© 2001-11 PRINTED IN JAPAN B51-7868-00 (S) 3420 SERVICE MANUAL CD RECEIVER KDC-5019/519/8020 KDC-7021/7021Y/B7021 This service manual does not include information on the CD mechanism assembly (exploded view, parts list, schematic diagram or mechanism operation description). For such information, please refer to the CD mechanism assembly service manual (X92-4030-0X, X92-4440-0X : B51-7867-00). Front glass (B10-4157-01) Panel assy (A64-2578-02) Front glass (B10-4158-01) Panel assy (A64-2579-02) KDC-5019 KDC-519 Front glass (B10-4162-01) Panel assy (A64-2583-02) Front glass (B10-4160-01) Panel assy (A64-2581-02) KDC-8020 KDC-7021/Y Front glass (B10-4163-01) Panel assy (A64-2584-02) KDC-B7021 DC cord (E30-4942-05) : KDC-7021Y (E30-4956-05) : KDC-7021/B7021 Antenna adaptor (T90-0523/0534-05) KDC-7021/7021Y/B7021 only Screw set (N99-1704-05) Screw set (N99-1722-05) Bracket (L) (J19-5051-03) KDC-5019/519/8020 only Bracket (R) (J19-5052-03) Lever (D10-4562-04)x2 (D10-4621-04)x2: KDC-7021/B7021 Mounting hardware assy (J21-9716-03) Torsion coil spring (G01-2924-04) Plastic cabinet assy (A02-1497-13) Remote controller assy (A70-2025-05) Remote controller assy (A70-0886-15) Escutcheon (B07-3010-02) DC cord (E30-4940-05) : KDC-5019/519 DC cord (E30-4939-05) : KDC-8020 G www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 2 BLOCK DIAGRAM PLL+B FM+B Q43,44 Q45,46 AM+B DIMMER MUTE 2WAY DET. ACC BU DET. A8V A8V Q4-6 IC3 Q9 Q7,8 Q10-13 SERVO AVR SERVO+B SW5V Q3 Q50,51 Q30 Q1,2 SW5V BU5V BU5V P CON ANT-CON Q26-29 MUTE IC8 Q32,33,35 DRIVER MUTE Q37-40 POWER IC IC4 SYSTEM MI-COM CD CH F/E A1,Q53 E-VOL IC2 PRE OUT SP-OUT DIMMER TEL-MUTE ACC ANT-CONT Q24,25 P-CONT BACK UP A-CONT P-CONT DECODER RDS IC1 IC14 Q52 EX.AMP CONTROL ILLUM +B RESET SW RESET IC IC16 IC2 IC1 Q7 Q3,4 Q5 LCD DRIVER REMO G/R SW DIMMER SW BUFFER NOISE Q36 OUTPUT VOLTAGE CONTROL EX.AMP Q14 Q15 Q31 (E,Z) TYPE (E,Z) TYPE (E,Z) TYPE (K,M) TYPE NAVI-MUTE PANEL 5V PANEL 5V KEY MATRIX SW14V SRM MECHA. SRM DRIVER MOTOR (BACK LIGHT) LCD ED1 CH QUAL SERVO+B MUTE R STOP SW2 LO/EJ MUTE L RST SW3 SW1 SDA SCL A8V BU5V SW5V RST REQ C CLK CH-CON DATA H REQ H CD AM FM P MUTE MUTE SW5V PANEL5V L DATAL L CE L CLK L DATAS DIMMER REMO RESET ILL+B SRM SW1 SRM DET SRM SW2 SRM SW3 SRM SUB- SRM SUB+ RDCK RDDA QUAL SDA SCL AFS AFS A8V PLL DATA PLL CLK IFC OUT S-METER SW5V SW5V DATA C BACK UP BU5V PANEL 5V CHANGER AM FM 230mV 1200mV 1200mV 251mV (E,Z) TYPE 470mV (K,M) TYPE AUDIO OUT NOISE CD 3600mV 3600mV 855mV 1372mV 3600mV 3600mV 600mV 1800mV DRIVER MUTE MO SW LCD AVR (X16- ) IC15 (E,Z) TYPE (K,M) TYPE (E,Z) TYPE www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 3 COMPONENT DESCRIPTION G SWITCH UNIT(X16-154X-XX, X16-1892-7X) Ref.No. Component Name Application/Function Operation/Condition/Compatibility IC1 LC75808W LCD driver with key matrix IC2 RS-171 Remote sensor IC Q1 DTA114EUA or KRA302 Key permission SW For the key scanning start and the key detection SW Q3 2SC4081 Red LED SW When a base goes Hi, RED LEDs are turned on. Q4 2SC4081 Green LED SW When a base goes Hi, GREEN LEDs are turned on. Q5 2SC4081 VLCD AVR For LCD driver IC Q6 DTA114EUA or KRA302 REMO SW While a base goes Lo, PAN 5V is supplied to the Remote sensor IC. Q7 DTC143ZK Dimmer SW Usually Q7's base goes Hi. When DIMMER mode is selected, pulse wave shape is applied to Q7's base. G ELECTRIC UNIT(X25-939X-XX, X25-8762-7X) Ref.No. Component Name Application/Function Operation/Condition/Compatibility IC1 UPD703033GC139 System MI-COM. IC2 TDA7407D E.VOL & N.C.MPX IC IC3 M5237ML AVR IC IC is combined with Q4, and it works as the error detection, the driver. IC4 TA8273H Power IC HD74HC02FP IC8 or TC74HC02AF Mute logic 2-input NOR x 4 or 74VHC02SJ IC14 TDA7479D RDS decoder IC15 LB1930M Motor driver IC IC16 S-80837ANNP Reset IC When BU 5V voltage is less than 3.7V, IC outputs Lo. Q1 2SB1548(P) BU 5V AVR While BACKUP is applied, AVR outputs +5V. Q2 2SC4081 or 2SD1819A Q1 and Q2 are inverted Darlington connection. Q3 2SA1576A or 2SB1218A SW 5V While a base goes Lo, SW 5V is supplied to the microprocessor peripheral circuits. Q4 2SB1548(P) A8V AVR Q4 is combined with IC3, and it outputs +8.3V. Q5 DTC144EUA or UN5213 A8V AVR SW A8V AVR ON/OFF control Q6 DTA124EUA or KRA303 While Q5's base goes Hi, Q6 is turned on, and A8V AVR is working. Q7 DTA124EUA or KRA303 A8V AVR and SERVO +B AVR ON/OFF control Q8 DTC144EUA or UN5213 SW14V SW While Q8's base goes Hi, Q7 is turned on, A8V AVR and SERVO +B AVR are working. Q9 2SD2375 SERVO +B AVR When Q9's base goes Hi, SERVO +B AVR outputs +7.6V. Q10 2SB1184 ILL +B AVR While Q11's base goes Hi, AVR outputs +10.7V. Q11 2SC4081 or 2SD1819A Works during POWER ON mode with a panel attached to the set. Q12 DTC144EUA or UN5213 ILL +B SW ILL +B AVR ON/OFF control Q13 DTA124EUA or KRA303 While Q12's base goes Hi, Q13 is turned on, and ILL +B AVR is working. Q14 DTA123JK or KRA105S EXT. AMP CON. SW When a base goes Lo, Q14 is turned on, and control pulse waveform shape is outputted. Q15 DTC144EUA or UN5213 Small lamp detection SW When vehicle small lamps turn on, Q15 is turned on . Q24 DTC114YUA or UN5214 ANT-CON. SW When Q24's base goes Hi, Q25 is turned on. Q25 2SB1277(Q,R) Works during the tuner reception mode. Q26 2SB1277(Q,R) P-CON SW When Q29's base goes Hi, Q26 is turned on . Q29 DTC114YUA or UN5214 Works during POWER ON mode. Q27 2SA1576A or 2SB1218A P-CON. protection SW Protect Q26 by turning ON when P-CON output is grounded. Q28 DTA124EUA or KRA303 P-CON. protection inhibit SW Prevents Q27 tuning ON during start-up after power ON. While BACKUP is applied, a base goes Hi, and Q30 is turned on. Q30 2SC4081 or 2SD1819A BU detection SW When momentary power down has detected, a base goes Lo, and Q30 is turned off. Q31 2SC4081 or 2SD1819A ACC detection SW While ACC is applied, a base goes Hi, and Q31 is turned on. Q32 DTA124EUA or KRA303 Mute driver for L Ch. When BU detection SW or System RESET or MI-COM.'s Pre-mute is Q33 DTA124EUA or KRA303 Mute driver for R Ch. working, a base goes Lo, and Q32 and Q33 are turned on. Q35 DTC124EUA or UN5212 E. VOL mute SW When BU detection SW or MI-COM.'s mute is working, a base goes Hi, and Q35 is turned on. Q36 2SC4081 or 2SD1819A Noise buffer www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 4 Ref.No. Component Name Application/Function Operation/Condition/Compatibility Q37 DTC143TUA or KRC410 Audio mute SW (Front L) When Q37's base goes Hi, Pre-output is muted. Q38 DTC143TUA or KRC410 Audio mute SW (Front R) When Q38's base goes Hi, Pre-output is muted. Q39 DTC143TUA or KRC410 Audio mute SW (Rear L) When Q39's base goes Hi, Pre-output is muted. Q40 DTC143TUA or KRC410 Audio mute SW (Rear R) When Q40's base goes Hi, Pre-output is muted. Q43 DTC124EUA or UN5212 FM +B SW When Q43's base goes Hi, Q44 is turned on, and A8V is supplied to the F/E. Q44 2SB1277(Q,R) Works during FM reception mode. Q45 DTC124EUA or UN5212 AM +B SW When Q45's base goes Hi, Q46 is turned on, and A8V is supplied to the F/E. Q46 2SB1277(Q,R) Works during AM reception mode. Q50 DTC144EUA or UN5213 PAN 5V SW While a panel is attached to the set, Q50 and Q51 are turned on, and Q51 2SA1576A or 2SB1218A BU 5V is supplied to the panel. Q52 2SC4081 or 2SD1819A Composite signal output buffer Q53 DTC144EUA or UN5213 IFC buffer Waveform shaping www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 5 MICROCOMPUTER'S TERMINAL DESCRIPTION G IC1(ELECTRIC UNIT : X25-939X-XX, X25-8762-7X) Pin No. Pin Name I/O Description Processing Operation 1 AM+B O AM+B control Hi: During AM reception 2 FM+B O FM+B control Hi: During FM reception, Hi: During FM reception if with RDS, RDBS 3 AFS O Noise detection time constant switching terminal Hi: During FM reception, Lo: During FM seek or AF search 4 PLL-DATA I/O Data input/output with F/E 5 PLL-CLK I/O Clock output to F/E 6 EVDD - Positive power supply connection terminal Connected to BU 5V lines. 7 EVSS - Ground connection terminal Connected to GND lines. 8 N.C. O Not used(N.C.) 9 BEEP O BEEP sound output 10 REMO I Data input from the remote control light sensor 11 PRE-MUTE L O Pre-out mute control (L) When M MUTE L input is Lo during CD source selected, PRE MUTE L outputs Lo. 12 PRE-MUTE R O Pre-out mute control (R) When M MUTE R input is Lo during CD source selected, PRE MUTE R outputs Lo. 13 IC2-SDA I/O Data line with IC2,CD mechanism MI-COM. 14 IC2-CLK O Clock line with IC2,CD mechanism MI-COM. 15,16 N.C. O Not used(N.C.) 17 DA-SDA / DIM-CON O Data output to D/A converter(V-LED model) Data line with D/A converter / Dimmer control output / Hi: Dimmer OFF, Pulse wave shape: Dimmer ON 18 TEST - Test terminal Not used(Connected to GND lines) 19 P-MUTE O Power IC mute control output Lo: Mute (during POWER OFF, ALL OFF, TEL MUTE) 20 P-STBY O Power IC standby control output Lo: Power IC OFF, Hi: Power IC ON, ALL OFF mode 21 MUTE O IC2 mute control output OPEN(Hi): Mute ON, Lo: Mute OFF 22,23 N.C. O Not used(N.C.) 24 ACC-DET I ACC detection terminal Lo: ACC ON, Hi: ACC OFF 25 DIMMER I Small lights detection input Lo: During vehicle small lamps turn on. 26 SW5V O SW 5V control output Lo: POWER ON mode Bass boost OFF__Hi: 160msec, Lo: 40msec 27 EXT-AMP-CONT O External amp. control output Bass boost LOW__Hi: 130msec, Lo: 70msec Bass boost HI__ Hi: 100msec, Lo: 100msec 28 P-CON O Power control output Lo: POWER OFF mode, Hi: POWER ON mode 29 ANT-CON O Antenna control output Hi: During TUNER mode or TI reception 30 P-ON O SW 14V control output Hi: POWER ON mode 31 RESET I Reset input terminal Lo: System reset 32 XT1 I Sub clock resonator connection terminal Clock count during POWER OFF mode 33 XT2 - Sub clock resonator connection terminal 34 REGC - Capacitor conection terminal for regulator inside microprocessor Oscillation: POWER ON mode, Oscillation stop: 35 X2 - Main clock resonator connection terminal POWER OFF mode or momentary power down detected 36 X1 I Main clock resonator connection terminal 37 VSS - Ground connection terminal Connected to GND lines. 