© 2002-10 PRINTED IN JAPAN B51-7986-00 (N) 2139 CASSETTE RECEIVER KRC-31Y/36/366L/37/37Y /391/394/394Y/466R /4904Y SERVICE MANUAL Mechanism extension cord : W05-0477-00 (7P), W05-0609-00 (10P) LOUD SCRL SCAN REP T.CALL M.RDM B.S/RDM MENU TI VOL ADJ CLK KRC-XXXX SRC OFF 45Wx4 AUD DISC LOUD SCRL SCAN REP T.CALL M.RDM B.S/RDM MENU AUTO AME CLK KRC-XXXX SRC OFF 45Wx4 AUD DISC LOUD SCRL SCAN REP T.CALL M.RDM B.S/RDM MENU AUTO AME CLK KRC-4904 SRC OFF 45Wx4 AUD DISC KRC-36/37/37Y /391/394 /394Y/466R Mounting hardware assy (J21-9716-03) Plastic cabinet assy (A02-1486-13) Screw set (N99-1610-15) Lever (D10-4589-04) x2 Antenna adaptor (T90-0523-05) DC cord (E30-4792-05) Depends on model. Refer to the parts list. Screw set (N99-1719-05) WIDE BAND KRC-31Y/366L KRC-4904Y Panel assy KRC-391: (A64-2538-02) KRC-36: (A64-2541-02) KRC-466R: (A64-2941-02) KRC-394/394Y: (A64-2945-02) KRC-37/37Y: (A64-2947-02) Panel assy KRC-366L: (A64-2942-02) KRC-31Y: (A64-2946-02) Panel assy (A64-2948-02) Escutcheon (B07-) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 2 BLOCK DIAGRAM FM ANT AM ANT RF GND FM+B AM+B AM LO/DX FM LO/DX IF SELECT RDS OUT FM SD OUT REQUEST K2I-VTH VCO-GND FSD OUT FM DET OUT AM DET OUT IF GND COMMON+B P-ON 5V DIG GND PLL DATA PLL CLK PLL CE HI UP ADJ FM+B AM+B A8V SW5V LO/DX SD S-METER PLL-DATA PLL-CE SW5V ACC-DET BU-DET SCL MUTE SDA EN1 EN2 EN3 PANEL RESET DSI CH MUTE NOISE DATA H DATA C REQ H REQ C CH RST CH CON CH CLK Rch COM Lch TAPE L/R MP IN AFS QUAL AM MPX OUT RR OUT LR OUT RF LEVEL SCL SW5V SDA SCL SDA OUT LF STBY MUTE SMUTE 5 10 BU5V AFS R QUAL R CLK R DATA BU5V REMO SW5V GREEN RED BU5V PHONE BEEP SVR P-MUTE P-STBY SVR AC GND(BEEP) TAPE L/R PLL-CLK SW5V L-RES L-CLK L-DATA S L-DATA L MUSIC EQ-MUTE MS-CONT MUSIC EQ-MUTE MS-CONT FWD/REV PACK IN M-STBY T-MODE T-END L-CE 340mV SUB+ SUB- Rch Lch PACK T-END M-STBY T-MODE FWD REV AUDIO 8V MOTOR BU14V SW5V IN PLAY HEAD SW5V BU14V BU5V BU14V EN1 EN2 EN3 P,CON ILLUM B.U.5V AM+B AUDIO FM+B FM+B AM+B AUDIO 8V AUDIO 8V AUDIO 8V BU5V SW5V TAPE CD-CH AM FM : 1719mV : 3424mV : 550mV : 1727mV TAPE CD-CH AM FM : 1786mV : 3546mV : 850mV : 1345mV AM : 160mV FM : 213mV CD L/R 1200mV BU14V CD L/R 8 RDS ANT. DECODER SYSTEM u-COM KEY PAN 5V MUTE E2PROM EQ AMP CD ISO AMP E-VOL LCD DRIVER LCD DSI REMO RST SW PAN IN SW GREEN RED or RST IC TEL DET TEL MUTE DRIVER MAIN SUB AVR SW5 B.U. DET SURGE-DET B.U. ACC P-CONT DC CONNECTOR REGULATOR ACC DET J2 VOLTAGE MUTE PRE R-Lch R-Rch AMP SVR MUTE THERMO PROTECTION FRONT Lch FRONT Rch REAR Lch REAR Rch IC4 J4 POWER IC TDA7386 CD/MD CHANGER SP OUT J5 PRE OUT IC10 SUB MOTOR DRIVER MOTOR DRIVER IC1 IC2 IC12 IC9 IC2 IC1 IC11 IC7 IC8 Q2,3 IC6 TUNER (X16) (X14) M M TAPE MECHA www . x ia o y u 1 6 3 . c o m QQ 3 7 6 3 1 5 1 5 0 9 9 2 8 9 4 2 9 8 T E L 1 3 9 4 2 2 9 6 5 1 3 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 3 COMPONENTS DESCRIPTION G SYNTHESIZER UNIT (X14-689x-xx) Ref. No. Function Operation IC1 System µ-com IC2 E-volume IC4 Power amplifier Speaker output. IC6 RDS decoder IC7 Power IC IC8 Mute control logic 3 input NOR gate x 3. IC9 Equalizer amplifier For full logical cassette mechanism control. IC10 Sub motor driver For full logical cassette mechanism sub motor driver. IC11 Reset IC Detection voltage below 3.0V. IC12 EEPROM Q1 P. CON detection Detects P.CON voltage. Q10 Backup detection Detects the backup voltage. Q11 Surge detection Detects surge voltage. Q20 ACC detection Detects ACC voltage. Q40 Preout mute driver Mutes when the base terminal voltage level becomes “L”. Q50 5V SW Works when the base terminal voltage level becomes “L”. Q101 DSI SW LED for DSI works when the base terminal voltage level becomes “H”. Q151 Panel 5V SW Works when the base terminal voltage level becomes “L”. Supplies VDD to panel. Q201 Noise detection Detects noise. Q221~224 Preout mute Mutes when the base terminal voltage level becomes “H”. Q251 Power IC SVR SW Discharges the capacitor’s voltage of SVR terminal after the base terminal voltage becomes “H”. Q301 Local seek SW Changes to the local seeking after the base terminal voltage becomes “H”. Q501 Motor driver AVR Works when the base terminal voltage becomes “H”. Supplies the power to the motor driver. Q551 Main motor SW Works when the base terminal voltage becomes “L”. Q552 Main motor SW Works when the base terminal voltage becomes “H”. G SWITCH UNIT (X16-1532-7x) Ref. No. Function Operation IC1 LCD driver IC2 Remote sensor Q1 Key scan SW Receives key signal when the base terminal voltage becomes “L”. Q2 Key illumination SW Key illumination color becomes green when the base terminal voltage becomes “H”. Q3 Key illumination SW Key illumination color becomes red when the base terminal voltage becomes “H”. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 4 MICROCOMPUTER’S TERMINAL DESCRIPTION G Microcomputer : UPD780058GCxxx (X14 : IC1) Pin No. Pin Name I/O Function / Operating Condition 1 DSI O DSI control. 2 PANEL I Panel detection. “L” : Panel exists 3 - - - 4 AVSS - GND. 5 L-RST O LCD driver reset. 6 L-CE O LCD driver chip enable. 7 AVREF1 I Reference voltage. 8 - - - 9 PLL-DATA I/O Front-end communication data. 10 PLL-CLK O Front-end communication clock. 11 L-DATA L I LCD driver communication data. 12 L-DATA S O LCD driver communication data. 13 L-CLK O LCD driver communication clock. 14 R-DATA I RDS data. 15 R-QUAL I RDS QUAL. 16 CH-DATA C I Changer communication data. 17 CH-DATA H O Changer communication data. 18 CH-CLK I/O Changer communication clock. 19 M-STBY I Cassette tape standby detection. “H” : Standby 20 T-END I Tape end detection. “H” : Run, “L” : Stop 21 ACC-DET I ACC detection. 22 BU-DET I Backup detection. 23 IC2 TYPE 0 I For service. “L” : Normally 24 IC2 TYPE 1 I For service. “L” : Normally 25 TYPE 0 I Destination discrimination. 26 TYPE 1 I Destination discrimination. 27 TYPE REF O Reference voltage for destination and service. 28 MOTOR O Cassette mechanism motor. “H” : ON, “L” : OFF 29 PLL-CE O Front-end communication ship enable. 30 SD I Station detection. “H” : Station exists, “L” : Station does not exist 31 ASF O Noise detection time constant switch. 32 LO/DX O Local seeking switch. “H” : LO, “L” : DX 33 VSS1 - GND. 34 P-MUTE O Power amplifier muting. 35 SVR O SVR control. 36 - - - 37 IC2-SCL O E-volume communication clock. 38 IC2-SDA I/O E-volume communication data. 39 MUTE O Muting control. 40 P-STBY O Power amplifier standby. Pin No. Pin Name I/O Function / Operating Condition 41 P. CON-DET I P. CON short-circuited detection. 42 CH-CONT O Changer control. 43 - - - 44 CH-REC H O Changer request. 45~47 - - - 48 EN2-1 O Power supply IC control. 49 EN2-0 O Power supply IC control. 50 BEEP O Buzzer. 