马兰士MARANTZ MR2020U音响电路图

分类：电子电工 日期： 点击：0
马兰士MARANTZ MR2020U音响电路图-0 马兰士MARANTZ MR2020U音响电路图-1 马兰士MARANTZ MR2020U音响电路图-2 马兰士MARANTZ MR2020U音响电路图-3 马兰士MARANTZ MR2020U音响电路图-4 马兰士MARANTZ MR2020U音响电路图-5 马兰士MARANTZ MR2020U音响电路图-6 马兰士MARANTZ MR2020U音响电路图-7 马兰士MARANTZ MR2020U音响电路图-8 马兰士MARANTZ MR2020U音响电路图-9

system MR2020 / Layla 4822 725 51183 First Issue 1999.01 298J855010 MIT Printed in Japan Service Manual R Please use this service manual with referring to the user guide ( D.F.U. ) without fail. 74 MR2020 /2G (Layla) MR2020 F,K,KK,U CD/Tuner System TABLE OF CONTENTS SECTION PAGE MR2021 (CD/Tuner Amplifier) 1 TECHNICAL SPECIFICATIONS ............................................................................................................. 1-1 2-1 HOW TO DISASSEMBLE ....................................................................................................................... 2-1 2-2 REPAIR INTRODUCTION ...................................................................................................................... 2-6 2-3 EXPLANATION OF CIRCUITS ............................................................................................................... 2-6 3 SERVICE MODE ..................................................................................................................................... 3-1 4-1 BLOCK DIAGRAM .................................................................................................................................. 4-1 4-2 AM STEREO ADJ.(F ONLY) ................................................................................................................... 4-1 4-3 MICROPROCESSOR DATA ................................................................................................................... 4-1 5 WIRING DIAGRAM ................................................................................................................................. 5-1 6 SCHEMATIC DIAGRAM AND PARTS LOCATION ................................................................................. 6-1 7B TUNER BOARD ECO5 .........................................................................................................................7B-1 7D TUNER 95 BOARD .............................................................................................................................. 7D-1 8 CD NAMI 8 BOARD ................................................................................................................................. 8-1 9 EXPLODED VIEW AND PARTS LIST ..................................................................................................... 9-1 10 ELECTRICAL PARTS LIST ................................................................................................................... 10-1 LS2021 ( Speaker System ) 1 EXPLODED VIEW AND PARTS LIST .................................................................................................... 1-1 CAUTION The System MR2020 (Layla) combines MR2021 (CD/Tuner Amplifier) with LS2021 (Speaker System). MARANTZ DESIGN AND SERVICE Using superior design and selected high grade components, MARANTZ company has created the ultimate in stereo sound. Only original MARANTZ parts can insure that your MARANTZ product will continue to perform to the specifications for which it is famous. Parts for your MARANTZ equipment are generally available to our National Marantz Subsidiary or Agent. ORDERING PARTS : Parts can be ordered either by mail or by Fax.. In both cases, the correct part number has to be specified. The following information must be supplied to eliminate delays in processing your order : 1. Complete address 2. Complete part numbers and quantities required 3. Description of parts 4. Model number for which part is required 5. Way of shipment 6. Signature : any order form or Fax. must be signed, otherwise such part order will be considered as null and void. MARANTZ AMERICA, INC. 440 MEDINAH ROAD ROSELLE, ILLINOIS 60172 USA PHONE : 630 - 307 - 3100 FAX : 630 - 307 - 2687 LENBROOK INDUSTRIES LIMITED 633 GRANITE COURT, PICKERING, ONTARIO L1W 3K1 CANADA PHONE : 905 - 831 - 6333 FAX : 905 - 831 - 6936 MARANTZ EUROPE B. V. P.O.BOX 80002 BUILDING SFF2 5600 JB EINDHOVEN THE NETHERLANDS PHONE : +31 - 40 - 2732241 FAX : +31 - 40 - 2735578 SUPERSCOPE TECHNOLOGIES, INC. MARANTZ PROFESSIONAL PRODUCTS 2640 WHITE OAK CIRCLE, SUITE A AURORA, ILLINOIS 60504 USA PHONE : 630 - 820 - 4800 FAX : 630 - 820 - 8103 TC ELECTRONICS CANADA LTD. 540 FIRING AVE. BAIE D’URFÉ, QUEBEC H9X 3T2 CANADA PHONE : 514 - 457 - 4044 FAX : 514 - 457 - 5524 MK ENTERPRISES LTD. 2F SHINHAN BLDG., 247-17 SEOKYO-DONG MAPO-KU, SEOUL KOREA PHONE : +82 - 2 - 323 - 2155 FAX : +31 - 2 - 323 - 2154 MARANTZ BRAZIL CAIXA POSTAL 21462 CEP 04698-970 SAO PAULO, SP, BRAZIL PHONE : 0800 - 123123 FAX : +55 11 534. 8988 PAl- YUING CO., LTD. 6 TH FL NO, 148 SUNG KIANG ROAD, TAIPEI, 10429, TAIWAN R.O.C. PHONE : +886 (2) 5221304 FAX : +886 (2) 5630415 MRZ STANDARD CO., LTD. 746 - 754 MAHACHAI RD., WANGBURAPAPIROM, PHRANAKORN, BANGKOK, 10200 THAILAND PHONE : +66 - 2 - 222 - 9181 FAX : +66 - 2 - 224 - 6795 WO KEE HONG ELECTRONICS SDN. BHD. NO. 102 JALAN SS 21/35, DAMANSARA UTAMA, 47400 PETALING JAYA SELANGOR DARUL EHSAN, MALAYSIA PHONE : +60 3 - 7184666 FAX : +60 3 - 7173828 MARANTZ JAPAN, INC. 35- I , 7- CHOME, SAGAMIONO SAGAMIHARA - SHI, KANAGAWA JAPAN 228-8505 PHONE : +81 42 748 1013 FAX : +81 42 741 9190 FORWARD MARKETING (S) PTE. LTD. 23, LORONG 8, TOA PAYOH, SINGAPORE 319257. PHONE : +65 2583640 FAX : +65 3564047 SHOCK, FIRE HAZARD SERVICE TEST : CAUTION : After servicing this appliance and prior to returning to customer, measure the resistance between either primary AC cord connector pins ( with unit NOT connected to AC mains and its Power switch ON ), and the face or Front Panel of product and controls and chassis bottom. Any resistance measurement less than 1 Megohms should cause unit to be repaired or corrected before AC power is applied, and verified before it is return to the user/customer. Ref. UL Standard N0. 1492(DR700) and No. 813(CDR630). USA CANADA EUROPE / TRADING USA CANADA BRAZIL (Discagem Direta Gratuita) TAIWAN THAILAND MALAYSIA In case of difficulties, do not hesitate to contact the Technical Department at above mentioned address. JAPAN Technical SINGAPORE 98110MIT SCAN AUDIO PTY. LTD. 52 CROWN STREET, RICHMOND 3121 VICTORIA AUSTRALIA PHONE : +61 - 3 - 9429 - 2199 FAX : +61 - 3 - 9429 - 9309 AUSTRALIA / NEW ZEALAND KOREA 1. TECHNICAL SPECIFICATIONS FM Tuner Frequency range ............................................................................................................................................ 87.5 ~ 108.0 MHz F only .................................................................................................................................... 76.0~ 90.0 MHz Sensitivity ........................................................................................................................................................ 21.2 dBf / 3.2 µV S/N (Mono/Stereo) ..................................................................................................................................................... 75 / 43 dB F only .......................................................................................................................................... 70 / 50 dB THD (Mono/Stereo) ...................................................................................................................................................1.5 / 1.5 % MW Tuner Frequency range ............................................................................................................................................... 531 ~ 1602 kHz U only ................................................................................................................................... 530 ~ 1700 kHz Sensitivity ................................................................................................................................................................. 500 µV / m /02, F only ............................................................................................................................................... 400 µV / m S/N .................................................................................................................................................................................... 50 dB LW Tuner Frequency range ................................................................................................................................................. 153 ~ 279 kHz Sensitivity ............................................................................................................................................................... 1800 µV / m Amplifier Music power ................................................................................................................................................... 25 W + 25 W (4Ω) Input sensitivity (AUX) ....................................................................................................................................... 310 mV / 47 kΩ U only ............................................................................................................................ 250 mV / 47 kΩ S/N (AUX) ......................................................................................................................................................................... 85 dB CD Player Channels ................................................................................................................................................................. 2 channels Frequency response ............................................................................................................................... 20 ~ 20,000 Hz ± 3 dB S/N ....................................................................................................................................................................82 dB (1000 Hz) THD ................................................................................................................................................................ 0.04 % (1000 Hz) Output level ...................................................................................................................................................................2 V RMS General Power supply /02 version.................................................................................................................................................. AC 230 V, 50 Hz F version ......................................................................................................................................... AC 100 V, 50Hz / 60 Hz K version ............................................................................................................................. AC 110V / 220 V, 50Hz / 60 Hz KK version .................................................................................................................................................. AC 220 V, 60 Hz U version .................................................................................................................................................... AC 120 V, 60 Hz Power consumption ............................................................................................................................................................25 W Power failure backup time ...............................................................................................................................APPROX. 15 min. Dimensions ................................................................................................................................ 450(W) x 104(H) x 308(D) mm Weight ............................................................................................................................................................................... 5.8 kg Table top Speaker LS2021 Speaker Mid-bass ............................................................................................................................................................................4” Dome tweeter..................................................................................................................................................................3/4” Input power Rated ................................................................................................................................................................... 25 W (6Ω) Max. ..................................................................................................................................................................... 40 W (6Ω) Frequency response ............................................................................................................................... 80 ~ 20,000 Hz ± 6 dB Dimensions ................................................................................................................................ 190(W) x 200(H) x 100(D) mm Weight ............................................................................................................................................................................... 