DVD/VCD/CD PLAYER DVF-3080-S/8100 SERVICE MANUAL © 2004-7 PRINTED IN KOREA B51-5894-00 (K/K) PDF 70% 70% POWRE OUT OUT OUT OUT Y CB CR COMPONENT VIDEO AUDIO VIDEO R L DIGITAL OUT (PCM/BIT STREAM) COAXIAL S VIDEO Panel * (A60-) Tray panel * (A29) Front glass (B03-3945-08) Jack, RCA * (E63-) Case (A01-3925-08) Power cord * (E30-) In compliance with Federal Regulations, following are repro- duction of labels on, or inside the product relating to laser product safety. KENWOOD Corp. certifies this equipment conforms to DHHS Regulations No.21 CFR 1040. 10, Chapter 1, subchapter J. DANGER : Laser radiation when open and interlock defeated. AVOID DIRECT EXPOSURE TO BEAM. Caution : No connection of ground line if disassemble the unit. Please connect the ground line on rear panel, PCBs, Chassis and some others. * Refer to parts list on page 31. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 2 CONTENTS / ACCESSORIES / CAUTIONS Please confirm that the following accessories are present. Audio cord (Red, White) ...(1) (E30-7334-08) : K,P,Y (E30-7335-08) : E,X Batteries (R03/"AAA" -size) ...(2) Remote control unit ...(1) (A70-1660-08) Video cable(Yellow) ...(1) (E30-7332-08) : K,P,Y (E30-7333-08) : E,X Coaxial cable (Black) ...(1) (E30-7336-08) : E,X (E30-7337-08) : K,P,Y The marking of products using lasers (For countries other than U.S.A. and U.S.-Military) The marking this product has been classified as Class 1. It means that there is no danger of hazardous radiation outside the product. Location: Back panel CLASS 1 LASER PRODUCT Caution on condensation Before transporting or moving this unit, carry out the following operations. 1. Set the POWER ON/OFF switch to the ON without loading a disc. 2. Wait a few seconds and verify that the display shown appears. "NO DISC" 3. Set the POWER ON/OFF switch to OFF. Note related to transportation and movement Condensation (of dew) may occur inside the unit when there is a great difference in temperature between this unit and the outside. This unit may not function properly if condensation occurs. In this case, leave the unit for a few hours and restart the operation after the condensa- tion has dried up. Be specially cautious against condensation in the following circum- stances: When this unit is carried from one place to another across a large difference in temperature, when the humidity in the room where this unit is installed increases, etc. "DTS" and "DTS Digital Out" are reg- istered trademarks of Digital Theater Systems, Inc. Manufactured under license from Dolby Laboratories. "Dolby" and the double-D symbol are trademarks of Dolby Laboratories. The microprocessor may fall into malfunction (impossibility to operate erroneous display, etc.) when the power cord is unplugged while power is ON or due to an external factor. In this case, switch off the power, wait for several seconds, and then switch the power on again. Operation to reset ACCESSORIES CAUTIONS CONTENTS / ACCESSORIES / CAUTIONS...............2 DISASSEMBLY FOR REPAIR.....................................3 BLOCK DIAGRAM .......................................................4 DECK MECHANISM ....................................................7 ELECTRICAL TROUBLESHOOTING GUIDE ...........11 WAVEFORMS............................................................15 PC BOARD ................................................................19 CIRCUIT VOLTAGE CHART .....................................21 SCHEMATIC DIAGRAM ............................................23 EXPLODED VIEW .....................................................30 PARTS LIST...............................................................31 SPECIFICATIONS..................................BACK COVER CONTENTS www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 3 DISASSEMBLY FOR REPAIR 1) Insert and push a Driver in the emergency eject hole(A) at the right side, or put the Driver on the Lever(B) of the Gear Emergency and pull the Lever(B) in direction of arrow so that the Tray Disc is ejected about 15~20mm. 2) Pull the Tray Disc until it is separated from the Base Main completely. Fig. How to Reset Parental Lock. 1. Connect the TV set to DVF-3080. 2. Push the power switch of DVF-3080 to be on. 3. Check the display of DVF-3080 shown “NO DISC”. 4. Push the “SETUP” key of remote control and TV has “set up menu” 5. Select the “16:9” on TV. 6. Push #key 1 3 9 7 1 3 9 and ENTER. Push #key again if mistype. 7. Push the power switch of DVF-3080 to be off. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 4 BLOCK DIAGRAM M M DISC SPINDLE MOTOR LOADING MOTOR DVD : A,B,C,D,RF0 CD : A,B,C,D,E,F,RF0 CDMDI,DVDMDI PICK UP KEY Input 6MHz B/Pb IC502 KV802.... KV852.... 1M 8BIT FLASH ROM M-RESET ROMAD[0:19] ROMRD ROMWR MD[00:15] L/R CVBS R/Pr G/Y TV_DAC[0:3] YC VF+ AC 90V~240V 50HZ/60Hz VF- -27VA 5V VD33,VD33D 12V 27MHz PWRCTL 1.8V IC504 AT24C02A EEPROM IC602 OP-AMP RC901 R/C LOAD[+,-] FOCUS[+,-] TRACK[+,-] SPINDLE[+,-] SLED (FEEDING) MOTOR SLED[+,-] M VD33D VD33D VD18/VD33 VD33D/5V BCLK LRCLK DACCLK IC604 MM1623XFBE VIDEO BUFFER IECDAOUT COAXIAL SPDI D2_T[1:3] SCART_16:9 RGB_SEL 3V3M CDLD,DVDLD,SVREF21 5V/8V HOMESW INSW,OUTSW ROMDATA[0:7] 5.2VA IC901 GMS81C2012(Hynix) Front Micom POWER BOARD VFD_RXD S_REQ 5.2VA 8V DMUTE IIC/VFD/DAC_SCK IC503 1M 16BIT 4Bank SDRAM VD33D IIC/VFD/DAC_TXD +12V 5V YC_MIX VIDEO_SW SER3,DAC_ML0 OPEN,CLOSE,SLEGP,SPINDLE,FOCUS,TRACK,SVREF IC506 74LCX373 VD33D GPOPALE DAC_RST DMUTE D2_T[1:3] SCART_16:9 RGB_SEL DAC_RST CD_DVD, VR_CD,VR_DVD CD_DVD_CT XSFGN,XSFGP CN505 EJTAG TRST TDI TDO TMS TCK 3.3V1 3.3V2 VD18 IC601 CS4391 2DAC IC201 IP4504 DRVSB OPU_SEL JACK -27VA/VF+/VF- DIG901 FLD DISPLAY MA[00:11] DMCLK CSJ BA0 BA1 DQM WEJ CASJ RASJ IC501 ALi M3355 1. Overall Block Diagram www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 5 BLOCK DIAGRAM 8VT 5VD -23VA VF+ RECTIFIER LINE FILTER SWITCHING IC TRANS FEED B. 5.2VA VF- RECTIFIER(FLD) RECTIFIER(3.8V) RECTIFIER(10V) LPF LPF RECTIFIER(14V) LPF 12V PWR CTL MULTI REG. 1.8V 3.3V RECTIFIER(5.2V) LPF AC100~240V ON/OFF PICK UP IC501 ALI M3355 DVDPLAYER COMBO CHIP MD IC201 IP4504 Motor Driver IC503 64M SDRAM FLASH ROM EEP ROM DVDLD,CDLD,CD_DVD DVDMDI.CDMDI SVREF21 DVD:A,B,C,D,RFO CD:A,B,C,D,E,F,RFO SLEGP,SPINDLE FOCUS,TRACK DRVSB,CLOSE OPEN,SVREF15 FOCUS+,FOCUS- TRACK+,TRACK- SPINDLE+,SPINDLE- SLED+,SLED- LOAD+,LOAD- OPENSW,CLOSESW,LIMITSW MA[0:11] DQM CLK CS CAS RAS WE MD[0:15] IIC/VFD/DAC_SCK IIC/VFD/DAC_TXD ROMAD[0:21] ROMRD ROMWR ROMDATA[0:7] 2. Power(SMPS) Block Diagram 3. SERVO Block Diagram www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 6 BLOCK DIAGRAM 4. MPEG & MEMORY Block Diagram 5. VIDEO & AUDIO Block Diagram IC501(MPEG+DSP+RF) ALiM3355 IC503 SDRAM 64M IC504 EEPROM