51 EN3 O Power supply IC control. 52 EN1 O Power supply IC control. 53 SW 5V O P. ON 5V control. “H” : OFF, “L” : ON 54 MUSIC I Tape signal detection. “H” : Signal does not exist, “L” : Signal exists 55 MS-CONT O tape advanced sensitivity control. “H” : Play, “L” : FF/REW 56 EQ-MUTE O Cassette tape muting. “H” : ON, “L” : OFF 57 FWD/REV I Cassette tape runing direction detection. “H” : FWD, “L” : REV 58 SUB+ O Sub motor control. 59 SUB- O Sub motor control. 60 RESET I System reset. 61 REMOTE I Remote control. 62 R-CLK I RDS clock. 63 CH-REQ C I Changer request. 64 PACK-IN I Cassette tape pack-in detection. 65 KEY-REQ I Key signal detection. 66 - - - 67 VSS0 - GND. 68 VDD1 - VDD. 69 X2 - Main system clock. 70 X1 I Main system clock. 71 IC - - 72 - - - 73 XT1 - VDD. 74 VDD0 - VDD. 75 AVREF 0 I Reference voltage. 76 S-METER I SD detection. “H” : SD exists, “L” : SD does not exist 77 T-MODE I Cassette tape mode detection. 78 PHONE I Navi mute : Over 2.5V, Tel mute : Less tha 2.5V 79 NOISE I Noise detection during FM mode. 80 AV CONT O reference voltage. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 5 ADJUSTMENT BALANCE/FADER/BASS/TREBLE : CENTER T. ADV/METAL/DOLBY NR/AUTO : OFF No. Item Input Output Receiver Alignment Align For Fig. Settings Settings Settings Points FM Section While holding preset “1” key, press and hold preset “6” key 98.1MHz TEST MODE : ON for a few seconds. 1 SD 0 dev – FM Preset “1” key, and “ADJ OK” is good. 35dBµ 98.1MHz preset “6” key “ADJ NG” is not good. (ANT input) (7 seg model : “1111” is good. “0000” is not good.) AM Section While holding preset “1” key, press and hold preset “6” key 990kHz TEST MODE : ON for a few seconds. (1) SD 0% mod – AM Preset “1” key, and “ADJ OK” is good. 35dBµ 990kHz preset “6” key “ADJ NG” is not good. (ANT input) (7 seg model : “1111” is good. “0000” is not good.) Cassette Deck Section TCC-153 Head azimuth screw Adjust so that output level in 1 AZIMUTH 10kHz SP OUT TAPE PLAY (FWD/REV) playing “FWD” and “REV” (a) becomes maximum each. TEST MODE : ON While holding the “FM” key and preset “6” key, reset the unit. TEST MODE : OFF Reset the unit. (a) AZIMUTH FWD REV PANEL FRONT www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 6 A B C D E 1 2 3 4 5 6 7 PC BOARD (COMPONENT SIDE VIEW) DTC DTH CLK TEST RES 5V GND W21 W23 C304 W2 W19 W5 R303 W24 R222 R143 W1 W17 W18 W20 W13 R161 W14 W16 W7 W22 W15 W8 W12 R229 W25 W4 W3 R232 R230 W11 W10 W9 W6 R160 R231 R158 R159 R409 R410 R407 R157 R21 R30 R1 R2 R155 R156 R153 R154 R408 R411 R406 R401 R537 R551 R404 R501 R405 R354 R402 R403 R552 R20 X1 X2 L201 C222 C401 C402 C221 C224 C255 C258 C257 C203 C223 C403 C201 C256 C253 C252 C251 C254 R221 R224 R223 L301 C1 L304 L303 L101 L306 L305 C509 C513 C507 C353 C505 C514 C518 C517 C351 C55 C306 C54 C50 C51 C52 C301 C53 C56 C101 C501 L1 R304 R305 R162 R102 R103 R10 R31 C531 C1 R14 1 18 1 25 2 24 9 10 6 7 5 1 13 11 3 8 12 4 2 1 2 12 13 1 24 7 1 B E 1 10 2 1 14 15 WH1 J2 CN2 CN1 P1 D251 D253 D252 D101 D40 D2 D551 D4 D3 D411 D410 D409 D401 D404 D403 D402 D1 Q551 D30 D20 D10 IC4 J5 J6 D161 D157 D160 D159 D153 J4 A1 IC7 J3 D407 D154 D11 X14-689x-xx (J74-1321-02) Refer to the schematic diagram for the values of resistors and capacitors. X14-689x-xx IC Q Address 4 4A 7 1C 551 5D www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 7 J I H G F 1 2 3 4 5 6 7 PC BOARD (FOIL SIDE VIEW) B E E B E B B E E B B E B E B E E B E B E B B E B E E B B E B E R132 R141 R228 R227 R226 R225 R258 C533 C534 C202 R262 R142 R113 R114 R112 C206 C105 R255 R257 R201 C207 R140 R122 R138 R123 R129 R261 R260 R137 R117 R118 R115 R116 R135 R136 R120 R202 R513 R512 R511 R514 R517 R516 R515 R504 R414 R413 R412 R415 R503 R502 C20 R518 C14 R536 R535 R556 R554 R534 R521 R520 R519 R522 R533 R531 C104 R251 C102 C103 R205 R204 R203 R252 C30 C40 R254 R253 R259 R111 C511 C508 C506 C516 C515 C512 C502 C354 C211 C210 C404 C356 C355 C307 C308 C302 C303 C305 C225 C532 C352 R101 R32 R50 R51 R104 R108 R109 R110 R105 R106 R107 R11 R12 R22 R23 C208 C209 R263 R256 C205 C204 R3 C2 R353 CP315 CP102 CP10 4 CP101 R145 CP103 R144 C106 R146 R15 R16 R4 C260 C259 TH1 14 1 28 15 1 4 5 8 1 7 8 14 1 8 9 16 40 1 10 11 20 21 30 31 B E 2 1 4 3 6 10 1 5 80 1 20 21 40 41 60 61 IC2 Q251 Q223 Q501 Q224 IC10 IC6 Q222 Q221 Q552 Q40 Q301 Q101 Q20 Q10 Q201 Q151 D301 Q50 IC1 IC8 IC11 IC9 IC12 Q1 D102 Q11 X14-689x-xx (J74-1321-02) Refer to the schematic dia- gram for the values of resis- tors and capacitors. X14-689x-xx IC Q Address 1 3F 2 4H 6 5G 8 3G 9 2G IC Q Address 10 2F 11 3F 12 4G 1 4H 10 4G IC Q Address 11 5H 20 4G 40 2H 50 3G 101 3F IC Q Address 151 6F 201 4H 223 2I 224 2H 251 4I IC Q Address 301 6H 501 2F 552 5G www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 8 K L M N O 1 2 3 4 5 6 7 PC BOARD (COMPONENT SIDE VIEW) AUD FM AM TI 56 RST CLK 6 5 4 3 2 1 2 3 4 1 VOL SRC ATT KI1 KS2 KS3 1 KI4 KS4 KS5 KS3 KI5 KI2 D14 IC2 D6 D5 D8 D7 D2 D1 D4 D3 D9 D12 D10 D11 D20 ED1 D22 D21 D13 X16-1532-7x (J74-1303-02) X16-1532-7x (J74-1303-02) IC Address 2 2L Refer to the schematic diagram for the values of resistors and capacitors. (FOIL SIDE VIEW) B E E B B E KI2 KI3 KI4 KI5 KS2 KS3 RES R16 R15 R18 R17 C5 R13 R14 R10 R9 R3 R4 R1 R2 R7 R8 R5 R6 C3 C1 C2 C4 R12 R11 R20 C6 C8 R23 R19 R22 C7 14 15 1 2 64 65 80 1 24 25 40 41 LGND REMO SW5V DATAL L-CE PAN5V DGND KS4 WL+B LRES KS5 KI1 L-CLK DATAS Q3 Q2 Q1 D18 D17 D19 J1 IC1 X16-1532-7x (J74-1303-02) X16-1532-7x (J74-1303-02) IC Q Address 1 4O 1 3O 2 3O 3 3O (KRC-36/37/Y/391/394/Y/466R) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 9 T S R Q P 1 2 3 4 5 6 7 B E E B B E KI2 KI3 KI4 KI5 KS2 KS3 RES R16 R15 R18 R17 C5 R13 R14 R10 R9 R3 R4 R1 R2 R7 R8 R5 R6 C3 C1 C2 C4 R12 R11 R20 C8 R23 R19 R22 14 15 1 2 64 65 80 1 24 25 40 41 LGND REMO SW5V DATAL L-CE PAN5V DGND KS4 WL+B LRES KS5 KI1 L-CLK DATAS Q3 Q2 Q1 D18 D17 D19 J1 IC1 X16-1532-7x (J74-1304-02) X16-1532-7x (J74-1304-02) IC Q Address 1 4T 1 3T 2 3T 3 3T Refer to the schematic diagram for the values of resistors and capacitors. AUD FM AM TI 56 RST CLK 6 5 4 3 2 1 2 3 4 1 VOL SRC ATT KI1 KS2 KS3 1 KI4 KS4 KS5 KS3 KI5 KI2 D14 IC2 D6 D5 D8 D7 D2 D1 D4 D3 D9 D12 D10 D11 D20 ED1 D22 D21 D13 X16-1532-7x (J74-1304-02) X16-1532-7x (J74-1304-02) IC Address 2 2Q PC BOARD (COMPONENT SIDE VIEW) (FOIL SIDE VIEW) (KRC-31Y/366L/4904Y) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 A B C D E 1 2 3 4 5 6 7 10K 10K 3.8V 3.8V 3.8V 3.8V 0 5 5V 0V 5V 1V 3.8V 3.8V 3.8V 3.8V 3.8V 3.8V 3.8V 3.8V 0V 3.8V 7.7V 5.0V 5.0V 0V 0V 7.6V 7.6V 0V 5V 0V 5V 0V IC9 IC10 IC8 CASSETTE MECHANISM (D40-1150-05) SYNTHESIZER UNIT (X14-689X-XX) (E30-4792-05) DC1 J4 CN1 D401 D402 D404 D403 D409 D411 D410 EQUALIZER