1.5 kg Design and specifications are subject to change without notice. 1-1 2-1. HOW TO DISASSEMBLE MR2020 1. Take the bottom case (001G) apart (1) Turn MR2020 upside down by the jig (Refer to fig.1-3). Take care that the top cover will not damaged, especially the 4 levers. If you don't have the jig, you prepare to put some magazine or telephone guide under the MR2020 (The height is over 3cm books). Fig.1 A jig for MR2020 (2) Remove 15 screws as shown in fig.4. Fig.2 The jig on MR2020 Fig.3 Turning over the MR2020 2-1 Fig.4 Position of 15 screws (3) While lifting the bottom case, remove the rear panel as shown in fig.5-6. Fig.5 Lifting the bottom case (4) Remove the mains code bush as shown in fig.7. Fig.6 Removing the rear panel 2-2 Fig.7 Removing the mains code bush (5) Lift up the bottom case, remove the put the one with turning to front side (Refer to fig.8). Remark for reassemble When you fit the bottom case, remove the lid of the bottom case (Refer to fig.9) and confirm the arrangement of lead lines for transformer.(Refer to fig.10). Fig.9 Removing the lid of the bottom case Fig.10 Arrangement of lead lines 2-3 Fig.8 Taking the bottom case apart 2. Take the top panel (001D) apart (1) Turn MR2020 upside down by the jig. (Refer to fig.1-3) Take care that the top cover will not damaged, especially the 4 levers. If you don't have the jig, you prepare to put some magazine or telephone guide under the MR2020. (The height is over 3cm books) (2) Push the rear panel while keeping hold the top cover (see fig.11 below). The top cover will move 5mm. (fig.12-13) Now, 4 screws on the top cover will become accessible. (fig.14) Take out these screws. (M3 type screw) Fig.11 Pushing the rear panel Fig.13 Pushed the rear panel Fig.12 Before pushing the rear panel Fig.14 Positions of 4 screws 2-4 (3) Turn the MR2020 to its normal operating position. (4) Open the top cover of MR2020 by hand. (5) Take out the 2 screws (M2 type screw) on the top (see fig.15). (6) The upper part and lower part of the top cover are connected to each other with adhesive tape. Separate these parts by pushing the transparent upper part in the middle (on CD shaped part) from the lower part, while holding the lower part. (7) The upper part and lower part of the top cover were separated (See fig.16-17). Fig.16 The upper part of top cover (the reverse side) Fig.17 The lower part of top cover and the others 2-5 Fig.15 Positions of 2 screws on the top 2-2. REPAIR INTRODUCTION PREPARATION FOR CD BLOCK 1. Set a disc for repair into product. 2. Turn the product upside down on the jig (Parts No.*MR2021JIG). Take care that the top cover will not damaged, especially the 4 levers. (Refer to "How to disassemble MD2020") 3. For the top panel will not open while repairing, remove the connecting wires of panel motor from the connector (J812). 4. Repair and operate it on the upside down position of the product. PREPARATION FOR MAIN AMPLIFIER PCB (P704) 1. Main amplifier is BTL output. 2. For removing the main amplifier PCB (P704) from the product, remove the wire (W802) from the terminal (WU02) of microprocessor PCB (PU04). Connect another wire with terminal (WU02) and GND as chassis instead of the wire (W802). REMARK Remove the bottom case from the product, Do not output signals of over 1W from both channels more than 10 minutes continuously. 2-3. EXPLANATION OF CIRCUITS FAN OPERATION The voltage added to the diode (D852) is depended on the resistance of the thermistor (R857) and resistors (R855,R858). When the temperature of the heat sink goes up, the resistance of the thermisor (R857) decreases, and the voltage added to the diode (D852) increases. 1. When the temperature of the heat sink is over 70 degrees Celsius, then D852 is on, through R852, Q851 is on, and the fan starts to revolve. 2. When the temperature of the heat sink is approx. 100 degrees Celsius or more, through R853, Q853 is on, and the product is STAND-BY status. But, if the fan revolve normally, the temperature of the heat sink will not be over 100 degrees Celsius and not be STAND- BY status. Therefore, the procedure of the over heat protection circuit check is as follows; (1) Connect the test point (J814) with a resistor of 680 ohm. (2) If the product is STAND-BY status, this circuit is normal. (3) Remove the resistor of 680 ohm from the test point (J814). FAN OPERATION CHECK Keep outputting 2.5W from both channels of the product. 2-6 When the bottom case is closing. If the fan revolving starts within 10 minutes, the function is correct working. Otherwise keep outputting 1W from both channels of the product when the bottom case is opening. If the fan revolving starts within 5 minutes, the function is correct working. REMARK Do not output over 1W when the bottom case is open. VCC CONTROL The regulation of primary voltage is not so higher intentionally for decreasing the no-load loss. Therefore, this circuit is used for the product to keep the voltage tolerance of the power IC. This circuit do not work when the output is from 0 to approx. 1Vrms. Then VCC is supplied from D709 only. When the output is more than 1Vrms, through D701- D704, R722, D706, and Q703 is on, current is supplied from Q702. When the output is over approx. 3Vrms, D709 is off, and VCC is supplied from Q702 only. SPEAKER PROTECTION 1. When either terminal of BTL outputs connect with GND (chassis) by mistake, the speaker protection circuit will work as follows. through R707-R710, Q704 or Q705 is on, and Q706 is on. Then #5Pin for Q701 is 0V, power IC (Q701) will be in power off. Therefore, the product will be STAND-BY status. 2. When the VCC CONTROL circuit is working correctly, maximum current of R825 is 1A, and voltage between R825 load is maximum 0.33V. When both terminals of BTL outputs are shorted on outputting over 0.25W, R825 is supplied over 2A, Q807 and Q803 is on, and the product will be STAND-BY status. CD 5V ON/OFF CONTROL The voltage for CD (CD 5V) is supplied from QX04 when the following conditions are satisfied fully. (for noise and laser protection) 1. Setting a disc on the product, and QU08 is on. 2. Closing top panel, and #78Pin for QU10 is 0V. 3. The product is in CD mode. MUTE CONTROL Mute signals output from microprocessor (QU10) are "MUTE (Pin No.37)", "MUTE2 (Pin No.7)", and "DSC MUTE (Pin No.5)". Fig.1 is workable output terminals by each mute signals, Fig.2 is the status of each mute. 2-7 Fig.1 Q701(SPK) QN01-QN04 (PHONE) QX05,QX06 (SUB WOOFER) QX07,QX08 (LINE OUT) QE01 MUTE YES YES YES NO NO MUTE2 NO NO DSC MUTE NO NO NO NO YES NO YES NO TOP PANEL OPEN SENSOR 1. The pulse (T=84msec, Duty 50%) is always added to LED (QU15), from #30Pin of QU10, through RF28 and QU22. 2. Cover the sensor with your fingers, the collector voltage of QU01 goes up over 0.7VP-P. and through RU71 and QU09, the pulse of 5VP-P inputs to #29Pin of QU10. Then the top panel will open. 3. Not needing to cover the sensor with your fingers, QU01 receives the light of LED reflected by lens oneself. Therefore, the collector of QU01 adds the reverse pulse through RF29, QU26 and RF32, for reduced incorrect working. So, the voltage of residual pulse for the collector of QU01 is suppressed to 0.1VP-P. REMARK When the sensor receives sunlight or a strong light as incandescent, top panel might open. POPS NOISE KILLER RX72, CX70 and QX70 are the circuit to delay power supply for approx. 2 seconds. Therefore, this circuit prevents pops noise generation when power switch is on or off. SUB WOOFER Sub woofer output is composed a low pass filter of cut-off frequency 150Hz octave 12dB. It is output 2V for AUX L,R input 60Hz, 200mV (volume is maximum). REMARK Sub woofer output level is depended on volume control. 2-8 Fig.2 POWER ON/OFF CD MODE STOP OR TRACK JUMP MUTE BUTTON ON MODE CHANGE VOLUME MINIMUM MUTE YES YES YES YES YES MUTE2 YES YES NO YES NO DSC MUTE NO YES NO NO NO 3 SERVICE MODE 1. How to set the service mode (1) While holding the CLOCK and CLEAR buttons together, put the mains plug to mains outlet. (2) FL check mode will start. (3) While in FL check mode, each time the FUNCTION button pressed (within 2 seconds), the mode changes in the following order. TR FREQ (Tracking point frequency memory mode) ¦ CD TEST (CD test mode) ¦ FL CHK (FL check mode) ¦ TR FREQ (Tracking point frequency memory mode) 2. FL CHECK MODE FL check mode will continue until change other mode. 3. TRACKING POINT FREQUENCY MEMORY MODE This mode is not available for repair(This is for check in factory.). If you set in this mode, some frequencies will register in each preset memory. REMARK User programmed frequencies will be deleted. While in Tracking point frequency memory mode, press the MEMO button. Press the CLEAR and the DISPLAY buttons together. The display shows “CLEAR” 2 seconds. Then all memories will be clear. 4. CD TEST MODE (1) Press the “+” button, then the sledge move to the outside. Press the “-” button then the sledge move to the inside. Press the CLEAR button while the sledge is moving, then the sledge stop. (2) Press the MEMO button, then the laser pick up unit is giving out the beam. Press the MEMO button again then the laser pick up unit stop beam out. All operations are available without the Disc. (3) While in CD test mode, CD play is available in opening the top panel. (4) If any ERROR is happened, the display shows “CD ERRX”. (X is a ERROR code.) The ERROR message will not be clear until pressing STOP or POWER buttons. Error Code Description 1 The sledge switch not turn on. 2 The sledge switch not turn off. 3 The laser pick up unit not focus. 4 The tracking is not fixed. 5 The spindle motor not locked. 5. How to stop the service mode Press the POWER button. Then product will be in POWER OFF (STAND-BY). REMARK The microprocessor will not be clear by this operation. (Refer to "3. TRACKING POINT FREQUENCY MEMORY MODE") 3-1 4-1 4-1 4-1 BLOCK DIAGRAM DECODER/ U-COM SAA7372 SERVO DRIVER TDA7073AT HF AMP TDA1300T CD UNIT CD94V5B1 SLED MOTOR SPINDLE MOTOR PICK UP FOCUS PRE AMP TE6321 H.P AMP NJM4556 E.Q BUFFER NJM4558 POWER AMP AN7125 MAIN U-COM F1(FL) +8V,+5V SUPPLY SERVO DRIVER TDA7073AT TRACK TUNER 95 ECO 5 RDS /02 ONLY FL DRIVER BUFFER NJM4558 TEMP DETECT M FL PANEL DRIVE IC PQ30RV2 PQ05RF2 7808 PQ12RF2 2SA1307 +5V(CD) +5V(U-COM) +9.3V(POWER AMP) +8V(CD) +12V(PANEL MOTOR) -26V(FL) F2(FL) +10V +21V +20V AUX IN LINE OUT SUB W.F DISC SENSOR(CD) PANEL OPN/CLS ON TOP KEY BOTTOM KEY DISPLAY PANEL PHOTO SENSOR R.C FAN MOTOR H.P(SW) S.P ANT. A/D INPUT RC5 U-COM U-COM U-COM +5V I2C DAC ANALOG CD BOARD NAMI 8 AM STEREO F ONLY Pin No. Pin Name Signal Name I/O Active Slow Function 1 P10 (INT0) _POW_DWN INT L POWER DOWN 2 P11 (INT1) _STANDBY OUT L L POWER STANDBY 3 P12 (INT2) SDA IN/OUT - IIC SDA(for RDS,DSC) 4 P13 (DVO) SCL OUT H L IIC SCL(for RDS,DSC) 5 P14 DSC_MUTE OUT L L DSC MUTE 6 P15 _CD_STANDBY OUT L L CD STANDBY 7 P16 _MUTE2 OUT L L LINE MUTE 8 P17 * IN - - N.C 9 TEST - IN - - GND 10 P21 (XTIN) 32.768kHz IN - - SUB X-TAL 11 P22 (XTOUT) 32.768kHz OUT - - SUB X-TAL 12 RESET _RESET IN L - RESET 13 XIN 8.0MHz IN - - X-TAL 14 XOUT 8.0MHz OUT - - X-TAL 15 VSS - GND - - GND 16 P20 (INT5) _HOLD IN L - HOLD IN 17 P30 (INT3) _RCIN INT - RC-5 BUS IN 18 P31 _RCOUT OUT L L RC-5 BUS OUT 19 P32 (SCK) TUNE_CLK OUT H L TUNER CLK 20 P33 (SI) _TUNE_WE OUT L - TUNER WRITE ENABLE 21 P34 (SO) TUNE_SDA IN/OUT H L TUNER SDA 22 P35 (HSCK) TUNER_ST_M ON IN H L TUNER STEREO/MONO 23 P36 CD7_RESET OUT L L CD7 RESET 24 P37 (HSO) DISC_IN IN H - DISC IN SENSOR 25 P00 SILD OUT L L CD7 CONTROL 26 P01 RAB OUT H L CD7 CONTROL 27 P02 SCL OUT H L CD7 CONTROL 28 P03 SDA IN/OUT H L CD7 CONTROL 29 P04 P_SEN_IN IN H - PANEL SENSOR IN 30 P05 P_SEN_OUT OUT H L PANEL SENSOR OUT 31 P06 P_MOTOR_P OUT H L PANEL MOTOR + 32 P07 P_MOTOR_N OUT H L PANRL MOTOR - 33 VDD +5V +5VS - - VDD 34 P60 (G15) * IN - - N.C 35 P61 (G14) * IN - - N.C 36 P62 (G13) AMPON OUT H L AMP POWER ON 37 P63 (G12) MUTE OUT H L MUTE 38 P64 (G11) _RDS_ON OUT H L RDS_POWER 39 P65 (G10) 11G OUT H - DIGIT OUT 40 P66 (G9) 10G OUT H - DIGIT OUT Pin No. Pin Name Signal Name I/O Active Slow Function 41 P67 (G8) 9G OUT H - DIGIT OUT 42 P70 (G7) 8G OUT H - DIGIT OUT 43 P71 (G6) 7G OUT H - DIGIT OUT 44 P72 (G5) 6G OUT H - DIGIT OUT 45 P73 (G4) 5G OUT H - DIGIT OUT 46 P74 (G3) 4G OUT H - DIGIT OUT 47 P75 (G2) 3G OUT H - DIGIT OUT 48 P76 (G1) 2G OUT H - DIGIT OUT 49 P77 (G0) 1G OUT H - DIGIT OUT 50 P80 (S0) P16 OUT H - SEGMENT OUT 51 P81 (S1) P15 OUT H - SEGMENT OUT 52 P82 (S2) P14 OUT H - SEGMENT OUT 53 P83 (S3) P13 OUT H - SEGMENT OUT 54 P84 (S4) P12 OUT H - SEGMENT OUT 55 P85 (S5) P11 OUT H - SEGMENT OUT 56 P86 (S6) P10 OUT H - SEGMENT OUT 57 P87 (S7) P9 OUT H - SEGMENT OUT 58 P90 (S8) P8 OUT H - SEGMENT OUT 59 P91 (S9) P7 OUT H - SEGMENT OUT 60 P92 (S10) P6 OUT H - SEGMENT OUT 61 P93 (S11) P5 OUT H - SEGMENT OUT 62 P94 (S12) P4 OUT H - SEGMENT OUT 63 P95 (S13) P3 OUT H - SEGMENT OUT 64 P96 (S14) P2 OUT H - SEGMENT OUT 65 P97 (S15) P1 OUT H - SEGMENT OUT 66 VKK -B - - - Power Supply for FL 67 P40 (KEY0) Key0 IN H - Key0 68 P41 (KEY1) Key1 IN H - Key1 69 P42 (KEY2) Key2 IN H - Key2 70 P43 (KEY3) Key3 