 dBs 4.8 dBs 40.8 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 12 1 2 3 4 1 2 3 4 C D F A B E A-a A-b A-b B 1 2 3 4 A AMP PCB AMP UNIT Consists of AMP PCB CONTROL PCB LED PCB 18.25 µH Decimal points for resistor and capacitor fixed values are expressed as : 2.2 2R2 0.022 R022 ← ← The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. NOTE : Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. 10K(B) 7.9 dBs 4.8 dBs 40.8 dBs www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 13 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-b C 5 6 7 LED PCB > > C 50 µH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 14 1 2 3 4 1 2 3 4 C D F A B E A-a A-b A-a A-a A-b A-a B B 1 2 3 4 > B CONTROL PCB 20K(E) 10K(A) BB ON GAIN TYP -3.8 dBs RCA IN(50 Hz) 400 mVrms to 6.5 Vrms = -5.74 dBs to 18.5 dBs -3.8 dBs -4.0 dBs -4.1 dBs 4.1 dBs 7.9 dBs 7.9 d www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 15 5 6 7 8 5 6 7 8 C D F A B E A-a A-b A-a A-b A-a C 5 6 7 > D CN1351 220 µH 220 µH www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 16 1 2 3 4 1 2 3 4 C D F A B E 3.2 REMOTE CONTROL UNIT D A CN241 BASS BOOST D REMOTE CONTROL UNIT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 17 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 18 1 2 3 4 1 2 3 4 C D F A B E 4. PCB CONNECTION DIAGRAM 4.1 AMP PCB Capacitor Connector P.C.Board Chip Part A A AMP PCB SIDE B SIDE A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 1 X 190 180 170 160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y FRONT FUSE BFC FUSE SPEA POWER TERMINAL 1 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 19 5 6 7 8 5 6 7 8 C D F A B E A SIDE A 40 150 170 180 190 200 210 220 230 240 250 260 270 280 290 160 B CN101 RCA SPEAKER OUTPUT SPEAKER OUTPUT 5 2 1 6 7 4 3 8 D CN1351 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 20 1 2 3 4 1 2 3 4 C D F A B E A A AMP PCB 140 150 170 180 190 200 210 220 230 240 250 260 270 280 290 160 1 2 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 21 5 6 7 8 5 6 7 8 C D F A B E A SIDE B 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 X 190 180 170 160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 0 Y C CN801 1 2 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 22 1 2 3 4 1 2 3 4 C D F A B E 4.2 CONTROL PCB B B CONTROL PCB B CONTROL PCB A CN103 POWER MODE INPUT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 23 5 6 7 8 5 6 7 8 C D F A B E B SIDE A SIDE B SUBSONIC MODE SELECT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 24 1 2 3 4 1 2 3 4 C D F A B E 4.3 LED PCB C C LED PCB C LED PCB SIDE A SIDE B A CN902 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 25 5 6 7 8 5 6 7 8 C D F A B E 4.4 REMOTE CONTROL UNIT D D REMOTE CONTROL UNIT D REMOTE CONTROL UNIT SIDE A SIDE