AMPLIFIER SUB MOTOR DRIVER Q552 Q551 CN2 MOTOR D551 A M HEAD Rch Lch MAIN T-END STBY SUB PACK FWD/REV M HD1 M M1 M2 PLAY IC1 : IC2 : TDA7407D IC4 : IC6 : TDA7479D IC9 : HA12221F IC7 : TDA3682ST IC8 : HD74HC27FP Q1,301 : DTC124EUA or Q10,11,20,101,201 2SD1819A Q40 : DTA124EUA or Q50 : 2SA1036K Q223,224 : DTC143TUA or Q251 : DTC114YUA or Q501 : 2SD1760 Q551 : 2SB1443 Q552 : DTC114EUA or D1 : S2V20 A D2,3 : 1GWJ43 (TPB5) D4,551 : AM01Z or D10,11,401,402 : MA4068 (N) -M D20 : MA4051 (N) -M D40,101,251-253 : B30-1567-05 403,404,407,409-411 : 1SS133 MUTE DRIVER PREOUT DRIVE MUTE IC12 IC10 IC11 LB1930M S-80835CNNB : BR24C01AF : : Q151 DTA114YUA or : MA4047-M or : D30 D102 MA4062-L or : D153,154,157,159-161, B-PART A-PART TDA7386 2SC4081 or : UN5112 UN5114 UN5216 UN5214 UN5211 1N5393G-M6 or ERA15-01 HZS5B1 HZS6C1 D407 B LINE GND LINE SIGNAL LINE (X14-689X-XX) C B UN5212 CH-IN ∗ DATA C GND REQ H CON MUTE S GND Rch RST 2 4 3 8 12 7 6 11 10 1 5 9 DATA H Lch CLK REQ C 13 R404 100 R405 4.7K R406 4.7K R402 10 R403 4.7 R407 4.7K R409 4.7K R408 4.7K R411 100 R410 100 R401 10 C403 100u10 + C402 1u50 + C401 1u50 + 5 7 6 30 29 28 27 26 25 24 23 22 21 1 2 3 4 5 6 7 8 9 10 31 32 33 34 35 36 37 38 39 40 M-OUT (R) EQ OUT (R) D IN (R) RAI (R) PB OUT (R) MS GV (S) MS GV (R) MA OUT MSI MS DET VCC MUSIC S/R (MSGV) F/R MTL M-OUT (L) RQ OUT (L) D IN (L) RAI (L) PB OUT (L) MUTE NFI (R) R IN (R) RIP F IN (R) F IN (L) V REF R IN (L) NFI (L) 1 2 3 4 5 6 7 8 9 10 MODE MODE+B SUB(-) SUB(+) PACK IN F/R GND HEAD L HEAD COM HEAD R 9 7 1u50 + C509 B.U. 42 44 16 63 18 17 5 4 3 2 1 SGND IN2 IN1 NC VCC 6 7 8 9 10 PGND OUT2 NC OUT1 NC 470 0.01 330K 5.1K 0.1u50 + 22u6.3 + C514 150 R514 0.01 330K 5.1K + R513 150 C513 22u6.3 + C517 0.1u50 15K 1500P R533 470 C532 0.01 R534 100K 470 57 64 R415 100K C404 0.01 VDD GND 1 2 14 13 3 12 11 4 5 6 7 10 9 8 77 59 58 C533 C534 9 7 R551 10K STBY T-END GND GND 4 6 7 5 2 3 1 M+B R552 1K 20 19 R556 470 R554 470 1/2W 10 9 6 8 7 5 4 1 3 2 HEAD R HEAD COM HEAD L GND F/R PACK IN SUB(+) SUB(-) MODE+B MODE MODE FWD/REV PACK M+R GND T-END STBY GND R413 100K R414 100K R412 100K R535 R536 22K R531 4.3K C515 R517 R519 12K R515 C512 R512 15K 1500P C511 R511 R520 R518 C516 12K R516 4.3K R522 R521 39 C518 3 1 2 7 4 5 6 7 B 5 3 1 6 2 4 8 REAR. L FRONT. L FRONT. R REAR. R P.CONT OUT ACC ANT.CONT 8 7 5 6 4 3 1 2 BATT A RED BLU/WHT BLK YEL GRN WHT GRY VIOL GRN/BLK WHT/BLK GRY/BLK VIOL/BLK 0.22 0.22 +B KRC-4904Y (E) KRC-31Y (E) KRC-394 (E) KRC-366L (M) 2-71 0-22 2-72 2-70 NO NO NO YES YES NO YES NO YES NO NO YES MODEL NAME KRC-394Y (E) UNIT R111 C308 KRC-466R (M) 0-21 YES YES YES A1 X86-3512-70 X86-3512-70 X86-3512-72 X86-3512-70 X86-3512-70 IC1 UPD780058GC418 UPD780058GC426 UPD780058GC418 UPD780058GC426 UPD780058GC418 NO NO YES YES NO R112 NO NO YES YES YES R113 +B +B +2V +5V +B +B +B +B +B NO YES YES YES Q301 NO NO NO YES YES NO YES NO NO YES YES R146 R118 NO YES YES NO NO R114 No. KRC-37Y (E) KRC-37 (E) +B 28 +2V +2V KRC-391 (E) KRC-36 (E) CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 J I H G F 47K 10K 22K 22K 3.6V 0V 0V 5V 0V 8.3V 4.1V 4.1V 4.1V 4.1V 0V 0V 4.1V 4.1V 4.1V 4.1V 4.1V 4.2V 0V 5V 5V 1V 8.0V 4.0V 4.0V 0V 7.3V 7.3V 7.3V 7.3V 7.2V 0V 4.7V 14.4V 7.3V 7.2V 7.2V 0V 14.4V 3.3V 0V 7.3V 7.2V 0V 5V 0V 5V 5V 0V 5.0V 0V 4.1V 0V 4.9V 0V 5.0V 2.5V 0V 5V 0V 5V 0V 0V 5V 5V 0V 5.0V 5V 0V 5V 0V 5V 0V 5V 0V 5V 0V 0V 5V 0V 5V 4.3V 0V 5V 0V 5V 0V 0V 0V 0V 5.0V 5V 0V 5V 0V 0V 5V 0 5 0V 5V 0V 5.0V 5V 0V 4V 0V 2.5V 5V 0V 1V 2.5V 1.6V 0V 5V 0V 5V 0V 3.8V 0V 0V 0V IC4 IC2 9X-XX) ∗IC1 D251 D252 D253 J5 DET. ACC D10 D11 Q11 Q10 DET. SERGE DET. BACK-UP Q40 Q501 SYSTE u-COM POWER AMPLIFER Q251 E-VOLUME AVR MOTOR DRIVER E DRIVER OUT IC SVR J2 SW D40 D20 Q20 D1 D2 D3 D4 D30 Q201 Q101 D102 DSI DETECTION NOISE ∗ B IVE UTE TEL MUTE POWER DC-IN/SP-OUT 2 4 6 8 10 12 14 16 18 20 22 24 GND STBY VCC GND SVR IN2 IN4 GND GND VCC MUTE GND 1 3 5 7 9 11 13 15 17 19 21 23 25 TAB OUT2- OUT2+ OUT1- OUT1+ IN1 GND IN3 OUT3+ OUT3- OUT4+ OUT4- CD 4.7K 4.7K C255 1u50 + C256 100u10 + R256 R255 33K 1K R254 R252 0.22u50 C254 0.22u50 C251 RL RR RR- FR+ FR- RR+ RL+ FL- FL+ RL- + 1u50 + 8.2K R257 R260 750 R261 430 35 TH1 R258 100 R259 22K R262 180K R231 R223 C223 13 1 3 2 4 5 L GREF VREF CD R R PH- 6 7 8 CD GND CD L 10 9 11 12 AFS MPX AM LEVEL MP IN 28 AC OUT L OUT RL OUT FR OUT FL AC OUT R 26 27 25 24 GND VDD OUT RR 23 21 22 QUAL S MUTE SCL SDA 19 20 18 17 MP OUT 14 16 15 MUX OUT L MUX OUT R C258 R251 4.7K C252 0.22u50 4.7K 0.22u50 C253 R253 FR RR RL FL 23 22 21 20 19 18 17 16 15 14 13 12 11 9 10 MS GV (S) MS GV (R) MA OUT MSI MS DET VCC MUSIC S/R (MSGV) F/R MTL MUTE 54 55 47u10 C501 + 0.01 C502 56 180K R502 0.22u50 C505 + C506 4.7 R501 3.3K R20 R32 22K 10K R30 C30 0.01 1/2W 10K R11 1000P C14 R14 82K 56K R15 100K R16 30K R10 VDD 14 13 12 11 10 9 8 C40 0.01 RR FR RL FL 0.01 C508 24K R504 0.47u50 C507 + 1.6K R503 10u10 + 22 R537 37 38 5 7 6 2.2u50 + 0.01 C202 47u10 + C201 4.7uH L201 C203 C206 0.015 C207 0.47 R201 2.7K R202 4.7K 34 50 C257 1u50 C205 1 C204 1 4.7K R203 C209 0.1 C208 0.1 C211 150P C210 0.033 Q251 40 47K R263 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 B.U B.U B.U GND GND GND T.MUTE P.CON ACC A.5 RR- RR+ RL- RL+ FL- FL+ FR+ FR- L1 C20 0.01 R22 47K 47K R21 R12 100K R23 100K 78 21 22 R31 47K RR- RR+ RL- FR+ FR- RL+ FL- FL+ 3300u16 + 4.7K C1 80 79 78 77 76 75 74 73 72 71 70 21 22 23 24 25 26 27 28 29 30 31 32 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 AV CONT NOISE PHONE T-MODE S-METER AV REF 0 VDD 0 XT1 XT2 IC ACC-DET BU-DET IC2 TYPE 0 IC2 TYPE 1 TYPE 0 TYPE REF MOTOR PLL-CE SD AFS LO/DX DSI PANEL AVSS L-RST L-CE AVREF1 PLL-DATA PLL-CLK L-DATA L L-DATA S L-CLK R-DATA R-QUAL CH-DATA C CH-DATA H CH-CLK M-STBY T-END 9 11 13 10 R2 7 9 9 7 78 2.2K ∗R146 4.7K R142 2 5 6 10 8 2.2K R102 2.2K R103 11 R104 100K 12 13 R105 2.2K R106 2.2K 14 15 16 17 18 20 19 240 R143 160K 4700P 22K R141 C105 15P C10 28 21 22 1K R204 4.7K R205 29 30 32 R116 4.7K R115 2.2K R117 4.7K ∗R118 2.2K R107 47K R109 47K ∗R113 47K ∗R111 47K ∗R114 47K ∗R112 47K TYPE 1 C106 R140 C531 0.01 4.7K R1 +5V +5V +5V +5V +5V +B +5V +B +B +5V +5V +B +B +5V +5V +B +B +B +B MUT RST MT MT MUT RST 77 +8V +8V +8V +8V www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 O N M L K 1 2 3 4 5 6 7 4.7K 4.7K 47K 10K 22K 22K 22K 22K 0V 5V 0V 0V 5V 5.0V 0V 5V 2.3V 2.3V 0V 5.0V 0V 0V 5.0V 0V 5.0V 0V 0V 5V 0V 5V 5V 0V 0V 5V 5V 0V 5V 0V 0V 0V 5V 0V 5V 5V 0V 0V 5V 5V 0V 5V 0V 5V 0V 5V 0V 5V 0V 0V 5V 5V 0V 0V 5V 5V 0V REV : 0V FWD : 5.0V 0V 5V 0V 5V 5V 0V 5V 0V 0V 5.0V 0V 5V 0V 5.0V 5.1V 14.1V 10.4V 5V 0V 0V 8.0V 8.3V 0V 13.8V 14.4V 8.3V 5V 2.5V ∗A1 ∗IC1 IC6 IC12 IC11 A IC7 D253 Q224 Q223 PRE OUT J5 J3 Q151 SYSTEM u-COM 5V SW D157 