38 VDD - Positive power supply connection terminal Connected to BU 5V lines. 39 CLKOUT O Internal system clock output Not used(N.C.) 40,41 N.C. O Not used(N.C.) 42 TYPE0 I Destination type selection terminal 0 43 TYPE1 I Destination type selection terminal 1 44 TYPE2 I Destination type selection terminal 2 45 N.C. O Not used(N.C.) 46 IC2 TYPE0 I IC2 setting terminal Lo: Initial value 47 IC2 TYPE1 I IC2 setting terminal Lo: Initial value 48 CH-REQH O Request output to changers Lo: Request www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 6 MICROCOMPUTER'S TERMINAL DESCRIPTION Pin No. Pin Name I/O Description Processing Operation 49 CH-RST O Reset output to changers : Reset 50 CH-MUTE I Mute request from changers Hi: Mute request 51 CH-CON O Changer control Lo: Standby mode, Hi: Operation mode 52 ILL-ON O Illumination AVR on/off control output Hi: POWER ON mode except panel detached 53 M-MUTE L I Mute request (L Ch.) from CD MECHA. MI-COM. Lo: Mute request 54 M-MUTE R I Mute request (R Ch.) from CD MECHA. MI-COM. Lo: Mute request 55 BVDD - Positive power supply connection terminal Connected to BU 5V lines. 56 BVSS - Ground connection terminal Connected to GND lines. 57 M-RST O Reset output to CD mechanism MI-COM. Lo: Reset 58 M-STOP O Stop request to CD mechanism MI-COM. Lo: Stop mode, Hi: Operation mode 59 N.C. O Not used(N.C.) 60 LO/EJ I/O CD mechanism loading/Eject switching output Lo: Loading, Hi: Eject, Hi-Z: Stop or Break 61 MOSW O CD mechanism loading motor control output Hi: CD loading/eject action or Break, Lo: other 62 N.C. O Not used(N.C.) 63 CD-SW3 I Down & limit switch detection input Hi: Chucking, Lo: Pickup most inner position 64 DA-SDA/NC O Clock output to D/A converter (V-LED model) Lo: Panel detached, momentary power down detected 65 LCE O CE output to LCD driver IC 66-69 N.C. O Not used(N.C.) 70 AV CONT O A/D converter reference voltage control output Hi: Active, Connected to AVREF terminal 71 AVDD - A/D converter positive power supply connection terminal Connected to BU 5V lines. 72 AVSS - A/D converter ground connection terminal Connected to GND lines. 73 AVREF I A/D converter reference voltage input terminal 74 PHONE I PHONE detection input 1V or less: TEL MUTE, 2.5V or greater: NAVI MUTE 75 SRM-SW3 I Mask mechanism position SW3 input Panel: (SW1,SW2,SW3)=(Lo,Lo,Hi) 76 SRM-SW1 I Mask mechanism position SW1 input Angle: (SW1,SW2,SW3)=(Hi,Hi,Lo) Eject: (SW1,SW2,SW3)=(Hi,Hi,Hi) 77 SRM-SW2 I Mask mechanism position SW2 input Mask : (SW1,SW2,SW3)=(Lo,Lo,Lo) 78 SRM-DET I Mask mechanism detection input Lo: Mechanism detected, Hi: mechanism not detected 79 NOISE I FM noise detection input 80 S-METER I S-meter input from F/E 81 R-DATA I Data input from the RDS decoder IC Except RDS, RBDS model: Not used(pull down to GND lines) 82 R-QUAL I Quality input from the RDS decoder IC Except RDS, RBDS model: Not used(pull down to GND lines) 83 IFC-OUT I F/E IFC OUT input terminal Lo: Station detected, Hi: Not detected 84,85 N.C. I Not used(pull down to GND lines) Standby: (SRM+B,SRM-B)=(Lo,Lo) 86 SRM-B O SRM mechanism submotor control output Clock wise: (SRM+B,SRM-B)=(Hi,Lo) Counter clock wise: (SRM+B,SRM-B)=(Lo,Hi) Break: (SRM+B,SRM-B)=(Hi,Hi) 87 R-CLK I Clock input from the RDS decoder IC Except RDS, RBDS model: Not used(pull down to GND lines) 88 CH-REQC I Request input from changers Lo: Request 89 KEY-REQ I Communication request from LCD driver IC 90 CD-SW1 I Loading SW detection input Lo: Loading start 91 CD-SW2 I 12cm disc detection SW input Lo: 12cm disc detected 92 SRM+B O SRM mechanism submotor control output 93 BU-DET I Momentary power down detection input Hi : When momentary power down detected or BU OFF Lo : BU ON 94 CH-DATAC I Data input from changers 95 CH-DATAH O Data output to changers 96 CH-CLK I/O Clock input/output with changers 97 L-DATA L I Data input from the LCD driver IC 98 L-DATA S O Data output to the LCD driver IC 99 L-CLK I/O Clock output to the LCD driver IC /Panel detaching detection input(LCD Driver) Lo: Panel attached 100 PAN5V O Panel 5V control Hi: Panel attached, Lo: Panel detached www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 7 KDC-5019/519/7021/7021Y/8020/B7021 8 TEST MODE TEST MODE / ATTENTION 1. How to enter the test mode While holding the FM and Preset 6 keys, reset the unit. 2. How to exit from the test mode While holding the Preset 6 key, reset the unit. (Note) The test mode cannot be terminated by ACC OFF, power OFF or momentary power down. 3. Initial status in the test mode • Sources : ALL OFF • Display : All segments are lit. • Volume : -10 dB (displayed as " 30 ") • Loudness : OFF • CRSC : OFF regardless of the presence of switching function. • SYSTEM Q : Flat 4. Special display in Tuner mode When any of the following messages is displayed in Tuner mode, the F/E may be abnormal. • " TNE2P NG ": The EEPROM is set to the default (unstable values) because the F/E was shipped without passing through the adjustment process, etc. • " TNCON NG ": Communication with the F/E is not possible. 5. Forced switching of K3I Each press of the Preset 6 key in Tuner mode should switch K3I from AUTO → Forced Wide → Forced Middle → Forced Narrow → AUTO. The initial status is AUTO and the display shows these modes as follows. • AUTO : FMA • Forced Wide : FMW • Forced Middle : FMM • Forced Narrow : FMN 6. Test mode specifications of the CD receiver • Forced ejection is inhibited in the reset start operation. When the unit is reset while a CD is loaded in it, the CD is not recognized by resetting. • Each press of the Track Up key jumps to the following track numbers: No. 9 → No. 15 → No. 10 → No. 11 → No. 12 → No. 13 → No. 14 → No. 9 (The cycle restarts from here.) • Each press of the Track Down key jumps to the previous track number to the track being played. 7. Audio-related specifications • A short press of the Q key initiates the audio adjustment mode. • Pressing the ∗ key on the remote initiates the audio adjustment mode. • Continuous holding of a remote control key is inhibited. • Bass, Middle and Treble are adjusted in 3 steps of Min / Center / Max with the Track Up/Down keys. • Balance is adjusted in 3 steps of Left Max / Center / Right Max with the Track Up/Down keys. • Fader is adjusted in 3 steps of Rear Max / Center / Front Max with the Track Up/Down keys. • HPF is adjusted in 2 steps of Through/220Hz with the Track Up/Down keys. • LPF is adjusted in 2 steps of Through/120Hz with the Track Up/Down keys. • Bass f, Bass Q, Bass EXT, Middle f, Middle Q and Treble f are not dealt with by the audio adjustment. 8. Menu-related specifications • A short press of the CLK key initiates the Menu mode. • Pressing the DNPP/SBF key on the remote initiates the Menu mode. • Continuous holding of a remote control key is inhibited. • Contrast is adjusted in 3 steps of 0/5/10 and the default is 5. 9. Backup current measurement When the unit is reset while ACC is OFF (i.e. by turning Backup ON), the MUTE terminal goes OFF in 2 seconds in place of 15 second. (The panel and CD mechanism are not activated at this time.) 10. Special display when the display is all on Pressing the Preset keys while the power is ALL OFF displays the following information. [PRESET 1] Version display (8 digits, Month/Day/Hour/Minute) (Display) SYS xxxxxxxx System microcomputer [PRESET 2] Serial No. display (8 digits) (Note) CD/RK type eXcelon model (Display) S. No. xxxxxxxx [PRESET 3] Short press : View power ON time. (The All OFF period is not counted.) Long press/hold : Clear power ON time. (Display) PonTim xxxxx Max. 65535 (hours) [PRESET 4] Short press : Display CD operation time. Long press/hold : Clear CD operation time (Display) CDTime xxxxx Max. 65535 (hours) [PRESET 5] Short press : Display CD ejection count. Long press/hold : Clear CD ejection count. (Display) EjeTim xxxxx Max. 65535 (times) [PRESET 6] Short press : Display Panel open/close count. Long press/hold : Clear Panel open/close count. (Display) PnCnt xxxxx Max. 655350 (times) 11. Other specifications • Automatic panel closing when a CD is inserted is inhibited. (M&T model) • Panel operation by turning power OFF/ON is inhibited. (M&T model) • Messages such as "CODE OFF" are not displayed when power is turned ON. • Pressing the ATT key opens or closes the panel. (M&T model) • Pressing the TI (AUTO) key during changer operation turns 2zone ON. 2zone can be turned OFF by pressing the TI (AUTO) key again. The P/S dot lights while 2zone is ON. • Pressing and holding the CLK key for a second in the ALL OFF status the Mask Key (security) write mode. tongue Turn 2 times. End of Roller ass’y FPC Security-related information 1. Forced Power ON mode (All models) Even when the security (Mask key) is approved, resetting the unit while holding the ATT and Preset 4 keys makes it possible to turn the power ON for 30 minutes. After 30 minutes have elapsed, it is not possible to return to the previous condition unless the unit is reset again. 