IN H - Key3 71 P44 (KEY4) Key4 IN H - Key4 72 P45 (KEY5) Key5 IN H - Key5 73 P46 (KEY6) Key6 IN H - Key6 74 P47 (KEY7) Key7 IN H - Key7 75 P50 (A/D) _DAVN IN L - RDS DAVAN 76 P51 (A/D) _PSWN IN L - RDS PSWN 77 P52 (A/D) _P_OPEN IN L - PANEL SW OPEN 78 P53 (A/D) _P_CLOSE IN L - PANEL SW CLOSE 79 P54 VER_SET0 IN - - 0:J 1:U10 0:U 09 1EU 80 P55 VER_SET1 IN - - 0: 0: 1: 1: :F :U :K,KK : /2 4-3 MICROPROCESSOR DATA 5-1 5-1 5. WIRING DIAGRAM NAMI 8 TUNER 95 or ECO 5 F ONLY CD94V5B1 6-1 6-1 6. SCHEMATIC DIAGRAM AND PARTS LOCATION PHONE WU09 (FROM JU01) 6-2 6-2 SPEAKER OUT /02 /02 /02 002M 6-3 6-3 P704 Q708 Q707 Q701 Q705 Q704 Q706 Q703 Q702 Q801 Q805 Q806 Q852 Q851 Q803 Q807 QD01 Q853 PX04 QX70 QN03 QN01 QH01 QN04 QN02 QE04 QE03 QX07 QX03 QX08 QE04 QE02 QX04 QX01 QX02 QX05 QX06 QX09 P804 PH04 PX54 PS64 /02 /02 /02 CD BOARD NAMI 8 TUNER BOARD TUNER 95 or ECO5 6-4 6-4 PU04 QU12 QU13 QU14 QU15 QU04 QU03 QU08 QU22 QU26 QU09 QU28 QU27 QU25 QU24 QU23 QU10 QU21 QU16 QU17 1U28 QU06 QU07 QU05 QU18 QU19 QU20 QF51 PS04 PS14 PS54 6-5 6-5 AM STEREO [F] VERSION TUNER BOARD ECO 5 From 1131 PA01 QA01 QA04 QA03 QA02 6-6 6-6 TUNER BOARD ECO5 7B-1 7B-1 BLOCK DIAGRAM 1 FM frontend AM Frontend FM Osc. FM Mixer AM Mixer AM Osc. AM IF IF1 IF2 FM Det. AM Det. 2 3 39 37 33 FM RADIO IC TEA 5757T TUNER BOARD ECO 5 systems 1101 (1102) LF filter 10 18 11 15 14 24 left left buffer ampl. RDS (MPX) RDS (MPX) right right stereo VCO 41 40 36 19 32 44 25 Stereo Decoder 1124 Vcc1 Vdd Vcc2 AFC AFC + AFC - 4 4 AGC Pre- scaler Multi- plexer Charge pump CONTROL AM-FRAME AERIAL Reference Oscillator 1126 1 4 1 4 6 1 stereo 27 28 29 clock data enable clock data enable Version P1 P0 MW/LW 31 30 programmable output ports AM-RF, AM-Osc. 3 5 1121 VLoop VLoop VLoop VLoop VLoop 2 6 5 43 1103 B C 450kHz 450kHz 450kHz 20 75kHz VStabA VStabB VStabB VStabA VStabB 10,7 MHz 10,7 MHz 35 9 Vcc Vdd Vcc1 7 23 VStabA VStabB 38 34 22 Vcc2 8 ECO5 sys., 240698 A AM-RF AM-Osc. FM-Osc. FM-RF Discriminator 10,7 MHz TABLE OF CONTENTS Blockdiagram ................................................................. 7B-1 Adjustmant table ........................................................... 7B-2 Component layout........................................................... 7B-3 Circuit diagram................................................................ 7B-4 Parts list ......................................................................... 7B-5 7B-2 7B-2 VARICAP ALIGNMENT FM RF FM IF VCO AM IF AM RF 3) 108MHz 87.5MHz (65.81MHz) 87.5MHz (65.81MHz) 87.5MHz (65.81MHz) 279kHz 153kHz 1602kHz 531kHz 5130 check 5122 check 5123 check 8V ±0.2V 4.3V ±0.5V (1.2V ±0.5V) 8V ±0.2V 1.1V ±0.4V 8V ±0.2V 1.1V ±0.4V 1494kHz 558kHz 560kHz 5102 1500kHz 5103 198kHz 1494kHz 558kHz 560kHz 1500kHz 198kHz 2106 5102 2106 3142 152kHz ±1kHz 1) 98MHz 5112 MAX FM 87.5 - 108MHz (65.81 - 74, 87.5 - 108MHz) LW 153 - 279kHz MW FM/MW/LW- version, 9kHz grid 531 - 1602kHz 1700kHz 530kHz 5123 check 8V ±0.2V 1.1V ±0.4V 1602kHz 531kHz 5123 check 6.9V ±0.2V 1.1V ±0.4V 108MHz 108MHz 2155 5131 MW FM/AM-version, 10kHz grid 530 - 1700kHz FM MW LW 98MHz, 1mV continuous wave 450kHz connect pin 6 of IC 7101 (AM Osc.) with short wire to ground (pin 4) Use service test program. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically. 4 1 3 4 4 A A 5119 FM 10.7MHz, 50mV continuous wave 2 F mod=1kHz ∆f=±22.5kHz 1) If sensitivity of frequency counter is too low adjust to max. channel separation (input signal: stereo left 90% + 9%, adjust output on right channel to minimum) Repeat ECO5, discr. coil, 090797 TUNER ADJUSTMENT TABLE ( ECO5 FM/MW- and FM/MW/LW - versions with AM-frame aerial ) ∆f=±15kHz VRF = 3mV C see remark 2) 220R 100nF 36 IC 7101 220R 100nF 40 IC 7101 2141 shortcircuit to block AFC 21 IC 7101 max. symmetric fo AM AFC MW C continuous wave VRF = 10mV 5111 5114 2 0 ± 2 mV DC 0 ± 3 mV DC MW 4) FM/MW/LW- and FM/MW-version ( 9kHz grid) 531 - 1602kHz B ∆f = ±30kHz VRF as low as possible max. symmetric fo MW FM/AM-version, 10kHz grid 530 - 1700kHz 3) For AM RF adjustments the original frame antenna has to be used ! 2) RC network serves for damping the IF-filter while adjusting the other one. 4) MW has to be aligned before LW. Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter FM 87.5 - 108MHz (65.81 - 74, 87.5 - 108MHz) FM/MW-version, 9kHz grid 531 - 1602kHz VARICAP ALIGNMENT FM RF VCO AM IF AM RF 3) 108MHz 87.5MHz 1602kHz 531kHz 5130 check 5123 check 8V ±0.2V 4.3V ±0.5V 6.9V ±0.2V 1.1V ±0.4V 1494kHz 558kHz 560kHz 5102 1500kHz 1494kHz 558kHz 560kHz 1500kHz 2106 5102 2106 3142 152kHz ±1kHz 1) 98MHz (83MHz for Japan) 5112 MAX FM 87.5 - 108MHz FM 87.5 - 108MHz MW FM/MW-version, 9kHz grid 531 - 1602kHz 1700kHz 530kHz 5123 check 8V ±0.2V 1.1V ±0.4V 108MHz 87.5MHz 108MHz 87.5MHz 2155 5131 MW FM/AM-version, 10kHz grid 530 - 1700kHz FM MW 98MHz, 1mV (83MHz for Japan) continuous wave 450kHz connect pin 6 of IC 7101 (AM Osc.) with short wire to ground (pin 4) Use service test program. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically. 5 1 3 5 4 A A mod=1kHz ∆f=±22.5kHz 1) If sensitivity of frequency counter is too low adjust to max. channel separation (input signal: stereo left 90% + 9%, adjust output on right channel to minimum) Repeat ECO5 AM stereo, discr.coil 090797 TUNER ADJUSTMENT TABLE ( ECO5 FM/MW- stereo versions with AM-frame aerial ) ∆f=±15kHz VRF = 3mV C see remark 2) 220R 100nF 36 IC 7101 220R 100nF 40 IC 7101 max. symmetric fo IF stereo module MW C continuous wave VRF = 10mV 5111 5114 2 0 ± 2 mV DC MW FM/MW-version, 9kHz grid 531 - 1602kHz ∆f = ±30kHz VRF as low as possible max. symmetric fo MW FM/AM-version, 10kHz grid 530 - 1700kHz 3) For AM RF adjustments the original frame antenna has to be used ! 2) RC network serves for damping the IF-filter while adjusting the other one. Waverange Input frequency Input Tuned to Adjust Output Scope/Voltmeter 107,75MHz 76MHz 5130 check 8V ±0.2V 2.4V ±0.5V FM Japan 76 - 90MHz plus Ch1 95.75MHz, Ch2 101,75MHz, Ch3 107.75MHz FM Japan 76 - 90MHz plus Ch1 95.75MHz, Ch2 101,75MHz, Ch3 107.75MHz 107.75MHz 76MHz 107.75MHz 76MHz 2155 5131 AM AFC MW 5240 4 max. 50R 100nF E ∆f=±15kHz VRF = 1mV B FM IF 5119 FM 10.7MHz, 50mV continuous wave 2 F 2141 shortcircuit to block AFC 21 IC 7101 0 ± 3 mV DC 7B-3 7B-3 marked components to be assembled as service solution for Local/DX - switching SW FM E C A C A A C B C C 34 E 11 FRAME 1 4 5 AM 98-05-14 B 33962 303 3103 B 1 A B C A B C 1 2 3 4 5 1 2 3 4 5 ECO 5 TUNER BOARD / component side view VCC VCC2 GND MPX ENABLE DATA CLOCK STEREO DATA ENABLE LEFT GND RIGHT FM 300 OHM FM 75 OHM Connector for AM - stereo Module 2SA... E C B C B E BC... SW VCC GND VCC2 1101 1102 2162 3110 6101 6103 6104 5130 5131 7102 9125 5115 1126 1127 3160 5116 9136 9137 1122 1120 3158 3159 3161 1123 1124 1125 1121 1105 SW-OSC MW-OSC 9113 9117 9121 9123 9128 9100 9105 9114 7104 5106 5123 5124 6102 2123 2125 1104 2104 2105 3105 9101 9115 9134 7107 5126 6106 FM-OSC 5109 5113 5122 FM-RF LW-OSC SW-RF FM-RF 2155 2130 VCO 9118 5127 9120 9126 9131 3173 5110 5121 6120 3157 3170 3171 3172 3142 3147 2144 2148 2133 2135 2138 1130 1131 AM-IF GND +FM R-FM L-FM L out 3152 6109 SW-RF MW-RF LW-RF 9111 2107 5103 5104 5102 1103 2106 2110 2115 LW-RF MW-RF SW-ANT 9122 9130 9133 AM-IF1 5111 7105 5105 2128 2129 AM-AFC AM-IF2 6107 9119 9124 5112 5114 3149 3154 1119 2137 SEARCH SENS. R out VCOkill STSIG STEREO V+ 1 AM FRAME AERIAL 1 ECO5 3396 stage .2, 250698 Voltage multiplier board This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram respectively partslist. 1 1 1 1 1 7119 5120 9129 3132 5119 DISCRIMI- NATOR A 1 C F 4 3 D B marked components to be assembled as service solution for Local/DX - switching SW FM E C A C A A C B C C 34 E 11 FRAME 1 4 5 AM 98-05-14 B 33962 303 3103 B 1 ECO 5 TUNER BOARD / copper side view This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram respectively partslist. ECO5 3396 stage .2, 250698 41.. in schematic diagram) (not all items shown Chip jumper E B C A C 1 23 34 12 5 4 1 8 2102 2103 3101 3143 3167 4154 3176 6111 7123 7124 3134 9114 3136 3137 4106 4107 4108 4153 2120 2157 3106 2112 2118 2119 7122 7101 7120 6130 6131 4150 4151 4152 4157 3126 3128 3168 4105 4120 3102 3103 3118 3120 3122 2153 2154 2158 2160 3104 2101 2116 2122 2149 2150 2152 2159 7103 4103 3153 3169 2166 2167 3141 3145 2145 2146 2151 2134 2136 2147 2131 2132 4111 6105 6110 3108 3133 4101 4102 4155 2108 2109 2113 2124 7108 4109 4110 4156 3112 3114 3116 3117 3121 2114 2117 3109 3177 3113 4159 3155 3156 3175 2143 2163 3181 2105 6101 9119 A B C A B C 5 4 3 2 1 5 4 3 2 1 3148 3146 3178 3179 4160 4161 7111 7125 4158 3144 4162 4163 2126 2165 2156 3119 2111 4104 2161 2127 7121 3127 2141 2142 2164 2139 2168 3140 7106 3125 7109 3111 3123 3115 3180 5 1 C F 4 3 A D 2 E 1101 A1 1102 A1 1103 C1 1104 B1 1105 A1 1119 C5 1120 A5 1130 B5 1131 B5 2104 A2 2105 A1 2106 C2 2107 C2 2110 C2 2115 C1 2123 A2 2125 A2 2128 C3 2129 C4 2130 A4 2133 A4 2135 B5 2137 C5 2138 A5 2144 B5 2148 B4 2155 A3 2162 A2 3105 B3 3110 A2 3132 B3 3142 A4 3147 B5 3149 C5 3152 A5 3154 C5 3157 B5 3158 A5 3159 A5 3160 A5 3161 A5 3170 C5 3171 C5 3172 C5 3173 A5 5102 C2 5103 C2 5104 C2 5105 B2 5106 B2 5109 B4 5110 B4 5111 C3 5112 C4 5113 B3 5114 C4 5115 A4 5116 A4 5119 B5 5120 B4 5121 B4 5122 B3 5123 B2 5124 B2 5126 B3 5127 B4 5130 A3 5131 A3 6101 A2 6102 A1 6103 A1 6104 A2 6106 B3 6107 C5 6109 C2 6120 C4 7102 A3 7104 C2 7105 C3 7107 B3 7119 C4 9100 A2 9101 B3 9105 B2 9111 C2 9113 B2 9114 B2 9115 B3 9117 B2 9118 B4 9119 C4 9120 B4 9121 A2 9122 C3 9123 B1 9124 C4 9125 A3 9126 B5 9128 A2 9129 B3 9130 C3 9131 A5 9133 C3 9134 B3 9136 A5 9137 A5 2101 C4 2102 C4 2103 C3 2108 A4 2109 A4 2111 A2 2112 B5 2113 A4 2114 A4 2116 B3 2117 A3 2118 B4 2119 B4 2120 B4 2122 B3 2124 A5 2126 C2 2127 C2 2131 C2 2132 C1 2134 C1 2136 B1 2139 B2 2141 B1 2142 B1 2143 A1 2145 C1 2146 C1 2147 C1 2149 B2 2150 B2 2151 C2 2152 C3 2153 C3 2154 C3 2156 C4 2157 B4 2158 B4 2159 C2 2160 C4 2161 A3 2163 A2 2164 B1 2165 B3 2166 B2 2167 B2 2168 B 1 3101 C3 3102 C3 3103 C3 3104 B3 3106 C4 3108 A4 3109 A4 3111 A3 3112 A3 3113 A2 3114 A3 3115 A3 3116 A3 3117 B4 3118 B3 3119 A3 3120 B4 3121 A3 3122 B3 3123 A3 3125 A3 3126 B3 3127 B3 3128 B3 3133 B4 3134 B4 3136 B4 3137 B4 3140 B2 3141 C2 3143 C2 3144 C2 3145 C2 3146 A1 3148 A1 3153 C2 3155 A2 3156 A1 3167 C2 3168 B3 3169 B2 3175 A2 3176 C2 3177 A1 3178 A1 3179 A1 3180 A4 3181 C3 4101 A4 4102 A4 4103 C2 4104 A2 4105 B3 4106 B4 4107 C4 4108 B4 4109 A3 4110 A3 4111 C1 4120 C2 4150 B2 4151 B3 4152 B3 4153 B4 4154 C3 4155 A4 4156 A2 4157 B3 4158 C2 4159 A2 4160 A1 4161 A1 4162 C1 4163 C1 6105 A4 6110 A4 6111 B4 6130 C2 6131 C3 7101 B2 7103 C2 7106 A3 7108 A3 7109 A3 7111 A1 7120 B4 7121 B3 7122 B4 7123 B4 7124 C4 7125 A1 7B-4 7B-4 to 1130,1131 AM Stereo module z 3175 2k7 AM-IF z 5113 SFU450B to/from AM-stereo module AM-IF P0 Low=AM mono P1 T030 T031 T038 T039 z AM-IF GND +FM R-FM L-FM L-out R-out VCO-kill STSIG stereo V+ 1131 z 1130 11 10 9 8 7 6 5 4 3 2 1 T033 T034 T035 T036 z 3177 10k 3147 3M3 7125 BC848C 3179 1M z z z 3178 3M3 z z_100R z_22k 2111 100p 7119 2SC1047 3113 1k t 3119t t t 330R 3 6 5 4 1 2 1121 MPX GND r 3143 22k Vcc1 7103 BC858C r r 3144 1k r 3176 1k r MPX MPX to 1121 buffer amplifier from 3144 r....for RDS version only LW=high MW=high LW=high MW=high Vcc2 Vdd AGC AM IF CONTROL AGC AM Det. CONTROL AGC IF AM Charge Pump DECODER STEREO AFC DET AM DET IF2 IF1 FM FM FM STABILIZER OSC AM AM MIXER AM Frontend AGC Frontend FM FM MIXER FM Pre- scaler Multi- plexer OSC x - - - - - - - - - - - - - - - - - - - - - - - x x - x x x x x x x x - x x x - - x x x VERSION PROGRAMMING COMPONENTS 3170 remark 7111 not mounted 3157 3156 6120 /15 FM/MW/SW-Eu /.. FM/MW/2xSW /17 FM/AM /14 FM-OIRT/MW/LW - - x x /14 FM-OIRT/MW /13 FM/MW-Stereo /06 FM-Japan/MW-stereo /01 FM/MW/SW-Ov /01 FM/MW /01 FM/MW-Stereo /00 FM/MW/LW/SW-Eu /00 FM/MW/LW x = component mounted - - - x /17 FM/AM-Stereo SW SW SW SW = Software initialisation t....for Japanese version (/06/26) only Stereo Mono/ Ripple Mixout Mixout FM-IF2 Enable OSC. Stereo FILTER printed printed AGC FM-In RF-GND AM-IF1-in AM FM FM-IF1 in AM-IF2 VSTABB VSTABA FM-IF2 AM-AFC P1 P0 Write DATA CLOCK Dig.GND XTAL Mono/ Vdd Vdd Vdd Vcc2 Fieldstrength Indic. AFC+ AFC- FM-Demod. IF GND PILOT right left MUTE LPF MPX-IN AF-Out VCO I-TUNE Vcc1 AM-OSC. FM-OSC. RF-GND FM-RF AM-RF Ripple y....for USA version (/17/37) only z....for AM-STEREO (/06/13/26/33) versions only x....not for all versions w...for LW only v...for SW-version 3.9-12.1MHz only u...for 2-band (FM/AM) version only AM-AFC 450 kHz AM-IF2 AM-IF1 FM-IF2 FM-IF1 to 3103 FM-RF FM-OSCILLATOR Q-MULTIPLIER TUNER BOARD ECO5 / Systems MW/LW-RF MW MW VCO AM-OSCILLATOR version detection DISCRIMINATOR 6131 D 7 6130 E 7 6120 G16 6107 H17 6105 E 6 6106 C 6 6105 K12 6104 C 3 6103 C 2 5131 D 8 5130 E 8 5123 L11 5122 M11 5121 F15 5119 I 12 5120 H13 5114 C16 5113 B12 5112 A15 5111 A13 5110 B14 5109 B13 5103 F 4 5102 E 4 4108 L 9 4106 K12 4105 B11 4104 B13 4103 G 9 4102 F 5 4101 G 5 3177 I18 3176 J 9 3175 B16 3179 I16 3180 M7 3178 I15 3171 H15 3170 F17 3169 G15 3167 G18 3161 E18 3160 E18 3159 F18 3158 F18 3157 F17 3156 G17 3155 H17 3154 H18 3153 H19 3152 H18 3147 I15 3146 I17 3145 H10 3143 I10 3144 I10 