B 5 4 3 2 1 1 3 2 4 BASS BOOST 12dB 9dB 6dB 0dB A CN241 1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 26 1 2 3 4 1 2 3 4 C D F A B E 5. ELECTRICAL PARTS LIST NOTE: • Parts whose parts numbers are omitted are subject to being not supplied. • The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... • The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. • Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No. Part No. Unit Number: CWH1327 Unit Name : Amp Unit Unit Number: CWM9848 Unit Name : Remote Control Unit Amp Unit Consists of Amp PCB Control PCB LED PCB ABC Unit Number: CWH1327 Unit Name : Amp Unit MISCELLANEOUS IC 111 IC NJM2068MD IC 112 IC NJM2068MD IC 131 IC NJM2068MD IC 141 IC NJM2068MD IC 151 IC NJM2068MD IC 161 IC NJM2068MD IC 162 IC NJM2068MD IC 201 (A,259,60) IC NJM2068MD IC 221 (A,268,60) IC NJM2068MD IC 241 (A,229,61) IC MAX309ESE IC 301 (A,256,109) IC TDA7570 IC 431 (A,150,92) IC NJM2903M IC 451 (A,161,92) IC NJM2068MD IC 901 (B,115,94) IC UPC494GS IC 902 (A,116,59) IC PA2027A Q 301 (A,208,121) Transistor 2SC4730 Q 302 (A,285,121) Transistor 2SA1826 Q 303 (A,196,128) Transistor DTC124EK Q 304 (A,272,131) Transistor DTA124EK Q 305 (A,208,127) Transistor 2SC4730 Q 306 (A,208,133) Transistor 2SA1826 Q 307 (A,285,133) Transistor 2SC4730 Q 308 (A,285,127) Transistor 2SA1826 Q 309 (A,208,139) Transistor 2SA1826 Q 310 (A,285,139) Transistor 2SC4730 Q 311 (A,270,149) Transistor 2SC1845 Q 312 (A,270,140) Transistor 2SC1845 Q 313 (A,183,143) Transistor 2SA992 Q 314 (A,183,152) Transistor 2SA992 Q 315 (A,161,187) FET IRFI9640G Q 316 (A,174,187) FET IRFI9640G Q 317 (A,190,187) FET IRFI9640G Q 318 (A,203,187) FET IRFI9640G Q 319 (A,229,187) FET IRFI9640G Q 320 (A,242,187) FET IRFI640G Q 321 (A,258,187) FET IRFI640G Q 322 (A,271,187) FET IRFI640G Q 401 (A,196,87) Transistor DTA124EK Q 402 (A,181,105) Transistor 2SA1576 Q 403 (A,192,87) Transistor DTC124EK Q 404 (A,181,101) Transistor 2SC4081 Q 405 (A,181,97) Transistor 2SC4081 Q 406 (A,177,97) Transistor 2SC4081 Q 407 (A,170,97) Transistor 2SA1576 Q 408 (A,275,92) Transistor DTC144EU Q 441 (A,281,89) Transistor DTC114EK Q 442 (A,281,94) Transistor 2SA1037K Q 443 (A,281,98) Transistor DTC143EK Q 601 (A,81,188) Transistor 2SD2395 Q 602 (A,94,187) Transistor 2SB1566 Q 901 (A,14,82) Transistor FKV550N Q 902 (A,14,69) Transistor FKV550N Q 903 (A,14,56) Transistor FKV550N Q 904 (A,14,150) Transistor FKV550N Q 905 (A,14,137) Transistor FKV550N Q 906 (A,14,124) Transistor FKV550N Q 907 (B,98,92) Transistor 2SD1766 Q 908 (B,98,102) Transistor 2SB1188 Q 909 (B,105,102) Transistor 2SB1188 Q 910 (B,105,92) Transistor 2SD1766 Q 912 (B,131,96) Transistor DTC124EK Q 914 (B,113,73) Transistor 2SA1576 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 27 5 6 7 8 5 6 7 8 C D F A B