© 2003-11 PRINTED IN JAPAN B53-0105-00 (N) 1839 CD RECEIVER KDC-5027/5027Y/508 SERVICE MANUAL Panel assy (A64-3195-02):KDC-5027/5027Y (A64-3196-02):KDC-508 Plastic cabinet assy (A02-1486-13) Lever (D10-4589-04) x2 Screw set (N99-1730-15) DC cord (E30-6132-15) Escutcheon (B07-3001-02):KDC-508 (B07-3083-02):KDC-5027/5027Y Mounting hardware assy (J22-0011-03) Antenna adaptor (T90-0523-05) CD MECHANISM EXTENSION CORD : W05-0618-00 TDF PANEL INFORMATION MODEL TDF PANEL No. TDF NAME KDC-5027/5027Y Y33-1930-64 TDF-5027 KDC-508 Y33-1930-65 TDF-508 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 2 BLOCK DIAGRAM BUFFER Q101 RDS DECODER IC7 Q201 BUFFER IC1 IC2 REMOCON RESET SW ENCODER ROTARY S1 WITH LCD DRIVER KEY MATRIX IC1 LCD PANEL DET S1 EJECT SW S1 EJECT ILLUMI DSI u-COM IC2 MPX E-VOL & ACC DET TEL MUTE B.U DET PRE MUTE DRIVER MUTE IC6 POWER IC IC4 THERMAL PROTECT ACC TEL MUTE BACK UP (REAR) PRE OUT SP OUT SURGE DET SERVO SERVO+B SW 14V Q21 WIRED REMO SUPPLY IC IC3 POWER ANT CON P CON RESET IC8 SW 5V Q4 PANEL 5V Q152 SW5V ILLUMI CON DRIVER MUTE S-METER AUDIO OUT IFC OUT PLL-DATA PLL-CLK SW5V AM+B A8V LOE/LIM SW 12EJE SW LOS SW MS CLK MS DATA M MUTE LO/EJ M STOP MOSW M RST SERVO+B A8V BU5V LX-DATA C LX-MUTE LX-REQ H LX-REQ C LX-CLK LX-CON LX-DATA H BACK UP NOISE QUAL S-METER R DATA R CLK FM AM MP IN LEVEL CD QUAL AFS CH SW5V BU5V PANEL DET EJECT DSI L CLK L DATAS L CE L DATAL VOLUME A VOLUME B REMO ILL CON MUTE P-MUTE PHONE ACC DET B.U DET BEEP PS1-0 PS1-1 PS1-2 PS2-0 PS2-2 RST BU5V BACK UP A8V SW5V BACK UP AM+B ILLUMI A8V BU5V BU5V BU5V MODE CD FM AM CH LEVEL 3600mV 1372mV 855mV 3600mV LX-RST TUNER CD CH SWITCH UNIT (X16- ) DAUGHTER UNIT (X89- ) www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 3 B B B B A x2 A x2 D C E G F H J How to Disassemble (PANEL ASSY) 1) Remove four screws (A). 2) While holding the section (B) indicated with arrows, pull and remove PANEL ASSY. DISASSEMBLY FOR REPAIR 3) Pull SWITCH UNIT (C) as indicated in the diagram and re- move knob (D). (The knob (D) is attached to the rotary with hook (E) and it is not possible to remove hook (D) only.) How to install knob (SRC) 1) Place knob (F) and knob (G) in the positions indicated in the diagram below. 2) While keeping these positions, use a piece of adhesive tape (H) to hold knobs in position, as shown in the diagarma. 3) Set the rotary (J) position as shown in the diagram. 4) While keeping the letters “SRC” horizontally in position, set it to the rotary on the panel. 5) Remove the adhesive tape (H). www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 4 ● SWITCH UNIT (X16-2502-70) Ref. No. Application/Function Operation/Condition/Compatibility IC1 LCD Driver Drives LCD IC2 Remote Control IC Controls the unit. Q1,Q4 REMO ON SW The power supply of IC2 is turned on when base level goes “L”. Q2 Key Illumination SW (Green) Lights Green key-illumination when base level goes “H”. Q3 Key Illumination SW (Red) Lights Red key-illumination when base level goes “H”. ● ELECTRIC UNIT (X34-3092-70) Ref. No. Application/Function Operation/Condition/Compatibility IC1 System µ-COM Controls FM/AM tuner, the changer, CD mechanism, Panel, volume, and tone. IC2 E.Vol & N.C.MPX Controls the source, volume, tone and FM multiplex detector. Bu5V (5V) Audio8V (8V) FM+B (8V) AM+B (8V) P-CON ANT-CON IC3 Power Supply IC IC4 Power IC Amplifies the front L/R and the rear L/R to 50W maximum. IC6 Muting logic IC Controls logic for muting. IC7 RDS decoder IC8 Reset IC “L” when detection voltage goes below 3.5V or less. Q1 Surge Detection “L” when the back-up voltage becomes more than 24V (momentary power down). “H” when the back-up voltage becomes less than 24V. Q2 BACK-UP Detection “L” when B.u is present. “H” when B.u is absent or momentary power down is detected. Q3 ACC Detection “L” when Acc is present. Q4 SW 5V ON when the base is “L”. Q21 Servo Regurator Q22 Servo SW Q101 Composite signal buffer DSI lights when the base is “L”. Q151 DSI Driver DSI turns off when the base is “H”. DSI turns on and off when panel is taken off. Q152 Panel 5V SW When the panel is attached, the base goes “L”, turning the Tr ON to supply 5V to the panel. When panel is taken off, panel 5Vcut off. Q153,Q154 ILLUMI Control ILLUMI lights when the base of Q153 is “H”. Q201 Noise buffer Q351 Pre Mute SW Mutes the Rear Lch when the base is “H”. Q352 Pre Mute SW Mutes the Rear Rch when the base is “H”. Q354 Pre Mute SW Drives the Pre Mute sw (Q351, 352) when the base is “L”. COMPONENTS DESCRIPTION SW1 OUT 1.5~3.0 Audio ON 3.5~5.0 Audio P-CON ON 7.0~ Audio P-CON P-ANT ON SW2 2.0~3.0 ILLUMI FM ON 4.0~ ILLUMI AM ON www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 5 MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name I/O Application Truth Value Processing Operation Description Table 1~5 N.C O OPEN (Output L fixed) 6 REMO I Remote control input 7 N.C O OPEN (Output L fixed) 8 BYTE I External data bus width switching input Connect to GND 9 CNVSS I Pull down at 1kΩ 10 XCIN I Sub clock input 11 XCOUT O Sub clock output 12 RESET I Reset input Normal : H, When RESET : L 13 XOUT O Main clock output 14 VSS - GND 15 XIN I Main clock input 16 VCC - Power supply input (5V) 17 NMI Pull up (B.U5V) 18 EJECT I EJECT detection input L : EJECT 19 R-CLK I RDS decoder CLK input (RDS model only) 20 LX-REQ S I Reception request from external slave L : Request 21 ILL CON O Illumination output control FLIP DET “L” during “H” 22 PANEL 5V I/O Panel 5V control L : ON (Panel detect & ACC ON) Hi-Z : OFF (Panel no detect or ACC OFF) 23 VOL A I VOL key input 24 VOL B I VOL key input 25 LOE/LIM SW (SW3) I CD DOWN SW detection H : Chucking 26 BEEP O BEEP output 27 M STOP O STOP request to CD mechanism When CD : H, When STOP : L 28 MOSW O CD mechanism MOTOR SW LOADING, EJECT, Brake : H 29 PLL-CLK I/O Clock output to F/E 30 PLL-DATA I/O Data input/output with F/E 31 LX-DATA M O Data output to external slave Last retention 32 LX-DATA S I Data input from external slave 33 LX-CLK I/O Clock input and output of external slave 34 LX-REQ M O Transmission request to external slave At request : L 35 L DATAS O Data output to LCD driver 36 L DATAL I Data input from LCD driver 37 L CLK I/O Clock output to LCD driver 38 FLIP-DET I Panel collapse detection L : Panel received, H : Panel collapse 39 L CE O CE output to LCD driver 40 LO/EJ I/O CD mechanism LOADING, EJECT switching STOP, Brake : Hi-z LOADING : L, EJECT : H 41 EPM I For flush writing Pull down at 100kΩ ● SYSTEM MICROCOMPUTER : M30302MC-1N4FP (X34 : IC1) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 6 MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name I/O Application Truth Value Processing Operation Description Table 42 M RST O RESET output to CD mechanism Normal : H, When RESET : L 43 M-MUTE R I MUTE request (Rch) from CD mechanism L : MUTE ON 44 12EJE SW (SW2) I 12cm DISC detection input L : 12cm disk 45 M-MUTE L I MUTE request (Lch) from CD mechanism L : MUTE ON 46 LX-CON O External slave selection ON : H, OFF : L 47 LO.S SW (SW1) I LOADING SW detection input L : LOADING START 48 DSI O EJECT key, DSI, guide ILLUMI output ILLUMI ON : L, ILLUMI OFF : H 49 PANEL-DET I Detection for panel or no panel H : Panel detect, L : Panel no detect 50 N.C O OPEN (Output L fixed) 51 IFC OUT I F/E IFC OUT input H : Station detect 52 R-DATA I RDS decoder DATA input (RDS model only) 53 R-QUAL I RDS decoder QUAL input (RDS MODEL only) 54 N.C OPEN (Output L fixed) 55 AFS O Constant switch terminal at noise detection During FM seek, AF search : L When receiving : H 56 SDA I/O Data input/output to IC2, CD mechanism 57 SCL I/O CLK output to IC2, CD mechanism 58 MUTE O IC2 MUTE control MUTE ON : H, MUTE OFF : L 59 N.C OPEN (Output L fixed) 60 IC2 TYPE 0 I Third party/genuine switching 0 L : Third party, H : Genuine (ROLL-OFF) 61 IC2 TYPE 1 I Third party/ genuine swithcing1 L : Third party, H : Genuine (NOISE-CANCEL) 62 VCC Power supply input (5V) 63 N.C O OPEN (Output L fixed) 64 VSS GND 65~67 TYPE 0~TYPE 2 I Destination switching port e 68 N.C O OPEN (Output L fixed) 