3142 G 9 3141 G10 3137 M13 3140 I13 3134 M12 3132 L 9 3128 M 8 3125 M 6 3123 M 7 3110 F 6 3120 C 6 3113 C13 3119 B13 3109 F 2 3108 E 3 3105 C 7 3104 B11 3103 C 8 3102 E 7 3101 E 7 2167 F16 2168 I 13 2166 G16 2165 C 9 2164 H14 2163 E16 2161 D16 2160 M12 2159 F 9 2158 M11 2155 D 8 2154 E 7 2153 E 8 2152 F 7 2150 B13 2149 C15 2148 F16 2147 F16 2146 F15 2145 G16 2144 H17 2143 I17 2142 H14 2141 H14 2140 H14 2138 H12 2139 H13 2137 J18 2136 J17 2135 J18 2134 J17 2133 H11 2132 I10 2131 I10 2130 H17 2129 C 9 2128 C11 2127 G10 2126 G 9 2125 M11 2123 M11 2122 N11 2120 L11 2109 G 3 2111 C13 2108 G 3 2107 G 6 2106 F 5 2104 B 6 2103 D 9 2102 G 7 2101 C 6 1130 I20 1131 I20 1126 E20 1124 G20 1121 E20 1103 D 2 1102 B 2 1101 A 1 9128 A 4 9117 L10 9101 C 6 9100 B 4 7124 M13 7125 I16 7122 M 9 7119 B13 7111 F18 7109 M 7 7105 F 2 7104 E 3 7103 I 9 7102 D 8 7101 G11 4 5 1 2 16 17 18 19 20 21 3 K J N I H G F E D C B A M L K J N I H G F E D C B A M L 4 5 1 2 16 17 18 19 20 21 3 HN1V02H Chip jumper 8 7 6 5 4 3 2 1 6105 z_TEA5759 to/from COMBI BOARD / Source Selector part to/from CONTROL BOARD x x x x FM 50 OHM LW LW MW w w w w_27p 2166 1n 2165 100n x 2163 100n 10p_w 2158 2159 33p 2126 330p 2142 100n 2145 220p 2150 100n 1u 2107 2146 220p 2147 220p 2148 22n 2143 220n 2141 100n 470n 2164 2136 15n_y22n 2134 15n_y22n 2149 22n 2104 100p 2103 1n 2101 100p (if 1102 is used) 2130 22n 2132 470n 2131 470n 2127 220n w 2109 10p w 2108 100p w 2122 3n3 2125 560p w 2123 390p 22p 2120 2153 s_560p 2152 33n x 2154 4p7 2102 10n u 2160 22n x 2161 100n 2167 12p 3169 150k 3105 220R 3132 47R 3146 22R 3157 100k 3161 Programmable Output Ports 470R 3160 470R 3159 470R 3158 470R 3156 100k 470R 3155 150R 3154 3167 220R 3153 470R 3152 470R 3141 56k 3145 2k2 4k7 w 3109 3108 2k2 w 3128 2k2 3125 10k 3134 220k w 3137 22k 3170 100k s_5k6 3101 33k 3102 100k t_18k 47p (if 1101 is used) 3103 18k 3104 180R 3110 47R 3171 330R 4k7 3123 6104 1N4148 6103 1N4148 6120 1N4148 y 9128 9101 9100 u 9117 P0 P0 P0 P0 P1 P1 Vcc1 Vcc1 Vdd REF REF Vdd AM FRAME AERIAL 7101 TEA5757 10 11 12 13 14 15 16 17 18 19 1 20 21 22 23 24 25 26 27 28 29 2 30 31 32 33 34 35 36 37 38 39 3 40 41 42 43 44 4 5 6 7 8 9 7104 7111 BC848C w 7105 BC338-40 BC338-40 w 7122 BC848C w 7124 BC848C T001 T002 T003 T005 T006 T013 T012 T011 T009 T014 T015 T017 T016 T018 T020 T021 T022 T023 T024 T025 T026 T027 T032 T037 T045 T041 T042 T040 T043 T044 T046 T047 2144 1u 2138 2u2 2128 10u 2129 100u 2133 1u 2135 220n 2137 220n stereo clock data enable 1126 1 4 3 2 Vcc right GND left 1124 1 4 3 2 4105 u 4102 u 4101 4103 4104 4108 4106 FM 300 OHM y 1101 1 2 1103 1 2 5112 1 2 3 4 6 5111 1 2 3 4 6 x 1102 1 2 1SV228 6130 1SV228 6131 5130 5131 2155 3-11p 3142 100k w_4-20p 2106 3-11p 3 6105 5 6 HN1V02H 2 6105 1 7 HN1V02H w 5103 1 2 3 4 6 w 5122 1 2 3 4 6 5123 1 2 3 4 6 7109 BC858B 7102 2SA838B 5109 5110 6107 BZX79-C11 5114 1 3 5102 1 2 3 4 5 6 5121 75KHz 3180 provisional 22k 41.. ECO5 systems, discr.coil, 240698 VSTABB VSTABA w w 450 kHz 450 kHz s...for East European version (/14/34) only 6106 1N4148 3120 0R 15p s_12p t_2p2 2139 15p (2140) 2140 exchanged by 2164 (SMD type 0805) from layout stage 3317.9 onwards respectively 3103 303 3380.1 and 3103 308 3396.1 2168 82p 5119 1 2 3 4 6 w 5120 CDA10.7MG61KA 3140 150R 3140 and 5120 provisional as alternative 0.7V 0.1V V 1.3V 0.15V 0.7V 1V 0.7V 0.7V 1.4V 1.4V 1.4V 1.4V 1.4V 1.4V 0.7V 0.3V 0.2V 5V 0V 150kHz, 50mVpp stereo stereo mono (11 - 14V) typ. 12V 11V 8V 8V 8V 1.2V 2V 1.3V stereo 0.3V mono 4.9V stereo 0.5V mono 4.9V 1.2V 1V 1V 0.7V 0.7V 0.7V 0.8V 1.2V 0.7V 1V 0V 8V 0V 0V 0V 2.1V ............. Vdc FM mode stereo Vdc MW mode Vdc LW mode Voltages measured while set is tuned to a strong transmitter EVM V V 4 3 C 1 2 B E 6101 remove Service Solution for Local/DX - switching BA484 2105 100p 3106 10k 9114 9119 4155 4156 P0 A 5 F Signal path FM AF - left/right AM MPX (Audio Frequency) 10 11 12 13 14 15 6 7 8 9 10 11 12 13 14 15 6 7 8 9 7B-5 MISCELLANEOUS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1101 4822 267 31505 SOCKET 2-POLE CLICKFIT, 300Ω only for /17 1102 4822 267 10283 SOCKET COAX, IEC 75Ω not for /17 CAPACITORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 2101 © 5322 122 32531 100pF 5% 50V not for /17 2101 © 5322 122 32452 47pF 5% 63V only for /17 2102 © 4822 122 33177 10nF 20% 50V 2103 © 5322 122 34123 1nF 10% 50V 2104 4822 122 33195 100pF 10% 50V 2106 4822 125 60101 3-11pF TRIMCAP. 2107 4822 121 51319 1µF 20% 50V 2120 © 5322 122 32658 22pF 5% 50V 2125 4822 121 51381 560pF 1% 400V 2126 © 5322 122 31863 330pF 5% 50V 2127 © 4822 126 13473 220nF 20% 50V 2128 4822 124 41579 10µF 20% 50V 2129 4822 124 41584 100µF 20% 10V 2130 4822 126 11585 22nF 20% 50V 2131 © 4822 126 13482 470nF 20% 16V 2132 © 4822 126 13482 470nF 20% 16V 2133 4822 124 40242 1µF 20% 63V 2134 © 4822 126 13188 15nF 5% 63V not for /17 2134 © 5322 122 32654 22nF 10% 63V only for /17 2135 4822 124 40746 0,22µF 20% 63V 2136 © 4822 126 13188 15nF 5% 63V not for /17 2136 © 5322 122 32654 22nF 10% 63V only for /17 2137 4822 124 40746 0,22µF 20% 63V 2138 4822 124 41576 2,2µF 20% 50V 2139 © 4822 126 14236 15pF 5% 50V 2141 © 4822 126 10002 100nF 20% 50V 2142 © 4822 126 10002 100nF 20% 50V 2143 © 4822 126 13473 220nF 20% 50V 2144 4822 124 40242 1µF 20% 63V 2145 © 4822 122 33575 220pF 5% 50V 2146 © 4822 122 33575 220pF 5% 50V 2147 © 4822 122 33575 220pF 5% 50V 2148 4822 126 11585 22nF 20% 50V 2149 © 5322 122 32654 22nF 10% 63V 2150 © 4822 122 31947 100nF 20% 50V 2152 © 4822 126 12105 33nF 5% 63V not for /14 2152 © 5322 116 80853 560pF 5% 63V only for /14 2153 © 4822 122 32139 12pF 5% 63V only for /14 2153 © 4822 122 32504 15pF 5% 50V not for /14 2155 4822 125 60101 3-11pF TRIMCAP. 2159 © 5322 122 32659 33pF 5% 50V 2160 © 5322 122 32654 22nF 10% 63V 2164 © 4822 126 13482 470nF 20% 16V 2165 © 4822 126 10002 100nF 20% 50V 2166 © 5322 122 34123 1nF 10% 50V 2167 © 4822 122 32139 12pF 5% 63V 2168 © 4822 126 13695 82pF 1% 63V RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3101 © 4822 051 20333 33kΩ 5% 0,1W not for /14 3101 © 4822 051 20562 5,6kΩ 5% 0,1W only for /14 3102 © 4822 051 20104 100kΩ 5% 0,1W 3103 © 4822 117 10965 18kΩ 2% 0,1W 3104 © 4822 117 11448 180Ω 10% 0,1W 3105 4822 116 83872 220Ω 5% 0,5W 3110 4822 116 52195 47Ω 5% 0,5W 3120 © 4822 051 20008 CHIP JUMPER 0805 3132 4822 116 52195 47Ω 5% 0,5W 3134 © 4822 051 20224 220kΩ 5% 0,1W 3141 © 4822 117 11148 56kΩ 1% 0,1W RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3142 4822 100 11163 100kΩ TRIMPOT LIN. 3145 © 4822 117 11449 2,2kΩ 1% 0,1W 3146 © 4822 051 20229 22Ω 5% 0,1W 3152 4822 116 83883 470Ω 5% 0,16W 3153 © 4822 051 20471 470Ω 5% 0,1W 3154 4822 116 83868 150Ω 5% 0,5W 3155 © 4822 051 20471 470Ω 5% 0,1W 3156 © 4822 051 20104 100kΩ 5% 0,1W not for /14/17 3157 4822 116 52234 100kΩ 5% 0,5W only for /14 3158 4822 116 83883 470Ω 5% 0,16W 3159 4822 116 83883 470Ω 5% 0,16W 3160 4822 116 83883 470Ω 5% 0,16W 3161 4822 116 83883 470Ω 5% 0,16W 3167 © 4822 117 11503 220Ω 5% 0,1W 3169 © 4822 051 20154 150kΩ 5% 0,1W 3170 4822 116 52234 100kΩ 5% 0,5W not for /14 3171 4822 116 52219 330Ω 5% 0,5W 4101 © 4822 051 20008 CHIP JUMPER 0805 4102 © 4822 051 20008 CHIP JUMPER 0805 4103 © 4822 051 20008 CHIP JUMPER 0805 4104 © 4822 051 20008 CHIP JUMPER 0805 4105 © 4822 051 20008 CHIP JUMPER 0805 4106 © 4822 051 20008 CHIP JUMPER 0805 4108 © 4822 051 20008 CHIP JUMPER 0805 4111 © 4822 051 20008 CHIP JUMPER 0805 4120 © 4822 051 20008 CHIP JUMPER 0805 4150 © 4822 051 10008 CHIP JUMPER 1206 4152 © 4822 051 10008 CHIP JUMPER 1206 4153 © 4822 051 10008 CHIP JUMPER 1206 4154 © 4822 051 10008 CHIP JUMPER 1206 4157 © 4822 051 10008 CHIP JUMPER 1206 4158 © 4822 051 10008 CHIP JUMPER 1206 4159 © 4822 051 10008 CHIP JUMPER 1206 COILS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 5102 4822 157 71634 RF-COIL MW 5109 4822 242 70665 FM-IF FILTER 10,7MHZ 5110 4822 242 70665 FM-IF FILTER 10,7MHZ 5111 4822 158 60511 AM-IF FILTER 450kHz 5112 4822 157 70302 AM-IF FILTER 450kHz 5114 4822 157 70302 AM-IF FILTER 450kHz 5119 4822 157 11443 DISCRIMINATOR COIL 5121 4822 242 10261 QUARTZ 75kHz 5123 4822 157 60517 RF-COIL AM 5130 4822 156 30947 RF COIL 1,5 TURNS 5131 4822 156 30947 RF COIL 1,5 TURNS DIODES ––––––––––––––––––––––––––––––––––––––––––––––––––––– 6103 4822 130 30621 1N4148 6104 4822 130 30621 1N4148 6105 © 4822 130 83075 HN1V02H 6106 4822 130 30621 1N4148 6107 4822 130 34488 BZX79-C11 6120 4822 130 30621 1N4148 only for /14/17 6130 © 4822 130 82833 1SV228 6131 © 4822 130 82833 1SV228 TRANSISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 7102 4822 130 60093 2SA838B 7111 © 5322 130 42136 BC848C INTEGRATED CIRCUITS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 7101 © 4822 209 90924 TEA5757H/V1, RADIO IC ELECTRICAL PARTSLIST TUNER ECO5 7B-6 ––––––––––––––––––––––––––––––––––––––––––––––––––––– ELECTRICAL PARTS LIST TUNER ECO5 for 06 ( Japanese version) 1102 4822 265 20598 SOCKET COAX YKD31-0468 75Ω 1130 4822 267 10749 CONNECTOR S11B-XH-A (11P) 2111 5322 122 32531 100pF 5%NP0 50V 2153 5322 122 33063 2.2pF 5% NP0 50V 3113 4822 051 10102 1kΩ 2% 0,25W 3119 4822 051 20331 330Ω 5% 0,1W 3134 4822 051 20223 22kΩ 5% 0,1W 3147 4822 111 50499 3.3MΩ 5% 0,2W 3155 4822 051 20101 100Ω 5% 0,1W 3175 4822 117 12955 2.7kΩ 1% 0,1W 0805 3177 4822 117 10833 10kΩ 1% 0,1W 3178 4822 051 20335 3.3MΩ 5% 0,1W 3179 4822 051 20105 1MΩ 5% 0,1W 4161 4822 051 20008 CHIP JUMPER. 0805 5113 4822 242 80989 FILTER SER. SFU450B 457kHz 5130 4822 157 70033 COIL-FM OSC 7101 TEA5759H/V1 RADIO IC 7119 4822 130 60163 2SC1047C 7125 5322 130 42755 BC847C BC848C 7D-1 7D-1 7D-1 PCS 83 453 IF1 FM VCC1 VCC1 VDD VCC2 7 VDD 23 STABILIZER FM-IF1I In 37 IF2 FM FM-IF2 35 V Stab B 34 33 FM-IF2I V Stab A 38 AM-MIX Out 40 AM-IF1 In 41 36 AM-IF2 32 AM-AFC AM IF AM DET DET FM AFC 19 AFC- 20 AFC+ 44 AGC AGC 10 AF-Out 18 FM-Demod AM MIXER 2 AM-RF AM FRONTEND AM OSC. STEREO DECODER CONTROL MPX-In 11 VC0 3142 9 LPF 12 Right 15 16 Left 14 13 Mute Stereo 21 Indc. XTAL OSC 25 P0 30 39 FM/AM 31 P1 27 CLOCK 28 DATA 29 WRITE Enable 5 FM Osc. CHARGE PUMP 8 I-Tune 24 Mono/ FM GND 3 4 RF GND 17 IF GND 26 Dig. GND 42 RF GND 1 Ripple AM-Osc. MW/LW-SELECTION 6 PILOT Filter Fieldstrength 22 VCC2 TEA5762 FM FRONTEND 1102 A B +B AGC 6 3 Fo Osc Out IF Out Ant1 7 1 GND 4 8 a F if F 10,7 MHz f0 = fin + fif +FM MT MT 5 VT 75kHz 10,7MHz VC0 IF-AM IF-AM AM-DET ANTI BIRDY FILTER 2 1 450kHz 450kHz 5111 5112 5114 450kHz 3 DATA ENABLE RDS 4 CLOCK 5 STEREO 6 GND 2 1 1121 4 GND 3 2 LEFT RIGHT 1 VCC 1124 10,7MHz 10,7MHz 2106 5102 MW 5103 LW 3 4 +FM VCC1 VDD VCC2 RDS RDS AM-RF AM-OSC 5123 MW 5122 LW 7 6 C TABLE OF CONTENTS Blockdiagram ..................................................................7D-1 Adjustmant table .............................................................7D-2 Component layout...........................................................7D-2 Circuit diagram................................................................7D-3 Partslist ...........................................................................7D-4 TUNER 95 BOARD BLOCKDIAGRAM PCS 96 921 7D-2 7D-2 7D-2 3104 217 04121/04341 bl. 110 - 01 TUNER 95 bis 1 1 2 IC 6105 1 e c b e c b c b e 8 4 1 6 4 LEU0149 9751 not in RDS version (04341) only in RDS version (04121) 1 1 TUNER 95 bis Combi: Copper side view 5109 3125 1102 1103 2125 2106 9100 9114 7104 2107 5102 9111 5123 5103 2123 3128 2102 1110 5122 9104 7105 9101 1126 2138 5110 9116 9119 2130 3167 1124 5111 9115 2128 2129 9125 5114 9126 5112 3142 2133 5115 2140 9118 3158 6120 5121 9123 9121 2144 9120 9102 3154 3155 6107 1121 9108 3159 3160 9107 3161 3164 2162 5107 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10 11 11 12 12 13 13 A A B B C C D D E E F F G G H H I I J J 1102 F4 1103 C3 1110 G7 1121 H11 1124 H9 1126 G10 2102 G7 2106 C5 2107 C4 2108 C6 2109 C5 2120 F5 2122 E6 2123 F6 2125 G5 2127 F9 2128 C7 2129 C8 2130 F8 2131 F9 2132 F9 2133 F10 2134 G10 2135 G11 2136 G10 2137 E11 2138 E10 2140 F10 2141 E10 2142 E9 2143 C10 2144 E10 2145 G11 2147 G11 2148 E9 2150 F8 2151 F9 2152 F9 2158 D10 2160 E9 2161 E9 2162 C11 3103 H6 3104 G6 3107 G7 3108 C6 3109 B7 3123 E4 3124 E5 3125 C7 3128 F6 3129 E6 3130 E6 3131 C6 3132 E5 3134 E5 3137 G5 3138 D9 3139 F8 3140 H8 3141 G9 3142 G10 3143 G8 3144 H8 3145 F9 3146 B10 3150 C11 3151 C10 3152 G9 3153 G9 3154 C10 3155 C10 3158 G11 3159 G11 3160 G11 3161 G11 3162 D9 3163 F8 3164 C11 3165 D8 3167 F8 3169 D5 3171 D11 3172 F7 3173 F7 3176 D9 3177 F7 3181 D8 3183 E7 3184 E7 3185 E7 3186 G8 3188 G11 3192 D8 3197 C7 5102 C4 5103 C5 5107 F10 5109 D7 5110 E9 5111 C8 5112 C9 5114 D8 5115 G9 5121 E9 5122 E7 5123 E5 6105 D4 6107 B10 6120 D10 7101 E9 7103 G9 7104 D5 7105 B6 7109 C6 7110 D11 7122 F7 7124 G6 9100 F4 9101 E7 9102 D10 9104 E6 9107 F11 9108 G11 9111 C4 9114 E5 9115 C8 9116 G8 9118 G10 9119 G7 9120 D10 9121 D9 9123 D9 9125 D8 9126 C8 4 1 5 8 b e c b e c b c e e b c 12 1 34 23 c e b 3184 3172 3185 3183 3197 2120 3137 3132 3123 6105 3134 3169 3124 2109 3103 7124 3104 7122 3108 3129 3130 2122 2108 3109 7109 3131 2145 7110 2143 3151 3146 7103 3143 3140 3107 3139 3163 3186 3144 2127 2131 3192 3181 7101 2132 3153 3145 3152 3141 2134 2136 2142 2161 2160 3162 2158 2141 3188 2135 2147 2137 3150 2150 3173 3177 2152 2151 2148 3176 3138 3171 3165 +12V MW LW MW LW = = 0,7V 0V = = 0V 0,7V VT 6 = = AM FM VDD 7V 6V +12V +FM +8V +1,4V +1,4V VCC +12V RIGHT LEFT +9,6V STEREO CLOCK DATA +9,6V ENABLE MPX 0V V AM FM 12V <0,5V VDD AM FM 7V = 6V = AM FM = = TUNER 95 bis Adjustment Table (FM, MW, LW with Frame antenna) Waverange Input frequency Input Set tuned to Adjust Output Scope / Voltmeter VARICAP ALIGNMENT FM (50) 108 MHz check 7 ... 