FRONT PANNEL IC502 KV802... KV852... CPURST, ROMWR, ROMRD ROMAD(0:19) TV_DAC0 TV_DAC1 TV_DAC2 TV_DAC3 BCLK,LRCLK,DACCLK DAC_RST SER(0:3) DAC_ML0 VIDEO Interface AUDIO Interface Pickup DVD-MD1 , CD-MDI SVREF21, DVD:A,B,C,D,RFO CD:A,B,C,D,E ,F ,RFO F+, F-, T+, T-, CD_DVD DVDLD CDLD, IIC/VFD/DAC_CLK IIC/VFD/DAC_TXD MRESET ,S_REQ VFD_RXD X501 27MHz BA1,BA0 , CSJ,RASJ, CASJ,WEJ ,DGM, DMCLK MD0:15 , MA0:11 , MPEG (RGB)/(YPbPr) CVBS COMPONENT(Y.Pb.Pr) SCART(RGB) CVBS IC604 VIDEO 6dB Amp IC601 AUDIO DAC (2CH) IC602 (OP Amp) LPF&Buffer AUDIO 'R' AUDIO 'L' MPEG DAC_RST DACCLK BCLK LRCLK SER3 A/V JACK www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 7 DECK MECHANISM PARTS LOCATION Starting No. 1 1, 2 1, 2, 3 1, 2, 3, 4 1 1, 6 1, 2, 6 1, 2, 6, 8 1, 2, 6, 8, 9 1, 2, 7 1, 2, 7 1, 2 1, 2 ,13 1, 2, 13, 14 1, 2, 7, 12, 13, 14 1, 2, 13 1, 2, 7, 12, 13, 14, 15, 16, 17 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Main Base Clamp Assembly Disc Plate Clamp Magnet Clamp Clamp Upper Tray Disc Base Assembly Sled Gear Feed Gear Middle Gear Rack Rubber Rear Frame Assembly Up/Down Belt Loading Gear Pulley Gear Loading Guide Up/Down PWB Assembly Loading Base Main 4 Screws, 1 Connector 1 Locking Tabs 1 Screw 1 Screw 1 Locking Tab 1 Locking Tab 1 Locking Tab 1 Hook 2Screw 2 Locking Tabs 4-1 4-1 4-1 4-1 4-1 4-2 4-3 4-3 4-3 4-3 4-3 4-4 4-4 4-4 4-4 4-4 4-4 4-4 Bottom Bottom Procedure Parts Fixing Type Fig- ure Disass embly Note When reassembling, perform the procedure in reverse order. The “Bottom” on Disassembly column of above Table indicates the part should be disassembled at the Bottom side. • Top View (Without Tray) • Bottom View • Top View (With Tray) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 8 DECK MECHANISM DISASSEMBLY 1.Main Base (Fig. 4-1) 1-1. Clamp Assembly Disc 1) Place the Clamp Assembly Disc as Fig. (A) 2) Lift up the Clamp Assembly Disc in direction of arrow(A). 3) Separate the Clamp Assembly Disc from the Holder Clamp. 1-1-1. Plate Clamp 1) Turn the Plate Clamp to counterclockwise direction and then lift up the Plate Clamp. 1-1-2. Magnet Clamp 1-1-3.Clamp Upper 2. Tray Disc (Fig. 4-2) 1) Insert and push a Driver in the emergency eject hole(A) at the right side, or put the Driver on the Lever(B) of the Gear Emergency and pull the Lever(B) in direction of arrow so that the Tray Disc is ejected about 15~20mm. 2) Pull the Tray Disc until it is separated from the Base Main completely. Fig. 4-1 Fig. 4-2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 9 DECK MECHANISM DISASSEMBLY 3.Base Assembly Sled (Fig. 4-3) 1) Release 4 Screw(S2). 2) Disconnect the FFC Connector(C1) 3-1. Gear Feed 3-2. Gear Middle 3-3. Gear Rack 1) Release the Scerw(S3) 4. Rubber Rear (Fig. 4-3) Fig. 4-3 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 10 DECK MECHANISM DISASSEMBLY 5. Frame Assembly Up/Down (Fig. 4-4) Put the Base Main face down(Bottom Side) 1) Release the screw(S4) 2) Unlock the Locking Tab(L3) in direction of arrow and then lift up the Frame Assembly Up/Down to separate it from the Base Main. • When reassembling move the Guide Up/Down in direction of arrow(C) until it is positioned as Fig.(C). • When reassembling insert (A) portion of the Frame Assembly Up/Down in the (B) portion of the Guide Up/Down as Fig.(B) 6. Belt Loading(Fig. 4-4) Put the Base Main on original position(Top Side) 7. Gear pulley (Fig. 4-4) 1) Unlock the Locking Tab(L4) in direction of arrow(B) and then separate the Gear Pulley from the Base Main. 8. Gear Loading (Fig. 4-4) 9. Guide Up/Down (Fig. 4-4) 1) Move the Guide Up/Down in direction of arrow(A) as Fig.(A) 2) Push the Locking Tab(L5) down and then lift up the Guide Up/Down to separate it from the Base Main. When reassembling place the Guide Up/Down as Fig.(C) and move it in direction arrow(B) until it is locked by the Locking Tab(L5). And confirm the Guide Up/Down as Fig.(A) 10. PWB Assembly Loading (Fig. 4-4) Put the Base Main face down(Bottom Side) 1) Release 1 Screws(S5) 2) Unlock the Loading Motor (C2) from the Hook (H1) on the Base Main. 3) Unlock 2 Locking Tabs(L6) and separate the PWB Assembly Loading from the Base Main. 11. Base Main(Fig. 4-4) Note Note Note Note Note Fig. 4-4 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 11 ELECTRICAL TROUBLESHOOTING GUIDE 2. System operation flow Power on 1.initializes SERVO,DSP and RISC registers 2.write RISC code to SDRAM 3.Reset RISC Show LOGO SLED at Inner Side? SLED Moves to Inner Position Tray Closed? Tray Close to closed position 1.Judge whether have disc and disc type 2.Jump to related disc reading procedure Received Open/close key? 1.Execute Pressed Key and IR Key 2.System operation on routine loop 1.Stop playback and open tray 2.Display tray open message and LOGO Receive close key? no yes no yes no yes no yes No 5V_A No 5.2VA Is 5.2VA section working? Is 5.2V present at emitter of Q107? Replace Q107. Is there a DC voltage At (+) terminal of BD101? Is there a DC voltage at R101? Replace IC101. note: This Trobleshooting has various information. Check F101 1. Power check flow No VF+ Is 5.2VA section working? Replace D102. Check F102 NO NO YES YES YES YES Replace R101. YES Replace BD101. YES YES A. B. NO NO NO NO www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 12 ELECTRICAL TROUBLESHOOTING GUIDE Show LOGO A yes Reset or Power on Flash Memory operates Properly? Check connection on lines between FLASH & M3355 and the FLASH access time whether is suitable or not. SDRAM works properly? Check connection lines between SDRAM(IC503) & M3355 and the SDRAM is damaged. M3355 VIDEO outputs properly? Check the related circuit of M3355. (IC501 PIN 2.3.7.8 check) Have TV signal output? Does Tray move inside when it is not at closed position? Check the filtering and amp circuit of TV signal .(IC604) B No No YES YES YES YES No NO NO Normal TROUT & TRIN signals? NO Check the load OPEN & CLOSE switch Normal TRCLOSE &TROPEN signal? NO Check the Tray control IO pins on M3355. Normal LOAD+ & LOAD signal NO Check the Tray control amplifying circuit on Motor driver.(IC201) Check the cable connection between main PCBA and loader. (MECHA) Check AV cable connection to TV set NO YES YES YES Test Check the AC Voltage (110V or 220V) Switch on the Power PCBA Check the Power PART Is the DC Voltage Outputs OK? (5.2V,5V,1.8V ,3.3V,8V,12V) Check the Power PART Is 3.3V, 1.8V,5V,12V and 8V outputs normal on main PCB Check the IC105 or diode Connect to PC RS232 Cable and Update the flash memory code Update Flash(IC502) Successfully? A 1.Check 27MHz system clock. 2.Check system reset circuit. 