2. Method of registration of the security code after EEPROM (Tuner Unit Ass'y) replacement (Code security model) 1.Enter the test mode. (See 1. How to enter the test mode) 2.Press the CLK key to enter the security registration mode. 3.Enter the code using the Preset 1/2/3/4 keys. Example: To enter " 3510 " • Press the Preset 1 key 4 times. • Press the Preset 2 key 6 times. • Press the Preset 3 key twice. • Press the Preset 4 key once. 4.Hold down the DISP key for at least 3 seconds and the message, " RE-ENTER " appears, so once again enter the code according to Step 3 above. 5.Press and hold the DISP key for 3 seconds until " APPROVED " is displayed. 6.Exit from the test mode. (See 2. How to exit from the test mode) (Note) All Clear is not applicable to the security code of this model. 3. Simplified method of clearing the security code (K Type only) 1.While the code entry is requested, press and hold the VOL UP key for 3 seconds while holding the DISP key pressed. (This should turn "----" off.) 2.Enter " KCAR " from the remote. (Same way as the 00 model) • Press the 5 key on the remote twice, then press the Track Up key. (This enters " K ".) • Press the 2 key on the remote 3 times, then press the Track Up key. (This enters " C ".) • Press the 2 key on the remote once, then press the Track Up key. (This enters " A ".) • Press the 7 key on the remote twice, then press the Track Up key. (This enters " R ".) 3.The security code is cleared and the unit enters the ALL OFF mode. 4.If you commit a mistake in the code entry, the unit enters the code request mode again. 4. Method of writing the Mask key while the EEPROM is in the initial status 1.Enter the test mode. (See 1. How to enter the test mode) 2.Press the CLK key to enter the Mask key registration mode. " TRANSMIT1 " should be displayed now. The display at this time should show " < > " in place of " [ ] ". 3.Point the Mask key remote toward the light sensor, and press and hold its key for more than 0.5 second. 4.When " TRANSMIT2 " is displayed, press and hold the key on the Mask key remote for more than 0.5 second again. The first and second counter codes are not compared at this time. 5.When " APPROVED " is displayed, the write operation is complete. Now the demonstration mode is initiated and the test mode is terminated. (Note) In the same way as previous models, if 30 minutes have elapsed with no code written, an error occurs and the power is turned OFF. 5. Method of initializing the Mask key (How to reset the unit from the Mask key approved condition to the factory condition) 1.Enter the test mode. (See 1. How to enter the test mode) 2." TRANSMIT1 " is displayed and the Mask key entry request mode is initiated. The display at this time should show " ∗ ∗ " in place of " [ ] ". 3.Press and hold the key on the Master key remote for more than 3 seconds. 4.When " TRANSMIT2 " is displayed, press and hold the key on the Master key remote for more than 3 seconds again. 5.When " APPROVED " is displayed, the Mask key is cleared, the demonstration mode is initiated, the test mode is terminated and the unit returns to the factory condition. 6. Method of clearing all Mask key-related data 1.Enter the test mode. (See 1. How to enter the test mode) 2.Press the CLK key to enter the Mask key registration mode. " TRANSMIT1 " should be displayed now. 3.Point the Master key remote toward the light sensor, and press and hold its key for more than 3 seconds (until the level display shows the full condition). 4.When " TRANSMIT2 " is displayed, hold the key on the Mask key remote for more than 3 seconds again. If " TRANSMIT1 " is displayed in place of " TRANSMIT2 ", restart the procedure from step 3. 5.When " APPROVED " is displayed, all security data is cleared and the unit returns to the condition before Mask key writing with the EEPROM in the initial status. ATTENTION Assembly of FPC(Flexible PC board) onto Roller ass’y Turn Roller ass’y by 2 times. Hook the end of Roller ass’y to the tongue. Insert the FPC into the slit of Roller ass’y then release the end of Roller ass’y and the tongue. w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KI1 KI4 KS5 1 KI2 KS4 KS2 KI5 KS3 KS1 KI3 3 2 4 68 1 18 19 RST ATT 1 2 3 4 5 6 TI DISP CLK FM AM SRC AUD X16-1892-7X (J74-1306-02) X16-154X-XX (J74-1306-02) ED1 D24 D23 IC2 D10 D9 D12 D11 D6 D5 D8 D7 D13 D20 D22 D21 D18 D15 D14 D17 D16 D3 D1 D2 C124 C125 R7 C126 C127 C123 C122 C121 R202 C128 R82 R90 R89 R69 R66 R75 R50 R72 C116 R204 R231 R230 R216 R215 R214 R111 R109 R100 R102 R205 R207 R206 R115 R208 R116 R119 C21 R10 W7 C149 C76 C141 R4 R3 X2 CP3 CP6 CP5 CP2 X1 R218 R217 R61 R60 R62 R59 R83 R84 R118 R117 CP1 CP4 R49 E B B E E B B E B E B E E B B E B E E B B E E B B E B E B E 1 25 26 50 51 75 76 100 28 15 14 1 9 16 1 8 I G O L R VT 20.0M 4.332M 32.768K 5V RESET IFCOUT X86 W100 L10 FL RR RL FL RL FR RR R46 R40 R45 R38 R34 R35 X3 C3 C1 C115 C96 C95 C93 C94 C5 C63 C65 C34 C36 C22 C66 C67 C68 C143 C142 C114 C40 C69 C134 C61 C9 C6 C8 C119 C120 C117 C118 L12 L11 L9 C113 L7 L1 W31 W30 W32 W20 W19 W18 W16 W15 W14 W13 W33 W34 W36 W35 W23 W22 W21 W24 W25 W26 W27 R37 R33 W12 W11 W10 C200 W17 R5 W38 W29 W28 L6 R212 R210 W5 R14 R36 W37 R11 R9 W39 W40 L4 W42 W41 FR E B 13 12 2 1 2 1 12 13 1 8 B E E B E B E B B E B E 24 1 1 3 24 25 2 1 1 6 2 1 1 16 9 8 1 2 7 6 IC2 IC14 IC3 Q2 Q32 Q33 Q35 Q51 Q43 Q45 Q50 Q8 Q7 Q3 Q5 Q6 Q15 Q52 IC1 D30 D31 D32 D15 D18 Q1 Q4 D2 D1 Q9 Q25 Q26 D23 D17 D24 D22 D5 D4 D3 D16 D8 D7 D28 D29 D27 IC4 D12 D11 D33 D34 D14 D41 D38 D39 D40 CN4 CN3 CN6 CN1 CN5 WH1 J1 D35 D36 CN7 Q46 Q44 D62 D61 D63 D64 CN2 X25-8762-7X (J74-1408-02) X25-939X-XX (J74-1398-02) A B C D E F G I H 1 2 3 4 5 6 7 PC BOARD (Component Side View) ELECTRIC UNIT Refer to the schematic diagram for the values of resistors and capacitors. 9 10 SWITCH UNIT ELECTRIC UNIT (X25-939X-XX/8672-7X) SWITCH UNIT (X16-154X-XX/1892-7X) . O N .f e R s s e r d d A C I Q 1 E 3 2 C 3 3 F 5 4 C 6 4 1 C 3 1 G 4 2 F 4 3 F 2 4 G 5 5 F 4 6 F 4 7 F 4 8 F 4 9 C 2 5 1 E 4 5 2 F 3 6 2 F 3 2 3 F 5 3 3 F 5 5 3 D 3 3 4 C 4 4 4 C 4 5 4 C 4 6 4 C 4 0 5 C 2 1 5 C 2 2 5 B 3 . O N .f e R s s e r d d A C I Q 2 H 2 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 B E B E B E E B 2 1 4 3 B E B E E B B E E B E B E B E B E B B E B E B E E B C11 C12 R8 L5 R164 W6 TH1 R162 R163 R161 R156 R157 R137 R155 R171 R170 R172 R169 R136 C7 R13 R19 R15 R130 R134 R135 R133 R131 R132 R233 R236 R237 R234 R235 R240 R239 R238 R159 R77 R76 R81 R80 R79 R93 R98 R97 R96 R88 R86 C133 R67 R73 R47 R48 R158 R74 C131 R71 R200 R168 R167 C135 R201 R166 R152 R151 R165 C137 R223 R222 R221 R224 R220 R213 R211 R108 R107 R106 R110 R105 R101 R99 R104 R103 R112 C161 R150 R114 R113 C43 C42 C41 C44 C48 C46 C39 C20 C38 C37 C35 C75 C74 C73 C140 C160 C62 C72 C71 C70 R16 R18 R17 R6 R43 C144 R41 R39 C146 R20 R42 C145 C4 R2 R1 C2 R44 R243 C45 R68 C151 C139 C153 C152 C147 C148 R203 R52 R54 R51 R53 R85 1 5 6 10 1 7 8 14 Q10 IC8 IC15 Q38 Q39 Q40 Q37 Q31 Q11 Q12 Q28 Q29 Q30 Q27 Q13 Q24 Q14 Q36 IC16 Q53 D60 D26 D25 X25-8762-7X (J74-1408-02) X25-939X-XX (J74-1398-02) R23 R22 R24 R21 R18 R17 R20 R19 C6 C7 R13 R14 R12 R11 C1 C2 R15 R16 R2 R1 R3 R5 R4 R9 R10 R8 R6 R7 C3 C12 R29 R28 C14 C13 C9 C5 C4 R27 C11 CP1 CP2 CP3 KI3 KI5 KS1 KS2 DGND KS4 KI4 KI1 VDD KS3 KI2 DIMMER RESET S.GND L-CE L-DATAS L-DATAL ILL+B KS5 REMO CLK L- ILLUM G E B E B B E B E B E B E 1 13 1 25 26 50 51 75 76 100 Q4 Q7 Q3 Q6 Q5 Q1 IC1 S28 D26 J1 X16-1892-7X (J74-1306-02) X16-154X-XX (J74-1306-02) J K L M N O P R Q 1 2 3 4 5 6 7 Refer to the schematic diagram for the values of resistors and capacitors. 