69 SVR O Power IC SVR control Momentary power dropped : H 70 P-STBY O Power IC STBY control POWER IC ON : H, OFF : L ALL OFF during : L 71 P-MUTE O Power IC MUTE control When POWER OFF : L, When ALL OFF : L When TEL MUTE : L 72 SW5V I/O SW5V control ON : L, OFF : Hi-z 73 B.U-DET I Momentary power dropped detection input L : B.U detect, H : B.U no detect 74 ACC-DET I Acc detection input L : Acc detect, H : Acc no detect 75 N.C O OPEN (Output L fixed) 76~78 PS1-0~PS1-2 O Power supply IC control terminal q 79,80 PS2-0~PS2-1 O Power supply IC control terminal w www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 7 MICROCOMPUTER’S TERMINAL DESCRIPTION Truth Value Table q PS1-0 PS1-1 PS1-2 AUDIO P-CON P-ANT L L L OFF OFF OFF H (L) L (H) L ON OFF OFF H H L ON ON OFF H H H ON ON ON Truth Value Table w PS2-0 PS2-1 ILLUMI FM+B AM+B L L OFF OFF OFF H(L) L(H) ON ON OFF H H ON OFF ON Truth Value Table e MODEL DESTINATION TYPE 0 1 2 KDC-5027 E L L H KDC-5027Y E2 L L H KDC-508 E L L H KDC-3025 K H L H KDC-325 K H L H KDC-5026 M (K) H H H KDC-5026G M (K) H H H Pin No. Pin Name I/O Application Truth Value Processing Operation Description Table 81 LX-MUTE I MUTE request from external slave H : MUTE ON, L : MUTE OFF 82~88 N.C O OPEN (Output L fixed) 89 KEY-REQ I Communication request from LCD driver L : Key input detect 90~92 N.C O OPEN (Output L fixed) 93 S-METER I S-meter voltage input 94 NOISE I FM noise detection 95 N.C O OPEN (Output L fixed) 96 AVSS - GND 97 PHONE I PHONE detection 1V or less : TEL MUTE, 2.5V or more : NAVI MUTE 98 VREF I Reference voltage input Connect to 100 pin 99 AVCC - 5V 100 REFCON O VREF control While power ON : H www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 8 1. How to enter the test mode • While holding the Preset 1 and Preset 3 keys, reset the unit. 2. How to exit from the test mode • Reset the unit, momentary power down, ACC OFF, power OFF, and Panel detached. • (Note) The test mode cannot terminated by Panel is fall down. 3. Initial status in the test mode • Sources : All OFF. • Display : All segments are lit. • Volume : -10 dB (displayed as 30) • Loudness : OFF • CRSC : OFF regardless of the presence of switching function. • SYSTEM Q : Flat. • BEEP : When pressing any keys, the buzzer generates a beep at any time. • DISPLAY TYPE: TYPE A 4. RDS automatic measurement • An addition to disposal of substitute for visual check PS display as usual production lines. • P-CON terminal is OFF by force, when received the PS data and in case of corrobaration PS display is “RDS_TEST”. (“_” is mean blank.) • This disposal is test mode only. • P-CON is switching the source or return with power on→off. 5. Special display in Tuner mode When any of the following messages is displayed in Tuner mode, the front end may be abnormal. • “TNE 2P NG”: The EEPROM is set to the default (unstable values) because the F/E was shipped without passing through the adjustment process, etc. • “TNCON NG”: Communication with the F/E is not possible. 6. Forced switching of K3I • Each press of the Preset 6 key in Tuner mode should switch K3I from AUTO → Forced Wide → Forced Middle → Forced Narrow → AUTO. The initial status is AUTO and the dis- play shows these modes as follows. • AUTO : FMA • Forced Wide : FMW • Forced Middle : FMM • Forced Narrow : FMN TEST MODE 7.CD Receiver Test Mode Specification • When resetting to start, forced ejection of CD is prohib- ited. When a CD is in place, the CD is not recognized when reset. • When this key is pressed, the mechanism jumps to the following track. No9 → No15 → No10 → No11 → No12 → No13 → No22 → No14 → No9 (Return to the first track.) • When this key is pressed, the track goes down by one from the currently played track. • When a CD being played, by pressing [1] key intermittently, the mechanism can be made to jump to Track No. 28. 8. Audio-related specifications • A short press of the Q key initiates the audio adjustment mode. • Pressing the ✽ key on the remote initiates the audio adjustment mode. • Fader is selected to the initial item. • Continuous holding of a remote control key is inhibited. • Bass, Middle and Treble are adjusted in 3 steps of -8/0/+8 with the Track Up/Down keys. • Balance is adjusted in 3 steps of L15/0/R15 with the Track Up/Down keys. • Fader is adjusted in 3 steps of F15/0/R15 with the Track Up/Down keys. • Volume Offset is adjusted in 2 steps of -8/0 with theTrack Up/Down keys. 9. Menu-related specifications • A short press of the MENU key initiates the Menu mode. Except, tape source is usually press and hold 1 second to enter the menu mode and short press initiates turn over. • Pressing the DNPP/SBF key on the remote initiates the Menu mode. • Continuous holding of a remote control key is inhibited. • Contrast is adjusted in 3 steps of 0/5/10 (5x7dot), 0/4/7 (14seg) with the Track Up/Down keys. 10. Backup current measurement • When the unit is reset while ACC is OFF (i.e. by turning Back-Up ON), the MUTE terminal goes OFF in 2 seconds in place of 15 second. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 9 11. Special display when the display is All ON Pressing the Preset keys while the power is All OFF dis- plays the following information. [14seg 8 digits] 1key Version display (8 digits, Month/Day/Hour/Minute) (Display) xxxxxxxx 2key 3key Short press: View power ON time. (The All OFF period is not counted.) Long press/hold: Clear power ON time. (Display) PONxxxxx Max. 65535 (hours) 4key Short press: Display TAPE operation time. Long press/hold: Clear TAPE operation time. (Display) TPTxxxxx Max. 65535 (hours) 5key Short press: Display TAPE ejection count. Long press/hold: Clear TAPE ejection count. (Display) EJCxxxxx Max. 65535 (times) 6key Short press: Display Panel open/close count. Long press/hold: Clear Panel open/close count. (Display) PCxxxxx Max. 655359 (times) FM key Display ROM colection version (Display) ROM Rxxx Invalid :ROM R– [15x7dot 12 digits] 1key Version display (8 digits, Month/Day/Hour/Minute) (Display) SYS_xxxxxxxx 2key 3key Short press: View power ON time. (The All OFF period is not counted.) Long press/hold: Clear power ON time. (Display) PonTim_xxxxx Max. 65535 (hours) 4key Short press: Display TAPE operation time. Long press/hold: Clear TAPE operation time. (Display) TPTim_xxxxx Max. 65535 (hours) 5key Short press: Display TAPE ejection count. Long press/hold: Clear TAPE ejection count. (Display) EjeCnt_xxxxx Max. 65535(times) 6key Short press: Display Panel open/close count. Long press/hold: Clear Panel open/close count. (Display) PnCnt_xxxxxx Max. 655359 (times) FM key Display ROM colection version (Display) ROM Rxxx Invalid: ROM R– 12. Other specifications • The line mute against times are 1 second from 10 sec- onds when starting the test mode. ■ Security • Forced Power ON mode (All models) Even when the security is approved, resetting the unit while holding the Q and 4 keys makes it possible to turn the power ON for 30 minutes.After 30 minutes have elapsed, it is not possible to return to the previous condition unless the unit is reset again. • Method of registration of the security code after EEPROM (F/E) replacement (Code security model) 1. Enter the test mode. (See How to enter the test mode) 2. Press the MENU key to enter the MENU. 3. When the message “Security” is displayed, press and hold the Track Up/Down key for 1second to enter the Security registration mode. 4. Enter the code using the FM/AM/Track Down keys. • FM key : Number up • AM key : Number down • Track Up key : Cursor right shift • Track Down key : Cursor left shift 5. Hold down the Track Up key for at least 3 seconds and the message, “RE-ENTER” appears, so once again en- ter the code according to Step 4 above. 6. Press and hold the Track Up key for 3 seconds until “AP- PROVED” is displayed. 7. Exit from the test mode. (See 2 How to exit from the test mode) (Note) All Clear is not applicable to the security code of this model. • Simplified method of clearing the security code 1. While the code entry is requested, press and hold the Track Up key for 3 seconds while holding the AUTO key pressed. (----will dissappear.) 