3.Check flash R/W enable signal PRD 4.Check RS232 Signals 5.Check flash memory related circuit Replace flash(IC502) Yes yes yes Yes No No No No www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 13 ELECTRICAL TROUBLESHOOTING GUIDE Laser turns on when reading disc?) C Yes LD01 or LD02 output properly? Check the laser power circuit on M3355 and connecting to power transistor. (Q201, Q202) Collector voltage of power transistor is OK? ( Q201, Q202) Check the related circuit on laser power TR D No Yes Check cable connection between transistor output and pick-up head. Check the RF connection between MD and M3355. Put disc in? Proper RF signal? Laser off Check the related circuit on M3355 RF signal Does spindle rotate? Disc ID is correct? Proper Spindle signal on M3355 Check spindle related circuit on M3355 Proper RF signal? Check the related circuit on M3355 RF signal Check the RF connection between MD and M3355. Yes Yes Yes Yes Yes Yes Yes No No No No No No No Does the SLED move to inner side when it is at outer position on? B Yes Motor Driver DRVSB Pin is High? Check the connection line of DRVSB signal Motor Driver DRVSB Pin is High? Check the related circuit of FOCUS. SLED+ and SLED- output properly ? Check the amp circuit on motor driver. C No Check the cable connection with MECHA. Optical Lens has movements for searching Focus? Proper Focus outputs to motor driver? Check Focus connection on M3355 and motor driver. Proper F+ & F- outputs? Check the amp circuit on motor driver. Check cable connect on with pick-up head. yes No Do not put in disc and tray close. No No No Yes Yes Yes Yes Yes No No www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 14 ELECTRICAL TROUBLESHOOTING GUIDE Normal Audio output when disc playback? E DAC received correct data stream? Check connection between M3355 & Audio DAC. (Check DAC_RST#, SER3, BCLK, LRCK,MCLK Normal Audio DAC out? (IC601) Check the related circuit of Audio DAC. (Check Audio out Pin 14, 15,18,19) Check Audio filter, amplify, mute circuit. (IC602 Application circuit)? TEST END Communications between IR.VFD Front panel key & M3355 & Front u-com(IC901) is normally? Check communication lines on M3355. Check the cable connection on Front panel. Yes Normal IR. VFD & Front panel key functions? Yes Yes No No No No No Yes Yes Yes Focus ON OK? D Yes Proper signals on A, B, C, D of M3355 Check the related circuit on M3355 SBAD signal . No No Check the related circuit on M3355 .Proper SBAD signal on M3355? Check connections between M3355 and pick-up head. Track On OK? Check cable connection on pick-up head. Proper tracking signal on M3355? Proper M3355 track signal on M3355? Check the related circuit on M3355 Check the track connection on M3355 and motor driver. Yes No E . Proper FE signal on M3355? Check the related circuit on M3355 FE signal Disc is play? T+ & T- output properly? Check the tracking control amp circuit on motor driver. Check RF signal waveform. Yes Yes No No No No No Yes Yes Yes No www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 15 WAVEFORMS 1. SYSTEM 27MHz CLOCK, RESET SIGNAL 1) M3355 main clock is at 27MHz(X501) 3.1V,27MHz FIG 1-1 2) M3355 reset is low active 5.2VA PWR_CTL(CN505 PIN7) M_RESET(CN505 PIN9) TRST FIG 1-2 2. SDRAM CLOCK 3. TRAY OPEN/CLOSE SIGNAL OPEN(CN203 PIN3) CLOSE(CN203 PIN4) LM-(IC201 PIN14) LM+(IC201 PIN13) OPEN CLOSE 1) SDRAM clock is at 135MHz IC503 PIN38 CLK=135MHz,Vp-p=3.3V FIG 2-1 1) Tray open/close waveform FIG 3-1 2) Tray open waveform OPEN(CN203 PIN3) CLOSE(CN203 PIN4) LM-(IC201 PIN14) LM+(IC201 PIN13) FIG 3-2 OPEN(CN203 PIN3) CLOSE(CN203 PIN4) LM-(IC201 PIN14) LM+(IC201 PIN13) 3) Tray close waveform FIG 3-3 4. SLED CONTROL SIGNAL(NO DISC CONDITION) RELATED SLEGP(2.1V/1.5V/0.85V) (IC501 PIN80) DRVSB(3.3V/0V) (IC501 PIN22) SLED+(7.3V/4V/2.4V) (IC201 PIN16) SLED-(7.3V/4V/2.4V) (IC201 PIN15) FIG 4-1 5. LENS CONTROL RELA SIGNAL(NO DISC CONDITION) TED FOCUS(2.1V/1.5V/0.9V) (IC501 PIN76) FOCUS+(3.5V/2.8V/2V) (IC201 PIN25) FOCUS-(3.4V/2.8V/2.1V) (IC201 PIN26) FIG 5-1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 16 WAVEFORMS 6. LASER POWER CONTROL RELATED SIGNAL(NO DISC CONDITION) DVDMDI(0V/180mV) (CN201 PIN22) DVDLD(3.2V/2.2V) (IC501 PIN39) CDLD(3.2V/2.3V) (IC501 PIN40) FIG 6-1 7. DISC TYPE JUDGEMENT WAVEFORM F+(CN201 PIN15) FE(IC501 PIN27) SBAD(IC501 PIN14) FIG 7-1(DVD) F+(CN201 PIN15) FE(IC501 PIN27) SBAD(IC501 PIN14) FIG 7-2(DVD) F+(CN201 PIN15) FE(IC501 PIN27) SBAD(IC501 PIN14) FIG 7-3 (CD) F+(CN201 PIN15) FE(IC501 PIN27) SBAD(IC501 PIN14) FIG 7-4 (CD) F+(CN201 PIN15) FE(IC501 PIN27) F-(CN201 PIN18) FOCUS(IC501 PIN76) FIG 8-1 (DVD) 8. FOCUS ON WAVEFORM F+(CN201 PIN15) FE(IC501 PIN27) F-(CN201 PIN18) FOCUS(IC501 PIN76) FIG 8-2 (CD) 9. SPINDLE CONTROL (NO DISC CONDITION WAVEFORM SPM+(5.5V/4V/1.5V) (CN202 PIN2) SPM-(5.3V/4V/1.6V) (CN202 PIN1) SPINDLE(1.5V/3V) (IC501 PIN82) FIG 9-1 (DVD) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 17 WAVEFORMS TE(IC501 PIN28) TRACK(IC501 PIN77) T+(CN201 PIN16) T-(CN201 PIN17) FIG 10-1 (DVD) TE(IC501 PIN28) TRACK(IC501 PIN77) T+(CN201 PIN16) T-(CN201 PIN17) FIG 10-2(CD) 10. TRACKING CONTROL SIGNAL(System checking) RELATED 12. M3355 AUDIO OPTICAL AND COAXIAL OUTPUT(ASPDIF) 11. RF WAVEFORM RF(IC501 PIN61) (1.4V/2.95V) FIG 11-1 IECDAOUT (IC501 PIN211) FIG 12-1 2) Y Jk601 pin7 (1V) FIG 13-2 13.M3355 VIDEO OUTPUT WAVEFORM 1) Full colorbar signal(CVBS) Jk601 pin6 (1V) FIG 13-1 14. AUDIO OUTPUT FROM AUDIO DAC 3) C JK601 PIN8 (0.7V) FIG 13-3 1) AUDIO L/R JK601 PIN4,5 1KHz 0DB FIG 14-1 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 18 WAVEFORMS 2) Audio Related Signal SER3(IC501 PIN167) BCLK(IC501 PIN170) 2.312MHz LRCLK(IC501 PIN168) 48KHz FIG 14-2 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 19 Refer to the schematic diagram for the value of resistors and capacitors. PC BOARD A C E B D 2 1 3 5 7 4 6 1. MAIN P.C.BOARD www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 20 Refer to the schematic diagram for the value of resistors and capacitors. PC BOARD F G I H J 2 1 3 5 7 4 6 4. SMPS P.C.BOARD 2. KEY P.C.BOARD 3. FRONT P.C.BOARD (Solder Side) (Solder Side) Note: This manual has no Scart pcb. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 21 CIRCUIT VOLTAGE CHART STOP PLAY HOLD MODE PIN NO. 1.49 2.58 2.63 2.61 2.63 2.6 2.63 0 1.51 3.79 0.2 0.2 3.96 3.95 3.96 3.97 3.94 3.93 7.95 1.51 1.51 1.51 2.73 5.21 1.02 2.63 2.61 2.62 5.07 1.81 3.34 3.94 3.37 0 12.89 11.91 9.71 8.08 5.07 0 1.52 2.59 2.61 2.57 2.82 2.69 2.68 0 1.48 3.8 0.2 0.2 3.95 3.94 3.9 3.58 2.86 5.01 7.94 1.79 1.53 1.52 2.73 5.18 0.09 2.84 2.63 2.57 5.06 1.81 3.34 3.92 3.34 0 12.89 11.91 9.51 8.02 5.05 0 1.52 2.65 2.63 2.6 3.15 2.65 2.72 0 1.48 3.43 0.2 0.2 3.59 3.95 4.1 3.64 2.07 5.03 7.56 1.85 1.57 1.52 2.33 5.21 3.15 2.9 3.13 2.6 IC201 (IP4504) IC105(AN80T54) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 1 2 3 4 5 6 7 8 9 10 11 12 STOP PLAY HOLD MODE PIN NO. VD33A_TVDAC XDAC3OUT XDAC2OUT XIREF1 XIDUMP XIEXT XDAC1OUT XDAC0OUT GNDA_TVDAC VD33A_TVDAC XGPIO[15] XGPIO[14] XGPIO[13] VD33D XGPIO[12] GNDD XGPIO[11] XGPIO[10] VD18D XGPIO[9] GNDD XGPIO[8] VDD3MIX1 XSBLPFO XCELPFO AVDD_AD XFELPFO XTELPFO AVSS_AD AVDD_SVO XTELP XTEXO AVDD_SVO XVREF21 XBIASR XDVDPD AVSS_GA XCDPD XDVDLD XCDLD AVSS_DPD XPDAUX2 XPDAUX1 XCD_F XCD_E XCD_D XCD_C XCD_B XCD_A AVDD_DPD XDVD_D XDVD_C XDVD_B XDVD_A 3.2 0.11 0 1.66 0.34 1.22 0.56 0.61 0 3.2 3.18 0.01 0.22 3.2 2.71 0 0.2 0 1.7 3.03 0 3.2 3.2 1.47 1.6 3.18 1.52 1.71 0 0 1.66 1.54 3.18 3.1 1.23 0 0 0 3.18 3.17 0 1.6 1.61 2.1 2.1 2.11 2.11 2.1 2.1 3.18 2.11 2.11 2.1 2.1 3.16 0.06 0.06 1.64 0.35 1.22 0.35 0.69 0 3.16 3.12 0.08 0.2 3.18 2.77 0 0.2 0.01 1.69 2.93 0 3.17 3.18 2.22 1.56 3.15 1.5 1.48 0 0 1.47 1.48 3.15 2.1 1.23 0 0 0 1.78 3.14 0 0.67 0.67 2.12 2.12 2.12 2.25 2.24 2.22 3.15 2.23 2.25 2.11 2.22 3.18 0 0 1.64 0.39 1.22 0.34 0.69 0.04 3.16 3.14 0 0.2 3.2 2.77 0 0.2 0 1.71 2.64 0 2.69 3.18 1.47 1.6 3.15 1.52 1.49 0 0 1.54 1.54 3.18 2.1 1.24 0 0 0 1.78 3.14 0 0.6 0.6 2.12 2.1 2.14 2.11 2.2 2.22 3.17 2.11 2.11 2.1 2.1 I C 5 0 1 ( M 3 3 5 5 ) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 STOP PLAY HOLD MODE PIN NO. XDPD_D XDPD_C XDPD_B XDPD_A AVDD_RC XCDRF XDVDRFP XDVDRFN XATTOP XATTON XVGAIN XVGAIP XGMBIASR XLPFOP XLPFON AVSS_RC AVSS_RAD XADCIN XADCIP AVDD_RAD AVDD_DA XFOCUS XTRACK VDD3MIX2 XSLEGN XSLEGP AVSS_GD XSPINDLE XVREF15 XSFGP XSFGN AVSS_DA XTRAY XTESTDA DVSS_RCK XSFLAG[0] XSFLAG[1] DV18_RCK XROMDATA[0] GNDD XROMDATA[1] VD18D XROMDATA[2] XROMDATA[3] XROMDATA[4] XROMDATA[5] XROMDATA[6] XROMDATA[7] XROMOEJ GNDD XROMWEJ XALE XROMADR[20] XROMADR[19] XROMADR[18] 2.11 2.11 2.1 2.11 3.18 2.32 2.1 2.07 0.91 0.9 2.05 2.05 1.87 0.91 0.89 0 0 1.73 1.7 3.18 3.18 1.52 1.49 3.19 2.44 1.49 0 1.49 1.48 2.17 2.12 2.18 2.5 2.5 0 3.19 3.2 1.7 3.19 0 0 1.11 0 0 0 0 0 0 3.18 0 3.19 0 3.19 3.19 3.19 2.1 2.1 2.1 2.1 3.15 2.1 2.1 2.11 0.9 0.89 2.03 2.03 1.86 0.9 0.88 0 0 1.74 1.7 3.15 3.15 1.36 1.55 3.17 2.51 1.57 0 2.06 1.52 2.16 2.54 2.54 2.44 2.51 0 3.16 3.16 1.72 3.17 0 0 1.71 0 0 0 0 0 0 3.17 0 3.17 0 3.16 3.14 3.17 2.1 2.1 2.11 2.1 3.15 2.1 2.1 2.1 0.88 0.89 2.04 2.03 1.86 0.92 0.87 0 0 1.72 1.71 3.15 3.16 1.36 1.53 3.18 2.49 1.53 0 2.41 1.51 0 2.12 0 0 2.51 0 0 0 1.72 3.17 0 0 1.71 0 0 0 0 0 0 3.18 0 3.17 0 3.18 3.19 3.18 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 STOP PLAY HOLD MODE PIN NO. XROMADR[17] XROMADR[16] XROMADR[15] XROMADR[14] XROMADR[13] VD33D XROMADR[12] XROMADR[11] XROMADR[10] XROMADR[9] XROMADR[8] XROMADR[7] XROMADR[6] XROMADR[5] GNDD XROMADR[4] VD18D XROMADR[3] XROMADR[2] XROMADR[1] GNDD XROMADR[0] XCRESETJ XEXTINTJ XCTXD XIN_XCLK XOUT VD18A_PLL XTOCK GNDA_PLL XGPIO[7] XGPIO[6] VD33D XDMCLK XCKE VD18D XMA[9] GNDD XMA[8] XMA[7] XMA[6] XMA[5] XMA[4] GNDD XMD[8] XMD[9] XMD[10] XMD[11] VD33D XMD[12] XMD[13] XMD[14] XMD[15] XMD[0] XMD[1] 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 3.19 0 3.19 1.69 0 0 0 0 0 5.25 3.19 3.25 1.6 5.19 0 0 3.14 3.19 1.8 2.93 1.69 0 0 0 0.14 0.17 0.16 0.17 0 2.81 2.69 2.81 2.8 3.2 2.87 2.84 2.88 2.77 2.79 1.7 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 3.17 0 3.19 1.71 0 0 0 0 0 5.25 3.17 3.23 1.62 5.21 0 0 3.14 3.17 1.77 2.94 1.7 0 0 0 0.12 0.16 0.15 0.12 0 2.17 2.87 2.87 2.87 3.17 2.87 2.17 2.84 2.88 2.76 2 3.16 3.18 3.17 3.18 3.17 3.18 3.18 3.16 3.16 3.16 3.18 3.17 3.17 3.16 0 3.17 1.7 0 0 0 0 0 5.25 3.18 3.23 1.61 5.21 0 0 3.14 3.17 1.77 2.93 1.71 0 0 0 0.12 0.27 0.14 0.11 0 2.48 2.52 2.57 2.55 3.17 2.54 2.18 2.72 2.78 2.7 2.33 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 STOP PLAY HOLD MODE PIN NO. GNDD XMD[2] XMD[3] XMD[4] XMD[5] GNDD XMD[6] VD18D XMD[7] XMA[3] XMA[2] XMA[1] XMA[0] XMA[10] VD33D XBA0 XBA1 XMA[11] XRASJ XCASJ XWEJ XDQM XCSJ XTRSTJ VD18D XTDO GNDD XTCK XTMS XTDI XGPIO[5] XGPIO[4] XGPIO[3] XGPIO[2] XGPIO[1] XGPIO[0] XDASCLK GNDD XBCLK XLRCLK XASDA[3] XASDA[2] XASDA[1] GNDD XASDA[0] VD18D XIECDATA VD33A_ADC XMIC1IN XADC_VREF XMIC2IN GNDA_ADC 0 2.89 2.88 2.9 2.88 0 2.82 1.7 2.07 0.19 0.2 0.21 2.05 2.04 3.2 2.97 2.58 0 0.06 3.02 3.18 0 2.96 3.2 1.69 0 0 3.8 3.43 3.18 3.15 3.18 3.14 0 0 3.2 1.46 0 1.33 0 0 0.08 0.08 0 0.08 1.7 1.7 3.2 1.45 1.45 1.47 0 0 0 2.84 2.89 2.88 0 2.88 1.7 2.07 0.2 0.16 0.16 0.18 1.82 3.17 2.43 2.21 0.13 0.13 2.58 3.14 0.08 2.22 3.16 1.71 0.09 0 3.1 0.09 3.03 0.09 3.16 3.13 3.08 1.69 0.07 1.52 0 1.33 0.14 0.14 0.14 1.62 0 0 1.45 1.71 3.17 1.45 1.45 0.1 0.09 0 0 2.6 2.47 2.3 0 2.31 1.71 2.49 0.16 0.22 0.24 0.07 2.7 3.17 2.88 2.58 0.04 0.01 2.96 3.08 0 2.81 3.11 1.7 0 0 3.05 3.04 3.03 0.12 3.18 3.1 3.19 0 3.19 1.48 0 1.33 0.01 0.01 0.01 0.08 0 0.08 1.71 1.71 3.2 1.45 1.45 0.01 0.01 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 C217 + 5.21 5.19 - 0 0 C544 + 3.19 3.16 - 0 0 C508 + 1.62 1.6 - 0 0 C563 + 3.27 3.25 - 0 0 C607 + 5.42 5.41 - 2.28 2.28 C640 + 5.21 5.2 - 0 0 C644 + 1.32 1.26 - 0.67 0.76 C633 + 2.51 2.5 - 2.35 2.35 C902 + 5.25 5.25 - 0 0 C109 + 3.96 3.93 - 0 0 C214 + 7.96 7.94 - 0 STOP PLAY HOLD MODE PIN NO. 3.2 0 3.2 3.2 3.2 3.2 0 0 0 0 3.2 5.25 0 1.54 1.33 3.2 3.2 3.2 1.7 2.2 0 0 0 0 0 0 0 3.2 3.2 0 0 0 0 0 3.2 0 3.2 3.26 3.2 0 3.2 0 0 0 0 0 0 3.2 3.25 2.85 3.25 2.87 2.85 3.17 3.17 3.17 0.97 3.16 3.16 3.16 3.16 3.16 1.02 3.16 5.25 2.73 3.19 1.71 2.43 3.17 3.16 3.17 3.17 3.17 3.17 0 0 0 0 0 3.17 3.17 0 0 0 0 0 0 0 3.23 0 3.17 0 3.17 0 3.17 0 0 0 0 3.17 3.23 2.86 3.22 2.87 2.5 IC502 (MX29L800) IC503 (M12L64164A) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 1 2 3 4 5 STOP PLAY HOLD MODE PIN NO. 0 2.81 2.9 3.25 2.85 2.87 1.9 2.8 3.25 0 3.18 3.07 3.14 2.95 2.9 2.6 2.81 0.05 0.16 0.16 0.16 3.26 0 0.16 0.15 0.16 0.12 0.05 0.05 0.04 2.85 3.26 1.79 0 2.7 2.7 2.9 3.26 2.92 2.92 0 2.92 2.94 3.26 2.91 2.94 0 2.9 0 0 0 0 0 0 0 2.1 2.04 3.22 2.1 2.91 0 3.22 0 3.1 2.58 0.61 2.97 2.96 0.32 2.83 0.06 0.18 0.18 0.17 3.24 0.59 0.17 0.53 0.53 0.5 0.16 0.17 0.5 0.08 3.236 1.78 0 0.1 0 2 3.23 1.95 2.01 0 2.03 2.17 3.23 2 2 0 1.85 0 0 0 0 0 0.12 IC504(AT24CO2A) 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 1 2 3 4 5 STOP PLAY HOLD MODE PIN NO. 3.21 0 3.25 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 3.3 3.25 3.27 0 1.35 1.64 1.56 0 3.19 0.12 3.2 5.11 2.11 5.04 2.29 2.28 0 5.19 2.29 2.3 5.04 5.17 2.52 5.17 1.36 0 1.68 0 2.52 0 3.16 0 3.23 0 0 0 0 0 0 0 0 0 0 0 3.23 3.17 0 0 0 0 0 0 3.23 3.23 3.26 0 1.35 1.63 1.56 0 3.16 0.13 3.17 5.1 2.1 0 2.29 2.28 0 5.18 2.28 2.29 0 5.16 2.47 5.16 1.27 0 1.55 0 2.51 0 IC506 (LCX373) IC601(CS4391) IC604(MM1623) 6 7 8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 2 3 4 5 6 7 8 9 STOP PLAY HOLD MODE PIN NO. 1.68 0 2.49 5.17 2.5 0 2.53 0 2.51 0 2.18 2.16 0 2.16 0.25 0.23 2.51 0.53 5.17 0.1 5.19 2.28 2.4 5.24 0 0 0 0 