11 12 PC BOARD (Foil Side View) ELECTRIC UNIT ELECTRIC UNIT (X25-939X-XX/8762-7X) . O N .f e R s s e r d d A C I Q 1 K 5 1 K 6 3 K 3 4 K 3 5 K 3 6 K 2 7 K 3 . O N .f e R s s e r d d A C I Q 8 N 4 5 1 Q 2 6 1 N 2 0 1 M 2 1 1 M 2 2 1 M 2 3 1 M 2 4 1 N 4 4 2 M 3 7 2 M 4 8 2 M 4 9 2 M 3 0 3 N 4 1 3 N 4 6 3 P 4 7 3 M 5 8 3 M 5 9 3 L 5 0 4 M 5 3 5 O 3 SWITCH UNIT (X16-154X-XX/1892-7X) SWITCH UNIT w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 A B C D E F G I H 1 2 3 4 5 6 7 D3 Q5 SW 5V Q8 D4 Q13 Q4 D2 D1 Q2 Q1 Q3 DETECTION SW SMALL LAMP Q6 Q9 Q7 Q11 Q10 Q15 Q24 D11 Q25 D12 D14 Q26 CN6 ILL +B Q12 PAN 5V Q51 DETECTION SW Q29 P-CON SW B.U. Q30 Q31 MUTE LOGIC Q27 Q28 D17 for Rch. MUTE DRIVER D36 D35 D34 D33 POWER IC D41 D40 D39 D38 Q37 Q38 Q14 EXT.AMP CON.SW J1 CN2 CN1 Q32 Q33 MUTE SW E. VOL CN4 D7 D8 D5 CORD RCA REAR FRONT SP OUT/DC IN CH-IN D15 D29 D27 D28 D32 D30 D31 Q39 Q40 Q50 D63 D64 D61 D62 Q35 Q36 D16 B LINE GND LINE SIGNAL LINE D26 D25 E. VOL & N. C. MPX IC AVR IC BU 5V AVR A8V AVR A8V SW AVR SW14V SW SERVO +B AVR AVR ILL +B SW ANT-CON. SW P-CON. PROTECTION SW INHIBIT SW P-CON. PROTECTION DETECTION SW ACC MUTE DRIVER for Lch. NOISE BUFFER AUDIO MUTE SW(FRONT L) SW(FRONT R) AUDIO MUTE AUDIO MUTE SW(REAR R) AUDIO MUTE SW(REAR L) SW (X25-939X-XX/8762-7X) 22K 22K 22K 22K 47K 47K 47K 22K 22K 47K 22K 22K 47K 47K 47K 10K 47K 10K 22K 22K 22K 22K 47K 2.2K 47K 47K 4.7K 4.7K 4.7K 4.7K 47K 47K 22K 22K 5.0V 14.4V 7.6V 9.0V 0V 0V 13.8V 1.25V 0V 7.6V 1.4V 4.1V 7.6V 5.0V 5.0V 4.1V 4.1V 4.1V 4.1V 4.1V 4.1V 5.0V 4.1V 4.2V 4.2V 4.9V 4.1V 4.1V 4.1V 4.1V 8.3V 3.6V 0-5.0V 0V 5.0V 0V 0V 0V 5.0V 0V 5.0V 5.0V 4.1V 0V 7.6V 7.6V 7.6V 1.4V 1.4V 7.6V 0V 0V 7.6V 0V 0V 1.4V 1.4V 0V 14.4V 5.0V 14.4V 8.3V 7.6V 10.7V R45 R39 22K R11 + R9 C9 100u10 Vref VIN R4 2.2K C2 2200P R3 C4 10u16 220u16 C6 100u6.3 + C3 + C5 22K R1 100 R2 + GND 4.3K R7 220u10 C8 + 1.5K 1K 100K R20 Q15 C1 3300u16 + 220 R5 R16 0.01 C20 R17 47K C21 0.022 24K 15K R6 R8 1 C7 27 C22 + 1u50 25 15 1K 1/2W R38 1K 1/2W Q24,25 R37 4.7K 3.3u35 C34 R33 4.7K R34 R36 4 3 W5 ILLMG ILL+B RST R233 R234 R236 R235 R237 1 2 4 5 3 6 7 470 1K 4.7K 470 1K REMO NC DGND VDD 10 8 9 11 12 13 99 65 98 97 47K R231 93 11 R43 5.6K R47 18K Q26,29 1/2W 28 29 C39 0.01 1 2 3 4 100K 0.068 C36 + 0.1u50 R40 1K R42 12K 1000P C37 + C35 R41 12K C48 0.01 14 13 12 R46 C38 47K 0.01 3.3K 1/2W 12 11 5 6 7 10 9 8 1u50 C115 + R204 R203 0.47u50 C113 + FR RR 9 19 2 FL Q37 8.2K R202 R201 100 FL RL 1.5K TH1 10u16 + 360 R161 13 FRA RRA FRB RRB C120 0.22u50 C118 0.22u50 + 22K R206 22K R208 22u16 C114 8 TAB GND2 OUT2- STBY OUT2+ VCC2 OUT1- 1 2 3 5 6 7 4 IN1 IN2 OUT1+ RIP GND1 9 10 11 12 C119 0.22u50 0.22u50 C117 RLA 22K R205 22K R207 FLA RLB FLB 22K 22K OUT4+ IN4 IN3 AUX IN OUT3+ GND3 OUT3- VCC1 PRE-GND 14 15 16 17 18 19 20 21 CD MUTE OUT4- GND4 22 23 24 25 180 R169 R170 Rch Rch Lch GND B.U. GND RRA FRA RRB FRB RLB FLA FLB RLA 560 15 14 R13 10K 10K R19 R15 1K Q14 10 REAR Lch- FRONT Lch+ REAR Lch+ FRONT Lch- 8 7 9 FRONT Rch- REAR Rch- FRONT Rch+ REAR Rch+ ACC PHONE P-CON EXT CONT P-ANT GND ILLUM 3 4 2 3 2 6 5 4 13 11 12 14 15 1 16 2 1 C12 0.1 C11 0.1 2 1 3 4 FR 10u16 + 360 R162 Q33 180 Rch Lch A GND Lch GND 5 6 + + + C67 0.47u50 C68 0.47u50 C69 47u6.3 R157 R155 R156 2 3 1 1 3 2 R14 F1 10A MUT MUT 140uH VDD GND 22K 30 C116 0.1 31 31 4.7K R230 R18 100K 22K 14 + 360 R163 360 R164 RL RR 10u16 + 10u16 22K 22K 180 R171 180 R172 1 2 3 4 5 6 7 8 9 10 11 12 13 14 VREF CREF L R CDR CDG CDL PH- AFS AM MPX LEVEL MPIN MPOUT 28 27 26 25 24 23 22 21 20 19 18 17 16 15 ACOUTL ACOUTR OUT FL OUT FR OUT RL OUT RR VDD GND SDA SCL SMUTE QUAL OUTR OUTL 2.2u50 + 0.47u50 + 0.47u50 + 4 8 47u10 C61 + 0.01 C62 1K R158 0.033 0.47 R150 4.7K R151 10K C73 0.01 C71 150P R152 4.7K C75 0.1 C74 0.1 20 52 10K R200 1K 1/2W R35 4.7uH L4 R10 2.2 L CE L CLK L DATA L L DATAS NC DIM CON 1K 17 R240 1K 10 100 21 FL FR RL RR R165 R166 R168 R167 C93 C94 C95 C96 11 13 79 4.7K R159 4.7uH L6 0.047 C161 SDA SCL ILLUMI 16 YEL 1 BLK WHT GRY/BLK WHT/BLK GRY BLU/WHT BLU/WHT REV 10 7 RL- EXT. CONT. 13 4 ORG/WHT TEL MUTE 3 14 15 2 BRN VIOL/BLK PNK/BLK RR+ RR- VIOL 12 5 11 6 GRN/BLK RL+ GRN 9 8 FL- ANT CON P.CON FR+ FR- FL+ 3 24 R48 22K R44 22K 26 74 0.01 +B 2200P C152 GND4 C72 C70 10 4.7 10 C66 C65 C63 47K Q12,13 Q27 Q28 Q32 Q38 Q39 Q40 BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V PAN5V SW5V SW5V SW5V SW5V A8V A8V A8V A8V A8V BU BU +B BU BU BU +B BU BU BU BU BU BU BU BU BU C151 2200P C153 0.022 B.U. GND1 D8 NO NO NO YES YES YES YES KDC-7021 X25-9392-72/8762-73 KDC-7021Y KDC-B7021 X25-9392-73 X25-9392-74/8762-74 YES YES KDC-8020 KDC-5019 KDC-519 MODEL NAME NO X25-9390-11 X25-9390-12 X25-9390-21 NO NO UNIT No. A NO YES X86-3242-70/3342-71 YES YES X86-3242-70/3342-71 X86-3242-70 NO NO NO NO NO C20 X86-3240-11 X86-3240-11 X86-3240-11 A1 YES YES YES C149 YES YES R18,34-36, YES YES YES NO NO NO 80,81,86 YES NO YES NO NO YES YES YES YES YES 25 Q24, YES YES NO NO YES Q14 NO NO NO R15-17, 217,218 YES YES NO NO NO YES NO YES NO YES NO NO YES NO NO YES NO YES YES NO R51 R52 YES NO NO NO YES YES NO NO R54 R53 R55 YES YES YES YES YES YES YES NO YES R56 NO NO NO W5 R238 FRONT L FRONT R ANT CONT P. CON GND ACC BLK 16 1 YEL BU VIOL/BLK GRN/BLK PNK/BLK ORG/WHT VIOL GRY BLU BLU/WHT RED 14 15 3 2 12 13 5 4 WHT WHT/BLK GRY/BLK 11 10 6 7 9 8 GRN ILLUMI EXT. CONT REAR R REAR L REAR L REAR R ILLUMI BU YEL 1 16 BLK GND WHT/BLK GRY/BLK BLU/WHT VIOL GRY ORG/WHT 2 3 15 14 RED 4 5 13 12 BLU GRN VIOL/BLK GRN/BLK 6 7 11 10 8 9 WHT FRONT R ANT CONT P. CON ACC FRONT L RL- RR- RR+ 1 FL+ FR- FR+ RL+ FL- 3 5 7 2 B 2 1 A 4 6 8 4 3 5 6 7 8 BU GND 2 1 L1 2 6 3 4 5 1 2 1 3 S8V S8V S8V D7 YES YES YES YES NO NO Q52 YES NO YES YES NO NO R13, YES YES YES YES NO NO 14 P. CON IC3 IC8 IC4 ELECTRIC UNIT (X25-939X-XX/8762-7X) (E30-4939-05) KDC-8020 DC CORD (E30-4940-05) KDC-519/5019 DC CORD IC2 (E30-4942-05) : KDC-7021Y DC CORD (E30-4956-05) : KDC-7021/B7021 CAUTION:For continued safety, replace safety critical components only with manufacturer’s recommended parts (refer to, parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage- current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. DTA123JK DTC114YUA DTC143TUA DTC143ZK UN5213 UN5214 2SA1576A 2SB1218A 2SD1819A E C B 2SB1184 B C E 2SB1548 E C B 2SB1277 B C E 2SC4081 B C E w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 J K L M N O P R Q 1 2 3 4 5 6 7 CN5 CN3 RESET IC CN7 RDS DECODER Q44 AM+B Q45 Q46 FM+B Q43 WH1 A1 CH CORD 2/2 X16- J1 to CD MECHA. (X32-5170) ANT. TUNER J1 A D22 D23 D24 Q53 D18 Q52 (X16-118X-XX) IC1 : IC2 : TDA7407D IC3 : M5237ML IC4 : TA8273H IC8 : HD74HC02FP or TC74HC02AF or IC16 : S-80837ANNP IC15 : LB1930M IC14 : TDA7479D Q1,4 : 2SB1548(P) Q2,11,30,31,36,52 : 2SC4081 or 2SD1819A Q3,27,51 : 2SA1576A or 2SB1218A Q5,8,12,15,50,53 : UN5213 or DTC144EUA Q6,7,13,28,32,33 : KRA303 or DTA124EUA Q9 : 2SD2375 Q10 : 2SB1184 Q14 : KRA105S or DTA123JK Q24,29 : UN5214 or DTC114YUA Q25,26,44,46 : 2SB1277(Q,R) Q35,43,45 : UN5212 or DTC124EUA Q37-40 : KRC410 or DTC143TUA D1 : S2V20 D2 : 1GWJ43 D3,16 : MA4056(N)-M D4 : MA4082(N)-L or HZS9A2L D5 : MA4110-L D7 : MA4056-M D8 : MA4047-M or HZS5B1 D11,12,14,33-36,38-41 : AM01Z or DSM1SD2 or ERA15-01 or D15,18,30-32,61-64 : 1SS133 D17 : MA4062(N)-M or D22-24,29 : MA4062-L or HZS6C1 D25,26 : RD6.8M(B2) D27,28 : MA4068(N)-M A D60 UPD703033GC139 HZS6C2L D60 IMSA-6801 or : SA-C2012-101TB SYSTEM MI-COM. SW SW COMPOSITE SIGNAL OUTPUT BUFFER IFC BUFFER DRIVER IC MOTOR 74VHC02SJ ERA15-02 PS2 M PS3 PS1 PM1 22K 22K 22K 22K 47K 47K 0V 5.0V 5.0V 5V 0V 7.6V 5.0V 0V 0V 7.6V 0V 5V 5V 0V 2.5V 2.5V 5.0v 0V 0V 5.0V 0V 5.0V 5.0V 5.0V 0V 0V 0V 5.0V 0V 5.0V 0V 5.0V 0V 0V 5.0V 5.0V 0V 5.0V 0V 0V 5.0V 0V 5.0V 0V 5.0V 3.5V 0V 5.0V 0V or 5.0V 0V 5.0V 0V 5.0V 5.0V 0V 5.0V 0V 5.0V 0V 5.0V 0V 0V or 5.0V 2.6V or 5.0V 5.0V 0V 1.6V 0V 0-5.0V 0-4.2V 5.0V 0V 5.0V 0V 0V 5.0V 0V 5.0V 5.0V 0V 0V 5.0V 5.0V 0V 5.0V 0V 5.0V 0V 0V 4.7V 0V 5.0V 0V 5.0V 5.0V 0V 0V 0V 5.0V 5.0V 0V 5.0V 0V 5.0V 5.0V 0V 5.0V 0V 0V 0V 5.0V 0V 5.0V 0V 5.0V 0V 7.6V 5.0V 7.6V 8.3V 8.3V 5.0V 29 96 R224 2.2K SW2 D OUT 22 21 R222 2.2K R223 2.2K R67 MOSW MUTE L MS CLK MUTE R SW1 MS DA NC BU 5V D GND M STOP AUDIO +B M RST GND Rch Lch LO/EJ SERVO SERVO SW3 4 R220 100K R221 100K 12 20 19 18 17 15 14 13 16 11 10 9 7 6 5 8 4 8 1 3 2 1 2 3 4 CLK REQ H REQ C CH RST DATA C DATA H CH CON CH MUTE R132 100 R131 4.7K R135 4.7K R133 100 R130 4.7K R134 100 R137 4.7K R136 4.7K 5 4 3 2 1 8 7 6 91 61 47u6.3 53 SCL 90 SDA 54 58 57 60 + 0.01 C41 C40 63 1 2 4 R102 1K R105 470 9 100 AM+B FM+B AFS PLL-DATA EVDD EVSS 1 2 3 4 5 6 7 8 CH-CLK 99 98 MC-DATA/L-DATAS SC-DATA/L-DATAL 97 BU-DET P-MUTE P-STBY IC2-SCL PRE-MUTE R IC2-SDA BEEP DA-SCA/DIM-CON TEST 10 12 13 14 REMO PRE-MUTE L 11 15 16 17 18 19 20 22 23 21 MUTE DIMMER 25 24 26 SW5V 27 EX-AMP-CONT 28 P-CON ANT-CON 29 95 SRM+B 94 92 93 CD-SW1 CD-SW2 SC-REQ/KEY-REQ 90 91 89 R-CLK CH-REQC SRM-B 87 88 XT2 31 30 P-ON 33 32 XT1 RESET X2 35 REGC 34 36 CLKOUT VSS 37 X1 39 VDD 38 40 79 83 86 84 85 R-QUAL IFC-OUT R-DATA 81 82 80 S-METER SRM-DET NOISE 77 78 76 SRM-SW2 SRM-SW1 SRM-SW3 PHONE AVREF AVSS 46 43 41 42 TYPE0 44 TYPE1 45 ILL-ON M-MUTE R M-MUTE L CD-SW3 MOSW LO/EJ MC-REQ/PANEL//L-CE M-RST BVSS BVDD CH-RST IC2 TYPE1 47 IC2 TYPE0 48 CH-CON 50 CH-MUTE 49 72 75 74 73 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 GND EXTRES + C143 C144 10u16 0.01 7 8 FILOUT FSEL ARI TM 10 9 SRM SUB+ SRM SW2 SRM DET GND SRM SW3 0.22 S-GND P-GND OSCO C142 C141 330P 5 6 3 10u16 4 + MPX OSCI OSEL VCC 12 11 VREF C146 X3 13 10P 1 2 82 81 16 QUAL RDDA RDCK T57 C145 15 14 10P 87 4 78 10 1 3 4 5 92 86 IN1 IN2 NC OUT2 2 VCC NC NC OUT1 8 7 6 9 3 6 77 5 7 0.01 C137 IF1 +B 24 IF1 GND AMIF OUT 22 S-METER 23 20 