D161 D153 D159 PANEL 5V SW MUTE PREOUT D160 ∗Q301 EEPRON Q50 ∗ C RESET D101 Q1 P.CON. DETECTION RDS DECODER LOCAL SEEK SW 2/2 X16- J1 (E30-4933-05) ANT WH1 D154 POWER SUPPLY L R R259 22K 270 R224 R232 100 100 R231 R223 270 10u16 C223 R227 30K R228 30K 10u16 C224 + C225 RR RL 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 RF GND FM ANT AM ANT FM+B AM+B FM LO/DX K2I-VTH VCO-GND FM SD OUT FSD OUT FM DET OUT AM DET OUT COMMON+B IF GND HI UP ADJ PLL CE PLL DATA PLL CLK P-ON 5V DIG GND IF SELECT REQUEST RDS OUT 52mH L301 10 11 8 + 100u10 C304 0.01 C305 13 30 R305 3.3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 ILL GND D GND L RST SW5V LAMP +B LED +B L DATA S L CLK L CE L DATA L VDD RST REMO PANEL SW ESD GND R153 1K R161 1K R154 1K R158 470 R156 1K R157 1K R159 1K R162 47 12 2 61 6 11 13 34 + R160 100 5 P1 R155 10 0.01 C303 0.01 C302 100u10 C301 + 4.7uH L303 L304 4.7uH 12 R303 R304 4.7 ∗C308 0.01 10 4.7uH L305 29 L306 4.7uH C306 10u16 0.01 + C307 AM LO/DX CP101 1K 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 31 32 33 34 35 36 37 38 39 40 XT2 IC X1 X2 VDD 1 VSS 0 KEY-REQ PACK-IN CH-REQ C R-CLK REMO RESET SUB- SUB+ FWD/REV EQ-MUTE MS-CONT MUSIC SW5V EN1 EN3 BEEP EN2-0 EN2-1 CH-REQ H CH-CONT P.CON-DET SD AFS LO/DX VSS 1 P-MUTE SVR GND IC2-SCL IC2-SDA MUTE P-STBY 1 2 3 4 5 6 7 8 QUAL RDDA VREF MPX OSEL GND ARI FIL OUT 16 15 14 13 12 11 10 9 RDCK T57 OSCO OSCI VCC EXTRES TM TSEL 10P C356 10P C355 9 32 C354 0.01 C353 10u6.3 + R354 330P C352 10u6.3 + C351 CP315 2.2K 10 CP104 1K R132 1K 58 59 57 56 55 54 53 52 51 48 50 R145 10K 44 42 R144 4.7K CP102 1K CP103 10K 22K R123 1 2 3 4 VSS 8 7 6 5 VCC WP SCL SDA 4.7uH L101 R122 10K R120 10K 37 38 X1 6.8K R138 C105 15P C104 15P 4.19MHz R135 2.2K R136 2.2M 61 62 R137 4.7K 40 39 35 34 47K R51 2.2K R50 53 14 15 62 2.2K R353 X2 30 32 R117 4.7K ∗R118 2.2K 2 1 3 4 100K 0.1 C101 100u6.3 + C102 0.01 63 C103 R101 C2 120K R3 100K R4 4.7K R129 4.332 MHz 0.01 +B +B +5V +5V +5V +5V +5V +5V +5V +5V +5V +5V +B +5V +5V +5V +5V +5V +5V +5V MT MUT RST 0.01 64 RST RST VCC 52 C52 10u16 C51 10u16 + 10u16 VP1 + +5V + BU.5V 13 C55 + C56 100u16 11 ILLUM 12 EN1 10 + AUDIO GND 8 9 AM+B 7 10u35 + C50 1 51 48 P.ANT FM+B EN3 4 5 6 P.CON EN2 2 3 10u50 C54 10u16 + C53 +10.4V +10.4V +10.4V +10.4V +8V +8V +8V +8V +8V +8V +8V +8V +8V +8V +8V +8V +5V +B +B +5V +B KRC-31Y/36/366L/37/Y/391/394/Y/466R/4904Y (1/2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 P Q R S T 1 2 3 4 5 6 7 10K 10K 5.0V 5.0V 3.0V 1.5V 0V 5V 0V 3.9V 0V 0V 0V 5V 0V ED1 (COMMON) IC1 IC2 SWITCH UNIT (X16-1532-7X) A ED1 (SEGMENT) J1 Q1 Q3 Q2 D11 ∗D14 D20 D12 D22 D9 D7 D6 D4 D2 D1 D8 D5 D21 J3 X14- 1/2 REMOTE SENSOR KEY SCAN SW KEY ILLUMI- NATION SW RST D18 D19 D10 LCD DRIVER ∗ B ∗ A D17 D11 ∗D14 ∗D13 D3 D3 ∗D13 D15 S19 14 15 16 17 18 19 20 21 22 23 24 25 1 2 6 4 3 5 7 8 10 9 11 13 12 ILL-GND D-GND L-RES SW5V LAMP+B LED+B L-DATAS L-CLOCK L-CE L-DATAL PANEL 5V RESET REMO PANEL SW ESD-GND 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 KS6 KS5 KS4 KS3 KS2 S56 COM3 COM2 COM1 S55 S54 S53 S52 S51 S50 S49 S48 S47 GREEN RED KEY S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 KI1 KI2 KI3 KI4 KI5 VDD VDD1 VDD2 VSS TEST OSC L-RES L-DATA L L-CE L-CLK L-DATA S KI1 KI2 KI4 KI3 C3 0.047 C1 C2 0.047 56K 0.01 R4 4.7 R3 4.7K R2 79 80 78 76 77 80 79 77 78 R5 1K R6 470 R7 470 R9 470 R8 470 1 4 OUT VCC 2 3 GND2 GND1 R10 1K 76 C5 KS5 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 KS4 KS3 KS2 C3 C2 C1 55 54 53 52 51 50 49 48 47 R12 R11 R20 47 2.2K 2.2K ∗R17 510 R18 510 R23 R16 330 R13 330 R15 330 IC2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 59 2.2 KI5 Q2,3 ∗R14 0.01 C8 220 R19 220 R22 C6 0.01 0.01 C7 C4 1000P R1 +B +B +B +5V +5V +5V +5V +5V +5V TP35 TP33 TP32 TP31 TP30 TP29 TP27 TP28 TP26 TP24 TP23 TP22 TP21 TP5 TP4 TP3 TP1 TP2 TP9 TP8 TP6 TP7 47K 1 18 49 45 3 2 41 42 4 5 43 44 47 6 7 46 8 9 48 14 51 10 11 50 13 12 52 53 16 15 54 55 17 59 4 9 7 19 20 5 6 21 22 8 11 23 24 10 25 www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 Y X W V U 1 2 3 4 5 6 7 Q2 D13,14 : ∗ : B30-1605-05 D1-14,20-22 Q2,3 : 2SC4081 Q1 : DTA114EUA IC2 : RS-171 IC1 : LC75883E VOL+ VOL- SRC AUD AUTO CLK ATT 1 2 4 3 5 6 FM AM : MA3062WA : B30-1633-05 D17-19 D15 GND LINE B LINE A B S5 S6 S7 S8 S2 S4 S3 S1 S10 S9 S22 S23 S21 S20 S11 S12 S13 S14 S18 S17 S16 S15 S28 S25 S29 S24 S27 S26 (X16-1532-7X) 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 54 55 56 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 16 17 18 19 20 21 22 23 24 S49 S48 S47 S46 S45 S44 S43 S42 S41 S40 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S25 S16 S17 S18 S19 S20 S21 S22 S23 S24 25 16 17 18 19 20 21 22 23 24 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 49 48 47 46 45 44 43 42 41 KI1 KI2 KI3 KI4 KI5 KS2 KS3 KS4 SK5 53 +B 2-71 MODEL NAME UNIT NO D13,14 YES 2-70 YES NO B30-1564-05 B30-1605-05 470 17 R14, 360 TP15 TP14 TP13 TP12 TP11 TP16 TP17 TP18 TP19 KRC-466R (M) KRC-394Y (E) KRC-394 (E) KRC-37Y (E) KRC-36 (E) KRC-391 (E) KRC-366L (M) KRC-37 (E) KRC-31Y (E) KRC-4904Y (E) No. 13 9 11 23 24 10 25 26 12 31 29 27 28 14 15 30 16 17 33 32 18 19 34 35 20 21 39 44 26 24 36 37 23 22 38 39 25 28 40 41 27 42 43 29 30 48 46 45 31 32 47 33 34 50 49 35 36 51 52 38 37 53 54 40 55 56 C2 C1 C3 CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance mea- surements shall be carried out (exposed parts are ac- ceptably insulated from the supply circuit) before the appliance is returned to the customer. • DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units. DTC114YUA DTC143TUA UN5111 UN5114 UN5211 UN5214 UN5216 2SA1036K 2SD1819A 2SD1760 2SB1443 2SC4081 DTA114EUA DTA124EUA DTC114EUA DTC124EUA DTA114YUA UN5212 BR24C01AF BR24C01AF-W LB1930M TDA7479D KRC-31Y/36/366L/37/Y/391/394/Y/466R/4904Y (2/2) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 15 Parts with the exploded numbers larger than 700 are not supplied. EXPLODED VIEW (MECHANISM) A B 1 2 3 a A B C D E F G H L M N P Q R S M2x2.5 M1.7x7 M2x2.2 M2x3 M2x5 (BLK) 1.2x3 1.6x3.2 1.6x3.2 2.1x4 1.5x3.2 1.5E : N09-4193-08 : N09-4194-08 : N09-4195-08 : N09-4196-08 : N09-4197-08 : N09-4198-08 : N09-4199-08 : N09-4200-08 : N19-2087-08 : N19-2088-08 : N19-2135-08 : N19-2146-08 : N19-2091-08 : N19-2092-08 : N29-0510-08 4 73 27 2 55 76 a CM1 63 79 52 79 6 52 74 74 45 16 16 13 13 17 45 67 8 40 41 77 9 68 1 37 19 10 107 38 94 95 80 15 18 53 83 62 23 22 59 35 46 42 69 36 7 47 48 103 105 100 102 3 HD1 33 75 32 34 26 24 CM2 70 25 71 44 39 57 14 43 G R R L M Q Q L M Ex2 M M 887 C L L L P L S G 899 G G G G H Bx2 M M M M N Dx2 Ax3 F F 5 P www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 16 EXPLODED VIEW (UNIT) C D 1 2 3 G G A A E (X14-) 726 765 745 771 F1 G H F E WH1 (X14-) A1 (X14-) E A E 205 CME1 744 E B E 701 706 764 801 A B C D E F G H N M2.6x4 M2.6x8 φ2x6 φ2x8 (BLK) φ3x5 φ3x8 φ3x16 φ3x8 WASHER : N30-2604-46 : N30-2608-46 : N80-2006-46 : N80-2008-45 : N83-3005-46 : N80-3008-46 : N83-3016-46 : N84-3008-46 : N29-0205-04 D D D D N 220 223 236 221 CL1 235 237 (X16-) C C PA1 207 245 255 253 238 252 250 251 225 208 254 301 302 ED1 304 303 204 203 E E B A 264 263 266 DC1 248 201 222 x2 740 770 772 Depends on model. Refer to the parts list Parts with the exploded numbers larger than 700 are not supplied. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 17 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST 201 1C A02-1486-13 PLASTIC CABINET ASSY 203 3D A22-2862-01 SUB PANEL 204 2C ✽ A46-1749-11 REAR COVER 205 1D A52-0782-02 TOP PLATE CL1 3D A53-1687-03 CASSETTE LID PA1 3C ✽ A64-2538-02 PANEL ASSY E3 PA1 3C A64-2541-02 PANEL ASSY E2 PA1 3C ✽ A64-2941-02 PANEL ASSY M2 PA1 3C ✽ A64-2942-02 PANEL ASSY M3 PA1 3C ✽ A64-2945-02 PANEL ASSY E4E PA1 3C ✽ A64-2946-02 PANEL ASSY E6 PA1 3C ✽ A64-2947-02 PANEL ASSY E5E1 PA1 3C ✽ A64-2948-02 PANEL ASSY E7 - B46-0100-50 WARRANTY CARD EE1M3 - B46-0100-50 WARRANTY CARD E2E3M2 - B46-0182-14 ID CARD EE3 - B46-0606-04 ID CARD E1E2M2 - B46-0606-04 ID CARD E4E5M3 - B46-0606-04 ID CARD E6E7 - B58-1365-04 CAUTION CARD - ✽ B64-2445-00 INSTRUCTION MANUAL (ENG. T-CHI.) M2M3 - ✽ B64-2446-00 INSTRUCTION MANUAL (ARABIC) M2M3 - ✽ B64-2449-00 INST.MANUAL (ENG. DUT. ITA. SPA.) EE1E2 - ✽ B64-2449-00 INST.MANUAL (ENG.DUT. ITA. SPA.) E3 - ✽ B64-2450-00 INSTRUC. MANUAL (FRE. GER. POR.) EE1E2 - ✽ B64-2450-00 INSTRUC. MANUAL (FRE. GER. POR.) E3 - ✽ B64-2451-00 INST.MANUAL (ENG.RUS. POL. CZE.) E4E5E6 - ✽ B64-2452-00 INSTRUC. MANUAL (HUN. CRO. SLO.) E4E5E6 - ✽ B64-2453-00 INSTRUCTION MANUAL (ENG. RUS.) E7 207 3D B07-3001-02 ESCUTCHEON EE1M2 207 3D B07-3001-02 ESCUTCHEON E4E5M3 207 3D B07-3001-02 ESCUTCHEON E6E7 207 3D B07-3054-02 ESCUTCHEON E2E3 208 3C B10-4127-01 FRONT GLASS E3 208 3C ✽ B10-4130-01 FRONT GLASS E2 208 3C ✽ B10-4363-01 FRONT GLASS M2 208 3C ✽ B10-4364-01 FRONT GLASS M3 208 3C ✽ B10-4366-01 FRONT GLASS E4E 208 3C ✽ B10-4367-01 FRONT GLASS E6 208 3C ✽ B10-4368-01 FRONT GLASS E5E1 208 3C ✽ B10-4369-01 FRONT GLASS E7 220 3D D10-4446-03 LEVER 221 3D D10-4447-03 LEVER 222 1C D10-4589-04 LEVER 223 3D D21-2329-04 SHAFT CME1 1C D40-1150-05 CASSETTE MECHANISM ASSY 225 3C E29-1880-02 CONDUCTIVE RUBBER DC1 1C E30-4792-05 DC CORD F1 2D F52-0006-05 FUSE(MINI BLADE TYPE) 235 3D G01-2525-04 TORSION COIL SPRING 236 3D G01-2987-04 TORSION COIL SPRING KRC-31Y/36/366L/37/Y/391/394/Y/466R/4904Y 237 3D G01-3096-04 EXTENSION SPRING 238 3C ✽ G01-3149-04 COMPRESSION SPRING - H10-4696-22 POLYSTYRENE FOAMED FIXTURE - H25-0329-04 PROTECTION BAG (280X450X0.03) M2E4E5 - H25-0329-04 PROTECTION BAG (280X450X0.03) M3E6E7 - H25-0337-04 PROTECTION BAG (180X300X0.03) - H25-1111-04 PROTECTION BAG (280X450X0.03) EE1E2 - H25-1111-04 PROTECTION BAG (280X450X0.03) E3 - ✽ H54-2695-03 ITEM CARTON CASE M2 - ✽ H54-2696-03 ITEM CARTON CASE M3 - ✽ H54-2698-03 ITEM CARTON CASE E - ✽ H54-2699-03 ITEM CARTON CASE E1 - ✽ H54-2700-03 ITEM CARTON CASE E4 - ✽ H54-2701-03 ITEM CARTON CASE E6 - ✽ H54-2702-03 ITEM CARTON CASE E5 - ✽ H54-2703-03 ITEM CARTON CASE E7 - ✽ H54-2822-03 ITEM CARTON CASE E2 - ✽ H54-2823-03 ITEM CARTON CASE E3 245 3C J19-5128-02 HOLDER 248 1C J21-9716-03 MOUNTING HARDWARE ASSY 250 3C K24-3820-04 KNOB (SRC) 251 3C K24-3821-04 KNOB (AUD) 252 3C K24-3822-04 KNOB (REL) 253 3C K25-1392-03 KNOB (1-6) 254 3C K25-1393-03 KNOB (FM/AM) 255 3C K25-1395-03 KNOB (VOL) 263 1C N99-1610-15 SCREW SET M2M3 264 1C N99-1719-05 SCREW SET M2M3 A 2D N30-2604-46 PAN HEAD MACHINE SCREW B 3D N30-2608-46 PAN HEAD MACHINE SCREW C 2C N80-2006-46 PAN HEAD TAPTITE SCREW D 2C N80-2008-45 PAN HEAD TAPTITE SCREW E 1D N83-3005-46 PAN HEAD TAPTITE SCREW N 3D N29-0205-04 RETAINING RING (1.5) 266 1C T90-0523-05 ANTENNA ADAPTOR D102 B30-1567-05 LED(1608,RED) C1 C90-5242-05 ELECTRO 3300UF 16WV C2 CK73GB1H103K CHIP C 0.010UF K C14 CK73GB1H102K CHIP C 1000PF K C20 CK73GB1H103K CHIP C 0.010UF K C30 CK73GB1H103K CHIP C 0.010UF K C40 CK73GB1H103K CHIP C 0.010UF K C50 CE04CW1V100M ELECTRO 10UF 35WV C51-53 C90-2597-05 ELECTRO 10UF 16WV C54 CE04CW1H100M ELECTRO 10UF 50WV C55 C90-2597-05 ELECTRO 10UF 16WV C56 CE04CW1C101M ELECTRO 100UF 16WV C101 CE04CW0J101M ELECTRO 100UF 6.3WV C102 CK73GB1H103K CHIP C 0.010UF K C103 CK73GB1C104K CHIP C 0.10UF K SYNTHESIZER UNIT (X14-689x-xx) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 18 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST C103 CK73GB1H104K CHIP C 0.10UF K C104,105 CC73GCH1H150J CHIP C 15PF J C106 CK73GB1H472K CHIP C 4700PF K C201 CE04CW1A470M ELECTRO 47UF 10WV C202 CK73GB1H103K CHIP C 0.010UF K C203 C90-2610-05 ELECTRO 2.2UF 50WV C204,205 CK73GB0J105K CHIP C 1.0UF K C206 CK73GB1H153K CHIP C 0.015UF K C207 CK73GB1A474K CHIP C 0.47UF K C208,209 CK73GB1C104K CHIP C 0.10UF K C208,209 CK73GB1H104K CHIP C 0.10UF K C210 CK73GB1E333K CHIP C 0.033UF K C210 CK73GB1H333K CHIP C 0.033UF K C211 CC73GCH1H151J CHIP C 150PF J C223,224 C90-2597-05 ELECTRO 10UF 16WV C225 CK73GB1H103K CHIP C 0.010UF K C251-254 C90-5296-05 NP-ELECT 0.22UF 50WV C255 C90-2608-05 ELECTRO 1.0UF 50WV C256 CE04CW1A101M ELECTRO 100UF 10WV C257 C90-2608-05 ELECTRO 1.0UF 50WV C258 C90-2935-05 ELECTRO 1.0UF 50WV C301 CE04DW1A101M ELECTRO 100UF 10WV C302,303 CK73GB1H103K CHIP C 0.010UF K C304 CE04DW1A101M ELECTRO 100UF 10WV C305 CK73GB1H103K CHIP C 0.010UF K C306 CE04DW1C100M ELECTRO 10UF 16WV C307 CK73GB1H103K CHIP C 0.010UF K M3E7 C307,308 CK73GB1H103K CHIP C 0.010UF K E2E3E4 C307,308 CK73GB1H103K CHIP C 0.010UF K E5E6 C307,308 CK73GB1H103K CHIP C 0.010UF K M2EE1 C351 C90-2592-05 ELECTRO 10UF 6.3WV E2E3E4 C351 C90-2592-05 ELECTRO 10UF 6.3WV E5 C351 C90-2592-05 ELECTRO 10UF 6.3WV M2EE1 C352 CC73GCH1H331J CHIP C 330PF J E2E3E4 C352 CC73GCH1H331J CHIP C 330PF J E5 C352 CC73GCH1H331J CHIP C 330PF J M2EE1 C353 C90-2592-05 ELECTRO 10UF 6.3WV E2E3E4 C353 C90-2592-05 ELECTRO 10UF 6.3WV E5 C353 C90-2592-05 ELECTRO 10UF 6.3WV M2EE1 C354 CK73GB1H103K CHIP C 0.010UF K E2E3E4 C354 CK73GB1H103K CHIP C 0.010UF K E5 C354 CK73GB1H103K CHIP C 0.010UF K M2EE1 C355,356 CC73GCH1H100D CHIP C 10PF D E2E3E4 C355,356 CC73GCH1H100D CHIP C 10PF D E5 C355,356 CC73GCH1H100D CHIP C 10PF D M2EE1 C401,402 C90-2608-05 ELECTRO 1.0UF 50WV C403 CE04CW1A101M ELECTRO 100UF 10WV C404 CK73GB1H103K CHIP C 0.010UF K C501 CE04CW1A470M ELECTRO 47UF 10WV C502 CK73GB1H103K CHIP C 0.010UF K C505 C90-2604-05 ELECTRO 0.22UF 50WV C506 CK73GB1H103K CHIP C 0.010UF K C507 C90-2606-05 ELECTRO 0.47UF 50WV C508 CK73GB1H103K CHIP C 0.010UF K C509 C90-2608-05 ELECTRO 