2. Enter “KCAR” from the remote. • Press the 5 key on the remote twice, then press the Track Up key. (This enters “K”) • Press the 2 key on the remote 3 times, then press the Track Up key. (This enters “C”) • Press the 2 key on the remote once, then press the Track Up key. (This enters “A”) • Press the 7 key on the remote twice, then press the Track Up key. (This enters “R”) 3. Security function is canceled and the unit enters the All OFF mode. 4. If you commit a mistake in the code entry, the unit en- ters the code request mode. TEST MODE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 10 A B C D E 1 2 3 4 5 6 7 CN4 J4 A1 CN3 J3 ELECTRIC UNIT X34-3092-70 (J74-1453-42) D302 D308 D307 D305 D306 D301 D303 D304 D202 D153 D162 D161 D155 D160 D154 D158 D152 D157 D151 D163 D201 D271 D269 D26 D27 D270/ D4 D3 D2 D253 D23 D2 J1 D31 D203 D255 D309 D311 D310 J2 C351 C352 C302 C253 C254 C251 C252 C255 C258 R22 W W41 R23 R31 R9 W205 R13 R113 R112 R114 R260/W202 R262/W204 R8 C C26 C164 C209 C354 C115 C117 X3 P1 C353 L3 C202 C201 BU5V GND RESET IFC NOISE CH-REQH CH-CON CH-CLK DATA CLK PLL-DATA S-MTR PLL-CLK CH-DATAC CH-DATAH C23 C256 C303 C211 C301 13 11 12 8 4 3 2 9 10 6 7 5 1 1 8 9 1 16 25 2 24 IC4 W32 W17 2 1 18 17 2 1 1 24 1 1 3 2 22 21 W37 W40 W43 W46 W38 W39 W20 W47 W44 W42 W48 W45 W49 W36 W34 W33 W31 W22 W21 W19 W16 W14 W15 W35 W60 W23 W26 W6 W7 W8 W10 W2 W12 W4 W9 W5 W59 W13 W30 W24 W25 W29 W50 CN2 CN1 S1 L10 L9 PC BOARD (COMPONENT SIDE VIEW) Refer to the schematic diagram for the values of resistors and capacitors. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 11 J I H G F 1 2 3 4 5 6 7 KI4 KS4 KS5 KI2 KI1 KS3 KI0 KS2 VCC VO 1 43 GND D2 SWITCH UNIT X16-2502-70 (J74-1568-02) D1 S1 D3 S2 D5 D6 D7 D10 D9 D8 D13 D12 D11 D32 D31 D4 IC2 ED1 AM FM RST AUD 1 2 3 4 5 6 DISP AUTO MENU SRC R2 C1 1 15 16 2 R1 R3 R4 R11 R6 R13 R7 R5 R12 R9 R10 R8 D1 J1 DAUGHTER UNIT X89-2570-10 (J74-1450-02) S1 X34-3092-70 IC Q Address 3 3F 4 2C 21 2G X16-2502-70 IC Address 2 3J D401 23 D22 D1 D21 R22 W51 L1 C24 C26 C409 X1 X2 C25 C28 CNVSS BU5V RESET S-MTR C22 C20 C27 C21 L2 C1 C23 C29 1 1 12 16 E B W46 W54 W47 W48 W52 W49 W50 W55 W58 W57 W53 L11 IC3 Q21 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 12 K L M N O 1 2 3 4 5 6 7 W101 C5 R10 C4 R254 C257 R261/W203 R259/W201 TH1 R253 R257 R252 R251 R255 C6 1 1 1 14 28 15 4 8 5 7 14 18 R12 R256 R32 R6 R1 B E E C C R4 R27 R28 R24 R25 R26 R315 C304 R414 R413 R411 R409 R412 R410 R408 R406 R407 R405 R404 R206 R101 C411 R168 R167 R52 R54 R53 R51 R59 R163 R155 R162 R153 R62 W103 W104 R501 W102 R67 R68 R64 C51 R61 R209 R210 R208 R312 R207 R203 C212 C205 C204 R204 C210 R304 R310 R311 R308 R309 R301 R306 R302 R307 R305 R303 C306 R205 R202 C165 R201 C203 R374 C206 C213 C52 R65 R152 R154 R313 R105 R63 R103 R102 R104 R60 R56 R58 R185 R166 R165 R184 R158 R186 R187 R159 R164 R314 C410 R402 C403 R106 C111 C401 R160 R161 R401 C402 R157 R403 R55 C3 R3 R5 R2 R21 C2 C31 R7 R11 R33 E B D258 Q1 Q22 Q2 E B Q3 E B Q20 B E Q356 B E Q151 E B Q152 Q502 Q501 E B E B E B Q154 E B Q153 E B Q4 IC6 IC10 IC2 Q23 B E D24 D25 D251 D254 D252 D257 D256 1 1 100 30 31 80 81 51 50 2 4 3 IC8 IC1 B E E C C ELECTRIC UNIT X34-3092-70 (J74-1453-42) PC BOARD (FOIL SIDE VIEW) Refer to the schematic diagram for the values of resistors and capacitors. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 13 T S R Q P 1 2 3 4 5 6 7 1 15 2 R10 C7 R22 C11 R11 KI4 R24 C6 R8 R16 V0 R14 R12 C10 R21 R23 CP1 CP2 R7 CP3 CP4 R31 C13 R25 C12 C8 16 J1 Q1 Q4 ESD-GND FLIPD GND RESET VOL B VOL A REMO DO CE CL PANEL 5V ILL +B DI KI2 KI1 KI0 KS5 KS3 KS2 KS4 48 33 1 16 17 32 64 49 B E B E E B E B IC1 Q3 Q2 D/ILL GND SWITCH UNIT X16-2502-70 (J74-1568-02) 17 1 2 18 CN1 DAUGHTER UNIT X89-2570-10 (J74-1450-02) X34-3092-70 IC Q Address 1 5L 2 4O 6 4M 7 5P 8 5K 1 3M 2 3M 3 3M 4 3M 22 3K 101 5P 151 5M 152 6M 153 5L 154 6L 201 4P 351 2P 352 2P 354 3P 501 6N 502 6M X16-2502-70 IC Q Address 1 5S 1 3S 2 6S 3 6S 4 3S R204 R360 R362 R364 R361 C357 C356 R351 R352 R358 R304 R310 R359 R363 R355 C356 R357 C306 R205 C118 C114 C119 C163 C113 R115 C112 R111 C116 E B Q201 E B Q101 B E Q356 E B Q355 B E B E Q351 Q352 B E Q354 9 16 8 1 IC7 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 14 U V W X Y 1 2 3 4 5 6 7 R82 R88 R86 R50 R84 R81 C61 R83 R87 R85 C36 C10 R9 C15 R10 C14 C44 R40 C43 C31 C42 R39 C47 C46 R49 C50 R46 R47 R42 C48 C45 R41 X1 CP2 CP1 C33 C75 C72 C71 C76 R31 C62 C73 C74 R37 R36 R53 C41 D3 Q6 EB S1 S2 S3 S4 CD PLAYER UNIT X32-5390-00 (J74-1485-12) 1 4 5 8 IC4 1 20 60 41 21 40 80 61 IC2 PC BOARD (COMPONENT SIDE VIEW) Refer to the schematic diagram for the values of resistors and capacitors. X32-5390-00 IC Q Address 2 4V 4 5V 6 2W www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 15 AD AC AB AA Z 1 2 3 4 5 6 7 Refer to the schematic diagram for the values of resistors and capacitors. D2 Q4 E E B B EB Q3 E B Q2 Q1 D1 BE Q5 1 16 1 16 32 17 CN1 IC1 R2 R1 R15 R14 R4 C1 R44 R43 C2 R5 C5 R6 C12 R7 R45 C52 R38 C34 C100 R100 R72 R48 C49 R33 R71 C38 R34 R32 R51 R37 C51 R89 R90 R92 C78 C77 R91 C40 C32 C101 C102 R52 R12 C17 C16 R11 C13 R8 C3 C18 VDET FE B/TE R13 VREF LDON A/TE PWM TBAL FBAL C39 TRCRS BDO OFT NRFDET GCTL VREF2 RFENV D/ARF CP4 CP5 CP3 SPDL SLED TRK FCS R35 C7 C8 C6 C11 C9 R3 16 30 15 1 IC3 CN2 TE IOP- VREF E ARF F RF IOP+ GND 12EJE LOS /CLK DATA PON LDCNT RW TRK IN TRK OUT FCS DOWN FCS UP D.GND BU.5V SPDL- SPDL+ /MUTER /MUTEL SLED IN/EJECT SLED OUT/LOAD MOTOR LO/EJ S7.5V S.GND 8EJE Rch A.GND 1 24 Lch A.+8V SPL LOE/LIM DRVMUTE /MSTOP D.OUT VCC GND LD PD VR C B A /MRST TVD TRD FOD SBIO P54 P53 P52 P51 P50 CD PLAYER UNIT X32-5390-00 (J74-1485-12) PC BOARD (FOIL SIDE VIEW) X32-5390-00 IC Q Address 1 2AB 3 6AB 1 3AA 2 3AA IC Q Address 3 3AA 4 5AC 5 2AB www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 16 A B C D E 1 2 3 4 5 6 7 10K 4.7K 22K 22K 2.3 4.80V 0.87pp 1.25V 1.70V 0V 0-4.8V 0V 2.40V 2.50V 4.90V 2.50V 0V 4.80V 2.40V 2.40V 2.40V 2.45V 0V 0V 4.80V 0V 4.80V 4.80V 3.0pp 5.0pp 0V 4.80V 4.80V 4.80V 4.90V 0V 4.90V 0-4.9V 0V 0-4.9V 0V 0V 0V 0.15V 0V 4.80V 2.40V 4.80V 4.90V 0V 7.80V 0V 0V 3.84V 0V 3.84V 7.80V 0V 4.90V 4.90V 4.90V 4.90V 4.90V 4.90V 4.90V 4.90V 0V 0-4.9V 3.84V 3.10V 3.10V 3.10V 3.10V 3.84V 7.80V 0V 0V 0V IC2 CD PLAYER UNIT (X32-5390-00) IC4 S2 ∗S4 S1 CN2 Q4 D2 Q3 Q2 Lch Rch A.GND A+5V BU+5V D.GND A.GND 12EJE SW LOS SW 8EJE SW SWITCH DOWN & LIMIT S3 DIGITAL +5V SW L.P.F. A+8V ANALOG +8V SW SW CD SIGNAL PROCESSOR MECHANISM CONTROL BULT IN MICRO PROCESSOR 10K S.GND 2 LOE/LIM SW 1 S.7.5V MOTOR LO/EJ A.GND 5 3 4 Rch Lch 6 7 8 BU+5V 15 A.+8V MSTOP MRST MUTE L MUTE R D.GND 9 10 11 12 13 14 8EJE SW DATA LOS SW 12EJE SW 18 NC 16 17 CLK 19 20 21 100x4 CP2 100x2 CP1 D.OUT 22 R72 200 R44 1K DEMPH/TRCRSO/TEXTCRC SENSE/RESY/FLAG/STOUT EFM/NFLOCK/CLDCK/STCK PCK/NTLOCK/FCLK/STLD DATA MSEL1 MSTOP OCD CLK RST IFZR IFZL 100Kx4 R43 CP5 61 63 62 65 64 66 R100 C100 16.934MHz X1 1000P 10 R42 4.7K 49 DRV MUTE VER/HOR TEST2 TEST1 XSUB2 XSUB1 DVSS2 DVDD3 NC 60 59 58 57 56 52 55 54 53 X2 51 50 X1 CLVS/VDET/CRC LOE/LIM(SW4) 12EJE/SDET(SW3) 8EJE(SW2) HOT 48 47 46 45 44 43 42 41 LRCK SRDATA VREFP 40 38 39 ICRST BCLK 36 37 35 FOD DVDD2 LDCNT CD-RW LO/EJ MOTOR P-ON MCNT XSEL EQCNT CLK SBIO SBIO 73 70 68 67 TX 69 71 72 74 76 75 78 77 79 C36 2.2 TRCRS 28 31 NC ASEL MSEL0 33 34 32 OUTL DVSS3 CSEL 30 29 AVDD2 AVSS1 OUTR AVDD1 27 25 26 TE FE 23 24 22 RFENV 21 C101 1000P 1000P C102 C34 0.1 100K R94 C33 0.1 C32 0.1 4 L R 5 65 63 61 62 66 68 29 27 L R 27 29 A/TE TRCRS FE RF 61 62 63 66 68 65 0.1 C47 0.1 C46 79 27K R46 R49 23 22 24 6 5 GND 3 4 2 7 8 VCC 1 68P C73 68P C74 330 R87 330 R88 2200P C75 C76 2200P 20K R83 R81 20K R84 20K R82 20K 470P C72 470P C71 0.1 C62 R85 20K R86 20K 0.1 C78 5.6K R92 3.3K R90 5.6K R91 0.1 C77 R89 3.3K (X34-) CN2 to X32-5390-00 (1/2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 17 J I H G F 1 2 3 4 5 6 7 CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. 