5.24 5.24 5.06 0 0 5.24 5.2 5.24 0 0 0 2.72 5.24 5.24 3.13 23.74 27.96 25.84 27.97 25.84 27.96 25.84 30.1 1.53 0 2.47 5.16 2.47 0 2.52 0 2.51 0 2 2.05 0 1.96 0.42 0.42 2.51 0.8 5.16 0.1 5.19 2.2 2.2 5.24 0 0 0 0 5.24 5.24 5.16 0 0 5.24 5.2 5.24 0 0 0 2.72 5.24 5.24 3.13 24.19 26.4 28.47 26.34 26.37 30.72 26.32 28.55 I C 9 0 1 C 2 1 7 C 5 4 4 C 5 0 8 C 5 6 3 C 6 0 7 C 6 4 0 C 6 4 4 C 6 3 3 C 9 0 2 C 1 0 9 C 2 1 4 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 STOP PLAY HOLD MODE PIN NO. 25.83 27.96 27.94 27.95 30.09 27.94 30.09 28.09 30.09 30.09 30.09 30.09 28.12 28.13 28.06 28.16 28.14 28.13 28.12 28.14 30.23 2.1 2.2 2.24 2.17 0 0 0 3.2 21.96 19.87 28.5 26.33 24.16 28.6 24.51 30.66 28.75 30.7 30.82 30.8 28.72 28.68 28.85 28.81 28.32 28.82 28.86 28.81 31 1.99 1.99 2.24 2 0 0 0 3.18 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 STOP PLAY MODE PIN NO. C579 + 3.2 3.16 - 0 0 C204 + 3.2 3.15 - 3.18 3.13 C504 + 3.21 3.18 - 0 0 C608 + 5.41 5.41 - 2.27 2.27 C621 + 5.42 5.41 - 0 0 C625 + 1.65 1.66 - 0.53 0.51 C634 + 2.15 2.13 - 2.05 2.13 C912 + 4.85 4.85 - 0 0 C112 + 3.94 3.91 - 0 0 C131 + 5.11 5.1 - 0 0 C202 + 5.21 5.19 - 0 0 C513 + 1.51 1.52 - 0 0 C215 + 3.2 3.15 - 0 0 C 5 7 9 C 2 0 4 C 5 0 4 C 6 0 8 C 6 2 1 C 6 2 5 C 6 3 4 C 9 1 2 C 1 1 2 C 1 3 1 C 2 0 2 C 5 1 3 C 2 1 5 STOP PLAY MODE PIN NO. C600 + 3.28 3.26 - 0 0 C609 + 5.41 5.41 - 2.27 2.27 C614 + 5.42 6.41 - 0 0 C631 + 2.51 2.5 - 0 0 C637 + 2.52 2.5 - 2.37 2.36 C908 + 5.25 5.25 - 0 C123 + 5.19 5.19 - 0 0 C120 + 11.91 11.91 - 0 0 C539 + 2.1 2.1 - 0 0 C587 + 1.72 1.7 - 0 0 C501 + 3.2 3.16 - 0 0 C604 + 2.25 2.19 - 0 0 C610 + 5.41 5.41 - 2.28 2.28 C 6 0 0 C 6 0 9 C 6 1 4 C 6 3 1 C 6 3 7 C 9 0 8 C 1 2 3 C 2 1 7 C 5 3 9 C 5 8 7 C 5 0 1 C 6 0 4 C 6 1 0 STOP PLAY MODE PIN NO. C638 + 2.15 2.78 - 0 0 C626 + 2.5 2.49 - 0 0 C636 + 2.51 2.5 - 2.31 2.31 C121 + 19.86 20.24 - 25.56 25 C137 + 5.17 5.17 - 0 0 C129 + 3.3 3.3 - 0 0 C205 + 3.19 3.15 - 3.18 1.77 C560 + 1.72 1.71 - 0 0 C507 + 0 0 - 1.47 1.45 C602 + 5.11 5.1 - 0 0 C619 + 11.69 11.67 - 0 0 C629 + 5.17 5.16 - 0 0 C627 + 2.5 2.5 - 0 0 C 6 3 8 C 6 2 6 C 6 3 6 C 1 2 1 C 1 3 7 C 1 2 9 C 2 0 5 C 5 6 0 C 5 0 7 C 6 0 2 C 6 1 9 C 6 2 9 C 6 2 7 STOP PLAY MODE PIN NO. C635 + 2.17 2.32 - 2.07 2.08 C122 + 0 0 - 30.2 30.71 C116 + 9.71 9.51 - 0 0 C542 + 3.19 3.16 - 0 0 C568 + 3.26 3.23 - 0 0 C506 + 1.46 1.44 - 0 0 C606 + 5.19 5.18 - 0 0 C620 + 5.42 5.41 - 0 0 C624 + 2.49 2.48 - 0.67 0.67 C577 + 3.26 3.23 - 0 0 C6W3 + 5.12 5.11 - 0 0 C104 + 12.89 12.89 - 0 0 C 6 3 5 C 1 2 2 C 1 1 6 C 5 4 2 C 5 6 8 C 5 0 6 C 6 0 6 C 6 2 0 C 6 2 4 C 5 7 7 C 6 W 3 C 1 0 4 + 8.07 8.05 - 0 0 C 1 1 8 DVF-3080-S/8100 22 CIRCUIT VOLTAGE CHART www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 A C E B D 2 1 3 5 7 4 6 NOTES) Warning NOTES) Parts that are shaded are critical NOTES) With respect to risk of fire or NOTES) electricial shock. NOTES : Symbol denotes AC ground. Symbol denotes DC chassis ground. VF(+) Power dead R102 is defective VF(-) Power dead ZD102 is defective Power dead IC101 is defective 5V Power dead Q107 is defective 3.3V, 1.8V, 8V, 12V Power dead IC105 is defective 1. POWER(SMPS) CIRCUIT DIAGRAM Please replace a defective power supply unit with a new one except fuse. 23 DVF-3080-S/8100 CAUTION: For continued safety, replace safety critical components only with man- ufacturer's recommended parts (refer to parts list). indicates safety critical com- ponents. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resis- tance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. The DC voltage is an actual reading mea- sured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measur- ing instruments used or on the product. www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 F G I H J 2 1 3 5 7 4 6 2. AV/JACK CIRCUIT DIAGRAM Video Signal Y Video Signal Color Video Signal CVBS 2CH Audio 2CH Audio out bad. All Video signal isn't KTC3875S-GR-T1 KTC3875S-GR-T1 appear or bad 2CH Audio out bad. M3355G (M3355A) CVBS (TV_DAC0) 75 (NC) 75 (NC) 75 (NC) 68 (820) 68 (820) 68 (820) Y/G (TV_DAC1) Cb/B (TV_DAC2) NC (YC-Y) (TV_DAC4) NC (YC-C) (TV_DAC5) Cr/R (TV_DAC3) NC (1u50) NC (0) NC (0) NC (1u50) C646 100P C645 100P IC601 CS4391-KZR IC602 NJM4580M Q604 KTC3875S-GR-T1 Q603 KTC3875S-GR-T1 E K,P,X,Y M3355G M3355A CVBS CVBS Y/G Y/G Cb/B Cb/B Cr/R Cr/R NC YC-Y NC YC-C NC 1u NC 0-OHM 75 NC 68 820 DESTINATION IC501 DAC0 DAC1 DAC2 DAC3 DAC4 DAC5 C624, 642 R666, 668 R651, 660,662 R661, 663,664 VIDEO OPTION 24 DVF-3080-S/8100 CAUTION: For continued safety, replace safety criti- cal components only with manufacturer's recommend- ed parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the sup- ply circuit) before the appliance is returned to the cus- tomer. The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instruments used or on the product. www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 2 K M O Q S L N P R T 1 3 5 7 4 6 9 10 DVF-3080-S/8100 Video signal not appeared Digitron all not display System not working System not working or screen is abnormal System not working or Digitron not display Program download fail System not operate OPTIONAL PART 3. SYSTEM CIRCUIT DIAGRAM M3355G M3355A KTC3875S-GR-T1 M3355G (E type) M3355A (K,P,X,Y type) 22P 22P C510 C511 C570 27P R526 10 IC506 74LCX373MTCX IC504 S524A40X21SCT0 3.3K 3.3K IC503 IS4216400A-7T KV85200002 (E type) KV80200001 (K,P,X,Y type) IC502 IC501 CAUTION: For continued safety, replace safety critical components only with manufacturer's recom- mended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-cur- rent or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depending on the measuring instru- ments used or on the product. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 5. FRONT & KEY CIRCUIT DIAGRAM Remocon not operate Remocon not operate System not operate or Digitron abnormal or Key not operate. Digital abnormal Digital abnormal IC901 HMS81C2012AHK0 (E type) B30-2669-08 3 3 LED LED Q901 KRC103S R912 220 R906 100 LED901 CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). indi- cates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The mea- surement value may vary depending on the measuring instruments used or on the product. 