AUDIO OUT 21 SDA 5 4.7uH L12 18 RDS OUT 19 NOISE OUT VDD 5V 17 15 SCL DIG GND 16 4 PLL +B 13 IFC OUT 14 12 10 OSC GND 11 VT OSC GND 8 9 W/N 1 4.7uH Q43,44 L10 1 Q45,46 1K R213 22K R212 4.7uH 2 R211 22K R210 1K 4 0.22 C133 AM +B OSC GND 7 5 OSC GND FM +B 6 0.01 C131 3 AM ANT 2 RF GND FM ANT L9 2 1 4.332MHz 3 NC L DATA L L DATA S L CE ILLMG L CLK ILL +B 13 11 12 RST 9 10 7 8 DIM CON NC REMO 5 6 4 DGND VDD 2 1 5 3 2 4 6 7 8 9 10 11 12 13 14 15 1 GND +B 94 95 51 88 48 49 50 96 ACC-DET CH-REQH DA-SCL/NC M-STOP AVDD AVCONT CH-DATAH CH-DATAC MC-CLK//L-CLK/PANEL PAN5V 27 28 24 25 26 52 R103 470 PLL-CLK 5 R106 4.7K R104 4.7K 30 1K R50 20 R113 47K 9 19 12 11 SCL SDA R109 1K R111 1K R112 10K R110 10K 21 R1115 100K C42 22P C43 27P C44 1 32.768kHz X2 20.0MHz X1 10K R49 R51 100K R52 100K R53 100K R54 100K R60 100K R62 100K 50 48 49 51 R100 1K R98 1K 93 97 100 99 96 95 94 R82 1K R96 100K R93 100K R88 100K R86 100K R81 100K R80 100K R79 2.2K C46 1000P R77 2.2K R75 1K R76 100K R74 2.2K R73 2.2K R85 R72 1K 2.2K R69 2.2K R117 1K R118 1K 31 65 57 60 58 61 63 53 54 90 91 0.1 3 1 2 SRM SW1 SRM SUB- C147 0.22 C148 75 76 76 77 75 79 78 86 88 87 83 82 81 80 92 2.2K R214 R216 2.2K R215 2.2K 4.7uH L11 0.01 C135 1000P C139 47K R243 83 13 11 10K 31 1K R217 4.7K R218 80 UNIT MODEL KDC-7021 KDC-B7021 2-71 KDC-7021Y KDC-8020 KDC-5019 KDC-519 NAME 0-10 No. R119 1K 17 R107 R108 10 R116 2.2K C140 0.47 47u10 C134 + 0.047 C160 100x2 CP3 1Kx2 CP2 1Kx2 CP5 100Kx2 CP4 1Kx2 CP1 R89 1K 2.2Kx2 CP6 100K R90 L5 98 1K R97 R101 1M R66 100K 10 C45 SCL SDA 2.2M 2.2K R114 10K 470 R84 1 3 2 5 4 7 6 NC 74 MPX MPX GND5 52mH L7 GND6 C149 GND7 R55 100K R56 100K TYPE2 BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V BU5V SW5V SW5V SW5V SW5V SW5V SW5V SW5V SW5V SW5V SW5V SW5V A8V A8V A8V A8V A8V A8V A8V A8V A8V A8V +B A8V A8V 220 R68 S8V S8V S8V GND VCC OUT S8V S8V S8V 1 6 7 8 4 5 2 3 VDD NC NC REMO DGND DIM CON L DATA S L DATA L RST L CE ILLMG L CLK ILL +B S.GND S.GND IC16 IC1 IC14 IC15 (X16-118X-XX) A MASK MECHA SUB-CIRCUIT UNIT DTA114EUA DTA124EUA DTC124EUA DTC144EUA IN GND OUT UN5212 3 2 1 RD6.8M A C N TC74HC02AF 1 7 14 8 M5237ML 1 2 3 LB1930M 1 5 6 10 TDA7479D 1 8 9 16 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 S T U V W X Y AA Z 1 2 3 4 5 6 7 10.7V 0V 5.0V 0V 0V 0V 5V 5.0V 8.5V/7.6V 6.8V/6.0V 5.1V/4.5V 3.4V/3.0V 1.7V/1.5V 0V 5.0V 0V 0V 5.0V J1 D7 D6 D5 D10 D9 D8 D18 D15 D14 D22 D16 D21 D20 D17 D13 D12 D11 D23 ∗D3 S1 VOL- S2 S4 ATT S5 S9 4 S11 6 S12 S8 S10 TI 5 2 S7 1 S6 SRC S22 S26 AM FM EJECT S15 S17 S16 S18 S14 S24 S20 dB S25 S13 DISP Q3 1/2 118 J1 IC1 : LC75808W IC2 : RS-171 Q1,6 : DTA114EUA or Q3-5 : 2SC4081 D2 DIMMER SW Q4 Q5 Q6 B30-1571-05 D1-3 : D26 : LCD DRIVER REMOTE SENSOR Q1 S3 RST IC Q7 VOL+ 3 S21 CLK S27 S19 S23 DTC143ZK Q7 : B30-1605-05 D5-18,20-22 : B30-1564-05 ∗ D23,24 : OPEN S28 ∗D26 D1 D24 B LINE GND LINE KRA302 REMO SW RED LED SW GREEN LED SW AVR VLCD KEY SW PERMISSION X16- 2 3 4 5 6 7 8 9 10 11 12 13 ILL+B ILLUM G L CLK L CE RESET L DATAS L DATAL DIMMER NC REMO NC D GND 330 R17 510 R22 R23 270 C13 0.01 KS3 KS5 KS2 KS1 KI1 KI2 KI3 KI4 1K 10K R15 1Kx4 CP2 KI1 KI4 KI3 KI2 4.7 R11 KI5 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 27 26 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 KS5 KS4 KS3 KS2 KS1 COM1 COM2 COM3 COM4 COM5 COM6 COM7 COM8 COM9 COM10 S60 S59 S58 S57 S56 S55 S54 S53 S52 S51 S45 S44 S43 S42 S41 S40 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 KI5 REMO RED GREEN KEY VDD VLCD VLCD0 VLCD1 VLCD2 VLCD3 VLCD4 VSS TEST OSC INH DO CE CL DI S4 S3 S2 S1 S10 S8 S7 S6 S5 S9 S15 S14 S13 S12 S11 S20 S19 S18 S17 S16 S21 S22 S23 S38 S34 S32 S31 S33 S36 S35 S37 S46 S42 S40 S39 S41 S44 S43 S45 S47 S50 S30 S29 S60 S59 S58 S57 S56 S55 S54 S53 S52 S51 C4 C1 C8 C2 C3 C7 C5 C6 KS1 KS4 KS2 KS3 CP3 1Kx4 C11 0.01 10K R16 R5 C4 0.1 C3 0.1 R4 C2 0.1 R3 C5 0.1 100 R9 2.2 C7 S49 S48 S25 S24 S50 S46 S47 S48 S49 28 29 30 31 32 S28 S27 S26 79 KI3 78 KI2 KI4 80 KI1 77 KS6 76 KI5 R13 1K 84 83 1 VDD S.GND R10 CP1 470x4 22K 97 98 99 100 97 98 99 100 C1 680P R1 43K GND2 VCC 4 3 GND1 OUT 1 2 KS5 R14 1K R18 330 R19 330 R20 330 R21 330 84 83 ∗C9 0.01 330 R24 KS4 8 3.9K R6 2.2K 2.2K 2.2K R2 2.2K 8 C6 2.2 R7 22K R12 750 R8 S.GND 10K R28 10K R27 ∗R29 1.2K ∗R25 1.2K C12 0.01 C14 0.01 +B MODEL NAME YES NO KDC-7021 (E) NO X16-1542-72 X16-1540-12 X16-1540-11 UNIT No. MA3082-M D26 MA3091-M B38-1088-05 B38-1086-05 ED1 YES X16-1542-73 MA3082-M B38-1088-05 NO YES NO YES C9 D3 NO YES NO YES R25, 29 MA3091-M B38-1086-05 KDC-5019 (K) KDC-B7021 (E) KDC-7021Y (E) KDC-519 (K) KDC-8020 (M) Q6 +B +B +B +5V +5V +B +5V +5V +B +B +B +B +B +B 14 15 UNIT No. X16-1892-71 X16-1892-72 SEG17 35 SEG17 35 SEG59 9 C1 COM1 1 COM8 COM3 COM4 COM6 COM5 COM7 COM2 C5 C4 C2 C3 3 2 5 4 C7 C8 C6 7 6 8 SEG52 17 SEG53 SEG54 SEG57 SEG58 SEG56 SEG55 SEG60 13 11 10 12 15 14 16 SEG51 18 SEG1 19 SSEG9 27 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 21 20 22 23 24 25 26 SEG16 SEG14 SEG15 SEG12 SEG10 SEG11 SEG13 31 29 28 30 33 32 34 S1 SEG1 19 27 SEG9 SEG5 SEG3 SEG4 SEG2 21 20 22 23 SEG8 SEG7 SEG6 24 25 26 S5 S3 S2 S4 S6 S8 S7 31 SEG13 SEG12 SEG11 SEG10 29 28 30 SEG14 SEG15 SEG16 33 32 34 S9 S10 S11 S12 S14 S13 S15 S16 SEG25 43 SEG24 SEG22 SEG23 SEG20 SEG18 SEG19 SEG21 39 37 36 38 41 40 42 SEG32 SEG31 SEG30 SEG29 SEG28 SEG26 SEG27 45 44 46 47 48 50 49 SEG39 SEG40 SEG38 SEG37 SEG36 SEG35 SEG33 SEG34 51 52 53 54 56 55 57 58 SEG48 SEG47 SEG46 SEG45 SEG43 SEG44 SEG42 SEG41 59 60 62 61 63 64 65 66 COM1 SEG52 S60 SEG49 SEG50 68 67 S56 S57 S59 S58 S53 S54 S55 COM3 COM2 COM4 COM5 COM6 COM7 COM8 SEG60 SEG58 SEG59 SEG57 SEG56 SEG54 SEG55 SEG53 S51 S52 SEG51 S32 43 SEG25 39 SEG21 SEG20 SEG19 SEG18 37 36 38 SEG22 SEG23 SEG24 41 40 42 S17 S18 S20 S19 S21 S22 S23 S24 SEG26 SEG27 SEG28 45 44 46 SEG32 SEG31 SEG30 SEG29 47 48 50 49 S28 S26 S25 S27 S30 S29 S31 S40 SEG36 SEG35 SEG33 SEG34 51 52 53 54 SEG38 SEG39 SEG40 SEG37 56 55 57 58 S36 S34 S33 S35 S38 S37 S39 SEG42 SEG43 SEG44 SEG41 59 60 62 61 SEG48 SEG47 SEG46 SEG45 63 64 65 66 S44 S42 S41 S43 S46 S45 S47 SEG50 SEG49 68 67 S49 S48 S50 5 9 10 7 8 6 3 4 2 1 17 18 15 16 13 14 12 11 A IC1 IC2 SWITCH UNIT (X16-1XXX-XX) ∗ED1(COMMON) ∗ED1(SEGMENT) 10K 10K 47K 4.7K 10K 10K CAUTION:For continued safety, replace safety critical components only with manufacturer’s recommended parts (refer to, parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. KDC-5019/519/7021/7021Y/8020/B7021 w w w . x i a o y u 1 6 3 . c o m Q Q 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 EXPLODED VIEW 19 Parts with exploded numbers larger than 700 are not suppied. A B 1 2 3 N N N M M N (X16-1XXX-XX) (X25-XXXX-XX) PS2 PS3 PS1 PM1 PFPC1 J1 FPC1 L E K Q Q Q D L B B A A F J J B B Px2 D A G H B B B B C F RC1 PME1 DC1 DC2 RC2 266 267 221 284 FC1 244 245 F1 P P P Px2 Tx2 P P T P P R S S S S WH1 IC4 DME1 ED1 304 304 303 302 301 DC3 M2x2 (BLK) M2x2.5 φ2x4 M2x2.5 M2x1.8 (BLK) FLAT WASHER FLAT WASHER FLAT WASHER RETAINING RING RETAINING RING M2x2.5 φ2x5 φ2x8 (BLK) φ3x5 φ2x4 (BLK) φ3x8 φ3x12 φ2.6x6 A B C D E F G H J K L M N P Q R S T : : : : : : : : : : : : : : : : : : N09-4400-05 N09-4401-05 N09-4427-05 N09-4448-05 N09-4449-05 N19-2154-04 N19-2155-04 N19-2156-04 N29-0523-05 N29-0522-05 N38-2025-46 N80-2005-46 N80-2008-45 N83-3005-46 N86-2004-45 N80-3008-46 N83-3012-46 N86-2606-46 275 213 282 258 789 200 271 255 285 227x2 232 230 231 233 234 204 263 272 257 203 212 229 219 235 236 228 256 262 205 259 269 237 260 261 286 250x4 749 748 770 206 747 701 202 220 (X16-) (X16-) 805 (X25-) 814 746 790 746 742 (X25-) 813 (X25-) 810 (X25-) (X25-) (X25-) 812 (X25-) 811 (X16-) (X16-) (X16-) (X16-) (X16-) (X16-) (X16-) PA1 222 277 268 278 276 280 281 279 243 714 211 223 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 PARTS LIST 20 Ref.No. Parts No. Description A d d A d d N e w Dest inati on Ref.No. Parts No. Description A d d A d d N e w Dest inati on ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. K: KDC-519 K1: KDC-5019 M1: KDC-8020 E2: KDC-7021Y Z1: KDC-7021 Z2: KDC-B7021 indicates safety critical components. 