1.0UF 50WV C511,512 CK73GB1H152K CHIP C 1500PF K C513,514 CE04CW0J220M ELECTRO 22UF 6.3WV C515,516 CK73GB1H103K CHIP C 0.010UF K C517,518 C90-2602-05 ELECTRO 0.10UF 50WV C531 C90-2594-05 ELECTRO 10UF 10WV C532 CK73GB1H103K CHIP C 0.010UF K C533,534 CK73GB1A224K CHIP C 0.22UF K CN1 E40-9541-05 PIN ASSY J2 E58-0902-05 RECTANGULAR RECEPTACLE J3 E58-0879-05 RECTANGULAR RECEPTACLE J4 E56-0834-05 CYLINDRICAL RECEPTACLE J5 E63-0013-05 PIN JACK WH1 E30-4933-05 CORD WITH PLUG (ANT) L1 L33-1063-15 CHOKE COIL L101 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) L201 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) L301 L33-1123-05 LINE FILTER COIL L303-306 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J) X1 L77-1167-05 CRYSTAL RESONATOR (4.19M) X2 L77-2002-05 CRYSTAL RESONATOR E2E3E4 X2 L77-2002-05 CRYSTAL RESONATOR E5 X2 L77-2002-05 CRYSTAL RESONATOR M2EE1 E 2D N83-3005-46 PAN HEAD TAPTITE SCREW F 2D N80-3008-46 PAN HEAD TAPTITE SCREW G 2D N83-3016-46 PAN HEAD TAPTITE SCREW H 2D N84-3008-46 PAN HEAD TAPTITE SCREW CP101 R90-1046-05 MULTI-COMP 1K X2 CP102 R90-1053-05 MULTIPLE RESISTOR CP103 R90-1056-05 MULTIPLE RESISTOR CP104 R90-1046-05 MULTI-COMP 1K X2 CP315 R90-1047-05 MULTI-COMP 2.2KX2 E2E3E4 CP315 R90-1047-05 MULTI-COMP 2.2KX2 E5 CP315 R90-1047-05 MULTI-COMP 2.2KX2 M2EE1 R1,2 RD14BB2C472J RD 4.7K J 1/6W R3 RK73GB2A124J CHIP R 120K J 1/10W R4 RK73GB2A104J CHIP R 100K J 1/10W R10 RD14BB2C303J RD 30K J 1/6W R11 RK73GB2A103J CHIP R 10K J 1/10W R12 RK73GB2A104J CHIP R 100K J 1/10W R14 RD14BB2C823J RD 82K J 1/6W R15 RK73GB2A563J CHIP R 56K J 1/10W R16 RK73GB2A104J CHIP R 100K J 1/10W R20 RD14DB2H332J SMALL-RD 3.3K J 1/2W R21 RD14BB2C473J RD 47K J 1/6W R22 RK73GB2A473J CHIP R 47K J 1/10W R23 RK73GB2A104J CHIP R 100K J 1/10W R30 RD14BB2C103J RD 10K J 1/6W R31 RD14BB2C473J RD 47K J 1/6W R32 RK73GB2A223J CHIP R 22K J 1/10W R50 RK73GB2A222J CHIP R 2.2K J 1/10W R51 RK73GB2A473J CHIP R 47K J 1/10W R101 RK73GB2A104J CHIP R 100K J 1/10W R102,103 RD14BB2C222J RD 2.2K J 1/6W SYNTHESIZER UNIT (X14-689x-xx) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 19 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST R104 RK73GB2A104J CHIP R 100K J 1/10W R105,106 RK73GB2A222J CHIP R 2.2K J 1/10W R107 RK73GB2A473J CHIP R 47K J 1/10W R109 RK73GB2A473J CHIP R 47K J 1/10W R111 RK73GB2A473J CHIP R 47K J 1/10W E2E3E4 R111 RK73GB2A473J CHIP R 47K J 1/10W E5M3 R111 RK73GB2A473J CHIP R 47K J 1/10W M2EE1 R112,113 RK73GB2A473J CHIP R 47K J 1/10W E6E7 R113 RK73GB2A473J CHIP R 47K J 1/10W E1E2E3 R113 RK73GB2A473J CHIP R 47K J 1/10W E4E5E R114 RK73GB2A473J CHIP R 47K J 1/10W M2M3 R115 RK73GB2A222J CHIP R 2.2K J 1/10W R116,117 RK73GB2A472J CHIP R 4.7K J 1/10W R118 RK73GB2A222J CHIP R 2.2K J 1/10W E2E3E4 R118 RK73GB2A222J CHIP R 2.2K J 1/10W E5E6 R118 RK73GB2A222J CHIP R 2.2K J 1/10W M2EE1 R120 RK73GB2A103J CHIP R 10K J 1/10W R122 RK73GB2A103J CHIP R 10K J 1/10W R123 RK73GB2A223J CHIP R 22K J 1/10W R129 RK73GB2A472J CHIP R 4.7K J 1/10W R132 RK73GB2A102J CHIP R 1.0K J 1/10W R135 RK73GB2A222J CHIP R 2.2K J 1/10W R136 RK73GB2A225J CHIP R 2.2M J 1/10W R137 RK73GB2A472J CHIP R 4.7K J 1/10W R138 RK73GB2A682J CHIP R 6.8K J 1/10W R140 RK73GB2A164J CHIP R 160K J 1/10W R141 RK73GB2A223J CHIP R 22K J 1/10W R142 RK73GB2A472J CHIP R 4.7K J 1/10W R143 RD14BB2C241J RD 240 J 1/6W R144 RK73GB2A472J CHIP R 4.7K J 1/10W R145 RK73GB2A103J CHIP R 10K J 1/10W R146 RK73GB2A222J CHIP R 2.2K J 1/10W E2E3E4 R146 RK73GB2A222J CHIP R 2.2K J 1/10W E5 R146 RK73GB2A222J CHIP R 2.2K J 1/10W M2EE1 R153,154 RD14BB2C102J RD 1.0K J 1/6W R155 RD14BB2C100J RD 10 J 1/6W R156,157 RD14BB2C102J RD 1.0K J 1/6W R158 RD14BB2C471J RD 470 J 1/6W R159 RD14BB2C102J RD 1.0K J 1/6W R160 RD14BB2C101J RD 100 J 1/6W R161 RD14BB2C102J RD 1.0K J 1/6W R162 RD14BB2C470J RD 47 J 1/6W R201 RK73GB2A272J CHIP R 2.7K J 1/10W R202,203 RK73GB2A472J CHIP R 4.7K J 1/10W R204 RK73GB2A102J CHIP R 1.0K J 1/10W E2E3E4 R204 RK73GB2A102J CHIP R 1.0K J 1/10W E5 R204 RK73GB2A102J CHIP R 1.0K J 1/10W M2EE1 R205 RK73GB2A472J CHIP R 4.7K J 1/10W E2E3E4 R205 RK73GB2A472J CHIP R 4.7K J 1/10W E5 R205 RK73GB2A472J CHIP R 4.7K J 1/10W M2EE1 R223,224 RD14BB2C271J RD 270 J 1/6W R227,228 RK73GB2A303J CHIP R 30K J 1/10W R231,232 RD14BB2C101J RD 100 J 1/6W R251-254 RK73GB2A472J CHIP R 4.7K J 1/10W R255 RK73GB2A333J CHIP R 33K J 1/10W R256 RK73FB2B102J CHIP R 1.0K J 1/8W R257 RK73GB2A822J CHIP R 8.2K J 1/10W R258 RK73FB2B101J CHIP R 100 J 1/8W R259 RK73GB2A223J CHIP R 22K J 1/10W R260 RK73GB2A751J CHIP R 750 J 1/10W R261 RK73GB2A431J CHIP R 430 J 1/10W R262 RK73GB2A184J CHIP R 180K J 1/10W R263 RK73GB2A473J CHIP R 47K J 1/10W R303 RD14BB2C120J RD 12 J 1/6W R304 RD14BB2C4R7J RD 4.7 J 1/6W R305 RD14BB2C2R2J RD 2.2 J 1/6W E7 R305 RD14BB2C3R3J RD 3.3 J 1/6W E2E3E4 R305 RD14BB2C3R3J RD 3.3 J 1/6W E5M3E6 R305 RD14BB2C3R3J RD 3.3 J 1/6W M2EE1 R353 RK73GB2A222J CHIP R 2.2K J 1/10W E2E3E4 R353 RK73GB2A222J CHIP R 2.2K J 1/10W E5 R353 RK73GB2A222J CHIP R 2.2K J 1/10W M2EE1 R354 RD14BB2C100J RD 10 J 1/6W E2E3E4 R354 RD14BB2C100J RD 10 J 1/6W E5 R354 RD14BB2C100J RD 10 J 1/6W M2EE1 R401,402 RD14BB2C100J RD 10 J 1/6W R403 RD14BB2C4R7J RD 4.7 J 1/6W R404 RD14BB2C101J RD 100 J 1/6W R405-409 RD14BB2C472J RD 4.7K J 1/6W R410,411 RD14BB2C101J RD 100 J 1/6W R412-415 RK73GB2A104J CHIP R 100K J 1/10W R501 RD14BB2C4R7J RD 4.7 J 1/6W R502 RK73GB2A184J CHIP R 180K J 1/10W R503 RK73GB2A162J CHIP R 1.6K J 1/10W R504 RK73GB2A243J CHIP R 24K J 1/10W R511,512 RK73GB2A153J CHIP R 15K J 1/10W R513,514 RK73GB2A151J CHIP R 150 J 1/10W R515,516 RK73GB2A123J CHIP R 12K J 1/10W R517,518 RK73GB2A334J CHIP R 330K J 1/10W R519,520 RK73GB2A512J CHIP R 5.1K J 1/10W R521,522 RK73GB2A432J CHIP R 4.3K J 1/10W R531 RK73GB2A471J CHIP R 470 J 1/10W R533 RK73GB2A471J CHIP R 470 J 1/10W R534 RK73GB2A104J CHIP R 100K J 1/10W R535 RK73GB2A471J CHIP R 470 J 1/10W R536 RK73GB2A223J CHIP R 22K J 1/10W R537 RD14BB2C220J RD 22 J 1/6W R551 RD14BB2C103J RD 10K J 1/6W R552 RD14DB2H102J SMALL-RD 1.0K J 1/2W R554 RK73GB2A471J CHIP R 470 J 1/10W R556 RK73GB2A471J CHIP R 470 J 1/10W D1 S2V20✽A DIODE D1 1N5393G-M6 DIODE D2,3 1GWJ43(TPB5) DIODE D4 AM01Z DIODE D4 ERA15-01 DIODE D10,11 MA4068(N)-M ZENER DIODE D20 MA4051(N)-M ZENER DIODE D30 HZS5B1 ZENER DIODE SYNTHESIZER UNIT (X14-689x-xx) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 20 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST D30 MA4047-M ZENER DIODE D40 1SS133 DIODE D101 1SS133 DIODE D153,154 HZS6C1 ZENER DIODE D153,154 MA4062-L ZENER DIODE D157 HZS6C1 ZENER DIODE D157 MA4062-L ZENER DIODE D159-161 HZS6C1 ZENER DIODE D159-161 MA4062-L ZENER DIODE D251-253 1SS133 DIODE D401,402 MA4068(N)-M ZENER DIODE D403,404 HZS6C1 ZENER DIODE D403,404 