E Q 915 (B,120,69) Chip Transistor DTC114TUA Q 916 (B,126,69) Transistor 2SC4081 Q 917 (A,109,67) Transistor DTA114EU Q 918 (A,94,67) Transistor 2SB1243 Q 919 (A,112,67) Chip Transistor DTC114TUA Q 920 (B,126,49) Transistor 2SC4081 Q 921 (B,139,49) Digital Transistor DTC124EUA Q 922 (B,131,49) Transistor 2SA1576 Q 923 (B,135,49) Transistor 2SC4081 Q 924 (A,14,94) Transistor FKV550N Q 925 (A,14,163) Transistor FKV550N D 100 (A,226,51) Diode UDZS16(B) D 201 (A,277,54) Diode ERA15-02VH D 202 (A,281,54) Diode ERA15-02VH D 203 (A,252,50) Diode ERA15-02VH D 204 (A,256,50) Diode ERA15-02VH D 242 (A,233,51) Diode UDZS16(B) D 301 (A,234,113) Diode MA111 D 302 (A,234,109) Diode MA111 D 303 (A,198,124) Diode MTZJ8R2(B) D 304 (A,274,127) Diode MTZJ8R2(B) D 305 (A,270,144) Diode MTZJ33(B) D 306 (A,183,148) Diode MTZJ33(B) D 307 (A,181,171) Diode FML22S D 308 (A,202,171) Diode FML22S D 309 (A,231,173) Diode FML22S D 401 (A,194,95) Diode MTZJ24(B) D 402 (A,197,103) Diode MTZJ30(B) D 403 (A,174,90) Diode MA111 D 404 (A,167,104) Diode MTZJ24(B) D 431 (A,151,87) Diode MA111 D 432 (A,148,87) Diode MA111 D 441 (A,284,98) Diode MA111 D 442 (A,281,105) Diode MTZJ3R9(B) D 443 (B,287,84) Diode MA111 D 451 (B,161,88) Diode 1SS355 D 452 (A,162,87) Diode 1SS355 D 453 (A,160,87) Diode 1SS355 D 454 (B,159,88) Diode 1SS355 D 601 (B,85,168) Diode UDZS16(B) D 602 (B,92,168) Diode UDZS16(B) D 603 (A,54,188) Diode FML22S D 604 (A,67,188) Diode FML22R D 801 LED NSPB346BS-5859 D 903 (A,111,75) Diode DAN202U D 904 (A,108,75) Diode DAN202U D 905 (B,120,75) Diode MA111 D 906 (A,233,100) LED NSPB346BS-5859 D 907 (A,130,52) Diode MA111 D 908 (B,99,58) Diode UDZS18(B) D 909 (A,94,58) Diode ERA15-02VH D 910 (B,287,64) Diode DAN202U D 911 (A,98,58) Diode ERA15-02VH D 912 (A,68,59) Diode RM4Z-LFJ4 D 913 (B,135,41) Diode UDZS7R5(B) ZNR201 (B,259,34) Surge Protector CSA30-201N ZNR202 (B,265,34) Surge Protector CSA30-201N ZNR203 (B,256,34) Surge Protector CSA30-201N ZNR204 (B,245,34) Surge Protector CSA30-201N L 201 (A,285,56) Ferri-Inductor CTF1007 Circuit Symbol and No. Part No. L 202 (A,289,56) Ferri-Inductor CTF1007 L 211 (A,252,61) Ferri-Inductor CTF1007 L 301 (A,236,140) Choke Coil 18.25 µH CTH1350 L 601 (A,41,159) Choke Coil 220 µH CTH1351 L 602 (A,69,159) Choke Coil 220 µH CTH1351 L 901 (A,53,62) Choke Coil 50 µH CTH1323 T 901 (A,64,105) Transformer CTT1127 TH901 (A,217,186) Thermistor CCX1013 TH902 (A,25,102) Thermistor CCX1013 TH903 (A,87,85) Thermistor CCX1064 TH904 (A,217,135) Thermistor CCX1064 S 101 Switch(POWER MODE) CSH1021 S 111 Slide Switch(INPUT) CSH1042 S 141 Switch(SUBSONIC) CSH1021 S 161 Switch(MODE SELECT) CSH1029 S 901 (A,100,79) Switch(BFC) HSH-156 VR131 Variable Resistor 20 kΩ(E) CCS1266 VR161 Variable Resistor 10 kΩ(A) CCS1265 VR301 (A,229,112) Semi-fixed 