0.17V 3.81V 4.90V 2.47V 1.44V 3.38V 2.50V 4.16V 0V 3.94V 0V 0V 0V 3.06V 2.50V 2.50V 2.50V 2.50V 2.50V 2.69V 2.69V 2.69V 0.95pp 0.91pp 2.50V 2.35V 2.35V 2.40V 2.35V 2.35V 2.45V 4.90V 0V 7.80V 3.50V 3.90V 3.84V 3.84V 3.81V 3.81V 3.60V 3.60V 7.80V 0V 0V 0V 2.35V 2.35V 2.35V 2.35V 2.35V 7.80V 2.35V 4.80V 4.80V 2.45V 0V 0.87pp 1.25V 1.70V 0V 0-4.8V 0V 2.40V 2.40V 2.40V 2.40V 2.40V 4.80V 2.50V 0V 0V 0.17V 2.69V 2.69V 2.69V 2.69V 0V 2.50V 3.84V 3.81V 3.81V 3.84V 2.00V IC3 IC1 KDC-3022, 322, 5023R (1/3) KDC-5024/V/Y/YV (1/3) KDC-507, 5094RY (1/3) (X93- ) OPTICAL PICKUP DPU1 DTA143XUA : Q4 D1 D3 D2 Q6 Q5 DA204U MA8051-L DAN202U 2SA1576A 2SC4081 : : : : : Q3 Q2 Q1 IC3 IC2 IC1 DTC124EUA MN6627771KP 2SA1362(Y) MCH6101 BA5824FP AN22002AA : : : : : : Q6 Q5 D3 D1 CN1 Q1 M M LOADING & SLED MOTOR SPINDLE MOTOR DM2 (X92- ) DM1 (X92- ) S.GND S.7.5V SPDL FCS TRK SLED D.GND D.5V Vref GND LINE SIGNAL LINE B LINE APC CURRENT AMP 4ch BTL DRIVER RF AMP DIGITAL LINE NJM4580M1 IC4 : 9 24 CNT LDIN OUTSL INSL- INSL+ OUT3 IN3- PREVCC IN2- BIAS 1 2 6 IN1- IN1+ OUT2 4 3 5 MUTE PREGND OUT1 7 8 C49 1500P C38 0.01 R48 10K 18K 10K R34 R33 2.2K R47 C51 1500P R71 13K 27 28 26 25 C37 0.01 R51 10K R50 3.9K R31 27K 10K R32 VO3+ VO3- VO4+ VO4- POW VCC2 POW GND2 VO2- VCC1 GND1 11 10 12 VO1+ VO1- 14 13 VO2+ 22 23 21 19 20 18 17 VREF GND R45 10K TRD FOD 79 80 TRCRS 22 12 FBAL TVD SPL PC PWM TBAL 1 2 3 4 5 NRFDET OFT BDO LDON DSLB DVDD1 9 6 7 8 10 11 PLLF2 DVSS1 AVSS2 DSLF ARF RFSW PLLF 13 14 15 16 17 18 IREF RFENV 21 19 20 C48 6800P C50 6800P 1000P R38 220K C31 0.1 C40 0.015 C41 C39 0.01 39K R35 R53 4.7K 10K R36 C10 0.033 R9 3.9K 4700P C14 C15 2200P B/TE 17 R41 47K C3 1 16 FCS- TRK- TRK+ FCS+ GND C+D GND VCC TBAL FBAL GCTL FEOUT FEN TEN TEOUT TEBPF VDET C52 0.1 R52 4.7K B GCTL 6.2K R37 24 VDET C13 270P R8 27K 19 18 20 22 21 23 C16 330P R11 33K 27 25 26 F E 28 D 30 29 32 C 31 A R15 4.7K IOP- IOP+ R4 10 R1 91 12 16 15 14 13 A 9 11 10 F B 8 7 6 E PD 5 4 3 VR LD 2 1 VC C6 39P VCC 9 COFTR OFTR NRFDET 14 15 13 3TOUT CBDO BDO 11 12 10 6 CAGC ARF CEA 8 7 RFN RFOUT RFIN 5 3 4 C12 3300P C11 6800P PD LD 1 2 C7 0.1 3.3K R6 RF R5 3.3K C1 10u6.3 R14 100K C2 2.2 18 19 13 12 SPDL- SPDL+ X32-5390-00 X32-5390-01 S4 YES NO TRCRS C45 0.1 C44 1000P C43 2200P R39 100K 820 R40 0.047 C42 RFENV BDO OFT NRFDET 9 7 8 4.7Kx4 CP4 1.8Kx4 CP3 16 TRK OUT TRK IN 14 15 FCS UP FCS DOWN 16 17 SLED IN /EJECT /LOAD SLED OUT 12 13 18 19 5 4 1 80 1 2 79 80 27K R46 39K R49 8 7 9 R7 3.6K 2P C5 ARF 1 C8 4700P C9 R13 240K C18 0.1 C17 0.1 R3 5.6K R2 5.6K 6 5 4 F E B CD A 6 5 100K R10 F A B E CD 22 24 23 22 4 79 2 14 16 15 17 2.2 C61 Q5,6 15 29 30 R12 910K POW POW + X32-5390-00 (2/2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 18 K L M N O 1 2 3 4 5 6 7 X34-3092-70 (1/3) P1 DEMODULATOR Q101 RDS CN1 D161 D162 D160 D155 D153 D154 D151 D152 D158 D157 5V SW D163 DET. SW PANEL S1 Q154 DRIVER DSI Q151 PANEL Q152 CONTR ILL. Q153 DETECTOR VOLUME & FM MPX ELECTRONIC Q201 SW Q351 D308 D306 D304 D311 D303 D302 D301 D307 D310 D309 REMO WIRED ∗CN4 ∗A1 J4 D201 D202 FM/AM TUNER E2P-ROM D203 FRONT LX-CN J2 D305 SW MUTE Q355 CN3 Q356 J3 MUTE DRIVE REAR MUTE Q354 MUTE SW Q352 PRE OUT ANT CORD WITH CONNECTOR ∗ D ∗ C R161 2.2M R160 2.2K 6 0.01 RESET C116 R111 EJECT VOL A VOL B DSI N. C FLIP DET L DATAS L DATAL L CLK N. C L CE ESD GND RDCL 52 RDDA VDDA C118 680P 10u16 C115 0.01 C114 7 CIN SCOUT 8 VSSA 6 2.2U50 C117 VREF MPX 3 4 5 12 9 MODE 11 10 VDDD SYNC VSSD 4.332MHz X3 13 OSCI 15 14 OSCO TCON 2.2K R115 27P 27P C112 C113 R112 2.2K R113 2.2K 53 330P QUAL 1 2 4.7K R114 2.2K 16 19 13 18 17 15 16 14 12 9 10 11 8 6 7 35 39 R162 100K R152 470 R154 470 R153 470 37 89 36 R185 470K R163 100K R157 470 R155 2.2K 38 24 R164 47K R184 470K R158 470 R159 1K 23 18 D GND PAN 5V ILL GND ILL +B REMO R186 2.2K 47K C163 0.01 C165 0.01 5 3 4 2 1 4 R R 47K C164 10u16 R165 R166 4.7K 22 R187 48 21 QUAL R355 R312 100K R313 100K R315 100K C304 0.01 ∗R374 RF GND OSCGND OSCGND OSCGND IFCOUT VDD5V OSCGND S-METER 2 1 1K 10 C201 N. C IF+B C119 24 IF GND N. C 23 22 2.2K 19 20 21 AUDIO N. C R106 93 C111 1000P 15 4.7K 16 17 18 D-GND SCL R105 29 R103 4.7K PLL+B 13 14 SDA 12 11 VT 30 51 2.2u50 C209 + 2 1 VREF GREF R202 0.022 C203 5 2.2u50 2.2u50 C202 + R206 1K 6 7 CDR 3 5 4 CASSL CASSR 8 6 7 9 10 RH- CDGND CDL AFS AM 0.47 C205 R203 4.7K 4.7K C213 0.1 11 12 MPX LEVEL 13 14 MPOUT MPIN 24 4 7 8 9 N. C 5 6 AM+B N. C 1 2 FMIN AMIN 3 ACOUTL RFOUT LFOUT ACOUTR 27 28 26 25 FR FL L3 L10 4.7uH 8 7 6 5 GND LROUT RROUT VDD 23 22 21 GND 4 SDA C210 0.01 RR RL C211 47u10 1 2 3 A0 A1 A2 VCC WP SCL SCL SDA 19 20 SMUTE 18 17 R207 R208 1K 57 56 10K 1K 10K R209 R210 C306 0.01 20 DATA S Lch RST Rch A GND MUTE C302 0.47u50 C303 47u10 46 34 6 5 81 C301 0.47u50 7 7 32 33 31 R311 100 R310 100 BU CON REQ H 8 4 3 7 GND 5 1 2 6 13 12 11 DATA M CLK REQ S 9 10 FL R314 100K C353 10u16 RL FR C354 10u16 R360 360 10u16 C351 R361 22K C357 0.01 C356 0.01 R359 360 R363 180 1 360 R351 180 R362 22K R364 2 3 180 R357 22K 100K R414 1 2 VCC 13 14 R204 4.7K MUXL MUXR 16 15 94 2.2K R205 55 58 R352 RR 10u16 C352 360 2 22K R356 180 R358 L9 4.7uH 1 2 3 F GND FL FR FRONT REMO. CONT 4.7K R305 4.7 R306 10 R302 10 R301 4.7K R307 4.7K R309 4.7K R308 4.7K R304 100 R303 470 R104 470 R102 1K R101 + + + 10K R201 0.01 C204 150P C206 0.1 C212 + + + + + + + + + IC7 IC10 (X34-3092-70) IC2 IC6 ELECTRIC UNIT 2.5V 0V 0V 0V 5.0V 2.5V 2.5V 5.0V 5.0V 0V 0V 0V 0V 5.0V 5.0V 0V 0V 4.0V 4.0V 4.0V 4.0V 4.0V 4.0V 4.7V 4.0V 4.0V 4.8V 4.1V 4.1V 4.1V 8.2V 4.1V 0V 5.0V 0V 5.0V 0V 3.6V 0.3-3.5V 5.0V 0V 4.7K 10K 47K 47K 47K 4.7K 4.7K 4.7K 4.7K 22K 22K 4.7K www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 19 T S R Q P X34-3092-70 (2/3) Q502 Q501 POWER S CN2 DET. SW PANEL CONTROL ILL. Q153 MICROPROCESSOR SYSTEM E E IC RESET D401 CD SERVO SW SW14 D21 Q4 Q3 ACC DET D4 DET B. U SW5V Q21 D27 Q23 Q22 D26 D271 AUDIO IC POWER D269 Q1 Q2 DET SERGE D2 D3 TEL MUTE D31 D25 D1 D23 D22 D24 SUPPLY IC POWER J1 DC-CN to CD MECHA UNIT CN2 (X32- ) ∗ B ∗ A C403 0.1 C6 0.01 1K R501 RESET SERVOGND 21 N. C MS-DATA LO. S SW 12EJE SW D-OUT MS-CLK M-MUTE R D-GND B. U5V N. C AUDIO+B M-MUTE L M-RST Lch M-STOP SERVO+B LO/EJ Rch GND MOSW 0.01 C52 R65 100K R64 100K 0.01 R68 2.2K 47K 470K 1K R167 R168 470 R187 R67 470 21 49 W103 2 1 5 4 3 9 8 7 6 10 13 12 11 15 14 18 17 16 20 19 R54 1K C51 R62 100K R61 100K R52 2.2K R51 2.2K 44 47 R53 1K 43 W104 R56 1K R55 1K 42 45 27 R59 100 R60 1K 40 28 LOE/LIM SW 36 33 31 32 34 35 R403 100K 39 37 38 40 46 42 43 44 45 49 48 47 22 PANEL 5V 22 26 28 PLL-DATA PLL-CLK MOSW 28 29 30 30 29 M STOP BEEP LOE/LIM SW(SW3) VOL B VOL A 25 27 27 26 24 23 25 24 23 20 R63 2.2K R58 2.2K 25 C410 0.01 NMI ILL CON LX-REQ S R-CLK EJECT 21 22 21 19 18 20 19 18 VCC XIN VSS XOUT X1 15 10.000MHz 17 16 W102 14 13 EPM L DATA L L DATA S LX-REQ H LX-CLK LX-DATA S LX-DATA M 33 32 31 36 35 34 LO/EJ L CE FLIP-DET L CLK 39 38 37 41 40 12EJE SW(SW2) LX-CON M-MUTE L M-MUTE R M RST 43 42 46 45 44 PANEL-DET LO.S SW DSI 49 48 47 N.C 50 + 1 2 4 3 5 VCC 13 14 11 12 9 10 GND 7 6 8 FL- FL+ 7 RR FR C254 RR- RR+ 0.22u50 0.22u50 C252 FR+ FR- RL+ RL- AVCC 2 32.768kHz R401 1K C402 22P 18P X2 C401 6 8 XCOUT XCIN CNVSS BYTE 12 11 10 9 N.C REMO N.C N.C N.C N.C 5 7 6 4 3 NC VSS 3 4 VDD VOUT R402 N.C 1 100K 2 1 REFCON 99 100 N.C NOISE VREF N.C AVSS PHONE KEY-REQ S-METER N.C N.C N.C 94 97 98 94 95 96 89 93 91 92 93 88 89 90 N.C N.C N.C N.C N.C N.C LX-MUTE 85 86 87 82 83 84 81 81 C21 100u10 73 74 5.6K R13 72 L11 4.7uH R12 47K 1/2W R10 22K C4 0.01 R8 3.3K R11 22K C5 0.01 R7 22K 33K R9 1.5K R21 C27 10u50 R24 10K + 78 C409 47u6.3 Q23 ILM 12 R27 10K R28 10K R26 10K R25 10K 80 79 77 76 SW2 11 10 SW1 1u50 PWGND2 STBY VCC2 TAB OUT2- OUT2+ 1 3 5 2 4 6 C255 R251 47K C257 1 PWGND1 AUXIN PWGND3 OUT1- OUT1+ 7 9 IN1 PREGND IN3 OUT3+ 11 13 15 17 8 10 RIP 12 IN2 14 IN4 16 18 20 VCC1 MUTE PWGND4 23 OUT3- OUT4+ 19 21 OUT4- CLIP OUT 25 22 24 330 R255 RL FL 0.22u50 C253 0.22u50 C251 C256 22u16 R253 4.3K R254 10 70 26 R256 330K 0.22u50 C258 R257 15K TH1 71 7 8 6 4 5 3 1 2 10K R6 10K C3 1000P R3 100K R2 36K 10K R5 R4 20K R1 82K R33 47K R31 FL- FL+ RL+ FL- FL+ RL+ RR- FR- RL- RR+ FR+ RL- FR- RR- P-ANT FR+ RR+ TEL MUTE P-CON GND ACC 10u16 + 220u16 100u16 0.01 10u25 + C26 27uH