4. DRIVER CIRCUIT DIAGRAM CD/DVD LD will not on KTC3875S-GR-T1 KTC3875S-GR-T1 KTC3875S- GR-T1 33K CAUTION: For continued safety, replace safety critical components only with manu- facturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The measurement value may vary depend- ing on the measuring instruments used or on the product. U V X Z AB AD W Y AA AC 2 1 3 5 7 4 6 DVF-3080-S/8100 11 12 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 AE AG AI AF AH 2 1 3 5 7 4 6 6. SCART CIRCUIT DIAGRAM KRC103M MTZJ13B MTZJ13B MTZJ5.6B MTZJ5.6B MTZJ5.6B MTZJ5.6B 29 DVF-3080-S/8100 CAUTION: For continued safety, replace safety critical com- ponents only with manufacturer's recommended parts (refer to parts list). indicates safety critical components. For continued protection against risk of fire, replace only with same type and rating fuse(s). To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the cus- tomer. The DC voltage is an actual reading measured with a high impedance type voltmeter with no signal input. The mea- surement value may vary depending on the measuring instruments used or on the product. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 30 EXPLODED VIEW (UNIT) DVF-3080/8100 J K L M φ3x10(BLK) φ3x8(BLK) :N09-5520-08 :N89-3010-45 :N89-3008-45 :N09-5521-08 OPTICAL VIDEO COMPONENT AUDIO DIGITAL S-VIDEO JK601 JK6W1 601 13 J J J J J 620 608 607 609 714 748 Jx2 Jx2 J M M M 647 610 Jx2 Jx2 715 Jx2 Kx3 606 L K 712 605x2 625 626 623 M 702 613 626 10 10 627 35A 627 35A 605 605 DVF-8100 DVF-3080 E only M 711 624 604 622 622 621 YEL BLK 51 16 16 1 2 A C B Parts with exploded numbers larger than 700 are not supplied. www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 31 PARTS LIST Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks J ✻ N09-5520-08 SCREW,DRAWING 353-051G K N89-3010-45 SCREW,DRAWING 353-046K L N89-3008-45 SCREW,DRAWING 353-046N M ✻ N09-5521-08 SCREW,DRAWING 353-051A LED901 ✻ B30-2669-08 DIODE,LED 0DL112000AJ C6A1 CE04KW0J471M ELECTRO 470UF 6.3WV E C6W1 CK73GB1A105Z CHIP C 1.0UF Z C6W2 CC73GCH1H101J CHIP C 100PF J C6W3 CE04KW1C100M ELECTRO 10UF 16WV E C6W4 CK73GB1H104Z CHIP C 0.10UF Z C201 CK73GB1H104Z CHIP C 0.10UF Z C202 CE04KW1C101M ELECTRO 100UF 16WV C204,5 CE04KW1C101M ELECTRO 100UF 16WV C206,7 CK73GB1H104Z CHIP C 0.10UF Z C208,9 CK73GB1H102K CHIP C 1000PF K C210 CK73GB1H821K CHIP C 820PF K C211 CK73GB1H102K CHIP C 1000PF K C212 CK73GB1H473K CHIP C 0.047UF K C213 CK73GB1H223K CHIP C 0.022UF K C214 CE04KW1C221M ELECTRO 220UF 16WV C215 CE04KW1C101M ELECTRO 100UF 16WV C216 CK73GB1H104Z CHIP C 0.10UF Z C217 CE04KW0J221M ELECTRO 220UF 6.3WV E C217 CE04KW1C221M ELECTRO 220UF 16WV KPXY C218,9 CK73GB1H104Z CHIP C 0.10UF Z C220,1 CK73GB1H332K CHIP C 3300PF K C501 CE04KW1C470M ELECTRO 47UF 16WV C502,3 CK73GB1H104Z CHIP C 0.10UF Z C504 CE04KW1C470M ELECTRO 47UF 16WV C505 CK73GB1H104Z CHIP C 0.10UF Z C506 CE04KW1C100M ELECTRO 10UF 16WV C507 CE04KW1H010M ELECTRO 1.0UF 50WV C508 CE04KW1C101M ELECTRO 100UF 16WV C509 CC73GCH1H471J CHIP C 470PF J C510,1 CC73GCH1H220J CHIP C 22PF J C512 CK73GB1H104Z CHIP C 0.10UF Z C513 CE04KW1C100M ELECTRO 10UF 16WV C514,5 CK73GB1H561J CHIP C 560PF J C516,7 CK73GB1H102K CHIP C 1000PF K C518 CK73GB1H104Z CHIP C 0.10UF Z C519-23 CK73GB1H102K CHIP C 1000PF K C524-31 CK73GB1H104Z CHIP C 0.10UF Z C532 CK73GB1H331J CHIP C 330PF J C533 CK73GB1H104Z CHIP C 0.10UF Z C534,5 CC73GCH1H471J CHIP C 470PF J C536 CK73GB1C224Z CHIP C 0.22UF Z C537 CK73GB1H391J CHIP C 390PF J C538 CK73GB1H104Z CHIP C 0.10UF Z C539 CE04KW1C100M ELECTRO 10UF 16WV C540,1 CK73GB1H104Z CHIP C 0.10UF Z C542 CE04KW1C101M ELECTRO 100UF 16WV C543 CK73GB1H104Z CHIP C 0.10UF Z C544 CE04KW1C101M ELECTRO 100UF 16WV C545 CK73GB1H104Z CHIP C 0.10UF Z ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 2 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks - ✻ H50-4932-08 BOX 3890R-C177A E3 - ✻ H50-4934-08 BOX 3890R-C177B X3 - ✻ H50-4936-08 BOX 3890R-C177C E8 - ✻ H50-4935-08 BOX 3890R-C177E K8P8 - ✻ H50-4933-08 BOX 3890R-C177F Y3 - ✻ H50-4931-08 BOX 3890R-C177G K3P3 - ✻ H10-7931-08 PACKING,CASING 3920R-E103A - ✻ B60-5480-08 INSTRUCTION(EG) - ✻ B60-5481-08 INSTRUCTION(FR) E3E8 - ✻ B60-5481-08 INSTRUCTION(FR) P3P8 - ✻ B60-5482-08 INSTRUCTION(4L) E3E8 10 1C ✻ E35-3718-08 CABLE,FLAT 6850R-JW24Y 13 1B ✻ D16-0805-08 BELT 4400R-0006B 16 1C,2C ✻ W02-4587-08 PWB(PCB) ASSEM 6871R-9288A 35A 1C,2C ✻ E35-3719-08 CABLE,FLAT 6850R-GF10Z 51 1C ✻ D40-1837-08 BASE ASSEMBLY 3041R-D008A 601 1B ✻ A01-3925-08 CASE 3110R-D013D 604 2A ✻ A60-2388-08 FRONT PANEL E8 604 2A ✻ A60-2389-08 FRONT PANEL K8P8 604 2A ✻ A60-2386-08 FRONT PANEL K3P3 604 2A ✻ A60-2387-08 FRONT PANEL E3Y3X3 605 2B,2C ✻ G11-2956-08 RUBBER 5040R-0069L 606 1C ✻ E30-7331-08 POWER CORD 6410RKHX03A X 606 1C ✻ E30-7319-08 POWER CORD 6410RAHX03A KPY 606 1C ✻ E30-7320-08 POWER CORD 6410RCHX03A E 607 1A ✻ E30-7332-08 PLUG ASSY(VID) 6611R1D003A KPY 607 1A ✻ E30-7333-08 PLUG ASSY(VID) 6611R1G001A EX 608 1A ✻ E30-7334-08 PLUG ASSY(AUD) 6611R2D003A KPY 608 1A ✻ E30-7335-08 PLUG ASSY(AUD) 6611R2G001A EX 609 1A ✻ A70-1660-08 REMOTE CONTROL 6711R1N166A 610 1B ✻ D40-1829-08 DECK ASSEMBLY, 6721RHD030A 613 2C ✻ W02-4574-08 SUB PWB(PCB) A 6885R-1029N P3 613 2C ✻ W02-4576-08 SUB PWB(PCB) A 6885R-1029E X3 613 2C ✻ W02-4578-08 SUB PWB(PCB) A 6885R-1029J K8 613 2C ✻ W02-4575-08 SUB PWB(PCB) A 6885R-1029L Y3 613 2C ✻ W02-4583-08 SUB PWB(PCB) A 6885R-1029P E8 613 2C ✻ W02-4579-08 SUB PWB(PCB) A 6885R-1030H P8 613 2C ✻ W02-4558-08 SUB PWB(PCB) A 6885R-1028B K3 613 2C ✻ W02-4559-08 SUB PWB(PCB) A 6885R-1027F E3 620 1A ✻ E30-7336-08 PLUG ASSY(COX) 6611R1G002A EX 620 1A ✻ E30-7337-08 PLUG ASSY(COX) 564-017E KPY 621 2A ✻ B43-0336-04 BADGE 622 2A ✻ A29-1235-08 TRAY PANEL K3P3Y3 622 2A ✻ A29-1236-08 TRAY PANEL E3X3 622 2A ✻ A29-1237-08 TRAY PANEL ASSY K8P8 622 2A ✻ A29-1238-08 TRAY PANEL ASSY E8 623 2A,2B ✻ B03-3945-08 WINDOW,DECO 3790R-D356A 624 2A ✻ A50-1418-08 COVER L 3550R-1002A 625 2B ✻ A50-1419-08 COVER R 3550R-1003A 626 2B,2C ✻ E35-3723-08 CABLE,FLAT KPY 626 2B,2C ✻ E35-3724-08 CABLE,FLAT EX 627 1C,2C ✻ E35-3727-08 CABLE,FLAT E 647 1B ✻ W02-4573-08 PWB(PCB) ASSEM 6871R-7184C Y 647 1B ✻ W02-4556-08 PWB(PCB) ASSEM 6871R-7184B KP 647 1B ✻ W02-4557-08 PWB(PCB) ASSEM 6871R-7184A EX ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 1 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . DVF-3080(3)/DVF-8100(8) MAIN PCB www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 32 PARTS LIST Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks C906,7 CK73GB1H104Z CHIP C 0.10UF Z C908 CE04KW0J221M ELECTRO 220UF 6.3WV C909-11 CK73GB1H104Z CHIP C 0.10UF Z C912 CE04KW1C470M ELECTRO 47UF 16WV C913,4 CK73GB1H104Z CHIP C 0.10UF Z JK6A1 ✻ E58-0073-08 JACK,SCART 6612M00003B E JK601 ✻ E63-1355-08 JACK,RCA 6612J00044B KPXY JK601 ✻ E63-1356-08 JACK,RCA 6612J00044E E F101 ✻ F53-0340-08 FUSE,SLOW BLOW 0FS1601B51B KPY F101 ✻ F53-0341-08 FUSE,SLOW BLOW 0FS1601B51D EX F6A1-3 ✻ L72-0647-08 FILTER(CIRC) 6200HJC901A E L201,2 ✻ L33-1686-08 INDUCTOR,RADIA 0LR0102J025 L203-5 ✻ L92-0582-08 FILTER(CIRC),E 6200HJC102A L501 ✻ L92-0582-08 FILTER(CIRC),E 6200HJC102A L502 ✻ L33-1687-08 INDUCTOR,CHIP 0LCCE00004L L503-8 ✻ L92-0582-08 FILTER(CIRC),E 6200HJC102A L600-4 ✻ L92-0582-08 FILTER(CIRC),E 6200HJC102A L901 ✻ L92-0582-08 