237 2A D14-0760-03 ROLLER 243 3A ∗ E29-1879-02 CONDUCTIVE RUBBER 244 2B E30-4935-05 CORD WITH PINPLUG E2 244 2B E30-4935-05 CORD WITH PINPLUG K,K1,M1 244 2B E30-4979-05 CORD WITH PINPLUG Z1,Z2 245 2B E30-4946-05 CORD WITH DIN CONNECTOR E2 245 2B E30-4946-05 CORD WITH DIN CONNECTOR K,K1,M1 245 2B E30-4947-05 CORD WITH DIN CONNECTOR DC1 1A E30-4940-05 DC CORD K,K1 DC2 1A E30-4939-05 DC CORD M1 DC3 1A E30-4942-05 DC CORD E2 DC3 1A E30-4956-05 DC CORD Z1,Z2 FC1 1B ∗ E39-0462-05 FLAT CABLE (22P) 250 1B F29-0049-05 INSULATING COVER F1 2B F52-0006-05 FUSE (MINI BLADE TYPE) (10A) F1 2B F52-0011-05 FUSE (MINI BLADE TYPE) (10A) E2 F1 2B F52-0011-05 FUSE (MINI BLADE TYPE) (10A) K,K1,M1 255 1B G01-2924-04 TORSION COIL SPRING 256 2A G01-3065-04 EXTENSION SPRING 257 2A G01-3066-14 TORSION COIL SPRING 258 3B G01-3069-04 EXTENSION SPRING 259 2A G01-3080-04 TORSION COIL SPRING 260 2A G09-2038-04 FORMED WIRE 261 2A G09-2042-04 FORMED WIRE 262 2A G11-1927-04 CUSHION 263 2A G16-1177-04 SHEET - H10-4762-12 POLYSTYRENE FOAMED FIXTURE Z1,Z2 - H10-4763-12 POLYSTYRENE FOAMED FIXTURE E2 - H10-4764-12 POLYSTYRENE FOAMED FIXTURE K,K1,M1 - H25-0329-04 PROTECTION BAG (280X450X0.03) E2 - H25-0329-04 PROTECTION BAG (280X450X0.03) K,K1,M1 - H25-0337-04 PROTECTION BAG (180X300X0.03) - H25-1108-04 PROTECTION BAG (100X300X0.03) - H25-1111-04 PROTECTION BAG (280X450X0.03) Z1,Z2 - ∗ H54-2339-03 ITEM CARTON CASE K1 - ∗ H54-2340-03 ITEM CARTON CASE M1 - ∗ H54-2341-03 ITEM CARTON CASE Z2 - ∗ H54-2345-03 ITEM CARTON CASE K - ∗ H54-2346-03 ITEM CARTON CASE Z1 - ∗ H54-2347-03 ITEM CARTON CASE E2 266 1B J19-5051-03 BRACKET (L) K,K1,M1 267 1B J19-5052-03 BRACKET (R) K,K1,M1 268 3A ∗ J19-5136-02 HOLDER 269 2A J21-9651-13 MOUNTING HARDWARE ASSY 271 1B J21-9716-03 MOUNTING HARDWARE ASSY 272 3A J90-0999-04 GUIDE PFPC1 1A J84-0122-04 FLEXIBLE PRINTED WIRING BOARD 275 3A K24-3646-04 KNOB (OPEN) 276 3A ∗ K24-3835-04 KNOB (SRC) 277 3A ∗ K25-1404-03 KNOB (VOL) 278 3A ∗ K25-1405-02 KNOB (PRESET) 279 3A ∗ K25-1406-03 KNOB (FM,AM) KDC-5019/519/7021/7021Y/8020/B7021 200 1A A02-1497-13 PLASTIC CABINET ASSY 202 1B ∗ A52-0808-02 TOP PLATE 203 2A A10-4807-13 CHASSIS CALKING ASSY 204 1A A10-4810-13 CHASSIS CALKING ASSY 205 2A A10-4893-04 CHASSIS CALKING ASSY 206 2A ∗ A10-4924-02 CHASSIS 211 3A ∗ A21-4171-03 DRESSING PANEL 212 2A A22-2865-03 SUB PANEL ASSY 213 3B ∗ A46-1753-01 REAR COVER PA1 3A ∗ A64-2578-02 PANEL ASSY K PA1 3A ∗ A64-2579-02 PANEL ASSY K1 PA1 3A ∗ A64-2581-02 PANEL ASSY M1 PA1 3A ∗ A64-2583-02 PANEL ASSY E2,Z1 PA1 3A ∗ A64-2584-02 PANEL ASSY Z2 PME1 2A ∗ A10-4921-02 CHASSIS ASSY RC1 1B ∗ A70-2025-05 REMOTE CONTROLLER ASSY (RC-410) RC2 2B A70-0886-15 REMOTE CONTROLLER ASSY E2,Z1,Z2 219 2A B03-3073-12 DRESSING PLATE 220 3B B07-3007-03 ESCUTCHEON ASSY (BLK) 221 1B B07-3010-02 ESCUTCHEON (J CAR) K,K1,M1 222 3A ∗ B10-4157-01 FRONT GLASS K 222 3A ∗ B10-4158-01 FRONT GLASS K1 222 3A ∗ B10-4160-01 FRONT GLASS M1 222 3A ∗ B10-4162-01 FRONT GLASS E2,Z1 222 3A ∗ B10-4163-01 FRONT GLASS Z2 223 3A ∗ B10-4222-03 FRONT GLASS - B46-0100-50 WARRANTY CARD K,K1,M1 - B46-0100-50 WARRANTY CARD Z1,Z2 - B46-0606-04 ID CARD K,K1 - B46-0612-14 ID CARD M1 - B46-0632-04 ID CARD E2,Z1,Z2 - B46-0645-03 USER CARD K,K1 - ∗ B64-2145-00 INST. MANUAL (ENG,RUS) E2 - ∗ B64-2146-00 INST. MANUAL (POL,CZE,HUN) E2 - ∗ B64-2147-00 INST. MANUAL (CRO,SWE,FIN) E2 - ∗ B64-2148-00 INST. MANUAL (ENG,FRE,SPA) K,K1 - ∗ B64-2149-00 INST. MANUAL (ENG,T-CHI) M1 - ∗ B64-2150-00 INST. MANUAL (ARABIC) M1 - ∗ B64-2151-00 INST. MANUAL (ENGLISH) Z1,Z2 - ∗ B64-2152-00 INST. MANUAL (FRE,GER,DUT) Z1,Z2 - ∗ B64-2153-00 INST. MANUAL (ITA,SPA,POR) Z1,Z2 227 1A D10-4562-04 LEVER 227 1A D10-4621-04 LEVER Z1,Z2 228 2A D10-4563-04 ARM ASSY 229 2A D10-4590-04 ARM 230 1A D13-2135-04 GEAR ASSY 231 1A D13-2138-04 GEAR 232 1B D13-2139-04 GEAR 233 1A D13-2140-04 GEAR 234 1A D13-2141-14 GEAR ASSY 235 2A D13-2165-03 GEAR ASSY 236 2A D14-0754-04 ROLLER www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 PARTS LIST 21 Ref.No. Parts No. Description A d d A d d N e w Dest inati on Ref.No. Parts No. Description A d d A d d N e w Dest inati on ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. K: KDC-519 K1: KDC-5019 M1: KDC-8020 E2: KDC-7021Y Z1: KDC-7021 Z2: KDC-B7021 indicates safety critical components. 280 3A ∗ K25-1407-03 KNOB (PROG) 281 3A ∗ K25-1408-03 KNOB (UP,DOWN) 282 3A K29-7017-03 KNOB (LOCK) 284 1B ∗ N99-1722-05 SCREW SET K,K1,M1 285 1B N99-1704-05 SCREW SET A 1A N09-4400-05 MACHINE SCREW (M2X2) B 1A N09-4401-05 MACHINE SCREW (M2X2.5) C 1A N09-4427-05 TAPTITE SCREW (S2X4) D 2A N09-4448-05 MACHINE SCREW (M2X2.5) E 3A N09-4449-05 MACHINE SCREW (M2X1.8 BLK) F 1B N19-2154-04 FLAT WASHER (1.6X5X0.25 LUMI) G 2A N19-2155-04 FLAT WASHER (1.6X5X0.35 LUMI) H 2A N19-2156-04 FLAT WASHER (1.2X3X0.25 POLY) J 1A N29-0523-05 RETAINING RING (2X5X0.4) K 2A N29-0522-05 RETAINING RING (1.5X4X0.4) L 3A N38-2025-46 PAN HEAD MACHIN SCREW M 3A N80-2005-46 PAN HEAD TAPTITE SCREW N 2B N80-2008-45 PAN HEAD TAPTITE SCREW P 1B N83-3005-46 PAN HEAD TAPTITE SCREW Q 2A N86-2004-45 BINDING HEAD TAPTITE SCREW PS1-3 1A S68-0856-05 PUSH SWITCH 286 1B T90-0523-05 ANTENNA ADAPTOR E2,Z1,Z2 286 1B T90-0534-05 ANTENNA ADAPTOR E2,Z1,Z2 PM1 1A T42-1034-04 MOTOR ASSY DME1 1B X92-4030-00 MECHANISM ASSY (DXM-6000W) J1 2A E58-0903-05 RECTANGULAR RECEPTACLE (15P) FPC1 2A ∗ J84-0121-12 FLEXIBLE PRINTED WIRING BOARD 301 3A B11-1324-04 OPTICAL DIFFUSER K,E2,Z1 301 3A ∗ B11-1382-04 OPTICAL DIFFUSER K1,M1,Z2 302 3A B11-1322-04 REFLECTION SHEET 303 3A ∗ B19-2134-03 LIGHTING BOARD D1-3 B30-1571-05 LED(WHITE) K,E2,Z1 D1,2 B30-1571-05 LED(WHITE) K1,M1,Z2 D5-18 B30-1605-05 LED(2COLOR PG/RED) D20-22 B30-1605-05 LED(2COLOR PG/RED) D23,24 B30-1564-05 LED(1608,BLUE) ED1 3A ∗ B38-1086-05 LIQUID CRYSTAL K,E2,Z1 ED1 3A ∗ B38-1088-05 LIQUID CRYSTAL K1,M1,Z2 C1 CC73GCH1H681J CHIP C 680PF J C2-5 CK73GB1C104K CHIP C 0.10UF K C2-5 CK73GB1H104K CHIP C 0.10UF K C6,7 CK73FB1A225K CHIP C 2.2UF K C9 CK73GB1H103K CHIP C 0.010UF K K,E2,Z1 C11-14 CK73GB1H103K CHIP C 0.010UF K 304 3A E29-1885-04 CONDUCTIVE RUBBER J1 E59-0835-05 RECTANGULAR PLUG (15P) CP1 R90-1016-05 MULTI-COMP 470 X4 CP2,3 R90-0724-05 MULTI-COMP 1K X4 R1 RK73GB2A433J CHIP R 43K J 1/10W R2-5 RK73GB2A222J CHIP R 2.2K J 1/10W R6 RK73GB2A392J CHIP R 3.9K J 1/10W R7,8 RK73GB2A223J CHIP R 22K J 1/10W R9 RK73GB2A101J CHIP R 100 J 1/10W R10 RK73GB2A102J CHIP R 1.0K J 1/10W R11 RK73GB2A4R7J CHIP R 4.7 J 1/10W R12 RK73GB2A361J CHIP R 360 J 1/10W R13,14 RK73GB2A102J CHIP R 1.0K J 1/10W R15,16 RK73GB2A103J CHIP R 10K J 1/10W R17-21 RK73FB2B331J CHIP R 330 J 1/8W R22 RK73FB2B511J CHIP R 510 J 1/8W R23 RK73FB2B271J CHIP R 270 J 1/8W R24 RK73FB2B331J CHIP R 330 J 1/8W R25 ∗ RK73GB2A122J CHIP R 1.2K J 1/10W K,E2,Z1 R27,28 RK73GB2A103J CHIP R 10K J 1/10W R29 ∗ RK73GB2A122J CHIP R 1.2K J 1/10W K,E2,Z1 S28 S70-0864-05 TACT SWITCH D26 MA3082-M ZENER DIODE K1,M1,Z2 D26 MA3091-M ZENER DIODE K,E2,Z1 IC1 LC75808W MOS-IC IC2 RS-171 ANALOGUE IC Q1 DTA114EUA DIGITAL TRANSISTOR Q1 KRA302 DIGITAL TRANSISTOR Q3-5 2SC4081 TRANSISTOR Q6 DTA114EUA DIGITAL TRANSISTOR Q6 KRA302 DIGITAL TRANSISTOR Q7 DTC143ZK DIGITAL TRANSISTOR C1 C90-5242-05 ELECTRO 3300UF 16WV C2 CK73GB1H222K CHIP C 2200PF K C3 C90-2866-05 ELECTRO 220UF 16WV C4 CK73GB1H103K CHIP C 0.010UF K C5 CE04NW1C100M ELECTRO 10UF 16WV C6 CE04NW0J101M ELECTRO 100UF 6.3WV C7 CK73FB1C105K CHIP C 1.0UF K C8 CE04CW1A221M ELECTRO 220UF 10WV C9 CE04NW1A101M ELECTRO 100UF 10WV C11,12 CK73FB1H104K CHIP C 0.10UF K C20 CK73GB1H103K CHIP C 0.010UF K E2,Z1,Z2 C21 CK73GB1E223K CHIP C 0.022UF K C21 CK73GB1H223K CHIP C 0.022UF K C22 CE04NW1H010M ELECTRO 1.0UF 50WV C34 CE04NW1V3R3M ELECTRO 3.3UF 35WV C35 CK73GB1C683K CHIP C 0.068UF K C36 CE04NW1H0R1M ELECTRO 0.1UF 50WV C37 CK73GB1H102K CHIP C 1000PF K C38,39 CK73GB1H103K CHIP C 0.010UF K C40 CE04NW0J470M ELECTRO 47UF 6.3WV C41 CK73GB1H103K CHIP C 0.010UF K C42 CC73GCH1H220J CHIP C 22PF J C43 CC73GCH1H270J CHIP C 27PF J C44 CK73GB0J105K CHIP C 1.0UF K KDC-5019/519/7021/7021Y/8020/B7021 SUB-CIRCUIT UNIT (X16-118X-XX) SWITCH UNIT (X16-1XXX-XX) ELECTRIC UNIT (X25-XXXX-XX) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 PARTS LIST 22 Ref.No. Parts No. Description A d d A d d N e w Dest inati on Ref.No. Parts No. Description A d d A d d N e w Dest inati on ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. K: KDC-519 K1: KDC-5019 M1: KDC-8020 E2: KDC-7021Y Z1: KDC-7021 Z2: KDC-B7021 indicates safety critical components. ELECTRIC UNIT (X25-XXXX-XX) L6 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) L7 L33-1039-05 LINE FILTER COIL (52mH) L9-12 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) X1 L78-0821-05 RESONATOR (20.0MHz) X2 L77-2738-05 CRYSTAL RESONATOR (32.768kHz) X3 L77-2002-05 CRYSTAL RESONATOR (4.332MHz) E2,Z1,Z2 P 2B N83-3005-46 PAN HEAD TAPTITE SCREW R 2B N80-3008-46 PAN HEAD TAPTITE SCREW S 2B N83-3012-46 PAN HEAD TAPTITE SCREW T 2B N86-2606-46 BINDING HEAD TAPTITE SCREW CP1,2 R90-0725-05 MULTI-COMP 1K X2 CP3 R90-1019-05 MULTI-COMP 100 X2 CP4 R90-0737-05 MULTI-COMP 100K X2 CP5 R90-0725-05 MULTI-COMP 1K X2 CP6 R90-1013-05 MULTI-COMP 2.2K X2 R1 RK73GB2A223J CHIP R 22K J 1/10W R2 RK73GB2A101J CHIP R 100 J 1/10W R3 RK73GB2A223J CHIP R 22K J 1/10W R4 RK73GB2A222J CHIP R 2.2K J 1/10W R5 RD14BB2C221J RD 220 J 1/6W R6 RK73GB2A153J CHIP R 15K J 1/10W R7 R92-3032-05 CHIP R 4.3K D 1/10W R8 R92-3047-05 CHIP R 24K D 1/10W R9 RD14BB2C152J RD 1.5K J 1/6W R10 ∗ RK73EB2E2R2J CHIP R 2.2 J 1/4W R11 RD14BB2C102J RD 1.0K J 1/6W R13 RK73EB2E102J CHIP R 1.0K J 1/4W M1,E2,Z1 R13 RK73EB2E102J CHIP R 1.0K J 1/4W Z2 R14 RD14BB2C561J RD 560 J 1/6W M1,E2,Z1 R14 RD14BB2C561J RD 560 J 1/6W Z2 R15 RK73EB2E103J CHIP R 10K J 1/4W E2,Z1,Z2 R16 RK73GB2A223J CHIP R 22K J 1/10W E2,Z1,Z2 R17 RK73GB2A473J CHIP R 47K J 1/10W E2,Z1,Z2 R18 RK73GB2A104J CHIP R 100K J 1/10W K,K1,M1 R19 RK73EB2E103J CHIP R 10K J 1/4W R20 RK73GB2A104J CHIP R 100K J 1/10W R33 RD14BB2C472J RD 4.7K J 1/6W R34,35 RD14DB2H102J SMALL-RD 1.0K J 1/2W K,K1,M1 R36 RD14BB2C223J RD 22K J 1/6W K,K1,M1 R37 RD14BB2C472J RD 4.7K J 1/6W R38 RD14DB2H102J SMALL-RD 1.0K J 1/2W R39 RK73GB2A223J CHIP R 22K J 