L2 + C20 22K C31 R32 C25 10u16 + C28 VDD VBU 9 VCC 7 8 C24 + AUDIO AM 6 5 3300u16 C1 + 4.7K R23 140uH C2 0.01 L1 B.U. R22 4.7K ∗W101 10u16 + C23 10u25 C29 FM 4 PANT 3 10u25 C22 PCON 2 1 GND 16 10 9 13 11 12 14 15 FUSE F1 10A + W203 W201 + + + + + IC1 C6 IC8 IC4 IC3 0V 5.0V 0V 0V 0V 5.0V 0V 5V 5V 0V 5.0V 0V 0V 5.0V 5.0V 0V 5.0V 5.0V 5.0V 0V 5V 0V 5V 0V 5V 0V 0V 0V 5.0V 0V 5.0V 5.0V 0V 0V 5.0V 0V 5V 0V 0V 0V 5V 5V 5V 0V 0V 5V 5V 0V 0V or 5.0V 0V or 5.0 9.8V 0V 7.2V 3.7V 0V 3.7V 0V 5.0V 0V 5.0V 0V 5.0V 5.0V 0V 0V 5.0V 0V 5.0V 5.0V 0V 0V 5V 0V 5.0V 5.0 0V 5.0V 0V 5.0V 0V 0.6V-4.1V 5.0V 0V-5.0V 0V-1.6V 0V 5V 0V 0V 5.0V 10.3V 2.4V 0V 4.8V 4.4V 2V 0V 0V 4.9V 0V 14.4V 8.8V 0V 3.7V 14.4V 0V 0V 4.3V 0V 13.1V 14.4V 5.0V 8.1V 7.9V 0V 8.1V 14.1V 14.2V 3.7V 3.7V 7.2V 7.2V 7.2V 7.2V 7.2V 7.2V 7.2V 47K 47K 22K 22K 47K 47K www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 20 Y X W V U 1 2 3 4 5 6 7 CAUTION : For continued safety, replace safety critical com- ponents only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance volt- meter. Values may vary slightly due to variations between individual instruments or/and units. X34-3092-70 (3/3), X89-2570-10 (1/1) DTA114EE DTC143TUA DTC144EE 2SA1036K 2SA1362 2SA1576A 2SC4617 2SC4081 DTA124EUA DTC124EUA DTC144EUA UMC2N DAN202U DA204U DTA114YUA MA142WK UN5212 MCH6101 1SS133 MA4062-L 160-163,301-308 D151-155,157,158, HZS5B1 : D31 : : D2-4,201,202,309-311 D26,27,203,269,271,401 D1F60 AM01ZNF D22,23 MA4082(N)-L MA4068(N)-M D24,25 : : D21 : : 1N5393G-M6 DTA124EUA 2SA1577 DTC144EUA 2SA1576A DTA114YUA : Q154 D1 Q354,501 : : Q153,502 Q152 Q151 : : : DTC143TUA Q101,201,351,352,355, UMC2N 2SD2375 2SA1036K 2SC4081 : Q21 Q22,23 356 : : Q4 Q1-3 : : BR24C01AF-W PST3435UL SAA6581T HD74HC27FP-E TB2903H BA4911-V4 TDA7407D : IC6 IC10 IC8 IC7 : : : IC4 IC3 IC2 : : : M30302MC-1N4FP IC1 : POWER SUPPLY CONTROL S1 SW EJECT CN1 2/2 UNIT J1 (X16- ) J1 GND LINE B LINE (X34-309x-xx) SIGNAL LINE SWITCH to IFC OUT IC2 TYPE 0 IC2 TYPE 1 B.U-DET ACC-DET 49 48 PANEL-DET DSI 49 48 N.C 50 ILM SW2 SW1 VDD VBU VCC AUDIO AM FM PANT PCON GND R9 470 ∗R410 22K R10 470 R12 1K R11 1K R13 1K 57 52 51 52 R-DATA 51 53 R-QUAL N.C 53 54 AFS SDA SCL 55 56 57 56 55 C411 0.01 60 MUTE N.C 58 59 VCC 61 62 R404 22K 58 R406 22K 65 N.C VSS TYPE 0 63 64 TYPE 1 66 ∗R408 22K ∗R409 22K REMO 5 PANEL-5V D-GND 1 2 ILL-GND ILL+B 3 4 RESET EJECT 6 7 VOL-A VOL-B 8 9 C1 0.01 15 13 5 6 9 8 17 14 15 L-CE 14 L-DATAL D-GND 16 PANEL-5V L-CLK 12 R5 470 R6 1K R8 240 R7 1K R3 470 R4 470 R2 470 R1 1K 0-12 0-21 0-11 76 71 P-MUTE N.C TYPE 2 67 N.C P-STBY 68 69 70 ∗R411 22K 70 R413 22K 73 SW5V 71 72 N.C PS1-0 74 75 72 73 74 76 L-DATAL 14 (DIMMER) EJECT-ILL FLIP-DET V-CLK 10 11 L-DATAS 12 13 ESD-GND V-DATA 16 L-CLK 15 L-CE 17 18 79 PS1-1 PS1-2 PS2-0 77 78 PS2-1 80 79 77 78 80 KDC-3025 KDC-325 11 9 7 5 3 9 14 11 13 12 11 13 5 16 16 15 17 6 8 12 1 VOL-B 6 V-CLK (DIMMER) REMO L-DATAS 10 ILL+B V-DATA 8 RESET ILL-GND VOL-A 4 FLIP-DET ESD-GND 2 X86-3720-11 X86-3720-11 X86-3722-11 YES YES YES NO NO NO NO NO NO YES NO NO YES YES YES NO NO NO NO NO YES UNIT No. R374, 410 2-70 KDC-5027/Y KDC-508 MODEL NAME X86-3722-70 NO YES D A NO YES C B R409 NO YES A1 R408 NO R411 NO NO NO YES W101 ANT CONT 4 13 P.CON RR+ RR- FR- FR+ FL- FL+ RL+ RL- B.U GND BLU/WHT 2 15 BLK 1 16 YEL RED 3 14 BRN TEL MUTE ANT CONT ACC GND 9 8 GRN/BLK VIOL/BLK FL+ 8 9 BLU/WHT WHT/BLK GRY/BLK FR+ P CONT FR- FL- GRY VIOL 5 12 6 7 11 10 WHT GRN RL+ RR+ RL- RR- GRN/BLK VIOL/BLK 13 4 BLU/WHT P. CON RED 2 1 BLK 15 16 YEL 3 14 WHT/BLK GRY/BLK FRONT R FRONT L 11 6 GRY BLU 5 12 VIOL 7 10 B.UP REAR R REAR L WHT GRN A 1 2 3 5 4 6 ACC 7 8 B 1 2 3 5 7 6 4 8 NO YES YES YES CN4 KDC-5026/G TEL MUTE BRN KDC-325 (1/2) C3 (X89-2570-10) A KDC-508 KDC-5027/Y (E30-6132-15) DC CORD KDC-5026/G KDC-325/3025 DC CORD (E30-6322-05) DAUGHTER UNIT 5V 0V 5.0V 0V 5.0V 0V 5V 0V 0V or 5.0V 0V or 5.0V 5.0V 0V 5.0V 0V 5.0V 0V 0V 5.0V 10.3V 8.1V 14.1V 14.2V 5.0V 0V 5.0V 0V 0V 5.0V 5.0V 0V 5.0V 0V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 21 Z AA AB AC AD 1 2 3 4 5 6 7 X16-2502-70 (1/2) 8 1 5 7 13 3 9 10 14 12 6 15 ILL+B ILL GND VOL B CL RESET VOL A CE NC NC REMO DI FLIP DET 4.7 R8 0.01 100 R10 2.2 C7 2 PANEL 5V R11 1K ESD-GND C6 16 GND 4 11 DO 6 4 GND 3 GND 2 GND 1 VCC VO 2 3 1 4 5 6 4 TP13 TP1 TP3 TP2 TP5 TP4 TP6 TP8 TP11 TP14 TP16 TP10 TP12 0.01 C10 0.01 C11 S42 S35 C1 C4 S41 C2 C3 S38 S39 S36 S37 S33 S34 S4 S3 1 2 S30 S31 S32 S27 S29 S28 S24 S26 S25 S21 S23 S22 S14 S9 S7 S6 S8 S5 S12 S13 S11 S10 S18 S20 S19 S17 S16 S15 SEG34 SEG36 SEG37 SEG35 SEG38 SEG33 49 SEG41 SEG42 COM3 COM2 COM4 SEG39 47 48 46 KS4 KS2 KS3 COM1 42 43 44 45 41 37 38 39 36 40 33 34 35 SEG4 55 KI4 KI2 KI3 KI1 KI0 KS5 52 50 51 53 54 V2 V1 V0 VDD OSC VSS 58 56 57 59 61 60 CE SO SI SCL 63 62 64 GREEN SEG3 RED 1 3 2 20 26 27 28 29 30 32 31 SEG30 SEG32 SEG31 SEG27 SEG29 SEG28 21 22 24 25 23 SEG24 SEG26 SEG25 SEG21 SEG23 SEG22 SEG14 SEG9 SEG6 SEG5 SEG8 SEG7 SEG11 SEG10 SEG13 SEG12 6 5 4 8 7 11 10 9 13 12 SEG18 SEG20 SEG19 SEG17 SEG16 SEG15 17 19 18 16 15 14 61 62 63 64 64 63 62 61 CP1 10K 470 CP3 1K R7 1K CP4 1K 1K KI4 KI3 KI0 KI2 KI1 KS5 KS3 KS4 Q2,3 TP21 TP26 TP27 KI4 TP28 TP24 TP25 TP23 TP22 KI3 KI2 TP29 KS3 TP30 TP31 KS4 TP32 KS5 TP20 TP19 TP18 KI0 KI1 TP33 2.2K R14 2 R12 2.2K 330 R23 R24 330 330 R25 270 R31 1 CP2 R16 D-GND+ FRIP DET 330 R22 560 R21 0.01 C12 0.01 C8 0.01 C13 TP35 J1 1/2 to J1 IC1 : NJU6535 IC2 : PNA4S22M Q1 : DTA114EE Q1 B30-1571-05 D2 : D31,32 : S31 RESET Q2,3 : B30-1605-05 D1 : B30-1564-05 D3-13 : B30-1566-05 REMOTE X89 CONTROL IC 2SC4617 REMO. CONTROL SW GND LINE B LINE Q4 UP/DOWN VOL S1 ILLUMINATION SW KEY AUTO/ S15 S13 DISP S14 6 4 S12 SRC S2 S18 FM S20 AM 3 S17 S19 S21 EQ S28 S25 S26 S27 S24 S23 5 S11 2 S16 1 S22 D4 D7 Q3 D6 D10 D13 Q2 D9 D12 D5 D8 D11 D2 D31 D32 D1 DTC144EE Q4 : LCD DRIVER D3 TI A IC2 SWITCH UNIT (X16-2502-70) IC1 10K 10K 47K 47K 0V 0V 5V 5.0V 5V 0V 5.0V 0V ED1(COMMON ED1(SEGMEN www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5027/5027Y/508 22 AI AH AG AF AE 1 2 3 4 5 6 7 CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. X16-2502-70 (2/2) KDC-5027/Y(2/2) KDC-508 (2/2) KRC-597/Y (2/2) 16 2 1 3 10 12 5 4 6 11 9 13 11 12 14 15 28 22 19 17 18 20 21 25 23 24 26 27 29 31 30 33 32 34 36 35 41 43 42 38 40 39 37 SEG9 SEG42 COM4 SEG41 COM2 COM3 COM1 SEG38 SEG39 SEG37 SEG35 SEG36 SEG34 SEG32 SEG33 SEG31 SEG29 SEG30 SEG28 SEG26 SEG27 SEG25 SEG23 SEG24 SEG22 SEG15 SEG20 SEG21 SEG19 SEG17 SEG18 SEG16 SEG12 SEG14 SEG13 SEG11 SEG10 SEG3 SEG6 SEG8 SEG7 SEG5 SEG4 S3 S4 S6 S7 S5 S9 S10 S8 S14 S12 S13 S11 S15 S16 S32 S29 S31 S30 S28 S27 S24 S25 S26 S23 S22 S19 S20 S21 S18 S17 S39 S35 S37 S28 S36 S24 S33 S42 S41 C1 C4 C3 C2 COM4 COM3 COM1 COM2 43 41 42 40 38 39 37 35 36 34 9 21 27 32 33 31 30 29 28 24 26 25 23 22 15 18 20 19 17 16 12 14 13 11 10 6 11 12 5 4 3 1 2 SEG23 SEG5 SEG3 SEG4 SEG6 SEG7 SEG10 SEG8 SEG9 SEG11 SEG12 SEG18 SEG13 SEG15 SEG14 SEG16 SEG17 SEG19 SEG20 SEG21 SEG22 SEG24 SEG25 SEG26 SEG28 SEG27 SEG31 SEG29 SEG30 SEG32 SEG33 SEG36 SEG34 SEG35 SEG37 SEG38 SEG41 SEG42 SEG39 MMON) GMENT) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 23 3 2 1 B A 858 K K 31 DM1 30 26 28 25 14 16 17 18 23 45 38 801 44 24 52 29 19 27 F DM2 834 850 849 807 806 37 43 43 43 56 37 37 53 41 51 55 36 33 33 40 15 39 42 11 13 12 10 22 32 35 43 2 37 Bx2 Ax2 Jx2 DPU1 H F F G DFPC1 E A B C E F G H J K : N09-4460-05 : N09-4472-15 : N09-6004-05 : N09-6007-05 : N09-6051-05 : N19-2163-04 : N39-2020-46 : N09-6108-05 : N09-6155-05 φ2x8 M1.7x8.5 M1.7x2.5 M2x2 φ2x6(BLK) 1.6 WASHER M2x2 M2x3.5 φ2x6 (X32) 8 809 5 Cx2 EXPLODED VIEW (MECHANISM) Refer to the service manual X92-4030-0x (B51-7867-00) for CD mechanism operation. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 24 3 2 1 D C (X16-) (X16) (X89-) ED1 DC1 F1 FC1 B C D E F G H J K L M3x8 φ2x6 φ2x8 φ3x5 φ2x5 φ2.6x6 φ3x8 φ3x10 φ3x20 φ2.6x6 : N30-3008-46 : N80-2006-46 : N80-2008-45 : N83-3005-46 : N84-2005-45 : N84-2606-45 : N80-3008-46 : N80-3010-46 : N83-3020-46 : N86-2606-46 208 215x2 244 771 770 772 728 765 720 206 261 201 G G G F 216 234 237 251 217 236 240 233 767 746 704 218 241 745 203 Ex2 Kx2 E E H J L K E DME1 (X34-) 702 E E Bx2 205 Dx2 Dx2 242 235 766 280 282 283 786 785 281 221 243 256 PA1 210 213 250 212 252 211 707 254 255 257 253 232 C Cx2 209 A 1 J 4 J 3 J 2 J 1 262 224 Parts with the exploded numbers larger than 700 are not supplied. EXPLODED VIEW (UNIT) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 25 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KDC-5027 E1 : KDC-508 E2 : KDC-5027Y PARTS LIST 201 1C A02-1486-13 PLASTIC CABINET ASSY 203 3D A22-2982-22 SUB PANEL ASSY 205 2C ✽ A46-1797-01 REAR COVER 206 1D A52-0829-02 TOP PLATE PA1 3C ✽ A64-3195-12 PANEL ASSY EE2 PA1 3C ✽ A64-3196-12 PANEL ASSY E1 - B46-0100-50 WARRANTY CARD EE1 - B46-0612-14 ID CARD - ✽ B64-2701-00 INSTRUCTION MANUAL (ENGLISH) - ✽ B64-2702-00 INSTRUC. MANUAL (FRE.GER.DUT.) EE1 - ✽ B64-2703-00 INSTRUC. MANUAL (ITA.SPA.POR.) EE1 - ✽ B64-2708-00 INSTRUC. MANUAL (HUN.CRO.SLO.) E2 - ✽ B64-2709-00 INSTRUCTION MANUAL (SWE.FIN.) E2 - ✽ B64-2721-00 INSTRUC. MANUAL (RUS.POL.CZE.) E2 208 1C B07-3001-02 ESCUTCHEON E1 208 1C B07-3083-02 ESCUTCHEON (DARK BLUE) EE2 209 3C ✽ B09-0533-03 CAP (ROTARY) 210 3C ✽ B10-4483-11 FRONT GLASS EE2 210 3C ✽ B10-4484-11 FRONT GLASS E1 211 3C ✽ B10-4493-12 FRONT GLASS E1 211 3C ✽ B10-4496-12 FRONT GLASS EE2 212 3C ✽ B11-1440-04 OPTICAL DIFFUSER 213 3C ✽ B43-1518-04 BADGE 215 1C D10-4589-04 LEVER 216 3D D10-4730-03 LEVER (LOCK) 217 3D D10-4731-03 LEVER (PUSH) 218 3D D39-0255-05 DAMPER 221 3C ✽ E29-1967-02 CONDUCTIVE RUBBER 224 2D E30-6224-15 CORD WITH CONNECTOR (WIRED-R/C) DC1 1C E30-6132-15 DC CORD FC1 2D E39-0476-05 FLAT CABLE (22PIN) F1 2D F52-0006-05 FUSE (MINI BLADE TYPE) (32V 10A) 232 3C G01-3203-04 COMPRESSION SPRING 233 3D G01-3171-04 TORSION COIL SPRING (LOCK) 234 3D G01-3172-04 TORSION COIL SPRING (PUSH) 235 2C G01-3173-04 COMPRESSION SPRING (REAR COVER) 236 3D G13-1267-04 CUSHION 237 3D ✽ G13-1273-04 CUSHION - H10-4856-12 POLYSTYRENE FOAMED FIXTURE - ✽ H13-2043-04 CARTON BOARD - H25-0329-04 PROTECTION BAG (280X450X0.03) E2 - H25-0337-04 PROTECTION BAG (180X300X0.03) - H25-1111-04 PROTECTION BAG (280X450X0.03) EE1 - ✽ H54-3015-03 ITEM CARTON CASE E - ✽ H54-3016-03 ITEM CARTON CASE E1 - ✽ H54-3019-03 ITEM CARTON CASE E2 240 3D J19-5203-03 HOLDER (LEFT) 241 3D J19-5204-03 HOLDER (RIGHT) 242 2C J19-5205-03 HOLDER (REAR COVER) 243 3C ✽ J19-5271-02 HOLDER 244 1D J22-0011-03 MOUNTING HARDWARE ASSY 250 3C ✽ K23-1081-03 KNOB (ROTARY) 251 3D K24-4000-03 KNOB (EJECT) 252 3C ✽ K24-4102-03 KNOB (SRC) 253 3C ✽ K24-4103-04 KNOB (REL) 254 3C ✽ K25-1593-03 KNOB (AUTO/CLK) 255 3C ✽ K25-1594-03 KNOB (PLAY/Q) 256 3C ✽ K25-1641-02 KNOB (PRESET) 257 3C ✽ K25-1642-03 KNOB (FM/AM) 261 1C N99-1730-15 SCREW SET B 3D N30-3008-46 PAN HEAD MACHINE SCREW (M3X8) C 3C N80-2006-46 PAN HEAD TAPTITE SCREW (2X6) D 2C N80-2008-45 PAN HEAD TAPTITE SCREW (2X8) E 1D N83-3005-46 PAN HEAD TAPTITE SCREW (3X5) F 3D N84-2005-45 PAN HEAD TAPTITE SCREW G 3D N84-2606-45 PAN HEAD TAPTITE SCREW (2.6X6) 262 1C T90-0523-05 ANTENNA ADAPTOR DME1 1D X92-4650-00 CD MECHANISM ASSY 280 2D ✽ B11-1439-04 OPTICAL DIFFUSER 281 2D ✽ B11-1441-04 REFLECTION SHEET 282 2D ✽ B19-2243-02 LIGHTING BOARD D1 B30-1564-05 LED (1608,BLUE) D2 B30-1566-05 LED (1608,RED) D3-13 B30-1605-05 LED (2COLOR PG/RED) D31,32 B30-1571-05 LED (WHITE) ED1 ✽ B38-1135-05 LIQUID CRYSTAL C6 CK73GB1H103K CHIP C 0.010UF K C7 CK73FB1A225K CHIP C 2.2UF K C8 CK73GB1H103K CHIP C 0.010UF K C10-13 CK73GB1H103K CHIP C 0.010UF K 283 2D ✽ E29-1968-04 CONDUCTIVE RUBBER J1 E59-0829-05 RECTANGULAR PLUG CP1 R90-0714-05 MULTI-COMP 10K X4 CP2 R90-1016-05 MULTI-COMP 470 X4 CP3,4 R90-0724-05 MULTI-COMP 1K X4 R7 RK73GB2A102J CHIP R 1.0K J 1/10W R8 RK73GB2A4R7J CHIP R 4.7 J 1/10W R10 RK73GB2A101J CHIP R 100 J 1/10W R11 RK73GB2A102J CHIP R 1.0K J 1/10W R12 RK73GB2A222J CHIP R 2.2K J 1/10W R14 RK73GB2A222J CHIP R 2.2K J 1/10W R16 RK73GB2A102J CHIP R 1.0K J 1/10W R21 RK73FB2B561J CHIP R 560 J 1/8W R22-25 RK73FB2B331J CHIP R 330 J 1/8W R31 RK73FB2B271J CHIP R 270 J 1/8W S2 S70-0814-05 TACT SWITCH S1 ✽ T99-0449-05 ROTARY ENCODER KDC-5027/5027Y/508 SWITCH UNIT (X16-2502-70) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 26 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation PARTS LIST E : KDC-5027 E1 : KDC-508 E2 : KDC-5027Y IC1 NJU6535 MOS-IC IC2 PNA4S22M ANALOGUE IC Q1 DTA114EE DIGITAL TRANSISTOR Q2,3 2SC4617 TRANSISTOR Q4 DTC144EE DIGITAL TRANSISTOR C1 C92-0566-05 CHIP-TAN 10UF 6.3WV C2 CK73FB1A225K CHIP C 2.2UF K C3 CK73GB0J105K CHIP C 1.0UF K C5 CC73GCH1H020C CHIP C 2.0PF C C6 CC73GCH1H390J CHIP C 39PF J C7 CK73GB1C104K CHIP C 0.10UF K C8 CK73GB0J105K CHIP C 1.0UF K C9 CK73GB1H472K CHIP C 4700PF K C10 CK73GB1C333K CHIP C 0.033UF K C11 CK73GB1H682K CHIP C 6800PF K C12 CK73GB1H332K CHIP C 3300PF K C13 CC73GCH1H271J CHIP C 270PF J C14 CK73GB1H472K CHIP C 4700PF K C15 CK73GB1H222K CHIP C 2200PF K C16 CC73GCH1H331J CHIP C 330PF J C17,18 CK73GB1C104K CHIP C 0.10UF K C31-34 CK73GB1C104K CHIP C 0.10UF K C36 CK73FB1A225K CHIP C 2.2UF K C37-39 CK73GB1H103K CHIP C 0.010UF K C40 CK73GB1H153K CHIP C 0.015UF K C41 CK73GB1H102K CHIP C 1000PF K C42 CK73GB1E473K CHIP C 0.047UF K C43 CK73GB1H222K CHIP C 2200PF K C44 CK73GB1H102K CHIP C 1000PF K C45-47 CK73GB1C104K CHIP C 0.10UF K C48 CK73GB1H682K CHIP C 6800PF K C49 CK73GB1H152K CHIP C 1500PF K C50 CK73GB1H472K CHIP C 4700PF K C51 CK73GB1H681K CHIP C 680PF K C52 CK73GB1C104K CHIP C 0.10UF K C61 CK73FB1A225K CHIP C 2.2UF K C62 CK73GB1C104K CHIP C 0.10UF K C71,72 CK73GB1H471K CHIP C 470PF K C73,74 CC73GCH1H680J CHIP C 68PF J C75,76 CK73GB1H222K CHIP C 2200PF K C77,78 CK73GB1C104K CHIP C 0.10UF K C100-102 CK73GB1H102K CHIP C 1000PF K CN1 E40-9536-05 FLAT CABLE CONNECTOR CN1 E41-0193-05 FLAT CABLE CONNECTOR CN2 E40-9339-05 FLAT CABLE CONNECTOR CN2 E41-0129-05 FLAT CABLE CONNECTOR X1 L78-0851-05 RESONATOR (16.93MHZ) CP1 R90-1019-05 MULTI-COMP 100 X2 CP2 R90-1014-05 MULTI-COMP 100 X4 CP3 R90-0974-05 MULT R 1.8K X4 CP4 R90-0718-05 MULTI-COMP 4.7K X4 CP5 R90-0720-05 MULTI-COMP 100K X4 R1 RK73GB2A910J CHIP R 91 J 1/10W R2,3 RK73GB2A562J CHIP R 5.6K J 1/10W R4 RK73FB2B100J CHIP R 10 J 1/8W R5,6 RK73GB2A332J CHIP R 3.3K J 1/10W R7 RK73GB2A362J CHIP R 3.6K J 1/10W R8 RK73GB2A273J CHIP R 27K J 1/10W R9 RK73GB2A392J CHIP R 3.9K J 1/10W R10 RK73GB2A104J CHIP R 100K J 1/10W R11 RK73GB2A333J CHIP R 33K J 1/10W R12 RK73GB2A244J CHIP R 240K J 1/10W R13 RK73GB2A914J CHIP R 910K J 1/10W R14 RK73GB2A104J CHIP R 100K J 1/10W R15 RK73GB2A472J CHIP R 4.7K J 1/10W R31 RK73GB2A273J CHIP R 27K J 1/10W R32 RK73GB2A103J CHIP R 10K J 1/10W R33 RK73GB2A183J CHIP R 18K J 1/10W R34 RK73GB2A103J CHIP R 10K J 1/10W R35 RK73GB2A393J CHIP R 39K J 1/10W R36 RK73GB2A103J CHIP R 10K J 1/10W R37 RK73GB2A622J CHIP R 6.2K J 1/10W R38 RK73GB2A224J CHIP R 220K J 1/10W R39 RK73GB2A104J CHIP R 100K J 1/10W R40 RK73GB2A821J CHIP R 820 J 1/10W R41 RK73GB2A473J CHIP R 47K J 1/10W R42 RK73GB2A472J CHIP R 4.7K J 1/10W R43 RK73GB2A102J CHIP R 1.0K J 1/10W R44,45 RK73GB2A103J CHIP R 10K J 1/10W R46 RK73GB2A273J CHIP R 27K J 1/10W R47 RK73GB2A222J CHIP R 2.2K J 1/10W R48 RK73GB2A103J CHIP R 10K J 1/10W R49 RK73GB2A473J CHIP R 47K J 1/10W R50 RK73GB2A392J CHIP R 3.9K J 1/10W R51 RK73GB2A103J CHIP R 10K J 1/10W R52,53 RK73GB2A472J CHIP R 4.7K J 1/10W R71 RK73GB2A133J CHIP R 13K J 1/10W R72 RK73FB2B201J CHIP R 200 J 1/8W R81-86 RK73FB2B203J CHIP R 20K J 1/8W R87,88 RK73FB2B331J CHIP R 330 J 1/8W R89,90 RK73GB2A332J CHIP R 3.3K J 1/10W R91,92 RK73GB2A562J CHIP R 5.6K J 1/10W R94 RK73GB2A104J CHIP R 100K J 1/10W R100 RK73GB2A100J CHIP R 10 J 1/10W S1,2 S68-0863-05 PUSH SWITCH S3 S68-0862-05 PUSH SWITCH D1 DAN202U DIODE D1 MA142WK DIODE D2 MA8051-L ZENER DIODE D3 DA204U DIODE IC1 AN22002AA ANALOGUE IC IC2 MN6627771KP MOS-IC IC3 BA5824FP ANALOGUE IC IC4 NJM4580M1 ANALOGUE IC Q1 MCH6101 TRANSISTOR Q2 2SA1362 (Y) TRANSISTOR CD PLAYER UNIT (X32-5390-00) SWITCH UNIT (X16-2502-70) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 27 E : KDC-5027 E1 : KDC-508 E2 : KDC-5027Y Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation PARTS LIST Q3 DTC124EUA DIGITAL TRANSISTOR Q3 UN5212 DIGITAL