FILTER(CIRC),E 6200HJC102A X501 ✻ L77-2439-08 RESONATOR,CRYS 6202R-BL06C X901 ✻ L78-0770-08 RESONATOR,CERA 6212BA3004A R5A1-8 RK73GB1J000J CHIP R 0 J 1/16W R6A1 RD14BB2C750J RD 75 J 1/6W E R6W1 RK73GB1J221J CHIP R 220 J 1/16W R6A2 RD14BB2C471J RD 470 J 1/6W E R6T2 RK73GB1J000J CHIP R 0 J 1/16W R6W2 RK73GB1J111J CHIP R 110 J 1/16W R6A3 RD14BB2C104J RD 100K J 1/6W E R6W3 RK73GB1J220J CHIP R 22 J 1/16W R6A4 RD14BB2C471J RD 470 J 1/6W E R6A5 RD14BB2C750J RD 75 J 1/6W E R6A6 RD14BB2C104J RD 100K J 1/6W E R6A7 RD14BB2C220J RD 22 J 1/6W E R6A8 RD14BB2C104J RD 100K J 1/6W E R6A9 RD14BB2C220J RD 22 J 1/6W E R201,2 RK73GB1J6R8J CHIP R 6.8 J 1/16W R203 RK73GB1J000J CHIP R 0 J 1/16W R204 RK73GB1J224J CHIP R 220K J 1/16W R205 RK73GB1J183J CHIP R 18K J 1/16W R206 RK73GB1J103J CHIP R 10K J 1/16W R207 RK73GB1J104J CHIP R 100K J 1/16W R208-10 RK73GB1J103J CHIP R 10K J 1/16W R211 RK73GB1J202J CHIP R 2.0K J 1/16W R212,3 RK73GB1J103J CHIP R 10K J 1/16W R214 RK73GB1J152J CHIP R 1.5K J 1/16W R215 RK73GB1J153J CHIP R 15K J 1/16W R216 RK73GB1J393J CHIP R 39K J 1/16W R217 RK73GB1J562J CHIP R 5.6K J 1/16W R218 RK73GB1J103J CHIP R 10K J 1/16W R219,20 RK73GB1J222J CHIP R 2.2K J 1/16W R221 RK73GB1J393J CHIP R 39K J 1/16W R222 RK73GB1J333J CHIP R 33K J 1/16W R224-7 RK73FB2A010J CHIP R 1 J 1/10W R228 RK73GB1J103J CHIP R 10K J 1/16W R229 RK73GB1J153J CHIP R 15K J 1/16W R230 RK73GB1J223J CHIP R 22K J 1/16W ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 4 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks C546,7 CC73GCH1H221J CHIP C 220PF J C548-53 CK73GB1H104Z CHIP C 0.10UF Z C554,5 CC73GCH1H221J CHIP C 220PF J C556-9 CK73GB1H104Z CHIP C 0.10UF Z C560 CE04KW1C221M ELECTRO 220UF 16WV C562 CK73GB1H104Z CHIP C 0.10UF Z C563 CE04KW1C221M ELECTRO 220UF 16WV C564-7 CK73GB1H104Z CHIP C 0.10UF Z C568 CE04KW1C101M ELECTRO 100UF 16WV C569 CK73GB1H104Z CHIP C 0.10UF Z C570 CC73GCH1H270J CHIP C 27PF J C571-6 CK73GB1H104Z CHIP C 0.10UF Z C577 CE04KW1C101M ELECTRO 100UF 16WV C579 CE04KW1C221M ELECTRO 220UF 16WV C580-6 CK73GB1H104Z CHIP C 0.10UF Z C587 CE04KW1C221M ELECTRO 220UF 16WV C588-98 CK73GB1H104Z CHIP C 0.10UF Z C599 CC73GCH1H470J CHIP C 47PF J C600 CE04KW1C101M ELECTRO 100UF 16WV C601 CK73GB1H104Z CHIP C 0.10UF Z C602 CE04KW1H010M ELECTRO 1.0UF 50WV C603 CK73GB1H104Z CHIP C 0.10UF Z C604 CE04KW1H010M ELECTRO 1.0UF 50WV C605 CK73GB1H104Z CHIP C 0.10UF Z C606 CE04KW1C101M ELECTRO 100UF 16WV C607-10 CE04KW1C470M ELECTRO 47UF 16WV C611 CK73GB1H102K CHIP C 1000PF K C612,3 CC73GCH1H271J CHIP C 270PF J C614 CE04KW1C221M ELECTRO 220UF 16WV C615 CC73GCH1H271J CHIP C 270PF J C616 CK73GB1H102K CHIP C 1000PF K C617 CC73GCH1H271J CHIP C 270PF J C618 CK73GB1H104Z CHIP C 0.10UF Z C619 CE04KW1C101M ELECTRO 100UF 16WV C620,1 CE04KW1C470M ELECTRO 47UF 16WV C622,3 CK73GB1H392K CHIP C 3900PF K C624 CE04KW1H010M ELECTRO 1.0UF 50WV KPXY C625-7 CE04KW1H010M ELECTRO 1.0UF 50WV C629 CE04KW1C101M ELECTRO 100UF 16WV C630 CK73GB1H104Z CHIP C 0.10UF Z C631 CE04KW1C220M ELECTRO 22UF 16WV C632 CK73GB1H104Z CHIP C 0.10UF Z C633 CE04KW0J471M ELECTRO 470UF 6.3WV KPXY C634 CE04KW0J102M ELECTRO 1000UF 6.3WV KPXY C635 CE04KW0J102M ELECTRO 1000UF 6.3WV C636,7 CE04KW0J471M ELECTRO 470UF 6.3WV C638 CE04KW0J102M ELECTRO 1000UF 6.3WV C639 CK73GB1H104Z CHIP C 0.10UF Z C640 CE04KW0J221M ELECTRO 220UF 6.3WV C641 CK73GB1H104Z CHIP C 0.10UF Z C642 CE04KW1H010M ELECTRO 1.0UF 50WV KPXY C643 CK73GB1H104Z CHIP C 0.10UF Z C644 CE04KW1H010M ELECTRO 1.0UF 50WV C645,6 CC73GCH1H101J CHIP C 100PF J C902 CE04KW1C100M ELECTRO 10UF 16WV ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 3 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 33 PARTS LIST Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks R635 RK73GB1J000J CHIP R 0 J 1/16W R637 RK73GB1J000J CHIP R 0 J 1/16W R638-46 RK73GB1J750J CHIP R 75 J 1/16W R647 RK73GB1J103J CHIP R 10K J 1/16W R648 RK73GB1J750J CHIP R 75 J 1/16W R650 RK73GB1J750J CHIP R 75 J 1/16W R651 RK73GB1J750J CHIP R 75 J 1/16W E R652 RK73GB1J102J CHIP R 1.0K J 1/16W R656,7 RK73GB1J000J CHIP R 0 J 1/16W R658 RK73GB1J472J CHIP R 4.7K J 1/16W R659 RK73GB1J000J CHIP R 0 J 1/16W R660 RK73GB1J750J CHIP R 75 J 1/16W E R661 RK73GB1J680J CHIP R 68 J 1/16W E R661 RK73GB1J821J CHIP R 820 J 1/16W KPXY R662 RK73GB1J750J CHIP R 75 J 1/16W E R663,4 RK73GB1J680J CHIP R 68 J 1/16W E R663,4 RK73GB1J821J CHIP R 820 J 1/16W KPXY R666 RK73GB1J000J CHIP R 0 J 1/16W KPXY R668 RK73GB1J000J CHIP R 0 J 1/16W KPXY R901 RK73GB1J681J CHIP R 680 J 1/16W R902 RD14BB2C152J RD 1.5K J 1/6W R903 RD14BB2C122J RD 1.2K J 1/6W R904 RD14BB2C152J RD 1.5K J 1/6W R905 RD14BB2C222J RD 2.2K J 1/6W R906 RK73FB2B101J CHIP R 100 J 1/8W R907 RD14BB2C822J RD 8.2K J 1/6W R908,9 RK73GB1J103J CHIP R 10K J 1/16W R910 RK73GB1J332J CHIP R 3.3K J 1/16W R911 RK73GB1J331J CHIP R 330 J 1/16W R912 RK73GB1J221J CHIP R 220 J 1/16W R938 RK73GB1J104J CHIP R 100K J 1/16W R951 RK73GB1J101J CHIP R 100 J 1/16W R953 RK73GB1J000J CHIP R 0 J 1/16W SW901-7 ✻ S70-0113-08 SWITCH,TACT 556-219B D600 DAP202K DIODE,SWITCHIN 0DSRM00118A DIG901 ✻ 6BT-341NK DIGITRON 6302R-V226A IC201 ✻ IP4504 IC,LINEAR 0ILNRIJ001A IC501 ✻ M3355A IC,LINEAR 0ILNRAC003A KPXY IC501 ✻ M3355G IC,LINEAR 0ILNRAC003G E IC502 ✻ KV8020001 PROGRAM 6957R-018HT KPY IC502 ✻ KV8520002 PROGRAM 6957R-018HE E IC502 ✻ KV8520004 PROGRAM 6957R-020AC X IC503 ✻ IS42S16400A-7T IC,MEMORIES 0IMMRII006A IC504 ✻ S524A40X21SCT0 IC,SAMSUNG ELE 0ISS240210A IC506 ✻ 74LCX373MTCX IC,STANDARD LO 0ISTLFA104A IC601 ✻ CS4391-KZ IC,PERIPHERALS 0IPRPCI003B IC602 NJM4580M IC,JRC 0IJR458000B IC604 ✻ MM1623XFBE IC,PERIPHERALS 0IPRPMT008A IC901 ✻ HMS81C2012AHK0 IC,MICRO CONTR 0IMCRHY070B IC902 KIA7042P IC,KEC 0IKE704200B Q6A1 KRC103M TRANSISTOR 0TR103009AE E Q201 2SA1037K TRANSISTOR,BIP 0TR103709BB Q201 ✻ 2SA1980SY TRANSISTOR,BIP 0TRAU80008A Q202 2SA1037K TRANSISTOR,BIP 0TR103709BB Q202 ✻ 2SA1980SY TRANSISTOR,BIP 0TRAU80008A ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 6 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks R231 RK73GB1J102J CHIP R 1.0K J 1/16W R232,3 RK73GB1J000J CHIP R 0 J 1/16W R234,5 RK73GB1J6R8J CHIP R 6.8 J 1/16W R501 RK73GB1J103J CHIP R 10K J 1/16W R502 RK73GB1J104J CHIP R 100K J 1/16W R503 RK73FB2A5R6J CHIP R 5.6 J 1/10W KPXY R503 RK73FB2A9R1J CHIP R 9.1 J 1/10W E R504 RK73FB2A561J CHIP R 560 J 1/10W R505-8 RK73GB1J472J CHIP R 4.7K J 1/16W R512-18 RK73GB1J101J CHIP R 100 J 1/16W R519-25 RK73GB1J330J CHIP R 33 J 1/16W R526 RK73FB2A100J CHIP R 10 J 1/10W R527 RK73GB1J472J CHIP R 4.7K J 1/16W R530 RK73GB1J330J CHIP R 33 J 1/16W R531 RK73GB1J105J CHIP R 1.0M J 1/16W R532 RK73GB1J473J CHIP R 47K J 1/16W R533-5 RK73GB1J122J CHIP R 1.2K J 1/16W R536,7 RK73GB1J000J CHIP R 0 J 1/16W R538 RK73GB1J122J CHIP R 1.2K J 1/16W R539 RK73GB1J000J CHIP R 0 J 1/16W R541 