10 kΩ(B) CCP1448 >FU221 (A,250,69) Fuse 3 A CEK1286 >FU901 Fuse 40 A CEK1332 >FU902 Fuse 40 A CEK1332 RESISTORS R 101 RS1/16S104J R 111 RD1/4PU683J R 112 RD1/4PU683J R 113 RS1/16S471J R 114 RS1/16S471J R 115 RS1/16S223J R 116 RS1/16S223J R 117 RS1/16S1002D R 118 RS1/16S1002D R 119 RS1/16S1002D R 120 RS1/16S1002D R 121 RS1/16S1002D R 122 RS1/16S1002D R 123 RS1/16S1002D R 124 RS1/16S1002D R 125 RS1/16S222J R 126 RS1/16S222J R 131 RS1/16S222J R 132 RS1/16S222J R 133 RS1/16S222J R 141 RS1/16S153J R 142 RS1/16S223J R 143 RS1/16S682J R 144 RS1/16S473J R 151 RS1/16S331J R 152 RS1/16S273J R 153 RS1/16S222J R 154 RS1/16S473J R 155 RS1/16S182J R 156 RS1/16S101J R 161 RS1/16S222J R 162 RS1/16S391J R 163 RS1/16S682J R 164 RS1/16S202J R 165 RS1/16S472J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 28 1 2 3 4 1 2 3 4 C D F A B E R 166 RS1/16S472J R 167 RS1/16S222J R 168 RS1/16S101J R 169 RS1/16S822J R 170 RS1/16S153J R 171 RS1/16S152J R 211 (B,258,42) RS1/16S471J R 212 (B,259,55) RS1/16S223J R 213 (A,263,60) RS1/16S1002D R 214 (A,262,66) RS1/16S1002D R 215 (A,259,66) RS1/16S1002D R 216 (A,255,63) RS1/16S1002D R 221 (B,260,42) RS1/16S471J R 222 (A,272,62) RS1/16S472J R 241 (B,230,48) RS1/16S472J R 242 (A,228,51) RS1/16S102J R 243 (A,231,51) RS1/16S102J R 244 (A,224,53) RS1/16S473J R 245 (B,230,54) RS1/16S473J R 246 (A,224,68) RS1/16S473J R 247 (A,229,67) RS1/16S104J R 248 (A,230,67) RS1/16S122J R 249 (A,232,67) RS1/16S471J R 250 (A,233,67) RS1/16S101J R 301 (A,232,107) RS1/16S472J R 302 (A,229,116) RS1/16S472J R 303 (A,232,113) RS1/16S153J R 304 (A,232,110) RS1/16S203J R 305 (A,245,97) RS1/16S101J R 306 (A,245,100) RS1/16S103J R 307 (A,267,126) RS1/2PMF123J R 309 (A,283,115) RD1/4PU102J R 310 (A,283,111) RD1/4PU561J R 311 (A,246,122) RS1/16S101J R 312 (B,271,116) RS1/16S101J R 313 (A,196,135) RD1/4PU183J R 314 (A,270,135) RD1/4PU183J R 315 (B,197,118) RS1/16S103J R 316 (B,271,120) RS1/16S103J R 317 (A,200,134) RS1/2PMF241J R 318 (A,217,125) RS1/2PMF221J R 319 (A,293,125) RS1/2PMF221J R 320 (A,277,135) RS1/2PMF241J R 321 (B,276,142) RS1/16S393J R 322 (B,187,146) RS1/16S393J R 323 (A,201,150) RS2PMF151J R 324 (A,219,159) RD1/4PU0R0J R 325 (A,223,159) RD1/4PU100J R 326 (A,293,169) RD1/4PU100J R 327 (A,289,169) RD1/4PU0R0J R 328 (A,289,155) RS2PMF121J R 329 (A,282,145) RS1/2PMF223J R 330 (A,215,159) RS1/2PMF4R7J R 331 (A,293,138) RS1/2PMF4R7J R 332 (A,194,145) RS1/2PMF223J R 333 (A,219,168) RD1/4PU104J R 334 (A,279,171) RD1/4PU104J R 335 (B,210,160) RS1/16S121J R 336 (A,215,171) RD1/4PU272J R 337 (A,171,178) RS1/2PMF100J Circuit Symbol and No. Part No. R 338 (A,188,178) RS1/2PMF100J R 339 (A,193,178) RS1/2PMF100J R 340 (A,210,178) RS1/2PMF100J R 341 (A,223,178) RS1/2PMF100J R 342 (A,248,178) RS1/2PMF100J R 343 (A,261,178) RS1/2PMF100J R 344 (A,265,178) RS1/2PMF100J R 345 (A,268,171) RD1/4PU272J R 346 (B,287,153) RS1/16S121J R 347 (A,209,160) 0.1 Ω CCN1158 R 348 (A,283,159) 0.1 Ω CCN1158 R 349 (A,253,169) RS2PMF220J R 350 (A,143,40) RD1/4PU473J R 351 (A,156,55) RS2PMF100J R 352 (A,175,55) RS2PMF100J R 353 (A,156,60) RS2PMF100J R 354 (A,175,60) RS2PMF100J R 355 (B,258,84) RS1/16S222J R 357 (A,210,145) RS2PMF151J R 358 (A,294,155) RS2PMF121J R 401 (A,152,86) RS1/16S473J R 402 (A,197,95) RD1/4PU473J R 403 (A,194,103) RD1/4PU393J R 404 (A,187,104) RD1/4PU122J R 405 (A,184,104) RD1/4PU223J R 406 (A,174,103) RS1/2PMF822J R 407 (A,177,104) RD1/4PU103J R 408 (A,177,90) RD1/4PU472J R 409 (A,170,104) RD1/4PU103J R 410 (A,181,90) RD1/4PU822J R 411 (A,273,91) RS1/16S101J R 431 (B,166,110) RS1/16S113J R 432 (B,161,110) RS1/16S184J R 433 (B,156,110) RS1/16S163J R 434 (B,151,87) RS1/16S473J R 435 (B,153,87) RS1/16S222J R 436 (B,153,94) RS1/16S222J R 437 (B,149,87) RS1/16S473J R 438 (B,147,87) RS1/16S163J R 439 (B,146,110) RS1/16S152J R 440 (B,151,110) RS1/16S204J R 441 (A,287,96) RD1/4PU102J R 442 (A,291,105) RD1/4PU223J R 443 (A,291,96) RD1/4PU202J R 444 (A,288,91) RD1/4PU222J R 445 (A,288,87) RD1/4PU333J R 451 (B,166,96) RS1/16S563J R 452 (B,164,95) RS1/16S103J R 453 (B,163,88) RS1/16S563J R 454 (B,159,83) RS1/16S333J R 455 (B,161,95) RS1/16S153J R 456 (B,159,95) RS1/16S563J R 457 (B,157,88) RS1/16S563J R 458 (B,157,95) RS1/16S103J R 459 (A,158,86) RS1/16S103J R 601 (A,83,174) RD1/4PU103J R 602 (A,94,174) RD1/4PU103J R 603 (A,170,159) RS2PMF470J R 604 (A,165,166) RS2PMF470J R 605 (A,82,138) RD1/2PM220J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 29 5 6 7 8 5 6 7 8 C D F A B E R 606 (A,49,138) RD1/2PM220J R 607 (A,63,137) RD1/2PM220J R 608 (A,184,113) RD1/2PM102J R 901 (A,33,70) RD1/2PM220J R 902 (A,37,126) RD1/2PM220J R 903 (A,23,84) RD1/2PM121J R 904 (A,23,71) RD1/2PM121J R 905 (A,23,65) RD1/2PM121J R 906 (A,19,150) RD1/2PM121J R 907 (A,23,140) RD1/2PM121J R 908 (A,23,127) RD1/2PM121J R 909 (B,97,106) RS1/16S472J R 910 (B,106,106) RS1/16S472J R 911 (B,110,105) RS1/8S472J R 912 (B,112,105) RS1/8S472J R 914 (B,121,108) RS1/16S563J R 915 (B,128,100) RS1/16S183J R 916 (B,121,103) RS1/16S104J R 917 (B,117,103) RS1/16S103J R 918 (B,127,89) RS1/16S472J R 919 (B,131,89) RS1/16S472J R 920 (B,129,89) RS1/16S472J R 921 (B,108,76) RS1/16S272J R 922 (B,106,75) RS1/16S272J R 923 (B,103,74) RS1/16S272J R 924 (B,110,76) RS1/16S272J R 925 (B,109,83) RS1/16S105J R 926 (B,120,86) RS1/16S242J R 927 (B,126,84) RS1/16S0R0J R 928 (B,126,79) RS1/16S273J R 929 (B,113,83) RS1/16S153J R 930 (B,120,84) RS1/16S182J R 931 (B,114,78) RS1/16S101J R 932 (B,114,76) RS1/16S362J R 933 (B,113,70) RS1/16S223J R 934 (B,114,67) RS1/16S103J R 935 (B,122,75) RS1/16S392J R 936 (B,110,67) RS1/16S223J R 937 (B,105,67) RS1/16S223J