TRANSISTOR Q4 DTA143XUA DIGITAL TRANSISTOR Q5 2SC4081 TRANSISTOR Q6 2SA1576A TRANSISTOR C1 C94-0216-05 ELECTRO 3300UF 16WV C2 CK73GB1H103K CHIP C 0.010UF K C3 CK73GB1H102K CHIP C 1000PF K C4-6 CK73GB1H103K CHIP C 0.010UF K C20 C90-2962-05 ELECTRO 100UF 16WV C21 CD04AS1A101M ELECTRO 100UF 10WV C22 CD04AS1E100M ELECTRO 10UF 25WV C24,25 CD04AS1C100M ELECTRO 10UF 16WV C26 CD04AS1E100M ELECTRO 10UF 25WV C27 CD04AT1H100M ELECTRO 10UF 50WV C28 C90-2980-05 ELECTRO 220UF 16WV C29 CD04AS1C100M ELECTRO 10UF 16WV C31 CK73GB1H103K CHIP C 0.010UF K C51,52 CK73GB1H103K CHIP C 0.010UF K C111 CK73GB1H102K CHIP C 1000PF K C112,113 CC73GCH1H270J CHIP C 27PF J C114 CK73GB1H103K CHIP C 0.010UF K C115 CD04AS1C100M ELECTRO 10UF 16WV C116 CC73GCH1H331J CHIP C 330PF J C117 CD04AS1H2R2M ELECTRO 2.2UF 50WV C118 CC73GCH1H681J CHIP C 680PF J C119 CK73GB1H103K CHIP C 0.010UF K C163 CK73GB1H103K CHIP C 0.010UF K C164 CD04AS1C100M ELECTRO 10UF 16WV C165 CK73GB1H103K CHIP C 0.010UF K C201,202 CD04AS1H2R2M ELECTRO 2.2UF 50WV C203 CK73GB1H223K CHIP C 0.022UF K C204 CK73GB1H103K CHIP C 0.010UF K C205 CK73GB1A474K CHIP C 0.47UF K C206 CC73GCH1H151J CHIP C 150PF J C209 CD04AS1H2R2M ELECTRO 2.2UF 50WV C210 CK73GB1H103K CHIP C 0.010UF K C211 CD04AS1A470M ELECTRO 47UF 10WV C212,213 CK73GB1C104K CHIP C 0.10UF K C251-254 C94-0179-05 ELECTRO 0.22UF 50WV C255 CD04AS1H010M ELECTRO 1UF 50WV C256 CD04AS1C220M ELECTRO 22UF 16WV C257 CK73GB1A105K CHIP C 1.0UF K C258 ✽ C94-0048-05 ELECTRO 0.22UF 50WV C301,302 ✽ CD04AS1HR47M ELECTRO 0.47UF 50WV C303 CD04AS1A470M ELECTRO 47UF 10WV C304 CK73GB1H103K CHIP C 0.010UF K C306 CK73GB1H103K CHIP C 0.010UF K C351,352 CD04AS1C100M ELECTRO 10UF 16WV C356 CK73GB1H103K CHIP C 0.010UF K C401 CC73GCH1H180J CHIP C 18PF J C402 CC73GCH1H220J CHIP C 22PF J C403 CK73GB1C104K CHIP C 0.10UF K C409 ✽ CD04AS0J470M ELECTRO 47UF 6.3WV C410,411 CK73GB1H103K CHIP C 0.010UF K CN1 E41-0167-05 PIN ASSY CN2 E40-9550-05 FLAT CABLE CONNECTOR CN4 E40-3260-05 PIN ASSY J1 E58-0863-15 RECTANGULAR RECEPTACLE J2 E56-0834-05 CYLINDRICAL RECEPTACLE J3 E63-0887-05 PIN JACK J4 E04-0312-05 RF COAXIAL CABLE RECEPTACLE L1 L33-1170-05 CHOKE COIL ASSY L2 L33-1926-05 CHOKE COIL L3 L33-1123-05 LINE FILTER COIL L9-11 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) X1 L78-0879-05 RESONATOR (10.0MHZ) X2 L77-2793-05 CRYSTAL RESONATOR X3 L77-2002-05 CRYSTAL RESONATOR E 2D N83-3005-46 PAN HEAD TAPTITE SCREW H 2D N80-3008-46 PAN HEAD TAPTITE SCREW J 2D N80-3010-46 PAN HEAD TAPTITE SCREW K 2D N83-3020-46 PAN HEAD TAPTITE SCREW L 2D N86-2606-46 BINDING HEAD TAPTITE SCREW R1 RK73GB2A823J CHIP R 82K J 1/10W R2 RK73GB2A363J CHIP R 36K J 1/10W R3 RK73GB2A104J CHIP R 100K J 1/10W R4 RK73FB2B203J CHIP R 20K J 1/8W R5,6 RK73GB2A103J CHIP R 10K J 1/10W R7 RK73GB2A223J CHIP R 22K J 1/10W R8 RD14DB2H332J SMALL-RD 3.3K J 1/2W R9 RD14BB2C333J RD 33K J 1/6W R10,11 RK73GB2A223J CHIP R 22K J 1/10W R12 RK73GB2A473J CHIP R 47K J 1/10W R13 RD14BB2C562J RD 5.6K J 1/6W R21 RK73FB2B152J CHIP R 1.5K J 1/8W R22,23 RD14BB2C472J RD 4.7K J 1/6W R25-28 RK73GB2A103J CHIP R 10K J 1/10W R31 RD14BB2C103J RD 10K J 1/6W R32 RK73GB2A223J CHIP R 22K J 1/10W R33 RK73GB2A473J CHIP R 47K J 1/10W R51,52 RK73GB2A222J CHIP R 2.2K J 1/10W R53-56 RK73GB2A102J CHIP R 1.0K J 1/10W R58 RK73GB2A222J CHIP R 2.2K J 1/10W R59 RK73GB2A101J CHIP R 100 J 1/10W R60 RK73GB2A102J CHIP R 1.0K J 1/10W R61,62 RK73GB2A104J CHIP R 100K J 1/10W R63 RK73GB2A222J CHIP R 2.2K J 1/10W R64,65 RK73GB2A104J CHIP R 100K J 1/10W R67,68 RK73GB2A471J CHIP R 470 J 1/10W R101 RK73GB2A102J CHIP R 1.0K J 1/10W R102 RK73GB2A471J CHIP R 470 J 1/10W R103 RK73GB2A472J CHIP R 4.7K J 1/10W R104 RK73GB2A471J CHIP R 470 J 1/10W R105 RK73GB2A472J CHIP R 4.7K J 1/10W R106 RK73GB2A222J CHIP R 2.2K J 1/10W R111 RK73GB2A472J CHIP R 4.7K J 1/10W CD PLAYER UNIT (X32-5390-00) ELECTRIC UNIT (X34-3092-70) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 28 E : KDC-5027 E1 : KDC-508 E2 : KDC-5027Y Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation PARTS LIST DAUGHTER UNIT (X89-2570-10) R112-114 RD14BB2C222J RD 2.2K J 1/6W R115 RK73GB2A222J CHIP R 2.2K J 1/10W R152-154 RK73GB2A471J CHIP R 470 J 1/10W R155 RK73GB2A222J CHIP R 2.2K J 1/10W R157,158 RK73GB2A471J CHIP R 470 J 1/10W R159 RK73GB2A102J CHIP R 1.0K J 1/10W R160 RK73GB2A222J CHIP R 2.2K J 1/10W R161 RK73GB2A225J CHIP R 2.2M J 1/10W R162,163 RK73GB2A104J CHIP R 100K J 1/10W R164,165 RK73GB2A473J CHIP R 47K J 1/10W R166 RK73GB2A472J CHIP R 4.7K J 1/10W R167 RK73GB2A474J CHIP R 470K J 1/10W R168 RK73GB2A102J CHIP R 1.0K J 1/10W R184,185 RK73GB2A474J CHIP R 470K J 1/10W R186 RK73GB2A222J CHIP R 2.2K J 1/10W R187 RK73GB2A473J CHIP R 47K J 1/10W R201 RK73GB2A103J CHIP R 10K J 1/10W R202-204 RK73GB2A472J CHIP R 4.7K J 1/10W R205 RK73GB2A222J CHIP R 2.2K J 1/10W R206-208 RK73GB2A102J CHIP R 1.0K J 1/10W R209,210 RK73GB2A103J CHIP R 10K J 1/10W R251 RK73GB2A473J CHIP R 47K J 1/10W R253 RK73GB2A432J CHIP R 4.3K J 1/10W R254 RK73GB2A100J CHIP R 10 J 1/10W R255 RK73GB2A331J CHIP R 330 J 1/10W R256 RK73GB2A334J CHIP R 330K J 1/10W R257 RK73GB2A153J CHIP R 15K J 1/10W R301,302 RK73EB2E100J CHIP R 10 J 1/4W R303 RK73EB2E101J CHIP R 100 J 1/4W R304,305 RK73EB2E472J CHIP R 4.7K J 1/4W R306 RK73EB2E4R7J CHIP R 4.7 J 1/4W R307-309 RK73EB2E472J CHIP R 4.7K J 1/4W R310,311 RK73EB2E101J CHIP R 100 J 1/4W R312-315 RK73GB2A104J CHIP R 100K J 1/10W R351,352 RK73GB2A361J CHIP R 360 J 1/10W R355,356 RK73GB2A223J CHIP R 22K J 1/10W R357,358 RK73FB2B181J CHIP R 180 J 1/8W R374 RK73EB2E102J CHIP R 1.0K J 1/4W R401 RK73GB2A102J CHIP R 1.0K J 1/10W R402,403 RK73GB2A104J CHIP R 100K J 1/10W R404 RK73GB2A223J CHIP R 22K J 1/10W R406 RK73GB2A223J CHIP R 22K J 1/10W R408 RK73GB2A223J CHIP R 22K J 1/10W R410 RK73GB2A223J CHIP R 22K J 1/10W R413 RK73GB2A223J CHIP R 22K J 1/10W R414 RK73GB2A104J CHIP R 100K J 1/10W R501 RK73GB2A102J CHIP R 1.0K J 1/10W W101 R92-2052-05 CHIP R 0 OHM J 1/10W W102 R92-1252-05 CHIP R 0 OHM J 1/16W W103,104 R92-2053-05 CHIP R 0 J 1/8W W201 R92-1252-05 CHIP R 0 OHM J 1/16W W203 R92-1252-05 CHIP R 0 OHM J 1/16W S1 S74-0821-05 MICRO SWITCH D1 1N5393G-M6 DIODE D2-4 MA4068 (N)-M ZENER DIODE D21 MA4082 (N)-L ZENER DIODE D22,23 AM01ZNF DIODE D24,25 D1F60 DIODE D26 1SS133 DIODE D31 HZS5B1 ZENER DIODE D151-155 MA4062-L ZENER DIODE D157,158 MA4062-L ZENER DIODE D160-163 MA4062-L ZENER DIODE D201,202 MA4068 (N)-M ZENER DIODE D203 1SS133 DIODE D269 1SS133 DIODE D271 1SS133 DIODE D301-308 MA4062-L ZENER DIODE D309-311 MA4068(N)-M ZENER DIODE D401 1SS133 DIODE IC1 M30302MC-1N4FP MICROCONTROLLER IC IC2 TDA7407D ANALOGUE IC IC3 BA4911-V4 ANALOGUE IC IC4 ✽ TB2903H ANALOGUE IC IC6 HD74HC27FP-E MOS-IC IC7 SAA6581T ANALOGUE IC IC8 PST3435UL MOS-IC Q1-3 2SC4081 TRANSISTOR Q4 2SA1036K TRANSISTOR Q21 2SD2375 TRANSISTOR Q22 UMC2N TRANSISTOR Q101 DTC143TUA DIGITAL TRANSISTOR Q151 DTA114YUA DIGITAL TRANSISTOR Q152 2SA1576A TRANSISTOR Q153 DTC144EUA DIGITAL TRANSISTOR Q153 KRC404 DIGITAL TRANSISTOR Q154 2SA1577 TRANSISTOR Q201 DTC143TUA DIGITAL TRANSISTOR Q351,352 DTC143TUA DIGITAL TRANSISTOR Q354 DTA124EUA DIGITAL TRANSISTOR Q354 KRA303 DIGITAL TRANSISTOR Q501 DTA124EUA DIGITAL TRANSISTOR Q501 KRA303 DIGITAL TRANSISTOR Q502 DTC144EUA DIGITAL TRANSISTOR Q502 KRC404 DIGITAL TRANSISTOR TH1 PTH9C42BE471Q POSITIVE RESISTOR A1 2D X86-3722-70 FRONT-END UNIT C1 CK73GB1H103K CHIP C 0.010UF K CN1 E41-0169-05 SOCKET FOR PIN ASSY J1 E58-0865-05 RECTANGULAR RECEPTACLE R1 RK73EB2E102J CHIP R 1.0K J 1/4W R2-5 RK73EB2E471J CHIP R 470 J 1/4W R6,7 RK73EB2E102J CHIP R 1.0K J 1/4W R8 RK73EB2E241J CHIP R 240 J 1/4W R9,10 RK73EB2E471J CHIP R 470 J 1/4W ELECTRIC UNIT (X34-3092-70) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 29 E : KDC-5027 E1 : KDC-508 E2 : KDC-5027Y Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation PARTS LIST R11-13 RK73EB2E102J CHIP R 1.0K J 1/4W S1 S70-0871-05 TACT SWITCH 2 1B ✽ A10-4827-32 CHASSIS 5 1B ✽ D10-4576-63 ARM ASSY 8 2A D10-4579-13 LEVER ASSY 10 2A D10-4581-13 ARM 11 2A D10-4582-13 ARM 12 3A D10-4583-03 ARM 13 3A D10-4584-03 ARM 14 3B D10-4585-03 ARM 15 2A D10-4586-13 SLIDER 16 3B D10-4587-32 