MA4062-L ZENER DIODE D407 HZS6C1 ZENER DIODE D407 MA4062-L ZENER DIODE D409-411 HZS6C1 ZENER DIODE D409-411 MA4062-L ZENER DIODE D551 AM01Z DIODE D551 ERA15-01 DIODE IC1 ✽ UPD780058GC418 MI-COM IC E2E3E4 IC1 ✽ UPD780058GC418 MI-COM IC E5E6 IC1 ✽ UPD780058GC418 MI-COM IC M2EE1 IC1 UPD780058GC426 MI-COM IC M3E7 IC2 TDA7407D ANALOGUE IC IC4 TDA7386 ANALOGUE IC IC6 TDA7479D ANALOGUE IC E2E3E4 IC6 TDA7479D ANALOGUE IC E5 IC6 TDA7479D ANALOGUE IC M2EE1 IC7 TDA3682ST ANALOGUE IC IC8 HD74HC27FP MOS-IC IC9 HA12221F ANALOGUE IC IC10 LB1930M ANALOGUE IC IC11 ✽ S-80835CNNB MOS-IC IC12 BR24C01AF MEMORY IC IC12 BR24C01AF-W MEMORY IC IC12 M24C01-WMN6T MEMORY IC IC12 S-24C01B MEMORY IC Q1 DTC124EUA DIGITAL TRANSISTOR Q1 UN5212 DIGITAL TRANSISTOR Q10,11 2SC4081 TRANSISTOR Q10,11 2SD1819A TRANSISTOR Q20 2SC4081 TRANSISTOR Q20 2SD1819A TRANSISTOR Q40 DTA124EUA DIGITAL TRANSISTOR Q40 UN5112 DIGITAL TRANSISTOR Q50 2SA1036K TRANSISTOR Q101 2SC4081 TRANSISTOR Q101 2SD1819A TRANSISTOR Q151 DTA114YUA DIGITAL TRANSISTOR Q151 UN5114 DIGITAL TRANSISTOR Q201 2SC4081 TRANSISTOR E2E3E4 Q201 2SC4081 TRANSISTOR E5 Q201 2SC4081 TRANSISTOR M2EE1 Q201 2SD1819A TRANSISTOR E2E3E4 Q201 2SD1819A TRANSISTOR E5 Q201 2SD1819A TRANSISTOR M2EE1 Q223,224 DTC143TUA DIGITAL TRANSISTOR Q223,224 UN5216 DIGITAL TRANSISTOR Q251 DTC114YUA DIGITAL TRANSISTOR Q251 UN5214 DIGITAL TRANSISTOR Q301 DTC124EUA DIGITAL TRANSISTOR E2E3E4 Q301 DTC124EUA DIGITAL TRANSISTOR E5E6 Q301 DTC124EUA DIGITAL TRANSISTOR M2EE1 Q301 UN5212 DIGITAL TRANSISTOR E2E3E4 Q301 UN5212 DIGITAL TRANSISTOR E5E6 Q301 UN5212 DIGITAL TRANSISTOR M2EE1 Q501 2SD1760 TRANSISTOR Q551 2SB1443 TRANSISTOR Q552 DTC114EUA DIGITAL TRANSISTOR Q552 UN5211 DIGITAL TRANSISTOR TH1 PTH9C42BE471Q POSITIVE RESISTOR A1 2D X86-3512-70 FRONT-END UNIT E2E3E4 A1 2D X86-3512-70 FRONT-END UNIT E5M3E6 A1 2D X86-3512-70 FRONT-END UNIT M2EE1 A1 2D X86-3512-72 FRONT-END UNIT E7 301 2C B11-1362-04 OPTICAL DIFFUSER 302 2C B11-1363-04 REFLECTION SHEET 303 2C B19-2131-03 LIGHTING BOARD D1-12 B30-1605-05 LED (2COLOR PG/RED) E2E3E4 D1-12 B30-1605-05 LED (2COLOR PG/RED) E5 D1-12 B30-1605-05 LED (2COLOR PG/RED) M2EE1 D1-14 B30-1605-05 LED (2COLOR PG/RED) M3E6E7 D13,14 B30-1564-05 LED (1608,BLUE) E2E3E4 D13,14 B30-1564-05 LED (1608,BLUE) E5 D13,14 B30-1564-05 LED (1608,BLUE) M2EE1 D15 B30-1633-05 LED (WHITE) D20-22 B30-1605-05 LED (2COLOR PG/RED) ED1 ✽ B38-1085-05 LIQUID CRYSTAL C1 CK73GB1H102K CHIP C 1000PF K C2,3 CK73GB1E473K CHIP C 0.047UF K C2,3 CK73GB1H473K CHIP C 0.047UF K C4 CK73GB1H103K CHIP C 0.010UF K C5 CK73FB1A225K CHIP C 2.2UF K C6-8 CK73GB1H103K CHIP C 0.010UF K E2E3E4 C6-8 CK73GB1H103K CHIP C 0.010UF K E5 C6-8 CK73GB1H103K CHIP C 0.010UF K M2EE1 C8 CK73GB1H103K CHIP C 0.010UF K M3E6E7 304 2C E29-1828-04 CONDUCTIVE RUBBER J1 E59-0828-05 RECTANGULAR PLUG R1 RK73GB2A563J CHIP R 56K J 1/10W R2 RK73GB2A473J CHIP R 47K J 1/10W R3 RK73GB2A472J CHIP R 4.7K J 1/10W R4 RK73GB2A4R7J CHIP R 4.7 J 1/10W R5 RK73GB2A102J CHIP R 1.0K J 1/10W R6-9 RK73GB2A471J CHIP R 470 J 1/10W R10 RK73GB2A102J CHIP R 1.0K J 1/10W R11,12 RK73GB2A222J CHIP R 2.2K J 1/10W SYNTHESIZER UNIT (X14-689x-xx) SWITCH UNIT (X16-1532-7x) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 21 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST R13 RK73FB2B331J CHIP R 330 J 1/8W R14 RK73FB2B361J CHIP R 360 J 1/8W E2E3E4 R14 RK73FB2B361J CHIP R 360 J 1/8W E5 R14 RK73FB2B361J CHIP R 360 J 1/8W M2EE1 R14 RK73FB2B511J CHIP R 510 J 1/8W M3E6E7 R15,16 RK73FB2B331J CHIP R 330 J 1/8W R17 RK73FB2B361J CHIP R 360 J 1/8W E2E3E4 R17 RK73FB2B361J CHIP R 360 J 1/8W E5 R17 RK73FB2B361J CHIP R 360 J 1/8W M2EE1 R17,18 RK73FB2B511J CHIP R 510 J 1/8W M3E6E7 R18 RK73FB2B511J CHIP R 510 J 1/8W E2E3E4 R18 RK73FB2B511J CHIP R 510 J 1/8W E5 R18 RK73FB2B511J CHIP R 510 J 1/8W M2EE1 R19 RK73FB2B221J CHIP R 220 J 1/8W R20 RK73GB2A470J CHIP R 47 J 1/10W R22 RK73FB2B221J CHIP R 220 J 1/8W R23 RK73FB2B511J CHIP R 510 J 1/8W D17-19 MA3062WA ZENER DIODE IC1 LC75883E MOS-IC IC2 RS-171 ANALOGUE IC Q1 DTA114EUA DIGITAL TRANSISTOR Q1 UN5111 DIGITAL TRANSISTOR Q2,3 2SC4081 TRANSISTOR 1 2A A10-4329-08 CHASSIS ASSY 2 1A J21-7779-08 MOUNTING HARDWARE 3 2B A11-0931-08 SUB CHASSIS ASSY 4 1A D10-4106-08 ARM 5 2A D10-4107-08 ARM 6 2A D10-4108-08 ARM 7 2B D10-4109-08 ARM 8 2A D10-4110-08 ARM ASSY 9 2A D10-4111-08 ARM ASSY 10 3A D10-4112-08 ARM 13 2A D10-4113-08 ARM 14 1B D13-1324-08 GEAR ASSY 15 3A D01-0614-08 FLYWHEEL ASSY 16 2A D13-1325-08 GEAR ASSY 17 2A D10-4114-08 ARM ASSY 18 3A D01-0615-08 FLYWHEEL ASSY 19 3A D13-1326-08 GEAR ASSY 22 2B D10-4115-08 SLIDER 23 3B D10-4116-18 SLIDER 24 1B J21-7780-08 MOUNTING HARDWARE 25 1B D10-4117-18 ARM 26 1B D10-4118-08 SLIDER 27 1A A52-0716-08 HOLDER 32 1B J90-0767-08 GUID 33 1B J19-4737-08 BRACKET 34 1B D12-0622-08 CAM 35 2B D13-1327-08 GEAR 36 2B D13-1328-08 GEAR 37 3A D13-1329-08 GEAR 38 3A D10-4119-08 ARM 39 1B D13-1330-08 GEAR 40 2A D13-1331-08 GEAR 41 2A D13-1332-08 GEAR 42 2B J11-0619-08 CLAMPER 43 1B D13-1333-08 GEAR 44 1B D13-1334-08 GEAR 45 2A D13-1335-08 GEAR 46 2B D10-4120-08 ARM 47 2B J19-4738-08 HOLDER 48 2B J11-0620-08 CLAMPER 52 2A D03-0312-08 REEL DISK 53 3A D15-0913-08 PULLEY 55 1A D10-4121-08 SLIDER 57 1B D13-1337-08 GEAR 59 2B J31-1036-08 COLLAR 62 3B D14-0683-08 ROLLER 63 1A D14-0684-08 ROLLER 67 2A G01-2832-08 TORSION COIL SPRING 68 2A G01-2833-08 TORSION COIL SPRING 69 2B G01-2834-08 TENSION COIL SPRING 70 1B G01-2835-08 TORSION COIL SPRING 71 1B G01-2836-08 TORSION COIL SPRING 73 1A G09-2020-08 SPRING 74 2A G01-2837-08 COMPRESSION COIL SPRING 75 1B G01-2838-08 TORSION COIL SPRING 76 1A G01-2839-08 TORSION COIL SPRING 77 2A G01-2843-08 TORSION COIL SPRING 79 1A G01-2840-08 TENSION COIL SPRING 80 3A G01-2841-08 TENSION COIL SPRING 83 3A D16-0609-08 BELT 94 3A S64-0807-08 LEVER SWITCH 95 3A S64-0808-08 LEVER SWITCH 100 2B E30-4460-08 CONNECTOR ASSY (10P) 102 2B T95-0213-08 PHOTO COUPLER 103 2B S62-0858-08 SLIDE SWITCH 105 2B S74-0813-08 LEAF SWITCH 107 3A E30-4468-08 CONNECTOR ASSY (7P) A 1B N09-4193-08 SCREW B 1B N09-4194-08 SCREW C 3A N09-4195-08 SCREW D 1B N09-4196-08 SCREW E 2A N09-4197-08 SCREW F 1B N09-4198-08 SCREW G 1A N09-4199-08 SCREW H 2B N09-4200-08 SCREW L 3A N19-2087-08 FLAT WASHER M 1B N19-2088-08 FLAT WASHER N 1B N19-2135-08 FLAT WASHER P 3A N19-2146-08 FLAT WASHER Q 2A N19-2091-08 FLAT WASHER R 1A N19-2092-08 FLAT WASHER S 2B N29-0510-08 RETAINING RING HD1 1B T31-0220-08 PLAYBACK HEAD SWITCH UNIT (X16-1532-7x) CASSETTE MECHANISM ASSY (D40-1150-05) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 22 Indicates safety critical components. ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. A d d N e w Parts No. Description Desti- nation Ref. No. A d d N e w Parts No. Description Desti- nation E : KRC-394 E4 : KRC-394Y M2 : KRC-466R E1 : KRC-37 E5 : KRC-37Y M3 : KRC-366L E2 : KRC-36 E6 : KRC-31Y E3 : KRC-391 E7 : KRC-4904Y PARTS LIST CM1 1A T42-0759-18 MOTOR ASSY (MAIN) CM2 1B T42-1005-08 MOTOR ASSY (SUB) CASSETTE MECHANISM ASSY (D40-1150-05) www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y 23 PARTS LIST Chip capacitor Code L W T Empty 5.6±0.5 5.0±0.5 Less than 2.0 A 4.5±0.5 3.2±0.4 Less than 2.0 B 4.5±0.5 2.0±0.3 Less than 2.0 C 4.5±0.5 1.25±0.2 Less than 1.25 D 3.2±0.4 2.5±0.3 Less than 1.5 E 3.2±0.2 1.6±0.2 Less than 1.25 F 2.0±0.3 1.25±0.2 Less than 1.25 G 1.6±0.2 0.8±0.2 Less than 1.0 H 1.0±0.05 0.5±0.05 0.5±0.05 Chip resistor Code L W T E 3.2±0.2 1.6±0.2 1.0 F 2.0±0.3 1.25±0.2 1.0 G 1.6±0.2 0.8±0.2 0.5±0.1 H 1.0±0.05 0.5±0.05 0.35±0.05 • Rating wattage Code Wattage Code Wattage Code Wattage 1J 1/16W 2C 1/6W 3A 1W 2A 1/10W 2E 1/4W 3D 2W 2B 1/8W 2H 1/2W (Less than 10pF) Code B C D F G (pF) ±0.1 ±0.25 ±0.5 ±1 ±2 CAPACITORS C C 4 5 T H 1 H 2 2 0 J 1 2 3 4 5 6 1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating 2 = Shape ... round, square, etc. 5 = Value 3 = Temp. coefficient 6 = Tolerance • Temperature coefficient 1st Word C L P R S T U Color* Black Red Orange Yellow Green Blue Violet ppm/°C 0 –80 –150 –220 –330 –470 –750 • Tolerance (More than 10pF) Code C D G J K M X Z P No code (%) ±0.25 ±0.5 ±2 ±5 ±10 ±20 +40 +80 +100 More than 10µF : –10~+50 –20 –20 –0 Less than 4.7µF : –10~+75 • Voltage rating 2nd word A B C D E F G H J K V 1st word 0 1.0 1.25 1.6 2.0 2.5 3.15 4.0 5.0 6.3 8.0 – 1 10 12.5 16 20 25 31.5 40 50 63 80 35 2 100 125 160 200 250 315 400 500 630 800 – 3 1000 1250 1600 2000 2500 2150 4000 5000 6300 8000 – CHIP CAPACITORS (EX) C C 7 3 F S L 1 H 0 0 0 J Refer to the table above. 1 2 3 4 5 6 7 1 = Type (Chip) (CH, RH, UJ, SL) 2 = Shape 3 = Dimension (EX) C K 7 3 F F 1 H 0 0 0 Z 4 = Temp. coefficient 1 2 3 4 5 6 7 5 = Voltage rating (Chip) (B, F) 6 = Value 7 = Tolerance RESISTORS • Chip resistor (Carbon) (EX) R D 7 3 E B 2 B 0 0 0 J 1 2 3 4 5 6 7 (Chip) (B, F) • Carbon resistor (Normal type) (EX) R D 1 4 B B 2 C 0 0 0 J 1 2 3 4 5 6 7 (Chip) (B, F) 1 = Type ... ceramic, electrolytic, etc. 5 = Voltage rating 2 = Shape ... round, square, etc. 6 = Value 3 = Dimension 7 = Tolerance 4 = Temp. coefficient CC45 Color* 2nd Word G H J K L ppm/°C ±30 ±60 ±120 ±250 ±500 Example : CC45TH = –470±60ppm/°C • Capacitor value 010 = 1pF 2 2 0 = 22pF 100 = 10pF 101 = 100pF Multiplier 102 = 1000pF = 0.001µF 2nd number 103 = 0.01µF 1st number L W T • Dimension www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299 KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y SPECIFICATIONS follows a policy of continuous advancements in development. For this reason specifications may be changed without notice. KRC-31Y/36/37/37Y/391/394/394Y KRC-366L/466R KRC-4904Y FM Frequency Range (Frequency step) 87.5MHz~108.0MHz (50kHz) 87.5MHz~108.0MHz (50kHz) 65MHz~74MHz (30kHz) Channel Space Selection - FIX - Usable sensitivity (S/N=26dB) - 8.1dBf (0.7µV/75Ω) - 65MHz~74MHz - - 1.4µV/75Ω 87.5MHz~108.0MHz 0.75µV/75Ω - 0.75µV/75Ω Quieting sensitivity (S/N=46dB) - 15.2dBf (1.6µV/75Ω) 65MHz~74MHz - - 1.4µV/75Ω 87.5MHz~108.0MHz 1.6µV/75Ω - 1.6µV/75Ω Frequency response (±3.0dB) 30Hz~15kHz 30Hz~15kHz 30Hz~15kHz S/N (dB) 65dB(MONO) 65dB(MONO) 65dB(MONO) Selectivity (DIN)(dB) ‡ 80dB (±400kHz) ‡ 80dB (±400kHz) ‡ 80dB (±400kHz) Stereo separation - 35dB - 65MHz~74MHz - - not specified 87.5MHz~108.0MHz 35dB (1kHz) - 35dB (1kHz) MW Frequency range (Frequency step) 531kHz~1611kHz (9kHz) 531kHz~1611kHz (9kHz) 531kHz~1611kHz (9kHz) Usable sensitivity (S/N=20dB) 25µV 28dBµ (25µV) 25µV LW Frequency range (kHz) 153kHz~281kHz 153kHz~281kHz 153kHz~281kHz Usable sensitivity (S/N=20dB) 45µV 45µV 45µV CASSETTE Tape speed 4.76cm/sec. 4.76cm/sec. 4.76cm/sec. Wow & Flutter (wrms)(%) 0.08% (WRMS) 0.08% (WRMS) 0.08% (WRMS) Frequency response (Hz)(±3.0dB) 30~14kHz (120µs) 30~14kHz (120µs) 30Hz~14kHz (120µs) Separation (dB) 43dB (1kHz) 43dB (1kHz) 43dB (1kHz) S/N (dB) NR OFF 54dB 54dB 54dB Dolby BNR on Dolby CNR on Preout level(mV)/Load 1800mV/10kΩ 1800mV/10kΩ 1800mV/10kΩ Preout impedance (Ω) � † † † 600Ω †600Ω †600Ω AMP Maximum Power 45Wx4 45Wx4 45Wx4 PWR DIN45324, +B=14.4V 28Wx4 - 28Wx4 Full Bandwidth Power - 22Wx4 (at less than 1%THD) TONE Bass 100Hz±10dB 100Hz±10dB 100Hz±10dB Middle 1kHz±10dB 1kHz±10dB 1kHz±10dB Treble 10kHz±10dB 10kHz±10dB 10kHz±10dB GENE Operating voltage (11~16v allowable) 14.4V 14.4V 14.4V Current Consumption 10A 10A 10A Installation size (WxHxD) 182x53x152 (mm) 182x53x152 (mm) 182x53x152 (mm) Weight 1400g 1400g 1400g KRC-31Y/36/366L/37/Y /391/394/Y/466R/4904Y KENWOOD CORPORATION 2967-3, Ishikawa-machi, Hachioji-shi, Tokyo 192-8525, Japan KENWOOD SERVICE CORPORATION P.O. BOX 22745, 2201 East Dominguez Street, Long Beach, CA90801-5745, U.S.A. KENWOOD ELECTRONICS CANADA INC. 6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8 KENWOOD ELECTRONICS LATIN AMERICA S.A. P.O. Box 55-2791 Paitilla, Plaza Credicorp Bank Panama, Piso 9, Oficina 901, Calle 50, Panama, Rep. de Panama KENWOOD ELECTRONICS BRASIL LTDA. Alameda Ministro Rocha Azevedo No. 456, Edificio Jaú, 10o Andar, Cerqueira César, Cep 0140-001, São Paulo-SP-Brasil KENWOOD ELECTRONICS UK LIMITED Kenwood House, Dwight Road, Watford, Herts, WD18 9EB, United Kingdom KENWOOD ELECTRONICS DEUTSCHLAND GMBH Rembrücker-Str. 15, 63150 Heusenstamm, Germany KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS BELGIUM N.V. Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium KENWOOD ELECTRONICS ITALIA S.p.A. Via G. Sirtori 7/9, 20129 Milano, Italy KENWOOD IBÉRICA S.A. Bolivia, 239-08020 Barcelona, Spain KENWOOD ELECTRONICS AUSTRALIA PTY. LTD. (A.C.N. 001 499 074) 16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113, Australia KENWOOD ELECTRONICS (HONG KONG) LTD. Unit 3712-3724, Level 37, Tower 1, Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD ELECTRONICS GULF FZE P.O. Box 61318, Jebel Ali, Dubai, U.A.E. KENWOOD ELECTRONICS (THAILAND) CO., LTD. 2019 New Pechburi Road, Bangkapi, Huaykwang, Bangkok, 10320 Thailand KENWOOD ELECTRONICS SINGAPORE PTE. LTD. 1 Genting Lane, #07-00, Kenwood Building, Singapore, 349544 KENWOOD ELECTRONICS (MALAYSIA) SDN BHD #4.01 Level 4, Wisma Academy Lot 4A, Jalan 19/1, 46300 Petaling Jaya, Selangor Darul Ehsan, Malaysia Manufactured under license from Dolby Laboratories. “Dolby” and the double-D symbol are trademarks of Dolby Laboratories. www. xiaoyu163. com QQ 376315150 9 9 2 8 9 4 2 9 8 TEL 13942296513 9 9 2 8 9 4 2 9 8 0 5 1 5 1 3 6 7 3 Q Q TEL 13942296513 QQ 376315150 892498299 TEL 13942296513 QQ 376315150 892498299