R 938 (A,145,74) RD1/4PU271J R 939 (A,148,74) RD1/4PU271J R 940 (A,128,58) RD1/4PU101J R 941 (A,138,74) RD1/4PU271J R 942 (A,142,74) RD1/4PU271J R 943 (A,132,58) RD1/4PU472J R 944 (A,98,67) RD1/4PU221J R 945 (A,101,67) RD1/4PU152J R 946 (A,105,67) RS1/16S223J R 947 (A,146,87) RS1/16S151J R 948 (B,121,49) RS1/16S472J R 949 (B,123,49) RS1/16S0R0J R 950 (B,125,46) RS1/16S104J R 951 (B,115,49) RS1/16S682J R 952 (B,103,52) RS1/16S682J R 953 (B,113,58) RS1/16S103J R 954 (B,142,49) RS1/16S683J R 956 (B,131,46) RS1/16S222J R 957 (B,128,47) RS1/16S472J R 958 (B,136,44) RS1/16S103J R 959 (B,134,44) RS1/16S103J Circuit Symbol and No. Part No. R 960 (B,129,43) RS1/16S473J R 961 (A,128,39) RD1/4PU222J R 962 (A,23,97) RD1/2PM121J R 963 (A,24,150) RD1/2PM121J CAPACITORS C 101 CEAT100M50 C 102 CEAT100M50 C 111 CEAT100M50 C 112 CEAT100M50 C 113 CCSRCH471J50 C 114 CCSRCH471J50 C 115 CEAT100M50 C 116 CEAT100M50 C 117 CKSRYB103K50 C 118 CKSRYB103K50 C 119 CCSRCH271J50 C 120 CCSRCH271J50 C 121 CCSRCH271J50 C 122 CCSRCH271J50 C 123 CKSRYB472K50 C 124 CKSRYB472K50 C 125 CKSRYB103K50 C 126 CKSRYB103K50 C 131 CFTNA154J50 C 132 CFTNA154J50 C 133 CKSRYB103K50 C 134 CKSRYB103K50 C 135 CFTNA154J50 C 136 CFTNA474J50 C 141 CFTNA474J50 C 142 CFTNA474J50 C 143 CFTNA474J50 C 144 CFTNA474J50 C 145 CKSRYB103K50 C 146 CKSRYB103K50 C 151 CEAT4R7M50 C 152 CFTNA224J50 C 153 CKSRYB103K50 C 154 CKSRYB103K50 C 155 CFTNA273J50 C 161 CKSRYB272K50 C 162 CKSRYB103K50 C 163 CKSRYB103K50 C 164 CKSRYB272K50 C 165 CKSRYB272K50 C 166 CKSRYB103K50 C 167 CKSRYB103K50 C 168 CFTNA223J50 C 201 (B,272,46) CKSQYB102K50 C 202 (B,279,46) CKSQYB102K50 C 203 (B,272,44) CKSQYB103K50 C 204 (B,279,48) CKSQYB103K50 C 205 (B,278,61) CKSQYB103K50 C 206 (B,276,61) CKSQYB102K50 C 211 (B,259,50) CCSRCH471J50 C 212 (A,262,50) CEAT100M50 C 213 (A,263,56) CKSRYB103K50 C 214 (A,262,67) CKSRYB272K50 C 215 (A,259,67) CKSRYB272K50 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 30 1 2 3 4 1 2 3 4 C D F A B E C 216 (A,256,66) CKSRYB103K50 C 217 (A,252,69) CKSRYB104K50 C 219 (B,249,59) CKSQYB103K50 C 221 (A,269,50) CEAT100M50 C 222 (A,272,59) CKSRYB272K50 C 223 (A,272,56) CKSRYB103K50 C 224 (A,268,66) CKSRYB103K50 C 225 (B,249,50) CKSQYB102K50 C 226 (B,249,48) CKSQYB103K50 C 227 (B,244,64) CKSQYB103K50 C 228 (B,244,62) CKSQYB102K50 C 229 (B,221,59) CKSQYB105K16 C 230 (B,248,45) CKSQYB103K50 C 241 (A,227,48) CKSQYB102K50 C 242 (A,232,48) CKSQYB102K50 C 243 (A,224,55) CKSRYB473K50 C 244 (A,228,55) CKSRYB103K50 C 245 (A,227,68) CKSRYB103K50 C 246 (A,224,66) CKSRYB473K50 C 301 (A,240,94) CEAT1R0M50 C 302 (A,256,90) CFTNA104J50 C 303 (A,250,93) CEAT100M50 C 304 (A,235,89) CEAT100M50 C 305 (A,245,89) CEAT100M50 C 306 (A,262,93) CEAT100M50 C 307 (A,240,101) CEATR22M50 C 308 (A,268,93) CEAT1R0M50 C 309 (A,274,98) CEAT1R0M50 