9V 87.5 - 108 MHz 87.5 MHz check 1.3 ... 2V MW (9) 1602 kHz 5123 8.3V ± 0.2V 531 - 1602 kHz 531 kHz check 1V ± 0.4V LW (3) 279 kHz 5122 8.3V ± 0.2V 153 - 279 kHz 153 kHz check 1V ± 0.4V FM – DETECTION FM 98 MHz 1mV continuous wave short pin 21 (IC7101) to ground 98 MHz 5107 0mV ± 3mV FM – VCO 98 MHz 1 mV FM continuous wave 98 MHz 3142 152kHz ± 1 kHz DISTORTION 98 MHz 1 mV mixcoil FM 90 % L + 98MHz inside Distortion 9 % pilot Tuner minimum mod = 1kHz 1110 AM – IF 450kHz 5111 ∆f = 10kHz symmetrical and Low as possible max. height MW Swept signal MW 5112 450kHz 5114 0mV ± 2mV continuous wave AM - RF 558kHz 558kHz 5102 MW Mod = 1kHz MAX 30 % AM 1494 kHz 1494kHz 2106 198kHz * LW mod = 1kHz 198kHz 5103 MAX 30 % AM * Signal send via a frame antenna adjtable for 3104 217 04121/04341 (..) = tuning grid in kHz repeat 100nF 50E 2 1 A C A A 2 1 B 7 7 4 3 6 Untitled-1 6/23/98, 1:49 PM 2 7D-3 PCS 922 7D-3 +12V A MW 0V V LW +8V 0V 1V 0,8V 2V +8V 2V +8V +9,6V +6V +7V +6V +7V MW 0V V LW 0V MW V LW MW LW = 0V = 0,7V 6 C 75 kHz 0,7V 0,9V 2 1 1,4V 1,4V +7V +6V +9,6V +7V +6V 11,8V 11,2V +12V +12V 0V FM AM V 4 3 STEREO = LOW mono 0V V stereo During communication 0 V 0V = No communication 1,3V 1,3V High = During communication 0 V FM .....V .....V AM FM AM .....V FM mode stereo Signal path AF 0,5V 0,5V MW LW = 0V = 0,7V 7 MW LW = 0V = 0,7V B +B 6 Fo Osc Out 8 1 Ant1 4 a F if F 10,7 MHz o F a = F + Fi µ 47 +FM 0E FM ANT. 9752 LEU0150 f 3104 217 04121/04341 bl. 130 - 01 IF1 FM VCC1 7 VCC1 VDD 23 VDD STABILIZER 1µ FM-IF1I In 37 IF2 FM FM-IF2 35 V Stab B 34 33 FM-IF2I 10,7 MHz V Stab A 38 100n 3 4 1 6 2 0E AM-MIX Out 40 AM-IF1 In 41 3 4 1 2 6 450 kHz 450 kHz 36 AM-IF2 450 kHz 3 1 32 AM-AFC AM IF AM DET DET FM AFC 19 AFC- 20 AFC+ 470n 44 0E AGC AGC 10 AF-Out 18 FM-Demod µ 10 0E AM MIXER 2 AM-RF AM FRONTEND AM OSC. STEREO DECODER CONTROL 2 3 1 4 6 MPX-In 11 56k VC0 9 100k 2k2 LPF 12 470n 470n Right 15 16 µ 2 Left 14 1 13 µ Mute 2 Stereo 100n 21 Indc. XTAL OSC 25 220n 15n 15n 220n 470E 470E RIGHT 4 GND 3 2 LEFT 1 P0 30 39 FM/AM 31 P1 27 CLOCK 28 DATA 29 WRITE Enable 5 FM Osc. CHARGE PUMP 8 I-Tune 10,7 MHz 24 Mono/ 1N4148 220p 470E 470E 470E 470E ENABLE 3 DATA 4 CLOCK 5 STEREO 6 GND MPX-RDS 2 1 220p 22n FM GND 3 4 RF GND 17 IF GND 26 Dig. GND 42 RF GND GND MT MT 330E 5 VT 1k AM-FRAME SOCKET 1 2 4 3 5 6 HN1V02H 5p2- 1 470n 5 0E 30p 7 2 6 3 0E HN1V02H BC338-40 27p 82p BC338-40 2k2 2k2 2 1 3 6 4 33p 390p 1 2 3 6 4 3n9 560p 22k 2 3 1 1 2 10k BC848C 0E 2k2 BC848C BC858B 4k7 VDD VDD 10k 0E 0E 0E BC858C 1k 22k VCC1 1k 1 Ripple 0E 220n BC858B 68k 220E +FM 100n µ 1 C11 BZX79/ 47E 220E 330E 220n VCC1 VDD VCC2 22n IF Out 7 0E 0E 0E 0E AM-Osc. 6 82E PILOT Filter Fieldstrength (VCC2) 0E VCC2 22 VCC2 VCC VT 4k7 100n 75 kHz 1n 150k 12p 4E7 µ 22 0E FE415-G23 22k not in RDS version (04341) only in RDS version (04121) 4 3 1 2 15p Toko 7KM 1 3 MT 2 5 4 82p AGC 3 IF - AM FM FRONTEND TUNER 95 bis ANTI BIRDY FILTER VC0 MW-OSC LW-OSC LW MW TEA5762 IF - AM AM - DET 2152 5107 2151 1126 3177 3151 2162 3164 2160 3162 2161 5121 3150 3188 7101 3107 3181 3132 3124 3172 2130 2143 3155 3154 3146 6107 2144 2142 3167 7110 2127 3184 3144 3143 3186 7103 3163 3129 3130 3125 3197 7109 7122 3128 3169 7124 3137 5103 3134 2125 2122 5122 2123 2120 5123 3108 3109 7105 2108 2109 7104 6105b 3123 3131 2107 6105a 2106 5102 1103 3104 3140 2148 2147 1121 3161 3160 3159 3158 2145 6120 5109 1124 3153 3152 2135 2134 2136 2137 2141 2133 2138 2131 2132 3145 3142 3141 5115 3185 2128 3183 2140 5114 5112 5111 3192 2150 5110 2129 1102 3103 2102 1110 2158 3173 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10 11 11 12 12 13 13 14 14 15 15 16 16 17 17 18 18 19 19 20 20 21 21 A A B B C C D D E E F F G G H H I I J J K K L L M M N N 1102 D1 1103 G2 1110 D4 1121 C21 1124 F21 1126 E20 2102 C2 2106 J4 2107 J6 2108 L2 2109 L3 2120 K7 2122 M7 2123 L7 2125 L7 2127 H16 2128 I13 2129 I8 2130 J20 2131 I17 2132 I17 2133 G18 2134 G19 2135 F19 2136 H19 2137 G19 2138 H18 2140 C14 2141 H15 2142 K19 2143 K20 2144 K20 2145 E19 2147 E19 2148 E19 2150 C6 2151 H12 2152 I11 2158 L18 2160 I15 2161 I15 2162 H20 3103 G3 3104 G4 3107 C6 3108 J1 3109 K1 3123 I6 3124 K7 3125 L11 3128 L9 3129 K8 3130 K8 3131 M10 3132 J7 3134 L6 3137 L5 3140 F7 3141 I16 3142 I16 3143 K17 3144 K17 3145 I17 3146 L20 3150 H19 3151 I20 3152 F20 3153 G20 3154 J20 3155 J20 3158 E19 3159 E19 3160 D19 3161 D19 3162 I15 3163 J8 3164 I20 3167 I20 3169 L5 3172 B6 3173 B6 3177 M10 3181 C7 3183 I13 3184 I8 3185 I13 3186 K16 3188 M20 3192 C12 3197 L11 5102 I3 5103 L4 5107 J12 5109 B6 5110 C9 5111 C11 5112 C12 5114 C13 5115 J15 5121 I15 5122 L7 5123 K7 6105a I5 6105b I6 6107 K20 6120 E17 7101 C15 7103 K17 7104 J2 7105 K2 7109 L10 7110 I19 7122 L9 7124 L6 Untitled-2 6/23/98, 1:51 PM 1 PCS 96 923 7D-4 7D-4 ELECTRICAL PARTS LIST - TUNER 95 BOARD ELECTRICAL PARTS LIST - TUNER 95 BOARD MISCELLANEOUS 1102 4822 267 10283 Socket Coaxial IEC 75R 1103 4822 265 31184 JST Connector 2 pin 1110 4822 210 10739 Frontend Assembly FE415-G23 CAPACITORS 2102 4822 124 40433 47µF 20% 25V 2106 4822 125 60102 Trimmer 5,2-30pF 100V 2107 4822 121 51252 470nF 5% 63V 2108 4822 126 13695 82pF 1% 63V 2109 4822 126 13691 27pF 1% 63V 2120 5322 122 32659 33pF 5% 50V 2122 5322 126 10465 3,9nF 10% 63V 2125 4822 121 10578 560P 1% 630V 2127 4822 122 32927 220nF +80/-20% 50V 2128 4822 124 41579 10µF 20% 50V 2129 4822 124 40242 1µF 20% 63V 2130 4822 126 11585 22nF +80/-20% 25V 2131 4822 122 33325 470nF 16V 2132 4822 122 33325 470nF 16V 2133 4822 124 40242 1µF 20% 63V 2134 4822 126 13188 15nF 5% 63V 2135 4822 122 32927 220nF +80/-20% 50V 2136 4822 126 13188 15nF 5% 63V 2137 4822 122 32927 220nF +80/-20% 50V 2138 4822 124 41576 2,2µF 20% 50V 2140 4822 121 51252 470nF 5% 63V 2141 4822 122 31947 100nF 20% 63V 2142 4822 122 31947 100nF 20% 63V 2143 4822 122 32927 220nF +80/-20% 50V 2144 4822 124 40242 1µF 20% 63V 2145 4822 122 33575 220pF 5% 50V 2147 4822 122 33575 220pF 5% 50V 2148 4822 122 33809 22nF 20% 50V 2150 4822 122 31947 100nF 20% 63V 2151 4822 126 14236 50V 15pF 5% 2152 4822 126 13695 82pF 1% 63V 2158 4822 122 31947 100nF 20% 63V 2160 4822 122 32139 12pF 2% 63V 2161 5322 122 34123 1nF 10% 50V 2162 4822 124 81151 22µF 50V RESISTORS 3103 4822 051 20008 0R Jumper 0805 3104 4822 051 10102 1k 2% 0,25W 3107 4822 051 20829 82R 5% 0,1W 3108 4822 117 11449 2k2 1% 0,1W 3109 4822 117 11449 2k2 1% 0,1W 3123 4822 051 10008 0R 5% 0,25W 3124 4822 051 10008 0R 5% 0,25W 3125 4822 116 83864 10k 5% 0,5W 3128 4822 116 52256 2k2 5% 0,5W 3129 4822 051 20008 0R Jumper 0805 3130 4822 051 10008 0R 5% 0,25W 3131 4822 051 10008 0R 5% 0,25W 3132 4822 051 20008 0R Jumper 0805 3134 4822 051 20223 22k 5% 0,1W 3137 4822 117 10833 10k 1% 0,1W 3138 4822 051 20008 0R Jumper 0805 3139 4822 051 10008 0R 5% 0,25W 3140 4822 051 20331 330R 5% 0,1W 3141 4822 051 20563 56k 5% 0,1W 3142 4822 100 11163 Trimmer 100k 30% 0,1W 3143 4822 051 20223 22k 5% 0,1W 3144 4822 051 10102 1k 2% 0,25W 3145 4822 117 11449 2k2 1% 0,1W 3146 4822 051 20479 47R 5% 0,1W 3150 4822 051 20472 4k7 5% 0,1W 3151 4822 051 20683 68k 5% 0,1W 3152 4822 051 20471 470R 5% 0,1W 3153 4822 051 20471 470R 5% 0,1W 3154 4822 116 83872 220R 5% 0,5W 3155 4822 116 52219 330R 5% 0,5W 3158 4822 116 83883 470R 5% 0,5W 3159 4822 116 83883 470R 5% 0,5W 3160 4822 116 83883 470R 5% 0,5W 3161 4822 116 83883 470R 5% 0,5W 3162 4822 051 20224 220k 5% 0,1W 3163 4822 051 10008 0R 5% 0,25W 3164 4822 052 10478 ! 4R7 5% 0,33W 3165 4822 051 10008 0R 5% 0,25W 3167 4822 116 83872 220R 5% 0,5W 3169 4822 051 20008 0R Jumper 0805 3171 4822 051 20008 0R Jumper 0805 3172 4822 051 10008 0R 5% 0,25W 3173 4822 051 20008 0R Jumper 0805 3176 4822 051 20008 0R Jumper 0805 3177 4822 051 20223 22k 5% 0,1W 3181 4822 051 10008 0R 5% 0,25W 3183 4822 051 10008 0R 5% 0,25W 3184 4822 051 10008 0R 5% 0,25W 3185 4822 051 10008 0R 5% 0,25W 3186 4822 051 10102 1k 2% 0,25W 3188 4822 051 10008 0R 5% 0,25W 3192 4822 051 20008 0R Jumper 0805 3197 4822 051 20472 4k7 5% 0,1W COILS & FILTERS 5102 4822 157 71634 MW AERIAL 5103 4822 157 71635 LW AERIAL 5107 4822 157 11443 FM Discriminator 10,7MHz 5109 4822 157 71639 Ceram Filter 10,7MHz 5110 4822 242 70665 Ceram Filter 10,7MHz 5111 4822 158 60511 AM-IF Filter 450kHz 5112 4822 157 70302 AM-IF Filter 450kHz 5114 4822 157 70302 AM-IF Filter 450kHz 5115 4822 157 71636 Anti-Birdy Filter 5121 4822 242 10261 X’tal Resonator 75kHz 5122 4822 157 60517 RF Coil AM 5123 4822 157 60517 RF Coil AM DIODES 6105 4822 130 83075 HN1V02H-B 6107 4822 130 34488 BZX79-B11 6120 4822 130 30621 1N4148 TRANSISTORS & INTEGRATED CIRCUITS 7101 4822 209 90315 TEA5762H/V1 7103 4822 130 42513 BC858C 7104 5322 130 44779 BC338-40 7105 5322 130 44779 BC338-40 7109 5322 130 41983 BC858B 7110 5322 130 41983 BC858B 7122 5322 130 42136 BC848C 7124 5322 130 42136 BC848C Note: Only the parts mentioned in this list are normal service spare parts. Untitled-2 6/23/98, 1:51 PM 2 CD BOARD NAMI 8 8-1 8-1 BLOCK DIAGRAM TABLE OF CONTENTS Block diagram .................................................................. 8-1 Component layout ............................................................ 8-2 Circuit diagram ................................................................. 8-3 Parts list ........................................................................... 8-4 SAA7372 CD7 BCLK WCLK SDA HFIN LDON DISC PHOTO DIODE ARRAY TURNTABLE MOTOR TRACK SERVO FOCUS SERVO SLIDE SERVO F E FLEX PCB A/D-CONVERTER SERIAL INTERFACE µP INTERFACE CONTROL PART EBU INTERFACE RAM ADDRESS. SUBCODE PROCESS. MOTOR CONTROL OUTPUT STAGES ERROR CORRECT. FRONT END TIMING DIGITAL PLL SRAM EFM DEMOD. Vref KILL PRE-PROC. FUNCTION CONTROL VERSATILE INTERFACE AUDIO PROCESS. PEAK DET. RA (PWM signal) RA FO SL FO (PWM signal) SL (PWM signal) TRACK FOCUS DISC Motor- DISC Motor+ SLIDE Motor+ SLIDE Motor- FOCUS Servo+ FOCUS Servo- TRACK Servo+ TRACK Servo- SLIDE DISC MOTOR MOTO1 (from CD7) MOTO2 (from CD7) L.P.F. L.P.F. L.P.F. MOTO2 MOTO1 8.4672MHz DOBM RESET SDA WCLK left channel MSB LSB MSB LSB right channel BCLK TRANSFER OF AUDIO SAMPLES VIA SERIAL INTERFACE OF CD7 CD7 ∅ DAC CD - Drive CD94V5B1 TDA7073AT MOTOR DRIVER TDA7073AT MOTOR DRIVER Q251 Q252 +5V SERIAL DATA INTERFACE D/A D/A DAC TDA1311AT DATA RESET SILD SICL RAB +5V +4.5V SUPPLY FOR TDA1311 Left out Right out Q401 Q425 J204 +8V +5V SUPPLY & AUDIO INTERFACE CONTROL INTERFACE A C D B Q201 Q221 J203 NC NC NC F TDA1300T HF-AMPLIFIER L.P.F. H.P.F. + LASER SUPPLY & PROTECT. E A C F D B E A C F D B LDON VDD MI Laser diode Monitor diode L.P.F. L.P.F. L.P.F. L.P.F. L.P.F. L.P.F. LO RN5RL3AA TDA1308 Q451 L.P.F. L.P.F. +4.5V +5V +8V KILL 8-2 8-2 NAMI 8 BOARD component side view NAMI 8 BOARD copper side view C201C3 C202C3 C203C4 C204C4 C205C3 C206C3 C207C4 C208C4 C210C4 C211C4 C212B4 C213C4 C214D3 C215C2 C217C3 C218D2 C219D3 C221C3 C222C3 C223B4 C224C4 C225B4 C226B4 C229C5 C230B4 C233B3 C234A3 C235B3 C236B3 C237B3 C238D1 C239D1 C240C1 C249D5 C250D5 C251C4 C252C4 C253C5 C254C5 C255C5 C256C5 C257B4 C258B5 C261B5 C262B5 C263A4 C265B4 C266B4 C267B4 C268B4 C271C4 C272C4 C401A3 C402A3 C411A3 C412A3 C413B2 C414B2 C425A4 C451A2 C452A2 C453A2 C454A2 C455B2 C456B2 C457B2 C458B2 C459A2 C460A2 C461A2 C475A4 D221B3 F201 D5 F202 C2 F203 C1 F204 B1 F205 A1 F206 B1 F207 D5 F208 D5 F411 B2 F412 B2 J201 D2 J202 A5 J203 A1 J204 C1 J205 B5 J206 A1 L221 C3 L451 C2 Q201C3 Q221B3 Q251C4 Q252A4 Q271C4 Q401A3 Q425A4 Q451A2 Q471B2 Q475B2 R201C4 R202C4 R203C3 R204C3 R205C4 R206C4 R209C4 R210D3 R211D3 R212D3 R213D3 R214C3 R215D2 R216C3 R217C4 R219C4 R220C4 R222B4 R223B4 R224B4 R225B3 R229B3 R230B4 R231B4 R232B4 R233B4 R234B4 R235B4 R236A4 R237A3 R238A3 R240B3 R241B3 R242C4 R251C4 R252C4 R253C4 R254C5 R255C5 R256C5 R257C5 R258C5 R259B4 R260B5 R261B5 R262B5 R263B5 R264B4 R265B4 R267B4 R268D5 R269C4 R271C4 R272C3 R281C3 R282C4 R283C3 R284C3 R286A3 R411A3 R412B2 R413B2 R414B2 R415B2 R416B2 R417B2 R418C2 R419C2 R420C2 R421C2 R422C2 R423A4 R425A4 R426A2 R451A2 R452A2 R453A2 R454A2 R455B2 R456A2 R457B2 R458A2 R459A2 R460B2 R461B2 R462B2 R471B2 R472B1 R475B1 R476C3 X221B5 A B C D E A B C D E 2 3 4 5 1 2 3 4 5 1 A B C D E A B C D E 5 4 3 2 1 5 4 3 2 1 8-3 8-3 CD BOARD NAMI 8 CD94V5B1 TDA1311AT 32 (5-BIT) CALIBRATED CURRENT SOURCES 1 CALIBRATED SPARE SOURCE 11-BIT PASSIVE DIVIDER LEFT BIT SWITCHES 6 I/V LEFT INPUT REGISTER LEFT OUTPUT REGISTER RIGHT BIT SWITCHES RIGHT INPUT REGISTER RIGHT OUTPUT REGISTER 8 I/V 32 (5-BIT) CALIBRATED CURRENT SOURCES 1 CALIBRATED SPARE SOURCE 11-BIT PASSIVE DIVIDER REFERENCE SOURCE CONTROL AND TIMING 1 2 3 5 4 VDD VOR IOR VOL WS DATA IOL GND BCK TDA1311A C201 C8 C202 C9 C203 D8 C204 C8 C205 C9 C206 C9 C207 D8 C208 C8 C210 E8 C211 E10 C212 E10 C213 E9 C214 B5 C215 A4 C217 C7 C218 C3 C219 A4 C222 C9 C223 F10 C224 F10 C225 F10 C226 F11 C230 F12 C233 B13 C234 B12 C235 B12 C236 B11 C237 B10 C238 J13 C239 J13 C240 J14 C245 I7 C249 J14 C250 J14 C251 E5 C252 E6 C253 E5 C254 E5 