RK73GB1J330J CHIP R 33 J 1/16W R542-4 RK73GB1J000J CHIP R 0 J 1/16W R545 RK73GB1J103J CHIP R 10K J 1/16W R546,7 RK73GB1J332J CHIP R 3.3K J 1/16W R550 RK73GB1J472J CHIP R 4.7K J 1/16W R551 RK73GB1J103J CHIP R 10K J 1/16W R552 RK73GB1J000J CHIP R 0 J 1/16W R553,4 RK73GB1J330J CHIP R 33 J 1/16W R556,7 RK73GB1J000J CHIP R 0 J 1/16W R559 RK73GB1J000J CHIP R 0 J 1/16W R561,2 RK73GB1J472J CHIP R 4.7K J 1/16W R563 RK73GB1J123J CHIP R 12K J 1/16W R568 RK73GB1J122J CHIP R 1.2K J 1/16W R577 RK73GB1J000J CHIP R 0 J 1/16W R580 RK73GB1J103J CHIP R 10K J 1/16W R582 RK73GB1J000J CHIP R 0 J 1/16W R583 RK73GB1J103J CHIP R 10K J 1/16W R601-4 RK73GB1J752J CHIP R 7.5K J 1/16W R605 RK73GB1J562J CHIP R 5.6K J 1/16W R606 RK73GB1J472J CHIP R 4.7K J 1/16W R607 RK73GB1J822J CHIP R 8.2K J 1/16W R608,9 RK73GB1J182J CHIP R 1.8K J 1/16W R610,1 RK73GB1J822J CHIP R 8.2K J 1/16W R612,3 RK73GB1J182J CHIP R 1.8K J 1/16W R614 RK73GB1J822J CHIP R 8.2K J 1/16W R615 RK73GB1J330J CHIP R 33 J 1/16W R616,7 RK73GB1J331J CHIP R 330 J 1/16W R618,9 RK73GB1J221J CHIP R 220 J 1/16W R620,1 RK73GB1J104J CHIP R 100K J 1/16W R622 RK73GB1J102J CHIP R 1.0K J 1/16W R623,4 RK73GB1J472J CHIP R 4.7K J 1/16W R625-8 RK73GB1J102J CHIP R 1.0K J 1/16W R629-32 RK73GB1J750J CHIP R 75 J 1/16W R633 RK73GB1J472J CHIP R 4.7K J 1/16W R634 RK73GB1J562J CHIP R 5.6K J 1/16W ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 5 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 34 PARTS LIST Ref. No Add- ress New Parts Parts No. Description Desti- nation Re- marks Q203 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q203 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q203 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q204 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q204 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q204 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q205 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q205 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q205 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q206,7 2SK3018 TRANSISTOR,BIP 0TRRH80042A Q501 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q501 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q501 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q600 2SA1037K TRANSISTOR,BIP 0TR103709BB Q600 ✻ 2SA1980SY TRANSISTOR,BIP 0TRAU80008A Q601 KRC103S TRANSISTOR 0TR103009AC Q601 ✻ MMUN2112LT1 TRANSISTOR,BIP 0TRON80007A Q601 ✻ SRA2203S TRANSISTOR,BIP 0TRAU80012A Q602 KRC103S TRANSISTOR 0TR103009AC Q602 ✻ MMUN2112LT1 TRANSISTOR,BIP 0TRON80007A Q602 ✻ SRA2203S TRANSISTOR,BIP 0TRAU80012A Q603 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q603 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q603 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q604 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q604 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q604 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q605 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q605 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q605 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q606 ✻ BC846ALT1 TRANSISTOR,BIP 0TRON80009A Q606 ✻ KTC3875S-GR-T1 TRANSISTOR 0TR387509AC Q606 ✻ 2SC5343SG TRANSISTOR,BIP 0TRAU80017A Q901 KRC103S TRANSISTOR 0TR103009AA RC901 ✻ W02-4555-08 REMOTE CONTROL 6712R1038GA ZD6A1,2 MTZJ5.6B ZENER DIODE 0DZ562609AA E ZD6A3,4 MTZJ13B ZENER DIODE 0DZ132609CA E ZD6A5,6 MTZJ5.6B ZENER DIODE 0DZ562609AA E ✽ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. 7 L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai) Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components . HOW TO READ THE PARTS LIST ABBREVIATION OF MODEL AND MASS PRODUCTION'S DESTINATIONS Australia Canada Europe PX/AAFES USA X P E Y K DVF-3080-S 3 X3 P3 E3 Y3 K3 DVF-8100 8 - P8 E8 - K8 MODEL ABB. www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 DVF-3080-S/8100 SPECIFICATIONS [Type] System ................................................... DVD video player Signal read system ......................... Semiconductor laser [D/A Conversion Section] D/A conversion ......................................................... 24 Bit Oversampling ... 8 fs (Sampling frequency; 44.1, 48 kHz) ......................... 4 fs (Sampling frequency; 96 kHz) [Audio section] Frequency response Sampling frequency ; 44.1 kHz ........... 8 Hz ~ 20 kHz Sampling frequency ; 48 kHz ............... 8 Hz ~ 22 kHz Sampling frequency ; 96 kHz ............... 8 Hz ~ 44 kHz Signal to noise ratio ............................ More than 100 dB Dynamic range........................................ More than 92 dB Total harmonic distortion ...... Less than 0.007 % (1 kHz) Channel separation................... More than 90 dB (1 kHz) Wow and flutter ....................... Below measurable limit Analog output level/impedance ..................... 2 V / 550 Ω Digital output level/impedance COAXIAL.............................................. 0.5 Vp-p / 75 Ω OPTICAL (Only DVF-8100 for Europe) ............. -21 dBm ~ -15 dBm (Wave length 660 nm) [Video Section] Video output format ......................................... NTSC/PAL Video compression DVD ................................................................... MPEG-2 Composite video output level ......................... 1 Vp-p (75 Ω load, sync. negative) S-video output level (Except for Europe) (Y-signal) .............. 1 Vp-p (75 Ω load, sync. negative) (C-signal) NTSC ........................................... 0.286 Vp-p (75 Ω) PAL .............................................. 0.300 Vp-p (75 Ω) Component Video output level (Y-signal) ................................................. 1 Vp-p (75 Ω) (Cb-signal) ............................................ 0.7 Vp-p (75 Ω) (Cr-signal)............................................. 0.7 Vp-p (75 Ω) RGB output level (SCART) (For Europe)..... 0.7 Vp-p (75 Ω) Horizontal resolution ........................ More than 500 lines Video signal to noise ratio .................... More than 70 dB [General] Power consumption ................................................. 12 W Dimensions .................................. W : 440 mm (17-5/16 ) ........................................................ H : 44 mm (1-3/4 ) ........................................................ D : 249 mm (9-13/16 ) Weight (net) (DVF-3080) .............................................. 2.2 kg (4.9 lb) (DVF-8100) .............................................. 2.3 kg (5.1 lb) KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. ÷ Sufficient performance may not be exhibited at extremely cold locations (Where water freezes). Note Note www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299