C 310 (A,274,104) CEAT100M50 C 311 (A,274,111) CEATR47M50 C 312 (A,268,108) CKSRYB332K50 C 313 (A,245,110) CKSRYB103K50 C 314 (A,239,109) CEAT101M25 C 315 (B,279,113) CKSRYB223K50 C 316 (A,268,109) CKSRYB332K50 C 317 (A,268,112) CKSRYB104K50 C 318 (A,255,120) CKSRYB332K50 C 319 (A,239,118) CEAT101M50 C 320 (A,255,122) CKSRYB224K16 C 321 (A,251,122) CKSRYB332K50 C 322 (A,248,122) CKSRYB473K50 C 323 (B,271,118) CKSRYB473K50 C 324 (B,211,118) CCSRCH101J50 C 325 (B,281,120) CCSRCH101J50 C 326 (A,198,120) CFTNA223J50 C 327 (A,274,122) CFTNA223J50 C 328 (B,210,162) CKSRYB224K16 C 329 (A,223,168) CFTNA104J2A C 330 (A,274,171) CFTNA104J2A C 331 (B,287,157) CKSRYB224K16 C 332 (B,217,167) CKSRYB682K50 C 333 (B,271,169) CKSRYB103K50 C 334 (A,233,159) 1 µF/250 V CCE1035 C 335 (A,233,166) 1 µF/250 V CCE1035 C 336 (A,268,158) 100 µF/100 V CEHAZL101M2A(P45) C 337 (A,204,158) CFTNA104J2A C 338 (A,277,158) CFTNA104J2A C 339 (A,196,158) 100 µF/100 V CEHAZL101M2A(P45) C 340 (A,244,160) CQMBA561J2A C 341 (A,259,136) 4.7 µF/250 V CCE1036 Circuit Symbol and No. Part No. C 342 (A,189,57) 10 µF/100 V CEAT100M2A C 343 (A,199,57) 10 µF/100 V CEAT100M2A C 344 (A,193,39) CFTNA103J50 C 345 (A,170,49) CFTNA103J50 C 346 (B,224,48) CKSQYB103K50 C 347 (A,170,44) CFTNA103J50 C 348 (B,226,48) CKSQYB102K50 C 401 (A,187,94) CEANP221M10 C 402 (A,159,106) CEAT220M50 C 403 (A,228,89) CEAT100M50 C 404 (A,201,96) CFTNA104J2A C 405 (A,202,105) CEANP4R7M50 C 431 (A,160,99) CEAT220M50 C 432 (B,155,87) CKSRYB103K50 C 433 (A,145,91) CKSRYB103K50 C 434 (A,150,106) CEANP1R0M50 C 435 (A,150,99) CEAT470M35 C 441 (A,286,105) CEAT100M50 C 451 (A,166,97) CKSRYB103K50 C 452 (A,155,91) CKSRYB103K50 C 453 (A,169,90) CEAT100M50 C 511 (B,249,62) CKSQYB102K50 C 601 (A,159,171) CFTNA104J50 C 602 (A,155,171) CFTNA104J50 C 603 (B,90,159) CKSRYB103K50 C 604 (B,104,172) CKSRYB103K50 C 605 (A,88,159) CEAT470M35 C 606 (A,102,171) CEAT470M35 C 607 (B,83,167) CKSRYB103K50 C 608 (B,90,167) CKSRYB103K50 C 609 (A,88,167) CEAT470M35 C 610 (A,94,167) CEAT470M35 C 611 (A,182,126) CFTNA104J2A C 612 (A,165,152) CFTNA104J2A C 613 (A,129,126) 3 300 µF/71 V CCH1703 C 614 (A,113,152) 3 300 µF/71 V CCH1703 C 615 (A,162,126) 3 300 µF/71 V CCH1703 C 616 (A,145,152) 3 300 µF/71 V CCH1703 C 617 (A,77,138) CQMA102K2E C 618 (A,54,138) CQMA102K2E C 619 (A,72,138) CQMA102K2E C 801 CKSQYB104K50 C 901 (A,81,72) 6 800 µF/16 V CCH1468 C 902 (A,81,54) 6 800 µF/16 V CCH1468 C 903 (A,30,60) CQMA472J50 C 904 (A,32,127) CQMA472J50 C 906 (A,125,102) CFTNA103J2A C 907 (B,119,103) CKSRYB104K50 C 908 (A,106,83) CEAT101M16 C 909 (B,111,86) CKSRYB103K50 C 910 (A,125,93) CEAT2R2M50 C 911 (A,123,83) CEANP221M10 C 912 (B,115,85) CKSRYB102K50 C 913 (B,117,85) CKSRYB472K50 C 914 (A,117,77) CEAT100M50 C 915 (B,112,67) CKSRYB103K50 C 