C255 F5 C256 F6 C257 E6 C258 E7 C261 G5 C262 G6 C263 G5 C265 H5 C266 H5 C267 G6 C268 H6 C271 D7 C401 J7 C402 J7 C411 J8 C412 I8 C413 J11 C414 I11 C451 J10 C452 I9 C453 J10 C454 I10 C455 J10 C456 I10 C459 J9 C460 J10 C461 J11 D221 B11 F201 J14 F202 J14 F203 I14 F204 I14 F207 B14 F411 J12 F412 I12 J201 B3 J202 F3 J203 B14 J204 I14 J205 F14 J206 A14 L221 B9 Q201 C5 Q221 D11 Q251 E4 Q252 G4 Q401 J7 Q425 H7 Q451 I10 R201 C8 R202 D8 R203 D8 R204 C8 R205 C8 R206 D8 R209 E9 R210 E9 R211 B5 R212 A4 R213 B4 R214 C4 R215 A5 R216 B8 R217 B8 R219 E8 R220 D9 R222 D9 R223 F10 R224 E10 R225 E11 R229 B10 R231 E11 R232 E11 R233 E11 R234 E12 R235 E12 R236 E12 R238 C12 R239 C12 R240 C12 R241 B12 R242 B11 R251 E5 R252 E5 R253 E5 R254 E6 R255 F5 R256 F5 R257 F5 R258 F6 R259 D6 R260 E6 R261 G5 R262 G5 R263 G5 R264 G6 R265 H5 R267 H6 R268 H6 R271 D7 R272 E8 R411 J8 R412 I8 R413 J11 R414 I11 R415 J12 R416 I12 R417 J12 R418 I12 R420 I13 R421 I13 R422 I13 R425 I7 R426 I7 R451 J9 R452 I9 R453 J10 R454 I10 R455 J10 R456 I9 R459 I9 R460 J9 X221 E10 8-4 8-4 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) PD04-CD SERVO DECODER DAC CIRCUIT BOARD PD04-CAPACITORS C201 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C202 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C203 4822 126 12495 CER. CHIP 1500pF ±10% DK96152300 C204 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C205 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C206 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C207 4822 126 14249 CER. CHIP 560PF ±10% DK96561300 C208 4822 126 13883 CER. CHIP 220pF ±5% CG 50V DD95221300 C210 4822 122 33788 CER. CHIP 82PF ±5% DD95820300 C212 4822 126 11567 CER. CHIP 0.022µF ±10% XTR DK96223200 C213 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C214 4822 126 12516 CER. CHIP 1000pF ±10% B 50V DK96102300 C215 4822 124 11131 ELECT CHIP 47µF 6.3V EY47600620 C217 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C218 4822 126 11567 CER. CHIP 0.022µF ±10 % XTR DK96223200 C219 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C221 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C222 4822 124 11131 ELECT CHIP 47µF 6.3V EY47600620 C223 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C224 4822 126 11669 CER. CHIP 27pF ±5% DD95270300 C225 4822 126 11669 CER. CHIP 27pF ±5% DD95270300 C226 4822 122 33777 CER. CHIP 47pF ±5% C6 50V DD95470300 C233 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C234 4822 124 11131 ELECT CHIP 47µF 6.3V EY47600620 C236 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C237 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C238 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C239 4822 124 11432 ELECT CHIP 100µF 10V EY10701020 C251 4822 126 11685 CER. CHIP 4700pF ±10% DK96472300 C252 4822 126 11568 CER. CHIP 470pF ±10% DK96471300 C253 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C254 4822 124 11432 ELECT CHIP 100µF 10V EY10701020 C255 4822 126 11685 CER. CHIP 4700pF ±10% DK96472300 C256 4822 126 11568 CER. CHIP 470pF ±10% DK96471300 C257 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C258 4822 124 11131 ELECT CHIP 47µF 6.3V EY47600620 C261 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C262 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C263 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C265 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C268 C271 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 C401 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C402 4822 124 11432 ELECT CHIP 100µF 10V EY10701020 C411 4822 124 11074 ELECT CHIP 10µF 16V EY10601620 C412 4822 124 11074 ELECT CHIP 10µF 16V EY10601620 C413 4822 126 14249 CER. CHIP 560PF ±10% DK96561300 C414 4822 126 14249 CER. CHIP 560PF ±10% DK96561300 C425 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C451 4822 126 11568 CER. CHIP 470pF ±10% DK96471300 C452 4822 126 11568 CER. CHIP 470pF ±10% DK96471300 C453 4822 126 11759 CER. CHIP 100PF ±5% DD95101300 C454 4822 126 11759 CER. CHIP 100PF ±5% DD95101300 C455 4822 124 11074 ELECT CHIP 10µF 16V EY10601620 C456 4822 124 11074 ELECT CHIP 10µF 16V EY10601620 C459 4822 124 11226 ELECT CHIP 22µF 6.3V EY22600620 C460 4822 126 11687 CER. CHIP 0.1µF +80%-20% DK98104200 C461 4822 124 11226 ELECT CHIP 22µF 6.3V EY22600620 PD04-RESISTORS R201 4822 051 30103 CHIP 10kΩ ±5% 1/16W NN05103610 R206 R209 4822 126 12339 CER. 2200PF 10% DK96222300 R210 4822 051 30223 CHIP 22kΩ ±5% 1/16W NN05223610 R212 4822 051 30332 CHIP 3.3kΩ ±5% 1/16W NN05332610 R213 4822 051 30223 CHIP 22kΩ ±5% 1/16W NN05223610 R214 4822 051 30104 CHIP 100kΩ ±5% 1/16W NN05104610 R215 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R219 4822 051 30472 CHIP 4.7kΩ ±5% 1/16W NN05472610 R222 4822 051 30224 CHIP 220kΩ ±5% 1/16W NN05224610 R223 4822 051 30105 CHIP 1MΩ ±5% 1/16W NN05105610 R224 4822 051 30151 CHIP 150Ω ±5% 1/16W NN05151610 R225 4822 051 30471 CHIP 470Ω ±5% 1/16W NN05471610 R229 4822 051 30223 CHIP 22kΩ ±5% 1/16W NN05223610 R231 4822 116 83208 CHIP 12kΩ ±5% 1/16W NN05123610 R232 4822 051 30223 CHIP 22kΩ ±5% 1/16W NN05223610 R233 4822 116 83208 CHIP 12kΩ ±5% 1/16W NN05123610 R235 4822 051 30273 CHIP 27kΩ ±5% 1/16W NN05273610 R236 4822 051 30273 CHIP 27kΩ ±5% 1/16W NN05273610 R238 4822 051 30471 CHIP 470Ω ±5% 1/16W NN05471610 R239 4822 051 30471 CHIP 470Ω ±5% 1/16W NN05471610 R240 4822 051 30471 CHIP 470Ω ±5% 1/16W NN05471610 R241 4822 051 30222 CHIP 2.2kΩ ±5% 1/16W NN05222610 R242 4822 051 30101 CHIP 100Ω ±5% 1/16W NN05101610 R251 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R253 4822 051 30103 CHIP 10kΩ ±5% 1/16W NN05103610 R254 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R255 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R257 4822 051 30103 CHIP 10kΩ ±5% 1/16W NN05103610 R258 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R259 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R260 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R261 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R263 4822 051 30103 CHIP 10kΩ ±5% 1/16W NN05103610 R264 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R265 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R267 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R268 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R271 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R272 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R411 4822 051 30332 CHIP 3.3kΩ ±5% 1/16W NN05332610 R412 4822 051 30332 CHIP 3.3kΩ ±5% 1/16W NN05332610 R413 4822 051 30104 CHIP 100kΩ ±5% 1/16W NN05104610 R414 4822 051 30104 CHIP 100kΩ ±5% 1/16W NN05104610 R415 4822 051 30471 CHIP 470Ω ±5% 1/16W NN05471610 R418 R419 FERRITE BEADS BK1608HM102-T FC90020120 R420 FERRITE BEADS BK1608HM102-T FC90020120 R421 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R422 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R423 4822 116 82487 CHIP 0Ω ±5% 1/16W NN05000610 R425 4822 117 11374 CHIP 120kΩ ±1% 1/10W NI01124110 R426 4822 117 12024 CHIP 27kΩ ±1% 1/10W NI01273110 R451 4822 051 30223 CHIP 22kΩ ±5% 1/16W NN05223610 R456 R459 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 R460 4822 051 30102 CHIP 1kΩ ±5% 1/16W NN05102610 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) PD04-SEMICONDUCTORS D221 4822 130 83715 CHIP DIODE 1SS301 DAN202U HZ21005000 Q201 4822 209 16855 IC TDA1300T HF AMP AND LASER CONT HC10172490 Q221 4822 209 91174 IC SAA7372GP SERVO HC10132490 Q251 4822 209 16372 IC TDA7073AT DUAL BTL DRIVER HC10165490 Q252 4822 209 16372 IC TDA7073AT DUAL BTL DRIVER HC10165490 Q401 4822 209 32196 IC TDA1311AT CC-DAC HC10173490 Q425 4822 209 15595 IC RN5RL35AA V-REGULATOR 3.5V HC10021770 Q451 4822 209 33165 IC TDA1308 POWER OP AMP HC10138490 PD04-MISCELLANEOUS F201 4822 157 10313 HF50ACC453215 FN31020010 F207 L221 4822 157 53872 CHIP INDUCTANCE NL322522-100K LU12103010 WD01 4822 320 12646 JUMPER LEAD FFC YU15073500 X221 4822 242 11017 CRYSTAL CM309S 8.4672MHz JX08001320 9-1 9. EXPLODED VIEW AND PARTS LIST Z 0 0 5 ( F , U O N L Y ) Z 0 0 4 Z 0 0 4 0 2 2 T 0 2 1 T Z0 0 2 0 0 8 T Z0 0 1 0 0 3 S 0 0 1 T, 0 2 0 T 0 0 2 T, 0 0 3 T( U ONL Y) 0 1 4 T( F ONL Y) Z0 0 6 ( K ONL Y) Z0 0 4 0 1 7 S 0 1 8 S 0 0 6 S 0 0 4 S 0 1 6 S 0 0 5 S 0 1 5 S /2 VERSI ON 0 0 1 T, 0 2 0 T 0 0 1 T Z0 0 2 Z0 0 4 Z0 0 1 0 0 7 Sx 2 0 0 1 S 0 0 3 T F ONL Y 0 0 8 Sx 2 0 2 0 S ( /2, F, K, KK) 0 0 1 S 0 0 9 Sx 2 Z0 1 0 MR2 0 2 0 L S2 0 2 1 MR2 0 2 1 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) PACKING 001T F USER GUIDE 298J851110 001T K USER GUIDE 298J851350 001T KK USER GUIDE 298J851360 001T /2 4822 736 16729 USER GUIDE 298J851310 001T U USER GUIDE 298J851250 Z001 REMOTE COMMANDER RC2020MR ZK298J0010 NOT STANDARD SPARE PARTS 001S F,U PACKING CASE MR2021 298J801010 003S F,U CUSHION L 298J809010 004S F,U CUSHION R 298J809020 020S F MASTER CARTON CASE MR2020 298J801030 010T CLAMPER ASSY 298J005500 014T F USER?S CARD 145J865210 020T F LABEL FLY SHEET JAPANESE 298J861110 020T /2,K, KK,U LABEL FLY SHEET ENGL1S4 298J861120 021T /2 SHEET FOR REMOCON ETC 298J107040 055T SCHEMATIC DIAGRAM 298J493A00 Z001 REMOTE COMMANDER RC2020MR ZK298J0010 Z002 F BATTERY UM-4NEPH/2S ZF24302000 Z003 AM LOOP ANTENNA LA-700HB LA00055020 Z004 F 4822 303 30314 FM FEEDER ANTENNA ZA02000070 Z004 /2,K, KK FM ANTENNA 931222R ZA02800020 Z004 U 4822 303 30314 FM FEEDER ANTENNA ZA02000070 Z005 F,U 4822 264 30265 PLUG ANT ADAPTER FM YP90000310 Z006 K 4822 265 10092 JACK AC ADAPTER S-I6116 PLRTY YJ04001240 Z007 F,K,KK SPEAKER BOX SPK SYSTEM AS20100180 Z007 U SPEAKER BOX SPK SYSTEM AS20100190 Z008 BADGE MARANTZ 354H251230 Z010 F, PACKING CASE FOR SPEAKER LS2021 298J801020 9-2 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) 001B F,K,KK, U FRONT PANEL ASSY 298J248510 001B /2 4822 466 12193 FRONT PANEL ASSY 298J248500 002B F,K,KK, U FRONT PANEL 298J248020 002B /2 FRONT PANEL 298J248010 003B 4822 45010615 WINDOW FL 298J158040 005B LENS SENSOR 298J355020 009B LENS DSC SENS 298J355030 011B 4822 410 12282 BUTTON TOP 298J270010 018B 4822 532 11388 T.L. WASHER FOR W802 54050300R0 023B SCREW FOR CD MECHA 183J010010 031B 4822 404 10992 SUSTAINER L 298J106020 032B 4822 404 10991 SUSTAINER R 298J106030 033B P.H.M. SCREW FOR SUSTAINER+PANEL 51250308U0 034B 4822 520 10859 SUSTAINER BEARING 298J106060 037B 4822 528 11315 CAM L 298J054010 039B 4822 528 11316 CAM R 298J054020 041B 4822 502 13315 B.T.SCREW W/TL FOR CUM+PANEL 51290308M0 043B P.H. B TITE 1 SCREW FOR CUM+SENSOR 51900208U0 049B WASHER FOR CD MECHA REAR 298J012010 052B COVER FOR GEAR ASSY 298J053020 055B BUFFER FOR CD 298J056070 001D F,K,KK, U WINDOW F 298J158030 001D /2 4822 466 10616 WINDOW N 298J158010 003D 4822 466 12194 LID 298J257010 004D BUFFER FOR LID 298J056020 005D 4822 402 11277 LEVER ASSY 298J354500 010D STICKER ADHESIVE FOR 011D 298J122010 011D 4822 462 11164 CAP FOR WINDOW 298J067030 012D 4822 402 11278 BRACKET ROLLER ASSY L 298J160520 013D 4822 402 11279 BRACKET ROLLER ASSY R 298J160530 015D ROLLER LID 298J358010 016D ROLLER LID 298J358010 019D 4822 530 70122 RG RING E RING 64000200R0 020D 4822 530 70122 RG RING E RING 64000200R0 041D P.H.M. SCREW FOR RETAINER 51250305U0 047D 4822 522 10751 GEAR FOR LID 298J058020 049D 4822 502 13315 B.T.SCREW W/TL FOR GEAR+LID 51290308M0 053D P.H.M. SCREW FOR LID 51250305U0 067D BUFFER FOR SHIELD 345S056030 001G 4822 442 01753 CASE BOTTOM 298J064010 003G 4822 381 12069 LENS IR 298J355010 005G 4822 410 12283 BUTTON FRONT STANDBY 298J270020 007G 4822 410 12282 BUTTON FRONT OPEN/CLOSE 298J270030 021G 4822 462 11165 LEG FRONT 298J057010 023G 4822 502 13315 B.T.SCREW W/TL FOR LEG FRONT+BOTTOM CASE 51290308M0 025G 4822 462 11166 LEG REAR 298J057020 026G 4822 462 11167 LEG FOR FRONT 298J057050 027G 4822 462 11168 LEG FOR REAR 298J057030 028G 4822 535 10629 PIN FOR FRONT LEG 298J254020 029G 4822 535 10631 PIN FOR REAR LEG 298J254010 030G LEG SUB 298J057040 037G 4822 522 10752 GEAR E 298J058010 049G 4822 442 01754 LID BOTTOM 298J257020 901G F REAR PANEL 298J250020 901G K REAR PANEL 298J250040 901G KK REAR PANEL 298J250050 901G /2 REAR PANEL 298J250010 901G U REAR PANEL 298J250030 917G 4822 532 60948 BUSHING AC MAINS 450H259010 001M 4822 522 10753 MECHANISM GEAR ASSY 298J304510 002M 4822 361 30368 D.C MOTOR MM00460020 011M 4822 522 10754 GEAR A 298J058100 013M 4822 522 10755 GEAR B 298J058110 015M 4822 522 10756 GEAR C 298J058120 017M 4822 522 10757 GEAR D 298J058130 019M PULLEY 298J262100 021M SHAFT A 298J112100 023M SHAFT B 298J112110 027M 4822 358 10273 BELT 298J264100 041M 4822 691 10781 MECHANISM CD MECHA ASSY 298J304500 045M 4822 529 10428 DAMPER SUSPENSION RUBBER A 298J130010 047M 4822 529 10429 DAMPER SUSPENSION RUBBER B 298J130020 049M COVER CD MECHA 298J053010 FH01 /2 FERRITE CORE ZCAT1325-0530A CLAMP FC50200020 L001 F MAINS TRANSF. AC100V TS17206010 L001 K MAINS TRANSF. AC110-220V TS17206040 L001 KK MAINS TRANSF. AC220V TS17206050 L001 /2 4822 146 11124 MAINS TRANSF. AC230V TS17206030 L001 U MAINS TRANSF. AC120V TS17206020 M001 4822 361 11159 D.C MOTOR BRUSHLESS FAN KD1204PFB2-8 MM01200290 M705 LEAF SPRING 298J116010 SS21 4822 271 30768 MINI SW. DOOR CLOSE SM01011530 SS22 4822 271 30768 MINI SW. DOOR OPEN SM01011530 WU03 4822 320 12647 JUMPER LEAD 8P FFC JS02-JS11 YU08238500 WU04 4822 320 