1/10W R40 RD14DB2H102J SMALL-RD 1.0K J 1/2W R41,42 RK73GB2A123J CHIP R 12K J 1/10W R43 RK73GB2A562J CHIP R 5.6K J 1/10W R44 RK73GB2A223J CHIP R 22K J 1/10W R45 RD14DB2H332J SMALL-RD 3.3K J 1/2W R46 RD14BB2C473J RD 47K J 1/6W R47 RK73GB2A183J CHIP R 18K J 1/10W R48 RK73GB2A104J CHIP R 100K J 1/10W R49 RK73GB2A103J CHIP R 10K J 1/10W R50 RK73GB2A102J CHIP R 1.0K J 1/10W R51 RK73GB2A104J CHIP R 100K J 1/10W K,K1,Z2 R52 RK73GB2A104J CHIP R 100K J 1/10W M1 C45 CK73EB0J106K CHIP C 10UF K C46 CK73GB1H102K CHIP C 1000PF K C48 CK73GB1H103K CHIP C 0.010UF K C61 CE04NW1A470M ELECTRO 47UF 10WV C62 CK73GB1H103K CHIP C 0.010UF K C63 CE04NW1H2R2M ELECTRO 2.2UF 50WV C65-68 CE04NW1HR47M ELECTRO 0.47UF 50WV C69 CE04NW0J470M ELECTRO 47UF 6.3WV C70 CK73GB1A474K CHIP C 0.47UF K C71 CC73GCH1H151J CHIP C 150PF J C72 CK73GB1E333K CHIP C 0.033UF K C72 CK73GB1H333K CHIP C 0.033UF K C73 CK73GB1H103K CHIP C 0.010UF K C74,75 CK73GB1C104K CHIP C 0.10UF K C74,75 CK73GB1H104K CHIP C 0.10UF K C93-96 C90-2597-05 ELECTRO 10UF 16WV C113 CE04NW1HR47M ELECTRO 0.47UF 50WV C114 CE04NW1C220M ELECTRO 22UF 16WV C115 CE04NW1H010M ELECTRO 1.0UF 50WV C116 CK73GB1C104K CHIP C 0.10UF K C116 CK73GB1H104K CHIP C 0.10UF K C117-120 C90-5296-05 NP-ELECT 0.22UF 50WV C131 CK73GB1H103K CHIP C 0.010UF K C133 CK73GB1A224K CHIP C 0.22UF K C134 CE04CW1A470M ELECTRO 47UF 10WV C135 CK73GB1H103K CHIP C 0.010UF K C137 CK73GB1H103K CHIP C 0.010UF K C139 CK73GB1H102K CHIP C 1000PF K C140 CK73GB1A474K CHIP C 0.47UF K C141 CC73GCH1H331J CHIP C 330PF J E2,Z1,Z2 C142,143 CE04NW1C100M ELECTRO 10UF 16WV E2,Z1,Z2 C144 CK73GB1H103K CHIP C 0.010UF K E2,Z1,Z2 C145,146 CC73GCH1H100D CHIP C 10PF D E2,Z1,Z2 C147,148 CK73GB1A224K CHIP C 0.22UF K C149 CK73GB1C104K CHIP C 0.10UF K K,K1,M1 C149 CK73GB1H104K CHIP C 0.10UF K K,K1,M1 C151,152 CK73GB1H222K CHIP C 2200PF K C153 CK73GB1E223K CHIP C 0.022UF K C153 CK73GB1H223K CHIP C 0.022UF K C160,161 CK73GB1E473K CHIP C 0.047UF K C160,161 CK73GB1H473K CHIP C 0.047UF K CN1 E40-3241-05 PIN ASSY (6P) CN2 E40-3237-05 PIN ASSY (2P) CN3 E40-3252-05 PIN ASSY (8P) CN4 E40-3261-05 PIN ASSY (3P) CN5 E40-9550-05 FLAT CABLE CONNECTOR (22P) CN6 E40-9557-05 FLAT CABLE CONNECTOR (13P) CN7 E40-5031-05 FLAT CABLE CONNECTOR (7P) J1 E58-0863-15 RECTANGULAR RECEPTACLE (16P) WH1 2B E30-4804-05 CORD WITH PLUG WH1 2B E30-4932-05 CORD WITH PLUG L1 L33-1170-05 CHOKE COIL ASSY (140UH) L4 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) L5 L92-0075-05 CHIP FERRITE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 PARTS LIST 23 Ref.No. Parts No. Description A d d A d d N e w Dest inati on Ref.No. Parts No. Description A d d A d d N e w Dest inati on ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. K: KDC-519 K1: KDC-5019 M1: KDC-8020 E2: KDC-7021Y Z1: KDC-7021 Z2: KDC-B7021 indicates safety critical components. R52,53 RK73GB2A104J CHIP R 100K J 1/10W E2,Z1 R53 RK73GB2A104J CHIP R 100K J 1/10W K1 R54 RK73GB2A104J CHIP R 100K J 1/10W K R54,55 RK73GB2A104J CHIP R 100K J 1/10W M1,Z2 R56 RK73GB2A104J CHIP R 100K J 1/10W K,K1,E2 R56 RK73GB2A104J CHIP R 100K J 1/10W Z1 R60 RK73GB2A104J CHIP R 100K J 1/10W R62 RK73GB2A104J CHIP R 100K J 1/10W R66 RK73GB2A104J CHIP R 100K J 1/10W R67 RK73GB2A103J CHIP R 10K J 1/10W R68 ∗ RK73GB2A221J CHIP R 220 J 1/10W R69 RK73GB2A222J CHIP R 2.2K J 1/10W R72 RK73GB2A102J CHIP R 1.0K J 1/10W R73,74 RK73GB2A222J CHIP R 2.2K J 1/10W R75 RK73GB2A102J CHIP R 1.0K J 1/10W R76 RK73GB2A104J CHIP R 100K J 1/10W R77 RK73GB2A222J CHIP R 2.2K J 1/10W R79 RK73GB2A222J CHIP R 2.2K J 1/10W R80,81 RK73GB2A104J CHIP R 100K J 1/10W K,K1,M1 R82 RK73GB2A102J CHIP R 1.0K J 1/10W R84 RK73GB2A471J CHIP R 470 J 1/10W R85 RK73GB2A222J CHIP R 2.2K J 1/10W R86 RK73GB2A104J CHIP R 100K J 1/10W K,K1,M1 R88 RK73GB2A104J CHIP R 100K J 1/10W R89 RK73GB2A102J CHIP R 1.0K J 1/10W R90 RK73GB2A104J CHIP R 100K J 1/10W R93 RK73GB2A104J CHIP R 100K J 1/10W R96 RK73GB2A104J CHIP R 100K J 1/10W R97,98 RK73GB2A102J CHIP R 1.0K J 1/10W R100 RK73GB2A102J CHIP R 1.0K J 1/10W R101 ∗ RK73GB2A105J CHIP R 1.0M J 1/10W R102 RK73GB2A102J CHIP R 1.0K J 1/10W R103 RK73GB2A471J CHIP R 470 J 1/10W R104 RK73GB2A472J CHIP R 4.7K J 1/10W R105 RK73GB2A471J CHIP R 470 J 1/10W R106 RK73GB2A472J CHIP R 4.7K J 1/10W R107 RK73GB2A225J CHIP R 2.2M J 1/10W R108 RK73GB2A222J CHIP R 2.2K J 1/10W R109 RK73GB2A102J CHIP R 1.0K J 1/10W R110 RK73GB2A103J CHIP R 10K J 1/10W R111 RK73GB2A102J CHIP R 1.0K J 1/10W R112 RK73GB2A103J CHIP R 10K J 1/10W R113 RK73GB2A473J CHIP R 47K J 1/10W R114 RK73GB2A103J CHIP R 10K J 1/10W R115 RK73GB2A104J CHIP R 100K J 1/10W R116 RK73GB2A222J CHIP R 2.2K J 1/10W R117-119 RK73GB2A102J CHIP R 1.0K J 1/10W R130,131 RK73EB2E472J CHIP R 4.7K J 1/4W R132-134 RK73EB2E101J CHIP R 100 J 1/4W R135-137 RK73EB2E472J CHIP R 4.7K J 1/4W R150 RK73GB2A472J CHIP R 4.7K J 1/10W R151 RK73GB2A103J CHIP R 10K J 1/10W R152 RK73GB2A472J CHIP R 4.7K J 1/10W R155,156 RK73EB2E100J CHIP R 10 J 1/4W R157 RK73EB2E4R7J CHIP R 4.7 J 1/4W ELECTRIC UNIT (X25-XXXX-XX) R158 RK73GB2A102J CHIP R 1.0K J 1/10W R159 RK73GB2A472J CHIP R 4.7K J 1/10W R161-164 RK73FB2B361J CHIP R 360 J 1/8W R165-168 RK73GB2A223J CHIP R 22K J 1/10W R169-172 ∗ RK73EB2E181J CHIP R 180 J 1/4W R200 RK73GB2A101J CHIP R 100 J 1/10W R201 RK73GB2A103J CHIP R 10K J 1/10W R202 RK73GB2A822J CHIP R 8.2K J 1/10W R203 RK73GB2A473J CHIP R 47K J 1/10W R204 ∗ RK73GB2A152J CHIP R 1.5K J 1/10W R205-208 RK73GB2A223J CHIP R 22K J 1/10W R210 RD14BB2C102J RD 1.0K J 1/6W R211 RK73GB2A223J CHIP R 22K J 1/10W R212 RD14BB2C102J RD 1.0K J 1/6W R213 RK73GB2A223J CHIP R 22K J 1/10W R214-216 RK73GB2A222J CHIP R 2.2K J 1/10W E2,Z1,Z2 R217 RK73GB2A102J CHIP R 1.0K J 1/10W E2,Z1,Z2 R218 RK73GB2A472J CHIP R 4.7K J 1/10W E2,Z1,Z2 R220,221 RK73GB2A104J CHIP R 100K J 1/10W R222-224 RK73GB2A222J CHIP R 2.2K J 1/10W R230 RK73GB2A472J CHIP R 4.7K J 1/10W R231 RK73GB2A473J CHIP R 47K J 1/10W R233 RK73EB2E471J CHIP R 470 J 1/4W R234 RK73EB2E102J CHIP R 1.0K J 1/4W R235 RK73EB2E472J CHIP R 4.7K J 1/4W R236 RK73EB2E471J CHIP R 470 J 1/4W R237,238 RK73EB2E102J CHIP R 1.0K J 1/4W R240 RK73EB2E102J CHIP R 1.0K J 1/4W R243 RK73GB2A473J CHIP R 47K J 1/10W D1 S2V20∗A DIODE D2 1GWJ43 DIODE D3 MA4056(N)-M ZENER DIODE D4 HZS9A2L ZENER DIODE D4 MA4082(N)-L ZENER DIODE D5 MA4110-L ZENER DIODE D7 MA4056-M ZENER DIODE M1,E2,Z1 D7 MA4056-M ZENER DIODE Z2 D8 HZS5B1 ZENER DIODE E2,Z1,Z2 D8 MA4047-M ZENER DIODE E2,Z1,Z2 D11,12 AM01Z DIODE D11,12 DSM1SD2 DIODE D11,12 ERA15-01 DIODE Z1,Z2 D11,12 ERA15-02 DIODE D14 AM01Z DIODE D14 DSM1SD2 DIODE D14 ERA15-01 DIODE Z1,Z2 D14 ERA15-02 DIODE D15 1SS133 DIODE D16 MA4056(N)-M ZENER DIODE D17 HZS6C2L ZENER DIODE D17 MA4062(N)-M ZENER DIODE D18 1SS133 DIODE D22-24 HZS6C1 ZENER DIODE D22-24 MA4062-L ZENER DIODE www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 PARTS LIST 24 Ref.No. Parts No. Description A d d A d d N e w Dest inati on Ref.No. Parts No. Description A d d A d d N e w Dest inati on ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. K: KDC-519 K1: KDC-5019 M1: KDC-8020 E2: KDC-7021Y Z1: KDC-7021 Z2: KDC-B7021 indicates safety critical components. D25,26 RD6.8M (B2) ZENER DIODE D27,28 MA4068 (N)-M ZENER DIODE D29 HZS6C1 ZENER DIODE D29 MA4062-L ZENER DIODE D30-32 1SS133 DIODE D33-36 AM01Z DIODE D33-36 DSM1SD2 DIODE D33-36 ERA15-01 DIODE Z1,Z2 D33-36 ERA15-02 DIODE D38-41 AM01Z DIODE D38-41 DSM1SD2 DIODE D38-41 ERA15-01 DIODE Z1,Z2 D38-41 ERA15-02 DIODE D60 IMSA-6801 SURGE ABSORBER D60 SA-C2102-101TB SURGE ABSORBER Z1,Z2 D61-64 1SS133 DIODE IC1 ∗ UPD703033GC139 MI-COM IC IC2 TDA7407D ANALOGUE IC IC3 M5237ML IC (VOLTAGE REGULATOR) IC4 2B TA8273H ANALOGUE IC IC8 HD74HC02FP MOS-IC IC8 TC74HC02AF MOS-IC IC8 74VHC02SJ MOS-IC Z1,Z2 IC14 TDA7479D ANALOGUE IC E2,Z1,Z2 IC15 LB1930M ANALOGUE IC IC16 S-80837ANNP MOS-IC Q1 2SB1548(P) TRANSISTOR Q2 2SC4081 TRANSISTOR Q2 2SD1819A TRANSISTOR Q3 2SA1576A TRANSISTOR Q3 2SB1218A TRANSISTOR Q4 2SB1548(P) TRANSISTOR Q5 DTC144EUA DIGITAL TRANSISTOR Q5 UN5213 DIGITAL TRANSISTOR Q6,7 DTA124EUA DIGITAL TRANSISTOR Q6,7 KRA303 DIGITAL TRANSISTOR Q8 DTC144EUA DIGITAL TRANSISTOR Q8 UN5213 DIGITAL TRANSISTOR Q9 2SD2375 TRANSISTOR Q10 2SB1184 TRANSISTOR Q11 2SC4081 TRANSISTOR Q11 2SD1819A TRANSISTOR Q12 DTC144EUA DIGITAL TRANSISTOR Q12 UN5213 DIGITAL TRANSISTOR Q13 DTA124EUA DIGITAL TRANSISTOR Q13 KRA303 DIGITAL TRANSISTOR Q14 DTA123JK DIGITAL TRANSISTOR M1,E2,Z1 Q14 DTA123JK DIGITAL TRANSISTOR Z2 Q14 KRA105S DIGITAL TRANSISTOR M1,E2,Z1 Q14 KRA105S DIGITAL TRANSISTOR Z2 Q15 DTC144EUA DIGITAL TRANSISTOR Q15 UN5213 DIGITAL TRANSISTOR Q24 DTC114YUA DIGITAL TRANSISTOR K,K1,M1 Q24 UN5214 DIGITAL TRANSISTOR K,K1,M1 Q25,26 2SB1277 (Q,R) TRANSISTOR K,K1,M1 Q26 2SB1277 (Q,R) TRANSISTOR E2,Z1,Z2 Q27 2SA1576A TRANSISTOR Q27 2SB1218A TRANSISTOR Q28 DTA124EUA DIGITAL TRANSISTOR Q28 KRA303 DIGITAL TRANSISTOR Q29 DTC114YUA DIGITAL TRANSISTOR Q29 UN5214 DIGITAL TRANSISTOR Q30,31 2SC4081 TRANSISTOR Q30,31 2SD1819A TRANSISTOR Q32,33 DTA124EUA DIGITAL TRANSISTOR Q32,33 KRA303 DIGITAL TRANSISTOR Q35 DTC124EUA DIGITAL TRANSISTOR Q35 UN5212 DIGITAL TRANSISTOR Q36 2SC4081 TRANSISTOR Q36 2SD1819A TRANSISTOR Q37-40 DTC143TUA DIGITAL TRANSISTOR Q37-40 KRC410 DIGITAL TRANSISTOR Q43 DTC124EUA DIGITAL TRANSISTOR Q43 UN5212 DIGITAL TRANSISTOR Q44 2SB1277(Q,R) TRANSISTOR Q45 DTC124EUA DIGITAL TRANSISTOR Q45 UN5212 DIGITAL TRANSISTOR Q46 2SB1277(Q,R) TRANSISTOR Q50 DTC144EUA DIGITAL TRANSISTOR Q50 UN5213 DIGITAL TRANSISTOR Q51 2SA1576A TRANSISTOR Q51 2SB1218A TRANSISTOR Q52 2SC4081 TRANSISTOR E2,Z1,Z2 Q52 2SD1819A TRANSISTOR E2,Z1,Z2 Q53 DTC144EUA DIGITAL TRANSISTOR Q53 UN5213 DIGITAL TRANSISTOR TH1 PTH9C42BD471Q POSITIVE RESISTOR A1 X86-3240-11 TUNER UNIT K,K1,M1 A1 X86-3242-70 TUNER UNIT E2,Z1,Z2 A1 X86-3342-71 TUNER UNIT Z1,Z2 ELECTRIC UNIT (X25-XXXX-XX) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 25 FM Section Frequency Range......................... 