916 (B,107,67) CKSRYB103K50 C 917 (A,233,95) CKSQYB104K50 C 918 (A,140,58) CEAT471M25 C 919 (A,117,69) CEAT220M50 Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 31 5 6 7 8 5 6 7 8 C D F A B E C 920 (A,106,67) CKSRYB103K50 C 921 (A,123,69) CEAT220M50 C 922 (B,105,56) CKSRYB103K50 C 923 (A,103,58) CEAT101M16 C 924 (B,108,58) CKSRYB103K50 C 925 (B,110,51) CKSRYB223K50 C 926 (A,112,49) CEAT100M50 C 927 (B,117,49) CKSRYB223K50 C 928 (A,119,49) CEAT100M50 C 929 (B,139,46) CKSRYB105K10 C 930 (B,71,51) CKSQYB103K50 C 931 (B,131,43) CKSRYB103K50 C 932 (A,90,47) CKSQYB102K50 C 933 (B,125,43) CKSQYB102K50 C 934 (A,90,44) CKSQYB103K50 C 935 (B,123,43) CKSQYB103K50 C 936 (A,90,42) CKSQYB104K50 C 937 (B,120,43) CKSQYB104K50 D Unit Number: CWM9848 Unit Name : Remote Control Unit MISCELLANEOUS Q 1351 (B,21,23) Transistor DTC114EU Q 1352 (B,22,6) Transistor DTC114EU D 1351 (B,12,25) Diode DAN202U D 1352 (B,16,6) Diode DAN202U D 1366 (B,21,11) Diode UDZS16(B) D 1367 (B,29,16) Diode UDZS16(B) S 1351 (A,6,11) Switch(BASS BOOST) CSD1128 RESISTORS R 1351 (B,15,16) RS1/16S103J R 1352 (B,18,18) RS1/16S102J R 1353 (B,31,21) RS1/16S103J R 1354 (B,31,16) RS1/16S102J R 1359 (B,16,8) RS1/16S102J Circuit Symbol and No. Part No. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 32 1 2 3 4 1 2 3 4 C D F A B E 6. ADJUSTMENT 6.1 OFFSET VOLTAGE ADJUSTMENT AMP PCB (SIDE A) RCA SPEAKER OUTPUT SPEAKER OUTPUT POWER TERMINAL 5 2 1 6 7 4 3 8 1 mV Meter Rg = 1k Rg = 1k - Connection Diagram - Offset Voltage Adjustment No. Measurement condition Measurement point Adjustment point Adjustment Method 1 Power on SP OUT VR301 mV Meter : 0 ± 15 mV No load, no input Rg = 1k www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 33 5 6 7 8 5 6 7 8 C D F A B E 7. GENERAL INFORMATION 7.1 DIAGNOSIS 7.1.1 DISASSEMBLY Case 1 1 Fig.1 Fig.2 - Removing the Case (Fig.1) - Removing the Amp Unit (Fig.2) Remove the two screws. Remove the five screws and then remove the Case. Disconnect the connector. Remove the six screws. Remove the nine screws and then remove the Amp Unit. 2 2 3 2 2 2 3 2 2 2 3 3 3 3 3 2 2 2 2 3 3 3 2 1 1 1 Amp Unit www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 34 1 2 3 4 1 2 3 4 C D F A B E 7.1.2 CONNECTOR FUNCTION DESCRIPTION www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 35 5 6 7 8 5 6 7 8 C D F A B E 8. OPERATIONS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 36 1 2 3 4 1 2 3 4 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 37 5 6 7 8 5 6 7 8 C D F A B E www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com PRS-D1000M/XU/UC 38 1 2 3 4 1 2 3 4 C D F A B E - Grease List Name Silicon Grease Jig No. GYA-009 Remarks Between Power TR and Sub Heat Sink www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 http://www.xiaoyu163.com