SLIDER 17 2B D10-4588-13 SLIDER 18 2B D10-4595-04 ARM 19 3B D10-4596-14 ARM 22 2A D13-2151-04 GEAR 23 2B D13-2152-04 GEAR 24 3B D13-2153-04 GEAR 25 3B D13-2154-04 GEAR 26 3B D13-2155-04 WORM 27 2B D13-2156-14 GEAR 28 3B D13-2157-04 GEAR 29 3B D13-2158-04 GEAR 30 2B D13-2168-04 GEAR 31 3B D13-2171-04 GEAR 32 2B D13-2172-03 RACK (GEAR) 33 2A D14-0759-04 ROLLER 35 2B D21-2382-04 SHAFT 36 1A D23-0954-04 RETAINER 37 1B D39-0246-05 DAMPER 38 2B G01-3072-04 EXTENSION SPRING 39 2A G01-3073-04 TORSION COIL SPRING 40 2A G01-3074-04 EXTENSION SPRING 41 1B G01-3075-14 EXTENSION SPRING 42 2A G01-3076-04 EXTENSION SPRING 43 1B G01-3077-14 EXTENSION SPRING 44 2B G02-1399-04 FLAT SPRING 45 2B G02-1408-04 FLAT SPRING 51 1A J21-9676-22 MOUNTING HARDWARE 52 3B ✽ J21-9677-22 MOUNTING HARDWARE 53 1B J21-9678-13 MOUNTING HARDWARE 55 1A J90-1001-11 GUIDE 56 1B J90-1023-03 GUIDE A 2B N09-4460-05 TAPTITE SCREW (OVAL P TAPTIT) B 1B N09-4472-15 MACHINE SCREW (M1.7X8.0) C 2B N09-6004-05 MACHINE SCREW (M1.7X2.5 IB-L) E 2B N09-6007-05 MACHINE SCREW (PAN M2X2) F 1A N09-6051-05 TAPTITE SCREW (BIND P 2X5) G 2A N19-2163-04 FLAT WASHER H 1B N39-2020-46 PAN HEAD MACHIN SCREW J 1B N09-6108-05 MACHINE SCREW (M2*3.5TYPE3) K 3B N09-6155-05 SEMS (TAPTITE SCREW) (PT2X6) DM1 3B T42-1066-04 DC MOTOR ASSY (SP) DM2 2B T42-1067-04 DC MOTOR ASSY (LO) DPU1 2B X93-2010-00 OPTICAL PICKUP ASSY CD MECHANISM ASSY (X92-4650-00) DAUGHTER UNIT (X89-2570-10) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 SPECIFICATIONS follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. KENWOOD CORPORATION 2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525 Japan KENWOOD USA CORPORATION P.O. Box 22745, 2201 East Dominguez Street, Long Beach, CA 90801-5745, U.S.A. KENWOOD ELECTRONICS CANADA INC. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 KENWOOD ELECTRONICS LATIN AMERICA S.A. P.O. Box 55-2791 Paitilla, Plaza Credicorp Bank Panama, Piso 9, Oficina 901, Calle 50, Panama, Rep. de Panama KENWOOD ELECTRONICS BRASIL LTDA. Alameda Ministro Rocha Azevedo No. 456, Edificio Jaú, 10o Andar, Cerqueira César, Cep 0140-001, São Paulo-SP-Brasil KENWOOD ELECTRONICS UK LIMITED Kenwood House, Dwight Road, Watford, Herts, WD18 9EB, United Kingdom KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker-Str. 15, 63150 Heusenstamm, Germany KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS BELGIUM N.V. Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium KENWOOD ELECTRONICS ITALIA S.p.A. Via G. Sirtori 7/9, 20129 Milano, Italy KENWOOD IBÉRICA S.A. Bolivia, 239-08020 Barcelona, Spain KENWOOD ELECTRONICS AUSTRALIA PTY. LTD. (A.C.N. 001 499 074) 16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113, Australia KENWOOD ELECTRONICS (HONG KONG) LTD. Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD ELECTRONICS GULF FZE P.O. Box 61318, Jebel Ali, Dubai, U.A.E. KENWOOD ELECTRONICS (THAILAND) CO., LTD. 2019 New Pechburi Road, Bangkapi, Huaykwang, Bangkok, 10320 Thailand KENWOOD ELECTRONICS SINGAPORE PTE. LTD. 1 Genting Lane, #07-00, Kenwood Building, Singapore, 349544 KENWOOD ELECTRONICS (MALAYSIA) SDN BHD #4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1, 46300 Petaling Jaya, Selangor Darul Ehsan, Malaysia FM Frequency Range (Frequency step) ......................................................... 87.5MHz~108.0MHz (50kHz) Usable Sensitivity (S/N 26dB) ................................................................................................ 0.7µV/75Ω Quieting Sensitivity (S/N 46dB).............................................................................................. 1.6µV/75Ω Frequency Response (±3.0dB) ........................................................................................... 30Hz~15kHz S/N ................................................................................................................................... 65dB (MONO) Selectivity (DIN) ......................................................................................................... ≥80dB (±400kHz) Stereo Separation ............................................................................................................... 35dB (1kHz) MW (AM) Frequency Range (Frequency step) ............................................................... 531kHz~1611kHz (9kHz) Usable Sensitivity (S/N 20dB) ......................................................................................................... 25µV LW Frequency Range.......................................................................................................... 153kHz~281kHz Usable Sensitivity (S/N 20dB) ......................................................................................................... 45µV CD Laser Diode............................................................................................................... GaAlAs (λ=780nm) Digital Filter (D/A)................................................................................................ 8 Times OverSampling D/A Converter .................................................................................................................................. 1 Bit Spindle Speed................................................................................................................. 500~200 (CLV) Wow & Flutter...................................................................................................... Below Mesurable Limit Frequency Response .................................................................................................. 10~20kHz (±1dB) Total Harmonic Distortion................................................................................................... 0.01% (1kHz) S/N Ratio............................................................................................................................. 93dB (1kHz) Dynamic Range .............................................................................................................................. 93dB Channel Separation ........................................................................................................................ 85dB Preout Level/Load - Unbalanced ................................................................................... 2000mV/10kΩ (CD/CD-CH) Preout Impedance ........................................................................................................................................... ≤600Ω AMP PWR (MAX) ............................................................................................................................... 50W x 4 PWR DIN45324, +B=14.4V ....................................................................................................... 30W x 4 TONE Bass .................................................................................................................................... 100Hz±10dB Middle ................................................................................................................................... 1kHz±10dB Treble .................................................................................................................................. 10kHz±10dB GENE Operating voltage (11~16v allowable)............................................................................................. 14.4v Current Consumption ........................................................................................................................ 10A Installation Size (W) ................................................................................................................... 182mm (H) ...................................................................................................................... 53mm (D) .................................................................................................................... 155mm Weight ....................................................................................................................... 1.20 (kg) 2.64 (lbs) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299