87.9MHz - 107.9MHz Frequency Step ............................ 200kHz Channel Space Selection ............. 50kHz/200kHz Usable Sensitivity (S/N:30dB) ...... 9.3dBf (0.8µV/75Ω) Quieting Sensitivity (S/N:50dB) .... 15.2dBf (1.6µV/75Ω) Frequency Response (±3.0dB) .... 30Hz - 15kHz S/N Ratio ...................................... 70dB (MONO) Selectivity ..................................... 80dB (±400kHz) Stereo Separation ........................ 40dB (1kHz) AM Section Frequency Range......................... 530kHz - 1700kHz Frequency Step ............................ 10kHz Channel Space Selection ............. 9kHz/10kHz Usable Sensitivity (S/N:20dB) ...... 28dBµ (25µV) CD Section Laser Diode .................................. GaAlAs (λ=780nm) Digital Filter (D/A) ......................... 8 Times Over Sampling D/A Converter .............................. 1 Bit Spindle Speed .............................. 500 - 200rpm (CLV) Wow & Flutter............................... Below Measurable Limit Frequency Response ................... 10Hz - 20kHz (±1dB) Total Harmonic Distortion............. 0.01% (1kHz) S/N Ratio ...................................... 105dB (1kHz) Dynamic Range............................ 93dB Channel Separation ..................... 85dB AMPLIFIER Section Preout Level/Load ........................ 1800mV/10kΩ (CD/CD-CH) (Unbalanced) Preout Impedance ........................ 600Ω Maximum Power .......................... 50W×4 Full Bandwidth Power .................. 22W×4 (at less than 1%THD) TONE Section Bass ............................................. 100Hz ±10dB Middle........................................... 1kHz ±10dB Treble ........................................... 10kHz ±10dB General Operating Voltage ........................ 14.4V (11V - 16V allowable) Current Consumption ................... 10A Installation Size (W) ..................... 182(mm) 7-3/16(in.) (H) ..................... 53(mm) 2-1/16(in.) (D) ..................... 162(mm) 6-3/8 (in.) Weight .......................................... 1.4kg (3.0lbs.) G KDC-5019/519 SPECIFICATIONS FM Section Frequency Range......................... 87.9MHz - 107.9MHz Frequency Step ............................ 200kHz Frequency Range......................... 87.5MHz - 108.0MHz Frequency Step ............................ 50kHz Channel Space Selection ............. 50kHz/200kHz Usable Sensitivity (S/N:30dB) ...... 9.3dBf (0.8µV/75Ω) Quieting Sensitivity (S/N:50dB) .... 15.2dBf (1.6µV/75Ω) Frequency Response (±3.0dB) .... 30Hz - 15kHz S/N Ratio ...................................... 70dB (MONO) Selectivity ..................................... 80dB (±400kHz) Stereo Separation ........................ 40dB (1kHz) MW (AM) Section Frequency Range......................... 531kHz - 1611kHz Frequency Step ............................ 9kHz Frequency Range......................... 530kHz - 1700kHz Frequency Step ............................ 10kHz Channel Space Selection ............. 9kHz/10kHz Usable Sensitivity (S/N:20dB) ...... 28dBµ (25µV) CD Section Laser Diode .................................. GaAlAs (λ=780nm) Digital Filter (D/A) ......................... 8 Times Over Sampling D/A Converter .............................. 1 Bit Spindle Speed .............................. 500 - 200rpm (CLV) Wow & Flutter............................... Below Measurable Limit Frequency Response ................... 10Hz - 20kHz (±1dB) Total Harmonic Distortion............. 0.01% (1kHz) S/N Ratio ...................................... 105dB (1kHz) Dynamic Range............................ 93dB Channel Separation ..................... 85dB AMPLIFIER Section Preout Level/Load ........................ 1800mV/10kΩ (CD/CD-CH) (Unbalanced) Preout Impedance ........................ 600Ω Maximum Power .......................... 50W×4 Full Bandwidth Power .................. 22W×4 (at less than 1%THD) TONE Section Bass ............................................. 100Hz ±10dB Middle........................................... 1kHz ±10dB Treble ........................................... 10kHz ±10dB General Operating Voltage ........................ 14.4V (11V - 16V allowable) Current Consumption ................... 10A Installation Size (W) ..................... 182(mm) (H) ..................... 53(mm) (D) ..................... 162(mm) Weight .......................................... 1.4kg G KDC-8020 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KDC-5019/519/7021/7021Y/8020/B7021 26 SPECIFICATIONS KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. FM Section Frequency Range......................... 87.5MHz - 108.0MHz Frequency Step ............................ 50kHz Usable Sensitivity (S/N:26dB) ...... 0.7µV/75Ω Quieting Sensitivity (S/N:46dB) .... 1.6µV/75Ω Frequency Response (±3.0dB) .... 30Hz - 15kHz S/N Ratio ...................................... 65dB (MONO) Selectivity (DIN) ........................... 80dB (±400kHz) Stereo Separation ........................ 35dB (1kHz) MW (AM) Section Frequency Range......................... 531kHz - 1611kHz Frequency Step ............................ 9kHz Usable Sensitivity (S/N:20dB) ...... 25µV LW Section Frequency Range......................... 153kHz - 281kHz Usable Sensitivity (S/N:20dB) ...... 45µV CD Section Laser Diode .................................. GaAlAs (λ=780nm) Digital Filter (D/A) ......................... 8 Times Over Sampling D/A Converter .............................. 1 Bit Spindle Speed .............................. 500 - 200rpm (CLV) Wow & Flutter............................... Below Measurable Limit Frequency Response ................... 10Hz - 20kHz (±1dB) Total Harmonic Distortion............. 0.01% (1kHz) S/N Ratio ...................................... 105dB (1kHz) Dynamic Range............................ 93dB Channel Separation ..................... 85dB G KDC-7021/Y,B7021 AMPLIFIER Section Preout Level/Load ........................ 1800mV/10kΩ (CD/CD-CH) (Unbalanced) Preout Impedance ........................ 600Ω Maximum Power .......................... 50W×4 Power DIN45324, +B=14.4V ........ 30W×4 TONE Section Bass ............................................. 100Hz ±10dB Middle........................................... 1kHz ±10dB Treble ........................................... 10kHz ±10dB General Operating Voltage ........................ 14.4V (11V - 16V allowable) Current Consumption ................... 10A Installation Size (W) ..................... 182mm (H) ...................... 53mm (D) ...................... 161mm Weight .......................................... 1.4kg KENWOOD ELECTRONICS ITALIA S.p.A. Via G. Sirtori 7/9, 20129 Milano, Italy KENWOOD IBÉRICA S.A. Bolivia, 239-08020 Barcelona, Spain KENWOOD ELECTRONICS AUSTRALIA PTY. LTD. (A.C.N. 001 499 074) 16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113, Australia KENWOOD ELECTRONICS (HONG KONG) LTD. Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD ELECTRONICS GULF FZE P.O. Box 61318, Jebel Ali, Dubai, U.A.E. KENWOOD ELECTRONICS (THAILAND) CO., LTD. 2019 New Pechburi Road, Bangkapi, Huaykwang, Bangkok, 10320 Thailand KENWOOD ELECTRONICS SINGAPORE PTE. LTD. 1 Genting Lane, #07-00, Kenwood Building, Singapore 349544 KENWOOD ELECTRONICS (MALAYSIA) SDN BHD #4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1, 46300 Petaling Jaya, Selangor Darul Ehsan, Malaysia KENWOOD CORPORATION 14-6, Dogenzaka 1-chome, Shibuya-ku, Tokyo 150-8501, Japan KENWOOD SERVICE CORPORATION P.O. Box 22745, 2201 East Dominguez Street, Long Beach, CA90801-5745, U.S.A. KENWOOD ELECTRONICS CANADA INC. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 KENWOOD ELECTRONICS LATIN AMERICA S.A. P.O. Box 55-2791 Paitilla, Plaza Credicorp Bank Panama, Piso 9, Oficina 901, Calle 50, Panama, Republic of Panama KENWOOD ELECTRONICS BRASIL LTDA. Av. Moema, 170-17˚, Andar-Cobertura “B”, Ed. Maximum Service Center, 04077-020 Moema, São Paulo-SP-Brasil KENWOOD ELECTRONICS UK LIMITED Kenwood House, Dwight Road, Watford, Herts, WD1 8EB United Kingdom KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker-Str. 15, 63150 Heusenstamm, Germany KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS BELGIUM N.V. Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299