12648 JUMPER LEAD 13P FFC JU10-JS01 YU13268500 W001 F 4822 321 11359 A.C MAINS CORD YC01800800 W001 K,U A.C MAINS CORD AC250V 10A YC01800880 W001 KK A.C MAINS CORD 3A 250V YC02000820 W001 /2 4822 321 11343 A.C MAINS CORD YC01800790 9-3 9-3 0 1 0 Dx 8 0 0 1 D 0 9 1 G U ONL Y 0 0 3 B 0 0 1 B PANEL ASSY. 0 3 1 B 0 3 7 G 9 2 6 G ( 0 0 2 B) 0 3 9 G 0 3 7 G 0 3 4 Bx 2 0 3 2 B 5 1 2 8 3 X8 ( U ) x 4 0 5 5 B ( 0 0 5 B) 0 1 1 B ( 0 0 9 B) 0 1 1 B 0 1 1 Dx 4 0 5 7 D 5 1 2 5 3 X5 ( U) x 8 0 3 9 Dx 8 0 5 5 D 0 6 4 D PS0 4 0 6 3 Dx 4 0 0 5 Dx 4 L EVER ASSY. 0 6 5 D 0 6 5 D PS1 4 5 1 2 5 3 X5 ( U) 0 5 1 D 0 6 4 Dx 2 0 1 2 D 0 4 8 Dx 2 ( 0 2 0 D) 0 2 5 D ( 0 2 1 D) ( 0 1 6 D) ( 0 1 8 D) 0 4 7 D 0 0 4 Dx 4 0 2 9 D 5 1 2 9 3 X8 ( M) x 4 0 0 3 D 0 2 5 D ( 0 2 3 D) ( 0 1 7 D) 0 5 9 D 0 1 3 D BRACKET ASSY. ( 0 1 5 D) ( 0 1 9 D) 5 1 5 0 3 X8 ( U) x 4 0 4 7 D 5 1 5 0 3 X8 ( U) 0 6 1 D 5 1 5 0 2 X8 ( U) 0 3 5 D BRACKET ASSY. 0 3 7 B 5 1 2 9 3 X8 ( M) 5 1 2 8 3 X8 ( M) 0 0 4 G 5 1 2 9 3 X8 ( M) 0 7 8 Gx 2 0 0 5 G 0 4 9 G 0 2 1 G K ONL Y 0 5 7 G 0 3 9 B 0 3 0 G 5 1 2 8 3 X8 ( U) PS5 4 5 1 2 8 3 X1 2 ( U) 0 0 1 G 5 1 2 8 3 X1 2 ( U) 0 9 0 Gx 2 0 8 5 G 5 1 2 8 3 X1 2 ( U) 0 2 7 Gx 2 0 2 9 Gx 2 0 2 5 Gx 2 5 1 2 9 3 X8 ( M) 0 2 1 G 0 2 6 Gx 2 0 2 8 Gx 2 5 1 2 8 3 X1 2 ( U) x 8 PH0 4 5 1 2 8 3 X8 ( M) PS6 4 5 1 9 0 2 X8 ( U) 5 1 2 9 3 X8 ( M) U V E RS I ON ( B OT T OM C A B . ) / 0 2 & K V E R S I O N 0 7 4 G 0 7 5 G 0 6 9 G 0 7 0 G 0 7 2 G 0 0 3 G 5 1 2 8 3 X6 ( U) 0 9 0 G 0 0 7 G 9 1 9 G P S 7 4 W0 0 1 9 0 1 G 5 1 2 8 3 X8 ( U) 9 0 7 G 5 1 2 8 3 X8 ( M) 9 1 7 G 9 0 9 G 5 1 2 8 3 X8 ( U) 9 2 3 G 9 2 5 G 0 4 9 M 0 4 5 M x 2 5 1 3 0 2 X6 ( A) 0 4 1 M 0 4 7 M x 2 0 4 9 Bx 2 PD0 4 0 2 3 Bx 4 0 2 6 Bx 2 5 1 2 8 3 X8 ( M) PX0 4 5 1 2 8 3 X8 ( M) 0 4 7 G 5 4 0 5 3 ( R) 0 4 7 B F ONL Y PA0 4 5 1 2 8 3 X8 ( M) 0 1 0 B PU0 4 0 8 7 G VU0 1 M7 0 7 5 1 2 8 3 X8 ( U) 0 3 5 B 0 1 5 Bx 2 5 1 2 8 3 X1 0 ( M) M7 0 5 M7 0 1 5 1 1 0 4 X8 ( U) L 0 0 1 5 1 1 0 3 X1 5 ( U) 0 0 9 G M0 0 1 P7 0 4 5 1 2 8 3 X8 ( M ) 5 1 2 8 3 X8 ( M) 0 4 5 B /02 ONLY 5 1 2 8 3 X8 ( M) A0 0 1 0 2 8 Bx 2 PX5 4 0 5 0 B 5 1 2 8 3 X8 ( M) ( 0 0 2 M) ( 0 2 5 M) ( 0 1 5 M) ( 0 2 7 M) ( 0 0 7 M) ( 0 0 3 M) ( 0 1 9 M) ( 0 2 1 M) ( 0 1 1 M) ( 5 1 1 0 ) 2 . 6 X4 ( A) ( 5 1 1 0 ) 2 . 6 X4 ( A) ( 5 1 1 0 ) 3 X6 ( M) ( 0 1 7 M) ( 0 1 3 M) ( 0 2 3 M) ( 0 0 4 M) ( 0 0 5 M) ( 0 0 6 M) x 2 5 1 2 8 3 X1 2 ( U) 0 6 7 G 0 6 5 G 0 0 1 M GEER ASSY. SYMBOL STYL E PARTS NAME 5 1 1 0 5 1 2 5 5 1 2 8 5 1 2 9 5 1 3 0 5 1 5 0 5 1 9 0 5 4 0 5 +B. H. M. SCREW +B. H. TAP TI TE SCREW( P TYPE) +B. H. TAP TI TE SCREW( B TYPE) +B. H. TAP TI TE SCREW( W/ T. L . WASHER) +P. H. TAP TI TE SCREW( B TYPE) +F. H. TAP TI TE SCREW( B TYPE) + P. H. TAP TI TE SCREW( B TYPE) TOOTHED L OCK WASHERS MARK MATERI AL / FI NI SH ( M) STEEL / COPPER ( U) STEEL / BL ACK ( A) STEEL / CHROMATE ( R) STEEL / UNI CHROMATE Z 0 0 1 SS21 SS22 TUNER CD NAMI 8 ( 0 2 9 M) 10. ELECTRICAL PARTS LIST The suppliers and their type numbers of fusible resistors are as follows; 1. KOA Corporation Part No. (MJI) Type No. (KOA) Description NH05 × × × 140 RF25S × × × × ΩJ (±5% 1/4W) NH05 × × × 120 RF50S × × × × ΩJ (±5% 1/2W) NH85 × × × 110 RF73B2A × × × × ΩJ (±5% 1/10W) NH95 × × × 140 RF73B2E × × × × ΩJ (±5% 1/4W) 2. Matsushita Electronic Components Co., Ltd Part No. (MJI) Type No. (MEC) Description NF05 × × × 140 ERD-2FCJ × × × (±5% 1/4W) RF05 × × × 140 NF02 × × × 140 ERD-2FCG × × × (±2% 1/4W) RF02 × × × 140 Examples ; Resistance value 0.1 Ω.... 001 10 Ω .... 100 1 kΩ .... 102 100 kΩ.... 104 0.5 Ω.... 005 18 Ω .... 180 2.7 kΩ .... 272 680 kΩ.... 684 1 Ω.... 010 100 Ω .... 101 10 kΩ .... 103 1 MΩ.... 105 6.8 Ω.... 068 390 Ω .... 391 22 kΩ .... 223 4.7 MΩ.... 475 ASSIGNMENT OF COMMON PARTS CODES. RESISTORS R : 1) GD05 × × × 140, Carbon film fixed resistor, ±5% 1/4W R : 2) GD05 × × × 160, Carbon film fixed resistor, ±5% 1/6W Examples ; Resistance value 0.1 Ω.... 001 10 Ω .... 100 1 kΩ .... 102 100 kΩ.... 104 0.5 Ω.... 005 18 Ω .... 180 2.7 kΩ .... 272 680 kΩ.... 684 1 Ω.... 010 100 Ω .... 101 10 kΩ .... 103 1 MΩ.... 105 6.8 Ω.... 068 390 Ω .... 391 22 kΩ .... 223 4.7 MΩ.... 475 Note : Please distinguish 1/4W from 1/6W by the shape of parts used actually. CAPACITORS C : CERAMIC CAP. 3) DD1 × × × × 370, Ceramic capacitor Disc type Temp.coeff.P350 N1000, 50V Examples ; Tolerance (Capacity deviation) ±0.25 pF .... 0 ±0.5 pF .... 1 ±5% .... 5 Tolerance of COMMON PARTS handled here are as follows : 0.5 pF 5 pF .... ±0.25 pF 6 pF 10 pF .... ±0.5 pF 12 pF 560 pF .... ±5% Capacity value 0.5 pF .... 005 3 pF ....030 100 pF .... 101 1 pF .... 010 10 pF ....100 220 pF .... 221 1.5 pF .... 015 47 pF ....470 560 pF .... 561 C : CERAMIC CAP. 4) DK16 × × × 300, High dielectric constant ceramic capacitor Disc type Temp.chara. 2B4, 50V Examples ; Capacity value 100 pF .... 101 1000 pF ....102 10000 pF ....103 470 pF .... 471 2200 pF ....222 C : 5) ELECTROLY CAP. ( ), 6) FILM CAP. ( ) 5) EA × × × × × × 10, Electrolytic capacitor One-way lead type, Tolerance ±20% Examples ; Capacity value 0.1 µF ....104 4.7 µF ....475 100 µF ....107 0.33 µF ....334 10 µF ....106 330 µF ....337 1 µF ....105 22 µF ....226 1100 µF ....118 2200 µF ....228 Working voltage 6.3V ....006 25V ....025 10V ....010 35V ....035 16V ....016 50V ....050 6) DF15 × × × 350 Plastic film capacitor DF15 × × × 310 One-way type, Mylar ±5% 50V DF16 × × × 310 Plastic film capacitor One-way type, Mylar ±10% 50V Examples ; Capacity value 0.001 µF (1000 pF) ....... 102 0.1 µF.... 104 0.0018 µF ........................ 182 0.56 µF.... 564 0.01 µF ........................ 103 1 µF.... 105 0.015 µF ........................ 153 : 1) The above CODES ( R , R , C , C and C ) are omitted on the schematic diagram in some case. 2) On the occasion, be confirmed the common parts on the parts list. 3) Refer to “Common Parts List” for the other common parts (RI05, DD4, DK4). Œ  Capacity value Tolerance  Capacity value Resistance value  Working voltage Capacity value ’ Capacity value NOTE NOTE ON SAFETY FOR FUSIBLE RESISTOR : Resistance value Resistance value (0.1 Ω − 10 kΩ) Resistance value Resistance value ANT. : ANTENNA BATT. : BATTERY CAP. : CAPACITOR CER. : CERAMIC CONN. : CONNECTING DIG. : DIGITAL HP : HEADPHONE MIC. : MICROPHONE µ-PRO : MICROPROCESSOR REC. : RECORDING RES. : RESISTOR SPK : SPEAKER SW : SWITCH TRANSF. : TRANSFORMER TRIM. : TRIMMING TRS. : TRAMSISTOR VAR. : VARIABLE X’TAL : CRYSTAL SM970926ACT ABBREVIATION AND MARKS { { { { { { { { { { Ž Œ  Ž   ‘ ’ ‘ NOTE ON SAFETY : Symbol Fire or electrical shock hazard. Only original parts should be used to replaced any part marked with symbol . Any other component substitution (other than original type), may increase risk of fire or electrical shock hazard. 10-1 10-1 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) P704-MOTOR DRIVE MAIN AMP CIRCUIT BOARD P704-CAPACITORS CD01 4822 122 30103 CER. 0.022µF +80%-20% 50V DK18223310 CD02 4822 122 30103 CER. 0.022µF +80%-20% 50V DK18223310 C701 4822 124 22273 ELECT. 0.47µF 50V OA47405020 C702 4822 124 22273 ELECT. 0.47µF 50V OA47405020 C721 4822 124 90357 ELECT. 2.2µF ±20% 50V RA-2 OA22505020 C722 4822 124 22273 ELECT. 0.47µF ±20% 50V OA47405020 C723 4822 122 31205 CER. 47pF ±5% CH 50V DD15470300 C724 4822 124 22274 ELECT. 4.7µF ±20% 50V RA-2 OA47505020 C725 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 C726 4822 124 90357 ELECT. 2.2µF 50V OA22505020 C727 4822 124 90362 ELECT. 22µF 50V ±20% RA2 OA22605020 C728 4822 126 12496 CER. 0.01µF +80%-20% 50V DD38103010 C801 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 C804 C805 4822 122 30103 CER. 0.022µF +80%-20% 50V DK18223310 C806 4822 124 42367 ELECT 3300µF 35V RE3 EA33803570 C807 4822 124 90367 ELECT. 2200µF 25V OA22802520 C808 4822 124 22695 ELECT. 2200µF 35V OA22803520 C809 4822 124 80582 ELECT. 4700µF 16V OA47801620 C810 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 C811 4822 124 12399 ELECT 3300µF 6.3V RE3 EA33800670 C812 4822 124 41543 ELECT. 1µF 50V OA10505020 C814 4822 124 90355 ELECT. 100µF 50V OA10705020 C815 4822 124 90362 ELECT. 22µF 50V OA22605020 C816 4822 124 90362 ELECT. 22µF 50V OA22605020 C818 4822 122 40617 CER. 0.1 +80%-20% 50V DD38104010 C819 4822 124 90354 ELECT. 100µF 16V OA10701620 C820 4822 124 90354 ELECT. 100µF 16V OA10701620 C821 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 C851 4822 124 90354 ELECT. 100µF 16V OA10701620 C852 4822 124 90352 ELECT. 10µF 16V OA10601620 P704-CAPACITORS (COMMON) PLASTIC FILM CAPACITOR ±5% 50V : C703-C710 C813 P704-RESISTORS R723 4822 050 21022 1kΩ ±5% 1/4W GG05102140 R724 4822 050 21022 1kΩ ±5% 1/4W GG05102140 R804 4822 111 90967 FUSE 4.7Ω 5%1/4W NF05047140 R809 4822 050 21021 100Ω ±5% 1/4W GG05101140 R810 4822 050 21021 100Ω ±5% 1/4W GG05101140 R825 4822 116 82444 0.33Ω ±10% 2W GO10332020 R830 JUMPER 75060501P0 R851 4822 052 10479 47Ω ±5% 1/4W GG05470140 R853 4822 116 80257 6.19kΩ 1% 1/6W GM11661910 R857 THERMISTOR ERTD2ZHJ103T HH00033020 P704-RESISTORS (COMMON) CARBON FILM FIXED RES. ±5% 1/6W : R701-R714 R721 R722 R725-R736 R801-R803 R805-R808 R811 R818-R824 R826-R828 R852 R854 -R856 R858 RD01-RD04 P704-SEMICONDUCTORS DD01 4822 130 10667 ZENER DIODE 4.7V HD30471000 D701 4822 130 82421 DIODE 1D3 1A 200V HD20002710 D704 D705 4822 130 80322 ZENER DIODE 15V HD31501000 D706 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 D707 4822 130 80132 ZENER DIODE 3.9V HD30391000 D708 4822 130 80838 ZENER DIODE 18V HD31801000 D709 4822 130 82421 DIODE 1D3 1A 200V HD20002710 D710 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 D711 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 D801 4822 130 83438 DIODE D5SB-10 200V 5A HE20016290 D802 4822 130 33057 DIODE S2VB20 HE20011290 D803 4822 130 82421 DIODE 1D3 1A 200V HD20002710 D806 D808 4822 130 82421 DIODE 1D3 1A 200V HD20002710 D809 4822 130 80272 ZENER DIODE 7.5V HD30751000 D810 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 D811 4822 130 82421 DIODE 1D3 1A 200V HD20002710 D812 4822 130 81659 ZENER DIODE 27V HD32701000 D813 4822 130 10667 ZENER DIODE 4.7V HD30471000 D814 JUMPER 75060501P0 D851 4822 130 80321 ZENER DIODE 10V HD31001000 D852 4822 130 83142 ZENER DIODE 6.2V HD30621000 D853 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 QD01 4822 209 83803 IC LB1641 MOTOR DRIVER HC10148030 Q701 4822 209 16224 IC AN7125 POWER AMP HC10169020 Q702 4822 130 11588 TRS. 2SA1307 O Y HT113072A0 Q703 4822 130 43313 TRS. 2SC3312 R S HT333122A0 Q704 4822 130 42433 TRS. 2SA933S R S HT109332B0 Q705 4822 130 42433 TRS. 2SA933S R S HT109332B0 Q706 4822 130 43313 TRS. 2SC3312 R S HT333122A0 Q707 4822 130 42433 TRS. 2SA933S R S HT109332B0 Q708 4822 130 43313 TRS. 2SC3312 R S HT333122A0 Q801 4822 209 17378 IC PQ30RV2 HC31930320 Q802 4822 130 61417 TRS. 2SB1240 TV-2 Q R HT212402A0 Q803 4822 130 43313 TRS. 2SC3312 R S HT333122A0 Q805 4822 209 17379 IC PQ12RF2 REQ.12V 2A HC31912320 Q806 4822 209 14623 IC NJM7808FA 8V 1A HC38908090 Q807 4822 130 42433 TRS. 2SA933 R S HT109332B0 Q851 4822 130 42292 TRS. 2SC2120 O HT321201A0 Q852 4822 130 42433 TRS. 2SA933S R S HT109332B0 Q853 4822 130 43313 TRS. 2SC3312 R S HT333122A0 P704-MISCELLANEOUS F803 F,U FUSE 1.6A 125V FS20160220 F803 /2,K,KK 4822 071 51602 FUSE T1.6A 250V FS20160200 F804 F,U FUSE 4.0A 125V UL CSA FS20400220 F804 /2,K,KK 4822 071 54002 FUSE 4.0A 250V VDE SEMKO FS20400200 F805 F,U FUSE T 1.25A 125V UL CSA FS20125220 F805 /2,K,KK 4822 071 51252 FUSE T1.25A 250V FS20125200 F806 F,U FUSE 500mA 125V UL CSA FS20050220 F806 /2,K,KK 4822 071 55001 FUSE T0.5A 250V FS20050200 J702 4822 290 60752 TERMINAL 4 PIN PUSH YT03040330 L701 4822 157 63085 AIR COIL SPK CHOCK COIL ML08010010 L704 HORIZONTAL TYPE L707 /2 4822 157 11848 ZJYS51R5-2P FN21000060 L708 /2 4822 157 11848 ZJYS51R5-2P FN21000060 P804-POWER SUPPLY CIRCUIT BOARD LB01 4822 157 70419 LF-4D-102 FN01020020 RB01 U 2.2M Ω ±10% 1/2W FOR UL RC10225820 SB01 K SLIDE SW. SLIDE 110V-220V SS02021670 10-2 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) PA04-AM-STEREO CIRCUIT BOARD [F Version] PA04-CAPACITORS CA02 F 4822 124 21894 ELECT 10µF 16V EJ10601610 CA03 F 4822 124 21894 ELECT 10µF 16V EJ10601610 CA04 F 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CA05 F 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CA11 F 4822 124 21894 ELECT 10µF 16V EJ10601610 CA13 F 4822 124 23053 ELECT 1µF 50V EJ10505010 CA14 F 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CA15 F 4822 122 31205 CER. 47pF ±5% CH 50V BLK DD15470300 CA16 F 4822 124 23056 ELECT 47µF 16V EJ47601610 CA20 F 4822 124 23056 ELECT 47µF 16V EJ47601610 CA21 F 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CA22 F 4822 124 40786 ELECT 2.2µF 50V EJ22505010 CA23 F 4822 124 40786 ELECT 2.2µF 50V EJ22505010 CA24 F 4822 124 23053 ELECT 1µF 50V EJ10505010 PA04-CAPACITORS (COMMON) HIGH DIELECTRIC CONSTANT CER. CAPACITOR ±10% 50V : CA01 CA17-CA19 PLASTIC FILM CAPACITOR ±5% 50V : CA06-CA10 CA12 PA04-RESISTOR RA08 F FUSE 82 Ω G 1/4W NF02820140 PA04-RESISTORS (COMMON) CARBON FILM FIXED RES. ±5% 1/6W : RA01-RA07 PA04-SEMICONDUCTORS DA01 F 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 DA02 F 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 DA03 F 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 QA01 F IC MC13022P AM STEREO HC10078170 QA02 F IC 74HC4053 C-MOS HC705300B0 QA03 F 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QA04 F 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 PB04-MISCELLANEOUS LA01 F I.F.T. COIL A7NRES-T1370Y 450kHz LI71010120 XA01 F SERAMVIB. CSA3.6MGF103 FQ03604020 PH04-HEAD PHONE JACK CIRCUIT BOARD PH04-CAPACITORS CH15 4822 126 12496 CER. 0.01µF +80%-20% 50V DD38103010 CH16 4822 126 12496 CER. 0.01µF +80%-20% 50V DD38103010 CH17 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 PB04-MISCELLANEOUS JH01 4822 242 11018 JACK HEAD PHONE HS10914-01-040 YJ01004500 LH10 JUMPER 75060501P0 LH14 PS04-SW ASSY CIRCUIT BOARD SS01 4822 276 14088 TACT SW. ALPS-SKQUAA SP01013280 SS02 4822 276 14088 TACT SW. ALPS-SKQUAA SP01013280 PS14-SW ASSY CIRCUIT BOARD SS11 4822 276 14088 TACT SW.ALPS-SKQUAA SP01013280 SS12 4822 276 14088 TACT SW.ALPS-SKQUAA SP01013280 PS54-IR ASSY C IRCUIT BOARD CS51 4822 126 10935 ELECT 100µF 6.3V EJ10700610 QS51 4822 130 11494 PHOTO UNIT RPM6936-V4 IR SENSOR HW10004210 SS51 4822 276 20508 PUSH SW. EVQ11L05R SP01013370 PS64-DOOR SW ASSY CIRCUIT BOARD SS61 4822 276 20508 PUSH SW. EVQ11L05R SP01013370 PU04-µ-COM ASSY CIRCUIT BOARD PU04-CAPACITORS CF22 4822 126 11558 CER. 0.1µF +80%-20% 50V DA17104110 CF49 /2 4822 126 10408 CER. 220pF ±10% B 50V DA16221110 CF50 /2 4822 126 10408 CER. 220pF ±10% B 50V DA16221110 CF51 /2 CER. 1500pF ±20% X 50V DA17152110 CF53 4822 124 21894 ELECT 10µF 16V EJ10601610 CF54 4822 124 21894 ELECT 10µF 16V EJ10601610 CF55 4822 126 10362 CER. 22pF ±5% SL 50V DA15220110 CF56 4822 126 10362 CER. 22pF ±5% SL 50V DA15220110 CF57 4822 124 21894 ELECT 10µF 16V EJ10601610 CF58 4822 124 21894 ELECT 10µF 16V EJ10601610 CF59 4822 124 23056 ELECT 47µF 16V EJ47601610 CF60 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CF61 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CU01 4822 126 10513 CER. 47pF ±5% SL 50V DA15470110 CU02 4822 126 10513 CER. 47pF ±5% SL 50V DA15470110 CU03 4822 126 10513 CER. 47pF ±5% SL 50V DA15470110 CU04 4822 126 10364 CER. 100pF ±10% B 50V DA16101110 CU05 /2 4822 126 10513 CER. 47pF ±5% SL 50V DA15470110 CU08 /2 4822 122 31237 CER. 82pF ±5% CH 50V DD15820300 CU09 /2 4822 122 31205 CER. 47pF ±5% CH 50V DD15470300 CU10 /2 4822 126 12496 CER. 0.01µF DC50V +80 -20% DD38103010 CU11 /2 4822 122 40617 CER. 0.1µF DC50V +80 -20% DD38104010 CU12 /2 4822 126 11071 CER. 330pF ±10% B 50V DA16331110 CU13 /2 4822 124 40786 ELECT 2.2µF 50V EJ22505010 CU14 /2 4822 126 10409 CER. 560pF ±10% B 50V DA16561110 CU17 4822 124 23295 BIG ELECT 0.022µF 5V EX22300510 CU18 4822 126 10935 ELECT 100µF 6.3V EJ10700610 CU19 4822 122 40586 CER. 0.01µF ±20% 50V DA17103110 CU20 4822 126 10935 ELECT 100µF 6.3V EJ10700610 CU21 4822 126 12867 ELECT. 1000µF 6.3V OA108006Q0 CU24 4822 122 40589 CER. 0.047µF ±10% F 50V DA17473110 CU27 4822 122 31823 CER. 15pF ±5% CH 50V DD15150300 CU28 4822 122 31823 CER. 15pF ±5% CH 50V DD15150300 CU29 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 CU30 4822 124 23053 ELECT 1µF 50V EJ10505010 CU31 4822 124 23053 ELECT 1µF 50V EJ10505010 CU32 4822 126 10408 CER. 220pF ±10% B 50V DA16221110 CU33 4822 122 33795 CER. 4700pF ±20% X 50V DA17472110 CU34 4822 126 10935 ELECT 100µF 6.3V EJ10700610 CU35 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CU36 4822 124 22726 ELECT 4.7µF 35V EJ47503510 CU37 4822 124 22726 ELECT 4.7µF 35V EJ47503510 CU38 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CU39 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 CU41 4822 126 10364 CER. 100pF ±10% B 50V DA16101110 CU42 4822 126 10364 CER. 100pF ±10% B 50V DA16101110 10-3 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) CU43 4822 126 10364 CER. 100pF ±10% B 50V DA16101110 CU44 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CU47 4822 122 40586 CER. 0.01µF ±20% Y 50V DA17103110 CU48 /2 CER. 1500pF ±20% X 50V DA17152110 CU53 4822 126 12867 ELECT. 1000µF 6.3V OA108006Q0 CU54 4822 122 40617 CER. 0.1µF +80 -20% 50V DC DD38104010 CU55 /2 4822 126 12496 CER. 0.01µF +80 -20% DC50V DD38103010 CU56 /2 4822 126 12496 CER. 0.01µF +80 -20% DC50V DD38103010 CU57 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 CU58 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 CU59 4822 124 40786 ELECT 2.2µF 50V EJ22505010 CU61 4822 126 10408 CER. 220P ±10% 50V DA16221110 CU64 CU65 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 PU04-CAPACITORS (COMMON) PLASTIC FILM CAPACITOR ±5% 50V : [CU45 CU46 : KK U] PU04-RESISTORS RU55 4822 050 23308 3.3MΩ ±5% 1/6W GD05335160 RU57 4822 050 23308 3.3MΩ ±5% 1/6W GD05335160 RU64 4822 117 10158 1Ω 1/4W GG GG05010140 RU65 4822 117 10158 1Ω 1/4W GG GG05010140 RU67 4822 052 10101 100Ω ±5% 1/6W GG05101160 RU88 4822 050 23308 3.3MΩ ±5% 1/6W GD05335160 PU04-RESISTORS (COMMON) CARBON FILM FIXED RES. ±5% 1/6W : RF01-RF16 RF19-RF26 RF28-RF32 RF51-RF62 RT61-RT64 RU01-RU04 [RU05 RU07-RU12 : /02] RU13-RU37 RU41-RU47 RU49 RU56 RU58-RU61 [RU62 : /02 U] [RU63 : /02 K KK] RU69 RU71-RU74 RU76-RU87 RU89-RU93 RU98 RU99 PU04-SEMICONDUCTORS DU01 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU02 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU03 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU04 JUMPER 75060501P0 DU05 4822 130 82421 DIODE 1D3 1A 200V HD20002710 DU06 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 DU07 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 DU08 4822 130 32362 DIODE 1SS176 MA165 1SS254 30V 0.1A HD20002000 DU09 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU10 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU12 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU13 4822 130 80837 DIODE HSS81TH 150V 150mA HD20027010 DU14 4822 130 80837 DIODE HSS81TD 150V 150mA HD20027010 DU15 4822 130 11585 L.E.D. SIM-22ST FOR DOOR HI20001210 DU16 JUMPER 75060501P0 QF51 4822 209 83631 IC NJM4558D-D HC10008090 QU01 4822 130 11586 PHOTO UNIT RPM-22PB PHOTO-DOOR HW10006210 QU02 4822 130 91368 PHOTO UNIT NJL5165KL DISC SENSOR HW10004090 QU03 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 QU04 4822 130 61892 TRS. 2SD2144S U V HT421442A0 QU05 /2 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QU06 /2 4822 130 61227 DIG.TRS. DTA114ES UN4111 10K 10K BA10001000 QU07 /2 4822 209 17372 IC SAA6588 RDS DECODER HC10174490 QU08 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 QU09 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 QU10 4822 209 17376 MICROPROCESSOR TMP87CS71F MR2020 E3E5 HU298JT000 QU14 4822 130 42682 DIG.TRS. DTA144ES UN4113 47K 47K BA10002000 QU16 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QU17 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 QU18 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QU19 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC HT30001000 QU20 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC. HT10001000 QU21 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QU22 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC. HT30001000 QU23 4822 130 43313 TRS. 2SC3312 2SC1740SLN HT30002000 QU24 4822 130 43313 TRS. 2SC3312 2SC1740SLN HT30002000 QU25 4822 130 43313 TRS. 2SC3312 2SC1740SLN HT30002000 QU26 4822 130 42715 TRS. 2SA1048 2SA933S 2SA1267 ETC HT10001000 QU29 4822 130 41947 TRS. 2SC2458 2SC1740S 2SC3199 ETC HT30001000 PU04-MISCELLANEOUS LU01 /2 4822 242 73843 EMI FILTER 0.022µF FM12223010 LU02 /2 4822 242 73843 EMI FILTER 0.022µF FM12223010 SU01 4822 276 20508 PUSH SW. EVQ11L05R SP01013370 SU16 VU01 4822 135 00271 DISPLAY UNIT FL FTABA 11-BT-164GK HQ30806410 XU01 4822 242 72236 CRYSTAL DT-38 32.768kHz XO001001T2 XU02 4822 242 72066 SERAMVIB. CST8.0MHz MT FQ08004010 XU03 /2 4822 242 10857 CRYSTAL 4.332MHz AT-49 JX04003260 PX04-SOUND CONT. H.P AMP CIRCUIT BOARD PX04-CAPACITORS CE09 4822 124 22703 ELECT. 0.22µF ±20% 50V OA22405020 CE10 4822 124 22703 ELECT. 0.22µF ±20% 50V OA22405020 CE11 4822 124 22273 ELECT. 0.47µF ±20% 50V OA47405020 CE12 4822 124 22273 ELECT. 0.47µF ±20% 50V OA47405020 CE17 4822 122 40617 CER. 0.1µF +80 -20% 50V DC DD38104010 CE18 4822 124 41539 ELECT. 47µF ±20% 16V RA-2 OA47601620 CE19 4822 124 41539 ELECT. 47µF ±20% 16V RA-2 OA47601620 CE20 4822 124 90354 ELECT. 100µF 16V OA10701620 CE21 4822 124 90354 ELECT. 100µF 16V OA10701620 CE27 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE28 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE31 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE32 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE35 4822 124 41543 ELECT. 1µF ±20% 50V RA-2 OA10505020 CE36 4822 124 41543 ELECT. 1µF ±20% 50V RA-2 OA10505020 CE37 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE38 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE41 4822 121 42327 FILM 470pF ±5% 50V DF15471350 CE42 4822 121 42327 FILM 470pF ±5% 50V DF15471350 POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, **:EUROPE) POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) CE45 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CE46 4822 122 40617 CER. 0.1µF +80%-20% 50V DD38104010 CH07 5322 122 32143 CER. 22pF ±5% 50V DD15220300 CH08 5322 122 32143 CER. 22pF ±5% 50V DD15220300 CH09 4822 124 41539 ELECT. 47µF ±20% 16V RA-2 OA47601620 CH10 4822 124 41539 ELECT. 47µF ±20% 16V RA-2 OA47601620 CH11 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CH12 4822 124 41539 ELECT. 47µF ±20% 16V RA-2 OA47601620 CH18 4822 124 41539 ELECT. 47µF 16V OA47601620 CX01 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX02 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX05 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX08 4822 124 41539 ELECT. 47µF 16V RA-2 OA47601620 CX09 4822 124 90352 ELECT. 10µF 16V OA10601620 CX10 4822 124 90352 ELECT. 10µF 16V OA10601620 CX11 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX12 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX13 4822 124 90352 ELECT. 10µF 16V OA10601620 CX14 4822 124 90352 ELECT. 10µF 16V OA10601620 CX17 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX18 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX19 4822 124 22273 ELECT. 0.47µF ±20% 50V OA47405020 CX20 4822 124 22273 ELECT. 0.47µF ±20% 50V OA47405020 CX21 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX22 4822 124 90357 ELECT. 2.2µF 50V OA22505020 CX23 5322 122 32143 CER. 22pF ±5% CH 50V BLK DD15220300 CX24 5322 122 32143 CER. 22pF ±5% CH 50V BLK DD15220300 CX25 4822 124 90357 ELECT. 2.2µF ±20% 50V RA-2 OA22505020 CX26 4822 124 90357 ELECT. 2.2µF ±20% 50V RA-2 OA22505020 CX27 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX28 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX29 4822 124 90352 ELECT. 10µF 16V OA10601620 CX70 4822 124 11574 ELECT 1000µF 16V RE3 EA10801670 CX71 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 CX72 4822 124 41539 ELECT. 47µF 16V OA47601620 CX73 4822 122 30043 CER. 0.01µF +80%-20% 50V DK18103310 PX04-CAPACITORS (COMMON) HIGH DIELECTRIC CONSTANT CER. CAPACITOR ±10% 50V : CE33 CE34 CE39 CE40 CH05 CH06 CH13 CH14 CX03 CX16 CX81 CX82 PLASTIC FILM CAPACITOR ±5% 50V : CE01-CE08 CE15 CD16 CE25 CE26 CE29 CE30 CE43 CE44 CE47 CH01-CH04 CX15 CX31 CX32 PX04-RESISTOR RX72 4822 111 90967 FUSE 4.7Ω 1/4W NF05047140 PX04-RESISTORS (COMMON) CARBON FILM FIXED RES. ±5% 1/6W : RE01-RE38 RH03-RH16 RN01-RN04 RX01-RX08 RX11-RX26 RX31-RX48 RX70 RX71 PX04-SEMICONDUCTORS QE01 4822 209 17382 IC TEA6321 DSC HC10170490 QE02 4822 130 61892 TRS. 2SD2144S U V HT421442A0 QE03 4822 209 83631 IC NJM4558D-D HC10008090 QE04 4822 209 83631 IC NJM4558D-D HC10008090 QH01 4822 209 82362 IC NJM4556D HC10016090 QN01 4822 130 43818 TRS. 2SC2878 A BRANK HT328782A0 QN04 QX01 4822 209 83631 IC NJM4558D-D HC10008090 QX02 4822 209 83631 IC NJM4558D-D HC10008090 QX03 4822 209 83631 IC NJM4558D-D HC10008090 QX04 4822 209 17381 IC PQ05RF2 REQ.5V 2A HC31905320 QX05 4822 130 43818 TRS. 2SC2878 A BRANK HT328782A0 QX08 QX09 4822 209 83631 IC NJM4558DD HC10008090 QX70 4822 130 61892 TRS. 2SD2144S U V HT421442A0 PX04-MISCELLANEOUS LH01 4822 157 62898 CHOKE COIL 180µH J LC11843800 LH03 4822 157 62898 CHOKE COIL 180µH J LC11843800 LH05 4822 157 62898 CHOKE COIL 180µH J LC11843800 LH15 JUMPER 75060501P0 LH16 JUMPER 75060501P0 LX01 4822 157 60122 CHOKE COIL 4.7µH J LC14723800 PX54-AUX-IN MONI-OUT REMOTE CIRCUIT BOARD PX54-CAPACITORS (COMMON) HIGH DIELECTRIC CONSTANT CER. CAPACITOR ±10% 50V : CX51-CX55 PX54-RESISTORS (COMMON) CARBON FILM FIXED RES. ±5% 1/6W : RX51-RX54 PX54-MISCELLANEOUS JX51 4822 265 11573 TERMINAL MONI-OUT AUX-IN YT02041230 JX52 4822 265 10684 TERMINAL SUB WOOFER RCA-1PIN YT02011020 LX51 4822 157 62908 CHOKE COIL 2.2µH J LC12223800 LX55 10-4 system LS2021 Service Manual R Please use this service manual with referring to the user guide ( D.F.U. ) without fail. 74 LS2021 /9M LS2021 F,K,KK,U Speaker System POS. NO VERS. COLOR PART NO. (FOR PCS) DESCRIPTION PART NO. (MJI) (VERS. :VERSION, U:U.S.A., F:JAPAN, K:FAR EAST, /X :EUROPE) LS01 4822 240 10354 LOUDSPEAKER, TWEETER QK000030R LS02 4822 240 10355 LOUDSPEAKER, WOOFER QK000040R LS03 4822 265 11569 SPEAKER TERMINAL YT001430R

标签：

版权声明

1. 本站所有素材，仅限学习交流，仅展示部分内容，如需查看完整内容，请下载原文件。
2. 会员在本站下载的所有素材，只拥有使用权，著作权归原作者所有。
3. 所有素材，未经合法授权，请勿用于商业用途，会员不得以任何形式发布、传播、复制、转售该素材，否则一律封号处理。
4. 如果素材损害你的权益请联系客服QQ：77594475 处理。

滇ICP备2022006959号-4